tk 2302_service manual
TRANSCRIPT
. This product uses Lead Free solder.This product complies with the RoHS directive for the European market.
SERVICE MANUAL © 2008-9 PRINTED IN JA PANB51-8838-00 (N) 672
TK-2302/2302(V)TK-2306
VHF FM TRANSCEIVER
CONTENTS
GENERAL .....................................................2
SYSTEM SET-UP .........................................3
REALIGNMENT ...........................................3
DISASSEMBLY FOR REPAIR ......................6
CIRCUIT DESCRIPTION ..............................9
SEMICONDUCTOR DATA .........................13
TERMINAL FUNCTION .............................13
COMPONENTS DESCRIPTION .................14
PARTS LIST ...............................................15
EXPLODED VIEW ......................................22
PACKING ....................................................23
ADJUSTMENT ..........................................25
PC BOARD
TX-RX UNIT (X57-7570-20) ...................30
SCHEMATIC DIAGRAM ............................34
BLOCK DIAGRAM .....................................38
LEVEL DIAGRAM ......................................40
SPECIFICATIONS ......................................41
Helical antenna(T90-1036-15)
Button knob (PTT)(K29-9425-03)
Button knob(Side1/Side2)(K29-9426-03)
Knob (Selector)(K29-9427-03)
Knob (Volume)(K29-9309-13)
Badge (Front)(B43-1622-04)
Plastic cabinet assy(A02-4040-03)
TK-2302/2302(V)/2306
2
Document Copyrights
Copyright 2008 by Kenwood Corporation. All rights re-served.
No part of this manual may be reproduced, translated, distributed, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or other-wise, for any purpose without the prior written permission of Kenwood.
Disclaimer
While every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for er-rors or omissions. Neither is any liability assumed for dam-ages resulting from the use of the information contained herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes.
GENERAL
INTRODUCTION
SCOPE OF THIS MANUALThis manual is intended for use by experienced tech ni -
cians familiar with similar types of commercial grade com -mu ni ca tions equipment. It contains all required service in for ma tion for the equipment and is current as of the pub-lication date. Changes which may occur after publication are covered by either Service Bulletins or Manual Revisions. These are is sued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment in for ma- tion, the full part identifi cation number should be in clud ed. This applies to all parts : components, kits, or chassis. If the part number is not known, include the chassis or kit number of which it is a part, and a suffi cient description of the re -quired component for proper identifi cation.
PERSONAL SAFETY
The following precautions are recommended for personal safety:
• DO NOT transmit until all RF connectors are verifi ed se -cure and any open connectors are properly terminated.
• SHUT OFF and DO NOT operate this equipment near elec tri cal blasting caps or in an explosive atmosphere.
• This equipment should be serviced by a qualifi ed tech ni -cian only.
SERVICE
This transceiver is designed for easy servicing. Refer to the sche mat ic diagrams, printed circuit board views, and align ment procedures contained within.
Model Type TX-RX unitFrequency
rangeRemarks
TK-2302 K,P,M
X57-7570-20136~174MHz
IF1: 38.85MHzLOC: 38.4MHz
TK-2302(V) K
TK-2306 M
TK-2302/2302(V)/2306
3
SYSTEM SET-UP
REALIGNMENT
1. Modes
User mode
Data programming mode
PC test mode PC tuning mode
PC mode
Wireless clone mode
Mode Function
User mode For normal use.
PC modeUsed for communication between the trans-ceiver and PC.
Data programming mode
Used to read and write frequency data and other features to and from the transceiver.
PC test modeUsed to check the transceiver using the PC. This feature is included in the FPU.
Wireless clone mode
Used to transfer programming data from one transceiver to another.
Choose the type of transceiver
Transceiver programming
Delivery
Merchandise received
Are you using the speaker microphone?
A personal computer, programming interface (KPG-22/22A), and FPU (programming software) are required for programming.(The frequency, TX power HI/LOW, and signalling data are programmed for the transceiver.)
YES
NO
KMC-17, KMC-21 or KMC-45Speaker microphone
(Option)
Are you using the optional antenna?YES
NO
KRA-22 or KRA-26Optional antenna
TX/RX 136~174 5.0WTK-2302: K,P,MTK-2302(V): KTK-2306: M
Frequency range (MHz) RF power Type
2. How to Enter Each Mode
Mode Operation
User mode Power ON
PC mode Received commands from PC
Wireless clone mode [PTT]+[Side2]+Power ON (Two seconds)
3. PC Mode
3-1. PrefaceThe transceiver is programmed by using a personal com-
puter, a programming interface (KPG-22/22A, USB adapter (KCT-53U)) and FPU (programming software).
The programming software can be used with a PC or compatible. Figure 1 shows the setup of a PC for program-ming.
3-2. Connection Procedure1. Connect the transceiver to the personal computer with
the interface cable and USB adapter (when the interface cable is KPG-22A, the KCT-53U can be used).
TK-2302/2302(V)/2306
4
Notes:• You must install the KCT-53U driver in the computer to
use the USB adapter (KCT-53U).• When using the USB adapter (KCT-53U) for the fi rst time,
plug the KCT-53U into a USB port on the computer with the computer power ON.
2. When the POWER is switched on, user mode can be en-tered immediately. When the PC sends a command, the transceiver enters PC mode.
When data is read from the transceiver, the red LED lights.
When data is written to by the transceiver, the green LED lights.
Notes :• The data stored in the personal computer must match
Model Name and Model Type when it is written into EE-PROM.
• Do not press the [PTT] key during data transmission or reception.
3-3. KPG-22/KPG-22A Description
(PC programming interface cable : Option)The KPG-22/22A is required to interface the transceiver
with the computer. It has a circuit in its D-sub connector (KPG-22: 25-pin, KPG-22A: 9-pin) case that converts the RS-232C logic level to the TTL level.
The KPG-22/22A connects the SP/MIC connector of the transceiver to the RS-232C serial port of the computer.
3-4. KCT-53U Description (USB adapter : Option)The KCT-53U is a cable which connects the KPG-22A to a
USB port on a computer.When using the KCT-53U, install the supplied CD-ROM
(with driver software) in the computer. The KCT-53U driver runs under Windows 2000 or XP.
3-5. FPU (Programming Software) DescriptionThe FPU is the programming software for the transceiver
supplied on a CD-ROM. The software on this disk allows a user to program the transceiver transceivers via Program-ming interface cable (KPG-22/22A).
3-6. Programming with PCIf data is transferred to the transceiver from a PC with the
FPU, the data for each set can be modifi ed.Data can be programmed into the EEPROM in RS-232C
format via the SP/MIC jack.In this mode the PTT line operate as TXD and RXD data
lines respectively.
List of FPU for transceiver
Model Type FPU
TK-2302 K,M KPG-118D(K)
TK-2302 P KPG-119D(K)
TK-2302(V) K KPG-119D(K)
TK-2306 M KPG-118D(M)
PCKPG-22 or KPG-22A or KPG-22A+KCT-53UIllustration is KPG-22
FPU
Tuning cable(E30-3216-05)
D-SUB(25-pin)
Transceiver Transceiver Transceiver
KPG-22
PC
GrayGray/Black1.5D-XV Lead wire1.5D-XV Shield wire
+–+–
SP
MIC
D-SUB(9-pin)
KPG-22A
PC
USB
KPG-22A
KCT-53U
PC
Fig. 1
4. Wireless Clone Mode
4-1. Outline“Wireless Clone Mode” copies the transceiver data to
another transceiver.The dealer can copy the transceiver data to another trans-
ceiver even without the use of a personal computer.
4-2. ExampleThe transceiver can copy the programming data to one or
more transceivers via RF communication.The clone source and clone target/s must be in wireless
clone mode.
REALIGNMENT
TK-2302/2302(V)/2306
5
REALIGNMENT
4-3. Operation1. To switch the clone target/s to wireless clone mode,
press and hold the [PTT] and [side2] keys while turning the transceiver power ON.
2. Wait for 2 seconds. The LED will light orange and the transceiver will announce “Clone”.
3. Select a channel table number using Side1 (increment channel table) and Side2 (decrement channnel table) keys.
4. To switch the clone source to wireless clone mode, press and hold the [PTT] and [side2] keys while turning the transceiver power ON.
5. Wait for 2 seconds. The LED will light orange and the transceiver will announce “Clone”.
6. Select the same channel table number as the clone target/s.
7. Press [PTT] on the clone source to begin data transmis-sion.
When the clone target starts to receive data, the LED will light green.
When the clone source fi nishes sending data, a “confi r-mation” tone will sound.
If data transmission fails while cloning, an “error” tone will sound from the target unit.
8. If the cloning fails, no data will be available in the target unit when it is returned to User mode.
9. When the cloning is successful, the target unit’s “Scan” and “Key lock” functions will return to their default values (Scan = OFF, Key lock = OFF).
Notes:• The dealer can clone data to two or more transceivers by
repeating the above procedures.• If the transceivers wireless clone mode is confi gured as
“Disabled”, the transceiver cannot enter wireless clone mode.
• The table shown below will cover the frequency tables used for wireless cloning.
• Wireless clone mode cannot be entered in battery low state.
• A unit cannot be a “Source Unit” if it is unprogrammed. If [PTT] is pressed, an “error” tone will sound.
• The language used in cloning depends on the “Model type” setting, not the FPU setting.
• Once a unit is set to be the source, it cannot be a target after the data has been transmitted. This protects the data in the source unit.
• Electronic interface may cause a failure in data transfer during wireless clone, such as when waveforms or elec-tromagnetics are being performed at the workbench.
• Wireless clone mode can be used ONLY by the autho-
rized service personnel.
• The wireless clone mode setting must be confi gured
as “Disable” before being delivered to the end-user.
• To clone, replace the antenna from both the source
transceiver and the target transceiver with a dummy
load.
• The transmit output power is automatically set to
Low in wireless clone mode.
• Clone frequency table
No.Operating frequency
136~174MHz
1 136.150
2 138.150
3 140.150
4 142.150
5 144.150
6 146.150
7 148.150
8 150150
9 152.150
10 154.150
11 156.150
12 158.150
13 160.150
14 162.150
15 164.150
16 166.150
17 168.150
18 170.150
19 172.150
20 174.150
TK-2302/2302(V)/2306
6
DISASSEMBLY FOR REPAIR
1. Removing the Case Assembly from the Chassis
1. Remove the volume knob q and channel knob w.2. Remove the two screws e.3. Lift and remove the chassis from the case assembly r.
(Use a fl at-blade screwdriver to easily lift the chassis.)
2. Removing the TX-RX unit from the Chassis
1. Detach the solder of speaker wire from the PCB before-hand.
2. Remove the packing t from the SP/MIC jack of the TX-RX unit.
3. Remove the ten screws y fi xing the TX-RX unit.4. Remove the solder of the antenna terminal with a solder-
ing iron u.5. Remove the solder of the positive terminal with a solder-
ing iron i. Note: You can remove the TX-RX unit from the chas-
sis without removing the solder at the positive terminal. However, in this case, you can not attach the packing (G53-1605-03) that is on the positive terminal to the chas-sis in assembling. So, it is advisable to remove the solder on the positive terminal fi rst.
6. Remove the FPC from the fl at cable connector o.7. Lift and remove the TX-RX unit from the chassis !0.
3. Removing the Battery Release Lever
from the Case Assembly
1. Press the upper part of the lever toward the inside of the case assembly. One side of the shaft will be removed q.
2. Lift and remove the battery release lever from the case assembly w.
4. Attaching the Battery Release Lever to
the Case Assembly
1. Insert one side of the shaft into the hole at the lever fi t-ting section on the case assembly q.
Caution: The thin spring (G01-4543-04) should be posi-tioned above the two tabs of the lever.
2. Tilt the battery release lever slightly forward w, so that the thick spring (G01-4542-04) is positioned below the case surface.
3. With the thick spring positioned below the case surface, attach the other side of the shaft to the case assembly by pressing the battery release lever e until it snaps into place r.
Caution: Be careful not to tilt the battery release lever too forward.
If the battery release lever is pushed in this state where the two tabs come below the case surface, there is a possibility of damaging the two tabs.
A thin spring
ShaftTow tabsA thick spring
TK-2302/2302(V)/2306
7
5. Assembling the Battery Release Lever
1. Place the lever w onto the stopper q.2. Place the thick spring e onto the lever.3. Hook the right and left ends of the thin spring r onto the
tabs of the stopper, then place the thin spring onto the lever t.
4. Slide the shaft through the hole of the stopper and lever y.
6. Attaching the Positive Terminal to the Chassis
Always attach the positive terminal to the chassis, using the following procedures, before mounting the TX-RX unit onto the chassis.
1. Remove the holder assembly w from the packing q of the positive terminal.
2. Mount the packing of the positive terminal into the chas-sis hole e.
3. Mount the holder assembly into the packing of the posi-tive terminal r.
7. Mounting the Chassis to the Case Assembly
1. Confirm that the waterproof packing attached to the circumference of the chassis is securely inserted in the groove of the chassis q.
2. Attach the speaker with waterproof packing to the speaker recess of the case assembly w. Make sure the speaker clasp is securely inserted.
3. Tighten the speaker clasp into the case assembly with the screw.
4. Insert the upper part of the chassis into the case assem-bly e.
Caution: Take care that the speaker lead wire is not caught by the microphone element.
5. Press the chassis r and the case assembly together to attach them.
Caution: If the packing of the SP/MIC does not come to the correct position after attaching the chassis to the case assembly, reposition the packing with your fi ngers.
Confirm that thewaterproof packing issecurely inserted in thegroove of the chassis.
DISASSEMBLY FOR REPAIR
TK-2302/2302(V)/2306
8
8. Attaching the Antenna Receptacle to the Chassis
Screw the antenna receptacle to the chassis in the order shown in the drawing so that the antenna receptacle comes to the center of the case hole.
Tighten this screw first.
Tighten this screw second
9. The Nuts of the Volume Knob and Channel Knob
Note that the shapes, colors and heights of nuts of the volume knob and channel knob are different from one another. (The nut of volume knob is silver, and the nut of channel knob is gold)
Use the following jig when removing the nuts of the vol-ume knob and channel knob.
• Jig (Part No.: W05-1012-00)
Volume knob(Long)
Channel knob(Short)
DISASSEMBLY FOR REPAIR
10. Screw sequence for mounting the TX-
RX unit to the chassis
Attach the TX-RX unit to the chassis using the screws in the order shown in the drawing below.
Note: From screw r onward no sequence is need.
TX-RX UNITComponent side view
TK-2302/2302(V)/2306
9
1. Frequency Confi guration
The receiver utilizes double conversion. The first IF is 38.85MHz and the second IF is 450kHz. The fi rst local oscil-lator signal is supplied from the PLL circuit.
The PLL circuit in the transmitter generates the neces-sary frequencies. Fig. 1 shows the frequencies.
ANTTX/RX : 136~174MHz
ANTSW
RFAMP
TXAMP
RFAMP
1st MIX MCF
38.85MHz
CF450kHz
IFSYSTEM
AFAMP
SP
RX:174.85~212.85MHz
PLLVCO
MICAMP
MIC
TX: 136~174MHz
38.4MHzX3
multiplyTCXO 12.8MHz
1/2
Fig. 1 Frequency confi guration
2. Receiver
The frequency confi guration of the receiver is shown in Fig. 2.
ANT
ANTSW
BPF
RCTV
RF AMPQ204
MIXERQ203
IF AMPQ202BPF
PCTV 1st Local
MCFXF201
IC201IF, MIX, DET
IC308AQUA-L
Q2X3 multiply
X1TXCO
CF201
2nd Local 12.8MHz
AF VOLIC309AF PA SP
Fig. 2 Receiver sectio
■ Front End (RF AMP)The signal coming from the antenna passes through the
transmit/receive switching diode circuit, (D103, D104 and D105) passes through a BPF (L214, L216 and L213), and is amplifi ed by the RF amplifi er (Q204).
The resulting signal passes through a BPF (L209 and L211) and goes to the mixer. These BPFs are adjusted by variable capacitors (D203, D204, D205 and D202). The input voltage to the variable capacitor is regulated by voltage out-put from the MCU (IC306).
CIRCUIT DESCRIPTION
■ First MixerThe signal from the front end is mixed with the fi rst local
oscillator signal generated in the PLL circuit by Q203 to pro-duce a fi rst IF frequency of 38.85MHz.
The resulting signal passes through the XF201 MCF to cut the adjacent spurious and provide the opitimun charac-teristics, such as adjacent frequency selectivity.
■ IF Amplifi er CircuitThe fi rst IF signal is passed through a four-pole monolithic
crystal fi lter (XF201) to remove the adjacent channel signal. The fi ltered fi rst IF signal is amplifi ed by the fi rst IF ampli-fier (Q202) and then applied to the lF system IC (IC201). The IF system IC provides a second mixer, limiting amplifi er, quadrature detector and RSSI (Received Signal Strength In-dicator). The second mixer mixes the fi rst IF signal with the 38.4MHz of the second local oscillator output (TCXO X1 and Q2) and produces the second IF signal of 450kHz.
The second IF signal is passed through the ceramic fi lter (CF201) to remove the adjacent channel signal. The fi ltered second IF signal is amplified by the limiting amplifier and demodulated by the quadrature detector with the ceramic discriminator (CD201). The demodulated signal is routed to the audio circuit.
■ Wide/Narrow Switching CircuitNarrow and Wide settings can be made for each channel
by switching the demodulation level.The WIDE (low level) and NARROW (high level) data is
output from IC306, pin 5. When a WIDE (low level) data is received, Q201 turn on. When a NARROW (high level) data is received, Q201 turn off.
Q201 turns on/off with the Wide/Narrow data and the IC201 detector output level is switched to maintain a con-stant output level during wide or narrow signals.
Q201
R209
R21
0
C20
9
CD
201
QUAD IFOUT
IC201FM IF SYSTEM
W/N(IC306) L : Wide
H: Narrow
AFOUT Q202
5R
Fig. 3 Wide/Narrow switching circuit
■ Audio Amplifi er CircuitThe demodulated signal from IC201 goes to AF amplifi er
through IC308.The signal then goes through an AF volume control , and
is routed to an audio power amplifi er (IC309) where it is am-plifi ed and output to the speaker.
TK-2302/2302(V)/2306
10
■ SquelchPart of the AF signal from the IC enters the FM IC (IC201)
again, and the noise component is amplifi ed and rectifi ed by a fi lter and an amplifi er to produce a DC voltage correspond-ing to the noise level.
The DC signal from the FM IC goes to the analog port of the MCU (IC306). IC306 determines whether to output sounds from the speaker by checking whether the input voltage is higher or lower than the preset value.
To output sounds from the speaker, IC306 sends a high signal to the AF_CONT line and turns IC309 on through Q312, Q313, Q314, Q315 and Q316. (See Fig. 4)
IC201: FM IFIF amp
SIGNAL
DTMF IC308AQUA-L
QT/DQT
BUSY QT/DQT IN
IC306MCU
AF_CONT
SPQ315,316IC309AF PA
Q312,313,314
CLK, DATA,STD, LOADN
SW
SW
Fig. 4 AF amplifi er and squelch
■ Receive Signaling
• QT/DQTThe output signal from FM IC (IC201) enters the MCU
(IC306) through IC308. IC306 determines whether the QT or DQT matches the preset value, and controls the SP MUTE and the speaker output sounds according to the squelch re-sults.
• MSK (Fleet Sync)The MSK input signal from the FM IC goes to pin 31 of IC
308. The signal is demodulated by MSK demodulator in IC 308. The demodulated data goes to the MCU for process-ing.
• DTMFThe DTMF input signal from the FM IC (IC201) goes to
IC308. The decoded information is then processed by the MCU.
3. PLL Frequency Synthesizer
The PLL circuit generates the fi rst local oscillator signal for reception and the RF signal for transmission.
■ PLLThe frequency step of the PLL circuit is 2.5, 5, 6.25 or
7.5kHz.A 12.8MHz reference oscillator signal is divided at IC1 by
a fi xed counter to produce an oscillator (VCO) output signal which is buffer amplifi ed by Q3 then divided in IC1 by a pro-grammable counter. The divided signal is compared in phase with the 5, 10, 12.5 or 15kHz reference signal from the phase comparator in IC1. The output signal from the phase comparator is fi ltered through a low-pass fi lter and passed to the VCO to control the oscillator frequency. (See Fig. 5)
■ VCOThe twice of operating frequency is generated by Q5 in
transmit mode and Q4 in receive mode. The oscillator fre-quency is controlled by applying the VCO control voltage, obtained from the phase comparator, to the varactor diodes (D4 and D8 in transmit mode and D3 and D6 in receive mode).
The RX_SW pin is set high in receive mode causing Q7 turn on. The TX_SW pin is set high in transmit mode. The outputs from Q4 and Q5 are amplifi ed by Q9 and sent to the prescaler (IC2).
■ Unlock DetectorIf a pulse signal appears at the LD pin of IC1, an unlock
condition occurs, and the DC voltage obtained from C4 and Q1 causes the voltage applied to the MCU to go low. When the MCU detects this condition, the transmitter is disabled, ignoring the push-to-talk switch input signal.
D4,8Q5
TX VCO
D3,6Q4
RX VCO
Q9BUFF AMP
1/2
Q3BUFFER
IC2
LPF
LPF
Q7,8T/R SW
RXTX
REF OSC
1/M
1/N
Phasecomparator
Chargepump
5,10,12.5 or 15kHz
5,10,12.5 or 15kHz
PLL DATA
X112.8MHz
IC1PLL IC
Fig. 5 PLL circuit
CIRCUIT DESCRIPTION
TK-2302/2302(V)/2306
11
4. Transmitter System
■ Microphone Amplifi erThe signal from the microphone passes through the
IC308. When encoding DTMF, it is turned OFF for muting the microphone input signal by IC308.
The signal passes through the Audio processor (IC308) for the maximum deviation adjustment, and goes to the VCO modulation input.
AGC
LPF
LPF
VCO
LPF TCXO
MIC
DTMF
IC308AQUA-L
IC306MCU
QTVCO
QTTCXO
X1
Fig. 6 Microphone amplifi er
■ Drive and Final Amplifi erThe signal from the T/R switch (D10 is on) is amplifi ed
by the pre-drive (Q101) and the drive amplifier (Q102) to 800mW.
The output of the drive amplifi er is amplifi ed by the RF power amplifier (Q105) to 5.0W (1W when the power is low). The output of the RF power amplifi er is then passed through the harmonic fi lter (LPF) and antenna switch (D103) and applied to the antenna terminal.
FromT/R SW
(D10)
DriveAMP
Pre-driveAMP
Q101 Q102
RF powerAMP
Q105
ANTSW
LPF
D103
ANT
VDD
VG
IC101(1/2)
IC101(2/2)
R117
R120
R123
+B
PCTV(IC306)
5TVD VG
Fig. 7 Drive and fi nal amplifi er and APC circuit
■ APC CircuitThe APC circuit always monitors the current flowing
through the drive amplifi er and RF power amplifi er (Q102 and Q105) and keeps a constant current.
The voltage drop at R117, R120 and R123 is caused by the current flowing through the RF power amplifier and drive amplifi er, and this voltage is applied to the differential amplifi er IC101 (1/2).
IC101 (2/2) compares the output voltage of IC101 (1/2) with the reference voltage from IC306. The output of IC101 (2/2) controls the VG of the RF power amplifier and drive amplifi er to make both voltages the same.
The change of power high/low is carried out by the change of the reference voltage.
■ Encode Signaling
• QT/DQTQT/DQT data of the QTTCXO Line is output from pin 14
of the MCU. The signal passes through a low-pass CR fi lter and goes to the TCXO (X1).
The QT/DQT data of the QTVCO Line is output from pin 15 of the MCU. The signal passes through a low pass CR fi l-ter, mixes with the audio signal, and goes to the VCO modu-lation input. TX deviation is adjusted by the MCU.
• DTMFHigh-speed data is output from pin 74 of the MCU. The
signal passes through a low-pass CR fi lter, and provides a TX and SP out tone, and is then applied to the audio proces-sor (IC308). The signal is mixed with the audio signal and goes to the VCO.
TX deviation is adjusted by the MCU.
• MSK (Fleet Sync)Fleet Sync utilizes 1200bps and 2400bps MSK signal is
output from pin 6 of IC308. And is routed to the VCO. When encoding MSK, the microphone input signal is muted.
5. Power Supply
There are four 5V power supplies in the transceiver: 5M, 5C, 5R, and 5T. 5M for MCU is always output while the power is on. 5M is always output, but turns off when the power is turned off to prevent malfunction of the MCU.
5C is a common 5V and is output when SAVE is not set to OFF.
5R is 5V for reception and output during reception.5T is 5V for transmission and output during transmission.
6. Control Circuit
The control circuit consists of a MCU (IC306) and its peripheral circuits. It controls the TX-RX unit. IC306 mainly performs the following:1) Switching between transmission and reception by the
PTT signal input.2) Reading system, group, frequency, and program data
from the memory circuit.3) Sending frequency program data to the PLL.4) Controlling squelch on/off by the DC voltage from the
squelch circuit.5) Controlling the audio mute circuit by the decode data in-
put.6) Transmitting tone and encode data.
CIRCUIT DESCRIPTION
TK-2302/2302(V)/2306
12
■ Frequency Shift CircuitThe MCU (IC306) operates at a clock of 14.746 MHz. This
oscillator has a circuit that shifts the frequency by BEAT SHIFT SW (Q305, Q306).
A beat sound may be able to be evaded from generation if “Beat Shift” is set to ON when it is generated in the inter-nal spurious transmission modulated sound of a transceiver.
X301
XOUT XIN
BSHIFT
Q305 Q306
IC306MCU
Hi: ONLow: OFF
Fig. 8 Frequency shift circuit
■ Memory CircuitMemory circuit consists of the MCU (IC306) and an EE-
PROM (IC305). An EEPROM has a capacity of 16k bits that contains the transceiver control program for the MCU and data such as transceiver channels and operating features.
MCU EEPROM
IC306 IC305
Fig. 9 Memory circuit
■ Low Battery WarningThe battery voltage is checked using by the MCU. The
transceiver generates a warning tone when it falls below the warning voltage shown in the table.1) The red LED blinks when the battery voltage falls below
the voltage (1) shown in the table during transmission. Note: The transceiver checks the battery voltage during
reception even when, in the FPU, the Battery Warning status function is set to “On TX” (default setting).
However, the LED does not blink during reception. Dur-ing transmission, the LED blinks to generate the warning tone of a low battery voltage.
2) The transceiver immediately stops transmission when the battery voltage falls below the voltage (2) shown in the table. A message tone beeps while the PTT switch is released.
Ni-Cd Battery Ni-MH Battery Li-ion Battery
(1) 6.2V 6.2V 6.2V
(2) 5.9V 5.9V 5.9V
66 IC306MCU
R301SB
R30
5
Fig. 10 Low battery warning
7. Control System
Keys and channel selector circuit. The signal from the keys and channel selector are directly input to the MCU, as shown in Fig. 11.
EN162
55
56
57
Channelselector
61605958
EN2EN3EN4EN5
IC306MCU
SIDE1
PTT PTTSW
SW1
SW2SIDE2
Fig. 11 Control system
CIRCUIT DESCRIPTION
TK-2302/2302(V)/2306
13
MCU: R5F212CCKCMB (TX-RX unit IC306)
Pin No. Signal Name I/O Function
1 5T_C O 5T control
2 PLL_STB O PLL strobe
3 5C_C O 5C control
4 5R_C O 5R control
5 W/N O Wide/Narrow switch
6 MODE I No function
7 AF_CONT O Speaker mute
8 BSHIFT O Beat shift control
9 RESET I MCU reset
10 XOUT O MCU clock (14.746MHz)
11 VSS - GND
12 XIN I MCU clock (14.746MHz)
13 VCC I Power supply input
14 QTTCXO O QT/DQT output
15 QTVCO O QT/DQT output
16~21 AUX6~AUX1 I/O No function
22 MIC_MUTE O MIC mute
23 AF_MUTE O No function
24~32 N.C O No function
33 RXDATA I No function
34 TXDATA O No function
35 OPTDET I Headset detect
36 TX_SW O TX VCO switch
37 RX_SW O RX VCO switch
38 LEDRX O Green LED control
39 LEDTX O Red LED control
40 APC_SW O APC switch
41 DC_SW O APC discharge switch
42 STD I Baseband IC data input
43 1/2 OSC O Baseband IC clock (3.6864MHz)
44 INT I No function
45 TXD O Serial data output
SEMICONDUCTOR DATA
Pin No. Signal Name I/O Function
46 RXD I Serial data input
47 DIR O Baseband IC data output
48 DI/O I/O Baseband IC data input / output
49 DTRLOADN O Baseband IC data output
50 TDATA/DTRCLK O Baseband IC data output
51 SCLK O Serial clock for baseband IC
52 TCLK/DTRDO I Baseband IC data input
53 RDF/FD I Baseband IC data input
54 MDSW I No function
55 PTT I PTT switch input
56 SIDE1 I Side1 key input
57 SIDE2 I Side2 key input
58~62 EN5~EN1 I Channel selector input
63 DIST1 I No function
64 DIST2 I No function
65 PLL_UL I PLL unlock signal input
66 BATT I Battery voltage detect
67 RSSI I RSSI input
68 BUSY I Busy signal input
69 VOX I VOX signal detect
70 QT/DQT_IN I QT/DQT signal input
71 EEPCLK O EEPROM clock
72 EEPDAT I/O EEPROM data input / output
73 TH_DET I Temperature detect
74 DTMF I DTMF/BEEP output
75 AVSS - GND
76 PCTV I APC/BPF control voltage
77 VREF I Reference voltage input
78 AVCC I Power supply input
79 PLL_DAT O PLL data output
80 PLL_CLK O PLL clock output
TERMINAL FUNCTION
TX-RX unit (X57-7570-20)
Pin No. Name I/O Function
CN301
1 B I B (Battery Voltage)
2 SB O Switched B
3 AFVOL_IN I Audio input
4 AFVOL_OUT O Audio output
5 AFVOL_GND - GND
Pin No. Name I/O Function
6 EN1 I Encoder pulse input
7 EN2 I Encoder pulse input
8 GND - GND
9 EN3 I Encoder pulse input
10 EN4 I Encoder pulse input
11 EN5 I Encoder pulse input
TK-2302/2302(V)/2306
14
TX-RX unit (X57-7570-20)
Ref. No. Part Name Description
IC1 IC PLL system IC
IC2 IC Prescaler
IC101 IC APC
IC201 IC FM system IC
IC301 IC Voltage detector/ Reset
IC303,304 IC Voltage regulator/ 5V
IC305 IC EEPROM
IC306 IC MCU
IC308 IC Audio processor
IC309 IC Audio amplifi er
Q1 Transistor Rectifi cation
Q2 Transistor Tripler
Q3 Transistor RF amplifi er
Q4 FET VCO/ RX
Q5 FET VCO/ TX
Q6 Transistor Rectifi cation
Q7 Transistor DC switch/ RX VCO
Q8 Transistor DC switch/ TX VCO
Q9 Transistor RF amplifi er
Q10 Transistor Ripple fi lter
Q11 Transistor RF amplifi er
Q101 Transistor RF amplifi er
Q102 FET TX drive amplifi er
Q103 Transistor Discharge switch
Q105 FET TX fi nal amplifi er
Q106 Transistor DC switch
Q107 FET DC switch
Q108 Transistor DC switch
Q201 Transistor Wide/Narrow switch/ RX
Q202 Transistor IF amplifi er
Q203 FET Mixer
Q204 FET Low noise amplifi er
COMPONENTS DESCRIPTION
Ref. No. Part Name Description
Q301 Transistor DC switch/ Red color LED
Q302 Transistor DC switch/ Green color LED
Q303 Transistor DC switch/ 5R
Q304 Transistor DC switch/ 5T
Q305,306 Transistor Beat shift switch
Q307 Transistor Wide/Narrow switch/ TX
Q308 Transistor Rectifi cation
Q310,311 Transistor MIC mute
Q312,313 Transistor DC switch
Q314 Transistor Mute switch
Q315,316 FET Mute switch
D3Variable Capci-tance Diode
Frequency control/ RX VCO
D4Variable Capci-tance Diode
Frequency control/ TX VCO
D6Variable Capci-tance Diode
Frequency control/ RX VCO
D8Variable Capci-tance Diode
Frequency control/ TX VCO
D9Variable Capci-tance Diode
Modulator
D10 Diode TX/RX RF switch
D101 Zener diode Voltage protection
D103~105 Diode ANT switch
D202~205Variable Capci-tance Diode
RF BPF tuning
D301 Diode Reverse voltage protection
D302 Diode Rectifi cation
D303 LED Red color LED
D304 LED Green color LED
D306 Diode Rectifi cation
D307 Diode Limiter
D308,309 Diode Rectifi cation
TK-2302/2302(V)/2306
15
PARTS LIST
Chip capacitor
Code L W T Empty 5.6±0.5 5.0±0.5 Less than 2.0 A 4.5±0.5 3.2±0.4 Less than 2.0 B 4.5±0.5 2.0±0.3 Less than 2.0 C 4.5±0.5 1.25±0.2 Less than 1.25 D 3.2±0.4 2.5±0.3 Less than 1.5 E 3.2±0.2 1.6±0.2 Less than 1.25 F 2.0±0.3 1.25±0.2 Less than 1.25 G 1.6±0.2 0.8±0.2 Less than 1.0 H 1.0±0.05 0.5±0.05 0.5±0.05Chip resistor
Code L W T E 3.2±0.2 1.6±0.2 1.0 F 2.0±0.3 1.25±0.2 1.0 G 1.6±0.2 0.8±0.2 0.5±0.1 H 1.0±0.05 0.5±0.05 0.35±0.05
• Rating wattage
Code Wattage Code Wattage Code Wattage 1J 1/16W 2C 1/6W 3A 1W 2A 1/10W 2E 1/4W 3D 2W 2B 1/8W 2H 1/2W
(Less than 10pF) Code B C D F G (pF) ±0.1 ±0.25 ±0.5 ±1 ±2
CAPACITORS
C C 4 5 T H 1 H 2 2 0 J 1 2 3 4 5 61 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating2 = Shape ... round, square, etc. 5 = Value3 = Temp. coefficient 6 = Tolerance
• Temperature coefficient
1st Word C L P R S T U Color* Black Red Orange Yellow Green Blue Violet ppm/°C 0 –80 –150 –220 –330 –470 –750
• Tolerance (More than 10pF)
Code C D G J K M X Z P No code (%) ±0.25 ±0.5 ±2 ±5 ±10 ±20 +40 +80 +100 More than 10μF : –10~+50 –20 –20 –0 Less than 4.7μF : –10~+75
• Voltage rating
2nd word A B C D E F G H J K V 1st word 0 1.0 1.25 1.6 2.0 2.5 3.15 4.0 5.0 6.3 8.0 – 1 10 12.5 16 20 25 31.5 40 50 63 80 35 2 100 125 160 200 250 315 400 500 630 800 – 3 1000 1250 1600 2000 2500 2150 4000 5000 6300 8000 –
• Chip capacitors
(EX) C C 7 3 F S L 1 H 0 0 0 J Refer to the table above. 1 2 3 4 5 6 7 1 = Type (Chip) (CH, RH, UJ, SL) 2 = Shape 3 = Dimension(EX) C K 7 3 F F 1 H 0 0 0 Z 4 = Temp. coefficient 1 2 3 4 5 6 7 5 = Voltage rating (Chip) (B, F) 6 = Value 7 = Tolerance
RESISTORS
• Chip resistor (Carbon)
(EX) R D 7 3 E B 2 B 0 0 0 J 1 2 3 4 5 6 7 (Chip) (B, F) • Carbon resistor (Normal type) (EX) R D 1 4 B B 2 C 0 0 0 J 1 2 3 4 5 6 7
1 = Type 5 = Rating wattage2 = Shape 6 = Value3 = Dimension 7 = Tolerance4 = Temp. coefficient
CC45Color*
2nd Word G H J K L ppm/°C ±30 ±60 ±120 ±250 ±500Example : CC45TH = –470±60ppm/°C
• Capacitor value
010 = 1pF 2 2 0 = 22pF100 = 10pF101 = 100pF Multiplier102 = 1000pF = 0.001μF 2nd number103 = 0.01μF 1st number
L
W
T
• Dimension
TK-2302/2302(V)/2306
16
✽ New Parts. indicates safety critical components.Parts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.
L : Scandinavia K : USA P : CanadaY : PX (Far East, Hawaii) T : England E : Eu ropeY : AAFES (Europe) X : Australia M : Oth er Areas
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
AK: TK-2302 K AP: TK-2302 P VK: TK-2302(V) K
AM: TK-2302 M BM: TK-2306 M
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
PARTS LIST
1 1A ✽ A02-4040-03 PLASTIC CABINET ASSY 2 3A ✽ A10-4124-01 CHASSIS
4 2C,2E ✽ B09-0725-03 CAP ACCESSORY 7 1C ✽ B62-2109-00 INSTRUCTION MANUAL AK,AM7 1C ✽ B62-2111-00 INSTRUCTION MANUAL BM7 1C,1E ✽ B62-2139-00 INSTRUCTION MANUAL AP,VK
9 1A D10-0649-03 LEVER 10 1A D21-0863-04 SHAFT 11 1A D32-0441-13 STOPPER
13 2B E04-0477-05 ANTENNA CONNECTOR (SMA) 14 3A E23-1253-04 TERMINAL (BATT-) 15 2A E23-1254-04 TERMINAL (BATT+) 16 2B ✽ E37-1175-15 SP WIRE LEAD (BROWN) 17 2B ✽ E37-1176-15 SP WIRE LEAD (GREEN)
19 3A F20-3353-14 INSULATING SHEET (CHASSIS BATT+)
21 1A G01-4542-04 COIL SPRING (LEVER) 22 1A G01-4543-14 COIL SPRING (STOPPER) 23 2A G10-1330-04 FIBROUS SHEET (AUDIO IC) 24 2A ✽ G11-4465-04 RUBBER SHEET (FINAL FET) 25 3B G13-2009-04 CUSHION (CHASSIS)
26 3A G13-2033-04 CUSHION (BATT-) 27 3A G13-2034-14 CUSHION (CHASSIS-) 28 3A G13-2038-24 CUSHION (CHASSIS-CERAMIC FILTER) 29 2A G13-2039-14 CUSHION (PCB-CERAMIC FILTER) 30 3A G53-1604-03 PACKING (CHASSIS)
31 2A G53-1605-03 PACKING (BATT+) 32 2A G53-1609-14 PACKING (ECM) 33 2B ✽ G53-1799-03 PACKING (VOLUME/SELECTOR) 34 1B ✽ G53-1800-03 PACKING (SP/MIC) 35 1B ✽ G53-1801-03 PACKING (SPEAKER)
36 2B ✽ G53-1802-04 PACKING (SMA)
38 2E ✽ H12-4250-05 PACKING FIXTURE AP39 2D ✽ H12-4251-05 PACKING FIXTURE AK,VK,BM39 2D ✽ H12-4251-05 PACKING FIXTURE AM40 1F H13-2109-03 CARTON BOARD AP42 3D ✽ H52-2300-03 ITEM CARTON CASE AK,VK,BM
42 3D ✽ H52-2300-03 ITEM CARTON CASE AM43 3F ✽ H52-2301-13 ITEM CARTON CASE AP
46 2A J19-5463-03 HOLDER (BATT+) 47 2A J19-5473-03 HOLDER ASSY (BATT+) 48 2C,2E ✽ J19-5521-03 HOLDER (SP/MIC) ACCESSORY 49 2B ✽ J19-5522-03 SPEAKER CLASP 50 2C,1E J29-0734-05 BELT HOOK ACCESSORY
51 2A ✽ J82-0121-05 FPC 52 1A ✽ J99-0737-04 ADHESIVE SHEET (PTT)
54 1B ✽ K29-9309-13 KNOB (VOLUME) 55 1A ✽ K29-9425-03 BUTTON KNOB (PTT) 56 1A ✽ K29-9426-03 BUTTON KNOB (MON/PF) 57 1B ✽ K29-9427-03 KNOB (SELECTOR)
A 3B ✽ N14-0848-05 CIRCULAR NUT (SELECTOR)
B 3B ✽ N14-0849-05 CIRCULAR NUT (VOLUME) C 2B N30-2604-48 PAN HEAD MACHINE SCREW (SMA) D 3A N30-2606-48 PAN HEAD MACHINE SCREW E 2A,3A,2B N83-2005-48 PAN HEAD TAPTITE SCREW 61 2C,2E N99-2046-05 SCREW SET ACCESSORY
63 2A ✽ R31-0670-15 VARIABLE RESISTOR
65 2A ✽ S60-0440-05 ROTARY SWITCH
67 1B T07-0369-15 SPEAKER 68 2D,2E T90-1036-15 HELICAL ANTENNA
70 1F W08-0970-35 AC ADAPTER (TRANSFORMER) AP71 1C W08-0988-05 CHARGER (KSC-35) AK,VK,AM72 1D W08-0989-15 AC ADAPTER (SWITCHING) AK,VK73 1D W08-0992-05 AC ADAPTER (SWITCHING) AM74 1C,2F ✽ W08-1067-05 CHARGER (KCS-31) AP,BM
75 1D ✽ W08-1075-05 AC ADAPTER (SWITCHING) BM
D303 ✽ B30-2315-05 LED (RED) D304 ✽ B30-2314-05 LED (GREEN)
C1 CK73HB1H332K CHIP C 3300PF K C2 CK73HB1C682K CHIP C 6800PF K C3 CK73GB1A105K CHIP C 1.0UF K C4 CK73HB1A104K CHIP C 0.10UF K C5 CK73HB1H102K CHIP C 1000PF K
C6 CK73HB1E103K CHIP C 0.010UF K C7 CC73HCH1H100D CHIP C 10PF D C8-10 CC73HCH1H101J CHIP C 100PF J C11 CK73FB0J106K CHIP C 10UF K C12 CK73HB1H102K CHIP C 1000PF K
C13 CC73HCH1H100D CHIP C 10PF D C14,15 CK73HB1E103K CHIP C 0.010UF K C16 CC73HCH1H470J CHIP C 47PF J C17 CK73HB1E103K CHIP C 0.010UF K C18 CC73HCH1H180J CHIP C 18PF J
C23 CK73HB1E103K CHIP C 0.010UF K C25 CC73HCH1H300J CHIP C 30PF J C26 CC73HCH1H020B CHIP C 2.0PF B C27 CS77AA1VR33M CHIP TNTL 0.33UF 35WV C29 CC73HCH1H270J CHIP C 27PF J
C30 CK73HB1H102K CHIP C 1000PF K C31 CK73HB1E103K CHIP C 0.010UF K C32 CS77CA1C3R3M CHIP TNTL 3.3UF 16WV C33 CK73HB1H471K CHIP C 470PF K C35 CS77CA1V0R1M CHIP TNTL 0.1UF 35WV
C36 CK73HB1H332K CHIP C 3300PF K C39 CK73HB1C682K CHIP C 6800PF K C40 CC73HCH1H060B CHIP C 6.0PF B C41 CC73HCH1H040B CHIP C 4.0PF B C42 CC73HCH1H060B CHIP C 6.0PF B
TK-2302/2302(V)/2306
TX-RX UNIT (X57-7570-20)
TK-2302/2302(V)/2306 (Y50-634X-XX)
TX-RX UNIT (X57-7570-20)
TK-2302/2302(V)/2306
17
PARTS LIST
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts Ref. No. Ad dress Parts No. Description Desti-
nationNewparts
TX-RX UNIT (X57-7570-20)
C44,45 CK73GB1A105K CHIP C 1.0UF K C47 CC73HCH1H150J CHIP C 15PF J C49 CC73HCH1H0R5B CHIP C 0.5PF B C50 CK73HB1H471K CHIP C 470PF K C51 CC73HCH1H100D CHIP C 10PF D
C52 CC73HCH1H121J CHIP C 120PF J C53 CC73HCH1H181J CHIP C 180PF J C56 CC73HCH1H060B CHIP C 6.0PF B C57 CC73HCH1H090B CHIP C 9.0PF B C58 CC73HCH1H020B CHIP C 2.0PF B
C59 CC73HCH1H2R5B CHIP C 2.5PF B C60 ✽ CC73HCH1H4R5B CHIP C 4.5PF B C61 CC73HCH1H050B CHIP C 5.0PF B C62 CK73HB1H471K CHIP C 470PF K C63 CC73HCH1H050B CHIP C 5.0PF B
C64 CC73HCH1H060B CHIP C 6.0PF B C65 CC73HCH1H050B CHIP C 5.0PF B C66 CK73HB1H471K CHIP C 470PF K C67 CC73HCH1H060B CHIP C 6.0PF B C68 CK73HB1H471K CHIP C 470PF K
C70,71 CC73HCH1H0R5B CHIP C 0.5PF B C72,73 CK73HB1A104K CHIP C 0.10UF K C74 CK73HB1H102K CHIP C 1000PF K C75 CK73HB1H471K CHIP C 470PF K C76 CS77CP0J100M CHIP TNTL 10UF 6.3WV
C77 CK73HB1H102K CHIP C 1000PF K C78 CC73HCH1H330J CHIP C 33PF J C79,80 CK73HB1H471K CHIP C 470PF K C81 CC73HCH1H150J CHIP C 15PF J C82,83 CK73HB1H471K CHIP C 470PF K
C84 CK73HB1H102K CHIP C 1000PF K C86-88 CK73HB1H102K CHIP C 1000PF K C89 CC73HCH1H101J CHIP C 100PF J C101 CK73HB1H102K CHIP C 1000PF K C102 CC73HCH1H390J CHIP C 39PF J
C103 CK73GB1A105K CHIP C 1.0UF K C106,107 CK73HB1H102K CHIP C 1000PF K C108 CC73HCH1H390J CHIP C 39PF J C109 CK73HB1A104K CHIP C 0.10UF K C110 CK73HB1H102K CHIP C 1000PF K
C114 CK73HB1H102K CHIP C 1000PF K C118 CK73HB1H102K CHIP C 1000PF K C119 CC73HCH1H270J CHIP C 27PF J C120 CK73HB1H102K CHIP C 1000PF K C122,123 CK73HB1H102K CHIP C 1000PF K
C124 CK73GB1A105K CHIP C 1.0UF K C125 CK73HB1E103K CHIP C 0.010UF K C127 CK73GB1A105K CHIP C 1.0UF K C129,130 CK73HB1H102K CHIP C 1000PF K C131 CC73HCH1H101J CHIP C 100PF J
C132 CC73GCH1H100D CHIP C 10PF D C134 CK73HB1H102K CHIP C 1000PF K C135 CK73HB1A104K CHIP C 0.10UF K C136 CK73HB1H471K CHIP C 470PF K C138 CC73GCH1H270J CHIP C 27PF J
C139 CC73GCH1H680J CHIP C 68PF J C140 CK73HB1H102K CHIP C 1000PF K C141 CC73GCH1H270J CHIP C 27PF J C143 CC73GCH1H130J CHIP C 13PF J C145 CC73GCH1H820J CHIP C 82PF J
C146 CC73GCH1H070B CHIP C 7.0PF B C148 CK73HB1H102K CHIP C 1000PF K C149 CC73GCH1H220J CHIP C 22PF J C150 CK73GB1H102K CHIP C 1000PF K C151 CC73GCH1H100D CHIP C 10PF D
C152 CC73GCH1H110J CHIP C 11PF J C153 CC73GCH1H100D CHIP C 10PF D C154 CC73GCH1H180J CHIP C 18PF J C155 CC73GCH1H120J CHIP C 12PF J C156 CC73GCH1H150J CHIP C 15PF J
C157 CC73HCH1H330J CHIP C 33PF J C158 CC73GCH1H070B CHIP C 7.0PF B C201 CK73GB1C224K CHIP C 0.22UF K C202 CK73FB0J106K CHIP C 10UF K C203 CK73HB1E103K CHIP C 0.010UF K
C204 CK73HB1H102K CHIP C 1000PF K C205 CK73HB1H182K CHIP C 1800PF K C206,207 CK73HB1H561K CHIP C 560PF K C208 CK73HB1A104K CHIP C 0.10UF K C209 CC73HCH1H680J CHIP C 68PF J
C210,211 CK73HB1A104K CHIP C 0.10UF K C212 CK73HB1H102K CHIP C 1000PF K C213,214 CK73HB1A104K CHIP C 0.10UF K C215 CC73HCH1H020B CHIP C 2.0PF B C216,217 CK73HB1E103K CHIP C 0.010UF K
C220 CC73HCH1H010B CHIP C 1.0PF B C221 CC73HCH1H120J CHIP C 12PF J C223 CC73HCH1H070B CHIP C 7.0PF B C224 CC73HCH1H060B CHIP C 6.0PF B C225 CK73HB1E103K CHIP C 0.010UF K
C226 CC73HCH1H130J CHIP C 13PF J C227 CC73HCH1H070B CHIP C 7.0PF B C228 CK73HB1A104K CHIP C 0.10UF K C229 CC73HCH1H060B CHIP C 6.0PF B C230 CK73HB1E103K CHIP C 0.010UF K
C231 CK73HB1H102K CHIP C 1000PF K C232 CC73HCH1H120J CHIP C 12PF J C233 CK73HB1H102K CHIP C 1000PF K C235 CK73HB1E103K CHIP C 0.010UF K C236 CK73HB1H102K CHIP C 1000PF K
C237 CC73HCH1H060B CHIP C 6.0PF B C238 CK73HB1H102K CHIP C 1000PF K C243 CK73FB0J106K CHIP C 10UF K C244 CC73HCH1H030B CHIP C 3.0PF B C245 CK73HB1H102K CHIP C 1000PF K
C246 CC73HCH1H560J CHIP C 56PF J C247 CC73HCH1H030B CHIP C 3.0PF B C248 CK73HB1H102K CHIP C 1000PF K C249 CC73HCH1H2R5B CHIP C 2.5PF B C250 CC73HCH1H560J CHIP C 56PF J
C251 CC73GCH1H050B CHIP C 5.0PF B C252 CK73HB1H102K CHIP C 1000PF K C254,255 CK73HB1H102K CHIP C 1000PF K C257 CC73HCH1H390J CHIP C 39PF J C258 CC73HCH1H040B CHIP C 4.0PF B
C259 CC73HCH1H560J CHIP C 56PF J C260 CC73HCH1H040B CHIP C 4.0PF B C261 CK73HB1H102K CHIP C 1000PF K C262 CC73HCH1H040B CHIP C 4.0PF B C263 CC73HCH1H560J CHIP C 56PF J
TK-2302/2302(V)/2306
18
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
PARTS LIST
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
TX-RX UNIT (X57-7570-20)
C400 CK73FB0J106K CHIP C 10UF K C402 CK73HB1A104K CHIP C 0.10UF K C403 CK73HB1A473J CHIP C 0.047UF J C404 CS77CC0J101M CHIP TNTL 100UF 6.3WV C405 CC73HCH1H221J CHIP C 220PF J
C408 CK73HB1H102K CHIP C 1000PF K C413-415 CK73HB1H102K CHIP C 1000PF K C418 CC73HCH1H390J CHIP C 39PF J TC1,2 C05-0384-05 CERAMIC TRIMMER CAP (10PF)
CN301 E40-6573-05 FLAT CABLE CONNECTOR J301 E11-0703-05 PHONE JACK (2.5/3.5)
F301 F53-0324-05 FUSE (2.5A)
101 2A J30-1282-14 SPACER
CD201 L79-1866-05 TUNING COIL CF201 2A L72-0973-05 CERAMIC FILTERL1 L92-0138-05 CHIP FERRITE L2 L40-4791-86 SMALL FIXED INDUCTOR (4.7UH) L4 L40-5681-86 SMALL FIXED INDUCTOR (0.56UH)
L6 L40-5681-86 SMALL FIXED INDUCTOR (0.56UH) L7 L92-0138-05 CHIP FERRITE L8 L40-1875-71 SMALL FIXED INDUCTOR (18NH) L9 L92-0470-05 CHIP FERRITE L10,11 L40-1885-92 SMALL FIXED INDUCTOR (180NH)
L12 L40-3375-71 SMALL FIXED INDUCTOR (33NH) L13,14 L40-1885-92 SMALL FIXED INDUCTOR (180NH) L15 L40-3378-67 SMALL FIXED INDUCTOR (33NH) L16 L40-2278-67 SMALL FIXED INDUCTOR (22NH) L17,18 L41-2785-45 SMALL FIXED INDUCTOR (270NH)
L19,20 L40-1885-92 SMALL FIXED INDUCTOR (180NH) L21 L92-0138-05 CHIP FERRITE L22 L40-3975-71 SMALL FIXED INDUCTOR (39NH) L23 L92-0138-05 CHIP FERRITE L24 L40-8275-71 SMALL FIXED INDUCTOR (82NH)
L102 L40-4775-71 SMALL FIXED INDUCTOR (47NH) L103 L41-1585-45 SMALL FIXED INDUCTOR (150NH) L104 ✽ L92-0472-05 CHIP FERRITE L105 L40-2275-92 SMALL FIXED INDUCTOR (22NH) L106 L34-4577-05 AIR-CORE COIL
L107 ✽ L92-0472-05 CHIP FERRITE L108 L34-4563-05 AIR-CORE COIL L109 L34-4573-05 AIR-CORE COIL L110 L34-4575-05 AIR-CORE COIL L111 ✽ L41-6885-39 SMALL FIXED INDUCTOR (0.68UH)
L112 L34-4576-05 AIR-CORE COIL L113 L34-4575-05 AIR-CORE COIL L114 L34-4567-05 AIR-CORE COIL L115 L40-1275-92 SMALL FIXED INDUCTOR (12NH) L116 L34-4566-05 AIR-CORE COIL
L117 L41-1092-44 SMALL FIXED INDUCTOR (1UH) L201 L40-1091-86 SMALL FIXED INDUCTOR (1.0UH) L202,203 L40-3975-71 SMALL FIXED INDUCTOR (39NH) L204 L92-0138-05 CHIP FERRITE L205 L41-5685-39 SMALL FIXED INDUCTOR (0.56UH)
L206 L40-1885-92 SMALL FIXED INDUCTOR (180NH) L207 L40-1085-92 SMALL FIXED INDUCTOR (100NH) L209 L41-5678-14 SMALL FIXED INDUCTOR (56NH) L210 L92-0138-05 CHIP FERRITE L211 L41-5678-14 SMALL FIXED INDUCTOR (56NH)
C264 CC73HCH1H050B CHIP C 5.0PF B C265 CC73HCH1H300J CHIP C 30PF J C303 CK73HB1H102K CHIP C 1000PF K C304 CK73HB1A104K CHIP C 0.10UF K C305 CC73HCH1H101J CHIP C 100PF J
C306 CK73GB1A105K CHIP C 1.0UF K C307 CC73HCH1H101J CHIP C 100PF J C310 CK73GB1A105K CHIP C 1.0UF K C311 CC73HCH1H101J CHIP C 100PF J C312 CK73HB1H102K CHIP C 1000PF K
C313 CC73HCH1H101J CHIP C 100PF J C315 CC73HCH1H101J CHIP C 100PF J C316 CK73HB1H102K CHIP C 1000PF K C318 CK73HB1E103K CHIP C 0.010UF K C319,320 CK73HB1H102K CHIP C 1000PF K
C321 CK73GB1A105K CHIP C 1.0UF K C322 CK73HB1H102K CHIP C 1000PF K C323 CK73GB1A105K CHIP C 1.0UF K C325 CK73HB1H102K CHIP C 1000PF K C327 CK73HB1H102K CHIP C 1000PF K
C331 CK73HB1A104K CHIP C 0.10UF K C332 CC73HCH1H050B CHIP C 5.0PF B C334 CK73HB1E103K CHIP C 0.010UF K C335 CK73FB0J106K CHIP C 10UF K C337 CC73HCH1H050B CHIP C 5.0PF B
C339 CK73GB1A105K CHIP C 1.0UF K C341 CK73HB1H102K CHIP C 1000PF K C353,354 CK73HB1E103K CHIP C 0.010UF K C356 CK73HB1H102K CHIP C 1000PF K C358 CK73GB1C224K CHIP C 0.22UF K
C359 CK73FB0J106K CHIP C 10UF K C360 CK73HB1A104K CHIP C 0.10UF K C361 CK73GB1A105K CHIP C 1.0UF K C362 CK73HB1H102K CHIP C 1000PF K C363 CC73HCH1H820J CHIP C 82PF J
C364 CC73HCH1H120J CHIP C 12PF J C365 CC73HCH1H121J CHIP C 120PF J C366 CK73HB1A104K CHIP C 0.10UF K C367 CK73GB1A105K CHIP C 1.0UF K C368 CK73HB1H271K CHIP C 270PF K
C369,370 CK73HB1A104K CHIP C 0.10UF K C371 CK73FB0J106K CHIP C 10UF K C372 CK73HB1H102K CHIP C 1000PF K C373 CC73HCH1H121J CHIP C 120PF J C374-376 CK73HB1H102K CHIP C 1000PF K
C377 CK73HB1A683K CHIP C 0.068UF K C378 CC73HCH1H820J CHIP C 82PF J C379,380 CK73GB1A105K CHIP C 1.0UF K C381 CK73HB1H391K CHIP C 390PF K C382 CK73HB1C153K CHIP C 0.015UF K
C383-385 CK73HB1A104K CHIP C 0.10UF K C386 CK73HB1E103K CHIP C 0.010UF K C388,389 CK73HB1H102K CHIP C 1000PF K C390,391 CK73GB1A105K CHIP C 1.0UF K C392 CK73HB1A333K CHIP C 0.033UF K
C393 CK73FB0J106K CHIP C 10UF K C395 CC73HCH1H221J CHIP C 220PF J C396 CK73HB1A104K CHIP C 0.10UF K C397 CK73GB1C474K CHIP C 0.47UF K C399 CC73HCH1H101J CHIP C 100PF J
If a part reference number is listed in a shaded box, that part does not come with the PCB.
TK-2302/2302(V)/2306
19
PARTS LIST
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts Ref. No. Ad dress Parts No. Description Desti-
nationNewparts
TX-RX UNIT (X57-7570-20)
L213 L41-5678-14 SMALL FIXED INDUCTOR (56NH) L214 L41-2778-14 SMALL FIXED INDUCTOR (27NH) L216 L41-2778-14 SMALL FIXED INDUCTOR (27NH) L301 ✽ L92-0472-05 CHIP FERRITE L302-304 L92-0138-05 CHIP FERRITE
L305 L92-0140-05 CHIP FERRITE L306 L40-2775-71 SMALL FIXED INDUCTOR (27NH) X1 ✽ L77-3042-05 TCXO (12.8MHZ) X301 ✽ L78-1433-05 RESONATOR (14.746MHZ) XF201 L71-0619-05 MCF (38.85MHZ/6.5KH)
CP1 RK75HA1J101J CHIP-COM 100 J 1/16W CP201 RK75HA1J104J CHIP-COM 100K J 1/16W CP202 RK75HA1J474J CHIP-COM 470K J 1/16W CP203 RK75HA1J104J CHIP-COM 100K J 1/16W CP204 RK75HA1J474J CHIP-COM 470K J 1/16W
CP301,302 RK75HA1J473J CHIP-COM 47K J 1/16W CP303,304 RK75HA1J102J CHIP-COM 1.0K J 1/16W R1 RK73HB1J223J CHIP R 22K J 1/16W R2 RK73HB1J103J CHIP R 10K J 1/16W R3 RK73HB1J473J CHIP R 47K J 1/16W
R4 RK73HB1J104J CHIP R 100K J 1/16W R5 RK73HB1J154J CHIP R 150K J 1/16W R7 RK73HB1J000J CHIP R 0.0 J 1/16W R8 RK73HB1J101J CHIP R 100 J 1/16W R9 RK73HB1J222J CHIP R 2.2K J 1/16W
R10 RK73HB1J102J CHIP R 1.0K J 1/16W R11 RK73HB1J334J CHIP R 330K J 1/16W R12 RK73HB1J221J CHIP R 220 J 1/16W R13 RK73HB1J101J CHIP R 100 J 1/16W R14 RK73HB1J100J CHIP R 10 J 1/16W
R15 RK73HB1J561J CHIP R 560 J 1/16W R16 RK73HB1J000J CHIP R 0.0 J 1/16W R17 RK73HB1J152J CHIP R 1.5K J 1/16W R18 RK73HB1J681J CHIP R 680 J 1/16W R19 RK73HB1J223J CHIP R 22K J 1/16W
R20 RK73HB1J000J CHIP R 0.0 J 1/16W R21,22 RK73HB1J103J CHIP R 10K J 1/16W R26 RK73HB1J273J CHIP R 27K J 1/16W R27 RK73HB1J824J CHIP R 820K J 1/16W R28 RK73HB1J102J CHIP R 1.0K J 1/16W
R29 RK73HB1J154J CHIP R 150K J 1/16W R30 RK73HB1J104J CHIP R 100K J 1/16W R31 RK73HB1J274J CHIP R 270K J 1/16W R32 RK73HB1J684J CHIP R 680K J 1/16W R33 RK73HB1J101J CHIP R 100 J 1/16W
R34 RK73HB1J181J CHIP R 180 J 1/16W R35 RK73HB1J680J CHIP R 68 J 1/16W R36 RK73HB1J101J CHIP R 100 J 1/16W R37 RK73HB1J472J CHIP R 4.7K J 1/16W R38 RK73HB1J154J CHIP R 150K J 1/16W
R39 RK73HB1J101J CHIP R 100 J 1/16W R40 RK73HB1J100J CHIP R 10 J 1/16W R41 RK73HB1J102J CHIP R 1.0K J 1/16W R42,43 RK73HB1J332J CHIP R 3.3K J 1/16W R44 RK73HB1J220J CHIP R 22 J 1/16W
R45 RK73HB1J331J CHIP R 330 J 1/16W R46 RK73HB1J222J CHIP R 2.2K J 1/16W R47 RK73HB1J472J CHIP R 4.7K J 1/16W R101,102 RK73HB1J103J CHIP R 10K J 1/16W R103 RK73HB1J331J CHIP R 330 J 1/16W
R104 RK73HB1J220J CHIP R 22 J 1/16W R105 RK73HB1J331J CHIP R 330 J 1/16W R106 RK73HB1J180J CHIP R 18 J 1/16W R107 RK73HB1J331J CHIP R 330 J 1/16W R108 RK73HB1J473J CHIP R 47K J 1/16W
R109 RK73HB1J271J CHIP R 270 J 1/16W R110 RK73HB1J104J CHIP R 100K J 1/16W R111 RK73HB1J822J CHIP R 8.2K J 1/16W R113 RK73HB1J331J CHIP R 330 J 1/16W R114 RK73GB2A000J CHIP R 0.0 J 1/10W
R116 RK73HB1J000J CHIP R 0.0 J 1/16W R117 RK73EB2ER39K CHIP R 0.39 K 1/4W R118 RK73HB1J222J CHIP R 2.2K J 1/16W R119 RK73HB1J473J CHIP R 47K J 1/16W R120 RK73EB2ER39K CHIP R 0.39 K 1/4W
R121 RK73HB1J470J CHIP R 47 J 1/16W R122 RK73HB1J104J CHIP R 100K J 1/16W R123 RK73EB2ER39K CHIP R 0.39 K 1/4W R124,125 RK73GH2A154D CHIP R 150K D 1/10W R126,127 RK73GH2A334D CHIP R 330K D 1/10W
R128 RK73HB1J105J CHIP R 1.0M J 1/16W R129 RK73HB1J473J CHIP R 47K J 1/16W R130 RK73HB1J000J CHIP R 0.0 J 1/16W R131 RK73HB1J563J CHIP R 56K J 1/16W R132 RK73HB1J104J CHIP R 100K J 1/16W
R133 RK73HB1J474J CHIP R 470K J 1/16W R134 RK73GB2A151J CHIP R 150 J 1/10W R201 RK73HB1J184J CHIP R 180K J 1/16W R203 RK73HB1J472J CHIP R 4.7K J 1/16W R204 RK73HB1J823J CHIP R 82K J 1/16W
R205 RK73HB1J100J CHIP R 10 J 1/16W R206 RK73HB1J272J CHIP R 2.7K J 1/16W R207 RK73HB1J332J CHIP R 3.3K J 1/16W R208 RK73HB1J823J CHIP R 82K J 1/16W R209 RK73HB1J332J CHIP R 3.3K J 1/16W
R210,211 RK73HB1J472J CHIP R 4.7K J 1/16W R212 RK73HB1J101J CHIP R 100 J 1/16W R213 RK73HB1J184J CHIP R 180K J 1/16W R214 RK73HB1J471J CHIP R 470 J 1/16W R215 RK73HB1J391J CHIP R 390 J 1/16W
R216 RK73HB1J561J CHIP R 560 J 1/16W R217 RK73HB1J221J CHIP R 220 J 1/16W R218,219 RK73HB1J104J CHIP R 100K J 1/16W R220 RK73HB1J560J CHIP R 56 J 1/16W R222,223 RK73HB1J000J CHIP R 0.0 J 1/16W
R224 RK73HB1J222J CHIP R 2.2K J 1/16W R225 RK73HB1J470J CHIP R 47 J 1/16W R226 RK73HB1J221J CHIP R 220 J 1/16W R228 RK73HB1J563J CHIP R 56K J 1/16W R229 RK73HB1J100J CHIP R 10 J 1/16W
R230 RK73HB1J000J CHIP R 0.0 J 1/16W R231 RK73HB1J102J CHIP R 1.0K J 1/16W R301 RK73HH1J474D CHIP R 470K D 1/16W R302 RK73GB2A000J CHIP R 0.0 J 1/10W R303 RK73HB1J101J CHIP R 100 J 1/16W
R304 RK73HB1J334J CHIP R 330K J 1/16W R305 RK73HH1J474D CHIP R 470K D 1/16W R306 RK73HB1J184J CHIP R 180K J 1/16W R307 RK73GB2A271J CHIP R 270 J 1/10W R308 RK73GB2A221J CHIP R 220 J 1/10W
TK-2302/2302(V)/2306
20
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
PARTS LIST
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts
TX-RX UNIT (X57-7570-20)
R309,310 RK73GB2A000J CHIP R 0.0 J 1/10W R313 RK73HB1J102J CHIP R 1.0K J 1/16W R314,315 RK73HB1J103J CHIP R 10K J 1/16W R316 RK73HB1J222J CHIP R 2.2K J 1/16W R317 RK73HB1J472J CHIP R 4.7K J 1/16W
R318 RK73HB1J182J CHIP R 1.8K J 1/16W R319 RK73HB1J000J CHIP R 0.0 J 1/16W R320 RK73HB1J123J CHIP R 12K J 1/16W R321 RK73HB1J103J CHIP R 10K J 1/16W R323 RK73HB1J102J CHIP R 1.0K J 1/16W
R324,325 RK73HB1J472J CHIP R 4.7K J 1/16W R340-342 RK73HB1J103J CHIP R 10K J 1/16W R344 RK73HB1J474J CHIP R 470K J 1/16W R345 RK73HB1J273J CHIP R 27K J 1/16W R347 RK73GB2A000J CHIP R 0.0 J 1/10W
R348 RK73HB1J102J CHIP R 1.0K J 1/16W R349 RK73HB1J105J CHIP R 1.0M J 1/16W R350 RK73HB1J124J CHIP R 120K J 1/16W R351 RK73HB1J334J CHIP R 330K J 1/16W R352 RK73HB1J104J CHIP R 100K J 1/16W
R353 RK73HB1J123J CHIP R 12K J 1/16W R354 RK73HB1J334J CHIP R 330K J 1/16W R355 RK73HB1J124J CHIP R 120K J 1/16W R356 RK73HB1J472J CHIP R 4.7K J 1/16W R357 RK73HB1J563J CHIP R 56K J 1/16W
R358 RK73HB1J474J CHIP R 470K J 1/16W R359 RK73HB1J473J CHIP R 47K J 1/16W R360 RK73HB1J332J CHIP R 3.3K J 1/16W R361 RK73GB2A000J CHIP R 0.0 J 1/10W R362 RK73HB1J184J CHIP R 180K J 1/16W
R363,364 RK73HB1J104J CHIP R 100K J 1/16W R365 RK73HB1J332J CHIP R 3.3K J 1/16W R366 RK73HB1J154J CHIP R 150K J 1/16W R367 RK73HB1J393J CHIP R 39K J 1/16W R368 RK73GB2A000J CHIP R 0.0 J 1/10W
R369 RK73HB1J823J CHIP R 82K J 1/16W R370 RK73HB1J102J CHIP R 1.0K J 1/16W R371 RK73HB1J272J CHIP R 2.7K J 1/16W R372 RK73HB1J000J CHIP R 0.0 J 1/16W R373 RK73HB1J224J CHIP R 220K J 1/16W
R374 RK73HB1J123J CHIP R 12K J 1/16W R375 RK73HB1J182J CHIP R 1.8K J 1/16W R376 RK73HB1J471J CHIP R 470 J 1/16W R377 RK73HB1J473J CHIP R 47K J 1/16W R378 RK73HB1J561J CHIP R 560 J 1/16W
R379 RK73HB1J102J CHIP R 1.0K J 1/16W R380 RK73HB1J474J CHIP R 470K J 1/16W R381 RK73HB1J151J CHIP R 150 J 1/16W R383 RK73HB1J563J CHIP R 56K J 1/16W R384 RK73HB1J333J CHIP R 33K J 1/16W
R385 RK73GB2A101J CHIP R 100 J 1/10W R387 RK73HB1J104J CHIP R 100K J 1/16W R388 RK73HB1J101J CHIP R 100 J 1/16W R389 RK73HB1J000J CHIP R 0.0 J 1/16W R390 RK73GB2A000J CHIP R 0.0 J 1/10W
R391 RK73HB1J102J CHIP R 1.0K J 1/16W R393 RK73GB2A000J CHIP R 0.0 J 1/10W R394 RK73HB1J473J CHIP R 47K J 1/16W R398 RK73HB1J000J CHIP R 0.0 J 1/16W VR1 ✽ R32-0737-05 SEMI FIXED VARIABLE RESISTOR
S1-3 S70-0414-05 TACT SWITCH
MIC301 2A T91-0651-15 MIC ELEMENT (ECM)
D3,4 1SV325F VARIABLE CAPACITANCE DIODE D6 1SV325F VARIABLE CAPACITANCE DIODE D8 1SV325F VARIABLE CAPACITANCE DIODE D9 1SV278F VARIABLE CAPACITANCE DIODE D10 MC2858 DIODE
D101 UDZW5.1(B) ZENER DIODE D103 HSC277 DIODE D104,105 HVC131 DIODE D202-205 1SV305F VARIABLE CAPACITANCE DIODE D301 GN1G DIODE
D302 ✽ HRC0203C DIODE D306 ✽ KDR731 DIODE D307 MC2850 DIODE D308,309 ✽ KDR731 DIODE IC1 MB15A02PFV2E1 MOS-IC
IC2 UPB1509GV BI-POLAR IC IC101 ✽ BA2904FVM MOS-IC IC201 TA31136FNG MOS-IC IC301 BD4840FVE MOS-IC IC303 XC6209B502PR MOS-IC
IC304 ✽ XC6209B502MR MOS-IC IC305 BR24L16F-W ROM IC IC306 ✽ R5F212CCKCMB MICRO CONTROL UNIT IC308 AQUA-L MOS-IC IC309 TA7368FG MOS-IC
Q1 ✽ KTC4075E(Y,GR) TRANSISTOR Q2 ✽ 2SC4774 TRANSISTOR Q3 2SC5636 TRANSISTOR Q4,5 2SK1875-F(V) FET Q6 ✽ KTC4075E(Y,GR) TRANSISTOR
Q7,8 RT1P430U TRANSISTOR Q9 2SC5636 TRANSISTOR Q10 ✽ KTC4075E(Y,GR) TRANSISTOR Q11 2SC5636 TRANSISTOR Q101 2SC4926YD TRANSISTOR
Q102 RQA0004PXDQS FET Q103 RT1N441U TRANSISTOR Q105 RD07MVS1BT122 FET Q106 RT1N441U TRANSISTOR Q107 2SK1824-A FET
Q108 RT1P441U TRANSISTOR Q201 RT1P441U TRANSISTOR Q202 ✽ 2SC4774 TRANSISTOR Q203,204 3SK318 FET Q301,302 RT1N441U TRANSISTOR
Q303 RT1P141U TRANSISTOR Q304 ✽ DTB723YE DIGITAL TRANSISTOR Q305,306 2SC4919 TRANSISTOR Q307 RT1N441U TRANSISTOR Q308 ✽ KTC4075E(Y,GR) TRANSISTOR
Q310 2SC4116(GR)F TRANSISTOR Q311 2SA1586(Y,GR)F TRANSISTOR Q312 RT1N441U TRANSISTOR Q313 ✽ 2SB1694 TRANSISTOR Q314 RT1N441U TRANSISTOR
Q315,316 2SK3577-A FET
TK-2302/2302(V)/2306
21
PARTS LIST
Ref. No. Ad dress Parts No. Description Desti-nation
Newparts Ref. No. Ad dress Parts No. Description Desti-
nationNewparts
TX-RX UNIT (X57-7570-20)
TH101 B57331V2104J THERMISTOR TH201 B57331V2104J THERMISTOR
TK-2302/2302(V)/2306
22
EXPLODED VIEW
Parts with the exploded numbers larger than 700 are not supplied.If a part reference number is listed in a box on the exploded view of the PCB, that part does not come with the PCB.These parts must be ordered separately.
3
2
1
BA
57
5455
52
561
11
10
9
22
21
34
67
35
49
1617
ETX-RX unit
Ex10
A
C
C
B
E
Dx2
701Model name plate
32
MIC301
51
29
CF201
6365
36
1333
25
2428
47
31
4615
2
19 30
2726
14
A : N14-0848-05 B : N14-0849-05C M2.6 x 4 : N30-2604-48 D M2.6 x 6 : N30-2606-48 E M2 x 5 : N83-2005-48
23
101
X57
X57
TK-2302/2302(V)/2306
23
PACKING (K,M TYPE)
Parts with the exploded numbers larger than 700 are not supplied.
3
2
1
DC
7 Instruction manual (B62-2109-00): AK,AM (B62-2111-00): BM (B62-2139-00): VK
702: AK,AM,VK
704 Protection bag
71 Charger (KSC-35) (W08-0988-05): AK,VK,AM74 Charger (KSC-31) (W08-1067-05): BM
75 AC adapter (W08-1075-05): BM
72 AC adapter (W08-0989-15): AK,VK73 AC adapter (W08-0992-05): AM
50 Belt hook (J29-0734-05)
4 Cap (B09-0725-03)
61 Screw set (N99-2046-05)
48 Holder (SP/MIC) (J29-5521-03)
39 Packing fixture (H12-4251-05)
42 Item carton case (H52-2300-13)
68 Helical antenna (T90-1036-15)
705 Battery assy (Ni-Cd): BM706 Battery assy (Li-ion): AK,VK,AM
*1
*2
*2
*1
AK: TK-2302 K VK: TK-2302(V) K AM: TK-2302 M
BM: TK-2306 M
TK-2302/2302(V)/2306
24
PACKING (P TYPE)
Parts with the exploded numbers larger than 700 are not supplied.
3
2
1
FE
7 Instruction manual (B62-2139-00)
703
704 Protection bag
50 Belt hook (J29-0734-05)
4 Cap (B09-0725-03)
61 Screw set (N99-2046-05)
48 Holder (SP/MIC) (J29-5521-03)
38 Packing fixture (H12-4250-05)
43 Item carton case (H52-2301-03)
40 Carton board (H13-2109-03)
70 AC adapter (W08-0970-35)
74 Charger (KSC-31) (W08-1067-05)
707 Battery assy (Ni-MH)
68 Helical antenna (T90-1036-15)
*1
*1
TK-2302/2302(V)/2306
25
Test Equipment Required for Alignment
Test Equipment Major Specifi cations
1. Standard Signal Generator (SSG)Frequency Range 136 to 174MHzModulation Frequency modulation and external modulationOutput –127dBm/0.1µV to greater than –47dBm/1mV
2. RF Power MeterInput Impedance 50ΩOperation Frequency 136 to 174MHzMeasurement Range Vicinity of 10W
3. Deviation Meter Frequency Range 136 to 174MHz
4. Digital Volt Meter (DVM)Measuring Range 10mV to 10V DCInput Impedance High input impedance for minimum circuit loading
5. Oscilloscope DC through 30MHz
6. High Sensitivity Frequency Counter
Frequency Range 10Hz to 1000MHzFrequency Stability 0.2ppm or less
7. DC Ammeter 5A
8. AF Volt Meter (AF VTVM)Frequency Range 50Hz to 10kHzVoltage Range 1mV to 10V
9. Audio Generator (AG)Frequency Range 50Hz to 5kHz or moreOutput 0 to 1V
10. Distortion MeterCapability 3% or less at 1kHzInput Level 50mV to 10Vrms
11. Spectrum Analyzer Measuring Range DC to 1GHz or more
12. Tracking GeneratorCenter frequency 50kHz to 600MHzOutput Voltage 100mV or more
13. 4Ω Dummy Load Approx. 4Ω, 3W
14. Regulated Power Supply 5V to 10V, approx. 3A Useful if ammeter equipped
■ Antenna connector adapterThe antenna connector of this transceiver uses an SMA
terminal.Use an antenna connector adapter [SMA(f) – BNC(f) or
SMA(f) – N(f)] for adjustment. (The adapter is not provided as an option, so buy a commercially-available one.)
■ Repair Jig (Chassis)Use jig (part No.: A10-4215-03) for repairing the transceiv-
er. Place the TX-RX unit on the jig and fi t it with screws.The jig facilitates the voltage check and protects the fi nal
amplifi er FET when the voltage on the fl ow side of the TX-RX unit is checked during repairs.
■ Battery Jig (W05-1011-00)Connect the power cable properly between the battery
jig installed in the transceiver and the power supply, and be sure output voltage and the power supply polarity prior to switching the power supply ON, otherwise over voltage and reverse connection may damage the transceiver, or the power supply or both.
Note: When using the battery jig, you must measure the voltage at the terminals of the battery jig. Otherwise, a slight voltage drop may occur within the power cable, be-tween the power supply and the battery jig, especially while the transceiver transmits.
+ Terminal (Red)
– Terminal (Black)
S
–
+
C1
100P
/25V
C2
470P
/25V
C3
100/
25V
R1
1.8M
+
+Terminal(Red)
–Terminal(Black)
Powersupply
Powercable
Schematic diagram
ADJUSTMENT
TK-2302/2302(V)/2306
26
Frequency and Signaling
The transceiver has been adjusted for the frequencies shown in the following table. When required, re-adjust them following the adjustment procedure to obtain the frequen-cies you want in actual operation.
■ Frequency (MHz)
Channel No. RX Frequency TX Frequency
1 155.050 155.100
2 136.050 136.100
3 173.950 173.900
4 155.000 155.000
5 155.200 155.200
6 155.400 155.400
7~16 - -
■ Signaling
Signaling No. RX TX
1 None None
2 None 100Hz Square Wave
3 QT 67.0Hz QT 67.0Hz
4 QT 151.4Hz QT 151.4Hz
5 QT 250.3Hz QT 250.3Hz
6 DQT D023N DQT D023N
7 DQT D754I DQT D754I
8 DTMF Decode [159D] DTMF Encode [159D]
9 None DTMF Tone 9
Preparations for Tuning the Transceiver
Before attempting to tune the transceiver, connect the unit to a suitable power supply.
Whenever the transmitter is tuned, the unit must be con-nected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a 8Ω dummy load and connected to an AC voltmeter and an audio distortion meter or a SINAD measurement meter at all times during tuning.
■ Adjustment frequency
TEST CH RX TX
Center 155.050MHz 155.100MHz
Low 136.050MHz 136.100MHz
High 173.950MHz 173.900MHz
Low’ 145.550MHz 145.600MHz
High’ 164.550MHz 164.600MHz
■ List of FPU for transceiver
Model Type FPU
TK-2302 K,M KPG-118D(K)
TK-2302 P KPG-119D(K)
TK-2302(V) K KPG-119D(K)
TK-2306 M KPG-118D(M)
ADJUSTMENT
Fig. 1 Center frequency
Fig. 2 High-edge frequency
Fig. 3 Low-edge frequency
TK-2302/2302(V)/2306
27
ADJUSTMENT
Common Section
Item Condition
Measurement Adjustment
Specifi cations / RemarksTest-equipment
Unit Terminal Unit Parts Method
1. Setting 1) BATT terminal votage: 7.5V2) SSG standard modulation [Wide] MOD: 1kHz, DEV: 3kHz [Narrow] MOD: 1kHz, DEV: 1.5kHz
2. VCO lock voltage
RX
1) CH: High Power meterDVM TX-RX
ANT
LV (CV)
TX-RX TC1 4.0V ±0.1V
2) CH: Low Check 0.6V or more
3. VCO lock voltage
TX
3) CH: High PTT: ON
TX-RX TC2 4.1V ±0.1V
4) CH: Low PTT: ON
Check 0.6V or more
Transmitter Section
Item Condition
Measurement Adjustment
Specifi cations / RemarksTest-equipment
Unit Terminal Unit Parts Method
1. Frequency Adjust
1) CH: High PTT: ON
f. counter ANT TX-RX VR1 173.900MHz ±50Hz
2. High Transmit
Power
1) TEST CH: Low, Low’, Center, High’, High (5 points)
BATT terminal voltage: 7.5V PTT: ON
Power meterAmmeter
FPU 5.0W±0.1W2.0A or less
3. Low Transmit
Power
1) TEST CH: Low, Low’, Center, High’, High (5 points)
BATT terminal voltage: 7.5V PTT: ON
1.0W±0.1W1.0A or less
4. Maximum Deviation
[Wide]
1) TEST CH: Center, Low, High (3 points)
AG: 1kHz/150mV Deviation meter fi lter LPF: 15kHz HPF: OFF PTT: ON
Power meterDeviation meterOscilloscope
AGAF VTVM
ANT
SP/MIC connector
4.4kHz (According to the lager +, –)
±80Hz
[Narrow] 2) TEST CH: Center PTT: ON
2.2kHz (According to the lager +, –)
±80Hz
5. DQT Balance
[Wide]
1) TEST CH: Center, Low, High (3 points)
Deviation meter fi lter LPF: 3kHz HPF: OFF PTT: ON
Make the demodu-lation wave into square waves.
[Narrow] 2) TEST CH: Center PTT: ON
TK-2302/2302(V)/2306
28
ADJUSTMENT
Item Condition
Measurement Adjustment
Specifi cations / RemarksTest-equipment
Unit Terminal Unit Parts Method
6. QT Fine Deviation [Wide]
1) TEST CH: Center, Low, High (3 points)
Deviation meter fi lter LPF: 3kHz HPF: OFF PTT: ON
Power meterDeviation meterOscilloscope
AGAF VTVM
ANT
SP/MIC connector
FPU 0.75kHz ±40Hz
[Narrow] 2) TEST CH: Center PTT: ON
0.38kHz ±40Hz
7. DQT Fine Deviation [Wide]
1) TEST CH: Center, Low, High (3 points)
Deviation meter fi lter LPF: 3kHz HPF: OFF PTT: ON
0.75kHz ±40Hz
[Narrow] 2) TEST CH: Center PTT: ON
0.38kHz ±40Hz
8. DTMF Fine Deviation [Wide]
1) TEST CH: Center Deviation meter fi lter LPF: 15kHz HPF: OFF PTT: ON
3.0kHz ±100Hz
[Narrow] 2) TEST CH: Center PTT: ON
1.5kHz ±100Hz
9. MSK Fine Deviation [Wide]
1) TEST CH: Center Deviation meter fi lter LPF: 15kHz HPF: OFF PTT: ON
3.0kHz ±100Hz
[Narrow] 2) TEST CH: Center PTT: ON
1.5kHz ±100Hz
Receiver Section
Item Condition
Measurement Adjustment
Specifi cations / RemarksTest-equipment
Unit Terminal Unit Parts Method
1. BPF Wave Adjust
1) Center frequency Spectrum analyzer setting Center-f: 155MHz Span: 200MHz RBW: 30kHz VBW: 30kHz ATT: 10dB2) High-edge frequency Spectrum analyzer setting Center-f: 174MHz3) Low-edge frequency Spectrum analyzer setting Center-f: 136MHz
SSG
Spectrumanalyzer
TX-RX
ANT
BPF
FPU Adjust the waveform as shown to the Fig. 1~3.
TK-2302/2302(V)/2306
29
ADJUSTMENT
Item Condition
Measurement Adjustment
Specifi cations / RemarksTest-equipment
Unit Terminal Unit Parts Method
2. Sensitivity [Wide]
1) TEST CH: Low, Center, High (3 points)
SSG otuput : –117dBm (0.3µV) SSG MOD: 3.0kHz
SSG
DVMOscilloscopeAF VTVM
ANT
SP/MIC connector
Check 12dB SINAD or more
[Narrow] 2) TEST CH: Center SSG otuput : –115dBm (0.4µV) SSG MOD: 1.5kHz
3. Squelch Open
[Wide]
1) TEST CH: Center, Low, High (3 points)
SSG otuput : –123dBm (0.16µV) SSG MOD: 3.0kHz
FPU Write
[Narrow] 2) TEST CH: Center SSG otuput : –122dBm (0.18µV) SSG MOD: 1.5kHz
4. Squelch Tight
[Wide]
1) TEST CH: Center, Low, High (3 points)
SSG otuput : –117dBm (0.3µV) SSG MOD: 3.0kHz
[Narrow] 2) TEST CH:Center SSG otuput : –116dBm (0.35µV) SSG MOD: 1.5kHz
5. Battery Warning Level
1) BATT terminal voltage: 5.9V SSGDVM TX-RX
ANTBATT terminal
Write BATT terminal voltage: 5.9V
Adjustment Points
■ Component side view
BATT+
LV
ANTBPF
BPF: BPF Wave AdjustLV (CV): VCO lock voltageBATT+: Battery Warning Level
■ Foil side view
TC2 TC1
S1PTT
S2SIDE1
S3SIDE2
J301EXT. SP/EXT. MIC
VR1
TC1 : VCO lock voltage (RX)TC2 : VCO lock voltage (TX)VR1 : Frequency adjustment
30
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
C44
C45
C213
C414
F301
C3
Q304
L304
R309
R310
R316
R317
R319
R324
MIC301
C303
BATT+
C310
R12
C318
R17
C321
R20R21
Q1
R26
R27
C331
R30
C337
C339
R2 R3
IC303
CP301
CP303
R201
RXD TXD
A4A1
A6A5A3
A2
1
4 5
8
THDET
MDSW
5M
3 4
51
LV
+ + +
+ –
C36
C39
C418
C1
C8
C9
Q305
Q306
L301
L303
L306
R301
R304
R305
R306
R313
R314
R315R
318
CN302RESET
CN303MODE
R320
R321
R323
X301
C316
C319
R19
C327
C332 C
334C335
R1
IC301
3 1
4 5
IC305
IC306
CP302
CP1
C10
R210
C27
C30
CN
201B
US
Y
C32
CN
202R
SS
I
CN
203B
PF
C35
C201
TH201
C210
Q303
Q307
L7
R325
IC1 R14
R15
R16
R18 R
22
R7
C341
Q201
C11
C15
R209
C2
C320
C4
C6
VOX
QTI
GND
SB
1
2021 40
41
606180
AFMUTE
AFCONT
B
GND
GND
5R
W/N
5C
PTT
MOD
LD
1011
120
TK-2302/2302(V)/2306 PC BOARD
TX-RX UNIT (X57-7570-20) Component side view (J79-0186-09)
Ref. No. Address
IC1 9G
IC101 4N
IC301 6B
IC303 6H
IC305 5C
IC306 7D
IC309 7O
Q1 8H
Ref. No. Address
Q103 4M
Q106 3M
Q107 3M
Q108 4M
Q201 5G
Q301 6P
Q302 6P
Q303 5I
Ref. No. Address
Q304 6I
Q305 7B
Q306 8B
Q307 8H
Q312 8P
Q313 7P
Q314 8O
Q315 8O
Ref. No. Address
Q316 8O
D101 4M
D303 8S
D304 8S
31
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
S
GD
D
G
S
D
GS
C400
C404
C405
C415
Q106
Q107
Q108
Q301
Q302
Q316
L302
R302
R303
R307
R308
R116
R117
R120
R123
CN301
R132
IC301
C304
C305
C307
C311
C313
C315
C130
C325
C140
R377
R378
R381
R383
R385
R387
R388
R389
D303
D304
C395
C396
C397
CP304
5T–
PCTV
+
ANT
1 11EN
5EN
4EN
3G
ND
EN2
EN1
AFV
OLG
ND
AFV
OLO
UT
AFV
OLIN
SB
BC
402
C403
Q103
Q312
Q313
Q314
Q315
L117
R111
R118 R
124
R125
R126
R128R
129
R130
R131
R133
C103
TH101
C107
C109
C122
C124
C320
C322
C136
R379
R380
R384
R390
D101
R393
IC101
45
18
IC309
C399
R127
C131
SP–
SP+
56
110
J79-0186-09
TXD
AE
SPI
SPO
NC
5M OPTDET MIC
PTT/RXD
MICIN
TX-RX UNIT (X57-7570-20) Component side view (J79-0186-09)
PC BOARD TK-2302/2302(V)/2306
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
32
JIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
DG
R2
R2R225
R226
R229R230
C49
C56
C59
C40
C64
C76
C23
C243
C245
C247C249
TC
C250C254
C255
G
G
S
D
C257
Q101
E
C E
B
D4
Q105D G
C260
D9
L104
L108
L110
L112L113
L116
CP202
CP204
R102
R104
R106R110
R134
L10
L14
C101
C102
L17
C106
C110
C118
S1PTT
S2SIDE1
S3SID
Q8
R31
R32
C143
C146 C148
C150
C151C154
C158
Q204
L216
J301EXT. SP/EXT. MIC
TXD
AE
SPI
SPO
NC
5MOPTDETMIC
PTT/RXD
MICIN
R222
R223
R224
R228
C244
C246
C248C
251
C252
C258
C259
C261
C262
D202
C263
D203
C264
D204
C265
D205
L102
L103
L105
L106
L107
L111
L114
R103
R105
R107
R108
R109
R113
R114
R119
R121
R122
C108C
114
C119
C120
C123
C125
C127
C129
C134
C135
C145
C149
C152
C153
C155
C156 C
157
D103
D104
D105
L209
L210
L211
L213
L214 R220
C53
C58
C61
C66
C72
C77
C228
C80
D8
L109
L115
CP201
CP203
L15
L21
C132
C138
C139
Q5
C141
R33
Q102
D S G
J79-0186-09
TK-2302/2302(V)/2306 PC BOARD
TX-RX UNIT (X57-7570-20) Foil side view (J79-0186-09)
Ref. No. Address
IC2 6K
IC201 6N
IC304 9P
IC308 8P
Q2 8N
Q3 7L
Q4 9L
Q5 8J
Q6 7K
Ref. No. Address
Q7 8K
Q8 7J
Q9 7K
Q10 7K
Q11 5L
Q101 6I
Q102 7H
Q105 7F
Q202 5N
Ref. No. Address
Q203 4K
Q204 5G
Q308 7R
Q310 7R
Q311 7R
D3 10K
D4 9J
D6 10K
D8 9I
Ref. No. Address
D9 8J
D10 5L
D103 5D
D104 4E
D105 4D
D202 4I
D203 4H
D204 4F
D205 4F
Ref. No. Address
D301 4R
D302 10P
D306 8R
D307 8Q
D308 7Q
D309 7Q
33
J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
D SG
D SG
R211
C25
XF201
R214
R215
C29
R217R218
R219
C31
R231
C51
C202
C204
C205
6
C206
C57
CD201
C209
9
C212
C62
C63
C408
C64
C215
C217
C413
C70
C221
C223
C225
C75
C226
C76C78
C229
C231
C81
45
18
C82
C83
C86
C236
C88
C238
C89CF201
C5
TC2
TC1
G
G
S
D
D3
D4
D9
Q308
Q310
Q311
L305
IC201
D10
L1
L2
L6
L10
L12
L13
C101
C102
L17
L18
L22
L23
L24
R340
R344
R345
R348
R10
R351R353
R354
R355
R356
R357
R358
R362
S3SIDE2
R368
R369
R29
Q6
Q8
R370
R371
R31
R32
R35
R375
R376
R38
R4
R39
R40R41
R43
R46
C353
C355
C358
R394
Q203 D301
D302
D306
C367
D307
D308
C369
D309
L201
L204
C370
C371
L206
C372
L207
C373
C374
C378
C381
C385
C386
IC308
1
910 16
17
252632
C390
C392
C393
X1
C12
C14
R203
C18
R205
R207
R208
R220
C61
C66
C77
C228
CP201
R101
L21Q
5
C23
R212
C26
R213
R216
C33
C40
C41
C42C
47C
50
C52
C203
C207
C208
C60
C211
C214
Q10
Q11
C65
C216
C67
C68
C71
C224
C74
C227
C79
C230C
232
C233
C84
C235
C87
C237
C7
D6
L4
L8
L9L11
L16
L19
L20
R11
R13
Q2
Q3
R28
Q4
Q7
R34
R36
R37
R5R9
R42
R44
R45
R47
C359
Q202
C360
C368
L202
L203
L205
C13
C16
C17
R204
R2068
9
116
C220
C73
IC2
C306
R347
R349
C312
R350
R352R
359
C323
R360
R361
R363
R364
R365 R
366
R367
Q9
R372
R373
R8
VR
1
R398
C361C
362
C363
C364
C365
C366
C375
C376
C377
C379
C380
C382
C383
C384
IC304 3
4
15
C388
C389
C391
CN
304M
DS
W
R341
R342
R374
C354
R391
C356
TX-RX UNIT (X57-7570-20) Foil side view (J79-0186-09)
PC BOARD TK-2302/2302(V)/2306
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
34
TK-2302/2302(V)/2306 SCHEMATIC DIAGRAM
X57-757 1/4
7
6
5
4
3
2
1
A B C D E
EN3
EN4
EN5
EN2
EN1
C31
9
1000
p
C32
7
1000
p
R306
180k
C31
8
0.01
u
C31
2
1000
p
C32
1
1u
C35
0.1u
35
C18
18p
C27
0.33
u35
C25
30p
C12
1000
p
R15
560
R14 10
C10
100p
R12
220
R20
0
R28 1k
R13
100
L7
R8
100
C7
10p
C14
0.01
u
C31
0.01uC
5
1000
p
L4 560n
C26
2p(B)
C4
0.1u
C9
100p
R9
2.2k
R10 1k
R22
10k
C16
47p
C13
10p
R29
150k
R18
680C
8
100p
C29
27p
R17
1.5k
C30
1000
p
C51
10p
R11
330k
R30
8
220
C32
5
1000
p
R1
22k
C32
0
1000
p
R30
7
270
L301
C31
310
0p
C30
510
0p
C30
40.
1u
C31
110
0p
D30
1
GN
1GC
307
100p
C33
470p
C31
0
1u
R5
150k
R4
100k
C1
3300
p
C2
6800
p
R2
10k
R3
47k
C32
3.3u
16
D303B30-2315-05
D304B30-2314-05
C3
1u
R303 100
R301
470k(D)
R30
5
470k
(D)
R304
330k
R70
Q301RT1N441U
Q302RT1N441U
C32
3
1u
S1
S2
S3
C32
2
1000
pC
50
470p
C42
6p(B
)
C40
6p(B
)
C41
4p(B)
C47
15p
1oS
CIN
2N
C1
3oS
CoU
T4
VP
5V
CC
6D
o7
GN
D8
LD9
NC
210
FIN
11C
LoC
K
12N
C3
13D
ATA
14LE
15FC
16N
C4
17Fo
UT
18P
19N
C5
20R
C31
510
0p
X1
12.8MHz
L77-3042-05
1VCoNT
2GND
3oUTPUT
4VCC
R16 0
R302 0
VR
110
0k
1Vo
UT
2S
UB
3N
C4
GN
D
5V
DD
1VIN
2VSS
3CE
4NC
5VoUT
C31
6
1000
p
L6 560n
L2
4.7u
L1
L9
F301F53-0324-05
2.5A
CP1RK75HA1J101J
C11
10u
C17
0.01
u
C15
0.01
u
C23
0.01
u
1N
C2
VS
S3
CE
4V
IN
5Vo
UT
C30
6
1u
L302
L8
18n
L12
33n
CN301
1 B
2 SB
3 AFVOLIN
4 AFVOLOUT
5 AFVOLGND
6 EN1
7 EN2
8 GND
9 EN3
10 EN4
11 EN5
C6
0.01u
B
C30
3
1000
p
R393
0
CV
Side1
Side2
LR
SIDE2
LG
GND
PTT
PTT
SIDE1
BATT
BATT
TXCO
REVERSEVOLTAGEPROTECTION
TX-RX UNIT (X57-7570-20)
DC SW/RED COLOR LED
5M
PLL_UL
EN1
LEDRX
EN3
5T
SB
5C_C
B
EN2
5R_C
PLL_CLK
5T_C
PLL_DAT
QTTCXO
BATT
EN5
5C
EN4
LEDTX
RESET
PLL_STB
5R
PLL_DAT
PLL_STB
PLL_CLK
2ND_LO
AFVOLIN
SIDE1PTT
INT
SIDE2
QTTCXO
PLL_DATPLL_STB
PLL_CLK
PLL_UL
B
5C
AFVOLOUT
DC SW/GREEN COLOR LED
RED COLOR LED GREEN COLOR LED
IC301BD4840FVE
VOLTAGEDETECTOR/RESET
D302
HRC0203C
RECTIFICATIONIC304
XC6209B502MR
VOLTAGEREGULATOR/5V
IC303XC6209B502PR
VOLTAGEREGULATOR/5V
KTC4075E(Y,GR)Q1
RECTIFICATION
2SC4774Q2
TRIPLER
2SC5636Q3
RF AMP
Q304DTB723YE
DC SW/5T
Q303RT1P141U
DC SW/5R
IC1MB15A02PFV2E1
PLL SYSTEM IC
0.66V
4.92V5.0V
2.86V
4.48V
4.92V
R:3.78VT:3.47V
5.0V
5.03V
R:4.84V
T:5.0V
R:7.6VT:7.45V
ON:5.02VOFF:0V
ON:4.88VOFF:0V
T:7.35VT:7.22V
35
SCHEMATIC DIAGRAM TK-2302/2302(V)/2306
X57-757 2/4
JIHGF
L21
TC2
10p
C71
0.5p(B)
C57 9p (B)
C70
0.5p(B)
D4
1SV
325F
C67
6p(B
)
C75
470p
C76
10u6
.3
C65
5p(B
)
C77
1000
p
C53
180p
R34
180
R30
100k
R37
4.7k
D8
1SV325F
D6
1SV325F
R32
680k
C58 2p (B)
TC1
10p
C61
5p(B
)
C56
6p(B
)
C78
33p
R35 68D9
1SV278F
C52
120p
R39
100D
3
1SV
325F
C68
470p
R26
27k
C44
1u
R27
820k
C36
3300
p
C39
6800
p
L303
C334
0.01u
L304
C332
5p(B)
R31
8
1.8k
R319
0
C337
5p(B)
R31
6
2.2k
R19
22k
R21
10k
R31
7
4.7k
R31
510
k
R38
150k
R31
270k
C60
4.5p
(B)
L11
180n
L16
22n
C59
2.5p (B) C74
1000
p
C635p(B)
C62
470p
C73
0.1u
C79
470p
L10
180n
L15
33n
C646p(B)
C72
0.1u
C66
470p
R33
100
1A0
2A1
3A2
4GND
5SDA
6SCL
7WP
8VCC
C80
470p
R32
0
12k
CP
303
RK
75H
A1J
102J
R43
3.3k
C86
1000
p
C81
15p
R42
3.3k
R44 22
C45
1u
X301
14.746MHzL78-1433-05
2SC4919Q305
R31
4
10k
R321
10k
CP
302
RK
75H
A1J
473J
C335
10u
L18
270n
L17
270n
L20
180n
L19
180n L2
2
39n
L13
180n
L14
180n
R36
100
15T
_C2
PLL
_STB
35C
_C4
5R_C
5W
/N6
MO
DE
7A
F_C
ON
T8
BS
HIF
T9
RE
SE
T10
XO
UT
11V
SS
12X
IN13
VC
C14
QTT
CX
O15
QTV
CO
16A
UX
617
AU
X5
18A
UX
419
AU
X3
20A
UX
2
21AUX1
22MIC_MUTE
23AF_MUTE
24LED_BLUE
25NC
26NC
27NC
28NC
29NC
30NC
312TONE
32NC
33RXDATA
34TXDATA
35OPTDET
36TX_SW
37RX_SW
38
LEDRX
39
LEDTX
40
APC_SW
41D
C_S
W
42S
TD
431/
2_O
SC
44IN
T
45TX
D
46R
XD
47D
IR
48D
I/O
49D
TRLO
AD
N
50TD
ATA
/DTR
CLK
51S
CLK
52TC
LK/D
TRD
O
53R
DF/
FD
54M
DS
W
55P
TT
56S
IDE
1
57S
IDE
2
58E
N5
59E
N4
60E
N3
61EN2
62EN1
63DEST1
64DEST2
65PLL_UL
66BATT
67RSSI
68BUSY
69VOX
70QT/DQT_IN
71EEPCLK
72EEPDAT
73TH_DET
74DTMF
75AVSS
76PCTV
77VREF
78AVCC
79 PLLDAT
80 PLLCLK
R323
1k
C33
1
0.1u
R310
0
R313
1k
R309
0
CP
301
RK
75H
A1J
473J
RESET MODE
PCTV
MDSW
LD
VOX
QTI
MICMUTE
AFMUTE
THDET
AFCONT
PTTSW
TXD
RXD
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5SW1
6SW2
7OUT
8VCC2
C82
470p
L23
R40 10
C83
470p
R41
1k
C84
1000p
R391
1k
R394
47k
C413
1000p
C41
4
1000
p
C41
8
39p
L306
27n
C49
0.5p
(B)
VCO (TX)
VCO (RX)
PRESCALER
BEAT SHIFT SW
EN2
BATT
5C
EN1
EN5
5M
5C_C
PLL_DAT
LEDRX
2ND_LO
PLL_STB
PLL_CLK
5T_C
SIDE2
INT
EN4
SB
5R_C
5T
LEDTX
EN3
B
RESET
PLL_UL
5R
QTTCXO
PTT
AFVOLINAFVOLOUT
SIDE1
LEDTXLEDRX
SB
RSSIPCTV
5M
AF_CONT
MIC_MUTE
OPTDETTXD
PTT
QT/DQT_INVOX
W/N
APC_SWDC_SW
5RB
5C
DTRLOADN
5TTH_DET
DTMF
2ND_LO
AFVOLIN
W/N
STD1/2_OSC
PTT
TXDDIR
DI/O
TDATA/DTRCLKSCLKTCLK/DTRDORDF/FD
BUSY
MODMOD
2ND_LO
1/2_OSC
MODULATOR
AFVOLOUT
IC306R5F212CCKCMA
MCU
IC305BR24L16F-W
EEPROM
FREQUENCYCONTROL/RX VCO
D3,6
FREQUENCYCONTROL/TX VCO
D4,8
Q52SK1875-F(V)
VCO/TX
KTC4075E(Y,GR)Q6
RECTIFICATION
KTC4075E(Y,GR)Q10
RIPPLEFILTER
Q8RT1P430U
DC SW/TX VCO
2SK1875-F(V)Q4
VCO/RX
Q7RT1P430U
DC SW/RX VCO
2SC5636Q9
RF AMP
2SC4919Q306
BEAT SHIFT SW
R:3.42V
4.88V
0.75V
R:0.58VT:5.1V
R:5.02VT:0.58V
T:3.03V
3.82V
BSHIFT ON:4.98VOFF:0V
4.05V
TX-RX UNIT (X57-7570-20)
36
TK-2302/2302(V)/2306 SCHEMATIC DIAGRAM
X57-757 3/4
K L M N O
-t
-t
B
C10
3
1u
C37
9
1u
R125
150k(D)
R21
0
4.7k
R214
470
R13
1
56k
C217
0.01u
R12
9
47k
C20
4
1000
p
R12
6
330k
(D)
R12
8
1M
R20
8
82k
C20
5
1800
p
TH10
1
100k
R213
180k
C215
2p(B)
C13
0
1000
p
C369
0.1u
C131
100p
R124
150k(D)
D10
1
UD
ZW
5.1(
B)
R13
3
470k
C207
560p
C21
6
0.01
u
C225
0.01u
C21
0
0.1u
R11
7
0.39
R12
3
0.39
R12
0
0.39
R21
2
100
R132
100k
R127
330k(D)
C208
0.1u
CF201L72-0973-05
450 kHz
C14
0
1000
p
IC201TA31136FNG
1
oSC
IN
2
oSC
oUT
3
MIX
oUT
4
VC
C
5
IFIN
6
DE
C
7
FILo
UT
8
FILI
N
9A
FoU
T
10Q
UA
D
11IF
oUT
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C20
1
0.22
u
C21
3
0.1u
C20
6
560p
R2073.3k
R118
2.2kR11
1
8.2k
C20
9
68p
R20
3
4.7k
R204
82k
C136
470p
C20
3
0.01
u
R20
6
2.7k
C374
1000p
R35
1
330k
R355
120k
C363
82p
R364
100k
C36
2
1000
p
R36
2
180k
R35
4
330k
C364
12p
C366
0.1uC384
0.1u
C382
0.015u
R369
82k
C381
390p
R363
100k
C37
3
120p
C386
0.01uC36
0
0.1u
R374
12k
C36
8
270p
C37
8
82p
C383
0.1u
C35
8
0.22
u
R37
6
470
R37
5
1.8k
C392
0.033u
C361
1u
R34
4
470k
C356
1000p
C365
120p
R353
12k
C35
5
0.01
u
R345
27k
R34
1
10k
R370
1kR352
100k
R356
4.7k
R209
3.3k
R349
1M
R20
1
180k
CD
201
L79-
1866
-05
Q201RT1P441U
C21
10.
1u
C21
40.
1uC372
1000pC390
1u
R367
39k
R366
150k
R365
3.3k
L201 1u
C367
1u
R13
0
0
C22
0
1p(B
)
C22
1
12p
R348
1k
R35
8
470k
R36
0
3.3k
R357
56k
R35
9
47k
TH20
1
100k
XF201L71-0619-0538.85 MHz
INoUT
R340
10k
C35
3
0.01
u
C35
4
0.01
u
R342
10k
C385
0.1u
R368
0
R361
0
C38
8
1000
p
C37
5
1000
p
C12
7
1u
R10
7
330
C11
4
1000
p
C12
2
1000
p
R11
9
47k
C13
2
10p
C10
6
1000
p L104
R10
8
47k
R47
4.7k
R10
3
330
R106
18
R10
1
10k
C10
1
1000
p C13
4
1000
p
R12
1
47
R10
9
270
R46
2.2k
L107
C13
5
0.1u
C10
9
0.1u
C87
1000
p
R102
10k
C12
9
1000
p
R45
330
C12
5
0.01
u
C88
1000
p
C12
3
1000
p
C89
100p
C10
7
1000
p
R10
5
330
R12
2
100k
R11
3
330
L106 9T
C11
8
1000
p
C21
2
1000
pR
211
4.7k
C22
9
6p(B
)
R215
390
C11
9
27p
R20
5
10
R32
4
4.7k
R325
4.7k
C339
1u
C34
1
1000
p
1A
GN
DIN
2TX
IN
3TX
INo
4LI
MLV
5E
XTL
IMIN
6M
oD
7V
DD
8D
TRLo
AD
N
9S
TD
10
TCLK/DTRDo
11
TDATA/DTRCLK12DI/o
13RDF/FD
14SCLK
15DIR
16XoUT
17X
IN
18V
SS
19A
MP
3P20
AM
P3N
21A
MP
3o22
AM
P4P
23A
MP
4N24
AM
P4o
25D
TRA
IN
26RXAF
27RXAFIN
28EXPoUT
29FILTERo
30RXINo
31RXIN
32AGND
R11
0
100k
C12
4
1u
C20
2
10u
RSSI
BUSY
C39
3
10u
C35
9
10u
R372
0
R34
7
0
C371
10u
L305
R10
4
22
L24
82n
D307MC2850
R350
120k
C377
0.068u
1oUT1
2-IN1
3+IN1
4VEE
5+IN2
6-IN2
7oUT2
8VCC
R373
220k
C39
1
1u
MOD
MIC
SB
5M
C370
0.1u
C37
6
1000
pC
380
1u
R371
2.7k
C38
9
1000
p
C102
39p
C108
39p
C110
1000p
R114
0
L105
22n
C120
1000pC
226
13p
C227
7p(B)
L203
39n
L202
39n
C224
6p(B)
C22
3
7p(B
)
D306KDR731
D308KDR731
D309KDR731
W/N
R398
0
L103
150n
L102
47n
Q103RT1N441U
R11
6
0
3.6864MHz CLK
MCF
38.4
MH
z
W/N SW/RX
FM SYSTEM IC
DISCHARGE SW
VOLTAGEPROTECTION
SB
RSSI
OPTDETTXD
QT/DQT_IN
PTT
MIC_MUTE
PCTV
5M
AF_CONT
VOX
W/N
STD
APC_SW
5T5C
5R
TH_DETDC_SW
B
DTMF
DTRLOADN
2ND_LO
AFVOLINAFVOLOUT
DIR
SCLK
RDF/FD
DI/O
TDATA/DTRCLK
TCLK/DTRDO
1/2_OSC
5T
5R
PCTV
PCTV
AF_CONT
TXDOPTDET
5M
PTT
SB
BUSY
RSSI
MOD
D308,309
MIC
AFVOLOUT
VOX
RECTIFICATION
2SC5636Q11
RF AMP
D10MC2858
TX/RXRF SW
RD07MVS1BT122Q105
TX FINAL AMP
IC101BA2904FVM
APC
2SK1824-AQ107
DC SW
Q108RT1P441U
DC SW
2SC4774Q202
IF AMP
D307
LIMITER
RECTIFICATION
D306
Q307RT1N441U
W/N SW/TX
Q106RT1N441U
DC SW
KTC4075E(Y,GR)Q308
RECTIFICATION
2SC4926YDQ101
RF AMP
RQA0004PXDQSQ102
TX DRIVE AMP
IC308AQUA-L
AUDIO PROCESSOR
2SC4116(GR)FQ310
2SA1586(Y,GR)FQ311
MIC MUTE
MIC MUTE
R:1.8VT:1.62V
4.85V
R:0VT:1.76V
T:0.55V R:7.6VT:6.95VT:1.21VT:2.71V
T:4.89V(H)T:2.58V(L)
W:0VN:5V
R:2.45VT:0V
TX-RX UNIT (X57-7570-20)
37
SCHEMATIC DIAGRAM TK-2302/2302(V)/2306
Note : The components marked with a dot (•) are parts of layer 1.X57-757 4/4
7
6
5
4
3
2
1
TSRQP
R381
150
C40
5
220p
R377
47k
R37
8
560
2SB1694Q313
C39
7
0.47
u
J301PTT/RXD
MICMICIN
OPTDET5MAE
TXDNC
SPOSPI
C399
100p
R38
4
33k
C39
5
220p
R379
1k
C402
0.1u
C404
100u6.3R
389
0
C40
3
0.04
7u
R38
3
56k
R380
470k
1 NC1
2 VCC
3 NC2
4 VIN
5 RIPPLE6
NF
7
PHASE
8
PRE-GND
9
PW-GND
10
PoUT
Q314RT1N441U
R38
7
100k
C40
8
1000
p
CN13
C13
8
27p
L113
7T
C15
6
15p
C14
8
1000
p
C158
7p(B)
C15
1
10p
L117 1u
C155
12p
C153
10p
C15
4
18p
L114
7T
L116
6T
R13
4
150
C14
9
22p
D10
5
HV
C13
1
D10
4
HV
C13
1
C247
3p(B)
R230
0
D20
5
1SV
305FL2
13
56n
R21
7
220
L214
27n
C26
4
5p(B
)
C257
39pC25
0
56p
R229
10C2361000p
C265
30p
L210
C25
2
1000
p
D20
3
1SV
305F
C260
4p(B)
C23
1
1000
p C25
1
5p(B
)
D20
4
1SV
305F
L211
56n
C238
1000p
L205
560n
R225
47
C25
9
56p
R21
9
100k
C23
7
6p(B
)
R216
560
C23
3
1000
p
C25
8
4p(B
)L209
56n
C25
4
1000
p
C23
2
12p
C26
3
56pC
246
56p
R22
6
220
C23
0
0.01
u
BPF
L204
3SK318Q203
C249
2.5p(B)
C26
1
1000
p
3SK318Q204
C24
5
1000
p
R22
8
56k
D20
2
1SV
305F
C262
4p(B)
C24
4
3p(B
)
R21
8
100k
C24
8
1000
p
R220
56
L112
8T
C25
5
1000
p
MIC301
C24
3
10u
CP
202
RK
75H
A1J
474J
CP
204
RK
75H
A1J
474J
C396
0.1u
C40010u
R39
0
0
C23
5
0.01
u
CP304RK75HA1J102J
CP
203
RK
75H
A1J
104J
CP
201
RK
75H
A1J
104J
R388100
R385
100
L108
3T
L109
5T
C13
9
68p
C14
1
27p
C14
3
13p
L110
7T
C145
82p
C150
1000p
L111
680n
C15
2
11p
L115
12n
C15
7
33p
R22
4
2.2k
R223
0
R222
0
L207
100n
C22
8
0.1u
L216
27n
R23
1
1k
C41
5
1000
p
C14
6
7p(B
)
L206
180n
ANT
MIXER
MUTE SW
5T
5R
AFV
OLO
UT
PCTV
AF_CONT
OPTDETTXD
5M
PTT
SB
PCTV
SBSB
MIC
GND
GND
DC SW
D103
HSC277
ANT SW
ANT SWANT SW
D204,205
RF BPF TUNING
RF BPF TUNING
D202,203
Q312RT1N441U
DC SW
IC309TA7368FG
AUDIO AMP
2SK3577-AQ316
MUTE SW
LOW NOISE AMP
Q204
2SK3577-AQ315
MUTE SW
R:4.8VR:1.7V
R:4.7V
R:0.73V
R:2.41V
R:2.41VR:0.94V
R:4.82V
T:0.35VR:7.73VT:9.2V
T:-1.45V
7.55V(MUTE OFF)R:0.25V(MUTE ON)
R:7.7V(MUTE ON)0.16V(MUTE OFF)
TX-RX UNIT (X57-7570-20)
TK-2302/2302(V)/2306
38
BLOCK DIAGRAM
Power Switch/AF Volum
ChannelSelector
R31-0670-15
S60-0440-05
1
2
3
4
5
6
7
8
9
10
11
Tx VCO
Q5:2SK1875-F(V)
LoopFilter
PLL IC
5C
IC1:MB15A02PFV2E1
X1:L77-3042-05
PLL_STB
PLL_DAT
PLL_CLK
PLL_UL
12.8MHz
2nd Local:38.40MHz
CeramicFilter
CF201:L72-0973-05
2nd IF:450kHz
BUSY
FM
ICTA31
MOD
BatteryProtector
D301:GN1G
Fuse
F301:F53-0324-05
2.5A
D303:B30-2315-05
SB
BATT
PTT
SIDE1
SIDE2
EEPROM
5M
EEPCLK
EEPDAT
IC305:BR24L16F-W
PTTSIDE1
X301:L78-1433-05
14.746MHz
RSSI
5M
IC306:R5F212CCKCMB
MCU
R305
R301
X57-7570-20 (TX-RX UNIT)
LED
LEDRXLEDTX
TCXO
Tripler
Q2:2SC4774
SIDE2
Q305,Q306:2SC4919
BSHIFT
RDF/FD
OPTDET
PLL_UL
VOX
BATT
QT/DQT_IN
BUSYRSSI
TH_DET
RXD
Low PassFilter
B
5C
5T
5R
5M
Regulator
Regulator
Voltage
Voltage
Switch
Switch
5T_C
5R_C
5C_C
IC303:XC6209B502PR
LEDD304:B30-2314-05
SBSB
5R
QTTCXO
Rx VCO
MOD
QTVCO
D4,D8:1SV325FD9:1SV278F
Q4:2SK1875-F(V)D3,D6:1SV325F
Switch
Switch
RX_SW
TX_SW
5M
Q7:RT1P430U
Q8:RT1P430U
Oscillator:272.000~348.000MHz
Oscillator:349.700~425.700MHz
B
SB
AFVOL_IN
AFVOL_OUT
EN1
EN2
EN3
EN4
EN5
IC304:XC6209B502MR
ResetDetectorVoltage
IC301:BD4840FVE
Q304:DTB723YE
Q303:RT1P141U
DET
EN1EN2EN3EN4EN5Reset
EEPCLK
DTMF
PCTV
PLL_DATPLL_CLKPLL_STB
5T_C5C_C5R_C
W/N
AF_CONT
BSHIFT
QTTCXOQTVCO
MIC_MUTE
TX_SWRX_SW
LEDTXLEDRX
APC_SW
STD
1/2_OSC
TXD
DTRLOADNTDATA/DTRCLKSCLK
Q
W/N
Rectifier
D302:HRC0203C
Rectifier
Q1:KTC4075E(Y,GR)
DC_SW
Switch Switch
Q301:RT1N441U Q302:RT1N441U
ShiftSwitch
CeramicOscillator
DI/OEEPDAT
TK-2302/2302(V)/2306
39
BLOCK DIAGRAM
Tx/Rx:136.000~174.000MHz
Low PassFilter
ANT
D104,D105:HVC131D103:HSC277
SwitchFinalAmp
Q105:RD07MVS1BT122
Q102:RQA0004PXDQS
DriveAmp
5T
RF Amp1stMixer
RF Amp
5R5R
D204,D205:1SV305FQ204:3SK318
Q203:3SK318
5C
Q11:2SC5636
BufferAmp
Q9:2SC5636
XF201:L71-0619-05
1st IF:38.85MHz
5C
LippleFilter
Q6,Q10:KTC4075E(Y,GR)
(V) RF Amp
Q3:2SC5636
5C
IF Amp
Q202:2SC4774
5R5C
Discrimi-nator
CD201:L79-1866-05
5R
1st Local:174.850~212.850MHz
40MHz
450kHz
BUSY
FM IF IC
IC201:TA31136FNG
Rx:136.000~174.000MHz
RXD
MicAGC/Mute
5M
Q310:2SC4116(GR)F
MIC_MUTE
D306:KDR731
VOX
AFPowerAmp
IC309:TA7368FG
AFVOL_IN
MOD
1/2_OSC
DIR
Audio Prosessor
IC308:AQUA-LQT/DQT_IN
5M
RSSI
Mic
T91-0651-15MIC301:
SP/MIC Jack
Speaker
Detector
B
IC101:BA2904FVM
Switch
Q201:RT1P441U
W/N
Tx:136.000~174.000MHz
Pre-driveAmp
Q101:2SC4926YD
PCTV
DI/O
TXD
SB
5R
5T
5T
TH101
TH_DET
APC
Q108:RT1P441U
SwitchAPC_SW
Q106:RT1N441U
BB
F
(V)F
TX_SW
T1P430U
Oscillator:272.000~348.000MHz
Frequen-cy
Divider
5C
IC2:UPB1509GV
Tx/RxSwitch
D202,D203:1SV305F
5T 5R
PCTVPCTV
BandPassFilter
BandPassFilter
MCF
Q312:RT1N441U
Q313:2SB1694
SwitchMute
Q314:RT1N441UQ315,Q316:2SK3577-A
OPTDET
AFVOL_OUT
Switch
Q311:2SA1586(Y,GR)F
Q308:KTC4075E(Y,GR)
D308,D309:KDR731
Q107:2SK1824-A
DET
DET
DTRLOADN
STD DTMF
Limiter
D307:MC2850
Protector D101:UDZW5.1(B)
Switch
Q307:RT1N441U
W/N
SwitchAPC_SW
Switch
Switch DC_SW
Q103:RT1N441U
T07-0369-15
E11-0703-05
Tempera-ture
Detector
D10:MC2858
Switch AF_CONT
SCLK
TDATA/DTRCLK
RDF/FD
TCLK/DTRDO
TK-2302/2302(V)/2306
40
LEVEL DIAGRAMR
eceiv
er
Secti
on
Tra
nsm
itte
r S
ecti
on
)zHk1( F
A
RF
(Cen
ter
Freq
uen
cy)
RF
(Cen
ter
Freq
uen
cy)
–121
.0d
Bm
–120
.5d
Bm
–118
.0d
Bm
–104
.0d
Bm
–106
.5d
Bm
–100
.5d
Bm
210m
V13
0mV
IF1
(38.
85M
Hz)
IF2
(450
kHz)
AF
(1kH
z)
SP
500m
WC
150
C25
7Q
204
C23
8Q
203
Q20
2X
F201
C21
7C
215
IC20
1
FM IF
SY
ST
EM
C39
0
AQ
UA
-L
IC30
8C
391
IC30
9
15m
Vrm
s
120m
Vrm
s1.
6dB
m8.
2dB
m37
.1d
Bm
–4.0
dB
m5.
0W
MIC
AQ
UA
-L
IC30
8C
45
VC
O
PLL
C51
C81
IC2
Q9
C87
RX
LOD10
C10
2Q
101
C10
8Q
102
Q10
5C
150
To m
ake
mea
sure
men
ts in
th
e A
F se
ctio
n, c
on
nec
t th
e A
C le
vel m
eter
. (A
NT
inp
ut:
–53
dB
m, 1
kHz
FM, 3
kHz
DE
V (
WID
E).
)In
th
e R
F se
ctio
n,u
se 1
000p
F co
up
ling
cap
acit
or.
(Th
e d
isp
lay
sho
ws
the
SS
G in
pu
t va
lue
req
uir
ed t
o o
bta
in
12d
B S
INA
D w
ith
ou
t Lo
cal L
evel
.)
AG
is s
et t
o t
he
MIC
Inp
ut
bec
om
es 3
kHz
DE
V. a
t 1k
Hz
MO
D. (
WID
E).
To m
ake
mea
sure
men
ts in
th
e A
F se
ctio
n, c
on
nec
t th
e A
C le
vel m
eter
.In
th
e R
F se
ctio
n, u
se 1
000p
F co
up
ling
cap
acit
or.
TK-2302/2302(V)/2306
41
SPECIFICATIONS
GeneralFrequency Range ...................................................136~174MHzNumber of channels ..............................................Max. 16Channel Spacing ....................................................25kHz, 30kHz (Wide) / 12.5kHz, 15kHz (Narrow)PLL Channel Stepping ...........................................2.5kHz, 5kHz, 6.25kHz, 7.5kHzOperating Voltage ..................................................7.5 V DC±20%Battery Life ............................................................More than 18 hours at 5 watts (5-5-90 duty cycle with KNB-45L battery)Operating Temperature range ...............................–30°C to +60°C (–22°F to +140°F)Frequency Stability ................................................±2.5ppm (–30°C to +60°C)Channel Frequency Spread ....................................38MHzDimensions and Weight (Dimensions not including protrusions) Radio Only .........................................................160g (5.6oz) With KNB-45L (2000mAh battery) .....................54 (2.13) W x 122 (4.8) H x 33.8 (1.33) D mm (inches) 280g (9.9oz)
Receiver (Measurements made per TIA/EIA-603)Sensitivity EIA 12dB SINAD ................................................0.25µV (Wide) / 0.28µV (Narrow)Selectivity ..............................................................70dB (Wide) / 60dB (Narrow)Intermodulation .....................................................65dB (Wide) / 60dB (Narrow)Spurious response .................................................65dBAudio Power Output ..............................................500mW at 4Ω less than 10% distortion
Transmitter (Measurements made per TIA/EIA-603)RF Power Output ...................................................5W/1WSpurious and Harmonics ........................................65dBModulation .............................................................16K0F3E (Wide) / 11K0F3E (Narrow)FM Noise ...............................................................45dB (Wide) / 40dB (Narrow)Audio Distortion .....................................................Less than 5%
TK-2302/2302(V)/2306
2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525 Japan
P.O. BOX 22745, 2201 East Dominguez Street, Long Beach,
6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8
Rembrücker Str. 15, 63150 Heusenstamm, Germany
Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium
KENWOOD House, Dwight Road, Watford, Herts.,
Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands
Via G. Sirtori, 7/9 20129 Milano, Italy
Bolivia, 239-08020 Barcelona, Spain
(A.C.N. 001 499 074)16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113 Australia
Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road,
1 Ang Mo Kio Street 63, Singapore 569110
CA 90801-5745, U.S.A.
Kwai Fong, N.T., Hong Kong
WD18 9EB United Kingdom
L’Etoile Paris Nord 2, 50 Allée des Impressionnistes, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
S
GD
D
G
S
D
GS
C44
C45
C400
C404
C405
C213
C414
C415
F301
C3
Q106
Q107
Q108
Q301
Q302Q304
Q316
L302
L304
R302
R303
R307
R308
R309
R116
R117
R310
R120
R316
R123
R317
R319
CN301
R324
R132
MIC301
C303
BATT+
C304
C305
C307
C310
C311
C313
C315
R12
C318
R17
C321
C130
R20R21
C325
Q1
R26
R27
C331
C140
R30
C337
C339
R2
R377
R3
R378
R381
R383
R385
R387
R388
R389
D303
D304
IC303
C395
C396
C397
CP301
CP303 CP304
R201
RXD TXD
A4A1
A6A5A3
A2
1
4 5
8
THDET
MDSW
5M
3 4
51
LV
+ + +
5T+ –
PCTV
+
ANT
1 11EN
5EN
4EN
3G
ND
EN2
EN1
AFV
OLG
ND
AFV
OLO
UT
AFV
OLIN
SB
B
C36
C39
C418
C1
C8
C9
Q305
Q306
L301
L303
L306
R301
R304
R305
R306
R313
R314
R315R
318
CN302RESET
CN303MODE
R320
R321
R323
X301
C316
C319
R19
C327
C332 C
334C335
R1
IC301
3 1
4 5
IC305
IC306
CP302
CP1
C10
R210
C27
C30
CN
201B
US
Y
C32
CN
202R
SS
I
CN
203B
PF
C35
C201
TH201
C210
Q303
Q307
L7
R325
IC1 R14
R15
R16
R18 R
22
R7
C341
Q201
C11
C15
R209
C402
C403
C2
Q103
Q312
Q313
Q314
Q315
L117
R111
R118 R
124
R125
R126
R128R
129
R130
R131
R133
C103
TH101
C107
C109
C122
C124
C320
C322
C136
R379
R380
R384
R390
D101
R393
IC101
45
18
IC309
C399
C4
C6
R127
C131
VOX
QTI
GND
SB
1
2021 40
41
606180
AFMUTE
AFCONT
B
GND
GND
5R
W/N
5C
PTT
MOD
LD
1011
120
SP–
SP+
56
110
J79-0186-09
TXD
AE
SPI
SPO
NC
5M OPTDET MIC
PTT/RXD
MICIN
TK-2302/2302(V)/2306 PC BOARD
TX-RX UNIT (X57-7570-20) Component side view (J79-0186-09) TX-RX UNIT (X57-7570-20) Component side view (J79-0186-09)
PC BOARD TK-2302/2302(V)/2306
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
Ref. No. Address
IC1 9G
IC101 4N
IC301 6B
IC303 6H
IC305 5C
IC306 7D
IC309 7O
Q1 8H
Ref. No. Address
Q103 4M
Q106 3M
Q107 3M
Q108 4M
Q201 5G
Q301 6P
Q302 6P
Q303 5I
Ref. No. Address
Q304 6I
Q305 7B
Q306 8B
Q307 8H
Q312 8P
Q313 7P
Q314 8O
Q315 8O
Ref. No. Address
Q316 8O
D101 4M
D303 8S
D304 8S
J K L M N O P Q R SIHGFEDCBA
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
D SG
D SG
R211
C25
XF201
R214
R215
C29
R217R218
R219
C31
R225
R226
R229R230
R231
C49
C51
C202
C204
C205
C56
C206
C57
CD201
C209
C59
C212
C62
C63
C408
C64
C215
C217
C413
C70
C221
C223
C225
C75
C226
C76C78
C229
C231
C81
45
18
C82
C83
C86
C236
C88
C238
C89CF201
C243
C245
C247C249
C5
TC2
TC1
C250C254
C255
G
G
S
D
G
G
S
D
C257
Q101
E
C E
B
D3
D4
Q105D G
C260
D9
Q308
L104
L108
Q310
Q311
L110
L305
L112L113
IC201
L116
CP202
CP204
R102
R104
R106
D10
R110
L1
L2
L6
R134
L10
L12
L13
L14
C101
C102
L17
L18
C106
L22
L23C110
L24
R340
R344
R345
C118
R348
R10
R351R353
R354
R355
R356
R357
R358
S1PTT
R362
S2SIDE1
S3SIDE2
R368
R369
R29
Q6
Q8
R370
R371
R31
R32
C143
R35
R375
R376
C146 C148
R38
R4
R39
C150
R40R41
C151
R43
C154
R46
C158
C353
C355
C358
R394
Q203
Q204
D301
D302
D306
C367
D307
D308
C369
D309
L201
L204
C370
C371
L206
C372
L207
C373
C374
C378
C381
L216
C385
C386
IC308
1
910 16
17
252632
C390
C392
C393
X1
C12
C14
R203
C18
R205
R207
R208
J301EXT. SP/EXT. MIC
TXD
AE
SPI
SPO
NC
5MOPTDETMIC
PTT/RXD
MICIN
R222
R223
R224
R228
C244
C246
C248C
251
C252
C258
C259
C261
C262
D202
C263
D203
C264
D204
C265
D205
L102
L103
L105
L106
L107
L111
L114
R103
R105
R107
R108
R109
R113
R114
R119
R121
R122
C108C
114
C119
C120
C123
C125
C127
C129
C134
C135
C145
C149
C152
C153
C155
C156 C
157
D103
D104
D105
L209
L210
L211
L213
L214 R220
C53
C58
C61
C66
C72
C77
C228
C80
D8
L109
L115
CP201
CP203
R101
L15
L21
C132
C138
C139
Q5
C141
R33
C23
R212
C26
R213
R216
C33
C40
C41
C42C
47C
50
C52
C203
C207
C208
C60
C211
C214
Q10
Q11
C65
C216
C67
C68
C71
C224
C74
C227
C79
C230C
232
C233
C84
C235
C87
C237
C7
Q102
D S G
D6
L4
L8
L9L11
L16
L19
L20
R11
R13
Q2
Q3
R28
Q4
Q7
R34
R36
R37
R5R9
R42
R44
R45
R47
C359
Q202
C360
C368
L202
L203
L205
C13
C16
C17
R204
R2068
9
116
C220
C73
IC2
C306
R347
R349
C312
R350
R352R
359
C323
R360
R361
R363
R364
R365 R
366
R367
Q9
R372
R373
R8
VR
1
R398
C361C
362
C363
C364
C365
C366
C375
C376
C377
C379
C380
C382
C383
C384
IC304 3
4
15
C388
C389
C391
CN
304M
DS
W
R341
R342
R374
C354
R391
C356
J79-0186-09
TK-2302/2302(V)/2306 PC BOARD
TX-RX UNIT (X57-7570-20) Foil side view (J79-0186-09) TX-RX UNIT (X57-7570-20) Foil side view (J79-0186-09)
PC BOARD TK-2302/2302(V)/2306
Component side
Foil side
Layer 1Layer 2Layer 3Layer 4
Ref. No. Address
IC2 6K
IC201 6N
IC304 9P
IC308 8P
Q2 8N
Q3 7L
Q4 9L
Q5 8J
Q6 7K
Ref. No. Address
Q7 8K
Q8 7J
Q9 7K
Q10 7K
Q11 5L
Q101 6I
Q102 7H
Q105 7F
Q202 5N
Ref. No. Address
Q203 4K
Q204 5G
Q308 7R
Q310 7R
Q311 7R
D3 10K
D4 9J
D6 10K
D8 9I
Ref. No. Address
D9 8J
D10 5L
D103 5D
D104 4E
D105 4D
D202 4I
D203 4H
D204 4F
D205 4F
Ref. No. Address
D301 4R
D302 10P
D306 8R
D307 8Q
D308 7Q
D309 7Q
-t
-t
EN3
EN4
EN5
EN2
EN1
B
C31
9
1000
p
C32
7
1000
p
R306
180k
C10
3
1u
C31
8
0.01
u
C37
9
1u
C31
2
1000
p
C32
1
1u
R125
150k(D)
L21
R21
0
4.7k
R214
470
C35
0.1u
35
TC2
10p
C71
0.5p(B)
C18
18p
C57 9p (B)
R13
1
56k
C217
0.01u
R12
9
47k
C70
0.5p(B)
C20
4
1000
p
R12
6
330k
(D)
D4
1SV
325F
C27
0.33
u35
C67
6p(B
)
R12
8
1M
R20
8
82k
C25
30p
C12
1000
p
C75
470p
R15
560
C20
5
1800
p
TH10
1
100k
C76
10u6
.3
R213
180k
R14 10
C10
100p
C65
5p(B
)
C215
2p(B)
C13
0
1000
p
C77
1000
p
C369
0.1u
C131
100p
R12
220
R124
150k(D)
C53
180p
R34
180
D10
1
UD
ZW
5.1(
B)
R20
0
R28 1k
R30
100k
R37
4.7k
R13
3
470k
C207
560p
C21
6
0.01
u
C225
0.01u
C21
0
0.1u
D8
1SV325F R11
7
0.39
R12
3
0.39
R13
100
L7
R8
100
R12
0
0.39
R21
2
100
D6
1SV325F
C7
10p
R32
680k
R132
100k
C14
0.01
u C58 2p (B)
R127
330k(D)
C208
0.1u
TC1
10p
CF201L72-0973-05
450 kHz
C14
0
1000
p
C31
0.01u
C61
5p(B
)
C5
1000
p
L4 560n
C26
2p(B)
C4
0.1u
C9
100p
R9
2.2k
IC201TA31136FNG
1
oSC
IN
2
oSC
oUT
3
MIX
oUT
4
VC
C
5
IFIN
6
DE
C
7
FILo
UT
8
FILI
N
9A
FoU
T
10Q
UA
D
11IF
oUT
12R
SS
I
13N
-DE
T
14N
-RE
C
15G
ND
16M
IXIN
C56
6p(B
)
C20
1
0.22
u
R10 1k
R22
10k
C21
3
0.1u
C20
6
560p
R2073.3k
C78
33p
R35 68D9
1SV278F
R118
2.2k
C16
47p
R11
1
8.2k
C52
120p
C13
10p
R29
150k
C20
9
68p
R39
100
R18
680
R20
3
4.7k
R204
82k
D3
1SV
325F
C8
100p
C136
470p
C68
470p
C20
3
0.01
u
C29
27p
R20
6
2.7k
R26
27k
R17
1.5k
C30
1000
p
C51
10p
R11
330k
C374
1000p
R35
1
330k
R355
120k
C44
1u
C363
82p
R364
100k
C36
2
1000
p
R36
2
180k
R35
4
330k
C364
12p
C366
0.1uC384
0.1u
C382
0.015u
R369
82k
C381
390p
R363
100k
C37
3
120p
C386
0.01uC36
0
0.1u
R374
12k
C36
8
270p
C37
8
82p
C383
0.1u
R381
150
C35
8
0.22
u
R37
6
470
C40
5
220p
R377
47k
R37
8
560
2SB1694Q313
R30
8
220
C39
7
0.47
u
R37
5
1.8k
J301PTT/RXD
MICMICIN
OPTDET5MAE
TXDNC
SPOSPI
C392
0.033u
C399
100p
R38
4
33k
C39
5
220p
R379
1k
C402
0.1u
C404
100u6.3
R38
9
0
C32
5
1000
p
C40
3
0.04
7u
C361
1u
R38
3
56k
R380
470k
R1
22k
C32
0
1000
p
1 NC1
2 VCC
3 NC2
4 VIN
5 RIPPLE6
NF
7
PHASE
8
PRE-GND
9
PW-GND
10
PoUT
R34
4
470k
Q314RT1N441U
R30
7
270
L301
C31
310
0p
C30
510
0p
C30
40.
1u
C31
110
0p
D30
1
GN
1GC
307
100p
R27
820k
C356
1000p
C365
120p
R353
12k
C35
5
0.01
u
R345
27k
R34
1
10k
R370
1k
C36
3300
p
C39
6800
p
R352
100k
L303
C334
0.01u
L304
R356
4.7k
R209
3.3k
R349
1M
C33
470p
C31
0
1u
C332
5p(B)
R31
8
1.8k
R319
0
C337
5p(B)
R5
150k
R4
100k
C1
3300
p
C2
6800
pR2
10k
R3
47k
C32
3.3u
16
R20
1
180k
R31
6
2.2k
CD
201
L79-
1866
-05
D303B30-2315-05
D304B30-2314-05
C3
1u
Q201RT1P441U
C21
10.
1u
C21
40.
1uC372
1000pC390
1u
R303 100
R38
7
100k
R19
22k
R21
10k
R367
39k
R366
150k
R301
470k(D)
R30
5
470k
(D)
R304
330k
R70
R31
7
4.7k
Q301RT1N441U
Q302RT1N441U
R365
3.3k
R31
510
k
L201 1u
C32
3
1u
C367
1u
R13
0
0
R38
150k
R31
270k
C60
4.5p
(B)
C22
0
1p(B
)
C22
1
12p
S1
S2
S3
C32
2
1000
p
L11
180n
L16
22n
C59
2.5p (B) C74
1000
p
C635p(B)
C62
470p
C73
0.1u
C79
470p
L10
180n
L15
33n
C646p(B)
C72
0.1u
C66
470p
R33
100
C50
470p
C42
6p(B
)
C40
6p(B
)
C41
4p(B)
C47
15p
R348
1k
R35
8
470k
R36
0
3.3k
R357
56k
R35
9
47k
TH20
1
100k
1oS
CIN
2N
C1
3oS
CoU
T4
VP
5V
CC
6D
o7
GN
D8
LD9
NC
210
FIN
11C
LoC
K
12N
C3
13D
ATA
14LE
15FC
16N
C4
17Fo
UT
18P
19N
C5
20R
XF201L71-0619-0538.85 MHz
INoUT
C31
510
0p
X1
12.8MHz
L77-3042-05
1VCoNT
2GND
3oUTPUT
4VCC
R340
10k
C35
3
0.01
u
C35
4
0.01
u
R342
10k
C385
0.1u
R16 0
R302 0
VR
110
0k
R368
0
R361
0
1Vo
UT
2S
UB
3N
C4
GN
D
5V
DD
1VIN
2VSS
3CE
4NC
5VoUT
1A0
2A1
3A2
4GND
5SDA
6SCL
7WP
8VCC
C31
6
1000
p
C38
8
1000
p
C40
8
1000
p
C37
5
1000
p
CN13
C80
470p
R32
0
12k
L6 560n
L2
4.7u
L1
CP
303
RK
75H
A1J
102J
C12
7
1u
R43
3.3k
R10
7
330
C11
4
1000
p
C13
8
27p
C12
2
1000
p
R11
9
47k
C13
2
10p
C10
6
1000
p
C86
1000
p
L104
L113
7T
R10
8
47k
R47
4.7k
R10
3
330
C15
6
15p
C81
15p
C14
8
1000
p
R106
18
R10
1
10k
C158
7p(B)
C10
1
1000
p C13
4
1000
p
R12
1
47
R10
9
270
R46
2.2k
L107
C13
5
0.1u
C15
1
10p
C10
9
0.1u
C87
1000
p
L117 1u
R102
10k
C12
9
1000
p
C155
12p
R45
330
R42
3.3k
C12
5
0.01
u
C88
1000
p
C12
3
1000
p
C89
100p
C153
10p
C10
7
1000
p
R44 22
R10
5
330
C15
4
18p
L114
7T
L116
6T
R12
2
100k
R11
3
330
L106
9T
R13
4
150
C11
8
1000
p
C14
9
22p
D10
5
HV
C13
1
D10
4
HV
C13
1
C21
2
1000
pR
211
4.7k
C22
9
6p(B
)
C247
3p(B)
R230
0
D20
5
1SV
305FL2
13
56n
R21
7
220
L214
27n
C26
4
5p(B
)
C257
39pC25
0
56p
R229
10C2361000p
C265
30p
L210
C25
2
1000
p
D20
3
1SV
305F
C260
4p(B)
C23
1
1000
p C25
1
5p(B
)
D20
4
1SV
305F
L211
56n
C238
1000p
L205
560n
R225
47
C25
9
56p
R21
9
100k
C23
7
6p(B
)
R216
560
C23
3
1000
p
C25
8
4p(B
)L209
56n
C25
4
1000
p
C23
2
12p
C26
3
56pC
246
56p
R22
6
220
C23
0
0.01
u
BPF
L204
3SK318Q203
C249
2.5p(B)
C26
1
1000
p
3SK318Q204
C24
5
1000
p
R22
8
56k
D20
2
1SV
305F
C262
4p(B)
C24
4
3p(B
)
R21
8
100k
R215
390
C24
8
1000
p
R220
56
L112
8T
C11
9
27p
R20
5
10
C25
5
1000
p
C45
1u
R32
4
4.7k
R325
4.7k
C339
1u
C34
1
1000
p
1A
GN
DIN
2TX
IN
3TX
INo
4LI
MLV
5E
XTL
IMIN
6M
oD
7V
DD
8D
TRLo
AD
N
9S
TD
10
TCLK/DTRDo
11
TDATA/DTRCLK12DI/o
13RDF/FD
14SCLK
15DIR
16XoUT
17X
IN
18V
SS
19A
MP
3P20
AM
P3N
21A
MP
3o22
AM
P4P
23A
MP
4N24
AM
P4o
25D
TRA
IN
26RXAF
27RXAFIN
28EXPoUT
29FILTERo
30RXINo
31RXIN
32AGND
MIC301X301
14.746MHzL78-1433-05
R11
0
100k
L9
F301F53-0324-05
2.5A
CP1RK75HA1J101J
C11
10u
C17
0.01
u
C15
0.01
u
C23
0.01
u
C12
4
1u
C20
2
10u
C24
3
10u
CP
202
RK
75H
A1J
474J
CP
204
RK
75H
A1J
474J
RSSI
BUSY
C396
0.1u
C40010u
C39
3
10u
C35
9
10u
R372
0
R34
7
0
C371
10u
2SC4919Q305
R31
4
10k
R321
10k
CP
302
RK
75H
A1J
473J
1N
C2
VS
S3
CE
4V
IN
5Vo
UT
C30
6
1u
L302
L305
R10
4
22
R39
0
0
C335
10u
L8
18n
L12
33n
L18
270n
L17
270n
L20
180n
L19
180n L2
2
39n
L24
82n
C23
5
0.01
u
D307MC2850
R350
120k
C377
0.068u
CP304RK75HA1J102J
L13
180n
L14
180n
R36
100
CP
203
RK
75H
A1J
104J
CP
201
RK
75H
A1J
104J
1oUT1
2-IN1
3+IN1
4VEE
5+IN2
6-IN2
7oUT2
8VCC
CN301
1 B
2 SB
3 AFVOLIN
4 AFVOLOUT
5 AFVOLGND
6 EN1
7 EN2
8 GND
9 EN3
10 EN4
11 EN5
R373
220k
C39
1
1u
15T
_C2
PLL
_STB
35C
_C4
5R_C
5W
/N6
MO
DE
7A
F_C
ON
T8
BS
HIF
T9
RE
SE
T10
XO
UT
11V
SS
12X
IN13
VC
C14
QTT
CX
O15
QTV
CO
16A
UX
617
AU
X5
18A
UX
419
AU
X3
20A
UX
2
21AUX1
22MIC_MUTE
23AF_MUTE
24LED_BLUE
25NC
26NC
27NC
28NC
29NC
30NC
312TONE
32NC
33RXDATA
34TXDATA
35OPTDET
36TX_SW
37RX_SW
38
LEDRX
39
LEDTX
40
APC_SW
41D
C_S
W
42S
TD
431/
2_O
SC
44IN
T
45TX
D
46R
XD
47D
IR
48D
I/O
49D
TRLO
AD
N
50TD
ATA
/DTR
CLK
51S
CLK
52TC
LK/D
TRD
O
53R
DF/
FD
54M
DS
W
55P
TT
56S
IDE
1
57S
IDE
2
58E
N5
59E
N4
60E
N3
61EN2
62EN1
63DEST1
64DEST2
65PLL_UL
66BATT
67RSSI
68BUSY
69VOX
70QT/DQT_IN
71EEPCLK
72EEPDAT
73TH_DET
74DTMF
75AVSS
76PCTV
77VREF
78AVCC
79 PLLDAT
80 PLLCLK
R323
1k
C33
1
0.1u
R310
0
R313
1k
R309
0
CP
301
RK
75H
A1J
473J
R388100
R385
100
RESET MODE
PCTV
MOD
MDSW
C6
0.01u
LD
VOX
QTI
MIC
MICMUTE
AFMUTE
THDET
AFCONT
PTTSW
TXD
RXD
SB
5M
B
C370
0.1u
C37
6
1000
pC
380
1u
R371
2.7k
C38
9
1000
p
IC2UPB1509GV
1VCC1
2IN
3IN
4GND
5SW1
6SW2
7OUT
8VCC2
C82
470p
L23
R40 10
C83
470p
R41
1k
C84
1000p
C102
39p
C108
39p
C110
1000p
R114
0
L105
22n
C120
1000p
L108
3T
L109
5T
C13
9
68p
C14
1
27p
C14
3
13p
L110
7T
C145
82p
C150
1000p
L111
680n
C15
2
11p
L115
12n
C15
7
33p
R22
4
2.2k
R223
0
R222
0
L207
100n
C22
6
13p
C227
7p(B)
L203
39n
L202
39n
C224
6p(B)
C22
3
7p(B
)
C22
8
0.1u
C30
3
1000
p
R391
1k
D306KDR731
D308KDR731
D309KDR731
R394
47k
R393
0
L216
27n
R23
1
1k
C413
1000p
C41
4
1000
p
W/N
C41
5
1000
p
R398
0
L103
150n
C41
8
39p
L102
47n
L306
27n
C49
0.5p
(B)
C14
6
7p(B
)
Q103RT1N441U
R11
6
0
L206
180n
ANT
CV
Side1
Side2
LR
SIDE2
LG
GND
PTT
PTT
SIDE1
BATT
BATT
TXCO
3.6864MHz CLK
MCF
38.4
MH
z
VCO (TX)
VCO (RX)
REVERSEVOLTAGEPROTECTION
PRESCALER
TX-RX UNIT (X57-7570-20)
MIXER
W/N SW/RX
FM SYSTEM IC
BEAT SHIFT SW
DC SW/RED COLOR LED
DISCHARGE SW
VOLTAGEPROTECTION
MUTE SW
EN2
5M
PLL_UL
EN1
BATT
5C
EN1
EN5
5M
5C_C
PLL_DAT
LEDRX LEDRX
2ND_LO
EN3
5T
PLL_STB
PLL_CLK
5T_C
SB
SIDE2
INT
5C_C
B
EN2
EN4
5R_C
PLL_CLK
SB
5R_C
5T_C
PLL_DAT
5TQTTCXO
BATT
EN5
LEDTX
5C
EN3
B
RESET
PLL_UL
EN4
5R
QTTCXO
LEDTX
PTT
RESET
PLL_STB
5R
PLL_DAT
PLL_STB
PLL_CLK
2ND_LO
AFVOLINAFVOLINAFVOLOUT
SIDE1SIDE1PTT
INT
SIDE2
QTTCXO
PLL_DATPLL_STB
PLL_CLK
PLL_UL
B
5C
SB
LEDTXLEDRX
SB
RSSI RSSI
OPTDETTXD
PCTV
QT/DQT_IN
5M
PTT
AF_CONT
MIC_MUTE
PCTV
MIC_MUTE
5M
OPTDETTXD
PTT
QT/DQT_IN
AF_CONT
VOX VOX
W/N W/N
APC_SWDC_SW
STD
APC_SW
5T
5RB
5C5C
DTRLOADN
5T
5R
TH_DET TH_DETDC_SW
DTMF
B
DTMF
DTRLOADN
2ND_LO2ND_LO
AFVOLIN AFVOLINAFVOLOUT
DIR
SCLK
RDF/FD
DI/O
TDATA/DTRCLK
TCLK/DTRDO
W/N
STD
1/2_OSC
1/2_OSC
PTT
TXDDIR
DI/O
TDATA/DTRCLKSCLKTCLK/DTRDORDF/FD
5T5T
5R 5R
AFV
OLO
UT
PCTV
PCTV
PCTV
AF_CONTAF_CONT
OPTDETTXD TXD
OPTDET
5M5M
PTTPTT
SB SB
BUSY BUSY
RSSI
MOD MODMOD
2ND_LO
1/2_OSC
D308,309
PCTV
SBSB
MIC MIC
MODULATOR
AFVOLOUT AFVOLOUTAFVOLOUT
VOX
GND
GND
DC SW/GREEN COLOR LED
DC SW
RED COLOR LED GREEN COLOR LED
RECTIFICATION
IC306R5F212CCKCMA
MCU
IC301BD4840FVE
VOLTAGEDETECTOR/RESET
D302
HRC0203C
RECTIFICATIONIC304
XC6209B502MR
VOLTAGEREGULATOR/5V
IC303XC6209B502PR
VOLTAGEREGULATOR/5V
KTC4075E(Y,GR)Q1
RECTIFICATION
2SC4774Q2
TRIPLER
2SC5636Q3
RF AMP
Q304DTB723YE
DC SW/5T
Q303RT1P141U
DC SW/5R
IC305BR24L16F-W
EEPROM
FREQUENCYCONTROL/RX VCO
D3,6
FREQUENCYCONTROL/TX VCO
D4,8
Q52SK1875-F(V)
VCO/TX
KTC4075E(Y,GR)Q6
RECTIFICATION
KTC4075E(Y,GR)Q10
RIPPLEFILTER
Q8RT1P430U
DC SW/TX VCO
2SK1875-F(V)Q4
VCO/RX
Q7RT1P430U
DC SW/RX VCO
2SC5636Q9
RF AMP
2SC4919Q306
BEAT SHIFT SW
2SC5636Q11
RF AMP
D10MC2858
TX/RXRF SW
RD07MVS1BT122Q105
TX FINAL AMP
IC101BA2904FVM
APC
2SK1824-AQ107
DC SW
Q108RT1P441U
DC SW
D103
HSC277
ANT SW
ANT SWANT SW
D204,205
RF BPF TUNING
RF BPF TUNING
D202,203
Q312RT1N441U
DC SW
IC309TA7368FG
AUDIO AMP
2SK3577-AQ316
MUTE SW
2SC4774Q202
IF AMP
IC1MB15A02PFV2E1
PLL SYSTEM IC
D307
LIMITER
RECTIFICATION
D306
Q307RT1N441U
W/N SW/TX
Q106RT1N441U
DC SW
KTC4075E(Y,GR)Q308
RECTIFICATION
LOW NOISE AMP
Q204
2SK3577-AQ315
MUTE SW
2SC4926YDQ101
RF AMP
RQA0004PXDQSQ102
TX DRIVE AMP
IC308AQUA-L
AUDIO PROCESSOR
2SC4116(GR)FQ310
2SA1586(Y,GR)FQ311
MIC MUTE
MIC MUTE
0.66V
R:3.42V
4.92V5.0V
2.86V
4.88V
0.75V
R:0.58VT:5.1V
R:5.02VT:0.58V
T:3.03V
3.82V
4.48V
4.92V
R:1.8VT:1.62V
4.85V
R:0VT:1.76V
T:0.55V R:7.6VT:6.95VT:1.21VT:2.71V
T:4.89V(H)T:2.58V(L)
R:4.8VR:1.7V
R:4.7V
R:0.73V
R:2.41V
R:2.41VR:0.94V
R:4.82V
W:0VN:5V
BSHIFT ON:4.98VOFF:0V
R:3.78VT:3.47V
5.0V
5.03V
R:4.84V
T:5.0V
R:7.6VT:7.45V
ON:5.02VOFF:0V
ON:4.88VOFF:0V
T:0.35VR:7.73VT:9.2V
T:-1.45V
T:7.35VT:7.22V
4.05V
R:2.45VT:0V
7.55V(MUTE OFF)R:0.25V(MUTE ON)
R:7.7V(MUTE ON)0.16V(MUTE OFF)
Tx/Rx:136.000~174.000MHz
Power Switch/AF Volum
ChannelSelector
R31-0670-15
S60-0440-05
1
2
3
4
5
6
7
8
9
10
11
Low PassFilter
ANT
D104,D105:HVC131D103:HSC277
SwitchFinalAmp
Q105:RD07MVS1BT122
Q102:RQA0004PXDQS
DriveAmp
5T
RF Amp1stMixer
RF Amp
5R5R
D204,D205:1SV305FQ204:3SK318
Q203:3SK318
5C
Q11:2SC5636
BufferAmp
Q9:2SC5636
XF201:L71-0619-05
1st IF:38.85MHz
Tx VCO
5C
LippleFilter
Q6,Q10:KTC4075E(Y,GR)
Q5:2SK1875-F(V) RF Amp
Q3:2SC5636
LoopFilter
5CPLL IC
IF Amp
Q202:2SC4774
5R
5C
IC1:MB15A02PFV2E1
X1:L77-3042-05
PLL_STB
PLL_DAT
PLL_CLK
PLL_UL
5C
Discrimi-nator
CD201:L79-1866-05
5R
1st Local:174.850~212.850MHz12.8MHz
2nd Local:38.40MHz
CeramicFilter
CF201:L72-0973-05
2nd IF:450kHz
BUSY
FM IF IC
IC201:TA31136FNG
Rx:136.000~174.000MHz
RXD
MicAGC/Mute
5M
Q310:2SC4116(GR)F
MIC_MUTE
D306:KDR731
VOX
AFPowerAmp
IC309:TA7368FG
AFVOL_IN
MOD
1/2_OSC
DIR
Audio Prosessor
IC308:AQUA-LQT/DQT_IN
5M
BatteryProtector
D301:GN1G
Fuse
F301:F53-0324-05
2.5A
D303:B30-2315-05
SB
BATT
PTT
SIDE1
SIDE2
EEPROM
5M
EEPCLK
EEPDAT
IC305:BR24L16F-W
PTTSIDE1
X301:L78-1433-05
14.746MHz
RSSI
5M
IC306:R5F212CCKCMB
MCU
Mic
T91-0651-15MIC301:
SP/MIC Jack
Speaker
R305
R301
Detector
B
IC101:BA2904FVMX57-7570-20 (TX-RX UNIT)
LED
LEDRXLEDTX
TCXO
Tripler
Q2:2SC4774
Switch
Q201:RT1P441U
W/N
Tx:136.000~174.000MHz
Pre-driveAmp
Q101:2SC4926YD
PCTV
DI/O
TXD
SB
5R
SIDE2
Q305,Q306:2SC4919
BSHIFT
RDF/FD
OPTDET
PLL_UL
VOX
BATT
QT/DQT_IN
BUSYRSSI
5T
5T
TH101
TH_DET
TH_DET
RXD
Low PassFilter
B
5C
5T
5R
5M
Regulator
Regulator
Voltage
Voltage
Switch
Switch
5T_C
5R_C
5C_C
IC303:XC6209B502PR
LEDD304:B30-2314-05
SBSB
APC
Q108:RT1P441U
SwitchAPC_SW
Q106:RT1N441U
5R
QTTCXO
Rx VCO
MOD
QTVCO
BB
D4,D8:1SV325FD9:1SV278F
Q4:2SK1875-F(V)D3,D6:1SV325F
Switch
Switch
RX_SW
TX_SW
5M
Q7:RT1P430U
Q8:RT1P430U
Oscillator:272.000~348.000MHz
Oscillator:349.700~425.700MHz
Frequen-cy
Divider
5C
IC2:UPB1509GV
Tx/RxSwitch
D202,D203:1SV305F
5T 5R
PCTVPCTV
BandPassFilter
BandPassFilter
MCF
Q312:RT1N441U
Q313:2SB1694
B
SB
AFVOL_IN
AFVOL_OUT
EN1
EN2
EN3
EN4
EN5
SwitchMute
Q314:RT1N441UQ315,Q316:2SK3577-A
OPTDET
AFVOL_OUT
Switch
IC304:XC6209B502MR
ResetDetectorVoltage
IC301:BD4840FVE
Q304:DTB723YE
Q303:RT1P141U
Q311:2SA1586(Y,GR)F
Q308:KTC4075E(Y,GR)
D308,D309:KDR731
Q107:2SK1824-A
DET
DET
DTRLOADN
STD
EN1EN2EN3EN4EN5Reset
DTMF
EEPCLK
DTMF
PCTV
PLL_DATPLL_CLKPLL_STB
5T_C5C_C5R_C
W/N
AF_CONT
BSHIFT
QTTCXOQTVCO
MIC_MUTE
TX_SWRX_SW
LEDTXLEDRX
APC_SW
STD
1/2_OSC
TXD
DTRLOADNTDATA/DTRCLKSCLK
Limiter
D307:MC2850
Protector D101:UDZW5.1(B)
Switch
Q307:RT1N441U
W/N
Rectifier
D302:HRC0203C
Rectifier
Q1:KTC4075E(Y,GR)
SwitchAPC_SW
Switch
Switch DC_SW
Q103:RT1N441U
T07-0369-15
E11-0703-05
DC_SW
Switch Switch
Q301:RT1N441U Q302:RT1N441U
ShiftSwitch
CeramicOscillator
DI/OEEPDAT
Tempera-ture
Detector
D10:MC2858
Switch AF_CONT
SCLK
TDATA/DTRCLK
RDF/FD
TCLK/DTRDO