parts list manual - multiquipparts.com list manual ©sullair ... and actual equipment operation....

02250203-987 R01

PORTABLE AIR COMPRESSORE900H

Failure to follow the instructions and procedures in this manual or,

misuse of this equipement will VOID its warranty!

WARRANTY NOTICE

PART NUMBER:

KEEP FORFUTURE REFERENCE

PARTS LIST MANUAL

©SULLAIR CORPORATIONThe information in this manual is currentas of its publication date, and applies tocompressor serial number:

and all subsequent serial numbers.

ELQ: 37212070248ETQ: 201210010000

AIR CARE SEMINAR TRAINING

Sullair Air Care Seminars are courses that provide hands-on instruction for the proper operation, maintenance,and servicing of Sullair products. Individual seminars on portable compressors and compressor electricalsystems are offered at regular intervals throughout the year at Sullair’s corporate headquarters training facilitylocated at Michigan City, Indiana.

Instruction includes training on the function and installation of Sullair service parts, troubleshooting commonfaults and malfunctions, and actual equipment operation. These seminars are recommended for maintenance,contractor maintenance, and service personnel.

For detailed course outlines, schedule, and cost information contact:

SULLAIR TRAINING DEPARTMENT

1-888-SULLAIR or219-879-5451 (ext. 5623)

[email protected]

- Or Write -

Sullair Corporation3700 E. Michigan Blvd.Michigan City, IN 46360

Attn: Service Training Department.

TABLE OF CONTENTS

PAGE SECTION DESCRIPTION PAGE SECTION DESCRIPTION

5 1.1 PROCEDURE FOR ORDERING PARTS

6 1.2 RECOMMENDED SPARE PARTS LIST

8 1.3 COMPRESSOR AND MOTOR MOUNT-ING

10 1.4 AIR INLET SYSTEM

14 1.5 AIR DISCHARGE SYSTEM

20 1.6 COOLING AND LUBRICATION SYSTEM

24 1.7 ASSEMBLY COOLER

26 1.8 PNEUMATIC CONTROL SYSTEM

30 1.9 ELECTRICAL SYSTEM

34 1.10 STARTER, ASSEMBLY

36 1.11 FRAME SYSTEM

38 1.12 ENCLOSURE

42 1.13 DECAL PLACEMENT

46 1.14 RUNNING GEAR

TABLE OF CONTENTS (CONTINUED)PAGE SECTION DESCRIPTION PAGE SECTION DESCRIPTION

02250203-987 R01 5

Parts List

1.1 Procedure for Ordering PartsParts should be ordered from the nearest Sullair Representative or the Repre-sentative from whom the compressor was purchased. If for any reason partscannot be obtained in this manner, contact the factory directly at the address,phone numbers or fax numbers above.

When ordering parts always indicate the Serial Number of the compressor. Thiscan be obtained from the Bill of Lading for the compressor or from the SerialNumber Plate located on the compressor. See Figure 1-1.

The genuine Sullair service parts listed meet or exceed the demands of thiscompressor. Use of replacement parts other than those approved by SullairCorporation may lead to hazardous conditions over which Sullair Corporationhas no control. Such conditions include, but are not limited to, bodily injury andcompressor failure.

Figure 1-1: Serial Plate Location

02250203-987 R01 6

1.2 Recommended Spare Parts List

Key Part Number Qty Description Notes

1 88290016-447 1 ELEM, AIR FLTER PRIMARY

2 88290016-448 1 ELEM, AIR FLTER SECONDARY

3 250034-086 1 ELEM, SEPARATOR

4 250025-526 2 ELEM, FLUID FILTER

5 88290004-892 1 ELEM, MTR COUPLING

6 02250153-296 1 ELEM, SCF 910 (FOR 02250153-041)

7 02250153-307 1 ELEM, SCH 910 (FOR 02250153-065)

8 88298000-562 1 KIT, RPR THERMAL VALVE (88298000-561)

9 250018-456 1 KIT, RPR MIN PRESS CK VLV (242405)

10 046782 1 KIT, RPR RECIRCULATION VLV (044912)

11 048410 1 KIT, RPR-PRESS REG VLV(048354)

12 041742 1 KIT, RPR-PRESS REG VLV(406929)

13 02250073-277 1 KIT, INLET VALVE REPR 6.50”

14 40696 1 GASKET, INLET VALVE

15 250038-676 1 KIT, SOL VALVE REPLACE 3W NC (250038-755)

16 250038-730 1 COIL, SOL VALVE REPLACE (250038-755)

17 250038-672 1 KIT, SOL VALVE REBUILD 3W NO (250038-666)

18 250038-730 1 COIL, SOL VALVE REPLACE (250038-666)

19 02250057-037 1 KIT, SHAFT SEAL REPLACEMENT

20 02250100-042 1 VLV, 1/2 BLOWDOWN

21 02250119-047 1 SW, TEMP 250F N.C

22 88291007-924 1 SW, PRESSURE

23 250030-757 1 SULLAIR AWF (5 GALLONS)

24 250030-758 1 SULLAIR AWF (55 GALLONS)

02250203-987 R01 7

Notes

02250203-987 R01 8

1.3 Compressor and Motor Mounting

88290006-340 R08

1.3 Compressor and Motor Mounting

02250203-987 R01 9


1 828408-125 1 CAPSCR,FERRY 1/2-13 X 1 1/4

2 829108-200 9 CAPSCR,HX GR5 1/2-13*2

3 829110-175 2 CAPSCREW,HX GR5 5/8-11*1 3/4

4 837808-125 9 WASHER,SPRLOCK REG PLTD 1/2

5 837810-156 2 WASHER,SPRLOCK REG PLTD 5/8

6 838210-112 2 WASER,PL-B REG UNFIN 5/8

788250181-895 1 COMPR&PART,DXX204220C180E55ACI 900CFM,60Hz

88250181-995 1 COMPR&PART,DXX204220C213E47ACI 900CFM,50Hz

8 88290004-891 1 CPLG,KTR ROTEX90 AFN002 E750HH

9 88290004-892 1 ELEM,FLEX SPLDER 95SHA AFN002

10 88290005-030 2 GD,CPLG DAPTER E750HH

11 88290005-032 1 HSG,ADAPTER E750HH

12 88290005-161 2 ISOL,VIBUNIT E750HH

13 88290014-497 2 ISOL,VIBE750XH LESS RUN

14 88290017-264 1 WSHR,2G 750HH-1050 COMP

1588290023-107 1 MTR,160KW1.15 380/50 IP55 380V&50Hz

88291007-449 1 MTR,160KW1.15 460/60 IP55 UL 460V&60Hz

16 88811120-075 4 SCREW,M20X75 GB5782-86GAV SSAI



19 88812108-020 8 SCREW,M8X20 GB5783 GAV SSAI

20 88818220-050 4 SCREW,SOCKET M20X50 GB/T70.1

21 88821120-180 4 NUT,M20 GB6170-86 GAV SSAI

22 88821122-194 8 NUT,M22 GB6170-86 GAV SSAI

23 88831120-030 8 WASHER,20 GB97.1-85 GAV SSAI

24 88832108-021 8 WASHER,SPRG 8 GB93-87 GAV SSAI

25 88832120-050 13 WASHER,SPRG 20 GB93-87 GAVSSAI


27 88833120-046 2 WSHR,BIG20 GB96-85 SSAI

02250203-987 R01 10

1.4 Air Inlet System

88821106-052


02250203-987 R01 11

Key Part Number Qty English Notes

1 02250054-861 1 TUBE,NYL .25 OD X 040W BLK(FT)

2 02250141-305 1 IND,SWT FLR ELEM CMACS RIGHT

3 040422 1 GASKET, 8 1/2 X 10 1/2 X 1/32

4 040696 1 GASKET, 1/32 X 6 1/4IDX8 1/4OD

5 250025-633 1 CLAMP, TUBE RUBR CTD 1/2”DIA

6 250028-582 1 TEE, MALE 1/4T X 1/4P

7 807602-005 1 BUHG,RED 1/2 X 1/8” STL

8 829112-150 7 CAPSCR,HX GR 3/4* 1 1/2

9 829112-200 1 CAPSCR,HX GR5 3/4-10 X 2

10 837812-188 8 WASHER, SPRLOCK REG PLTD 3/4

11 838212-112 1 WASHER, PL-B REG PLTD 3/4

12 88290003-367 2 SUPT,AIR FLTR 750HH-1050

13 88290004-722 1 CLP,T BOLT 171.45

14 88290004-725 1 CLP,T BOLT 196.9

15 88291000-689 1 SA, INLET VALVE

16 88290010-231 1 SUPT, PIPE

17 88290011-049 1 FTG,FLG,ADPT POP-COMP E750/900

18 88290014-489 1 FLTR,AIR 4580092911 MANN

19 88291007-458 1 ELB,RUBBER 90 7’’ TO 6’’

20 88291007-743 1 SUPT,AIR FILTER ABOVE HANGER

21 88291007-755 1 SUPT,AIR FILTER ELQ750HH+






27 88818004-012 2 SCREW,CROSS M4X12 GB818-85GAV+

28 88821106-052 1 NUT,M6 GB6170-86 GAV SSAI


02250203-987 R01 12

29 88821108-068 2 NUT,M8 GB6170-86 GAV SSAI

30 88821110-084 8 NUT M10 GB6170-86 GAV SSAI

31 88821112-108 8 NUT,M12 GB6170-86 GAV SSAI








39 88833106-018 2 WSHR,BIG6 GB96-85 SSAI

Key Part Number Qty English Notes

02250203-987 R01 13

Notes

02250203-987 R01 14

1.5 Air Discharge System

88291007-977 R01


02250203-987 R01 15


1 02250153-041 1 SCF-910N NPT2-1/2

2 02250153-065 1 SCH-910N NPT2-1/2

3 02250153-287 1 KIT, FXKE5 SC HEAD CLAMP

4 242405 1 VLV,MIN PRESS & CHECK-2 MPT

5 250006-448 1 VLV, RELIEF 1-1/2’’ 200PSIG

6 250034-086 1 ELEMENT,OIL SEP 10.63 X 20”LG

7 807602-010 3 BUHG,RED 1/2 X 1/4”” STL

8 807800-020 1 PLUG, PIPE 1/2” 3000# STL

9 829106-200 4 CAPSCR,HX GR5 3/8-16 X 2


11 860104-025 5 CONN,37FL/MPT 1/4 X 1/4

12 860108-050 1 CONN,37FL/MPT 1/2 X 1/2

13 860204-025 1 ELBOW, 37FL 90M 1/4 X 1/4

14 860208-050 3 ELBOW,37FL 90M 1/2 X 1/2

15 868430-010 1 TEE,PIPE 1/4 300#

16 868504-025 1 NIP,PIPE HEX 1/4 X 1/4” PLT

17 88290001-031 1 PLUG,OIL TANK 25S-300 SSAIC

18 88290001-219 1 GL,SIGHT,FSF4525S-300 SSAIC

19 88290001-541 1 CONN,SEP-MIN VLV 150AC SSAIC

20 88290002-435 1 VLV,BALLDN15 Q11MP-25P SSAIP

21 88290002-688 10 FLG,HALF 2-1/2”” LS16-100 SSAI

22 88290002-836 1 PLUG,TANK DRAIN R1/2

23 88290006-597 4 ISOL,VIB E750HH-900H TANKMNTIG

24 88290007-143 2 FTG,FLG KIT SAE SPLT 2

25 88290008-411 1 HOSE,PRESS LATEX 1/4*400

26 88290008-418 2 HOSE,PRESS LATEX 1/4*1800

27 88290017-625 2 ADPT,AIR-WATER SEP 2G 750HH+


02250203-987 R01 16

28 88290018-785 1 SEP,WTR SCWS-1700 N2-1/2 DH

29 88291001-684 1 TUBE,RLF OUT DN25 DPQ750H

30 88291007-288 1 TUBE,DISCHARGE TO O/W SEP+

31 88291007-290 1 TUBE,DISCH EPQ900HH-1000AC



35 88291007-925 1 TNK,AOS ELQ750HH-1000AC ASME

36 88291007-462 1 TUBE,FLEX TEE ELQ750HH-1000AC

37 88291007-464 1 TUBE,DISCH ELQ750HH-1000AC

38 88291007-479 1 TUBE,COMPRDISCHANGE ELQ750HH+

39 88291007-488 1 TUBE,DISCH ELQ750HH-1000AC

40 88291007-490 2 SUPT,SEP TANK ELQ750HH-1000AC

41 88291007-506 1 TUBE,ASSY COMPRDIS ELQ750HH+

42 88291007-507 3 ADPT,NPT2’’ TO FLANGE +

43 88291007-599 4 VLV,BALL NPT2 DN50

44 88291007-600 1 VLV,BALLDN50 Q11MP-25P NPT1

45 88291007-659 1 SUPT,AIR-WATER SEP AND FILTER+

46 88291007-729 1 SUPT,DISCH TUBE ELQ750HH+

47 88291007-771 1 SUPT,DISCH TUBE ELQ750HH+

48 88291007-781 1 TUBE,CONN NPT2-1/2 ELQ750HH+

49 88291008-194 2 TUBE,DISCH ELQ750HH-1000A

50 88291008-269 4 U-BOLT,ELQ900HAC

51 88291008-345 1 SUPT,DISCH TUBE

51 88291008-348 1 SUPT,DISCH TUBE

53 88291008-424 1 VLV,SOL 2WNC 8262G261 UL





02250203-987 R01 17







62 88813108-020 6 SCREW,M8X20 GB5787-86 SSAI

63 88821108-068 8 NUT,M8 GB6170-86 GAV SSAI

64 88821112-108 8 NUT,M12 GB6170-86 GAV SSAI

65 88821116-148 4 NUT,M16 GB6170-86 GAV SSAI

66 88822108-076 6 NUT,M8 GB6177-86 SSAI









75 88833108-022 8 WSHR,BIG8 GB96-85 SSAI

76 88842026-051 1 O-RING,VITON 51.5X2.65GB3452.1

77 88842035-047 1 O-RING,VITON47.5X3.55GB3452.1

78 88842035-056 2 O-RING,VITON 56X3.55 GB3452.1

79 88842035-065 11 O-RING,VITON 65X3.55 GB3452.1

80 88842035-085 1 O-RING,VITON 85X3.55 GB3452.1

81 88842035-090 1 O-RING,VITON 90X3.55 GB3452.1

82 88851060-090 1 CLIP,SGL60X90 JB/ZQ4492-86SSAI



02250203-987 R01 18

83 88851076-110 2 CLIP,SGL76X110JB/ZQ4492-97SSAI

84 88861024-050 1 ELB,RC1-1/2 GB3287 SSAI

85 88871008-044 1 NIP,R1/2 GB3287 SSAI

86 88871024-059 1 NIP,R1-1/2 GB3287 SSAI

87 88291008-366 1 HOSE,HIGH PRESS 1/2X1300


02250203-987 R01 19

Notes

02250203-987 R01 20

1.6 Cooling and Lubrication System

88291007-268 R01


02250203-987 R01 21


1 020169 1 CONNECTOR, FLEX 1/4T X 1/4P

2 02250101-490 1 CONN, TUBE MALE BHD 1/4 X 1/4

3 02250117-782 1 STRAINER, STR-THRED SAE

4 02250125-776 1 ORIFICE,.094 PLUG 1/8”NPT

5 02250126-129 1 GLASS, SIGHT ORF/BLOCK SAE

6 049905 1 VLV,CHECK 1/4

7 249853 1 BUSHING,SPLIT TAPER P1 1 3/8

8 250025-526 2 ELEM,FLUID FILTER

9 250030-758 1 FL,AWF 55GA(DRUM)

10 807603-005 1 BUHG,RED 3/4 X 1/8”” STL

11 829106-100 4 CAPSCR,HX GR5 3/8-16 X 1


13 841215-004 1 TUBE,STNLS STL 1/4 20GA FT

14 860104-025 1 CONN,37FL/MPT 1/4 X 1/4

15 860204-025 1 ELBOW, 37FL 90M 1/4 X 1/4

16 860208-050 4 ELBOW,37FL 90M 1/2 X 1/2

17 868504-025 1 NIP,PIPE HEX 1/4 X 1/4” PLT

18 88290002-435 2 VLV,BALLDN15 Q11MP-25P SSAIP

19 88290002-836 2 PLUG,TANK DRAIN R1/2

20 88290005-536 1 CONN,ELBOW M60x2-M42X2 ADJUST

21 88290005-544 1 CONN,STRT M60-M48

22 88290005-546 1 SUPT,OIL FILTER E750HH-900H

23 88290005-911 2 GD,FAN E750HH-900H

24 88290006-589 1 SUPT,OIL RETURN E750HH-900H

25 88290007-143 2 FTG,FLG KIT SAE SPLT 2

26 88290008-415 1 HOSE,PRESS LATEX 1/4*1000

27 88290017-330 1 HOSE,HIGH PRESS 1/2X650


02250203-987 R01 22

28 88290017-331 1 HOSE,HIGH PRESS 1/2X400

29 88291002-156 1 CONN,M48 TO M60,E750HH-900H

30 88291007-274 1 CLR,ASSY EPQ900HH-1000AC

3188291007-448 1 MTR,5.5HP1.0 460/6 IP55 460V, 50Hz

88290006-561 1 MTR, 380/50 5.5HP1.2 IP55+ 380V,50Hz

32 88291007-519 1 TUBE,DN40 OIL TO UNIT E750HH+

33 88291007-533 1 TUBE,DN40 OIL FROM TANK

34 88291008-225 1 SUPT,FAN MOTOR ELQ750HH-1000+

35 88291008-245 1 HOSE,DN40 OIL FROM COOLER

36 88291008-248 1 SHLD,FAN ELQ900HAC

37 88291008-253 2 PNL,CLR MAINTENANCE ELQ900HAC

38 88291008-258 1 ELB,M48 TO M60,ELQ900HAC

39 88291008-333 1 PNL,MAITENANCE OF FAN BOX

4088291008-987 1 FAN,36’’&TWIST 29,ELQ900HA 380V, 50Hz

88291008-370 1 FAN,36’’&TWIST 23,ELQ900HAC 460V, 60Hz

41 88291008-415 1 PNL,MAITENANCE OF FAN BOX

42 88291008-416 1 HOSE,OIL TO COOLER ELQ900HAC

43 88291008-417 1 SUPT,OIL TUBE ELQ900HAC

44 88291008-817 2 ELB,M48 TO M60,E750HH-900H

45 88298000-561 1 VLV,ASSY THERMAL VALVE 180F





50 88812110-035 4 SCREW M10X35 GB5783 GAV SSAI





02250203-987 R01 23

53 88813108-016 14 SCREW,M8X16 GB5787-86 SSAI

54 88813108-020 34 SCREW,M8X20 GB5787-86 SSAI

55 88821110-084 4 NUT M10 GB6170-86 GAV SSAI

56 88821112-108 2 NUT,M12 GB6170-86 GAV SSAI

57 88822108-076 10 NUT,M8 GB6177-86 SSAI






63 88842026-045 6 O-RING,VITON 45X2.65 GB3452.1

64 88842035-038 1 O-RING,VITON 38.7X3.55GB3452.1

65 88842035-045 11 O-RING,VITON 45X3.55 GB3452.1

66 88842035-056 2 O-RING,VITON 56X3.55 GB3452.1

67 88851045-075 1 CLIP,SGL45X75 JB/ZQ4492-86SSAI

68 88871008-044 2 NIP,R1/2 GB3287 SSAI


02250203-987 R01 24

1.7 Assembly Cooler

1.7 Assembly Cooler

02250203-987 R01 25


1 88291007-273 1 FRM, CLR SUPT ELQ900H-1000AC

2 88291007-271 1 CLR, OIL EPQ900H-1000AC

3 88291007-272 1 CLR, AFTER EPQ900H-1000AC

02250203-987 R01 26

1.8 Pneumatic Control System

88291008-263 R01


02250203-987 R01 27


1 02250054-861 60ft TUBE,NYL .25 OD X 040W BLK(FT)

2 02250091-395 2 ORF,0.04O 1/4 FNPT X 1/4 MNPT

3 02250100-042 1 VLV,2-WAY PNEUMATIC 1/2 NPT

4 041006 1 SILENCER, AIR 1/2

5 044912 1 VLV,2-WAY PNEUMATIC

6 048354 1 VLV,PRESSURE REGULATOR

7 048448 1 GA, PRESS AIR 0-200PSI

8 049905 2 VLV,CHECK 1/4

9 250003-798 1 GA,DIFF PRESS 0-15PSI

10 250003-799 1 GAUGE, DIFF PRESS 0-30PSI

11 250018-430 5 ELBOW, 1/4 TUBE X 1/4 NPT

12 250021-379 4 CONN,FEM 1/4” TUBE X 1/8”FNPT

13 250041-286 1 ELBOW, 90 1/4T X 1/8” NPT F

14 406929 1 VLV,DIFF PRESS REG 1/4”NPT

15 801515-020 1 ELBOW, TUBE 90DEG 1/2”” 150#

16 802202-023 2 TEE,RED 1/2 X 1/2 X 3/4” 150#

17 807602-010 2 BUHG,RED 1/2 X 1/4”” STL

18 807800-010 1 PLUG,PIPE 1/4” 3000# STL

19 841500-004 3 BULKHEAD,PIPE 1/4” NPT

20 860104-012 1 CONN,37FL/MPT 1/X 1/8

21 860104-025 2 CONN,37FL/MPT 1/4 X 1/4

22 860204-025 9 ELBOW, 37FL 90M 1/4 X 1/4

23 860208-050 6 ELBOW,37FL 90M 1/2 X 1/2

24 860504-025 1 ELBOW, TUBE 90M 1/4 X 1/4

25 861704-025 2 TEE,37FL M BR 1/4 X 1/4

26 861804-025 4 TEE,37FL M RN 1/4 X 1/4

27 868430-010 2 TEE,PIPE 1/4 300#


02250203-987 R01 28

28 868504-025 5 NIP,PIPE HEX 1/4 X 1/4” PLT

29 868508-050 4 NIP,PIPE HEX 1/2 X 1/2” PLT

30 869704-012 1 TEE,ADAPTOR 1/4T X 1/8M X1/8F

31 877900-010 1 ELBOW, PIPE 90 1/4” 3000# PLT

32 88290004-380 1 GUAGE,P.FZ004CDBH002(0-2.0MPA)

33 88290006-379 2 CONN,37FL/GM 1/4”NPTX1/4”G

34 88290006-440 1 SEP,AIR/OIL CORTROL LINE

35 88290006-612 1 HOSE,ASSEMBLY FOR E750HH-900H

36 88290008-411 5 HOSE,PRESS LATEX 1/4*400

37 88290008-412 3 HOSE,PRESS LATEX 1/4*500

38 88290008-414 1 HOSE,PRESS LATEX 1/4*800

39 88290008-415 1 HOSE,PRESS LATEX 1/4*1000

40 88290008-418 2 HOSE,PRESS LATEX 1/4*1800

41 88290017-327 1 SUPT,RECIRCLE VALVE

42 88290017-330 2 HOSE,HIGH PRESS 1/2X650

43 88290017-338 1 HOSE,HIGH PRESS 1/2”X1800

44 88291007-786 1 PNL,ENCLOSURE ELQ900HAC

45 88291008-262 1 SUPT,CTRL COMPONENT

46 88291008-371 1 GA,TEMP MURPHY

47 88291008-434 1 SUPT,FOR MUFFLER E750HH-900H




51 88813108-016 6 SCREW,M8X16 GB5787-86 SSAI


53 88821106-052 2 NUT,M6 GB6170-86 GAV SSAI




02250203-987 R01 29



57 88291007-924 1 PRESSURE SWITCH


02250203-987 R01 30

1.9 Electrical System

88291007-922 R01


02250203-987 R01 31


1 02250120-626 3 CONN,CAM LOCK E1016-1600

2 88290002-748 4 CONN,FLEX D96-5 BM75X2-64

3 88290002-732 3M COND,CHN ZV95-1 DN64 (M)+


5 250038-666 1 VLV,SOL 3WNO 1/4 8320G192

6 250038-755 1 VLV,SOL 3WNC 1/4 8320G182

788291009-989 1 START, ASSY, 380/50 ELQ900HAC 380V, 50Hz

88291007-492 1 START, ASSY,ELQ750HH-1000AC 460V, 60Hz

8 88291008-433 3M CABLE,UL1020 4/0AWG BLACK

9 88291008-767 1 CONN,HSK-M20G

10 88291007-513 1 BOX,CAM LOCK ELQ750HH-1000AC

11 88291007-514 1 PNL,CAM LOCK BOX ELQ750HH+

12 88291008-846 1 CTL,EMG CEPY1-2001 ABB UL 2NC

13 88291008-768 2M CABLE,UL 2AWG GREEN/YELLOW

14 02250117-337 3 COVER,CAM LOCK A100895-1

15 88291008-435 6 TERM,JST 100-L10 UL

16 88291008-769 2 TERM,JST 38-L8 UL

17 88813105-025 12 SCREW,M5X25 GB5787-86 SSAI

18 88813106-012 14 SCREW,M6X12 GB5787-86 SSAI

19 88813108-012 8 SCREW,M8X12 GB5787-86 SSAI

20 88813108-020 1 SCREW,M8X20 GB5787-86 SSAI

21 88813110-020 4 SCREW,M10X20 GB5787-86 SSAI

22 88821105-047 12 NUT,M5 GB6170-86 GAV SSAI

23 88821108-068 2 NUT,M8 GB6170-86 GAV SSAI

24 825008-448 3 NUT,HX GR8 UNFIN 1/2-13

25 88290006-040 1 PAD,ELEC BOX EPQ750HH-1000

26 88290015-877 14M COND,POLYAMIDE TUBING AD21.2B+


02250203-987 R01 32

27 88290015-878 4M COND,POLYAMIDE TUBING AD28.5B+

28 88290016-219 1M CONN,POLYAMIDE TUBING AD15.8B+

29 88291008-401 1M HOSE,POLYAMIDE TUBING AD106B



32 88290015-879 10 CONN,APEAK WQG1-M20/AD21.2 +

33 88290015-881 1 CONN,APEAK WQG1-M25/AD28.5 +

34 88291004-095 1 CONN,APEAK WQG1-M32B/AD28.5+

35 88291008-400 2 CONN,WGFPM AD106B

36 88290016-221 1 CONN,ELBOW WQW1-M16/AD15.8 +

37 02250119-047 2 SW,TEMP 250F N.C. LG BULB

38 88291007-924 1 SW,PRESS 0-2.2MPA KPS37

39 88291008-758 1 PNL,BOX ELQ900HAC UL


02250203-987 R01 33

Notes

02250203-987 R01 34

1.10 Starter, Assembly

88291007-492 R02

1.10 Starter, Assembly

02250203-987 R01 35

Key Part Number Qty Description Mark

1 88291007-524 1 ENCL,START ELQ900HAC

2 88291007-580 4m DUCT,PXC-5035 PLASTIC

388291009-028 1 XFMR,630VA 380V-110V UL TC1, 380V, 50Hz

88291008-373 1 XFMR,630VA 460V-110V UL TC1, 460V, 60Hz

4 88291008-762 3 FU,5A 10*38 UL FU2-3

5 88291008-764 3 FU,2A 10*38 UL FU1

6 88291008-327 1 RLY,VOLT DPB01CM48 KA6

7 88291008-328 1 RLY,TIME DAC01CM24 Y-D KT1

8 88291008-329 1 RLY,TIME DBB01DM24 KT0

9 88291008-330 1 RLY,TIME DCB51CM24 KT2

1088291009-027 3 CNTOR,3RT50656AF36 265A 110V KM1-3, 380V, 50Hz

88291008-274 3 CNTOR,3RT50646AF36 225A AC110V KM1-3, 460V, 60Hz

11 88291008-275 2 CNTOR,3RT60251AG20 17A AC110V KM4-5

12 88291008-277 1 RLY,OVLD 3RB20661GC2 55-250A FR1

13 88291008-300 1 BRKR,3VL41401GB300AA0 QF1

14 88291008-301 1 BRKR,3RV60111KA15 9-12.5A QF2

15 88291008-302 3 RLY,AUX 3RH61221AF00 AC110V KAO-2

16 88291008-303 1 CONTACT,TD 3RA28131AW10 KA1

17 88291008-349 1 CNTOR,MCN-LOCK 3RA19542A

18 88290007-930 3 TERM,249-117 END STOP WAGO

19 88290009-405 3 TERM,283-101 GREY 0.2-16MM XT1

20 88290009-406 1 TERM,280-302 END ORANGE XT1

21 88290010-556 3 TERM,280-641 0.08-2.5MM GREY+ XT1

22 88290010-557 1 TERM,280-313 END ORANGE XT1

23 88290013-569 3 TERM,280-637 GROUND+ XT1

24 88291000-925 1 TERM,WEIDMULLER HDC HE 24 FT XT2

25 88291000-927 1 TERM,WEIDMULLER 1212400000 XT2

02250203-987 R01 36

1.11 Frame System

88291007-358 R01

1.11 Frame System

02250203-987 R01 37


1 88290017-979 6 PLUG,FRAME DRAIN HOLE CHN

2 88291007-451 1 FRM,FULL BUNDING ELQ750HH+

3 88291007-654 2 PNL,LIFT FORK HOLE ELQ750HH+

4 88291007-698 2 SUPT,START ELQ750HH-1000AC

5 88291008-663 1 BAIL, LFT,ELQ750HH-1000AC



8 88813106-012 8 SCREW,M6X12 GB5787-86 SSAI

9 88813108-016 1 SCREW,M8X16 GB5787-86 SSAI





02250203-987 R01 38

1.12 Enclosure

88291007-500 R01

1.12 Enclosure

02250203-987 R01 39


1 040125 2 GROMMET, RUBBER

2 250022-436 1 WEATHERSTRIP,3/16 X 3/8 (FT)

3 839105-112 2 EYEBOLT,REG CP 5/16-18X1 1/8

4 88290003-947 6 SUPT,AIR-SPRING

5 88290006-048 1 BM,CAN LEFT-UP E750HH-1000

6 88290006-050 1 BM,CAN FRONT-UP E750HH-1000

7 88290006-055 1 PNL,COR FRONT RH E750HH-900H

8 88290006-058 1 PNL,AIR INL LH E750HH-900H

9 88290006-063 2 HNG,CAN DOOR SIDE E750HH-900H

10 88290006-064 1 HNG,CAN DOOR FRONT E750HH-900H

11 88290006-069 2 PNL,GIRDER TOP E750HH-900H

12 88290006-071 1 CVR,SERVICE TANK E750HH-900H

13 88290006-073 1 PNL,COV CAN FRONT E750HH-900H

14 88290006-075 1 CVR,CAN ROOF AOS TANK+

15 88290006-077 4 HNG,SS-FH-B01 E750HH-900H

16 88290006-078 3 SPG,AIR S=310 F=550N

17 88290006-079 2 SPG,AIR S=310 F=350N

18 88290006-106 1 PNL,GIRDER SIDE TOP RH

19 88290006-312 2 NUT,RTNRM8

20 88290007-116 1 STRIP,FLR RUBBER MY-S6(M)

21 88290009-877 1 LOC,MS705 H=30 SH LIANGJIANG

22 88290012-630 2 HNG,C6-24 SOUTHCO

23 88290015-366 7 LOC,FOR DOOR 900XHH-1150XH+

24 88290015-644 2 LATCH,CATEL CX-7003 SL AE B1

25 88290016-605 5 LOC,LOCKCATCH FOR 88290015-366

26 88290018-085 3 HNG,2G 750HH-1050 L=39X25.4MM

27 88291007-501 1 PNL,COR REAR LH ELQ750HH+

1.12 Enclosure

02250203-987 R01 40

28 88291007-502 1 PNL,COV CAN REAR ELQ750HH+

29 88291007-869 2 BAF,COOLER ELQ750HH-1000AC

30 88291008-205 1 DOOR,INLET ELQ900HAC

31 88291008-206 1 SUPT,CAPONY ELQ900HAC

32 88291008-207 1 BM,CAN INLET-UP ELQ750HH-1000+

33 88291008-211 1 DOOR,OUTLET ELQ750HH-1000AC

34 88291008-214 1 DOOR,OUTLET ELQ750HH-1000AC

35 88291008-216 1 BM,CAN INLET-UP ELQ750HH-1000+

36 88291008-254 1 DOOR,SIDE WITH INLET LOUVERS

37 88291008-313 1 PNL,COR FRONT LH ELQ750HH+

38 88291008-315 1 DOOR,CONTROL PNL ELQ900HAC

39 88291008-444 1 PNL,GIRDER TOP E750HH-1000AC

40 88291008-445 1 PNL,COR REAR RH E750HH-1000AC

41 88291008-446 1 PNL,CAN MIDDLE ROOF E750HH+

42 88291008-447 2 BM,CAN PNL REAR DOOR+

43 88291008-666 1 DOOR,SIDE EL750HH-1000AC

44 88291008-667 2 BM,CAN SIDE-DOWN ELQ750HH+

45 88291008-675 1 DOOR,CAN FRONT ELQ750HH+

46 88291008-676 1 BM,CAN FRONT-DOWN ELQ750HH+

47 88291008-682 1 PNL,FOR HANGER ELQ750HH-1000

48 88813105-012 1 SCREW,M5X12 GB5787-86 SSAI

49 88813108-016 23 SCREW,M8X16 GB5787-86 SSAI

50 88813108-020 6 SCREW,M8X20 GB5787-86 SSAI


52 88818305-016 1 SCR,CR RCD CSNK M5X16 GB819-85

53 88818305-020 2 SCR,CR RCD CSNK M5X20 GB819-85

54 88821105-047 5 NUT,M5 GB6170-86 GAV SSAI


1.12 Enclosure

02250203-987 R01 41

55 88822108-076 18 NUT,M8 GB6177-86 SSAI



58 88833108-022 4 WSHR,BIG8 GB96-85 SSAI


02250203-987 R01 42

1.13 Decal Placement

88291007-913 R04


02250203-987 R01 43


1 02250117-423 1 DECAL,CAM LOCK

2 02250117-424 1 DECAL,CAM LOCK

3 02250117-425 1 DECAL,CAM LOCK

4 02250155-495 2 DECAL,BLACK WWW.SULLAIR.COM

5 042218 2 DECAL,DANGER HI VOLTAGE

6 049850 1 SIGN,DANGER ELECTROCUTION

7 250021-337 1 TAG,FIRST START

8 88290001-278 1 DECAL,ROTATION CHN&ENG SSAI

9 88290001-322 1 DECAL,GROUND SSAIC

10 88290004-163 2 DECAL,SULLAIR 5.75X46 BLACK

11 88290006-605 1 DECAL,E900H BLACK SSAIP

1288291006-937 1 DECAL,WRN380V SSAIC 380V

88290013-209 1 DECAL,WRN460V SSAIC 460V

13 88290013-683 1 NPL,FOR EXPORT MODEL

14 88290013-723 7 RIVET,BUSTERPOP DIA3.2 L=8

15 88290016-615 7 DECAL,DOORS CLOSED CAUTION ENG

16 88290017-255 3 DECAL,WARNING-SEVER-FAN-PORT

17 88290017-257 2 DECAL,WRAING PRESS VESSEL

18 88290017-259 1 DECAL,SULLAIR AWF ENG

19 88290017-260 1 DECAL,5 YEAR WARRANTY ENG

20 88290017-261 1 DECAL,WARNING BREATH ENG

21 88290017-262 1 DECAL,BARNING BREATH

22 88290018-914 1 DECAL,AFTERCOOLER DRAIN ENG

23 88290018-924 1 DECAL,OILCOOLER DRAIN ENG

24 88290018-936 1 DECAL,ROTATION SSAIC ENG

25 88291006-944 1 DECAL,WARNING

26 88291008-307 1 DECAL,WITH AFTERCOOLER&FILTER


02250203-987 R01 44

27 88291008-308 2 DECAL,WATER DRAIN

28 88291008-309 1 DECAL,SUMP TANK DRAIN

29 88291008-310 2 DECAL,ROTATION FAN EN

30 88291008-325 1 DECAL,GENERAL MAINTENEACE

31 88291008-350 1 DECAL,WD ELQ900HAC

32 88291008-694 4 REFL,RED 3M

33 88291008-696 1 REFL,24’’RED- WHITE-RED 3M

34 88291008-698 4 REFL,AMBER 3M 2’’X4.5’’

35 02250075-540 1 DECAL,PE DESIGNATION

36 02250075-045 1 DECAL,PROTECTIVE EARTH GROUND

37 02250172-803 1 DECAL.CAUTION BELOW 0 READ +

3802250069-412 1 DECAL,VOLTAGE 380V&50HZ 380V, 50Hz

02250069-399 1 DECAL,VOLTAGE 460V&60HZ 460V, 60Hz

39 049852 1 SIGN,WARNING GROUND FAULT

40 02250172-283 1 TAG, INLET VALVE OIL CHAMBER +


02250203-987 R01 45

Notes

02250203-987 R01 46

1.14 Running Gear

02250204-141 R01

1.14 Running Gear

02250203-987 R01 47


1 02250202-798 1 RN GR,E900 DTQ

2 829216-911 8 CAPSCR, HEX 10.9 M16 X 55 FL THD

3 843103-038 4 RIVET, POP 3/16 X 3/8

4 875110-112 8 WASHER, PL-B HARDENED PLTD 5/8

5 E900H 1 VARIOUS

6 NAMEPLATE 1 VARIOUS

NOTE:

A1: USE LOC-TITE GRADE 242 (BLUE) ON ITEMS #2 & #4 (8-PLACES)

TORQUE ITEMS #2 & #4 TO 150 FT-LBS (8-PLACES).

Notes

02250203-987 R01 48

02250203-987 R01 49

Notes

Printed in the U.S.A.Specifications subject to change

without prior notice.E12EP

Always air. Always there.

SULLAIR CORPORATION3700 East Michigan Boulevard • Michigan City, Indiana, 46360 U.S.A.

Telephone: 1-219-879-5451

WWW.SULLAIR.COM

parts list manual - multiquipparts.com list manual ©sullair ... and actual equipment operation....

Documents