visit designbydelta.com/downloads free-standing 4 bike
TRANSCRIPT
x1 — Top Connector
x2 — Top Pole
x2 — Center Pole
x2 — Bottom Pole
x2 — Base Stand (Left + Right)
x1 — Base Bracket
x4 — Long Bolts
x8 — Arms
x6 — Short Bolts
x2 — Extra Long Bolts
x2 — Nuts (10mm)
x2 — Washers
x4 — O Ring
x1 — Basket
PartsA
B
C
D
E
F
G
H
I
J
KK
L
M
N
Assembly instructions HDRS6801
WARNINGDO NOT EXCEED MAXIMUM TOTAL WEIGHT LIMIT OF 160 LBS (70 Kgs)MAX LOAD PER HOOK: 35 LBS (15.9 kgs) / MAX WEIGHT PER BIKE: 40LBS (18.2 kgs)LOAD HEAVIER BIKES, INCLUDING E-BIKES, ON LOWER TIER.
C
H
D
A
K
FE
L
I
G
B
Assembly VideoVisit designbydelta.com/downloadsScan with your smartphone camera to view
C
H
D
A
FFMFN E
I
IJ
G
Tool(s) RequiredPhillips HeadScrewdriver
Adjustable Wrench(or 10mm)
Free-Standing 4 Bike Rackwith Basket
1Connect base bracket (F), bottom poles (D) and base stand (E)as shown using long bolts (G, J) Nuts (K) and Washers (L).Do not tighten bolts until rack is fully assembled and tubes areproperly aligned. Fully assemble base before continuing.
3
5
Connect toppoles (B) to centerpoles (C), securewith short bolts (I).Connect topconnector (A) to toppoles (B) usinglong bolts (G).
Use short bolt (I) toattach basket (N) bypositioning in line withdesired height holeon the inside of thecenter pole (C)(FIGURE 1)
4
2Connect center poles (C) to bottom poles (D),secure with short bolts (I).
Adjust position of arms beforeplacing bike on stand.
Tighten all bolts, usingthe wrench to hold nutswhere needed.O Rings (M) can be usedto slide over base legswhere needed on uneven�oor surfaces
IMPORTANT / SAFETY
Delta Cycle Corporation36 York Avenue, Randolph, MA 02368 USA800-474-6615 / www.designbydelta.com
© Copyright 2020
After rack is assembled Arms should be placed at desired height - two perbike (front and rear).
Front side of rack features thelonger section of the base foot
Need help? Please do not return to store.For immediate response email [email protected]
Always load bikes on the arms of the bottom,front side of the rack �rst to maintain stability.
Remove bikes from the top �rst.
Store e-bikes and other heavybikes on lower arms only.
Do not allow children to play or hang from rack.
FIGURE 2
FIGURE 1