k6394 a90 9923 service manual - air conditioning solutions · item model rav-164bh-pe heronhill -...
TRANSCRIPT
BUILT-IN DUCT TYPERAV-164BH-PE/164AH-PE RAV-264BH-PE/264AH-PERAV-264BH-PE/264AH8-PERAV-364BH-PE/364AH8-PERAV-464BH-PE/464AH8-PE
CEILING TYPERAV-134CH/CHR-PE/134AH-PERAV-164CH/CHR-PE/164AH-PERAV-264CH/CHR-PE/264AH-PERAV-264CH/CHR-PE/264AH8-PERAV-364CH/CHR-PE/364AH8-PERAV-464CH/CHR-PE/464AH8-PE
WALL TYPERAV-134KH/KHR-PE/134AH-PERAV-164KH/KHR-PE/164AH-PERAV-264KH/KHR-PE/264AH-PERAV-264KH/KHR-PE/264AH8-PE
CARCASE TYPERAV-104NH-PERAV-134NH-PE/134AH-PERAV-164NH-PE/164AH-PERAV-264NH-PE/264AH-PERAV-264NH-PE/264AH8-PE
LOW WALL/PAINTED FLOOR TYPERAV-164SH/SHR-PE/164AH-PERAV-264SH/SHR-PE/264AH-PERAV-264SH/SHR-PE/264AH8-PE
2 WAY CASSETTE TYPERAV-104TUH-PERAV-134TUH-PE/134AH-PERAV-164TUH-PE/164AH-PE
4 WAY CASSETTE TYPERAV-164UH-PE/164AH-PERAV-264UH-PE/264AH-PERAV-264UH-PE/264AH8-PERAV-364UH-PE/364AH8-PERAV-464UH-PE/464AH8-PE
AIR-CONDITIONERSPLIT TYPE, HEAT PUMP
FILE NO. A90-9923
Printed in UK DECEMBER 1999
TOSHIBA
SERVICE MANUAL
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
CONTENTS
2
1. SPECIFICATIONS 32. CONSTRUCTIONS VIEWS 213. WIRING DIAGRAMS 314. SPECIFICATIONS OF ELECTRICAL PARTS 415. REFRIGERANT PIPING DIAGRAMS 566. PERFORMANCE CHARACTERISTICS 627. EXPLODED VIEWS AND PARTS LISTS 65
The units referred to within this Manual conform with the protection requirements of Directives 89/336/EECElectromagnetic Compatibility and 73/23/EEC Low Voltage.
Operating conditions of units are as follows:
SUMMARY
OUTDOOR TEMPERATURE
ROOM TEMPERATURE
ROOM HUMIDITY
-2 to 43ûC (COOL)-10 to 21ûC (HEAT)
18 to 32ûC (COOL)15 to 29ûC (HEAT)
LESS THAN 80% (COOL)
Diameter (mm)
Nominal Diameter (inch)
6.4 9.5 12.7 15.9 19 22
1/4 3/8 1/2 5/8 3/4 7/8
Cooling Capacity is based on the following temperature conditions:Indoor air inlet temperature 27ûC DB, 19ûC WB.Outdoor air inlet temperature 35ûC DB.
Heating Capacity is based on the following temperature conditions:Indoor air inlet temperature 20ûC DB.Outdoor air inlet temperature 7ûC DB, 6ûC WB.
For details on Control Circuits, refer to Service Manual A90-9925.
Metric/Imperial pipe conversion:
Note 1:
Note 2:
Note 3:
Note 4:
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
3
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputExternal staticpressureOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
Long-life filter kit
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hWmmAqmmAq
mmmmmmkg
m3/hW
kW
mmmmmmkg
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
42/39/3650
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿32.5 (ID)RAV-164BH-PE
Black (zinc galvanized steel & thermal insulator)
34577087539
Finned tubeMulti-blade fan
84060410
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
High pressure switch, fuse, crankcase heater,
inner overload relay, bi-metal thermostat
RBC-RK162BE-PE
807002858
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
StandardMax. motor
HeightWidthDepth
ModelOutput
HeightWidthDepth
Specifications are subject to change without notice
RAV-164BH-PEItem Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
4
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputExternal staticpressureOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
Long-life filter kit
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hWmmAqmmAq
mmmmmmkg
m3/hW
kW
mmmmmmkg
7.17.91
220-24050
COOLING HEATING3.1 2.9590 90
15.0 14.280
43/40/3753
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿32.5 (ID)RAV-264BH-PE
Black (zinc galvanized steel & thermal insulator)
3451,07087553
Finned tubeMulti-blade fan
1,1401004
10RAV-264AH-PE
Bronze white (Munsell 6Y7.5/1)79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
High pressure switch, fuse,crankcase heater,
inner overload relay, bi-metal thermostat
RBC-RK262BE-PE
80100028510
Washable
7.17.93
380-41550
COOLING HEATING2.9 2.9585 854.9 5.0
2543/40/37
53R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿32.5 (ID)RAV-264BH-PE
Black (zinc galvanized steel & thermal insulator)
3451,07087553
Finned tubeMulti-blade fan
1,1401004
10RAV-264AH8-PE
Bronze white (Munsell 6Y7.5/1)79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
High pressure switch, fuse,crankcase heater, over current
relay, bi-metal thermostat, reversephase protector
RBC-RK262BE-PE
80100028510
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
StandardMax. motor
HeightWidthDepth
ModelOutput
HeightWidthDepth
Specifications are subject to change without notice
Item Model RAV-264BH-PERAV-264BH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
5
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputExternal staticpressureOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
Long-life filter kit
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hWmmAqmmAq
mmmmmmkg
m3/hW
kW
mmmmmmkg
10.010.8
3380-415
50COOLING HEATING
4.2 3.987 857.0 6.6
4245/42/39
55R407C
2.735
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
¿32.5 (ID)RAV-364BH-PE
Black (zinc galvanized steel & thermal insulator)
3451,42087558
Finned tubeMulti-blade fan
1,8201204
10RAV-364AH8-PE
Bronze white (Munsell 6Y7.5/1)1,240930385103
Finned tubePropeller fan
6,00039 + 63
ZR49KCE-TFD-2303.0
RBC-RK462BE-PE
801,35028512
Washable
12.513.8
3380-415
50COOLING HEATING
5.15 5.487 858.5 9.2
5046/43/40
55R407C
3.550
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
¿32.5 (ID)RAV-464BH-PE
Black (zinc galvanized steel & thermal insulator)
3451,42087562
Finned tubeMulti-blade fan
2,1001404
10RAV-464AH8-PE
Bronze white (Munsell 6Y7.5/1)1,240930385118
Finned tubePropeller fan
6,00039 + 63
ZR61KCE-TFD-2303.75
RBC-RK462BE-PE
801,35028512
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-50m)
Larger side size*Coupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
StandardMax. motor
HeightWidthDepth
ModelOutput
HeightWidthDepth
*(¿22) should be used when length of pipe exceeds 30mSpecifications are subject to change without notice
Item Model RAV-464BH-PERAV-364BH-PE
High pressure switch, fuse, reverse phase protector, crankcase heater,inner overload relay, delivery temperature sensor
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
6
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
3.64.21
220-24050
COOLING HEATING2.0 2.1588 909.9 10.4
6040/37/33
50R407C
1.0535
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-134CH/CHR-PE
SilkyMist188
1,03064024
Finned tubeMulti-blade fan
78034
Washable
RAV-134AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
43/39/3650
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-164CH/CHR-PE
SilkyMist188
1,03064024
Finned tubeMulti-blade fan
85034
Washable
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
Specifications are subject to change without notice
High pressure switch, fuse, crankcase heater, inner overload relay,bi-metal thermostat
RAV-164CH/CHR-PERAV-134CH/CHR-PEItem Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
7
Specifications are subject to change without notice
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
7.17.91
220-24050
COOLING HEATING3.1 2.9590 90
15.0 14.280
45/41/3753
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264CH/CHR-PE
SilkyMist188
1,23064028
Finned tubeMulti-blade fan
1,20034
Washable
RAV-264AH-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
7.17.93
380-41550
COOLING HEATING2.9 2.9585 854.9 5.0
2545/41/37
53R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264CH/CHR-PE
SilkyMist188
1,23064028
Finned tubeMulti-blade fan
1,20034
Washable
RAV-264AH8-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
RAV-264CH/CHR-PE RAV-264CH/CHR-PE
High pressure switch, fuse,crankcase heater, inner overload
relay, bi-metal thermostat
High pressure switch, fuse,crankcase heater, overcurrent relay,thermostat, reverse phase protector
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
8
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
10.010.8
3380-415
50COOLING HEATING
4.2 3.987 857.0 6.6
4247/43/40
55R407C
2.735
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
¿20 (OD)RAV-364CH/CHR-PE
Silky Mist240
1,43064039
Finned tubeMulti-blade fan
1,68075
Washable
RAV-364AH8-PEBronze white (Munsell 6Y7.5/1)
1,240930385103
Finned tubePropeller fan
6,00039 + 63
ZR49KCE-TFD-2303.0
12.513.8
3380-415
50COOLING HEATING
5.15 5.487 858.5 9.2
5049/45/41
55R407C
3.550
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
¿20 (OD)RAV-464CH/CHR-PE
Silky Mist240
1,63064044
Finned tubeMulti-blade fan
2,10075
Washable
RAV-464AH8-PEBronze white (Munsell 6Y7.5/1)
1,240930385118
Finned tubePropeller fan
6,00039 + 63
ZR61KCE-TFD-2303.75
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-50m)
Larger side size*Coupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
RAV-364CH/CHR-PE RAV-464CH/CHR-PE
High pressure switch, fuse, reverse phase protector, crankcase heater,inner overload relay, delivery temperature sensor
*(¿22) should be used when length of pipe exceeds 30mSpecifications are subject to change without notice
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
9
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
3.64.21
220-24050
COOLING HEATING2.0 2.1588 909.9 10.4
6042/38/35
50R407C
1.0535
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-134KH/KHR-PE
Silky Mist372
1,15022620
Finned tubeTransverse flow fan
70027
Washable
RAV-134AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
43/39/3650
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-164KH/KHR-PE
Silky Mist372
1,15022620
Finned tubeTransverse flow fan
77027
Washable
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
RAV-134KH/KHR-PE RAV-164KH/KHR-PE
High pressure switch, fuse, crankcase heater, inner overload relay,bi-metal thermostat
Specifications are subject to change without notice
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
10
1. SPECIFICATIONS
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
7.17.91
220-24050
COOLING HEATING3.1 2.9590 90
15.0 14.280
44/40/3753
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264KH/KHR-PE
Silky Mist372
1,47822626
Finned tubeTransverse flow fan
1,20027
Washable
RAV-264AH-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
High pressure switch, fuse, bi-metalthermostat, crankcase heater,
inner overload relay
7.17.93
380-41550
COOLING HEATING2.9 2.9585 854.9 5.0
2544/40/37
53R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264KH/KHR-PE
Silky Mist372
1,47822626
Finned tubeTransverse flow fan
1,20027
Washable
RAV-264AH8-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
High pressure switch, fuse,overcurrent relay, crankcase heater,thermostat, reverse phase protector
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
Specifications are subject to change without notice
Item Model RAV-264KH/KHR-PE RAV-264KH/KHR-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
11
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)Refrigerant
Interconnectionpipe
Condensate drain pipe diameterAppearance colour
DimensionsNet weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filter
PhaseVHzkW%AAdB(A)
mm
mm
mm
mmmmmmkg
m3/hW
1220-240
500.0793
0.330.6
40/37/34R407C¿12.7Flare¿6.4Flare
¿20 (OD)Zinc, galvanized steel
600 (if top air outlet) 580 (if front outlet)745 (including drain catch)
230 (if top air outlet) 250 (if front air outlet)21
Finned tubeMulti-blade fan
55034
Washable
Indoor Unit (High, Med, Low)Name of RefrigerantLarger side sizeCoupler styleSmaller side sizeCoupler style
HeightWidthDepth
RAV-104NH-PE
Specifications are subject to change without notice
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
12
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
3.64.21
220-24050
COOLING HEATING2.0 2.1588 909.9 10.4
6041/38/35
50R407C
1.0535
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-134NH-PE
Zinc (galvanized steel)
600 (if top air outlet) 580 (if front air outlet)1,045 (including drain catch)
230 (if top air outlet) 250 (if front air outlet)25
Finned tubeMulti-blade fan
62534
Washable
RAV-134AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
42/39/3650
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-164NH-PE
Zinc (galvanized steel)
600 (if top air outlet) 580 (if front air outlet)1,045 (including drain catch)
230 (if top air outlet) 250 (if front air outlet)29
Finned tubeMulti-blade fan
74034
Washable
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
RAV-134NH-PE RAV-164NH-PE
High pressure switch, fuse, crankcase heater, inner overload relay,bi-metal thermostat
Specifications are subject to change without notice
Item Model
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
13
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
5.76.71
220-24050
COOLING HEATING2.8 2.890 90
13.7 13.580
42/39/3653
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264NH-PE
Zinc (galvanized steel)
600 (if top air outlet) 580 (if front air outlet)1,045 (including drain catch)
230 (if top air outlet) 250 (if front air outlet)29
Finned tubeMulti-blade fan
90034
WashableRAV-264AH-PE
Bronze white (Munsell 6Y7.5/1)79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
5.76.73
380-41550
COOLING HEATING2.8 2.880 825.1 4.9
2542/39/36
53R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264NH-PE
Zinc (galvanized steel)
600 (if top air outlet) 580 (if front air outlet)1,045 (including drain catch)
230 (if top air outlet) 250 (if front air outlet)29
Finned tubeMulti-blade fan
90034
Washable
RAV-264AH8-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
High pressure swich, fuse,crankcase heater, inner overload
relay, bi-metal thermostat
High pressure switch, fuse,crankcase heater, overcurrent relay,thermostat, reverse phase protector
Specifications are subject to change without notice
Item Model RAV-264NH-PE RAV-264NH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
14
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
42/39/3650
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿20 (OD)RAV-164SH/SHR-PE
SilkyMist640
1,03018824
Finned tubeMulti-blade fan
85034
Washable
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
High pressure switch, fuse, bi-metal thermostat, crankcase heater, inner overload relay
Specifications are subject to change without notice
Item Model RAV-164SH/SHR-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
15
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputAir filterOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
7.17.91
220-24050
COOLING HEATING3.1 2.9590 90
15.0 14.280
44/39/3653
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264SH/SHR-PE
SilkyMist640
1,23018828
Finned tubeMulti-blade fan
1,20034
Washable
RAV-264AH-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
7.17.93
380-41550
COOLING HEATING2.9 2.9585 854.9 5.0
2544/39/36
53R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
¿20 (OD)RAV-264SH/SHR-PE
SilkyMist640
1,23018828
Finned tubeMulti-blade fan
1,20034
Washable
RAV-264AH8-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
High pressure switch, fuse,crankcase heater, inner overload
relay, bi-metal thermostat
High pressure switch, fuse,crankcase heater, overcurrent relay,thermostat, reverse phase protector
Specifications are subject to change without notice
Item Model RAV-264SH/SHR-PERAV-264SH/SHR-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
16
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)Refrigerant
Interconnectionpipe
Condensate drain pipe diameterAppearance colour
DimensionsNet weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputCEILING PANEL modelAppearance colour
Dimensions
Net weightAir filter
PhaseVHzkW%AAdB(A)
mm
mm
mm
mmmmmmkg
m3/hW
mmmmmmkg
1220-240
500.0793
0.330.6
40/36/34R407C¿12.7Flare¿6.4Flare
¿25.5 (OD)Grey (galvanized steel& thermal insulation)
19091048023
Finned tubeTransverse flow fan
5507 x 2
RBC-U133PG(W)-PESilky white (Munsell 2.9Y8.9/0.8)
251,0505504.5
Washable
Indoor Unit (High, Med, Low)Name of RefrigerantLarger side sizeCoupler styleSmaller side sizeCoupler style
HeightWidthDepth
HeightWidthDepth
Specifications are subject to change without notice
Item Model RAV-104TUH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
17
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL modelAppearance colour
Dimensions
Net weight
Air filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
3.64.21
220-24050
COOLING HEATING2.0 2.1588 909.9 10.4
6040/36/34
50R407C
1.0535
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿25.5 (OD)RAV-134TUH-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7007 x 2
RAV-134AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG330X3F-4LS1.5
RBC-U133PG(W)-PESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
41/37/3550
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
¿25.5 (OD)RAV-164TUH-PE
Grey (galvanized steel & thermal insulator)
19091048023
Finned tubeTransverse flow fan
7507 x 2
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
RBC-U133PG(W)-PESilky white (Munsell 2.9Y8.9/0.8)
25
1,050
550
4.5
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
Specifications are subject to change without notice
High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat
Item Model RAV-164TUH-PERAV-134TUH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
18
Specifications are subject to change without notice
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL model
Appearance colour
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
4.55.01
220-24050
COOLING HEATING2.2 2.290 89
10.6 10.760
38/35/3250
R407C1.235
Capillary tube & Expansion valve¿12.7Flare¿6.4Flare7.5
30
1530
1" BSP (male threaded connection)RAV-164UH-PE
Black (zinc galvanized steel &thermal insulator)
25982082025
Finned tubeCentrifugal fan
1,02028
RAV-164AH-PEBronze white (Munsell 6Y7.5/1)
74088031061
Finned tubePropeller fan
2,70039
PG350X3F-4LS1.5
RBC-U264PG(W)-ERBC-U264PGR(W)-E
White20
9409406
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
High pressure switch, fuse, bi-metal thermostat, crankcase heater, inner overload relay
Item Model RAV-164UH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
19
Item
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL model
Appearance colour
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
7.17.91
220-24050
COOLING HEATING3.1 2.9590 90
15.0 14.280
43/39/3550
R407C1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
1" BSP (male threaded connection)RAV-264UH-PE
Black (zinc galvanized steel &thermal insulator)
25982082025
Finned tubeCentrifugal fan
1,26028
RAV-264AH-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
PG460X3F-4MS2.2
RBC-U264PG(W)-ERBC-U264PGR(W)-E
White20
9409406
Washable
7.17.93
380-41550
COOLING HEATING2.9 2.9585 854.9 5.0
2543/39/35
50R407C
1.935
Capillary tube & Expansion valve¿15.9Flare¿9.5Flare7.5
30
1530
1" BSP (male threaded connection)RAV-264UH-PE
Black (zinc galvanized steel &thermal insulator)
25982082025
Finned tubeCentrifugal fan
1,26028
RAV-264AH8-PEBronze white (Munsell 6Y7.5/1)
79088031080
Finned tubePropeller fan
3,00063
YG460X3F-MS2.2
RBC-U264PG(W)-ERBC-U264PGR(W)-E
White20
9409406
Washable
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-30m)
Larger side sizeCoupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
High pressure switch, fuse,crankcase heater, inner overload
relay, bi-metal thermostat
High pressure switch, fuse,crankcase heater, overcurrent relay,thermostat, reverse phase protector
Specifications are subject to change without notice
Item Model RAV-264UH-PERAV-264UH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
1. SPECIFICATIONS
20
Cooling capacityHeating capacity
Power source
Power consumptionPower factorRunning currentStarting currentOperating noise (SPL)
Refrigerant
Refrigerant control
Interconnection pipe
Condensate drain pipe diameterINDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeIndoor fan typeAir volumeFan motor outputOUTDOOR UNIT ModelAppearance colour
Dimensions
Net weightHeat exchanger typeOutdoor fan typeAir flow volumeFan motor output
Compressor
Protective device
CEILING PANEL model
Appearance colour
Dimensions
Net weightAir filter
kWkWPhaseVHz
kW%AAdB(A)dB(A)
kgg/m
mm
mm
m
m
mmmm
mmmmmmkg
m3/hW
mmmmmmkg
m3/hW
kW
mmmmmmkg
Indoor Unit (High, Med, Low)Outdoor UnitName of RefrigerantCharge VolumeAdd. Volume (20-50m)
Larger side size*Coupler styleSmaller side sizeCoupler styleStandard lengthMaximum actual pipe length(of one way)Maximum height differenceIf Indoor Unit higherIf Outdoor Unit higher
HeightWidthDepth
HeightWidthDepth
ModelOutput
HeightWidthDepth
*(¿22) should be used when length of pipe exceeds 30mSpecifications are subject to change without notice
Item Model RAV-464UH-PERAV-364UH-PE
High pressure switch, fuse, reverse phase protector, crankcase heater,inner overload relay, delivery temperature sensor
10.010.8
3380-415
50COOLING HEATING
4.2 3.987 857.0 6.6
4242/40/37
55R407C
2.735
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
1" BSP (male threaded connection)RAV-364UH-PE
Black (zinc galvanized steel &thermal insulator)
3091,23082043
Finned tubeCentrifugal fan
1,75036
RAV-364AH8-PEBronze white (Munsell 6Y7.5/1)
1,240930385103
Finned tubePropeller fan
6,00039 + 63
ZR49KCE-TFD-2303.0
RBC-U464PG(W)-ERBC-U464PGR(W)-E
White20
1,3509408
Washable
12.513.8
3380-415
50COOLING HEATING
5.15 5.487 858.5 9.2
5045/43/40
55R407C
3.550
Capillary tube & Expansion valve¿19 (¿22)
Flare¿9.5Flare7.5
50
2050
1" BSP (male threaded connection)RAV-464UH-PE
Black (zinc galvanized steel &thermal insulator)
3091,23082043
Finned tubeCentrifugal fan
1,82036
RAV-464AH8-PEBronze white (Munsell 6Y7.5/1)
1,240930385118
Finned tubePropeller fan
6,00039 + 63
ZR61KCE-TFD-2303.75
RBC-U464PG(W)-ERBC-U464PGR(W)-E
White20
1,3509408
Washable
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
21
Rear return airinlet knockouts
320
Electrical box
60 80
150
Unit dimension: A
Hanging bolt pitch: B
J=MxK H
Air outletN-¿200
Hanging bolt4-M10Provided at site
Unit dimension: 800
Hanging bolt pitch: 565 210720
63080
345
80
60
270
1110
0
170
320
6-¿4 Mounting screwhole ¿160
¿125 Knockouthole (rear)(Fresh air inlet)
Thermal insulator
Refrigerantpiping joint(Gas ¿F)
Refrigerantpiping joint(Liquid ¿G)
Drain pipe connectionport (Inner diameter: 32.5)
(Port diameter: nominalfor PVC pipes) ¿35Wiring connection port
Lower returnAir inlet
Ensure that there is sufficient space around theindoor unit for installation and servicing
Indoor unit 300-400
200
450
450
Inspectionhole
Provide an inspectionhole in this position
RAV-164BH-PERAV-264BH-PERAV-364BH-PERAV-464BH-PE
700100013501350
750105014001400
12.715.919.019.0
6.49.59.59.5
252252252252
280580930930
280290310310
1233
2344
Model A B F G H J K M N
(Unit : mm)
Indoor UnitRAV-164BH-PERAV-264BH-PERAV-364BH-PERAV-464BH-PE
70
75
305
9012
0340
320
2.1
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
22
30
62
AlternativeKnock-out holefor drain piping 80 80
145
3478
30
50140
8512
Refrigerant pipeconnection (Gas ¿G)
Hard vinyl chloridepipe outer dia. 20mmRefrigerant pipeconnection (Liquid ¿F)
Drain piping joint
Han
ging
bol
tpi
tch
170
640 25
0
B
A
(Hanging bolt pitch)
Hanging bolt hole4 - (12x25) Slot
Knock-out holes forpiping and wiring
50130
1010
0
150
180
200
D
130
Hanging plate(Left)
Hanging plate(Right)
85 12
120
Right-side panelknock-out forpiping and wiring
Air inlet
Air filterC
Indoor UnitRAV-134CH/CHR-PERAV-164CH/CHR-PERAV-264CH/CHR-PERAV-364CH/CHR-PERAV-464CH/CHR-PE
Han
ging
bol
tLe
ss th
an 4
0
B
Outer hanging bolt pitch
Han
ging
bol
tLe
ss th
an 4
0
E40
Inner hanging bolt pitch
Greater than400
Gre
ater
than
500
150Minimum
150Minimum
Space required for service and installation
(unit : mm)
Model A B C D F G
RAV-164CH/CHR-PERAV-264CH/CHR-PE
1,030 920 540 188 6.4 12.7
RAV-364CH/CHR-PERAV-464CH/CHR-PE
1,430 1,320 550 240
E
1,020
1,420 9.5 19.01,630 1,520 550 240 1,620 9.5 19.0
RAV-134CH/CHR-PE 1,030 920 540 188 1,020 6.4 12.7
1,230 1,120 540 188 1,220 9.5 15.9
2.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
23
158
143
A
Air outlet4-way adjustable
372
4070 118
Piping hole(Knockout hole)
226
216
¿20
40
495595
900(Both sides)Piping hole(Knockout hole)
Refrigerant pipeconnection(Gas ¿B)
Refrigerant pipeconnection(Liquid ¿C)
Drain pipe
MODEL A B C
RAV-134KH/KHR-PE 1150 12.7 6.4
RAV-164KH/KHR-PE
RAV-264KH/KHR-PE
1150 12.7 6.4
1478 15.9 9.5
RAV-134KH/KHR-PERAV-164KH/KHR-PE
20 40 110 150150
110 40 20
40
600
Slots18-6x306-¿6 Holes
Anchor bolt holes4 - 10x20 slots
RAV-264KH/KHR-PE
2650
169
4350
Installation board mounting bolt hole location
2650
169
4350
20 40 110 150 150 150 150 110 2040
940Anchor bolt holes4 - 10x20 slots
Slots21-6x308-¿6 Holes
More than 300 More than 300
More than 30
Space required for service
Indoor UnitRAV-134KH/KHR-PERAV-164KH/KHR-PERAV-264KH/KHR-PE
(OD
.)
(unit : mm)
2.3
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
24
2016
014
0
150
65
95
A
B
6014
525 100 150
MinimumMinimum
Upper plate / Duct plate
Air outletFixing location tofloor / base
Space required for service and installation
10
20
Hx¿4.7 hole
4xø15 holeFixing location to wall
345
600
160
70
Electrical boxEarth connectioninside
Air filterAir intake
E
DC
Flare jointLiquid ¿F
Flare jointGas ¿G
315
140
6595
2xø4.7 Hole
436
397
274
224
104
110155
230
Fixinglocation tofloor / base
Drain hoseconnector(OD ø20)
Drain catch
HModel A B C D E ¿F ¿G
RAV-104NH-PE
RAV-134NH-PERAV-164NH-PERAV-264NH-PE
580
880
550
850
610
910
4x100
7x100
580
880
6.4
6.4
9.5
12.7
12.7
15.9
5
8
(Units : mm)
Indoor UnitRAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PE
10
10
13370
175
145
2.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
25
30
62
AlternativeKnock-out holefor drain piping 80 80
145
3478
30
50140
8512
Refrigerant pipeconnection (Gas ¿G)
Hard vinyl chloridepipe outer dia. 20mmRefrigerant pipeconnection (Liquid ¿F)
Drain piping joint
Han
ging
bol
tpi
tch
170
640 25
0
B
A
(Hanging bolt pitch)
Hanging bolt hole4 - (12x25) Slot
Knock-out holes forpiping and wiring
50130
1010
0
150
180
200
D
130
Hanging plate(Left)
Hanging plate(Right)
85 12
120
Right-side panelknock-out forpiping and wiring
Air inlet
Air filterC
Han
ging
bol
tLe
ss th
an 4
0
B
Hanging bolt pitch
Indoor UnitRAV-164SH/SHR-PERAV-264SH/SHR-PE
Gre
ater
than
400
Greater than 500
150Minimum
150Minimum
PLAN VIEW
Space required for service and installation
Model A B C D F G
RAV-164SH-PERAV-164SHR-PE 1,030 920 540 188 6.4 12.7
RAV-264SHR-PERAV-264SH-PE 1,230 1120 540 188 9.5 15.9
(unit : mm)
2.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
26
48029080 110
190
70840
Hanger bolt(4-M10)
A
190
25
Drain pipe joint(outer ¿25.5)
Refrigerant piping joint(Liquid ¿6.4)
Refrigerant piping joint(Gas ¿12.7)
Wiring connection
66
73
Panel outer dimension 1050
Ceiling opening 1010Hang bolt pitch 930
840
2040
7040
2040
11090
Pan
el o
uter
dim
ensi
on 5
50
Cei
ling
open
ing
510
480
Han
g bo
lt pi
tch
410
TOSHIBA
1050
550
600Minimum
600Minimum
600Minimum
200
Space required for service and installation
View A
(Unit: mm)
Indoor UnitRAV-104TUH-PERAV-134TUH-PERAV-164TUH-PE
96 131
156
2.6
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
27
Ceiling
195
106
106
298
138
160
259
30
39 20
Knockout for side ducts ¿150 (both sides)
30 40 536
405400
268
195
800
(Han
ger
bolt
pitc
h)82
0 (E
xter
nal c
asse
tte d
imen
sion
)88
0 (C
eilin
g op
enin
g)94
0 (P
anel
dim
ensi
on)
Condensate pipe 1" BSPthreaded connection536
620 (Hanger bolt pitch)820 (External cassette dimension)
880 (Ceiling opening)940 (Panel dimension)
13030
Fresh air inlet
940
940
80
240
138
185
170100
73 140 20
0
Refrigerant pipe connection(Gas ¿A)
Refrigerant pipe connection(Liquid ¿B)
Wiring connection(Gland plate 3x¿20 holes)Drain pipe connection
(1" BSP threaded connection)
Model (RAV-) 164UH 264UH
¿A¿B
12.76.4
15.99.5
Indoor UnitRAV-164UH-PERAV-264UH-PE
45°
45°¿180
Side outlet duct size 6 - ¿6
¿180
45° 45°
80
10
30 6
¿15
0
¿20
0
32
130
130
¿100
4 - ¿6
¿130¿144
Fresh air inlet duct size
8010
30 2
¿97 ¿30
¿14
4
2.7
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
28
45°
45°¿180
Side outlet duct size 6 - ¿6
¿180
45° 45°
80
10
30 6
¿15
0
¿20
0
32
130
130
¿100
4 - ¿6
¿130¿144
Fresh air inlet duct size
8010
30 2
¿97 ¿30
¿14
4
CeilingCeiling panel
30
202
941106
210
348 30
913
8 30
39 20
106
Knockout for side ducts ¿150 (both sides)40 30 610
605
800
(Han
ger
bolt
pitc
h)82
0 (E
xter
nal c
asse
tte d
imen
sion
)88
0 (C
eilin
g op
enin
g)94
0 (P
anel
dim
ensi
on)
Condensate pipe 1" BSPthreaded connection
9401030 (Hanger bolt pitch)
1230 (External cassette dimension)
1290 (Ceiling opening)
1350 (Panel opening)
30
130
Fresh air inlet
940
1350
80
240
138
185
170100
73 140 20
0
Refrigerant pipe connection(Gas side ¿19.0)
Refrigerant pipe connection(Liquid side ¿9.5)
Wiring connection(Gland plate 3x¿20 holes)Drain pipe connection
(1" BSP threaded connection)
Indoor UnitRAV-364UH-PERAV-464UH-PE
2.8
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
29
880Air outlet
104
500
B
320
37 566Blow out guidemounting hole(4-¿3 embosses)
90
88
Handle(Both sides)
310
Electricparts box
Earth screw (M6)
Terminal cover
A
364
18
12
165117
40
340
12 4550
790
70360
280
30
5070
45
Hole for drain(2x¿19 hole)
Knock-out hole for drain(2-20x60 slots)
Anchor bolt hole(4-12x18slots)
Refrigerant pipe connection(Liquid ¿ C)
Refrigerant pipe connection(Gas ¿ D)
When installed with theinlet facing the wall
(Space for wiringand piping)
500
300
100
OutletOutlet (Space for wiringand piping)
100 100
500
Space required for service
When installed with theoutlet facing the wall
Outdoor UnitRAV-134AH-PERAV-164AH-PERAV-264AH-PERAV-264AH8-PE
Model A B ¿C ¿D
RAV-134AH-PERAV-164AH-PE
RAV-264AH-PERAV-264AH8-PE
740 380 6.4 12.7
790 430 9.5 15.9
(unit : mm)
2.9
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
2. CONSTRUCTION VIEWS
30
Handle(front side only)
930Air outlet
Handle(Both sides)
5050
0
299
115
500
37 566
90
150
615
Blow out guide mounting hole(8-¿3 embosses)
Terminal cover
Earth screw(M6)
385
275
245
1240
440
18
When installed with theinlet facing the wall
(Space for wiringand piping)
500
300
150
OutletOutlet (Space for wiringand piping)
150
150
500
Space required for service
When installed with theoutlet facing the wall
12512 30
416
12
50
45 45840
Air outlet
Anchor bolt hole(4-12x18 slots)
Air inlet
Air inlet
30
36044
5580
29
Refrigerant pipeconnection(Gas ¿19)
Refrigerant pipeconnection(Liquid ¿9.5)
Knock-out hole for drain(2-30x80 slots)
(unit : mm)
Outdoor UnitRAV-364AH8-PERAV-464AH8-PE
73
70
Knock-out hole(¿40)
2.10
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3. WIRING DIAGRAMS
31
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
YELBLUORGBLKBRWRED
FMYELBLU
ORGBLKRED
Connectorassembly(accessory)
(Fan speedincreaseoption)
CN12
CN02
RE
MO
CO
N
TR
1
3
1
32 2
4 4
CN01(TRANS)
3
1
3
122
TA
CN04(TA)
CN05(TC)
TC
RY01(output)
YELBLUORGBLKBRWRED
FM
CN15(LAN)
53113571357 531
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
CN09(WHI).(LOUVER)
GR
Y
RE
D
RE
D
GR
Y
BLK
1
3
1
3
1
3
5
7
1
3
5
7
99
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RED
YEL
BLU
ORG
BLK
3
L2 L3 NL1
1 2 3
F2
(3 Phasemodel)
PowerSupply380/415V3N~50HzOutdoor unit
L
B C
1 2
N
F2
(1 Phasemodel)
PowerSupply220/240V~50Hz
X Y A
X Y
CentralRemoteController(Optional)
A B C
RemoteController
(Optional)
Indoor unit
1 2 3
RED
RCWHI
GRY
Symbol Name Symbol NameFM TARC TCTRF
RY01~RY07
RAV-164BH-PERAV-264BH-PERAV-364BH-PERAV-464BH-PE
EarthScrew
GRN/YEL
EarthScrew
GRN/YELYEL
ORG
BLUR
ED
GRYGRY
ORGBLUBLKYEL
WH
I
CN21
Fan MotorRunning CapacitorTransformerFuse (PCB)
SensorSensorRelay
3.1
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3. WIRING DIAGRAMS
32
Symbol Name Symbol NameFM TARC TCTR GMF RY01~RY07
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
1
3
1
3
1
3
1
32 2
4 4
TR
CN01(TRANS)
3
1
3
1 CN02
22
CN15(LAN)
53113571357 531
TA
CN04(TA)
CN05(TC)
TC
RE
MO
CO
N
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
CN09(WHI).(LOUVER)
X Y A B C
X Y
CentralRemoteController(Optional)
A B C
RemoteController(Not CHR models)(Optional)
A B C
Infra-RedReceiver
(CHR models)
Indoor unit
1 2 3
GR
Y
RE
D
RE
D
GR
Y
BLK
GM
BLK
BLK
RY01(output)
GRN/YEL
RED
YEL
BLU
ORG
BLK
FMWHI
GRY
RC
RED
1 2 3
1 2 3
L2 L3 N
NL
F2
(1 Phase model)
PowerSupply220/240V~50Hz
F2
(3 Phase model)
L1
PowerSupply380/415V3N~50Hz
Outdoor unit
RAV-134CH/CHR-PERAV-164CH/CHR-PERAV-264CH/CHR-PERAV-364CH/CHR-PERAV-464CH/CHR-PE
CN12
CN02
RE
DW
HI
YELBLKBLUORG
BLUYELORG
GRYGRY
CN21
EarthScrew
GRN/YEL
EarthScrew
Fan MotorRunning CapacitorTransformerFuse (PCB)
SensorSensorGeared MotorRelay
1
3
5
7
1
3
5
7
99
3.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3. WIRING DIAGRAMS
33
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol NameFM TARC TCTR GMF RY01~RY07
1
3
1
3
1
3
1
32 2
4 4
TR
CN01(TRANS)
CN12
3
1
3
1
CN02
22
CN15(LAN)
53113571357 531
TA
CN04(TA)
CN05(TC)
TC
RE
MO
CO
N
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RY01 RY06
CN10(PUMP)
F(L1) (N)
CN03(SERIAL)
RY07
CN09(WHI).(LOUVER)
X Y A B C
X Y
CentralRemoteController(Optional)
A B C
RemoteController(Not KHR models)(Optional)
A B C
Infra-RedReceiver
(KHR models)
Indoor unit
1 2 3
GR
Y
RE
D
RE
D
GR
Y
BLK
GM
BLK
BLK
RY01(output)
RED
YEL
BLU
ORGBLK
1 2 3
1 2 3
L2 L3 N
NL
F2
(1 Phase model)
PowerSupply220/240V~50Hz
F2
(3 Phase model)
L1
PowerSupply380/415V3N~50Hz
Outdoor unit
FM
RCGRYRED
WHIWHI
RED
YELBLUORG
BLK1
3
5
7
1
3
5
7
99
1
3
5
7
1
3
5
7
99
RAV-134KH/KHR-PERAV-164KH/KHR-PERAV-264KH/KHR-PE
YELORG
BLU
RE
D
GRYGRY
ORGBLUBLKYEL
WH
I
CN21
EarthScrew
GRN/YEL
EarthScrew
Fan MotorRunning CapacitorTransformerFuse (PCB)
SensorSensorGeared MotorRelay
3.3
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3. WIRING DIAGRAMS
34
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol NameFM TARC TCTRF
RY01~RY07
CN12
CN02
RE
MO
CO
N
TR
1
3
1
32 2
4 4
CN01(TRANS)
3
1
3
122
TA
CN04(TA)
CN05(TC)
TC
RY01(output)
FM
GRN/YEL
CN15(LAN)
53113571357 531
RY01 RY06
CN10(PUMP)
F(L1) (N)
CN03(SERIAL)
RY07
CN09(WHI).(LOUVER)
GR
Y
RE
D
RE
D
GR
Y
BLK
1
3
1
3
1
3
5
7
1
3
5
7
99
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RED
YEL
BLU
ORG
BLK
3
L
B C
1 2
N
F2
(1 Phasemodel)
PowerSupply220/240V~50Hz
X Y A
X Y
CentralRemoteController(Optional)
A B C
RemoteController
(Optional)
Indoor unit
1 2 3
GRN/YEL
RCWHI
GRY
RE
DW
HI
YELBLKBLUORG
BLUYELORG
GRYGRY
CN16
CN21
6
34
6
34
1 1
5 5
2 2
RED
YEL
BLUORG
BLK
L2 L3 NL1
1 2 3
F2
(3 Phasemodel)
PowerSupply380/415V3N~50HzOutdoor unit
RAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PE
EarthScrew
EarthScrew
Fan MotorRunning CapacitorTransformerFuse (PCB)
SensorSensorRelay
3.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
35
3. WIRING DIAGRAMS
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
Symbol Name Symbol NameFM TARC TCTRF
RY01~RY07
CN12
CN02
RE
MO
CO
N
TR
1
3
1
32 2
4 4
CN01(TRANS)
3
1
3
122
TA
CN04(TA)
CN05(TC)
TC
RY01(output)
FM
GRN/YEL
CN15(LAN)
53113571357 531
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
CN09(WHI).(LOUVER)
GR
Y
RE
D
RE
D
GR
Y
BLK
1
3
1
3
1
3
5
7
1
3
5
7
99
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RED
YEL
BLU
ORG
BLK
3
L
B C
1 2
N
F2
(1 Phasemodel)
PowerSupply220/240V~50Hz
X Y A
X Y
CentralRemoteController(Optional)
A B C
RemoteController(Not SHRmodels)
(Optional)
Indoor unit
1 2 3
RED
RCWHI
GRY
RE
DW
HI
YELBLKBLUORG
BLUYELORG
GRYGRY
CN16
CN21
L2 L3 NL1
1 2 3
F2
(3 Phasemodel)
PowerSupply380/415V3N~50HzOutdoor unit
RAV-164SH/SHR-PERAV-264SH/SHR-PE
GRN/YEL
EarthScrew
EarthScrew
A B C
Infra-RedReceiver
(SHR models)
Fan Motor
Running Capacitor
Transformer
Fuse (PCB)
Sensor
Sensor
Relay
3.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
36
3. WIRING DIAGRAMS
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
1
3
1
3
1
3
1
32 2
4 4
TR
CN01(TRANS)
CN12
3
1
3
122
CN15(LAN)
53113571357 531
TA
CN04(TA)
CN05(TC)
TC
RE
MO
CO
N
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
X Y A B C
X Y
CentralRemote
Controller(Optional)
A B C
RemoteController(Optional)
Indoor unit
RE
D
PU
R
RE
D
GR
Y
BLK
RY01(output)
RED
YEL
BLU
ORG
BLK
Outdoor unit
1 2 3
1 2 3
NL
F2
(1 Phase model)
PowerSupply220/240V~50Hz
123456789
101112131415
123456789
101112131415
DM
CS
F3
TR
InterfacePCB
SM01
SM02
WH
I
RED
YELBLU
ORGBLK
WHI
RED
123456
123456
123456
123456
FM02
FM01
RED
WH
I
WHI
REDYEL
ORGBLU
BLK
RC02
RC01
WH
I
WH
I
1 12 2
GR
Y
GR
Y
CN09(WHI)
(LOUVER) BLK
BLK
Symbol Name Symbol NameFM01, 02
TA
RC01, 02
TC
TR DM
F3
RY01~RY07
F
SM01, 02CS
EarthScrew
GRN/YEL
CN02
YELORG
BLU
RE
DGRYGRY
ORGBLUBLKYEL
WH
I
CN21
1 351 35
22
664
4
RAV-104TUH-PERAV-134TUH-PERAV-164TUH-PE
1 1
3 3
5 5
7 7
9 9
Fuse (PCB)Fuse (Interface) PCBDrain PumpStepper MotorFloat Switch
Fan MotorRunning CapacitorTransformerSensorSensorRelay
3.6
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
37
3. WIRING DIAGRAMS
Symbol Name Symbol NameFM TARC TC
GMTR RY01~RY07DM CS
shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Do not operate the units with the magnetic contactor pushed in.
1
3
1
3
1
3
1
32 2
4 4
TR
CN01(TRANS)
CN12
3
1
3
1
CN02
22
CN15(LAN)
53113571357 531
1
3
5
7
1
3
5
7
99
TA
CN04(TA)
CN05(TC)
TC
RE
MO
CO
N
RY02
RY03
RY04
UL
L
M
H
CN07(FAN)
RY01 RY06
CN10(PUMP)
F (L1) (N)CN03
(SERIAL)
RY07
CN09(WHI).(LOUVER)
X Y A B C
X Y
CentralRemoteController(Optional)
A B C
RemoteController(Not PGR models)(Optional)
A B C
Infra-RedReceiver
(PGR models)
Indoor unit
1 2 3
RE
D
GR
Y
RE
D
GR
Y
BLK
GM
BLK
BLK
RY01(output)
RED
YEL
BLU
ORG BLK
1 2 3
F2
(3 Phase model)
(1 Phasemodel)
Outdoor unit
5
3
9
7
1
RED
WHIGRY
RED
BLUORG
BLK
RE
DW
HI
YELBLKBLUORG
CN16
BLUYELORG
GRYGRY
PU
R
GR
Y
DM
CN21
CS
L2 L3 NL1
PowerSupply380/415V3N~50Hz
FM
RC
8
6
4
2
5
3
9
7
1
8
6
4
2
YEL
GRN/YEL
RAV-164UH-PERAV-264UH-PERAV-364UH-PERAV-464UH-PE
EarthScrew
GRN/YEL
SensorSensorGeared MotorRelay
Float Switch
Fan Motor
Running Capacitor
Fuse (PCB)
TransformerDrain Pump
3
L
1 2
N
F2
PowerSupply220/240V~50Hz
EarthScrew
F
3.7
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
38
3. WIRING DIAGRAMS
Symbol Name Symbol Name Symbol Name20SF
RY05,0749C
20SRRCcRCo
CM52CFMoTLTE
26HD
F263HCHF
TR
Do not operate the units with magnetic contactor pushed in.
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.
A B C 1 2 3
1 2 3
Indoor unit
Outdoor unit
Earth
EarthScrew TR
BLK WHI WHI
RY05
RY07Wave
ControlCircuit TE
TL
RED
F
BLU
BLK
654321
654321
RED
WHIFM0WHIGRY
RED
BLK
RCo
321
321
B
52CA
9 121110
F2
20SR
L C
26HD
63H
20SF
L N
49C
52C RCc
CM
CH
1 2
3 4
13 14
31 32Power Supply 220/240V~50Hz
RAV-134AH-PERAV-164AH-PERAV-264AH-PE
RED
TD
TD
Solenoid coil (4 way valve)RelayInner overload relaySolenoid coil (2 way valve)Running capacitor (compressor)Running capacitor (fan motor)
CompressorMagnetic contactorFan motorSensorSensorBimetal thermostat
Fuse (T5A)High pressure switchCrankcase heaterFuse (on PCB)TransformerSensor (Dummy)
3.8
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
39
3. WIRING DIAGRAMS
Symbol Name Symbol Name Symbol Name20SF
RY05,0749C51C
RCo
CM52CFMoTLTE
63HCHF
TR
Do not operate the units with magnetic contactor pushed in.
Shows terminal block and figures show terminal numbers. Broken lines show wiring at site.1.
2. When the three phases are not connected correctly, the reverse phase protector operates, and the unit will not start. In this case, check the three phase wiring.
A B C 1 2 3
1 2 3
Indoor unit
Outdoor unit
Earth
EarthScrew
TR
BLK WHI WHI
RY05
RY07Wave
ControlCircuit
TE
RED
F
BLU
BLK
GRY
BLK
B
52CA
9 121110
20SF
NCH
1 2
3 4
5 6
31 32Power Supply 380-415V 3N~50Hz
F2
47C
L1 L2 L313 14
CM
654321
654321
RED
WHIFM
WHI
RED
0
RCo
TL
RED
BLK
RAV-264AH8-PE
TD
321
321 L C
63H
47CS
R
T
U
V
W
2
4
6
22
21
51C
49C
51C
52C
47CTD
F2CompressorMagnetic contactorFan motorSensorSensorSensor (Dummy)
20SR
26HD
Fuse (T5A)High pressure switchCrankcase heaterFuse (on PCB)TransformerBi-metal thermostat
Solenoid coil (4 way valve)RelayTemperature Overload relayCurrent Overload relayReverse phase protectorRunning capacitorSolenoid coil (2-way valve)
20SR
26HD
3.9
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
3. WIRING DIAGRAMS
40
Symbol Name Symbol Name Symbol Name20SF
RY05,0747CF2
RC01,02
CM52C
FMUP,LOWTLTE
63HCHF
TR
Do not operate the units with magnetic contactor pushed in.
Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
1.
2. When the phases are not connected correctly, the reverse phase protector operates and the unit will not start. In this case, check the three phase wiring. *Compressor has internal thermal protection
A B C 1 2 3
1 2 3
Indoor unit
Outdoor unit
Earth
EarthScrew
TR
BLK WHI WHI
RY05
RY07Wave
ControlCircuit
TE
RED
F
BLU
BLK
GRY
BLK
52C9 121110
20SF
NCH
1 2
3 4
5 6
21 22Power Supply 380-415V 3N~50Hz
321
321 L C
63H
F2
47C
A1
L2 L313 14
CM *
654321
654321
RED
WHIFM
WHI
RED
UP
654321
654321
RED
WHIFM
WHI
RED
LOW
GRY
RC01
RC02
BLKBLK
47C
TL
RED
BLK
S
R
T
RAV-364AH8-PERAV-464AH8-PE
TD
TD
Solenoid coilRelayReverse Phase ProtectorFuse (T5A)Running capacitor
CompressorMagnetic contactorFan motor (Outdoor)SensorSensor
High pressure switchCrankcase heaterFuse (on PCB)TransformerSensor
52C
A2
L1
3.10
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
41
4. SPECIFICATIONS OF ELECTRICAL PARTS
RAV-364BH-PE
RAV464BH-PE
SMF-230-60-4A
EEP2G405HQA114
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-164BH-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 60W, 4 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
No PARTS NAME TYPE SPECIFICATIONS
RAV-264BH-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
STF-200-100-4B
EAG40M505UF
ST-10568
Output (rated) 100W, 4 pole, 200V, 1 Phase, 50Hz
AC 400V, 5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
STF-200-120-4B
EAG40M505UF
ST-10568
Output (rated) 120W, 4 pole, 200V, 1 Phase, 50Hz
AC 400V, 5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
STF-200-140-4F
EAG40M106UF
ST-10568
Output (rated) 140W, 4 pole, 200V, 1 Phase, 50Hz
AC 400V, 10µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
4.1
4.2
4.3
4.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
42
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-134CH/CHR-PE
4. SPECIFICATIONS OF ELECTRICAL PARTS
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
SMF-230-34-4H
EEP2H155HQA107
ST-10568
MT8-3-6
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-164CH/CHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
SMF-230-34-4D
EEP2W255HQA113
ST-10568
MT8-3-6
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-264CH/CHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
SMF-230-34-4D
EEP2W255HQA113
ST-10568
MT8-3-6
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
4.5
4.6
4.7
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
43
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-364CH/CHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
SMF-230-75-4U
EVM45M305UF
ST-10568
MT8-3-6
Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 3.0µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-464CH/CHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
SMF-230-75-4B
EEP2G405HQA114
ST-10568
MT8 -3-6
Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz
AC 400V, 4.0µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
4.8
4.9
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
44
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-134KH/KHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
MMF-230-27-4P
EEP2H105HQA105
ST-10568
MT8-3-6
Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-164KH/KHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
MMF-230-27-4P
EEP2H155HQA107
ST-10568
MT8-3-6
Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
No PARTS NAME TYPE SPECIFICATIONS
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
RAV-264KH/KHR-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
MMF-230-27-4R
EEP2W205HQA107
ST-10568
MT8-3-6
Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.0µF
AC 187-264V
AC 230V, 3W
Maximum input38mA
Maximum input15.5mA
4.10
4.11
4.12
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
45
4. SPECIFICATIONS OF ELECTRICAL PARTS
RAV-104NH-PE
SMF-230-34-4H
EEP2H155HQA107
ST-10568
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
SMF-230-34-4H
EEP2W205HQA107
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-134NH-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
SMF-230-34-4E
EEP2W255HQA113
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-164NH-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2,5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
SMF-230-34-40
EEP2H155HQA107
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-264NH-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
No PARTS NAME TYPE SPECIFICATIONS
4.13
4.14
4.15
4.16
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
46
4. SPECIFICATIONS OF ELECTRICAL PARTS
SMF-230-34-4D
EEP2W255HQA113
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-164SH/SHR-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
SMF-230-34-4D
EEP2W255HQA113
ST-10568
No PARTS NAME TYPE SPECIFICATIONS
RAV-264SH/SHR-PE
Indoor Unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Sensor for room temperature
Sensor for heat exchanger temperature
Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
AC 187-264V
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
1
2
3
4
5
4.17
4.18
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
47
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 450V, 0.5µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EVM45M504UF
ST-10568
MP35EA2
PCD-4N230TF-3
FS-085-003E
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-104TUH-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-264V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EEP2H105HQA105
ST-10568
MP35EA2
PCD-4N230TF-3
FS-085-003E
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-134TUH-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 187-254V
DC 12V, 80mNm
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
PAF-230-7-4
EEP2H105HQA105
ST-10568
MP35EA2
PCD-4N230TF-3
FS-085-003E
Indoor unit fan motor (x2)
Running capacitor forindoor fan motor (x2)
Transformer (Indoor Unit)
Stepper motor (x2)
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
RAV-164TUH-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
4.19
4.20
4.21
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
48
4. SPECIFICATIONS OF ELECTRICAL PARTS
MMF-230-28A
EEP2H105HQA105
ST-10568
MT8-3-8
PJV-0739
FS-085-003B
Indoor unit fan motor
Running capacitor forindoor fan motor
Transformer (Indoor Unit)
Geared motor
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz
AC 500V, 1.0µF
AC 287-264V
AC 240V, 3W
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
RAV-164UH-PE
MMF-230-28A
EEP2W205HQA107
ST-10568
MT8-3-8
PJV-0739
FS-085-003B
Indoor unit fan motor
Running capacitor forindoor fan motor
Transformer (Indoor Unit)
Geared motor
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
1
2
3
4
5
6
7
8
Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.0µF
AC 187-264V
AC 240V, 3W
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
No PARTS NAME TYPE SPECIFICATIONS
RAV-264UH-PE
4.22
4.23
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
49
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
1
2
3
4
5
6
7
8
RAV-364UH-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
MMF-230-36A
EEP2W255HQA113
ST-10568
MT8-3-8
PJV-0739
FS-085-003B
Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz
AC 450V, 2.5µF
AC 187-264V
AC 230V, 3W
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
Indoor unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
No PARTS NAME TYPE SPECIFICATIONS
1
2
3
4
5
6
7
8
RAV-464UH-PE
ûC 15 20 25 30 40
k½ 16.1 12.6 10.0 8.0 5.2
ûC -12 10
k½ 67.5 21.3
MMF-230-36A
EVM45M305UF
ST-10568
MT8-3-8
PJV-0739
FS-085-003B
Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz
AC 450V, 3.0µF
AC 187-264V
AC 230V, 3W
AC 230V, 0.2A
AC 230V, 0.5A
Maximum input38mA
Maximum input15.5mA
Indoor unit fan motor
Running capacitor for indoor fan motor
Transformer (Indoor Unit)
Geared motor
Drain pump
Float switch
Sensor for room temperature
Indoor Unit sensor for heatexchanger temperature
4.24
4.25
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
50
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Running capacitor for compressor
Transformer (Outdoor Unit)
Bimetal thermostat
1
2
3
4
5
6
7
8
9
10
11
12
13
14
RAV-134AH-PE
ûC -12 10
k½ 67.5 21.3
ûC -12 10
k½ 67.5 21.3
PG330X3F-4LS
SMF-230-39N-2
EEP2G405HQA114
FMCa-1S-02
ACB-2TB04W
CHV-AC240V
NEV AC 240V
MT-44MP456W
FT-67
CS-12A
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 440V, 45µF
AC 187-264V
Tripping temperature: 110ûCResetting temperature: 90ûC
4.26
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
51
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Running capacitor for compressor
Transformer (Outdoor Unit)
Bimetal thermostat
1
2
3
4
5
6
7
8
9
10
11
12
13
14
RAV-164AH-PE
ûC -12 10
k½ 67.5 21.3
ûC -12 10
k½ 67.5 21.3
PG350X3F-4LS
SMF-230-39N-2
EEP2G405HQA114
FMCa-1S-02
ACB-2TB04W
CHV-AC240V
NEV AC 240V
MT-44MP456W
FT-67
CS-12A
Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 440V, 45µF
AC 187-264V
Tripping temperature: 110ûCResetting temperature: 90ûC
4.27
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
4. SPECIFICATIONS OF ELECTRICAL PARTS
52
No PARTS NAME TYPE SPECIFICATIONS
RAV-264AH-PE
ûC -12 10
k½ 67.5 21.3
ûC -12 10
k½ 67.5 21.3
PG460X3F-4MS
SMF-230-63N-2
EEP2G405HQA114
FMCa-1S-02
ACB-2TB04W
CHV-AC240V
NEV AC 240V
EAR42M606UF
FT-67
CS-12A
Output (rated) 2.2kW, 2 pole, 220/240V, 1 Phase, 50Hz
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 420V, 60µF
AC 187-264V
Tripping temperature: 110ûC Resetting temperature: 90ûC
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Running capacitor for compressor
Transformer (Outdoor Unit)
Bimetal thermostat
4.28
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
4. SPECIFICATIONS OF ELECTRICAL PARTS
53
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil for four-way valve
Crankcase heater
Sensor for defrosting
Fuse
Sensor for cooling operation in lowambient temperature
Solenoid coil for two-way valve
Reverse Phase Protector
Transformer (Outdoor Unit)
Bimetal thermostat
1
2
3
4
5
6
7
8
9
10
11
12
13
14
RAV-264AH8-PE
ûC -12 10
k½ 67.5 21.3
ûC -12 10
k½ 67.5 21.3
YG460X3F-MS
SMF-230-63N-2
EEP2G405HQA114
FMSa-1
ACB-2TB04W
CHV-AC240V
NEV AC 240V
STR-4AD
FT-67
CS-12A
Output (rated) 2.2kW, 2 pole, 380/415V, 3 Phase, 50Hz
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 220-240V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
T5A
Maximum input15.5mA
AC 220-240V, 50Hz
AC 187-264V
Tripping temperature: 110ûC Resetting temperature: 90ûC
4.29
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
4. SPECIFICATIONS OF ELECTRICAL PARTS
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil
Crankcase heater
Outdoor unit for heatexchanger temperature
Transformer for outdoor unit
Fuse
Sensor for cooling operation in lowambient temperature
Reverse Phase Protector
Sensor for deliverypipe temperature
1
2
3
4
5
6
7
8
9
10
11
12
13
RAV-364AH8-PE
ûC -12 10
k½ 67.5 21.3
ZR49KCE-TFD-230
SMF-230-63N-2
SMF-230-39N-2
EEP2G405HQA114
FC-2S
ACB-2TB04W
CHV-AC240V
FT-67
STR-4AD
Output (rated) 3.0kW, 2 pole, 380/415V, 3 Phase, 50Hz
Winding resistance 3.73½ at 20ûC
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 230V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
AC 187-264V
T5A
Maximum input15.5mA
ûC -12 10
k½ 67.5 21.3
ûC 23 100
k½ 57.0 3.4
54
4.30
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
4. SPECIFICATIONS OF ELECTRICAL PARTS
55
No PARTS NAME TYPE SPECIFICATIONS
Compressor
Outdoor unit fan motor
Running capacitor for outdoor fan motor
Magnetic contactor
High pressure switch
Solenoid coil
Crankcase heater
Outdoor unit for heatexchanger temperature
Transformer for outdoorunit
Fuse
Sensor for cooling operation in lowambient temperature
Reverse Phase Protector
Sensor for deliverypipe temperature
1
2
3
4
5
6
7
8
9
10
11
12
13
RAV-464AH8-PE
ûC -12 10
k½ 67.5 21.3
ZR61KCE-TFD-230
SMF-230-63N-2
SMF-230-39N-2
EEP2G405HQA114
FC-2S
ACB-2TB04W
CHV-AC240V
FT-67
STR-4AD
Output (rated) 3.75kW, 2 pole, 380/415V, 3 Phase, 50Hz
Winding resistance 2.19 ½ at 20ûC
Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz
Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz
AC 400V, 4µF
AC 230V, 50Hz
Tripping pressure 30kgf/cm2GResetting pressure 23kgf/cm2G
AC 220-240V
AC 240V, 28W
Maximum input15.5mA
AC 187-264V
T5A
Maximum input15.5mA
ûC -12 10
k½ 67.5 21.3
ûC 23 100
k½ 57.0 3.4
4.31
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
5.1
5. REFRIGERANT PIPING DIAGRAMS
56
Distributor strainerCapillary tube
TC Sensor
Indoor unit
Heat exchanger
Strainer
Cooling
Heating
Refrigerant pipe (Gas)¿12.7mm (1/2")
Refrigerant pipe (Liquid)¿6.4mm (1/4")
Indoor UnitRAV-104NH-PERAV-104TUH-PE
Model Capillary
RAV-104NH-PE ID¿1.7x250Lx2P
RAV-104TUH-PE ID¿2.4x300Lx2P
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
57
Indoor unit
Cooling
Heating
Packed valve
Strainer
Liquid receiver
Capillary tube¿3.0x600Lx1P
Dryer
Expansionvalve Check
valve
Heat exchangerTL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)¿12.7mm (1/2")
Refrigerant pipe (Liquid)¿6.4mm (1/4")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
Strainer
Compressor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
Capillary tube¿2.6x400Lx1P
Accumulator
Capillary tube¿0.8x1000Lx1P
2-wayvalve
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMainCapillary
RAV-134CH/CHR-PEID¿2.0x300Lx2P
RAV-134KH/KHR-PE
ID¿2.0x200Lx2P
RAV-134AH-PE ID¿2.6x400Lx1P
RAV-134TUH-PE
RAV-134NH-PE
ID¿1.7x300Lx2PID¿1.7x400Lx2P
ID¿2.4x300Lx2P
ID¿1.7x150Lx3P
BypassCapillary
ID¿0.8x1000Lx1P
Cooling BypassCapillary
ID¿3x600Lx1P
Indoor UnitRAV-134CH/CHR-PERAV-134KH/KHR-PERAV-134NH-PERAV-134TUH-PE
Outdoor UnitRAV-134AH-PE
Liquid tank onx2 CH/CHRand TUH only
Distributor strainercapillary tube
TC Sensor
Heat exchanger
Strainer
5. REFRIGERANT PIPING DIAGRAMS
5.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
58
5. REFRIGERANT PIPING DIAGRAMS
Distributor strainercapillary tube
TC Sensor
Indoor unit
Heat exchanger
Strainer
Cooling
Heating
Packed valve
Strainer
Liquid receiver
Capillary tube¿3.0x600Lx1P
Dryer
Expansionvalve Check
valve
Heat exchangerTL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)¿12.7mm (1/2")
Refrigerant pipe (Liquid)¿6.4mm (1/4")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
Strainer
Compressor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
Capillary tube¿2.6x400Lx1P
Accumulator
Capillary tube¿0.8x1000Lx1P
2-wayvalve
INDOOR UNIT OUTDOOR UNIT
Model Capillary ModelMainCapillary
RAV-164BH-PEID¿1.7x150Lx2P
RAV-164CH/CHR-PE
ID¿1.7x300Lx1P
RAV-164AH-PE ID¿2.6x400Lx1PRAV-164KH/KHR-PE
RAV-164NH-PE
RAV-164SH/SHR-PE
RAV-164TUH-PERAV-164UH-PE
ID¿1.7x300Lx2PID¿1.7x400Lx2PID¿1.7x300Lx2PID¿1.7x300Lx2PID¿1.7x200Lx3P
BypassCapillary
ID¿0.8x1000Lx1P
Cooling BypassCapillary
ID¿3x600Lx1P
Indoor UnitRAV-164BH-PERAV-164CH/CHR-PERAV-164KH/KHR-PERAV-164NH-PERAV-164SH/SHR-PERAV-164TUH-PERAV-164UH-PE
Outdoor UnitRAV-164AH-PE
ID¿1.7x300Lx1PID¿1.7x400Lx2PID¿1.7x250Lx2P
ID¿2.0x200Lx3PID¿2.2x200Lx2P
5.3
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
59
5. REFRIGERANT PIPING DIAGRAMS
Liquid tank onx1 CH, CHRx3 NH only
Distributor strainercapillary tube
Indoor unit
Cooling
Heating
Packed valve
Strainer
Dryer
Expansionvalve Check valve Heat exchanger
TL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)¿15.9mm (5/8")
Refrigerant pipe (Liquid)¿9.5mm (3/8")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
Strainer
Compressor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAIN CAPILLARY
RAV-264AH-PERAV-264AH8-PE ID¿2.6x300Lx1P
Indoor UnitRAV-264BH-PERAV-264CH/CHR-PERAV-264KH/KHR-PERAV-264NH-PERAV-264SH/SHR-PERAV-264UH-PE
Outdoor UnitRAV-264AH-PERAV-264AH8-PE
Capillary tube¿2.6mm x 300L x 1P
2-wayvalve
Accumulator
RAV-264CH/CHR-PE
RAV-264UH-PE
RAV-264BH-PE
RAV-264KH/KHR-PE
RAV-264NH-PE
RAV-264SH/SHR-PE
ID¿2.6x200x4PID¿2.6x600x2PID¿2.6x200x5PID¿2.6x400x1P
ID¿2.6x200x4PID¿2.6x400x2PID¿2.6x600x4PID¿2.6x400x2PID¿2.6x200x5PID¿2.6x400x1PID¿2.6x200x4PID¿2.6x600x2P
ID¿1.0x500Lx1P
BYPASS CAPILLARY
Check valve
Strainer
BypassCapillary
TC Sensor
Strainer
Heat exchanger
5.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
60
5. REFRIGERANT PIPING DIAGRAMS
Liquid tank onx2 CH,CHRx3 UH only
Distributor strainercapillary tube
TC Sensor
Indoor unit
Heat exchanger
Strainer
Cooling
Heating
Packed valve
Strainer
Liquidreceiver
Capillary tubeDryer
Expansionvalve
Check valveHeat exchanger
TL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)¿19mm (3/4")
Refrigerant pipe (Liquid)¿9.5mm (3/8")
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
MufflerX2
Strainer
Accumulator
CompressorTD Sensor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAIN CAPILLARY
RAV-364BH-PE ID¿2.2x200Lx6P
RAV-364CH/CHR-PE ID¿2x200Lx7PRAV-364AH8-PE ID¿2.5x500Lx1P
Indoor UnitRAV-364BH-PERAV-364CH/CHR-PERAV-364UH-PE
Outdoor UnitRAV-364AH8-PE
RAV-364UH-PE
ID¿2.6x200Lx6P
ID¿2.6x300Lx2P
ID¿2.6x500Lx2P
5.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
61
5. REFRIGERANT PIPING DIAGRAMS
Indoor unit
Cooling
Heating
Packed valve
Strainer
LiquidTank
Capillary tube
Dryer
Expansionvalve Check valve Heat exchanger
TL sensor
Distributor
TE sensor
Refrigerant pipe (Gas)ø19mm (3/4²)
Refrigerant pipe (Liquid)ø9.5mm (3/8²)
P2Packed valve
Line pressure
Cooling Heating
P1 High pressure Low pressure
P2 High pressureLow pressure
MufflerX2
Strainer
Accumulator
CompressorTD Sensor
Four-way valve
High pressure switch
P1
Check joint
Outdoor unit
Indoor unitRAV-464BH-PERAV-464CH-PERAV-464UH-PE
Outdoor unitRAV-464AH8-PE
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAIN CAPILLARY
RAV-464BH-PE IDø2.2x200Lx6P
RAV-464CH/CHR-PE
RAV-464UH-PE
IDø2x200Lx8P
IDø2.6x200Lx6P
IDø2.6x300Lx2P
IDø2.6x500Lx2P
RAV-464AH8-PE IDø3x600Lx1P
Liquid tank onx3 CH,CHRx4 UH only
Distributor strainercapillary tube
TC Sensor
Heat exchanger
Strainer
5.6
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
62
6. PERFORMANCE CHARACTERISTICS
2.88
3.06
3.24
3.42
3.60
3.78
3.96
4.14
4.32
3.60
3.82
4.05
4.28
4.50
4.73
4.95
5.18
5.40
5.68
6.04
6.39
6.75
7.10
7.46
7.81
8.17
8.52
8.00
8.50
9.00
9.50
10.00
10.50
11.00
11.50
12.00
10.00
10.63
11.25
11.88
12.50
13.13
13.75
14.38
15.00
RAV-134AH-PE RAV-164AH-PE RAV-264AH-PERAV-264AH8-PE
RAV-364AH8-PE RAV-464AH8-PE
5.04
4.83
4.62
4.41
4.20
3.99
3.78
3.57
3.36
3.15
2.94
2.73
2.52
2.31
6.00
5.75
5.50
5.25
5.00
4.75
4.50
4.25
4.00
3.75
3.50
3.25
3.00
2.75
9.48
9.09
8.69
8.30
7.90
7.51
7.11
6.72
6.32
5.93
5.53
5.14
4.74
4.35
12.96
12.42
11.88
11.34
10.80
10.26
9.72
9.18
8.64
8.10
7.56
7.02
6.48
5.94
16.56
15.87
15.18
14.49
13.80
13.11
12.42
11.73
11.03
10.35
9.66
8.97
8.28
7.59
RAV-134AH-PE RAV-164AH-PE RAV-264AH-PERAV-264AH8-PE
RAV-364AH8-PE RAV-464AH8-PE
Capacity Ratio (%)
Capacity Ratio (%)
Room Temp. (Wet Bulb) (¡C)
Room Temp. (Dry Bulb) (¡C)
Am
bien
t Tem
p. (
Dry
Bul
b) (
¡C)
Am
bien
t Tem
p. (
Wet
Bul
b) (
¡C)
Cooling capacity
Heating capacity
(kW)
(kW)
6.1
6.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
63
6. PERFORMANCE CHARACTERISTICS
Cooling Capacity Ratio
Cooling Capacity Ratio
Piping Length (m)
Piping Length (m) Piping Length (m)
Piping Length (m)
Out
door
Uni
t H
eigh
t H
(m
)O
utdo
or U
nit
Hei
ght
H (
m)
Out
door
Uni
t H
eigh
t H
(m
)
Out
door
Uni
t H
eigh
t H
(m
)
Heating Capacity Ratio
Heating Capacity Ratio
The broken line shows in case the piping length is 30m or less
Capacity Correction FactorsRAV-134AH-PERAV-164AH-PERAV-264AH-PERAV-264AH8-PE
Capacity Correction FactorsRAV-364AH8-PERAV-464AH8-PE
6.3
6.4
INDOORUNIT
H L
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
64
6. PERFORMANCE CHARACTERISTICS
Piping Length/Additional Refrigerant Volume
The amount of refrigerant put into the outdoor unit at the factory is sufficient to fill up to 20m ofrefrigerant pipework.
If the length of the refrigerant pipework is 20m or less, addition of refrigerant at the installation siteis unnecessary.
If the length of the pipework exceeds 20m, extra refrigerant must be added. Refer to the tablebelow for details of the extra amounts.
Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction ofthe compressor.
The prescribed amount of the replenishment of the refrigerant is shown in the table below:
!
!
!
!
134AH-PE
164AH-PE
264AH/AH8-PE
364AH8-PE
464AH8-PE
134A-PE
164A-PE
264A/A8-PE
364A8-PE
464A8-PE
0.18 0.35 Ñ Ñ Ñ Ñ 0.79 1.05 1.23 1.4 Ñ Ñ Ñ Ñ
0.18 0.35 Ñ Ñ Ñ Ñ 0.94 1.2 1.38 1.55 Ñ Ñ Ñ Ñ
0.18 0.35 Ñ Ñ Ñ Ñ 1.64 1.9 2.08 2.25 Ñ Ñ Ñ Ñ
0.18 0.35 0.53 0.7 0.88 1.05 2.44 2.7 2.88 3.05 3.23 3.4 3.58 3.75
0.25 0.5 0.75 1.0 1.25 1.5 3.13 3.5 3.75 4.0 4.25 4.5 4.75 5.0
0.18 0.35 Ñ Ñ Ñ Ñ 0.79 1.05 1.23 1.4 Ñ Ñ Ñ Ñ
0.18 0.35 Ñ Ñ Ñ Ñ 0.94 1.2 1.38 1.55 Ñ Ñ Ñ Ñ
0.18 0.35 Ñ Ñ Ñ Ñ 1.64 1.9 2.08 2.25 Ñ Ñ Ñ Ñ
0.18 0.35 0.53 0.7 0.88 1.05 2.44 2.7 2.88 3.05 3.23 3.4 3.58 3.75
0.25 0.5 0.75 1.0 1.25 1.5 3.13 3.5 3.75 4.0 4.25 4.5 4.75 5.0
ADD ONLY R407C REFRIGERANT TO THESE UNITS!
MODEL(RAV-)
Recharge amount if unit is reclaimed(kg)±50g
Lessthan5m
Lessthan20m
Lessthan25m
Lessthan30m
Lessthan35m
Lessthan40m
Lessthan45m
Lessthan50m
Additional amount of refrigerant to add at installation site (kg)±50g
Lessthan20m
Lessthan25m
Lessthan30m
Lessthan35m
Lessthan40m
Lessthan45m
Lessthan50m
Filledat
Factory
6.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
65
7. EXPLODED VIEWS AND PARTS LISTS
214
204
208
203215
209
210
211
212
205
207
216
201
213
217
202
206
218
Indoor UnitRAV-164BH-PERAV-264BH-PERAV-364BH-PERAV-464BH-PE
RefNo. Part No. Description Model
201
202
203
204
204
204
204
205
205
205
205
206
207
208
43160394
43107215
43120149
43A21009
43121516
43121528
43121535
43A44031
43A44032
43A44039
43A44040
43A50003
43A50004
43155080
Connector-9P
Sensor Holder
Fan-Multi Blade
Fan Motor SMF-230-60-4A
Fan Motor STF-200-100-4B
Fan Motor STF-200-120-4B
Fan Motor STF-200-140-4F
Refrigeration Asm
Refrigeration Asm
Refrigeration Asm
Refrigeration Asm
Sensor-Room Temp
Sensor-H/Exchanger
MF Capacitor 4mF 400V
All
All
All
RAV-164BH-PE
RAV-264BH-PE
RAV-364BH-PE
RAV-464BH-PE
RAV-164BH-PE
RAV-264BH-PE
RAV-364BH-PE
RAV-464BH-PE
All
All
RAV-164BH-PE
RefNo. Part No. Description Model
208
208
209
210
211
212
213
213
213
214
215
216
217
218
43155096
43155097
43A58004
43A60010
43A60001
43A69010
43A72004
43A72005
43191310
43125135
43A60009
43A88011
43A70002
43125137
MF Capacitor 5mF 400V
MF Capacitor 10mF 400V
Transformer Ð AI
Terminal Block Ð ÔABCXYÕ
Terminal Block Ð Ô123Õ
PC Board Ð AI
Drain Pan Assembly
Drain Pan Assembly
Drain Pan Assembly
Bearing
Bushing
Owners Manual
Drain Socket
Coupling
RAV-264/364BH-PE
RAV-464BH-PE
All
All
All
All
RAV-164BH-PE
RAV-264BH-PE
RAV-364/464BH-PE
RAV-464BH-PE
All
All
All
RAV-464BH-PE
Indoor UnitRAV-164BH-PERAV-264BH-PERAV-364BH-PERAV-464BH-PE
7.1
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
66
7. EXPLODED VIEWS AND PARTS LISTS
223 43A44029 RAV-464CH/CHR224 43155101 RAV-134CH/CHR224 43155138 RAV-164/264CH/CHR224 43A55001 RAV-364CH/CHR224 43155080 RAV-464CH/CHR225 43A70007 All226 43172121 RAV-134/164CH/CHR226 43172119 RAV-264CH/CHR226 43172122 RAV-364CH/CHR226 43172123 RAV-464CH/CHR227 43179107 All228 43180284 134/164/264CH/CHR229 43180283 264/364/464CH/CHR230 43A88011 All231 43A21008 All232 43A50005 All233 43A50004 All234 43102624 All235 43102625 All236 43117812 All237 43A58004 All238 43A60001 All239 43A60010 All240 43A69010 All241 43A69012 All242 43A91001 RAV-134/164CH242 43A91002 RAV-264CH242 43A91003 RAV-364CH242 43A91004 RAV-464CH243 43A91040 RAV-134/164CHR243 43A91041 RAV-264CHR243 43A91042 RAV-364CHR243 43A91043 RAV-464CHR244 43A91005 RAV-134/164CH/CHR244 43A91006 RAV-264CH/CHR244 43A91007 RAV-364CH/CHR244 43A91008 RAV-464CH/CHR
RefNo. Part No. Description Model
201 43107214 All202 43107215 All203 43107216 All204 43107223 All205 43107222 All206 43107224 RAV-364/464CH/CHR207 43109321 264/364/464CH/CHR208 43109322 134/164/264/364CH/CHR209 43109324 RAV-134/164CH/CHR209 43109320 RAV-264CH/CHR-PE209 43109327 RAV-364CH/CHR209 43109328 RAV-464CH/CHR210 43109329 All211 43119373 All212 43119393 All213 43119394 All214 43120172 134/164/264CH/CHR214 43120174 364/464CH/CHR215 43A21013 RAV-134CH/CHR215 43A21005 RAV-164/264CH/CHR215 43A21007 RAV-364CH/CHR215 43A21006 RAV-464CH/CHR216 43125131 164/264/364/464CH/CHR217 43125142 164/264/364/464CH/CHR218 43125143 RAV-164CH/CHR218 43125141 RAV-264CH/CHR218 43125145 RAV-364CH/CHR218 43125144 RAV-464CH/CHR219 43126127 134/164/264CH/CHR219 43126129 364/464CH/CHR220 43126128 134/164/264CH/CHR220 43126130 364/464CH/CHR221 43A39004 All222 43A39005 264/464CH/CHR223 43A44037 RAV-134CH/CHR223 43A44038 RAV-164CH/CHR223 43A44054 RAV-264CH/CHR223 43A44030 RAV-364CH/CHRÊ
RefNo. Part No. Description Model
Indoor UnitRAV-134CH/CHR-PERAV-164CH/CHR-PERAV-264CH/CHR-PERAV-364CH/CHR-PERAV-464CH/CHR-PE
Refrigeration AssemblyMF CapacitorMF CapacitorMF CapacitorMF CapacitorHose AssemblyDrain Pan AssemblyDrain Pan AssemblyDrain Pan AssemblyDrain Pan AssemblyPlugAir Filter Ð LargeAir Filter Ð SmallOwners ManualGeared MotorSensor ÐÊRoom Temp.(TA)Sensor ÐÊH/Exchanger (TC)Side Panel Right Assmb.Side Panel Left Assmb.Plate HTransformer Ð AITerminal Block 123Terminal Block ABC XYPC Board (AI)Infra-Red ReceiverUnder PanelUnder PanelUnder PanelUnder PanelUnder Panel (Remote)Under Panel (Remote)Under Panel (Remote)Under Panel (Remote)Upper Panel AsmUpper Panel AsmUpper Panel AsmUpper Panel Asm
HingeSensor HolderSpringGrille Shaft Ð LeftGrille Shaft Ð RightGrille Support Ð CentreInlet Grille Ð LargeInlet Grille Ð SmallHorizontal GrilleHorizontal GrilleHorizontal GrilleHorizontal GrilleVertical GrilleBolt CoverShaft HolderLeverFan Ð Multi BladeFan Ð Multi BladeFan MotorFan MotorFan MotorFan MotorBearingCouplingShaft SSShaft SSShaft SSShaft SSFan Case ÐÊLowerFan Case ÐÊLowerFan Case Ð UpperFan Case Ð UpperConnect BarConnect BarRefrigeration AssemblyRefrigeration AssemblyRefrigeration AssemblyRefrigeration Assembly
206 244211
231
205 203
234
224
215217218
214
223
240
227233
238
239
232
237
206
201
210 202
236207
212221222213
241
225
226 219
228
229
242/243
230
220
216
235
204
209
Indoor UnitRAV-134CH/CHR-PERAV-164CH/CHR-PERAV-264CH/CHR-PERAV-364CH/CHR-PERAV-464CH/CHR-PE
7.2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
67
7. EXPLODED VIEWS AND PARTS LISTS
Indoor UnitRAV-134KH/KHR-PERAV-164KH/KHR-PERAV-264KH/KHR-PE
220
RefNo. Part No. Description Model
Fan Ð MotorFan Ð MotorPC Board Ð (AI)Transformer Ð (AI)CapacitorCapacitorCapacitorTerminal 123Terminal XYTerminal ABCSensor Ð Room Temperature TASensor Ð Heat Exchanger TCRefrigeration ASMRefrigeration ASMRefrigeration ASMDrain PanDrain PanDrain HoseH-GrilleH-GrilleV-Grille
RAV-134/164KH/KHR-PERAV-264KH/KHR-PE
AllAll
RAV-134KH/KHR-PERAV-164KH/KHR-PERAV-264KH/KHR-PE
AllAllAllAllAll
RAV-134KH/KHR-PERAV-164KH/KHR-PERAV-264KH/KHR-PE
RAV-134/164KH/KHR-PERAV-264KH/KHR-PE
AllRAV-134/164KH/KHR-PERAV-264KH/KHR-PE
All
RefNo. Part No. Description Model
215 43A39004216 43022189217 43120135217 43120136218 43A09004219 43A80008220 43A00001221 43A00002222 43A00003222 43A01005223 43121533224 43A19002225 43107215226 43122028226 43122029227 43119394228 43A91050228 43A91051229 43A69012230 43A88011
Connection BarBearingCross Flow FanCross Flow FanInlet GrilleAir FilterSide Cabinet Ð LeftSide Cabinet Ð RightControl PanelControl Panel - RemoteGeared MotorSensor Holder, TASensor Holder, TCFan NoseFan NoseLeverD Cabi Ð AssemblyD Cabi Ð AssemblyInfra Red Receiver Ð (AI)OwnerÕs Manual
AllAll
RAV-134/164KH/KHR-PERAV-264KH/KHR-PE
AllAllAllAll
KH models onlyKHR models only
AllAllAll
RAV-134/164KH/KHR-PERAV-264KH/KHR-PE
AllRAV-134/164KH/KHR-PERAV-264KH/KHR-PE
KHR models onlyAll
210
216
213
226
218
230
224
219229
211
212
214
227
222
228223
215
225
221201
203
204
205
206208
209
207202217
201 43A21016201 43A21017202 43A69010203 43A58004204 43155100204 43155101204 43A55002205 43A60001206 43A60011207 43A60002208 43A50008209 43A50009210 43A44049210 43A44050210 43A44051211 43172112211 43172114212 43170182213 43A09005213 43A09006214 43A09003
Indoor UnitRAV134KH/KHR-PERAV164KH/KHR-PERAV264KH/KHR-PE
7.3
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
68
7. EXPLODED VIEWS AND PARTS LISTS
Indoor UnitRAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PE
201201201202202203203204205206207207208209209209209210210210210211211212213214215216217218219220
Fan MotorFan MotorFan MotorFan Case LowerFan Case LowerFan Case UpperFan Case UpperSS ShaftCouplingBearingMulti Blade FanMulti Blade FanSensor HolderRefrigeration AssemblyRefrigeration AssemblyRefrigeration AssemblyRefrigeration AssemblyMF CapacitorMF CapacitorMF CapacitorMF CapacitorFilterFilterSensor Ð Heat Exchanger TCSensor Ð Room Temp TATransformer Ð (AI)Terminal Block 123Terminal Block ABCXYPC Board Ð (AI)Drain Catch AssemblyDrain HoseOwnerÕs Manual
43A2101343A2100443A210204312612743126129431261284312613043125143431251424312513143120172431201744310721543A4404543A4404643A4404743A440484315510143A55002431551384315510143A8000643A8000743A5000443A5000343A5800443A6000143A6001043A6901043A700044317019743A88011
RefNo. Part No. Description Model
220
217 214
216
215
212 213
206
208 204
201
202 211
207
205
203
218
219
210
209
RAV-104/134NH-PERAV-164NH-PERAV-264NH-PE
RAV-104/134/164NH-PERAV-264NH-PE
RAV-104/134/164NH-PERAV-264NH-PERAV-164NH-PERAV-164NH-PERAV-164NH-PE
RAV-104/134/164NH-PERAV-264NH-PE
AllRAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PERAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PERAV-104NH-PE
RAV-134/164/264NH-PEAllAllAllAllAllAllAllAllAll
Indoor UnitRAV-14NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PE
Indoor UnitRAV-104NH-PERAV-134NH-PERAV-164NH-PERAV-264NH-PE
7.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
69
7. EXPLODED VIEWS AND PARTS LISTS
Indoor UnitRAV-164SH/SHR-PERAV-264SH/SHR-PE
RefNo. Part No. Description Model Ref
No. Part No. Description Model
201 43107214202 43107215203 43107216204 43107223205 43107222207 43109321208 43109322209 43109324209 43109320210 43109329211 43119373212 43119393213 43119394214 43120172215 43A21005216 43125131217 43125142218 43125143218 43125141219 43126127220 43126128221 43A39004222 43A39005223 43A44052223 43A44053
224 43155101224 43155138225 43A70007226 43A72002226 43A72003227 43179107228 43180283229 43180284230 43A88011231 43A50005232 43A50004233 43102624234 43102625235 43117812236 43A58004237 43A60001238 43A60010239 43A69010240 43A69012241 43A91046241 43A91044241 43A91047241 43A91045242 43A91052242 43A91053
HingeSensor HolderSpringGrille Shaft LeftGrille Shaft RightInlet Grille LargeInlet Grille SmallLouvreLouvreVertical GrilleBolt CoverShaft HolderLeverFan, Multi BladeFan MotorBearingCouplingShaft SSShaft SSFan Case LowerFan Case UpperConnect BarConnect BarRefrigeration AssemblyRefrigeration Assembly
AllAllAllAllAll
RAV-264SH/SHR-PEAll
RAV-464SH/SHR-PERAV-264SH/SHR-PE
AllAllAllAllAllAll
RAV-264SH/SHR-PERAV-264SH/SHR-PERAV-164SH/SHR-PERAV-264SH/SHR-PE
AllAllAll
RAV-264SH/SHR-PERAV-164SH/SHR-PERAV-264SH/SHR-PE
MF CapacitorMF CapacitorHose AssemblyDrain Pan AssemblyDrain Pan AssemblyPlugAir Filter SmallAir Filter LargeOwnerÕs ManualSensor Ð room temperatureSensor Ð heat exchanger (TC)Side Panel Assm Ð rightSide Panel Assm Ð leftPlate HTransformer Ð (AI)Terminal Block Ð 123Terminal Block Ð ABCXYPC Board Ð (AI)Infra-red Receiver Ð (AI)UnderpanelUnderpanel Ð (remote)UnderpanelUnderpanel Ð (remote)Upper panelUpper panel
RAV-164SH/SHR-PERAV-264SH/SHR-PE
AllRAV-164SH/SHR-PERAV-264SH/SHR-PE
AllRAV-264SH/SHR-PERAV-164SH/SHR-PE
AllAllAllAllAllAllAllAllAllAll
RAV-164/264SH/SHR-PERAV-164SH-PE
RAV-164SHR-PERAV-264SH-PE
RAV-264SHR-PERAV-164SH/SHR-PERAV-264SH/SHR-PE
236237
238
231232
239
224
216226
229
228
207
208
241
213
212 210
222
202
221
201217
220214
219215
218
227
205203
211
233232
242
209
223
204234
230
225
235
240
Indoor UnitRAV-164SH/SHR-PERAV-264SH/SHR-PE
7.5
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
70
7. EXPLODED VIEWS AND PARTS LISTS
Indoor UnitRAV-104TUH-PERAV-134TUH-PERAV-164TUH-PE
Casing AssemblyFanFloat SwitchPump AssemblyBearingDrain ConnectionDrain HoseTerminal ABC XYTerminal 123Fan MotorSensor HolderCasing OutletHeat ExchangerHeat ExchangerHeat ExchangerCanoe ClipDrain PanOwnerÕs ManualInterface PC BoardCapacitor, Metal FilmCapacitor, Metal FilmPC Board - (AI)Transformer - (AI)Sensor - Heat Exchanger (TC)Sensor - Room Temperature (TA)
201202203204205206207208209210211212213213213214215216217218218219220221222
43A22001430202884315121743A7000343020253430710194307016443A6001043A6000143A2101443A5000643A2200243A4404243A4404343A440444303924043A7200143A8801143A69008375557214315510043A6901043A5800443A5000443A50008
RefNo. Part No. Description Model
AllAllAllAllAllAllAllAllAllAllAllAll
RAV-104TUH-PERAV-134TUH-PERAV-164TUH-PE
AllAllAllAll
RAV-104TUH-PERAV-134/164TUH-PE
AllAllAllAll
213
215
205
221
220
219
222
201
217
203
207206
204
208
209
210
212
202
218
216
214
214
211
214
Indoor UnitRAV-104TUH-PERAV-134TUH-PERAV-164TUH-PE
7.6
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
71
7. EXPLODED VIEWS AND PARTS LISTS
Indoor UnitRAV-164UH-PERAV-264UH-PE 201
RefNo. Part No. Description Model
201 43A70005 All 202 43A44033 RAV-164UH-PE202 43A44034 RAV-264UH-PE203 43A70006 All204 43A51002 All205 43A21018 All206 43A11004 All207 43A20001 All208 43A72006 All209 43A22003 All210 43A19004 All211 43A58004 All212 43A69010 All213 43A50007 All214 43A50005 All215 43A60001 All216 43A60002 All217 43A60011 All218 43155100 RAV-164UH-PE218 43A55002 RAV-264UH-PE219 43097166 All220 43A97002 All221 43A72008 All222 43107215 All223 43A88011 All
Drain Hose AssemblyRefrigeration AssemblyRefrigeration AssemblyDrain PumpFloat SwitchFan MotorRubber InsulationCentrifugal FanDrain Pan AssemblyBellmouthFan GuardTransformer (AI)PC Board (AI)Sensor - Heat Exchanger (TC)Sensor - Room Temp. (TA)Terminal 123Terminal ABCTerminal X,YMF CapacitorMF CapacitorWasherFan WasherPlugSensor HolderOwnerÕs Manual
203
204
202
207
219220
216217215
212
211
213218
214221
210
209
208
222
206
205
223
Indoor UnitRAV-164UH-PERAV-264UH-PE
7.7
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
72
7. EXPLODED VIEWS AND PARTS LISTS
221
216217215
212
211
214
213
210
209
208
220
219
207
205
206
Indoor UnitRAV-364UH-PERAV464UH-PE
201
203
204
223
222
202
RefNo. Part No. Description Model
201 43A70005 RAV-364/464UH-PE202 43A44035 RAV-364UH-PE202 43A44036 RAV-464UH-PE203 43A70006 RAV-364/464UH-PE204 43A51002 RAV-364/464UH-PE205 43A21019 RAV-364/464UH-PE206 43A11005 RAV-364/464UH-PE207 43A20002 RAV-364/464UH-PE208 43A72007 RAV-364/464UH-PE209 43A22004 RAV-364/464UH-PE210 43A19005 RAV-364/464UH-PE211 43A58004 RAV-364/464UH-PE212 43A69010 RAV-364/464UH-PE213 43A50007 RAV-364/464UH-PE214 43A50005 RAV-364/464UH-PE215 43A60001 RAV-364/464UH-PE216 43A60002 RAV-364/464UH-PE217 43A60011 RAV-364/464UH-PE218 43155138 RAV-364UH-PE218 43155120 RAV-464UH-PE219 43097166 RAV-364/464UH-PE220 43A97002 RAV-364/464UH-PE221 43A72008 RAV-364/464UH-PE222 43107215 RAV-364/464UH-PE223 43A88011 RAV-364/464UH-PE
Drain Hose AssemblyRefrigeration AssemblyRefrigeration AssemblyDrain PumpFloat SwitchFan MotorRubber InsulationCentrifugal FanDrain Pan AssemblyBellmouthFan GuardTransformer (AI)PC Board (AI)Sensor - Heat ExchangerSensor - Room Temp.Terminal 123Terminal ABCTerminal X,YMF CapacitorMF CapacitorWasherFan WasherPlugSensor HolderOwnerÕs Manual
218
Indoor UnitRAV-364UH-PERAV-464UH-PE
7.8
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
73
7. EXPLODED VIEWS AND PARTS LISTS
RefNo. Part No. Description Model Ref
No. Part No. Description Model
Outdoor UnitRAV-134AH-PERAV-164AH-PERAV-264AH-PERAV-264AH8-PE
13
21
4512307
229
11
10
18
15
39
29
23
525
248
40
16
19
14
32
136
17
32
1 2 2 3 3 4 5 6 7 8 91010101112121314151617181919202121222323
Propeller FanFan MotorFan MotorCondenserCondenserBase Spring, BBase Spring, ASpring BufferPC BoardHigh Pressure SwitchTerminal Block, 4PTerminal Block, 2PTerminal Block, 2PTerminal Block, 4PTerminal Block, 4PMagnetic ContactorMagnetic ContactorFan GuardHangerSolenoid CoilCover, Electrical PartsSensor HolderCord ClampAccumulatorAccumulatorDryerMF Capacitor Ð CompressorMF Capacitor Ð CompressorMF Capacitor Ð FanComp Ð PG330X3F-4LSComp Ð PG350X3F-4LS
4312015643A2100343A2100243A4301643A4301743049132431492124314919843A6901143A490014306047943A6000343A6000443A6000543A60001431523344315234543A190014311936843A46004431620274310721543A63001431481054314811443A4500443155115430553794315508043A4150643A41507
AllRAV-134/164AH-PERAV-264AH/AH8-PERAV-134/164AH-PERAV-264/AH/AH8-PE
AllAllAllAllAllAll
RAV-134/164AH-PERAV-264AH-PE
RAV-264AH8-PEAll
RAV-134/164/264AH-PERAV-264AH8-PE
AllAllAllAllAllAll
RAV-134/164AH-PERAV-264AH/AH8-PE
AllRAV-134/164AH-PE
RAV-264AH-PEAll
RAV-134AH-PERAV-164AH-PE
23232424252526272728293031323334353637383940404142424343444445
Comp Ð PG460X3F-4MSComp Ð YG460X3F-MSPacked Valve (6.35mm)Packed Valve (9.5mm)Packed Valve (12.7mm)Packed Valve (15.9mm)Check jointExpansion ValveExpansion ValveCoil, 2-Way ValveCheck ValveTransformer Power2-Way ValveSensor Ð Heat Exchanger (TL)Sensor Ð Heat Exchanger (TC)SpringHeater, CrankcaseThermostat, Bi-metalThermostat, Bi-metal (comp)Fuse T5A4-Way ValveCapi FormCapi FormASM Roof PlateASM Side CabinetASM Side CabinetASM Air-Out CabinetASM Air-Out CabinetFin-GuardFin-GuardReverse Phase Protector
43A4150843A4150943A4601343146415431464064314641743A4601543A4601443A4601743A460164314628343A580034304615143A5000143A190014319306343157167431501224305027743A600064314641843A4703743A4703643A9101643A9101943A9102243A9101743A9101843A9102343A9102443154148
RAV-264AH-PERAV-264AH8-PE
RAV-134/164AH-PERAV-264AH/AH8-PERAV-134/164AH-PERAV-264AH/AH8-PE
AllRAV-134/164AH-PERAV-264AH/AH8-PE
AllAllAllAllAllAllAllAllAll
RAV-264AH8-PEAllAll
RAV-134/164AH-PERAV-264AH/AH8-PE
AllRAV-134/164AH-PERAV-264AH/AH8-PERAV-134/164AH-PERAV-264AH/AH8-PERAV-134/164AH-PERAV-264AH/AH8-PE
RAV-264AH8-PE
41
3833
35
6
4
27
20
2631
28
3734
42
44
43
Outdoor UnitRAV-134AH-PERAV-164AH-PERAV-264AH-PERAV-264AH8-PE
7.9
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
74
7. EXPLODED VIEWS AND PARTS LISTS
4
21
19
20
32
24
33 27
3
1
8
38
23
35
20 4306047921 43A6000522 43A6000123 4310721524 43A5300425 4315019626 43A5000127 43A6901128 43A4600429 43A4900130 4315716731 43A4703231 43A4703332 43A5800333 4315414834 4315026135 4306321936 43A6000637 43A9102738 43A9103738 43A9102939 43A9102840 43A9103640 43A9103141 43A91030
5
31
1610
9
29
28
15
39
14
3426
2
18
36
37
6
13
7
11
17
22
25
40
41
12
30
Outdoor UnitRAV-364AH8-PERAV-464AH8-PE
1 43A21002 2 43A21003 3 43120156 4 43A19001 5 43A43012 5 43A43014 6 43A43013 6 43A43015 7 43119368 8 43162027 9 43A41503 9 43A4150210 43A4200111 43A4600811 43A4600912 4314641513 4314641614 4314732115 4314649915 4314649816 4314628317 43A4500117 43A4500218 4314811418 4314810519 43155080
AllAllAllAll
RAV-464AH8-PERAV-364AH8-PERAV-464AH8-PERAV-364AH8-PE
AllAll
RAV-464AH8-PERAV-364AH8-PE
AllRAV-464AH8-PERAV-364AH8-PE
AllAllAll
RAV-464AH8-PERAV-364AH8-PE
AllRAV-464AH8-PERAV-364AH8-PERAV-464AH8-PERAV-364AH8-PE
All
Terminal Block, 4PTerminal, 4PTerminal, 4PSensor HolderMagnetic Contactor, FC-2SSensor, Heat Exchanger TE
Sensor (Cond Out), TL
PC Board, AH-803Solenoid Coil, CHV-AC240VHigh Pressure Switch, ACB-2TB04WCrankcase Heater, AC240V, 28WCapillary AssemblyCapillary AssemblyPower Transformer, FT67Reverse Phase Protector, STR-4ADSensor (Delivery Pipe), TD
Sensor Holder, TD
Fuse T5AASM Roof PlateASM Side CabiASM Side CabiAir Out CabiFin Guard Ð BackFin Guard Ð BackFin Guard Ð Side
AllAllAllAllAllAllAllAllAllAllAll
RAV-464AH8-PERAV-364AH8-PE
AllAllAllAllAllAll
RAV-464AH8-PERAV-364AH8-PE
AllRAV-464AH8-PERAV-364AH8-PE
All
RefNo. Part No. Description Model Ref
No. Part No. Description Model
Fan Motor AC230V, 50Hz 63WFan Motor AC230V, 50Hz 39WPropeller FanFan GuardCondenser LowerCondenser LowerCondenser UpperCondenser UpperHanger, PlasticCover, Electrical PartsCompressor, ZR61KCE-TFD-230Compressor,ZR49KCE-TFD-230Compressor BootExpansion Valve, BGX-2330 3.65DPSExpansion Valve, BGX-2330 3.5DPSPacked Valve, (9.5mm)Packed Valve, (19mm)Check Joint4-Way-Valve, CHV-04014-Way-Valve, CHV-0301Check Valve, YCV5-3S-TFDryer, XH10Dryer, XH10Accumulator, 2.5LtrAccumulator, 1.6LtrCapacitor, Plastic Film, 4.0mF, 400V
Outdoor UnitRAV-364AH8-PERAV-464AH8-PE
7.10
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
75
7. EXPLODED VIEWS AND PARTS LISTS
Ceiling PanelRBC-U133PG(W)-PE
10
8
10
7
2
5
4
7
6
9
1
3
Grille-L-RSupport plateASM-Grille-OutASM-MotorSupport plate
6789
10
43009503430071244300949943A2600143007125
RefNo. Part No. DescriptionRef
No. Part No. Description
FilterPlate connect (long)ASM-Grille-OutBushingPlate connect (short)
12345
4308039243007108430095044300710743007109
Ceiling PanelRBC-U133PG(W)-PE
7.11
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
76
7. EXPLODED VIEWS AND PARTS LISTS
RefNo. Part No. Description Model
PanelPanel (Remote)Grille CatchJoint KitCamMotor Kit AssemblyLouver-(Small)Grille Ð Air InletCushion Air Outlet BCushion Air Outlet CCushion Air Outlet DGeared MotorCord, Remote ControllerInfra-Red Receiver - (AI)Air Filter
1124567911121314151617
4340065843400001434070724340708543407091431072494340911043A09009434110074341100843411009431216714346053243A6901241480545
1112
12
4
6
5149
1
13
7
16
Ceiling PanelRBC-U264PG(W)-ERBC-U264PGR(W)-E
15
2
17
RBC-U264PG(W)-ERBC-U264PGR(W)-E
AllAllAllAllAllAllAllAllAllAll
RBC-U264PGR(W)-ERBC-U264PGR(W)-E
All
Ceiling PanelRBC-U264PG(W)-ERBC-U264PGR(W)-E
7.12
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
77
7. EXPLODED VIEWS AND PARTS LISTS
Ceiling PanelRBC-U464PG(W)-ERBC-U464PGR(W)-E 11
10
13
4
6
5
14
3
1
10
7
168
15
2
9
17
RefNo. Part No. Description Model
PanelPanel (Remote)Grille CatchGrille, Louvre MJoint KitCamMotor Kit AssemblyLouver Ð (Small)Louver Ð (Large)Grille Air InletCushion Air Outlet ACushion Air Outlet BCushion Air Outlet DGeared MotorCord, Remote ControllerInfra Red ReceiverAir Filter
1 1 2 3 4 5 6 7 8 910111314151617
43400662434000034340707243407076434070854340209143107249434091104340911443A09010434110064341100743411009431216714346053243A6901241480546
RBC-U464PG(W)-ERBC-U464PGR(W)-E
AllAllAllAllAllAllAllAllAllAllAllAll
RBC-U464PGR(W)-ERBC-U464PGR(W)-E
All
Ceiling PanelRBC-U464PG(W)-ERBC-U464PGR(W)-E
7.13
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
78
Notes
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
79
Notes
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
TOSHIBA AIR CONDITIONING
PORSHAM CLOSE, BELLIVER INDUSTRIAL ESTATE, PLYMOUTH PL6 7DB UK
A division of Toshiba Carrier UK Ltd
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807