aoco cultivars - juser.fz-juelich.de
TRANSCRIPT
ho s for thentifi ion of
aoco Cultivars
Dr. Peter RangeLandesanstalt fOr Pflanzenbau Forchheim
Chern. Ing. Savvas DivanidisTobacco Institute of Greece
Forschungszentrum JOlich GmbHScientific Series of the International Bureau
GREEK AND GERMANTOBACCO VARIETIES
Chemical Methods for theIdentification ofTobacco Cultivars
Dr. Peter RangeLandesanstalt fOr Pflanzenbau Forchheim
Chem. Ing. Savvas DivanidisTobacco Institute of Greece
German-Greek-Cooperationin Scientific Research and Technological Development
Die Deutsche Bibliotl1ek - CIP - Einl1eitsaufnal1me
Greek and German tobacco varieties: chemical methods for the identification oftobacco cultivars : German Greek cooperation in scientific research and tecl1nologicaldevelopment / Forscl1ungszentrum Julicl1 GmbH. Peter Range; Sawas Divanidis. Jullch : Forscl1ungszentrum, Zentralbibliotl1ek, 1995(Scientific series of tile International Bureau / Forscl1ungszentrum JOIicl1 GmbH; Vol.28)ISBN 3-89336-145-6NE: Range, Peter:; Forschungszentrum <Julich~ Ilnternationales BOro: Scientific series of ..,
Herausgeberund Vertrieb:
Druck:
Copyright:
Forschungszentrum JOlich GmbHZENTRALBIBLIOTHEK0·52425 JOlichTelefon (02461) 61·5368· Telefax (02461) 61·61 03
Graphische Kunstanstalt Dieter Gehler, DOren-Birkesdorf
Forschungszentrum JOlich 1995
Scientific Series of the International Bureau, Volume 28
ISSN 0938·7676
ISBN 3·89336·145-6
TABLE of contents Page
Preface 7
Abstract 8
1 Introduction 9
2 Tobacco Plantation 102.1 Soil and Growing Conditions 102.1.1 Flue Cured Tobacco 112.1.2 Oriental Tobacco 122.1.3 Burley Tobacco . 122.2 Plantation Areas in Greece 122.2.1 Thessaloniki-Soxos and Karditza-Mitropoli 132.2.2 Thessaloniki-Plati 142.2.3 Komotini and Kozani-Chirolimni 142.2.4 Katerini-Vrias/N.Efessos 152.2.5 Agrinion-Sfina 16
3 Tobacco Quality 173.1 Outer and Inner Quality 173.2 Regulations of the European Union 183.3 Methods 183.3.1 Nitrate 193.3.2 Carbon Monoxide 193.3.3 Nitrogen Oxides 19
4 Greek Tobacco Breeding Lines 224.1 Breeding Line 5/R 224.2 Breeding Line 4N 254.3 Breeding Line 1IB 284.4 Breeding Line 2/K 314.5 Breeding Line 3/S 314.6 Discussing the Results 31
5. German Tobacco Cultivars 345.1 Geudertheimer 345.2 Burley 355.3 The Effects of Nitrogen-Fertilization 375.3.1 Condensate 375.3.2 Nicotine 395.3.3 Carbon Monoxide 405.3.4 Nitric Oxide 415.3.5 Nitrate 435.3.6 Nicotine and Nornicotine 435.4 Discussing the Results 436 Tobacco Breeding 446.1 Identification of Tobacco Varieties 456.2 Secondary Plant Compounds of Content 456.3 Isoenzymes and Alloenzymes 456.4 Methods 466.4.1 Protein Extraction Procedures 466.4.2 Electrophoresis Procedure 47
5
6.4.3 Isoelectric Focusing Procedure 486.4.4 Protein and Enzyme Staining Techniques 486.4.5 Documentation 496.5 Results and Discussion 506.5.1 Tobacco Seed 506.5.2 Green Leaf : 516.5.3 Dry Tobacco 52
7 Conclusion 53
EXPERIMENTAL 57
8 Nitric Oxide Analysis 578.1 BAT Nitric Oxide Analyzer in Combination with Smoking Machine Filtrona
SM 302 578.1.1 Additional Equipment required 578.1.2 Setting Up and Calibration Instructions 578.1.3 Smoking Procedure 588.2 Monitor Labs. Nitrogen Oxides Analyzer 8440E in Combination with Smoking
Machine Borgwaldt RM 20 CS and Automatically Working Nitrogen FlushingUnit 59
8.2.1 Additional Equipment required 598.2.2 Setting Up and Calibration 608.2.3 Smoking Procedure 60
9 Electrophoresis 619.1 Protein and Enzyme Extraction 619.1.1 Equipment 619.1.2 Buffers 629.1.3 Reagents 629.1.4 Staining Salts 629.1.5 Sample Preparation 629.1.6 Cleaning Procedure for the Dialysis Tube 649.1.7 Rapid Determination of the Protein Concentration 649.2 Vertical Polyacrylamide Slab Gel Electrophoresis 659.2.1 Equipment 659.2.2 Buffers 669.2.3 Reagents 669.2.4 Staining Salts 669.2.5 Stock Solutions 669.2.6 Simple Gels 689.2.7 SDS-Gradient Gels 699.2.8 Application of Samples 719.2.9 Operating the Electrophoresis 719.2.10 Removing the Gels 719.3 Isoelectric Focusing 729.3.1 Agarose Gels 729.3.2 Preparation of Solutions 729.3.3 Sample Preparation 739.3.4 Operating the Isoelectric Focusing 739.3.5 Staining of Samples 749.4 Protein and Enzyme Staining Procedures 759.4.1 Unspecific staining of proteins 759.4.2 Rapid Staining for Native Gels and IEF-Gels 76
6
9.4.3 Silver Staining 769.4.4. Destaining and Drying of Polyacrylamide Slab Gels 779.4.5 Specific Staining of Enzymes 779.5 Enzyme Staining Procedures of Agarose Gels 789.5.1 Chemicals 789.5.2 Preparation of Enzyme Buffers 789.5.3 Transfer Membrane Preparation Solutions : 799.5.4 Stain Solutions 799.5.5 Enzyme Staining 80
10 Summary 81
BIBLIOGRAPHy 83
7
Preface
In the framework of the German-Greek co-operation in Science and Technology, a projectwas implemented by the Landesanstalt fur Pflanzenbau Forchheim, Rheinstetten and theTobacco Institute of Greece, Drama, directed to the plantation control of tobacco varietiesin the Common Market, to the development of methods for the determination of nitric oxidein tobacco smoke and to the improvement of identification procedures for tobacco varieties in seed, green and dried leaves and in tobacco powder.
Joint work also comprised the plantation of tobacco varieties at five tobacco stations in thenorthern and middle part of Greece, having different soil and climate conditions.
Preliminary results have been presented at the 29th Workshop of the Technical Committeefor Tobacco Plantation of the Federal Association ofthe German Tobacco Farmers, Bruchsal-Buchenau, Germany, 1989, at the XXXII. Tobacco-Colloquy, in Toulouse, France, 1990,at the Coresta Symposium, Kallithea (Halkidiki), Greece, 1990 and at the 1st German-GreekWorkshop on Environmental Engineering in Oberpfaffenhofen, 1991.
The authors wish to express their gratitude to Dr. P. Schweiger, Director of the Landesanstalt fur Pflanzenbau Forchheim, to Prof. A. G. Sficas, Department of Agriculture, Universityof Thessaloniki and to Mr. Mour Paschal ides, the former Directors of the Tobacco Instituteof Greece, for their helpful discussions and their kindness, to Prof. R. Preussmann, Instituteof Toxicology and Chemotherapy, German Cancer Research Center, Heidelberg, for thekind help in measuring the nitrosamines, to Mr. H. Drescher and Mr. U. Krohn from H. Borgwaldt, Hamburg, to Mr. K. RUdy, Mr. Weindl, Mr. A. Zangenberg, Mr. H. P. Eismann and Mr.E. Aichele, from Kontron Elektronik, Eching - MOnchen, for their support and helpful discussions during the development of the nitric oxide method for tobacco smoke, to Prof. K.Wegmann, Institute of Chemical Plantphysiology, University of TObingen, to Dr. H. Delinceeand Mrs. Sigrid Delincee, Institute of Biochemistry, Federal Agency of Food (BFE), Karlsruhe, and to Mrs. Maria MOiler from Desaga, Heidelberg, for their support and helpful discussions during the development of the electrophoretic methods for the tobacco proteindetermination. The authors are deeply indebted to Mrs. Maria MOiler for reading the electrophoresis chapters and offering valuable comments, also to Mrs. Litsa Divanidis for thetranslation of several chapters and reading the report.
Acknowledgments are gratefully extended, to Dr.Andrea Schumacher and to Dr. N. Billenkamp, Breeders of the Landesanstalt fur Pflanzenbau Forchheim, in carrying out the plantation and selection of the tobacco varieties, to Mr. Sp. Halivopoulos and Mrs. Vasiliki Tsakmaki, Chemists of the Tobacco Institute of Greece, for their valuable assistance in carryingout this project, to Mrs. Elisabeth Fischer, in carrying out the electrophoretic and thin layerisoelectric focusing separation of tobacco proteins, and to Mr. P. Kappler and P. Klein, incarrying out the tobacco and tobacco smoke analysis, the nitric oxide calculations and thedata processing, Chemistry Technicians of the Landesanstalt fur Pflanzenbau Forchheim,and to Mr. B. Turkochorlis and to Mr. D. Hatzigeorgiou, Chemistry Assistants of the Tobacco Institute of Greece, in carrying out the tobacco and tobacco smoke analysis and thedata processing and last to Mr. U. Ziegler, agronomist of the Landesanstalt fOrPflanzenbauForchheim, who showed us the possibilities to work with different standard graphic programs to create our graphs.
The authors feel deeply indebted for the equipment support and the grants of the FederalMinistry for Research and Technology, Bonn, and the grants of the Ministry of Industry,Energy and Technology, Athens.
9
Abstract
Seventeen German and five Greek cultivars from the harvest 1987 and 25 German Geudertheimer cultivars, - new breeding lines and common types from Oriental-, Clqar-, Burleyand Virgintobacco -, from the harvest 1990 were analyzed according to nitrogen fertilization for the leaf constituents nitrate, alkaloids, sugar, and nitrogen, for the smoke constituents condensate, nicotine, carbon monoxide and nitric oxide: The limitation to 15 mgcondensate per cigarette, asked by the European Commission for 1993, could only be fulfilled with the lower stalk positions of the cultivars. Nicotine was changing according to thetobacco types. Carbon monoxide was found in a middle range equal for all types. Nitricoxide was changing according to the nitrogen fertilization and the cultivars. A corresponding increase of the nitric oxide percentage in the tobacco smoke was observed in varietiesneeding more nitrate fertilizer. Nitrate, nicotine and the sum of nornicotine and myosmine inthe leaf correlated with cultivar, climate and fertilization. The nitrosamines in the tobaccoleaf and the tobacco smoke varied with the nitrate content in the cultivars, the harvestingand curing conditions.
Cigarettes, made of tobacco leaves and containing small amounts of nitrate, generatedless nitric oxide than cigarettes made of tips, which contained more nitrate.
Twenty-five breeding lines of dark air cured tobacco from the harvest 1990 were identifiedwith Polyacrylamide Gel Electrophoresis.
10
1 Introduction
Irakllon~"'·
n I k I
II Na Ii 0 n
..
..Arta
Picture 1: Tobacco Plantation Areas in Greece
In Greece tobacco is in the first rank of the national income; the main plantation areas areplotted in picture 1.
In Germany tobacco belongs to the special-purpose crops1-6); the main plantation areasare plotted in picture 2.
In Baden-Wurtternberq for example with its small family farms, 1987 2.5% of the area wascultivated with these crops, but the profit amounted to 73% of all crops/!
The cultivation of tobacco in the EU is restricted to regions with well-defined cultivars andcertain yields. According to the region, cultivar and classification, the tobacco farmers geta premium of more than50% of the tobacco pricefrom the EU. The premiumsfor the cultivars are paid according to the regional plantation conditions.
In the Common Market 1988the situation for the Greektobacco farmers was characterized by only a littlechance of selling the localdark varieties especially ofthe Agrinion area. The German tobacco farmers hadalso problems, caused byan Italian overproduction oftheir Geudertheimer varieties in South Italy.
In the year 1989, there was aseparation of the Geudertheimer plantation areas inan area "GeudertheimerNorth" in Germany and anew area "GeudertheimerSouth" in Italy. Before 1989it was attractive to thefarmers in southern regionsof Italy to plant GermanGeudertheimer varieties toget the high premium. Thispremium was much higherthan the premium for theown regional tobacco cultlvars. In consequence toomuch Geudertheimer tobacco of bad quality wasproduced, which couldn'tbe sold and had to bebought at the intervention price from the Common Market. Consequently, for the followingyear the EU authorities reduced the plantation area of the Geudertheimer cultivars. Thisarea restriction was made at the German farmers' expense.
11
II Dresden
Berlin
III
NCirnb'fQ
IIIStuttgart
IIIBremen
IIIacnn
On the other hand all tobacco producing countriesof the EU were asked by theEU Commission to lower thehazardous compounds, especially the tar content. According to the directive "Europe against Cancer" the taryield of all cigarettes marketed in the European Unionshould not be greater than15 mg beyond 1993 and notgreater than 12 mg beyond1998. Therefore, all high tarproducing tobacco cultivarswould have no chance ofselling in the Common Market after this date. ForGreece there is an exceptiontill the year 2006.
For the produce control it isnecessary to develop newbreeding lines with low tarcontent and low contents ofcarbon monoxide and nitrogen oxides, and it isnecessary to develop newlaboratory methods, too, todifferentiate between the tobacco cultivars.
Picture 2: Tobacco Plantation Areas in Germany There is a special interest forGreece and Germany and forthe other tobacco producing
countries, too, in developing identification methods to detect whether the offered tobaccoin the Common Market is from the declared plantation area or not. This has to be done witha "cultlvar card" characterizing the tobacco according to its outer and inner quality and ananalytical description of the tobacco cultivar too.
2 Tobacco PlantationGreek and German tobacco planters look for new fields for the plantation of flue cured tobacco. Planting tobacco, it is necessary to understand how the manifestation of soil characteristics is influenced by the environment. In potential new growing areas"" this can complicate the problem and possibly mislead the choice of soils for early trials?'.
2.1 Soil and Growing Conditions
Reasonable moisture-holdin~ capacity and free drainage, pH-, organic matter- and salinity-values (see table Nr. 1)9-1 ), as the contents of nitrogen, phosphorous, potassium, calcium, magnesium, manganese and chlorine, are the only basic requirements needed inchoosing suitable soils (see tables Nr. 2 and 3).
12
Table 1: Recommended pH-, Electric Conductivity-, and Organic Matter-Values for SoilSamples from Fields for Tobacco Plantation
Electric OrganicpH Conductivity Matter
mS/cm %C
sand, loamy sand 5,3 - 6,0 < 0,75 1-4
sandy loam 6,1 - 6,7 < 0,75 1-4
loam 6,8- 7,2 < 0,75 1-4
Table 2: Recommended P-, K- and Mg-values for soil Samples from Fields for TobaccoPlantation
P K Mgmg/kg mg/kg mg/kg
light soils 92 -109 108 -166 42 - 60
medium soils 92 -109 174 - 249 78 -120
strong soils 92 -109 257 - 291 90 -150
Table 3: Recommended Mn- Values for Soil Samples from Fields for Tobacco Plantation
Active Mn mg/kg
pH < 6,0 ph 6,0 - 6,5 ph> 6,0
low <3 < 5 < 7
medium 3-4 5 -10 7 -14
high >4 >10 >14
According to the type of tobacco and the part of the growing season the plant uptake of nutrition elements is different. Nitrogen uptake for virgin cultivars for instance must be low ornonexistent in the latter part of the growing season. On the opposite acceptable growth,yield and quality are not obtained without adequate nitrogen nutrition during early growth.Similar conditions are found for oriental tobaccos, while Burley cultivars need four timesmore nitrogen during the growing season.
2.1.1 Flue Cured Tobacco
Flue-cured tobacco is a low-nitrogen product. In an open soil, tobacco roots have beenfound at a depth of 120 em, so concern is not only with the topsoil. Subsoil will much influence the moisture status, according to whether its permeability is excessive or very restricted. Not so obvious is the subsoil potentiality for releasing nitrogen towards the end ofthe season. Increasing fineness of texture and increasing redness of color are indications ofsuch a possibility. Color is a more certain guide than texture.
The basic requirements will obviously be met by medium-coarse sands or sandy loams onthe surface, underlain by fine sandy loam or sandy clay, which extends to a depth of 120 150 em. The pH-values will normally be in the range 5.5 - 5.6.
13
The typical flue-cured soils are light-colored sandy loams and fine sandy loams, 15 - 25 cmdeep, with yellowish or reddish sandy clay subsoil. They will have greater latitude in absorbing variations of the climate and giving a reasonable return from a range of weatherconditions-which, of course, is why they are considered particularly suitable. Growing fluecured tobacco on a light, well-drained soil provided care has been taken in making up thefertilizer dressing, the optimum cultural treatments can be used to extract the maximumpossible crop from the environment in the reasonable expectation that as yield increasesso will the degree of usability8).
2.1.2 Oriental Tobacco
The finest, most gentle, feminine, classical tobaccos are all Yakas (upland). Soils in thefoothills, in semi-arid climates with heavy winter storms, are likely to be eroded and thereforthin and low in nitrogen reserves. These conditions combined with the rest of environmentgive the products. The soil consists of stony, sandy, calcareous clays of grey to reddishcolor. Soil depth is limited, over a calcareous subsoil, and organic matter is low. Converselythe Ova (plain) are richer, deeper soils, which have received some deposit from the moreupland areas. The greater fertility, higher organic matter content and better water-holdingcapacity produce the somewhat rougher more masculine tobaccos which are the Ovas,and entirely acceptable as such. If one gets right down to the very deep alluvial floodplains, growth is stronger and questions of quality acceptability become more doubtful.However the greater productivity makes these areas more attractive to farmers8).
2.1.3 Burley Tobacco
It is the typical tobacco of the deep fertile open soils.Reddish-brown silt loams of limestone origin with subsoils of well-structured silty clayscomplete a picture of fertility, excellent drainage and good aeration. Good water holdingcapacity to maintain growth through periods of erratic rainfall. Other brown or yellowbrown soils of limestone origin are very usable but often need more fertilizer. Heavier loamshave all the necessary attributes of depth, fertility and open texture'".
2.2 Plantation Areas in Greece
Greece is a country well known for his famous oriental tobaccos and is predominantlysuited for this type of tobacco. It has mountain soils of the lithosolic group occurring as"rock soils" on the slopes or near the base of mountains. The surface layers are thin or shallow, are very stony throughout, are underlain with rock, and are of low productivity.
There is an extensive zone of forest soils, - from which the forests have been largely removed -, which have been derived from the disintegration of granitic and limestone parentrocks. The A horizon is feebly developed, and the B horizon is underlain with parent material of white chalk. The soil was named "Terra Rossa" according to its red color due to thecontent of ferric hydroxide.
The soils of the Macedonian and Thracian area on which the best quality of oriental tobacco is being grown are upland forest soils, designated brown podsols, red and yellowpodsols, and Mediterranean dry forest soils. These podsolic soils generally light texturedand of low to medium productivity. The brown soils are high in calcium carbonate, granular,dark brown to reddish brown in color, shallow and of medium productivity. The red and yellow podsols have a grayish surface layer but the clay subsoils are red or yellowish. They areacid, low to medium in organic matter and productivity, and of good soil structure. The soilof the dry Mediterranean group range from very sandy to clay, and are alkaline to slightlyacid. Some of them are developed from limestone, and all are shallow and low in humus.
14
Others have arisen from non-limestone parent material and have a reddish brown B horizon11). The more fertile ova and plains soils provide suitable burley soils, given avoidanceof tight pockets with poor drainage8),
The inland areas of Macedonia, Thessaly and Thrace are transitional between Mediterranean and the continental climates. Spring is wetter and the dry season is largely confinedto July and August though rainfalls up to 25 mm are not uncommon eyen in those months8).For some areas irrigation is necessary.
To find out, if a field fits for the tobacco plantation or shows possible nutrition deficiencies,soil samples must be taken. One hundred and eight soil samples were taken in the autumn1990 and in the spring 1991 from five experimental tobacco fields in the northern andmiddle part of Greece. They were analyzed for pH-, salinity- (expressed as Electrical Conductivity in mS/cm) and organic matter-value. They were analyzed for the content of nitrogen, of phosphorous, of potassium, of magnesium, of manganese and of chlorine, too.
2.2.1 Thessaloniki-Soxos and Karditza-Mltropoll
Fields for the Virgin tobacco plantation in the areas Thessaloniki-Soxos and Karditza-Mitropoli are found. The soil samples from Thessaloniki-Soxos show low to acceptable pH-,low organic matter-values, a low salinity (expressed as Electrical Conductivity in mS/cm),low phosphorous-, low to high potassium-, very high magnesium-, high manganese- andlow chlorine-contents (see table Nr. 4); the soil samples from fields of Karditza-Mitropolishowed high pH-, low organic matter-values, a low salinity (expressed as Electrical Conductivity in mS/cm), low phosphorous-, low potasslum-, very high magnesium- and lowchlorine-contents (see table Nr. 5).
Table 4: Chemical Analysis of Soil Samples from Fields for Virgin Tobacco Plantation,Thessaloniki - Soxos 1991
Organic ElectricMatter Conduct. P K Ca Mg Mn CI
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg
5,3 1,04 0,12 28 50 1840 270 27 4,7
5,1 1,38 0,09 18 50 1500 250 22 4,7
4,9 1,00 0,13 24 100 1350 190 27 4,7
5,6 1,35 0,10 28 230 2500 306 29 7,1
5,6 1,49 0,20 28 203 1430 145 57 7,1
Table 5: Chemical Analysis of Soil Samples from Fields for Virgin Tobacco Plantation,Karditza - Mitropoli 1991
Organic ElectricMatter Conduct. P K Ca Mg CI
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg
7,7 1,17 0,16 16 47 3480 320 2,4
7,1 1,73 0,26 36 80 3080 398 16,6
5,1 1,15 0,12 18 50 1310 545 4,7
7,5 1,37 0,15 10 50 9000 462 2,4
15
Organic ElectricMatter Conduct. P K Ca Mg CI
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg
6,4 1,26 0,15 22 47 2310 852 2,45,5 1,28 0,10 26 63 1610 697 7,17,6 1,55 0,12 32 60 9250 264 2,4
7,6 1,53 0,15 18 47 13000 150 2,46,6 1,31 0,11 16 50 2800 895 7,1
2.2.2 Thessaloniki-Plati
Fields for the Burley tobacco plantation in the area Thessaloniki-Plati are found. The soilsamples show acceptable pH-, low to medium organic matter-values, a low salinity (expressed as Electrical Conductivity in mS/cm), low phosphorous-, medium to very high potassium-, high magnesium- and low chlorine-contents (see table Nr. 6).
Table 6: Chemical Analysis of Soil Samples from Fields for Burley Tobacco Plantation,Thessaloniki - PIaU 1991
Organic ElectricMatter Conduct. P K Ca Mg Mn
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg
8,0 1,37 0,15 7 205 12500 360 7,18,0 1,27 0,20 10 220 13000 310 14,78,4 1,05 0,24 8 145 13125 397 11,8
7,0 1,82 0,15 11 300 13000 360 7,1
7,8 1,85 0,16 10 345 13000 410 7,17,9 1,75 0,17 9 340 12250 435 4,77,8 2,30 0,16 6 540 12250 537 2,4
2.2.3 Komotini and Kozani-Chirolimni
The soil samples from fields for the Oriental tobacco plantation of Komotini and KozaniChirolimni show acceptable to high pH-, low to medium organic matter-values, a lowsalinity (expressed as Electrical Conductivity in mS/cm), low phosphorous-, medium tohigh potassium-, very high magnesium-, high manganese- and low chlorine-contents (seetables Nr. 7 and 8).
Table 7: Chemical Analysis from Soil Samples from Fields for Oriental Tobacco Plantation,Komotini 1991
Organic ElectricMatter Conduct. P K Ca Mg Mn Cl
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg
5,2 1,91 0,15 14 237 2730 612 53 14,2
5,6 2,04 0,11 22 283 2510 565 41 14,2
16
Organic ElectricMatter Conduct. P K Ca Mg Mn CI
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg
7,2 1,98 0,20 26 367 3075 243 59 7,1
6,9 1,90 0,20 14 307 4080 260 44 4,7
5,4 1,85 0,09 28 330 2650 424 46 9,5
5,1 1,60 0,12 22 190 1850 247 24 4,7
Table 8: Chemical Analysis of Soil Samples from Fields for Oriental Tobacco Plantation,Konzani - Chiromlimni1991
Organic ElectricMatter Conduct. P K Ca Mg CI
pH %C mS/cm mg/kg mg/kg mg/kg mg/kg mg/kg
7,9 2,15 0,17 14 320 14375 477 11,8
7,2 2,39 0,19 9 180 6250 540 7,1
8,0 1,37 0,15 7 205 12500 360 7,1
8,0 1,27 0,20 10 220 13000 310 14,2
8,4 1,05 0,24 8 145 13125 397 11,8
7,8 1,82 0,15 11 300 13000 360 7,1
7,8 1,85 0,16 10 345 13000 410 7,1
7,9 1,75 0,17 9 340 12250 435 4,2
7,8 2,30 0,16 6 540 12250 537 2,4
2.2.4 Katerini-Vrias/N.Efessos
The soil samples from fields for the Oriental and Burley tobacco plantation of KateriniVrias/N.Efessosshow acceptable to high pH-, medium organic matter-values, a low salinity(expressed as Electrical Conductivity in mS/cm), low phosphorous-, low to medium potassium-, medium to high magnesium-, high manganese- and low chlorine-contents (seetable Nr. 9)
Table 9: Chemical Analysis of Soil Samples from Fields for Oriental and Burley TobaccoPlantation, Katerini - Vrias/N. Efessos 1990
OrganicMatter P K Ca Mg Mn CI
pH %C mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg
7,2 1,93 26 163 2290 153 65 4,7
5,5 1,97 26 283 1200 149 61 7,1
4,9 1,95 22 307 870 115 88 7,1
5,7 2,20 22 197 1410 142 63 4,2
7,3 2,16 34 247 2580 146 69 9,5
7,0 2,00 28 260 2010 143 68 7,1
17
OrganicMatter P K Ca Mg Mn CI
pH %C mg/kg mg/kg mg/kg mg/kg mg/kg mg/kg
4,7 2,27 28 160 970 120 70 7,17,3 2,26 40 190 2740 159 60 4,76,6 2,00 22 267 1770 164 59 4,76,4 1,94 22 160 1560 132 39 9,57,4 2,00 34 170 2990 173 53 7,15,5 2,06 22 233 1280 149 64 11,87,0 1,79 22 230 1770 131 53 4,76,0 1,56 22 233 3240 131 57 7,17,5 1,68 32 180 2480 120 91 4,75,1 1,79 49 263 2390 138 83 14,26,1 1,79 24 273 755 95 93 4,77,7 1,93 22 223 1270 114 59 2,47,7 1,83 32 243 3260 152 81 7,17,0 1,83 32 247 1770 126 60 2,4
2.2.5 Agrinion-Sfina
The soil samples from fields for Oriental and Burley tobacco plantation of Agrinion-Sfina,Mg-Trial, 0,20 em, show acceptable to high pl-l-, low to medium potasslurn-, medium tohigh magnesium- and high manganese-contents (see tables Nr. 10 and 11)
Table 10: Chemical Analysis of Soil Samples from Fields for Oriental and Burley TobaccoPlantation, Agrinion - Sfina, Mg-Trial, 0,20 em, 1990
K Ca Mg K Ca MgpH mg/kg mg/kg mg/kg pH mg/kg mg/kg mg/kg
5,9 147 1040 232 7,4 170 3700 202
6,0 153 1380 80 7,5 160 2960 159
5,9 160 1540 306 6,9 173 2460 237
6,4 267 1460 289 7,8 137 4300 201
7,6 193 2760 151 7,7 163 1240 907
5,7 157 1030 116 6,0 130 2360 126
6,4 193 1610 108 7,2 167 2630 138
7,6 200 2280 148 6,8 170 1890 172
5,7 150 1590 290 5,2 153 2800 349
6,4 137 2280 126 6,6 160 3120 146
18
K Ca Mg K Ca MgpH mg/kg mg/kg mg/kg pH mg/kg mg/kg mg/kg
7,0 150 2320 159 7,5 153 3100 163
7,0 153 1970 290 7,6 160 13700 208
Table 11: Chemical Analysis of Soil Samples from Fields for Oriental and Burley TobaccoPlantation, Agrinion - Sfina, 0,20 em, 1990
Ca Mn Ca MnpH mg/kg mg/kg pH mg/kg mg/kg
5,6 1390 21 7,8 5850 59
5,1 940 42 7,2 2900 51
6,1 1820 32 6,4 1950 33
7,2 2150 36 7,7 5675 56
6,6 1490 45 7,2 2460 52
7,6 2850 45 7,3 2500 38
7,0 2300 42 5,5 1210 26
6,9 2070 25 6,0 1520 22
7,0 1990 28 4,7 800 14
7,7 3780 44 7,0 1570 19
5,6 1100 25 6,5 3880 40
6,6 1750 29 6,8 1930 30
7,8 3250 39 7,6 2940 34
7,6 2780 42 7,5 3740 37
3 Tobacco QualityAll tobacco cultlvars, especially the oriental types in Greece, are well fitted to their growingsite and its environment. They are divided in aromatic, taste and neutral tobaccos. Theirquality is influenced by the climate and the soil. Also the cultural practice such as seedlingproduction, fertilization, water requirement and last harvesting, curing and the handling ofthe produce has a great influence to the quality.
3.1 Outer and Inner Quality
Characterizing the tobacco cultivars according to outer and inner quality, the outer qualityis described by the kind, form and appearance of the leaves; sensorial and physicalmethods are used; the inner quality is correlated on one hand with positive tobacco-ownsubstances of value and on the other hand with negative intrinsic and extrinsic compounds, hazardous to smokers and co-smokers. The inner quality itself is subdivided in apositive quality and a negative quality: the positive quality is referring to the simple lnor-
19
ganic and organic elements necessary for the tobacco nutrition, - the so-called micro- andmacroelements -, but also to the more complex organic plant-own compounds essentialfor the smell and taste of tobacco smoke, such as the amount of proteins and sugars or thekind of aromatic compounds; the negative quality implies the hazardous smoke substances and the residues from soil, water and air pollution, from fertilizers and plant protection agents and their metabolites. All these compounds can be found in the leaf or ontheleafsurtace12-1~.
3.2 Regulations of the European Union
The handling and use of the plant protection agents and their metabolites is regulated bynational and international guidelines and laws17), which establish amounts of the toleratedresidues of the plant protection agents and their metabolites. According to the EU directive91/414/EWG the harmonization of national regulations in plant protection matters has totake place18).
For hazardous smoke substances the EU Commission had demanded the limitation ofcondensate to 12 mg per cigarette in 1988. Most of the produced tobaccos didn't fulfill thisdemand. The lower stalk positions only of the cultivars showed a tar content below 15 mgper cigarette. This is the case for Greek and for German cultivars, too. Till 1993 the limitation therefore was raised to 15 mg condensate per cigarette.
By this regulation, certain tobacco cultivars are more seriously affected than others, particularly the local varieties grown and smoked in Greece. The oriental varieties "Tsebelia"and "Mavra" are endangered as will be the dark air-cured Havanna, Badischer Geudertheimer and Paraguay. Many areas in Greece, where dark air-cured tobacco and orientalvarieties are grown, are not at all suited to other cultivars and crops in terms of soil andclimate conditions.
In these regions the cultivation of adopted tobacco cultivars with an acceptable tar/nicotine ratio and diminished carbon monoxide- and nitric oxide-content may only be successful. Especially the aromatic oriental tobacco as it is planted in Greece with its low nicotine and medium sugar content, is valuable, to balance blend cigarettes in taste andaroma. Neutral types improve blends by reducing nicotine content and making cigarettesmilder in taste and of better combustibility.
The cultivars Virgin and Burley are of interest for the Greek and German plantation, Geudertheimer only for the German plantation.
3.3 Methods
Since the early twentieth the chemical examination of tobacco in leaf and smoke is in progress. Many data about nitrogen, nitrate, sugars, alkaloids, condensate, nitric oxide and carbon monoxide for different tobacco varieties have been published. They are reviewed forinstance from A. Wenusch, 1939 and 194013) and T. C. Tso, 1972 and 199016).
Under the interaction aspect is the relationship among nitrate in the tobacco leaves and nitric oxide, and carbon monoxide in the tobacco smoke, and nitrosamines, too, in the leavesand in the smoke is of interest.
Total nitrogen was determined according to the Kjeldahl method19), total sugar accordingto the Schorl method19) and alkaloids according to DIN 10241 or by the gaschromatography method according to DIN ISO 1031520). Nitrosamines were determined in the Institute for Toxicology of the German Cancer Research Center, Heidelberg, by gaschromatography-thermal energy analyzer method (GC-TEAf1-24).
20
Nicotine and condensate (free from water) were determined according to DIN ISO 3402,DIN ISO 3308, DIN ISO 4387, DIN ISO 10315, DIN ISO 10362-1 or ISOTC 126 N 47120), alkaloids in tobacco smoke as nicotine were determined according to DIN ISO 1031520) andcarbon monoxide according to DIN 1024820).
3.3.1 Nitrate
Nitrate was determined by gaschromatography according to the "xylene" method25): afterextraction with water and filtration the nitrate reacts in presence of sulfuric acid with p-xylene to 2-nitro-p-xylene according to the reaction mechanisms shown below:
_ H2S04CH3 - C6H4 - CH3 + N03 > CH3 (N02) - C6H 4 - CH3-H+
3.3.2 Carbon Monoxide
The gas carbon monoxide in the tobacco smoke is measured in a flow cell with an air - tightnondispersive infrared detector (NDIR) after stimulation at the absorption wavelength in theinfrared region in comparison with a reference carbon monoxide sealed inside a separate'cell. The depletion of energy at the absorption wavelength gives rise to a change in thepressure of the detector, causing a small movement of a thin metallic diaphragm, - the oneelectrode of a variable electrical capacitor -, and a capacitance change of the capacitorsolely related to the amount of the energy absorbing sample undergoing measurement andin turn related to the amount of carbon monoxide of the sample.
3.3.3 Nitrogen Oxides
To compare different results in the determinations of the gaseous nitric oxide in tobaccosmoke, it is necessary to check the device of the used nitric oxide analyzers; also it is of interest to understand, how the used smoking machines in combination with the used analyzers are working. Last it is necessary to consider the smoking parameters for the smokingprocedure.
The measurement of the hi~h~ reactive nitric oxide in the gasphase of tobacco smoke hasbeen proved to be difficult 6, ,28).
The cigarette manufacturers in Germany and Greece mainly use the BAT. nitric oxide analyzer from the company BAT.29), R. & D. D. Group R. & D. Center, Southampton, UK, combined with the smoking machine SM 302 from the company Filtrona Instruments & Automation Ltd.30), Harpenden, UK, working on the basis of a chemiluminescence detector,where the photomultiplier electrical output signal is buffered by an amplifier attenuated anddisplayed in combination with a chart recorder.
Nitrogen oxides analyzers based on the chemiluminescence detector use the high reactivity of nitrogen oxide in that way that a definite small fraction of the nitric oxide moleculesreacts with ozone to form activated nitrogen dioxide species N02*; as the activated oremitting species (N02*) reverts to a lower energy state, it emits a broadband radiation from500 to 3000 nm with a maximum intensity at approximately 1100 nm.
NO + 03 ~ N02* + 02N02* ~ N02 + hv
Since one nitrogen oxide molecule is required to form one N02* molecule, the chemiluminescence emission intensity is proportional linearly to the nitrogen oxide concentration inthe sample. The photornultipller tube current is proportional directly to the chemiluminescence emission intensity31, 32). Under reducing conditions, as they are found in tobacco
21
smoke, most of these analyzers measure less nitric oxide. Carbon monoxide, hydrogen,ammonia, sulfur dioxide, methane and other hlqher aliphatic hydrocarbons reduce nitricoxide by the reaction mechanisms shown below"33):
2CO + 2NO <II ~ N2 + 2C02CO + 2NO iii ~ N20 + CO25H2 + 2NO <II ~ 2NH3 + 2H20
2NH3 + 4NO iii .. 2N2 + N20 + 3H20
Negative nitric dioxide values are found, too, in nitrogen oxides analyzers as the MonitorLabs. Nitrogen Oxides Analyzer 8440E.,4), Atlanta, USA, working on that way that thesample stream entering the analyzer is split into a nitrogen oxides and a nitric oxide stream.The one difference between the nitrogen oxides and the nitric oxide stream in this device, in comparison with B. A.1. nitric oxide analyzer29) -, is that in the nitrogen oxides stream isplaced a converter with molybdenum as catalyst, converting the nitric dioxide to nitricoxide. Nitric dioxide concentration level is derived by electronically subtracting the nitricoxide signal from the nitrogen oxides signal.
Positive nitric dioxide signals in tobacco smoke were found with the Monitor Labs. Nitrogen Oxides Analyzer 8440E34), Atlanta, USA, after the molybdenum converter was replaced by a converter containing carbon. The positive nitric dioxide signals can be used asfinal check before starting the nitric oxide measurement and during the nitric oxidemeasurement in cigarette smoke, too35).
Calculation
The calculation of the nitric oxide yield in tobacco smoke for puff to puff smoking of cigarettes was derived according to the calculation of the carbon monoxide yield of DIN ISO3402 20) or CORESTA recommended method Nr. 536), assuming nitric oxide to be an idealgas37), with a defined puff volume of 35 ml per two seconds and a draw intermission of 10seconds.
Let: Cobs = observed nitric oxide concentration, vpmN = total number ofpuffs inthe measured sample
(including three clearing puffs)V = puff volume, mlq = number ofcigarettes to produce the measured samplet = ambient temperature, 'Cop = ambient pressure, kPa
Calculation of the nitric oxide yield - volume per cigarette basis - at 101,3 kPa and O°C:
Cobs x V x N x P x 273III nitric oxide per Cigarette = ---3-------
q x 10 x 101,3 x (t + 273)
Short formula:
with:
III nitric oxide per CigaretteCobs x N x p
-::------ X F103x (t+273)
22
F = 35 x 273
103x101,3
0,012572 (one cigarette)= 0,050289 (four cigarettes)
0,100576 (eight cigarettes)
Calculation of the nitric oxide yield - mass per cigarette basis - at 101,3 kPa and O°C:
Cabs x V x N x P X 273 x 30/1g nitric oxide per Cigarette
qx103x101,3x (t+273) x 22,4
Short formula:
with:
/1g nitric oxide per CigaretteCobsxNxp-----xFqx(t+273)
F == 35 x 273 x 30
103 x 101,3 x 22,4
== 0,01684 (one cigarette)0,06736 (four cigarettes)
== 0,13472 (eight cigarettes)
Balance Method
Tocheck the method of BAT. nitric oxide analyzer29) in combination with the smoking machine M 302 of the com~any Filtrona30) there was the need of a balance method. The nitrogen oxides rnethod'' ) developed with the Monitor Labs. Nitrogen Oxides Analyzer8440E34), Atlanta, USA, in combination with the diluting stack sampler for monitoring gaseous emissions Model 797 of the com~any Kipp Analytica39, 40), and the smoking machineRM 20 of the company H. Borqwaldt" ), was modified for the use as balance method. Thediluting stack sampler of the company Kipp Analytica, rarefying the nitrogen oxides withdried and purified air to avoid the chemical reaction with other smoke components37), wasreplaced for a nitrogen flushing unit, using two three-way valves, the one electrically operated from the pump stroke unit of the smoking machine combined with a back pressurevalve, the other mechanically operated (see graph 1).
Graph 1Valve Circuit Oiagramm for Puff by PuffAnalysis of Nitric Oxide in TobaccoSmoke with Nitrogen Flashing of theSmoking Machine and the Nitric OxideAnalyzer
SMOKINGMACHINE
TO NO-ANALYZER
PISTON PUMP
23
During the draw intermission the connecting tubes and the nitrogen oxides analyzer isflushed with nitrogen gas of highest purity between every puff of the smoking machine: infresh cigarette smoke, - on a puff by puff basis -, nitrogen oxides are directly measurablewithout dilution35).
Smoking Machine Borgwaldt RM 20 CS
The Borgwaldt RM 20 CS smoking machine is a rotating machine with 20 channels. For thedetermination of nitrogen oxides with the central Cambridge filter holder every channel canbe used as single port, so that the nitrogen oxides content is measurable in the puff volumepuff by puff per single cigarette. During the draw intermission the smoking machine and nitrogen oxides measuring apparatus is automatically flushed with nitrogen (see graph Nr. 1).Depending on the stagnant volume of the smoking machine and the nitrogen oxidesmeasuring apparatus up to five cigarettes can be smoked per smoking procedure withoutinterfering peaks on the chart recorder.
Smoking Machine Filtrona M 302
The smoking machine M 302 of the company Filtrona30) is a linear smoking machine witheight channels, ports and separate Cambridge filter holders working in a way that the nitricoxide content is determined in the puff volume puff by puff per eight cigarettes together.The really drawn puff volume per puff is therefore 35 ml times eight (the used number of thechannels for smoking eight cigarettes toqether), After the calculation formula from thehandbook for B. A. 1. nitric oxide analyzer<T2)
Nitric oxide (1l9/Cigarette) A x N ~ P x 0T0168473 +
was corrected with the factor of eight in
Nitric oxide (llg/Cigarette)
where A =average concentration (vpm)N = number of lit puffs per cigaretteP = barometric pressure (mm Hg)T =room temperature ('C).
the nitric oxide measurement took place.
AxNxPxO.13470273+ T
4 Greek Tobacco Breeding LinesThe Greek tobacco breeding lines were cultivated in 1987. Twenty-eight samples of fiveGreek breeding lines have been analyzed for compounds in leaf and smoke. Up to sevenstalk positions of the breeding lines 1/B, 2/K, 3/S, 4N and 5/R have been recorded. The tobacco leaf components nitrate, nicotine, sugar and total nitrogen are given in% (see graphsNr. 2, 3, 4, 5 and 6).
In the tobacco smoke condensate, nicotine, carbon monoxide and nitric oxide have beenevaluated. The smoke components are specified per cigarette (see graphs Nr. 7, 8, 9, 10,and 11).
4.1 Breeding Line 5/R
The condensate amounts of the breeding line 5/R (see graph Nr. 11) fulfill the directions ofthe EU in the harvesting grades from "lugs" to "cutter". This breeding line is somewhatbetter than the German Burley cultivars, grown in Forchheim (see graphs Nr. 26a and 27a).
24
Graph 2: Compounds in Tobacco from Greek Breeding Une 11B 1987Harvesting Grades 1 - 7, N-Fertilization 30 kg Nlha
14..---------------------------,
12
10
8
6
4
o2 3 4 5 6 7
Nitrate GC % III 0,74 0,41 0,21 0,17 0,1 0,06 aTotal N % III 2,23 2,37 2,67 2,61 2,78 2,22 3,2
Nicotine GC % IS] 2,46 2,97 3,32 4,17 3,72 2,74 3,32
Total Sugar % 0 7,63 6,96 5,93 6,3 6,1 12,1 6,46..Reducing Sugar % I&l 5,43 5,1 4,26 4,93 4,43 9,36 5,1
Sucrose % I'ZJ 2,09 1,76 1,58 1,3 1,58 2,6 1,29
Graph 3: Compounds in Tobacco from Greek Breeding Une 21K 1987Harvesting Grades 1 - 4, N-Fertilization 40 kg Nlha
25.----------------------------,
20
15
10
5
2 3 4
Nitrate GC % II 0 0 0 0
Total N % tzl 1,6 1,68 1,6 2,43Nicotine GC % II 0,51 0,46 0,46 1,32Total Sugar % ~ 19,1 17,66 18,73 10,2Reducing Sugar % D 16,63 14,7 15,93 8,16..Sucrose % f2] 2,34 2,81 2,66 1,93
The nicotine rates correspond with a good climate in Greece and equal to good German tobacco cultivars. 4 mg nicotine per cigarette have been found in the "tips"; the carbon monoxide content is a little bit higher than in the German cultivars.
The nitric oxide amounts have been found in all harvesting grades to be higher than 200 Ilgper cigarette: in the "lugs" the nitric oxide amount has been found to be 385 Ilg per cigarette, significantly higher than the amounts of German Burley cultlvars (see graphs Nr. 26aand 27a).
25
Graph 4: Compounds in Tobacco from Greek Breeding Line 3/5 1987Harvesting Grades 1 - 6, N-Fertilization 30 kg N/ha
25,-------------------------------,
Nitrate GC % III 0,2 0,1 0,1 0,1 0,1 0,1
Total N % I7J 2,24 1,91 2,12 2,24 1,95 1,7
Nicotine GC % III 1,37 2,32 2,06 1,32 1,43 1,14
Total Sugar % ~ 12,96 22,26 15,4 12,8 16,63 16,8
Reducing Sugar % 0 18,56.. 10,56 13,5 10,73 14,9 15,4
Sucrose % [2l 2,28 3,51 1,8 1,96 1,64 1,33
Graph 5: Compounds in Tobacco from Greek Breeding Line 4/V 1987Harvesting Grades 1 - 6, N-Fertilization 30 kg N/ha
30 ,--------------------------------,
25
20
15
10
5
2 3 4 5 6
Nitrate GC % II 0,1 0,1 0,1 0,1 0,1 °Total N % [Z] 1,19 1,12 1,23 1,22 1,49 1,13Nicotine GC % II 1,77 1,43 1,89 2 2,86 3,26Total Sugar % ~ 19,96 23,86 27,46 25,66 25,13 23,46Reducing Sugar % 0 17,86 20,13 24,6 22,63 23,33 22,46
Sucrose % Ell 1,99 3,54 2,71 2,87 1,71 1,33
Altogether the content of smoke compounds of the Greek tobacco breeding line is significantly higher than of the German cultivars, except for the condensate content.
Regarding to the nitrate amounts of the tobacco leaf, it has been found out, that the nitraterates of 3% (see graph Nr. 6) in tobacco leaf are high and responsible for the high nitricoxide content.
The nicotine amounts with up to 5.15% nicotine in tobacco leaf (see graph 6) are very hightoo. Such high nicotine amounts could only be found in German Burley cultivars during hotand dry tobacco years (see graphs Nr. 26a and 27a).
26
Graph 6: Compounds in Tobacco from Greek Breeding Line 51R 1987Harvesting Grades 1 - 5, N-Fertilization 200 kg Nlha
6.-----------------------~--___,
5
4
3
2
o2 3 4 5
Nitrate GC % II 3 2,4 1,2 0,6 1,3Total N % ~ 3,16 3,2 3,85 4,16 3,44Nicotine GC % 0 1,89 1,89 3,95 5,03 5,15Total Sugar % ~ 0 0 0 0 0
Graph 7: Compounds in Smoke from Greek Breeding Line 11B 1987Harvesting Grades 1 - 7, N-Fertilization 30 kg Nlha
40,----------------------,
30
20
10
2 3 4 5 6 7
Condensate mg/cig II 15,67 21,75 28,51 33,85 36,16 32,94 33,48
Nicotine mg/cig ~ 1,63 2,25 3,06 3,67 3,61 3,06 3,34
Carbon monoxide mg/cig 0 11,83 14,58 17,34 19,07 19,52 19,8 15,79:;:
Nltr. oxide mg/cigxO,1 ~ 1,6 1,45 1,31 1,24 1,2 1,1 1,16
4.2 Breeding Line 4N
The breeding line 4N has been investigated in all harvesting grades from 1 to 6. The condensate amounts of 25 mg per cigarette in the lower harvesting grades are exceeding thedirections of the EU (see graph Nr. 10).
The nicotine amounts from 1.4 to 3.1 mg nicotine per cigarette have been found in themiddle to high range (see graph Nr. 10).
27
Graph 8: Compounds in Smoke from Greek Breeding Line 2/K 1987Harvesting Grades 1 - 4, N-Fertilization 40 kg N/ha
40,---------------------------,
25
20
15
10
5
° 2 3 4
Condensate mg/cig III 23,12 22,96 24,65 34,16Nicotine mg/cig [83 0,49 0,49 0,37 1,39Carbon monoxide mg/cig 0 13,55 13,73 14,71 16,15Nitr. oxide mg/cigxO,1 ss 0,72 0,79 0,92 0,12
65432
= r-r-
""r-r-
Iiii;y:; Ii "" xx. """ 00 e-e-e = ~ )0( bz:x
°5
25
20
30
15
10
Graph 9: Compounds in Smoke from Greek Breeding Line 3/S 1987Harvesting Grades 1 - 6, N-Fertilization 30 kg N/ha
35
Condensate mg/cig III 20,05 21,29 25,41 25,15 31,55 30,52Nicotine mg/cig I2lI 1,35 1,11 1,54 1,17 1,6 1,2Carbon monoxide mg/cig 0 11,11 11,95 12,88 13,84 14,25 14,29Nitr. oxide mg/cigxO,1 1S1 0,92 0,84 0,77 0,72 0,69 0,68
The carbon monoxide amounts from 15.8 to 19.9 mg per cigarette are much higher thanthe amounts of the German cultivars (see graph Nr. 10, 12a and 13a).
The nitric oxide contents with amounts from 76 to 115 /1g per cigarette are in the low tomiddle range (see graph Nr. 10).They are corresponding to the amounts in the German cultivar Virgin D.
The low nitric oxide contents in the smoke are referring to the low nitrate amounts in the tobacco leaf. Here are the nitrate amounts lower than 0.1% or not detectable.
28
65432
."...,
"'" "'"=
~iiZR) ~ ~ ~ 50< """ 122 h ""
15
10
5
°
25
20
Graph 10: Compounds in Smoke from Greek Breeding Line 4/V 1987Harvesting Grades 1 - 6, N-Fertilization 30 kg N/ha
40
35
30
Condensate mg/cig • 25,9 29 28,47 30,13 34,14 32,09Nicotine mg/cig 123 1,5 1,42 1,73 1,67 2,66 3,11Carbon monoxide mg/cig 0 19,96 18,87 15,85 15,36 18,01 16,81Nitr. oxide mg/cigxO,1 ~ 0,76 0,77 0,8 0,85 0,95 1,15
Graph 11: Compounds in Smoke from Greek Breeding Line 5IR 1987Harvesting Grades 1 - 5, N-Fertilization 200 kg N/ha
25,-------------------------,
2 3 4 5
Condensate mg/cig • 10,17 12 14,6 18,5 20,52Nicotine mg/cig ~ 0,83 1,01 2,28 3,43 3,98Carbon monoxide mg/cig 0 9,02 9,6 11,18 13,41 13,58Nitr. oxide mg/cigxO,1 ~ 3,86 3,58 2,72 2,15 2,55
The nicotine rates have been found to be in a middle to high range from 1.4. to 3.2%.
The sugar amounts have been found in an upper range from 19.9 and 27.4%.
The total nitrogen contents are low and showing a little variation only from 1.1. to 1.4% (seegraph Nr. 5).
29
Graph 12: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Lines1987; Harvesting grades 1 - 6
2.000
1.500
1.000
500
J1lh .nnJ1JLrl1.n.m~ri! • .1\ ~ 1-
NNN MS ng/olg 121 40 37 35 32 18 8 4 3 2 1 0 0 0 0 0 24 232 264 328 315 458 0 0 0 0 0 0
NNN pret ng/ol9 IZJ 107 96 69 75 33 16 63 0 0 0 0 0 0 0 0 81 424 632 1.12 1.13 1.63< 0 0 0 0 0 aNNK MS ng/olg 028 15 18 15 14 5 9 7 6 8 4 0 a a 0 7 30 50 46 46 52 a a a 0 a aNNK pre! ng/olg E'I 59 41 16 a a a 15 0 a a a a a a 0 a 50 46 71 73 114 a 0 a 0 a aNAT/B MS ng/olg o 47 22 50 46 51 12 6 3 6 4 a a a 0 a 23 359 300 365 384 392 a 0 0 a a aNAT/S prel ng/olg [] 10 54 75 63 68 0 25 0 0 0 0 0 0 0 0 20 336 322 650 931 576 a 0 0 a a aN03 mn/oi II 6,1 4 2,2 1 0,5 0,1 1,6 1,1 0,6 0,4 0,2 0,1 0 0,1 0,3 1,5 22,5 19,2 10,1 5,4 9 0 0,05 0,1 0,15 0,2 0.3
65432
~ It. ~ ~ ~ ~rl :::~ ...
r; jVrm ~nW y;, :..~ ~mlo
20
80
40
60
100
1. Harvesling Grade I2. HaNesling Grade II3, Harvesling Grade III4, Harvesling Grade IV5, Harvesling Grade V6 Harvesling Grade VI
Graph 13: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Line 1/B1987; Harvesting grades 1 - 6, Fertilization 30 kg N/ha
120
NNN MS ng/cig E3 40 37 35 32 18 8
NNN prst, ng/cig l?L1 107 96 89 75 33 18
NNK MS ng/clg [J 26 15 18 15 14 5
NNK pret, ng/cig ~ 69 41 18 0 0 0
NAT/S MS ng/cig [] 47 22 50 48 51 12
NAT/S pret. ng/clg CD 10 54 75 53 68 0
Nitrate mg/cig II1II 6,1 4 2,2 1 0,5 0,1
4.3 Breeding Line 1/B
The breeding line 1/8 is a type of tobacco with high condensate amounts in the upper harvesting grades. More than 33.4 mg condensate per cigarette are observed (see graphNr.7).
30
Graph 14: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Line 21K1987; Harvesting grades 1 - 4, N- Fertilization 30 kg Nlha
100
80
1. HaNestJng Grade I602, HaNesting Glade II
3, H8IVesting Grade III4, Harvesting Grade IV 40
20
02 3 4
NNN MS ng/clg [] 0 0 0 24"
NNN pret. ng/clg [Z] 0 0 0 81
NNK MS ng/clg IQI 0 0 0 7
NNK pret. ng/cig ~ 0 0 0 0
NAT/S MS ng/clg [] 0 0 0 23
NAT/S pret. ng/clg CD 0 0 0 20
Nitrate mg/cig II 0 0,1 0,3 1,5
Graph 15: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Line 31S1987; Harvesting grades 1 - 6, N- Fertilization 30 kg Nlha
60 ~---------------------------,
501, HaNesting Grade I2, HaNesling Grade II 403, Harvesting Grade III4, HaNesting Grade W 305, HaNesting Grade V6, HaNesting Grade VI '
10
o2 3 4 5 6
NNN MS ng/clg I2l 4 3 2 1 0 0
NNN pret. ng/clg IZJ 53 0 0 0 0 0
NNK MS ng/cig 0 9 7 8 6 4 0
NNK pret. ng/clg [SJ 15 0 0 0 0 0
NAT/S MS ng/clg II 6 3 6 4 0 0
NAT/S pret. ng/clg CD 25 0 0 0 0 0Nitrate mg/cig II 1,6 1,1 0,6 0,4 0,2 0,1
The nicotine content has been found in the middle to high range from 1.6 and 3.6 mg percigarette.
The carbon monoxide amount is also high. It has been found in the range from 11.8 to 19.8mg per cigarette.
The nitric oxide contents are in the middle range from 110 to 160 /1g per cigarette (seegraph Nr. 7).
31
Graph 16: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Line 4/V1987; Harvesting grades 1 - 6, N- Fertilization 30 kg Nlha
2,5 r------------------------------,
2
1. Harvesting GradeI2. HarveslingGrade II3. HarveslingGrade III 1,54. Harvesling Grade IV6. Harvesting Grade V6. Harvesting GradeVI
0,5
2 3II1II
411/
5I
6I
NNN MS ng/olg III 0 0 0 0 0 0
NNN pret. ng/olg I'ZI 0 0 0 0 0 0
NNK MS ng/olg 0 0 0 0 0 0 0
NNK pref. ng/o1g ~ 0 0 0 0 0 0
NAT/S MS ng/olg D 0 0 0 0 0 0
NAT/S pref. ng/olg ~ 2 0 0 0 0 0
Nitrate mg/olg III 0 0,05 0,1 0,15 0,2 0,3
Graph 17: Nitrosoalcaloids and Nitrate Contents in Cigarettes of Greek Breeding Line SIR1987; Harvesting grades 1 - 5, N- Fertilization 30 kg Nlha
NNN MS ng/olg I'ZJ 232 284 328 315 456
NNN pret. ng/olg D 424 632 1.123 1.132 1.633>:
NNK MS n9/0lg I2J 30 60 48 46 52
NNK pret. ng/ol9 0 60 48 71 73 114'"
NAT/S MS ng/olg ~ 359 300 365 384 392
NAT/S pref. ng/olg [] 336 322 660 931 676
Nitrate mg/olg III 22,5 19,2 10,1 5,4 9
The high nitrate contents in the tobacco leaf (see graph Nr.2) can only be used partly as anexplanation of the extreme nitric oxide contents. The nitrate contents are decreasing fromthe lower to the higher harvesting grades. According to the indirect correlation between nitrate content and stalk positions in the first harvesting grade 0.7% nitrate has been foundand in the 6. harvesting grade only 0.1% nitrate.
The nicotine contents are ranging from high levels to very high ones, from 2.4 to 3.7%.
The sugar content has been found in a low to middle range from 5.9 to 12.1%.
32
The total nitrogen amount has been found in a middle range from 2.2. and 3.2% (see graphNr.2).
4.4 Breeding line 2/K
This breeding line 2/K is an oriental tobacco type. The condensate content has been foundin an extremely high range from 22.9 to 34.1 mg per cigarette.
The nicotine content is observed to be in a low to middle range from 0.3 to 1.3 mg per cigarette.
The carbon monoxide amounts are high and ranging from 13.5 to 16.1 mg per cigarette.
The nitric oxide amounts are ranging from low to middle rates: in the lower harvestinggrades from 72 to 92 I-lg per cigarette, in the upper harvesting grades 120 I-lg per cigarette(see graph Nr. 8).
In the tobacco of the breeding line 2/K no nitrate is detectable. The nicotine contents havebeen found in the low to middle range from 0.4 to 1.3%.
The sugar amounts are referring to a middle range from 10.2 to 19.1%, in which the upperharvesting grade is showing the lowest sugar amount.
The total nitrogen has been found to be 1.6% with exception of the upper harvesting grade,in which the content is referring to 2.4%. The total nitrogen has only a slight variation (seegraph Nr. 3).
4.5 Breeding line 3/5
The breeding line 3/8 is an oriental tobacco type with a condensate content ranging from20 to 31.5 mg per cigarette. The nicotine content is ranging from 1.1 to 1.6 mg per cigaretteand the amount is medium.
The carbon monoxide contents have been found in a middle range from 11.1 to 14.2 mgper cigarette.
The nitric oxide contents are found in a low to a middle range from 68 to 92 I-lg per cigarette(see graph Nr. 9).
The nitrate contents of the breeding line 2/K have been found in a low range of 0.1%.
The nicotine amounts are in the middle range from 1.1 to 2.3%.
The sugar contents have been also found in a middle range from 12.8 to 16.8% except thesecond harvesting grade, which has been found to be 22.2%.
The total nitrogen content is medium and is ranging from 1.7 to 2.2% (see graph Nr.4).
4.6 Discussing the Results
High rates of nitrate fertilizer given to tobacco are responsible for high contents of nitrogen,total alkaloids, nitrate and volatile bases in tobacco, for the high percentage of volatile nltrosamines, too, as it has been proved. N-nitroso-nornicotine (NNN) is the mostly found nitrosamine in the mainstream of the smoke. A high percentage of N-nitroso-nornicotine isobserved in cured and especially in fermented tobacco, which contain a lot of nitrate22, 23).
A survey of the rates of nitrosamines N'- nitrosonornicotine (NNN), 4-(methylnitrosamino)1-(3-pyridil)-1-butanone (NNK) and N'-nitrosoanabasine / N'-nitrosoanatabine (NAB/NAT)with nitrate is shown from all primes of the five Greek breeding lines in graph Nr. 12.
33
Additionally from every prime of five different Greek breeding lines the contents of condensate, nicotine, carbon monoxide and nitric oxide on the one hand (seegraphs Nt:7 -11), nitrate, nitrosamines in the cigarette tobacco and in the mainstream smoke on the other hand(see graphs Nr. 13 - 17) are shown as graph and diagram.
Discussing the results and the correlations, the rates of carbon monoxide increase in everyprime in all tobacco breeding lines except 4N breeding line in which an irregularity in therates is observed. Breeding lines with high nitrate percentage (5/R) have high percentage innitric oxide and nitrosamines. Corresponding decrease of nitrate and nitric oxide is foundout in every prime in the breeding lines 1/B, 3/8 and 5/R and corresponding increase inevery prime in 2/K and 4N. In 5/R breeding line the highest percentage of nitrosaminesboth in tobacco leaves and in the mainstream smoke is observed. In 4N, 2/K and 3/8 no nitrosamines are observed, while 1/B is in a middle position.
In 5/R breeding line the rates of carbon monoxide are much lower (9 - 13 mg/cig) than thecorresponding rates of 4N breeding line (15 - 20 mglcig). 1/B, 2/K and 3/8 breeding linesare in a middle position (11 - 18 mg/cig). Generally the rates of carbon monoxide increasein every prime of all tobacco breeding lines except 4N breeding line, in which an irregularityin the rates of carbon monoxide is observed.
It has been found out that in breeding lines with high percentage of nitrate such as 5/Rthere is most of both nitric oxide and nitrosamines. Breeding lines showing low nitrate contents, such as 4N, 2/K and 3/8, have low contents of nitric oxide and nitrosamines, too. The1/B breeding line is in the middle position both in nitrate, nitric oxide and nitrosamines.Generally a corresponding decrease of nitrate and nitric oxide is found out in every prime inthe breeding lines 1/B, 3/8, 5/R and a corresponding increase of the same parameter inevery prime in 2/K and 4N breeding lines.
Regarding the nitrosamines in 5/R breeding line the highest percentage is observed in themain stream smoke and in the tobacco leaves, too. This result is in contrast to the breedinglines 4N, 2/K and 3/8, in which no nitrosamines are observed, while the breeding line 1/B isin a middle position.
It is characteristic that the rates of nitrosamines in 5/R breeding line are ten-fold higher thanin 1/B breeding line. These rates of nitrosamines in smoke and in leaf are in a completecorrespondence to the rates of nitrate in tobacco. Comparing the percentages of N'-nitrosonornicotine (NNN), L-(methylnitrosamino)-1-(3-pyridil)-1-butanone (NNK) and N'-nitrosoanabasine IN' -nitrosoanatabine (NAB/NAT) it is observed, that the half to one third of theN' -nltroso-nornlcotlne (NNN) and L-(methylnitrosamino)-1-(3-pyridil)-1-butanone (NNK)rates of the mainstream smoke are found in the tobacco leaf, while the rates of N'-nitrosoanabasine I N'-nitrosoanatabine (NAB/NAT) in the mainstream smoke and in the leavesare equal.
The nitric oxide rates of in 5/R breeding line are the highest (385 - 215 flg/cig). In the 1/Bbreeding line a decrease to half the rates is observed. In 5/R lines nitric oxide rates arebetween 160 - 110 flg/cig, while in the rest of the breeding lines the rates are in lowerpercentage (68 - 120 flg/cig).
Considering the results in detail, it is found out, that the 1/B breeding line shows a decreaseof the rates of nitrate in every prime (6.1 - 0.1 mg/cig). Corresponding decrease takes placein rates of nitric oxide in the smoke (160 -110 g/cig) and N-nitroso-nornicotine in the mainstream. In contrast an increase of the rates of carbon monoxide in every prime (11.8 -19.8mg/cig) is observed.
In 318 breeding line a decrease of the rates of nitrate, - corresponding to the rates of nitricoxide and N'-nitrosonornicotine -, combined with an increase of the carbon monoxiderates is observed.
34
65432
,.".,. = """:
: :
H :
!i
:
h:, I00l -e-o I0.'l ~ ~ ;~ f-:= ~ ~
5
°
151, Geudertheimer III2, Bad, Geudertheimer3, Bad, GeudertheimerW4, Bad, Geudertheimer K 10
5, Perega6, Perega 234
Graph 18a: Compounds in Smoke from Geudertheimer Cultivars 1987,LUGS, N-Fertilization 180 kg N/ha
20
Condensate mg/cig III 13,36 14,09 14,15 15,71 14,54 17,41Nicotine mg/cig IF§j 0,49 0,46 0,37 0,34 0,56 0,19Carbon monoxide ml/cig [J 9,1 8,5 8,8 8,4 8,4 8,6:::
Nitr. oxide mg/cigxO,1 bSl 0,84 0,76 0,67 0,62 0,73 0,78
65432
bv ~ ~ ~ b-e-e ~ Iv., ~ I:n ~ ~
°
30
5
1, Geudertheimer III2, Bad, Geudertheimer 25
3, Bad, GeudertheimerW 20
4, Bad, Geudertheimer K5, Perega 15
6, Perega 234 10
Graph 18b: Compounds in Smoke from Geudertheimer Cultivars 1987,LUGS, N-Fertilization 180 kg N/ha
35
Condensate mglg tdm III 26,28 24,88 27,36 30,36 28,71 30,09Nicotine mg/g tdm fi2J 0,96 0,81 0,72 0,66 1,11 0,33CO ml/g tdm 0 17,8 15 17 16,2 16,6 17,5"
NO mg/g tdm x 0,1 ~ 1,66 1,34 1,29 1,2 1,45 1,35
Compared with 1/8 and 3/8 breeding lines the 2/K and 4N breeding lines - with an increase in the rates of nitrate and nitric oxide in every prime - show an inverse correlation tothe nitrate and nitric oxide.
In 5/R breeding line a decrease of the rates of nitrate and nitric oxide from the first to thefourth prime and then an increase is observed. In carbon monoxide an increase is observedin every prime. The decrease of nitric oxide and nitrate is much bigger in this breeding line,than in 1/8, 2/K and 3/8 breeding lines.
35
5. German Tobacco OultivarsSeventeen German cultivars of the harvest 1987 and twenty-eight new breeding lines ofdark air cured tobacco of the harvest 1990 have been analyzed in leaf and smoke for nitrate, alkaloids, condensate, nicotine, carbon monoxide and nitric oxide. Nitric oxide hasbeen determined separately in a second smoke procedure. To have a comparison with thecommercial brands, the contents of tobacco smoke compounds are calculated in milligrams per cigarette (see graphs Nr. 18a - 27a) and to have a comparison within the cultivars the values are additionally calculated per one gram smoked tobacco, related to the drymatter (see graphs Nr. 18b - 27b).
In previous investigations the cultivar Virgin D showed a low rate of nitric oxide. Therefore,no German Virgin cultivar has been analyzed.
Six Geudertheimer cultivars, - lugs and leaf, N-fertilizer 180 kg/ha -, eleven Burley cultivars, - leaf and tips, N-fertilizer 180 kg/ha -, and the cultivar Badischer Burley E, - N-fertilizer variation 0 kg and 250 kg/ha -, have been investigated. All tobacco samples were unfermented.
For the first investigation one thousand six hundred and twenty cigarettes (twenty-sevensamples) and for the second investigation one thousand six hundred and eighty (twentyeight samples) from every sample sixty tipples cigarettes, well defined in paper, fillingpower, and hardness were made by hand, under standardized conditions.
5.1 Geudertheimer
The Geudertheimer cultivars Geudertheimer III, Badischer Geudertheimer W, BadischerGeudertheimer K and Perega 234 were planted in 1987 in Forchheim (see graphs Nr. 18a19b). The stalk positions "lugs" and "leaf" were only air dried. The graphs Nr. 18a and 19ashow the results of the analysis of condensate, nicotine, carbon monoxide and nitric oxide.
The EU limitation for 1993 to fifteen milligrams condensate per cigarette is fulfilled for thecultivars Geudertheimer III and Badischer Geudertheimer W in the stalk position "lugs". Inthe stalk position "leaf" no Geudertheimer cultivar is within this limitation: all cultivars havevalues of nineteen milligrams per cigarette and have therefore clearly four milligrams condensate more (see graphs Nr. 18a and 19a).
The nicotine level in the stalk position "lugs" of the Geudertheimer cultlvars is very low. Thestalk position "leaf" has with 0.19 milligram nicotine per cigarette the lowest nicotine content (see graphs Nr. 18a and 19a). The tobacco year 1987 showed low temperatures combined with wet and rainy weather. Therefore, the low nicotine content shows more theweather conditions than the Geudertheimer properties: In dry and warm years the Geudertheimer cultlvars produce high nicotine contents.
The carbon monoxide contents from eight to ten millimeters per cigarette in the Geudertheimer cultivars are very low. They are comparable with the contents of the commerciallow carbon monoxide brands (see graphs Nr. 18a and 19a).
The Geudertheimer cultivars have surprisingly low nitric oxide contents: They are in the region from sixty-seven to eighty-eight micrograms per cigarette (see graphs Nr. 18a and19a).
The Geudertheimer cultivars planted in 1990 in Forchheim show generally higher contentsof tobacco leaf and smoke compounds (see graphs Nr. 20 - 25b). Nitric oxide contents arein the region from two hundred and forty-eight (PB SB 5) to five hundred and fifty-six (Italien. Havanna) micrograms per cigarette (see graph 24a) according to the high nitrate contents from 3 and ca. 4% respectively (see graph Nr. 21).
36
65432
=""'" =
ii:
= ~ ; ,
I::
!I liil1= K'-'l "" "" h-v "'" [so( ~ :;0< ~ 0:'l
°
20
10
1, Geudertheimer III2, Bad, Geudertheimer3, Bad, GeudertheimerW 15
4, Bad, Geudertheimer K5, Perega6, Perega 234
5
Graph 19a: Compounds in Smoke from Geudertheimer Cultivars 1987,LEAF, N-Fertilization 180 kg N/ha
25
Condensate mg/cig l1li 19,48 19,31 18,25 18,78 18,37 19,63Nicotine mg/cig ~ 0,74 0,86 0,47 1,29 1,01 0,19Carbon monoxide ml/cig [J 10,2 9,3 9 9,5 10,1 10Nitr. oxide mg/cigxO,1 ~ 0,88 0,77 0,66 0,73 0,82 0,79
65432
~..~ ;..::
;~
bv><: '0."'< Iw m Iv-.- m 50< -c-c-i R:x:: ::~ m°
401, Geudertheimer III2, Bad, Geudertheimer 30
3, Bad, GeudertheimerW4, Bad, Geudertheimer K 20
5, Perega6, Perega 234 10
Graph 19b: Compounds in Smoke from Geudertheimer Cultivars 1987,LEAF, N-Fertilization 180 kg N/ha
50
Condensate mg/g tdm l1li 38,13 38,14 31,71 32,98 33,61 34,97Nicotine mg/g tdm f2I 1,45 1,7 0,82 2,27 1,85 0,34
CO ml/g tdm 0 20 18,3 15,7 16,8 18,5 17,8:::
NO mg/g tdm x 0,1 ~ 1,72 1,52 1,15 1,29 1,49 1,41
The other compounds in tobacco smoke, tar and carbon monoxide, don't differ so muchand have less variability according to parameters, as to be seen in 25 breeding lines of theGeudertheimer cultivars of the harvest 1990 (see graphs Nr. 23a - 25b).
5.2 Burley
In the year 1987 the cultivars Badischer Burley E, Bursanica 217 Pereko, B 535, Burley 21,G 37 and Burley CA were planted. The Maryland cultivar MD 609 was planted for thepurpose of comparison (see graphs Nr. 26a and 26b). All Burley cultivars have in the stalk
37
Graph 20: Compounds in Tobacco from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Ferlilization 180 kg N/ha
Nitrate % • 3,11 3,99 3,5 3,22 2,6 2,9 2,32 1,92 2,5
Nicotine % ~ 1,04 0,05 0,11 0,09 0,03 1,79 0,23 0,91 0,13
Sum of Nom. W 0,06 1,08 1,32 1,43 0,77 0,07 0,75 0,09 0,55+Myosm.% ;:;;.
Graph 21: Compounds in Tobacco from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Ferlilization 180 kg N/ha
5
10. Havanna lie 411. Havanna dunkelrol12. Iialien. Havanna13.PB SB 5 314. Pay S10215. Phillippiin16. Semois 217. Z14918. Z149 NA
015 16 17 1810 11 12 13 14
• 3,63 3,72 3,9 3 3,77 1,97 3,03 2,6 2,46Nitrate %
~ 0,13 0,03 0,76 1,12 1,6 0,21 1,76 0.3 0,35Nicotine %
Sum of Nom. W 0,72 0.6 0,1 0,05 0.06 0,68 a 0.54 0,37+Myosm.% .;.;.
position "leaf" condensate values between nineteen and twenty-two milligrams per cigarette. They are clearly outside the EU-Iimitation for 1998. Therefore, these Burley cultivarshave no chance of getting any promotion by the EU-authorities in the future, too.
The Burley cultivars as well as the Geudertheimer cultivars show very low nicotine contents. Bursanica 217, Pereco and B 535 have a nicotine content of 0.25 milligram per cigarette, the cultivar Badischer Burley E of 0.93 milligrams per cigarette, the cultivar Burley CA
38
Graph 22: Compounds in Tobacco from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Fertilization 180 kg N/ha
4
19Z 228 320Z32821 Z328 NA22, Havanna lI{Ve'rP.90}23Z 234 224 Z89125 Z89228 Z89327 Z 228xMo 609·1.'·628Sao Gecdennemer
019 20 21 22 23 24 25 26 27 28
Nitrate % • 2,4 3,02 3,74 2,29 2,29 1,49 2,37 2,2 1,83 1,77 2,6
Nicotine % ~ 1,05 0,04 0,06 0,36 0,36 0,48 0,78 0,1 0,1 0,41 0,73
Sum 01 Norn. 0° 0,74 0,84 0,45 0,45 0,78 0,24 0,85 0,83 0,83 0,9
+Myosm.%
of 0.99 milligrams per cigarette and the cultivar Burley 21 of 1.33 milligrams per cigarette(see graphs Nr. 26a and 26b).
The Burley cultivars show very low carbon monoxide contents, too. The amounts between8.6 and 9.8 milliliters per cigarette are still somewhat lower than the amounts of the Geudertheimer cultivars (see graphs Nr. 26a and 26b).
The amounts of nitric oxide in the Burley cultivars are low. They have with amounts from 85up to 211 micrograms per cigarette higher contents of nitric oxide than the Geudertheimercultivars. The nitric oxide content of the cultivar Badischer Burley E with 211 microgramsper cigarette is only somewhat lower than that of the cultivar Maryland MD 609 with 227micrograms per cigarette (see graphs Nr.26a and 26b). This content equals to commercialbrands with very high content of nitric oxide.
5.3 The Effects of Nitrogen-Fertilization
For the Geudertheimer and Burley cultivars a N-fertilization of 180 kg per hectare is recommended. The N-fertilization of more than of 180 kg per hectare is a special experiment toshow the effect of high N-fertilization in the smoke contents. In the case of 0 kg per hectarethe tobacco plant can only use the N-amount that is created by the mineralization in the soilduring the year. The harvesting grades of "leaf" and "tips" have been investigated in the tobacco leaf and smoke.
5.3.1 Condensate
The condensate amounts of the Burley-tobacco with 250 kg N-fertilization per hectare iscorresponding to 180 kg N per hectare. It has been found, that without N-fertilization theBurley tobacco with 15.18 mg condensate per cigarette has already too much condensateaccording to the EU demand. The Bad Geudertheimer creates less condensate with 250 kgN per hectare (only 14.93 mg per cigarette). This amount seems to be false because the180 kg N-fertilization creates already an amount of 19.31 mg per cigarette. In the Bad
39
98765432
r-r- ,
I fCC C"'"C"'"
.. <, I
i<:< ~ ~ ~ ~, '0
~ ~ ~ ~~y.' ,",,' ~'/ .:<o
5
25
15
20
10
I 55·55·D13
2 Appe!1362xBe, 6' ·103 Appe':erre4 Appelter'e 3625 Aur ac6 Drag:~ Yen7.E:s.?a'agJay S: 0'/758 Els Pof/S9,GigaS 361 xEs Parag
Graph 23a: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, 180 kg N/ha
30
Condensate mg/cig II 17,79 17,42 22,34 22,74 24,22 20,57 22,86 17,55 18,79
Nicotine mg/cig [] 2,32 0,24 0,24 0,34 0,17 3,48 0,22 2,29 0,16Carbon monoxide ml/cig 0 9,53 10,39 10,87 11,49 11,27 10,7 10,49 9,48 9,68Nitr, oxide mg/clgxO,l ~ 3,87 4,7 3,63 3,2 ° 2,89 4,73 3,95 3,94
98765432
.'P'
"
~ ~ ~ ~/ ...
~ ~ ••. ~ '.~ ~,',>: 1<o
20
10
301, 55-55·P132, Appell,362xBei 61·103, Appelterre4, Appelterre 3625, Auriac6, Dragon Vert7, Els.Paraguay S101/758 Eis Pb/769, Gigas 381 x Els, Parag
Graph 23b: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, 180 kg N/ha
40
Condensate mg/g tdm II 27,06 27,04 33,71 34,64 36,27 33,73 33,7 26,81 30,51
Nlootlne mg/g tdm lSJ 3,53 0,37 0,36 0,52 0,26 5,7 0,32 0,5 0,26"
CO ml/g tdm 0 14,48 16,11 16,93 17,41 16,88 17,55 15,46 14,48 15,72
NO mg/g tdm x 0,1 E3 6,15 7,27 5,76 5,48 ° 5,01 8,03 5,67 7,52
Burley E, "tips", 20.6 mg condensate per cigarette are found with the fertilization of 250 kgN per hectare. In comparison without N-fertilization the 250 kg N-fertilization makes thecondensate content high, while in comparison with 180 kg N-fertilization the condensatecontent is not so high. The cultivar Bad Burley E, "tips", and the cultivar Burley NA, "Ieaf",having 250 kg N-fertilization per hectare - are showing the same condensate amount of 20mg per cigarette. The same has been observed in the cultivar Burlina T 89, "leaf", with acondensate content of 18.93 mg per cigarette. Comparing the Burley cultivars no differences are found with equal N-fertilization and within the same harvesting grade (see graphsNr. 27a and 27b).
40
181716151413121110
" ,[
~ X ~ ?;'
~ ~ ~ ~ ... ~f?:
>::.<;: < '<
5
o
20
15
10
10 Havanna lie11 Havanna dunkelrot12. Italien. Havanna13.PBSB514. Pay S 10215 Phillippijn16. Semois17. Z 14918. Z 149 NA
Graph 24a: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Fertilization 180 kg N/ha
25
Condensate mg/cig I11III 23,04 21,51 19,56 21,14 20,88 21,69 21,49 21,1 19,86
Nicotine mg/clg GJ 0,21 0,16 1,62 0,38 2,37 3,34 3,38 0,56 0,83Carbon monoxide ml/cig 0 10,71 9,58 9,86 10,48 10,8 10,48 11,11 10,22 11,02Nltr. oxide mg/clgxO,1 ESI ° ° 5,56 2,48 5,01 4,4 5,01 4,14 3,56
181716151413121110
:.::.\c-.<./.<.i<>:)<~~:.::
>-.~
~.~0 r-, ;~~
~ ~ ~.:~
~ ~m ~ 9;: "'7;, ~I ~v' oX .'< b-r-
40
o
20
10
50
30
10. Havanna lie11. Havanna dunkelrot12. Italien. Havanna13 PB SB 514. Pay S 10215 Phillippijn16. Semois17. Z 14918, Z 149 NA
Graph 24b: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Fertilization 180 kg N/ha
60
Condensate mg/g tdm I11III 37,73 31,42 32,04 34,8 33,57 32,05 34,62 34,08 35,09
Nicotine mg/g tdm lSI 0,35 0,24 2,65 0,62 3,82 4,94 54,5 0,9 1,48
CO ml/g Idm [J 17,54 13,98 16,15 17,26 17,37 15,49 17,9 16,52 19,65
NO mg/g IdmxO,l IS3 ° ° 9,36 4,4 8,83 7,72 9,27 7,7 6,1
5.3.2 Nicotine
The cultivar Bad. Burley E, "leaf", having a N-fertilization of 250 kg per hectare, is creating ahigh nicotine amount of 2.53 mg nicotine per cigarette. Without N-fertilization a low contentof 0.37 mg nicotine per cigarette has been found. In the cultlvar Bad. Burley E, "tips", thecontent of 0.49 mg nicotine per cigarette has been found without N-fertilization and with anN-fertilization of 250 kg per hectare the an amount of 2.72 mg nicotine per cigarette (seegraph Nr. 27a). In this experiment it is documented that without N-fertilization low nicotinecontents are got.
41
28272625242322212019
I
I;;; ~I~ ~ ~ ;. ~ ~ ~ ~ ~ ~
.) ~. , ,:'. . . "l
5
o
20
15
10
19. Z 22820. Z 32821. Z 328 NA2. Hav.II(Verm.90)
23 Z 23424. Z 89125. Z 89226. Z 89327. Z 228xMd 609-1-1-628. Bad.Geuderth.
Graph 25a: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Fertilization 180 kg N/ha
25
Condensat mg/clg II 21,45 19,7 16,2 22,04 18,64 20,06 21,64 20,15 20,99 20,38
Nicotin mg/cig [] 2,08 0,15 0,14 0,83 1,18 1,39 1,66 0,33 0,07 0,3
Carbon monoxide ml/cig 0 11,31 9,09 7,72 9,12 10,78 11,58 11,73 11,25 11,04 9,7
Nitr. oxide mg/cigxO,l ~ 3,46 4,15 4,61 2,74 2,9 3,5 3,63 2,82 3,4 3,05
28272625242322212019
r
I
I
~ ~ I~ ~ ~ ~ ~II;;) §j ~ ~Y, :;; .:;' ~o
40
30
19. Z 22820, Z 32821. Z 328 NA22. Hav.lI(Verm.90)23. Z 23424. Z 89125. Z 89228. Z 893 . 2027. Z 228xMd 609-1·1-628. 8ad.Geuderth,
10
Graph 25b: Compounds in Smoke from New Breeding Lines of Dark Air-Cured TobaccoCultivars 1990; LEAF, N-Fertilization 180 kg N/ha
50
Condensate mg/g tdm I11III 39,52 29,66 24,51 39,57 33,94 36,08 35,61 36,47 38,05 4,3Nicotine mg/g tdm D 3,82 0,23 0,21 1,49 2,13 2,51 2,73 0,6 0,13 0,6CO mi/g tdm 0 20,83 13,69 11,67 16,37 19,35 20,84 19,31 20,34 20,02 19,34NO mg/g tdm x 0,1 ISJ 5,92 6,99 7,17 4,18 5,85 6,96 6,63 5,6 6,74 5,53
The special cultivar Burlina T 89 has been found with high nicotine content, the otherspecial cultivar Burlina NA has been found with low till middle nicotine content with a N fertilization of 250 kg per hectare. That is why Burlina T 89 is a high-Ievel-nicotine-cultivarand the Burlina NA is a low-Ievel-cultivar.
5.3.3 Carbon Monoxide
Different N-fertilization is influencing the carbon monoxide content only slightly. A comparison between the N-fertilization of 250 kg N per hectare and no fertilization is creating the
42
r-t- ,-I r r-:
.
~ "'I "'I I0J c '-'J f§j <, ~ <' '0l
8765432°
1, Bad Burley E2, Bursanica 21 7 20
3, Pereko4, B 535 15
5, Burley 216, MD 609 10
7, G 378, Burley CA 5
Graph 26a: Compounds in Smoke from Burley Cultivars 1987;LEAF, N-Fertilization 180 kg N/ha
25
Condensate mg/cig III 19,22 20,42 19,05 21,12 21,17 21,21 22,01Nicotine mg/cig !SJ 0,93 0,25 0,25 0,25 1,33 1,11 0,99Carbon monoxide ml/cig D 9,8 9,5 8,6 9,2 9,8 8,6 9Nitro oxide mg/cigxO,1 E8J 2,11 0,95 0,94 1,03 0,94 2,27 0,85 1,16
8765432u r rr:
I
II
l'Vl ~ f0J 17 10:1 A Rl°
40
20
10
30
1, Bad Burley E2. Bursanica 2173. Pereko4. B 5355. Burley 216. MD 6097. G 378, Burley CA
Graph 26b: Compounds in Smoke from Burley Cultivars 1987;LEAF, N-Fertilization 180 kg N/ha
50
Condensate mg/g tdm III 35,1 35,77 35,55 39,09 35,74 31,79 39,27Nicotine mg/g tdm l23 1,7 0,44 0,47 0,46 2,25 1,66 1,77CO ml/g tdm 0 18 16,6 16,1 17,1 16,5 12,9 16,1NO mg/g tdm x 0,1 ~ 3,85 1,66 1,76 1,91 1,59 1,27 2,06
same carbon monoxide content of 10.4 - 11.3 ml per cigarette. The only exception is thecultivar Burlina 183, "tips", with a N-fertilization of 250 kg per hectare and 1301 ml per cigarette (see graphs Nr. 27a).
5.3.4 Nitric Oxide
The nitric oxide amounts are directly correlated with the N-fertilizationo The variant withoutN-fertilization has been found in the cultivar Bad. Burley E, "leaf", with the lowest amount of
43
Graph 27a: Compounds in Smoke from Burley Cultivars 1987 Changing with NitrogenFertilization; LEAF and TIPS, N-Fertilization 0 - 250 kg N/ha
25
I~EAF
1, Bad Burley E(0 kg N/ha)2, Bad Burley E(250 kg N/ha) 20
3, Burlina T89 (250 kg N/ha)4, Burlina NA (250 kg N/ha) 15
5, Bad Geuderth, (250 kg N/ha)6, Bad Burley E(0 kg N/ha) 10
7, Bad Burley E(250 kg N/ha)5
°5Zb-~[~~ Rl ~
2 3 4 5
TIPS
6 7
Condensate mg/clg • 15,18 19,74 18,93 20,9 14,93 20,23 20,6
Nicotine mg/clg IT8l 0,37 2,53 2,22 0,5 0,62 0,49 2,72
Carbon monoxide ml/cig CJ 10,7 10,6 10,8 11,3 10,4 10,8 13,1
Nltr. oxide mg/cigxO,1 rs 0,61 2,32 2,06 1,41 1,7 0,93 2,77
765432
LEAF TIPS
rr:;.:
"'" !soL ~ d ~ ss Iv; ~ it m~°
1. Bad Burley E(0 kg N/ha)2, Bad Burley E(250 kg N/ha) 30
3, Burlina T89 (250 kg N/ha)4, Burlina NA (250 kg N/ha)5, Bad Geuderth, (250 kg N/ha) 20
6, Bad Burley E(0 kg N/(ha)7, Bad Burley E(250 kg N/ha)
10
Graph 27b: Compounds in Smoke from Burley Cultivars 1987 Changing with NitrogenFertilization; LEAF and TIPS, N-Fertilization 0 - 250 kg N/ha
40
Condensate mg/g tdm • 25,58 31,84 31,82 34,93 24,71 32,76 35,62
Nicotine mg/g tdm ~ 0,62 4,08 3,73 0,84 1,03 0,79 4,7
CO ml/g tdm 0 18 17,1 18,1 18,9 17,2 17,5 22,6NO mg/g tdm x 0,1 ~ 1,04 3,74 3,47 2,36 2,82 2,1 4,79
61 /1g nitric oxide per cigarette, the variant with 250 kg N per hectare has been found with232 /1g nitric oxide per cigarette (see graph Nr. 27a). The variant with 180 kg N per hectarehas been found with 211 g per cigarette (see graph Nr. 26a). The cultivar Burlina T 89,"leaf", has been found with the very high content of 206 /1g nitric oxide per cigarette with aN-fertilization of 250 kg per hectare. 180 kg N per hectare create a nitric oxide content of 95/1g per cigarette in the cultivar Bursanica, "leaf" (see graph Nr. 26a). The cultivar Burlina NAhas been found with a slightly increased nitric oxide content of 141 /1g per cigarette with aN-fertilization of 250 kg per hectare. The cultivar Bad. Geudertheimer is producing an
44
amount of 170 g nitric oxide per cigarette, with a N-fertilization of 250 kg per hectare, 180kg N are producing only 67 fig nitric oxide per cigarette. All amounts are related to the "leaf"(see graphs Nr. 18a and 27a). A surmounted N-fertilization has been found in the cultivarBad Geudertheimer to create the double nitric oxide content. Very high nitric oxideamounts have been found in the cultivar Bad Burley E, "leaf" and "tips", in the variant with250 kg N per hectare: 232 and 277 fig nitric oxide per cigarette (see graph Nr. 27a).
5.3.5 Nitrate
The components of the tobacco smoke are influenced by the amounts and composition ofthe tobacco leaf substances. In the cultivar Bad Burley E with a N-fertilization of 250 kg perhectare a nitrate amount of 1.2% has been found, creating a nitric oxide amount of 232 figper cigarette. Therefore it is now clearly seen, that the cultivar Bad Geudertheimer createsa high nitric oxide content of 170 fig per cigarette with a N-fertilization of 250 kg per hectareand a nitrate content of 1.1% in the leaf: it is the same nitrate content found in the leaf of theBad Burley Ecultlvar that is responsible for a high nitric oxide content. The cultivars BurlinaT 89 and Burlina NA have been found with a N-fertilization of 250 kg per hectare to createnitrate amounts of 1.1% or 0.9%, which correlate with the high nitric oxide contents of 206fig per cigarette and 140 fig per cigarette (see graphs Nr. 27a and 28).
5.3.6 Nicotine and Nornicotine
Independently of the cultivars low nicotine contents in the tobacco leaves have beenfound. Only the cultivar Burlina T 89 has been found with a slightly higher content of 1.58%nicotine from the cultivar Bad Burley E with a content of 1.3% nicotine and aN-fertilizationof 250 kg per hectare. The cultivar Burlina NA is creating only 0.2% nicotine together with ahigh nornicotine content of 1.92%. The low amounts of the tobacco leaf components aredirectly correlated with the low amounts of the tobacco smoke contents. These lowamounts are due to the tobacco year 1987, a cold and rainy year.
Graph 28: Compounds in Smoke from Burley Cultivars 1987 Changing with NitrogenFertilization; LEAF and TIPS, N-Fertilization 0 - 250 kg Nlha
2,5
1, Bad Burley E(0 kg N/ha) LEAF TIPS
2, Bad Burley E(250 kg N/ha)2
3, Burlina T89 (250 kg N/ha)4, Burlina NA (250 kg N/ha) 1,5
5, Bad Geuderth, (250 kg N/ha)6, Bad Burley E(0 kg N/ha)
0,5
° 2 3 4 5 6
Nitrate % • 0,1 1,2 1,1 0,9 0,1 1,1
Nicotine % [ZJ 0,28 1,3 1,58 0,2 0,42 0,33
Sum of Nornic.+Myosm.% • 0,05 0,03 0,01 1,92 0,01 °45
5.4 Discussing the Results
A graphic plot between N-fertilization and nitrate contents in tobacco leaves and nitricoxide in tobacco smoke is showing the casual relationship between high nitrogen fertilization and the extreme high nitric oxide amounts in the tobacco smoke (graph Nr. 29). AllBurley cultivars have been evaluated with the fertilizer concentration 0 kg N per hectare,180 kg N per hectare and 250 kg N per hectare. The graph is showing clearly increasingrates of nitric oxide in tobacco smoke with increasing nitrogen fertilization. Without N-fertilization the tobacco plant could only use the soil nitrogen created during the vegetationperiod by mineralization. The nitric oxide content starts at different levels according to theharvesting grades. The curve "Ieaf" goes from 60 Ilg nitric oxide per cigarette without N fertilization to 230 Ilg nitric oxide with a N-fertilization of 250 kg per hectare (see graph Nr.29,curve "Ieaf"). In the harvesting grade "tips" 100 Ilg nitric oxide per cigarette without N-fertilization are observed and 280 Ilg nitric oxide per cigarette with 250 kg N-fertilization perhectare (see graph Nr. 29, curve "tips"). Considering the results the rates of N-fertilizationare in good correspondence with the rates of nitric oxide. Appropriate to the harvestinggrade there is a linear proportion to be seen.
A summary of the nitric oxide rates shows that they usually range in accordance with N-fertilization of the cultivars. It has been found out that in the harvesting year 1987 the Geudertheimer cultivar with a N-fertilization of 180 kg per hectare has a very low nitric oxide range.This nitric oxide range corresponds with the low ranges of the Greek breeding lines 4N and3/8 with a N-fertilization of 30 kg per hectare, by which the breeding lines 2/K and 1/B areobserved to have significantly higher nitric oxide ranges with the common fertilization of30 - 40 kg per hectare (see graph Nr. 30).
From this it is clearly to be seen, that an excessive N-fertilization in tobacco cultivationused for an increase in the yield is creating high levels of nitric oxide in tobacco smoke. Thisis shown by the German cultivar Bad Burley E in the harvesting grade "Ieaf" and "tips". Altogether the Burley cultivars are very high in nitric oxide content. An unexpectedly low content was found in the German Geudertheimer cultivars and in the Greek breeding line 3/8from the year 1987. Independently of fertilization and harvesting grades it has been foundthat the nitric oxide content is significantly correlated to differences in the tobacco cultlvars. Therefore, the nitric oxide content has to be considered as a quality and breeding attribute.
NO pg/cig300,---------------------------,
250
200
150
+
-1-
TIPS
LEAF
Graph 29: Nitric Oxidein Smoke from BurleyCultivars 1987;LEAF and TIPS, NFertilization 0 - 250 kgNlha
100
50
200 250
N kg/ha
15010050O'--------------------------!
o
46
NO j.lg/ha400
Graph 30: Nitric Oxide
Din Tobacco Cu/tivars
3001987; Overall Range GREECE GERMANYfrom all HarvestingGrades; N-Fertilization 200 D D0- 250 kg N/ha
D100 c::::J D c:J
01/B 2/K 3/S 4/V 5/R Burley Geudert30 40 30 30 180 180 180
N kg/ha
6 Tobacco BreedingThe main goals in tobacco breeding43, 44, 45) are high yields, differentiation from existingvarieties, rigidity of the plant and resistance to tobacco diseases. Characterization canadditionally be done according to the chemical point of view in analyzing the chemicalcompounds.
After a three years lasting plantation trial the breeder will get from the German FederalAgency of Varieties a cultivar protection for ten years, if there is a significant improvementin breeding about the outer and inner quality of the new tobacco cultivar compared to oldervarieties. Due to the close relation between the modern tobacco cultivars, this is withoutanalytical methods rarely to achieve.
6.1 Identification of Tobacco Varieties
In Germany in three cases the chemical compounds of tobacco varieties are used for theidentification of new breeding lines: Varieties that are low in nicotine content and varietiesthat produce nornicotine from nicotine during the air drying process, they are described according to the alkaloid contents; Virgin varieties are described according to the duvatriendiol amount.
6.2 Secondary Plant Compounds of Content
Because the metabolism of the tobacco plant, - responsible for the existing amounts -,chemical compounds as alkaloids and duvatrienediols, which pertaine to the quality of thetobacco sample, are secondary plant compounds of content and vary according to the climate, the environment, the plantation and harvesting procedures; normally they can't beused for an identification of the tobacco varieties. This is only achieved by the analysis ofthe genetic code, - the DNA in chromosomes -, or by the analysis of a special group ofplant cell proteins, which are directly generated by the DNA.
6.3 Isoenzymes and Alloenzymes
The differences found in these specialized protein types as peroxidase and polyphenol oxidase directing the metabolism in the plant cell are called "isoenzymes" or "alloenzymes".
47
They are genetically determined and the result of the expression of the allelic genes46). Thewhole genotypical expression of the isoenzymes is best visible in the ripe tobacco plant.Electrophoretically separated tobacco peroxidase and polyphenoloxidase show onlyquantitative and no qualitative expression differences in different stages of the plant development as S. J. Sheen has pointed out47).
The isoenzymes are determined in the green tobacco leaf shortly before their maturity. Forthe identification of the cultivars, the quantity of the isoenzymes in the patterns is not so important as the quality differences in the patterns produced by the single cultivar or appearing as additional patterns in the electrophoregram of the F7-generation in comparison tothe parents. According to the complexity of these protein compounds they are named according to their function; the therm "isozyme system" is often used for them.
6.4 Methods
6.4.1 Protein Extractipn Procedures
Seed Proteins
According to H. Stegemann et a1.48) the seed proteins were ground in a mortar, washedwith cold acetone (- 30°C, dried over Na2S04 free from water) and extracted withtris-borate buffer pH 8.9. Until to the further preparation the residue was stored in a freezer(- 20°C).
Green Tobacco Leaves
The protein extraction of green tobacco leaves was done according to M. Abet et aI.49), thedialysis and concentration procedure according to T. Cooper50) and the measurement ofthe protein concentration according to N. E. Bradford 51).
Picture 3: Working Place for Electrophoresis of Proteins Consisting of Desaphor VA 150Chamber, Desatronic 3000 / 200 Power Supplyand Frigostat
48
Using a cold mortar (- 30°C) six frozen green tobacco leaves without midrib, cut in smallpieces, were ground to a fine powder with liquid nitrogen, stored over night in a freezer,filtrated and washed with a cold acetone-water mixture (4:1, - 30°C) and cold acetone(- 30°C). The tobacco powder was homogenized in Mcilivaine Buffer 0,1 M, pH 2.8, containing dithiothreitol; the mixture then centrifuged at 15000 rpm, the supernatant filtrated ina dialysis tube, dialyzed against tris 5 mM-glycine 38,5 mM buffer pH 2,8 to pH 4, concentrated against polyethylene glycol 20000 to a content of 2 ml, centrifuged at 1500 rpm, theprotein content measured to 0,1 %, and stored in a freezer at - 30°C.
Air-Dried and Milled Tobacco Samples
The procedure used for the extraction of the proteins from air-dried and milled tobaccosamples equals the Rrocedure for proteins of green tobacco leaves. "Acetone dry powder"according to A. Gorg52) had to be prepared additionally: Using a cold mortar (- 30°C) the tobacco meal was ground with cold acetone (- 30°C, dried over Na2S04 free from water), thetobacco slurry filtrated, washed twice with a cold acetone-water mixture (4:1 vt»,- 30°C), three times with cold acetone (- 30°C), dried by aspiration, freed from smell in avacuum-desiccator and stored in a freezer (- 20°C).
6.4.2 Electrophoresis Procedure
After previous work done with dry tobacco showing the degradation of tobacco proteins indark air cured tobacco during the natural fermentation process, for which an isoelectric focusing method with Sephadex G 75, pH gradient 2 - 11, was developed53), and after firstattempts to separate proteins of tobacco seeds using the isoelectric focusing method withpolyacrylamide gel slabs, pH gradient 6 - 954), the electrophoresis method was used forthe separation of proteins and enzymes.
The electrophoresis with polyacrylamide gel slabs, with its fewer number of bands in theprotein and enzyme profiles than in that ones of the isoelectric focusing method, is easierfor the characterization of tobacco cultivars. For tobacco cultivar identification seven publications in the literature were found using the polyacrylamide gel electrophoresismethod55). The most publications describe the isoelectric focusing method as the methodof choice for other cultivars56).
Picture 4: Desatronic IT Integrator for the Quantitative Estimation of Protein Profiles
49
Since 1992 - considering the toxicity of polyacrylamide gel slabs and the waste problem for tobacco cultivar identification the isoelectric focusing method with commercial available agarose gel slabs is used, too.
Electrophoresis was performed using a Desaphor VA 150 chamber, a polymerization stand,a peristaltic pump Desaga STA, a magnetic stirrer, a Desatronic 3000/200 power supplyand a Frigostat (see picture Nr.3) in combination with a Desatronic IT integrator (see pictureNr.4).
The electrophoresis chamber was designed to hold two vertical polyacrylamide gel slabs.Each slab could hold up to twenty four samples.
The procedure for casting the gels was adapted from the operating instructions for theelectrophoresis equipment of the company Desaga57).
The used solutions were modified according to H. Stegemann et a1.48)and K. Altland 58) tofit the procedure.
The concentration of the acrylamide and bisacrylamide (T %) and the amount percentageof the N, N'-Methylene-bis-acrylamide (bisacrylamide (C %)) was calculated as follows:
T = (A + B) x 100 1V C =B x 100 1(A + B)A =g Acrylamide B =g Bisacrylamide V =Volume of the solution
For proteins from tobacco seed a SDS gradient gel, T =8 % till 25 %, C =5 %, electrophoresis system was used.
For proteins from green tobacco leaves, air dried and milled tobacco samples a discontinuous gel electrophoresis system was used consisting of a separation gel (TG : T =10 %,C =5 %, pH =9.1) and a concentration gel (KG: T =2.5 %, C =7.5 %, pH =6,7).
A tris-HCI buffer (pH 9,1) was used in the separating gel and a tris-HsP04 buffer (pH 6,7) inthe concentration gel. All gels were ammonium persulfate catalyzed. Sample density wasincreased with 40 % sucrose helping to prevent samples from migration between the wells.
The lower electrode buffer was tris-HCI (pH 8.1) and the upper electrode buffer tris-glycine(pH 8,9).
Gels were run from cathode to anode at a voltage of 500 volts and a current of 100 mA.Electrophoresis was ended when the marker dye (0,01 % bromophenol blue) had migratedto the bottom of the gel.
The gels were removed from the cells and appropriately stained.
6.4.3 Isoelectric Focusing Procedure
Isoelectric focusing was performed using a horizontal electrophoresis unit Desaphor HF, a3000-Volt power supply Desatronic, a circulating water bath Frigostat, a third electrode forDesaphor HF (see picture Nr. 5).
The procedure for isoelectric focusing was adapted from the operating instructions for theelectrophoresis equipment of the company Desaga57) and with commercial available agarose gel slabs, pH gradient 3 - 10 plus spread at pH gradient 3 - 7 (HyPure Gel Desaga Nr.150009) according to the procedures for the identification of corn varieties from the company Isolab inc.59Jand the identification of potato varieties from "HyPure Procedures" submitted from the company Desaga60).
6.4.4 Protein and Enzyme Staining Techniques
For total protein staining Coomassie Brilliant Blue was used normally, but for small proteinamounts the very sensitive silver staining according to E. Hempelmann, M. Zwanzig and
50
Picture 5: Desaphor HF for Isoelectric Focusing of Proteins
M. MUller61) was used. Silver staining can be used for SDS gels, IEF gels and PAGE gels(native).
For malate dehydroqenase, esterase and peroxidase different staining techniques according to G. J. Brewer6'2) were used.
Malate DehydrogenaseThe staining solution for malate dehydrogenase contained 0.05 M tris pH 7.0, p-nitrobluetetrazolium, phenazine methosulfate, malic acid, and diphosphopyridine nucleotide.
EsteraseFor esterase 1% 1,2-naphthyl acetate solution was used as the substrate that a goodisoenzyme profile resulted. Since 1,2-naphthyl acetate is not very soluble, it was made upin 70% acetone-aqua dest. with the 1,2-naphthyl acetate being dissolved in the acetonefirst.
PeroxidaseThe substrate used for the detection of peroxidase isoenzymes was benzidine. Benzidineproved to be good in both the number and clarity of bands produced.
6.4.5 Documentation
After extraction, clean-up and concentration procedures, the isoenzymes and alloenzymeswere electrophoretically separated and densitometrically scanned (see picture Nr. 6).
Photographs were taken and diagrams were drawn of all the gels. The estimation wasmade from the electrophoregrams, the relative mobility (Rt) for each band calculated and
51
protein profiles drawn with the graphic program Chart from the company Microsoft (seefigures Nr. 1 and 2). Rf can be defined as:
distance the protein migratedRf = distance the dye migrated
1980; -+9
2. 00 (l'-r-----'--Itt-'--'-----'-----'-__+_ 2. (l 0 0
1982
1 • 6 (1 '~'--.J 1.600
1.2C'u) 1. ,0- _ 1.200
,,
L~. 80.3---1
I
O.40aJ
(t.oe0
75.0
: j
; :
:100.0
1~ ii.: '. ! ~9: ~
O.8(1(l
0.400
0.000
~3. 200
144.9
o,,~ i \ ~ , .• "
,.,,~ u&.~.I.~.J.Lffi!>_ e , '"
Picture 6: Densitometric Estimation of Electrophoregrams of Tobacco Seed Proteins Bedischer Geudertheimer of two Different Years
6.5 Results and Discussion
6.5.1 Tobacco Seed
To their genuineness different dark or bright tobaccos were examined first in protein bandsof the tobacco seeds of two crops, whose harvest had a difference of two years. Seeds offormer crops were examined because during the second year after the harvest there is anoptimum of germination. The above examined seeds were proved to be genuine becauseof the identical protein bands with an exception of Geudertheimer III and Badischer BurleyE (see figures Nr. 1 and 2).
52
1 Bad. Geuderth.2 Geuderth. III3 Pereg 2344 Perega5 Bad. Burl. E6 B 57 Bursanica 2178 Burlina 1839 Virgin Aurea10 Bel 10
1098765432
°
0,4
0,2
0,3
0,1
0,7
0,6
0,9
0,8
Rf 0,5
Figure 1: Seed proteine profiles from different Cigar tobaccos,Burley and Virgin cultivars; harvested 1980
Seed protein profilesfrom the harvestingyears 1980 (see figureNr. 1) and 1982 (seefigure Nr. 2) show thesame profiles with theonly exception of thecultivar Virgin Aurea(profile Nr. 9), due tothe impurity of theseed.
From the protein profiles, no significantidentification of singlecultivars is possible,only the tobacco typesare distinguishableand their correlation tothe blue mold resistance (Rf-region 0.4).Varieties resistant against the blue mold disease from varieties not resistant could be identified. So the resistant varieties Bel 10, Burlina 183, Bursanica 217, Perega and Pereg 234appear to have one protein band in Rf-rate 0,6 (see figures Nr. 1 and 2).
6.5.2 Green Leaf
1 Bad. Geuderth.2 Geuderth. III3 Pereg 2344 Perega5 Bad. Burl. E6 B 57 Bursanica 2178 Burlina 1839 Virgin Aurea10 Bel 10
°
0,9
0,8
0,7
0,2
0,1
0,4
0,6
0,3
Rf 0,5
1 2 3 4 5 6 7 8 9 10
Figure 2: Seed proteine profiles from different Cigar tobaccos,Burley and Virgin cultivars; harvested 1982
The Burley tobaccowas harvested fromthe experimental fieldof Forchheim, BadenWUrttemberg, in 1989,as mature green tobacco of the stalkposition "lugs".
Individual varieties orrelative breeding linesin dark and light tobaccos could be ident-ified because of protein and isoenzyme bands in the green leaf. A relation to the proteinbands was observed just before the ripening of the green tobacco leaves in the prime "tip".The varieties Badischer Burley E, Burlina '83 and Bursanica 217 could be identified only bytheir protein bands while the breeding lines B 520, B 21, Pereco, B 535 and B 535 Bursa
Green tobacco protein and isoenzyme profiles of a cultivar vary with the plantation area,the harvesting year, the stalk position and the maturity of the leaf. Leaf protein profiles fromdifferent Burley cultiv-ars are shown in figures Nr. 3 and 5. Additionally, leaf isoenzymeprofiles of peroxidaseare shown in figuresNr. 4 and 6.
53
Figure 3: Leafprotein profiles from different Burley cultivars; fieldexperiment 39/89, lugs, green tobacco
86: B 520-NA
665: B 5
687: G 37
694: Md B72
67B: PerekD-NA
B4: R-220lBursal
693: Md 341
646: Bad.Burl.E
665 669 678 684 686 687 693 694 646 650 660: Burley 21/.0
0.8
0.2
0.4
0.0 could be identified inrelation to proteinbands and peroxidaseband (see figures Nr. 5and 6).
All new breeding linesshow protein profiles(figure Nr. 3) differentfrom the reference cultivars B 5 and Bad Burley E. Additionally, it isobserved that the protein profiles of thebreeding lines are different from each otherexcept Nr. 693 and 694(see figure Nr. 3).
To differentiate between these breeding lines the peroxidase profiles have to be considered(see figure Nr. 4). All Burley breeding lines show a typical band at the Rf-region of 0.70 0.74 (see figures Nr. 3 and 5) to the reference cultivars B5 and Bad Burley E.
Figure 4: Leaf peroxidase profiles from different Burley cultivars;field experiment 39/89, lugs, green tobacco
665: B 5
678: ParekD-NA
84: R-220 IBursal
86: B 520-NA
6B7: G 37
693: Md 34\
694: Md 872
646: Bad.Burl.E
660: Burley 21
665 669 678 684 686 687 693 694 646 650/.0
0.8
0.2
0.4
0.0
6.5.3 Dry Tobacco
After harvesting of tobacco leaves during the drying process to a water content below10%, during their curing or fermentation and storage process an enzymatic and oxidantdecomposition of proteins is occurring, described in a previous publication of H. Delinceeand P. Range53). Therefore, differing protein and isoenzyme profiles between green anddried tobacco are observed: whereas normally the profiles of dry tobacco show fewer
bands then the greenones (see figures Nr. 7and 6) and the proteinprofiles more bandsthan the isoenzymeprofiles (see figures Nr.7 and 8).
The identification ofdifferent tobacco varieties based on proteinand isoenzym bandswas done in dry andground tobaccosamples of the prime"leaf" coming from experimental plantationsof the LAP (see figuresNr. 3 -16).
All the varieties were identified according to their protein bands (see figures Nr. 11, 12, 13and 14).
Also the question about the genuineness of "F-taler" cultivar from 1986 compared with theone of 1978, both planted in an experimental cultivation in 1988, was examined in dry tobacco comparing the different protein bands (see figure Nr. 11, profile Nr. 775 profile Nr.
54
56: Md 609
561: B 5201B.21
565: B.211B 535
591: PerekDlB 535
696: B 535lBuree.
46: Bed.Burl.E
652: Burllne
654: Bureen Ice
46: Bed.Burl.E
50: BurlBY 21
52: Burllne
54: Bureenlce
65B: Md 609
5BI: B 5201B.21
565: B.211B 535
596591585581658654652646
0.4
1.0
0.8
0.2
0.0
0.0
0.4
0.2
Figure 5: Leafprotein profiles from different Burley cultivars; fieldexperiments 35 and 38/89, lugs, green tobacco
776): It was found outthat they are geneti-cally different to-baccos. Theisoenzymes and protein bands in the greenleaf can be identifiedfrom the ones of thedry material when itcomes to their numberand their position. Inthe few bands that canfound in theisoenzymes profilesthe loss of peroxidasewas characteristic (seefigure Nr. 12).
Although protein and isoenzyme profiles of dry tobacco fewer bands than profiles of greentobacco leaves are showing, the tobacco varieties can be identified in the dry material. Forexample the breeding lines with profile Nr. 782 and Nr. 783 show no differences in the protein and isoenzyme profiles: this leads to the conclusion that these breeding lines are fromthe same origin (see figures Nr. 11 and 12); the breeding lines with profile Nr. 775 and Nr.776 have been expected to be the same breeding line, but it is obvious from the proteinprofile that they are different (see figure Nr. 12).
According to this anidentification of thebreeding lines can bedone in dry tobacco asin green tobaccoleaves by the proteinprofiles in combinationwith the isoenzymeprofiles.
7 Conclusion
0.8
1.0646 650 652 654 658 581 585 591 596
591: PerekDlB 536
596: B 5351Buree.
Figure 6: Leaf peroxidase profiles from different Burley cultivars;field experiments 35 and 38/89, lugs, green tobacco
As it is shown in thisstudy, an identificationof tobacco breedinglines of the different tobacco types is poss-ible by their protein profiles in combination with the isoenzyme profiles of peroxidase ingreen tobacco leaves and in dry tobacco, belonging to tobacco from the same area andenvironment, harvesting year and stalk position.
Based on these findings for old and new breeding lines of Cigar, Burley and Virgin tobaccopresented in figures Nr. 1 to 16, it is feasible that the electrophoretic procedures will become a practical meaning as a method of choice for the cultivar identification in N. tabacum: Together with the quality analysis in tobacco and tobacco smoke an identity-card forevery culture can be made.
55
0.0
0.2
0.4
Rf0.6
0.8
1.0590 591 592 593 62
690: Bursan.217
691: Burllna 183
692: B 620
693: Bad. Burl. E
62:Md 609
Figure 7: Leaf protein profilesfrom different Burley cultivars;field experiment 37/88, leaf,dry tobacco
690: Bursan.2170.0
0.2
0.4
Rf0.6
0.8
1.0590 591 592 593 62
Figure 8: Leaf peroxidase pro691: Burllna 183 files from different Burley cui-692: B 620 tivars; field experiment 37/88,693:Bad. Burl. E leaf, dry tobacco
62:Md 609
0.0
0.2
0.4
Rf
0.6
0.8
615: Burlay 49
619: While Burley
626: Md B72
627: Maryland
62B: Sumat.Schl.
Figure 9: Leaf protein profilesfrom different Burley cultivars;field experiment 39/88, leaf,dry tobacco
/.0
0.0
0.2
0.4
Rf0.6
0.8
1.0
56
6/5
6/5
619
6/9
626
626
6Z1
6Z1
628
628
616: Burley 49
619: While Burley
626: Md 872
627: Msryland
628: Sumat.Schl.
Figure 10: Leaf peroxidaseprofiles from different Burleycultivars; field experiment 39/88, leaf, dry tobacco
0.0
O.C
OA
0.8
1.0775 776 782 78J 786 787
775:F·lolor \978
776:F·lolor \966
782: Cobol
783: Dobltcener
786: Trumpl
787:Skronlowskl
Figure 11: Leaf profiles fromdifferent Cigar tobacco cuitivars; field experiment 49/88,leaf dry tobacco
0.0
0.2
0.4
0.8
1.0
0.0
0.2
0.4
0.8
1.0
0.0
0.2
0.4
0.8
1.0
775
754
J95
776 782
759
J46 J97
78J
618
786
402
787
62J
405
776:F·leter \978
776:F·lotor \986
782: Cobol
783: Debltconor
786: Trumpf
787:SkronlOWBkl
754: Bod,Geuder,
759: Z 149
618: 8urlw 21
623: KY 6\
395; Gold A
396: Pelt'll
397: Robuolo
402: V 3
405: V It
Figure 12: Leaf peroxidaseprofiles from different Cigartobacco cu/tivars; field experiment 49/88, leaf, dry tobacco
Figure 13: Leaf protein profiles from different Cigar tobaccos and Burley cu/tivars;field experiment 39 and 47/88,leaf, dry tobacco
Figure 14: Leaf protein profiles from different Virgin cuttivars; field experiment 29/88,leaf, dry tobacco
57
0.0
0.2
0.4
Rf
0.6
0.8
1.0
0.0
0.2
0.4
0.8
1.0
618
618
623
623
634
750
750
754
754 757
757
759
759
618: Burley 21Figure 15: Leaf protein pro-
623: KY 61 files from different Cigar to-634: K35A baccos and Burley cultivars;750; Geuderlh.11I field experiments 39 and 471754: Bad.Geudor, 88, leaf, dry tobacco757: Perege
759: Z 149
61B: Burley 2\623' KY 61 Figure 16: Leaf peroxidase
. profiles from differet Cigar to-760: Geuderlh.1I1 baccos and Burley cultivars;764: Bed.Geuder. field experiments 39 ad 47188,767: Pereg. leaf, dry tobacco769: Z 149
Figure 16: Leel peroxldeee prollle. lrom dlllerent Clger lobaccoe end Burleycuilivars; lIeld experiments 39 and 47{BB.leaf.
58
EXPERIMENTAL
8 Nitric Oxide Analysis
8.1 BAT Nitric Oxide Analyzer in Combination with Smoking Machine FiItrona SM 302(see operating instructions30))
8.1.1 Additional Equipment required
- 1 mV or 10 mV recorder - with speed of response at least 0.5 second full scale deflection. A suitable recorder can be supplied if required.
Calibration gases - suggested as follows:1 cylinder 100 vpm nitric oxide in nitrogen.1 cylinder 400 vpm nitric oxide in nitrogen.1 cylinder 700 vpm nitric oxide in nitrogen.1 cylinder 1000 vpm nitric oxide in nitrogen.Certificate of analysis to be supplied by the manufacturer,
4 stainless steel, corrosion resistant regulators suitable for use with the above mixtures.
Cylinder of oxygen.
Cylinder of nitrogen.
Regulators for oxygen and nitrogen cylinders.
Optional quick connect unions for calibration gases.4-SS-QM1-81-200 Swagelock female.1-SS-QM2-S-200 Swagelock male.With stainless steel or P.T.F.E. tubing for connection to regulators.
8.1.2 Setting Up and Calibration Instructions
- Make all connections described in the installation procedure. (1)
Switch on the nitrogen supply. (2)
Using the instrument controls, set the nitrogen pressure to 60 p.s.i.g. Measure the nitrogen flow rate from the reaction cell, exhaust vent at the rear of the analyzer. The flowrate should be 7.2 x 10-3 m3 h(1 (120 cm3 mln"). If not correct, unlock by lifting smalllever on nitrogen flow controller dial and adjust flow rate as necessary. (3)
Switch on the oxygen supply. (4)
Using the instrument control, set the oxygen pressure to 10 p.s.i.g. Measure the combined nitrogen and oxygen flow rate from the reaction cell exhaust vent.The total flow rate should be 9.0 x 10-3 m3 h(1 (150 cm3 rnln"), If not correct, unlock bylifting small lever on oxygen flow controller dial and adjust flow rate as necessary. (Thisflow rate is also preset and only minor adjustment should be necessary.) Lock the flowcontroller. (5)
Switch on the MAINS and FAN/OZONE switches and leave for 20 minutes warm uptime. (6)
Switch on and zero the recorder, following the instructions given in the recorder manual.Return the recorder to the measuring mode. (7)
59
- Set the GAIN control to a suitable value. (8)
- Zero the recorder using the analyzer ZERO control. (9)
- Connect one of the standard gas mixtures to the stainless steel 3-way tap in the smok-ing machine analyzer link line, using a length of RT.F.E. tubing and stainless steel fittings.Because of the nature of RT.F.E., a short length of stainless steel tubing should be inserted into the end of the RT.F.E. tubing before making any connections. (10)
- Check that the SLIDER SAMPLE VALVE is in the withdrawn position and the TESTswitch is in the SAMPLE position. (11)
- Turn the 3-way tap on the smoking engine to allow a standard gas to flow through thesample line, open the needle valve (if fitted) on the pressure regulator of the standard gasmixture, and set the pressure to approximately 5 p.s.i.g. (This should result in a flow gasthrough the pressure valve.) (12)
- Allow sufficient time for the lines to be thoroughly purged with gas, turn the 3-way tap tothe "Off" position, wait 3 - 5 seconds to allow the pressure in the line to come to atmospheric pressure, press the GAS SAMPLE VALVE firmly in. (13)
- After the peak is recorded, withdraw the gas SAMPLE VALVE, switch the 3-way valve topermit a further sample of standard gas to flow through the system. (14)
- Repeat Instruction (13). If necessary, adjust the attenuation to achieve an acceptablepeak height. (15)
- Continue to repeat Instructions 13 and 14 until three successive peaks of similar heighthave been obtained. Read off the mean peak height. (16)
- Repeat instructions 10 - 16 for the remaining three standard gas mixtures. (17)
- Switch off all the cylinders of standard gas mixtures. (18)
- Plot the calibration graph of nitric oxide concentration (vpm) certified by the manufac-turer against mean peak height (adjusted for attenuation). This graph should belinear. (19)
8.1.3 Smoking Procedure
The following instructions apply to the procedure used with a Cigarette ComponentsModel 302 smoking engine.
WARNING Ensure that the 3-way tap is turned to allow vapor phase to pass from thesmoking engine to the nitric oxide analyzer before switching on the smokingengine.
- Set up the smoking engine in the usual way. Allow at least a 15 minute warm up time before checking puff volume. Zero the puff counter.
- Attach a prepared Cambridge filter holder to each of the 8 ports. Insert a cigarettemarked with the appropriate butt mark into each holder.
- Set the attenuation to the appropriate value. This value will be known beforehand afterexperience has been gained with the technique and its application to various cigarettebrands and types.
- Set the TEST switch to the RUN position. This will result in the solenoid valve operatingonce. Wait until this cycle has been completed before proceeding to the next instruction(approximately 15 seconds).
- Follow the smoking engine operating instructions to light cigarettes.
60
- The nitric oxide analyzer will sample after each puff automatically. Ensure that the peakis clearly recorded "on scale" and if necessary adjust the attenuation.
- Allow smoking to continue until the butt mark is reached. All cigarettes must be allowedto take the same number of puffs and thus the cotton puff-termination device cannot beused. Smoking is terminated when the average butt mark is reached. Typically some willbe just over and others will be just under the butt mark.
- With all the cigarettes extinguished, allow the smoking engine to take three clearingpuffs, recording the nitric oxide concentration as above.
- Calculate an average peak height (allowing for attenuation) by adding together all of theindividual peak heights, including the clearing puffs, and dividing by the number of litpuffs.
- Using the standard calibration graph, read off the average concentration of nitric oxide inthe vapor phase.
- Record barometric pressure and room temperature adjacent to the instrument.
- Calculate the delivery of nitric oxide per cigarette from the formula - mass per cigarettebasis -.
Nitric oxide (l1g/Cigarette) =A x N ~~3x+0~13470
where A = average concentration (vpm)N = number of lit puffs per cigarette (including 3 clearing puffs)P = barometric pressure (kPa)T = room temperature (C).
8.2 Monitor Labs. Nitrogen Oxides Analyzer 8440E in Combination withSmoking Machine Borgwaldt RM 20 CS and Automatically WorkingNitrogen Flushing Unit(see operating tnstructlons-'': 41))
The automatically working nitrogen flushing unit consists of two three-way valves and oneback pressure valve from stainless steel. The one in combination with the back pressurevalve is electrically operated from the pump stroke unit of the smoking machine, the othermechanically operated with the pressure of the mainstream smoke (see graph I). TheP.T.F.E. tubings for connection from the smoking machine to the nitrogens oxide analyzerhas a stagnant volume of 5 ml. During the draw intermission of the smoking machine theconnecting tubes and the nitrogen oxides analyzer are flushed with nitrogen gas of highestpurity between every puff of the smoking machine.
8.2.1 Additional Equipment required
- Electrically operated three-way valve from stainless steel.
Mechanically operated three-way valve from stainless steel.
Back pressure valve from stainless steel.Optional quick connect unions for calibration gases.With P.T.F.E. tublnq 0,4 cm in diameter for connections.
1 mV or 10 mV recorder - with speed of response at least 0.5 second full scale deflection. A suitable recorder can be supplied if required.
Calibration gases - suggested as follows:1 cylinder 100 vpm nitric dioxide in nitrogen.
61
1 cylinder 100 vpm nitric oxide in nitrogen.1 cylinder 500 vpm nitric oxide in nitrogen.1 cylinder 1000 vpm nitric oxide in nitrogen.Certificate of analysis to be supplied by the manufacturer.
- 4 stainless steel corrosion resistant regulators suitable for use with the above mixtures.
- Cylinder of synthetic air.
- Cylinder of highly purified nitrogen.
- Regulators for synthetic air and nitrogen cylinders. Optional quick connect unions forcalibration gases.4-SS-QM1-B1-200 Swagelock female.1-SS-QM2-S-200 Swagelock male.With stainless steel or PT.F.E. tubing for connection to regulators.
8.2.2 Setting Up and Calibration
- Make all connections described in the installation procedure (see operating instructions 34,41)).
- Calibrate from the smoking port described in the calibration procedure (see operating instructions34,41)).
8.2.3 Smoking Procedure
The following instructions apply to the procedure used with the RM 20 CS cigarette smoking machine.
- Set up the smoking engine in the usual way. Allow at least a 15 minute warm up time before checking puff volume. Zero the puff counter.
- Attach a prepared Cambridge filter holder to the port. Insert 5 cigarettes marked with theappropriate butt mark into each holder.
- Set the attenuation to the appropriate value. This value will be known beforehand afterexperience has been gained with the technique and its application to various cigarettebrands and types.
- Follow the smoking engine operating instructions to light cigarettes.
- The nitrogen oxides analyzer will sample after each puff automatically. Ensure that thepeak is clearly recorded and if necessary adjust the attenuation.
- Allow smoking to continue until the butt mark is reached. Smoking is terminated whenbutt mark is reached.
- With all the cigarettes extlnqulshed, allow smoking engine to take three clearing puffs,recording the nitric oxide concentration as above.
- Calculate an average peak height (allowing for attenuation) by adding together all of theindividual peak heights, including three clearing puffs, and dividing by the number of litpuffs.
- Using the standard calibration graph, read off the average concentration of nitric oxide inthe vapor phase.
- Record barometric pressure and room temperature adjacent to the instrument.
62
- Calculate the delivery of nitric oxide per cigarette from the formula. Calculation of nitricoxide yield - volume per cigarette basis - at 101,3 kPa and O°C:
Cobs x V x N x P x 273III nitric oxide per Cigarette = ---=-3------~
qx10 x101,3x (t+273)
Short formula:
CobsxNxpIII nitric oxide per Cigarette = t 273 x F
q x (+ )
with:
F = 35 x 273
103 x 101,3
0,012572 (1 cigarette)= 0,050289 (4 cigarettes)= 0,100576 (8 cigarettes)
Calculation of nitric oxide yield - mass per cigarette basis - at 101,3 kPa and O°C:
Cobs x V x N x P x 273 x 30Ilg nitric oxide per Cigarette
q x 103 x 101,3 x (t + 273) x 22,4
Short formula:
with:
Ilg nitric oxide per CigaretteCobs x N x P----~xFqx(t+273)
F = 35 x 273 x 30
103 x 101,3 x 22,4
0,01684 (1 cigarette)= 0,06736 (4 cigarettes)
0,13472 (8 cigarettes)
9 Electrophoresis
9.1 Protein and Enzyme Extraction
9.1.1 Equipment
CentrifugeMicrocentrifugeMortarPhotometerWater Yet Pump
63
FreezerSteam BathPetri DishesVacuum DesiccatorPaper Filter1,5 ml Microcentrifuge TubesPlatinum ConeDialysis Tube, 2,5 em in Diameter Serva Nr. 44144BeakersVolumetric Flasks
9.1.2 Buffers
Tris-Borate Buffer pH 8.9Mcilivaine Buffer, pH 2.8 (Merck)Glycine Buffer pH 2,8 (Merck)SDS (Sodium Dodecylsulfate)
9.1.3 Reagents
Albumin~-Mercaptoethanol
Polyethylene glycol 20000DithiothreitolEDTA (Ethylendiamine tetraacetic Acid, disodium salt)SucroseAcetone95% Ethanolcone. Phosphoric AcidSodium Sulfate free from waterSodium Hydroxide
9.1.4 Staining Salts
Bromophenol BlueCoomassie Brilliant Blue G 250 (C. I. 42655)
9.1.5 Sample Preparation
Stock Solution
0,1 M Mcilivaine Buffer, pH 2.8, 10 mM Dithiothreitol:
- make a mixture84,15 ml 0,1 M (21,0 g/I) Citric Acid * H2015,85 ml 0,2 M (35,6 g/I) Na2HP04 * 2 H200,15 g Dithiothreitol
Tris-Glycine Buffer, pH 8,3:
5 mM Tris (0,61 g/I)38,5 mM Glycine (2,89 g/I)10 mM Dithiothreitol (1,54 g/I)
64
Tobacco Seeds
- Weigh out 500 mg of tobacco seeds.
Grind in an on dry ice pre-chilled mortar.
Transfer with cold acetone (- 30°C, dried over Na2S04 water-free) to a 5 ml syringe tubeprepared at the bottom with a fast running paper filter.
Wash with cold acetone (- 30°C) until the filtrate is clear.
Dry the residue by aspiration with the aid of a water yet pump and store in a freezer(- 20°C) until use.
Make the solution:1 ml tris-borate buffer, pH 8,9, (see 9.2.5)2 g SDS2 g ~-mercaptoethanol
some crystals bromophenol blueaqua dest. to make to 100 ml
Add 1 ml of the solution to a 30 mg seed extract in a 1,5 ml microcentrifuge tubes.
Heat 15 minutes on a steam bath, centrifuge.
Add to an aliquot sucrose to a final concentration of 10% before applying 10 ilion theconcentration gel for electrophoresis (see 9.2.8).
Green Tobacco Leaves
- Cut in small pieces six frozen green tobacco leaves (harvested from the same parcel andstalk position) without midrib.
Grind with liquid nitrogen in a mortar until the leaf tissue becomes a fine powder.
Store over night in a freezer at - 20°C.
Pre-chill the mortar and pestle with dry ice.
Filtrate and wash with suction the tobacco powder through a filter paper (200 mm in diameter, Schleicher and SchOll 1460; with the aid of a platinum cone), wash twice with acold acetone-water mixture (- 30°C, 4:1 vlv) and three times with cold acetone (- 30°C).
Dry the residue by aspiration with the aid of a water yet pump, transfer to Petri dishes,dry in a vacuumdesiccator free from smell and store the sample in a freezer at - 20°C.
Homogenize in a cold mortar 50 g of the tobacco powder in 90 ml Mcilivaine Buffer0,1 M, pH 2.8, containing dithiothreitol 10 mM (1 mllg fresh tissue).
Centrifuge the mixture at 16.000 rpm, 4°C, for twenty minutes.
Filtrate the supernatant with a folded filter in a dialysis tube (50 cm in length, 0,21 cm indiameter, SERVA Nr. 44144, (cleaning procedure, see 9.1.6).
Dialyze for 4 to 5 hours against tris 5 mM-glycine 38,5 mM buffer pH 8,3, dithiothreitol1 0mM, to pH 4,3 - 4,5.
Let drip off the dialysis tube and cover several times with polyethylene glycol 20000,SERVA Nr. 33138, till a content of 2 ml.
Centrifuge at 1500 rpm.
Measure the protein content in the supernatant, - the 0,2 ml aliquot must have at least150 Ilg protein content -, (procedure, see 9.1.7) and store in a freezer at - 20°C.
Add to an aliquot sucrose to a final concentration of 10% and apply 10 fll on the concentration gel.
65
Air-Dried and Milled Samples
- Pre-chill the mortar and pestle with dry ice.
- Weigh out 50 g of grounded leaf tissue.
- Grind with 100 ml cold acetone (- 30°C dried over Na2S04 free from water) until the to-bacco meal becomes a slurry. The mortar should be on dry ice.
- Transfer the tobacco slurry quantitatively in a beaker. Keep over night in a freezer(- 20°C).
- Transfer and filtrate with suction the tobacco slurry through a filter paper (200 mm indiameter, Schleicher and SchOll 1460; with the aid of a platinum cone), wash two timeswith a cold acetone-water mixture (- 30°C, 4:1 v/v) and three times with cold acetone(- 30°C).
- Dry the residue by aspiration with the aid of a water yet pump, transfer to Petri dishes,dry in a vacuumdesiccator free from smell and store the sample in a freezer at - 20°C.
- Homogenize in a cold mortar 10 g - 15 g of the tobacco powder in 50 - 70 ml McilivaineBuffer 0,1 M, pH 2.8, containing dithiothreitol 10 mM (1 ml/g fresh tissue).
- Centrifuge the mixture at 16.000 rpm, 4°C, for twenty minutes.
- Filtrate the supernatant with a folded filter in a dialysis tube (50 em in length, 0,21 em indiameter, Serva Nr. 44144) (cleaning procedure, see 9.1.6).
- Dialyze for 4 to 5 hours against tris 5 mM glycine 38,5 mM buffer pH 8,3, dithiothreitol1 0mM, to pH 4,3 - 4,5.
- Let drip off the dialysis tube and cover several times with polyethylene glycol 20000,SERVA Nr. 33138, till a content of 2 ml.
- Centrifuge at 1500 rpm.
- Measure the protein content in the supernatant, - the 0,2 ml aliquot must have at least150 /1g protein content - (procedure, see 9.1.7) and store in a freezer at - 20°C.
- Add to an aliquot sucrose to a final concentration of 10% and apply 10 ilion the concentration gel.
9.1.6 Cleaning Procedure for the Dialysis Tube (make in advance)
Heat with stirring the dialysis tube for thirty minutes in EDTA 0,5 M, pH 7 - 9 (bring to solution with cone. sodium hydroxide; the solution should be clear), decant, and wash eighttimes with aqua dest., using gloves against protein contamination.
9.1.7 Rapid Determination of the Protein Concentration51)
Blank Stock Solution (make four weeks before use):
100 mg Coomassie Brilliant Blue G 250 (C. I. 42655)50 ml 95% ethanol100 ml cone. phosphoric acidaqua dest. to make a final volume of 1000 mlfiltrate before use
66
Calibration
stock solution:50 mg albumin100 ml aqua dest.
aqua dest. to make a final volume of 1 ml:
1. volumetric flask: 0,2 ml containing 100 ~g albumin2. volumetric flask: 0,4 ml containing 200 ~g albumin3. volumetric flask: 0,6 ml containing 300 ~g albumin4. volumetric flask: 0,8 ml containing 400 ~g albumin5. volumetric flask: 1,0 ml containing 500 ~g albumin
Dilute 0,1 ml of every volumetric flask with 5 ml blank stock solution, measure after 2 minutes the photometer extinction at a wavelength of 595 nm and make a standard curve:
1. volumetric flask: 0,1 ml containing 10 ~g albumin2. volumetric flask: 0,1 ml containing 20 ~g albumin3. volumetric flask: 0,1 ml containing 30 ~g albumin4. volumetric flask: 0,1 ml containing 40 ~g albumin5. volumetric flask: 0.1 ml containing 50 ~g albumin
Sample
Dilute 0,1 ml centrifuged supernatant of the protein dialyzed solution with 5 ml blank solution, measure after 2 minutes the photometer extinction at a wavelength of 595 nm andestimate the protein content from the standard curve.
9.2 Vertical Polyacrylamide Slab Gel Electrophoresis
9.2.1 Equipment
Desaga Desaphor VA3000 Volt Power Supply DesatronicChamber and polymerization standCirculating Water Bath FrigostatDiffusions Destaining ApparatusStaining TraysBlotting PaperThermoplate SIlluminating BoxUltrasonic bathDesaga multiple syringe 1a ~I with 12 channelsMicrosyringes or MicropipetorsMicrotiter plateBeakersStir Bars and Stir Plate1.5 ml Microcentrifuge TubesMicrocentrifugeVortexSpatulasTimer
67
9.2.2 Buffers
Trls-Borate Buffer pH 7,1Tris-Borate Buffer pH 8,9Tris-HCI Buffer pH 6,7Tris-HCI Buffer pH 8,08Tris-HCI Buffer pH 8,9Tris-Glycine Buffer pH 9
9.2.3 Reagents
Tris (Tris(hydroxymethyl)-aminomethane)AcrylamideBisacrylamideSodium Phosphate (dibasic)Phosphoric AcidHydrochloric AcidSDS (Sodium Dodecylsulfate)TEMED (N, N, N', N'-Tetramethyl-ethylenediamine)Ammonium peroxidisulfate:SucroseGlacial Acetic AcidSodium HydroxideGlycineTrichloroacetic Acid2-Propanol
9.2.4 Staining Salts
RiboflavinCoomassie Brilliant Blue RBromophenol Blue
9.2.5 Stock Solutions
Simple Gels for Green, Dried and Milled Tobacco
Mix each of these solutions58) in a beaker using a magnetic stir bar.
Separation Gel:
Stock Solution TG 1 (toxic, avoid skin contact)38 9 acrylamide2 9 bisacrylamideaqua dest. to make a final volume of 100 ml
Stock Solution TG 218,15 9 trisaqua dest. to make a final volume of 90 mlcone HCI to titrate till pH 9,1 (about 2 ml)0,2 ml TEMEDaqua dest. to make a final volume of 100 ml
Stock Solution TG 3 (must be made daily)200 mg ammonium persulfateaqua dest. to make a final volume of 100 ml
68
Concentration Gel:
Stock Solution KG 1 (toxic, avoid skin contact)9,25 9 acrylamide0,75 9 bisacrylamideaqua dest. to make a final volume of 100 ml
Stock Solution KG 22,23 9 triscone H3P0 4 to titrate till pH 6,7 (about 1,1 ml)0,1 ml TEMEDaqua dest. to make a final volume of 100 ml
Stock Solution KG 32 mg riboflavin40 9 sucroseaqua dest. to make a final volume of 100 ml
Stock Solution KG 4 (must be made daily)100 mg ammonium persulfateaqua dest. to make a final volume of 100 ml
Stock Solution Upper Electrode Buffer (Cathode):tris-glycine pH 8.925,8 9 tris17,4 9 glycineaqua dest. to make a final volume of 5000 ml
Stock Solution Lower Electrode Buffer (Anode):tris-HCI pH 8,0872,5 9 trisaqua dest. to make a final volume of 4000 mlcone HCI to titrate till pH 8,1aqua dest. to make a final volume of 5000 ml
Stock solutions TG1, TG2, KG1, KG2 and KG3 may be made in advance and kept in brownbottles in the refrigerator when not in use.
Stock solutions Upper and Lower Electrode Buffer may be made in advance and brought to4°C.
Stock solutions TG 3 and KG 4 must be made daily.
Gradient Gels for the Separation of Tobacco Seed Proteins
Mix each of these solutions48) in a beaker using a magnetic stir bar.
Stock Solution ST1 (toxic, avoid skin contact)30 9 acrylamide0,8 9 bisacrylamideaqua dest. to make a final volume of 100 ml
Stock Solution St2: Separation gel tris - HCI Buffer pH 8.936,6 9 tris48 ml 1 N HCI to titrate till pH 8.9aqua dest. to make a final volume of 100 ml
Stock Solution St3: Concentration gel (and sample) tris-HCI- Buffer pH 6,73,54 9 NaH2P0 45,7 9 tris
69
25 ml 1 N HCI to titrate till pH 6,7aqua dest. to make a final volume of 100 ml
Stock Solution St410% SDS
Stock Solution St510% TEMED (wlv) in aqua dest.
Stock Solution St6 (must be made daily)10 % ammonium peroxidisulfate (wlv) in aqua dest.:0,5 9 ammonium persulfateaqua dest. to make a final volume of 5 ml
Stock Solution St7a: Electrode Buffer - tris (10 mM) - boric acid (200 mM) pH 7,16,055 9 tris4 I aqua dest.ca. 61,83 9 boric acid to titrate till pH 7,1aqua dest. to make a final volume of 5 Idilute 1 I with 2 I aqua dest. just before useadd 3 9 SDS
Stock Solution 7b: Electrode Buffer - tris (125 mM) - borate (19 mM) pH 8,975,69 9 trls4 I aqua dest.ca. 5,87 9 boric acid to titrate till pH 8,9aqua dest. to make a final volume of 5000 mldilute 1 I with 2 I just before use3g SDS
9.2.6 Simple Gels
Handling of the Desaphor VA (see Operating Instructions of the Co. Desaga57)
Chamber and Polymerization Stand (see operating instructions)
- Fill the lower buffer through with lower electrode buffer (5 I).
- Adjust on time the thermostat to the temperature of 5°C (native proteins).
Separation Cell (see operating instructions)
Gel Casting (see operating instructions)
Separation Gel (T=10%, C =5%; TG1 : TG2 : TG3 =1 : 1 : 2)Mix 12,5 ml TG1
12,5 ml TG2
- Degas for 2 min using an ultrasonic bath.
- Add the catalyst.
- Add 25,0 ml TG3.
- Mix and pour the gel liquid into the polymerization cuvette.
- Overlayer with 2 times 0,5 ml aqua dest. from each side and allow to polymerize for1 hour.
- Remove water layer after polymerization.
70
Concentration Gel (T= 2,5%, C = 7,5%; KG1 : KG2 : KG3 : KG4 = 1 : 1 : 1 : 1)Mix 2,5 ml KG1
2,5 ml KG22,5 ml KG32,5 ml KG4
- Degas for 2 min using an ultrasonic bath.
Pour the gel liquid on top of the polymerized separation gel and insert well former.
Allow to polymerize with UV-light.
Remove well former and rinse the wells with the upper electrode buffer.
9.2.7 SDS-Gradient Gels (T = 6 till 25%, C = 5%)
Handling of the Desaphor VA (see Operating Instructions of the Co. Desaga57)
Chamber and Polymerization Stand (see operating instructions)
- Fill the lower buffer through with electrode buffer St7a (pH 7.1, 5 I).
- Adjust on time the thermostat to the temperature of 17"C.
Separation Cell (see operating instructions)
Gel Casting (see operating instructions)
Solution A1, T = 6%Mix 5,1 ml St1
16,5 ml aqua dest.3,2 ml St20,25 ml St40,3 ml St51°III St6
Solution A2, T =7,5%Mix 6,33 ml St1
15,2 ml aqua dest.3,2 ml St20,3 ml St40,3 ml St510 III St6
Solution A3, T = 8%Mix 6,75 ml St1
14,8 ml aqua dest.3,2 ml St20,3 ml St40,3 ml St510 III St6
Solution A4, T = 10%Mix 8,5 ml St1
13,1 ml aqua dest.3,2 ml St20,3 ml St40,3 ml St51°III St6
71
Solution 81, T =20%Mix 16,9m1St1
4,7 ml aqua dest.3,2 ml St20,5 g sucrose0,3 ml St40,3 ml St51° 111 St6
Solution 82, T =25%Mix 21,2 ml St1
0,4 ml aqua dest.3,2 ml St20,5 g sucrose0,3 ml St40,3 ml St51° 111 St6
Concentration GelMix 3,22 ml St1
14,1 ml aqua dest.2,5 ml St30,2 ml St40,35 ml St53°111 St6
- Degas all gel solutions just before use.
Gel Solution Combinations used are:(for one 150 mm separation cell from every solution 30 ml)
A1 with 81A3 with 81A4 with 81A3 with 82
Concentration GelMix 3,22 ml St1
14,1 ml aqua dest.2,5 ml St30,2 ml St40,35 ml St530111 St6
- Place the gaskets onto the polymerization stand with the holes fitting over the tube connections for filling the cell with the gel solution.
Pump the solution of high concentration into the vessel with the low concentrated solution, mix this continuously with a magnetic stirrer and pump simultaneously with twoother pump tubings the mixed solution into the cell.
Water layer and allow to polymerize for 1 hour.
Remove water layer.
Pour concentration gel and insert well former.
Allow to polymerize for 15 minutes.
Remove wellformers and drain by shaking or blotting wells with absorbent paper.
Replace the second cell by a blind cell in the case you are working with one gel only.
72
9.2.8 Application of Samples
- Place the gaskets with slids on the upper buffer trough.
Mount the separation cells - wells to the bottom - onto the upper buffer trough.
Fill the lower buffer trough with the anode buffer.
Place the upper buffer trough in oblique position into the chamber.
Avoid trapping air bubbles at the free ends of the gel.
Using discontinuous buffer system, close stopcock A.
Fill the trough with upper electrode buffer (ca. 1,0 I).
Remove any air bubbles from the sample wells with a buffer - filled small syringe.
Make a preliminary run of the gels without samples.
Switch on the buffer circulation for the lower buffer and stabilize the current on 50 mAper slab gel, limit the voltage on 500 V, run for ca. 0,5 h.
Give the concentrated fraction of the samples into the wells of a microtiter plate.
Add a bromophenol blue crystal and sucrose (10 %).
Use a well cleaned Desaga multiple syringe 10 III with 12 channels.
Apply 1aIII of each concentrated fraction in a well of the concentration gel.
Close the chamber with the lid and start the electrophoresis.
9.2.9 Operating the Electrophoresis
cathode = upper electrode
anode = lower electrode
- Adjust the power supply to the proper voltage and current.
Simple Gels
- Concentration gel: 500 V limit, 50 mA per gel slab.; ca 0,5 h until bromophenol blue hasreached the separation gel, than switch to 500 V, 100 mA for one separation gel.
Gradient-Gels
- Concentration gel: 500 V, 100 mA; 0,5 h until bromophenol blue has reached the separation gel, than switch to 500 V, 150 mA (ca 2,5 h) for the separation gel.
- Stop the electrophoresis when the front of the tracking dye reaches the lower end of thecell (visible by the added dye bromophenol to the samples).
- Switch off the power supply.
- Take off the lid.
- Switch off the buffer circulation pump.
9.2.10 Removing the Gels (see operating instructions)
- Stain appropriately (see 9.4 - 9.8).
73
9.3 Isoelectric Focusing
9.3.1 Agarose Gels, pH 3 - 10 plus Spread at pH 3 - 7
Equipment
Desaga Desaphor HF Horizontal Electrophoresis Unit3000 Volt Power Supply DesatronicCirculating Water Bath FrigostatThird Electrode for Desaphor HFDiffusions Destaining ApparatusStaining TraysBlotting PaperPreCut IEF Electrode WicksThermoplate SIlluminating BoxSample Templates-Polyester 48 well (Desaga Nr. 150202)HyPure Gel (Desaga Nr. 150009)Microsyringes or MicropipetorsBeakersStir Bars and Stir Plate1.5 ml Microcentrifuge TubesMicrocentrifugeVortexSpatulasTimer
Chemicals
Glacial Acetic AcidSodium HydroxideGlycineTrichloroacetic Acid2-PropanolCoomassie Brilliant Blue R
9.3.2 Preparation of Solutions
Mix each of these solutions in a beaker using a magnetic stir bar.
Anolyte Solution
0.5 M Acetic Acid- Add 15 ml Glacial Acetic to 485 ml of distilled or deionized water.
Catholyte Solution
0.5 M Sodium Hydroxide- Add 10 9 Sodium Hydroxide to a beaker.- Bring volume up to 500 ml with distilled or deionized water.- Stir until Sodium Hydroxide is dissolved.
74
Fixative Solution
- Add 40 g Trichloroacetic Acid to a beaker.- Bring volume up to 200 ml with aqua dest.- Stir until Trichloroacetic Acid has dissolved.
Wash Solution
- Add 5.0 g Trichloroacetic Acid to a beaker.- Bring volume up to 1 I with aqua dest.- Stir until Trichloroacetic Acid has dissolved.
Brilliant Blue R-250 Stain
- Add 350 ml 2-Propanol and 80 ml Glacial Acetic Acid to 570 ml distilled or deionizedwater.
- To this solution add 1.0 g Brilliant Blue R-250.- Stir the solution at least 30 minutes to dissolve.
Glycine Extraction Solution
2% Glycine- Add 2 g Glycine to 100 ml distilled or deionized water.- Gently stir to mix.- Adjust the pH to 8.6 with 6 M Sodium Hydroxide.
9.3.3 Sample Preparation (see 9.1)
9.3.4 Operating the Isoelectric Focusing
- Turn on circulating water bath and set temperatures to 15°C, 15 minutes before the run.
Clean the cooling plate with water and towel dry.
Remove a HyPure Gel from its package. Carefully remove the protective cover sheetfrom the gel surface. Do not touch the gel or use it if it is torn or dried. Cut the bottomright-hand corner of the gel; this corner will be used as a reference point.
Pipette 3 ml of water onto the center of the Desaphor HF cooling plate.
Hold the gel by its diagonal corners to form a parabola.
Place the bottom of the parabola on the bead of water.
Distribute slowly the bead of water by using the backing of the gel (be careful not to trapair bubbles between the gel and cooling plate).
Center the gel on the Desaphor HF cooling plate.
Thoroughly blot any excess water from the periphery of the gel using a paper towel.
Place a piece of Blotting Paper evenly on the gel. Smooth the paper lightiy with fingertips.
After five seconds, gently remove the blotting paper.
Prepare three PreCut IEF Wicks. (Twoof the wicks will be used as anode wicks, one willbe used as the cathode wick).
Place the two "anode" wicks, rough-side down on several white paper towels. (NOTE:Brown or colored paper towels may exude a dye into the electrode wick. Use whitepaper towels only)
75
- Evenly saturate each wick with 4 - 5 ml of Anolyte Solution. Gently blot the wicks to ridexcess fluid. The wicks should just begin to appear dry before being placed on the gel.
- Place each anode wick onto the edges of the gel. Run a finger along the entire length ofthe wick to ensure even contact between the wick and gel. Refer to the Alignment Diagram for proper placement of the wicks.
- Wash hands of residual Anolyte Solution.
- Place the remaining wick, rough-side-down, on several white paper towels.
- Evenly saturate the wick with 4 - 5 ml of Catholyte Solution.
- Gently blot the wick with another paper towel to rid any excess fluid (wick should justbegin to appear dry).
- Place the wick along the center of the gel between the two anode wicks.
- Make sure all the wicks are parallel to each other.
- Run a finger along the entire length of the wick to ensure even contact between the wickand gel.
- Position the templates 1 cm from the anodes.
- Apply 10 III of the sample to each sample well.
- Place the metal spring from the electrodes from top onto the electrode ledge and adjustthe electrodes onto the middle of the corresponding electrode strips.
- Center the electrodes evenly over the wicks.
- Load the three electrodes with the two 4 mm thick glass plates delivered.
- Slide the lid onto the chamber and lock it by turning the locking knob 90 degrees clock-wise.
- Connect the plugs with the outlet sockets of the power supply (the red plug with the redoutlet socket, the black plug with the black one).
- Switch on the main switch - power knob -.
- Press the key N-SET for stabilizing the power and turn the knob above until the displayshows 40 Watts.
- The voltage is limited at 1500 V, the current is set at a value of about 60 mA.
- Push the key ON/OFF for starting the separation.
- Run the gel for 60 minutes at 40 Watts.
- Remove the application strips and dry the surface of the agarose gel from exudation orcondense water with a thin sheet of filter paper.
- Focus the gel for further 60 minutes at 40 Watts constant.
- When the electrophoresis run is complete, turn the power supply off.
- Remove the Desaphor HF safety cover, the glass plates and electrodes.
- Remove the wicks from the gel's surface.
9.3.5 Staining of Samples (see also 9.5)
- Place the gel into a staining tray and pour on 200 ml of Fixative Solution.
- Rock or agitate the gel for 20 minutes.
- After the bands have been permanently fixed, discard the Fixative Solution.
76
- Wash the gel for one hour in 500 ml of Wash Solution.
- Discard the Wash Solution and repeat this wash step with 500 ml of fresh Wash Solution.
- Allow gel to dry completely by placing the gel on a flat surface overnight at room tem-perature (15°C - 30°C) or by placing it onto a gel dryer (Thermoplate S) at 60°C for twohours. The gel is dry when an even sheen appears across the gel's surface.
- When the gel is dry, place the gel in a staining tray, agarose side up.
- Cover the gel with 200 ml of Brilliant Blue R-250 Stain.
- Rock the gel gently for 30 - 60 minutes or until bands reach desired intensities. Discardstain. (Destaining is usually not necessary when using this stain.)
- Rinse the gel 10 minutes in distilled or deionized water.
- Air dry the gel.
- The gel may now be analyzed.
9.4 Protein and Enzyme Staining Procedures
9.4.1 Unspecific staining of proteins
Fixation
Solution:Mix 54 g trichhloroacetic acid
136 ml methanol340 ml aqua dest.16 g sulfosallcyllc acid (if necessary)
- Shake the gel for 0,5 h.
- Wash with 10% acetic acid for 10 min.
Standard Staining
Staining Solution:Mix 100 rnl Fixative Solution
2.5 ml 1% Coomassie Brilliant Blue R 250(Manifold use is possible.)
- Shake the gel for 3 h (or over night).
Destaining Solution
Stock Solution:Mix 63 ml 96 % acetic acid
375 ml methanol562 ml aqua dest.(For repeated use purify with charcoal, 1 g / 100 ml.)
- Shake for 3 h (or over night).
- Changing the bath several times.
Stock Solution (Modification)Mix 200 ml methanol
100 ml acetic acidaqua dest. to make to 1000 ml
77
9.4.2 Rapid Staining for Native Gels and IEF-Gels60)
Staining Solution
Mix 40 ml 0,3 % Coomassie Brilliant Blue G 250 in aqua dest. (wlv)15 ml cone. perchloric acid
- Let it stand for 10 min.
- Add 250 ml aqua dest.(Manifold use is possible.)
Destaining and Preserving Solution
Mix 100 ml cone. acetic acid20 ml glycerinaqua dest. to make to 1000 ml
9.4.3 Silver Staining61)
Fixative Solution
10% trichhloroacetic acid
- Shake for 0.5 h.
Dithiothreitol Treatment
Mix 4 mg dithiothreitol40 ml ethanol10 ml acetic acid150 ml aqua dest.
- Shake for 0.5 h.
Background Brightening Up
- Oxidize with 0,5 % K2Cr207 or 0.1 % H202 for 5 min.
- Wash with aqua dest. for 5 min.
Silver nitrate Impregnation
- Stain with 200 rnl O, 1% silver nitrate for 10 min.
- Wash with aqua dest. for 1 min.
Paraformaldehyde Treatment
Mix 6 g sodium carbonate40 mg p-formaldehydeaqua dest. to make a final volume of 200 ml
- Shake for 5 till 7 min (controlling the development on an illuminating box).
- Stop the development with 1% acetic acid.
Impregnation Solution
Mix 50 ml methanol10 ml glycerin40 ml aqua dest.
- Shake for 1 hour.
78
9.4.4. Destaining and Drying of Polyacrylamide Slab Gels
- Shake the gel in a solution of 10% acetic acid and 5% glycerin for 1 hour.
Cut 2 sheets of cellophane film (a little bit bigger than the gel and the supporting glassplate).
Swell them in 5% glycerin-aqua dest. mixture for 30 min.
Span the one sheet over a 4 mm thick glass plate.
Put the gel on it.
Span the other sheet on the gel and the glass plate.
Remove the air bubbles.
Turn the edges of the sheets around the glass plate.
Dryat room temperature on a place without draft.
9.4.5 Specific Staining of Enzymes62)
Peroxidase - PER
Staining Solution:Mix 90 mg benzidine
100 ml ethanol66 ml 3% hydrogen peroxide10 ml glacial acetic acidaqua dest. to make to 200 ml
- Shake until the bands appear (45 till 60 sec).
- Transfer gel to 7% acetic acid for 5 min.
- Rinse and hold in aqua dest.
Esterase - EST
Staining Solution:Mix 0.1 g Fast Blue RR
10 ml 0,2 M NaH2P04 * H20 (pH 4,6)50 ml 0,2 M Na2HP04 * H20 (pH 8,8)Prepare and add shortly before use the stock solution:3 ml1 % a, ~-naphthylacetate in 70% acetone-aqua dest. solution(Make first a solution in acetone and then aqua dest. to make to 100 mI.)
- Shake at room temperature until the bands appear (1.0 h).
Malate Dehydrogenase - MDH
Staining Solution:Mix 0,61 g tris (0,05 M)
2,1 g malic acid (0,2 M)
- Add 70 ml aqua dest.
- Adjust pH to 7 with 10% sodium hydroxide (ca 9 ml)
- Add 66 mg diphosphopyridine nucleotide (0,001 M)5 mg phenazine methosulfate (0,000136 M)35 mg p-nitroblue tetrazolium (0,00043 M)aqua dest. to make to 100 ml
79
- Strain through glass wool before to use.
- Shake gel in the dark at 3rC until bands develop.
- Wash and fix in 2% acetic acid.
9.5 Enzyme Staining Procedures of Agarose Gels59)
9.5.1 Chemicals
Buffers
Tris (Tris (hydroxymethyl)-aminomethane)Sodium Phosphate (monobasic)Sodium Phosphate (dibasic)Sodium CitrateSodium Acetate
Staining Salts, Co-Factors
Fast Blue RR SaltOrtho-DianisidineMMT, (3-[4, 5-Dimethyl-2-thiazolyl]-2, 5 - diphenyl-2 H-tetrazolium bromide)Magnesium ChlorideAND (P-Nicotinamide adenine dinucleotide, reduced form)NBT (Nitro Blue Tetrazolium)PMS (Phenazine Methosulfate)
Subtrates
a-Naphthyl AcetateDL-Malic AcidDL-Isocitric Acid
Reagents
MethanolEthanolHydrogen Peroxide 30%Glacial Acetic AcidHydrochloric AcidSodium ChlorideSodium HydroxideAcetone
9.5.2 Preparation of Enzyme Buffers
Mix each of these enzyme buffers in a beaker using a magnetic stir bar.
Stop Solution
Add 80 ml glacial acetic acid and 250 ml ethanol to 670 ml distilled or deionized water.
0.1 M Tris-HCI (pH 8.5), Buffer Solution
- Add 12.1 g of Tris to 900 ml of distilled or deionized water.
- Titrate with concentrated HCI to adjust solution to pH 8.5.
80
- Dilute with distilled or deionized water to 1000 ml.
0.6 M Sodium Phosphate (pH 6. 1), Buffer Solution
- Add 71.9 g sodium phosphate (monobasic) to 900 ml of distilled or deionized water.
- Titrate with 6.0 M NaOH to adjust solution to pH 6.1.
- Dilute to 1000 ml with aqua dest.
0.5 M Citrate Buffer (pH 4.4) - used in Peroxidase Stain
- Add 14.7 g sodium citrate to 90 ml of aqua dest.
- Titrate with concentrated HCI to adjust solution to pH 4.4.
- Dilute to 100 ml aqua dest.
Ortho-Dianisidine - used in Peroxidase Stain
- Add 2.75 g of o-dianisidine to 500 ml of methanol that has a concentration greater than90%.Caution: Avoid skin contact, may be carcinogenic.
This solution will keep for 9 months at room temperature.
6 M Sodium Hydroxide - used to Titrate
- Add 24 g sodium hydroxide to 90 ml of aqua dest., stir until dissolved.
- Dilute to 100 ml with aqua dest.
9.5.3 Transfer Membrane Preparation Solutions
Impregnating Solution
200 ml Methanol > 90%
Equilibration Solution
2,4 g Tris
29,0 g Sodium chloride
- To make with aqua dest. to 900 ml.
- To titrate with cone. hydrochloric acid to pH 7,5.
- To make with aqua dest. to 1000 ml.
This solution will keep for 1 month at room temperature.
9.5.4 Stain Solutions
Peroxidase - PER
To prepare stain:20 ml 0 - dianisidine buffer10 ml citrate buffer pH 4.470 ml aqua dest.
Just before staining add:5 ml 3% hydrogen peroxide
Staining is complete in 30 - 40 minutes or until bands reach strong intensities.
81
Esterase - EST
To prepare stain:
Solution I80 ml 0.6 M phosphate buffer pH 6.180 mg Fast Blue RR Salt
Just before staining add solution II:
Solution IIThis can be made up 15 minutes before use.10 ml 50% Acetone80 mg a-naphthyl acetate
Staining is complete in 60 - 90 minutes or until bands reach strong intensities.
Malate Dehydrogenase - MDH
To prepare stain:
- In a 100 ml beaker with a stir bar add:50 ml 0.1 M tris HCL pH 8.5150 mg DL-malic acid
- Stir until the DL-malic acid is dissolved.
- Re-adjust the pH to 9.2 using 6 M NaOH added dropwise.
Just before staining add:
20 mgAND10 mg MIT5 mg PMS
- Allow the staining to continue for 45 - 60 minutes or until the bands reach strong intensities.
9.5.5 Enzyme Staining
The Chemicals and steps listed in the first area of the section (To prepare stain) can becompleted during the electrophoretic run. The chemicals and steps listed in the secondarea (Just before staining) should be added only 3 - 4 minutes before the stains use. Therecommended time interval for proper staining is provided. The following points are to aidin achieving optimal results.
- The formulas are measured for use on transfer membranes. To stain a gel, double thevalues are given.
- Stir until all chemicals are dissolved.
- It is helpful to rock or agitate the gel while staining.
- Remove any air bubbles by gently lifting the gel corners with a spatula.
- To stop the enzymatic reaction rinse the gel with distilled or deionized water. Place in75 - 100 ml stop solution for 3 minutes. Do Not use the stop solution on Transfer membranes. To stop staining of transfer membranes simply rinse with distilled or deionizedwater.
- Transfer membranes fade upon drying. To avoid this, keep them in water until scoring iscompleted.
82
- Score the bands immediately. If the gel cannot be scored immediately, a photograph ofthe banding patterns is recommended.
- Diagnostic banding patterns can be observed anywhere in the 8 em inter-electrodespace.
- After the gel has been scored place the gel in 500 ml distilled or deionized water for onehour. The gel can then be air dried for permanent storage.
10 SummarySeventeen German and five Greek cultivars from the harvest 1987 and twenty-five GermanGeudertheimer cultivars from the harvest 1990 were analyzed according to nitrogen fertilization. New breeding lines as well as common types from oriental, cigar, Burley and Virgintypes investigated for smoke and leaf constituents: condensate, nicotine, nitric oxide andcarbon monoxide in smoke; nitrate, alkaloids, sugar, and nitrogen in leaf.
In the autumn 1990 and spring 1991 one hundred and eight soil samples were taken fromfive tobacco experimental fields in the northern and the middle part of Greece, in order tofind out their fitting for tobacco plantation or possible nutrition deficiencies.
The limitation to 12 mg condensate per cigarette, asked by the European Commission for1998, can only be fulfilled with the lower stalk positions of the cultivars. Nicotine is changing according to the tobacco types. Carbon monoxide was found in a middle range equalfor all types. Nitric oxide changes according to the nitrogen fertilization and the cultivars.The leaf constituents nitrate, nicotine and the sum of nornicotine and myosmine correlatewith cultivar, climate and fertilization. The nitrosamines in the tobacco and tobacco smokevary with the nitrate content in the cultivars, the harvesting and curing conditions.
The correlation among nitrate in the tobacco leaves, nitric oxide and carbon monoxide inthe mainstream smoke, nitrosamines in the leaves and in the mainstream smoke wereexamined in every prime in the Greek breeding lines 5/R, 1/B, 2/K, 3/S and 4N.
The rates of carbon monoxide increase in every prime in all tobacco breeding lines exceptfor 4N breeding line, in which an irregularity in the rates is observed. Breeding lines withhigh nitrate percentage (5/R), there are high percentage in nitric oxide and nitrosamines. Acorresponding decrease of nitrate and nitric oxide is found out in every prime in the breeding lines 1/B, 3/S and 5/R and a corresponding increase in every prime in 2/K and 4N. In 51R breeding line is observed the highest percentage of nitrosamines both in tobacco leavesand in the mainstream smoke. In 4N, 2/K and 3/S no nitrosamines are observed, while 1/Bin a middle position is.
Twenty-five breeding lines of dark air cured tobacco from the harvest 1990 were identifiedwith an electrophoretic method according to their protein and isoenzyme patterns.
The genuineness of different dark or light tobaccos was examined in protein bands of thetobacco seeds of two crops whose harvest had a difference of two years. They wereproved to be genuine because of the identical protein bands with an exception of Geudertheimer III and Badischer Burley E.
Varieties resistant to diseases from varieties not resistant could be identified. So the resistant varieties Bel 10, Burlina 183, Bursanica 217, Perega and Pereg 234 appear to have oneprotein band in Rf-rate 0,6.
Individual varieties or relative breeding lines in dark and light tobaccos could be identifiedbecause of protein and isoenzym bands in the green leaf in the prime "tip". The varietiesBadischer Burley E, Burlina '83 and Bursanica 217 could be identified only by their protein
83
bands. The breeding lines B 520, B 21, Pereco, B 535 and B 535 Bursa could be identifiedin relation to protein bands and peroxidase bands.
The identification of different tobacco varieties based on protein and isoenzym bands wasexamined in dry and ground tobacco samples.
All the examined varieties were taken from the prime "leaf". They were coming from experimental fields of the Landesanstalt fur Pflanzenbau Forchheim. They could be identifiedfrom their protein bands.
The question about the genuineness of "f-taler" varieties from 1986 compared with theones of 1978, which comes from the experimental cultivation could be examined in dry tobacco. It was found out that they are genetically different tobaccos.
Despite of enzymatic and oxidant decomposition process, - during the drying of tobaccoand its storage -, the isoenzymes and protein bands could be identified in tobacco varieties in the dry material.
The isoenzymes and protein bands in the green leaf could be identified from the ones of thedry material when it comes to their number and their position. The few bands in the dry material were characterised by a loss of peroxidase bands in the isozyme patterns.
Based on our findings, it is feasible that electrophoretic procedures will become a practicalmeaning for cultivar identification in nicotiana tabacum. With the quality analysis in tobaccoand tobacco smoke an identity-card for old and new breeding lines of cigar, Burley and Virgin tobacco can be made.
84
BIBLIOGRAPHY
1) Collective of Authors (1953): "Tobacco-Technical Book", published by vvb tabakdresden under the leadership of G. Dietze, Fachbuchverlag GmbH, Leipzig (G)*
2) HOlser, H. (1966): "Tobacco Plant of Virginia", in Hagemanns Extension Graphs:Foreign Useful Plants, Graph 3, Lehrmittelverlag W. Hagemann, DOsseldorf, Postfach5129 (G)*
3) Glaser, G. (1967): "Tobacco Plantation Areas", in "The Plantation of Special PurposeCrops on Both Sides of the Northern Part of the River Rhein between Karlsruhe andWorms", self-publishing of the Geographical Institute of the University of Heidelberg,0-69117 Heidelberg, Germany, p. 144 - 181 (G)*
4) Seibert Th. and Hechler G. (1976): "Tobacco Plantation in Germany", Pfalzische Verlagsanstalt GmbH, Landau/Pfalz (G)*
5) Collective of Authors under the leadership of Garbe, H. J.(1989): "Tobacco", VEB Deutscher Landwirtschaftsverlag, Berlin (G)*
6) Schweiger, P. (1992): "Tobacco", Vortr. PflanzenzOchtg. 22, p. 196 - 203 (G)*
7) Anonymous (1987): "Bases for Fertilization Advice in Crop Farming and Grassland", Information for Crop Production, Baden WOrttemberg, Ministry of Rural Area, Agricultureand Forestry, 0 - 70190 Stuttgart, p. 37 (G)*
8) Akehurst, B. C. (1981): "Tobacco", 2. Edition, Longmann, London and New York, p. 188- 189, 290, 379
9) Scheffer, F. and Schachtschabel, P. (1984): "Advisory Book of Soil Science", 11. Edition, Ferdinand Enke Verlag, Stuttgart, p. 341 - 343 (G)*
10) Schweiger, P. (1993): "Tobacco Plantation", in Fist Numbers for Agriculture and Horticulture, 12. Edition, Hydro Agri DOlmen Gmbh, DOlmen, p. 539 - 543 (G)*
11) Wolf, F. A. (1962): "Aromatic or Oriental Tobaccos", Duke University Press, North Carolina, USA, p. 113 - 114
12) BrOckner, H. (1936): "Biochemistry of Tobacco and Tobacco Processing", Paul Parey,Berlin (G)*
13) Wenusch, A. (1939): "Tobacco Smoke", Arthur Geist Verlag, Bremen; (1940): "Chemistry of Tobacco Leaf", Arthur Geist Verlag, Bremen (G)*
14) Stedmann, R. L. (1968): "The Chemical Composition of Tobacco and Tobacco Smoke",Chem. Rev. 68, p. 153 - 207
15) Schmidt, J. A. (1982): "Tobacco", in Ullmanns Encyclopaedia of Technical Chemistry, 4.Aufl., Verlag Chemie, Weinheim, p. 367 - 384 (G)*
16) Tso, 1. C. (1972): "Physiology, and Biochemistry ofTobacco Plants", Dowden, Hutchinson and Ross, Inc., Stroudsburg, Pa. 18360, USA; (1990): "Production, Physiology, andBiochemistry of Tobacco Plant", ideals, Inc., Beltsville, Maryland, USA
17) Fischbach, E. D. (1992): "Domestic and Foreign Residues - Situation in Tobacco", DerDeutsche Tabakbau 72 (5), p. 4 - 6 (G)*
18) Klingauf, F., Brammeeier, H., Beer, H. and Redlhammer, S. (1993): "The ProspectiveWay - Determinations of Targets in Agrarian Policy by the Government of the FederalRepublic of Germany and Conclusions for Activities in Plant Protection", Nachrichtenbl. Deut. Pflanzenschutzd. 45 (11), p. 247 - 252 (G)*
85
19) Wahl, R. (1972): "Tobacco", in Handbook of Food Technology, Bd. VI, Semi-LuxuriesContaining Alkaloids, Spices and Common Salt, Springer Verlag, Berlin, Heidelberg,New York, p. 310 - 347 (G)*
20) Beuth Verlag, BurggrafenstraBe 6, D-10787 Berlin, Germany
21) Hecht, S. S., Adams, J. D. and Hoffmann, D. (1983): " Tobacco - Specific Nitrosoamines in Tobacco and Tobacco Smoke", in Environmental Carcinogens - SelectedMethods of Analysis, Vol. 6, N-Nitroso Compounds, edited by Egan, H., Preussmann,O'Neill, I. K., Eisenbrand, G., Spiegelhalder, B. and Bartsch H., International Agency forResearch on Cancer, Lyon, IARC Sci. Publ. Nr. 45, p. 93 - 101
22) Tso, T. C., Lowe, R. and DeJong, D. W. (1975): "Homogenized Leaf Curing", Beitr. Tabakforsch. 8 (1), p. 44 - 51
23) Spiegelhalder, B., Kubacki, St. J. and Fischer, Sophia (1989): "A Method for the Determination of Tobacco-specific Nitrosoamines (TSNA), Nitrate and Nitrite in TobaccoLeaves and Processed Tobacco Beitr. Tabakforsch. 14 (3), p. 135 - 144
24) Fischer, Sophia and Spiegelhalder, B. (1989): "Improved Method for the Determinationof Tobacco-specific Nitrosoamines (TSNA) in Tobacco Smoke Beitr. Tabakforsch. 14(3), p.145-153
25) MOiler, H. and Siepe,' V. (1979): "Determination in Comparison of Nitrate Contents inFood with the Help of Different Methods", Dtsch. Lebensmittel Rdsch. 75, 175 - 183(G)*
26) Anonymous (1977): "A Review of Methods to Determine Nitric Oxides in CigaretteSmoke", CORESTA Task Force, MOnchen, CORESTA, Paris CEDEX, p. 1 - 12
27) Anonymous (1980): "Determination of Nitric Oxides", CORESTA Minutes, Smoke StudyGroup, Manila, CORESTA, Paris CEDEX
28) Klimisch, H. J. and Kirchheim, E. (1977): " Additionally to the Quantitative Determination of Nitrogen Oxides in Cigaret Smoke with the Help of the ChemiluminescenceMethod": Z. Lebensm. Unters. Forsch. 163, p. 48 - 52 (G)*
29) B. A. T., R. & D. D. Group R. & D. Center, Southampton, UK
30) Filtrona Instruments &Automation Ltd., Harpenden, UK
31) Jenkins, R. A. and Jill, B. E. (1979): "Procedure for the Determination Oxides of Nitrogen (NOx) in Cigarette Smoke by Chemiluminescence Analysis", Analytical Chemistry Division, Oak Ridge National Laboratory, P. O. Box, X, Oak Ridge, Tennessee37830, USA
32) Ball, M. (H. F. & Ph. F. Reemtsma, Hamburg) (1980): "Experience with the Automatic Nitric Oxide Determination in Cigarette Smoke", lecture during the XXII. Tobacco Colloquy, Wien, p. 2 -19 (G)*
33) Howind, H. R. (1982): "Investigations to the Combustion of Ballast Rich Brown Coal ina Fluidized Bed Reactor at a Pilot Plant Scale, Thesis, Institute of Technical Chemistry,University of Hannover, D-30167 Hannover, Germany, p. 31 - 36 (G)*
34) Monitor Labs., Atlanta, California, USA
35) Range, P., Drescher H., Rudy, R. and Kappler, P. unpublished
36) CORESTA, Paris CEDEX
37) Hedden, K., (1976): "About the Units of Measure for the Examination of Carbon Monoxide in Cigarette Smoke", Beitr. Tabakforsch. 8 (7), p. 459 - 460 (G)*
86
38) Range P., Heil, O. and Zangenberg, A, unpublished; 1982 on the occasion of the second joint experiment for nitrogen oxides in tobacco smoke the method was presentedto the CORESTA Smoke Study Group, CORESTA, Paris CEDEX, (G)*.
39) Kipp Analytica, Phileas Foggstraat 24,7821 AK Emmen - The Netherlands
40) Kontron Elektronik, Oskar-von-MillerstraBe 1, 0-85386 Eching bei MOnchen, Germany
41) Heinrich Borgwaldt, Schnackenburger Allee 15, 0-22507 Hamburg, Germany
42) Yallup, A E. (1978): "Handbook for B. A T. Nitric Oxide Analyzer, Engineering ReportNr. E. 225 unclassified", issued by N. E. Willis, Prog. Ref. 35. 02. 01., copy Nr. 50, B. AT., R. &D. D. Group R. &D. Center, Southampton, UK, submitted through the companyFiltrona, Bornsmouth, U. K.
43) Schumacher, Andrea: "Determination of Quantitative Genetic Parameters in a BreedingGarden of Burley-Tobacco, Nicotiana tabacum L., and their Breeding Relevance", Thesis, Faculty 111- Agricultural Science I, University of Hohenheim, 0-70599 Stuttgart-Hohenheim(G)*
44) N. Billenkamp, (1992): "Varietal Trials, - why?", Der Deutsche Tabakbau 72 (11), p. 15;(1993): "Results of the Varietal Trials 92", Der Deutsche Tabakbau 73 (4), p. 8 - 11;(1993): "Cultivar and Cultivation Tests 1993", Der Deutsche Tabakbau 73 (5), p. 7 (G)*
45) Billenkamp, N. (1993): "Aspects of Tobacco Growing in the Reunified Federal Republicof Germany with Special Attention to Research Programs", lecture during the sessionof the CORESTA Phytopathology Group, 15. - 22. 09. in Budapest, CORESTA, ParisCEDEX
46) Rothe, G. M. (1989): "Practise of the One-Dimensional Gel Electrophoresis" in "Practice of Electrophoretic Separation Methods" (H. Wagner, E. Blasius (Editors) in "Instruction Guidance for the Chemical Laboratory Practice", Bd. 23, p. 21 - 22,34 - 36,4748, 51 - 53, published by Springer Verlag, Berlin, Heidelberg, New York, London, Paris,Tokyo (G)*
47) Sheen, S. J. (1983): "Tobacco" in "Isozymes in Plant Genetics and Breeding" from S. D.Tanksley and T. J Orton (Editors), p. 203 - 227 Elsevier Science Publishers B. v., Amsterdam; Mader, M. (1985): "Enzymatic Differentiation of the Cell Wall of Plants", Blolologie in unserer Zeit 15 (5), p. 141 - 151 (G)*
48) Stegemann, H. and Burgermeister, W. (1984): " Gel Electrophoresis and Isoelectric Focusing with the Apparatus PANTA-PHOR (and MONO-PHOR)", PAGE-Manual, Institute of Biochemistry, Biologische Bundesanstalt, Messeweg 11, 0-38104 Braunschweig, p. 1 - 64 (G)*
49) Abet, M., Piro, F. and Tonini, A. (1984): "Enzyme Polymorphism as a Mean of TobaccoCultivars Identification", Ann. Inst. Exp. Tob. Scafati, IX, p. 45 - 51
50) Cooper, T. (1980): "The Tools of Biochemistry", p. 355 - 357, published by Walter deGruyter & Co, Berlin (G)*
51) Holtzhauer, M. (1988): "Biochemical Laboratory Methods", p. 5 - 6, published bySpringer Verlag, Berlin, Heidelberg (G)*
52) G6rg, Angelika (1973): "The Use of Disc-Electrophoresis and Isoelectric Focusing ofPolyacrylamide Gels for Characterizing of Plant Proteins and Enzymes and Influence ofGenetic and Ecologic Factors", Thesis, Technical University of MOnchen, Faculty ofBrewery and Food Technology, 0-85354 Freising-Weihenstephan, Germany, p. 116 117 (G)*
87
53) Dellncee, H. and Range, P.(1979): "Development of an Analytical Method for the Determination of Protein Degradation in Tobacco": Der Deutsche Tabakbau 59 (24), p. 320321 (G)*
54) Range, P., Fisher, Elisabeth and Muller, Maria, unpublished
55) Conklin, M. E. and Smith, H. H.(1969): "Effects of Fast Neutron Versus X-Irradiation onDevelopment, Differentiation and Peroxidase Isozymes in a genetically Tumorous Nicotiana Amphiploid and its Parents Int. J. Radiat. BioI. 16 (4), p. 311 - 321; Rucker, Waltraud and Radola, B. J. (1971): "Isoelectric Patterns of Peroxidase Isoenzymes from Tobacco Tissue Cultures, Planta (Berl.) 99, p. 192 - 198; Sheen, S. J. (1972): "IsozymicEvidence Bearing on the Origin of Nicotiana Tabacum", Evolution 26, p. 143 - 154;Ham, Changyawl, Cheong YeoI Sohn, and Yung Jin Kim, (1975): "Studies on the Electrophoretic Variation in TetrazoliumOxidase Isozyme of Nicotiana Species": KoreanJour. Botany 18 (4), p. 150 -154; Coussirat, J. A (1983/84): "Induction of Soluble (b)Proteins by Peronospora tabacinia A. in Tobaccos Treated with Polyacrylic Acid andFungicides and in Untreated Tobaccos", A du Tabac-Sect. 2 18, p. 107 - 122; Abet, M.,Piro, F. and Tonini, A(1985): Ann. Inst. Exp. Tob. Scafati X, p. 55 - 60; Wilkinson, C. A,Mulchi, C. L. and Aycock, M. K., Jr.(1985): "Polyacrylamide Gel Electrophoresis for cuitivar Identification in Tobacco", Crop Science 25, p. 971 - 974
56) Dellncee, H. (1986): "Advances in Isoelectric Focusing of Proteins", Izotoptechnika 29(1 - 2), p. 1 - 26; Westermeier, R. (1990): "Electrophoresis Practical Course", VCH Verlagsgesellschaft mbH, Weinheim (G)*; McDonald, M. B., Jr. (1991): "Blotting of SeedProteins from Isoelectrically Focused Gels for Cultivar Identification", Seed Sci. &Technol., 19, p. 33 - 40
57) Desaga GmbH, P.O.B. 101969, 0-690099 Heidelberg
58) Altland, K., Hackler, R. and Knoche, W. (1980): "Double One-Dimensional Electrophoresis of Human Serum Transferrin: A New High-Resolution Screening Method forGenetically Determined Variation", Hum. Gen. 54, p. 221 - 231; Altland, K., Rauh, S.and Hackler, R. (1981): "Demonstration of Human Prealbumin by Double One-Dimensional Slab Gel Electrophoresis", Electrophoresis 2, p. 148 - 155
59) Black, J., During, Linda (1989): "Procedure for the Identification of Corn Varieties usingIsoelectric Focusing and Native Blotting", in: "Isolab inc., Innovative BiochemicalMethodology", Drawer 4350, Akron, Ohio USA 44321
60) Desaga Lab-Report Nr. 2511 (08. 05. 1981), Desaga GmbH, P.O.B. 101969, 0-690099Heidelberg)
61) Hempelmann, E., Zwanzig, M. and MUlIer, Maria (1987): "Additionally Investigations tothe Mechanism of the Polychromatic Silver Staining", Elektrophorese Forum '87", editor B. J. Radola, Institute of Brewery and Analytical Chemistry, Technical University ofMunchen, 0-85354 Freising-Weihenstephan, p. 385 - 388 (G)*
62) Brewer, G. J. (1970): "An Introduction to Isozyme Techniques", p. 86 - 87,102 - 103,Academic Press, New York
* only in German language available
88
previously published in this series
Climatic Zones and Rural Housingin IndiaEditors: N.K. Bansal, G. MinkeGERMAN-INDIAN COOPERATIONISBN 3-89336-008-5
Titanium Nitride CoatingsPreparations, Characteristics andApplicationsS. Marinkovlc, Z. Martnkovlc andH. KotterGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-010-7
The Nappe Structure of the NorthSporades in GreeceThe Glossa Unit of SkopelosV. Jacobshagen and D. MatarangasGERMAN-GREEK COOPERATIONISBN 3-89336-015-8
Impact of Green on the UrbanAtmosphere in AthensM. Horbert, A. Kirchgeorg,A. Chronopoulou-Sereli,J. ChronopoulousGERMAN-GREEK COOPERATIONISBN 3-89336-016-6
Development and Improvement ofIdentification Methods for Time Varyingand Nonlinear Industrial ProcessesBilateral Cooperation betweenTechnische Hochschule Darmstadt andUniverza "Edvarda Kardelja" LjubljanaGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-022-0
Digital Adaptive Controledited by: K. Schwamberger,A. Schumann and D. Matko, B. ZupancicGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-021-2
Boron Nitride CoatingsPreparation, Characteristics andApplicationsS. Marinkovlc and Z. Marinkovlcwith collaboration of H. Kotter andCh. MeixnerGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-024-7
A Test Method for Solar Water HeatersCharacterisationby M. BosanacGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-032-8
Selected Studies of Adsorption onMetal and Semiconductor Surfacesby B. Gumhalter, M. Milun andK. WandeltGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-034-4
Osnovi nauke 0 materijalima(neue Werkstoffe)by G. Ondracek and I. StarnenkovlcGERMAN-YUGOSLAV COOPERATIONISBN 3-89336-036-0
Scientific Series of the International Bureau
Fundamentos do Metodo de Correntes ParasitasS. Stegemann (1990)GERMAN-BRASILIAN COOPERATION
2 Diamond and Diamondlike CoatingsS. Marinkovi6 and Z. Marinkovi6 with S. Krawczynski (1990)GERMAN-YUGOSLAV COOPERATION
3 Environmental Research in Aquatic SystemsM. Branica (1990)GERMAN-YUGOSLAV COOPERATION
4 Volcanic Tremor and Magma Flowedited by R. Schick and R. Mugiono (1991)GERMAN-INDONESIAN COOPERATION
5 Petrography, Geochemistry and Petrogenesis of the MIGIF-HAFAFIT GNEISSESat HAFAFIT MINE Area, South Eastern Desert, EgyptAbdelazeem Ahmed Rashwan (1991)GERMAN-EGYPTIAN COOPERATION
6 Terpene in Nadeln und Zweigen von Picea abies (L.) KarstProjektleitung: H. Ziegler, V. Tlsler (1991)GERMAN-YUGOSLAV COOPERATION
7 Titanium Nitride CoatingsPreparations, Characteristics and Applications (2nd edition)S. Marinkovi6, Z. Marinkovi6 and H. Kotter (1991)GERMAN-YUGOSLAV COOPERATION
8 The Thermal Degradation of Poly(2-Mono-, 2,2-Di and 2,2,2-TrichloroethylMethacrylate) - Kinetics and Mechanisms-I. Popovi6, L. Katsikas, J. Velickovi6, W. Schnabel (1991)GERMAN-YUGOSLAV COOPERATION
9 New Developments in Diamond and Diamondlike CoatingsPreparation, properties and applicationS. Marinkovi6 and Z. Marinkovi6 with S. Krawczynski (1991)GERMAN-YUGOSLAV COOPERATION
10 Integral Methods for the Calculation of Electric FieldsFor Application in High Voltage Engineering (1992)GERMAN-YUGOSLAV COOPERATION
11 Rechnerunterstutzte MontageablaufplanungM. Rabe, Y. Wang, I. Veza (1992)GERMAN-CROATIAN COOPERATION
12 Reference Materials and Methods in Environmental and Biological ResearchM. Rossbach (1992)GERMAN-SLOVENIAN COOPERATION
Scientific Series of the International Bureau
13 Photoacoustic Spectroscopy with Emphasis toApplication on Solid and Powered SamplesA. Alebi6-Jureti6, C. Zetzsch (1992)GERMAN-CROATIAN COOPERATION
14 Fracture Mechanics and Mechanical Testing Laboratory at InchassM.M. Ghoneim, A.M. Nasreldin, A.A. Elsayed, D. Pachur (1992)GERMAN-EGYPTIAN COOPERATION
15 Analysis Methods and Techniques for Hard Thin Layer Coatings Characterization in particular on TItanium Nitride -B. Bliznakovska, M. Milosevskiin cooperation with S. Krawczynski, Ch. Meixner, H.-A. Kotter (1993)GERMAN COOPERATION with the University "Kiril i Metodij", Skopje
16 Biomaterialsedited by J. Krawczynski, G. Ondracek (1993)GERMAN COOPERATION with the University of Skopje
17 CVD - Main Concepts, Applications and RestrictionsB. Bliznakovska, M. Milosevsklin cooperation with S. Krawczynski, Ch. Meixner, H.-A. Kotter (1993)GERMAN COOPERATION with the University "Sv. Kiril i Metodij", Skopje
18 Thessaloniki '91 Field Measurement Campaignedited by N. Moussiopoulos, G. Kaiser (1993)GERMAN-GREEK COOPERATION
19 Geochemistry and Tectonic Significance of thePan-African EI Sibai Window, Central Eastern Desert, EgyptGamal Mohamed Kamal EI Din Saber (1993)GERMAN-EGYPTIAN COOPERATION
20 A Transect from a Tectonic Melange to an Island-Arc in thePan-African of SE Egypt (Wadi Ghadir Area)Hani EI-Akhal (1993)GERMAN-EGYPTIAN COOPERATION
21 Coding Theory and Bilinear ComplexityS. Shokranian, M.A. Shokrollahi (1993)GERMAN-BRASILIAN COOPERATION
22 Experimental Design and AnalysisA. Kiprijanova, L. Markovska in cooperation with S. Krawczynski (1993)GERMAN COOPERATION with the University "Sv. Kiril i Metodij", Skopje
23 Progress in Diamond and Diamondlike Coatings ProcessingB. Bliznakovska, Ch. Meixner in cooperation with S. Krawczynski (1994)GERMAN COOPERATION with the University "Sv. Kiril i Metodij", Skopje
Scientific Series of the International Bureau
24 Reference Materials on the Project Improvement of Transmission Capabilityedited by J. Krawczynski, D. Povh (1994)GERMAN-SLOVENIAN-COOPERATION
25 Ino-German Project on Alternatives to CFCS for Refrigeration Applications.Technical Status ReportL.R. Oellrich, S. Srinivasa Murthy (1994)GERMAN-INDIAN COOPERATION
26 Untersuchungen im ternarsn System AI203-Si02-li02 zur Herstellungbiokeramischer PhasenTK Khalil (1994)GERMAN-EGYPTIAN COOPERATION
27 Materials Research for Information Technologyedited by G. Kaiser, N. Constantopoulos (1994)GERMAN-GREEK COOPERATION
28 Greek and German Tobacco VarietiesChemical Methods for the Identification of of Tobacco CultivarsP. Range, S. Divanidis (1995)GERMAN-GREEK COOPERATION