spt safety induction presentation

1

2

3

4

5

SPT’s primary objective is to receive raw natural gas from Temane, Pande & Inhassoro wells; the gas is then separated from any fluids, pressurised and supplied to our customers in Mozambique and South Africa.

In order to create a safe and healthy working environment its vitally important that anyone entering the SPT site is aware of and understands basic safety, health & environment requirements that govern our operations.

At SPT we are ISO 9001, ISO 14001 and OHSAS 18001 certified.

6

7

The protection against physical injury, equipment damage, property loss and others by anticipation, recognition, evaluation and control of hazards arising in or from the workplace that could impair the health and well-being of workers, taking into account the possible impact on the surrounding communities and the general environment.

Safety can also be defined as the set rules and regulations to control identified hazards and risk in order to eliminate or mitigate them to a level that the organizations considers acceptable.

8

9

Hazard is the potential of a substance, activity or process to cause harm. E.g.: Use of Grinder

Risk is the likelihood of a substance, activity or process to cause harm.E.g.: Sparks, Flying particles

10

11

12

1. Leadership, Commitment and Culture2. Legal and Other Requirements3. Risk Management & Management of Change4. SHE Strategic and Operational Planning5. Roles, Responsibilities and Accountability6. Training, Awareness, Competence, Behaviour and Consequence7. Communication, Consultation and Participation8. Assets Integrity9. Service Providers and Partners10. Emergency Preparedness & Response11. Documents, Records and Data Management 12. Monitoring, Measurement and Assurance 13. Incidents, Non Conformances and Action Management14. Performance Review, and Improvement

13

14

15

16

17

18

19

20

21

22

1. Zero Harm to People and Environment Every person (Sasol and Service Provider employees) has the right and

responsibility to STOP any unsafe act and/or condition immediately2. Compliance with Procedures & Work Instructions

Where specific Procedures & Work Instructions exists, all persons shall adhere strictly to the provisions and order of tasks

3. Personal Protective Equipment (PPE) The prescribed PPE shall be worn when –

• entering operating facilities • conducting work activities where the wearing of PPE is prescribed

4. Substance abuse No person shall enter operational facilities under the influence of or in the

possession of alcohol and banned substances – ZERO TOLERANCE5. Vehicle and Road Safety

No person (driver) shall violate the Driving Life Saving Behaviours (DLSB’s)

23

Mr R.U. Safe05.03.2013Production

Contactor working at height without Using a safety harness

Instructed person to immediatelySafely descend from height

For the reporting of:1.Unsafe Acts2.Unsafe Conditions3.Near Misses4.Commendable Act / Behaviour

24

Behavioural Based Safety ObservationsIs an education and observation process used to improve safety and reduce risk in the workplace using a proactive approach intended to observe, recognize and communicate with employees about workplace / task identified:• Rushing• Frustration• Fatigue• Complacency• Eyes not on task• Mind not on task• Line of fire• Loss of balance/traction/grip (which in turn increase the risk of injury) and others

NO NAME NO BLAME

25

In the unlikely event of an alarm you must: Remain calm, don’t panic, stop your work Listen the instructions given in PA Speakers or Two way Radios Go to your muster point or the nearest. Do not run.

Our Emergency phone number is 44 1111

All personal are required to follow the SPT Emergency procedure

SPT has a medical clinic on sitefor medical assistance

26

Video: Gas Processing Facility

Explosion de gas en Reynosa, Tamaulipas (2 angulos).mp4.mp4

27