keolis transit drivers ergonomics manual 1. contents 2 keolis commitment--------------------------4...

Keolis Transit Drivers Ergonomics Manual

1

CONTENTS

2

Keolis Commitment-------------------------- 4Introduction----------------------------------- 5Areas prone to risk--------------------------- 6Adjusting the seat---------------------------- 7Driving Tips---------------------------------- 13Steering Techniques------------------------- 14Secure and release Wheel chair------------ 16At Home- ------------------------------------- 17Take the break-------------------------------- 18Seat Adjustments----------------------------- 19

3

Stretches and Exercises-----------------21-32

Standing Stretches------------------ 21 Hands and Wrists------------------- 23Shoulders and Arms---------------- 26Back and Neck---------------------- 30

Conclusion------------------------------------33-34RECARO Seat adjustment -----------------36-38

Keolis TransitIS COMMITTED

TO YOUR HEALTH AND SAFETY

4

You can help us keep our commitment to providing you with a safe and healthy work environment. Please review the helpful information provided in this manual and begin adopting these safe practices in your daily routine.

You’ll be glad you did! 

INTRODUCTION

5

We all have the desire to be safe but the knowledge to do so must be learned. Over the years, Ergonomics have become a useful tool in preventing workplace illness and accidents which usually result from continuous repetition of the same motions exacerbated by awkward postures. This manual provides an overview of the basic guidelines needed to ensure a safe and comfortable workstation. An ergonomically correct work area coupled with the appropriate work habits, can conceivably eliminate the risk of acquiring repetitive motion disorders associated with driving your vehicle.

6

AREAS PRONE TO RISK

•NECK

•SHOULDERS

•LOWER BACK

•UPPER BACK

•FEET AND LEG

Adjusting The Driver’s Seat

7

•Height of the seat for the driver. The knees of the driver should be lower than the hip joints. Your feet must have enough weights on them for stability and to be able to reach all floor pedals and controls.

8

DISTANCE

•Distance from the seat to the knees. Keep 2” to 4” inches of space between the front edge of the seat and the back of your knees. Move your seat forward enough to reach all foot pedals and to see ahead..

9

TILT

•The Tilt of your seat back. Adjust the seat back so you are sitting nearly completely vertically (upright).

At most, you should be tilted back 10 degrees.

The lumbar support should fit comfortably into the curve of your lower back. Your back should not be rounded, try to maintain the natural inward curve of your spine. Use the chair back for support. There should not be any pressure in your buttock area.

10

FRONT SECTION OF SEAT

(If there is a separate section from the main seat.)

This section of the seat should be set to slope slightly downward; NEVER UPWARD!

Again keeping the edge of the seat 2” to 4” away from the back of your knees.

11

BACK OF THE SEAT 

DO NOT “mold” your spine to fit the seat! Instead do the following:  • Adjust the built-in cushioning at middle and low back so that the seat is molded to fit the individual curves of your spine.

• If the built-in adjustments are not sufficient, you may have to add your own cushions (or folded towel or sweater, etc.)

12

NECK SUPPORT

•The neck support should reach the base of the skull (the large “bump” at the back of your head) without you having to move your head backwards.

13

TIPS TO FOLLOW WHEN DRIVING

• Do Not move your chin or head forward to see better. Instead, lean your whole trunk forward, tilting from the hip joint.

• Do Not slump down over the steering wheel . Note the posture of your back at any given time and keep it vertical.

• To reach controls in front, lean your whole trunk forward moving from the hips. Lift your arms up in front but do not let the shoulders or shoulder blades round forward.

14

STEERING WHEEL TECHNIQUES

Your hands should be at the 9 and 3 position on the wheel. You will be most comfortable and have the best control of the bus with your hands in this position. Never hook your thumbs under the wheel. The two acceptable techniques that are:

• The push-pull method. – With your hands correctly placed on the wheel, you can use the push-pull method to steer the bus. One hand pulls and the other pushes the wheel, depending on the direction in which you are turning.

• Hand-over-Hand method – Lean forward at the hip joint and grasp the wheel at 1 o’clock with your right hand, palm down. Lean back and pull the wheel to 5 o’clock position. Lean forward and grasp the outside of the rim with your left hand at 1 o’clock. Lean back and pull to 5 o’clock. Repeat process until the bus is in the desired position.

15

PALMIMG THE STEEING WHEEL

IS NEVER ACCEPTABLE!!!

• This type of steering can begin to cause shoulder injuries and pain. It can also be deemed to be a Preventable Injury when making the determination in a Worker Compensation Claim investigation.

• and the fare box stand alone.

16

SECURING AND RELEASING WHEELCHAIR STRAPS

• Try keeping your spine straight as you reach for the straps and other controls.

•Bend from the hips and knees instead of from the waist if possible.

17

AT HOME

• Avoid sitting for too long - if you have already been sitting all day driving.

• When you do sit, don’t slouch – sit up straight or use a recliner chair, tilted back.

18

TAKE THE BREAK

•When given the opportunity, take the break.

• Even getting up for a drink of water will give your body the stretch it needs to be comfortable. Consider the stretches in the “Stretches and Exercise” section of this manual to help relax your muscles and improve circulation.

19

Keolis Transit/ USSC SeatsFleet Vehicle Seats

Pneumatic Lumbar support upper

For and Aft slide

Backrest Tilt

Seat Cushion Adjustment

Pneumatic Lumbar support lower

Pneumatic Lumbar support sides

20

Keolis Transit/ USSC SeatsFleet Vehicle Seats

Raise and Lower Seat Button pull out

and push in

Headrest

Armrest Adjustment

21

22

Stretches and Exercises

23

Hands and WristsHands and Wrists

•Outstretch your hands together, until you feel a mild stretch.

•Hold 5-8 second.

•Interlock your hands in front of you.

24

Hand and WristHand and Wrist

•Clench both fists and hold for 5 seconds.

•Spread your fingers as far as you can and hold for 5 seconds. Relax and repeat several times.

25

Wrists Wrists

•Hold your hands in front of you and bend your fingers at the knuckles.•Gently rotate your wrists so that the fingertips form circles in the air. •Repeat several times.

26

Shoulders and ArmsShoulders and Arms

•Slowly open your elbows outward while forcing your shoulder blades together until a stretch is felt.

•Hold 10 seconds.

•Interlock your fingers behind your head.

27

ArmsArms

• Stretch your left arm around your neck.

•Hold for 15 seconds.

•Repeat with right arm.

28

Shoulders Shoulders

•Tilt your head to your left shoulder and stretch your neck.

•Hold 10-15 seconds.

•Repeat with the right shoulder.

29

ShouldersShoulders

•Relax your arms at your side then raise your shoulders.

•Rotate them up and down in a circular motion.

• Repeat several times.

30

•Keep your head down and your neck relaxed.

•Lean forward to stretch your neck.

•Hold 10 - 20 seconds.

Back and NeckBack and Neck

31

NeckNeck

•Turn your head slowly to the left for 5 seconds

•Turn your head slowly to the right for 5 seconds.

• Repeat several times.

32

BackBack

•Hold 8 - 10 seconds

•Repeat other side.

•Gently turn your torso at the waist.

•Stretch your elbow above your shoulder until you feel the stretch.

33

CONCLUSION

This manual was devised and developed by the Safety and Training Department with documentation support from TSI, Memorial Hospital Occupational Health Services, RECARO USSC, RTC and Keolis staff. In order to minimize and/or prevent health hazards associated with the work place. Please incorporate the information provided in this manual in your daily routine at home and at work.

34

If after viewing these materials, and you have any questions or concerns,

feel free to contact the Safety, Training, & Security Director for: Keolis

Keolis Transit

Cecil Fielder; Safety, Training, & Security Director 702 851-2602

Leyanne Lacaran; Subrogation and Claims Supervisor 702 851-2645

35

Receipt of Employee Ergonomics Manual I have received my copy of the Keolis Transit Drivers Ergonomics Manual. I have read and been trained in its use. I understand and will comply with the information it contains.Since the information in this manual is necessarily subject to change as situations warrant, it is understood that changes in this manual may supersede, revise, or eliminate one or more of the sections in this manual. These changes will be communicated to me by my supervisor or through official notices. I accept responsibility for keeping informed of these changes.

Name [Please Print]_______________________________________________________

Signature__________________________________________________Date__________

Instructor _________________________________________________Date __________

Training Time ________________________

36

The RECARO Ergo M Seat

37

38