african development bank group · pdf fileafrican development bank group ... iaa associates...

African Development Bank Group

African Development Bank's Field Office in Abuja,

Nigeria

LOT 3: VOL 3 ‐ BILLS OF QUANTITIES: ELECTRICAL

WORKS

Prepared by Interstate Architects Ltd.

In Conjunction with: IAA Associates Ltd.

KOA Associates Ltd. & Construction Economists Partnership Ltd.

APRIL, 2015

AFRICAN DEVELOPMENT BANK: ABUJA FIELD OFFICE, NIGERIAELECTRICAL SERVICES BOQ

ITEM BILL No. 1 - ELECTRICAL SERVICES: MAINS SUPPLY, DISTRIBUTION & EARTHINGDESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

PHCN CONNECTION

1 Allow for PHCN connection at 11KV including all charges, fees, poles, isolators,skipper panel/metering facilities, etc.(contractor must provide details/breakdown)Meters to include PHCN KVA(Max), KWHr & KVAr etc. sum

Supply, install and connect the following:

2 HV Switchgeara 11kV, 50Hz, 400A 250MVA free standing HV panel with 4No. sections

and comprising of:INCOMING SECTION - 1No.630A TP SF6 withdrawable circuit breaker complete with shunt trip coil,closing coil, locking magnet andindicators for open, close and trip operations with solid state protection relay, surge arrestors, space heaters, hygrostat, multimeter and current transformers etc.BUS/METERING SECTION - 1No.1No 630A TP SF6 withdrawable circuit breaker complete with shunt trip coil, closing coil, locking magnet and indicators for open, close and trip operations with space heaters, voltage transformers and current transformers etc.OUTGOING SECTION - 2Nos.2No @ 630A TP SF6 withdrawable circuit breaker complete with shunt trip coil, closing coil, locking magnet and indicators for open, close and trip operations with solid state protection relay, surge arrestors, space heaters, hygrostat, multimeter and current transformers etc.e.g. Merlin Gerin, ABB or Approved equal. 1 No

b Tripping unit c/w trickle charger and battery cabinet 1 ,,

c Control and monitoring panel for Bucholtz and Winding temperature devices on transfomers complete with indicators, push button controls etc. 2 ,,

3 TRANSFORMER

650kVA 11/0.4kV, 50Hz Dyn1, ONAN oil immersed step-down transformer c/w bucholz & winding temperature protection, oil conservator tank with silica-gel breather, cable boxes etc. The transformer shall be the type without feedhorns.e.g. Elco, ABB or approved equal 2 ,,

4 Generator350KVA, 50HZ, 400V, turbo-charged, electric start, water cooled, Prime diesel generator complete with heat exchangers. The generator shall be The soundproof type. Engine shall be rigidly coupled to a self regulating alternator with necessary instrumentation and Controls mounted on the set. The set is to be fitted with the following; - Integral base tank to manufacturers standard. - Generator exhaust system comprising of horizontal black mild steel pipe with line silencer and a vertical section terminating in a goose neck to the set and shall be the residential type. - Allow for the extension of the generator exhaust by 3m. - Spare parts for 5000hrs operation.e.g. Cat, Cummins engine generator or Approved equal 3 ,,

Page1/1 To Collection

AfDB NGFO: ELECTRICAL WORKS BOQ 1



RATE RATE COST

5 LOAD SHARING/SYCHRONISING/AMF Control

Auto-mains failure start/change over, synchronising control panel &load sharing e.g. Legrand, Mane, or Approved equal. 1 No

6 Main Switch Board(MLVP)Free standing/wall mounted 500V, 1250A rated busbars, switchboard comprisingIncomer - 3No 630A 4p ACB c/w overload, - 2No 1250A 4p ACB c/w overload,Bus Section - 1No 630A 4p MCCB c/w overload,c/w overload, earth fault protection including shunt trip coil etc., local LEDfault indicators, Ammeter and Voltmeter with seven position selector switch and current transformers etc.Outgoingcomplete with 32A busbars, AC/3 rated contactorsand external lighting contactor and photocell kit and override switch - 1No 630A TPN ACB c/w meters

- 2No 200A TPN MCCB - 6No 100A TPN MCCB - 4No 63A TPN MCCB - 5Nos 45A TPN MCCB - 2Nos 32A TPN MCCB - 1No 25A TP MCCB - 1No 40A SPN MCCB - 1No 5A SP MCB - 8Nos 20A SP MCB c/w contactor - Surge diverter as specified.e.g. Legrand, Mane, or Approved equal. 1 "

7 Main Office Sub-panel(SMB - M)Free standing/wall mounted 500V, 800A rated busbars, switchboard comprisingIncomer - 1No 630A TPN ACB c/w metersOutgoing - 1No 400A TPN MCCB - 1No. 200A TPN MCCB - 1No. 100A TPN MCCB - 8No 63A TPN MCCB - Surge diverter as specified.e.g. Legrand, Mane, or Approved equal. 1 No

8 Ground Floor Panel(SMB-G)Wall/free standing floor sub-main board(SMB's) comprising of:Incomer:200A TPN MCCB, 200A busbars with ammeters, voltmeter with selector switchoverload, earth fault protection including shunt trip coil etc., local LED fault indicators, Ammeter and Voltmeter with seven position selector switch and current transformers etc.Outgoing - 4Nos. 63A TP MCCB - 2Nos. 32A TP MCCBe.g. Legrand, Mane, or Approved equal. 1 "

Page 1/2 To Collection




RATE RATE COST

9 Roof Terrace (Fifth) floor panel(SMB-R1)Wall/free standing floor sub-main board(SMB's) comprising of:Incomer:400A TPN MCCB, 400A busbars with ammeters, voltmeter with selector switchoverload, earth fault protection including shunt trip coil etc., local LED fault indicators, Ammeter and Voltmeter with seven position selector switch and current transformers etc.Outgoing - 2Nos. 63A TP MCCB - 16Nos. 32A TP MCCBe.g. Legrand, Mane, or Approved equal. 1 No

10 Roof (Sixth) floor panel(SMB-R2)Wall/free standing floor sub-main board(SMB's) comprising of:Incomer:100A TPN MCCB, 160A busbars with ammeters, voltmeter with selector switchoverload, earth fault protection including shunt trip coil etc., local LED fault indicators, Ammeter and Voltmeter with seven position selector switch and current transformers etc.Outgoing - 2Nos. 16A TP MCCB - 11Nos. 32A TP MCCBe.g. Legrand, Mane, or Approved equal. 1 No

11 UPS BusbarWall mounted UPS busbar comprising of:Incomer:100A TP MCCB, 100A busbarsOutgoing - 2No 100A TP MCCBe.g. Legrand, Mane, or Approved equal. 1 "

12 UPS Equipment

- UPS system to be configured for 1+1 parallel redundant operation - Supplied c/w network cards (RJ45) for link to IT System

a True On-line, 1+1 Mode, Liebert NX Series 60KVA 3-Phase in/out, 50Hz, 415V UPS with the following: - 1+1 Module for the applicable series & 10m Cable - Integral by-pass switch - Battery Cabinet with Battery CCT Breaker -15-minute Autonomy Battery String -3-yr life - operating softwares for remote monitoringE.g. Liebert NX Series or approved equal 2 "

b Suitable 60kVA automatic voltage regulator with resettable time delay and integral circuit breaker and LCD display e.g. Claude Lyons 2 ,,

c Installations & Configurations Lot





RATE RATE COSTSupply, install and connect:

Distribution Boards

1 63A TPN 8-way floor UPS distribution board c/w type 3 Mcbs withintegral isolator and 63A TPN 300mmA RCD e.g. Legrand, MK Electric or approved equal 5 No

2 63A TPN 10-way floor distribution boards c/w type 3 Mcbs integral isolator and 63A TPN 300mmA RCD e.g. Legrand, MK Electric or approved equal 6 "

3 40A TPN 6-way Security House distribution boards c/w type 3 Mcbs integral isolator and 40A TPN 300mmA RCD e.g. Legrand, MK Electric or approved equal 1 "

4 40A SPN 8-way Plantroom consumer unit c/w type 3 Mcbs integral isolator and 40A SPN 300mmA RCD e.g. Legrand, MK Electric or approved equal 1 "

5 40A SPN 8-way Water treatment plantroom consumer unit c/w type 3 Mcbs integral isolator and 40A TPN 300mmA RCD e.g. Legrand, MK Electric or approved equal 1 "

Switch Disconnectors(IP65)

6 100A TP switchdisconnector as UPS & Fire pumps isolatorse.g. Legrand 221 07 or approved equal 2 No.

7 63A TP switchdisconnector as Lift, WTP & AHUs Isolatorse.g. Legrand 221 06 or approved equal 6 "

8 45A TP switchdisconnector as irrigation & Fountain pump set isolatorse.g. Legrand 221 04 or approved equal 4 "

9 32A TP switchdisconnector as A/C outdoor units, Sewage lift pump set isolatorse.g. Legrand 221 03 or approved equal 15 "

10 25A TP switchdisconnector as diesel pump set isolatore.g. Legrand 221 02 or approved equal 2 "

11 16A TP switchdisconnector as hosereel pump set isolatorse.g. Legrand 221 01 or approved equal 4 "

12 16A SP switchdisconnector as water pumps isolatore.g. Legrand 043 01 or approved equal 10 "





RATE RATE COST

CablesAll cables to be kabelmetal, Bicc, Pirelli or approved equalAll cables are to be supplied complete with lugs, glands, cleats etc.

1 3x1c 95mm2 XLPE/SWA/TPE cable from HV panel to 650kVA transformer 120 m

a 1c 70mm2 TPE/TPE insulated cables as cpc for 13 above 120 ,,

2 1c 300mm2 TPE/TPE cable to the Main LV Panel from - Generators 720 m - Transformer 720 " - Main Building Panel (MB-SMB) 400 "

3a 4c 120mm2 TPE/TPE cable from MB-SMB to Roof Terrace Floor Panel (SMB-R1) 25 "b 4c 120mm2 TPE/TPE cable from MLVP to Chillers 200 "

4 4c 50mm2 TPE/TPE cable from MB-SMB to Ground Floor Panel (SMB-G) 20 "

5 4c 35mm2 TPE/TPE cable from MB-SMB to Roof panel (SMB-R2) 30 "

6 4c 16mm2 TPE/TPE cable from Main Building Panel to - Floor DBs ( RAW & CLEAN POWER) 60 " - AHUs 100 " - Lift Isolators 55 " - Pressurization Fans 150 " - Extractor Fans 120 "

7 4c 35mm2 TPE/TPE cable from MLVP to the UPS isolator 60 "

8 4c 25mm2 TPE/TPE cable from MLVP to Water Treatment Plant - Water Treatment Plant 15 " - Fire pump set 120 "

8 5c 16mm2 TPE/TPE cable from MLVP to - Sewage lifting pump set 150 " - Irrigation pump set 150 " - Fountain pump set 180 "

9 5c 10mm2 TPE/TPE cable from MB-SMB to - A/C outdoor Unit on the roof 480 " - Water Booster Pump set 30 " - Hosereel Pump set 40 "





RATE RATE COST

11 5c 6mm2 TPE/TPE cable from MLVP to the - Water Transfer Pump set 15 " - Borehole PUMP 50

12 3c 6mm2 TPE cables to - Diesel Pump 30 "

13 3c 6mm2 TPE/TPE cable for external lighting 1000 m

14 1c 2.5mm2 TPE/TPE cable within the external lighting pole 120 m






Earthing All cables to be kabelmetal, Bicc, Pirelli or approved equalAll cables are to be supplied complete with lugs, glands, cleats etc.

1 1c 300mm2 TPE cable from - Transformer to the earth bar 40 m - Generator to the earth bar 30 " - MLVP to the earth bar 10 " - Earth bars to earth electrodes 15 "

2a 1c 95mm2 TPE cable from Roof Terrace Floor Panel (SMB-R1) to MB-SMB earth bar 25 "b 1c 95mm2 TPE/TPE cable from Chillers to MLVP earthbar 200 "

4 1c 35mm2 TPE cable from Ground Floor Panel (SMB-G) to MB-SMB 20 "

5 1c 25mm2 TPE cable from Roof panel (SMB-R2) 30 "

6 1c 16mm2 TPE/TPE cable from - Floor DBs ( RAW & CLEAN POWER) 60 " - AHUs 100 " - Lift Isolators 55 " - Pressurization Fans 150 " - Extractor Fans 120 "

7 1c 25mm2 TPE cable fromthe UPS isolator 60 "

8 1c 16mm2 TPE cable from - Water Treatment Plant 15 " - Fire pump set 120 "

8 1c 16mm2 TPE cable from - Sewage lifting pump set 150 " - Irrigation pump set 150 " - Fountain pump set 180 "

9 Allow for equipotential bonding to all exposed metalwork such as cable trays, pipework etc. Lot

10 Floor Earth Terminal c/w insulators and channel base. Copper bar to be of 300mm2 csa minimum 3 No

11 IT room Earth Terminal c/w insulators and channel base. Copper bar to be of 300mm2 csa minimum 1 No

12 Earth Terminal c/w insulators and channel base. Copper bar to be of 500mm2 csa minimum 1 No

13 Concete inspection pit comprising: - 5 hole eath bar - 1.2m long 12.5mm diameter copperbond earth rods c/w Coupling and driving head - cable-to-rod lugsto achieve an earth resistance of =< 0.2 ohms 4 "

14 Allow for additional earthing sum






Cable Trays & PVC-U Pipes /Trunkings

1 225mmW x 50mm covered galvanised cable tray with admiralty pattern c/w all accessories such as bends,tees, end caps, couplings, Supports, brackets etc. 15 m

2 150mmW x 50mm covered galvanised cable tray with admiralty pattern c/w all accessories such as bends,tees, end caps, couplings, Supports, brackets etc. 20 "

3 225mmW x 50mm covered galvanised cable tray with admiralty pattern c/w all accessories such as bends,tees, end caps, couplings, Supports, brackets etc. to be color coated RED for LV riser 15 m

4 150mmW x 50mm covered galvanised cable tray with admiralty pattern c/w all accessories such as bends,tees, end caps, couplings, Supports, brackets etc. to be color coated RED for LV riser 20 "

5 150x50mm 3-compartment skirting trunking c/w covers, bends,couplersretainers, corners, accessory boxes etc.e.g. MK Prestige Plus Profile M or approved equal 250 "

6 150x50mm 3-compartment galvanised steel (or PVC-U) undersceed trunking c/w vertical access box, end caps couplers, brackets, concealed service boxes etc.e.g. MK Prestige Plus Profile M or approved equal 500 m

7 250x250mm Concealed service outlet box adaptors c/w 225-1503-compartment reducers e.g. MK Ega Slimeline Flushfloor FXSA 250/3-225 + SLR 225-150 or approved equal 100 No.

8 100mm diameter uPVC pipe c/w all accessories Lot

9 50mm diameter uPVC pipe c/w all accessories Lot

10 20mmD flexible conduit Lot

11 32mm dia uPVC pipe sleeve including accessories etc. Lot


COLLECTION

Page 1/1Page 1/2Page 1/3Page 1/4Page 1/5Page 1/6Page 1/7Page 1/8

Page 1 TO SUMMARY



ITEM BILL No. 2 - ELECTRICAL SERVICES: LIGHTING INSTALLATIONDESCRIPTION QTY UNIT BASIC FIXED TOTAL


Cables, Conduit etc. in Final Circuits -All cables to be Kabelmetal or approved equal

- Lumniaires are to be supplied complete control gears, fixing accessories, lamps etc.

- All fluorescent luminaires are to have power factor correction of 85% minimum.

1 20mm dia PVC-U conduit wired using 1c 1.5mm2 PVC cables as shown on drawing to each lighting fitting, socket, switch etc. 1012 No Lighting Fittings

Supply and Install the following

Ground Floor

2 600x600mm, 45W, recessed LED panel lighting luminaire for use with exposed Teeceilings. Fitting complete with LEDlite modulars driver & using highly efficient LED lamps. e.g. Thorn LT MOD45CW 207 "

3 Ditto but with 3hr integral emergency version 95 "

4 1190mm surface mounted fitting for use with 1x58W LED lamps. Fitting c/w lampand reflector. e.g. THORN INDUS LED, 96207574 or approved equal. 18 "


6 Circular surface mounted downlights for 12W(3500k) LEDs fitting to be completewith integrated white bezel decorative inner ring for enhance appearance.e.g. THORN BASELED 165 MCE 1x18W LED L935 HFX, 96107988 24 "

7 Ditto but with 3hr integral emergency versione.g. THORN BASELED 22 MRE 1x3W LED E3NMR 96107359 24 "

8 Vertical recessed mounted downlights for 18W(3500k) LEDs fitting to be complete with integrated white bezel decorative inner ring for enhanced appearance anddiffuser.e.g. THORN BASELED 165 MRE 1x18W LED L927 HFX, IP44, 96107984 orapproved equal 58 "

9 Ditto but with 3hr integral emergency versione.g. THORN BASELED 1K 165 MRE 1X18W LED L935 E3TX, 96107990 24 "

10 Decorative ceiling recessed low energy and high efficacy luminaire for use with 1x20W LED FL L840 GRY led lamp. Fitting complete with the driver and diffuser.e.g. THORN TIDON LED, 96107410 or approved equal 22 "


12 Ceiling mounted self contained single side exit sign with led strips and batteryfor sustained emergency lighting for 3hr duration. Self extinguishing polycarbonatedbody. Using 3W LED lamps.e.g. THORN VOYAGER SIGMA LED E3TX WHI 96233815 + 96233876 or approved eq 30 "




ITEM BILL No. 2(Contn'd) - ELECTRICAL SERVICES:LIGHTING INSTALLATIONS DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

13 A stylish recessed high-flux-led downlight, luminaire in die-cast aluminium withone-piece specular anodised reflector. Fitting complete with 1x34W LED lamps.e.g. THORN CRUZ 160 LED 34W L840 HFX or approved equal 132 No.


15 Recessed mini-spot LED luminaire in die cast aluminium body fitting complete withswitchable driver and decorative ring and reflector for use with 3x3W 4K LED lampse.g. THORN D-CO LED SPOTLIGHTS, 96107862 or approved equal 92 "


17 Recessed mini-spot LED luminaire in die cast aluminium body fitting complete withswitchable driver and decorative ring and reflector for use with 6x1.2W 4K LED lampse.g. THORN D-CO LED SPOTLIGHTS, 96107446 or approved equal 20 "


19 Circular surface(Wall) mounted downlights for 12W(3500k) LEDs fitting to be completewith integrated white bezel decorative inner ring for enhance appearance.e.g. THORN BASELED 165 MCE 1x18W LED L935 HFX, 96107988 17 "

20 Ditto but with 3hr integral emergency versione.g. THORN BASELED 22 MRE 1x3W LED E3NMR 96107359 12 "

21 wall mounted cylindrical floodlight LED luminaire in die-cast aluminium body,with up/down illumination for white (6000K) 2 x3W LED lampse.g. THORN CESAR LED 47 "





RATE RATE COST

EXTERNAL LIGHTING: SITE AND ANCILLARY BUILDING

1 Efficient symmetrical distribution floodlight employing intensive LED technologyfitting complete with heat dissipation sink and glass filter and remote control gear/connection box for 65W 240V 54LED whi/6000k. The fitting is to be in die-castaluminium suitable for ground mounting on a short strirrup, fitting sealed to IP66e.g. THORN CONTRAST LED 65W, 96254292 17 No.

2 Flange mounted, 1150mmH cylindrical shaped bollard of high vandal resistance with sand blasted polycarbonate sleeves covering high purity aluminium louvre opticalsystem. Material to be LM6 aluminium alloy. To have a single tamper resistant boltfor access to lamp & LED driver using 18x1.2W LED. IP54. fitting c/w antiglare band& small luminous conee.g. THORN PROMENADE BOL LED WHI/WHI 11500MM MPL ANT, 96252596 or approved equal 19 "

3 Decorative aluminium post-top luminaire with teflon coated reflector. Fitting complete with 3 meter pole and 32x1.1W high powered LED lamps. Lantern completewith drivers and heat sink. IP65 base station to 3m height, 76mm dia steel shaft column 7 bracket, ADELIE COL 3M CCO MPL ST FAI GRYe.g. THORN ADELIE 32W LED 5300K CL2 96254108 + 96254572(COLUMN) 11 "

4 1190mm surface mounted fitting for use with 2x58W LED lamps. Fitting c/w lampand reflector. e.g. THORN INDUS LED, 96207571 or approved equal. 37 "


6 Weatherproof 1190mm surface mounted fitting for use with 2x58W LED lamps. Fitting c/w lamp and reflector. e.g. THORN INDUS LED, 96207571 or approved equal. 4 "

7 Circular surface mounted downlights for 12W(3500k) LEDs fitting to be completewith integrated white bezel decorative inner ring for enhance appearance.e.g. THORN BASELED 165 MCE 1x18W LED L935 HFX, 96107988 2 "

8 Terminal base connector c/w 5A fuse/circuit breaker mounted in baseboard compartment of lighting column 30 "

EXTERNAL LIGHTING: HELIPAD LIGHTING

9 Round luminaire with grey painted aluminium frame and semi-frosted glassusing 7 X 2W LED lamps c/w lamp & fixing accessories for Touchdown and Lift-off areae.g. Thorn Mica Slim LED 96257472 or approved equal 16 "

10 Efficient symmetrical distribution floodlight employing intensive LED technologyfitting complete with glass filter and remote control gear/connection box for 24W 240V 18LED whi/3000k. The fitting is to be in die-castaluminium suitable for ground mounting on a short strirrup, fitting sealed to IP66e.g. THORN QBA LED 24W, 96254272 8 "





RATE RATE COST

Wiring AccessoriesAll gridswitches are to be complete with matching conduit boxes

1 Ceiling mounted PIR presence detector switch with built-in photocellcapable of switching On/off luminaires including LED lighting luminairse in response to room occupancy and daylight levels E.g. Thorn SwitchLite MRE SLD or approved equal 87 No.

2 Wall/Corner mounted PIR presence detector switch with built-in photocell, 110 degreecoverage and up to 12metre detection range. Capable of switching on/offluminaires including LED lighting luminairse in response to space occupancy and daylight levels. For corridors, staircases and toilets.E.g. Thorn SwitchLite SLD LONG RANGE or Approved equal 29 "

3 1-gang, plateswitch with 1-way 10A sp and white moulded cover platec/w screw plug e.g. Legrand Milac 6132 00 or approved equal 93 "

4 Photo Electric (Dusk/Dawn) switch for external lightinge.g. MK Masterseal 56748 GRY 1 "


6 1-gang, intermediate plateswitch 10A sp and white moulded cover platec/w screw plug e.g. Legrand Milac 6132 16 or approved equal 14 "

7 2-gang, intermediate plateswitch 10A sp and white moulded cover platec/w screw plug e.g. Legrand Milac 6132 17 or approved equal 3 "







RATE RATE COST

Wiring Accessories (Contn'd)

10 3-gang, plateswitch with 1-way 10A sp and white moulded cover platec/w screw plug e.g. Legrand Milac 6132 04 or approved equal 1 No.

11 1-gang, plateswitch with 1-way 65-500W dimmer switch and platewhite moulded cover c/w screw plug e.g. Legrand Milac 6133 01 or approved equal 1 "





COLLECTION

Page 2/1

Page 2/2

Page 2/3

Page 2/4

Page 2/5

Page 2 TO SUMMARY



ITEM BILL No. 3 - ELECTRICAL SERVICES: POWER INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST Supply, erect and connect the following:

Conduit Cables, Accessory boxes for Final Circuits

1 20mm dia PVC-U conduit wired in radial circuit using 1c 2.5mm2 PVC cable to each 13A RAW power SSO, and flex etc. c/w separate CPC

(earth wire) per circuit accessory boxes etc. 468 No

2 20mm dia PVC-U conduit wired in radial circuit using 1c 4mm2 PVC cable to each 15A outlet & water heater outlet

c/w separate CPC (earth wire) per circuit accessory boxes etc. 3 "

Wiring Accessories

3 13A twin-gang switchsocket outlet with white moulded coverplatec/w screw plug as RAW power outlete.g. Legrand Milac 6132 64 or approved equal 560 "

4 13A 1-gang switchsocket outlet with white moulded coverplatec/w screw plug as RAW power outlete.g. Legrand Milac 6132 61 or approved equal 3 "

5 13A flex outlet with white moulded coverplatec/w screw plug(fan coil unit,hand-drier, water heater etc)e.g. Legrand Milac 6132 42 or approved equal 90 "

6 Weatherproof 13A 1-gang switchsocket outlete.g. Legrand Milac 6132 61W or approved equal 5 "

7 Flush 15A dp switch with flex outlet in base & neon. White moulded coverplate.e.g. Legrand Milac 6132 68 or approved equal 3 "

Page 3/1 TO SUMMARY



ITEM BILL No. 4 - ELECTRICAL SERVICES: FIRE DETECTION AND ALARM SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

Supply, erect and connect the following:

Supply and deliver to site, moving into position, erection, connecting up,witness testing, proving to insurance inspectors, demonstrating to the Employer, commissioning and maintenance of the complete Installation outlined in this specification and in the drawings.

Conduit, Cables & Accessory boxes 1 25mm dia upvc conduit c/w draw wire to each trigger device and

sounder from Fire Alarm Control Panel, Repeat and Mimic panels, Voice control units etc 260 No

2 Enhanced 2c 2.5mm2 LSHF cable to each trigger device, sounder and sounder from Fire Alarm Control Panel, Repeat and Mimic panels, Voice control units etce.g. FS Cables 387E02502 260 "

3 1c 1.5mm2 LSHF flexible speaker cable e.g. FS Cables 24901503 36 "

Equipment & Trigger devices

All devices are to be supplied/installed c/w proprietaryterminal plates, accessories etc.

4 Addressable monitored optical smoke sensor e.g. Gent 34710 160 No.

5 Addressable monitored optical heat sensor e.g. Gent 34710 3 "

6 Addressable monitored optical duct smoke sensor e.g. Gent 34760 6 "

7 Addressable monitored manual call point e.g. Gent 34800 18 "

8 Addressable 2-way electronic sounder with weatherproof kite.g. Gent 34202 30 "

9 Model S3. programmable sounder/strobe c/w short circuitand remote control. e.g. Gent S3-SN-ST-R 3 "

10 Mains powered Interface unit + 24Vd.c relay e.g. Gent 34440+19104-52 2 "

11 150mm Dia, 6W round metal Ceiling Speaker e.g. Gent vigilon 13421-14-DC 36 "




ITEM BILL No. 4(Contn'd) - ELECTRICAL SERVICES: FIRE DETECTION AND ALARM SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

12 Addressable 4-loop microprocessor based Vigilon Fire Control Panel c/wintegral back-up battery, NIC, terminal node etc e.g. Gent Vigilon Vig1 + 3xVIG-LPC+ VIG-NC+VIG-1ST-FIX-G +VIG-DOOR-SS+VIG-FLUSH-SS 1 No.

13 Vigilon Repeat Panel c/w integral battery and power supplye.g. Gent Vigilon VIG-RPT + VIG-RPT-1ST-FIX+VIG-RPT-DOOR-SS +COMPACT-FLUSH-SS 2 "

14 Vigilon Master Audio Control unit with network, integral emergency microphone and desk console/emergency microphonee.g. Vigilon VA-1312+VA1315 1 "

15 Distributed Amplifier Unit with Zonal amplification, Survellaince, routing,power supply and battery, control interfaces, fault display, user interface,network interface and vigilon loop interfacee.g. Vigilon 200W DAU 1 "

16 BMS ControlSignalling/controlling (LSHFcables, cabling including all required accessories) to BMS controller (IQ) from contacts in control panel Lot


COLLECTION

Page 4/1

Page 4/2

Page 4 TO SUMMARY



ITEM BILL No.5 - ELECTRICAL SERVICES: CENTRAL TV SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST Supply, erect and connect the following:

-Contractor shall include report, brochures and schematic diagrams including method statement for this service. Non compliance may disqualify bid

-Client to give final approval on equipment and material product specifications/selection

- All products to be cisco or approved equal. Installer/supplier to ensurethat equipment selection are carried out such appropriate hierearchy aremaintained at all times

- All products to be supplied c/w the propreitary software, accessories etc.

Conduit, Cables & Accessory boxes etc.

1 25mm dia uPVC conduit c/w accessory & draw boxes, couplers, locknuts etc c/w draw-wire cable to each TV outlet from amp/splitters etc. 12 No.

2 75 ohms low loss 100% shielded co-ax cable to each outlet from amp/splitters etc. 12 "

3 Cat 6 utp cable to each hubs, switches, outlets to TV sets etc.e.g. Systimax, BrandRex, Avaya Lots "

Equipment and Wiring Accessories

4 Satellite dish e.g. Orbitron ST-10 or approved equal 2 No.

5 C-Band LNB/feed Horn e.g. Chaparral combo or approved equal 1 "

6 Multi-channel indoor head end mixer/amplifiere.g. Teleste CM 720 or approved equal 1 "

7 In-line transient overvoltage protectione.g. Furse ESP CCTV/B or approved equal 3 "

8 Integrated DSTV signal receiver/decoder for public usee.g. Multichoice or approved equal 1 "

9 Signal modulatorse.g. Drake VM 400 or approved equal 12 "

10 Pre-amplifier(for weak signals only)e.g. Teleste CM 7263 or approved equal 12 "

11 12-way RF coupler 1 "

12 12-way active signal splitter/coupler e.g Labgear 1

13 4-way active signal splitter e.g Labgear 1 "

14 4-way small gain amplifier/splitter e.g Labgear 3 "




ITEM BILL No.5(Contn'd) - ELECTRICAL SERVICES: CENTRAL TV SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

15 Single TV socket with cover plate (Legrand Galea 7759 66 + 7778 66) 12 Nos.

16 Free standing, full sized, 19" Telecommunication cabinet with glass door and lock c/w earthing set etc. 3 "

17 Power supply unit(1500VA) 2 "

18 Cat. B line protectione.g. Furse ESP240 or approved equal 2 "

19 Miscellaneous wiring accessories, end of line units, etc (please indicate) Lot


COLLECTION

Page 5/1

Page 5/2

Page 5 TO SUMMARY



ITEM BILL No. 6 - ELECTRICAL SERVICES: CONFERENCING SYSTEMS INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

Supply, erect and connect the following: -Contractor shall include report, brochures and schematic diagrams including

method statement for this service. Non compliance may disqualify bid

- All products to be bosch, cisco or approved equal. Installer/supplier to ensure that

Equipment selection are carried out such appropriate hierearchy are maintained at all times

-System to be supplied c/w all required equipment/devices for

effectice operation of the entire installation.

-All products to be supplied c/w the propreitary software, accessories etc.

-All products and software to be the the most recent/current at the time of delivery.

- All servers to be supplied c/w appropriate/approved software & licencing

Conduit & Accessory boxes

1 25mm dia upvc conduit c/w draw wire to each wired delegate units,chairman unit, interpreter unit, LCD screens, Monitors, etc from the equipment rack 528 No

2 Cat 7 utp cable from the equipment rack to each unit outlet etc. 528 ,,e.g. Systimax, Avaya or approved equal

3 4core optic fibre cable(back-bone) c/w termination kits and color codedfor ease of identification e.g Avaya 50 m

Equipment, Accessories & Cables

4 Multi-function delegate unit c/w the following: - channel selector with number display and abbreviated channel nos, - haedphone socket and volume control, graphic LCD display - 5 soft buttons( also as voting buttons), battery packs, - rims, headphone socket, long stem pluggable microphone and power supplye.g BOSCH DCN-CONFF Concentus Full function or approved equivalent 60 ,,

5 Multi-function chairman unit c/w the following: - priority key,channel selector with number display and abbreviated channel nos - haedphone socket and volume control, graphic LCD display - 5 soft buttons( also as voting buttons), battery packs, long stem pluggable microphone, - rims, headphone socket and power supplye.g BOSCH DCN-CONCM Concentus Chairman or approved equivalent 1 ,,

6 Interpreter desk unit c/w the following: - lon9 stem pluggable microphone, power supply, battery pack, - graphic LCD with backlighting, pre-select buttonse.g BOSCH DCN-WDCS-D or approved equivalent 3 ,,

7 Lightweight headphones with replaceable earpads. Lots

8 Central control unit capable of the following: - controlling a maximum of 245 wired/wireless contribution units - simultaneous interpretation functions & distribution of language channels - intercom function, standalone automatic camera control, voting control - microphone management etcc/w 500GB storage capacitye.g BOSCH CCU2 Central Control Unit or approved equivalent 1 Nos.

9 Battery charger capable of charging 65 batteries at a time Lot




ITEM BILL No. 6 (contn'd) - ELECTRICAL SERVICES: CONFERENCING SYSTEMS INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

10 Ceiling mounted Wireless Access Pointfor wireless discussion unit connectione.g BOSCH DCN-WAP or approved equivalent 1 Nos.

11 Interface Unit for interfacing the audio from the discussion system to a CobraNet network employing a standard ethernet networke.g BOSCH LBB 4404/00 or approved equivalent 1 ,,

12 Ip-based high speed Panoramic autodome, 360 degress per second pan & tilt speed cameras. 18x, 26x optical zoom day/night camera c/w pedestal mountingaccessories e.g BOSCH Autodome 300 series or approved equivalent 2 ,,

13 Ip-based high speed panoramic autodome, 360 degress per second pan & tilt speed cameras. 18x, 26x optical zoom day/night camera for ceiling mountinge.g BOSCH Autodome 300 series or approved equivalent 2 ,,

14 IP-based 16 camera input and 10 monitor output Automatic camera switcher c/w external PC or Control interface connector, keyboard connector etc.e.g BOSCH LTC 8200 Allegiant or approved equivalent 1 ,,

15 Full function keyboard with variable speed joystick control and display c/wextension cable and rack mounting kite.g BOSCH LTC 8555/00 or approved equivalent 1 ,,

16 High performance LCD video display monitor as operator disdplay unit 1 ,,

17 42" diagonal LCD HDTV screen with wireless adapter connector, USB connector and multimedia interface input.e.g Samsung, Sanyo or approved equivalent 10 ,,

18 Allow for pendant mounting and diagonal floor mounting accessories Lots ,,

19 Media presentation controller 1 "

20 8 channel transmitter c/w symmetrical audio input & interpreter modulee.g BOSCHINT-TX0 8 + LBB 3422/20 or approved equivalent 1

21 CD Recorder 1

22 HDD / DVD Recorder 1

23 12-port switch for cameras 2

24 Audio expander e.g BOSCH DCN LBB 4402/00 or approved equivalent 1

25 Ceiling mounted loudspeakers e.g. BOSCH LB2-UC15-L or approved equivalent 1

26 Central matrix module c/w control, HD-SDI, DVI inputs & outputs 1




ITEM BILL No. 6 (contn'd) - ELECTRICAL SERVICES: CONFERENCING SYSTEMS INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

27 Wireless language distribution system c/w transmitter, interface modules, infra-red radiator, 20nos. pocket receiversand earphones (quantity to be confirmed by the client), Charging unit and all accessories required for a functioning system. e.g. BOSCH Integus System or Approved equal 1 Nos

28 Standard credit-card format ID cards Lots

29 Proprietry SoftwaresThe system shall be equipped with all required proprietry software which includes the following: - Main Sotware module - Automatic Camera Control - Microphone management - Synoptic Microphone Control - Simultaneous interpretation - multi and parliamentry voting - Attendance registration and Access - Delegate database - Message distribution - Automatic Camera Control - Multi PC Control - ID Card encoder Lots

30 Standard credit-card format ID cards Lots


COLLECTION

Page 6/1

Page 6/2

Page 6/3

Page 6 TO SUMMARY



ITEM BILL No. 7 - ELECTRICAL SERVICES: BUILDING MANAGEMENT SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST

Supply, install and connect the following;

The BMS services shall cover all items/materials required to have in place an efficient and functional system in compliance with the design objective.

All devices shall be in compliance with standard LON Marked devices.

All Cables to be LSHF type

Conduit, Cables & Accessory boxes

1 20mm dia upvc conduit wired using multicore fire retardant power cables to each connected device, plant, equipment etc 125 No

2 20mm dia upvc conduit wired using multicore fire retardant control cable to each connected device, plant, equipment etc from the IQ controllers/sensors 125 "

3 25mm dia upvc conduit wired using cat 6 utp cable to each door controllers, work stations etc from hub 125 "

TECHNICAL ROOM

Main Control Console:4 Programmable Logic device console for multi-terminal

system management network comprising: - PLC central processing unit - 18-inch color visual display unit - 12-port digital input panel - Electronic relay system for audible alarm systeme.g. Trend 963 Supervisor system or approved equivalent. 1

5 3Hr. emergency battery power supply back-up foritem 'A' above. 1

6 Rack cabinet for items 'A' and 'B' above. (18u -600wx800d) 1

Equipment

7 IP based IQ controller with 32 bit platform for fan coil units, AHU's, pumps, door controllers, fire alarm panel, lighting controls, HV/MLVP panels etce.g Trend IQ3excite or approved equal 19 No

8 Proprietary Input/output module for the above 3 "

9 Integrated Services Router with firewall e.g. SuperStack II Router 400/SuperStack 3 Firewall, Cisco, 3com or approved equal 1 "




ITEM BILL No. 7(Contn'd) - ELECTRICAL SERVICES: BUILDING MANAGEMENT SYSTEM INSTALLATION DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COSTSupply, erect and connect the following:

10 24-port stackable 10/100Mbps ethernet switch for cat.5e cablee.g. Cisco, 3com or approved equal 1 "

11 Trend PC supervisor/server consisting of: - Niagara software BMS framework, wireless gateway, voice mail, sms notification, IP console, licences e.t.c.e.g. Trend 962 SUPERVISION 2 "

12 Mobile Smart Display Unit(SDU) e.g. Trend SDU 1 "

13 42 U Rack cabinet for for BMS panel 1

14 Allow for system interface with controlled/monitored equipment includinginstallation Lot

15 Standby Generators Controllers:

a BMS monitor controller with capacity for multiple universal input and one digital input eg Trend IQ228 or approved equivalent 2 No.

Monitors and sensors:

b Generator base tank mounted differential level switch 2 No.

c 0-400oC Flue gas engine temperature sensor c/w 230mm probe 2 No.

d Electronic status indicator relays to trigger controller digitalsignals to central console Lot

e Allow for multicore cabling to the Generators Synchronisation panel in Generator House from main control console in Technical room 250 m

16 Server RoomControllersBMS monitor controller with capacity for multiple universal input and one digital input eg. Trend IQ228 or approved equivalent 1 No.

Monitors and sensors

Digital powermeter for 400V, 50Hz supply with capability for voltage, current, KVA and kVAR measurement on 60kVA UPS equipment input and output terminals 6 No.

Electronic status indicator relays to trigger controller digital signals to central console Lot

Allow for multicore cabling to main control console in Main Technical Room 50 m





RATE RATE COST

14 Ventilation Air Handling UnitsControllers

a BMS monitor controller with capacity for multiple universal input and one digital input eg Trend IQ228 or approved equivalent 3 No.

Monitors and sensorsb AHU bag filter differential pressure sensor 3 Noc AHU sand filter differential pressure sensor 3 "d AHU FAN differential pressure sensor 3 "e AHU FAN start/stop sensor 3 "f AHU FAN status sensor 3 "g AHU FAN general alarm sensor 3 "h AHU FAN A/M switch 3 "i Modulating valve control 3 "j Motorized fire damper 3 "k Supply duct temperature sensor 3 "l Return duct temperature sensor 3 "

m Emergency stop for F.C.U. & Cassette type units Lotn Electronic status indicator relays to trigger controller digital signals to Loto central console

p Allow for multicore cabling to main control console in Main Technical Room via Telecomms Closet on roof level Lot

15 Staircase Pressurisation FansControllers

a BMS monitor controller with capacity for multiple universal input and one digital input eg Trend IQ228 or approved equivalent 3 "

Monitors and sensorsb Start/Stop sensor 3 "c On/Off status sensor 3 "d General alarm sensor 3 "e A/M switch FAF 3 "f Differential Pressure Switch sensor 3 "

g Electronic status indicator relays to trigger controller digital signals to Lotcentral console

h Allow for multicore cabling to main control console in Main Technical Room Lot





RATE RATE COST

16 Fire Alarm & Detection PanelsControllers:

a BMS monitor controller with capacity for multiple universal input and one digital input eg Trend IQ228 or approved equivalent 2 "

Monitors and sensors:

b Electronic status indicator relays to trigger controller digital signals to central console Lot

c Allow for multicore cabling to main control cosole in Main Technical Room 40 "

17 Access Control System

a BMS monitor controller with capacity for multiple universal input and one digital input eg Trend IQ228 or approved equivalent Lot

Monitors and sensorsb Control Signal to disable access control unit upon receipt of fire signal

from Fire Alarm Control Panel Lot

c Electronic status indicator relays to trigger controller digital signals to central console Lot

d Allow for multicore cabling to main control console in Main Technical Room Lot

18 CCTV System

a Allow for interface between the BMS and the CCTV system Lot


COLLECTION

Page 7/1

Page 7/2

Page 7/3

Page 7/4

Page 7 TO SUMMARY



ITEM BILL No. 8 - ELECTRICAL SERVICES: FM200 FIRE DETECTION & SUPPRESSION SYSTEM(SERVER ROOM)DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST


Supply and deliver to site, moving into position, erection, connecting up, witness testing, proving to insurance inspectors, demonstrating to the Employer, commissioning and maintenance of the complete Installation outlined in this specification and in the drawings.

Conduit, Cables & Accessory boxes 1 20mm dia upvc conduit c/w draw wire to each trigger device and

sounder from Fire Alarm Control Panel 2 No.

2 Enhanced multicore 2.5mm2 LSHF cable to each trigger device, sounder and sounder from Fire Alarm Control Panel, Repeat and Mimic panels, Voice control units etce.g. FS Cables 387E02502 2 "

DETECTION & ALARM

3 Gent Model 3295 Extinguishing Control Panel 1 No.

4 Gent Model 14112 Manual Call Point 1 "

5 Gent Model 7840 Optical Smoke Detector with Base 2 "

6 Gent Model 2511 Sounder 2 "

7 Gent Ionization Detector 2 "

8 24V D.C Flasher 1 "

9 Gent 3296 3 lamp status inducator unit c/w mode select & manual release Remote Status Indicator 1 "

10 6-Pair Cables 20 m

EXTINGUISHING SYSTEM

11 32kg FM200 Container Assembly suitable for 32litre FM200 agent c/w: - Suitable container brackets - Removable electrical solenoid - 0.2A - Pneumatic actuator - Manual 'strike' actautor - pilot hose - valve to pilot hose adaptor - discharge pressure switch - discharge hose - container and manifold bracket assembly - entrance warning sign and manual release sign e.g. Macron 1 No




ITEM BILL No. 8(Contn'd)- ELECTRICAL SERVICES: FM200 FIRE DETECTION & SUPPRESSION SYSTEM(SERVER ROOM)DESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COST


EXTINGUISHING SYSTEM( cont'd)

12 50mm Sch. 80 Pipe 3 m

13 40mm Sch. 80 Pipe 10 "

14 25mm Sch. 80 Pipe 20 "

15 Manual Release Sign 1 No.

16 Entrance Warning Sign 1 "

17 Manual release switch 1 "

18 Abort release switch 1 "

19 6mm BSPT X8mm BSPP Adaptor 1 "

20 20mm 360 degrees Discharge Nozzle 1 "

21 40mm 360 degrees Discharge Nozzle 1 "

22 Discharge delay valve 1 "

23 CO2 discharge valve 1 "

24 Installation Accessories Lot

25 BMS ControlSignalling/controlling (LSHFcables, cabling including all required accessories) to BMS controller (IQ) from contacts in control panel Lot


Collection

Page 8/1

Page 8/2

Page 8 TO SUMMARY



ITEM BILL No. 9 - ELECTRICAL SERVICES: EARTHING AND LIGHTNING PROTECTION SYSTEMDESCRIPTION QTY UNIT BASIC FIXED TOTAL

RATE RATE COSTSupply, erect and connect the following:

1 Indelec Prevectron 2 type S6.60 arrestor c/w 5m pole 1 set

2 20mm x 3mm bare HDHC copper tape e.g Furse TC 030 85 m

a Suitable saddles for the above e.g. CP205 Lot

3 25mm x 3mm PVC covered copper tape for use as down conductor (to be included in the structural column) e.g. Furse TC125 30 m

a D.C. clips for the above e.g. Furse CP210 Lot

4 25x3mm Screw down test clamp e.g. Furse CT305 100 No

5 25x3mm, 4-way copper square junction clampe.g. Furse CT105-FU 40 "

6 Lightweight inspection pit with plastic base and comprising: - 2No 1.2m long, 12.7mm dia copperbond earth rods - coupling, driving head and tape-to-rod clamps - 8-way earth bar on channel baseto achieve an overall earth resistance of <= 10 ohmse.g. Furse PT006+RB105+CG170+ST100+CR105 3 ,,

7 Lightning Flash counter 1

8 1c 70mm2 bare copper conductor for use as ring earth electrode c/wmatching lugs etc e.g Furse CB070 900 m

9 Allow for bonding to all exposed metalwork on roof level Lot

Page 9/1 TO SUMMARY



1 Bill No 1 - MAINS SUPPLY, DISTRIBUTION & EARTHING

2 Bill No 2 - LIGHTING INSTALLATION

3 Bill No 3 - POWER INSTALLATION

4 Bill No 4 - FIRE DETECTION AND ALARM SYSTEM

5 Bill No 5 - CENTRAL TV SYSTEM

6 Bill No 6 - CONFERENCING SYSTEM

7 Bill No 7 - BUILDING MANAGEMENT SYSTEM

8 Bill No 8 - FM200 FIRE DETECTION & SUPPRESSION SYSTEM

9 Bill No 9 - EARTHING AND LIGHTNING PROTECTION SYSTEM

Sub-Total

Add 5% VAT

Add 10% Contingency

Total

SUMMARY


african development bank group · pdf fileafrican development bank group ... iaa associates...

Documents