286700 to 286799 - technikhandel · 286700 to 286799 2247– 3 assemblies include all parts shown...
TRANSCRIPT
COPYRIGHT by BRIGGS & STRATTON CORPORATIONAll rights reserved. No part of this material may be reproduced or transmitted,in any form or by any means, electronic or mechanical, including photocopying,recording or by any information storage and retrieval system, without permissionin writing from Briggs & Stratton Corporation.
FORM MS–2247–4/99REPLACES FORM MS–2247–2/99
FILE IN SECT. 2 OF SERVICE MANUAL
286700 to 286799
Illustrated Parts ListModel Series
286700 to 286799TYPE NUMBERS
0102, 0103,0111 through 0119,0120 through 0129,0130 through 0139,0140 through 0149,0150 through 0159,0160 through 0169,0170 through 0179,0182 through 0190,0401 through 0425,0437, 0438, 0439,0441, 0442, 0443, 0450 through 0455, 0604, 0622, 0634,
TYPE NUMBERS1015 through 1029,1102, 1103, 1122,1137, 1139, 1141,1152, 1160, 1162,
1172,1182 through 1190,1193, 1194, 1196,1197, 1198, 1199, 1424,1425, 4015,
4016,4020 through 4031,
4515, 45164520 through 4529.
TO FINDTHE CORRECT NUMBER OF THE PART YOU NEED:
FOLLOW THE INSTRUCTIONS BELOW
A. Refer to Engine Model, Type and Code Number that is stamped on the blower housing of engine.Engine type numbers such as 0123 01 are listed only as 0123 in most instances. The two digits (01or 02, etc.) to the right of the space may be required for more accurate parts identification in someinstances. Select the Illustrated Parts List covering the correct Model Series and Type Number.
B. Refer to the Illustrations and compare the original part with Illustration. The number next to the illustration is the Reference Number. Assemblies include all parts shown in frames. All parts shownin assembly frames having individual reference numbers can be purchased separately.
C. After the Reference Number has been identified, refer to the Numerical text, where Reference andPrimary Part Number are listed. THE PRIMARY PART IS USED ON ALL TYPE NUMBERS EXCEPT THOSE TYPE NUMBERS UNDER “NOTE.”
D. If a “Note” appears below the Primary Part Number, it means that this part differs from the PrimaryPart for certain types. If your Type number is listed under “Note,” order the part referred to at the “Note.”
E. If your Engine Type Number does not appear after any part number listed under “Note,” use the Primary Part Number.
F. For Engine Type Numbers not covered by this book, check other Parts Lists having the same engine model or contact your source of supply.
PRINTED IN U.S.A.
286700 to 286799
2247–2 Assemblies include all parts shown in frames. 492
383
13
6A349
14
337
635
6
3
7
9 10
11REQUIRES SPECIAL TOOLSTO INSTALL. SEE REPAIRINSTRUCTION MANUAL.
307
306
552
668
1058 OWNER’S MANUAL
1019 LABEL KIT
691
1 2
322
8
869 871
322A
308
668322A
5 870
1 496413 Cylinder Assembly2 399265 Bushing/Seal Kit
(Magneto Side)3 �391086 Oil Seal
(Magneto Side)5 494240 Cylinder Head6 22963 Washer
(Cylinder Head)6A 94315 Washer
(Cylinder Head)7 �∅ 271866 Cylinder Head Gasket8 495735 Breather Assembly
––––––– Note –––––495734 Breather Assy.Used on Type No(s).0137, 0153, 0155,0166, 0184, 0190,0416, 0425, 0450,1137, 1184, 1190,1425, 4020, 4520.
9 �∅ 27803 Breather Gasket10 691666 Screw
(Breather Assembly)11 280100 Breather Tube13 94622 Screw
(Cylinder Head)
14 691109 Stud(Cylinder Head)(Used in Position #5and #6)––––––– Note –––––93781 Stud(Cylinder Head)Used on Type No(s).0113, 0116, 0118,0119, 0120, 0121,0123, 0124, 0144,0158, 0159, 0412,0418, 0419, 0423,0438, 4016, 4028,4031.
306 690459 Cylinder Shield307 94930 Screw
(Cylinder Shield)308 491490 Cylinder Head Cover322 94786 Screw
(Cylinder Cover)322A 94881 Screw
(Cylinder Cover)337 802592 Spark Plug349 94314 Nut
(Cylinder Cover)383 89838 Spark Plug Wrench552 491986 Governor Crank
Bushing
635 66538 Spark Plug Boot668 690510 Spacer691 �491323 Governor Shaft Seal869 261463 Valve Seat
(Intake)870 262924 Valve Seat
(Exhaust)871 261961 Guide Bushing
––––––– Note –––––231218 Guide Bushing(Brass Intake Valve)
1019 491255 Label Kit1058 273681 Owner’s Manual
(Emission)(Used After Code Date97063000).––––––– Note –––––273131 Owner’sManual(Emission)(Used Before CodeDate 97070100).272697 Owner’sManual(Non Emission)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–3 Assemblies include all parts shown in frames. 493
26
27
31
25
27
28
34
33
36
3540
40A
45
4542
357
810
733
146
111
709
1616A
24
741146
741
759
757
761
758
759
758A
32
29
32A
16 693944 Crankshaft(Used After Code Date95080200).––––––– Note –––––498971 Crankshaft(Used Before CodeDate 95080100).
16A 496784 Crankshaft24 222698 Flywheel Key25 394661 Piston Assembly
(Standard)––––––– Note –––––394662 PistonAssembly(.010” O.S.)394663 PistonAssembly(.020” O.S.)394664 PistonAssembly(.030” O.S.)
26 391780 Ring Set(Standard)––––––– Note –––––392331 Ring Set(Std. Chrome)391781 Ring Set(.010” O.S.)391782 Ring Set(.020” O.S.)499999 Ring Set(.030” O.S.)
27 691299 Piston Pin Lock(Used After Code Date95101500).––––––– Note –––––260924 Piston PinLock(Used Before CodeDate 95101600).
28 498319 Piston Pin(Standard)––––––– Note –––––299691 Piston Pin(Standard)(Used Before CodeDate 95101600).
498320 Piston Pin(.005” O.S.)391286 Piston Pin(.005” O.S.)(Used Before CodeDate 95101600).
29 494504 Connecting Rod(Standard)––––––– Note –––––495490 ConnectingRod(.020” Undersize)
31 222299 Rod Screw Lock
32 94695 Screw(1 7/8” Long)(Connecting Rod)
32A 94648 Screw(1 5/8” Long)(Connecting Rod)
33 262246 Exhaust Valve34 262247 Intake Valve35 65906 Valve Spring
(Intake)36 26828 Valve Spring
(Exhaust)40 221596 Valve Retainer
(Intake)40A 292260 Valve Retainer
(Exhaust)42 494553 Valve Keeper45 262248 Valve Tappet
111 94160 Retainer Pin146 94196 Timing Key357 91540 Drive Pulley Key709 262243 Eccentric733 94673 Screw
(Crankshaft Extension)741 691284 Timing Gear757 213998 Counterweight Link758 399891 Counterweight
758A 692423 Counterweight759 691239 Counterweight Pin761 691096 Screw
(Counterweight)810 231828 Crankshaft Extension
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–4 Assemblies include all parts shown in frames. 494
46
43
22
15
20
12
15A
4
20
19
4 494238 Engine Sump12 �271916 Crankcase Gasket
(.015” Thick, Std.)––––––– Note –––––�271997 CrankcaseGasket(.005” Thick)�271996 CrankcaseGasket(.009” Thick)
15 94239 Oil Drain Plug15A 690341 Oil Drain Plug
19 490666 Bushing/Seal Kit(PTO Side)
20 �291675 Oil Seal(PTO Side)
22 692125 Screw(Engine Sump)
43 490815 Governor/Oil Slinger46 212897 Camshaft
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–5 Assemblies include all parts shown in frames. 495
REQUIRES SPECIAL TOOLSTO INSTALL. SEE REPAIRINSTRUCTION MANUAL.
950
130
95 987
147
51
142 105
137
104
186
108A
634
108231
93
131 133
106
975
276
LMT NUMBERLOCATION
987A
53
654
50
54
51A692
127
THIS CARBURETOR SERVICES BOTH CHOKE–A–MATIC AND MANUAL CHOKE SYSTEMS
634A
1091
141A
98
94
141125
94A
134
50 213819 Intake Manifold51 ��272465 Intake Gasket
51A �∅ 272554 Intake Gasket53 691098 Stud
(Carburetor)54 94913 Screw
(Intake Manifold)93 690602 Throttle Shaft Bushing94 498030 Idle Mixture Kit
94A 494383 Idle Mixture Kit95 �94098 Screw
(Throttle Valve)98 495800 Idle Speed Kit
104 �690525 Float Hinge Pin105 �231855 Float Needle Valve
(Used After Code Date92071900).
106 Inlet Seat(See Next Page)
108 690464 Choke Valve108A 692344 Choke Valve
125 Carburetor(See Next Page)
127 � Welch Plug(Sold in Kit Only)
130 224539 Throttle Valve131 494379 Throttle Shaft Kit133 494381 Carburetor Float134 �494788 Needle/Seat Kit
(Gravity Feed)(Used Before CodeDate 92072000).––––––– Note –––––398188 Needle/SeatKit(Pump Feed)(Used Before CodeDate 92072000).
137 ��281165 Float Bowl Gasket141 495097 Choke Shaft Kit
(Manual Choke)141A 495931 Choke Shaft Kit
(Choke–A–Matic)(Used After Code Date92091400).––––––– Note –––––494380 Choke Shaft Kit(Choke–A–Matic)(Used Before CodeDate 92091500).
142 Carburetor Nozzle(See Next Page)
147 �497472 Pilot Jet(LMT 1, 2, 3, 4, 5, 7,37, 38, 39, 40, 41, 77,78, 79, 80, 81)
186 493496 Hose Connector231 �94098 Screw
(Choke Valve)276 ��281164 Sealing Washer634 �690801 Spring/Seal Assembly
(Manual Choke)634A �690802 Spring/Seal Assembly
(Choke–A–Matic)654 94010 Nut
(Carburetor)692 262820 Detent Spring950 94642 Screw
(Float Bowl)975 495933 Float Bowl987 �691326 Throttle Shaft Seal
987A �281167 Throttle Shaft Seal(LMT 1 thru 5, 7, 37thru 41)
1091 691333 Limiter Cap
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–6 Assemblies include all parts shown in frames. 496
REQUIRES SPECIAL TOOLSTO INSTALL. SEE REPAIRINSTRUCTION MANUAL.
142 106
LMT NUMBERLOCATION
THIS CARBURETOR SERVICES BOTH CHOKE–A–MATIC AND MANUAL CHOKE SYSTEMS
125
134
106 �231854 Inlet Seat(Gravity Feed)(Used After Code Date92071900).––––––– Note –––––�280328 Inlet Seat(Gravity Feed)(Used Before CodeDate 92072000).
231856 Inlet Seat(Pump Feed)(Used After Code Date92071900).
125 498027 Carburetor(Gravity Feed)(Choke A Matic andManual Choke)(Used After Code Date96072500).––––––– Note –––––499158 Carburetor(Pump Feed)(Choke A Matic andManual Choke)(Used After Code Date96072500).Used on Type No(s).0137, 0153, 0155,0166, 0184, 0190,0425, 4020, 4520.495706 Carburetor(Choke A Matic andManual Choke)(Used Before CodeDate 96072600).
134 �494788 Needle/Seat Kit(Gravity Feed)(Used Before CodeDate 92072000).––––––– Note –––––398188 Needle/SeatKit(Pump Feed)(Used Before CodeDate 92072000).
142 �691434 Carburetor Nozzle(Standard)(LMT 92, 93, 94, 96)––––––– Note –––––�691425 CarburetorNozzle(Standard)(LMT 1, 2, 3, 4, 5, 7,37, 38, 39, 40, 41, 77,78, 79, 80, 81, 157,158, 159, 160)
497737 CarburetorNozzle(High Altitude)(LMT 92, 93, 94, 96)
497567 CarburetorNozzle(High Altitude)(LMT 1, 2, 3, 4, 5, 7,37, 38, 39, 40, 41, 77,78, 79, 80, 81, 157,158, 159, 160)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–7 Assemblies include all parts shown in frames. 497
267265
373520
359
507
559
270268269
271
188
216 216A
232202
216B
222222A 203
209
188 691693 Screw(Control Bracket)
202 262767 Mechanical GovernorLink
203 691381 Bell Crank209 691278 Governor Spring
––––––– Note –––––260695 GovernorSpringUsed on Type No(s).0129, 0137, 0138,0146, 0149, 0150,0155, 0157, 0159,0160, 0161, 0162,0163, 0164, 0167,0169, 0172, 0424,0425, 1124, 1137,1160, 1162, 1172,1194, 1197, 1198,1425, 4027, 4527.260871 GovernorSpringUsed on Type No(s).0102, 0103, 0114,0116, 0119, 0130,0131, 0134, 0140,0147, 0177, 0183,0401, 0403, 0411,0412, 0420, 0437,0438, 0439, 0441,0442, 0443, 0450,0452, 0453, 0454,0455, 0604, 0634,1103, 1183.
261126 GovernorSpringUsed on Type No(s).0184, 0185, 0422.261306 GovernorSpringUsed on Type No(s).0115, 0120, 0122,0124, 0136, 0141,0144, 0151, 0152,0166, 0173, 0186,0413, 0414, 0416,0417, 0622, 1021,1025, 1026, 1028,1029, 1122, 1141,1152, 1186, 4020,4021, 4025, 4026,4028, 4029, 4520,4525, 4526, 4528,4529.690576 GovernorSpringUsed on Type No(s).0118, 0126, 0176,0182, 0187, 0418,0419, 0423, 1182,1187.
216 262766 Choke Link216A 690574 Choke Link216B 691281 Choke Link
222 694042 Control Bracket(Used After Code Date99010700).––––––– Note –––––495611 ControlBracket(Used Before CodeDate 99010800).
222A 494041 Control Bracket232 262785 Governor Link Spring265 221535 Casing Clamp267 94906 Screw
(Casing Clamp)268 65616 Control Wire Casing
(Cut to RequiredLength)
269 26633 Control Wire(Cut to RequiredLength)
270 63426 Nut(Control Wire Casing)
271 290568 Control Lever359 92791 Washer
(Ground Terminal)373 90576 Nut
(Ground Terminal)507 398525 Insulator520 691084 Ground Terminal559 94896 Screw
(Remote Choke Stop)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–8 Assemblies include all parts shown in frames. 498
524
525
177
523287
847
851 334
333
404
742614
616
505
562
227
524
525A
441
177
523449
847A
177 �270920 O-Ring Seal(Dipstick)
227 691374 Governor ControlLever
287 94073 Screw(Dipstick)
333 492341 Magneto Armature334 94731 Screw
(Magneto Armature)404 94927 Washer
(Governor Crank)
441 224390 Oil Fill Bracket449 94874 Screw
(Oil Fill Bracket)505 691251 Nut
(Governor ControlLever)
523 495230 Dipstick524 �281370 Dipstick Tube Seal525 691398 Dipstick Tube
525A 495768 Dipstick Tube
562 691119 Bolt(Governor ControlLever)
614 93306 Cotter Pin616 495157 Governor Crank742 93307 E-Ring Retainer847 496415 Dipstick/Tube
Assembly847A 490474 Dipstick/Tube
Assembly851 493880 Spark Plug Terminal
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–9 Assemblies include all parts shown in frames. 499
DC ONLY DUAL CIRCUIT TRI–CIRCUIT 16 AMP 9 AMP
SEE SEE NOTE
877 877A 877B 877B
878A 878 878C 878A
501A
526
NOTE: ALL ALTERNATORS USE REF. NO. 1119 MOUNTING SCREW
501
ASSEMBLY FLYWHEELASSEMBLY
FLYWHEELASSEMBLY
SEE NOTEUNDER UNDER
878A
10 AMP
FLYWHEELSEE
ASSEMBLYFLYWHEEL
SEE
ASSEMBLYFLYWHEEL
SEE
ASSEMBLYFLYWHEEL
501
526A 526A
878A
878B
1054
356
356A729A
356B
920
789
474B474C474C474B474A474
356 398808 Stop Wire356A 494328 Stop Wire356B 690807 Stop Wire
474 391529 Alternator474A 393474 Alternator474B 392595 Alternator474C 393295 Alternator
501 394890 Regulator501A 491546 Regulator
526 690326 Screw(Regulator)
526A 94786 Screw(Regulator)
729A 691335 Wire Clip789 497708 Wiring Harness877 393814 Alternator/Connector
Wire877A 393456 Alternator/Connector
Wire877B 393537 Alternator/Connector
Wire
878 393362 Alternator Harness878A 393422 Alternator Harness878B 399916 Alternator Harness878C 392606 Alternator Harness
920 807829 Starter Solenoid1054 280275 Cable Tie1119 93621 Screw
(Alternator)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–10 Assemblies include all parts shown in frames. 4910
725
186A
601
240
958
957
182A
182
707846
179
707846179
480527
190
229
788
628385
387
183972
187
183A
601
918
179 94286 Screw(Fuel Tank Strap)
182 690443 Fuel Tank Bracket(R.H.)––––––– Note –––––222980 Fuel TankBracket(R.H.)Used on Type No(s).0186.
182A 692535 Fuel Tank Bracket(L.H.)
183 496853 Fuel Tank Strap(R.H.)
183A 496852 Fuel Tank Strap(L.H.)
186A 67218 Hose Connector187 492790 Fuel Line
(Cut to RequiredLength)
190 94627 Screw(Fuel Tank for RewindStart)––––––– Note –––––93634 Screw(Fuel Tank for ElectricStart)
229 690259 Washer(Fuel Tank)
240 298090 Fuel Filter––––––– Note –––––394358 Fuel Filter(Used on Engines withFuel Pumps)
385 94786 Screw(Fuel Pump)
387 491922 Fuel Pump480 94874 Screw
(Tube Clamp)527 221428 Tube Clamp601 95162 Hose Clamp
628 94896 Screw(Fuel Pump Bracket)
707 690279 Nut(Fuel Tank Strap)
725 690403 Heat Shield788 690458 Fuel Pump Bracket846 90832 Washer
(Fuel Tank Strap)918 393815 Vacuum Hose
(Cylinder–To–ImpulsePump)(Cut to RequiredLength)
957 493988 Fuel Tank Cap(Plastic)
958 494768 Fuel Shut-Off Valve(Plastic)
972 390225 Fuel Tank(Plastic)(3 Quart)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–11 Assemblies include all parts shown in frames. 4911
�467
968
967
167
445
423
607
646
607A
176
875
167 281051 Air Cleaner Stud Seal176 �∅ 281106 O-Ring Seal
(Air Cleaner Base)423 692126 Screw
(Air Cleaner Base)––––––– Note –––––94513 Screw(Air Cleaner Base)(Used Before CodeDate 98091400.)
445 496894 Air Cleaner CartridgeFilter
467 493903 Air Cleaner Knob607 690703 Screw
(Air Cleaner Brace)607A 94929 Screw
(Air Cleaner Brace)646 690460 Air Cleaner Brace
875 693676 Air Cleaner Base––––––– Note –––––494237 Air CleanerBase(Used Before CodeDate 98091400.)
967 272403 Pre Cleaner Filter968 281104 Air Cleaner Cover
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–12 Assemblies include all parts shown in frames. 4912
303
300A
883
728
725A
298
301
819
676A
263
836
237
346
677
676
994
676A
676B
300B
300 832
613
677
677
237 690409 Guard Retainer263 691083 Screw
(Guard Retainer)298 261564 Muffler/Elbow Locknut300 491413 Exhaust Muffler
300A 498984 Exhaust Muffler(Used After Code Date97012300).––––––– Note –––––493963 ExhaustMuffler(Used Before CodeDate 97012400).
300B 391569 Exhaust Muffler301 93768 Exhaust Pipe303 690281 Exhaust Elbow346 94896 Screw
(Spark Arrester)613 94929 Screw
(Exhaust Muffler)677 94896 Screw
(Muffler Deflector)676 396903 Muffler Deflector
676A 393761 Muffler Deflector
676B 397630 Muffler Deflector725A 690420 Heat Shield
728 93927 Screw(Heat Shield)
819 94513 Screw(Muffler Bracket)
832 692361 Muffler Guard836 94186 Screw
(Muffler Guard)883 �∅ 272293 Exhaust Gasket994 392390 Spark Arrester
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–13 Assemblies include all parts shown in frames. 4913
304
305
37
78
732
729
727
1036 EMISSIONS LABEL
37 690456 Flywheel Guard––––––– Note –––––690806 FlywheelGuardUsed on Type No(s).0131, 0139, 0418,1015, 1122, 1139,4015, 4016, 4515.
78 94896 Screw(Flywheel Guard)
304 691400 Blower Housing(Red)(Used After Code Date93072000).––––––– Note –––––494268 BlowerHousing(Red)(Used Before CodeDate 93071900).
690846 BlowerHousing(Black)(Used After Code Date93072000).494269 BlowerHousing(Black)(Used Before CodeDate 93071900).
305 94786 Screw(Blower Housing)
727 490324 Starter Drive Cover729 690596 Wire Clip732 94903 Screw
(Starter Drive Cover)1036 694325 Emissions Label
(Used After Code Date98123100).––––––– Note –––––499362 EmissionsLabel(Used After Code Date97063000 and BeforeCode Date 99010100).499361 EmissionsLabel(Used Before CodeDate 97070100).
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–14 Assemblies include all parts shown in frames. 4914
73
73A
1006
1005
23B
726
455
75
332
934
74A
74
668A
363
23
783
1051
695
165
726
23A
23 693557 Flywheel(Steel Ring Gear)(Includes Steel PinionGear)––––––– Note –––––693556 Flywheel(Steel Ring Gear)(Includes Steel PinionGear)Used on Type No(s).1021, 1160, 1172,1182, 1185, 1424,1425, 4520, 4521.
23A 492326 Flywheel(Plastic Ring Gear)––––––– Note –––––492325 Flywheel(Plastic Ring Gear)Used on Type No(s).0111, 0116, 0121,0126, 0127, 0129,0142, 0145, 0149,0157, 0160, 0161,0163, 0170, 0172,0173, 0174, 0175,0176, 0179, 0182,0185, 0414, 0416,0417, 0422, 0424,
0425, 0442, 0443,0450, 0455, 1021,1160, 1172, 1182,1185, 1424, 1425,4020, 4021, 4030,4031, 4515, 45164520, 4521.
23B 693555 Flywheel(Used with RewindOnly Starter)(Used After Code Date98091300).––––––– Note –––––690775 Flywheel(Used with RewindOnly Starter)(Used Before CodeDate 98091400).
73 691191 Rotating Screen73A 224517 Rotating Screen
74 93758 Screw(Rotating Screen)
74A 94626 Screw(Rotating Screen)
75 225136 Washer(Flywheel)
165 693148 Nut(Ring Gear)
332 94877 Nut(Flywheel)
363 19203 Flywheel Puller455 691173 Flywheel Cup
668A 691323 Spacer695 693109 Screw
(Ring Gear)726 392134 Ring Gear
(Aluminum)(Services Plastic RingGear Only.)
783 693713 Pinion Gear(For Steel Ring GearOnly)
934 94627 Screw(Fan Retainer)
1005 280687 Flywheel Fan1006 690452 Fan Retainer1051 263080 Ring–Retaining
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–15 Assemblies include all parts shown in frames. 4915
373
65
678
57
56
58
59
64
63
655
563563A
493
930
76
71
6870
67
608
55
60
66
949
55 393576 Rewind StarterHousing(Includes 63” Rope)
56 295871 Starter Pulley57 490179 Rewind Starter Spring58 66884 Starter Rope
(63” Long)59 490653 Grip Insert60 490652 Starter Rope Grip63 260414 Ratchet Spring64 281204 Ratchet Spring
Adapter
65 94904 Screw(Rewind Starter)
66 399671 Starter Clutch67 394897 Clutch Housing68 63770 Clutch Ball70 298799 Clutch Ratchet71 691359 Ratchet Cover76 68238 Rachet Seal
373 94908 Nut(Ground Terminal)
493 692825 Mounting Bracket
563 94902 Screw(Debris Screen Guard)
563A 93067 Screw(Debris Screen Guard)
608 390391 Rewind Starter655 222598 Rewind Spring Anchor678 490817 Rewind Spacer930 280685 Rewind Guard949 397530 Debris Screen Guard
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–16 Assemblies include all parts shown in frames. 4916
544
802
801
803
310
697
311729A
1051
309
510
1090
797A
783
513
797
783B
1051
513
783A
510A
503
675
309 693551 Starter Motor(3 5/8” HousingLength)(For Steel Ring GearOnly)––––––– Note –––––497595 Starter Motor(3 5/8” HousingLength)(For Plastic Ring GearOnly)––––––– Note –––––693054 Starter Motor(3 5/8” HousingLength)( For Aluminum RingGear Only)––––––– Note –––––693552 Starter Motor(4 3/8” HousingLength)(For Steel Ring GearOnly)––––––– Note –––––497401 Starter Motor(4 3/8” HousingLength)(For Plastic Ring GearOnly)
––––––– Note –––––499521 Starter Motor(4 3/8” HousingLength)( For Aluminum RingGear Only)
310 690323 Bolt(Starter Motor)(3 5/8” HousingLength)––––––– Note –––––691263 Bolt(Starter Motor)(4 3/8” HousingLength)
311 497608 Brush Set503 691532 Starter Strap510 693699 Starter Drive
(Used With Steel RingGear)
510A 497606 Starter Drive(Used With Aluminum& Plastic Ring Gears)
513 398003 Drive Clutch544 497603 Starter Armature
(3 5/8” HousingLength)
675 225137 Washer(Brush Retainer)
697 690372 Screw(Drive Cap)
729A 691224 Wire Clip783 693713 Pinion Gear
(For Steel Ring GearOnly)
783A 693059 Pinion Gear(For Aluminum RingGear Only)
783B 693058 Pinion Gear(For Plastic Ring GearOnly)
797 693167 Nut(Brush Retainer)
797A 92278 Nut(Brush Retainer)
801 691429 Drive Cap802 497607 End Cap803 691427 Starter Housing
(3 5/8” HousingLength)(4 3/8 Housing LengthServiced by Ref. 309.)
1051 263080 Retaining Ring1090 497605 Brush Retainer
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–17 Assemblies include all parts shown in frames. 4917
513
896
310
803A
544A
783A876311A
802A
697A
309A NOTE: For Replacement Starter Motor, See Ref. 309, Previous Page
801A
510A
729B
10831083A
1003
311B
1083
1083A
403
926
309A Starter Motor(For ReplacementStarter Motor, See Ref309, Previous Page)
310 690323 Bolt(Starter Motor)(For 3 5/8” HousingLength)––––––– Note –––––691263 Bolt(Starter Motor)(For 4 3/8” HousingLength)692329 Bolt(Starter Motor)(For 4 9/16” HousingLength)
311A 395538 Brush Set(For 3 5/8” HousingLength)
311B 490311 Brush Set(For 4 9/16 ” HousingLength)
403 690288 Washer(End Cap)
510A 495878 Starter Drive513 398003 Drive Clutch
544A 390837 Starter Armature(For 3 5/8 ” HousingLength)––––––– Note –––––490309 StarterArmature(For 4 3/8” HousingLength)
697A 94627 Screw(Drive Cap)
729B 224723 Wire Clip783A 693059 Pinion Gear
(For Aluminum RingGear Only)
801A 394856 Drive Cap802A 395537 End Cap
(For 3 5/8” HousingLength)––––––– Note –––––494988 End Cap(For 4 3/8” HousingLength)
803A 398159 Starter Housing(For 3 5/8” HousingLength)––––––– Note –––––494205 StarterHousing(For 4 3/8” HousingLength)
876 495877 Gear Kit896 94288 Drive Retainer Pin926 498233 Housing/Cap Kit
(For 4 9/16” Hsg.Length)
1003 490316 Brush Spring(For 4 9/16” Hsg.Length)
1083 94010 Nut(End Cap)
1083A 93715 Nut(End Cap)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–18 Assemblies include all parts shown in frames. 4918
176
51A
358 ENGINE GASKET SET
20
12
3
79
524
177 883
691
7
9
51A
883
176
1095 VALVE OVERHAUL GASKET SET
3 �391086 Oil Seal(Magneto Side)
7 �∅ 271866 Cylinder Head Gasket9 �∅ 27803 Breather Gasket
12 �271916 Crankcase Gasket(.015” Thick, Std.)––––––– Note –––––�271997 CrankcaseGasket(.005” Thick)�271996 CrankcaseGasket(.009” Thick)
20 �291675 Oil Seal(PTO Side)
51A �∅ 272554 Intake Gasket176 �∅ 281106 O-Ring Seal
(Air Cleaner Base)177 �270920 O–Ring Seal
(Dipstick Tube)
358 494241 Engine Gasket Set524 �281370 Dipstick Tube Seal691 �491323 Governor Shaft Seal883 �∅ 272293 Exhaust Gasket
1095 498539 Valve Overhaul GasketSet
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
286700 to 286799
2247–19 Assemblies include all parts shown in frames. 4919
121 CARBURETOR OVERHAUL KIT
51
95
104
105
137
276
142
147
987A
987127
634
634A
231
977 CARBURETOR GASKET SET
137 27651
REQUIRES SPECIAL TOOLSTO INSTALL. SEE REPAIRINSTRUCTION MANUAL.
106
106
51 ��272465 Intake Gasket95 �94098 Screw
(Throttle Valve)104 �690525 Float Hinge Pin105 �231855 Float Needle Valve
(Used After Code Date92071900).
106 �231854 Inlet Seat(Gravity Feed)(Used After Code Date92071900).––––––– Note –––––�280328 Inlet Seat(Gravity Feed)(Used Before CodeDate 92072000).
231856 Inlet Seat(Pump Feed)(Used After Code Date92071900).
121 499220 Carburetor OverhaulKit(LMT 92, 93, 94, 95,96)(Used After Code Date96072500).––––––– Note –––––499231 CarburetorOverhaul Kit(LMT 157, 158, 159,160)(Used After Code Date96072500).497481 CarburetorOverhaul Kit(Used Before CodeDate 96072600).
127 � Welch Plug(Sold in Kit Only)
134 �494788 Needle/Seat Kit(Gravity Feed)(Used Before CodeDate 92072000).
137 ��281165 Float Bowl Gasket
142 �691434 Carburetor Nozzle(Standard)(LMT 92, 93, 94, 96)––––––– Note –––––�691425 CarburetorNozzle(Standard)( LMT 1, 2, 3, 4, 5, 7,37, 38, 39, 40, 41, 77,78, 79, 80, 81, 157,158, 159, 160)
147 �497472 Pilot Jet(LMT 1, 2, 3, 4, 5, 7,37, 38, 39, 40, 41, 77,78, 79, 80, 81)
231 �94098 Screw(Choke Valve)
276 ��281164 Sealing Washer634 �690801 Spring/Seal Assembly
(Manual Choke)634A �690802 Spring/Seal Assembly
(Choke A Matic)977 494385 Carburetor Gasket Set987 �691326 Throttle Shaft Seal
987A �281167 Throttle Shaft Seal(LMT 1 thru 5, 7, 37thru 41)
� Included in Engine Gasket Set–Ref. No. 358∅ Included in Valve Overhaul Gasket Set–Ref. No. 1095
� Included in Carburetor Overhaul Kit–Ref. No. 121� Included in Carburetor Gasket Set–Ref No. 977
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION