xm-2252hx - bcae1.com - xm-2252.pdf · xm-2252hx – 11 – – 12 – ... pre amp + filter mute...

– 1 –

MICROFILM

XM-2252HXSERVICE MANUAL

STEREO POWER AMPLIFIER

SPECIFICATIONS

US ModelCanadian Model

AEP ModelUK Model

– 2 –

Specifications ............................................................................. 1

1. SERVICING NOTE ....................................................... 2

2. GENERAL ....................................................................... 3

3. ELECTRICAL ADJUSTMENTSSelf-Diagnosis Function ...................................................... 7Idling Adjustment ................................................................ 8

4. DISASSEMBLY5-1. Bottom Plate, Panel (Front), Panel (Rear) Removal ..... 95-2. AMP/Power Board Removal ........................................ 9

5. DIAGRAMS5-1. IC Block Diagrams ..................................................... 105-2. Printed Wiring Board – Amplifier Section – .............. 115-3. Schematic Diagram – Amplifier Section – ................. 135-4. Printed Wiring Board – Power Section – .................... 155-5. Schematic Diagram – Power Section – ...................... 17

6. EXPLODED VIEWS ................................................... 19

7. ELECTRICAL PARTS LIST .................................... 21

TABLE OF CONTENTS

SECTION 1SERVICING NOTE

CANCELLING THE PROTECTOR DURING SERVICINGCut JW213 on the amplifier board to cancel the protector.After servicing always be sure to return JW213 to its original state.

JW213

C927

C929

C928

C930

– 3 –

SECTION 2GENERAL

This section is extracted frominstruction manual.

– 4 –

– 5 –

– 6 –

– 7 –

SECTION 3ELECTRICAL ADJUSTMENTS

SELF-DIAGNOSIS FUNCTION

In addition, this unit comes with a function which alerts when set-tings of the Hi-Current and Hi-Voltage modes are wrong. There aretwo switches at the base of this unit to switch to the Hi-Current andHi-Voltage modes respectively. When these two switches are not toset to the same modes, the Hi-Current and Hi-Voltage indicators onthe top panel change from green to amber to indicate an error."See INSTRUCTION MANUAL for more information."

HI-CURRENT

MODE

THERMAL

OFFSET

OVER-CURRENT

HI-VOLTAGE

POWER/PROTECTOR

Hi-Current, Hi-Voltage switch

Hi-Current, Hi-Voltage indicatorsIf the switches are set properly,one will light up in green. If wrong,both will light up in amber.

– 8 –

IDLING ADJUSTMENT• L-CH (R-CH) Adjusting Method

Connection:

Procedure:1. Rotate the semi-fixed resistor VR101 (R-CH is VR201) com-

pletely in the counterclockwise direction as seen from the com-ponent side.• The large variable range of the semi-fixed resistor prevents

flow of excessive current to the output MOS-FET.• Take note than when an excessive current flows, the protec-

tors operate (both the amber and green lamps light up at thesame time) and the amplifier will stop operating.

TP101TP102

R168

R150

R249

R268

TP202

C929C933

C931

C932

C934C930

C927 C928

VR201(R-CH)

VR101(L-CH)

TP201

POWER BOARDAMPLIFIER BOARD

Digital voltmeter

(L-CH TP102)(R-CH TP202)

(L-CH TP101)(R-CH TP201)

+

–

2. Set the input signal setting to non-signal.

3. Apply a 14.4V power supply voltage between the +12V and RE-MOTE terminals and GND terminal.

4. AdjustmentsConnect a digital voltmeter between the two terminals of thecement resistors R149 and R150 (0.03 Ω) indicated as TP101and TP102 (TP201 and TP202 for R-CH).Rotate the semi-fixed resistor VR101 and adjust so that the volt-age between TP101 and TP102 comes between 0.5 mV and 1.1mV with 0.8 mV as the center.Adjust R-CH in the same way.

• Perform adjustments carefully as voltage changes are minute.• When adjusting from the component side, rotating the semi-fixed

resistor control in the clockwise direction increases the idlingcurrent while rotating in the counterclockwise direction decreasesthe idling current.

Adjustment Location:– AMP/POWER Board – (Component side)

XM-2252HX

– 9 –

SECTION 5DIAGRAMS

5-1. IC BLOCK DIAGRAMS

IC101- 103, 201- 203 NJM4580E IC901 µPC494GS

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printedin each block.)

For schematic diagrams.Note:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• ¢ : internal component.• C : panel designation.• U : B+ Line.• Power voltage is dc 14.4V and fed with regulated dc power

supply from ACC and BATT cords.• Voltage and waveforms are dc with respect to ground

under no-signal conditions.no mark : POWER ON

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal productiontolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal productiontolerances.

• Circled numbers refer to waveforms.• Signal path.F : AUDIO

For printed wiring boards.Note:• X : parts extracted from the component side.• ¢ : internal component.

1

2

3

4 5

6

7

8A OUT

A –IN

A +IN

V–

V+

B OUT

B –IN

B +IN

A B

41 2 3 5 6 7 8

91016 15 14 13 12 11

ERROR

0.1V

REG.REF.

OSC

ERROR

SECTION 4DISASSEMBLY

Note : Follow the disassembly procedure in the numerical order given.

4-1. BOTTOM PLATE, PANEL (FRONT), PANEL (REAR) REMOVAL

4-2. AMP/POWER BOARD REMOVAL

Note :Amplifier board and Power board are notseparated because the board is long and heavy.Take care not to damage the board when removing.

Heat sink block

7 Auto fuse (F902)

6 Connector (CNP802)

8 Auto fuse (F901)

9 Screw (BTP 3x8)

!£ Screw (BTP 3x8)

0 Three screws (BTP 3x8)

!¡ Three screws (BTP 3x8)

!¢ Three screws (BTP 3x8)

!∞ Two screws (BTP 3x8)!§ Screw

(BTP 3x8)

!™ Panel (Front)

!¶ Panel (Rear)


3 Two screws (BTP 3x5)

4 Two screws (BTP 3x5)


5 Bottom plate

7 Heat sink

6 Light interseption rubber

3 Four screws (P 4x10)




5 Amp/power board

Amplifier board

Power board

– 10 –

• WAVEFORMS

1

2

3

4

14Vp-p

27 µsec

29Vp-p

27 µsec

29Vp-p

27 µsec

60Vp-p

27 µsec

XM-2252HX

– 11 – – 12 –

• SemiconductorLocation

D101 A-8D102 A-5D103 C-6D104 C-6D105 A-9D201 G-7D202 F-6D203 E-6D204 E-6D205 G-9D801 C-8D802 C-8D803 D-8D804 E-9D930 C-7D931 C-7D932 E-7D933 E-7

IC101 B-2IC102 D-3IC103 C-2IC201 B-3IC202 E-4IC203 D-2IC807 E-8IC902 C-8

Q101 C-2Q102 D-6Q103 C-6Q104 C-6Q105 C-6Q106 C-6Q107 C-6Q108 C-6Q109 A-6Q110 A-7Q111 A-8Q112 A-5Q113 A-6Q114 C-6Q115 C-6Q116 C-7Q117 C-6Q118 B-8Q119 A-8Q120 B-8Q121 B-8Q201 D-3Q202 D-6Q203 E-6Q204 E-6Q205 E-6Q206 E-6Q207 E-6Q208 E-6Q209 G-6Q210 G-7Q211 G-8Q212 G-6Q213 G-5Q214 E-6Q215 E-6Q216 E-7Q217 E-6Q218 F-8Q219 G-8Q220 F-8Q221 F-8Q801 C-8Q802 C-8Q803 C-7Q804 B-7Q805 C-8Q806 D-8Q807 D-9Q808 D-8Q809 D-8Q810 E-8Q811 E-8Q812 E-7Q813 E-7

Ref. No. Location

5-2. PRINTED WIRING BOARD – AMPLIFIER SECTION –

1

F

E

D

C

B

A

2 3 4 5 6 7 8 909

G

C102

C101

VR803

VR802

JW71

C112C113

JW74

JW73

JW72

JW58

JW60

JW57

JW56

C207

JW170

JW169

JW168

JW22

CN

802

JW8

C209 C208 C210 C108

JW49

JW50

JW7 JW16

JW15

C12

4

JW14

JW13

JW163 JW12 JW20

JW160

JW21

JW28

JW158

JW27

JW26

Lch AMP

PRE AMP+

FILTER

MUTEPROTECT

PROTECT+

LED DRIVE

Rch AMP

Q209

JW32

Q213

JW31

Q102

Q202

JW12

8

JW12

7

C12

1

JW126

CN

J803

IC807

JW171

JW40

JW45

JW41

JW43

JW44

JW42

Q210

TP201

Q109Q112 Q113 Q110

JW118

JW120

JW119

JW90

JW91

JW105

JW104

JW103

JW102

JW101

JW100

JW65

JW64

JW99

JW98

JW97

JW62

JW61

JW93

JW94

JW95

JW96

R23

2

JW30

JW29

JW25

C22

4

JW4

JW3

JW1

JW10 JW17

JW18

JW19

JW9

JW166

JW164

JW159

JW165

JW2

JW162

JW161

R256

JW6

JW5

JW11

VR201

VR101

JW33

JW34

JW38

JW39

JW37

JW36

JW35

Q212

LD803

THERMAL

TP

203

TP

204

Q211

TH801

TP103

TP

104

Q111

JW138

JW137

JW150

TP101

JW13

9

JW13

1

JW13

0

JW14

0

CN

P80

2-2

Q207 Q208

R94

5

R94

6

JW122

Q204

Q203Q205

Q206

JW12

3

C22

1

R23

1

R156

JW12

9

JW13

5

JW125

JW134

JW13

6

R94

3

R94

4

C803

CN

P80

4-2

Q105

Q106

C80

1

IC90

2

JW170

JW14

6

JW14

4JW

145

JW14

1

JW14

2JW

143

Q104

Q103

R13

2

JW11

2 JW115

JW114

JW111JW76

JW75 JW110

JW11

3

C12

9R

131

C12

0

JW10

7

JW10

6

JW10

8

JW10

9

JW12

4

C22

0

C20

6

C22

9

JW121

C809

CN

J801

JW80 JW

84

JW83

JW82

JW81

C226

R159

JW85

JW78

JW79

JW86

JW87

JW88

JW89

C964

C961

JW77 JW92

C201C126

C202

JW153JW152

CNJ804JW

69

JW70

S80

3

C10

9

VR801

JW51

JW52

C110

C107

C212C213

C106

JW55

JW53

JW54

JW63

JW59

C962

C963

JW24

JW23

JW167

R259

JW11

6

JW11

7

JW46

JW48

JW67

JW66

C80

6

C11

4

C21

4 JW68

Q107Q108

BLK

BLU

BLU

BLU

BLU

BLK

BLU

BLU

BLU

BLU

1-674-540- 11

R150

R149

R167

R166

S G S G S G

TO POWER BOARD

POWER BOARDCNP804-1

TO POWER BOARD

A

POWER BOARDCNP802-1

C

POWER BOARDCNP802

B

LD801

OFFSET

LD802

OVER CURRENT

POWER/PROTECTION

L

R

L

R

CNJ804

HIGH LEVELINPUT

L

L+RMONO

R

(MONO)

L

R

INPUT

SPEAKER OUT

OUTPUT

(THROUGH)

CN802

VR803LEVEL

(MIN – MAX)

VR802LOW BOOST

(40Hz)(0dB – +10dB)

VR801FILTER

(50Hz – 200Hz)

S803FILTER

LPF

OFF

HPF

VR101IDLING

TO POWER BOARD

TO POWER BOARD

R268

R267

R250

R249

VR201IDLING

C117C116

C80

5

C80

4R

153

R25

3R

811

C217

C216

R160

R157

R104

C104

IC101

IC201

C204R204

R207C205 R206

R258

R106

R110

R10

2C

125 C

119

R20

8R

201

D102

R135R136

R162 R164

R137

R163

C957 Q11

9

R14

8

C95

8

R138

R125

R225

C230

R229 R230

R238 R830

R831

C227D203

C228D204

R129

C802

D103 D104C127 C128

C12

3

R16

6

R12

8

R13

4

R12

7

R13

3

R81

0R

139 R

809

R80

7

R80

8R

806

R80

1R12

6R

226

R23

3

R22

7

R22

8

R23

4

R82

9

R82

8

C80

8

R23

9

C22

3

R235 R236

D201

R237 R263

C955

D20

2R

264

R26

2 JR11

R26

1

C95

6

C23

1

R26

6

C94

5

C94

6

R26

5R

165

R130C130 C

131

R17

1

R17

4R

173

R15

1

R15

2

R17

2R

147

R144R141

R169

R170

R146

R145

R27

3

R25

1

R82

3R

827

R84

7

R81

6

JR28

R81

8

R81

3

R84

9

R84

8

R82

1

R80

5

R80

2

JR32

C94

4

C94

3

R80

3

R81

5

R82

0

R81

7

R81

2

R81

4

C80

7

R25

2

R27

1

R27

4R

248

R24

7R

272

R270

R824

R826 R825

R819

R906

R804

R822

R832

JR27

R269

R244 R241

R245

R246

D10

1

R16

1

R14

0

C22

5C

953

C95

4

R21

0

R10

1

C11

8

R15

8

R20

5

R10

3

C10

3

C95

1C

952 JR

1R

108

R12

1

R11

6

R12

0

R12

2

R12

3

C11

5

JR5

JR2

JR6

JR4

JR3

C21

8

R20

2

C21

9

R25

7

R20

3

C20

3

R10

5

R22

3

R21

6R

114

R22

1 R22

0

JR31

JR30

R21

1

R11

1

R21

3

R21

2

R21

4R

112

R11

3

JR7

R22

2

R117

JR8

JR29

JR10

R217

R209

R109

IC202

IC102

C11

1

R11

9C

215

JR9

C21

1

R21

9

R21

8

R11

8

R12

4

R22

4

C105R107

R260

R24

0

IC103

IC203

Q11

8Q

120

D80

2

D80

1Q

801

Q80

8

Q809

D932

Q216

Q81

1

Q22

0Q

221

Q21

9Q

218

D20

5

Q80

6

Q81

0

Q81

3

Q81

2

D80

4

Q80

7

D803

D933

Q217Q215Q214

Q201

Q80

2

Q80

4Q

803

Q805

D930 D931

Q116Q117

Q101

Q114 Q115

D10

5

Q12

1

LD802LD80

1

LD803

AMPLIFIER BOARD

G S G S G S G S

(Conductor side)

1

9

2

8

1

5

1

5

XM-2252HX

– 13 – – 14 –

5-3. SCHEMATIC DIAGRAM – AMPLIFIER SECTION –• See page 10 for IC Block Diagrams.

LPF

OFF

HPF

LPF

OFF

HPF

LOW BOOST LEVEL

IDLING

POWER AMP

IDLINGPOWER AMP

17, 18

XM-2252HX

– 15 – – 16 –

5-4. PRINTED WIRING BOARD – POWER SECTION –

• SemiconductorLocation

D805 D-7D806 D-7D807 D-9D901 C-9D902 D-9D903 C-5D904 C-5D905 D-5D906 D-5

Ref. No. Location

D907 C-5D908 C-5D909 D-5D910 D-5D911 C-4D912 D-4D913 C-4D914 D-4D915 A-4

D916 A-3D917 F-4D918 F-3D919 A-5D920 A-3D921 F-5D922 F-3D925 C-1D926 C-5

D927 C-5D928 D-5D929 D-5D934 D-1D935 D-1D936 C-1D937 C-1D938 C-5D939 C-5

D940 C-5D941 C-5D942 C-3D943 C-3D944 D-7D945 D-6

IC901 C-8IC903 C-7

Q814 D-9Q815 D-9Q901 C-9Q902 C-9Q903 D-10Q904 A-7Q905 A-6Q906 A-7Q907 A-6

Q908 F-7Q909 F-6Q910 F-7Q911 F-6Q912 B-6Q913 B-7Q914 E-7Q915 E-7Q916 C-7

Q917 C-7Q918 C-5Q919 D-5Q920 C-5Q921 D-5Q926 C-9Q927 C-6

Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location Ref. No. Location

S801HI-CURRENT

D920 D916

JW24

9

JW25

0

JW25

1

JW25

5

D915 D919 Q907

C92

4

C92

3 JW252

JW253

JW254

C93

1

C928

JW24

6

JW23

0

JW23

1

JW24

3

JW24

4

JW24

5

JW24

7

JW24

8

C93

2C

934

C94

2

JW260

C941 C921 L904

Q921

Q919

Q918

Q920

C93

3

JW242

JW241

JW240

JW23

8

JW23

9

JW26

2 JW26

3

JW26

4

JW26

6JW

275

JW27

7

JW27

6

JW26

5

Q911

JW274

JW273

JW272

JW271

JW268

JW267

JW267

JW269

Q909

JW27

0

T902

JW295

JW29

6

JW29

5

JW29

7

Q908

JW360

JW359

JW358

JW360

JW361

JW335

JW336

JW33

1JW

332

JW33

3

JW33

4

JW35

2

JW35

3

JW35

4

JW372

JW373

F90

1

JW35

0

JW35

1

JW37

7

JW37

1

JW33

0

JW323

JW32

0

JW32

1

L901

JW37

8

Q902

JW346Q901

TP801TP802

JW345

JW343

JW344

JW342

F90

2

JW374

JW375C918

C90

2

JW39

9

JW34

0

JW33

7

JW33

8

JW34

1

JW30

5

JW30

4

JW30

3

JW30

2

PL901

FAN DRIVE

CN

P80

1

JW37

6 R911

JW34

9

JW347

JW347

CNJ801

JW348

Q904

T901

Q905

JW293

JW292

JW291

JW290

JW289

Q906

JW28

8

JW28

7

JW28

6

JW25

7

JW25

6

JW25

8 JW28

5

JW28

4

LchPOWER SUPPLY

RchPOWER SUPPLY

TP102

JW36

7

JW20

6

JW36

9

JW20

7

JW20

8

CN

P80

4-1

CN

P80

2-1

C927

JW213

CN

J802

D93

7

D93

6

D93

5

D904

D93

4

JW37

0

JW21

1

PROTECTOR OFF

JW21

4

JW21

5

JW21

6

JW21

7

S801

OFF ON

ON OFF

ON OFF

C919

C939

JW261

L903

D903

C940 C920

C922

D909

D910

D905

D906

JW27

8JW

280

D908 Q927

JW279

D907

JW32

7

C912

C911

JW32

9

JW32

6

C913

C914

C965

C905

C917

C916

JW307

JW31

0

JW31

1

JW31

2

JW308

JW30

9

JW306

JW29

9

JW30

0

JW30

1

C915

IC903

JW31

3

JW31

6

C90

3

C90

4

JW31

7

JW31

3JW

314

R938

R937

JW31

5

JW31

8

JW31

9

JW25

9 JW28

2

JW28

1 JW28

3

JW23

2

JW23

3

JW23

4

JW23

5

JW23

6

JW23

7

C92

6

D918D922 D917 D921Q910

JW22

9

JW36

8 JW20

3

JW20

4

JW20

5

C929 C930

TP202

C92

5

JW21

9

JW21

8

JW22

0

JW22

1

JW22

2

JW22

3

JW32

2

JW324

JW357

JW355

JW356

BLK

REDDC FAN MOTOR

GND

CN801

40A

F901

+12V

REMOTE

40A

F902

1-674-541- 11

LD804

HI – VOLTAGE

TO AMPLIFIER

BOARD

TO AMPLIFIER BOARD

AMPLIFIER BOARDCNP804-2

A

AMPLIFIER BOARDCNP802-2

C

AMPLIFIER BOARDCNJ803

B

LD805

HI – CURRENT

MODE

M

(FN801)

(Conductor side)POWER BOARD

TO AMPLIFIER BOARD

TO AMPLIFIER

BOARD

LED DRIVE

S802HI-VOLTAGE

SWITCHINGCONTROL

L902

C96

0

JR33

R95

3

R95

2

R95

1

R94

8

R94

9

R95

0

LD80

5

LD80

4

C95

9

JR26

R94

2R

941

C937

C938R947 D

945

R83

8

R83

6 R834

R84

0

JR25

R92

3

R91

7

R91

8

R92

4

TH

804

TH

805

TH

803

JR16

R93

3

R90

4

R90

3

R84

5R84

4D80

7

R95

9

R95

5

R84

6

C90

8

R909

R907

R908

R912

R90

2

R84

1

R90

5

R90

1

C90

1R

842

JR24

JR14

R93

6R

934

R92

2

R91

4

R91

3

R92

1

JR12

R935 R916

R935

JR15

JR21

R839

R837JR23

JR22D945

R835

R833

C810

R920R919

JR13

R932 R930 R931 R929

R928 R926 R927 R925

C910

R910

C90

6

C90

7

JR20

JR19

JR18

JR17

D925

D942 D943

D928

D929

D94

4 D80

5

D806

Q902Q903

Q92

6

Q81

4

D90

2

Q91

7

Q91

6

Q915Q914

Q912 Q913

R93

9R

940

D940 D938 R957 TH901

R958D941 D939

C935

C936D927

D926

D912

D914

D913

D911

R93

9

IC901

1

E

F

D

C

B

A

2 3 4 5 6 7 8 9 1009

1

5

12

98

1

5

OFF

S802

ON

OFFON

OFFON

XM-2252HX

– 17 – – 18 –

5-5. SCHEMATIC DIAGRAM – POWER SECTION –• See page 10 for IC Block Diagrams.

DC FAN MOTOR

13, 14

34

6

28

7

19

5

S801

ON

ON

OFF

OFF

S802

ON

OFF

ON

OFF

LED COLOR

AMBER

GREEN

GREEN

AMBER

MODE

Prohibit

HI-CURRENT

HI-VOLTAGE

Prohibit

OFF

OFF

ON

ON

OFF

OFF

ON

ON

OFF

OFF

ON

ON

XM-2252HX

– 19 – – 20 –

SECTION 6EXPLODED VIEWS

NOTE:• Items marked “*” are not stocked since they are

seldom required for routine service. Some delayshould be anticipated when ordering these items.

• The mechanical parts with no reference number inthe exploded views are not supplied.

• Hardware (# mark) list and accessories and pack-ing materials are given in the last of this parts list.

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

1 3-034-552-01 PLATE, ORNAMENTAL2 3-035-494-01 SHEET (DOUBLE-FACE)

* 3 3-023-804-01 SHEET, DIFFUSION* 4 3-035-489-01 PANEL (FRONT)* 5 3-035-490-01 PANEL (REAR)

* 6 3-035-491-01 PLATE, BOTTOM

FN801

#1

#1

#1

F902

F901

1

2

4

3

5

86

7

7

#1

#2

#2

#2#2

#2

#3#3

#2

#2

#2

#2

#2 #2

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

51 3-035-483-01 RUBBER, LIGHT INTERCEPTION* 52 A-3294-710-A AMP/POWER BOARD, COMPLETE* 53 3-023-798-01 BRACKET (VR)* 54 3-023-799-01 BRACKET (HIGH LEVEL)

55 1-575-388-11 CABLE, FLAT 9P

56 3-912-431-01 M4X8 (P)* 57 3-035-968-01 BRACKET (CHASSIS)

* 58 3-035-493-01 HEAT SINK (SUB)* 59 3-023-800-01 BRACKET (BOTTOM PLATE)

60 3-037-684-01 PLATE, RETAINER

61 3-025-081-01 SHEET (INSULATING)* 62 3-035-492-01 HEAT SINK

TH801 1-809-664-51 THERMISTOR, POSITIVETH802 1-809-664-51 THERMISTOR, POSITIVE

7 3-023-803-01 COVER* 8 3-023-795-01 BRACKET (FAN)

F901 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) (40A)F902 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) (40A)

FN801 1-763-107-11 MOTOR, FAN

TH802

#4

#6#4

#6

#4

#4

#7#7

#9

#9

#5

#5

#7

#8

#10 #10

#7

#8

#8

#8

#4

#4

TH801

51

54

55

60

6161

61

61

60

5757

62

59

58

58

58

58

59

59

59

56

53

56

52

NOTE:• F901, F902 AND FN801 are including into the

AMP/Power board.

(1) BOTTOM PLATE AND PANEL (FRONT/REAR) SECTION

(2) AMP/POWER BOARD SECTION

– 21 –

SECTION 7ELECTRICAL PARTS LIST

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

AMPLIFIER

• SEMICONDUCTORSIn each case, u: µ , for example:uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,uPC...: µ PC..., uPD...: µ PD...

• CAPACITORSuF : µ F

• COILSuH : µ H

• Due to standardization, replacements in the parts listmay be different from the parts specified in thediagrams or the components used on the set.

• -XX, -X mean standardized parts, so they may havesome difference from the original one.

Note:

When indicating parts by referencenumber, please include the boardname.

* A-3294-710-A AMP/POWER BOARD, COMPLETE(Including AMPLIFIER BOARD

and POWER BOARD)

1-575-388-11 CABLE, FLAT 9P* 3-035-968-01 BRACKET (CHASSIS)* 3-035-493-01 HEAT SINK (SUB)

3-037-684-01 PLATE, RETAINER3-025-081-01 SHEET (INSULATING)

7-685-646-79 +P 3x8 TYPE2 N-S7-685-144-11 +P 3x5 TYPE2 N-S7-682-546-09 SCREW +B 3x57-682-949-01 +PSW 3x107-685-649-79 +P 3x14 TYPE2 N-S

AMPLIFIER BOARD****************

< CAPACITOR >

C101 1-126-047-11 ELECT 4.7uF 20% 50VC102 1-126-047-11 ELECT 4.7uF 20% 50VC103 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC104 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC105 1-163-231-11 CERAMIC CHIP 15PF 5% 50V

C106 1-130-497-00 MYLAR 0.15uF 5% 50VC107 1-130-497-00 MYLAR 0.15uF 5% 50VC108 1-126-047-11 ELECT 4.7uF 20% 50VC109 1-126-047-11 ELECT 4.7uF 20% 50VC110 1-126-047-11 ELECT 4.7uF 20% 50V

C111 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC112 1-126-047-11 ELECT 4.7uF 20% 50VC113 1-126-957-11 ELECT 0.22uF 20% 50VC114 1-126-022-11 ELECT 47uF 20% 10VC115 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C116 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC117 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC118 1-164-222-11 CERAMIC CHIP 0.22uF 25VC119 1-164-222-11 CERAMIC CHIP 0.22uF 25VC120 1-126-022-11 ELECT 47uF 20% 10V

C121 1-107-597-11 CERAMIC 22PF 5% 500VC123 1-165-319-11 CERAMIC CHIP 0.1uF 50VC124 1-137-397-11 FILM 0.047uF 5% 100VC125 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC126 1-126-940-11 ELECT 330uF 20% 25V

C127 1-165-319-11 CERAMIC CHIP 0.1uF 50VC128 1-165-319-11 CERAMIC CHIP 0.1uF 50VC129 1-136-165-00 FILM 0.1uF 5% 50VC130 1-131-596-11 CERAMIC CHIP 4700PF 50VC131 1-131-596-11 CERAMIC CHIP 4700PF 50V

C201 1-126-047-11 ELECT 4.7uF 20% 50VC202 1-126-047-11 ELECT 4.7uF 20% 50VC203 1-163-243-11 CERAMIC CHIP 47PF 5% 50V

C204 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC205 1-163-231-11 CERAMIC CHIP 15PF 5% 50V

C206 1-130-497-00 MYLAR 0.15uF 5% 50VC207 1-130-497-00 MYLAR 0.15uF 5% 50VC208 1-126-047-11 ELECT 4.7uF 20% 50VC209 1-126-047-11 ELECT 4.7uF 20% 50VC210 1-126-047-11 ELECT 4.7uF 20% 50V

C211 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC212 1-126-047-11 ELECT 4.7uF 20% 50VC213 1-126-957-11 ELECT 0.22uF 20% 50VC214 1-126-022-11 ELECT 47uF 20% 10VC215 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C216 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC217 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC218 1-164-222-11 CERAMIC CHIP 0.22uF 25VC219 1-164-222-11 CERAMIC CHIP 0.22uF 25VC220 1-126-022-11 ELECT 47uF 20% 10V

C221 1-107-597-11 CERAMIC 22PF 5% 500VC223 1-165-319-11 CERAMIC CHIP 0.1uF 50VC224 1-137-397-11 FILM 0.047uF 5% 100VC225 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC226 1-126-940-11 ELECT 330uF 20% 25V

C227 1-165-319-11 CERAMIC CHIP 0.1uF 50VC228 1-165-319-11 CERAMIC CHIP 0.1uF 50VC229 1-136-165-00 FILM 0.1uF 5% 50VC230 1-131-596-11 CERAMIC CHIP 4700PF 50VC231 1-131-596-11 CERAMIC CHIP 4700PF 50V

C801 1-124-282-00 ELECT 22uF 20% 25VC802 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC803 1-126-967-11 ELECT 47uF 20% 50VC804 1-164-222-11 CERAMIC CHIP 0.22uF 25VC805 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

C806 1-128-551-11 ELECT 22uF 20% 25VC807 1-163-133-00 CERAMIC CHIP 470PF 5% 50VC808 1-163-133-00 CERAMIC CHIP 470PF 5% 50VC809 1-128-551-11 ELECT 22uF 20% 25VC943 1-165-319-11 CERAMIC CHIP 0.1uF 50V

C944 1-165-319-11 CERAMIC CHIP 0.1uF 50VC945 1-165-319-11 CERAMIC CHIP 0.1uF 50VC946 1-165-319-11 CERAMIC CHIP 0.1uF 50VC951 1-165-319-11 CERAMIC CHIP 0.1uF 50VC952 1-165-319-11 CERAMIC CHIP 0.1uF 50V

C953 1-165-319-11 CERAMIC CHIP 0.1uF 50VC954 1-165-319-11 CERAMIC CHIP 0.1uF 50VC955 1-162-542-11 CERAMIC CHIP 680PF 5% 100VC956 1-162-542-11 CERAMIC CHIP 680PF 5% 100VC957 1-162-542-11 CERAMIC CHIP 680PF 5% 100V

C958 1-162-542-11 CERAMIC CHIP 680PF 5% 100VC961 1-126-059-11 ELECT 10uF 20% 50VC962 1-126-059-11 ELECT 10uF 20% 50V

• Items marked “*” are not stocked since they areseldom required for routine service. Some delayshould be anticipated when ordering these items.

• RESISTORSAll resistors are in ohmsMETAL: Metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF : nonflammable

– 22 –


C963 1-126-059-11 ELECT 10uF 20% 50VC964 1-126-059-11 ELECT 10uF 20% 50V

< CONNECTOR >

CN802 1-537-478-21 TERMINAL BOARD (4P) (SPEAKER OUT)CNJ801 1-784-904-11 CONNECTOR 4P (HIGH LEVEL INPUT)CNJ803 1-766-902-11 CONNECTOR, FFC/FPC (ZIF) 9PCNJ804 1-779-078-51 JACK, PIN 4P

(INPUT (MONO) OUTPUT (THROUGH))

< DIODE >

D101 8-719-056-93 DIODE UDZ-TE-17-18BD102 8-719-056-93 DIODE UDZ-TE-17-18BD103 8-719-977-40 DIODE UDZ-TE-17-13BD104 8-719-977-40 DIODE UDZ-TE-17-13BD105 8-719-801-78 DIODE 1SS184

D201 8-719-056-93 DIODE UDZ-TE-17-18BD202 8-719-056-93 DIODE UDZ-TE-17-18BD203 8-719-977-40 DIODE UDZ-TE-17-13BD204 8-719-977-40 DIODE UDZ-TE-17-13BD205 8-719-801-78 DIODE 1SS184

D801 8-719-025-34 DIODE 02CZ6.8-TE85LD802 8-719-801-78 DIODE 1SS184D803 8-719-801-78 DIODE 1SS184D804 8-719-801-78 DIODE 1SS184D930 8-719-025-49 DIODE 02CZ15-TE85L

D931 8-719-025-49 DIODE 02CZ15-TE85LD932 8-719-025-49 DIODE 02CZ15-TE85LD933 8-719-025-49 DIODE 02CZ15-TE85L

< IC >

IC101 8-759-711-82 IC NJM4580EIC102 8-759-711-82 IC NJM4580EIC103 8-759-711-82 IC NJM4580EIC201 8-759-711-82 IC NJM4580EIC202 8-759-711-82 IC NJM4580E

IC203 8-759-711-82 IC NJM4580EIC807 8-719-156-73 PHOTO COUPLER PS2501-1LAIC902 8-719-156-73 PHOTO COUPLER PS2501-1LA

< DIODE >

LD801 8-719-070-01 DIODE SEC2764C (OFFSET)LD802 8-719-070-01 DIODE SEC2764C (OVER CURRENT)LD803 8-719-070-01 DIODE SEC2764C (THERMAL)

< TRANSISTOR >

Q101 8-729-422-29 TRANSISTOR 2SD601A-SQ102 8-729-203-48 TRANSISTOR 2SC3327-AQ103 8-729-184-53 TRANSISTOR 2SC1845-EAQ104 8-729-184-53 TRANSISTOR 2SC1845-EAQ105 8-729-140-82 TRANSISTOR 2SA988-PAFAEA

Q106 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ107 8-729-822-80 TRANSISTOR 2SA1541Q108 8-729-822-47 TRANSISTOR 2SC3955-EQ109 8-729-954-51 TRANSISTOR 2SC1545Q110 8-729-049-52 TRANSISTOR FS70SMJ-2

Q111 8-729-049-52 TRANSISTOR FS70SMJ-2Q112 8-729-049-53 TRANSISTOR FX50SMJ-2

Q113 8-729-049-53 TRANSISTOR FX50SMJ-2Q114 8-729-205-76 TRANSISTOR 2SC3138Y-TE85LQ115 8-729-216-21 TRANSISTOR 2SA1162-Y

Q116 8-729-105-08 TRANSISTOR 2SA1330Q117 8-729-230-49 TRANSISTOR 2SC2712-YGQ118 8-729-216-31 TRANSISTOR 2SA1163-GQ119 8-729-216-31 TRANSISTOR 2SA1163-GQ120 8-729-271-31 TRANSISTOR 2SC2713-G

Q121 8-729-271-31 TRANSISTOR 2SC2713-GQ201 8-729-422-29 TRANSISTOR 2SD601A-SQ202 8-729-203-48 TRANSISTOR 2SC3327-AQ203 8-729-184-53 TRANSISTOR 2SC1845-EAQ204 8-729-184-53 TRANSISTOR 2SC1845-EA

Q205 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ206 8-729-140-82 TRANSISTOR 2SA988-PAFAEAQ207 8-729-822-80 TRANSISTOR 2SA1541Q208 8-729-822-47 TRANSISTOR 2SC3955-EQ209 8-729-954-51 TRANSISTOR 2SC1545

Q210 8-729-049-52 TRANSISTOR FS70SMJ-2Q211 8-729-049-52 TRANSISTOR FS70SMJ-2Q212 8-729-049-53 TRANSISTOR FX50SMJ-2Q213 8-729-049-53 TRANSISTOR FX50SMJ-2Q214 8-729-205-76 TRANSISTOR 2SC3138Y-TE85L

Q215 8-729-216-21 TRANSISTOR 2SA1162-YQ216 8-729-105-08 TRANSISTOR 2SA1330Q217 8-729-230-49 TRANSISTOR 2SC2712-YGQ218 8-729-216-31 TRANSISTOR 2SA1163-GQ219 8-729-216-31 TRANSISTOR 2SA1163-G

Q220 8-729-271-31 TRANSISTOR 2SC2713-GQ221 8-729-271-31 TRANSISTOR 2SC2713-GQ801 8-729-216-21 TRANSISTOR 2SA1162-YQ802 8-729-230-49 TRANSISTOR 2SC2712-YGQ803 8-729-230-49 TRANSISTOR 2SC2712-YG

Q804 8-729-216-21 TRANSISTOR 2SA1162-YQ805 8-729-230-49 TRANSISTOR 2SC2712-YGQ806 8-729-230-49 TRANSISTOR 2SC2712-YGQ807 8-729-230-49 TRANSISTOR 2SC2712-YGQ808 8-729-230-49 TRANSISTOR 2SC2712-YG

Q809 8-729-230-49 TRANSISTOR 2SC2712-YGQ810 8-729-230-49 TRANSISTOR 2SC2712-YGQ811 8-729-216-21 TRANSISTOR 2SA1162-YQ812 8-729-230-49 TRANSISTOR 2SC2712-YGQ813 8-729-216-21 TRANSISTOR 2SA1162-Y

< RESISTOR >

R101 1-208-518-61 RES,CHIP 22K 2% 1/10WR102 1-208-518-61 RES,CHIP 22K 2% 1/10WR103 1-208-518-61 RES,CHIP 22K 2% 1/10WR104 1-208-518-61 RES,CHIP 22K 2% 1/10WR105 1-208-806-11 RES,CHIP 10K 2% 1/10W

R106 1-208-518-61 RES,CHIP 22K 2% 1/10WR107 1-208-806-11 RES,CHIP 10K 2% 1/10WR108 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR109 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR110 1-208-806-11 RES,CHIP 10K 2% 1/10W

R111 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR112 1-208-534-61 RES,CHIP 100K 2% 1/10WR113 1-208-534-61 RES,CHIP 100K 2% 1/10W

AMPLIFIER

– 23 –


R114 1-208-534-61 RES,CHIP 100K 2% 1/10WR116 1-216-635-11 METAL CHIP 220 0.5% 1/10W

R117 1-208-534-61 RES,CHIP 100K 2% 1/10WR118 1-208-441-61 RES,CHIP 1.5K 2% 1/10WR119 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR120 1-216-647-11 METAL CHIP 680 0.5% 1/10WR121 1-208-518-61 RES,CHIP 22K 2% 1/10W

R122 1-208-506-11 RES,CHIP 6.8K 2% 1/8WR123 1-208-806-11 RES,CHIP 10K 2% 1/10WR124 1-216-631-11 METAL CHIP 150 0.5% 1/10WR125 1-208-510-61 RES,CHIP 10K 2% 1/8WR126 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10W

R127 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR128 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR129 1-208-810-11 RES,CHIP 15K 2% 1/10WR130 1-208-810-11 RES,CHIP 15K 2% 1/10WR131 1-249-556-11 CARBON 1.5K 5% 1/4W

R132 1-259-324-11 CARBON 6.8K 5% 1/2WR133 1-216-635-11 METAL CHIP 220 0.5% 1/10WR134 1-216-635-11 METAL CHIP 220 0.5% 1/10WR135 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR136 1-216-651-11 METAL CHIP 1K 0.5% 1/10W

R137 1-208-413-11 RES,CHIP 100 2% 1/8WR138 1-208-534-61 RES,CHIP 100K 2% 1/10WR139 1-208-534-61 RES,CHIP 100K 2% 1/10WR140 1-208-413-11 RES,CHIP 100 2% 1/8WR141 1-216-206-00 RES,CHIP 2.2K 2% 1/8W

R144 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR145 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR146 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR147 1-216-685-11 METAL CHIP 27K 0.5% 1/10WR148 1-208-806-11 RES,CHIP 10K 2% 1/10W

R149 1-240-882-11 REGISTER 0.03 5WR150 1-240-882-11 REGISTER 0.03 5WR151 1-208-806-11 RES,CHIP 10K 2% 1/10WR152 1-208-806-11 RES,CHIP 10K 2% 1/10WR153 1-208-550-61 RES,CHIP 470K 2% 1/10W

R156 1-217-784-11 FUSIBLE 10 5% 5W FR157 1-208-526-61 RES,CHIP 47K 2% 1/10WR158 1-208-526-61 RES,CHIP 47K 2% 1/10WR159 1-216-471-11 METAL OXIDE 27 5% 3W FR160 1-216-210-00 RES,CHIP 3.3K 2% 1/8W

R161 1-216-150-00 RES,CHIP 10 2% 1/8WR162 1-216-150-00 RES,CHIP 10 2% 1/8WR163 1-216-230-00 RES,CHIP 22K 2% 1/8WR164 1-216-230-00 RES,CHIP 22K 2% 1/8WR165 1-216-603-11 METAL CHIP 10 0.5% 1/10W

R166 1-216-603-11 METAL CHIP 10 0.5% 1/10WR167 1-240-882-11 REGISTER 0.03 5WR168 1-240-882-11 REGISTER 0.03 5WR169 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR170 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10W

R171 1-216-238-00 RES,CHIP 47K 2% 1/8WR172 1-216-685-11 METAL CHIP 27K 0.5% 1/10WR173 1-208-806-11 RES,CHIP 10K 2% 1/10WR174 1-216-238-00 RES,CHIP 47K 2% 1/8WR201 1-208-518-61 RES,CHIP 22K 2% 1/10W


R207 1-208-806-11 RES,CHIP 10K 2% 1/10WR208 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR209 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR210 1-208-806-11 RES,CHIP 10K 2% 1/10WR211 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10W

R212 1-208-534-61 RES,CHIP 100K 2% 1/10WR213 1-208-534-61 RES,CHIP 100K 2% 1/10WR214 1-208-534-61 RES,CHIP 100K 2% 1/10WR216 1-216-635-11 METAL CHIP 220 0.5% 1/10WR217 1-208-534-61 RES,CHIP 100K 2% 1/10W

R218 1-208-441-61 RES,CHIP 1.5K 2% 1/10WR219 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR220 1-216-647-11 METAL CHIP 680 0.5% 1/10WR221 1-208-518-61 RES,CHIP 22K 2% 1/10WR222 1-208-506-11 RES,CHIP 6.8K 2% 1/8W

R223 1-208-806-11 RES,CHIP 10K 2% 1/10WR224 1-216-631-11 METAL CHIP 150 0.5% 1/10WR225 1-208-510-61 RES,CHIP 10K 2% 1/8WR226 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR227 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10W

R228 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR229 1-208-810-11 RES,CHIP 15K 2% 1/10WR230 1-208-810-11 RES,CHIP 15K 2% 1/10WR231 1-249-556-11 CARBON 1.5K 5% 1/4WR232 1-259-324-11 CARBON 6.8K 5% 1/2W

R233 1-216-635-11 METAL CHIP 220 0.5% 1/10WR234 1-216-635-11 METAL CHIP 220 0.5% 1/10WR235 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR236 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR237 1-208-413-11 RES,CHIP 100 2% 1/8W

R238 1-208-534-61 RES,CHIP 100K 2% 1/10WR239 1-208-534-61 RES,CHIP 100K 2% 1/10WR240 1-208-413-11 RES,CHIP 100 2% 1/8WR241 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR244 1-216-206-00 RES,CHIP 2.2K 2% 1/8W

R245 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR246 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR247 1-216-685-11 METAL CHIP 27K 0.5% 1/10WR248 1-208-806-11 RES,CHIP 10K 2% 1/10WR249 1-240-882-11 REGISTER 0.03 5W

R250 1-240-882-11 REGISTER 0.03 5WR251 1-208-806-11 RES,CHIP 10K 2% 1/10WR252 1-208-806-11 RES,CHIP 10K 2% 1/10WR253 1-208-550-61 RES,CHIP 470K 2% 1/10WR256 1-217-784-11 FUSIBLE 10 5% 5W F

R257 1-208-526-61 RES,CHIP 47K 2% 1/10WR258 1-208-526-61 RES,CHIP 47K 2% 1/10WR259 1-216-471-11 METAL OXIDE 27 5% 3W FR260 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR261 1-216-150-00 RES,CHIP 10 2% 1/8W

R262 1-216-150-00 RES,CHIP 10 2% 1/8WR263 1-216-230-00 RES,CHIP 22K 2% 1/8WR264 1-216-230-00 RES,CHIP 22K 2% 1/8W

AMPLIFIER

– 24 –


R265 1-216-603-11 METAL CHIP 10 0.5% 1/10WR266 1-216-603-11 METAL CHIP 10 0.5% 1/10W

R267 1-240-882-11 REGISTER 0.03 5WR268 1-240-882-11 REGISTER 0.03 5WR269 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR270 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR271 1-216-238-00 RES,CHIP 47K 2% 1/8W

R272 1-216-685-11 METAL CHIP 27K 0.5% 1/10WR273 1-208-806-11 RES,CHIP 10K 2% 1/10WR274 1-216-238-00 RES,CHIP 47K 2% 1/8WR801 1-208-558-61 RES,CHIP 1M 2% 1/10WR802 1-208-774-11 RES,CHIP 470 2% 1/10W


R808 1-208-806-11 RES,CHIP 10K 2% 1/10WR809 1-208-806-11 RES,CHIP 10K 2% 1/10WR810 1-208-558-61 RES,CHIP 1M 2% 1/10WR811 1-208-486-61 RES,CHIP 1K 2% 1/8WR812 1-216-206-00 RES,CHIP 2.2K 2% 1/8W

R813 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR814 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR815 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR816 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR817 1-216-210-00 RES,CHIP 3.3K 2% 1/8W

R818 1-208-806-11 RES,CHIP 10K 2% 1/10WR819 1-208-806-11 RES,CHIP 10K 2% 1/10WR820 1-216-648-11 METAL CHIP 750 0.5% 1/10WR821 1-216-659-11 METAL CHIP 2.2K 0.5% 1/10WR822 1-208-806-11 RES,CHIP 10K 2% 1/10W

R823 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR824 1-208-806-11 RES,CHIP 10K 2% 1/10WR825 1-216-238-00 RES,CHIP 47K 2% 1/8WR826 1-208-806-11 RES,CHIP 10K 2% 1/10WR827 1-208-806-11 RES,CHIP 10K 2% 1/10W

R828 1-208-806-11 RES,CHIP 10K 2% 1/10WR829 1-208-510-61 RES,CHIP 10K 2% 1/8WR830 1-208-806-11 RES,CHIP 10K 2% 1/10WR831 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR832 1-216-210-00 RES,CHIP 3.3K 2% 1/8W

R847 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR848 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR849 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR906 1-216-210-00 RES,CHIP 3.3K 2% 1/8WR943 1-244-901-11 RES, CHIP 15K 5% 1/2W

R944 1-244-901-11 RES, CHIP 15K 5% 1/2WR945 1-244-901-11 RES, CHIP 15K 5% 1/2WR946 1-244-901-11 RES, CHIP 15K 5% 1/2W

< VARIABLE RESISTOR >

RV101 1-241-761-11 RES, ADJ, CARBON 1K (IDLING)(L-ch)RV201 1-241-761-11 RES, ADJ, CARBON 1K (IDLING)(R-ch)

< SWITCH >

S803 1-572-185-11 SWITCH, SLIDE (FILTER)

< THERMISTOR >

TH801 1-809-664-51 THERMISTOR, POSITIVETH802 1-809-664-51 THERMISTOR, POSITIVE

< VARIABLE RESISTOR >

VR801 1-225-647-11 RES, VAR 20K/20K/20K/20K (LEVEL)VR802 1-225-648-11 RES, VAR 5K/5K (LOW BOOST)VR803 1-225-648-11 RES, VAR 5K/5K (FILTER)

**************************************************************

(Including in AMP/POWER BOARD, COMPLETE)

POWER BOARD*************

< CAPACITOR >

C810 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC811 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC901 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC902 1-130-471-00 MYLAR 0.001uF 5% 50VC903 1-128-551-11 ELECT 22uF 20% 25V

C904 1-126-933-11 ELECT 100uF 20% 16VC905 1-126-933-11 ELECT 100uF 20% 16VC906 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC907 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50VC908 1-163-141-00 CERAMIC CHIP 0.001uF 5% 50V

C909 1-136-173-00 FILM 0.47uF 5% 50VC910 1-165-319-11 CERAMIC CHIP 0.1uF 50VC911 1-136-161-00 FILM 0.047uF 5% 50VC912 1-111-044-11 ELECT 2200uF 20% 16VC913 1-111-044-11 ELECT 2200uF 20% 16V

C914 1-111-044-11 ELECT 2200uF 20% 16VC915 1-136-161-00 FILM 0.047uF 5% 50VC916 1-111-044-11 ELECT 2200uF 20% 16VC917 1-111-044-11 ELECT 2200uF 20% 16VC918 1-111-044-11 ELECT 2200uF 20% 16V

C919 1-126-052-11 ELECT 100uF 20% 50VC920 1-126-052-11 ELECT 100uF 20% 50VC921 1-126-052-11 ELECT 100uF 20% 50VC922 1-126-052-11 ELECT 100uF 20% 50VC923 1-130-321-00 FILM 0.1uF 5% 100V

C924 1-130-321-00 FILM 0.1uF 5% 100VC925 1-130-321-00 FILM 0.1uF 5% 100VC926 1-130-321-00 FILM 0.1uF 5% 100VC927 1-128-493-11 ELECT 4700uF 20% 63VC928 1-128-493-11 ELECT 4700uF 20% 63V

C929 1-128-493-11 ELECT 4700uF 20% 63VC930 1-128-493-11 ELECT 4700uF 20% 63VC931 1-128-230-11 ELECT 100uF 20% 80VC932 1-128-230-11 ELECT 100uF 20% 80VC933 1-128-230-11 ELECT 100uF 20% 80V

C934 1-128-230-11 ELECT 100uF 20% 80VC935 1-165-319-11 CERAMIC CHIP 0.1uF 50VC936 1-165-319-11 CERAMIC CHIP 0.1uF 50VC937 1-165-319-11 CERAMIC CHIP 0.1uF 50VC938 1-165-319-11 CERAMIC CHIP 0.1uF 50V

C939 1-126-023-11 ELECT 100uF 20% 16V

POWERAMPLIFIER

– 25 –


C940 1-126-023-11 ELECT 100uF 20% 16VC941 1-126-023-11 ELECT 100uF 20% 16VC942 1-126-023-11 ELECT 100uF 20% 16VC959 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50V

C960 1-163-021-11 CERAMIC CHIP 0.01uF 10% 50VC965 1-128-551-11 ELECT 22uF 20% 25V

< CONNECTOR >

CN801 1-537-920-21 TERMINAL BOARD (2P)(+12V, GND)CNJ801 1-793-279-11 CONNECTOR 1P (REMOTE)CNJ802 1-766-902-11 CONNECTOR, FFC/FPC (ZIF) 9P

* CNP801 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P (FN801)

< DIODE >

D805 8-719-801-78 DIODE 1SS184D806 8-719-801-78 DIODE 1SS184D807 8-719-158-49 DIODE RD12SB2D901 8-719-025-33 DIODE 02CZ6.2-TE85LD902 8-719-025-50 DIODE 02CZ16-TE85L

D903 8-719-987-67 DIODE 11EFS2D904 8-719-987-67 DIODE 11EFS2D905 8-719-987-67 DIODE 11EFS2D906 8-719-987-67 DIODE 11EFS2D907 8-719-987-67 DIODE 11EFS2

D908 8-719-987-67 DIODE 11EFS2D909 8-719-987-67 DIODE 11EFS2D910 8-719-987-67 DIODE 11EFS2D911 8-719-054-55 DIODE 1SS306(TE85L)D912 8-719-054-55 DIODE 1SS306(TE85L)

D913 8-719-054-55 DIODE 1SS306(TE85L)D914 8-719-054-55 DIODE 1SS306(TE85L)D915 8-719-210-30 DIODE F10P20F(R)D916 8-719-210-30 DIODE F10P20F(R)D917 8-719-210-30 DIODE F10P20F(R)

D918 8-719-210-30 DIODE F10P20F(R)D919 8-719-210-30 DIODE F10P20F(R)D920 8-719-210-30 DIODE F10P20F(R)D921 8-719-210-30 DIODE F10P20F(R)D922 8-719-210-30 DIODE F10P20F(R)

D925 8-719-820-05 DIODE 1SS181D926 8-719-025-49 DIODE 02CZ15-TE85LD927 8-719-025-49 DIODE 02CZ15-TE85LD928 8-719-025-49 DIODE 02CZ15-TE85LD929 8-719-025-49 DIODE 02CZ15-TE85L

D934 8-719-200-82 DIODE 11ES2D935 8-719-200-82 DIODE 11ES2D936 8-719-200-82 DIODE 11ES2D937 8-719-200-82 DIODE 11ES2D938 8-719-056-97 DIODE UDZ-TE-17-27B

D939 8-719-056-97 DIODE UDZ-TE-17-27BD940 8-719-056-97 DIODE UDZ-TE-17-27BD941 8-719-977-81 DIODE DTZ33BD942 8-719-801-78 DIODE 1SS184D943 8-719-820-05 DIODE 1SS181

D944 8-719-801-78 DIODE 1SS184D945 8-719-056-78 DIODE UDZ-TE-17-4.3B

< FUSE >

F901 1-533-743-11 FUSE (BLADE TYPE)(AUTO FUSE)(40A)F902 1-533-743-11 FUSE (BLADE TYPE)(AUTO FUSE)(40A)

< FAN MOTOR>

FN801 1-763-107-11 MOTOR, FAN

< IC >

IC901 8-759-144-88 IC µPC494GSIC903 8-719-156-73 IC PHOTO COUPLER PS2501-1LA

< COIL >

L901 1-424-112-11 INDUCTOR 7.5uHL902 1-424-112-11 INDUCTOR 7.5uHL903 1-410-396-71 INDUCTOR 0.45uHL904 1-410-396-71 INDUCTOR 0.45uH

< DIODE >

LD804 8-719-070-01 DIODE SEC2764C (HI-VOLTAGE)LD805 8-719-070-01 DIODE SEC2764C (HI-CURRENT)

< PILOT LAMP >

PL801 1-518-540-00 LAMP, PILOT

< TRANSISTOR >

Q814 8-729-216-21 TRANSISTOR 2SA1162-YQ815 8-729-032-94 TRANSISTOR 2SD1859TV2QQ901 8-729-041-38 TRANSISTOR 2SB1241TV2QQ902 8-729-216-21 TRANSISTOR 2SA1162-YQ903 8-729-230-49 TRANSISTOR 2SC2712-YG

Q904 8-729-030-72 TRANSISTOR MTAJ50N05HDQ905 8-729-030-72 TRANSISTOR MTAJ50N05HDQ906 8-729-030-72 TRANSISTOR MTAJ50N05HDQ907 8-729-030-72 TRANSISTOR MTAJ50N05HDQ908 8-729-030-72 TRANSISTOR MTAJ50N05HD

Q909 8-729-030-72 TRANSISTOR MTAJ50N05HDQ910 8-729-030-72 TRANSISTOR MTAJ50N05HDQ911 8-729-030-72 TRANSISTOR MTAJ50N05HDQ912 8-729-230-49 TRANSISTOR 2SC2712-YGQ913 8-729-230-49 TRANSISTOR 2SC2712-YG

Q914 8-729-230-49 TRANSISTOR 2SC2712-YGQ915 8-729-230-49 TRANSISTOR 2SC2712-YGQ916 8-729-106-60 TRANSISTOR 2SB1115AQ917 8-729-106-60 TRANSISTOR 2SB1115AQ918 8-729-207-82 TRANSISTOR 2SC3421-Y

Q919 8-729-207-82 TRANSISTOR 2SC3421-YQ920 8-729-207-89 TRANSISTOR 2SA1358-YQ921 8-729-207-89 TRANSISTOR 2SA1358-YQ926 8-729-230-49 TRANSISTOR 2SC2712-YGQ927 8-729-119-78 TRANSISTOR 2SC403SP-51

< RESISTOR >

R833 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR834 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR835 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR836 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR837 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10W

POWER

– 26 –

Sony CorporationPersonal & Mobile Communication Company9-926-491-11 99C090260-1

Printed in Japan © 1999. 3Published by Quality Assurance Dept.

XM-2252HX


R838 1-208-770-11 RES,CHIP 330 2% 1/10WR839 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR840 1-208-770-11 RES,CHIP 330 2% 1/10WR841 1-218-760-11 RES,CHIP 220K 2% 1/10WR842 1-216-635-11 METAL CHIP 220 0.5% 1/10W

R844 1-208-770-11 RES,CHIP 330 2% 1/10WR845 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR846 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10WR901 1-208-806-11 RES,CHIP 10K 2% 1/10WR902 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10W

R903 1-208-518-61 RES,CHIP 22K 2% 1/10WR904 1-208-812-11 RES,CHIP 18K 2% 1/10WR905 1-216-103-00 METAL CHIP 180K 5% 1/10WR907 1-216-202-00 RES,CHIP 1.5K 2% 1/8WR908 1-216-202-00 RES,CHIP 1.5K 2% 1/8W

R909 1-216-663-11 METAL CHIP 3.3K 0.5% 1/10WR910 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR911 1-249-576-11 CARBON 10K 5% 1/4WR912 1-208-474-61 RES,CHIP 330 2% 1/8WR913 1-208-486-61 RES,CHIP 1K 2% 1/8W

R914 1-208-486-61 RES,CHIP 1K 2% 1/8WR915 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR916 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR917 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR918 1-216-651-11 METAL CHIP 1K 0.5% 1/10W

R919 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR920 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR921 1-208-397-11 RES,CHIP 22 2% 1/8WR922 1-208-397-11 RES,CHIP 22 2% 1/8WR923 1-208-397-11 RES,CHIP 22 2% 1/8W

R924 1-208-397-11 RES,CHIP 22 2% 1/8WR925 1-208-373-11 RES,CHIP 2.2 2% 1/8WR926 1-208-373-11 RES,CHIP 2.2 2% 1/8WR927 1-208-373-11 RES,CHIP 2.2 2% 1/8WR928 1-208-373-11 RES,CHIP 2.2 2% 1/8W

R929 1-208-373-11 RES,CHIP 2.2 2% 1/8WR930 1-208-373-11 RES,CHIP 2.2 2% 1/8WR931 1-208-373-11 RES,CHIP 2.2 2% 1/8WR932 1-208-373-11 RES,CHIP 2.2 2% 1/8WR933 1-208-365-61 RES,CHIP 100 2% 1/10W

R934 1-208-365-61 RES,CHIP 100 2% 1/10WR935 1-208-486-61 RES,CHIP 1K 2% 1/8WR936 1-216-651-11 METAL CHIP 1K 0.5% 1/10WR937 1-215-863-11 METAL OXIDE 100 5% 1W FR938 1-215-863-11 METAL OXIDE 100 5% 1W F



R953 1-216-206-00 RES,CHIP 2.2K 2% 1/8WR955 1-208-526-61 RES,CHIP 47K 2% 1/10WR956 1-208-806-11 RES,CHIP 10K 2% 1/10W

R957 1-216-667-11 METAL CHIP 4.7K 0.5% 1/10WR958 1-216-635-11 METAL CHIP 220 0.5% 1/10W

< SWITCH >

S801 1-771-387-11 SWITCH, TOGGLE (HI-CURRENT)S802 1-771-387-11 SWITCH, TOGGLE (HI-VOLTAGE)

< TRANSFORMER >

T901 1-433-939-11 TRANSFORMER, DC-DC CONVERTERT902 1-433-939-11 TRANSFORMER, DC-DC CONVERTER

< THERMISTOR >

TH803 1-810-506-11 THERMISTOR NTH5G39B223K01 (22K)TH804 1-810-506-11 THERMISTOR NTH5G39B223K01 (22K)TH805 1-810-506-11 THERMISTOR NTH5G39B223K01 (22K)TH901 1-810-506-11 THERMISTOR NTH5G39B223K01 (22K)

**************************************************************

MISCELLANEOUS*************

F901 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) (40A)F902 1-533-743-11 FUSE (BLADE TYPE) (AUTO FUSE) (40A)FN801 1-763-107-11 MOTOR, FANTH801 1-809-664-51 THERMISTOR, POSITIVETH802 1-809-664-51 THERMISTOR, POSITIVE

**************************************************************

ACCESSORIES & PACKING MATERIALS*******************************

3-037-683-01 COVER, 2P TERMINAL TABLE3-367-410-01 SCREW (DIA. 5X15), TAPPING3-866-284-11 MANUAL, INSTRUCTION (EXCEPT G)

(ENGLISH, FRENCH)3-866-284-21 MANUAL, INSTRUCTION (AEP,UK,G)

(GERMAN, ITALIAN)3-866-284-31 MANUAL, INSTRUCTION (AEP,UK,G)

(SPANISH, PORTUGUESE)

3-866-284-41 MANUAL, INSTRUCTION (AEP,UK,G)(DUTCH, SWEDISH)

**************************************************************

*************HARDWARE LIST*************

#1 7-685-544-14 +BTP 3x5 TYPE2 N-S#2 7-685-546-19 +BTP 3x8 TYPE2 N-S#3 7-685-797-09 +PTT 2.6x16 (S)#4 7-685-646-79 +P 3x8 TYPE2 N-S#5 7-685-144-11 +P 3x5 TYPE2 N-S

#6 7-682-546-09 SCREW +B 3x5#7 7-685-660-79 +P 4x10 TYPE2 N-S#8 7-685-645-79 +P 3x6 TYPE2 N-S#9 7-682-949-01 +PSW 3x10#10 7-685-649-79 +P 3x14 TYPE2 N-S

POWER

xm-2252hx - bcae1.com - xm-2252.pdf · xm-2252hx – 11 – – 12 – ... pre amp + filter mute...

Documents