volvo navigations system installation.pdf
TRANSCRIPT
-
8/14/2019 Volvo Navigations system Installation.pdf
1/24
Installation instructions, accessories - Navigation system portableVolvo Car Corporation Gteborg, Sweden
XC60Section Group Weight(Kg/Pounds) Year Mont
3 391 0.067 / 0.15 2009 08
XC60 2009, XC60 2010
IMG-334408
-
8/14/2019 Volvo Navigations system Installation.pdf
2/24
Required tools:
A0000162 IMG-239664
IMG-334484
IMG-334409
-
8/14/2019 Volvo Navigations system Installation.pdf
3/24
IMG-334410
-
8/14/2019 Volvo Navigations system Installation.pdf
4/24
INTRODUCTION
NOTE! Read through the whole installationinstruction before starting the work.
The front page gives the date of this edition andthe edition it replaces
The second page shows the tools needed for theinstallation and the contents of the installation kit
The illustrations display the procedure in order ofoperation. The order of operation is repeated inthe text section
Cut out the text page in order to follow theillustrations and text at the same time.
Navigation system portable
-
8/14/2019 Volvo Navigations system Installation.pdf
5/24
1
IMG-245980
Note!
Work is carried out the same way on left-hand drive cars as onright-hand drive cars (Mirrored). Left-hand drive car shown. In caseswhere there are differences between left and right-hand drive cars,both versions are shown.
Turn the ignition switch to position 0.
Note!
Wait at least three minutes before unplugging the connectors orremoving other electrical equipment.
2
IMG-298585
Remove the tunnel console's panel on the left-hand side (Alsoapplies to right-hand drive cars). It is secured with sevenclips on the inside.
3
IMG-282523
Carefully pry loose the panel with air blower all round. Thepanel is secured by five clips on the sides and at the top andwith four mounting springs on the lower edge.
4
IMG-282524
Pull out the panel and disconnect the connector for the hazardwarning lights.
5AIllustrations A and B
Replacement of the panel for the air vent
Poke the catches downwards using a small screwdriver.
-
8/14/2019 Volvo Navigations system Installation.pdf
6/24
IMG-303983
5B
IMG-303984
Fold down the air nozzle and unhook it from the four mountingeyelets at the lower edge of the panel.
6
IMG-303985
Poke the catches on the hazard warning button in and pushthe button out.
7
IMG-334413
Remove and transfer the clips to the new panel, place the oldone to one side.
8
IMG-334414
Install the button for the hazard warning lights in the newpanel.
-
8/14/2019 Volvo Navigations system Installation.pdf
7/24
9
IMG-334416
Install the air vent in the new panel.
10
IMG-329154
11
IMG-329155
Use tape to protect the tunnel console.
12
IMG-293021
-
8/14/2019 Volvo Navigations system Installation.pdf
8/24
13
IMG-293022
14
IMG-293023
15
IMG-293024
16
IMG-329163
17
-
8/14/2019 Volvo Navigations system Installation.pdf
9/24
IMG-293028
18
IMG-293029
19
IMG-329164
20
IMG-334421
Remove the rear end with cover.
Disconnect the connectors for the 12 V socket and seat
heating.
21
Route the cable harness to the centre console in the sameway on left-hand drive and right-hand drive cars
-
8/14/2019 Volvo Navigations system Installation.pdf
10/24
IMG-334422
Take a piece of curtain wire and insert it in the rear edge of thetunnel console and slide it forward on the left-hand side andout where the left side panel was located.
Lift up the console at the rear edge to facilitate access.
22
IMG-334423
Take the large cable harness from the kit and secure it to theend of the wire using a piece of masking tape.
Pull the cable harness forward.
Lift up the tunnel console at the rear edge to facilitate pullingthrough.
Check that the cable harness is not trapped when the tunnelconsole is positioned.
23
IMG-334424
Connect the male connector (1) in the new cable harness tothe 12 V socket.
Connect the disconnected connector (2) from the 12 V socketto the female connector (2) in the new cable harness.
Reconnect the green connector (3).
Insert the connectors and fuse holder down as far as possible.
24
IMG-329164
25
Wrap the connectors and fuse holder with foam tape.
-
8/14/2019 Volvo Navigations system Installation.pdf
11/24
IMG-334425
26
IMG-334426
Position the connectors and fuse holder.
27
IMG-334427
28
-
8/14/2019 Volvo Navigations system Installation.pdf
12/24
IMG-334428
29
IMG-334429
30
IMG-293023
31
IMG-334431
32
-
8/14/2019 Volvo Navigations system Installation.pdf
13/24
IMG-334432
33
IMG-334433
Insert the wire through the centre console on the left-hand sideand out where the side panel was located.
34
IMG-334434
Tape the routed cable using a piece of masking tape and pullup.
35
IMG-334435
Take the short cable from the kit and connect to the newlyrouted one.
36 Steps 36-49 are mirrored for right-hand drive cars
-
8/14/2019 Volvo Navigations system Installation.pdf
14/24
-
8/14/2019 Volvo Navigations system Installation.pdf
15/24
40
IMG-222268
Remove the screws and the panel.
41
IMG-222270
Disconnect the lighting connector and place the panel to oneside.
42
IMG-295944
Remove the two screws.
-
8/14/2019 Volvo Navigations system Installation.pdf
16/24
43
IMG-295945
Carefully pry off the glovebox lighting.
44
IMG-295946
Loosen the connector from the lamp in the glovebox lighting, itmay be tight.
45
IMG-295947
Remove the six screws.
If necessary, disconnect the connector from the SIM cardholder.
Pull the glove compartment out slightly so that the clipsrelease.
Remove the glovebox.
46
Take the panel with cradle and aerial from the kit.
-
8/14/2019 Volvo Navigations system Installation.pdf
17/24
IMG-334449
Insert the aerial over the air vent to the right and down towardsthe rear edge of the dashboard.
Note!
Leave enough cable excess so that the panel with cradle is not inthe way when making connections in the centre console.
47
IMG-333785
Continue to route the aerial with cable, from the right air duct inthe centre console, and then along the rear edge of thedashboard to the right.
Secure using pieces of butyl tape.
48
IMG-333786
Continue to route the aerial with cable towards the air duct atthe right end of the dashboard.
Route it on the outside of the air duct and out through the holein the end and position on the dashboard.
Secure the cable to the outside of the air duct using butyl tape.
49
Clean the surface in front of the air vent on the right-hand sideof the dashboard and wipe dry.
-
8/14/2019 Volvo Navigations system Installation.pdf
18/24
IMG-334451
50
IMG-334452
Remove the protective tape from the mounting tape.
51
IMG-334453
Steps 51-53 are mirrored for right-hand drive cars
Secure the aerial approximately in position as shown.
52
IMG-334454
Route the cable under the cradle (1) for the A-pillar and back.
Route the cable excess back to the rear edge of the dashboardwhere the cable was previously routed.
53AIllustrations A and B
Secure the cable excess at the existing pieces of butyl tapeaccording to image A and B.
Also secure on the right-hand side of the air duct.
-
8/14/2019 Volvo Navigations system Installation.pdf
19/24
IMG-334455
53B
IMG-334456
54
IMG-334457
Secure the green connectors at the existing cable harnessusing cable ties.
55
IMG-334458
Connect the connectors to the cradle and button for the hazardwarning lights.
56
Push the panel into place. Ensure that the cables are not infront of the air vents.
-
8/14/2019 Volvo Navigations system Installation.pdf
20/24
IMG-334459
57
IMG-333791
Steps 57-66 are mirrored for right-hand drive cars
58
IMG-333792
59
IMG-333793
60
-
8/14/2019 Volvo Navigations system Installation.pdf
21/24
IMG-296464
Take the glovebox and connect the connector to the Sim cardholder, if necessary.
Insert the connector to the glovebox lighting.
61
IMG-296465
62
IMG-296466
63
IMG-296467
64
-
8/14/2019 Volvo Navigations system Installation.pdf
22/24
IMG-286608
65
IMG-225272
66
IMG-280033
67A
IMG-333800
67B
Illustrations A, B and C
Take the Garmin device, connect the aerial and align the guideholes in the bottom, with the corresponding lugs in the cradle.
Fold it to the limit position and check that it springs up andlocks in the catches on the reverse. When removing, press thereceiver down until the catches release and then fold itbackwards and disconnect the connector from the aerial.
-
8/14/2019 Volvo Navigations system Installation.pdf
23/24
IMG-333801
67C
IMG-334328
-
8/14/2019 Volvo Navigations system Installation.pdf
24/24
VolvoCar Corporation, 2009 Printed in Sweden 3075814