type: thruster t600 (n) & (t) 390kg · 2016. 12. 12. · type: thruster t600 (n) & (t)...
TRANSCRIPT
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 1 of 11
TYPE: Thruster T600 (N) & (T) 390kg (1) MANUFACTURER Thruster Aircraft (UK)
Continued Support: Thruster Aircraft LLP North Hanger Wickenby Airfield Langworth, Lincs LN3 5AX
(2) UK IMPORTER: N/A
(3) CERTIFICATION:
BCAR Section S Issue 1 (4 April 1995) with Working Papers S861 and S901 for the T600 with Rotax 582. JAR 22 paras 1935 and 1939 have been employed to satisfy Section S Subpart J for the composit propeller.
(4) DEFINITION OF BASIC STANDARD:
Mod TAS 001 Issue 1 dated 18 April 1995 Master drawings list F10 (T600N) Issue 1 dated 2 Jan 1997 Master Drawings List F20 (T600T) Issue 1 dated 2 Jan 1997
(5) COMPLIANCE WITH THE MICROLIGHT DEFINITION
(a) MTOW 390 kg
(b) No. Seats 2
(c) Maximum Wing Loading 25 kg/m²
(d) Vso 32 kn CAS
(e) Permitted range of seat loading* 55-86 kg per seat
(f) T600N: Typical Empty Weight (ZFW) T600T: Typical Empty Weight (ZFW)
199 189
kg kg
(g) T600N: ZFW + 172 kg crew + 1 hr fuel (21 litres / 15 kg) T600T: ZFW + 172 kg crew + 1 hr fuel (21 litres / 15kg)
386
376
kg kg
(h)
T600N: MaxZFW + 86 kg pilot + full fuel T600T: MaxZFW + 86 kg pilot + full fuel
40lt Tank 318 318
25lt Tank 307 307
kg kg
(i) T600N Max ZFW at initial permit issue T600T Max ZFW at initial permit issue
203 203
kg kg
*Note: It is the Pilot’s responsibility to ensure the aircraft is flown within the MTOW
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 2 of 11
(6) POWER PLANTS Designation T600N T600T T600T
Engine Type Rotax 503 DCDI-2V Rotax 503 DCDI-2V Rotax 582 2v
Reduction Gear B-Type 2.58:1 B-Type 2.58:1 B-Type 2.58:1
Exhaust System Rotax straight. After Muffler Optional
Rotax straight. After Muffler Optional
Rotax straight. After Muffler Optional
Intake System Air Filter Air Filter Air Filter
Propeller Type Brolga 2 Blade Brolga 3 Blade
Brolga 2 Blade Brolga 3 Blade
Brolga 3 Blade
Propeller Dia x Pitch 68" x 13 º 68" x 09 º
68" x 13 º 68" x 09 º
68" x 12 º
Noise Type Cert No. 44M Issue 11 44M Issue 11 44M Issue 15
AAN approving configuration 24970 24970 26145 (7) MANDATORY LIMITATIONS: (a) Max Take-Off Weight 390 kg
(b) CG Limits Aft Limit: FWD Limit:
482 mm Aft of datum 389 mm Aft of datum
(c) CG datum (see annex C)
(d) Cockpit Loadings
Min: Max:
Port 55 86
Starboard Either Seat 86
Total kg kg
(e) Never Exceed Speed 80 KIAS
(f) Manoeuvring Speed 60 KIAS
(g) Permitted Manoeuvres 30° Nose up / 30° nose down Non Aerobatic Normal acceleration limits, +4 / -2g
(h) Fuel Contents (Max Useable) 25lt or 38.7lt depending on tank fitted
(i) Power Plant (see table below)
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 3 of 11
Engine T600N Rotax 503 DCDI-2V
T600T Rotax 503 DCDI-2V
T600T Rotax 582 DCDI-2V
Max RPM 6500 6500 6500
MAX CHT 250°C(480°F) 250°C(480°F) -na- water cooled
MAX EGT 650°C (1200°F)
650°C (1200°F)
650°C (1200°F)
Fuel Spec Mogas min RON 91 (mon83) leaded or non leaded or Argas fuel 100LL (blue) mixed 50:1 with 2 stroke oil
Engine Oil Spec Two stroke Two stroke Two stroke
Gearbox oil spec SAE 140-API-GL5
SAE 140-API-GL5
SAE 140-API-GL5
Fuel/Oil Mix 50:1 50:1 50:1
Coolant Temperature -na- -na- 80°C
Oil Pressure -na- -na- -na-
Oil Temperature -na- -na- -na-
Fuel Pressure -na- -na- -na- (8) INSTRUMENTS REQUIRED:
ASI
Altimeter RPM CHT / EGT
Compass Coolant temp
Fuel Pressure
VSI Slip ball
Required 0 to 100 Kts min.)
Required Required Required Optional Water cooled engines
only
-na- Optional Optional
(9) CONTROL DEFLECTIONS: Elevator UP: 30°+/- 2° Tailplane trim UP: -na- Elevator DOWN: 30° +/- 2° Tailplane trim DOWN: -na- Ailerons UP: 40°+/- 2° Rudder LEFT: 25°+/- 2° Ailerons Down: 30°+/- 2° Rudder RIGHT: 25°+/- 2°
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 4 of 11
(10) PILOT'S NOTES, MAINTENANCE MANUALS REFERENCES:
10.1 Manuals approved for use with this aircraft.
(a) Pilot Operating Handbook POH Part Number 210-055 POH Supplement Rotax 582 Pt No. 210-057 Change Sheet N0. 2 is required for Ultralam coverings
10.2 The following placards are to be fitted:-
(a) Flight Limitations Placard (to be visible to pilot) See Annex D. (b) Engine Limitations Placard (to be located near to engine instruments) See Annex D. (c) Fuel Limitations Placard (to be located near to filler cap) A placard is to be fitted showing fuel capacity ( litres), fuel type(s), fuel:oil ratio
(if relevant) and if MTOW can be exceeded with full fuel and maximum cockpit weight, the fuel loads at MTOW for cockpit weights of 180kg / 170kg / 160kg etc. at 10kg intervals down to the maximum fuel load. An example is shown at Annex D.
(d) Switches See Annex D.
(11) MANDATORY MODIFICATIONS / SERVICE BULLETINS / AIRWORTHINESS
DIRECTIVES ETC: See Annex A for required modifications. Also see Thruster website @ www.thruster.co.uk for
latest information.
Annual Bettsometer test is to be carried out to 1320 grammes with wing sails fitted and tensioned to flight. Test must be to both upper and lower surfaces.
(12) MINIMUM PERFORMANCE AT MAX TAKE-OFF WEIGHT Rate of Climb: Rotax 503 400 fpm at 50 KIAS Rotax 582 600 fpm at 50 KIAS
Stall or Minimum Flying Speed: 32 KIAS at MTOW / idle
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 5 of 11
(13) APPROVED OPTIONAL MODIFICATIONS See Annex B. Also see Thruster website @ www.thruster.co.uk for latest information
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 6 of 11
Issue History
Issue No. Reason and signatory 1 02/04/97 Initial Issue
A C LOVE 2 10/05/99 Propeller option added to modification TAS 009 (AAN 26863)
Rotax 582 engine option for T600T added to modification TAS 006 (AAN 26145) A J MAXWELL
3 06/07/99 Alternative material for wing and empennage skins - Modifications TAS 010 (AAN 26144) A J MAXWELL
4 07/09/99 Rotax 582 engine options for T600N with increased MTOW to 450 kg - Modification TAS 020 (AAN 27119) A J MAXWELL
5 23/05/03 BM52 Issue 5 removes reference to T600N (450 kg) Rotax are now being transferred to BM63 Issue 1. A J MAXWELL
6 06/11/07 Editorial Corrections A J MAXWELL
7 05/05/12 Editorial Corrections, Corrections to Cockpit Loading, Control Deflections, AAIB Safety action addition of “Area Of Special Attention” ANNEX E T LOVE
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 7 of 11
Illustration of Aircraft - 3 View T600N
T600T
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 8 of 11
Illustration of Aircraft - Photograph T600N
T600T
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 9 of 11
ANNEX A – MANDATORY MODIFICATIONS
1. None
ANNEX B - APPROVED OPTIONAL MODIFICATIONS The installation of all optional modifications is to be inspected by a BMAA inspector and an entry made in the appropriate logbook(s). Note that other approved modifications may exist which are not listed here.
Thruster Mod Date Title TAL 03-3 12/02/1992 Rotax Exhaust After Muffler TAL 03-9 12/02/1992 GRP Wheel Spats TAS 010 10/07/1997 Ultralam Wing Skins
TAS 013 02/12/1997 Ivo Prop Installation
TAS 018 29/09/1997 Disabled Person Mod “Crip Kit”
TAS 026 01/03/2004 Lever for existing Bungee Trim System
TAS 030 01/03/2004 Carburettor Inlet Heater
TAS 031 01/03/2004 Wing Strobe Lights
TAS 033 01/03/2004 Roll Trim Bias
TAS 034 01/03/2004 Battery Isolator Switch
TAS 035 01/03/2004 Extended Control Colum Stick (Training Aid)
TAS 037 01/03/2004 Wider Nose Wheel
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 10 of 11
ANNEX C WEIGHING INFORMATION
1. CG Datum: Aft of Wing Leading Edge Tube 2. Weighing attitude: Wings and Fusetube Level 3. Mainwheel moment arm: T600N: 767.5 mm AOD
T600T: 31.5mm AOD 4. Nosewheel moment arm:
Tailwheel moment arm: 750 (mm) (Forward) of datum 4075 (mm) (Aft) of datum
5. Fuel moment arm: 1030 (mm) (Aft) of datum 6. Crew moment arm: 423 (mm) (Aft) of datum (Front Seat position)
448 (mm) (Aft) of datum (Mid Seat Position) 473 (mm) (Aft) of datum (Rear Seat Position)
7. Crew weights: Minimum 55 kg / maximum 86 kg 8. Aft CG Limit: 482 (mm) (Aft) of datum 9. Fwd CG Limit: 389 (mm) (Aft) of datum
ANNEX D EXAMPLE PLACARDS
(a) Flight Limitations Placard (to be visible to pilot)
[Type] [Engine] [Registration]
Never Exceed Speed: 80 KIAS Manoeuvring Speed : 70 KIAS Stall Speed: 32 KIAS Best climb speed: 50 KIAS Best glide speed: 45 KIAS Pitch Limits: 30° nose down, 30° nose up. Bank angle limits: +/- 60° Maximum Stall entry rate: 1 kn/s Normal Acceleration Limits: +4 / -2g Empty Weight: 199 kg * Max Take-Off Weight: 390 kg Minimum Cockpit Weight: 55 kg Maximum Cockpit Weight: 86 kg in each seat.* Aerobatics and deliberate spinning prohibited. * this must match the most recent W&CG report for the aircraft.
(b) Engine Limitations Placard (to be located near to engine instruments)
A placard showing the limitations for all indicated engine parameters is to be mounted close to the engine instruments. This requirement need not be complied with for limitations shown as coloured markers (red for danger, amber for caution) on the instrument displays.
CIVIL AVIATION AUTHORITY – SAFETY REGULATION GROUP
MICROLIGHT TYPE APPROVAL DATA SHEET (TADS)
NO: BM 52 ISSUE: 7
TADS BM 52 Issue 7 Page 11 of 11
(c) Fuel Limitations Placard (to be located near to filler cap)
FUEL Capacity * Litres 50:1 2 Stroke oil
Cockpit Weight (kg) Max. Fuel Load (litres) 180 170 ….
…. Or below Full fuel 83 MON or 90 RON minimum unleaded to
BS(EN)228 or 97+ octane 4-star / MOGAS leaded fuel to BS 4040, or AVGAS 100LL
* dependant on Fuel Tank Fitted
(d) Switches
All switches are to be marked with function and sense (up=on, down=off).
ANNEX E Areas for Special Attention During Inspections
1. Carburettor Heating System to minimise risk of Carburettor Icing. An accident caused by
Carburettor Icing has been reported which was due in part to the Electric Carburettor Heating system being fitted on the inlet of the Carburettor rather than the outlet in the vicinity of the butterfly valve. Check that the installation is correct and operational.
�������������� ���� �������������� ����������������� !"�#$%"&��'(�)*+,-�.(('/01203456�785/93�2958:39;8<="�>?--?@,AB�$C%,?A�+"D!,+"E�FG�%=, �H$AE$%?+G�I"+J,%�#,+"C%,K"�LHI#M�, �J$AE$%?+G�>?+�$**-,C$F-"�$,+C+$>%�+"B, %"+"E�,A�%="NA,%"E�O,ABE?J�?*"+$%,AB�?A�$�NO�P))�I"+J,%�%?�Q-GR���������������STUVWSXU�YZU�WXU[Z\XWW] _ab���c"$E,AB�"EB"� *$+�$%%$C=J"A%�F+$Cd"%RYeefgahgfgbi���<=+! %"+�),+�j"+K,C" �<=+! %"+�<k((�j"+," �J,C+?-,B=% RU hl�m���#!+,AB�$�+?!%,A"�$,+>+$J"�,A *"C%,?A�?>�$�<=+! %"+�<k((n� J$--�C+$Cd �@"+"�>?!AE?A�%="�-"$E,AB�"EB"� *$+�$%%$C=J"A%�F+$Cd"%�I$+%�n?�(o(p.kqr�%="�C+$Cd �@"+"�-?C$%"E�?A%="�F"AE�+$E,! �C-? "�%?�%="�?!%"+�"EB"�?>�%="�F+$Cd"%R��<="�J,C+?-,B=%�=$E�-?BB"E$**+?s,J$%"-G�tu(�>-G,AB�=?!+ �$AE� ,AC"�A"@�=$E�F""A�%"%="+"E�E?@A�?!% ,E"�@="A�A?%>-G,ABR��<="�%,"�E?@A�C$F-" �=$E�F""A�$%%$C="E�%?�%="�-,>%� %+!%�"AE �$Ev$C"A%�%?�%="� %$,A-" F+$Cd"% R���%�, �-,d"-G�%=$%�%=, �*$+%,C!-$+�J,C+?-,B=%�=$ �!AE"+B?A"�$� ,BA,>,C$A%�A!JF"+�?>CGC-,C� %+" �+"K"+ $- �*$+%,C!-$+-G�E!"�%?�F",AB�%"%="+"E�?!% ,E"�,A�$--�@"$%="+ R\�wefghma���x">?+"�>!+%="+�>-,B=%�>+?J�%="�">>"C%,K"�E$%"�?>�%=, �HI#�,A *"C%�%="�-"$E,AB"EB"� *$+� %+!%�F+$Cd"% �>?+�C+$Cd �,A�$CC?+E$AC"�@,%=�<=+! %"+�),+�j"+K,C" �j"+K,C"�x!--"%,A<)jyjx(z�� !"�.R��)%�%="� $J"�%,J"�$A�,A *"C%,?A�, �$- ?�+"D!,+"E�?>�%="�%+$,-,AB�"EB"{�v!+G %+!%�$AE�+"$+�-,>%�C$F-"�F+$Cd"% �>?+�C+$Cd {�$ �%=" "�F+$Cd"% �$+"�$--�?>�$� ,J,-$+�E" ,BAR|"*-$C"�$AG�C+$Cd"E�F+$Cd"% �F">?+"�>!+%="+�>-,B=%R��|"%!+A�C+$Cd"E�F+$Cd"% �%?�<=+! %"+�),+j"+K,C" R��|"*"$%�%=" "�,A *"C%,?A �*+,?+�%?�%="�>,+ %�>-,B=%�?>�%="�E$GR��<="�*,-?%�J$G�*"+>?+J%=" "�,A *"C%,?A R)�C?*G�?>�%="�j"+K,C"�x!--"%,A�$AE�>!+%="+�,A>?+J$%,?A�C$A�F"�?F%$,A"E�>+?J&<=+! %"+�),+�j"+K,C" H$-%=?! "},AB"n"$+�~$A%$B"���.�o�j<"-& (�.'u�o'''(uQ$s& (�.'u�o'''z(�J$,-&B?+E?A�%=+! %"+RC?R!d|"C?+E�C?J*-,$AC"�@,%=�%=, �HI#�,A�%="�$,+C+$>%�-?B�F??dR<=, �HI#�F"C?J" �">>"C%,K"�?A�u�H$G�.(('R�AD!,+," �+"B$+E,AB�%=, �HI#� =?!-E�F"�J$E"�%?�%="�NA,%"E�O,ABE?J�P,K,-�)K,$%,?A�)!%=?+,%G{�)**-,C$%,?A �$AE�P"+%,>,C$%,?Aj"C%,?A{�j$>"%G�|"B!-$%,?A�}+?!*{�)K,$%,?A��?! "{�}$%@,Cd�),+*?+%�j?!%={�~" %�j! "s{�|�k�(�|I=?A"&��tt�L(M��.z'�uq'�tz���Q$s&���tt�L(M��.z'�uq'zz'
� ������������� �������������������������������������������� !!"#�$%&#'�()�*+&,-#.�(/0/� 1�%++,.2%1+#�34&5�6.&4+7#�((809�,:�&5#�64.�;%<4=%&4,1�*.2#.�(//>�%!�%?#12#2�&5#�:,77,341=�%+&4,1�.#@"4.#2�-A�&54!�B%12%&,.A�C#.?4&�$4.#+&4<#�8BC$9�4!�?%12%&,.A�:,.�%DD74+%-7#�%4.+.%:&�.#=4!&#.#2�41�&5#�E14�F41=2,?�,D#.%&41=�,1�%�EF�G66�C#.?4&�&,�H7AI���������� ����JK �LJM ��N �LM ON�ML�PQ:,74%&4,1�G,..,!4,1�RD74&!�67"?414"?�H7A41=�R&."&�P12!I�L�ST�U����VV��U�S������� W5."!&#.�WX//Y�WZ//�%12�WRW�!#.4#!�?4+.,74=5&�%4.+.%:&�34&5�%7"?414"?�%77,A�:7A41=�!&."&�#12!I� ��[���� G,..,!4,1�!D74&&41=�41�&54!�D.4?%.A�!&."+&".#�?%A�3#%\#1�&5#�D%.&�!"::4+4#1&7A�&5%&�4&�?%A�.#!"7&�41�&5#�7,!!�,:�%�341=�%12�+,1!#@"#1&�7,!!�,:�&5#�%4.+.%:&I��W54!�BC$�5%!�-##1�.#<4!#2�41�&5#�74=5&�,:�&5#�&AD#�2#!4=1�,.=%14!%&4,1]!�41<#!&4=%&4,1!Y�&,�%DD7A�+,..,!4,1�D.,&#+&4,1�%12�41+.#%!#�D#.4,2�-#&3##1�41!D#+&4,1!I�������V����U��� #:,.#�:".&5#.�:74=5&�8%!�.#@"4.#2�-A�&5#�,.4=41%7�BC$9Y�+%..A�,"&�&5#�41!D#+&4,1�+%77#2�"D�41�W5."!&#.�64.�R#.<4+#!�R#.<4+#�"77#&41�W6R_R �0Z� !!"#�(�8,.�7%&#.�%DD.,<#2�.#<4!4,19I��� :�%1A�+.%+\�4!�:,"12�.#D7%+#�&5#�D%.&!�34&5�!,"12�:4&&41=!I����� :�+,?D74%1+#�5%!�-##1�%+54#<#2�34&541�&5#�7%!&�0/�:7A41=�5,".!�41�%++,.2%1+#�34&5�4!!"#�0�,:�&54!�BC$_R Y�&5#�.#!"7&!�.#?%41�<%742�:,.�&5#�.#?%412#.�,:�&5%&�0/�5,".!I� 1!D#+&4,1�?%A�-#�+%..4#2�,"&�-A�&5#�D47,&_,31#.I��G%..A�,"&�:".&5#.�41!D#+&4,1!�#<#.A�0//�5,".!�_X�?,1&5!�354+5#<#.�4!�!,,1#.I����#D7%+#?#1&�,:�&5#�!&."&�#12!�34&5�!&##7�#12�:4&&41=!�&#.?41%&#!�&5#�1##2�:,.�.#D#%&�41!D#+&4,1I���M�[����U��V����U��a�������[������[���U����������������U��b�����S��cd�e�;,<#?-#.�(/0/�Mbb�U�����������0I�W54!�BC$�3%!�1,&�D"-74!5#2�:,.�+,1!"7&%&4,1I���(I�P1@"4.4#!�.#=%.241=�&54!�BC$�!5,"72�-#�.#:#..#2�&,�64.+.%:&�G#.&4:4+%&4,1�$#D%.&?#1&Y�G4<47�6<4%&4,1�����6"&5,.4&AY�R%:#&A�#="7%&4,1�f.,"DY�6<4%&4,1�g,"!#Y�f%&34+\�64.D,.&�R,"&5Y�h#!&�R"!!#QY�gX�/i Y�����E14�F41=2,?I�����W#7'�jee�8/90(>Z�klZl(X���H%Q'�jee�8/90(>Z�klZ>lX��P?%47'�2#D%.&?#1&I+#.&4:4+%&4,1m+%%I+,I"\���