travel trailer owner’s manual - jayco, inc · travel trailer owner’s manual model year 2008

www.jayco.com

Travel TrailerOwner’s Manual

Model Year 2008

� WARNING: Read all instructions in this manual and componentmanufacturer supplied information before using your RV.

This manual has been provided by Jayco, Inc. for the sole purpose of providing instructionsconcerning the operation and maintenance of this vehicle and its components. Nothing inthis manual creates any warranty, either expressed or implied. The only warranty offered byJayco, Inc. is as set forth in the limited warranty applicable to this vehicle.

The owner’s failure to provide required service and/or maintenance could result in the lossof warranty. The owner should review Jayco’s limited warranty and the limited warrantiesthat apply to specific components that are offered with this vehicle.

Instructions are included in the manual for operating various components which areoptional on some vehicles. In addition, the owner should refer to individual manufacturer’soperating instructions contained in the owner’s packet.

©2007 Jayco, Inc. LITHO USA 01/08**08-1 Part #0500695.2008

TABLE OF CONTENTS

I

WARRANTY & SERVICE ABOUT THIS MANUAL .................................1 CHANGE OF ADDRESS/OWNERSHIP FORM ..5 CUSTOMER RELATIONS..............................3 CUSTOMER RESPONSIBILITY ......................2 DEALER RESPONSIBILITY ...........................2 JAYCO CUSTOMER FIRST EMERGENCY

ROADSIDE ASSISTANCE ..........................6 JAYPLUS™ EXTENDED SERVICE

CONTRACT .............................................6 MANUFACTURING PROCESS .......................2 OBTAINING EMERGENCY WARRANTY

REPAIR...................................................6 OBTAINING SERVICE AT JAYCO ..................7 OBTAINING SERVICE FOR SEPARATELY

WARRANTED ITEMS.................................7 REPLACEMENT PARTS ...............................7 REPORTING SAFETY DEFECTS ...................1 SAFETY ALERTS ........................................1 SUGGESTIONS FOR OBTAINING SERVICE ....3 THE GOODIE BAG ......................................1 THE JAYCO TRAVEL CLUB ..........................4 TOWABLE LIMITED WARRANTY ...................8 UPDATE YOUR CONTACT INFORMATION......4

OCCUPANT SAFETY

CARBON MONOXIDE ALARM .....................14 EMERGENCY EGRESS WINDOW................12 EMERGENCY WEATHER PLANNING ...........11 FIRE EXTINGUISHER.................................13 FIRE SAFETY ...........................................12 FUEL SAFETY ..........................................17 PROPANE ALARM.....................................16 SMOKE ALARM.........................................13

PRE-TRAVEL INFORMATION

FIRST SHORT TRIP...................................24 HITCH (CUSTOMER SUPPLIED) .................21 HITCH HEIGHT & HITCH BALL ...................21 LOADING YOUR RV..................................23 RV BRAKE SYSTEM .................................22 SWAY CONTROL (CUSTOMER SUPPLIED) ..22 TOW VEHICLE ..........................................19 VEHICLE IDENTIFICATION NUMBER (VIN)

EXPLAINED ...........................................19 VEHICLE LABELS......................................19 WEIGHING YOUR TOW VEHICLE & RV.......23 WEIGHT DISTRIBUTING SYSTEM

(CUSTOMER SUPPLIED).........................22 WEIGHT LABELS ......................................20

TOWING & HANDLING BREAKAWAY SWITCH...............................28 DRIVING & ALCOHOL................................28 EMERGENCY STOPPING ...........................32 EMERGENCY TOWING ..............................33 FIFTH WHEEL HITCHING PROCEDURES.....30 FIFTH WHEEL LANDING GEAR ..................30 RV DRIVING SCHOOLS & SEMINARS.........28 SAFETY CHAINS .......................................28 STABILIZER JACKS ...................................29 TOWING ..................................................31 TRAVEL TRAILER HITCHING PROCEDURES 30 WIRE HARNESS/CONNECTOR PLUG .........29

RV TIRES

CHANGING THE TIRE................................36 SPARE TIRE CARRIER (IF SO EQUIPPED) ..36 VINYL TIRE COVER (IF SO EQUIPPED) ......35 WHEEL LUGS...........................................36

ELECTRICAL SYSTEM - 30 AMP 120-VOLT AC SYSTEM.............................39 120-VOLT CIRCUIT BREAKERS..................40 12-VOLT DC OUTLET (IF SO EQUIPPED) ...44 12-VOLT DC SYSTEM...............................42 12-VOLT FUSE PANEL ..............................43 30 AMP POWER CORD .............................40 AUXILIARY BATTERY (CUSTOMER

SUPPLIED)............................................42 BATTERY ISOLATOR FOR YOUR TOW

VEHICLE (CUSTOMER SUPPLIED)...........43 CALCULATING ELECTRICAL LOAD .............42 CONVERTER............................................41 ELECTRICAL SYSTEM PRECAUTIONS ........39 GFCI RECEPTACLE OUTLET ....................41 IN CASE OF AN ELECTRICAL FIRE ............39

PLUMBING SYSTEM

12-VOLT WATER PUMP & SWITCH (IF SO EQUIPPED).................................47

BATHROOM SHOWER OR TUB ..................49 BLACK & GREY TANK DRAINS ..................54 BLACK/GREY WATER HOLDING TANKS .....53 BLACK/GREY WATER SYSTEM

(IF SO EQUIPPED).................................53 DRAINING THE FRESH WATER SYSTEM ....50 FAUCETS.................................................49 FRESH WATER CONNECTIONS .................46 FRESH WATER HOLDING .........................46 MONITOR PANEL......................................45 OUTSIDE SHOWER (IF SO EQUIPPED).......49

TABLE OF CONTENTS

II

PLUMBING SYSTEM, CONT. SANITIZING THE PLUMBING SYSTEM.........51 THE FRESH WATER SYSTEM ....................45 TOILET ....................................................54 WATER HEATER ......................................47 WATER PRESSURE REGULATOR

(CUSTOMER SUPPLIED) ........................47 WATER PURIFICATION SYSTEM

(IF SO EQUIPPED).................................50 WINTERIZING THE PLUMBING SYSTEM......52

PROPANE SYSTEM

CALCULATING PROPANE USAGE...............63 DOT PROPANE CYLINDER........................58 HOSES, PIPES, TUBES & FITTINGS ...........62 HOW TO LEAK TEST THE PROPANE

SYSTEM ...............................................58 INSTALLING PROPANE CYLINDER(S) .........60 PROPANE REGULATOR.............................62 PROPANE SAFETY PRECAUTIONS.............57 TRAVELING WITH PROPANE .....................63 USING THE PROPANE SYSTEM .................62

SLIDEOUT SYSTEMS

OPERATING THE SLIDEOUT ......................65 TRANSIT BARS (IF SO EQUIPPED).............65 TROUBLESHOOTING THE SLIDEOUT..........66

CAMPING & OPERATING AIR CONDITIONER (IF SO EQUIPPED)........74 ATTIC FAN (IF SO EQUIPPED) ...................74 BBQ GRILL (IF SO EQUIPPED)..................73 BOOTH DINETTE (IF SO EQUIPPED) ..........69 COLD WEATHER USAGE...........................67 CONDENSATION.......................................68 COOKING WITH PROPANE........................71 DEPARTING CAMP CHECKLIST..................75 DUCTING & RETURN AIR ..........................74 ENTRANCE DOOR WITH SCREEN DOOR....69 EXTENDED DRY CAMPING ........................67 FURNACE (IF SO EQUIPPED) ....................74 HIDE-A-BED (IF SO EQUIPPED) ................69 IN CASE OF A GREASE FIRE ....................72 J-STEEL™ SOFA (IF SO EQUIPPED) .........69 KEYS.......................................................69 KITCHEN STOVE, RANGE OR OVEN

(IF SO EQUIPPED).................................72 MICROWAVE (IF SO EQUIPPED) ................71 PANTRY (IF SO EQUIPPED).......................72 PATIO AWNING (IF SO EQUIPPED) ............73 REFRIGERATOR .......................................71 SETTING UP YOUR CAMPSITE ..................68

TELEPHONE JACK (IF SO EQUIPPED) ........70 THERMOSTAT ..........................................74 TV ANTENNA & CABLE TV .......................70 TV POWER SUPPLY .................................70

STORAGE & MAINTENANCE ABS PLASTIC ..........................................78 CABINETRY & TABLES..............................79 CLEANING THE EXTERIOR........................80 CLEANING THE INTERIOR .........................77 COUNTERTOPS........................................79 DÉCOR ITEMS..........................................78 DOORS & LOCKS .....................................82 EXTERIOR ROOF & SIDEWALL VENTS .......82 E-Z LUBE AXLE .......................................82 FLOORING ...............................................79 FORMALDEHYDE......................................77 FURNITURE UPHOLSTERY ........................78 HARDWARE & SINK OR SHOWER

FIXTURES.............................................78 MAINTENANCE CHECKLIST .......................85 MAXISTOR™ STORAGE (IF SO

EQUIPPED) ...........................................82 PANELING ...............................................79 REAR BUMPER ........................................83 REPLACING LIGHT BULBS.........................80 ROOF LADDER (IF SO EQUIPPED).............83 RUBBER ROOF ........................................83 SEALANTS...............................................83 STORAGE CHECKLIST ..............................85 TRAILER FRAME ......................................82 WINDOWS ...............................................82

SPECIFICATIONS & GLOSSARY APPROXIMATE ELECTRICAL LOAD RATING 92 CIRCUIT BREAKERS .................................91 DC FUSE PANEL LAYOUT.........................91 GLOSSARY OF TERMS .............................93 OEM LIST ...............................................89 OEM WHEEL LUG TORQUE CHART ..........90 PROPANE CONSUMPTION CHART .............91

ADDENDUMS ..............................................97

WARRANTY & SERVICE

Congratulations! Thank you for selecting aJayco RV. We are excited to welcome you toour growing RV family. Jayco is the largestprivately held manufacturer of recreationvehicles in the world. We are committed tobeing the most respected name in RVs. Weinvite you to drop by our Visitors Centerlocated in Middlebury, Indiana. To book agroup tour or check our scheduled factory tourtimes (free admission, closed holidays) please call 1-800-RV-JAYCO.

ABOUT THIS MANUALThis manual is a guide to the operation andmaintenance of your RV. Jayco RVs areavailable in several sizes and models, soaccessories and components may differ.Some equipment described in this manualmay not apply to your RV. If you find thecomponents vary significantly from what isdescribed, contact your dealer to ensure youhave the correct information. Nothing in thismanual creates any warranty, eitherexpressed or implied, nor does it cover everypossible detail of equipment, standard oroption, installed on or in your RV.

Information, illustrations and specifications inthis manual reflect the most current availableat the time of publication approval, are subjectto change and not intended to indicate actualsize.

THE GOODIE BAGThe Goodie Bag contains original equipmentmanufacturer (OEM) operator manuals,warranty cards and/or registrations. It isimportant you complete and mail the warrantycards and registrations within the prescribedtime limits to avoid loss of warranty coverage.This manual and the Goodie Bag should beconsidered a permanent part of the RV. If theRV is sold, they should remain with the RV forthe next owner.

SAFETY ALERTSYour safety, and the safety of others, is veryimportant. To help you make informeddecisions, we have provided operating

procedures and other information on safetylabels affixed to your RV and in this manual.Please call your dealer or Jayco CustomerService if you are unsure how to proceed.Always use the appropriate safety gear whenservicing or maintaining your RV.

This is the safety alert symbol. It isused to alert you to potentialpersonal injury hazards. Obey all

safety messages that follow this symbol toavoid possible injury or death.

REPORTING SAFETY DEFECTS

In the United StatesIf you believe that your RV has an allegeddefect that could cause a crash or cause injuryor death, you should immediately inform theNational Highway Traffic Safety Administration (NHTSA) and Jayco.

1

SECTION 1WARRANTY & SERVICE

DANGERThis indicates an imminently hazardoussituation which, if not avoided, will result indeath or serious injury.

WARNINGThis indicates a potentially hazardoussituation which, if not avoided, will result indeath or serious injury.

CAUTIONThis indicates a potentially hazardoussituation which, if not avoided, will result inminor or moderate injury.

CAUTIONThis indicates a potentially hazardoussituation which, if not avoided, may result in property damage.

If NHTSA receives similar complaints, it mayopen an investigation, and if it finds that asafety defect exists in a group of vehicles itmay order a recall and remedy campaign.However, NHTSA cannot become involved inindividual problems between you, your dealeror Jayco. For additional information, pleaserefer to the NHTSA website atwww.safercar.gov.

To contact NHTSA by phone:Call the Department of Transportation (DOT)Vehicle Safety Hotline at 1-888-327-4236 anda NHTSA representative will record yourcomplaint information (TTY: 1-800-424- 9153or 1-202-484-5238).

To contact NHTSA by mail:U.S. Department of TransportationNational Highway Traffic Safety AdministrationOffice of Defects Investigation NVS-211400 7th Street SWWashington, DC 20590

In CanadaIf you believe your RV has an alleged safetydefect, you should contact Transport Canadaand Jayco. Transport Canada prefers to becalled instead of posted mail or email as itenables their investigators to confirm that yourinformation is correct, and to answer yourquestions accurately. For additionalinformation, please refer to the TransportCanada website at www.tc.gc.ca.

To contact Transport Canada by phone:Call 1-800-333-0510 (or 1-613-993-9851 ifyou are calling from the Ottawa region) andask to speak to a defect investigator.

To contact Transport Canada by mail:Road Safety and Motor VehicleRegulation DirectorateTransport CanadaTower C, Place de Ville330 Sparks StreetOttawa, Ontario K1A 0N5

MANUFACTURING PROCESSJayco recreation vehiclesare manufactured for use as temporary living quarters for recreation, camping andtravel uses, all as defined by the bylaws of the Recreation Vehicle Industry Association (RVIA).

This recreation vehicle isnot intended for use as a

full-time residence or for commercial use.Commercial use means using the RV as abusiness asset such as a mobile office orusing the RV for lease or rental purposes.

Jayco reserves the right to discontinue orchange specifications or design at any timewithout notice and without incurring anyobligation whatsoever. RV's built for sale inCanada may differ to conform to CanadianCodes.

CUSTOMER RESPONSIBILITYIt is important you read and understand theinformation in this manual and your GoodieBag before using your RV.

Familiarize yourself with the applicablewarranties. You are responsible for ensuringthe procedures for obtaining warranty repairare followed properly. It is your responsibilityand obligation to return your RV to your dealerfor warranty service repair.

As the owner of the RV, you are responsible for regular and proper maintenance performed inaccordance with this manual and the OEMmanuals. Regular and proper maintenance will help prevent conditions arising from neglectthat are not covered by warranty.

As with your other personal belongings, it isimportant to protect yourself and others withinsurance coverage. Your insurance agent can assist you in obtaining the appropriateinsurance coverage for personal liability, theft,collision, property damage, etc.

2


MEMBER

TR L

EA

EVE HL W T - R HA TIL FIE F R •

TM

ANSI/NFPA A119.2

RVIA seal

DEALER RESPONSIBILITYAt the time of sale of the new RV, your dealer is expected to:

0 Deliver your RV in the best conditionpossible. Your RV must pass the dealer'sthe pre-delivery inspection (PDI), including all systems tests.

0 Provide orientation of the RV, its systems,components and operation.

0 Request that you read all warrantyinformation and explain any provision notclearly understood.

0 Ensure you receive the Goodie Bag. Yourdealer can assist you in completing theOEM warranty cards or registrations, andlocate any required component model orserial numbers.

0 Complete and return the "WarrantyRegistration and Customer Delivery Form" to Jayco within 10 days of delivery toactivate the applicable warranty coverage.

The Towable Limited Warranty is activatedonly after Jayco receives a signed and dated"Warranty Registration and Customer Delivery Form" from your dealer. If it has been morethan 60 days since the purchase of your newRV and you have not received a confirmationletter from Jayco, please contact JaycoCustomer Service.

SUGGESTIONS FOR OBTAINING SERVICEThe independent dealers authorized to sellJayco RVs are also there to provide serviceafter the sale. We work closely with them in aneffort to keep you satisfied. To help ensureyour dealer provides the level of service youexpect, here are some suggestions we wouldlike to make:

Contact your dealer at once… Do not waituntil you are ready to use your RV. Your dealer may not be able to service it immediatelyand/or the repair may require parts be ordered. The dealer’s service department is busiest onMondays, Fridays and before the holidays.

Prepare for the appointment… If you arehaving warranty work performed, be sure tohave the right papers with you. Take yourwarranty folder and have your vehicleinformation available. Not all the work to beperformed may be covered by the warranty;discuss additional charges with the dealer’sservice management.

Prepare a list… Provide your dealer with awritten list of specific repairs needed. It isimportant that you provide any vehicle repairhistory to the dealer’s service manager. Keepa maintenance log of your RV service history.This can often provide a clue to the currentissue.

Be reasonable with your requests… If youleave a list with several items and you needyour RV returned back by a specific time,discuss the situation with the dealer’s servicemanagement and list your items in order ofpriority. This may include making a secondappointment for work not completed or partsthat the dealer may need to order.

Don’t expect to look over the technician’sshoulder… Please do not be offended if youare told you cannot watch the work beingdone. Some insurance requirements forbidadmission of customers to the service area.

Inspect the work performed… Finally, check out the service or repair job when youpick up your RV. Notify the dealer’s servicemanagement immediately of anydissatisfaction. If you cannot return your RVimmediately for repair, make an appointmentas soon as possible.

Please be aware that all repair businessesrequire notification of any issues with theirrepairs within a specified time limit. Make sureyou are familiar with your dealer or RV repaircenter's repair policies.

CUSTOMER RELATIONSJayco has empowered its dealers to makewarranty and repair decisions. If a specialcircumstance occurs that requires information

3


from Jayco, we have asked your dealer’sservice management to make the contact onyour behalf. This is why you should alwaystalk to your dealer’s service managementfirst.

Most issues arise from misunderstandingsabout warranty or service needs. Werecognize that, on some occasions, you willnot be totally satisfied with a dealer’s decisionor actions. If this is the case, you should writeor call Jayco Customer Service. Our hours areMonday – Friday, 8:00 a.m. – 5:00 p.m. EST(closed holidays).

Please provide the following information:

0 Your name, location and phone number.

0 Your RV’s 17-digit vehicle identificationnumber (VIN).

0 Your date of purchase.

0 The name of the selling dealer.

# If different from above, the contactinformation for the RV repair facilityyou are contacting Jayco to discuss.

0 A detailed description of the concern.

0 If applicable, the component description,serial number and model number.

Mailing address Shipping addressJayco, Inc. Jayco, Inc.Customer Service Customer ServiceP.O. Box 460 100 Bontrager Drive903 S. Main Street Bldg 42 Door 4220Middlebury IN 46540 Middlebury IN 46540

Phone (toll free) (800) 283-8267Phone (local) (574) 825-0608Fax (toll free) (866) 709-9139

Brochure request [email protected] email [email protected] email [email protected] www.jayco.com

An important note about alterations and warranties Installations or alterations to the originalequipment vehicle as distributed by Jayco arenot covered by the Towable Limited Warranty.The special body company, assembler,

equipment installer or upfitter is solelyresponsible for warranties on the body orequipment and any alterations (or any effect of the alterations) to any of the parts,components, systems or assemblies installedby Jayco. Jayco is not responsible for thesafety or quality of design features, materialsor workmanship of any alterations by suchsuppliers.

UPDATE YOUR CONTACTINFORMATIONHelp keep your contact information current sothat, in the event of a recall or customernotification letter, you are notified. Please copy and mail your completed "Change of Addressor Ownership, Stolen, Totaled or Destroyed"form to Jayco.

If you purchased your RV as "used," includeproof of ownership (i.e., a copy of your bill ofsale, insurance policy, etc.).

THE JAYCO TRAVEL CLUBAll owners of Jayco RVs areeligible for membership in the Jayco Travel Club. The clubpromotes family camping and the active use of your RV with others who have similarinterests in the RV lifestyle.

One "International Rally" is held each year invarious locations around the United Statesand Canada. In addition, the club offers avariety of local and regional activitiesthroughout the year.

By belonging to the Jayco Travel Club, you willfind new ways to enjoy your RV and makefriends all across the country. For moreinformation please visit www.jaycorvclub.comor call 1-800-262-5178.

4


CHANGE OF ADDRESS/OWNERSHIP FORM

5


JAYPLUS EXTENDED SERVICE CONTRACT

Don't letunexpected repaircosts keep youfrom traveling

toward your dreams.

Protect yourself with a JayPlus™ ExtendedService Agreement. For more information,contact your dealer or call 1-800-527-3426.

Your dealer can help you obtain a JayPlus™insurance quote from GMAC Insurance or call1-877-484-2261 (Savings Code: GL 2A).

JAYCO CUSTOMER FIRSTEMERGENCY ROADSIDE ASSISTANCEJayco has teamed up with Coach-Net to offer24/7 motorist assistance. We are offering thisfree of charge for the first year of ownership(certain restrictions apply*). You may continueyour emergency roadside assistance benefitsin the following years by contacting Coach-Net to discuss terms and rates for thisindependently continued coverage.

For details on accessing your emergencyroadside assistance benefits, please refer toyour Member Benefit Guide that is sent out 6-8 weeks after your completed "WarrantyRegistration and Customer Delivery Form" isreceived by Jayco, or contact Coach-Net(www.coach-net.com) at 1-877-801-0333.

*To qualify for coverage, your RV must beeligible as set forth under the terms of theTowable Limited Warranty.

OBTAININGEMERGENCY WARRANTY REPAIRA roadside emergency can happen at anytime, whether your RV is new or old. If you aretraveling, using the following guidelines canhelp get you back on the road faster.

1. Call 1-800-RV-JAYCO or use our websitedealer locator to find an authorized Jaycodealer in your area. Contact them for an

appointment; they will handle all warrantyrepair billing and returned parts for you.

2. If you cannot locate an authorized Jaycodealer near you, ask the campground stafffor referrals or check the local telephoneyellow pages. Or contact Jayco CustomerService or your selling dealer forassistance in locating a repair facility.

a. Contact the RV repair facility to discussyour situation and make anappointment. Ask how their billing willbe handled. They may choose to billJayco directly; otherwise, you areexpected to pay them.

b. Have the RV repair facility inspect yourRV. Either they or you must call JaycoCustomer Service to discuss applicable warranty coverage prior to any repairwork being performed.

c. Jayco Customer Service will issue anauthorization number upon warrantyrepair approval and advise if anyoriginal parts need to be returned.

d. Once Jayco Customer Service hasissued an authorization number, the RV repair facility may begin actual repair toyour RV.

e. Inspect the completed repair workthoroughly. If you are not satisfied,communicate that immediately to theRV repair facility management. Makesure you are satisfied with the repairbefore you pay or leave the premises.

f. For reimbursement, either you or theRV repair facility must send a copy ofyour itemized repair bill and allrequested return parts by UPS (regularground, freight pre-paid) within 60 daysof the completed repair date.

To expedite processing your warrantyclaim, include your name, address, phonenumber, RV 17-digit VIN and authorizationnumber. If returning parts, include a copyof your return freight bill.

6


Obtaining weekend or after business hours repair assistanceIf an authorized Jayco dealer is not locatednearby, contact your selling dealer forassistance. If your dealer is closed, check withthe campground staff or telephone yellowpages for an RV repair facility. Have the itemrepaired and contact Jayco Customer Serviceimmediately the following business day.

Failure to contact Jayco Customer Service,unauthorized or improper warranty repairs, orfailure to return requested original parts mayresult in loss of reimbursements and/or loss ofwarranty.

OBTAINING SERVICE FORSEPARATELY WARRANTED ITEMSYour selling dealer is responsible for servicingyour RV before delivery, and has an interest inyour continued satisfaction. We recommendyour dealer perform all inspection, warrantyand maintenance services. Some dealers may be authorized service centers for those OEMswhose products are warranted separately andexcluded from the Towable LimitedWarranty.

OBTAINING SERVICE AT JAYCOShould your RV be in need of service, and your dealer recommend that the repairs be made atthe Jayco Factory Service Center, your RVmay be returned to us with the followingguidelines*:

0 You or your dealer must make a confirmed appointment a minimum of 60 days prior to dropping off your RV at the Jayco FactoryService Center.

0 The holding tanks must be emptied andrinsed. We have a dumping stationavailable for customer use.

0 The propane system and all electricalsystems must be shut down and turned off. We are not responsible for dischargedbatteries or propane tanks.

0 During the appropriate season, pleaseensure your RV is winterized.

0 Unless prior approval has been obtainedfrom the Jayco Factory Service Center, allpersonal items must be removed from thearea where you are requesting servicerepair and the refrigerator emptied. We are not responsible for loss of food items.

0 You are responsible for all transportationcosts. You may need to arrange foralternative accommodations for sometypes of repairs. Please be preparedaccordingly.

*Jayco Customer Service occasionally utilizeslocal independent repair facilities. Your RVmay be referred to or repaired by one of theselocal repair facilities.

REPLACEMENT PARTSParts for Jayco RVs are distributed exclusively by authorized Jayco dealers. Jayco does notsell parts retail direct or to non-authorizeddealers. If an original part is no longeravailable, Jayco will try to provide anappropriate substitute.

7


TOWABLE LIMITED WARRANTY

TOWABLE LIM ITED WAR RANTY

WHAT AND WHO IS COV ERED

The Jayco war ranty cov ers this rec re ational ve hi cle ("RV"), when used only for its in tended pur pose of rec re ational travel andcamp ing, for two (2) years. It cov ers RV's sold in the United States, U.S. Ter ri to ries and Can ada, only. The war ranty pe riod be ginson the date that the RV is de liv ered to the first re tail pur chaser by an in de pend ent, au tho rized dealer of Jayco, or, if the dealer placesthe ve hi cle in ser vice prior to re tail sale, on the date the RV is first placed in such ser vice. In the event that a sub stan tial de fect in ma -te rial or work man ship, at trib ut able to Jayco, is found to ex ist dur ing the war ranty pe riod, it will be re paired or re placed, at Jayco'sop tion, with out charge to the RV owner, in ac cor dance with the terms, con di tions and lim i ta tions of this lim ited war ranty.

This lim ited war ranty ap plies to the first con sumer pur chaser only. You may con tact an in de pend ent, au tho rized dealer for de tails. All rights and lim i ta tions within this war ranty are ap pli ca ble to the orig i nal owner of the RV only. .

Jayco's ob li ga tion to re pair or re place de fec tive ma te ri als or work man ship is the sole ob li ga tion of Jayco un der this lim ited war -ranty. Jayco re serves the right to use new or remanufactured parts of sim i lar qual ity to com plete any work, and to make parts and de -sign changes from time to time with out no tice to any one. Jayco re serves the right to make changes in the de sign or ma te rial of itsprod ucts with out in cur ring any ob li ga tion to in cor po rate such changes in any prod uct pre vi ously man u fac tured. Jayco makes nowar ranty as to the fu ture per for mance of this RV, and this lim ited war ranty is not in tended to ex tend to the fu ture per for mance of this RV, or any of its ma te ri als, com po nents or parts. In ad di tion, the RV owner's ob li ga tion to no tify Jayco, or one of its in de pend ent,au tho rized deal ers, of a claimed de fect does not mod ify any ob li ga tion placed on the RV owner to con tact Jayco di rectly when at -tempt ing to pur sue rem e dies un der state or fed eral law.

LIM I TA TIONS, EX CLU SIONS AND DIS CLAIMER OF IM PLIED WAR RAN TIES

ANY IM PLIED WAR RANTY THAT IS FOUND TO ARISE BY WAY OF STATE OR FED ERAL LAW, IN CLUD ING ANYIM PLIED WAR RANTY OF MER CHANT ABIL ITY OR ANY IM PLIED WAR RANTY OF FIT NESS, IS LIM ITED IN DU RA -TION TO THE DU RA TION SET FORTH IN THIS LIM ITED WAR RANTY AND IS LIM ITED IN SCOPE OF COV ER AGE TO THE SCOPE OF COV ER AGE OF THIS LIM ITED WAR RANTY. Jayco makes no war ranty of any na ture be yond that con tainedin this lim ited war ranty. Jayco does not au tho rize any per son to cre ate any other ob li ga tion or li a bil ity for it re gard ing this RV, andJayco is not re spon si ble for any rep re sen ta tion, prom ise or war ranty made by any dealer or other per son be yond what is ex presslystated in this lim ited war ranty, and no one has the au thor ity to en large, amend or mod ify this lim ited war ranty. Any sell ing or ser vic -ing dealer is not Jayco's agent, but an in de pend ent en tity.

JAYCO SHALL NOT BE LI A BLE FOR ANY IN CI DEN TAL OR CON SE QUEN TIAL DAM AGES THAT MAY RE SULTFROM BREACH OF THIS LIM ITED WAR RANTY OR ANY IM PLIED WAR RANTY. THIS EX CLU SION OF CON SE -QUEN TIAL AND IN CI DEN TAL DAM AGES SHALL BE IN DE PEND ENT OF ANY FAIL URE OF THE ES SEN TIAL PUR -POSE OF ANY WAR RANTY, AND THIS EX CLU SION SHALL SUR VIVE ANY DE TER MI NA TION THAT THIS LIM ITEDWAR RANTY OR ANY IM PLIED WAR RANTY HAS FAILED OF ITS ES SEN TIAL PUR POSE.

Some states do not al low lim i ta tions on how long an im plied war ranty lasts, or the ex clu sion or lim i ta tion of in ci den tal or con se -quen tial dam ages, so the above lim i ta tions or ex clu sions may not ap ply to you.

2008 Model Year – Towable Page 1 of 3

8


HOW TO GET SER VICE

To ob tain war ranty ser vice the owner must do all of the fol low ing:

1. No tify an in de pend ent, au tho rized dealer of Jayco, or Jayco, of the sub stan tial de fect in ma te rial or work man ship at trib ut ableto Jayco, within the war ranty cov er age pe riod des ig nated above;

2. Pro vide the no ti fi ca tion men tioned in (1), above, within ten (10) days of when the owner dis cov ered, or should have dis cov -ered, the sub stan tial de fect in ma te rial or work man ship at trib ut able to Jayco;

3. Promptly sched ule an ap point ment with and take the RV to an in de pend ent, au tho rized dealer of Jayco, or Jayco, for re pairs;and

4. Pays any freight or trans por ta tion costs, im port du ties, fees and all in ci den tal ex penses as so ci ated with ob tain ing war ranty ser -vice.

For war ranty ser vice, sim ply con tact one of Jayco's in de pend ent, au tho rized ser vice cen ters for an ap point ment and then de liveryour RV to the ser vice cen ter on the spec i fied ap point ment date. If you need as sis tance you may con tact Jayco, at P.O. Box 460,Middlebury, In di ana 46540, Attn: Cus tomer Ser vice, (574) 825-0608, (800) 283-8267 or www.jayco.com.

NOTE: Jayco does not con trol the sched ul ing of ser vice work at the in de pend ent, au tho rized deal er ships. You may en coun ter somede lay in sched ul ing or com ple tion of work. Also, you must no tify the sell ing dealer at time of de liv ery to have work per formed onany de fect that oc curred at the fac tory dur ing man u fac ture at no cost to you as pro vided by this lim ited war ranty. (See be low un derWHAT IS NOT COV ERED).

If two (2) or more ser vice at tempts have been made to cor rect any cov ered de fect that you be lieve im pairs the value, use or safety ofthe RV, or if it has taken lon ger than thirty (30) days for those types of re pairs to be com pleted, you must, to the ex tent per mit ted bylaw, no tify Jayco di rectly, in writ ing, at the above ad dress, of the un suc cess ful re pair(s) of the al leged de fect(s) so that Jayco can be -come di rectly in volved in mak ing sure that you are pro vided ser vice pur su ant to the terms of this lim ited war ranty.

WHAT IS NOT COV ERED

By way of ex am ple only, this Lim ited War ranty does not cover any of the fol low ing: de fects in ma te ri als, com po nents or parts of theRV not at trib ut able to Jayco, items that are added or changed af ter the RV leaves the pos ses sion of Jayco; ad di tional equip ment orac ces so ries in stalled at any deal er ship, or other place of busi ness, or by any other party, other than Jayco; any RV used for rental orother com mer cial pur poses (Note: It shall be con cluded that the RV has been used for com mer cial and/or busi ness pur poses if theRV owner or user files a tax form claim ing any busi ness or com mer cial tax ben e fit re lated to the RV, or if the RV is pur chased in abusi ness name); any RV sold out side the United States, U.S. Ter ri to ries or Can ada; any RV not used solely for rec re ational traveland camp ing; nor mal wear, tear or us age, such as tears, punc tures, soil ing, mil dew, fad ing, or dis col or ation of ex te rior plas tic or fi -ber glass, or soft goods, such as up hol stery, drapes, car pet, vi nyl, screens, cush ions, mat tresses and fab rics; the ef fects of con den sa -tion or mois ture from con den sa tion in side the RV; mold or any dam age caused by mold to the in side or out side of the RV;im per fec tions that do not af fect the suit abil ity of the RV for its in tended pur pose of rec re ational use or items that are work ing as de -signed but that you are un happy with; prob lems, in clud ing wa ter leaks, re lated to mis use, mis han dling, ne glect or abuse, in clud ingfail ure to main tain the RV in ac cor dance with the owner's man ual, or other rou tine main te nance such as in spec tions, lu bri cat ing, ad -just ments, tight en ing of screws, tight en ing of lug nuts, seal ing, ro tat ing tires; dam age due to ac ci dent, whether or not fore see able,in clud ing any acts of weather or dam age or cor ro sion due to the en vi ron ment, theft, van dal ism, fire, or other in ter ven ing acts not at -trib ut able to Jayco; dam age re sult ing from tire wear or tire fail ure; de fac ing, scratches, dents, chips on any sur face or fab ric of theRV; dam age caused by off road use, over load ing the RV or al ter ation of the RV, or any of its com po nents or parts; wheel align mentor ad just ments to ax les when caused by im proper main te nance, load ing or dam age from road haz ards, in clud ing off road travel,wheel dam age or bal anc ing or dam age from tire fail ures. Also, any costs as so ci ated with ob tain ing ser vice, in clud ing by way of ex -am ple, travel costs, are spe cif i cally ex cluded from the cov er age of this warranty.

In ad di tion, this lim ited war ranty does not cover any ma te rial, com po nent or part of the RV that is war ranted by an other en tity, in -clud ing, by way of ex am ple, han dling, brak ing, wheel bal ance, muf fler, tires, tubes, bat ter ies, gauges, gen er a tor, jacks, in verter, mi -cro wave, tele vi sion, VCR, CD player, tape player, ra dio, speak ers, tele vi sion, re frig er a tor, range, wa ter heater, wa ter pump, stove,car bon mon ox ide de tec tor, smoke de tec tor, fur nace or any air con di tioner. (Note: The writ ten war ranty pro vided by the man u fac -turer of the com po nent part is the di rect re spon si bil ity of that man u fac turer).

De fects and/or dam age to in te rior and ex te rior sur faces, trim, up hol stery and other ap pear ance items may oc cur at the fac tory. These items are usu ally de tected and cor rected at the fac tory or by the sell ing dealer prior to de liv ery to the re tail cus tomer. Youmust in spect your RV for this type of dam age when you take de liv ery. If you find any such de fect or dam age you must no tify thesell ing dealer at time of de liv ery to have these items cov ered by this lim ited war ranty and to have work per formed on the items at nocost to you as pro vided by this lim ited war ranty.


9


EVENTS DIS CHARG ING JAYCO FROM OB LI GA TION UN DER WAR RANTY

Cer tain things com pletely dis charge Jayco from any ob li ga tion un der this war ranty and void it. By way of ex am ple, the fol low ingshall dis charge Jayco from any ex press or im plied war ranty ob li ga tion to re pair or re place any de fect that re sults from: any rental orother com mer cial use or pur chase of the RV (as de fined in this war ranty), any RV sold out side the United States, U.S. Ter ri to ries orCan ada, any de fect in a sep a rately man u fac tured com po nent part, owner ne glect or fail ure to pro vide rou tine main te nance (SeeOwner's Man ual), un au tho rized al ter ation, off road use, col li sion or ac ci dent, whether or not fore see able, in clud ing any acts ofweather or dam age or cor ro sion due to the en vi ron ment, theft, van dal ism, fire, ex plo sions, over load ing in ex cess of weight rat ings,and tam per ing with any por tion of the RV.

LE GAL REM E DIES

Any ac tion to en force any por tion of this lim ited war ranty, or any im plied war ranty, shall be com menced within six (6) months af terex pi ra tion of the war ranty cov er age pe riod des ig nated above. Any per for mance of re pairs shall not sus pend any lim i ta tion pe riodfrom ex pir ing. Any per for mance of re pairs af ter the war ranty cov er age pe riod has ex pired, or per for mance of re pairs re gard ing anything ex cluded from cov er age un der this lim ited war ranty shall be con sid ered "good will" re pairs, and they will not al ter the ex pressterms of this lim ited war ranty, or ex tend the war ranty cov er age pe riod or this lim i ta tion pe riod in this para graph. In ad di tion, thiswar ranty is not in tended to ex tend to fu ture per for mance, and noth ing in this war ranty, or any ac tion of Jayco, or any agent of Jayco,shall be in ter preted as an ex ten sion of the war ranty or this lim i ta tion pe riod. Some states do not al low a re duc tion in the stat ute oflim i ta tions, so this re duc tion may not ap ply to you.

WAR RANTY REG IS TRA TIONS:

Your war ranty reg is tra tion re cords should be com pleted and de liv ered to the man u fac tur ers of com po nent parts. The sell ing deal er -ship will as sist you in com plet ing and fill ing out the Jayco prod uct war ranty reg is tra tion form. That form must be re turned to Jaycowithin ten (10) days of your tak ing de liv ery of the RV. Your Jayco war ranty will not be reg is tered un less this war ranty reg is tra tionis com pleted and re ceived by Jayco. Fail ure to file this war ranty reg is tra tion with Jayco will not af fect your rights un der this lim itedwar ranty as long as you can pres ent proof of pur chase, but it can cause de lays in ob tain ing the ben e fits of this lim ited war ranty, and it may in hibit any ser vic ing fa cil ity's abil ity to pro vide proper re pairs and/or part re place ment.

CARE AND MAIN TE NANCE

It is the Owner's re spon si bil ity to per form proper care and main te nance of the RV, and to as sure cor rect load dis tri bu tion. For de tails re gard ing this, please see your Jayco owner's man ual and the owner's man u als of other com po nent part man u fac tur ers. These out -line var i ous care and main te nance that is re quired to main tain your RV. Please re view all man u als sup plied with your RV, and con -tact your sell ing deal er ship or sup plier of the com po nent part if you have ques tions. Note: Fail ure to main tain the RV as noted inthose man u als voids this lim ited war ranty, and any dam age to the RV as a re sult of your fail ure to per form such care, is not cov eredby this lim ited war ranty.

THIS WAR RANTY GIVES YOU SPE CIFIC LE GAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS THATVARY FROM STATE TO STATE.

JAYCO, INC.

903 South Main * P.O. Box 460 * Middlebury, IN 46540

Tele phone: 574-825-0608

(800) 283-8267


10


OCCUPANT SAFETY

Camping is a great way to enjoy the outdoorswith your family and friends. By following theproper precautions and planning, you can help insure a safe, enjoyable and trouble-free trip.We encourage you to develop a family safetyplan in case of an emergency or severeweather condition, and practice it with yourentire family, especially children.

0 Ask an out-of-state relative or friend toserve as the "family contact." Make sureeveryone knows the name, address,phone number and email of the contactperson.

0 Draw a floor plan of your RV and find twoways to exit. There should be one way toget out of your RV without opening thedoor.

0 Teach everyone what the RV safety alarmsignals mean and how to be prepared toleave the RV by themselves if necessary.

0 Teach how to check doors and not to openthe them if the doors are hot. Also teacheveryone to stay low to try to avoidbreathing smoke, fumes or gases.

0 In case family members are separatedfrom one another, have a plan for gettingback together. Decide on a meeting placea safe distance from your RV and makesure everyone understands to wait there.

0 Make sure everyone knows where to go tocall the fire department or 911 from outside the RV.

0 Conduct safety drills at least every sixmonths to make sure everyone, includingguests, knows what to do to escape safely. Practice evacuating the RV blindfolded; ina real fire situation, the amount of smokegenerated may make it impossible to see.

0 Consult your local fire department foradditional safety precautions.

Pets may not be allowed into shelters forhealth and space reasons. Prepare anemergency plan for pets that includes at leasta 3-day supply of dry food and a largecontainer of water. The survival of a beloved

pet or valuable livestock will often depend onthe plans that its owner has made in advance.

EMERGENCY WEATHER PLANNINGOne of the more serious conditions you needto take into account when camping is that ofthe weather, which is subject to change withlittle or no warning. Earthquakes, hail,flooding, hurricanes, wintry weather,tornadoes – these and other extreme weatherconditions can threaten your safety anddamage your tow vehicle or RV.

Local radio and TV stations normallybroadcast weather conditions and warnings as they occur. Research other methods oflearning about severe weather conditions andhow to deal with them. You may want toconsider investing in a weather radio. Weather radios offer 24 hour-a-day VHE broadcasts ofweather observations and forecasts directlyfrom the US National Weather Service. Thefrequencies used by the US National Oceanicand Atmospheric Administration (NOAA)weather radio stations are 162.400, 162.425,162.450, 162.475, 162.500, 162.525 or

11

SECTION 2OCCUPANT SAFETY

Familiarize yourself with the followingweather terms:

Warning - Indicates that a particularweather hazard is either imminent or hasbeen reported. A warning indicates theneed to take action to protect life andproperty. Move to a safe locationimmediately. The type of hazard isreflected in the type of warning (i.e.,tornado warning, blizzard warning, etc.).

Watch - Indicates a particular hazard ispossible and that conditions are morefavorable than usual for its occurrence. Awatch is a recommendation for planning,preparation and increased awareness(i.e., to be alert for changing weather,listen for further information and thinkabout what to do if the dangermaterializes).

162.550 megahertz or visit their website atwww.noaa.gov.

Repairing severe weather damageIf your tow vehicle or RV becomes an unluckyvictim of severe weather damage, you willmost likely need repair work. Call yourinsurance company as soon as you can toreport your claim.

Be aware of the heat index if camping duringhot weather. Keep yourself hydrated, and try to stay indoors in an air-conditioned area duringa high heat index warning.

EMERGENCY EGRESS WINDOWThe emergency egress window is designed to allow a quick exit from the RV during anemergency if access to the main entrance door is not available.Practice opening the egresswindow before an emergency occurs, andmake sure all occupants know how to operateit.

When pulling into your campsite, make sureyour egress is not blocked by trees or otherobstacles. Verify the area below the window isover solid ground that can be used as anescape path. Do not remove the following label from your RV:

FIRE SAFETYAt best, a fire in your RV can delay or ruin avacation; at worst, it can mean injury, financialloss, and even death. If a fire starts, executeyour family safety plan. Make sure everyoneknows to stop, drop to the ground and roll back

and forth, shielding their face from the fire withtheir hands, if their clothes catch fire.

Learn and teach safe fire practices. Buildcampfires away from nearby trees or bushes.Maintain at least a three-foot clear area free ofleaves, dry grass, pine needles, etc., aroundgrills, campfires and/or tents. Supervisechildren at all times when campfires areburning or grills are in use. Always have a wayto extinguish the campfire quickly andcompletely. Never leave a fire — even acigarette — burning unattended.

Teach family members how to use the fireextinguisher and replace it as recommended.Do not store combustible materials in closedareas or near a heat source. Do not attempt touse water to put out a grease fire. Water canspread some types of fire and create anelectrocution hazard during an electrical fire.

Always call the Fire Department, no matterhow small the fire. However, be aware that if afire threatens your RV, you should not placethe call to your emergency services frominside the RV. It is better to get out first andplace the call from somewhere else.

More information on fire fighting can be foundat the National Fire Protection Associationwebsite (www.nfpa.org).

If you feel a fire was caused by product failure,contact Jayco Customer Service at1-800-283-8267 for approval before you cleanany debris, enter, move or repair your RV(failure to notify Jayco may result in loss ofcoverage).

12


WARNINGDuring severe weather conditions moveindoors to a place of safety or shelter asdirected by the campground or appropriateauthorities. Avoid trees or power lines thatcould fall on your vehicle. The safest placeduring severe weather conditions is insidea basement or storm shelter, not an RV ortow vehicle.

EXIT0010919

Fig. 2.1 Emergency egress window label

FIRE EXTINGUISHERA portable fire extinguisher can save lives andproperty by putting out a small fire orcontaining it until the fire department arrives;but portable extinguishers have limitations. Itis important to recognize when to leave the RV. Because fire grows and spreads so rapidly, the number one priority is to get out safely. TheUnderwriter Laboratories (UL) classifyhousehold fire extinguishers into four types:

Rating Intended Use

Type AFor use on fires involving combustiblematerials such as wood, cloth and paper.

Type BFor use on flammable liquid fires,including kitchen grease. Never use water on this type of fire!

Type CFor use in fires involving energizedelectrical equipment

TypeABC

Works on all three types of fires listedabove.

The factory-installed dry chemical fireextinguisher, suitable for extinguishing smallfires of the Class B and Class C type, islocated near the entry door.

Operation

Keep your back to a clear exit when you usethe fire extinguisher so you can make an easyescape if the fire cannot be controlled. If theroom fills with smoke, leave immediately.Know when to leave. Fire extinguishers areone element of a fire response plan, but theprimary element is safe escape.

There are different types and sizes of fireextinguishers, but for the most part they all

work the same way. To operate a fireextinguisher, remember the word PASS.

Pull the pin. Hold the extinguisher with thenozzle pointing away from you, and releasethe locking mechanism.

Aim low. Point the extinguisher at the base ofthe fire.

Squeeze the lever slowly and evenly.

Sweep the nozzle from side-to-side until thefire is out.

Disposal

Contact your local fire department, sanitationdepartment or environmental protectiondepartment to find out what your local lawsstipulate before disposing of your used(non-refillable) factory-installed dry chemicalfire extinguisher.

SMOKE ALARMThree of the most common fire safety issuesare smoking in bed, leaving childrenunattended and cleaning with flammablefluids. There is no way to guarantee againstinjury or loss of life in a fire; however, thesmoke alarm is intended to help reduce thoserisks. Individuals with medical problems, orwho are hard of hearing, should consider using warning devices that provide both audible andvisual signals.

Proper use and care of your smoke alarm maysave your life. Smoke alarms can only work ifthey are properly located, installed,operational and maintained and if smoke

13


CAUTIONAvoid inhaling the dry chemical agent in the fire extinguisher. It is not toxic, but maycause skin irritation. In case of contact,flush the affected area with clean, coolwater. If irritation persists, contact aphysician immediately.

reaches them. They are not foolproof. Do notremove the following label from your RV:

OperationThe factory-installed ceiling mounted smokealarm is operational once the 9-volt battery iscorrectly connected. The LED will flash toshow the battery is supplying power to thealarm. When the product of combustion issensed, the smoke alarm sounds a loud alarmthat continues until the air is cleared.

How to testStand at arm’s length from the smoke alarmwhen testing. The alarm horn is loud and maybe harmful to your hearing. The test button willaccurately test all functions. Never use anopen flame from a match or lighter to test thesmoke alarm; you may ignite and set fire to thesmoke alarm and your RV. If the smoke alarmdoes not test properly, replace it immediately.

BatteryThe smoke alarm will not function if the batteryis missing, disconnected, dead, the wrongtype of battery is used or the battery is installed incorrectly. When the battery becomes weak,the smoke alarm will “beep” (the low batterywarning). If the low battery warning sounds,the battery MUST be replaced. Neverdisconnect the battery to silence the smokealarm.

CARBON MONOXIDE ALARM

Carbon monoxide (CO) is an insidious poison.It is a colorless, odorless and tasteless gas.Many cases of reported carbon monoxidepoisoning indicate while victims are awarethey are not well, they become so disorientedthey are unable to save themselves by eitherexiting the RV or calling for assistance. Youngchildren and household pets may be the firstaffected.

The CO alarm is designed to detect the toxiccarbon monoxide fumes that result fromincomplete combustion, such as those emitted from appliances, furnaces, fireplaces and auto exhaust. A CO alarm is NOT A SUBSTITUTEfor other combustible gas, fire or smokealarms.

14


The following symptoms are related tocarbon monoxide poisoning and should bediscussed with all members of thehousehold:

Mild exposure – Slight headache, nausea,vomiting, fatigue (often described as"flu-like" symptoms).

Medium exposure – Throbbing headaches,drowsiness, confusion, fast heart rate.

Extreme exposure – Convulsions,unconsciousness, heart and lung failure.Exposure to carbon monoxide can causebrain damage, death.

WARNINGIf you are in a RV with either a nearby towvehicle engine running or the generator (ifso equipped) running there is a potential for exhaust fumes to filter back into the RV.Avoid inhaling exhaust gases as theycontain carbon monoxide, which is apotentially toxic gas that is colorless andodorless.

TEST SMOKE ALARM OPERATION AFTER VEHICLE HAS BEEN IN STORAGE, BEFORE EACH TRIP, AND AT LEAST ONCE PER WEEK DURING USE.

FAILURE TO COMPLY MAY RESULT IN SERIOUS INJURY.

0173019

WARNING

Fig 2.2 Smoke alarm label

There are hazards against which carbonmonoxide detection may not be effective, such as natural gas leaks or explosions. Individuals with medical problems, or who are hard ofhearing, should consider using warningdevices that provide both audible and visualsignals.

What you should do if the alarm sounds

The CO alarm will automatically sense whenthe level of carbon monoxide in the air reaches dangerous levels. You should stay outside theRV in fresh air until the CO alarm is silenced.When the CO alarm sounds, do not stand tooclose to it. The sound produced by the COalarm is loud because it is designed to wake aperson in an emergency. Prolonged exposureto the CO alarm at a close distance may beharmful to your hearing.

1. Operate the RESET/SILENCE button.

2. Immediately move to fresh air (outdoors orby an open door or window) and executeyour family safety plan.

3. Do not re-enter the premises. If you areunable to exit the premises do not moveaway from the open door or window untilthe emergency service responders havearrived, the premises have been aired outand your CO alarm remains in its normalcondition.

If your CO alarm reactivates within a 24-hourperiod, repeat steps 1-3 and call a qualifiedappliance technician to investigate for sources of carbon monoxide from fuel burningequipment and appliances, and inspect forproper operation of this equipment (ifproblems are identified during this inspection,have the CO alarm replaced immediately).

Note any combustion equipment not inspected by the technician. Make sure that any motorvehicle is not and has not been operating in anattached garage or adjacent to your RV.

BatteriesThe CO alarm will not function if the batteriesare missing, disconnected, dead, the wrongtype of battery is used or the batteries areinstalled incorrectly. When the batteriesbecome weak, the CO alarm will “beep” (thelow battery warning). If the low battery warningsounds, the batteries MUST be replaced.Never disconnect the batteries to silence theCO alarm.

Testing the CO alarmPress and hold the test/reset button on thefront of the CO alarm for several seconds. Ifthe CO alarm does not test properly, replace itimmediately. Do not remove the following label from your RV:

Maintenance

The CO alarm is pre-calibrated at the OEMfactory and requires no maintenance otherthan to clean the outside casing occasionallywith a cloth. Ensure that the holes on the frontof the CO alarm are not blocked with dirt and

15


WARNINGActuation of this alarm may indicate thepresence of carbon monoxide that can KILL YOU. This alarm will only indicate thepresence of carbon monoxide gas at thesensor. Carbon monoxide gas may bepresent in other areas.

WARNINGTest device operation after vehicle has been in storage, before each trip, and at least once per week during use.

AVERTISSEMENTFaire l’essai des appareils utilisés dans les véhicules de plaisance aprèstoute période de remisage, avant chaque voyage et une fois par semainelorsqu’ils sont en cours d’utilisation.

Fig. 2.3 CO alarm testing label

WARNINGIf the CO alarm is not maintained andfunctioning properly according to OEMsupplied instructions, you will not bewarned if carbon monoxide is present in the air. Death or serious illness could resultfrom asphyxiation (inability to breathe) ifcarbon monoxide is present.

dust. DO NOT USE CLEANING AGENTS,BLEACH OR POLISH.

PROPANE ALARM

For your safety protection, a new RV thatcontains a propane gas system with propaneconsuming appliances must have a propaneleak detection device. Because the chemicalcomposition of propane is heavier than air, thepropane alarm is located near the floor of theRV (leaking propane tends to flow to andpocket in low areas). A lit green LED indicateswhen the factory-installed alarm is active.Individuals with medical problems, or who arehard of hearing, should consider usingwarning devices that provide both audible andvisual signals.

This alarm is designed to sense the presenceof propane gas; however, there are othercombustible fumes or vapors that may bedetected by the sensor including (but notlimited to) acetone, alcohol, butane andgasoline. These chemicals can be found incommonly used items such as deodorants,colognes, perfumes, adhesives, lacquer,kerosene, glues, wine, liquor, most cleaningagents and the propellants of aerosol cans.High temperatures can activate glue andadhesive vapors. If you close up your RV on ahot day, the chemicals used in its constructionmay be detected for months after the vehiclewas constructed (see Formaldehyde).

If the alarm sounds1. Turn off all propane gas appliances (i.e.,

stove, water heater, furnace, etc.).

2. Open all windows and roof vents andexecute your family safety plan.

3. Turn OFF the propane tank valve.

4. Do not touch any electrical switch or useany phone or radio in the RV.

5. Do not start any vehicle engine orgenerator.

6. Determine and repair the source of theleak.

7. Do not re-enter the RV until the problem iscorrected.

If the propane alarm keeps sounding at regular intervals, a propane leak may be present.Contact your dealer or propane gas service tohave the problem corrected before using thepropane system again.

Testing the propane leak alarmIf the propane alarm does not test properly,replace it immediately. Do not remove thefollowing label from your RV:

Battery or converter power source

The propane alarm is powered by 12-volt DCthrough the converter or from an auxiliarybattery. This propane alarm is continuouslydrawing a small amount of 12-volt current;although this current draw is slight, it could

16


WARNINGThe alarm cannot detect propane or sounda warning for two minutes after it has beenturned on. The propane leak alarm is not asmoke or fire alarm. The alarm will onlyindicate the presence of propane gas at thesensor. Explosive gas may be present inother areas.

� WARNING

TEST THIS ALARM’SOPERATION AFTER EACHSTORAGE PERIOD, BEFOREEACH TRIP AND AT LEASTONCE PER WEEK DURINGUSE.

Fig. 2.4 Propane alarm testinglabel

WARNINGThe propane alarm should never bedisabled because of nuisance or lowbattery alarms. If the auxiliary battery cableis disconnected, and other 12-volt power isnot available, the propane alarm will notwork and you will not be warned if leakingpropane is present.

drain your auxiliary battery during extendedstorage periods. If the auxiliary batterybecomes extremely drained, the LED light onthe face of the alarm will not light or the alarmmay begin to sound on its own. This conditionis not likely to occur except during storagesituations.

FUEL SAFETYFor your protection and others, it is critical tounderstand the danger associated with fuel.Take time to become educated about theproperty of fuel and use it safely. If you spillfuel on the RV, clean it up immediately. Fuelcan dull or soften paint and damage othersurfaces. Use care when fueling your RV.

17


DANGERAutomotive fuels can cause serious injuryor death if misused or mishandled. If youhave further questions, consult your dealeror Jayco Customer Service for assistance.

0 Always shut OFF the tow vehicleengine while refueling.

0 Do not bring or store fuel or otherflammable liquids inside the RVbecause a fire or explosion may result.

0 Before refueling, extinguish allsmoking materials and any openflames.

0 Before refueling, always turn OFF allspark producing appliances (i.e., waterheaters, furnaces, etc.).

0 Do not overfill the fuel tank(s). Thepressure in an overfilled fuel tank maycause leakage and lead to fuel sprayand/or fire.

0 Fuel spills represent a serious firehazard, and should be cleaned upimmediately.

0 Never restart an engine or re-light anypilot lights while raw fuel is present.

FAILURE TO COMPLY COULD RESULTIN FIRE, DEATH OR SERIOUS INJURY.

THIS PAGE IS INTENTIONALLY BLANK

18


PRE-TRAVEL INFORMATION

To help ensure your traveling enjoyment, callahead for tourist information in each area thatyou will be visiting or traveling through. To helpeliminate frustration, make sure you obtain themost current road maps. Research and makesure there are no federal, state or localregulations that may prohibit you from fullyenjoying your camping adventure.

0 Arrange for someone to check your houseperiodically while you are away. Stop mailor newspaper delivery.

0 If you intend to be away for more then twoweeks, you may want to considerrequesting police surveillance for yourhouse.

0 Carry an extra set of vehicle and housekeys with you on a separate key ring.

0 Be sure to renew your license if it hasexpired, or will expire during your trip.

If you are planning to visit other countries,contact the consulate nearest the point atwhich you plan to enter that country for thespecific and most current information(including rules for re-entering the UnitedStates).

Always carry your vehicle registration,insurance policy card(s) and warrantyregistration.

TOW VEHICLEIf you plan to tow your RV with a tow vehicleyou already own, contact your automotivedealer to find out your vehicle towing capacity.If you plan to purchase a new tow vehicle, becertain to tell your automotive dealer theGVWR, size and type of RV that you will betowing (some tow vehicles can be purchasedwith an optional tow package). As a minimumrequirement, the Gross Vehicle Weight Rating(GVWR) of your RV must not exceed your towvehicle’s towing rating.

Some automotive manufacturers publishbrochures that discuss towing considerations.Ask your automotive dealer how to obtain acopy of this information. If applicable, verify ifthe brochure ratings are listed “with” or“without” an optional tow package.

VEHICLE IDENTIFICATION NUMBER(VIN) EXPLAINEDThe 17-digit VIN is the legal identification ofthe completed RV and provides informationunique to your camper. It is located on anexterior frame cross member (usually on thethird or fourth cross member under thecamper, forward of the bumper).

A serial number is needed whenever makingan appointment or ordering replacement partsfrom your dealer. The serial number is the last8-digits of the VIN (in the example shown, theserial number is 81J70060).

VEHICLE LABELSDecals and data plates used throughout theRV aid in its safe and efficient operation;others give service instructions. Read alldecals, data and instruction plates beforeoperating your RV. If any decal, data orinstruction plate is painted over, damaged orremoved, it should be replaced.

Keep a record of the 17-digit vehicleidentification number (VIN) and your licensenumber in the event theft or vandalismrequires you to supply this information to theauthorities.

19

SECTION 3PRE-TRAVEL INFORMATION

Fig. 3.1 VIN example

WEIGHT LABELS

Vehicle weight labels are posted on Jaycomanufactured RVs so you can make aninformed decision before your purchase. Donot remove these labels from your RV. If thelabels are missing, contact your dealer orJayco Customer Service for replacements.

You may question the total weight capacity ofthe tires on your RV being less than theGVWR; this is correct. In order to calculate theactual weight on the RV tires, it is necessary toinclude the tongue weight. The tongue weightis actually being carried by your tow vehicle,not the RV tires.

For example: If the tires are rated at2,000 lbs. each x 4 tires = 8,000 lbs.and the RV has a GVWR of 9,000 lbs.with a tongue weight of 1,200 lbs. Theactual weight on the RV tires is 7,800

lbs. which is within the weight rating ofthe tires.

If you have further questions, please contactyour dealer or Jayco Customer Service.

20


JAYCO, INC.MANUFACTURED BY:FABRIQUÉ PAR:

INC. VEHICLE MFG. BY:VÉHICULE FABRIQUÉ PAR:

GVWR/PNBV: KG V.I.N./N.I.V.

DATE

GAWR/PNBE: KG

FRONT/DEVANTINT./CENTRALREAR/ARRIÉRE

SIZE/DIMENSIONTIRE/PNEU RIMS/JANTE

PRESS./COLD INFL.PRESS.DE GONFL. À

PSI/LPC KPA

TYPE OF VEHICLE/TYPE DE VÉHICULE: TAILER / CARAVANEMULTIPURPOSE PASSENGER VEHICLE/VÉHICULE DE TOURISME À USAGES MULTIPLES

THIS VEHICLE CONFORMS TO ALL APPLICABLEU.S. FEDERAL MOTOR VEHICLE SAFETYSTANDARDS AND STANDARDS PRESCRIBED UNDERTHE CANADIAN MOTOR VEHICLE SAFETY REGULATIONS EFFECT ON THE DATE OFMANUFACTURE SHOWN ABOVE.

CE VÉHICULE CONFORME À TOUTES LESNORMES QUI LUI SONT APPLICABLES ENVERTU DU REGLÈMENT SUR LASÉCURITÉ DES VÉHICULES AUTOMOBILEDU CANADA EN VIGUER À LA DATE SAFABRICATION CI-DESSUS.

FROID

Fig. 3.3 Federal Certification label

TIRE

FRONT

REAR

SPARE

SIZE COLD TIRE PRESSURESEE OWNER’S

MANUAL FOR

ADDITIONAL

INFORMATIONFD-323

TIRE AND LOADING INFORMATION

Fig. 3.2 Tire and Loading Information

TRAILER WEIGHT INFORMATION

VIN or SERIAL NUMBER

MODEL

GVWR (Gross Vehicle Weight Rating) is the maximum permissible weightof this trailer when separated from the tow vehicle.

UVW (Unloaded Vehicle Weight) is the total weight of this trailer asmanufactured at the factory when separated from the tow vehicle. If ap-plicable, it includes full generator fuel, engine oil, and coolants.

CCC (Cargo Carrying Capacity) is equal to GVWR minus each of thefollowing: UVW, full fresh (potable) water weight (including the waterheater), full LP-gas weight.

GCWR (Gross Combination Weight Rating) means the value specified bythe trailer manufacturer as the maximum allowable weight of this trailerwith its towed trailer or towed vehicle.

**The GCWR of this trailer is:

CARGO CARRYING CAPACITY (CCC) COMPUTATION

Pounds / Kilograms (kg.)

GVWR

Minus UVW

Minus fresh water weight of gallons @ 8.33 Lbs./gal.

Minus LP-gas weight of gallons @ 4.24 Lbs./gal.

CCC for this trailer*

*Dealer installed equipment will reduce the CCC.

**This trailer is not recommended or intended to be used to tow anyother vehicle or trailer.

CONSULT OWNER MANUAL(S) FOR SPECIFIC WEIGHINGINSTRUCTIONS AND TOWING GUIDELINES.

Fig 3.4 Trailer Weight Information label

WARNINGThe factory-installed weight labels arespecific to the recreation vehicle for whichthey are supplied and are notinterchangeable.

HITCH (CUSTOMER SUPPLIED)

Hitch selection is important because it affectsthe towing and handling characteristics of your RV. There are many kinds of hitches availablefor various uses and assuring that you havethe correct hitch installed is critical to a safetowing experience.

Ask your dealer about the proper class andtype of hitch you need to purchase for yourindividual tow vehicle/RV combination (a travel trailer requires a frame mounted hitch; a fifthwheel requires a pin box hitch bolted directly to the floor of the truck box through the frame).Fifth wheels have a factory-installed standardpin box that is not interchangeable.

The hitch manufacturer assigns a hitch classrating based on the capacity that hitch has fortowing and a weight classification. The weightclassification is determined from the hitch’sweight carrying capacity (also known as thetongue weight on a travel trailer). Beforeselecting a hitch, you must know your RV’sGVWR and tongue weight or pin box rating.

Maintain the proper tongue weight of thetrailer. Stay within the target range of10%-15% of the overall gross weight (traveltrailer weight plus contents). Fifth-wheelstypically maintain 25% of their overall grossweight (trailer weight and contents) on thehitch.

Equipment that sometimes gives autos, trucksand sport utility vehicles a softer ride canaccentuate swaying when pulling a RV;conversely, suspension that is too stiff willincrease vibration, bounce and acceleratewear of your tow vehicle and trailer. Educateyourself to protect you, your family and othermotorists.

The rating of the hitch package purchasedshould be equal to or greater than the RV’sGVWR and the hitch weight (or pin boxrating).

HITCH HEIGHT & HITCH BALLTo determine the hitchheight for your model,make sure that the traileris level. When the loadedRV is hitched to the towvehicle, check the hitch

ball height. This can be determined bymeasuring the distance from the center of thehitch ball to the ground. Record this number inthe box for future reference.

Adjust the equalizing bars of the hitchassembly so that the tow vehicle and the trailer are essentially level. A high hitch will transferweight behind the axles and cause the vehicleto fishtail. A low hitch will transfer additionalweight to the hitch. Refer to the hitchmanufacturer instructions to adjust theweight-distributing hitch to the proper height.

If you have additional questions, consult withyour dealer. Jayco cannot be responsible forthe suspension system of any tow vehicle.There are a variety of tow vehicle suspensionsystems available that will affect the ballheight, stability and levelness of a hooked upRV. Make certain your dealer is aware of thetow vehicle you are using so a compatiblehookup is achieved. Depending on the model,your required travel trailer hitch ball diameter is 2-5/16” (consult your dealer for assistance).

There is no recommended hitch height forfifth-wheel travel trailers; usually the fifth wheel pin box is adjustable for variance in trucks andtruck suspension systems.

21


CAUTIONUsing an oversized or undersized hitch cancause damage to the RV frame. Jaycocannot be responsible for the tow vehiclesuspension system. The final ball heightafter the tow vehicle/travel trailercombination is completely hooked up is afactor that must be considered. To avoidoverloading your trailer axles and minimizepossible handling difficulties, your trailershould be level when hooked to your towvehicle. Do not overload your tow vehicle. This unit hitch

height is:

SWAY CONTROL (CUSTOMER SUPPLIED)

Sway control devices are available to reducethe sway produced by crosswinds, airdisplacement caused by other vehiclespassing you in transit, incorrect weightdistribution, excessive speed, the RV tiresdropping onto the shoulder of the road, etc.You will also want to discuss this purchase with your dealer.

The use of a sway control device will help tocontrol the side-to-side movement and keepsway in check.

Suggestions for sway situations:0 Slowly ease your foot off the accelerator.

0 Turn the steering wheel as little aspossible. Natural lag time reaction whencounter-steering to correct sway couldpossibly make it worse.

0 If the trailer is equipped with electricbrakes, using the hand control will help tokeep the vehicles aligned.

0 As soon as possible, stop to determine thecause of the sway. Check all equipmentand load distribution. If the problem cannot be solved immediately, contact yourdealer for a service appointment (travel ata very reduced speed on your way there).

WEIGHT DISTRIBUTING SYSTEM(CUSTOMER SUPPLIED)A weight distributing hitch system provides amore stable tow vehicle/RV combination. Thissystem will spread the weight evenly todistribute it to the tow vehicle front and rearaxles and the trailer axle. Consult with yourdealer to familiarize yourself with the operation and requirements of the weight distributing

hitch system. Be certain your tow vehicle cancarry the hitch weight.

RV BRAKE SYSTEM

The electric brakes are designed to work withthe tow vehicle brakes. To maintain properbraking performance, both the RV and towvehicle brakes must be used together.Separate use of the braking systems willcause accelerated wear and damage.

When your RV is new, it is impossible toadjust the brake shoes precisely. It takesapproximately 1,000 miles and/or 50medium to heavy stops to “burnish” fit or“seat” the shoes to the brake drum. Afterthe initial break-in period your brake shoesmust be adjusted accurately for bestperformance and increased durability.

Braking system components include:

0 Tow vehicle battery

0 Brake controller

0 Wire harness/connector plug

0 Trailer battery

0 Breakaway switch

Tow vehicle batteryThe tow vehicle battery is the primary sourceof power for your RV's electric brakeoperation. To ensure available power whenneeded, keep your tow vehicle battery andcharging system working properly.

22


WARNINGA sway control device (customer supplied)should be used with your tow vehicle/traveltrailer combination. Consult with yourdealer to obtain the proper equipment foryour needs.

WARNINGFailure to maintain the brakes in properworking condition as specified in theoperator’s manual supplied by the axleOEM will cause property damage, personal injury and possibly death. Consult with your dealer for assistance.

Brake controller (customer supplied)The brake controller should be installed in thetow vehicle to work in conjunction with the RVelectric brakes. Consult with your dealer or thebrake controller OEM to decide what is right for your towing combination.

LOADING YOUR RV

Decide on the various items of food, clothing,equipment and other supplies you will need for the length and destination of your trip. Storeand secure all loose items inside the RV before traveling. Overlooked items such as cannedgoods, or small appliances on the countertop,cooking pans on the range or free-standingfurniture items can become dangerousprojectiles during a sudden stop.

Distribute cargo side-to-side so the weight oneach tire does not exceed one-half of theGAWR for either axle. For traveling safety, it isimportant to make sure any tie down straps (ifso equipped) on appliances or furniture aresecured.

WEIGHING YOUR TOW VEHICLE & RV

Now that your RV is loaded you should have itweighed. The actual weight of the RV,passengers, all options, liquids, the hitchweight of your towed vehicle and yourpersonal cargo is important for you to know soyou do not exceed the GVWR.

There are two important factors when loadingyour RV, total weight and balance. It isimperative that you verify compliance within all applicable weight ratings. Overloading yourRV will void the Towable Limited Warrantyand the warranties of many component partmanufacturers.

Have your RV weighed periodically at apublic scale to determine the proper loaddistribution. Keep in mind that individualscales will operate differently. Thesurroundings of the scale need to be adequate to accommodate weighing each side of yourRV.

To weigh your tow vehicle and RV

23


WARNINGDO NOT EXCEED YOUR GVWR! Thismeans you should weigh your RV asloaded for your normal travel to determinethe actual weight. If you exceed the GVWR, you MUST remove items from the RV, ordrain liquids, then re-weigh the vehicle toensure you have achieved a safe weight.Do not travel with full grey/black holdingtanks. This not only wastes gas but,depending upon the location of the grey orblack holding tanks, can affect handlingcharacteristics.

WARNINGNever load the RV in excess of the GAWRfor either axle. Overloading your RV mayresult in adverse handling characteristicsand damage to the chassis.

WARNINGStore items in areas designated forstorage. Do not store anything in the areasreserved for the converter, electrical panels or the furnace or water heater, etc.

WARNINGTotal weight of your tow vehicle and RVmust not exceed the GCWR. Do notassume that you can tow a RV thathappens to be within the capacity of the tow vehicle hitch. By doing so, you may exceedthe total GCWR of your tow vehicle and RVtowing combination.

WARNINGIt is important to redistribute the load toavoid component failure as well as toimprove the handling characteristics of thevehicle.

Read through all the weighing instructionsbefore you begin. If you have furtherquestions, consult with your dealer or the scale operator. Your RV must be weighed fullyloaded (that is with food, clothing, fuel, water,propane, supplies, etc).

1. Weigh the RV including the tongue weight,while detached from the tow vehicle. Thisactual overall weight must be less than orequal to the GVWR for safe operation. Ifthe overall weight is greater than theGVWR, some contents must be removeduntil the actual overall weight is less thanor equal to GVWR.

2. Hitch the RV to your tow vehicle. Weigh the RV and the tow vehicle to determine theGCW. Make sure that this rating is lessthan or equal to the GCWR as specified bythe manufacturer of your tow vehicle. If this overall weight is greater than the GCWR,some contents must be removed to bringthe combination into compliance with thelisted ratings.

3. Weigh the RV while attached to butexcluding the tow vehicle. This will result in the actual weight that is exerted on all ofthe RV tires. This weight may besubtracted from the overall RV GVWR todetermine the actual “tongue” weight.

4. With the RV still attached to the towvehicle, weigh each wheel positionseparately to ensure each tire is notoverloaded.

To determine the wheel position weight:5. Pull the RV onto the scale so only one tire

is on the scale. Record the weight. YourRV must remain as level as possible on the scale (even though an axle or side is notphysically on the scale). Obviously, toobtain the side-to-side weights, there mustbe enough space on either side of thescale to accommodate the RV beingpartially off the scale.

6. To calculate the opposite side of the RVwheel position weight, subtract the first

side’s weight from the weight determinedin step #3.

If there is a difference in the weights on oneside of the vehicle as compared to weights onthe other side, components (tires, wheels,brakes, springs, etc.) on the heavier side could be overloaded, even though the total axle loadis within the GAWR. It is important toredistribute the load to avoid componentfailure, improve the handling characteristics ofthe tow vehicle and not void the TowableLimited Warranty.

With these actual weights, it is now possible tocompare them against the Trailer WeightInformation label weight ratings to ensure youare below the posted minimum ratings.

FIRST SHORT TRIPAfter familiarizing yourself with the RV,including going through test runs on thesystems and having the RV weighed, it is timeto take one or two short trips. The experiencegained can be priceless.

We recommend an overnight stay at a nearbycampground. That way it is more convenient ifyou need to go back to get an item you forgotor didn’t know you would need. Otherwise, you may end up spending time or moneyneedlessly by bringing along unused itemsthat take up space or trying to locate andpurchase items you hadn’t counted onneeding prior to leaving your home on anextended trip in unfamiliar territory.

Not all RVers will need the same equipment orsupplies. For example, individual needs andpersonal tastes differ, as does the variousclimates and terrains you will be travelingthrough with your RV.

Remember if most of your trips are planned forthe summer and your shake down trip is madeduring some other season, there will beadjustments that you will need to take intoconsideration.

24


Be sure to have a pen and notebook availableto write down items that you feel may beneeded in future travels, as well as noting theequipment you feel you need to become morecomfortable using or learning how to operatesafely.

RV Departure ChecklistFollowing is a preliminary list of items thatneed to be checked on your RV before leavingyour home or campsite. As you camp, you may want to develop your own list tailored to yourindividual camping style in addition to thechecklist provided:

0 Check the area under the RV afterovernight parking and look for water orother fluid leaks. If leaks are detected, findthe cause and have it repairedimmediately.

0 Have someone observe the operation ofall exterior lights while you activate thecontrols.

0 Check wheel lug nuts for tightness andtires for proper air inflation pressure.

0 Examine the tires for excessive tread wear or uneven wear patterns. Check forstones, nails, glass or other objects lodged in the tread. Inspect for tread cuts orsidewall cracks.

0 Check the propane cylinder gauge tomake sure there is propane available.

0 Retract any awning(s) and secure them for transport.

0 Close all the roof vents.

0 If so equipped, disconnect any cable TV or phone hookups and lower the TV antenna.

0 Turn off the interior lights and appliances.

0 Secure any loose, heavy or sharp objectsin the RV or exterior compartments.

0 Disconnect the shore line power cord andensure it is stored correctly.

0 Fasten all interior and exterior doorssecurely. Lock them (if applicable).

0 Make sure the stabilizer jacks and entrystep are retracted to the travel position.

0 Make sure the tongue jack (travel trailer) is retracted to the travel position and thedolly wheel removed.

0 Walk around your RV one last time tomake sure everything is stored away andthe baggage compartments are closedand locked.

0 Pull forward, clean the site (if applicable)and check for forgotten items.

0 Secure and lock the entrance door.

Pre-travel ChecklistIn order to enjoy your travel, having all the right tools and supplies will help. A checklist may be beneficial to avoid forgetting somethingessential. This list is meant to be a startingpoint, while realizing that personal preferencewill also play a large role in your packing.There are items here that may not apply foryou and items that could trigger other ideas.As you expand your camping experience, youmay wish to develop your own list of needs.

Before leaving home

– All list items packed in tow vehicle/RV

– Arrange for pet care, mail and/or newspaper pickup

– Disposable rubber gloves

– Lock refrigerator door (if so equipped)

– Leave itinerary with neighbor, familymember or friend

– Map/road atlas/campground directory

– Membership cards

– Owner Manual and Goodie Bag

– Proof of insurance

– Road flares

– Roadside assistance membership cardand/or policy

– RV keys

– Secure loose items

– Security watch for house(neighbor/family/friend)

– Vehicle registration

– Weigh fully loaded trailer (people, cargo and liquids included) and maintain proper weight distribution (redistribute as necessary)

25


Bedding

– Blankets

– Comforters

– Pillows

– Sheets

– Sleeping bagsKitchen

– Aluminum foil, plastic wrap, etc.

– Charcoal and lighter fluid

– Cooking utensils

– Dish soap

– Dish towels and rags

– Food supplies

– Paper plates, towels, napkins, coffee filters,etc.

– Pots & pans

– Trash bags and/or paper sacksPersonal Supplies

– Clothing

– Laundry detergent

– Toiletries

– Towels - beach and bathRecreation

– Campfire supplies

– fire grate for cooking

– firewood, newspapers and/or kindling

– matches in waterproof container and/orutility lighter

– skewers, pie irons, etc.

– Games - cards, board, dice

– Lawn chairs

– Outdoor activity equipment (fishing poles,tennis rackets, etc.)

Supplies

– Bug spray

– First aid kit

– Flashlight(s)

– Sun screen

– Toilet paper

RV

– Check lights

– brake lights

– clearance lights

– turn signals

– Check tire pressure (including spare tire)

– Check tire wear (uneven wear pattern)

– Check wheel lug torque

– Proper tongue weight maintained (10-15%of gross weight - travel trailer and contents)

– Safety pin or locking lever must be seated (ifapplicable)

– Secure shore line power cord

– Surge protector

– Telephone and/or cable wire (if applicable)

– Test brakes for proper operation

– Tools

– AC voltage tester

– axe

– duct tape

– fuses and light bulbs (compatible withyour RV)

– jack

– jumper cables

– rope, cord, bungee cord(s) or wire

– saw (bow or folding)

– shovel (small folding)

– tire pressure gauge

– tool kit (screws, hammer, pliers, etc.)

– torque wrench

– work gloves

– Trailer is level

– Trailer safety chains connected (ifapplicable)

– Wheel blocks removed

26


TOWING & HANDLING

Driving safety and protection against injurycannot be fully ensured. However, werecommend you pay special attention to thefollowing:

0 The use of daytime running lights canincrease other motorists’ awareness of the RV to all traffic.

0 Keep the tires inflated to the specifiedlevels. Replace the tires before they areexcessively worn.

0 Before changing lanes, check the outsiderearview mirrors for other vehicles andactivate the appropriate turn signal to alertother drivers.

0 While driving, watch the behavior of otherdrivers, bicyclists and pedestrians. Always follow all traffic laws and regulations. Payattention to traffic and road conditions. Bea courteous and alert driver. Always leaveroom for unexpected events, such assudden braking.

0 Never drive when you are sleepy or tired.Never drive when alcohol, drugs ormedication have affected your judgment,reflexes or alertness.

0 Obey all traffic laws and use your seatbelts at all times. Many states have lower speedlimit requirements for tow vehicle/RVcombinations. We recommend that you do not exceed the posted speed limit whentowing an RV.

0 Driving with the propane system on canadd to the danger if you are involved in anaccident or have a fire. Most refrigeratorswill keep food cold or frozen for eight hours without running while you travel. Shut thepropane system off at the propanecylinder.

0 Adverse weather conditions and extremesin terrain may affect the performance andhandling of your tow vehicle. Do notoperate the tow vehicle cruise control onicy or extremely wet roads, winding roads,in heavy traffic or in any other trafficsituation where a constant speed cannotbe maintained.

27

SECTION 4TOWING & HANDLING

WARNINGDo not leave children or pets unsupervisedin the vehicle (even if children are securedby a child restraint system). They could:

0 Injure themselves on parts of thevehicle.

0 Unlock and open the entry door, oropen the emergency exit window, andthen possibly injure other persons ordamage property.

0 Get out of the vehicle and either injurethemselves when doing so or theycould be injured by passing vehicles.

Be seriously or even fatally injured byprolonged exposure to extreme heat orcold.

WARNINGDo not expose child restraint systems todirect sunlight. Metallic parts of the childrestraint system could heat up, forexample, and the child could be burned orinjured.

WARNINGYou must observe the law if you are drivingwhen operating a cell phone in your towvehicle. If it is permitted to operate a cellphone while the tow vehicle is in motion,you must only operate it when road andtraffic conditions permit. You mayotherwise be distracted from the trafficconditions, cause an accident and injureyourself and others.

Some cell phones may interfere with yourtow vehicle electronics and therebyjeopardize the operational safety of yourtow vehicle (to research this further, contact your tow vehicle dealer or manufacturer foradditional information).

RV DRIVING SCHOOLS & SEMINARSIf you have any concerns about driving whiletowing a RV, consult an expert for specific RVdriver education. There are private RV schools and some RV owner’s organizations that offerdriving seminars. The schedules and locations of the various RV driver education seminarsand schools can be researched throughRV-related publications and internet sites.

Use caution when using the internet as aresource tool. Verify the information is from acredited and reliable source in the RV industry, and it pertains to your RV. If in doubt, contactyour dealer or Jayco Customer Service.

DRIVING & ALCOHOL

The presence of alcohol in significant levels inthe blood increases the probability that thedriver will be involved in an accident. Exerciseyour good judgment and encourage others todo the same. Know the legal alcohol limits anddo not exceed them. Be aware of yourpersonal limits, which may be lower than thelegal limits. Should you ever exceed your limits or find your driving is impaired, find alternativetransportation. NEVER DRINK AND THENDRIVE.

BREAKAWAY SWITCH

The breakaway switch is a crucial part of theRV braking system. Located on the traveltrailer A-frame or fifth wheel pin box, thisswitch will apply the trailer brakes if the trailerbecomes detached from the tow vehicle.Attach the breakaway switch lanyard to apermanent part of the tow vehicle (on a traveltrailer do not attach it to the hitch ball or similarremovable parts) when hitching the trailer. Ifthe RV becomes detached from the towvehicle, the pull pin will be pulled from theswitch. This automatically causes the switch to “close” and activates the RV brakes.

A battery (customer supplied) must beinstalled to activate the breakaway switch.

SAFETY CHAINSSafety chain requirements vary from state tostate. Your RV is equipped with chains to meetSAE standard requirements for maximumgross trailer weight. Always have the safetychains attached when towing. Install them asshown below so they do not restrict sharpturns, but tight enough so they do not drag onthe ground.

28


CAUTIONNEVER use the breakaway switch andtrailer brake system as a parking brake.Doing so would create a high amp draw onthe battery and converter. This can causedamage to wiring, connectors and thebreakaway switch.

WARNINGDriving after drinking or taking drugs(including some prescriptions and/orover-the-counter medications) can lead toan accident. Studies have shownperceptions are less sharp, reflexes areslower, drowsiness may be experiencedand/or judgment may be impaired.

Crisscross the left safety chain under thecoupler and attach to the right mounting slot inthe trailer hitch; repeat with the right safetychain. Slack for each length should be thesame but not more than necessary to permitthe vehicle to turn at its minimum radius.

WIRE HARNESS/CONNECTOR PLUGA 7-way wire harness/connector plug is wiredinto your trailer to connect electrical powerfrom the tow vehicle for travel. This suppliespower to the RV brakes, tail lights, clearancelights, turn signals, brake lights, etc. Wiring tooperate your brakes must be the same size inboth the tow vehicle and RV (the RV brakewiring is 12-gauge wire). When attaching wires to your tow vehicle, carefully and tightly tapeall the connections for moisture protection.

White 1 Ground

Blue 2 Brakes

Green 3 Running lights

Black 4 Auxiliary Battery charge line

Red 5 Stop & left turn

Brown 6 Stop & right turn

Yellow 7 Back up

The connector plug may build up corrosionwith extended use and should be cleanedperiodically to insure good electrical contact.

Make sure the connector plug is kept cleanand protected from road elements as youtravel.

STABILIZER JACKS

1. Each stabilizer jack can be individuallyadjusted to stabilize the trailer for use.

2. When setting your RV up on soft ground,you may wish to place a wood pad or theequivalent under each stabilizer jack foot.This will help keep the stabilizer jack fromsinking into the ground.

3. To lower each jack, insert the jack crankonto the applicable stabilizer jack shaft.

4. Turn the crank clockwise to lower each leguntil it contacts the ground and stabilizesthe trailer.

To raise each jack, insert the jack crank ontothe applicable stabilizer jack shaft and turn thecrank counter-clockwise.

The stabilizer jacks must be fully retractedbefore moving or towing the RV to preventstabilizer jack damage.

29


4 black

6 b

row

n

3 green

5 r

ed

7 yellow

1 white2 blue

Fig. 4.27-way trailer plugCar end, rear view

WARNINGDO NOT USE THE STABILIZER JACKSTO LEVEL THE RV. It is important toremember that the stabilizer jacks are to beused only for support while occupying andmoving around the RV. They are notdesigned to bear the weight of the RV.

1. Inspect chains to determine if they are properly attached to trailer frame.

2. Criss-cross left chain and attach to right mounting slot in tow vehicle hitch.

3. Repeat step 2 with right chain. Slack for each length should be the same but not more than necessary to permit the vehicle to turn at their minimum radius.

4. Properly mounted safety chains. Note that the jack is fully raised and dolly wheel removed.

Fig. 4.1 Safety chain installation

TRAVEL TRAILER HITCHING PROCEDUREHooking up your RV will become easier withpractice. The following procedure will help until you become more experienced.

1. Make sure the trailer wheels are blocked.

2. Turn the tongue jack crank to raise thetravel trailer tongue above the hitch ball.

3. Open the coupler latch on the travel trailerhitch.

4. Back the tow vehicle into the properposition.

5. Turn the tongue jack crank to lower thecoupler onto the hitch ball.

6. Close the coupler latch after it iscompletely seated.

7. Install the (customer supplied) weightdistributing bars (equalizers) as directedby the OEM.

8. Remove the dolly wheel or platform andretract the tongue jack to its maximumheight.

9. Attach the breakaway switch cable to thetow vehicle.

10. Walk around the RV to verify exterior lightsare working correctly.

11. Attach the safety chains.

12. Plug in your wire harness/connector plugfrom the tow vehicle to the travel trailer.

13. Remove the trailer wheel blocks.

If an Atwood brake actuator is used with anequalizing hitch, be sure the hanger chainshang between straight down and forward up to34°. Do not use less than 6-1/2" hanger chainlength. For optimum brake performance, hangchains forward 34°. Refer to OEM manual formore information.

FIFTH WHEEL LANDING GEAR

The fifth wheel landing gear can be operatedmanually. The fifth wheel landing gear must befully retracted before moving or towing the RVto prevent damage.

FIFTH WHEEL HITCHING PROCEDUREHooking up a fifth wheel will become easierwith practice. The following procedure will help until you become more experienced.

1. Make sure the trailer wheels are blocked.

2. Make sure the hitch lever is in its open or“cocked” position unless it has beendesigned to open automatically. Adjust thefifth-wheel travel trailer pin to the properheight. Lower the tailgate, if applicable.

3. Back the truck so the hitch encircles thefifth-wheel travel trailer pin.

4. A gentle contact of the hitch saddle against the pin will cause the mechanism to close.

5. Secure the hitch lever as specified by themanufacturer.

6. Put the truck in drive (DO NOT press onthe accelerator) and ‘bump’ the hitch tomake sure it is locked.

7. Be sure to raise the fifth-wheel landinggear all the way up.

8. Attach the breakaway switch cable to thetow vehicle.

9. Plug the wire harness/connector plug fromthe tow vehicle to the fifth wheel.

10. Raise the tailgate of the tow vehicle, ifapplicable.

30


WARNINGDO NOT USE THE FIFTH WHEELLANDING GEAR TO SUPPORT THETOW VEHICLE WEIGHT. The fifth wheellanding gear is designed to bear the frontloaded weight of the RV only.

11. Remove the wheel chocks from the trailerwheels

TOWING

You will find that your RV will travel safely andcomfortably at most posted trailer highwayspeed limits. However, it will take longer than a passenger automobile to reach that speed.Keep this in mind when overtaking andpassing another vehicle. Allow more time to go around the vehicle you are passing. Youcannot cut back into the traffic lane as quicklydue to the longer length of your tow vehicle/RV combination. Drive with caution to avoidsituations that might require quick momentumchanges.

Even though your RV is equipped with brakesdesigned for GVWR, we suggest practicingstopping away from traffic until you becomeaccustomed to your RV’s stopping distance. Agood way to practice is at a large parking lot(where it is permissible). Easing to a stop andstarting smoothly saves wear and tear on yourtow vehicle/RV combination.

Drive defensively, try to anticipate problemsthat may occur and prepare for them (even ifthey may never happen). Be aware of roadsurface conditions. Slow down well in advance of dips and bumps to reduce the jolting to yourtow vehicle/RV combination. Drive over themslowly and let the trailer tires pass over thembefore accelerating. Cross railroad tracks

slowly (always release your brakes beforecrossing).

When descending a long hill, drop down into alower gear (or lower range if you haveautomatic transmission). Avoid conditions thatrequire excessive and prolonged use of yourbrakes. Apply and release brakes at shortintervals to give them a chance to cool. Thetow vehicle transmission and engine will helpin controlling downhill speed and can lengthenbrake life. The distance required to stop the RV is greater than an automobile’s. Use carewhen accelerating or decelerating on aslippery surface. Abrupt speed changes cancause skidding and loss of control.

Driving through water deep enough to wet thebrakes may affect stopping distance or causethe vehicle to pull to one side. Check the RV’sbrake operation in a safe area to be sure theyhave not been affected. Never operate anyvehicle if a difference in braking efficiencyis noticeable.

Towing behind your RV

DO NOT tow anything behind your RV. TheRV frame and bumper are not designed fortowing.

Vehicle ClearanceRemember some bridges, older ones inparticular, may not support the weight of yourtow vehicle/RV combination. Know the weightand size of your towing combination andobserve any posted weight and clearancelimits. The added height of roof airconditioners, TV antennas or floodlights maycause clearance problems around sometunnels, canopies and hanging signs.

31


WARNINGWhenever possible, do not travel withwaste in the holding tanks. Liquid or debrisin the holding tank(s) may affect the towingcharacteristics and may result in propertydamage or personal injury.

WARNINGYour RV braking system is rated foroperation at GVWR not GCWR.

WARNINGTowing items behind your Jayco trailer, oroverloading the rear, will void the warrantyand may result in: damage to the trailer oradd-on items, towing difficulties, propertydamage and/or personal injury.

Turning CornersWhen turning, the tires do not follow the path of your tow vehicle tires. The RV will make atighter turn than the tow vehicle. You mustcompensate for this action by carefully pullingthe tow vehicle out into the intersection furtherthan you would normally so that the RV clearsthe curb (or any parked vehicles along thecurb). When making a turn, check the roadclearance and be aware of others. Havesomeone help guide you out of a difficultparking space or traffic pattern. Swerves andsharp turns, especially at high speeds, couldresult in loss of control of the RV.

Backing upIf your camping destination does not have pullthrough sites, pick a level site and back incarefully. We suggest you stop near the site,get out of the RV and observe the surroundingarea. Check to ensure there are no obstaclesin your path and that you have plenty of vehicle clearance. Check for low-hanging tree limbs,posts, large rocks or other obstacles. Try tochoose a site that is on the driver’s side, so you can see what the rear of the RV is doing. Withthe site on the passenger side, you would bebacking into the site on your blind side, whichis more difficult. When you determine the siteconditions are satisfactory, maneuver the RVinto position for backing up into the site space.Back the RV up slowly using your tow vehiclemirrors as a guide. Have another personoutside the RV assist you until the RV isparked in the desired position.

ParkingAfter the RV is in the desired location, set thetow vehicle parking brake and place thetransmission in park. Turn OFF the ignitionswitch. Go outside the RV and block all wheels securely with wheel chocks. The wheel chocks can be wood blocks or purchased items aslong as they prevent the RV from rolling. Beaware of your surroundings. If parking at nightat a rest stop, truck stop or parking lot chose awell-lighted area.

EMERGENCY STOPPINGAlways carry road flares or reflective warningsigns to display if necessary. Pull off theroadway as far as possible for emergencystopping or tire changing. Turn ON your RVhazard warning flashers. If traveling at night,use three red warning indicators such asflares, reflectors or lanterns, as follows:

1. Place the first warning indictor on the traffic side of the RV, directed at the nearestapproaching traffic.

32


Here are some tips to keep in mind whenparking in unfamiliar surroundings:

Have a pre-determined plan of action…Develop response plans for all situations.Dry-run typical situations as a way ofmaking your responses to each simulationsecond nature. A cellular phone is a goodinvestment to protect yourself, especiallywhen traveling alone.

Be alert to all situations… Assess yoursurroundings to help anticipate possibleproblems and responses. If someoneunfamiliar knocks on the door, do not open it until you are certain the request is legitimate and represents no possible harm to you oryour RV.

Trust your intuition… This is a natural tool at your disposal. If something does notseem to be right, you may want to evacuatethe vicinity immediately or call 911.

Remember, nothing is 100 percenteffective… Do not rely on your dog or analarm system, etc. Always remain wary.

Developing these habits may help preventloss to you or your property as you traveland enjoy your RV.

2. Place the second warning indicator 100feet behind the RV in the center of the laneand toward approaching traffic.

3. Place the third warning indicator 100 feetin front of the RV in the center of the laneand away from the traffic approaching from behind.

The hazard-warning flasher providesadditional safety if the RV is stopped on theside of the roadway and presents a possiblehazard to other motorists. When the flasher ison, it serves as a warning to others toapproach and overtake your vehicle withcaution.

For personal safety, always stand off theroad and out of the way of traffic. Curvesand/or hills may affect the safe placementof warning indicators

EMERGENCY TOWING

If your RV needs to be towed, please contactan emergency road service provider or aqualified service facility for assistance.

33


WARNINGNever allow anyone to go under the RVwhile it is being lifted and/or beingtowed.


34


RV TIRES

Read and understand the followingbefore taking your first trip in yourRV!

Proper care and maintenance of your tires isessential to ensure your safety, as well as thesafety of others, as you travel. Taking time tobecome educated on the special qualities ofRV tires and care they require will enhanceyour travel enjoyment.

Routine maintenance on your RV is important,but it cannot be overstated just how criticalproper tire maintenance is to the safety,operation and durability of your new RV. Youmust follow the manufacturer’s inflationguidelines for maximum load capacity;under-inflation is just as dangerous asover-inflation. To insure your tires areoperating safely, regular inspection of yourtires and checking tire pressures is absolutelymandatory.

Examine your tires frequently for unusualwear. Alignment, balance and bearing wearwill affect tire wear. Make sure to look for

cracking, bulging, uneven tread wear, etc.Check and adjust tire pressures before andafter each trip. Always check and adjust withthe tires cold. Never add or release pressurefrom the tires when they are hot (or afterhaving driven a mile or more).

Replacement

If you experience a flat tire on your RV whiledriving, gradually decrease your vehicle speed (if possible). Hold the steering wheel firmly and move the RV to a safe place on the side of theroad. Any service or warranty coverage ontires is to be handled by the tire storerepresenting the brand installed on your RV;they are not to be returned to your dealer orJayco. If you have questions regarding your tires, contact the tire OEM or JaycoCustomer Service.

VINYL TIRE COVER (IF SO EQUIPPED)Your tires are manufactured with componentsthat cause “bleeding” onto the tire cover. Toprevent this, it is recommended to use aseparator (garbage bag, paper, cloth, etc.)between the tire and the cover.

35

SECTION 5RV TIRES

DANGERFailure to follow proper inflationguidelines may result in tire failure,which, under certain circumstances cancause loss of vehicle control oraccidents that may result in propertydamage, bodily injury and/or death.

WARNINGIt is recommended that the tire pressure bechecked at the beginning of each journey to obtain the maximum life of the tire. Followthe instructions listed on the FederalCertification label, affixed to the roadsidefront corner of your trailer, to determine thecorrect tire pressure. Under-inflation maycause tire failures and swaying; this mayresult in loss of control, injury, death orproperty damage.

WARNINGBe sure to use only tires that are rated forRV use. The use of passenger tires shouldbe avoided. The load rating/ rangeembossed on the sidewall of passengertires must be de-rated accordingly; they donot have the same load capability as tiresthat are specifically identified for RV use.Failure to use tires that are properlymatched to your recreation vehicle couldlead to premature tire wear or less thanoptimum trailer handling.

WARNINGWhen replacing a tire make sure to replaceit with a tire of the same size andspecifications (refer to the FederalCertification label).

SPARE TIRE CARRIER (IF SOEQUIPPED)

The spare tire is mounted on the rear bumper.The spare tire bracket can be released andextended down to access a storagecompartment at the rear of the trailer withoutremoving the tire.

To extend the tire down1. Remove the cotter key

from the pin holdingthe tire carrier inplace.

2. Remove the pin andextend the tire carrieraway from the trailer.

3. Always return the tire carrier to the uprightposition and lock it in place while traveling.

To remove the tire from the tire carrier1. Remove the lug nuts holding the tire in

place.

2. Remove the support bracket from thebottom lug.

3. Pull the tire from the tire carrier.

To install the tire on the tire carrier1. Place the tire on the tire carrier with the top

lug bolt inserted into one of the holes in thetire rim and the bottom lug bolt in the center of the rim.

2. Install the top lug nut.

3. Place the support bracket over the bottomlug bolt across the center of the rim.

4. Install the bottom lug nut over the supportbracket.

5. Make sure the lug nuts are tightenedsecurely before returning to travel.

CHANGING THE TIRE

1. Keep the RV attached to the tow vehicle.Block the tire on the opposite side of theRV from the tire you are changing.

2. Loosen the wheel lug on the tire you arechanging before jacking up the RV. DONOT remove the lug nuts; only loosenthem for ease of removal when the tire isoff the ground.

3. Locate the main frame rail of the trailer (itspans from front-to-back just inside thetires).

4. To raise the RV, place the jack (hydraulicor screw) under the main frame rail. It mustbe just ahead of the front tire or just behindthe rear tire.

WHEEL LUGSTorque is the amount of rotating force appliedto a fastener, such as a lug nut. Proper torqueof lug nuts can only be achieved by using aproperly calibrated torque wrench and socket.Do not use a 4-way socket or any other type of

36

SECTION 5RV TIRES

Fig 5.2 Spare tire carrier installation

WARNINGNever raise the RV by placing the jackunder the axle, springs or any attachmentparts. Failure to comply could result inproperty damage, personal injury or death.

Fig. 5.1 Cotterkey

WARNINGWhen replacing a tire make sure to replaceit with a tire of the same size andspecifications (refer to the FederalCertification label information.)

wrench that does not measure the actualpressure applied to the lug nut.

After your first trip, check the wheel lug torqueperiodically for safety. Check the wheel lugsafter winter storage, after a wheel removal,before starting a trip or following extensivebraking. Use the correct star pattern sequence to attach the RV wheels (see Wheel LugTorque Chart).

1. Start all nuts by hand to prevent crossthreading.

2. Tighten the nuts in the sequence shown.

3. Tighten the lug nuts equally in stages asindicated for your trailer’s wheels (seeWheel Lug Torque Chart).

Check and re-torque after the first 10, 25and 50 miles (16, 40 and 80 kilometers).Thereafter, check and maintain the torqueaccording to the listed torque values (seeWheel Lug Torque Chart).

For more informationTires are warranted by the tire manufacturerand are to be serviced and warranted by anappropriate service center. They are not to bereturned to your dealer or Jayco. If you havequestions regarding your tires, contact thetire manufacturer or Jayco CustomerService.

37

SECTION 5RV TIRES

WARNINGFailure to maintain proper torque of thewheel lug nuts could lead to separation ofthe tire and wheel while driving, possiblyresulting in property damage or personalinjury.

WARNINGWheel lug nuts must be applied andmaintained at the proper torque levels toprevent loose wheels, broken studs andpossible separation of the wheel(s) fromyour trailer. The lug nuts on the wheels ofyour RV must be maintained according tothe listed torque values (see Wheel LugTorque Chart). Over-torqued and/orunder-torqued wheels may result incomponent failure.


38

SECTION 5RV TIRES

ELECTRICAL SYSTEM – 30 AMP

Your RV contains separate low voltage(12-volt DC) and high voltage (120-volt AC)electrical systems. All installations have beenmade in compliance with the safetyrequirements of ANSI standard A.1192,National Electric Code and CanadianStandards Association Code. Because thewiring and circuitry is engineered into adedicated system specific to your RV, werecommend you do not make unauthorizedchanges or add fixed appliances yourself.Only a qualified RV technician should attemptto make changes or additions to the electricalsystem. Approved materials, components andmethods of installation must be used to meetsafety and code requirements. Changes oradditions made to your RV may create ahazardous condition.

ELECTRICAL SYSTEM PRECAUTIONS Careless handling of electrical componentscan be fatal. Always take the appropriatesafety precautions when working around theRV electrical system.

0 Use caution when using metal toolsaround the RV electrical system. If a toolcontacts a battery terminal or metalconnected to it, a short circuit could occurwhich could cause personal injury,explosion or fire.

0 Remove your rings, metal watchbandsand any other metal jewelry beforeworking around the RV electrical system.

0 Never touch or use electrical componentswith bare feet, wet hands or while standing in water or on wet ground.

0 NEVER allow children to play with theelectrical system or components.

Always make sure the electrical componentsare turned OFF before disconnecting theauxiliary battery (customer supplied). Alwaysdisconnect the power cord and auxiliarybattery negative cable from the battery beforeworking around the RV electrical systems.

IN CASE OF AN ELECTRICAL FIRE

1. Execute your family safety plan.

2. After everyone is clear and accounted for,if possible:

a. Disconnect the shore line power cordfrom the external power source.

b. Disconnect the auxiliary battery cables(if applicable).

c. Turn OFF the generator (if applicable).

3. Check the fire to see if you can attempt toput it out with the fire extinguisher. If thereis any doubt, call the local Fire Departmentfor emergency assistance.

4. Do not touch any electrical wires orappliances.

If you feel the fire was caused by a productfailure you must contact Jayco CustomerService for approval before you clean anydebris, enter, move or repair the RV (failure tonotify Jayco may result in loss of coverage).

Always have faulty or damaged wiring andelectrical components repaired before usingyour RV again.

120-VOLT AC SYSTEM

39

SECTION 6ELECTRICAL SYSTEM – 30 AMP

WARNINGDo not attempt to use water to put out anelectrical fire. Water can spread sometypes of fire, and electrocution is possiblewith an electrical fire.

WARNINGMake very certain the external powersource (30 amp systems only) you connectthe power cord to is a 30 amp/120-volt ACRV receptacle and not 240 volt AC.

Your RV is equipped with a 120-volt AC/30 amp power cord and load center. A maximumof 30 amps of power can be consumed at anygiven time. It may be necessary to staggerusage of some appliances to maintain yourpower usage at 30 amps or lower. The 120-volt AC system provides power to most of theappliances and all of the electrical outlets.

120-VOLT CIRCUIT BREAKERSThe circuit breaker panel protects the 120-voltelectrical system from overloads, shorts in thewiring and shorts in the connectedcomponents. When an overload or shortoccurs, the circuit breaker will open (or “trip”)preventing any further flow of electricity anddamage to the RV.

If a circuit breaker has been tripped, shut OFFthe connected appliance (i.e., air conditioner,microwave, etc.) and allow a brief coolingperiod. Then reset the circuit breaker bymoving the appropriate switch OFF and backON. If the circuit breaker is continually trippedand no overload is evident, contact your dealer to have the electrical system tested andrepaired.

A circuit breaker identification label ispermanently attached to the inside surface ofthe 120-volt load center.Circuit breakers willnot offer complete protection of the RVelectrical system in the event of a power surgeor voltage spike.

MaintenanceAt the beginning of camping season, inspectall the breakers. Turn each breaker OFF andback ON. Have the circuit breakers replacedas needed.

Replacement

Please contact your RV dealer for repairassistance when replacing circuit breakers.

30 AMP POWER CORDThe 30 amp power cord is also commonlyreferred to as the “shore line power cord.” Thispower cord is designed to ground the RVelectrical system through the external powersource receptacle. It is also designed to carry30 amps at a nominal 120 volts.

Occasionally the electrical service provided by a campground may experience low or highvoltage (i.e., surges or spikes). Any prolongedexposure will shorten the life of the electricalsystem and appliances. Consult your dealerfor recommendations on power surgeprotection.

Connecting the power cordAlways test the 30 amp external power source(i.e., the campsite power box or electrical box)with a ground monitor, before connecting yourpower cord to it. If the ground monitor indicates ‘reverse polarity’ or an ‘open ground’ DO NOTconnect the power cord.

1. Turn OFF the load center main 120-voltcircuit breaker.

2. Carefully extend the entire length of thepower cord (approximately 25’ - 35’) fromthe electric cable hatch to the externalpower source.

3. Plug the power cord into the receptacle. Be sure all the power cord prongs are properly plugged into the receptacle.

4. Return to your RV and turn ON the loadcenter main circuit breaker.

5. To help prevent power surges fromdamaging the connected loads, pleasefollow these instructions when hooking upto the external power source:

The shore line power cord should beunplugged when the RV is left unattended.If something would happen to the electrical system, this may help limit potentialdamage.

40


WARNINGReplacement circuit breakers must be ofthe same voltage, amperage rating andtype. Never use a higher rated replacement circuit breaker; doing so may cause a fireby overheating the RV wiring.

When you are ready to leave, reverse thepower cord connection process. Use care toprevent damaging the power cord electricalconnection pins when connecting ordisconnecting the shore line power cord.Grasp the plug to remove from the outlet; donot unplug by pulling on the cord. Be sure toclose the electric cable hatch to prevent waterleaks.

MaintenanceInspect the power cord for cuts, cracks andworn insulation. Have the power cord replaced immediately if these symptoms are noticed.

CONVERTERThe converter converts 120-volt AC power touseable 12-volt DC power when the powercord is connected to campground power. Theconverter has a built-in protective thermalbreaker that will shut down the converter if itbecomes overheated. Overheating can becaused by operating the converter above itsmaximum limit for an extended period of timeor by an obstruction to its ventilation. A portionof the RV 12-volt load (lights or motors orboth), should be turned OFF to reduce the total load. Remove any obstructions to theconverter cooling fins or fan.

Inspection and maintenanceIf the converter is not working (or the auxiliarybattery is not charging, if so equipped), checkthe reverse polarity fuse(s) located in the12-volt fuse panel. There are no customerserviceable parts in the converter. If theconverter box is opened, it will void the OEMwarranty. If you have further concerns contactyour dealer.

GFCI RECEPTACLE OUTLETGrounding is your personal protection fromelectrical shock. Your RV has a ground faultcurrent interrupter (GFCI) receptacle outletengineered into the 120-volt AC electricalsystem. It may have additional outlets wiredthrough, and protected by, the GFCI. Itsfunction is to reduce possible injury caused byelectric shock. The GFCI will not protectagainst short circuits or overloads.

41


WARNINGPLUG INTO 30-AMP SERVICE ONLY.

0 Do not hook up the 30-amp power cordto any receptacle until you have verified proper polarity and grounding. Polarityindicators can be purchased in mostelectrical and hardware stores.

0 Do not use any cheater plug, adapter or extension cord to reduce incoming ACpower or break the continuity of thecircuit connected to the grounding pin.

0 Do not connect the power cord into anoutlet that is not grounded, or adapt the30-amp power cord plug to connect it to a receptacle for which it is notdesigned.

0 Do not remove the grounding pin toconnect to a non-grounded receptacle.Removal of the ground pin disables animportant safety feature designed toprevent shock and electrocutionhazards.

0 Do not connect the power cord to anextension cord. Use of an improperextension cord will cause overheatingof the cord as well as potentiallycausing premature failure of the ACequipment.

It is the responsibility of the owner of theelectrical receptacle to ensure that thereceptacle is properly wired and grounded.Reverse polarity and/or impropergrounding of your RV can cause personalinjury or death.

WARNINGThe power cord must be fully extendedwhen in use and not left coiled in theelectrical compartment or on the ground. Ifthe power cord is left coiled, it maypotentially create enough heat to melt itsprotective casing.

Test all GFCI receptacles monthlyThe 120-volt AC electrical system must be onin order to test the GFCI.

1. Plug a 120-volt AC electrical device intothe GFCI receptacle outlet.

2. Push and release the RESET button (the120-volt AC electrical device shouldoperate normally).

3. Push in the TEST button.

4. The RESET button should pop outindicating the GFCI receptacle has been“tripped” and the 120-volt AC electricaldevice should cease to operate.

5. Push in the RESET button again and itshould hold. If the GFCI did not trip, do notuse the GFCI receptacle outlet or thosewired to it. Call your dealer for repairassistance if it does not hold and popsback out. Any faulty equipment must berepaired before your RV is used again.

Although your RV’s exterior power receptacle(if so equipped) is not a GFCI receptacleoutlet, it is wired through and protected by theinterior GFCI.

CALCULATING ELECTRICAL LOADWhen you purchase and use 120-voltappliances, remember your RV is limited to amaximum load of 30 amps. When campingand traveling, remember each appliance and120-volt accessory places a load on the RVelectrical system. You may periodically trip acircuit breaker if the combined load of theseappliances and accessories exceeds your 30amp rating.

You can determine the amperage rating of anappliance by dividing the watts used (usuallyfound on a label or plate affixed to theappliance) by your RV’s supply voltage.

For example: 1200-watts divided by120-volts AC equals 10-amps.

12-VOLT DC SYSTEMThe majority of your RV lighting is powered by12-volt electricity. The 12-volt DC system iscomposed of components that will operatewhen the following conditions are met:

0 Power is supplied by the tow vehiclealternator when the engine is running andthe 7-way trailer plug is connected. Thispowers the RV’s running lights, brakelights, turn signals and brakes.

In addition, the 7-way trailer plug providesa common ground and a 12-volt chargeline to charge the auxiliary battery.

0 The converter will supply interior 12-voltDC power when the power cord is pluggedinto campground power. The converter will also charge the auxiliary battery in mostsituations.

0 The auxiliary battery powers many interior12-volt components including the lightingfixtures, water pump, 12-volt motors,12-volt appliances, etc. It also powers thebreakaway switch.

AUXILIARY BATTERY (CUSTOMER SUPPLIED)Your RV has many 12-volt DC loads. Whencombined, their total is more than theconverter can produce. High demands for12-volt power can be met by an auxiliarybattery for limited periods of time. The 12-voltDC electrical system is designed for usagewith a Group 27, deep cycle battery.

Dry campingConsider the charge condition of the auxiliarybattery when dry camping. If the auxiliarybattery is not being recharged and power isbeing drawn from it, it will eventuallydischarge. A battery will discharge at a fasterrate as its energy level becomes depleted. It isrecommended you plan your electrical usageaccordingly. For accuracy, test the auxiliarybattery voltage using a volt-ohm meter(customer supplied).

A fully charged auxiliary battery will read 12.7volts DC and 1.265 specific gravity at 80°F

42


(32°C). The auxiliary battery is considereddischarged at 11.8 volts DC by electronicstandards; when voltage drops below thoselevels, permanent damage may occur.Typically, a deep cycle battery has anamp-hour rating of 75-100 amps. If you run thefurnace and refrigerator simultaneously, youwill be using approximately (12.0 + 3.0) 15.0amps per hour. This does not include any12-volt lights, water pump or any other 12-voltcomponent.

If the furnace and refrigerator in theabove example operated constantly, a75 amp-hour battery would becomefully discharged in 5 hours (75ah / 15a= 5h).

The auxiliary battery should be installed inparallel with the battery in your tow vehicle.When the 7-way trailer plug is connected, bothbatteries power the RV so it is important not todischarge your tow vehicle battery below thelevel required to start the engine. To preventthis from occurring, disconnect the 7-waytrailer plug or install a battery isolator. Whenthe tow vehicle engine is operating with the RV connected, the tow vehicle charging systemwill charge both batteries.

Replacement and maintenanceSome equipment in your RV will draw smallamounts of current even when turned OFF. Toprevent the auxiliary battery from beingdischarged when your RV is not connected toshore line power, disconnect the auxiliarybattery negative cable at the battery. Duringstorage, it is important to check the voltagemonthly and recharge the auxiliary battery asneeded. If you remove the auxiliary batteryfrom your RV, store it in a dry, cool area per the OEM instructions.

When it is time to replace the auxiliary battery,replace it with a Group 27 deep cycle batteryonly. Contact the battery OEM for furtherinformation. Do not reverse the positive andnegative battery cables (doing so will blow thereverse polarity fuse(s) that protect theconverter).

BATTERY ISOLATOR FOR YOUR TOWVEHICLE (CUSTOMER SUPPLIED)You may want to consider the installation of abattery isolator on your tow vehicle as aconvenience feature:

0 It receives current from the tow vehiclealternator and controls distribution ofenergy to both the auxiliary battery and the tow vehicle battery.

0 It serves as a check valve to preventenergy from being drawn from your towvehicle chassis battery (so you can startyour tow vehicle engine).

Your dealer can assist you with the selection,purchase and installation of this aftermarketpart.

12-VOLT FUSE PANELThe 12-volt fuse panel is labeled to indicatethe fuse sizes, positions and componentspowered. At the beginning of camping season, inspect all the 12-volt fuses and replace asneeded.

Replacing a fuse

Before replacing a fuse, always turn OFF theelectrical component(s) protected by it.

1. Disconnect the power cord.

2. If so equipped, disconnect the auxiliarybattery negative cable at the battery.

3. Remove the fuse panel cover to checkfuses.

4. Pull the fuse straight out of the fuse block.If the fuse is not blown, something elsemust be causing the problem. Pleasecontact your dealer for further assistance.

43


WARNINGReplacement fuses must be of the samevoltage, amperage rating and type. Neveruse a higher rated replacement fuse; doingso may cause a fire by overheating the RVwiring.

5. Insert a new fuse of the same specifiedvoltage, amperage rating and type in theoriginal location. Never use a higherrated replacement fuse.

The fuse panel label should be keptpermanently affixed to your RV. The fuses willnot offer complete protection of the RVelectrical system in the event of a power surgeor spike.

12-VOLT DC OUTLET (IF SO EQUIPPED)There may be a 12-volt DC outlet (notapplicable on all models) in your RV. When the12-volt DC outlet socket is used as a powersource for an electric appliance, make surethat the electric appliance operates at 12-voltsand has an electric capacity of 60 (5 amps)watts or less. Cap the 12-volt DC outlet when it is not in use as the socket might becomeclogged by foreign material and becomeshort-circuited.

44


PLUMBING SYSTEM

There are two different water systems in yourRV: the fresh water system and the wastewater system. The fresh water system consists of the fresh water holding tank, fresh waterconnections, water pump, outside showerassembly (if so equipped), water heater,faucets, shower or tub, and water purificationsystem (if so equipped). The waste watersystem consists of the waste water holdingtank, sewage holding tank, drains and toilet.

Recreation vehicles shake and vibrate whilegoing down the road. It is possible forplumbing fittings to come loose. Check allfittings, pressure and waste, for leaks beforeeach trip or before vehicle storage as part ofyour normal maintenance:

0 Inspect all faucets, the water purificationsystem (optional) and sink connections(including drain baskets or filters).

0 Remove the access panels. If soequipped, inspect the shower faucetfittings and shower drain lines.

0 If so equipped, inspect connections at thewater pump and water heater.

At the end of every trip, you should drain anyunused water from the fresh water system.

There are labels affixed to the exterior of theRV’s sidewall that indicate the locations of thewater system drains and fills. Be aware somedrains may be located inside the RV (once theexterior label is found, go inside to find thedrain corresponding location).

THE FRESH WATER SYSTEMAll water contains contaminant and mineralparticles that can cause fresh water systemodors. Untreated well water is a major sourceof water system odors. The fresh water (orpotable water) system needs periodicsanitization and winterization to take care of all the components within the plumbing systemand help discourage the growth of bacteriaand other organisms that can contaminate thewater supply.

MONITOR PANELThe interior wall-mounted monitor panelallows you to monitor the fresh water, greywater, black water and auxiliary battery levels.These functions are controlled using the “tact”switches located on the monitor panelfaceplate. The monitor panel operates on12-volt DC power supplied by either theconverter or auxiliary battery. Sensorsinstalled in the holding tanks connect to aresistor assembly (relaying an electronicmessage to the display board). No power isdrawn from the battery unless a switch ispushed or turned ON. Fuses for the monitorpanel are located in the load center. Refer tothe OEM operator’s manual for furtherinformation.

OperationPress only one “tact” switch at a time. As youpush either the “FRESH”, “BLACK” or“GREY1” switch, one or more LED lights willilluminate indicating that holding tank contentlevel. When pushing the “BATT” switch, thehighest LED light illuminated indicates theestimated auxiliary battery condition.

C = charge at 12.7 voltsG = good at 12.1 voltsF = fair at 11.6 voltsL = low at 6.0 volts

Water pump switch (optional)When the water pump switch is ON the waterpump runs until 45 pounds of pressure hasbeen achieved. The red light will stay ON. Turn the water pump switch OFF when it is not inuse.

Water heater switch (optional)The “propane GAS” water heater switchenables propane operation of the water

45

SECTION 7PLUMBING SYSTEM

WARNINGDO NOT drink water deemedmicrobiologically unsafe or of unknownquality.

heater. The “ELECTRIC” water heater switchenables electric operation of the water heater.

FRESH WATER HOLDING TANKThe fresh water tank can be filled by pressurefilling through the fresh water inlet (called citywater) or by gravity fill. There are plasticoverflow tubes plumbed into the fresh waterholding tank. They allow water to flow out ofthe water tank. Occasionally, you may seewater coming from the overflow tubes (locatedunderneath the RV) when the fresh waterholding tank is filled. This is normal, and iscaused by external circumstances, includingthe RV being parked on an incline, or themotion caused by starting or stopping the RVduring travel.

Do not cap, block or modify the fresh watertank overflow tubes in any way. Enough waterpressure can build up during the filling process to damage the plumbing system if the overflowtubes are obstructed.

FRESH WATER CONNECTIONS

There are two types of direct exterior freshwater connections in your RV: city water andgravity fill.

To use the city water fill1. If needed, sanitize the water system.

2. Move the "water heater bypass valve" tothe NORMAL position.

3. Remove the connection cap and attach anon-toxic drinking water hose to the inlet.

4. Turn ON the water at the water source.

5. Enter the RV and open the cold watersupply faucets to bleed air from the waterlines.

6. The water heater will fill first, followed bythe supply lines and faucets.

When the water lines are nearly full, youmay experience some “air pockets.” Allowthem to escape before closing the coldwater supply faucets.

The fresh water connection should beunplugged (i.e., the non-toxic drinkingwater hose disconnected) when the RV isleft unattended for any amount of time. Ifsomething would happen to the watersystem, this may help limit water damageto a smaller area.

To disconnect the city water fill7. Shut OFF the water at the water source.

8. Disconnect the non-toxic drinking waterhose and reinstall the connection cap.

To reduce the chance of contamination,prevent the non-toxic drinking water hose from coming into contact with the ground. Reinstallthe connection cap when the fresh waterconnection is not being used. Do not removethe following label from your RV:

46


WARNINGNever leave the RV unattended while fillingthe fresh water system.

City Water Gravity Fill

Fig. 7.1 Fresh water connections

WARNINGPOTABLE WATER ONLY. SANITIZE,FLUSH AND DRAIN BEFORE USING.SEE INSTRUCTION MANUAL.FAILURE TO COMPLY COULDRESULT IN DEATH OR SERIOUSINJURY. AD-04

Fig. 7.2 Potable water only label

Dry campingYou can gravity fill the fresh water system ifyou do not have access to city water; however,allow extra time to fill the fresh water system ifyou are using this method. Follow the stepslisted above; however, at step 3 put the otherend of the non-toxic drinking water hose intoyour container of fresh water, and turn ON thewater pump (instead of turning ON the water at the water source). When the fresh water tankis full, shut OFF the water pump anddisconnect the non-toxic drinking water hose.

WATER PRESSURE REGULATOR(CUSTOMER SUPPLIED)

Excessive pressure from water supplysystems may be encountered in some parks,especially in mountain regions. Waterpressure regulators are available to protectyour system against such high pressure. Aregulator of this type is recommended toprevent damage to the plumbing system orcomponents. Water pressure regulators(customer supplied) are available from yourdealer to protect the RV plumbing systemagainst such high pressure.

12-VOLT WATER PUMP & SWITCH(IF SO EQUIPPED)Once activated, the water pump (also knownas the on-demand pump) will self-prime, andprovide water. The water pump continues torun until approximately 45 lbs. of pressure isachieved and shut off. The water pump willautomatically re-start when pressure drops.Some cycling may occur, depending on thevolume of water being released. The waterpump is engineered by the OEM with a check

valve to prevent water from back flowing intothe fresh water supply tank

The water pump switch should be in theOFF position when the RV is leftunattended for any amount of time. Ifsomething would happen to the watersystem, this may help limit water damageto a smaller area.

Dry campingWhen you want to use water in your RV andthe RV is not hooked up to city water, you willneed sufficient 12-volt DC power to run thewater pump.

WATER HEATER

The water heater is designed to heat waterquickly and efficiently. The water heatermanufacturer has preset the sensing limit tomaintain the water temperature when thewater heater is activated. Hydrogen gas in thewater lines may result if you have not used thewater heater for two weeks or more. To reducethe risk of injury under these conditions, openthe hot water faucet for several minutes at thekitchen sink before you use any electricalappliance connected to the hot water system.If hydrogen is present, you probably will hearan unusual sound such as air escapingthrough the pipe as the water begins to flow.Hydrogen gas may be present even afterwater has been drained from the tank. Openthe sink faucet at the sink and allow system tovent for five to ten minutes (or as needed).

47


WARNINGDo not replace any component part with anaccessory part that is not authorized by thewater heater manufacturer, such as an“add-on” electric heating element. Suchitems are not approved to be installed andcould create an unsafe condition and willvoid all warranties.

CAUTIONNot using a water pressure regulator whenusing city water may cause the o-rings tofail. To prevent damage to the plumbingsystem or components when using the citywater connection, a water pressureregulator rated for 40 lbs. is recommended.

Odor from the hot water systemMany water supplies contain sufficientamounts of sulfur to produce an odor, oftencalled “sulfur water.” Sulfur water can becaused by a chemical action or by bacteria.Generally, sulfur water is not harmful, onlyunpleasant to smell. To eliminate sulfur water(or bacteria) sanitize the water heater. Odorfrom sulfur water is not a service problem.

High altitude derationOperation of the water heater at high altitudesmay require derating. Consult with your localpropane gas company, dealer or the waterheater OEM for proper derating of the waterheater. Change out of the orifice (derating)should be done by your dealer or a serviceagency authorized by the water heatermanufacturer. It is important that once the RVhas returned to lower elevation any highaltitude deration or other adjustments bereversed for proper operation of the waterheater.

Pressure & temperature relief valveWhen cold water is heated in the water heatertank, the water pressure will rise. For thisreason, a pressure and temperature (P&T)relief valve is required for safety in all waterheaters. It is normal for the P&T relief valve torelease a small quantity of water during theheating cycle and does not indicate a defective P&T relief valve. One way to reduce thefrequency of the water weeping or drippingfrom the P&T relief valve is to maintain an airpocket at the top of the water heater. This airpocket will form in the tank by design;however, it will be reduced over time by theeveryday use of your water heater (refer to theOEM manual); If the weeping persists, consult

your dealer or a service agency authorized bythe water heater manufacturer.

Operating instructions

STOP! Read the safety and operatinginformation provided in the OEM operator’smanual before attempting to activate the water heater. Make sure the water heater is filledwith water before use; momentary operation of the water heater without water in it can bedetrimental.

Draining and winterizationIf the RV is to be stored over the wintermonths, the water heater must be drained toprevent damage from freezing. It isrecommended the water heater be drainedand bypassed during the winterization process particularly if introducing RV antifreeze into the plumbing system.

Water heater bypassUse the factory installed water heater bypass,available in most floor plans, to avoid filling theentire water heater with RV antifreeze.

To bypass the water heater close valves A andB, and open the mixer valve (valve C). Fornormal camping usage of the water heater,reverse these instructions.

48


WARNINGIf you smell propane gas then STOP! andfollow the procedures listed in Sec. 3Propane System before attempting tooperate the water heater.

FRESH

WATER

TANK

AN

TIF

RE

EZ

E

E

D

PUMP

HO

T

CO

LD

C

B

A

WATER

HEATER

Fig. 7.3 Water heater bypass

WARNINGHYDROGEN GAS IS EXTREMELYFLAMMABLE. Do not smoke or have anyopen flame near the open faucet. On DSIwater heater models make sure the interiorcontrol switch is OFF during the abovelisted procedure.

Water heater switch (optional)The "propane GAS" water heater switchenables propane operation of the waterheater. The "ELECTRIC" water heater switchenables electric operation of the water heater.

OUTSIDE SHOWER (IF SO EQUIPPED)A handheld shower assembly with both hotand cold water is available for washing orrinsing outside the RV. Be sure the waterheater is ON and had sufficient time to heat the water.

Open the door with the key and allow it tohinge down.

1. If dry camping, besure the 12-voltwater pump is ON.

2. Remove the handheld showerheadand hose from itsholder and turn ONthe sprayer headvalve.

3. Open the faucetknobs and adjustthem to the desiredtemperature.

To cease operation, close the faucet knobsand the showerhead valve. After the water hasbeen allowed to drain from the showerhead,replace it in the outside shower compartment.Any remaining water in the shower hose willdrip or run out of the vacuum breaker; this isnot a leak but performs as intended. Water willdrain out along outer edge of the ABS plasticbox.

The showerhead can be removed to drain thehose faster. If you choose to remove theshowerhead to drain the hose, reassemble itfor storage. Coil the hose and arrange it withthe showerhead inside the faucet assembly.Make sure that the hose is not being pinchedand the showerhead is not being damagedwhen the door is closed. For sanitary reasons,

keep the exterior shower compartment doorclosed when not in use.

FAUCETSThe faucets operate much the same way asthe faucets in your home. Make sure there issufficient water available and, if dry camping,the 12-volt water pump is turned ON beforeoperating. To open the faucets, turn the hotand cold knobs ON and adjust the temperature to your comfort level. Close the faucets when a sufficient amount of water is released.

The shower faucet (if so equipped) requires avacuum breaker when the shower hose andhead are used. There are two purposes for this breaker:

0 To prevent siphoning water through thehose from another fixture.

0 To prevent water from being contained inthe hose.

The showerhead DOES NOT have a completeshut-off valve (the complete shut-off is at thefaucet). The showerhead may drip slightly inthe OFF position after use; this is normal anddoes not indicate a leak or defect. There maybe air in the plumbing lines that will need to bebled out before a steady stream of watercomes from the faucet.

BATHROOM SHOWER OR TUB Your bathing facilities in the RV function similar to those in your home. Prepare the bath orshower curtains to prevent water from spillingonto the floor. Keep the water heater andholding tank capacities in mind when using the fresh water system. Long showers are notsuggested due to the limited amount of wateravailable. The used water will drain through

49


Fig. 7.4 OutsideShower

WARNINGWater temperatures over 125°F (49°C) cancause severe burns instantly or death fromscalds; therefore, be careful when using hot water. Always test the water temperaturebefore showering or washing.

the plumbing pipes into the grey water holdingtank.

1. Be sure the water heater is ON and hadsufficient time to heat the water.

2. If dry camping, be sure your 12-volt waterpump is ON.

3. Adjust the hot and cold faucets to thedesired temperature before bathing.

4. To conserve water while showering, wetdown and turn the water OFF while youuse soap, then rinse.

5. When you are finished, shut the waterfaucets OFF.

Unlike your home, the RV does not contain awater pressure balance valve. If someone isusing the shower, it is recommended that thefresh water system NOT BE USED until he orshe is finished.

MaintenanceRead the OEM operator’s manual. The tub and shower walls (if applicable) in your RV aremade of ABS plastic material. Use a milddetergent soap and warm water to clean(these cleaning instructions are similar tothose recommended for fiberglass tubs andshower walls). Contact your RV dealer forrepair or replacement.

DO NOT use gritty or abrasive particle soapsor scouring compound to clean ABS plastic.Avoid using “Citrus” or biodegradable cleaners which contain “D-Limonene.” They willdamage plastic materials.

WATER PURIFICATION SYSTEM(IF SO EQUIPPED)The water purification system is located underthe kitchen sink. If the water supply has notbeen used for some time, allow the water toflow for several minutes to flush the system.When not in use, the water filter cartridgeshould be stored out of freezing temperatures.RV antifreeze will damage the water filtercartridge. The OEM has supplied a clearplastic bypass hose with fittings on either end

to replace the water filter cartridge when theRV is being winterized. This clear plasticbypass hose is re-usable; store it when it is notin use.

Each new RV is winterized with RV antifreezebefore it leaves Jayco, Inc. To use the waterpurification system the clear plastic bypasshose must be removed and the water filtercartridge installed.

Replacing the water filter cartridgeFollow the instructions on the water cartridgefilter. Replace the water filter cartridge whenwater flow from the kitchen faucet is too slowfor convenience, or at least once a year.

1. Drain the fresh water system.

2. Place a container beneath the watercartridge filter to catch any spillage.

3. Unscrew the fittings at the top and bottomof the water filter cartridge. Pull the waterfilter cartridge down and out of the fittings.

4. Insert the new water filter cartridge andtighten the fittings securely by hand.Dispose of the used water cartridge filter.

DRAINING THE FRESH WATERSYSTEMOpen all faucets, including the outside showerfaucet (if so equipped).

1. Open the “exterior fresh tank drain” valve on thepermanent fresh waterholding tank (if soequipped). This knobturns 45° to open orclose.

50


Fig. 7.5Exterior fresh water drain

2. Open the “low pointdrains.” As theirname indicates, thevalves will be at thelowest point of waterlines. A label may beplaced on the outside of the RV to indicatewhere the drains arelocated. The drains will typically need to be opened from inside the trailer. Once thelabel is found on the outside of the trailer,go inside to find the corresponding location of the drains.

3. Turn ON the water pump and allow it to runas needed.

4. If so equipped, operate the toilet flush lever until water stops flowing.

5. Relieve the water pressure using the water heater P&T valve BEFORE removing thewater heater drain plug. Otherwise, if thereis any water pressure present the water will spray out of the opening when the drainplug is removed.

When you are finished draining the fresh water system, reverse these steps and, if soequipped, dump the grey and black waterholding tanks at an appropriate facility oraccording to local public codes.

SANITIZING THE PLUMBING SYSTEM

Potable water systems require periodicmaintenance to deliver a consistent flow offresh water. For your personal safety, theplumbing system should be sanitized whenyour RV is new, at the beginning and end ofeach season and when the water systembecomes contaminated (or approximatelyevery three months of use).

How to sanitize with a water pump (if soequipped)

1. Level the RV and drain the fresh watersystem.

2. Close the drain valves.

3. Prepare a chlorine solution using 1/4 cupof household bleach (sodium hypochloritesolution) to one gallon (3.785 liters) ofwater in a container. Prepare one gallon ofsolution for every 15 gallons of tankcapacity. This will result in a residualchlorine concentration of 50 ppm in thewater system.

If a 100-ppm concentration is required asdiscussed in step 9, use ½ cup ofhousehold bleach with one gallon of waterto prepare the chlorine solution. Onegallon of the solution should be used foreach 15 gallons of tank capacity.

4. Turn the "water heater bypass" valves tothe BYPASS position.

5. At the gravity fill connection, place a hoseinto the container with the chlorinesolution.

6. Turn the water pump ON.

7. After the recommended amount of solution is in the tank, turn OFF the water pump.

8. Turn the "water heater bypass" valves tothe NORMAL position.

9. Open the hot water line on all the faucetsuntil water begins to flow continuously anda chlorine smell is noticeable.

10. Close the hot water lines and repeat withthe cold water lines on the faucets.

51


WARNINGFailure to sanitize the potable water system could result in death or serious illness.

WARNINGChlorine is poisonous. Always recap thehousehold bleach bottle and clean utensilsand containers after use.

Fig. 7.6 Lowpoint drains

11. Let the solution remain in the system for atleast four hours when disinfecting with50-PPM residual chlorine.

If a shorter time period is desired, then a100-PPM chlorine concentration should be permitted to sit in the system for at leastone hour.

12. After the required period, drain the chlorine solution from the fresh water system (seeDraining the fresh water system).

Some solution may remain in the waterheater and will be flushed in the followingsteps:13. Fill the fresh water system completely full

using clean (potable) water.

14. Then, drain the fresh water system (seeDraining the fresh water system).

If a chlorine taste lingers in the water, flush thewater system with a solution consisting ofone-quart vinegar to five gallons of cleanwater. Re-flush as necessary.

WINTERIZING THE PLUMBINGSYSTEM

Preparing your RV for colder weather orstorage is very important for most states andCanada. Failure to prepare your RV maycause water supply lines and the water heaterto freeze. No commodity or product should beadded to the fresh water system to ensurefreeze protection other than RV antifreeze.The RV should be winterized at the end of thecamping season or when the RV will beexposed to temperatures that will fall at orbelow 32°F (0°C). Repairs due to freezing arenot warrantable.

There are two methods of winterizing yourtrailer based upon your model. Please read,

understand and follow all instructions beforebeginning.

Air pressure (all models)This method will utilize an air hose to blowexcess water from the water lines.

1. Make sure all holding tanks are empty anddrain valves OPEN.

2. Run the water pump until it is dry, this willtake approximately 15-20 seconds.

3. OPEN all faucets and drains, and the toilet.

4. Using an air hose and adapter (customersupplied), blow air through the city waterconnection. Any remaining water will blowout in five to ten minutes.

5. Pour one cup of non-toxic RV antifreezeinto all drain P-traps.

Water heater bypass (most models)It may be easier to winterize the RV withanother person to assist you.

1. Level the RV and drain the fresh waterplumbing system.

2. If so equipped, replace the water filtercartridge with the clear plastic bypasshose.

3. Make sure the water heater 12-volt and120-volt interior control switches are OFF.

4. Turn the water heater bypass valves to theBYPASS position.

5. Make sure the “fresh tank drain” and "lowpoint drains" are closed.

6. Insert the garden hose into a container ofRV antifreeze solution (this quantity should be enough to winterize the RV); attach theother end to the Gravity Fill.

7. Turn the water pump ON.

8. Open the hot water line on all the faucets(kitchen, lavatory, shower and outsideshower) until RV antifreeze begins to flowcontinuously.

9. Close the faucet hot water lines and repeat with the cold water lines on all the faucets.

52


WARNINGAutomotive antifreeze (ethylene glycol) and windshield washer antifreeze (methanol)are poisonous. Never use these products in your fresh water system. These productsare harmful and may be fatal if swallowed.

Do not forget to run RV antifreeze throughthe toilet.

When you are done adding RV antifreeze10. Remove the garden hose from the

container of RV antifreeze.

11. To prevent staining, wipe the RVantifreeze out of the sinks, shower (or tub)and toilet using a soft, dry cloth.

To reduce the chance of contamination,prevent the garden hose from coming intocontact with the ground. If needed, contactyour dealer for assistance.

BLACK/GREY WATER SYSTEM(IF SO EQUIPPED)Water from the sinks and shower flow into thegray water (or waste water) holding tank.Water from the cassette toilet (if so equipped)will flow into the sewage (or black water)holding tank.

Drain pipesThe drain pipes have a “P-trap” installed tohelp prevent odors from escaping into the RV.During travel, water from the P-traps may spilland permit odors into the RV. These odorscome from food particles decomposing in thetank. By adding water and using a RVapproved deodorizing agent you will dissolvethe contents faster and will keep the drain lines and tanks clean and free flowing. Thesechemicals are available at an RV supply storeor your dealer.

Vents

Another important part of this system is thevent pipes and vents that release air from thegrey and black water holding tanks. Theexterior vent cap is attached to the roof andmust be kept clear of obstructions to performas intended. On some models, the vent pipemay be part of the drainage system referred toas a “wet vent” (water flows downward as airflows upward in the same pipe).

BLACK/GREY WATER HOLDINGTANKS

The weight of the holding tank contents is notcalculated into the RV cargo carrying capacity(this extra weight would reduce your availablecargo capacity). Traveling with full holdingtank(s) could possibly cause you to exceed the individual tire ratings and/or the RV GAWR orRV GVWR. Potential damage to suspensioncomponents, such as springs, tires and axles,could result. If your RV holding tank(s) arelocated behind the axles, the weight of the fulltank(s) will reduce the hitch weight. Trailersway and other handling difficulties can be theresult of the hitch weight being too light.

Dump the gray and black water holding tanksbefore traveling to avoid carrying unnecessary weight. If you are dry camping and cannotimmediately empty your holding tanks, reduceyour vehicle speed until you reach a dumpingstation. When connected to the sewer drainline at a campground, keep the “black tankdrain” valve closed until the holding tank is atleast ¾ full. This should provide sufficientwater to assist in complete draining of theblack water holding tank. Repeat as needed.

Before using the RV or after dumping the greyand black water holding tanks, always add theproper amount of deodorant to the black watertank to prevent malodors and help break downholding tank contents (unless winterizing).Follow the deodorant bottle or packageinstructions. Driving to a disposal site willnormally loosen any accumulated waste

53


WARNINGNever travel with full black or grey waterholding tanks. This not only wastes yourfuel but depending on the location of thetank(s), it can affect your tow vehiclehandling characteristics.

debris or solids from the sides of the holdingtanks.

Never leave the black tank drain in the openposition continuously when connected to thecampground sewer system.

BLACK & GREY TANK DRAINSThere are labels on the exterior of the RVindicating the location of the grey tank drainand black tank drain (also called dump valves). Always drain the black water holding tank firstso the following grey tank waste water canhelp rinse any solids or debris from the dumpoutlet and sewer hose.

1. To make drainage easier, level the RV.

2. Remove the sewer hose housing dust cap,and attach the sewer hose (customersupplied).

3. Place the end of the sewer hose into theapproved dump station.

4. Open the black tank dump valve (close thedump valve when the black water holdingtank is emptied).

5. Open the grey tank dump valve (close thedump valve when the grey holding tank isemptied).

6. Remove, clean and store the sewer hose.

7. Close the sewer hose housing dust cap.

Most states and parks have strict laws andregulations to prohibit dumping of wastes ofany kind into anything other than properdisposal facilities or sewer systems. Almost allprivately owned parks offer a campsite hookup for sewage. You can locate many dumpstations throughout the United States andCanada in Woodall’s, Rand McNally CampGuide, Good Sam Camp Guide, KOAKampgrounds Camp Guide and various otherpublications. Some fuel stations also havedump stations.

Please contact your dealer for assistance inthe purchase and installation of a sewer hoseor sewer hose extension (if needed).

TOILET

The toilet is efficient and easy to operate.Generally, more water is required only whenflushing solids. Prior to using the sanitationsystem, it is strongly recommended to flushthe toilet several times to release sufficientwater into the holding tank. If there is not asufficient amount of water used duringflushing, the waste materials may notevacuate properly from the drain line to thetank. Clogged tanks and pipes couldeventually occur.

The toilet system will perform better whenwater is run for ten to fifteen seconds afterflushing to ensure that the waste will proceedto the bottom of the tank. Unlike a toilet in a

54


Fig. 7.7 Black & Grey tank dump valves

WARNINGIt is important to prevent solid wastebuildup. Follow the toilet manufacturer’srecommended instructions each time afteremptying the black water holding tank.

WARNINGDo not add automotive antifreeze or caustic chemicals such as laundry detergents intothe holding tanks. Although these productsmay have a deodorizing effect, they maydamage the plastic and rubber parts of theplumbing system or the components.

home, which uses four to seven gallons (18 -32 liters) of water per flush, the averagerecreation vehicle system uses one to threequarts (1 - 3 liters). For added convenienceand better sanitation system performance, it isadvisable to always have four to six inches (10- 15 cm) of water in the toilet.

To prevent help toilet blockage, always use RV grade single-ply toilet paper. Do not flushpaper towels, diapers, sanitary napkins orother foreign objects down the RV toilet.

Sewage (black) tank preparation

1. Release one to two quarts (1 or 2 liters) ofwater into the toilet bowl.

2. Follow the directions on your toiletchemical bottle (customer supplied), byplacing the recommended quantity ofholding tank chemical into the toilet bowl.

3. Flush the toilet and allow at least twogallons (8 liters) of water to flow into theholding tank.

Waste (grey) holding tank preparationNo special preparation is required, however,placing a small quantity of chemicals into thistank, such as baking soda or an approved RVchemical, will reduce odors from food particlesin the system.

Cleaning & MaintenanceThe toilet should be cleaned regularly formaximum sanitation and operationalefficiency. Do not use chlorine (undiluted) orcaustic chemicals, such as laundry bleach ordrain opening types, in the toilet system.These products damage the seals in toiletsand dump valves.

55


CAUTIONIt is important to add enough water toprevent solid waste buildup. Follow thedirections listed below and in the OEMoperator’s manual.


56


PROPANE SYSTEM

LP (liquefied petroleum) gas is a clean andefficient form of energy when proper handlingand safety precautions are observed. Itenables you to enjoy a comfortable lifestylewhen other forms of energy are not easilyaccessible. LP-gas includes propane, butaneand/or a mixture of both. Regulatory codesrequire you use propane only in your RV.

Propane is used as a fuel source for themajority of your appliances. The propanesystem is comprised of a propane container orcylinder, a two-stage regulator, hoses, pipingand tubing to deliver propane to eachappropriate appliance. If you have furtherquestions about the operation of theappliances or the propane system afterreading this Owner’s Manual and the OEMoperator’s manuals, contact your dealer or aqualified propane service technician.

Testing the propane system

Although both Jayco and your selling dealertest carefully for leakage, travel vibrations canloosen fittings. Continued maintenance isnecessary for safe operation. The propanesystem should be checked every 30 days ofRV use or 5,000 miles of travel (or at leastonce a year) as part of your normalmaintenance. The propane system testingshould only be performed by your dealer or aqualified propane service technician.

PROPANE SAFETY PRECAUTIONSPropane is a colorless and odorless gas that in the liquefied state resembles water. Anodorant (ethyl mercaptan) with a scent similarto rotten eggs is added as a warning agent. It is possible some individuals may be less

sensitive to the odorant used and not noticethe smell of propane.

If you do not smell the propane odorant (forexample, when filling the propane cylinder),notify your dealer or propane service providerimmediately.

Propane is flammable, is always containedunder pressure, and the liquid can freeze skin.Always wear protective clothing such asgloves and eye protection when the potentialfor contact with liquid propane is present. Ifyou smell propane gas within the RV, quicklyand carefully perform the procedure listed onthe label below. This label should be keptpermanently affixed to your RV.

It is important that everyone knows whereto find the propane cylinder manual shutoff valve, and understands to operate it.

57

SECTION 8PROPANE SYSTEM

DANGERNever use an open flame to test for apropane leak. Do not check for leaks using products that contain ammonia or chlorine;these products can cause cracks to form on the metal tubing and brass fittings.

WARNINGThe propane cylinder is equipped with asafety valve that relieves excessivepressure by discharging gas to theatmosphere. Do not bring or store portablepropane containers(s) or other flammableliquids inside the RV because a fire orexplosion may result.

IF YOU SMELL GAS

1. Extinguish any open flames, pilot lights and all smoking materials.

2. Do not touch electrical switches.3. Shut off the gas supply at the

container valve(s) or gas supply connection.

4. Open doors and other ventilating openings.

5. Leave the area until odor clears.6. Have the gas system checked

and leakage source corrected before using again.

FAILURE TO COMPLY COULD RESULT IN EXPLOSION RESULTING IN DEATH OR SERIOUS INJURY. 0173021

DANGER

Fig. 8.1 “If you smell propane” label

HOW TO LEAK TEST THE PROPANE SYSTEM

Use an appropriate propane leak detectorsolution or create a soapy water solution. Thepropane leak detector solution can bepurchased at most dealerships (if soapy wateris used, make sure that the soap used doesnot contain ammonia or chlorine). Apply thepropane leak detector solution to all propanepiping connections. If a leak is present, thesolution will bubble at the connections.

If a leak is detected1. Execute your family safety plan.

2. Turn off the propane at the cylinder(s).

3. Turn off all appliances that utilize propane.

4. Unplug the shore line power cord.

5. Disconnect the 12-volt auxiliary battery (ifso equipped).

6. Contact your dealer for a serviceappointment. Have the propane systemrepaired before using it again.

DOT PROPANE CYLINDER

Propane is stored in pressurized containers ina liquid state. As the propane is released fromthe container, it changes to vapor that is thenused for the operation of the appliances.

Propane will not run through the appliances inthe liquid state. The volume of liquid propaneincreases approximately 1-½% for every 10°F(5.5°C) it is warmed. Heat the propane 100°F(55°C) and the container liquid volume willincrease 15%. That is why it is imperative toleave sufficient space inside the cylinder toallow for natural expansion of gas duringwarmer weather.

The following label should be keptpermanently affixed to your RV.

The main shut off valve must be kept closed atall times unless you are using the propanesystem or filling the propane cylinder. Whenthe cylinder is disconnected from the hose,install the valve cover that is attached so thecontainer. This is required by the National FireProtection Agency (NFPA), other applicablelocal codes and for your own safety.

Close the propane cylinder main shut off valveby hand tightening only. Use of tools creates apotential to over tighten the valve (damagingthe interior seals on the cylinder valve seat). If

58


WARNINGDOT propane cylinders must betransported and stored in an uprightposition so the pressure relief device willfunction properly. Laying a DOT propanecylinder on its side may potentially create avery dangerous situation.

THIS PROPANE PIPING SYSTEM ISDESIGNED FOR USE WITHPROPANE ONLY. DO NOT CONNECTNATURAL GAS TO THIS SYSTEM.Securely cap inlet when not connectedfor use. After turning on propane, exceptafter normal cylinder replacement, testpropane piping and connections toappliance for leakage with soapy wateror bubble solution. Do not use productsthat contain ammonia or chlorine. JA-176

DO NOT FILL PROPANE CONTAINER(S)TO MORE THAN 80 PERCENT OFCAPACITY.FAILURE TO COMPLY COULD RESULTIN A FIRE OR PERSONAL INJURY.

WARNING

CAUTION

Fig. 8.2 “Do not fill to more than80%” label

WARNINGIT IS STRONGLY RECOMMENDED THAT YOU HAVE A PROFESSIONAL TESTTHE RV PROPANE SYSTEM FOR LEAKS ONE TIME EACH YEAR AS PART OFNORMAL MAINTENANCE.

this type of damage occurs, the cylinder willnot close properly and create a false sense ofsecurity.

The following label should be keptpermanently affixed to your RV.

Servicing or filling

Have the RV checked for leaks at theconnections on the propane system soon afterthe purchase and the initial filling of each

propane cylinder. When you have a newcylinder filled for the first time, make sure yourpropane supplier purges your new cylinder oftrapped air. Otherwise, an improper mixture ofgas and air will make it impossible to light yourpropane appliances.

When a propane container is low, occasionallythere may be a concentration of an onion orgarlic-like odor, which can be mistaken for apropane leak. After a propane cylinder hasbeen refueled, the odor will usually disappear.If not, turn OFF each propane cylinder shut offvalve and have the propane system inspectedby your dealer or a qualified propane servicerepresentative.

No one should be inside and only the qualifiedpropane service technician should be near theRV while the propane tank is being filled. Thenew propane container must be carefullypurged for best performance and must NEVER BE OVERFILLED. The following label shouldbe kept permanently affixed to your RV.

Before filling your propane cylinder, make sure that the propane technician is qualified (knowsand understands proper inspection and safetyprocedures).

The position of the propane container(s) andthe hoses are critical to proper operation andpropane flow. Follow these instructions tomake sure your propane container(s) areconnected properly.

59


WARNINGTHIS SYSTEM IS DESIGNED FOR USE WITH PROPANE ONLY.

BEFORE TURNING ON PROPANE:(A)

(B)

(C)

(A)

(B)

BE CERTAIN APPLIANCES ARE CERTIFIED FOR PROPANE AND ARE EQUIPPEDWITH CORRECT BURNER ORIFICES.

MAKE CERTAIN ALL PROPANE CONNECTIONS ARE TIGHT BY TESTING WITHSOAPY WATER, ALL APPLIANCE VALVES ARE TURNED OFF, AND ANY UN-CONNECTED OUTLETS ARE CAPPED.

LIGHT ALL PILOTS.

ALL CONNECTIONS, INCLUDING THOSE AT THE APPLIANCES, REGULATORS,AND CYLINDERS, SHOULD BE LEAK-TESTED PERIODICALLY WITH SOAPY WATERBY THE OCCUPANT. NEVER USE A LIGHTED MATCH OR OTHER FLAME WHENCHECKING FOR LEAKS.

DO NOT LEAVE SYSTEM TURNED ON OR CONTAINERS CONNECTED UNTIL THESYSTEM HAS BEEN PROVEN TO BE FREE OF ANY LEAKS.

COOKING APPLIANCES SHOULD NOT BE USED FOR SPACE HEATING

WHEN THE CONTAINERS ARE DISCONNECTED, THE PROPANE SUPPLY LINESHOULD BE CAPPED OR PLUGGED.

(D)

(E)

AFTER TURNING ON PROPANE:

AVERTISSEMENTCETTE INSTALLATION EST CONCUE POUR LE PROPANE SEULEMENT.

AVANT LA MISE EN SERVICE:(A)

(B)

(C)

(A)

(B)

(D)

(E)

APRÈS LA MISE EN SERVICE:

S’ASSURER QUE LES APPAREILS SONT CERTIFIÉS POUR LE PROPANE ET MUNISD’ORIFICES DE BRÛLEUR APPROPRIÉES.

VÉRIFIER L’ÉTANCHÉITÉ DE TOUS LES RACCORDEMENTS AU PROPANE, LAFERMETURE DE TOUS LES ROBINETS D’APPAREILS ET L’OBTURATION DETOUTES LES SORTIES NON RACCORDÉES.

ALLUMER TOUTES LES VEILLEUSES.

L’OCCUPANT DOIT ÉPROUVER PÉRIOIQUEMENT L’ÉTANCHÉITÉ DE TOUS LESRACCORDEMENTS, Y COMPRIS CEUZ AUX APPAREILS, AUX DÉTENDEURS ETAUX BOUTEILLES, EN Y APPLIQUANT DE L’EAU SAVONNEUSE. NE JAMAIS SESERVIR D’UNE ALLUMETTE OU AUTRE FLAMMES POUR LA DÉTECTION DESFUITES.

NE PAS LAISSER L’ALIMENTATION OUVERTE, NI LES RÉCIPIENTS RECCORDÉS,AVANT D’AVOIR COMPLÉTÉ L’ÉPREUVE D’ÉTANCHÉITÉ AU PROPANE DEL’INSTALLATION.

LES APPAREILS DE CUISSON NE DOIVENT PAS ÉTRE UTILISÉS POUR LECHAUFFAGE DES LOCAUX.

LORSQUE LES RÉCIPIENTS SONT DÉCONNECTÉS, L’ALIMENTATION DE PROPANEDOIT ÊTRE OBTURÉE OU SCELLÉE. JA-105

DO NOT CONNECT NATURAL GAS TO THIS SYSTEM.

NE PAS L’ALIMENTER EN GAZ NATUREL.

Fig. 8.3 “Use propane only” label

WARNINGBefore entering a propane or fuel servicestation make sure all pilot lights areextinguished. Shut off gas to all appliancesby closing the propane gas main shut offvalve. Always shut OFF any engine beforerefueling. Do not smoke and do not operateother ignition sources while refueling.

DANGERALL PILOT LIGHTS, APPLIANCESAND THEIR IGNITORS (SEEOPERATING INSTRUCTIONS) SHALLBE TURNED OFF BEFORE REFUELINGOF MOTOR FUEL TANKS AND/ORPROPANE CONTAINERS.FAILURE TO COMPLY COULD RESULTIN DEATH OR SERIOUS INJURY. AD-05

Fig. 8.4 “Shut off during re-fueling” label

INSTALLING PROPANE CYLINDER(S)

Double propane cylinder assembly with thecylinder rack located on the A-frameThe containers must be positioned in the traywith the valves pointing away from the trailer.The wing nut is placed on the threaded rod tohold the cross bar down and orient thecontainers. The regulator bracket is held inposition by the threaded rod and centers theregulator between the two cylinders that aresecured at the base on the tray.

1. Connect the 3/8” low-pressure hose to theoutlet of the two-stage regulator.

2. Place the cylinders on the bracketprovided on the A-frame and secure themso the outlet of the cylinder valves pointaway from the front of the trailer.

3. Using the threaded center rod, position the regulator bracket. This centers theregulator between the two cylinders asthey are secured to the base tray.

4. Attach the1/4” inverted flare x 11” Type-1pigtail hose to the regulator inlet and theright hand swivel nut to the cylinder valve.

Double propane cylinders located in arecessed compartment or housing:

1. Connect the 3/8” low-pressure hose to theoutlet of the two-stage regulator.

2. Place the cylinder on the bracket in therecess compartment or housing andsecure them so the outlets of the cylindervalves are facing the “sidewalls” of thecompartment or housing (opposite of eachother).

3. Mount the regulator on the center backwall of the compartment or housing so thevent is pointed downward.

4. Attach the 1/4” inverted flare x 18” Type-1pigtail hose to the regulator inlet and theright hand swivel nut to the cylinder valve.

Main Supply Hose – Low PressureAttach the main supply hose from the regulator to the brass manifold fitting in the frame of thetrailer. The swivel brass nut on the main hosewill be your final attachment. Several things to

60


Fig. 8.5 Double cylinder assembly

Fig. 8.6 Two propane cylinders

WARNINGThe pigtail hose must be installed to avoidtension or pulling stress at either end of thehose. Keep the pigtail hose away fromsharp edges of the cylinder collar, rigidcorners, walls, doors or other compartmentstructures including the cover.

WARNINGEnsure that all fasteners are securedbefore traveling.

remember each time the propane container isremoved:

1. Check that ALL fittings are tight.

2. Check that ALL connections are testedwith a propane leak detector (or soapywater) solution.

3. Open the main valve slowly to avoid a fastrush of propane to the excess flow valvecausing propane freeze up. If youexperience a propane “freeze-up,” closethe main valve and wait at least fifteen (15)minutes before trying again. Refer to theregulator OEM operator’s manual.

4. Listen carefully - a “hissing” sound longerthan one second may indicate a propaneleak. If you feel there may be a leakpresent, close the valve and contact yourdealer or qualified propane technician forrepair assistance.

Replace all protective covers and caps on thepropane system after filling. Make sure thevalve is closed and the compartment door issecurely latched.

Propane container overfillNever overfill your propane container abovethe liquid capacity indicated on the container. If a container is overfilled, liquid gas may flowthrough the gas regulator, causing it to freezeand/or introduce dangerous excessive gaspressure into the lines. In addition, anoverfilled container placed in hot sunlight mayexpel excessive gas through the relief valveand be susceptible to ignition by any nearbyopen flame or spark.

If you do overfill the propane container, contact your dealer or a qualified propane technicianfor assistance immediately. Do not attempt toservice a propane container overfill yourself.

MaintenancePropane gas is normally non-corrosive - youneed not worry about the inside of yourcontainer. However, the outside should bekept free from rust by a periodic coat of paint ina light reflective color. Rust, scratches and/ordents can affect the safety of the cylinder.Inspect the cylinder at regular intervals. If there is a problem, have it evaluated by a qualifiedtechnician and discard it. DOT requires that avisual inspection be made prior to each filling.

Any cylinder that has been exposed to fire,leaks or seems damaged should not berefilled. Do not attempt to repair anycontainers, container valves, regulator orappliances by yourself. Use only trainedcertified propane gas service technicians toperform repairs.

Propane cylinder recertificationIf you have an older RV you should know that,according to Federal law, DOT cylinders mayonly be used for 12 years after theirmanufacture date (the number of years forcertification may vary in your area). After that,the cylinders must be “recertified” whichprovides another five years of use. Thecylinders can be recertified every five yearsthereafter. Federal DOT (Department ofTransportation) regulations require periodicinspections and re-qualifications of thepropane cylinders. DO NOT USE damaged orrusted containers.

Verify with your local propane dealer that allrequired inspections and certifications havebeen completed on the propane cylinder within the correct time period before refilling thecylinder.

61


3/8" MPT x 1/2" FemaleFlare Swivel

Fig. 8.7 Main supply hose

PROPANE REGULATOR

Have the LP system checked for leakage eachtime a cylinder is refilled or after any part of thepropane system has been disconnected.

Two stage regulatorThe two-stage regulator has the only movingcomponents in the propane system. Its solefunction is to reduce the pressure from thepropane containers to a safe and consistentlow operating pressure. The first stagereduces the container pressure to 10-13 lbs.The second stage reduces the 10-13 lbs. ofpressure further to an operating pressure of11” W.C. (water column) or 6.35 oz. of outletpressure to your appliances.

The second stage is adjustable and will needto be adjusted by your dealer or qualifiedpropane service technician for optimumperformance (this adjustment should alwaysbe made with a properly calibratedmanometer). If the pressure is too high, itaffects performance and safety; if the pressure is too low, your appliances will not operatecorrectly.

If your RV is equipped with the “automatic”two-stage regulator, with both cylinders full ofpropane, turn the lever on the regulatortowards the cylinder you wish to use first. Thiswill now be the “supply” cylinder and the otherthe “reserve.” Slowly open both cylindervalves. The indicator on top of the regulatorwill turn bright green. When the cylinderbecomes empty, the indicator will change tobright orange. Now turn the regulator lever to

the side of the “reserve” cylinder and the green signal should return. You may now remove theempty cylinder to have it refilled withoutinterrupting the flow from the full bottle. Afterfilling the cylinder, connect the pigtail hose and slowly open the bottle valve.

HOSES, PIPES, TUBES & FITTINGSThe hoses, pipes, tubes and fittings used inyour propane system are designed towithstand pressures exceeding those of thepropane system. However, becauseenvironment and time can both contribute tothe deterioration of these components, theymust be inspected for wear at regular intervals. Be sure to inspect the hose before eachseason and when having the tank refilled.Look for signs of deterioration such as cracksor loss of flexibility. When replacing the hose or other propane components, make sure toalways replace them with components of thesame type and rating (check with your dealer).

Fittings are used to connect the varioussystem components to each other. The P.O.L.fitting at the end of the propane supply hose ismade of brass so that pipe sealants are notnecessary to prevent leaking. It also has aleft-handed thread, which means that it isturned clockwise to remove, andcounter-clockwise to tighten. The P.O.L. fittinghas been designed to help restrict the flow ofLP gas in the event of a regulator failure orhose malfunction.

USING THE PROPANE SYSTEM

After the RV is completely set up and you areprepared for camping enjoyment, use thefollowing steps for propane operation:

62


WARNINGDo not use portable fuel-burningequipment, including wood and charcoalgrills and stoves, inside the RV. The use ofthese items inside a RV may cause fires orasphyxiation (inability to breathe).

WARNINGPropane regulators must always beinstalled with the regulator vent facingdownward. Regulators that are not locatedin baggage compartments have beenequipped with a protective cover. Makesure the regulator vent faces downwardand (if applicable) the cover is in place tominimize vent blockage that could result inexcessive gas pressure causing fire orexplosion.

1. Close ALL burner valves, controls and pilot light valves.

2. Open the main valve in the propanecontainer slowly to avoid a fast rush ofpropane vapor through the excess flowvalve causing propane “freeze.” Shouldyou experience propane “freeze-up”, close the main valve and wait 15 minutes beforetrying again.

3. Listen carefully as propane begins to flow.If a hissing noise is heard for more thanone or two seconds, close the main valveand contact your dealer to have thepropane system tested.

4. Light the appliances as needed anddirected in the appropriate appliancemanufacturer’s owner manual located inthe Goodie Bag.

Make sure that you read and fully understandALL safety requirements for handling andoperation of the propane system. The GoodieBag contains OEM operator’s manuals for thevarious appliances hooked to your propanesystem. The propane system provides addedbenefits to your camping enjoyment; however,it must be handled with care. If you have anyquestions or concerns, consult with yourdealer and/or the specific OEM.

If you have double cylinders on your RV, useonly one at a time. Otherwise, the propanesupply will be drawn equally from bothcylinders until the supply has been totallyexhausted. Using one cylinder until it is empty,then using the second cylinder will allow you to fill the empty cylinder at your conveniencewithout running totally out of propane.

If flooding is predicted for your area, shut OFFeach propane cylinder valve before the waterrises. If the propane system has been flooded,do not turn it back ON until it has been checked by your dealer or a qualified propane servicetechnician.

CALCULATING PROPANE USAGEIt is important to remember that (if applicable)your furnace, refrigerator, water heater and

range all may use propane to operate. Eachhas a different BTU rating, and you will need toconsider them to determine how long yourpropane supply will last. Most RV gasappliances are operated intermittently.Propane consumption depends on individualuse of appliances and the length of timeoperated. Unless there is heavy use of hotwater, the water heater consumption ofpropane is minimal. During cool temperatureor high wind conditions, furnace consumptioncan be extremely high.

To calculate your propane supply, take theBTU ratings for your propane appliances anddivide that into the BTU availability. Eachgallon of propane (3.86 liters) produces about91,500 BTU’s (46,514 kilojoules) of heatenergy.

TRAVELING WITH PROPANEUse care when fueling your tow vehicle. Makecertain your propane container is properlyfastened in place. The label listed belowshould be kept permanently affixed to your RV:

Some states prohibit propane appliances to be operated during travel, especially inunderground tunnels. Make sure you know the laws for the areas where you travel.

63


DANGERALL PILOT LIGHTS, APPLIANCESAND THEIR IGNITORS (SEEOPERATING INSTRUCTIONS) SHALLBE TURNED OFF BEFORE REFUELINGOF MOTOR FUEL TANKS AND/ORPROPANE CONTAINERS.FAILURE TO COMPLY COULD RESULTIN DEATH OR SERIOUS INJURY. AD-05

Fig. 8.8 Refueling warning label


64


SLIDEOUT SYSTEMS

The slideout room system is designed foradditional floor space and comfort. Themechanical components are gear driven.Electric powered slideout room systems havea manual override to allow you to extend orretract the slideout room(s) in case of a powerloss. Make sure you have sufficient poweravailable before operating your slideoutsystem.

TRANSIT BARS (IF SO EQUIPPED)

Some RVs have transit bars that need to beinstalled when the slideout room is in the travel mode. Remove the transit bars beforeoperating the main slideout room. Be sure toinstall the transit bars where indicated by labelon the interior RV wall before traveling.

The following label should remain permanently affixed to the RV:

OPERATING THE SLIDEOUT

1. The auxiliary battery (customer supplied)must be fully charged and connected. Ifpossible, the RV should be hooked up to120-volt AC power so the converteroperates.

2. The RV must be level and the stabilizerjacks in the extended position.

3. Locate the slideout control switch.

4. To move the room out, press the OUTsection of the switch and hold it until themotor stops (travel time is approx. 25seconds). Operating the switch after theroom is fully extended will damage theswitch and motor.

65

SECTION 9SLIDEOUT SYSTEMS

WARNINGEnsure that the trailer is level beforeoperating the slideout room. Water leaksand other problems could result if theslideout is operated without leveling thetrailer.

Ensure there are no people or obstructionsblocking the path of the room when it ismoving. Keep away from the slide railswhen the room is in motion. The gearassembly may pinch or catch on looseclothing causing personal injury.

Ensure the slideout is in the closed positionprior to hooking the unit to the tow vehicle.

FAILURE TO FOLLOW THESEINSTRUCTIONS COULD RESULT INSERIOUS INJURY OR DEATH.

CAUTIONDo not place excessive weight in theslideout room. It can cause the slideoutroom to malfunction and cause damage tothe slideout.

Fig. 9.1 Transit bar

TRANSIT BARJA-119

Fig. 9.2 Transit bar label

CAUTIONIMPORTANT! Never store the slideoutwithout the travel bars installed. This helpsseal the slideout in the closed position.

CAUTIONAdditional support jacks are not neededunder the slideout. Damage can occur toyour slideout room from improper use ofaftermarket support jacks.

After the slideout isextended, verify that the corners of the blackrubber seal are set upcorrectly. The corners of this seal are cut at a 45°angle. The top of theseal must overlap theside of the seal to avoidthe possibility of waterpenetration.

Retracting slideout roomPress the IN section of the slideout controlswitch and hold it until the motor stops.Operating the switch after the room is fullyretracted will damage the switch and motor.

Maintenance

Your slideout system has been designed torequire very little maintenance. To ensure along life of your slideout system, read,understand and follow these simpleinstructions. This system contains a pre-lubedbearing that is lubricated when the room ismoved in and out. Do not spray oil or greaseon the rails while the room is extended.

TROUBLESHOOTING THE SLIDEOUTIf the slideout does not move when the slideout switch is depressed, follow these steps.

0 Check the auxiliary battery (customersupplied) for a full charge and good wireconnections.

0 Check the 12-volt fuse or circuit breaker.

0 Check for loose connections at theslideout motor.

If the slideout still will not operate, follow thesesteps.

0 If the slideout is extended, refer to thefollowing section on overriding the specificslideout system installed on your RV.

0 If the slideout is retracted, leave it in thatposition.

0 Contact your dealer or Jayco CustomerService for repair assistance.

If the slideout extends crooked or only oneside moves, follow these steps.

0 Follow steps on overriding the specificslideout system installed on your RV.

0 You may need to push the side that is notsliding to get it to retract all the way.

0 Contact your dealer or Jayco CustomerService for repair assistance.

RBW Slideout override Inside the RV, locatethe hex head screw on the front of the slidemotor. Using a ratchetand 3/4" socket, turnthe screw counter-clockwise to retractthe slideout. Install the travel bars in theproper locations asindicated by the walllabels.

V-tech slideout override If the RV has anunderbelly, locateand remove theaccess panel toaccess the slideoutmotor (this panel istypically under theRV on the oppositeside of the slideoutroom). Use a 3/4socket and ratcheton the hex head located on the end of the drive shaft. Turn the drive shaft until the slideout is in the position you desire.

66

SECTION 9SLIDEOUT SYSTEMS

CAUTIONDo not work on your system unless the12-volt DC (auxiliary battery, customersupplied) and 120-volt AC electricalsystems (shore line power cord) have beendisconnected.

Fig. 8.6 Main slidehex head

Fig. 9.4 RBW slidehex head

Fig. 9.3 Exteriorslideout roomcorner

CAMPING & OPERATING

By purchasing your RV you have entered intoa lifestyle that encourages long-lastingfriendships. People who camp next to oneanother for a few days are allowed the uniqueopportunity to cultivate new acquaintancesand neighbors. Camping is a great way to relax and enjoy the great outdoors with your familyand friends. Please remember to tread lightlyon our beautiful land and leave only yourfootprints so that others may enjoy nature asmuch as you did.

Searching for the right campground prior totraveling might be the first step in selectingyour site. Some campgrounds accept advance reservations (recommended depending onyour travel destination and the season of theyear, especially holidays). With time, you willknow what you are looking for and what bestfits your needs. A few items to keep in mindwhen selecting your campsite are:

0 Arrive before dark, if possible, to make thesite selection easier.

0 Is the ground level? This will help withleveling your RV and making your staymore comfortable.

0 Is there plenty of space?

0 Will it accommodate slideout, awnings,etc.?

0 Is there room for picnic tables, lawn chairs, campfire, etc.?

0 Is it void of hanging limbs that maydamage your unit?

0 Is it located in a convenient area?

0 Will you be able to park close enough tohookups (water, sewer, electric)?

0 Are you away from noisy areas or thingsthat might detract from a positiveexperience?

0 Is there plenty of shade? Is there gooddrainage in case of bad weather?

Some campgrounds will post a set of rules foryou to see when you check in, but your fellowcampers will count on your basic goodmanners and courtesy. Show respect toothers, don’t make shortcuts through occupied

campsites. Remember to keep your campsitetidy. Put refuse in containers provided for thatpurpose, and please avoid contaminating anylake or stream. If you are traveling with pets,we encourage you to research thecampground policy regarding pets.

EXTENDED DRY CAMPING

Your RV has been built for enjoyment in arecreational manner. It is not intended to beused as full-time living quarters.

COLD WEATHER USAGEProper care should be taken when planning touse your RV in cold weather. Please keep inmind that your RV was not designed for useduring sub-freezing weather. When used infreezing or below freezing temperatures, thefollowing precautions need to be taken:

0 More protection will be needed to protectthe fresh water and drainage systems toavoid freezing problems (see Winterizingthe Plumbing System).

0 Propane and sufficient power is neededfor protection from possible freeze-ups onthe propane regulator. Keep in mind thatmore frequent furnace operation willsubstantially increase battery draw andpropane use.

0 During cool weather usage, ventilation orthe addition of a dehumidifier may berequired to reduce condensation (seeCondensation).

0 Check outside extrusions on compartment doors, locks, slide outs, windows, vents,etc., for frozen moisture before operatingto avoid damage to parts.

67

SECTION 10CAMPING & OPERATING

CAUTIONContinuous living in your RV could causeaccelerated wear and damage tocomponent parts. Use of the RV other thanfor its intended purpose of recreationaltravel and camping may affect yourwarranty coverage.

CONDENSATION

Condensation is a natural phenomenon. Theamount of condensation will vary with climateconditions, particularly the relative humidity.Condensation occurs because there is watervapor present in the air, which each of us addsto by breathing, bathing or cooking. The watervapor usually collects on the coolest surfaces.When the temperature reaches the “dewpoint,” the water vapor in the air condensesand changes to a liquid form. If moisture isunable to escape the RV, you will experiencecondensation.

Most people have experienced thisphenomenon when a moisture forms on theirwindows. Outside air is cooling the window onthe outside while inside air is warming thewindow on the inside; the resulting moisture isattracted to that surface and the windowsbegin to sweat.

To reduce condensationProper ventilation and, if needed, the use of adehumidifier (customer supplied) will assist incontrolling condensation. Many RV andmarine dealers carry small dehumidifiers sized for RV use. Other suggestions are:

0 Crack open windows and roof vents toallow warm moist air to escape.

0 When taking a shower open the bath roofvent (if so equipped) approximately ½”allowing the moisture to escape.

0 Use the range hood fan (if so equipped)when cooking or washing dishes.

0 Avoid hanging wet towels (or clothes)inside the RV to dry.

0 If condensation is found in cabinets orclosets, open those doors slightly toequalize the temperature and provideventilation.

SETTING UP YOUR CAMPSITE

Un-hitching your travel trailer1. Position the RV as desired.

2. Level the RV (side-to-side).

3. Block the wheels securely to prevent theRV from moving.

4. Unhook the wire harness/connector plug,safety chains and breakaway switchlanyard.

5. Install the dolly wheel or platform.

6. Release the weight distributing bars(customer supplied).

7. Open the tongue jack coupler latch.

8. Turn the tongue jack crank to raise thecoupler above the hitch ball.

9. Level the RV (front-to-back) with thetongue jack crank.

10. If applicable, lower the stabilizer jacks.

11. Pull the tow vehicle away, as desired.

Leveling the RVNow that you have parked your RV, you needto ensure it is level. Leveling is very important.A level RV is more comfortable for sleepingand walking. The refrigerator is designed tooperate when level for best performance dueto the absorption system. The water drainagesystems are designed with proper slope andmust be level for proper operation. Theappliances perform best when level.

68


WARNINGCondensation needs to be taken seriously.Ignoring it can damage the RV (damagecaused by condensation is notwarrantable), and more importantly couldlead to mold or mildew issues which couldbe a health hazard.

Correct Incorrect

Fig. 10.1 Blocking the wheels

KEYSSeveral keys are provided when you purchaseyour RV. Most keys have an individual keynumber stamped on the plate. Record thesekey numbers and keep the information in safeplace. You can order a key blank from your RVdealer to have duplicate keys made. If you lose the keys, contact your RV dealer or a locksmith for assistance.

Make sure the keys are not inside the RVbefore you close and lock the entrancedoor.

ENTRANCE DOOR WITH SCREENDOOR

The entrance door is located on the curbsideof the RV. Always hold onto the entrance doorwhen opening or closing it as damage causedby because you failed to do so is notwarrantable.

BE SAFE, LOOK BEFORE ENTERING OREXITING YOUR RV!

HIDE-A-BED (IF SO EQUIPPED)The hide-a-bed sofa functions much the sameas a regular residential hide-a-bed sofa. Tomake the hide-a-bed sofa into a bed, removethe seat cushions and pull the strap located atthe front of the sofa seat bottom out towardsyou firmly and gently.

To convert the hide-a-bed back into the upright sofa position, reverse the process (make sureto pull the seat belts out into their usablepositions). Be sure to hold the sofa strap firmlyto ensure the hide-a-bed sofa does notsuddenly drop shut. Refer to the furnituremanufacturer’s care instructions for thisproduct.

J-STEEL SOFA (IF SO EQUIPPED)The J-steel sofa functions much the same as aresidential futon. To make the J-steel sofa in toa bed, lift up on the bottom seat cushion andpull it towards you. The sofa back will dropdown to provide a flat sleeping surface.

For additional comfort and to reduce fabricdamage, you may want to place a cover or airmattress (customer supplied) over the J-steelsofa when it is in the sleeping position.

BOOTH DINETTE (IF SO EQUIPPED)The dinette is designed to seat up to fouradults. You can access the dinette benchstorage by removing all the cushions and lifting the bottom seat supports. If the dinette bottomseat support is screwed shut, it is to protectfactory-installed equipment (do not use thatarea for storage). To convert back to a boothdinette, reverse the process.

The booth dinette can be converted into a bed.To convert, remove all the cushions from thebooth dinette. Lift the tabletop, remove thedetachable table legs and place the tabletopon the ledges provided between the boothdinette benches. Lay the seat back cushionsagainst the back of the booth dinette bench.Lay the dinette seat bottom cushions inbetween the seat back cushions. The areawhere the cushions meet should be slightlyraised. Push the raised cushion ends downgently. The cushions are designed to fit snugly. Reverse this process when converting back tothe booth dinette.

Extendable dinette (if so equipped)Your RV may be equipped with sideextensions on the dinette benches that can beused only when the slideout is extended.

69


CAUTIONMake sure the entrance door is completelyclosed and locked when traveling. Lockingthe door helps prevent it from openingunintentionally.

1. Remove the snapstrap (located at theback of the dinettebench) that securesthe extensions in the travel position.

2. Pull out the dinettebench extensionuntil it hits thefactory-installedstops.

3. Remove the seat, seat back cushion andplywood seat extender from the revealedstorage compartment (put the cushions offto the side).

4. Position the plywood seat extender acrossthe dinette bench extension brackets. Theplywood seat extender MUST be in placeto use the extendable dinette.

5. Place the seat and seat back cushions onthe extensions and repeat the process forthe other dinette bench extension.

To close the extendable dinette, reverse theprocess. The extendable dinette must beclosed, the snap strap secured and thetabletop put in the bed position BEFORE theslideout room is retracted for transit.

TV POWER SUPPLYFor good station reception, the TV power supply must beturned ON to view localtelevision stations. Turning the TV power supply ON sends12-volt DC through the cableto the TV roof antenna. Thevoltage energizes thetransistors in the antennahead amplifier. The TV signalthen comes down the cable tothe outlets.

Turn the TV power supply OFF to view cabletelevision or to use a VCR or DVD (if your RV is so equipped).

TV ANTENNA & CABLE TVRG-6 coax runs from the TV antenna andexterior cable TV connector to a wall platenear the dedicated television space.

The television entertainment system will notrun cable television on one television set andlocal stations off the other set withoutcustomer modification. You can either viewlocal stations or you can view cable television.

TV antennaTo raise the TV antennato the operating positionturn the antennaelevating crank clockwise in the UP direction untilsome resistance toturning is noted.

On amplified models, 12-volt DC power isrequired (refer to the OEM manual). After theantenna is in the full UP position, pull down onthe round knob with both hands until itdisengages from the ceiling plate. Rotate theknob for best picture.

Lowering the antenna Rotate the antenna until the pointer on thedirectional handle aligns with the pointer onthe ceiling plate. Turn the elevating crankcounterclockwise in the DOWN direction untilresistance is noted. The antenna is now locked in the travel position.

TELEPHONE JACK (IF SO EQUIPPED)To operate your interior phone the RV must beconnected to an external telephone serviceprovider. To use the phone, plug a telephonecord with a RJ-11 plug (customer supplied) tothe exterior phone jack.

70


ONON OFFOFF

AUX/SATAUX/SAT

TVTV

WINEGARDWINEGARD

Fig. 10.3TV PowerSupply

Fig. 10.4

Fig. 10.5

Fig. 10.2Extendabledinette

REFRIGERATOR

The refrigerator is not intended for quickfreezing or cooling. We recommend stocking itwith pre-frozen or pre-cooled food whenpossible. The shelves should not be coveredwith paper or plastic and the food items shouldbe arranged so air can circulate freely. Keepthe area at the back of the refrigerator cleanand free of debris. Check for obstructions inthe exterior refrigerator vent area (i.e., spiderwebs, bird nests, etc.). Use a soft cloth to dustoff the debris.

For optimum efficiency and performance, it isrecommended the refrigerator be checked atleast twice a year as part of the routinemaintenance.

MICROWAVE (IF SO EQUIPPED)Make sure there is sufficient 120-volt poweravailable before operating the microwave.Ensure the microwave turntable (if soequipped) is secured prior to traveling.

COOKING WITH PROPANE

Unlike large homes, the oxygen supply insidea RV is limited. The following warning labelsare located in the kitchen area to remind you to provide an adequate amount of fresh air forcombustion. To avoid danger of asphyxiation,provide proper ventilation when using the gasrange top or gas oven. Do not remove thefollowing labels from your RV:

71


WARNINGDo not turn gas range burner controls ONand allow propane gas to escape beforelighting.

WARNINGIT IS NOT SAFE TO USE COOKING APPLIANCES FOR COMFORT HEATING.Cooking appliances need fresh air for safe operation.Before operation:

1. Open overhead vent or turn on exhaust fan.2. Open window.

FAILURE TO COMPLY COULD RESULT IN DEATH OR SERIOUS INJURY. 0010948

Fig. 10.6 Cooking / comfort heating label

TO ENSURE A SUPPLY OF FRESH AIR TO OCCUPANTS, OPEN VENTILATORS WHEN FUEL BURNING RANGE, FUEL BURNING CARRY-ON APPLIANCE, AND/OR FUEL BURNING LIGHTS ARE IN OPERATION. COOKING APPLIANCES SHOULD NOT BE USED FOR SPACE HEATING PURPOSES.

DE MANIÈRE Ã ASSURER UNE ALIMENTATION EN AIR FRAIS AUX OCCUPANTS, OUVRIR LES VENTILATEURS LORSQUE LA CUISINÈRE, LES APPAREILS DE CHAUFFAGE PORTABLES ET/OU LES LAMPES DE COMBUSTION D’HUILE SONT EN FONCTIONNEMENT. LES APPAREILS DE CUISSON NE DOIVENT PAS SERVIR AU CHAUFFAGE DES LOCAUX.

0014357

Fig. 10.7 Ensure a supply of fresh air label

WARNINGDo not use portable fuel burning equipment (i.e., wood and charcoal grills or stoves)inside the RV.

WARNINGIf you smell propane gas STOP! Follow thedirections located in your OEM operator’smanuals and in this manual.

CAUTIONIt is recommended the telephone cord bedisconnected from the external powersource in the event of a storm. Thetelephone cord can carry voltage from theexternal power source into the RV andcause potential damage.

KITCHEN STOVE, RANGE & OVEN(IF SO EQUIPPED)

To prevent damage, always use the OEMrecommended size flat bottom pan(s).Generally, the pan should be large enough tocover the burner, but not be more than oneinch larger than the burner grate.

Do not use a broiler pan, griddle or any otherlarge utensil that covers more than one burnerat a time. This will create excessive heat thatmay cause melting, sooting or discoloration.

In addition, the use of undersized pans couldexpose a portion of the heating element todirect contact and may result in ignition ofclothing. Proper relationship of pans to burnerwill improve efficiency.

Oven (if so equipped)

The propane gas oven must have 12-voltpower to operate. If you have any questionscontact your dealer or Jayco CustomerService. Do not use the oven as a storagearea.

IN CASE OF A GREASE FIRE

Grease is flammable. Never allow grease tocollect around top burners or on the cook topsurface. Wipe spills immediately. If a fire doesstart, follow these basic safety rules:

0 Have everyone evacuate the RVimmediately.

0 After everyone is clear and accounted for,check the fire to see if you can attempt toput it out. If it is large or the fire is fuel-fed,get clear of the RV. Have the FireDepartment handle the emergency.

0 Try to smother a flaming pan with atight-fitting lid or cookie sheet.

0 Never pick up a flaming pan.

0 Flaming grease outside of the pan can beextinguished with baking soda or amultipurpose dry chemical or foam-typefire extinguisher.

PANTRY (IF SO EQUIPPED)Depending on the kitchen layout of your RV,you may have a pantry that you can use to

72


WARNINGDuring and after use, do not touch or letclothing or other flammable material comein contact with the top burners (or heatingelements), burner grates or other areasnear the top burners or oven until they havehad sufficient time to cool. These areas can get hot enough to cause burns.

Never leave cooking food unattended. Turn pan handles inward, but not over the tops of the other range burners. Ensure that pansused are large enough to contain the foodand avoid boil-overs. Heavy splattering orspills left on the cook top can ignite andcause burns.

If using glass, glass/ceramic, ceramic,earthenware or other glazed utensils (orcookware) verify it is safe for use on the topburners. Only certain types of utensils (orcookware) are suitable for surface or topburner use.

WARNINGDo not attempt to use water to put out thefire. Water can spread some types of fire,and electrocution is possible with anelectrical fire.

WARNINGDo not cover the oven vent openings whilethe oven is in operation. Restricting the flow of combustion air will create anasphyxiation hazard.

store items you wish to take with you as youtravel and camp. Ensure items stored in thepantry are secured so they do not shift duringtravel. The cabinetry has been designed toaccommodate the normal camping items (i.e.,paper plates, flatware, cookware, etc.) whichare bulky but not necessarily heavy.

Remember your RV’s load capacity isdesigned by weight, not volume, so youcannot necessarily use all available space.

BBQ GRILL (IF SO EQUIPPED)

The BBQ grill is for use outside of the RV.Never use this grill inside a compartment orthe RV. Before operating the BBQ grill, makesure that it is securely placed on the supportbracket. The BBQ grill must be COMPLETELYcooled before storing to avoid damaging thecarrying case (if so equipped) and causinginjury from handling the grill when it is hot. Wait until the grill is completely cooled, then store it.

Attaching the "quick-coupler" connectionThe "quick coupler" is directly connected to the RV propane system. The “quick coupler”

connection has a positive shut-off valve asrequired by code and standards.

1. Place the “quick coupler handle in the OFFposition and push back the sleeve. Thevalve handle must be OFF to make theconnection.

2. Insert the plug and release the sleeve.

3. Push the plug until the sleeve snapsforward, locking the plug into the socket.

4. Turn the handle ON to allow propane toflow to the drop in stove.

Vitco grills onlyThe carrying case will ONLY accommodate acool grill. The grill carrying case has a pocketfor accessories such as the propane hose inthe lid. The bracket will not fit inside thecarrying case and will need to be stored in aseparate location. Sanitize the detachablesteakplate extension tray before using it.

BBQ Grill Prep (if so equipped)Your RV is equipped with a propane “quickcoupler” connection and support bracket foreasy installation of the BBQ grill.

PATIO AWNING (IF SO EQUIPPED)

Please refer to the awning OEM operator’smanual. Keep your awning in good condition to prevent costly repairs. It is very important tokeep the awning clean. If weather conditionsare windy or stormy, close the awning into thetravel mode position. Shut the awning in the

73


“ON”Sleeve

“OFF”

Socket Plug

Sleeve“OFF”

Fig. 8.14 Quick connect coupler

WARNINGThe maximum weight limit for the bracketon the side of your trailer is 50 lbs. This limitincludes the weight placed on the BBQ gill.Exceeding this weight limit could causedamage to the unit and possibly causepersonal injury from hot equipment.

WARNINGMake sure that you read, understand andfollow all information supplied with your RVabout propane before operating the BBQgrill. The propane hose must be correctlyconnected before lighting the grill. Failureto follow instructions supplied by the grillmanufacturer with your RV or to use anyother components than those originallysupplied with the grill could lead to death orserious injury from fire or explosion.

WARNINGAwnings must be closed (and locked ifapplicable) while the RV is in transit.

travel position if you will be away from the RVfor an extended period of time.

The 12-volt power awning may need to beadjusted (retracted) to operate the entry door(some JAY FLIGHT models).

DUCTING & RETURN AIRAll heat discharges, registers and return airgrills must be free and clear of obstructions.This includes all closeable registers that areintended to reduce airflow, not shut it offcompletely.

ATTIC FAN (IF SO EQUIPPED)The 12-volt DC attic fan (or powered roof vent)allows fresh air to circulate through the RV.

Do not leave the attic fan open when the RV isstored or unattended for long periods. Highwinds, other unusual conditions orobstructions may prevent the dome fromclosing; the resulting leakage could causenon-warrantable damage.

THERMOSTATThere are may be up to two 12-volt DCthermostats in your RV. Use the controls to setthe temperature to your comfort setting.

AIR CONDITIONER (IF SO EQUIPPED)Your RV has a roof mounted air conditioningsystem that is controlled by a thermostat.Cooled air enters the RV through theadjustable “chill grill.” Make sure you havesufficient power available before operating theair conditioner. Do not operate the airconditioner without the return air filter.Operating the system without the filter allowsthe lint and dirt that is normally stopped by thefilter to accumulate on the cooling coil of the air conditioner. This also will lead to a loss of airvolume, possible equipment damage and anexpensive cleaning process.

A special foam gasket is placed between theroof material and the subframe of the airconditioner to guard against water leakage.The air conditioner is subjected to wind

pressures along with motor vibration duringnormal operation. Inspect the mounting boltsfor tightness to ensure there is no leakage orlooseness at least annually. Re-tighten boltswhen they are loose. DO NOT over tightenthese bolts as it may damage this gasket. Theair conditioner gasket is a wearable part thateventually will need to be replaced smaintenance. To gain access to the bolts,remove the filtered panel cover on central airsystems or the entire air box on non-central airconditioners.

FURNACE (IF SO EQUIPPED)

The RV furnace installed in the RV iscontrolled by a thermostat. The furnacerequires both 12-volt power and propane gasfor full operation. Make sure you havesufficient power available before operatingyour furnace. If you have any questionscontact your dealer or Jayco CustomerService.

74


WARNINGTo ensure your personal safety, do notobstruct or alter the furnace in any manner.Do not install screens over the vent for anyreason. Screens will become restricted and cause unsafe furnace operation. For yoursafety, only OEM factory authorized partsare to be used on your furnace.

WARNINGThe furnace should be inspectedperiodically (monthly during the heatingseason) for presence of soot on the vent.Soot is formed whenever combustion isincomplete. This is a visual warning that the furnace is operating in an unsafe manner. If soot is observed on the vent, immediatelyshut the furnace OFF and contact aqualified service agency. Operating thefurnace under this condition could lead toserious property damage, personal injury or loss of life.

A qualified RV technician should perform allfurnace maintenance at least once a year(more often depending on furnace usage).Never attempt to repair the furnace yourself.

DEPARTING CAMP CHECKLISTWhen the time arrives to return home, it isagain critical that you complete the necessaryprocedures to ensure a safe trip. As youdevelop a routine, it is possible that a checklistwill be helpful. This is a general list, which youmay want to customize as you determine yourown needs.

Safety

– Make sure you follow all safety precautionsnoted in this owner’s manual and in anyOEM operator’s manual when preparing totravel home.

Interior

– Close roof vents

– Close windows & latch blinds

– Counter items put away or tied down

– Furnace turned off

– Latch drawers, cabinets & doors

– Lights turned off

– Lower antenna & satellite dish (if applicable)

– Move slideout in and lock it in place (ifapplicable)

– Position the booth dinette in the bed position for travel (if applicable)

– Refrigerator door locked

– Set refrigerator to 12-volt (if applicable)

– Water heater turned off

– Water pump turned off

Exterior

– Empty black holding tank

– Empty gray holding tank

– Lock all exterior compartments

– Pack equipment into compartments andsecure it

– Propane turned off

– Retract awning and secure in place (ifapplicable)

– Retract slideout (if applicable)

– Retract step

– Rinse black holding tank, if necessary

– Visually look under RV for items missed

– Water hose & electric cord unhooked andstored

RV

– Check belts

– Check fluids

– oil

– coolant

– transmission fluid

– washer fluid

– power steering fluid

– brake fluid

– battery terminal

– Check lights

– headlights

– brake lights

– clearance lights

– turn signals

– Breakaway switch and lanyard connected

– Check tire pressure (include inner wheeland spare, if applicable)

– Check tire wear (uneven wear pattern)

– Check wheel lugs

– Coupler locking pin connected (if applicable)

– Dolly wheel removed (if applicable)

– Proper tongue weight maintained (25% ofgross weight - fifth-wheel travel trailer andcontents)(10-15% of gross weight -conventional travel trailer and contents)

– Retract stabilizer jacks

– Retract steps

– Safety pin or locking lever must be seated (ifapplicable)

– Test brakes for proper operation

– Tongue jack fully up (if applicable)

– Trailer electric cable secure

– Trailer is level.

– Trailer safety chains connected (ifapplicable)

75



76


STORAGE & MAINTENANCE

Depending upon your area and where yourRV is stored, your vehicle may be a target fordamage from rodents and insects. To protectyour RV, never leave food inside and ensurethat all surfaces are clean. Place rodentcontrol products in the unit during periods ofstorage. Mice and other rodents can do atremendous amount of damage to the drapes,cushions, etc., particularly during the wintermonths. Storing your RV in a field can make itparticularly inviting. Periodically inspect itduring storage and seal off any areas that canoffer an entry point to rodents or insects.Remember to remove any screens or tapeused to seal openings before using the RVagain. Damage from rodents or insects is notcovered by the Towable Limited Warranty.

When storing your RV, it is recommended thatthe auxiliary battery (customer supplied) bedisconnected to avoid battery discharge.

FORMALDEHYDEThe RV industry uses many products including carpeting, paneling, shelving, plywood,draperies, and fabrics that may have usedformaldehyde in the process of making thoseproducts. Other airborne pollutants includingcampfires, cigarettes and cigarettebyproducts, cooking and carbon monoxideoften have a higher concentration offormaldehyde than an RV. Air pollutants canbe an irritant and you may experience irritationto the eyes, ears, nose and throat.

When an RV is closed up for a period of time, itis possible for a process of outgassing to occur which can draw irritants into the air. So it isvery important to properly ventilate your RV toremove the outgassing. This is more prevalentin new RV’s as they release moisture fromconstruction materials through several heating and cooling sessions until dissipated.

Areas of high heat and humidity will increasethe outgassing process. Ventilate by openingall the windows, and circulate the air with anoscillating fan. Remember ventilation isimperative at all times in close quarters, notonly for indoor air quality, but also for proper

function of appliances and elimination ofcondensation (see Condensation).

The following label should be left permanentlyaffixed to the RV:

CLEANING THE INTERIOR To keep the value of your RV, perform regularmaintenance using the proper materials andprocedures. Use only those materials andprocedures that comply with all localenvironmental pollution control regulations.Carefully select the materials to be sure thatthey do not contain corrosives.

Make sure you have selected the rightcleaning agent before you begin the cleaningprocess. If in doubt, check to see if the cleanerwill cause damage by testing a small area outof sight or contact your dealer for assistance.Follow the instructions provided by thecleaning product manufacturer. Never use thefollowing chemicals to clean your RV; thesecan all be dangerous, and can damage yourRV:

0 Acetone

0 Benzine

0 Carbon tetrachloride

0 Gasoline

0 Lacquer thinner

0 Nail polish remover

0 Naphtha

0 Paint thinner

0 Turpentine

77

SECTION 11STORAGE & MAINTENANCE

WARNINGSome products in this vehicle contain formaldehyde, which may occasionally be an irritant to you. You may experience a greater concentration during high humidity and temperatures, but ventilation usually removes it. If you are affected, ventilate the vehicle and leave until the formaldehyde disappears. Please contact our Customer Service Department if you desire assistance.

DO NOT REMOVE THIS TAG0010957

Fig. 11.1 Formaldehyde warning label

FURNITURE UPHOLSTERYTo retain the value of your RV, maintain thefurniture upholstery carefully and keep theinterior clean. Vacuum the furniture regularlyusing a soft brush attachment to remove anyloose dirt or debris.

Fabric (if so equipped)It is recommended the fabric be professionallycleaned if it becomes stained or soiled. Theprofessional cleaner should be made awarethe fabrics have been treated to be fireresistant. After the cleaning process, pleaseremember to have the fabric re-treated to helpensure your personal safety.

Suede Upholstery (if so equipped)It is recommended the suede be professionally cleaned if it becomes stained or soiled.

Vinyl Upholstery (if so equipped)Do not dry clean vinyl components. If they aredry cleaned, the vinyl on the reverse side willshrink, become hard and crack. If a spill doesoccur water base cleaners are recommended(solvents are not recommended as they mayhave an adverse reaction to the specificbacking of your upholstery fabric). Blot up thespot, but do not rub it in or saturate the area.Clean it in a well ventilated area and avoidproducts containing toxic materials. Use aprofessional furniture cleaning service for anoverall cleaning.

Clean the suede or vinyl upholstery only asrecommended. Using other processes thanthose listed may produce undesired resultsand possibly damage the upholstery. This type of damage is not warrantable.

DÉCOR ITEMSDécor items such as window treatments, nightpleated shades, mini blinds and décor glassshould be cared for as follows:

Window treatments and curtainsDust occasionally with a vacuum and softbrush attachment. Due to fire retardantchemicals, they should be professionallycleaned only. The professional cleaner shouldbe made aware that these items have beentreated with a fire retardant.

Shower Curtain (if so equipped)To help prevent mildew or mold, clean theshower curtain.

Décor Glass (if so equipped)Use a glass cleaner to remove smudges,smears and spots. If there is any decorativeetching on the décor glass, use care whencleaning around that area.

ABS PLASTICSABS plastic components will retain theiroriginal beauty with reasonable care. Dust and wipe clean with soft, damp cloth or chamois,wiping gently. Do not use gritty or abrasiveparticle soaps or scouring compound to cleanABS plastic. Avoid using “Citrus” orbiodegradable cleaners which contain“D-Limonene” as they may damage plasticmaterials.

HARDWARE & SINK OR SHOWER FIXTURESUse mild dish soap and water to clean thesefixtures. Do not use harsh chemicals or sprays. A mild solution of vinegar and water works wellto remove hard water spots and stains from the sink or shower fixtures.

78


WARNINGCleaning materials can be dangerous.Some are poisonous. Others are highlyflammable. Some are dangerous if youbreathe their fumes in a closed space.Always open your RV doors and windowswhen you are cleaning inside.

Always use the appropriate safetyequipment. Never mix cleaningproducts. They may interact withdamaging or hazardous results.

PANELINGTo clean, use a mild solution of soap andlukewarm water with a soft sponge or cloth. Do not use abrasive cleaners as they could causethe vinyl to scratch and turn dull. Grease spotsand stubborn dirt can be cleaned off with anall-purpose spray cleaner. Harsh cleaners andorganic solvents can attack the printed vinyl;they are not recommended.

CABINETRY & TABLESTo keep hardwood doors, cabinet fronts andhardwood tables looking like new regularlydust with a soft cloth dampened with acleaning polish or mild detergent solution.Avoid using ammonia based products orsilicone oils as they may cause damage if used over a long period of time. The finish is durable and resistant to most household spills.However, spills should be wiped up promptly to avoid potential problems. Excessiveprolonged exposure to direct sunlight, hightemperatures and high humidity can causedamage to both the finish and the wood itself.These should be avoided.

COUNTERTOPSGlass rings, food spills, water spots andsmudges usually wipe off with a damp sponge. Stubborn stains can be removed with ageneral-purpose spray cleaner. Some stainscan be removed by squeezing fresh lemonjuice over the stain and allowing the juice tosoak for approximately forty-five minutes. After 45 minutes, sprinkle baking soda over thelemon juice and rub with a soft cloth

To prevent permanent damage0 Always use hot pads or trivets under hot

pans, dishes, or heat producingappliances such as frying pans.

0 Always use a cutting board; never use aknife on the countertop.

0 Avoid harsh chemicals such as draincleaners, oven cleaners, etc.

0 Do not let cleaners with bleach set on thetop. Wipe them off promptly.

FLOORINGRemember to wear rubber gloves to protectyour hands when cleaning. Always test acleaning agent in an inconspicuous area forcolorfastness.

Carpet (if so equipped)Vacuum regularly with a vacuum cleaner witha revolving brush or beater bar. Be sure thevacuum does not have teeth, combs or roughedges as they may damage the carpet. It isimportant to remove loose soil and debriswhile it is on the surface. Heavily traveledareas (i.e., walkways, areas in front of thefurniture) may be protected with small throwrugs to prolong the life of the carpet. Somespills contain chemicals that will destroy carpet fibers and dyes. If you have doubts about whatcaused the spot, contact a professional carpetcleaner.

Because of the additional dirt typicallyassociated with camping, we recommend thatyou vacuum the carpet frequently. Have toughand deep stains professionally steam cleaned. Use spot removers for minor spills. Always test the carpet for color fastness in aninconspicuous area before using any product..

Vinyl flooring (if so equipped)Periodically vacuum or sweep to remove dirtand gritty particles. Although most commonspills will not permanently stain the vinyl floors, they are usually easier to remove if wiped upbefore they set. Simply blot with a paper toweland wipe clean with a damp cloth. As part of aregular maintenance program, sponge mopthe entire floor. Do not use dish detergents orvinegar and water because they will dull yourfloor.

To care for the vinyl floor covering, use a dampmop with water and a mild cleaner. DO NOTSOAK THE FLOORING. Use care to avoidwetting the carpet edges. To avoid problems of “yellowing” linoleum, the flooring OEMrecommends avoiding cleaners that contain oil based solvents (i.e. cleaners containing lemon oil, Murphy’s Oil Soap, etc.).

79


REPLACING LIGHT BULBSBefore replacing a bulb, be sure the light is off.Do not touch the glass part of the new bulbwith your bare fingers. The skin oil left on theglass will evaporate when the bulb gets hot,the vapor will condense on the reflector and itwill dim the surface. Replace a bulb only with anew bulb of the same rating and type.

CLEANING THE EXTERIORTo protect your RV’s exterior finish, wash itoften and thoroughly. The exterior can beaffected by ultra-violet exposure; yellowing orfading may occur. Regular cleaning andwaxing will help protect the exterior. If chalkingoccurs, wash and try to wax a small area tosee if the luster returns. If the exteriorbecomes scratched, nicked or cracked haveyour dealer inspect the RV; check with yourinsurance agent to see if this damage iscovered under your policy (if applicable).

Depending on your model, the exterior isconstructed of aluminum or fiberglass. Referto the general instructions that follow for careinformation. We recommend that you do nottake your RV through automatic car washes.Extreme caution should be used if utilizing anytype of pressure sprayer around allattachments, doors, windows, appliancevents, etc. Avoid forcing water inside the RV,which could possibly damage componentparts.

Foreign materialIndustrial fall out, road tar, bird droppings, treesap, insect remains, seawater and otherforeign materials can damage the finish of your RV. Generally, the longer the foreign materialremains in contact with the exterior finish, themore extensive the damage. Wash your RV assoon as possible if it becomes contaminatedwith foreign material.

WashingChemicals contained in dirt and dust picked up from the road surface can cause damage if lefton the RV for a long time. Frequent washingand waxing is the best way to protect your RVfrom this damage. Frequent washings also

protect your RV from environmental elements,such as rain, snow and salt air.

Do not wash the RV when it is in directsunlight. Park the RV in the shade and spray itwith water to remove dust. Next, using anample amount of clean water and acar-washing mitt or sponge, wash the RV fromtop to bottom. Use a mild car-washing soap ifnecessary. Rinse thoroughly and wipe dry with a chamois or soft cloth. Carefully clean thejoints and flanges of the slideout (if soequipped), doors, hood, etc., where dirt islikely to remain.

Some types of hot water washing equipmentapply high pressure and heat to the RV. Theymay cause heat distortion and damage to theresin parts and may flood the RV’s interior.Therefore, be sure to observe the following:

1. Keep the washing nozzle about 16 inches(40 cm) or more away from the RV body.

2. When washing around the glass areas,hold the nozzle at right angles to the glasssurface.

During cold weatherSalt and other chemicals that are spread onwinter roads in some geographical areas canhave a detrimental effect on the RV’sunderbody. If your RV is exposed to theseconditions, spray the underbody with ahigh-pressure hose every time you wash theexterior of your RV. Take special care toremove mud or other debris that could trap and hold salt or moisture. After washing your RV,

80


CAUTIONWhen washing the RV, wear a pair ofrubber gloves to protect your hands. Avoidspraying or splashing water on theelectrical components. Avoid using carwashers that use rotating brushes. Thistype of washer may cause scratches on theRV exterior.

wipe off all water drops from the rubber partsaround the slideout and doors.

If the slideout or door is frozen, opening it byforce may tear off or crack the rubber gasketthat is installed around the slideout or door.Pour warm water on the gasket to melt the ice(wipe off the water thoroughly after openingthe slideout or door). To prevent the weatherstripping from freezing, treat it with a siliconespray.

Waxing your RVWax your RV once or twice a year, or whenpainted surfaces do not shed water well. Use a soft cloth to apply a small amount of wax to thepainted surfaces. After the wax has dried,polish the RV with a dry, soft cloth.

Do not wax your RV in direct sunlight. Wax itafter the surfaces have cooled. Do not applywax to any area having a flat black finish as itcan cause discoloration. If the finish has beenstained with wax, wipe off the area with a softcloth and warm water. When waxing the areaaround the various openings, do not apply anywax on the weatherstrip. If it is stained withwax, the weatherstrip cannot maintain aweatherproof seal around the opening.

Polishing your RVIf painted surfaces have been severelydamaged and have lost their original luster and color tone, polish the surface lightly with a finepolishing compound. Avoid limiting yourpolishing to the damaged surface only; polish

a somewhat wider area, moving the polishingcloth in one direction. After polishing, flush thecompound from the surface and apply a coatof wax to regain a beautiful luster.

Damaged paintTo prevent corrosion, touch up small cracksand scratches in the paint coat as soon aspossible with touch-up film or paint. Carefullycheck the body areas facing the road and thetires for damage to the paint coat caused byflying stones, etc. To purchase touch-up paint,use the closest automotive paint (availablelocally) match possible.

Cleaning plastic partsUse a sponge or chamois to clean plasticparts. Use warm water and a soft cloth orchamois to remove any white residue fromdark colored plastic surfaces. Do not use ascrubbing brush or other hard tools as theymay damage the plastic surface. Do not usewax containing abrasives that may damagethe plastic surface.

Chrome parts (if so equipped)To prevent chrome parts from spotting orcorroding, wash with water, dry thoroughly,and apply a non-abrasive automotive wax. Ifthe chrome is severely damaged or pitted, use

81


CAUTIONDo not use waxes containing high-abrasivecompounds. Such waxes remove rust andstains effectively, but they are also harmfulto the luster of the surface, since they mayscrape off the coating. Further, they aredetrimental to glossy surfaces, such as thegrille, garnish, moldings, etc. Do not usegasoline or paint thinners to remove roadtar or other contamination to the paintedsurface.

CAUTIONDo not allow plastic to come into contactwith brake fluid, engine oil, grease, paintthinner, or battery acid. These will damageplastic. Use a soft cloth and a milddetergent solution to wipe away any suchcontact.

CAUTIONDo not use a buffer and a buffing compound as it may damage the exterior surface.Please contact a professional paint bodyshop for assistance.

a commercially available chrome polishproduct.

Stone Guard (if so equipped)Wash the stone guard with mild liquiddishwashing soap or liquid car washing soapand water. Do not use powdered detergent,powdered soap, liquid and spray cleaners orpressure washing. Wax frequently to protectthe surface and make cleaning easier.

EXTERIOR ROOF & SIDEWALL VENTSWhile you are cleaning the exterior roof, alsoinspect the roof vents (including sealants) forcracks and keep them clean. Inspect therefrigerator and holding tank vents forblockages from bird nests, spider webs,leaves, etc. Water heater, furnace andrefrigerator exterior doors need to be keptclean and free of obstructions (i.e., insectnests, mud daubers, etc.) while the appliances (if so equipped) are in use.

WINDOWSAny ventilating window may permit waterinside, especially during heavy rainstorms.Condensation will also cause water toaccumulate on windows and in the tracks. Thewindow “glass” can normally be cleaned with a sponge and water. Use glass cleaner toremove wax, oil, grease, dead insects, etc.After washing the glass, wipe it dry with aclean, soft cloth.

DOORS & LOCKSLocks on entrance and baggage doors needbiannual lubrication using a light coat ofsilicone spray. Do not permit the spray to come into contact with the tent.Conditions such asrain, salt, dust and pollution may increase themaintenance needs.

MAXISTOR™ STORAGE (IF SO EQUIPPED)The Maxi-Store Storage provides space forlarge and bulky items. However, keep allweight capacities in mind as you load thisstorage space. A label similar to the followingis located inside the storage compartment’s

doors. The maximum weight allowed in thisstorage area will vary (depending your model). Make sure that you stay within the weight limits on the label attached to your RV.

If your RV has the MaxiStor™ storage door,you will need to fold up the beds to open up the area for storage. To utilize this compartment,follow these simple steps:

1. Remove the mattress cushions and placethem along the interior wall at either end ofthe bunk.

2. Lift up in the center of the bed platform.Fold both ends up.

3. The top bunk will fold up to provide a largerstorage space.

4. Load cargo into the storage area.

TRAILER FRAMESand, pebbles, objects on the highway,climate (salt air exposure) or ice inhibitingchemicals used during the winter months willdamage the paint, inviting rust and otherdeterioration. Periodically inspect the exteriorexposed areas, clean and repaint the steelmembers occasionally and whenever younotice rust or paint chipped away, to insureprotection.

E-Z LUBE AXLEThe E-Z lube feature on your axles providesthe ability for the bearings to be periodicallylubricated without removing the hubs from theaxle. This feature consists of axle spindles that

82


WARNINGPROPER ATTENTION MUST BE TAKEN TO ASSURE TOWING AND TRAVELING SAFETY. CONSULT YOUR OWNER’S MANUAL(S) FOR SPECIFIC LOAD DISTRIBUTION, WEIGHING INSTRUCTIONS AND TOWING GUIDELINES. COMPLY WITH THE TOW VEHICLE’S OWNER’S MANUAL FOR TOWING REQUIREMENTS.

THIS STORAGE AREA IS TO BE LOADED BY WEIGHT NOT BY VOLUME.MAXIMUM CAPACITY ### LBS. (### KG.)

1. LOAD THE STORAGE AREA FROM FRONT TO BACK, KEEPING HEAVIER ITEMS TO THE FRONT OF THE STORAGE AREA.

2. LOAD ALL ITEMS EVENLY FROM SIDE TO SIDE IN THE STORAGE AREA.3. SECURE ALL ITEMS TO PREVENT LOAD SHIFTS DURING TRANSIT.4. AFTER LOADING, WEIGH THE TRAILER AT THE HITCH, EACH AXLE, AND EACH WHEEL. OBSERVE

ALL TRAILER GROSS, AXLE AND TIRE RATINGS.5. IF THE WEIGHT OF THE LOADED TRAILER EXCEEDS ANY OF THE RATINGS AS LISTED ON THE

CERTIFICATION LABEL LOCATED ON THE FRONT LOWER LEFT OUTSIDE WALL, REMOVE OR REDISTRIBUTE THE CARGO LOAD UNTIL THE WEIGHT(S) ARE LESS THAN THE MAXIMUM RATINGS.

6. THIS AREA IS NOT FOR STORAGE OR TRANSPORTATION OF ENGINE FUEL(S), COMBUSTIBLE LIQUIDS OR VEHICLES EQUIPPED WITH FUEL POWERED ENGINES.

FAILURE TO FOLLOW THESE GUIDELINES AND INSTRUCTIONS MAY RESULT IN ADVERSE TRAILER TOWING AND HANDLING AND COULD LEAD TO AN ACCIDENT OR LOSS OF CONTROL RESULTING IN DEATH OR SERIOUS INJURY.

Fig. 11.2 MAXISTOR™ label

have been specially drilled and fitted withgrease zerks in their ends. When grease ispumped into the zerk, it is channeled to theinner bearing and then flows back to the outerbearing and eventually back out the greasecap hole. If you have further questions, consult with your dealer.

The convenient lubrication provisions of theE-Z lube must not replace periodic inspectionand maintenance of the bearings. Use ahand-operated grease gun; improper use of acommercial grease gun may damage theseals.

REAR BUMPER

The rear bumper of your RV is not designed tocarry cargo. Items that extend beyond thebumper OR weigh over 100 lbs. (45kg) willplace undo strain on the bumper. The 100 lb.bumper capacity includes the weight of thespare tire that may have been attached at thefactory.

Some items may fall within the given weightrange, however, can still cause damage. Overtime, weight added to the bumper will causedamage from the motion created whiletraveling. In addition, extra weight behind theaxle may reduce the hitch weight (leading toadverse handling conditions from wind gustsand/or passing traffic).

RUBBER ROOFThe rubber roof on your RV is manufactured by Alpha Systems. Read and follow the OEMoperator’s manual when cleaning the rubber

roof. If you have questions, contact yourdealer.

ROOF LADDER (IF SO EQUIPPED)Your RV may be equipped with an optionalroof ladder. The RV roof has decking under the rubber roof membrane to allow you to walk onthe roof (with caution) to do maintenance.

SEALANTS

Water is a RV’s worst enemy when it enterswhere it is not intended. Sealants perform avery important function; they must beinspected closely and be regularly maintained.

We incorporate many different types ofsealants, including butyl/putty, blackbutyl-encapsulated foam, silicone (clear andcolored), roof sealant, foam, etc. In general,sealants do not have “set” lifetimes. Varyingenvironmental factors affect the pliability andadhesiveness of sealants.

83


WARNINGIf your RV is equipped with a roof ladder, do not leave items attached to it whiletraveling. The ladder has a weight limit of350# when using it to access the roof. DONOT exceed this weight limit.

CAUTIONDo not add items to the RV rear bumper.Add-on items will eventually damage yourbumper. Damage caused by suchaftermarket equipment installation orimproper loading voids the TowableLimited Warranty.

CAUTIONFailure to properly maintain or reseal yourRV may result in serious water damage tothe roof and other parts of the RV. Thisdamage is not covered by the TowableLimited Warranty.

CAUTIONTo check the exterior sidewall sealants, use a stepladder placed safely beside the RV.Do not prop a ladder against the body of the RV as it may damage the finish.

Sealants can be affected by ultravioletexposure, air pollution, extreme temperaturesand exposure to other elements. Conditionssuch as rain, salt, dust and pollution mayincrease the need to maintain your RV’ssealants. Checking the sealants is consideredcustomer maintenance.

It is recommended that you or your dealerinspect all sealants a minimum of every sixmonths. Make sure to check the roof and allfour sides of the RV including all moldings,windows, doors, vents and exteriorattachments. Reseal as necessary and atleast one time each year as preventativemaintenance.

0 Replace sealant and cap seal if you noticeany cracks, gaps, lifting, looseness,peeling, shrinkage, voids or any sign ofphysical deterioration. Complete your

repairs immediately to prevent damage toyour RV.

0 Always use the same type of sealantoriginally used to build your RV. Consultyour dealer for assistance with the propersealant(s) to use on the specific area(s) ofyour RV.

0 If you notice water inside the RV,immediately have the dealer check for thesource of the leak. Failure to correct theleak may result in serious damage to yourRV; this damage may not be warrantable.

Although the diagrams below may notaccurately reflect the exact model of your RV,make sure you inspect all sealants asindicated in the text. If you have questionsand/or need assistance with sealing your RV,consult with your dealer.

84


A/CA/C

112

3

44

4 4

44

44

55

5

56

66

6

JaycoJayco4 4

4

11

1 1

4

66

5

2 2

2

63 3

JaycoJayco

A/CA/C

1

1

1 1

1

1

1 1

2

22 2

3

3

3

3

3 3

3

33

44 4 4

4 44

4

4

4 4 4

5 55

545

5

6

6

6

6

6

2

5

1 = Moldings2 = Vents/Attachments to Roof3 = Slideout Trim/Moldings

4 = Windows/Doors5 = Exterior Attachments6 = Marker & Tail Lights

STORAGE CHECKLIST

Prior to StorageIf storing for the winter, be sure the RV iswinterized (refer to Sec. 5 Plumbing System,Winterizing the plumbing system).

– Check your roof and other surfaces toensure there is no damage and potentialleakage that might otherwise go unnoticeduntil it is too late.

– Close all windows and roof vents.

– Close the propane cylinder valve(s). If yourcylinders do not already have a cover,purchase at least a vinyl propane cylindercover and make sure the regulator iscovered.

– Cover all external outlets, such as furnace,exhaust, etc. to prevent mice or otherrodents from entering.

– Cover the roof air conditioner.

– Disconnect 120-volt AC power to the RV.

– Do not use the stabilizing jacks duringstorage.

– Drain all water lines.

– Drain and flush all holding tanks (freshwater, gray water, black water and/or hotwater tanks).

– Inspect the sealant and reseal as needed.

– Remove all batteries from the RV and storein a place where they won’t freeze. Batteries that have been frozen will never hold aproper charge.

– Remove all perishable items from theinterior. If storing during the winter months,include any items that are susceptible tofreezing.

– Store your RV indoors, under a roof orpurchase a tarp to cover your RV duringstorage. Make sure you invest in a good tarp that can “breathe.

– Thoroughly wash the interior and theexterior of your RV.

– To prevent weather checking and other UVdamage, cover tires that are exposed tosunlight.

– Turn all cushions on edge to prevent themoisture/mildew buildup during storage.

– Turn off 12-volt DC/120-volt AC/propane tothe refrigerator; defrost and clean. Usecrumpled newspaper or open boxes ofbaking soda in the refrigerator to eliminateodors during storage.

During Storage Period

– Remove snow loads from the top of your RVto prevent damage to the unit’s structure.

MAINTENANCE CHECKLISTThis list is a quick reference sheet forsuggested areas of regular maintenance.Review all OEM operator’s manuals suppliedwith your RV to perform these listedmaintenance items.

Prior to First Trip

– Check propane lines for leaks.

– Check wheel lug nuts at specified intervalsto listed torque specifications, re-torque asneeded (refer to the axle OEM operator’smanual).

– Open all windows and the entry door, startthe furnace. Leave the windows and dooropen and the furnace ON until the odor fromthe initial use of the furnace is fullydissipated.

– Sanitize fresh water system.

– Test propane, smoke and carbon monoxidedetectors.

First Two-Hundred Miles

– Check wheel nuts at specified intervals tolisted torque values. Re-torque as needed.Refer to the axle manufacturer's manual.

– Have brakes adjusted by a qualified servicetechnician.

85


CAUTIONExcessive snow, 8" or more, or ice, 2" ormore, places excessive weight on the RVroof. Remove excessive snow or ice asneeded. Care MUST be exercised to notdamage the roof material when removingsnow & ice. Excessive weight can damagethe roof, seals, etc. Water leaks and poor fitor operation are the results of this damage.

Each Trip

– Check battery water level (If equipped withbattery.)


– Check running lights.

– Check tire pressure and wear. Make surethe tires are cold when checking the tirepressure.

– Flush out water heater tank.

– Inspect safety chains for signs of wear. (Ifapplicable)

– Test brakes.


After Every Tire Change

– Tighten wheel nuts to specified torquevalues at 10, 25 and 50 miles (16, 40, and 80 kilometers) to assure that they are correctly“seated” after the tire change. Refer to theaxle OEM operator’s manual.

Daily

– Ensure propane detector operation light isgreen in color.

– Recharge battery after each use.

Weekly


– Check tire pressure and wear. Make suretires are cold when checking the tirepressure.


Monthly

– Check fire extinguisher pressure. Refer tothe fire extinguisher label for specificinstructions.

– Clean and lubricate the coupler (ifapplicable)

– Test the ground fault circuit interrupter(GFCI)

Every Three Months or 3,000 Miles


– Check wheel nuts at specified intervals tolisted torque values. Re-torque as needed.Refer to the axle manufacturer’s manual.

– Check, clean, tighten and lubricate batterycables.

– Compare refrigerator pilot flame with idealflame. Refer to the refrigerator OEMoperator’s manual for ideal flame. Havecleaned and adjusted as necessary by aqualified technician. (RV type refrigeratoronly)

– Compare water heater pilot flame with idealflame. Refer to the water heater OEMoperator’s manual for ideal flame. Havecleaned and adjusted as necessary by aqualified technician.

– Drain and sanitize fresh water system.

– Examine the tires for unusual wear, sidewalldefects from possible cuts, bulging andabrasions.

– Have brakes adjusted by a qualified servicetechnician.

– Inspect propane cylinders for rust, pits,gouges, scrapes or sharp dents. Repaintcylinders if rust is present.

– Inspect refrigerator combustion seals. Havecleaned and adjusted as necessary by aqualified RV technician. (RV typerefrigerator only)

– Inspect refrigerator door seal.

– Lubricate hitch ball (if applicable)

– Lubricate tongue jack (if applicable)

Every Six Months or 6,000 Miles

– Check pipe connections for tightness.Tighten if necessary. Lubricate all movingparts on the entrance steps.

– Clean and lubricate stabilizer jacks.

– Clean drains with approved drain cleaners.

– Have suspension system serviced by aqualified service technician.

– Inspect and reseal as defined earlier in thischapter.

– Inspect wheels for cracks, dents ordistortion.

– Lubricate entrance and baggage door locks.

– Lubricate the bearing surface between therotating gear housing and the base plate onthe television antenna.

– Lubricate the elevating gear on thetelevision antenna.

86


– Lubricate the rubber quad ring on theelevating shaft located on the televisionantenna.

– Perform routine preventative maintenanceon entire trailer and all component parts.

Every Year or 12,000 Miles

– Apply silicone spray to the fifth-wheellanding gear inner tube and pad and theinside of the handle alignment tube. (ifapplicable)

– Check demand tank vent for obstructions.

– Check water pump connections andmountings for tightness.

– Clean city water entry strainer.

– Grease gears in the gear box and at the topof each leg of the fifth-wheel landing gearwith extreme pressure grease. (ifapplicable)

– Have brakes inspected and serviced by aqualified technician.

– Have furnace inspected and serviced by aqualified technician.

– Have propane system inspected andserviced by a qualified technician.

– Have the refrigerator inspected andserviced by a qualified technician.

– Inspect and reseal as defined earlier in thischapter.

– Lubricate moving parts on the awninghardware. (Awning option only.)

– Manually operate the pressure-temperaturecontrol lever on the water heater.

– Oil the shaft bushings of the fifth-wheellanding gear with SAE 30 oil. (if applicable)

– Perform routine preventative maintenanceon entire trailer and all component parts.

– Repack wheel bearings.

– Replace battery on the carbon monoxidedetector.

– Rotate fluorescent tubes in the light fixtures.

Every Five Years

– Replace propane and carbon monoxidedetectors.

87



88


SPECIFICATIONS & GLOSSARY

OEM LISTThe following chart provides information to contact some of the individual original equipmentmanufacturers (OEM) of appliances/component parts that may be installed on your RV. Theinformation listed in this chart is the latest available at the time of publication of this manual. If you have questions or concerns on component parts not listed here, contact your RV dealer for furtherassistance.

Component Part OEM Website Phone #

Air Conditioner Coleman www.rvcomfort.com/rvp (316) 832-4357

Attic Fan (power) Ventline www.ventline.com (574) 848-4491

Awning Carefree of Colorado www.carefreeofcolorado.com (800) 622-3230

Axle Dexter Axle www.dexteraxle.com (574) 295-7888

BBQ GrillVitcoC-Land Manufacturing

www.vitco.comwww.clandmanufacturing.com

(877) 736-2635(352) 624-9667

Carbon Monoxide Alarm Quantum www.qginc.com (800) 432-5599

Converter Iota www.iotaengineering.com (520) 294-3292

DVD/CD Contact your RV dealer

Entrance Step Hickory Springs www.hickorysprings.com (800) 438-5341

Exhaust Fan Ventline www.ventline.com (574) 848-4491

Fifth Wheel LandingGear

Atwood www.atwoodmobile.com (815) 877-5700

Furnace Atwood/Hydroflame www.atwoodmobile.com (815) 877-5700

Microwave Contact your RV dealer

Outside Shower B & B Molders www.bandbmolders.com (574) 259-7838

Propane Alarm MTI www.mtiindustries.com (800) 383-0269

Propane Cylinder Manchester Tank www.manchestertank.com (800) 877-8265

Propane Regulator Marshall Brass www.marshallbrass.com (800) 447-9513

Range Atwood www.atwoodmobile.com (815) 877-5700

Rangehood Ventline www.ventline.com (574) 848-4491

Refrigerator Norcold www.norcold.com (800) 543-1219

RV Frame Leland Engineering www.lelandengineering.com (800) 669-7681

Slideout (main) V-tech n/a(574) 294-6409(574) 266-7356

Slideout (sofa) RBW Industries www.rbwindustries.com (800) 451-7821

Smoke Alarm MTI www.mtiindustries.com (800) 383-0266

Speakers Contact your RV dealer

Television Contact your RV dealer

Thermostat Coleman www.rvcomfort.com/rvp (316) 382-4357

Tires Contact your local tire distributor for assistance

Toilet Thetford www.thetford.com (800) 521-3032

TV Antenna Winegard www.winegard.com (800) 788-4417

Water Filter Flowmatic www.flowmatic.com (800) 461-4406

Water Heater Atwood www.atwoodmobile.com (815) 877-5700

Water Pump Shurflo www.shurflo.com (800) 854-3218

89

SECTION 12SPECIFICATIONS & GLOSSARY

OEM WHEEL LUG TORQUE CHARTWheel Lug Nut Diagrams:

Wheel Torque Instructions: *All torque wrenches mentioned below must have settings visible for auditing purposes.

1. Start lug nuts with fingers on studs to avoid cross threading.

2. Stage 1, Torque: Impact lug nuts in a star pattern* until snug to rim. –See Wheel Lug Nut Diagram

3. Stage 2,Torque: Use properly calibrated torque wrench to torque each lug nut, in a star pattern, tothe values indicated. Wheels must remain stationary during torquing process for control purposes. –See Wheel Lug Nut Torque Chart and Wheel Lug Nut Diagram

4. Stage 3, Torque: Use properly calibrated torque wrench to torque each lug nut, in a star pattern, tothe values indicated. Wheels must remain stationary during torquing process for control purposes. –See Wheel Lug Nut Torque Chart and Wheel Lug Nut Diagram

Lug Nut Rim Type Stage 1 Stage 2Stage 3

Recommended FinalTorque Range

AcceptableTorque Range

4-Lug Nuts 12" Steel 20-25 ft/lbs 30-50 ft/lbs 65-75 ft/lbs 50-75ft/lbs

5-Lug Nuts 13" Steel 20-25 ft/lbs 30-50 ft/lbs 65-75 ft/lbs 50-75ft/lbs

5-Lug Nuts 13" Chrome 20-25 ft/lbs 30-50 ft/lbs 65-75 ft/lbs 50-75ft/lbs

5-Lug Nuts 14" Steel 20-25 ft/lbs 70-90 ft/lbs 110-120 ft/lbs 90-120 ft/lbs

5-Lug Nuts 14" Chrome 20-25 ft/lbs 70-90 ft/lbs 110-120 ft/lbs 90-120 ft/lbs

5-Lug Nuts 14" Aluminum 20-25 ft/lbs 70-90 ft/lbs 110-120 ft/lbs 90-120 ft/lbs









90


1

2

34

1

2

34

5

1

2

3

4 5

6

4-Lug Nuts 5-Lug Nuts 6-Lug Nuts

1

2

3

4 5

6

78

8-Lug Nuts

DC FUSE PANEL LAYOUTBelow is a typical wiring layout. Your individual trailer may be different.

# Size Function

1 12.5 amp breaker Bedroom Slideout Motor

2 15 amp fuse Bathroom Lights & Vent

3 15 amp fuse Monitor Panel/Holding Tanks/Water Pump/Water Heater/Sink Lights

4 15 amp fuse Refrigerator/Furnace

5 15 amp fuse Bedroom Lights

6 15 amp fuse Propane Detector/TV Outlet

7 15 amp fuse Porch/Entry/Main Living Area Lights

8 15 amp fuse Bunk/Rear Ceiling/Trunk Lights

9 15 amp fuse Main Slideout Lights

10 15 amp fuse Option

11 15 amp fuse Option

12 20 amp breaker Main Slideout Motor

CIRCUIT BREAKERSThe following table provides generic circuit breaker alignment information. Your RV may not be exactly the same as shown depending on model, floor plan and options.

Main 30-amp main, incoming power to unit

A 15-amp microwave

B 15-amp refrigerator/GFCI (kitchen/bath)

C 20-amp air conditioner

D 15-amp utility/converter

E 15-amp water heater

PROPANE CONSUMPTION CHARTThe following chart provides an average propane consumption information.

ApplianceApproximate BTU Consumption

Per HourApproximate

Kilojoules Per Hour

Water Heater 12,000 12,660

Refrigerator 1,500 1585

Furnace 16,000 - 35,000 16,880 - 36,930

Range w/ Oven 29,100 30,700

Slide-in Cooktop - 3 burner 22,000 23,200

91


APPROXIMATE ELECTRICAL LOAD RATINGSUse actual amperage (or wattage divided by 120) of appliance being used whenever possible.

120 VOLT SYSTEM

AIR CONDITIONER - COLEMAN MACH 13,500 BTU (RUN) 13.50-16.25 AMPS

AIR CONDITIONER - COLEMAN MACH 13,500 BTU (START UP) 15.75-16.25 AMPS*

BLENDER (ESTIMATED 300-400W) 2.50-3.50 AMPS

COFFEE MAKER (ESTIMATED 1000-1300W) 7.00-11.00 AMPS

CONVERTER - SINGLE 45 AMPS (IOTA 750W) 5.00-6.25 AMPS

CURLING IRON (ESTIMATED 50-100W) .50-1.00 AMPS

ELECTRIC BLANKET (ESTIMATED 150-200W) 1.25-1.75 AMPS

ELECTRIC FAN - PORTABLE (ESTIMATED125-175W) 1.00-1.50 AMPS

ELECTRIC FRYING PAN (ESTIMATED 1000-1200W) 8.50-10.00 AMPS

HAIR DRYER (ESTIMATED 1000-1900W) 8.50-16.00 AMPS

HOME THEATER SYSTEM (EXECUTIVE 128W, MEMOREX 133W) 1.25-1.75 AMPS

LAPTOP COMPUTER CHARGER (ESTIMATED 25-75W) .25-75 AMPS

MICROWAVE OVEN (900-1500W) 7.50-12.50 AMPS

RADIO (ESTIMATED 10-35 W) .10-.30 AMPS

REFRIGERATOR - RV GAS/ELECTRIC (NORCOLD #611 300W, #821 300W) (ESTIMATED250-350W)

2.00-3.00 AMPS

SATELLITE RECEIVER (ESTIMATED 50-150W) .50-1.25 AMPS

STEAM IRON (ESTIMATED 1000-1500W) 8.50-12.50 AMPS

TELEVISION (ESTIMATED 65-2100W) .50-2.00 AMPS

TOASTER (ESTIMATED 1000-1500W) 8.50-12.50 AMPS

TOASTER OVEN (ESTIMATED 1100-1600W) 9.25-13.50 AMPS

VCR (ESTIMATED 25-75W) .25-75 AMPS

WATER HEATER - RV GAS/ELECTRIC (ATWOOD 11.66 AMPS) 11.75-12.25 AMPS

12 VOLT SYSTEM

AISLE LIGHTS 1.0 AMPS

BAGGAGE COMPARTMENT LIGHTS 1.4 AMPS

BEDROOM RADIO 1.5 AMPS

DECORATIVE WALL LIGHTS 1.5 AMPS

EXTERIOR ENTERTAINMENT CENTER 5.0 AMPS

FANTASTIC FAN 5.0 AMPS

FLUORESCENT DOUBLE 12" 2.0 AMPS

FLUORESCENT DOUBLE 18" 2.5 AMPS

FURNACE 12.0 AMPS

HALOGEN LIGHT 1.5 AMPS

ILLUMINATED SWITCH .50 AMPS

LP DETECTOR ALARM 1.0 AMP

PORCH LIGHT 1.50 AMPS

POWER VENT 2.0 AMPS

REFRIGERATOR 3.0 AMPS

TV PLATE/ANTENNA BOOSTER 1.0 AMP

WATER HEATER 6.0 AMPS

WATER PUMP 7.0 AMPS

*MOMENTARY LOAD

92


GLOSSARY OF TERMS

AC ELECTRICITY – Alternating current also known as shoreline power. For purposes ofthis manual, it refers to 120-volt AC(abbreviated 120 VAC).

AUXILIARY BATTERY – For purposes ofthis manual, the term refers to the 12-volt DCgroup 27 deep cycle battery (customerpurchased) that should be installed in yourcamper.

BLACK WATER – Term associated with the sewage holding tank. The toilet drains directlyinto this tank.

BRITISH THERMAL UNIT (BTU) - Measurement of heat that is the quantityrequired to raise the temperature of one pound of water 1°F. RV air-conditioners and furnacesare BTU-rated.

CAMP STORE – A store that usually hasbread, milk and other essentials but not freshmeats, fruits or vegetables.

CAMPER – For purposes of this manual, this term refers to your conventional travel trailer or fifth wheel travel trailer.

CAMPING - An outdoor recreational activityinvolving the spending of one or more nights ina tent, primitive structure or recreation vehicleat a campsite with the purpose of getting awayfrom civilization and enjoying nature.

CAMPSITE - The term usually means anarea where an individual or family might gocamping.

CARBON MONOXIDE – A colorless,odorless and poisonous gas.

CARGO CARRYING CAPACITY (CCC) - Equal to GVWR minus each of the following:UVW, full fresh (potable) water weight(including water heater), full propane weightand SCWR.

CITY WATER – Term associated with thewater supply you hook up to at the campsite. It

is called city water because water is pulledfrom a central outside source (like a city) andnot the fresh water tank.

CURBSIDE – This refers to the side of thecamper that faces the curb when parked. Alsoreferred to as the door side.

DC ELECTRICITY – Direct current alsoknown as auxiliary battery power. Forpurposes of this owner’s manual, it refers to12-volt DC (abbreviated 12 VDC).

DEALER – For purposes of this manual, thisrefers to the independent dealer authorized tosell and/or service your camper by Jayco, Inc.This term will be used in this context unlessspecified otherwise.

DRAIN TRAP – This is the curve that is in alldrains. Water is trapped in the curve andcreates a barrier so tank odors cannot escapethrough the drain.

DRY CAMPING – Camping when there is no city water hookup or shore power (i.e., usingonly the water and power available in thecamper and not from any other source).

DUMP STATION – Site where you drainyour gray water (waste) and your black water(sewage) tanks. In most states, it is illegal todrain your tanks anywhere except dumpstations.

DUMP VALVE – Another name for theT-handle valve used to release and drain theblack tank (sewage) and gray tank (waste).

EGRESS WINDOW – The formal name forthe emergency escape window. Egresswindows are identified by their labeling.

FRESH WATER – The fresh water systemprovides potable water to the fresh water tank,kitchen sink, shower, bathroom lavatory, toilet, water heater and outside shower.

FULL HOOK-UP SITE – A campsite thathas city water, shore power and sewerhook-ups or connections available.

93


GRAY WATER – Term associated with thewaste water holding tank. Water from the sinkdrains, shower and washer/dryer (if soequipped) go into this tank.

GROSS AXLE WEIGHT RATING (GAWR) – The MAXIMUM ALLOWABLE WEIGHT each

axle assembly is designed to carry, asmeasured at the tires, therefore including theweight of the axle assembly itself. GAWR isestablished by considering the rating of eachof its components (tires, wheels, springs,axle), and rating the axle on its weakest link.The GAWR assumes that the LOAD ISEQUAL ON EACH SIDE.

GROSS CARRYING CAPACITY (GCC) - Means the maximum carrying capacity of yourcamper. The GCC is equal to the GVWRminus UVW. The GCC will be reduced by theweight of fresh water or other tanks, propane,occupants, personal items or dealer installedaccessories.

GROSS COMBINED WEIGHT RATING(GCWR) – The MAXIMUM ALLOWABLECOMBINED WEIGHT of the tow vehicle andthe attached towed vehicle. GCWR assumesthat both vehicles have functioning brakes,with exceptions in some cases for very lighttowed vehicles, normally less than 1,500pounds. (Check your tow vehicle’s towingguide.)

GROSS TRAILER WEIGHT RATIING(GTWR) - The MAXIMUM TOWEDVEHICLE WEIGHT. Each component(receiver, drawbar, ball) of a ball-type hitch has its own rating. Some ball-type hitches haveseparate ratings when used with a weightdistributing system.

GROSS VEHICLE WEIGHT RATING(GVWR) – The MAXIMUM ALLOWABLEWEIGHT of the fully loaded vehicle, includingliquids, passengers, cargo, and the tongueweight of any towed vehicle.

HITCH WEIGHT – The amount of thecamper’s weight that rests on the tow vehicle.It should be approximately 10% - 15% with

conventional trailers; approximately 15% -20% for fifth wheels.

LOW POINT – The lowest point in theplumbing. Drains are placed here so that water will drain out of the lower end of the camperwhen flushing or winterizing the water system.These drains must be closed when you fill thewater tank.

NET CARRYING CAPACITY (NCC) - TheMAXIMUM WEIGHT of all personalbelongings, food, fresh water, propane, tools,dealer installed accessories, etc., that can becarried by the RV.

OEM – This refers to the original equipmentmanufacturer of the individual appliances orcomponents.

PRIMITIVE SITE – A campsite that mayhave city water, shore power or sewerhook-ups but not all of them; primitive sitesmay have no hook-ups or connections at all.

PULL-THROUGH SITES – Campsites youcan drive through and park (without having toback up into the site).

ROADSIDE – This refers to the side of thecamper that faces the road when it is parked.Often called the off-door side.

SANITIZATION – Refers to the camper’sfresh water system that has been sanitizedwith chlorine bleach before use or afterstorage.

POWER SOURCE – Also referred to asshore power, this refers to the receptacleoutlet you are using to plug in your shorelinepower cord. This can be a campsite power boxor electrical box, a residential receptacle outlet specifically wired for your camper or agenerator (customer supplied).

SHORELINE POWER CORD – This is theelectrical power cord that runs from thecamper to the campsite shore power outlet.

94


SLEEPING CAPACITY WEIGHT RATING(SCWR) – The manufacturer's designatednumber of sleeping positions multiplied by 154pounds (70 kilograms).

TIRE RATINGS - The MAXIMUM LOAD that a tire may carry is engraved on the sidewall,along with a corresponding COLD inflationpressure. A reduction in inflation pressurerequires a reduction in load rating. Tiremanufacturers publish charts that establishthe load capacity at various inflationpressures.

TONGUE WEIGHT, TONGUE LOAD,VERTICAL LOAD (TWR/TLR/VLR) - Tongue Weight, Tongue Load, Vertical LoadRating Different terms for the MAXIMUMVERTICAL LOAD that can be carried by thehitch UNLOADED.

UNLOADED VEHICLE WEIGHT (UVW) - The WEIGHT of a vehicle as built at the factory with full fuel, engine (generator) oil andcoolants. It does not include cargo, freshwater, propane, occupants, or dealer installedaccessories.

WEIGHT & LOAD - These terms aregenerally used interchangeably. For thepurposes of understanding RV applications,vehicles have WEIGHT, which impart LOADSto tires, axles and hitches. Scalemeasurements taken when weighing areLOADS carried by the tires. These measuredloads are used to calculate Gross VehicleWeight (GVW), Gross Axle Weight (GAW),Gross Combination Weight (GCW), and hitchloads.

WINTERIZED – Refers to a camper that hasbeen prepared for storage. The water systemshave been drained and RV antifreeze hasbeen added to protect the water lines anddrains. The low point drains should be in theopen position.

95



96


ADDENDUMS

There are no addendums issued at this time.

97

SECTION 13ADDENDUMS


98

SECTION 13ADDENDUMS

travel trailer owner’s manual - jayco, inc · travel trailer owner’s manual model year 2008

Documents