tm 9-6920-483-34-2_dragon_ir_set_m89_1982
TRANSCRIPT
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
1/65
TM 9-6920-483-34-2
TECHNICAL MANUAL
DS AND GS MAINTENANCE MANUAL
F A U L T I S O L A T I O N I N S T R U C T I O N S
F O R I R T R A N S M I T T I N G S E T M 8 9
DRAGON MEDIUMANTITANK/ASSAULT WEAPON SYSTEM
HEADQUARTERS, DEPARTMENT OF THE ARMY
JULY 1982
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
2/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
3/65
SAFETY SUMMARY
The following are general safety precautions that personnel must understand and apply during operation
and maintenance.
KEEP AWAY FROM LIVE CIRCUITS
Operating personnel must observe safety regulations at all times. Do not replace components or make
adjustments inside the equipment with high voltage present. Under certain conditions, dangerous
potentials may exist when the power control is in the OFF position. To avoid injury, remove power and
discharge and ground a circuit before touching it.
DO NOT SERVICE OR ADJUST ALONE
Under no circumstances should any person reach into the enclosure for the purpose of servicing oradjusting the equipment except in the presence of someone who is capable of rendering aid.
RESUSCITATION
Personnel working with or near high voltages should be familiar with modern methods of resuscitation.
WARNING
Personnel must wear safety goggles when destroying the I R lamp assembly to prevent eye damage or loss
of sight.
The lamp bulb in the I R source is pressurized to about 215 psi. Safety goggles shall be worn and a
protective shield for the body (such as plexiglass panel) shall be used whenever disassembly beyond the
filter retainers (i.e., within the housing) is necessary. If lamp bulb is to be handled, light gloves shall be
worn. Failed bulbs shall be disposed of by enclosing them within a thick plastic bag before breakingwith a tool with a fIat surface such as a shovel. Disposal techniques similar to those for cathode ray
tubes are recommended.
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
4/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
5/65
Technical Manual ))
No. 9-6920-483 -34-2 )
DS AND GS MAINTENANCE
*TM 9-6920-483
HEADQUARTERS,
DEPARTMENT OF THE A
Washington, D. C., 27 July
MANUAL:
FAULT ISOLATION INSTRUCTIONS FOR IR TRANSMITTING SET M89
(DRAGON MEDIUM ANTITANK/ASSAULT WEAPON SYSTEM)
CHAPTER 1. INTRODUCTION
Purpose and scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Troubleshooting procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Forms, records, and reports. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Security responsibilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reports of equipment manual improvements . . . . . . . . . . . . . . . .
CHAPTER 2. FAULT ISOLATION
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Test sequence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Special equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Repair parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Paragraph
1-1
1-21-31-41-5
2-12-22-32-4
*This manual supersedes TM 9-6920-483-34-2, 31 January 1977, including
a l l c h a n g e s .
i/(ii blank)
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
6/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
7/65
TM 9-6920-483-34-2
CHAPTER 1
INTRODUCTION
1-1. PURPOSE AND SCOPE.
This manual contains fault isolation instructions for, the direct support and general support maintenanceof the M89 infrared transmitting set.
1-2. TROUBLESHOOTING PROCEDURES.
Troubleshooting and testing of the training equipment and subassemblies will be accomplished by theprocedures contained in chapter 2, and the schematics in TM 9-6920-483-34-1.
1-3. FORMS, RECORDS, AND REPORTS.
All personnel and organizations responsible for operating and/or maintaining this equipment are alsoresponsible for the preparation and disposition of appropriate forms, records, and reports.
1-4. SECURITY RESPONSIBILITIES.
a. The security classification of the DRAGON Weapon System Equipment is UNCLASSIFIED.Portions of data relative to the DRAGON system are classified.
b. The importance of security of classified material cannot be overemphasized. Security is anindividual as well as a Command responsibility.
c. Safeguarding of classified material will be accomplished in accordance with current directives.
1-5. REPORTS OF EQUIPMENT MANUAL IMPROVEMENTS.
Reports of errors, omissions, and recommendations for improving this publication by the individualuser are encouraged. U.S. Marine Corps reports should be submitted on Form NAVMC 10772 inaccordance with MCO 5600.4 — All other should be submitted on DA Form 2028, RecommendedChanges to Publications, and forwarded directly to: Commander, U.S. Army Missile Command, ATTN:DRSMI-SNPM, Redstone Arsenal, Alabama 35898.
1-1/(1-2 blank)
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
8/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
9/65
TM 9-6920-4
CHAPTER 2
FAULT ISOLATION
2-1. GENERAL.
a. This procedure is designed to be used by an electronics technician when the target source fails toperform correctly.
b. We strongly recommend that you start at the beginning of thenot skip or omit anything unless instructed, because the procedure isin this sequence.
2-2. TEST SEQUENCE.
Test sequences referenced in the procedure are:
“Troubleshooting The Power Supply Modulator” Instructions . . . . . .Lamp - “Failure to Modulate” - Instructions . . . . . . . . . . . . . . . . . . . .“Troubleshooting the PCA Card” Instructions . . . . . . . . . . . . . . . . . .
Output Power Calibration Instructions . . . . . . . . . . . . . . . . . . . . . . . .
2-3. SPECIAL EQUIPMENT.
Two pieces of special equipment required to perform these tests are:
procedure and work through, anddesigned to work effectively only
. . . . . . . . . . . begin on page 2-10
. . . . . . . . . . . begin on page 2-27
. . . . . . . . . . . begin on page 2-30
. . . . . . . . . . . begin on page 2-46
Tektronix type 422 oscilloscope -or- equivalent (with a compensated probe)Fluke digital multimeter, type 853A-03 -or- equivalent
Additional piece of equipment required to perform PSM Output Power Calibration
Variable power supply 24 Vdc to 30 Vdc @ 30 Amps.
2-4. REPAIR PARTS.
Refer to TM 9-6920480-24P-1 for repair parts.
2-1
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
10/65
TM 9-6920-483-34-2
TO perform repairs on the TARGET SOURCE (TS)& the POWER SUPPLY MODULATOR (PSM)
YOU need to understand each unit’s purpose& the functions it provides.
The TARGET SOURCEhouses/ cool s t he Xenon l amp
& provi des opti cal fi l teri ng for the radi ated li ght
BEFORE ANY ELECTRICAL TESTING ALWAYS USE E12 & E13 FOR GROUND CONNECTIONtest all cables for continuity between appropriate pins
for shorts between adjacent pins0
TO OBSERVE WAVE-FORMS• IF ANY TEST FAILS TO FIND FAULTY COMPONENT use Tektronix 422 oscilloscope or equivalent
look for circuit wiring “OPENS”look for circuit wiring ERRORS
use a compensated probe
look for circuit wiring “SHORTS”0
FOR DC VOLTAGE MEASUREMENT & CONTINUITY CHECKS• A FAILURE NOT UNCOVERED BY INSTRUCTIONS (during testing) use Fluke Digital Multimeter or equivalent
is cause to continue the test series (if possible)as the failure is likely located by a later test • ALL RESISTANCE VALUES ARE IN OHMS
• VOLTAGE READINGS ARE TO GROUND
2-2
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
11/65
TM 9-6920-4
The POWER SUPPLY MODULATORprovi des cooli ng f or it self provi des the l amp
wi th regul ated/ modul ated power and i ts monit ori ng& wi th controll ed boost vol tage for starti ng
has a DC-t o-DC converterhas a modul ati on and power control cardhas current and vol tage contr ol & swi tchi ng for l amp starti ng
arc stabi l i zi ng& normal operati on.
GENERAL STRATEGY
FI RST i sol ate t he problem to t he TARGET SOURCE(TS)or POWER SUPPLY MODULATOR(PSM)
I F BOTH ARE FAULTY - repai r t he PSM f i rst .
SECOND determi ne those basi c funct i ons not operati ng normal l y.
THI RD i sol ate the fai l ed componentby checking the operati on of al l mi nor ci rcui t f uncti ons
contri buti ng to the faul ty basi c f uncti on.
26V power cable l eads
2-3
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
12/65
TM 9-6920-483-34-2
2-4
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
13/65
TM 9-6920-483-34-2
2-5
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
14/65
9-6920-483-34-2
2-6
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
15/65
TM 9-6920-48
2-7
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
16/65
TM 9-6920-483-34-2
2-8
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
17/65
TM 9-6920-4
2-9
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
18/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
19/65
TM 9-6920-4
2-11
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
20/65
920-483-34-2
2-12
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
21/65
TM 9-6920-4
2-13
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
22/65
TM 9-6920-483-34-2
2-14
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
23/65
TM 9-6920-4
2-15
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
24/65
M 9-6920-483-34-2
2-16
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
25/65
TM 9-6920-4
2-17
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
26/65
TM 9-6920-483-34-2
2-18
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
27/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
28/65
TM 9-6920-483-34-2
2-20
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
29/65
TM 9-6920-4
2-21
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
30/65
M 9-6920-483-34-2
2-22
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
31/65
TM 9-6920-4
2-23
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
32/65
M 9-6920-483-34-2
2-24
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
33/65
TM 9-6920-4
2-25
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
34/65
TM 9-6920-483-34-2
2-26
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
35/65
TM 9-6920-4
2-27
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
36/65
TM 9-6920-483-34-2
2-28
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
37/65
TM 9-6920-4
2-29
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
38/65
M 9-6920-483-34-2
2-30
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
39/65
TM 9-6920-483-34-2
2-31
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
40/65
TM 9-6920-483-34-2
2-32
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
41/65
TM 9-6920-4
2-33
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
42/65
M 9-6920-483-34-2
2-34
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
43/65
TM 9-6920-4
2-35
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
44/65
M 9-6920-483-34-2
2-36
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
45/65
TM 9-6920-4
2-37
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
46/65
TM 9-6920-483-34-2
2-38
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
47/65
TM 9-6920-4
2-39
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
48/65
TM 9-6920-483-34-2
2-40
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
49/65
TM 9-6920-483-34-2
2-41
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
50/65
M 9-6920-483-34-2
2-42
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
51/65
TM 9-6920-4
2-43
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
52/65
20-483-34-2
2-44
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
53/65
TM 9-6920-4
2-45
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
54/65
TM 9-6920-483-34-2
2-46
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
55/65
TM 9-6920-4
2-47
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
56/65
TM 9-6920-483-34-2
2-48
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
57/65
TM 9-6920-
2-49
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
58/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
59/65
By Order of the Secretary of the Army:
E. C. MEYERGeneral, United States Army
Chief of Staff
Official:
ROBERT M. JOYCE Brigadier General, United States Army
The Adjutant General
D i s t r i b u t i o n :
These copies are for s tockage only to be is sued upon reques t for Fore ignMil i ta ry Sales Cases .
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
60/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
61/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
62/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
63/65
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
64/65
PIN: 015062-0
-
8/9/2019 TM 9-6920-483-34-2_DRAGON_IR_Set_M89_1982
65/65
This fine document...
Was brought to you by me:
Liberated Manuals -- free army and government manuals
Why do I do it? I am tired of sleazy C-!"M sellers# $ho ta%e &ubliclyavailable information# sla& '$atermar%s( and other )un% on it# and sell it.Those masters of search engine mani&ulation ma%e sure that their sites thatsell free information# come u& first in search engines. They did not create it...They did not even scan it... Why should they get your money? Why are notletting you give those free manuals to your friends?
I am setting this document *!++. This document $as made by the ,
overnment and is /"T &rotected by Co&yright. *eel free to share#re&ublish# sell and so on.
I am not as%ing you for donations# fees or handouts. If you can# &lease&rovide a lin% to liberatedmanuals.com# so that free manuals come u& first insearch engines:
Free Military and o!ernment Manuals
–"incerely#$or %hudo!
http://www.liberatedmanuals.com/http://www.liberatedmanuals.com/http://www.liberatedmanuals.com/http://www.liberatedmanuals.com/