small scale sewage treatment and reuse system for...
TRANSCRIPT
![Page 1: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/1.jpg)
SmallScaleSewageTreatmentandWastewaterReuseSystemforPakistan
Principal Investigators
Dr. Safia AhmedProfessor and ChairProfessor and Chair
Department of MicrobiologyQuaid‐i‐Azam University, Islamabad, Pakistan
Dr. Rumana RiffatProfessor and Associate Dean for Academic Affairs
School of Engineering and Applied ScienceThe George Washington University Washington DC USAThe George Washington University, Washington DC, USA
![Page 2: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/2.jpg)
IntroductionIntroduction
• Water scarcity is a major problem in the world• 60% of world population will experience it by 2025.• The situation is much worse in developing countries. (Causes 80‐90% of all diseases and 30% of all deaths)
• Millions of people, especially those living in poorly developed countries have little access to proper sewage disposal.
• The presence of different contaminants in untreated sewage is a major source of contamination of freshwater resources.
• Proper treatment of sewage, and reclamation and reuse of wastewater is becoming a sustainable solution for clean water.
![Page 3: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/3.jpg)
ObjectivesObjectives
• The objective of this research was to develop an efficient j pmethod for treatment of sewage, and reuse of the wastewater and biosolids, which will improve public health and sanitation as well as reduce water shortagehealth and sanitation, as well as reduce water shortage.
• Four treatment systems were proposed for investigation y p p gin this study. They were:
(i) Dual Digestion. ( ) kl l(ii) Trickling Filter System.(iii) Constructed Wetland System.(iv) Membrane Bioreactor System.(iv) Membrane Bioreactor System.
![Page 4: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/4.jpg)
MembraneReactor SystemMembraneReactorSystem
Forward Osmosis• An osmotic process that uses semi‐permeable membrane for separation of water and solute.
• Concentrated draw solution generates high osmoticConcentrated draw solution generates high osmotic pressure that pulls clean water from wastewater.
Advantages• Driven by natural osmotic pressure, thus eliminating need of high hydraulic pressure.
• Consumes 20‐30% less energy than other desalination processes.• Low‐fouling potential and high physical cleaning efficiency.• High rejection of ions.g j
![Page 5: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/5.jpg)
MembraneReactor SystemMembraneReactorSystem
Membrane Distillation• A thermally driven separation process that use hydrophobic, micro‐porous membrane
• water evaporates through the membrane p gand condenses on the other side of the membrane.
Advantages• Driven by low‐degree temperature gradient (20‐30 oC).
(• Low‐grade heat (e.g., waste heat, geothermal heat, and solar heat) as energy input.
• Very high rejection of non‐volatile water contaminants.
![Page 6: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/6.jpg)
MembraneReactor SystemMembraneReactorSystem
Purified Water
Reconcentrated Draw Solution
Diluted Draw Solution
Forward Osmosis Membrane DistillationForward Osmosis Membrane Distillation
![Page 7: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/7.jpg)
MembraneCharacteristicsMembraneCharacteristics
FO MembraneC ll l t t b
MD MembraneP l l (PP) b• Cellulose acetate membrane
• Asymmetric structure• Polypropylene (PP) membrane • Porosity: 0.2 µm• Asymmetric structure
AFM Images of FO and MD membranes
![Page 8: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/8.jpg)
MembraneReactor SystemMembraneReactorSystem
Laboratory setup
![Page 9: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/9.jpg)
MembraneReactor System ‐ResultsMembraneReactorSystem Results
• Rejection of NH4+ and COD4
* COD was added to the feed solution using non‐fat dry milk
• Rejection of Arsenic
* Source of Arsenic in Feed: Sodium Arsenite (NaAsO2)
![Page 10: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/10.jpg)
MembraneReactor System ‐ResultsMembraneReactorSystem Results
• Synthetic Wastewater Feed
* T l C d i i M i S/
Observations:• More than 99 9% removal of all tested contaminants
* Total Conductivity Measurements in uS/cm
• More than 99.9% removal of all tested contaminants• Some contaminants (i.e. arsenic) that pass the FO system are rejected by the MD system, thus make this dual layer filtration
ffvery effective.
![Page 11: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/11.jpg)
Dual Digestion• Biological treatment process
• Combination of aerobic and anaerobic digestion processes
• Aerobic digestion– Aeration (air or pure oxygen)– Consumption of organic components
by microbes as their food & energy source
– Partial degradation through fermentative metabolism
• Anaerobic digestionAnaerobic digestion– Oxygen free environment– Full stabilization of organic waste
![Page 12: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/12.jpg)
Single-stage lab-scale anaerobic digester
Lab-scale temperature phased anaerobic digestiondigester anaerobic digestion
![Page 13: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/13.jpg)
Lab-scale Dual Digestion S t R ltSystem - Results
• Treatment of wastewater at 25 and 45ocTreatment of wastewater at 25 and 45 c – Significant decrease in the BOD (95%), COD (90 –95%), TKN (99%), turbidity (100%), color (100%), pathogen count, and other contaminants.
• Thermophilic anaerobic digestion at 55oC– The quality of sludge improved significantly in term of reduction in COD (81%) and BOD5 (82%), TSS (81%) TS (75%) higher biogas productionTSS (81%), TS (75%), higher biogas production and efficient reduction of pathogen after 8 days treatment.
![Page 14: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/14.jpg)
Trickling Filterg• The trickling filter or biofilter consists of a bed of inert
medium of either rock or plastic.
Mi i b tt h d t th di d f• Microorganisms become attached to the media and form a biological layer or fixed film. Organic matter in the wastewater diffuses into the film, where it is metabolized. Periodically, portions of the film slough off the media.p g
![Page 15: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/15.jpg)
Polystyrene media
Lab-scale Trickling Filter
Rubber media
![Page 16: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/16.jpg)
Steel cage with hooksPVC pipe
Stone media
W PShower
Plastic media Polystyrene media
Tire derived rubber media
Sid i f TF
Water Pump
Side view of TF
Top view of TF
Plastic container
Lower view of Shower
16
Top view of TF
![Page 17: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/17.jpg)
300
400
500
600
(mg/L)
PolystyrenePlasticRubberStone
300400500600700
OD (m
g/L)
PlasticRubberPolystyreneStone
0
100
200
0 12 24 36 48
BOD
0100200300
0 12 24 36 48
CO
48Time (hours) Time (hours)(5‐15°C) (5‐15°C)
1000 Polystyrene 1500Polystyrene
400
600
800
1000
BOD (m
g/L)
StoneRubberPlastic
500
1000
COD (m
g/L)
PolystyreneStoneRubberPlastic
0
200
0 12 24 36 48Time (hours) 25‐35°C
00 12 24 36 48
Time (hours)(25‐35°C)
![Page 18: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/18.jpg)
Constructed Wetland• These are artificially engineered systems,
Imitate natural systems– Imitate natural systems– Use a combination of soil, microbes and
plantsplants– Treatment under more controlled conditions.
![Page 19: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/19.jpg)
TypesTypes
C t t d Constructed wetlands
Subsurface flow
Surface flow
Free floating system
Rooted Rooted emergent emergent
MacrophyteMacrophyteSystemSystem
Submerged Submerged MacrophyteMacrophyte
systemsystem
Vertical Vertical subsurface subsurface
FlowFlow
Horizontal Horizontal subsurface subsurface
FlowFlow
SystemSystem
FlowFlow
Hybrid CW CW
![Page 20: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/20.jpg)
Advantages/Disadvantages f C t t d W tl dof Constructed Wetlands
Advantages• Low energy
Easy to operate
Disadvantages• Large area required
Easily affected by• Easy to operate• Environmental friendly• Cost effective
• Easily affected by seasonal variations
• Simple maintenance• High Efficiency• Effluent can be reusedEffluent can be reused• Aesthetically appealing
![Page 21: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/21.jpg)
Continued. . .
S3
S2
Sequentially Arranged Units of Hybrid Constructed Wetland
Lab Scale Hybrid Constructed Wetland Constructed Wetland
![Page 22: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/22.jpg)
Wastewater Composition: Determinants
Organic pollutionBOD
Heavy metalsHg, Ag
CODTOCSS TSS Settleables
g, gCd, ZnCu, NiPb ASS, TSS, Settleables
Nitrogen PollutionNH4-N, NO3-N, NO2-N
Pb, AsCr,
Pathogenic Microorganisms4 3
Phosphorous PollutionOrtho-phosphatesT l h h
Pathogenic MicroorganismsColiform bacteria
Total phosphates
22
![Page 23: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/23.jpg)
Constructed Wetland - ResultsConstructed Wetland Results
• Free water surface CWFree water surface CW– a significant reduction was observed in parameters, e.g. BOD5 (97.69%), COD (97.69%),), turbidity (100%), odour (100%), and pathogens (100%).
H b id CW• Hybrid CW– More than 95% improvement in BOD5, COD, turbidity odour and pathogenturbidity, odour and pathogen.
– The bacterial population was most abundant and diverse in the rhizosphere .p
![Page 24: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/24.jpg)
1st Year1 Year• Design and construction of efficient plastic g p
media Trickling Filter (TF) for treatment of domestic and chemically contaminated water
• Design and construction of lab-scale Constructed Wetland (CW) for treatment ofConstructed Wetland (CW) for treatment of domestic sewage
• Evaluate the efficiency of sequential aerobic-anaerobic Dual Digestion (DD).
![Page 25: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/25.jpg)
2nd Year2 Year• Two types of filter media - polystyrene and yp p y y
rubber cubes, were used in the attached growth (TF) bioreactors.
• A laboratory-scale hybrid CW with vertical and horizontal flow, was used for treatingand horizontal flow, was used for treating domestic wastewater.
• Sequential aerobic-anaerobic treatment (DD) was assessed for domestic wastewater.
![Page 26: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/26.jpg)
3rd Year3 Year• Continue lab-scale studies for the treatment
processes developed.• Construction of Wetlands and Tricking filters
at pilot scale at QAU for treatment ofat pilot-scale at QAU for treatment of wastewater.
• Visit of researcher from QAU to GWU forVisit of researcher from QAU to GWU for training and research on membrane bioreactors. F ll l H b id tl d t ti i• Full scale Hybrid wetland construction in collaboration with NBS (Nano Bio-solutions) at QAU.Q
![Page 27: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/27.jpg)
Workshops and Seminars C d dConducted
• ”Evaluation Of Various Wastewater Treatment Processes For Municipal Wastewater And Sludge,” Environmental Engineering Workshop, Civil & Environmental Engineering Department George Washington University August 10Department, George Washington University, August 10, 2011.
• One Day International Seminar on “Wastewater treatment and its Reuse,” Quaid-i-Azam University, Islamabad, May 17, 20122012.
![Page 28: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/28.jpg)
International PublicationsInternational Publications• Abdul Rehman, Iffat Naz, Zia Ullah Khan , Muhammad Rafiq, Naeem Ali,
and Safia Ahmed (2012) Sequential Application of Plastic Media Tricklingand Safia Ahmed (2012). Sequential Application of Plastic Media Trickling Filter and sand Filter for Domestic Waste Water Treatment at low temperature Conditions. British Biotechnology Journal, 2(4):179‐191.
• Rabia Aamir, Shama Sehar, Naeem Ali, Abdul Hameed, Safia Ahmed ( ) ff f d l(2012), Effect of Hydraulic Retention Time on Wastewater Treatment Efficiency of a Laboratory Scale Hybrid Constructed Wetland. Environmental Monitoring and Assessment (under review)’
• Ziaullah Khan, Iffat Naz, Shama Sehar, Abdul Rehman, Naeem Ali, Abdul , , , , ,Hameed and Safia Ahmed. Removal of pollution indicators from sewage by fixed film bioreactor and sand filter at low temperature. Submitted for publication in “Water and Environment”.
• Sadaf Shabbir Naeem Ali M Ishtiaq Safia Ahmed and Abdul HameedSadaf Shabbir, Naeem Ali, M. Ishtiaq, Safia Ahmed and Abdul Hameed. Effect of hydraulic loading rate on treatment efficiency of a small‐scale constructed wetland. Submitted for publication in Canadian Journal of Microbiology.
![Page 29: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/29.jpg)
Future CollaborationsFuture Collaborations
• Capital Development Authority IslamabadCapital Development Authority, Islamabad• Nano Bio Solutions Pvt., Islamabad
i l i l b d• Environmental Protection Agency, Islamabad
![Page 30: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/30.jpg)
AcknowledgementsAcknowledgements• USAID – Pakistan‐US Science and Technology
Cooperation Program.• Higher Education Commission, Pakistan.• All the students and faculty involved in this• All the students and faculty involved in this
research at QAU and GWU.
![Page 31: Small Scale Sewage Treatment and Reuse System for Pakistansites.nationalacademies.org/PGA/cs/groups/pgasite/... · 2020. 4. 14. · at pilotat pilot-scale at QAU for treatment ofscale](https://reader035.vdocuments.site/reader035/viewer/2022071420/611910c68509af306b6c1a27/html5/thumbnails/31.jpg)