3-210

UN

ITS

Proportional pressure regulators series REGTRONIC have the job of precisely regulating the pressure in a system, the variables depending on the input command. The pressure value and a series of information and diagnostics are visible at all times on the graphic display. The user-display interface, LEDs and buttons are all on one side.The programming and reading software is comprehensive, simple and intuitive. Pressure control takes place in a “closed-loop” with an electronic precision pressure sensor that measures the downstream pressure, a control system that compares it with the desired pressure, and two mini solenoid valves that adjust the pressure to reach the target value.

TECHNICAL DATAThreaded portsFluidMIN inlet pressure barMAX inlet pressure barTemperature range °CPressure regulation range barFlow rate at 6.3 bar ∆P 0.5 bar Nl/minFlow rate at 6.3 bar ∆P 1 bar Nl/minExhaust flow rate at 6.3 bar with 0.1 bar overpressure Nl/minExhaust flow rate at 6.3 bar with 0.5 bar overpressure Nl/minWeight KgClass of protectionPower supply Input signal (input impedence) Voltage Current Serial ports ManualOutput signal Analog Digital

LinearityHysteresisRepeatabilitySensitivity/Dead-bandOutput pressure display Accuracy Unit of measurement Minimum resolutionAnalog output accuracyTemperature characteristicsResponse time with ∆P =1 bar from 6 to 7 bar sfrom 7 to 6 bar sInstallation positionNote

REGTRONIC REGTRONIC REGTRONIC REGTRONIC NEW DEAL 300 400 1/8’’ 1/4’’ 3/4’’ 1’’ 1/2’’ 3/4’’ 1’’ 1’’ 1 1/4’’ 1 1/2’’ 2’’

Filtered, unlubricated air. The air must be filtered at least 10 µmRegulation pressure +1 bar

11-10 to 50

0.05 to 10 (settable full scale and minimum pressure) 770 1490 10000 4500 18.000 20.000 1050 1700 13000 7000 - - 320 500 1800 250 400 400 650 1200 2000 500 850 850 0.38 0.38 1.3 1.5 5 5.8

IP 65 24 Vcc +10% -5% I max 110 mA

0 to 5 Vcc, 0 to10 Vcc (approx. 168 KΩ)4 to 20 mA (approx. 100 KΩ)

RS 232Keypad

0 to 10 Vcc (1 V=1bar) - 1 mA maxPNP open collector output:: max 24V 60 mANPN open collector output: max 24V 60 mA

≤ ± 0.5% (Full scale)≤ ± 0.2% (Full scale)≤ ± 0.2% (Full scale)

setting range 10 to 100 mbar≤ ± 0,3% (Full scale)

bar, Mpa, psi0.01 bar - 0.001 MPa - 0.01 psi

≤ ± 0,4% (Full scale)max 2 mbar / °C

volume 100 cc volume 1000 cc volume 1000 cc volume 1000 cc 0.2 0.3 0.45 0.35 0.3 0.3 0.45 0.7

in any positionThe features shown refer to the static condition only. With air consumption on the output side, the pressure may vary.

PRO

PORT

ION

AL P

RECI

SIO

N P

RESS

URE

REG

ULAT

OR

“REG

TRO

NIC

” SE

RIES

PROPORTIONAL PRECISION PRESSURE REGULATOR “REGTRONIC” SERIES

3-211

UN

ITS

LIQUID CRYSTAL GRAPHIC DISPLAY PROGRAMMABLE AND FLEXIBLE

PRECISION M12 x 1 CONNECTOR

8-pin connector- standard- available from the trade

As well as the pressure, it displays complete intuitive messages covering several lines.

Setting options:

LANGUAGE

UNIT OF MEASUREMENT

TYPE OF INPUT

TYPE OF DIGITAL OUTPUT

DEAD-BAND

FULL SCALE

MINIMUM PRESSURE

± 0,5 % (full scale)Linearity

± 0,2 % (full scale)Hysteresis

± 0,2 % (full scale)Repeatability

range 10 to100 mbarSensitivity

CONFIGURATION OF THE M12X1 8-PIN CONNECTOR FUNCTION DIAGRAM

1 = TX (RS232) (White)2 = RX (RS232) (Brown)3 = set 0-10 V / 0-5 V / 4-20 mA (Green)4 = digital out 0-24 V NPN (Yellow) 5 = analog out 0-10 V (Grey)6 = digital out 0-24 V PNP (Pink) 7 = 0 V (GND) (Blue)8 = power supply +24V (Red)

Regulator connectorviewed from above

DISPLAY

CONTROLCIRCUIT

OUTPUT SIGNAL

OUTLET SOLENOIDVALVE

PRESSURE SENSOR

INPUT SIGNAL

INLET SOLENOIDVALVE

IN OUT

PRO

PORT

ION

AL P

RECI

SIO

N P

RESS

URE

REG

ULAT

OR

“REG

TRO

NIC

” SE

RIES

1

7

65

8

4

3

2

3-212

UN

ITS

REG

TRO

NIC

1/8

’’; 1

/4’’

FLOW CHARTS

REGTRONIC 1/8’’; 1/4’’

COMPONENTS

a CARTRIDGES: nickel-plated brassb RING: vulcanized NBRc ROD: steeld BODIES: painted aluminiume PRESSURE SENSORf SOLENOID VALVE: 10 mm series PLT-10g SHELL: technopolymerh CONNECTOR M12 8 pini ELECTRONIC BOARDSj CONTROL DIAPHRAGM: anti-oil rubber k SPRING: stainless steell POPPET: nickel-plated brass

A = 2.5 bar B = 4 bar C = 6.3 bar D = 8 bar

ON EXHAUST ON REGULATION

D

C

B

AInle

t pre

ssur

e [b

ar]

Flow rate [Nl/min]-1800 -1600 -1400 -1200 -1000 -800 -600 -400 -200 0 200 400 600 800 1000 1200

10

9

8

7

6

5

4

3

2

1

0

1/8’’ ON EXHAUST ON REGULATION

D

C

B

AInle

t pre

ssur

e [b

ar]

Flow rate [Nl/min]-1800 -1600 -1400 -1200 -1000 -800 -600 -400 -200 0 200 400 600 800 1000 1200 1400 1600 1800

10

9

8

7

6

5

4

3

2

1

0

1/4’’

3-213

UN

ITS

REG

TRO

NIC

1/8

’’; 1

/4’’

INSTALLATION

A On the wall with 2 M3 hex screws B On the base with legs code 9200710C On the wall with legs code 9200710

Code Description 5521500 REGTRONIC 1/85522500 REGTRONIC 1/4

DIMENSIONS AND ORDERING CODES

IN OUT

IN OUT

IN OUT IN OUT

3-214

UN

ITS

FLOW CHARTS

a REGULATOR BODY: aluminiumb LOWER CAP: aluminiumc UPPER PLATE: aluminiumd SPACER: aluminiume GASKET: NBRf PISTON ROD: aluminiumg CAP FOR PLAIN GASKET: OT58 brassh PLAIN GASKET: NBRi ROD: OT58 brassj VALVE: OT58 brassk VALVE SPRING: steell GASKETS: NBRm ELECTRONIC BOARDSn CONNECTOR M12 8 PINo PRESSURE SENSORp SOLENOID VALVE: 10 mm series PLT-10q SHELL: tecnopolymer

DIMENSIONS AND ORDERING CODES

Code Description1520003 REGTRONIC 3/41620003 REGTRONIC 1

A = 2.5 bar B = 4 bar C = 6.3 bar Pm = 7 bar

ON EXHAUST ON REGULATION

Inle

t pre

ssur

e [b

ar]

Flow rate [Nl/min]-3000 -1500 0 1500 3000 4500 6000 7500 9000 10500 12000 13500

8

7

6

5

4

3

2

1

0

C

B

A

REG

TRO

NIC

NEW

DEA

L

REGTRONIC

COMPONENTS

3-215

UN

ITS

FLOW CHARTS

COMPONENTS

a BODY: tecnopolymerb END PLATE: zamakc STEM: OT58 brassd UPPER CUP: aluminiume PISTON: OT58 brassf CUP: aluminiumg PRESSURE SENSORh SOLENOID VALVE: 10 mm series PLT-10i SHELL: tecnopolymerj CONNECTOR M12 8 PINk ELECTRONIC BOARDSl GASKET: NBRm VALVE WITH NBR VULCANIZED GASKETn VALVE SPRING: stainless steelo LOWER CUP: tecnopolymer

DIMENSIONS AND ORDERING CODES

Code Description 4402012A REGTRONIC 300 without end plates4402012 REGTRONIC 300 1/24502012 REGTRONIC 300 3/44602012 REGTRONIC 300 1

G A 1/2’’ 110 3/4’’ 110 1’’ 112

Inle

t pre

ssur

e [b

ar]

8

7

6

5

4

3

2

1

0

A = 2.5 bar B = 4 bar C = 6.3 bar Pm = 7 bar

ON EXHAUST ON REGULATION

Flow rate [Nl/min]-1000 0 1000 2000 3000 4000 5000 6000 7000 8000

REG

TRO

NIC

300

REGTRONIC 300

A

B

C

3-216

UN

ITS

FLOW CHARTS

COMPONENTS

a BODY: Aluminiumb END PLATE: Aluminiumc THREADED BUSH, AXIAL ADJUSTMENT: OT58 brassd RETAINING RING: OT58 brasse ROLLING DIAPHRAGMf BRASS PLUG: OT58 brassg VALVE SPRING: Stainless steelh STEM: OT58 brass with air relief holei VALVE WITH NBR VULCANIZED GASKETj GASKETS: NBRk CONNECTOR M12 8 PINl SHELL: technopolymerm SOLENOID VALVE: 10 mm series PLT-10n PRESSURE SENSORo ELECTRONIC BOARDS

REGTRONIC 400 1’’ to 1 1/2’’

A = 6 barB = 4 barC = 2 bar

Pm = 7 bar

ON EXHAUST ON REGULATION

A

B

C

Inle

t pre

ssur

e [b

ar]

Flow rate [Nl/min]

-7000 -5000 -3000 -1000 1000 3000 5000 7000 9000 11000 13000 15000 17000 190000

7

6

5

4

3

2

1

REG

TRO

NIC

400

REGTRONIC 400

3-217

UN

ITS

DIMENSIONS

ORDERING CODES NOTES

Code Description6102012A REGTRONIC 400 without edn plates6102012 REGTRONIC 400 16202012 REGTRONIC 400 1 1/46302012 REGTRONIC 400 1 1/26402012 REGTRONIC 400 2

REGTRONIC 400 2’’

A = 6 barB = 4 barC = 2 bar

Pm = 7 bar

ON EXHAUST ON REGULATION

A

B

C

Inle

t pre

ssur

e [b

ar]

Flow rate [Nl/min]

-7000 -5000 -3000 -1000 1000 3000 5000 7000 9000 11000 13000 15000 17000 190000

7

6

5

4

3

2

1

REGTRONIC 400Threaded port G 1” 1 1/4’’ 1 1/2’’ 2’’A 225 to 255 283 to 313B 127C 116D 105E 141.4F 80H 182I 52.5L M6 holeM 105.4N 16.5R (exhaust) 1/4’’

REG

TRO

NIC

400

3-218

UN

ITS

M12x1 PRE-WIRED 8-PIN FEMALE STRAIGHT CONNECTOR

FIXING BRACKET KIT FOR REGTRONIC 1/8’’ E 1/4’’

INPUT/OUTPUT END PLATE KIT FOR SKILLAIR

M12x1 PRE-WIRED 8-PIN FEMALE 90° CONNECTOR

CONNECTOR KIT FOR SKILLAIR CODE A

Code DescriptionW0970513010 M12X1 pre-wired

8-PIN strainght connector,cable L = 5 m

1 - White2 - Brown3 - Green4 - Yellow5 - Grey6 - Pink7 - Blue8 - Red

Code Description9200710 Fixing bracket kit

Code Description9430701 IN/OUT end plate kit 300 1/29530901 IN/OUT end plate kit 300 3/49531001 IN/OUT end plate kit 300 19631001 IN/OUT end plate kit 400 19631101 IN/OUT end plate kit 400 1 1/49631201 IN/OUT end plate kit 400 1 1/29631301 IN/OUT end plate kit 400 2

Code DescriptionW0970513011 M12X1 pre-wired

8-PIN 90° connector,cable L= 5 m

1 - White2 - Brown3 - Green4 - Yellow5 - Grey6 - Pink7 - Blue8 - Red

Code Description9430301 Connector kit 3009630301 Connector kit 400

N.B. supplied complete with four M4X6 screws

NOTES

ACC

ESSO

RIES

REG

TRO

NIC

ACCESSORIES REGTRONIC