March/April 2016

porkjournalwww.primarymedia.com.au

Volume 38 Issue 2

PrintPost Approved PP10003090 ISSN 1032 3759

2016 SA Pig Industry Day

Early adopters Matt and Sharon Starick benefit from Blueprint Pig Nutrition Program Lienert Australia

grows under Alltech ownership

Virkon®S has been independently tested for “Virucidal Effi cacy of a Disinfectant for Use on Inanimate Environmental Surfaces against Porcine Epidemic Diarrhea Virus (PEDV)”. This is an approved EPA test protocol. Virkon®S is proven to be effective against PEDV at a dilution rate of 1:600, in the presence of high organic content (5%) and at low temperatures (down to 5˚C). Virkon®S can be used on housing, surfaces, equipmentand footwear. It is especially effective in combating the spread of disease via transport vehicles.

Virkon®S: Effective biosecurity against PEDV in a single pack.

VIRKON®S.INDEPENDENTLY PROVEN TO BE EFFECTIVE AGAINST PORCINE EPIDEMIC DIARRHEA VIRUS (PEDV).

Virkon S_297x210_PEDV.indd 2 23/05/2014 16:48

porkjournalwww.primarymedia.com.au

EDITORIAL & DESIGN

FEATURES

NEWS

ADVERTISING

SUBSCRIPTIONS

ENQUIRIES

EDITOR:

JOURNALIST/PHOTOGRAPHER

PRODUCTION EDITOR

GRAPHIC DESIGNER

ADVERTISING SALES

Peter BedwellPhone: (02) 9797 2406Mob: 0419 235 288Email: primarymedia@bigpond.comRates are available at www.primarymedia.com.au

OFFICE ADDRESS:250 Hawthorne Pde, Haberfield NSW 2045Phone: (02) 9797 2406Mob: 0419 235 288Production: 0409 944 472Email: primarymedia@bigpond.com

Pork Journal consists of a bi-monthly management magazine and an annual industry review, The Pig Industry Yearbook.Published by C D Supplies Pty Ltd trading as Primary Media (ACN 091 560 557)

All material copyright (editorial and advertisements) and may not be reproduced without the written consent of the publishers. Whilst every care is taken to ensure the accuracy of the contents of PORK JOURNAL, the publishers do not accept any responsibility or liability for the material herein.

AUSTRALIAOne Year - $55.00*

NEW ZEALAND One Year - NZ$80

OTHER COUNTRIESOne Year: Airmail - $A90Please send payment in Australian dollars.

Send payment and full details to:250 Hawthorne Pde, Haberfield NSW 2045

*Australian subscription rate includes GST

Peter Bedwell

Alex Bedwell

Rosemary Embery

Alex Bedwell

Page 8: Lienert Australia grows under Alltech ownership By Peter Bedwell

3

Sophie Thomson, Matt Starick and Rohan Wundke.

March/April 2016Volume 38 Issue 2

NEW PRODUCTS

Page 4: 2016 SA Pig Industry Day Takeaways

Page11: Scholarship to improve piglet viability

Page 16: WAPPA Pig Day Out 2016 looks to the future

Page17: SunPork appoints Group CEO and MD

Page 18: ABARES 2016 predictions for pork production

Page 19: AusScan advances animal nutrition

Page 20: Feed additive industry manages its risks

Page 20: Natuphos E launched at APSA

Virkon®S has been independently tested for “Virucidal Effi cacy of a Disinfectant for Use on Inanimate Environmental Surfaces against Porcine Epidemic Diarrhea Virus (PEDV)”. This is an approved EPA test protocol. Virkon®S is proven to be effective against PEDV at a dilution rate of 1:600, in the presence of high organic content (5%) and at low temperatures (down to 5˚C). Virkon®S can be used on housing, surfaces, equipmentand footwear. It is especially effective in combating the spread of disease via transport vehicles.

Virkon®S: Effective biosecurity against PEDV in a single pack.

VIRKON®S.INDEPENDENTLY PROVEN TO BE EFFECTIVE AGAINST PORCINE EPIDEMIC DIARRHEA VIRUS (PEDV).

Virkon S_297x210_PEDV.indd 2 23/05/2014 16:48

Page 12: Early adopters, Matt and Sharon Starick benefit from Blueprint Pig Nutrition ProgramBy Peter Bedwell

NEWS

4

2016 SA Pig Industry Day Takeaways

costs through feed conversion.“Post-cervical AI has taken off in the

USA as a way to improve reproduction and reduce labour costs, by introducing single mating strategies.

“They are combining two AI technologies through set-time inseminations and reducing sire numbers, so only the best genetics is being used. This is something I feel we should have a good look at doing locally,” said Roger.

‘Super Sow’ management Caleb Smith, a 2000-sow producer

from Central Victoria, outlined how the introduction of his ‘Super Sow’ management program has led to improvements in sow fertility at his farm.

“We worked closely with our genetics supplier to focus on improving our born alive performance. We developed EBV’s for born alive and culled P1 sows that couldn’t deliver the numbers we were looking for,” said Caleb.

“That lifted our average born alive from 11.8 to 12.6 over a two year period, but our average number weaned/litter stayed static through high pre-weaning losses, primarily due to low birthweights.

“In 2010, we decided to start

An audience of 140 producers, researchers, students and agribusiness representatives attended another successful SA Pig Industry Day, held in the Barossa Valley on February 26.

Nine speakers contributed to the event’s technical sessions prior to the popular industry happy hour and evening dinner, with chairman Dr Darryl D’Souza keeping the day running like clockwork.

Benchmarking dataFollowing a formal welcome from

PorkSA’s chairman Matthew Starick, Pork CRC CEO Dr Roger Campbell led off with his opening address looking at where Australian producers sit globally from a productivity viewpoint.

Using production data generated through the CRC’s Benchmarking Project, Roger compared Australian farm data to that from Canada, USA, Denmark, Netherlands and Brazil, highlighting how differences seen in the number of pig’s weaned/sow/year, carcase weight and feed costs influenced profitability across the various industries.

“The take home message is that we are doing well at the moment,” Roger said. “However, our average carcase weight of around 78kg is an obvious constraint compared to over 90kg in those other countries, and it runs its inefficiencies right through the supply chain, impacting on the profitability of exporting pork,” he said.

“Some lessons from the ‘best’ of the local benchmarking group were that their 2014/15 production costs ranged between $2.42 - $3.20/kg carcase.

“Our best three herds produce 29.6, 26.5 and 25.6 pigs/sow/year, with born alive performances of 13.8, 13.5 and 11.5 and pre-weaned mortality figures of 11.7, 12.9 and 11.1%.

“The point of highlighting this level of productivity is to make sure we make the best out of what is achievable and ensure we are protecting our business from what can go wrong,” Roger stressed.

“Biosecurity will continue to play a big role in protecting us from the risks associated with imported pork. We also need to keep improving the eating quality of Aussie pork, differentiate it to our consumers and reduce production

Panel Q&A session after the morning speakers at the recent SA Pig Day. LtoR: Dr Kate Plush, Caleb Smith, Dr Roger Campbell and Dr Darryl D’Souza.

w

By GRAEME POPE

weighing all piglets at birth and our purebreds again at 14 days of age.

“Because of this we have found that litter weight is highly repeatable, and so we now use a sow selection index to rank our sows based on average numbers born alive, litter born alive weight, piglet weights at birth and 14 days, and numbers weaned.

“During 2014/15, we averaged 11.2 pigs weaned/litter and 26.5 weaned/sow/year. We conduct an annual review of our herd’s genetic progress with our genetics supplier to confirm we are heading in the right direction,” Caleb added.

Optimising gilt longevitySARDI’s Dr Kate Plush presented

findings from an APL-funded joint project with QDPI, which analysed Elite Herd performance data from 21 herds in order to identify potential factors influencing gilt longevity on these participating farms.

The top three performing farms in both states were then visited to obtain a ‘real time’ impression of their routine gilt selection, mating and gestation management practices, before developing a producer workshop based around ‘best practice’ gilt management guidelines.

SEE YOU AT

PPPE

STAND 22

6

NEWSThe Elite Herd data analysis

revealed huge differences between farms in all reproductive measures, including farrowing rate (65 – 91%), percentage of gilts farrowing three litters (40 – 90%), empty sow days (27 – 98 days) and pigs weaned/sow/year (18.4 – 24.3, with an average 21.5).

Across herds, gilts were most commonly culled due to age, reproductive failure, NIP or lameness, but up to 40% of gilts were culled without a recorded reason on one farm.

Kate provided the audience with the Project’s list of ‘should do’s’ to optimise gilt longevity.

“Gilts should be first selected at 90kg or by 20 weeks of age, based on weight for age plus physical confirmation and udder characteristics,” she said.

“They can be run in groups of up to 25 from 25 weeks of age with an epididymectomised boar, which could improve farrowing rate by 10% and total born by half a pig per litter.

“Then they should be run daily to a DMA from 27 weeks of age, have their heat recorded and then be mated by 30 – 33 weeks of age,” said Kate.

“Cull any gilt that fails to show heat by 30 weeks of age, mate or inseminate twice 24 hours apart, check for returns at 21 days and only re-mate NIPS’s once,” she stressed.

“Review your current induction program with your veterinarian to make sure you are not over-using Oxytocin and consider splitting prostaglandin doses eight hours apart to lift born alive numbers”.

APL pork marketing APL’s Marketing Manager Peter

Haydon provided his usual up-beat explanation on how APL was investing its advertising dollars to create pork demand.

“Pork is experiencing the second fastest growth in fresh meat sales across all other sectors, with a 4.8%

v per year increase for the past five years. Right now, all sectors of the pork value chain are making money, from the producer to the retailer,” he said.

“Around 7% of households buy pork every 2-3 weeks and they account for more than 20% of the total pork volume moved.

“Casual dining out of home accounts for another 20% and we need to build relationships with that consumer sector to maintain that volume.

“But we are now looking at pork substitution into existing recipes to increase pork demand by another 3-5% each year, by producing videos showing how pork can substitute for other meats in stir frys, sausage and mince recipes,” said Peter.

AUS-ScanDr Charles Rikard-Bell, Pork CRC,

provided an update on the adoption of AUS-Scan technologies by nutritionists to optimise the value of feed energy when pricing grain.

“Knowing the energy content of grain before you buy it can lead to more astute purchasing and more accurate ration formulations,” he said.

“The consequences of unidentified drifts in the energy content of feed include under or over supplying energy to the animals, variable feed intakes, shortfalls in protein, wasted feed efficiency and poor growth.”

Charles used a least cost diet formulation exercise derived by SA nutritionist Tony Edwards to quote that 1MJ DE/kg in grain energy content was worth between $25 to $30/tonne at today’s grain prices.

Given the fact that average wheat DE values can range between 12.4 – 15.0 MJDE/kg, barley 10.6 – 14.7 MJDE/kg and triticale 12.3 – 16.5 MJDE/kg in any given parcel, applying NIRS technology through AUS-Scan calibrations at the time of grain

purchasing can help producers optimise their feed dollar investments!

Improving BiosecurityVeterinarian Dr Jon Bartsch, Barry

Lloyd & Associates from Gawler alerted producers to the importance of pig truck cleanliness as a risk factor to their farm’s biosecurity program. John has a PorkSA-funded project investigating the adequacy of truck wash facilities at major SA abattoirs and practical measures to be adopted both on-farm and in-lairage to reduce the risk of new disease introductions through the pig transport process.

“Current risk factors I have seen when unloading pigs at lairage include the use of recycled wash down water and cross-contamination at unloading from misting and poor drainage as drivers move around their vehicles.

“Abattoirs should provide truck drivers with clean boots and overalls on-arrival, as they do for all other personnel visiting their site.

“Gross de-contamination of vehicles can be improved through having hot water pressure washing facilities available, ceasing the use of recycled water for final rinsing and disinfection after pressure washing.

“Lairage staff shouldn’t work forward of the unloading ramp and truck drivers shouldn’t enter the lairage,” he said.

“The cleaning equipment should be set up to operate independent of the plant’s main power supply, be that gas or electricity, so that vehicles can still be cleaned during unexpected outages.

“The drainage and roadways around the truck wash areas should also be sealed and built to drain properly, so that drivers don’t have to walk through contaminated water.

“It is in everyone’s interest to work with their contractors and processors to ensure these biosecurity practices are followed,” Jon said.

RSPCA Australia has congratulated the Australian pork industry for putting the welfare of its animals first, by spending $50 million to replace sow stalls.

Australian Pork has announced that since 2010, pig producers have invested the money in on-farm changes to replace sow stalls for group housing, as a result of research and development and consumer sentiment.

According to Australian Pork, more

than 70% of Australian sows are now spending most of their pregnancies in group housing, with the industry aiming to have all sows out of stalls by 2018.

This constructive move to improve pig welfare is a great reason for Australians to buy Australian pork over imported products. About $10 million of imported pork products is sold in Australia each week, predominantly from countries which still use sow stalls.

Pork industry sets the example for animal welfare

Nutrients are a potent stimulus of gene expression. Knowing this helps us explain why performance can be improved and provides important clues on HOW to optimize the cell, tissue

and organ function through the diet. Nutrigenomics ensures precision nutrition that targets animal performance looking to the future and what physical, financial and environmental

benefits can be sustained.

Six fundamentals to achieve your animals’ genetic potential.

MICROBIOMICS

GUT DEVELOPMENT

FEED QUALITY

IMMUNE DEFENCE

REPRODUCTIVE FUNCTION

NUTRIENT FORM & FUNCTION

2

3

4

5

6

Tel: 1 800 649 231 | lienerts.com.au

Lienert Australia Head Office | 8 Roseworthy Rd | Roseworthy 5371 | SA | Australia

NUTRITION PROGRAM

8

Lienert Australia grows under Alltech ownership

A lthough Pork Journal has visited

the Lienert operation on numerous occasions, our visit in March 2016 was the first since the global company Alltech took over the Roseworthy, South Australian-based operation in

September 2014.A relatively small, family-owned

business, Lienert became part of a very large, but still family-owned company as Dr Pearse Lyons, the founder and President of Alltech, pointed out when he visited Australia at the time of the acquisition.

Many of the key staff members of Lienert have been with the company through its numerous changes in the last 15 years.

The company, established by the Lienert family more than 40 years ago, has manufactured and supplied ingredients, supplements and nutritional advice to a range of livestock industries in Australia, New Zealand and the Philippines.

The company’s client base includes small family farms, integrated businesses and commercial feed mills.

Lienert’s close relationship with

farmers made the company an ideal acquisition for Alltech, as the company has dedicated a global on-farm strategy to fuel Alltech’s growth, which has been nearly 400% in recent years, with sales now beyond $2 billion.

While discussing progress with Lienert’s General Manager, Mark Peebles, and Technical Services Manager, Rohan Wundke, Mark pointed out the expansion with key staff members and operational capability since the company became part of the overall Alltech enterprise.

A big boost to activity was the launch of the Alltech/Lienert Blueprint program for pork producers at the Victorian Pig Fair in Bendigo in March 2015.

Lienert’s Blueprint creep pellet feed is now on-farm and operational.

“The Blueprint nutrition program, based upon the study of nutrigenomics, is designed to target animal health and performance at the cellular level and build upon genetic potential at each stage of an animal’s life cycle,” said Mark.

“Besides nutritional applications, Blueprint includes farm analysis, management consultancy, return on

By PETER BEDWELL

w

Some of the Alltech/Lienert staff: LtoR: Rohan Wundke, Cassie Dickson, Sophie Thomson, Mark Peebles and Lisa Nietschke.

532158_PEST_SELONTRA PERMIT AD_HALF PG_125x173_OL.indd 1 8/04/2016 2:56 pm

9

10

FEATURE

1. Alyshia McRae. 2. Rohan Wundke. 3. Alltech products. 4. Trent Hughes.

investment calculations and feed quality and nutrient and feed efficiency laboratory testing.

“The Blueprint program incorporates Alltech’s primacy in science, allowing Lienert to strengthen our support on-farm,” said Mark.

“By understanding the animal at the cellular level, Blueprint allows Lienert to work with our customers to improve both performance and profitability,” Mark added.

Pork Journal went on a recent tour of the Lienert facility where new lab and analytical capability has been acquired.

Samples of all diets and specific ingredients are kept for each batch as a program like Blueprint relies on this precise data to achieve its aims.

With the Blueprint program for pigs well established, the release of Blueprint for ruminants in February this year has significantly increased the workload for the nutrition team at Lienert.

It was over a decade ago when Pork Journal was at the Alltech conference held in Lexington, Kentucky and the founder and President of the company, Dr Pearse Lyons strode on stage with a gene chip in one hand and then introduced the concept of genomics.

Subsequently, not only has the company introduced new products based on this technology (Actigen), at one time Alltech launched a pilot program with Lyons Farm beef, an example of the ‘farm to fork’ model.

Two generations of the Pork Journal team have sampled that fabulous beef product and can certainly attest to the fabulous eating quality of the Alltech Angus herd.

So the management skills developed by Alltech for its own products must contribute to the overall effectiveness of the various Blueprint species programs.

Alltech has put its research and development money where the consumer’s ever more demanding mouth is.

Feed conversion rates, average daily weight gain, numbers of piglets born alive and successfully weaned are all vital production markers for pig farmers but so is eating quality – especially for pork.

For the Alltech/Lienert enterprise, the pig Blueprint program could not have been released at a better time for the industry.

Domestic pork consumption has increased significantly in recent times, feed prices have stabilised and our $A is making our pork more competitive in existing and potential overseas markets.

v

New trade deals may soon open up some significant opportunities in several Asian markets but we must ensure that we increase production levels to keep pace with existing and potential demand.

New markets, both domestic and overseas, will almost certainly in the not too distant future require either significantly reduced antibiotic use or even no antibiotic use. This will be a challenge but Alltech has for many years invested significant effort into facing that challenge.

Any long-term strategy to either reduce or eliminate antibiotic use will

require not only alternative animal health products, but also more intense on-farm management focus.

Pork Journal raised the topic of cost competitiveness with Mark Peebles.

It is no secret that many of the products developed by Alltech have competition from products produced in low cost regions.

“In the future it is quite possible that we will have access to leading Alltech products produced locally that will not only deliver our established performance, but also consistent quality and safety – while also being cost competitive,” Mark said.

1

2

3 4

11

•••••••

NEWS

Scholarship to improve piglet viability

The Ronald J Lienert Memorial Scholarship (RLMS) was awarded to Adelaide University Animal Science graduate Alexander Dean at the SA Pig Industry Day dinner, held February 26.

Presented by Adam Lienert, this industry-funded Scholarship is awarded annually to a graduate student planning to complete a pig-focused research project at Roseworthy Campus during their Honours year.

It recognises the significant contributions made by the late Ronald Lienert OAM, Sheaoak Log to the advancement of the Australian pig industry through pig breeding and genetic improvement, agribusiness and industry politics.

Prior to beginning his undergraduate degree at Roseworthy, Alexander had limited experience with pigs.

His initial interest in pigs began only a few years ago with the introduction of three Wessex Saddleback pigs to his family property on King Island, Tasmania.

Further practical experience was gained at the Roseworthy Campus piggery during his course, along with assignments focused on the current drive towards lower confinement pig housing systems.

In 2015, Alexander joined the Pig Club as a part of the Production Animal Special Interest Group on-Campus.

During his 2016 Honours year, his research will primarily focus on investigating nutritional strategies with potential to improve piglet thermoregulation and colostrum intake during the first 2-3 days of life, through maternal supplementation with caffeine and vitamin A.

The RLMS has been awarded annually since 2011, with all recipients either continuing with further pig-focused studies at completion of their Honours program, or entering the commercial pig industry.

For further information, contact Graeme Pope on 0438 423 900.

By GRAEME POPE

Adam Lienert (left) presents the Ronald J Lienert Memorial Scholarship to Adelaide University Animal Science graduate, Alexander Dean at the SA Pig Industry Day Dinner.

12

Early adopters, Matt and Sharon Starick, benefit from Blueprint Pig Nutrition Program

F ollowing the visit to the Alltech/

Lienert premises at Roseworthy, Rohan Wundke, Technical Services Manager and Sophie Thomson, a graduate nutritionist who joined the on-farm team last year, took Pork Journal to Kongolia Farms, Mathew and Sharon Starick’s farm on the Murray Plains, which was one of the first to adopt the Blueprint for Pigs system.

At about the same time that Dr Pearse Lyons first released the results of his company’s research into genomics, Pork Journal was visiting the Starick family farm for the first time.

After two generations of the farm focussing on cropping and sheep production, Mathew’s father Warren Starick diversified the business into poultry back in 1972 and together with Matthew and Sharon, went into pigs in 1994.

Warren, who retired in 2011,

became not only a successful farmer rearing pigs, layer hens and establishing a large cropping enterprise, but was also an executive member of the National Farmers’ Federation and the South Australian Farmers Federation.

Today, Kongolia farms is based on an expanded pig rearing business and cropping activity after the layer enterprise was closed in 2007.

The cropping business on the 1200 hectare property is of critical advantage in the overall farm business model, being able to produce high quality grains.

The pig rearing side has just about doubled in size since our first visit back in 1972.

These days 220 sows are housed in two main farrowing sheds and weaners grown out in six straw based shelters, supplied by local company Jacksons Australia. Three more of these have

been added since the last visit.The farm uses batch farrowing

growing around 175 pigs over 13 weeks and has been a long term believer in Myora genetics.

Matt has maintained low disease levels after conducting a ‘Swiss’ depop about 13 years ago. Keeping their high herd health status is critical in maintaining production levels.

“We have been a closed herd for eight years now which helps us manage farm biosecurity,” Matt explained.

A key element of adopting the Blueprint program was the construction of a new feed milling shed and equipment.

The feed milling equipment was supplied by Martin Liese’s Skiold and Vacmillsolutions.

“The plant is a Skiold Flex Mill combination which automatically pre-mills different grains through a Skiold

Sophie Thompson and Rohan Wundke from Alltech/Lienert with Matthew Starick at Kongola Farms.

w

13

SHELTERS8, 10, 12, 13 & 15M Clearspan

Configured to suit your requirements

FEEDERS2 – 8 tonne storage capcityIdeal for non-powered sites

LOAD OUT FACILITIESRamps, round yards, shelters, yards

SILOS4 – 70 tonne

STRUCTURAL ENGINEERING

Design • Engineering • Fabrication

Ph: 08 8531 2700 Fax: 08 8531 2711 185 Thomas Street, Murray Bridge SA 5253Email: sales@jacksonsaustralia.com Website: www.jacksonsaustralia.com

Danisco Animal Nutrition

Copyright© 2014 DuPont or its a . All rights reserved. The DuPont Oval Logo,DuPont™ and all products denoted with ® or ™ are registered trademarks ortrademarks of DuPont or its a

Lower your feed costs, improve uniformity and increase raw materialexibility, while reducing environmental impact with these innovative

feed solutions.

Used alone, or in combination, these reliable, heat stable enzyme andnatural betaine products are customized to increase nutrient availabilityand improve tability for pig producers.

Contact our distributor Feedworks, AustraliaTel 03 5429 2411 www.feedworks.com.au

MORE PROFIT FROM IMPROVED NUTRITION

Email : mal.mottram@feedworks.com.au david.cadogan@feedworks.com.au stuart.wilkinson@feedworks.com.au

14

FEATURE

1. The farm has now expanded to include six straw-based shelters. 2. The new Skiold SK500 disc mill. 3. Sophie and Matt with the Blueprint handbook and on-farm toolkit. 4. Matt with Rohan discussing the importance of pellet size.

1

2

3

SK500 disc mill with grain cleaner into four different milled grain silos.” Martin explained.

“The disc mill can be adjusted for a range of grain particle sizes that Matthew requires for his diets.

“The mixing is achieved by a Skiod uni mix 1500 1.5 tonne mixer unit.

“The whole plant is controlled by a Skiold Flexmill automatic control panel, which, other than allowing the plant to run automatically with minimal labour involvement, also provides capability for Matthew to store all his formulations, production history, stocks and ingredients.

“The equipment was acquired from Skiold & VMS in a kit format and Matthew was able to install it all himself,” Martin concluded.

The new mill and its capabilities combined with the Lienerts/Alltech Pig Blueprint system (of which grain particle size is an important component) are delivering consistent improvements in all growth stages.

“As an independent medium sized operation we didn’t have the opportunity to benchmark our performance as the big growing companies can, or those that may be part of a marketing group,” Matt said.

Blueprint gives us that opportunity to benefit from a process that delivers that benchmarking capability which gets us to focus on the things that are going to make a difference on our farm.

Pork Journal also discussed that perennial problem for pig farmers, which is finance.

“Banks are nervous about lending the kind of sums needed to increase our production capacity by another 50% whereas if we were just buying land for cropping, for instance, it wouldn’t be that much of a struggle.

We already have a considerable cropping capacity and can be almost self sufficient in base grain production but Blueprint can in effect be an independent audit on the farms capabilities and potential for further growth that may help us convince financiers as we grow the operation,” Matt said.

Matt and Sharon Starick’s farm was one of the first to adopt the Blueprint for Pigs system.

“We are achieving 24 piglets per sow and our first focus has been on starter diets and we have through Blueprint not experienced a growth check weaning at 21 days.

“Now our focus is moving to breeders; longer term we are looking to improve sow housing.

v

15

FEATURE

4 5

5. Pellet size matters when it comes to the Blueprint system.

“Eight months ago, when we started the Blueprint program, our biggest issues were maintaining constant sow condition and feed intake in the farrowing house but that seems to be under control now,” Matt said.

Apart from helping to run the farming operations, Sharon Starick is deeply involved with local, regional and national issues, particularly those involving agriculture.

She is the Chair of the SA Murray-Darling Basin Natural Resources Management Board, on the board of Animal Health Australia and Chair of the Rural Business Support.

She is also a director of the Royal Automobile Association of South Australia.

Her interest in the pig industry also extends to holding the position of chair of the APIQ panel.

Matt and Sharon’s three daughters are also passionate about agriculture and are becoming more involved in farming activities with Rebekah, 18, undertaking an Agricultural Science degree while Leah (15) and Hannah (12) are enjoying the agricultural program at school.

The Alltech/Lienert Pig Blueprint system obviously has the potential for application across all aspects of pig production but it seems to particularly suitable for small to medium sized independent operations like the Starick’s Kongolia Farms.

In the face of increased demand for pork both from Australian and regional export markets is to be met the fastest growth in production will, in all probability, come from this middle sector of the industry.

At a time when returns for growers are healthy it would seem to make sense for growers like the Starick’s to invest in the overall improvement that management and nutrition programs like Blueprint for Pigs can deliver.

Finally Pork Journal would like to thank Matt Starick as well as Sophie Thomson and Rowan Wundke from Alltech/Lienerts for their time in helping us to produce our on –farm story.

The original Lienert business grew out of the Lienert family pig farming

enterprise and many of the key Lienert nutrition staff working with both the old and new ownership come from farms themselves.

Certainly Rowan Wundke has that background and perhaps this is what makes them take that extra bit of effort for their clients like the Starick family.

A critical factor in any livestock management strategy like Blueprint is the dedication of those that deliver and monitor the product.

It was noticeable on our visit to the Starick farm and in discussions afterwards how enthusiastic Rowan, and now Sophie, are about the progress that Matt and Sharon Starick have made in improving their productivity and thus their profitability.

SKIOLD & Vacuum Milling Solutions • Jimboomba Qld 4280 • Tel.: +61 755 477 588 • E-mail: martin@vacmillsolutions.com.au

&

CONTACT:Martin Liese: 0417 447 952Adrian Navie: 0448 865 525

GRAIN MILLING SPECIALIST

GRAIN MILLING DOESN'T HAVE TO BE A LABOUR INTENSIVE JOB!

SKIOLD & Vacuum Milling Solutions specialize in the design, sales and installation of quality grain milling equipment.

We supply the latest in grain milling and augering equipment. Australian

made and from around the world. We cover all of Australia and also the

pacific islands.

With 15 years experience in the farming industry we pride ourselves on

quality equipment, installations and undertake a commitment to ensure

customers satisfaction.

GRAIN MILLING AND AUGERING EQUIPMENT SPECIALISTSDESIGN, SALES AND INSTALLATION

CALL US TODAY TO HEAR WHAT WE CAN DO FOR YOU!

Discmill, mixer, augers, bucket elevator, jet filter, mineral hopper

16

NEWS

An insightful reflection by animal nutritionist Tony Edwards of ACE Livestock Consulting on how the past 30 years of research has benefited pork producers, set the scene for a vibrant 2016 Pig Day Out, attended by about 100 people and hosted by West Australian Pork Producers’ Association (WAPPA) and Department of Agriculture and Food WA (DAFWA) in April at Technology Park, Bentley.

Quoting fascinating statistics, such as the rise in average daily weight gain from 450gm in the 1970s to 700gm today, pigs produced per sow per year from 16 to 24 and kilograms of meat produced per sow per year from 960kg to 1800kg, Mr Edwards noted that pork production technology had advanced rapidly.

“However, we need to constantly improve to remain competitive and the main driver of improvements will be scientific research. There is still much more to uncover and we are currently well short of the biological potential of the pig,” he said.

Addressing the issue of where Australia sits in the global pig and pork productivity and profitability stakes, Pork CRC CEO Roger Campbell said the Australian industry was currently one of the most profitable and vibrant in the world.

“I expect growth based on longer term contracts, which will reflect demand for high integrity Australian pork and I also think there’s still plenty of money on the table for Australian pork producers if they can work on improving reproduction, carcass weights, feed efficiency and product differentiation,” Dr Campbell said.

Global trends were the use of post cervical AI and set time AI, fatty acids in lactation, tryptophan levels in lactation diets and large pellets in creep and weaner feeds.

Other R&D speakers in the morning session at WAPPA Pig Day Out 2016 included: • Dr Jae Kim, DAFWA: Dietary use of tryptophan and methionine;• Dr Megan Trezona, DAFWA: Outdoor

pig production;• Karen Moore, DAFWA: Feeds to control fat deposition after second dose of Improvac.

The afternoon session began with an entertaining biosecurity training session for producers and transporters by veterinarian Kim Nairn of Portec Veterinary Services.

Dr Nairn said pig manure posed the greatest disease risk and transporters, producers and processors needed to be vigilant about not transfering faecal matter.

His take home message for producers was “go home after today and take a good look at all biosecurity measures on your farms”.

Darryl D’Souza from APL sparked spirited debate when he updated the meeting on the Australian Pork Industry Quality Program (APIQ) and APL’s shaping our future program in relation to gestation stall free.

Dr D’Souza said APL’s aim was to keep regulators on its side and to defend its stance on farrowing crates and fresh pork imports.

In the final session, Murdoch University presentations included:• Prof John Pluske: Suppressing voluntary feed intake of finisher pigs;• Jeremy Ayre: Microalgae to treat piggery anaerobic digestion effluent;• Samantha Sterndale: Reducing stress through nutrition to improve pig growth;• Ingunn Stensland: Supplements to improve intestinal health in E.coli infected weaners.

Last speaker was Dr Kim Nairn,

WAPPA Pig Day Out 2016 looks to the future

this time wearing his ‘producer hat’ as he reflected on how his Peel Pork piggery survived the devastating January Yarloop bushfire.

Addressing a brief WAPPA general meeting at the start of Pig Day Out, WAPPA President Dawson Bradford commended WA producers and researchers on how they collaborated for the benefit of the industry and how this needed to continue as DAFWA transitioned and the onus of R&D in WA increasingly moved onto industry.

Rob Wilson updated developments relating to Pork Innovation WA (PIWA), an incorporated association expected to attract initial transition funding from DAFWA.

PIWA has been awarded a grower group R&D grant of $375,000, which will be administered by DAFWA and cover all aspects of free range pork production in WA.

Dr Wilson also announced the Pork CRC had awarded an honours project, through Murdoch University, to be associated with that free range work.

PIWA executive management committee members are Dr Rob Wilson (Chair), Ron Penn (Craig Mostyn Group), David Plant (Milne Agrigroup), John Pluske (Murdoch University), Neil Ferguson (Westpork) and Jan Cooper (WAPPA).

WA’s pork industry employs about 1700 full and part-time workers and more than $50 million has been invested in housing and production systems during the past five years to meet new guidelines for sow housing and production efficiency.

Speakers included (LtoR) Karen Moore (DAFWA), Tony Edwards (ACE Livestock Consulting), Hugh Payne (DAFWA), Roger Campbell (Pork CRC), Jae Kim (DAFWA), Megan Trezona (DAFWA) and Diana Turpin (Murdoch University).

By BRENDON CANT, BCA PR Pty Ltd

17

NEWSSunPork appoints Group CEO and MD

Progress on food labelling laws

In recent years, the SunPork Group of Companies has grown to become a dominant Australian producer, processor and distributor of pork and value-added pork products.

The Group currently consists of three operating entities – Sunpork Pty Ltd covering SunPork Farms and PIC Australia with Robert van Barneveld as the Chair and Managing Director, and Sunpork Fresh Foods Pty Ltd and Swickers Kingaroy Bacon Factory Pty Ltd with Ross Ingram as the Chief Executive Officer.

With the retirement of Ross Ingram, the Sunpork Fresh Foods/Swickers Board has been considering options for a suitable successor.

The Shareholders and all Boards have also been examining ways to improve the supply chain and how to ensure all aspects of the business have a common focus. After due consideration, it has been agreed that the best way to achieve this is to bring all of the operating entities under common management to facilitate a ‘One SunPork’ approach.

To drive a focussed business and align the supply chain, the Shareholders and Boards have announced that Dr Robert van Barneveld will assume the role of Group CEO and Managing Director of the SunPork Group including SunPork Pty Ltd and its associated entities, SunPork Fresh Foods Pty Ltd and Swickers Kingaroy Bacon Factory Pty Ltd. His responsibility in this role commenced on April 4, 2016.

Robert has worked with the Cameron, Hall and Mclean families and their pork businesses since 2002. For the past 18 months he has been focussed on the integration of SunPork Farms. His role will now extend to full integration across the supply chain. Robert is already very familiar with all of the existing entities and is looking forward to building the SunPork business and brand further and developing the existing strengths within these well-established enterprises.

This appointment means he will assume overall operational responsibility of all existing businesses which will also involve

For all your livestock needs

Vegetable Protein Meals,

Animal Protein Meals,

Vitamins and Mineral Premixes,

Feed additives and Supplements,

Custom and Standard Millpacks,

Animal Health and Husbandry.

Suppliers of Elite nutrition and solutions

Ph: (02) 9609 7922Fax: (02) 9609 7923

Kym: 0439066054Luke: 0439066006

kym@nationalfeedsolutions.com.auluke@nationalfeedsolutions.com.au

some structural changes at a senior management level. In particular, Dr Darryl D’Souza has been appointed to

assume the role of CEO, Sunpork Solutions (which currently manages benchmarking, training, science, technology and adoption, nutrition and veterinary services to the farming enterprises).

In addition, the company is in the process of appointing a Group Chief Financial Officer to better integrate the growing financial and information technology aspects of the business. Rod Hamann will remain CEO, Sunpork Farms South, Paul O’Leary will continue as CEO, SunPork Farms North and PIC Australia, Rhys Collins will be Chief Operating Officer, SunPork Fresh Foods and Linchon Hawkes will be General Manager – Operations of Swickers Kingaroy Bacon Factory.

In addition to operations, Directors will also consider options to refine and simplify the legal structure of the overall business over coming months.

The Australian Made Campaign, the organisation that administers and promotes the green-and-gold ‘Australian Made, Australian Grown’ logo, has welcomed the Federal Government’s announcement that State and Territory Ministers have agreed to support use of the logo in a new country-of-origin labelling scheme for food products.

Under the new system, all food products made or grown in Australia will carry the kangaroo logo, along with a bar chart showing what proportion of the ingredients come from Australia.

Australian Made Campaign Chief Executive, Ian Harrison, said the new food labelling scheme had the potential to improve clarity and consistency for Australian consumers and recognised the announcement as an important milestone for the logo.

“We welcome this endorsement of the Federal Government’s new country-of-origin food labelling scheme,” Mr Harrison said.

“More transparent food labelling will give shoppers a better understanding of the provenance of their purchases and will also provide Australian farmers and manufacturers with a much-needed leg up.”

18

NEWS

CEO of APL Andrew Spencer

ABARES 2016 predictions for pork production

New perfect pork campaign

The Australian Government ABARES organisation, part of the Department of Agriculture and Water Resources, held its 2016 Outlook Conference on March 1-2 at the National Convention Centre, Canberra ACT.

The opening address was given by Deputy Prime Minister and Minister for Agriculture and Water Resources, Barnaby Joyce.

“We are all well aware of the massive increase required in global food production as populations grow and become more prosperous out to 2050.

“Australia is well placed to take advantage of this growing demand because we have the space, water, ground conditions and clean green image to do it.

“A key issue we must focus on is how we can improve the level of Australian investment in our agricultural industries,” he said.

Andrew Spencer, CEO of Australian Pork Limited spoke on the ‘Meat & Livestock- Value creation through supply chains’, session.

His topic was ‘Investing in pork industry growth in Australia’.

He covered the many challenges the pig industry has faced in recent times including vegan driven animal welfare activity, imports, eating quality and the successful move to sow stall free production.

For anybody with an interest in where the industry has been, and more importantly, where it is going it is worth listening to his entire 15 minute presentation by following this link:http://www.agriculture.gov.au/abares/outlook-2016/Pages/presentation-videos-transcripts/andrew-spencer.aspx

As Mr Spencer points out, there is much cause for optimism which is clearly indicated in the Pig Meat Outlook to 2020-2021 prepared by ABARES Karen Dutra.

“Over the hook pig prices are forecast to increase in 2016-17 in response to higher consumer demand for pig meat partly in response to higher consumer demand for pig meat partly in response to forecast higher retail prices for beef and lamb,” the report suggested.

“Australian pig meat production is projected to rise over the short and medium term (to 2020-21) through herd expansion.

“Pig meat imports are projected to rise over the short term, with US pig

meat supplies recovering from disease issues and higher levels of shipments from the European Union because of the Russian Federation’s ongoing ban on EU pig meat.

“The Australian weighted average over the hooks pig price is forecast to rise by 10% in 2015-16 to 356 cents per kg.

“This primarily reflects increased demand for locally produced fresh pork resulting from consumers facing rising retail prices for red meats.

“Over the medium term, over the hooks pig prices are projected to remain high, reaching 363 cents per kg by 2020-21 (in 2015-16 dollars).

“Demand for locally produced pork is expected to remain firm over the remaining outlook period as prices for competing red meats are projected to remain relatively high,” the report’s introduction concluded.

Though imports are predicted to continue to rise so are exports.

“Australian pig meat exports have been forecast to increase by 3% in 2015-16 to around 28,000 tonnes

(shipped weight).Value of exports in 2015-16 is

forecast to increase by 19% to $122, million, with the assumed lower $A supporting export values,” the ABARES report stated.

A new campaign from Australian Pork Limited promises to deliver perfect pork meals in just 10 minutes.

Butcher Anthony Puharich from Vic’s Meats and Victor Churchill is the face and voice of the $5 million campaign, which launched recently focussed on a pork steak.

Australian Pork Limited General Manager of Marketing, Peter Haydon, said the campaign aimed to build consumer familiarity with more pork cuts.

“Pork has been increasing in popularity for some time and ABARES has forecast consumption to overtake beef in 2017,” Mr Haydon said.

“While that’s the case, we know that people still gravitate towards cuts like ribs, roasts and sausages. They are less familiar with cuts like pork steaks, which are great quick cooking cuts.”

“The how to cook campaign will help people become more confident in cooking pork steaks through a simple memory tool.

“A perfect pork steak is as simple as 6-2-2,” Mr Haydon said.

“Firstly, choose a pork steak that’s two centimetres thick, then preheat a pan to a medium-high heat. Cook the steak for six minutes on one side, two minutes on the other, then remove from the heat without turning and rest for two minutes.

“This process of 6-2-2 is nice and easy to remember and delivers a steak that’s delicious to eat.”

Mr Haydon said pork steaks were a great weeknight cut, able to be matched with a range of sides and sauces for a quick dinner.

“We think once people try this technique at home, they’ll make pork steaks part of their menu repertoire,” Mr Haydon said.

“There are plenty of recipe suggestions on our website too, that can help transform a simple steak into a satisfying meal.”

The new campaign got underway this month at retailers, butchers, and on television and radio.

APL is also suggesting that people who want tips and pork recipes, can visit www.pork.com.au

19

PORK CRC NEWS

AusScan calibrations have been one of the most valuable technological advancements in animal nutrition in the past 30 years, according to leading South Australian animal nutritionist Tony Edwards of ACE Consulting.

Mr Edwards recently addressed an AusScan near infrared reflectance (NIR) workshop for Australian nutritionists and feed-mill technicians, which aimed to:• Improve industry’s knowledge and understanding of NIR technology. • Discuss applications of the technology and improving data management. • Demonstrate using AusScan Online.• Discuss the future of NIR.• Outline how to utilise energy values.

Speaking at the University of Sydney, he stressed that by knowing the digestible energy of grains before feeding livestock, nutritionists could provide more accurate formulations and confidently select the correct parcels of grains for composite diets.

Using least cost formulations and today’s grain prices, he informed the workshop that “1 MJ DE/Kg was worth $25 to $30 per tonne”.

He suggested that the undersupply or oversupply of energy in diets had consequences which could further increase costs due to reduced performance of livestock.

Joint venture partners Aunir UK and Cooperative Research Centre for High Integrity Australian Pork (Pork CRC) made AusScan calibrations available to customers worldwide a year ago via the Aunir website (www.aunir.co.uk).

Agri-Torque’s Ivan Ward, who consults throughout the Asia Pacific region on the application of NIR, discussed the use of NIR technology in feed mills, including how in line NIR opportunities provide real-time information and capture nutrient variation.

An excellent case study was presented which demonstrated NIR’s effectiveness in providing rapid and accurate information on product quality measures before acceptance into the feed mill.

Workshop attendees learnt the steps required to verify accurate NIR readings, with emphasis on sampling techniques.

Samantha Openshaw of FOSS Pacific gave a live demonstration on scanning whole grains, with insights into sample preparation.

Interestingly, the FOSS machine will

AusScan advances animal nutritioncombine five scans of the grain sample in one pass, thereby ensuring coverage of the whole sample.

According to workshop facilitator, Pork CRC Manager, Commercialisation and Research Impact, Charles Rikard-Bell, NIR machines have user friendly software and uploading and downloading files to the AusScan website is a quick and easy process.

Chris Piotrowski of Aunir in the United Kingdom presented the future of NIR in industry and the workshop attendees learnt that technological advancements would reduce the size of NIR machines.

“This generated much discussion on the progress made in the development of hand held devices and the corresponding accuracy of the measurements,” Dr Rikard-Bell said.

“Chris also gave a fascinating insight on other uses of NIR machines to verify ingredient uniformity simply by viewing spectra curves, noting that feed mills could get valuable insights into product variability simply by understanding spectra variations.

“It was also now possible to summate spectra files of raw materials to produce a spectra output for a complete feed,” he said.

AusScan Online is now available

Biotronic® Top3

The Biomin® Permeabilizing Complex in Biotronic® Top3 damages the outer membrane of Gram-negative bacteria thus boosting the synergistic effect of its components, the organic acids and the phytochemical.

• Increased weight gain • Improved feed conversion• Maximised economical benefi t

Tel.: +61 2 9872 6324offi ce.australia@biomin.net

biotronictop3.biomin.net

the breakthrough in pathogen control

MANAGEM

ENT

Naturally ahead

through Elizabeth Owens (EOwens@symbioalliance.com.au) at Symbio Laboratories https://www.symbiolabs.com.au and Ian Wickham (IanWickham@feedcentral.com.au) at Feed Central https://www.feedcentral.com.au.

To create an AusScan Online account, visit www.aunir.com/products/ausscan-online and follow the links.

A full list of available calibrations can be found on the Aunir website www.aunir.com/products/ausscan-online.

Aunir is a leading developer and supplier of NIR spectroscopy solutions, which cost effectively test the quality attributes of ingredients and products used in the animal feed and flour milling industries across the world.

Pork CRC is a Cooperative Research Centre supported by the Australian Government and a range of stakeholders, including industry and universities, which supports and manages research to differentiate Australian pork as a ‘high integrity’ meat that is welfare-optimal, premium quality, nutritious, in high demand and produced while conserving energy and water, minimising greenhouse gas emissions and minimising cost of production.

20

NEWS

Pork Journal recently met with the Feed Ingredients and Additives Association of Australia (FIAAA) President, Jonothon Doubleday who explained what the association is all about and how changes to AgVet regulations would bring $100M of benefits to the intensive livestock industry.

The FIAAA was formed in 2011 with a key undertaking “to advocate and promote the safe use of feed ingredients ……”.

In February 2012 FIAAA implemented its Code Of Practice for use by feed ingredients and additives suppliers in the use of safe feed. (For a copy of the Code see http://www.fiaaa.com.au/Code-of-Practice/Code-of-Practice.aspx).

“In addition to the Code of Practice, the FIAAA provides members a voice and advocate to interact with Government and Industry,” Mr Doubleday said.

“One of the initial efforts was to better align risk and regulation which previously required long delays for approvals through the regulatory body (APVMA).

“After many meetings, including study tours with Government and APVMA representatives, a new model for regulation of ‘nutritional and digestive substances’ was put forward and progressed in a co-operative relationship with industry, government and regulators.

“FIAAA Executive Committee met with Minister Barnaby Joyce when he announced changes which provide improved access to feed ingredients and additives by simplifying regulations and cutting red tape.

“Industry has estimated a potential benefit exceeding $100M to the intensive livestock industry.

“Better regulation imposes responsibility on industry,” said Mr Doubleday.

“From March 2015 government recognised that regulations imposes cost and that industry managed systems were effective in managing risk.

“Our FIAAA Code of Practice now provides its members with an opportunity to demonstrate feed safety, fundamental to our association”.

Following Minister Joyce’s announcement of the de-regulated approach for “excluded nutritional and

digestive” (END) products the FIAAA Code was upgraded in 2015 to reflect the new Veterinary Chemical regulations and is now used by its members to demonstrate compliance.

“FIAAA members who are Certified are audited to demonstrate their compliance.

“More than 21 of our members are now Certified and the number is rapidly growing as member transition to the new requirements.

“Stockfeed mills using FIAAA Certified members products can rest easy that quality and regulatory compliance are managed effectively by the industry Code.”

“We congratulate the government for recognising that regulation imposes costs and that other regulatory frameworks are effective at managing risks, such as Industry QA systems.

“This allows a better alignment of regulatory effort with risk and recognises the responsibility of the feed industry. It also allows the regulator (APVMA) to focus effort on higher risk products and align Australia with international practice on animal feed,” said Mr Doubleday.

The Australian stock feed

Feed additive industry manages its risks

Natuphos E launched at APSA

industry is reliant upon the use of a wide range of feed ingredients and additives. The FIAAA Code of Practice includes product sourcing, detailed specifications and descriptions, testing, certificates of analysis, labeling, product recall procedures, traceability and information on correct product use. It also now incorporates the AgVet regulatory requirements.

Global chemical company, BASF, launched a new animal feed enzyme, Natuphos E, at the recent Australasian Pig Science Association Conference.

“Natuphos E contains a natural enzyme, known as phytase, which enables pig and poultry to better utilise phosphorous and other important nutrients like energy, proteins and minerals – bringing a range of benefits to the feed manufacturing industry,” BASF’s animal nutrition expert, Leon Hall said.

“The majority of phosphorous in grains and oilseeds is bound as phytate, an anti-nutritive factor found in feed. Phytate-bound phosphorous is unavailable to animals and is wasted when excreted, meaning manufacturers are forced to add inorganic phosphates to feed mixes to balance out the required phosphorous.

“Natuphos E releases the phosphorus from phytate, alleviating the need to add inorganic sources, saving manufacturers money and slowing

Jonothon Doubleday.

down the use of non-renewable rock phosphates.

“In addition to making phytate-bound phosphorous available to animals, it also releases other associated nutrients making animals generally more efficient at digesting their feed, leading to less excretion of undigested nutrients.

“BASF introduced the world’s first phytase feed enzyme, Natuphos, 25 years ago. We are very excited to announce that the next generation technology is here and it has been built on decades of experience.

“Our new phytase is called Natuphos E because it’s more efficient, economical and environmentally friendly than its predecessor, which has been the industry gold standard for the last two-and-a-half decades.

“This novel, hybrid 6-phytase shows excellent stability properties. It withstands the rigors of feed production and handling, and shows excellent efficiency in the animal.”

21

NEWSAlltech Ideas Conference explores agriculture as the key to future of food

Mobile.......0428 637 717Phone.....(02) 9974 2704Fax..........(02) 9974 2705

www.axonmachinery.com.auAXON

SPREADER SIZES: 6-40 TONNES

• HEAVY DUTY DESIGN AND CONSTRUCTION

• IDEAL FOR ALL TYPES OF MANURE & COMPOST

• WILL ALSO SPREAD LIME & GYPSUM

• EMPTY LESS THAN 4 MINS

• AN EVEN SPREAD WIDTH UP TO 24 METRES

MANURE SPREADERS

Project4:Layout 1 21/03/14 12:22 PM Page 1

Within the next 34 years, the world will add an extra three billion mouths to feed. What will that mean for humanity, or, perhaps even more importantly, the agriculture and food sectors responsible for nourishing them?

At ONE: The Alltech Ideas Conference, held from May 22 to 25 in Lexington, Ky., USA, attendees will explore this question with experts from around the world.

“A future of plenty is ours if individuals, the private sector, agriculture and governments make meaningful choices today that harness the power of technology, conserve resources and encourage innovation,” said founder and President of Alltech, Dr Pearse Lyons.

“The agriculture industry is the linchpin in this equation, and ONE will feature a variety of relevant talks and breakout sessions on feed efficiency, farm management and profitability, crop innovation, algae and DHA, nutrition and genetic expression, immunity and gut health, alternative protein sources, international agribusiness opportunities and much more.

“With its topical blend of science, agriculture, entrepreneurship, business and marketing information, ONE will show attendees how they can make a real difference in our changing world.”

Confirmed agriculture talks and breakout sessions at ONE include:• ‘One giant step: The digital farm’ with David Hunt, co-founder of Agrilarity.• ‘Rule No.1: There are no rules’, with Mary Shelman, former Director of the agribusiness program at Harvard Business School.• ‘ONE Centimeter of soil’, with Robert Walker, General Manager for Alltech Crop Science.• ‘How long can we go? Feed efficiency and profitability for the nutritionist of the future’.• ‘The future of disease control: What role can nutrition play in PEDV, avian influenza, foot-and-mouth disease, salmonella and Campylobacter?’• ‘Crop Innovation: Feed a plant – Reviewing the latest breakthroughs in technologies and information management’.• ‘A World of Milk: How consumer trends, farm practices and new expectations are shaping dairy farming in the future’.• ‘A World of Beef: How consumer trends, farm practices and new expectations are shaping beef production in the future’.• ‘The Future of Fish: Where next for fish farming now that aquaculture exceeds fish from the sea, now that fish consumption exceeds beef’.• ‘The Prosumer: Future proofing your food business – What do you need to know about the food consumer of the future and how it will impact food, feed and farming?’.• ‘Nutrition, Immunity & Gut Health: 30 years of Alltech research and how intestinal health is becoming the focus of veterinarian medicine’.• ‘Bridging the Protein Gap – In a world of scarcity, how will we feed the planet with fewer protein options? Thinking creatively about nutrition’.• ‘Emerging Agribusiness Opportunities – Lessons from Harvard Business School and lessons to design the ideal agribusiness’.

• ‘Feeding the Rumen: The basis of profitability and sustainability on your farm’.• ‘What you need to know about Algae and DHA: Fish, pets, farm animals and people’.

Other speakers giving agriculture-related talks or leading breakout sessions at ONE include:• Dr. Ronan Power, Vice President of Alltech life sciences.• Aidan Connolly, Chief Innovation Officer and Vice President of Corporate Accounts at Alltech.• Seth Siegel, author of ‘Let There Be Water: Israel’s Solution for Water-Starved World’.

Attendees will be able see ONE Vision, a virtual world commissioned by Alltech that visualizes 2050 and showcases a planet of plenty, where technology and science align in order to produce nutritious food for the world’s nine billion inhabitants.

Attendees will also hear from Apple co-founder Steve Wozniak, former CEO of Ford, Alan Mulally,among others, as well as view a live performance by Riverdance and attend a craft beer festival.

For more information or to register, visit one.alltech.com and join the conversation online with #ONEBigIdea.

22

NEW PRODUCTS

porkjournalServing the pork industry in Australia and New Zealand

Don’t miss out on a single issue of porkjournalFill out the coupon and send it in.To view copies of the magazine on-line go to our website www.primarymedia.com.au and click on latest issues

Send this completed form to: Poultry Digest, 22 George St,East Gosford NSW 2251. Ph: (02) 4323 0005

Please send me the next six issues of POULTRY DIGESTEnclosed is my cheque for: A$55.00 (inc GST) or A$80.00

for overseas. Send your email address for a digital version.Cheques are to be made payable to Primary Media in Australian $

Please charge A$ to my: (please tick appropriate box) VisaCard MasterCard Bankcard

Expiry date Signature................................

(Please print all your details in BLOCK LETTERS)

NAME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .ADDRESS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . P/CODE . . . . . . . . . . .

Send this completed form to Pork Journal, 22 George St, East Gosford, NSW 2250. Ph: (02) 4323 0005

Please send me the next six issues of PORK JOURNAL

Send this completed form to Pork Journal, 250 Hawthorne Parade, Haberfield NSW 2045. Ph: 02 9797 2406

Dr Geoff Irish has joined AusPac.

market share AusPac Ingredients has achieved across a range of animal species and market segments” said Geoff. “You can’t achieve this with products that are less than world class”.

Geoff is excited by the opportunities that exist to further the success of the business through his technical knowledge and standing in the industry.

“There is a real shift in thinking in terms of how industry approaches novel feed additive products”.

“I have seen many of these as they have been introduced to the Australian market, but what has impressed me with the Selko range has been the research depth and technical validation provided by Nutreco.”

The products that Geoff will be focussing on are Selko pH, Fysal, Selacid Green Growth, Presan and Optimin organic trace minerals.

“I have been aware of these products for a number of years and I am pleased to have the opportunity

Dr Geoff Irish joined AusPac Ingredients Pty Ltd as Technical Manager on January 25, 2016.

Geoff completed a Bachelor of Agricultural Science (1st Class Honours) at the University of Adelaide in 1988 and a PhD in poultry nutrition at the University of Sydney in 1992.

After completing his PhD he spent 3 years as a Post-Doctoral Fellow at the University of Saskatchewan, Canada examining methods of improving the nutritional value of soybean meal and predicting the nutritional value of wheat and barley for poultry.

Since returning to Australia in 1996 Geoff has been involved in the animal stockfeed and feed additive industry. During this time Geoff has had experience with a number of products in the Selko range and has seen first-hand the growth of the market share of Selko products in the hands of the Nutreco distributor, AusPac Ingredients.

“I have been impressed by the

Dr Geoff Irish joins AusPac Ingredients here at AusPac Ingredients,” said Geoff. “Having had limited direct contact with Nutreco’s research network and facilities in the past, I am excited by the chance to increase this connection and by the possibilities to add real value to the Australian industry”.

Breeding better pigsfor Australia

www.picaustralia.com.au

PIC AustraliaPO Box 39Grong GrongNSW 2652

Ph: 02-6956 2105Fax: 02-6956 2203

www.primegro.com.au

Primegro, a divison of Rivalea.

LESS WAIT.

145 days

105 kilosless than

MORE WEIGHT.

PRIMEGRO TERMINAL GENETICS lead to rapid growth and increased profitability.Superior growth rate gives you the choice – more weight per pig, or less time to market. Either way, increased efficiency and profitability are the result. To find out more, contact Matthew Tull – Primegro Business Manager on 0439 612 747 or (02) 6033 8340

Results are based on typical progeny growth performance achieved using Primegro Genetics grown under a high health environment and fed using the Rivalea Nutritional Program.

TRIAL OUR TERMINAL GENETICS

AND SEE FOR YOURSELF

Call us today!