pioneer avh p6500dvd,avh p6550dvd

8/8/2019 Pioneer Avh p6500dvd,Avh p6550dvd

1/210

PIONEER CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, JapanPIONEER ELECTRONICS (USA) INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A.PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, BelgiumPIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936

C PIONEER CORPORATION 2003 K-ZZU. APR. 2003 Printed in Japan

ORDER NO

CRT3038

AV RECEIVER/DVD PLAYER WITH 6.5 INCH WIDE DISPLAY

AVH-P6500DVD UC

ervice

n l

- This service manual should be used together with the following manual(s):

Model No. Order No. Mech. Module Remarks

CX-3016 CRT3056 MS3 DVD Mech. Module:Circuit Description, Mech.Description, Disassembly

AVH-P6500DVD/UC

NOTE:

- Manufactured under license from Dolby Laboratories. "Dolby" and the double-D symbol are trademarks of Dolby

Laboratories. Confidential unpublished works. 1992-1997 Dolby Laboratories. All rights reserved.

- Inverter for LCD back light becomes a high voltage.

For details, refer to "Important symbols for good services".

AVH-P6500DVD EWAVH-P6550DVD RC,RD


2/210

2

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

SAFETY INFORMATION

- DVD Player Service Precautions

1. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during

power-on mode may damage the ICs inside the unit.

2. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-sol-

der) by referring to the DISASSEMBLY on page 167.

3. Please adjusting the skew after changing the pickup unit(see page 133).

4. During disassembly, be sure to turn the power off since an internal IC might be destroyed when a connector is

plugged or unplugged.

UC

CAUTION

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.

Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair

complex products such as those covered by this manual.

Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.

If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so

and refer the repair to a qualified service technician.

WARNING

This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of

California to cause cancer, birth defects or other reproductive harm.

Health & Safety Code Section 25249.6 - Proposition 65

EW

1. Safety Precautions for those who Service this Unit.

Follow the adjustment steps (see pages 129 through 166)in the service manual when servicing this unit. When check-

ing or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results.

Caution:

1. During repair or tests, minimum distance of 13cm from the focus lens must be kept.

2. During repair or tests, do not view laser beam for 10 seconds or longer.

2. The triangular label is attached to the mechanism

unit frame.


3/210

3

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

On the top of the player.

CAUTION :

VORSICHT :

ADVARSEL :

VARNING :

VARO! :

VISIBLE AND INVISIBLE LASER RADIATION WHEN OPEN.AVOID EXPOSURE TO BEAM.

SICHTBARE UND UNSICHTBARE LASERSTRAHLUNG, WENNABDECKUNG GEFFNET NICHT DEM STRAHL AUSSETZEN!

SYNLIG OG USYNLIG LASERSTRLING VED BNINGUNDG UDSTTELSE FOR STRLING.

SYNLIG OCH OSYNLIG LASERSTRLNING NR DENNADEL R PPNAD BETRAKTA EJ STRLEN.

AVATTAESSA ALTISTUT NKYV JA NKYMTTMLLELASERSATEIL YLLE. L KATSO STEESEN. VRW1860

CLASS 1LASER PRODUCT

WARNING!

The AEL (accessible emission level )of the laser power output is less than CLASS 1

but the laser component is capable of emitting radiation exceeding the limit for

CLASS 1.

A specially instructed person should do servicing operation of the apparatus.

Laser diode characteristicsWave length:

DVD:640~660nm

CD:770~810nm

Maximum output:2.44mw(Emitting period :9sec.)

DVD:743mw(Emitting period : unlimited)

Additionla Laser Caution

Transistors Q1101 and Q1102 in PCB drive the laser diodes for DVD and CD

respectively. When Q1101 or Q1102 is shorted between their terminals,

the laser diodes for DVD or CD will radiate beam. If the top cover is removed

with no disc loaded while such short-circuit is continued, the naked eyes may

be exposed to the laser beam.


4/210

4

[ Important symbols for good services ]In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely.When you find the procedures bearing any of the symbols, be sure to fulfill them:

2. Adjustments

To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable.In accordance with the procedures or instructions described in this manual, adjustments should be performed.

3. Cleaning

For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning,proper cleaning should be performed to restore their performances.

5. Lubricants, glues, and replacement partsAppropriately applying grease or glue can maintain the product performances. But improper lubrication or applyingglue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply theprescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribedones should be used.

4. Shipping mode and shipping screws

To protect the product from damages or failures that may be caused during transit, the shipping mode should be set orthe shipping screws should be installed before shipping out in accordance with this manual, if necessary.

1. Product safety

You should conform to the regulations governing the product (safety, radio and noise, and other regulations), andshould keep the safety during servicing by following the safety instructions described in this manual.

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

CAUTIONDanger of explosion if battery is incorrectly replaced.

Replaced only with the same or equivalent type recommended by the manufacture.

Discord used batteries according to the manufacture's instructions.

ES

CAUTION

Danger of explosion if battery is incorrectly replaced.

Replaced only with the same or equivalent type.

Battery

Slide the tray out on the back of the

remote controller and insert the battery

with the (+) and () poles pointing in

the proper direction.

Note :

Use a CR2025 (3V) lithium battery

only. Never use other types of battery

with this unit.


5/210

5

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

CONTENTS

SAFETY INFORMATION ............................................2

1. SPECIFICATIONS........................................................6

2. EXPLODED VIEWS AND PARTS LIST .......................8

2.1 PACKING...............................................................8

2.2 EXTERIOR(1).......................................................102.3 EXTERIOR(2).......................................................14

2.4 EXTERIOR(3).......................................................16

2.5 DVD MECHANISM MODULE.............................18

3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM...20

3.1 BLOCK DIAGRAM ..............................................20

3.2 OVERALL CONNECTION DIAGRAM.................26

3.3 MOTHER PCB(GUIDE PAGE).............................28

3.4 RELAY PCB .........................................................34

3.5 EXTENSION PCB................................................35

3.6 DVD CORE UNIT(MS3)(SODC)(GUIDE PAGE) .36

3.7 DVD CORE UNIT(MS3)(CPU)(GUIDE PAGE) ....42

3.8 COMPOUND(A) AND COMPOUND UNIT(B)........50

3.9 PU UNIT(REFERENCE).......................................51

3.10 TUNER UNIT.....................................................52

3.11 INVERTER PCB .................................................54

3.12 MONITOR PCB,UPPER PCB AND SENSE PCB(GUIDE PAGE)56

3.13 GRILLE PCB ......................................................62

3.14 PANEL PCB .......................................................64

3.15 MAIN UNIT,SW UNIT AND VOLUME UNIT ...66

4. PCB CONNECTION DIAGRAM...................................68

4.1 MOTHER PCB .....................................................68

4.2 RELAY PCB AND EXTENSION PCB ..................72

4.3 DVD CORE UNIT(MS3) ......................................74

4.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ...78

4.5 TUNER UNIT.......................................................80

4.6 INVERTER PCB ...................................................82

4.7 MONITOR PCB ...................................................84

4.8 UPPER PCB.........................................................88

4.9 SENSE PCB.........................................................89

4.10 GRILLE PCB ......................................................90

4.11 PANEL PCB .......................................................91

4.12 MAIN UNIT .......................................................92

4.13 SW UNIT AND VOLUME UNIT........................94

5. ELECTRICAL PARTS LIST ...........................................95

6. ADJUSTMENT ..........................................................129

6.1 JIG CONNECTION DIAGRAM .........................129

6.2 DVD ADJUSTMENT.........................................130

6.3 MAIN VIDEO LEVEL ADJUSTMENT...............1506.4 MONITOR PCB ADJUSTMENT .......................152

6.5 INVERTER PCB ADJUSTMENT.......................156

6.6 MOTHER PCB ADJUSTMENT.........................157

6.7 MONITOR TEST MODE ...................................158

6.8 DOT CLOCK ADJUSTMENT............................162

6.9 TOUCH PANEL CALIBRATION ........................163

7. GENERAL INFORMATION........................................167

7.1 DIAGNOSIS ......................................................167

7.1.1 DISASSEMBLY ........................................167

7.1.2 PCB LOCATIONS.....................................173

7.1.3 CONNECTOR FUNCTION DESCRIPTION.174

7.2 PARTS ...............................................................176

7.2.1 IC ..............................................................176

7.2.2 DISPLAY...................................................202

7.3 OPERATIONAL FLOW CHART.........................203

7.4 CLEANING........................................................204

8.OPERATIONS .............................................................205


6/210

6

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

1. SPECIFICATIONS


7/210

7

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


8/210

8

20

34

15

16

1718

1914

11

32

3312

13

1

36

35

21

2

3

7

6

58

96

7

10

4

24

23

27

25

29

3130

22

28

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

2. EXPLODED VIEWS AND PARTS LISTNOTE:

- Parts marked by * are generally unavailable because they are not in our Master Spare Parts List.

- Screws adjacent to mark on the product are used for disassembly.

- For the applying amount of lubricants or glue, follow the instructions in this manual.

(In the case of no amount instructions, apply as you think it appropriate.)

2.1 PACKING


9/210

9

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

- PACKING SECTION PARTS LIST

Part No.

MarkNo. Description P6500DVD/UC P6500DVD/EW P6550DVD/RC P6550DVD/RD

* 1-1 Polyethylene Bag CEG1116 CEG1116 CEG1116 CEG11161-2 Owners Manual CRB1836 CRB1830 CRB1838 CRB18381-3 Owners Manual CRB1837 CRB1831 CRB1839 CRB18401-4 Installation Manual CRD3782 CRD3781 CRD3783 CRD3784

* 1-5 Card ARY1048 Not used Not used Not used

2 Carton CHG5077 CHG5076 CHG5078 CHG50793 Contain Box CHL5077 CHL5076 CHL5078 CHL50794 Air Cushioned Bag CEG1089 CEG1089 CEG1089 CEG10895 Polyethylene Bag CEG1173 CEG-162 CEG-162 CEG-1626 Protector CHP2707 CHP2707 CHP2707 CHP2707

7 Protector CHP2706 CHP2706 CHP2706 CHP27068 Protector CHP2387 CHP2387 CHP2387 CHP23879 Protector CHP2708 CHP2708 CHP2708 CHP2708

10 Remote Control Unit CXC1224 CXC1226 CXC1226 CXC1226* 11 Polyethylene Bag E36-615 E36-615 E36-615 E36-615

12 Screw CBA1650 CBA1650 CBA1650 CBA165013 Bush CNV1917 CNV1917 CNV1917 CNV191714 Cord Assy CDE7168 CDE7168 CDE7168 CDE716815 Cord Assy CDE7193 Not used CDE7193 CDE7193

16 Cord Assy CDE7194 CDE7194 CDE7194 CDE7194

17 Cord Assy CDE7321 CDE7321 CDE7321 CDE732118 Cord Assy CDE7187 CDE7187 CDE7187 CDE718719 Antenna Cable CDH1281 CDH1281 CDH1281 CDH128120 Sheet CNM7244 CNM7244 CNM7244 CNM724421 Sub Craton CHG5080 CHG5080 CHG5080 CHG5080

* 22 Polyethylene Bag CEG-158 CEG-158 CEG-158 CEG-15823 Screw Assy CEA3686 CEA3686 CEA3686 CEA368624 Screw CBA1468 CBA1468 CBA1468 CBA146825 Screw CMZ50P060FTC CMZ50P060FTC CMZ50P060FTC CMZ50P060FTC27 Screw BMZ50P060FTC BMZ50P060FTC BMZ50P060FTC BMZ50P060FTC

* 28 Polyethylene Sheet CNM4338 CNM4338 CNM4338 CNM4338

* 29 Lock Tie Not used CNV-754 CNV-754 CNV-754* 30 Fastener CNM6544 CNM6544 CNM6544 CNM6544* 31 Fastener CNM6545 CNM6545 CNM6545 CNM6545

32 Accessory Assy CEA3685 CEA3685 CEA3743 CEA3743

33 Fixing Screw JGZ20P070FMC JGZ20P070FMC Not used Not used34 Cord Assy Not used CDE7192 Not used Not used

* 35-1 Polyethylene Bag Not used CEG1116 Not used Not used35-2 Owners Manual Not used CRB1832 Not used Not used35-3 Owners Manual Not used CRB1833 Not used Not used

35-4 Owners Manual Not used CRB1834 Not used Not used35-5 Owners Manual Not used CRB1835 Not used Not used

* 35-6 Passport Not used CRY1013 Not used Not used* 35-7 Warranty Card Not used CRY1157 Not used Not used

* 35-8 Caution Card CRP1298 CRP1298 Not used Not used36 Cleaning Cloth Assy CEA3952 CEA3952 CEA3952 CEA3952

- Owner's Manual, Installation ManualPart No. Language

CRB1836 English

CRB1837 French

CRD3782 English,French

CRB1830 English

CRB1831 Spanish

CRB1832 German

CRB1833 French

CRB1834 Italian

Part No. Language

CRB1835 Dutch

CRD3781 English,Spanish,German,

French,Italian,Dutch

CRB1838 English

CRB1839 Traditional chinese

CRB1840 Spanish

CRD3783 English,Traditional chinese

CRD3784 English,Spanish


10/210

10

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

2.2 EXTERIOR(1)


11/210

11

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

1 Screw CMZ50P060FTC2 Case See Contrast table(2)3 Panel CNB28284 Holder CNC95105 Screw IMS26P050FTC

6 Holder CND1435

7 Bracket CND14388 Bracket CND14399 Holder CND1440

10 Holder CND1441

11 Bracket CND148212 Bracket CND160313 Insulator CNM811014 Insulator CNM849515 Cord Assy See Contrast table(2)

16 Transistor(Q851) 2SD237517 Panel See Contrast table(2)18 IC(IC308) PAL007A19 Mother Unit See Contrast table(2)

20 Screw BMZ26P160FTC

21 Screw BSZ26P080FTC22 Clamper CEF100923 Terminal(CN155) See Contrast table(2)24 Connector(CN701) CKM133225 Connector(CN301) CKM1389

26 Connector(CN972) CKS194027 Connector(CN1702) CKS194428 Connector(CN971) CKS219129 Connector(CN801) CKS312430 Connector(CN156) CKS3131

31 Connector(CN154) CKS3132

32 Connector(CN803) CKS375133 Connector(CN202) CKS390234 Connector(CN101,CN5901) CKS398635 Connector(CN805) CKS4068

36 Connector(CN203) CKS413237 Connector(CN152) CKS424938 Connector(CN151) See Contrast table(2)39 Connector(CN1502) CKS446740 Connector(CN1701) CKS4496

41 Connector(CN1500) CKS468042 Connector(CN153) CKS468143 Connector(CN201) CKS469144 Holder CNC539945 Holder CND1433

46 Holder CND143447 Holder CND143648 Holder CND143749 Heat Sink CNR168450 Heat Sink CNR1703

51 Clamper CNV125152 Fan Motor CXM126253 Screw BMZ20P025FTC54 Screw BMZ20P030FZK55 Screw BMZ26P030FZK

56 Screw BMZ26P040FTC57 Sheet CNM852658 Screw(M2x2) CBA155159 Label See Contrast table(2)60 Cord CDE6574

61 Cord Assy CDE7167

62 Cord Assy CDE717563 Cord Assy CDE717664 Cable CDE717865 Cable CDE7282

66 DVD Mechanism Module(MS3) CXK631067 Screw PMZ20P160FTC68 Button CAC795369 Screw CBA111170 Spring CBH2681

71 Spring CBH268272 Spring CBH268373 Cable CDE717974 Holder CND1841

75 Insulator CNM8510

76 Arm CNV756777 Arm CNV756878 Arm CNV756979 Panel Unit See Contrast table(2)80 Screw(M2 x 4) CBA1734

81 Screw BPZ20P080FZK82 Button(Detach) See Contrast table(2)83 Button(Eject) See Contrast table(2)84 Button(SRC) CAC794685 Button(EQ) CAC7947

86 Button See Contrast table(2)

87 Button(Reset) See Contrast table(2)88 Button CAC8149* 89 Badge See Contrast table(2)

90 Spring CBH2680

91 Cover CNS744192 Keyboard Unit See Contrast table(2)93 Sheet CNM851494 Connector(CN5501) CKS465795 Connector(CN5902) CKS4658

96 Grille Unit See Contrast table(2)97 Knob Unit CXC203498 Clamper See Contrast table(2)99 Sheet CNM8515

100 Cusion CNM8516

101 Holder CND1840

102 Insulator CNM8521

103 Screw(M2.6 x 2.5) CBA1482

104 Screw(M2.6 x 4) CBA1738

105 Spacer CNM8552

106 Spacer CNM8575

(1) EXTERIOR(1) SECTION PARTS LIST

Mark No. Description Part No. Mark No. Description Part No.


12/210

12

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

(2) CONTRAST TABLE

AVX-P6500DVD/UC , AVX-P6500DVD/EW , AVX-P6550DVD/RC and AVX-P6550DVD/RD are constructed

the same except for the following:

Part No.

Mark No. Description P6500DVD/UC P6500DVD/EW P6550DVD/RC P6550DVD/RD

2 Case CNB2910 CNB2910 CNB2911 CNB291115 Cord Assy CDE7177 CDE7177 Not used Not used17 Panel CNS7480 CNS7480 CNS7481 CNS7481

19 Mother Unit CWM8760 CWM8759 CWM8761 CWM8762

23 Terminal(CN155) CKF-047 CKF-047 Not used Not used

38 Connector(CN151) CKS4454 CKS4454 Not used Not used

59 Label Not used VRW1860 Not used Not used

79 Panel Unit CXC1895 CXC1895 CXC1896 CXC189682 Button(Detach) CAC7944 CAC7944 CXC7951 CXC795183 Button(Eject) CAC7945 CAC7945 CXC7950 CXC7950

86 Button CAC7948 CAC7948 CXC7949 CXC794987 Button(Reset) CAC8053 CAC8053 CXC8054 CXC8054

* 89 Badge CAH1754 CAH1754 CAH1792 CAH1792

92 Keyboard Unit CWM8766 CWM8765 CWM8766 CWM8766

96 Grille Unit CXC2181 CXC2180 CXC2182 CXC2182

98 Clamper CEF1009 CEF1009 Not used Not used


13/210

13

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


14/210

14

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

2.3 EXTERIOR(2)


15/210

15

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

101 Screw(M2x3) CBA1082102 Screw(M2x2) CBA1250103 Screw(M2x4) CBA1277104 Screw(M2x1.5) CBA1615

105 Washer CBF1038

106 Spring CBH2645107 Spring CBH2646108 Spring CBH2647109 Spring CBL1585110 Spring CBL1586

111 Spring CBL1587112 Cord Assy CDE7047113 Cord Assy CDE7213114 Shaft CLA4270115 Shaft CLA4305

116 Shaft CLA4306

117 Shaft CLA4309118 Bracket CND1221119 Heat Sink CND1228120 Case CND1229

121 Holder CND1318122 Holder CND1449123 Sheet CNM7939124 Sheet CNM8037125 Insulator CNM8048

126 Insulator CNM8158127 Sheet CNM8159128 Tape CNM8160129 Insulator CNM8294

130 Gear CNR1664

* 131 Gear CNR1665132 Gear CNR1677133 Gear CNR1678134 Gear CNR1679135 Gear CNR1680

136 Gear CNR1688137 Gear CNR1708138 Gear CNR1709139 Gear CNV7383140 Holder CNV7384

141 Holder CNV7385142 Rack CNV7386

143 Rack CNV7387* 144 Slider CNV7388

145 Slider CNV7389

* 146 Holder CNV7390147 Arm CNV7391148 Gear CNV7522149 Gear CNV7523

150 Gear CNV7524

151 Gear CNV7529152 Chassis Unit CXB9509153 Frame Unit CXB9511154 Holder Unit CXB9512155 Shaft Unit CXB9513

156 Holder Unit CXB9514157 Motor Unit(M3001)(Position) CXB9515158 Motor Unit(M3002)(Angle) CXB9516159 Screw CZB3082160 Screw CZB3083

161 Washer CZB3084

162 Main Unit CZW3087163 SW Unit CZW3088164 Volume Unit CZW3089165 Screw IMS20P020FTC

166 Screw IMS20P030FZK167 Washer YE15FUC168 Screw BMZ26P050FTC169 Connector(CN3801) CKS4068170 Connector(CN3802,CN3803) CKS3124

171 Connector(CN3807,3809) CKS3125172 Connector(CN3808) CKF1064173 IC(IC3801) BA00AST174 Volume(VR3841) CCW1025

175 Flexible PCB CNP7118

176 Holder CNV7446177 Screw CBA1484178 Holder CND1314179 Screw JFZ20P022FNI180 Cover CNS7438

181 Screw BPZ20P060FZK

- EXTERIOR(2) SECTION PARTS LIST



16/210

16

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

2.4 EXTERIOR(3)


17/210

17

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

201 Cord Assy CDE7194202 Cap CNV6727203 Cord Assy See Contrast table(2)204 Fuse(10A) See Contrast table(2)205 Cap See Contrast table(2)

206 Resistor See Contrast table(2)

207 Cord Assy CDE7321208 Cap CNS1472209 Resistor RS1/2PMF102J210 Remote Control Unit See Contrast table(2)

211 Cover CZN5357212 Cord Assy See Contrast table(2)213 Fuse(10A) See Contrast table(2)214 Cap See Contrast table(2)215 Resistor See Contrast table(2)

216 Screw BSZ26P060FTC217 Screw BSZ30P060FZK218 Cord Assy CDE7280219 Chassis CNA2615220 Case See Contrast table(2)

221 Insulator CNM8124222 Tuner Unit See Contrast table(2)223 Screw BMZ30P050FTC224 FM/AM Tuner Unit See Contrast table(2)225 Holder CND1432

226 Terminal(CN1412) CKF-047227 Pin Jack(CN1403) CKS1825228 Connector(CN101,CN102) CKS4653229 Pin Jack(CN1401,CN1402) CKS2918230 Connector(CN1404) CKS4467

231 Connector(CN1405) CKS4663232 Antenna Jack(CN1406) CKX1056

233 Holder CNC6746234 Holder CNC7205235 Holder CNC9888

236 Holder CND1451

237 Transistor(Q1404) 2SD2375238 Grille Unit See Contrast table(2)239 Touch Panel CSX1057240 Button(ENT,WIDE,MENU) See Contrast table(2)

241 Button CAC7936242 Screw JFZ20P022FNI

243 FFC CDE7195244 LCD CAW1805245 Holder CND1468

246 Lighting Conductor CNV7564247 Sheet CNM8488248 Holder CND1469249 Insulator CNM8131250 FFC CDE7196

251 LCD Panel CWX2671252 Insulator CNM8132253 Sheet CNM7783254 Sheet CNM7784255 Holder CND1467

256 Screw BPZ20P060FTC257 Monitor Unit See Contrast table(2)258 Connector(CN4461) CKS3968259 Connector(CN4801) CKS3991260 Connector(CN4201) CKS4054

261 Connector(CN4301) CKS4054262 Connector(CN4311) CKS4374263 Connector(CN5002) CKS4428264 Connector(CN4701) CKS4495265 Connector(CN4312) CKS4496

266 Connector(CN4451) CKS4595267 Connector(CN5001) CKS4595268 Connector(CN4421) CKS4675

269 Holder CND1677270 Insulator CNM7351

271 Cushion CNM8440

(1) EXTERIOR(3) SECTION PARTS LIST


(2) CONTRAST TABLEAVX-P6500DVD/UC , AVX-P6500DVD/EW , AVX-P6550DVD/RC and AVX-P6550DVD/RD are constructedthe same except for the following:

Part No.Mark No. Description P6500DVD/UC P6500DVD/EW P6550DVD/RC P6550DVD/RD

203 Cord Assy Not used CDE7192 Not used Not used204 Fuse(10A) Not used CEK1136 Not used Not used205 Cap Not used CNS1472 Not used Not used

206 Resistor Not used RS1/2PMF102J Not used Not used210 Remote Control Unit CXC1224 CXC1226 CXC1226 CXC1226

212 Cord Assy CDE7193 Not used CDE7193 CDE7193213 Fuse(10A) CEK1136 Not used CEK1136 CEK1136214 Cap CNS1472 Not used CNS1472 CNS1472215 Resistor RS1/2PMF102J Not used RS1/2PMF102J RS1/2PMF102J220 Case CNB2834 CNB2834 CNB2878 CNB2878

222 Tuner Unit CWM8774 CWM8773 CWM8774 CWM8774224 FM/AM Tuner Unit CWE1651 CWE1650 CWE1651 CWE1651238 Grille Unit CXC1095 CXC1094 CXC1101 CXC1101240 Button(ENT,WIDE,MENU) CAC7935 CAC7935 CAC7952 CAC7952257 Monitor Unit CWM8764 CWM8763 CWM8764 CWM8764


18/210

18

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

2.5 DVD MECHANISM MODULE


19/210

19

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

1 DVD Core Unit(MS3) CWX27092 Connector(CN1501) CKS42823 Cover CNC99434 Connector(CN1202) CKS46245 Connector(CN1611) CKS4052

6 Connector(CN1603) CKS43747 Connector(CN1101) CKS46258 Connector(CN1201) CKS40679 Screw BMZ20P020FTC

10 Screw(M2 x 3.5) CBA1571

11 Screw(M2 x 2.5) CBA162312 Washer CBF103813 Washer CBF106414 Spring CBH258615 Spring CBH2587

16 Spring CBH258817 Spring CBH258918 Spring CBH2590

19 Spring CBH259120 Spring CBH2592

21 Spring CBH259322 Spring CBH259423 Spring CBH259524 Spring CBH259625 Spring CBH2597

26 Spring CBH259827 Spring CBH259928 Spring CBH260029 Spring CBH260130 Spring CBH2602

31 Spring CBH260332 Spring CBH260433 Spring CBH260534 Spring CBH271135 Spring CBL1564

36 Pickup Unit(Service)(DP5) CXX163937 Shaft CLA388138 Shaft CLA420639 Shaft CLA420740 Lever CNC9933

41 Holder CNC993942 Holder CNC994043 Holder CNC994144 Frame CNC994445 Sheet CNM6883

46 Sheet CNM828347 Sheet CNM828748 Lever CNV715449 Lever CNV715550 Cam CNV7156

51 Rack CNV715752 Clamper CNV715853 Arm CNV715954 Arm CNV716055 Arm CNV7161

56 Arm CNV716257 Arm CNV716358 Arm CNV716459 Roller CNV716560 Arm CNV7166

61 Guide CNV716762 Gear CNV716963 Gear CNV717064 Gear CNV717165 Gear(Brack) CNV7172

66 Gear CNV717367 Gear CNV717468 Rack CNV717569 Gear CNV717670 Arm CNV7177

71 Lever CNV717872 Lever CNV717973 Screw IMS20P030FTC

74 Gear CNV718175 Holder CNV7183

76 Holder CNV718477 Guide CNV774578 Roller CNV734479 Damper CNV747080 Damper CNV7471

81 Coller CNV764582 Compound Unit (A) CWX275283 Gathering PCB CNX383584 Compound Unit (B) CWX275385 Washer YE20FTC

86 Chassis Unit CXB868087 Arm Unit CXB868188 Frame Unit CXB868389 Arm Unit CXB868490 Bracket Unit CXB8685

91 Motor Unit(LOADING)(M1) CXB868792 Motor Unit(CARRIAGE)(M2)CXB868893 Screw Unit CXB868994 Roller Unit CXB869095 Motor(SPINDLE)(M3) CXM1211

96 Screw JFZ20P018FTC97 Photo-transistor(Q1299) CPT231SCTD98 Switch(S1201,S1202,S1203) CSN105199 Spring Switch(S1204,S1205) CSN1052

100 Resistor(R1298,R1299) RS1/16S0R0J

101 Screw JFZ20P018FTC102 103 Arm CNV7742104 Arm CNV7743105 Spring CBH2710


- DVD MECHANISM MODULE SECTION PARTS LIST


20/210

20

DTR,RXPC,TXPC

CCR

CCG

CCB

CCSYNC

YS

CCREM

ANR

ANG

ANB

CSYNC

1

2

3

4

8

18

18

19

17

20

15

7

1

1

2

2

9

10 4

4,52

1

15

3

4

(1/2)MOTHER PCBA

NAVI 26PIN

RGB CABLE

108

107

105

106

137

21

15

13

17

16

20

19

18

SYSTEM

CONTROLLERIC601

PE5347A(EW)PE5348A(UC,RC,RD)

(2/2)

CN805

RXMON

TXMON

DREM

REMUTE

VBU

VDD5

CN151(2/2)CN803

(1/2)

CN201

ANGLEIN

LIFTPUL

MTRS

MTRPW

MTR2

MTR1

deg)sw

pushsw

SNSPW

ANGLEIN

LIFTPUL

MTRS

MTRPW

MTR2

MTR1

angl)sw

pushsw

SNSPW

VDD

VBU

Q106

Q105

Q104

18

25

1

2

3

19

20

5

21

30

31

32

27

20

19

18

17

16

15

13

12

11

10

1

2

3

M

KEYMATRIX

ILLUMINATION

GRILLE PCB

PANEL PCB

ILMG,ILMA(EW model)

IC5501RS-140

CN5902

CN5501

CN5901

KEY0-2

KEY0-2

REMCOM

RESETCN101RESET

(UC,EW model)

SWAC5R6

AVCC5V

B.U.

B.U.

L

X60118.874368MHz

BUZZER

73

74

68

132

VDD5

5

4VDD5SRVDD

SRVDD

VC33

VCC5

IC 602S-80841CNUA-B82

IC 801BA00BC0WFP

IC 803BP5451

IC 806BA00BC0WFP

IC 804S-818A33AUC-BGM

Q802

CN1702

C

D

EXTENSION PCB

CN202

CN1701

CN1603

CN8(2/

Q107

Q112

(UC,EW model)

ACC5

Q843

Q801

Q819

Q844

Q818

Q601

FU808

35p

VDD

Q126

dsens

710

710

16

9

2

9

6 12

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM

3.1 BLOCK DIAGRAM


21/210


22/210

22

MAIN ANT

CN1405

SL

DO

DI

CK

CE1

RDSHSLK

RDSLOCK

RDSDATA

RDSCK

ROMVDD

TUNL

CN1404

CN1502 CN1

19BGSENS

BCAM

AUXV

AUXL

REARV

REARL

CE2

LDET

CN1412

REVERSE GEAR SENSE

2

I

CN

NAVI 2RGB C

AV BUS

Q1404

RER VIEW CAMERA IN

L VIDEO IN

CN1402

V VIDEO IN

L REAR VIDEO OUT

CN1401

V REAR VIDEO OUT

19

2 2

12 12

5 5

9 9

22 22

26 26

FMRF

ANT adj

RF adj

FM ANT

T51

CF52CF51

VCC

VDD_

3.3

3.3V 2.5V

IC 4

3.3V 2.5V

IC 22.5V

CE2

RO

M_

VDD

SL

DI

CK

CE1

LDET

DO

RDS

_CK

RD

S_D

ATA

RD

S_L

OCK

RDS

_HSLK

6 13 5 10 9 8 11 14 18 19 20 21

1

3

IC 13.3V

AM ANT FMRFATT

LPFOSC

IC 3 EEPROM5.0V

IC 55V 3.3V

ATT MIXER, IF AMP DET, FM MPX,RDS DECODER

23Lch

FM/AM TUNER UNIT

TUNER UNITG

RELAY PB

CN1D

CNI

CN1D

CN1406

(EW model)

4

4 1,2

17

IC 1402BA00ASFP

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


23/210


24/210

24

26

24

DVD CORE UNIT (MS3)

Q1101

Q1102

Q1104

Q1103

Q1105

65LD

78LD

2

4

VSHF

CN1101

CN1201

CN1202

LPC01

LPC02

IC 1706TC7SH08FU

IC 1702M5M5V216ATP-70HI

IC 1705PD6447A

FEPIC 1101

AN8703FH

SODCIC 1301

MNZS26EDCUB

IC 1202AN8471SAT1

36XWR

CPUIC 1701

PE5395A(1/2)

62 63 90

X17005MHz

CLKOUT

94

17

1

2

3

11

86

111

97

79

96

CD/DVD

X2 X1

XWR

DMIXON

FSSW

XUWRDSCSNS

SRAM

FLASH MEMORY

IC 1201BA5985FM

23

PICKU

PUNIT(SERVICE)(DP5)

A,B1-4,C,RF+,RF-

M

SPINDLEMOTOR

M

CARRIGEMOTOR

M

LOADING

MOTOR

FOP,FOM,TOP,TOM

COP,COM

DRIVER

9

LOM

10

LOP

10

A0-17,D0-7

D

FD,TD,MD,CRGDRV,FG

FG

S1206

S1902

S1903

S1904

S1901

S1905

CLAMP SW

12cm

8cm

8cm

Disc sens

Disc sens

COMPOUND UNIT(B)F

COMPOUND UNIT(A)E

TBAL,FBAL,JLINE,TEY,ASF,FEY,ARF+,ARF-,OFTR,BOO,RFENV,TESTSG

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


25/210

25

36

34

4

6

3

8

11

21,22

8788 136

26

5

2

3

3 IC 1502TC74VCX74FT

IC 1504TC74VCX74FT

IC 1505TC7PA04FU

IC 1501M2V64S40DTP-6L

SDRAM

SICOMN,SOCOMN,SCKCOMN,etc

IC 1507SM8707FV

XWRH,XWR

SRCK

LRCK

CLK27

HCLK

1

512

3

14

7

1

10

3,5

5

8

4

7

6 2

2,36,7

1

3

CLOCK GEN.

Rch OUT

IECOUT

Lch OUT

IC 1605PCM1742KE

IC 1604NJM2100V

CN1501

CN1611

VCC33

AV CHIPIC 1503

MN677531KAUB

83

IECOUT

CPUIC 1701

PE5395A(2/2)

11

12VCC33

CN203A

CN971A

IC 1602NJM2100M

AMUTE,VCONTB,XRES,IRQPWR,HSTCMD,SLVSTS

1

CN1603

CN1701C

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


26/210

26

model

TUNER UNIT

RELAY PCB

G

B

MAIN UNITNSW UNITOVOLUME UNITP

EXTENSION

PCB

C

I

INVERTER PCBHLCD PANEL

TOUCH

PANEL

MS3 MECHANISM MD

MOTHER PCBA

E F

POWERSUPPLY

DIGITALOUTPUT

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.2 OVERALL CONNECTION DIAGRAM


27/210

27

FAN

MONITOR PCBI

ANISM MODULE GRILLE PCBL

PANEL

PCB

M

PCB

UPPER PCB

J

SENSE PCBK

FM/AM ANTENNA

CONNECTOR (NAVI)

AVBUS

IPBU

S

RCACORD

EXTENSIONCONNECTOR

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


28/210

28

A-a A-b

A-a A-b

A-b-a

Large sizeSCH diagram

Guide page

Detailed page

Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or"ELECTRICAL PARTS LIST".

A-a

A B C

NAVI26PINRGBCABLE

DCN1611

GCN1405

BCN1500

IP-BUSCORD

M

CN5901

I CN4461D

CN15

01

>

>

>>

>

>

>

>

>

>

>

SYSTEM CONTROLLER

MS3 VIDEO

RCA INPUT VIDEO

NAVI DVD VIDEO

AV-BUS

VIDEOVIDEO FILTER

AUDIOISOLATOR

IP-BUSDRIVER

AV SELECTOR

VIDEO ISOLATOR

OPTICAL OUTPUT BUFFER

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

VV

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

EW,UC,RC

RC,RD

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.3 MOTHER PCB(GUIDE PAGE)


29/210

29

A-b

A

CXM1262

FAN

CN202

CN201

N CN3801AV-BUS CABLE

>>

>

>

>

>

>

>

>>

>

>

270H

CCN1702

FRONTLCH

FRONTR CH

REARLCH

REARR CH

SUBWOOFERLCH

SUBWOOFERR CH

CEK???10A

>

Decimal points for resistor

and capacitor fixed values

are expressed as :

2.2 2R2

0.022 R022

The>mark found on some component parts indicatesthe importance of the safety factor of the part.

Therefore, when replacing, be sure to use parts of

identical designation.

Symbol indicates a resistor.

No differentiation is made between chip resistors and

discrete resistors.

NOTE :

Symbol indicates a capacitor.

No differentiation is made between chip capacitors and

discrete capacitors.

: The power supply is shown with the marked box.

A MOTHER PCB

MOTHER UNITConsists ofMOTHER PCBRELAY PCBEXTENSION PCB

POWER AMP

EVOL.

NAVIGUIDE

MIXING

VCC 3.3V REG.

VCC 5V, VCC 1.8V D/D CONVERTER

VD8VD/D CONVERTER

SRVDD REG.

HIGH OUT

AUDIO SIGNAL LINE

VIDEO SIGNAL LINEV

V

V

V

V

V

V V

V V

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


30/210

30

A-a

A-b

A-a

A-a

A-b 1 2

EW,UC,

RC

RC,RD

DCN1611

GCN1405

ICN4461

D CN1501

>

>>

>

>

>

>

>

>

MS3VIDEO

RCAINPUTVIDEO

NAVIDVDVIDEO

AV-BUS

VIDEO

VIDEOFILTER

AUDIO

ISOLATOR

AVSEL

ECTOR

VIDEOISOLATOR

OPTICALOUTPUTBUFFER

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

V

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


31/210

31

A-a

A-b

A-a

A-a

A-b3 4 5

NAVI 26PIN RGB CABLE

BCN1500

IP-BUS

CORD

M CN5901

>

>

SYSTEMCONTROLLER

IP-BUS

DRIVER

V V

V

V

V

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


32/210

32

A-a

A-b

A-b 1 2

CN202

CN201

N

CN3801

AV-BUSCABLE

>

>

>

>

CCN1702

FRONT

LCH

FRONT

RCH

REAR

LCH

REAR

RCH

SUBWOOFER

LCH

SUBWOOFER

RCH

The>mark

foun

donsome

componen

tparts

indica

tes

the

importanceo

fthesa

fety

fac

toro

fthepart.

There

fore,

whenrep

lac

ing,b

esure

tousepartso

f

iden

tica

ldes

igna

tion.

:Thepowersupplyis

shownwiththemarkedbox.

A

MOTHE

RPCB

MOTHERUNIT

Consistsof

MOTHERPCB

RELAYPCB

EXTENSIONPCB

POWERAMP

EVOL.

NAVI

GUIDE

MIXING

HIGHOUT

AUDIOSIGNALLINE

VIDEOSIGNALLINE

V

V

V

V

V

V

V

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


33/210

33

CXM1262

A-a

A-b

A-b3 4 5

FAN

>

>

>

>

>

>

>

>

270

H

CEK???

10A >

Dec

ima

lpo

intsforres

istor

an

dcapac

itor

fixe

dva

lues

areexpresse

das:

2.2

2R2

0.0

22

R022

Sym

bol

indica

tesares

istor.

No

diffe

ren

tia

tion

isma

de

be

tweenc

hipres

istorsan

d

discre

te

res

istors.

NOTE: S

ym

bol

indica

tesacapac

itor.

No

diffe

ren

tia

tion

isma

de

be

tweenc

hipcapac

itorsand

discre

te

capac

itors.

VCC3.3

VREG.

VCC

5V,

VCC1.8

VD/DCONVERTER

VD8V

D/DCONVERTER

SRVDDREG.

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


34/210

34

B

GCN1404

ACN153

B RELAY PCB

AUDIO SIGNAL LINE

VIDEO SIGNAL LINEV

V

V

V

V

V

V

MOTHER UNITConsists ofMOTHER PCBRELAY PCBEXTENSION PCB

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.4 RELAY PCB


35/210

35

C

ACN201

C EXTENSION PCB

DCN1603

MOTHER UNITConsists of

MOTHER PCBRELAY PCBEXTENSION PCB

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

3.5 EXTENSION PCB


36/210

36

D-a

D

1/2

1/2

PIC

UP

UNIT(SERVICE)(DP5)

E

F

M

M2CARRIAGE

MOTORCXB8688

M

M3SPINDLEMOTOR

CXM1211

M

M1LOADINGMOTORCXB8687

1

53

9

7

2

48

6

RF SIGNAL

FOCUS SERVO LINEF

TRACKING SERVO LINET

CARRIAGE SERVO LINEC

SPINDLE SERVO LINES

F

T

F

F

F

F

T

C

S

T

C

S

T

T

S

S

C

S

S

T

S

C

F

T

F

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.6 DVD CORE UNIT(MS3)(SODC)(GUIDE PAGE)


37/210

37

D-b

D

1/2

1/2

D 2/2

D 2/2

D 2/2

D 2/2

D 1/2 DVDCORTE UNIT(MS3) (SODC)

#

$

%

@

0

!

C

S

Servo

stream

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


38/210

38

A-a

D-b

(1/2)

D-a

(1/2)

D-b 1/2

D-a 1/2

1

PICUP UNIT(SERVICE)(DP5)

1

5

3

9

7

RFSIGNAL

FOCUSSERVOLINE

F

TRACKINGSERVOLINE

T

CARRIAGESERVOLINE

C

SPINDLESERVOLINE

S

F T

T F

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


39/210

39

A-a

D-b 1/2

D-a 1/2

D-b

(1/2)

D-a

(1/2)

2

EF

MM2

CARRIAGE

MOTOR

CXB8688

M M3

SPINDLE

MOTOR

CXM1211

MM

1

LOADING

MOTOR

CXB8687

2

4

8

6

F

F

F

FTCS

T

CS

T

T

S

S

C

S

S

T

SC

F

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


40/210

40

D-b 1/2

D-b

(1/2)

D-a

(1/2)

1

Servo D

2/2D

2/2

D

1/2

DVDCOREUNIT(MS3)(S

ODC)

C

S

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


41/210

41

D-b 1/2

D-b

(1/2)

D-a

(1/2)

2

stream

D

2/2

D

2/2

#

$ %

@ !

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


42/210

42

D-a

D 2/2

2/2

D 1/2

D 1/2

D 1/2

D 1/2

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.7 DVD CORE UNIT(MS3)(CPU)(GUIDE PAGE)


43/210

43

D-b

D

2/2

2/2

D 1/2

D 1/2

D 2/2 DVD CORE UNIT(MS3) (CPU)

CN203

&

*

(

)

Clock Generalator

stream

stream

System Computer

pin

pin

A

CN971

A

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


44/210

44

A-a

D-b

(2/2)

D-a

(2/2)

D-b 2/2

D-a 2/2

21

D

1/2

D

1/2

D

1/2

D

1/2

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


45/210

45

A-a

D-b 2/2

D-a 2/2

D-b

(2/2)

D-a

(2/2)

3 4

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


46/210

46

D-b 2/2

D-b

(2/2)

D-a

(2/2)

21

D

1/2

D

2/2

DVDCOREUNIT(MS3)(CPU)

CN203

&

*

( )

A

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


47/210

47

D-b 2/2

D-b

(2/2)

D-a

(2/2)

3 4

Cloc

kGeneralator

stream

stream

SystemC

omputer

pin

pin

D

1/2

D

1/2

CN971

A

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


48/210

48

1 FEY 500mV/div. 1ms/div.

Focus search

2 CH1: ASF

3 CH2: RFENV

Focus search

200ms/div. 1ms/div. 1 CH1: FEY 500mV/div. 1ms/div.

4 CH2: FD 1V/div. 1ms/div.

Focus close

2 CH1: ASF

3 CH1: RFENV

Focus close

5 CH1: TEY 500mV/div. 1ms/div.

Focus close(DVD)5 CH1: TEY 500mV/div. 1ms/div.

Focus close(CD)

1 CH1: FEY

4 CH2: FD

Play

500mV/div.20ms/div.5 CH1: TEY

6 CH2: TD

Play

500mV/div.20ms/div. 7 CH1: RFOUT 0.1V/div. 0.1s/div.

Play(DVD surroundings on inside)

7 CH1: RFOUT 0.1V/div. 0.2s/div.

Play(CD)

5 CH1: TEY

8 CH2: CRGDRV

Surroundings on inside->

surroundings on outside

500mV/div. 100ms/div.

-Waveforms Note:1. The encircled number denote measuring pointes in the circuit diagram.

2. Reference voltage VHALF : 1.65V

VHALF VHALF

VHALF

VHALF

VHALF

VHALF

VHALF

VHALF

200mV/div. 2ms/div.

VHALF

VHALF

VHALF

VHALF

VHALF

VHALF

VHALF

7 CH1: RFOUT200mV/div. 100s/div.

9 CH2: BDO 2V/div. 100s/div.

Black dot

VHALF

VHALF

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


49/210

49

4 CH1: FD 1V/div. 100s/div.

6 CH2: TD 500mV/div. 100s/div.

Black dot

5 CH1: TEY

1 CH2: FEY

EDC1 mode set up(DVD)

500mV/div.1s/div.

VHALF

VHALF

VHALF

VHALF

0 CH1: STD1

! CH2: STD4

@ CH3: STD7

# CH4: STENABLE

G

5V/div. 2s/div.

G

G

G

$ CH1: STCLK

% CH2: STVALID

# CH3: STENABLE

5V/div. 2s/div.

G

G

G

$ CH1: STCLK

% CH2: STVALID

# CH3: STENABLE

5V/div. 50s/div.

G

G

G

^ CH1: Not used

& CH2: SRCK

* CH3: LRCK

G

2V/div. 2s/div.

G

G

( CH1: LO

) CH2: RO

G

1V/div. 500s/div.

G

CH1: COMPO 200mV/div. 10s/div.

[White 100% output]

G

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


50/210

50

E F

F COMPOUND UNIT(B)

COMPOUND UNIT(A)E

S1901

Q1299

S1902

S1903

R1298

0R0

1

2

3

4

5

6

S1905

R1299

0R0

CPT231SCTD

CLAMP

12cm

8cm

DISC SENS DISC SENS

8cm

CN1202

D 1/2

D 1/2

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.8 COMPOUND UNIT(A) AND COMPOUND UNIT(B)


51/210

51

24Iop78

L2

LC

Vcc

GND

GND

IC1

L4C2C3

C6

C7

L3

1715

C1

16

65LD78LD

LDGND

R1C5 Short round

L1C4

78LD

65LD

65MD

65MDGVR2/ 65Rmd

VR1/ 78RmdVmda

1

2

3

4

6

5

7

R2

L6

MDA

Top View

up

MDA

A

SW

Vcc

C8

C9

12

GND13

V r14

MDC

9 8

78MD

78MDG

MDG

B1B1

B2

RF-

B3

RF+

B4

C

Vref : 2.5V

GND

C10TH1

TEMP

Vcc

SW

A

NC

T-

T+

F-

F+

B2

RF-

B3

RF+

B4

C

LDGND

23

26

25

07

08

05

06

22

21

20

19

18

17

27

02

01

03

04

09

16

15

14

13

12

11

10

Iop65

Im/ 2

Im

Im/ 2

IshfVshf : 4V

CN1101D 1/2

Short round

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

3.9 PU UNIT(REFERENCE)


52/210

52

G

MAIN

ANTENNA

BCN1502

ACN152

V

V

V

V

V

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.10 TUNER UNIT


53/210

53

G

>

>

G TUNER UNITAUDIO SIGNAL LINE

VIDEO SIGNAL LINEV

V

V

V

V

V V

FM

/AMTUNERUNIT

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


54/210

54

H

I CN4451

H INVERTER PCB

LCD MODULE

MONITOR UNITConsists ofMONITOR PCBUPPER PCBSENSE PCBINVERTER PCB

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.11 INVERTER PCB


55/210

55

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


56/210

56

I-a

I J K

ACN803

HCN5001

TO

UCHSCREEN

SUB DISPLAY

J UPPER PCB

K SENSE PCB

KCN4312

V

JCN4331

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.12 MONITOR PCB,UPPER PCB AND SENSE PCB(GUIDE PAGE)


57/210

57

I-b

I

Separation

MultiProcessing Video

Interface

Controller

>

LCDMODULE

EW

I MONITOR PCB

MONITOR UNITConsists ofMONITOR PCBUPPER PCBSENSE PCBINVERTER PCB

VIDEO SIGNAL LINEV

V

V

V

V

EW

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


58/210

58

A-a

I-b

I-a

I-a

I-b

H

CN5001

TOUCH SCREEN

SUBDISPLAY

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


59/210

59

A-a

I-b

I-a

I-a

I-b

KJ

ACN803

J

UPPERPCB

EW

EW

K

SEN

SEPCB

KCN4312

J

CN4331

V

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


60/210

60

I-a

I-b

I-b

>

IMONITORPCB

V V

V

V

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


61/210

61

I-a

I-b

I-b

Separation

Multi

Processing

Video

Interface

Controller

LCD MODULE

EW

EW

MON

ITORUNIT

Consistsof

MON

ITORPCB

UPPERPCB

SENSEPCB

INVE

TERPCB

VIDEOSIG

NALLINE

V

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


62/210

62

L

UC/RC/RD

EW

EW

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.13 GRILLE PCB


63/210

63

L

L

M

CN5902

GRILLE PCB

KEYBOARD UNITConsists ofGrille PCBPanel PCB

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


64/210

64

M

M PANEL PCB

A CN101

L CN5501

RESET

KEYBOARD UNITConsists ofGrille PCBPanel PCB

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.14 PANEL PCB


65/210

65

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


66/210

66

(Highspeed:L,

Lowspeed:H)

Shortround

(Open)

Photopulseoutpu

t

Photopulsedriver

5Vregulato

rforsense

Anglesensevolumepowersupplyswitch

Positionmotor

Anglemotor

Regulatoroutput

Voltageadj.input

Regulatorfordriver

Positionmotor

Positionmotor:H

Anglemotor

Anglemotor:H

Motordriver

Angleoperation

Horizonoperation

Note:Itcomesoutlowerabout1.5vthanVcc.

N

MAINUNIT

Positionmotor

Anglemotor

LIFT SW ANGLE SWCXB9515

CXB9516

P VOLUMEUNITO SW UNIT

Angle sense

CN805A

(De

g.0:L)

(EJ

ECT:L)

(Deg.0:L)

(EJECT:L)

3 6251 8

7

4

M3001

M3002

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

3.15 MAIN UNIT,SW UNIT AND VOLUME UNIT

N O P


67/210

67

-Waveforms The encircled number denote measuring pointes in the circuit diagram.

CLOSE -> OPEN

OPEN -> CLOSE

5 CH1:MTR16 CH3:ANGLSW

0->MAX

2 CH2:MTRSEL7 CH4:ANGLIN

MAX -> Deg.0 DOWN

1 CH1:MTR23 CH3:LIFTSW

2 CH2:MTRSEL4 CH4:LFTPLS


2 CH2:MTRSEL4 CH4:LFTPLS

5 CH1:MTR16 CH3:ANGLSW

2 CH2:MTRSEL7 CH4:ANGLIN

Set back open -> Set


8 CH2:MTRS4 CH4:LFTPLS

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


68/210

68

CapacitorConnector

P.C.Board Chip Part

A

A MOTHER PCB

SIDE B

SIDE A

NOTE FOR PCB DIAGRAMS

1.The parts mounted on this PCB

include all necessary parts for

several destination.

For further information for

respective destinations, be sure

to check with the schematic dia-gram.

2.Viewpoint of PCB diagrams

FR

B CN1500

NCN3801

G CN1405

D CN1611

C CN1702

I CN4461

NRG

D CN1501

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4. PCB CONNECTION DIAGRAM

4.1 MOTHER PCB


69/210

69

A

SIDE A

IC,Q,ADJ

CORD ASSY

FRONT

RCA0

801

AV BUS CABLE

IP-BUS CORD

NAVI 26 pinRGB CABLE

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


70/210

70

A

A MOTHER PCBIC,Q

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


71/210

71

A

SIDE B

M CN5901

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


72/210

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.2 RELAY PCB AND EXTENSION PCB

72

B

B RELAY PCBSIDE A SIDE B

BRELAY PCB

C EXTENSION PCB C EXTENSION PCB SIDE BSIDE A

C

G CN1404 A CN153

D CN1603 A CN201


73/210

73

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


74/210

74

D

D DVD CORE UNIT(MS3)IC,Q ADJ

PICKU

(SERVI

ACN971

M2

M1

M3

F

RFOUT

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.3 DVD CORE UNIT(MS3)


75/210

75

D

PICKUP UNIT

(SERVICE)(DP5)

C CN1701

A CN203

3

COMPOGNDV

GND1

SIDE A

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


76/210

76

D

D DVD CORE UNIT(MS3)

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


77/210

77

D

SIDE BIC,Q

E

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


78/210

78

COMPOUND UNIT(B)

E F

FCOMPOUND UNIT(A)E

D

D

CLAMP

12cm

8cm

DISC SENS

DISC SENS

8cm

S1901

S1902

S1903

S1904

S1905

R1299

R1298

Q1299

CN1202

16

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.4 COMPOUND UNIT(A) AND COMPOUND UNIT(B)


79/210

79

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


80/210

80

G

G TUNER UNIT SIDE A

IC,Q

A CN152

BCN1502

MAIN ANTENNA

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.5 TUNER UNIT


81/210

81

G

G TUNER UNIT SIDE B

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


82/210

82

H

H INVERTER PCB H INVERTER PCBSIDE A SIDE B

ICN4451

LCD MODULE

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.6 INVERTER PCB


83/210

83

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


84/210

84

I

I MONITOR PCB

H CN5001

LCD MODULE

TOUCH PANEL

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.7 MONITOR PCB


85/210

85

I

SIDE A

JCN4301

SUB DISPLAY

A CN803

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


86/210

86

I

I MONITOR PCB

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


87/210

87

I

SIDE B

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


88/210

88

J

J UPPER PCB J UPPER PCBSIDE A SIDE B

KCN4312

ICN4201

OPEN/CLOSE

HA

LF/CLK

TA/NEWS

DISP

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.8 UPPER PCB


89/210

89

K

K SENSE PCB K SENSE PCBSIDE A SIDE B

J CN4311

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

4.9 SENSE PCB


90/210

90

L

L GRILLE PCB SIDE A SIDE BL GRILLE PCB

M CN5902

SOURCE

REAR

BACK

ATT

A

NGLE-

ANGLE+

BAN

D

EQ

EJECT

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.10 GRILLE PCB


91/210

91

M

M PANEL PCB SIDE A SIDE BM PANEL PCB

L CN5501

A CN101

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

4.11 PANEL PCB


92/210

92

N MAIN UNIT SIDE A

PCN3841

CN3842

CN3843

ACN805

OCN3831

CN3832CN3833

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.12 MAIN UNIT

N


93/210

93

N MAIN UNITSIDE B

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

N


94/210

94

VOLUME UNIT

P

SW UNITO

PO

ANGLE SW

LIFT SW

ANGLE SENSE

N CN3807

N CN3809

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

4.13 SW UNIT AND VOLUME UNIT


95/210

95

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

5. ELECTRICAL PARTS LIST

NOTE:

- Parts whose parts numbers are omitted are subject to being not supplied.

- The part numbers shown below indicate chip components.

Chip Resistor

RS1/_S___J,RS1/__S___J

Chip Capacitor (except for CQS.....)

CKS....., CCS....., CSZS.....

Q 108 Transistor 2SC4081Q 109 Transistor DTC144EUQ 110 Transistor 2SA1577Q 111 Transistor UMH1NQ 112 Transistor 2SC4081

Q 113 Transistor DTC124EUQ 115 Transistor 2SA1577Q 116 Transistor DTC144EUQ 117 Transistor 2SA1577

Q 118 Transistor DTC124EU

Q 119 Transistor 2SA1576Q 120 Transistor DTC124EUQ 126 Transistor 2SC2412KQ 151 Transistor 2SC4081Q 152 Transistor 2SA1576

Q 153 Transistor DTC124EUQ 201 Transistor DTC323TUQ 203 Transistor DTC323TUQ 205 Transistor 2SA1576Q 206 Transistor DTC124EU

Q 207 Transistor IMD2AQ 301 Transistor 2SC2412KQ 302 Transistor DTC323TUQ 303 Transistor DTC323TUQ 304 Transistor DTC323TU

Q 305 Transistor IMD2AQ 306 Transistor 2SA1576Q 307 Transistor DTC124EUQ 308 Transistor 2SA1576Q 309 Transistor DTC124EU

Q 310 Transistor 2SC4081Q 311 Transistor DTC323TUQ 312 Transistor DTC323TUQ 313 Transistor DTC323TUQ 314 Transistor DTC323TU

Q 315 Transistor DTC323TUQ 316 Transistor DTC323TUQ 317 Transistor DTC144EUQ 318 Transistor IMD2AQ 319 Transistor IMD2A

Q 501 Transistor 2SC4081Q 502 Transistor 2SC4081Q 503 Transistor 2SC4081Q 504 Transistor 2SC4081Q 505 Transistor 2SC4081

Q 601 Transistor DTC124EUQ 602 Transistor 2SC4081Q 701 Transistor 2SA1576Q 702 Transistor IMX1Q 703 Transistor DTC114EU

Q 704 Transistor 2SA1576Q 801 Transistor 2SD1767Q 802 Transistor IMD2AQ 803 Transistor 2SA1797Q 804 Transistor DTC124EU

Unit Number : CWM8760(UC model)Unit Name : Mother Unit

MISCELLANEOUS

IC 151 IC TA2050FIC 152 IC TA2050FIC 153 IC TA2050FIC 154 IC HA12187FPIC 155 IC TC4S81F

IC 201 IC TC74VHCT08AFTIC 202 IC SM5304AVIC 203 IC TC74VHC08FTIC 301 IC NJM4558VIC 302 IC NJM4558V

IC 303 IC NJM4558VIC 304 IC NJM2068VIC 305 IC PML009AIC 306 IC NJM4558VIC 307 IC NJM4558V

IC 308 IC PAL007AIC 309 IC PA2028AIC 501 IC NJM2137VIC 502 IC NJM2137VIC 503 IC NJM2137V

IC 504 IC NJM2137VIC 505 IC NJM2137VIC 506 IC CXA2089QIC 507 IC BA7623FIC 601 IC PE5348A

IC 602 IC S-80841CNUA-B82

IC 801 IC BA00BC0WFPIC 803 IC BP5451IC 804 IC S-818A33AUC-BGNIC 805 IC AN8011S

IC 806 IC BA00BC0WFPIC 807 IC S-812C50AUA-C3EIC 971 IC TC7WT125FUQ 101 Transistor DTC124EUQ 102 Transistor 2SA1576

Q 103 Transistor IMD2AQ 104 Transistor DTC114EUQ 105 Transistor DTA114EUQ 106 Transistor DTC144EUQ 107 Transistor 2SC4081

=====Circuit Symbol and No.===Part Name Part No.--- ------ ------------------------------------------ -------------------------


A CB

Mother Unit

Consists ofMother PCBRelay PCBExtension PCB


96/210

96

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

Q 805 Transistor DTC124EUQ 806 Transistor 2SD1767Q 807 Transistor DTC124EUQ 808 Transistor IMD2AQ 811 Transistor 2SA1797

Q 815 Transistor 2SD1767

Q 816 Transistor 2SA1577Q 817 Transistor DTC124EUQ 818 Transistor DTC124EUQ 819 Transistor 2SA1797

Q 820 Transistor 2SA1797Q 821 Transistor DTC114EUQ 822 Transistor 2SJ529SQ 824 Transistor 2SC4081Q 826 Transistor 2SJ529S

Q 827 Transistor 2SJ529SQ 828 Transistor 2SA1797Q 829 Transistor DTC124EUQ 830 Transistor DTC124EUQ 832 Transistor 2SA1576

Q 833 Transistor 2SD1767Q 834 Transistor 2SA1576

Q 835 Transistor DTC124EUQ 838 Transistor DTC124EUQ 839 Transistor 2SA1576

Q 840 Transistor DTC124EUQ 841 Transistor 2SB1184F5Q 842 Transistor 2SD1767Q 843 Transistor DTC114EUQ 844 Transistor 2SA1615-Z

Q 851 Transistor 2SD2375Q 852 Transistor IMD2AQ 854 Transistor 2SA1577Q 855 Transistor DTC124EUQ 903 Transistor 2SA1797

Q 904 Transistor DTC124EUD 101 Diode UDZS5R6(B)D 102 Diode Network DA204U

D 103 Diode Network DA204UD 104 Diode Network DA204U

D 105 Diode Network DA204UD 106 Diode Network DA204UD 107 Diode Network DA204UD 108 Diode 1SS355D 109 Diode 1SS355

D 110 Diode Network DA204UD 151 Diode HZU2R7(B1)D 152 Diode HZU2R7(B1)D 153 Diode HZU2R7(B1)D 154 Diode HZU2R7(B1)

D 155 Diode HZU2R7(B1)D 156 Diode HZU2R7(B1)D 157 Diode UDZS5R6(B)D 158 Diode UDZS5R6(B)

D 159 Diode UDZS5R6(B)

D 160 Diode UDZS5R6(B)D 161 Diode HZU2R7(B1)D 162 Diode HZU2R7(B1)D 163 Diode HZU2R7(B1)D 164 Diode HZU2R7(B1)

D 165 Diode UDZS5R6(B)D 166 Diode Network DA204UD 167 Diode Network DA204UD 302 Diode MA111D 303 Diode DAN202U

D 304 Diode DAN202UD 305 Diode DAN202UD 306 Diode UDZS8R2(B)D 307 Diode DAN202UD 500 Diode UDZ12(B)

D 601 Diode MA111

D 602 Diode DAN202UD 701 Diode DAN202UD 702 Diode HZU6R8(B3)D 703 Diode S1G-6904G2P

D 704 Diode S1G-6904G2PD 705 Diode S1G-6904G2PD 706 Diode UDZS7R5(B)D 707 Diode DAN202UD 708 Diode S1G-6904G2P

D 709 Diode S1G-6904G2PD 801 Diode UDZS5R6(B)D 802 Diode HZU8R2(B1)D 803 Diode HZU5R6(B2)D 805 Diode UDZS5R6(B)

D 806 Diode S2G-6600D 807 Diode S1G-6904G2P

D 808 Diode RB063L-30D 809 Diode MA111D 812 Diode RB063L-30

D 813 Diode SC802-06D 814 Diode RB063L-30D 815 Diode S2G-6600D 816 Diode RB063L-30D 817 Diode HZU9R1(B1)

D 819 Diode DAN202UD 820 Diode UDZS20(B)D 851 Diode HZU10(B1)D 852 Diode DAN202UD 853 Diode S2G-6600

L 101 Inductor CTF1399L 151 Inductor LCTC2R2K1608L 201 Coil CTH1295

L 202 Inductor CTF1399L 203 Inductor CTF1305

L 204 Inductor CTF1305L 205 Inductor CTF1399L 206 Inductor CTF1399L 207 Inductor CTF1379L 301 Inductor CTF1399

L 302 Inductor CTF1399L 303 Inductor CTF1399L 304 Inductor LCTA2R2J2520L 305 Inductor CTF1399L 307 Inductor CTF1379

L 308 Inductor CTF1379L 310 Inductor CTF1399L 311 Inductor CTF1399L 312 Inductor LCTA101J2520

L 501 Inductor CTF1399

L 502 Inductor CTF1399L 503 Inductor CTF1399L 504 Inductor CTF1399L 505 Inductor CTF1399L 506 Inductor LCTA100J2520

L 507 Inductor CTF1383L 508 Inductor CTF1383L 509 Inductor LCTA150J2520L 601 Inductor LCTA2R2J2520L 602 Inductor CTF1306




97/210

97

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

L 603 Inductor CTF1306L 604 Inductor CTF1306L 701 Inductor LCTC2R2K1608L 702 Inductor LCTC2R2K1608L 801 Coil CTH1295

L 803 Coil CTH1295

L 804 Inductor CTF1379L 805 Coil CTH1295L 806 Coil CTH1295L 807 Coil CTH1267

L 812 Coil CTH1295L 813 Choke Coil 270H CTH1263L 901 Inductor CTF1395L 902 Inductor CTF1379L 971 Inductor CTF1379

X 601 Resonator 18.874MHz CSS1622VR 501 Semi-fixed 3.3k(B) CCP1393VR 801 Semi-fixed 10k(B) CCP1396FU 151 Fuse 1A CEK1280FU 154 Fuse 5A CEK1289

FU 155 Fuse 5A CEK1289FU 156 Fuse 5A CEK1289

FU 157 Fuse 5A CEK1289FU 158 Fuse 5A CEK1289FU 201 Fuse 1A CEK1280

FU 202 Fuse 1A CEK1280FU 203 Fuse 1A CEK1280FU 204 Fuse 1A CEK1280FU 205 Fuse 1A CEK1280FU 206 Fuse 1A CEK1280

FU 207 Fuse 1A CEK1280FU 301 Fuse 5A CEK1289FU 302 Fuse 4A CEK1288FU 701 Fuse 5A CEK1289FU 801 Fuse 250mA CEK1276

FU 802 Fuse 3A CEK1286FU 803 Fuse 1.25A CEK1281FU 804 Fuse 1.75A CEK1283FU 805 Fuse 1.75A CEK1283FU 806 Fuse 3A CEK1286

FU 807 Fuse 2.3A ICPS2R3FU 808 Fuse 1A CEK1280FU 901 Fuse 1A CEK1280EF 801 EMI Filter CCG1142BZ 101 Buzzer CPV1063

RESISTORS

R 101 RS1/16S332JR 102 RS1/16S332JR 103 RS1/16S223JR 104 RAB4C222JR 105 RS1/16S102J

R 106 RS1/16S102JR 107 RS1/16S222JR 109 RS1/16S104JR 110 RS1/16S103JR 111 RS1/16S102J



R 124 RS1/16S103JR 125 RS1/16S223J

R 126 RS1/16S472JR 127 RS1/16S223JR 128 RS1/16S472J


R 136 RS1/16S0R0JR 138 RS1/16S102J



R 153 RS1/16S181JR 154 RS1/16S223JR 155 RS1/16S681JR 156 RS1/16S681J

R 157 RS1/16S150J












98/210

98

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

R 199 RS1/16S102JR 201 RAB4C102JR 202 RAB4C102JR 203 RS1/16S473JR 204 RS1/16S0R0J

R 207 RS1/16S750J

R 209 RS1/16S0R0JR 212 RS1/16S332JR 213 RS1/16S332JR 214 RS1/16S512J

R 216 RS1/16S0R0JR 217 RS1/16S101JR 219 RS1/16S681JR 220 RS1/16S0R0JR 301 RS1/16S101J

R 302 RS1/16S222JR 304 RS1/16S392JR 305 RS1/16S472JR 306 RS1/16S0R0JR 307 RS1/16S473J

R 308 RS1/16S103JR 309 RS1/16S473J





R 327 RS1/16S473JR 328 RS1/16S223J




R 344 RS1/16S104J



R 355 RS1/16S103JR 356 RS1/16S0R0JR 359 RS1/16S0R0JR 360 RS1/16S0R0JR 361 RS1/16S0R0J

R 362 RS1/16S0R0J




R 377 RS1/16S473JR 378 RS1/16S103J





R 395 RS1/16S0R0JR 396 RS1/16S0R0J

R 397 RS1/16S0R0JR 503 RS1/16S472JR 504 RS1/16S750JR 506 RS1/16S472JR 507 RS1/16S472J



R 520 RS1/16S472J






99/210

99

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC


R 536 RS1/16S472J



R 546 RS1/16S472JR 547 RS1/16S101JR 548 RS1/16S102JR 549 RS1/16S0R0JR 550 RS1/16S0R0J

R 551 RS1/16S392JR 552 RS1/16S472J

R 553 RS1/16S0R0JR 554 RS1/16S562JR 555 RS1/16S562J

R 556 RS1/16S562JR 557 RS1/16S562JR 558 RS1/16S0R0JR 559 RS1/16S0R0JR 561 RS1/16S0R0J



R 602 RS1/16S102JR 603 RS1/16S473J

R 604 RS1/16S0R0JR 605 RS1/16S0R0JR 606 RS1/16S473JR 607 RS1/16S473JR 608 RS1/16S473J


R 615 RAB4C102JR 616 RAB4C102JR 617 RAB4C102JR 621 RAB4C102J

R 622 RS1/16S473J




R 645 RS1/16S102J


R 650 RS1/16S473JR 651 RS1/16S103JR 652 RS1/16S473JR 653 RAB4C102JR 654 RS1/16S473J

R 655 RAB4C681JR 656 RS1/16S102JR 657 RS1/16S102JR 658 RS1/16S681JR 659 RS1/16S681J

R 660 RS1/16S472JR 661 RS1/16S472J

R 662 RS1/16S473JR 663 RS1/16S0R0JR 664 RS1/16S473J




R 708 RS1/16S473JR 709 RS1/16S103J




R 812 RS1/16S391J

R 813 RS1/16S391JR 821 RS1/16S391JR 822 RS1/16S472JR 823 RS1/16S222JR 824 RS1/16S1203D

R 825 RS1/16S1502DR 826 RS1/16S6802DR 827 RS1/16S2201DR 828 RS1/16S470JR 829 RS1/16S470J


=====Circuit Symbol and No.===Part Name Part No.--- ------ ------------------------------------------ ------------------------


100/210

100

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC


R 835 RS1/16S473J

R 836 RS1/16S6200DR 837 RS1/16S3602DR 838 RS1/16S3901DR 839 RS1/16S100J

R 840 RS1/16S0R0JR 847 RS1/16S2203DR 848 RS1/16S102JR 850 RS1/16S103JR 851 RS1/16S221J

R 852 RS1/16S272JR 853 RS1/16S0R0JR 855 RS1/16S6801DR 856 RS1/16S1502DR 857 RS1/16S272J

R 858 RS1/16S473JR 860 RS1/16S6801D

R 861 RS1/16S102JR 864 RS1/16S5602DR 865 RS1/16S1002D

R 868 RS1/16S102JR 870 RS1/16S102JR 871 RS1/16S1503DR 872 RS1/16S0R0JR 873 RS1/16S8202D

R 874 RS1/16S3301DR 875 RS1/16S473JR 876 RS1/16S0R0JR 877 RS1/16S472JR 878 RS1/16S103J


R 883 RS1/16S103JR 884 RS1/16S103J



R 895 RS1/16S472JR 896 RS1/16S392JR 897 RS1/10S0R0JR 898 RS1/10S0R0J

R 900 RS1/16S102J


R 971 RS1/16S221JR 972 RS1/16S621JR 973 RS1/16S473JR 974 RS1/16S361JR 975 RS1/16S0R0J

CAPACITORS

C 101 CKSRYB103K50C 102 CKSRYB104K16C 103 CKSRYB104K16C 104 CKSRYB103K50

C 105 CKSRYB104K16

C 106 CKSRYB104K16C 151 CKSRYB104K16C 152 CKSRYB471K50C 153 CKSRYB104K16C 154 CKSRYB104K16

C 155 CKSRYB104K16C 156 CKSRYB104K16C 157 CKSRYB105K6R3C 158 CKSRYB105K6R3C 159 CKSRYB105K6R3

C 160 CKSRYB105K6R3C 161 CKSRYB105K6R3C 162 CKSRYB105K6R3C 163 CKSRYB105K6R3C 164 CKSRYB105K6R3

C 165 CKSYB475K10C 166 CKSRYB104K16C 167 10F/16V CCH1442C 168 10F/16V CCH1442C 169 CKSRYB104K16

C 170 10F/16V CCH1442C 171 10F/16V CCH1442C 172 10F/16V CCH1442C 173 CKSRYB104K16C 174 CKSRYB104K16

C 175 10F/16V CCH1442C 201 CEV221M4C 202 CEV221M4C 203 CKSYB106K6R3C 205 CKSRYB102K50

C 206 CKSRYB102K50C 207 CKSYB475K10C 209 CEV220M6R3C 210 CEV101M16C 220 CKSRYB103K50

C 221 CKSRYB103K50C 301 10F/16V CCH1442C 302 CKSYB106K6R3C 303 CKSQYB105K16C 304 CKSQYB105K16

C 305 10F/16V CCH1442C 306 10F/16V CCH1442C 307 CCSRCH220J50C 308 CKSYB475K10C 309 CKSRYB102K50

C 310 CCSRCH220J50

C 311 4.7F/35V CCH1483C 312 4.7F/35V CCH1483C 313 CKSRYB104K16C 314 CKSRYB104K16

C 315 CKSRYB104K16C 316 CCSRCH101J50C 317 10F/16V CCH1442C 318 CKSRYB104K16C 319 CKSRYB104K16

C 320 CKSRYB224K10C 321 CKSRYB105K6R3C 322 CKSRYB105K6R3C 323 CKSRYB102K50C 324 CKSRYB105K6R3




101/210

101

5 6 7 8

5 6 7 8

AVH-P6500DVD/UC

C 325 CKSRYB105K6R3C 326 47F/16V CCH1413C 327 CKSRYB224K10C 328 CKSRYB104K16C 329 CKSRYB105K6R3

C 330 CKSRYB105K6R3

C 331 CKSRYB105K6R3C 332 CKSRYB105K6R3C 333 47F/16V CCH1413C 334 CKSYB475K10

C 335 CKSYB475K10C 336 CKSYB475K10C 337 CKSYB475K10C 338 CKSYB475K10C 339 CKSYB475K10

C 340 CKSYB475K10C 341 CKSYB475K10C 345 CCSRCH100D50C 346 CCSRCH100D50C 347 10F/16V CCH1442

C 348 CKSRYB104K16C 349 CKSRYB104K16

C 350 CCSRCH100D50C 351 CCSRCH100D50C 352 CCSRCH100D50

C 353 CCSRCH100D50C 354 10F/16V CCH1442C 355 CKSYB475K10C 356 CEVL101M10C 357 4.7F/35V CCH1483

C 358 CKSQYB225K10C 359 CKSQYB225K10C 360 CKSQYB225K10C 361 CKSQYB225K10C 362 CKSQYB225K10

C 363 CKSQYB225K10C 364 CKSRYB105K10C 365 CKSRYB105K10


C 368 CKSRYB105K10C 369 CKSRYB105K10C 370 CKSRYB105K10C 371 CKSRYB105K10C 372 10F/16V CCH1442

C 373 CKSRYB105K10C 374 33F/25V CCH1444C 375 CKSYB684K16C 376 10F/16V CCH1442C 377 10F/16V CCH1442

C 378 10F/16V CCH1442C 379 33F/25V CCH1444C 380 33F/25V CCH1444C 381 CKSRYB105K6R3

C 382 3300F/16V CCH1486

C 383 10F/16V CCH1442C 384 10F/16V CCH1442C 385 10F/16V CCH1442C 386 CKSRYB222K50C 387 CKSRYB222K50

C 388 CKSRYB222K50C 389 CKSRYB222K50C 390 CKSRYB222K50C 391 CKSRYB222K50C 392 CKSRYB104K16

C 393 10F/16V CCH1442C 394 CKSYB475K10C 395 CKSYB475K10C 396 CKSRYB473K50C 397 CKSRYB104K16

C 398 CKSRYB104K16

C 399 CKSRYB104K16C 404 10F/16V CCG1138C 501 CKSYB106K6R3C 502 CKSYB106K6R3

C 503 CKSYB106K6R3C 504 CKSYB106K6R3C 505 CKSYB106K6R3C 506 CKSYB106K6R3C 507 CKSYB106K6R3

C 508 CKSYB106K6R3C 509 CKSYB106K6R3C 511 CCSRCH6R0D50C 512 CKSRYB105K6R3C 514 CCSRCH6R0D50

C 515 CKSRYB105K6R3C 517 CKSRYB105K6R3

C 518 CCSRCH6R0D50C 519 CKSRYB102K50C 520 CKSYB106K6R3

C 521 CKSRYB104K16C 522 CKSYB106K6R3C 523 CKSRYB102K50C 524 CKSYB106K6R3C 525 CKSRYB104K16

C 526 CCSRCH6R0D50C 527 CKSRYB102K50C 528 CKSYB106K6R3C 529 CKSRYB104K16C 530 CKSRYB105K6R3

C 531 CKSRYB105K6R3C 533 CCSRCH6R0D50C 534 CKSRYB105K6R3


C 537 CKSRYB105K6R3C 539 CKSRYB105K6R3C 540 CKSRYB102K50C 541 CKSYB106K6R3C 542 CKSRYB104K16

C 543 CKSRYB105K6R3C 544 CKSRYB105K6R3C 545 CKSRYB105K6R3C 546 CKSRYB105K6R3C 547 CKSRYB105K6R3

C 548 10F/16V CCH1442C 549 CKSRYB104K16C 550 CKSRYB105K6R3C 551 CEV221M4

C 552 CEV221M4

C 553 CEV221M4C 554 CEV221M4C 555 CEV101M16C 556 CKSYB106K6R3C 557 CKSYB106K6R3

C 558 10F/16V CCH1442C 559 CKSYB106K6R3C 560 CKSRYB223K50C 601 CKSRYB105K6R3C 602 CEV2R2M50




102/210

102

1 2 3 4

1 2 3 4

AVH-P6500DVD/UC

C 603 CCSRCH101J50C 604 CKSRYB105K6R3C 605 CKSRYB105K6R3C 606 CCSRCH7R0D50C 607 CCSRCH7R0D50

C 608 CCSRCH100D50

C 609 CCSRCH100D50C 672 CKSRYB104K16C 701 CKSRYB103K50C 702 CKSRYB104K16

C 703 CKSRYB105K10C 704 CKSRYB104K16C 705 CKSQYB104K25C 706 CKSRYB104K16C 707 CKSRYB104K16

C 801 CKSRYB104K16C 802 47F/16V CCH1413C 803 CKSRYB103K50C 806 47F/16V CCH1413C 810 CKSRYB104K16

C 811 47F/16V CCH1413C 812 CKSRYB103K50

C 813 CKSRYB474K10C 814 470F/6.3V CCH1437C 815 0.22F/3.5V CCL1058

C 816 CKSRYB102K50C 817 CKSRYB105K6R3C 818 220F/10V CCH1409C 819 CKSRYB102K50C 820 CKSYB475K10

C 824 CEHAZL471M16C 826 CKSYB225K16C 827 CKSYB225K16C 828 CEV1R0M50C 829 CKSRYB102K50

C 830 CKSYB475K10C 831 CKSRYB103K50C 832 CCSRCH121J50

C 835 CKSYB475K16C 836 2200F/16V CCH1405

C 838 470F/6.3V CCH1437C 839 47F/16V CCH1413C 840 CKSRYB474K10C 841 CKSRYB104K16C 842 CKSRYB104K16

C 843 CKSYB475K16C 844 CEHAZL471M16C 846 10F/16V CCH1442C 847 CKSRYB103K50C 848 CKSRYB103K50

C 849 CEV101M16C 850 0.1F/5.5V CCL1059C 851 CKSRYB103K50C 852 CKSRYB103K50

C 853 CEV101M16

C 854 CKSRYB104K16C 855 CKSRYB104K16C 856 10F/16V CCH1442C 857 CKSRYB102K50C 858 CEV101M16

C 870 CKSYB225K16C 874 CKSRYB104K16C 878 100F/16V CCH1228C 882 1000F/16V CCH1428C 883 100F/16V CCH1228

C 971 CCSRCH150J50C 972 CKSRYB104K16C 973 CKSYB106K6R3

Unit Number : CWM8759(EW model)Unit Name : Mother Unit

MISCELLANEOUS

IC 151 IC TA2050FIC 152 IC TA2050FIC 153 IC TA2050FIC 154 IC HA12187FPIC 155 IC TC4S81F

IC 201 IC TC74VHCT08AFTIC 202 IC SM5304AVIC 203 IC TC74VHC08FTIC 301 IC NJM4558VIC 302 IC NJM4558V

IC 303 IC NJM4558VIC 304 IC NJM2068VIC 305 IC PML009AIC 306 IC NJM4558VIC 307 IC NJM4558V

IC 308 IC PAL007AIC 309 IC PA2028AIC 501 IC NJM2137VIC 502 IC NJM2137VIC 503 IC NJM2137V

IC 504 IC NJM2137VIC 505 IC NJM2137VIC 506 IC CXA2089QIC 507 IC BA7623FIC 601 IC PE5347A

IC 602 IC S-80841CNUA-B82IC 801 IC BA00BC0WFPIC 803 IC BP5451IC 804 IC S-818A33AUC-BGNIC 805 IC AN8011S

IC 806 IC BA00BC0WFPIC 807 IC S-812C50AUA-C3EIC 971 IC TC7WT

pioneer avh p6500dvd,avh p6550dvd

Documents