okipage 4w (parts, circuit diagram) troubleshooting manual
TRANSCRIPT
All specifications are subject to change without notice.
OKIPAGE4wLED Page PrinterTroubleshooting Manualwith Component Parts List
(ODA/OEL/INT)
¡
1997.12.10 Rev. 2
CONTENTS
1. OUTLINE..................................................................................................... 1
2. TOOLS ........................................................................................................ 1
3. CIRCUIT DESCRIPTION ............................................................................ 2
4. TROUBLESHOOTING .............................................................................. 21
5. CIRCUIT DIAGRAM.................................................................................. 27
6. COMPONENT PARTS LIST
- 1 -
1. OUTLINE
This manual has been written to provide guidance for troubleshooting of the OKIPAGE4w Printer(primarily for its printed circuit boards), on an assumption that the reader is knowledgeable of theprinter. Read the maintenance manual for this printer P/N M-521426 if necessary.Note:1. High voltage power supply board and power supply unit containing a high voltage power
supply is dangerous. From the viewpoint of the safety standards, the local repairing of adefective board is not allowed. Thus, the objects to be locally repaired as a result oftroubleshooting are switches and fuses.
2. TOOLS
For troubleshooting the printer, the tools listed below may be needed in addition to generalmaintenance tools.
Tool Remarks
Oscilloscope Frequency response 100 MHz or higher
Soldering iron A slender tip type, 15-20 watts
Ectension code kit P/N : 40105501
- 2 -
3. CIRCUIT DESCRIPTION
3.1 Outline
The circuit of OKIPAGE4w consists of a main control board, a high voltage power supply boardand a power supply unit. The block diagram is shown in Fig. 3-1. The main control board controlsthe reception and transmission of data with a host I/f and processes command analysis, bit imagedevelopment, raster buffer read. It also controls the engine and high voltage outputs.
(1) Reception and transmission controlThe main control board has one parallel I/F port which is compliant to the IEEE 1284specification.An interface task stores all data received from the host into a receive buffer first, and returnsthe printer status upon request of the host.
(2) Command analysis processingThe OKIPAGE4w printer has the following emulation mode.
Hiper-W: OKI originalAn edit task fetches data from the receive buffer, analizes commands, and sets I/O registers.
(3) Raster data processingThe decompression circuit in the CPU expands the compressed data and stores the data intothe raster buffer.
(4) Raster data transferThe LED head control circuit in the CPU sends the data stored in the raster buffer to the LEDhead.
(5) High voltage controlThe high voltage control circuit in the CPU.
The high voltage power supply board generates high voltage outputs, and have sensors, LED fordisplay.The power supply unit generates +24VDC output, +5DC output.
- 3 -
Figure 3-1 OKIPAGE4w Block Diagram
CPU
(M
SM65
917)
EPR
OM
(6
4 KB
yte)
Addr
ess
latc
h
D-R
AM
(128
KBy
te)
LED
H
EAT
ON
Hig
h-vo
ltage
pow
er I/
F
A0 ~
A10
A0 ~
A7
D0
~ D
7
AD0
~ AD
7
A8 ~
A15
D0
~ D
3
Driv
er
<Mai
n Co
ntro
l Boa
rd>
10M
Hz
5V
5V 0VL
Res
et
circ
uit
LED
hea
d
Mai
n m
otor
Sens
ors
EEPR
OM
Para
llel
I/F
Para
llel
I/FPa
ralle
l I/F
CN
LS07
LED
hea
dLE
D h
ead
Ther
mis
tor
EP c
artr
idge
Driv
er
Driv
er
Driv
erAC
out
put
ON
/OFF
LED
Mai
n m
otor
<Hig
h-vo
ltage
Pow
er S
uppl
y Bo
ard>
LED
M
Sens
ors
TEM
P
+24V +5V
0VL
0VP
<Pow
er S
uppl
y U
nit>
HIg
h vo
ltage
po
wer
su
pply
Switc
hing
po
wer
sup
ply
HEA
T O
N
TR-V
SEN
TR-I
SEN
Hig
h-vo
ltage
po
wer
Man
ual f
eed
sens
or
Pape
r sen
sor
Out
let s
enso
r To
ner s
enso
r Co
ver o
pen
switc
h
Mai
n m
otor
Hea
ter
(Hal
ogen
lam
p)
AC
(120
V/2
30 V
)
Elec
trom
agne
tic
clut
chEl
ectr
omag
netic
cl
utch
Elec
trom
agne
tic
clut
ch
TEM
P TR
-VSE
N
TR-I
SEN
- 4 -
3.2 CPU and Memory
(1) CPU (MSM65917)CPU core nX-8CPU clock 10 MHzData bus width External 8 bits, Internal 8 bits
(2) Program ROMROM capacity 64k-bytes (512-kbit EPROM)ROM type 512 kbits (64k x 8 bits)Access time 150 nsec
When mask ROM in the CPU is valid, the EPROM is not mounted.
(3) Resident RAMRAM capacity 128k bytes (256k x 4 bits D-RAM one piece)RAM type 1M bits (256k x 4 bits)Access time 70 ns
The block diagram of CPU and memory circuit is shown in Fig. 3-2.
- 5 -
Figure 3-2 Block Diagram of CPU & Memory in OKIPAGE4w
CPU IC 6
ALE
RDN ROCS
DA10 DWR
CAS
RAS0 RAS1 RAS2
LS373 IC3
IC2 EPROM
(64k x 8 bits)
IC11 DRAM
(256k x 4 bits)
AD00 to AD07 A00 to A07
A08 to A15
DD00 to DD03
DA00 to DA09
Main Control Board
- 6 -
3.3 Reset Control
When power is turned on, RST-N signal is generated by IC5.
Power OFFPower ON
+5V
RST-N
CPU
631
2
3
IC5
+5V+5V
RSTN
- 7 -
Instruction Start bit Operation Address Datacode
Read (READ) 1 10 A5 to A0
Write Enabled (WEN) 1 00 11XXXX
Write (WRITE) 1 01 A5 to A0 D15 to D0
Write All Address (WRAL) 1 00 01XXXX D15 to D0
Write Disabled (WDS) 1 00 00XXXX
Erase 1 11 A5 to A0
Chip Erasable (ERAL) 1 00 10XXXX
3.4 EEPROM Control
The BR93LC46A on the main control board is an electrical erasable/programmable ROM of 64-bit x 16-bit configuration. Data input to and output from the ROM are bidirectionally transferredin units of 16 bits through I/O port (EEPRMDT-P) in serial transmission synchronized with a clocksignal from the CPU.
CS
SK
DI
DOHIGH-Z
1 2 4 9 10 25
Min. 450 ns
1 0 1 A5 A4 A1 A0 D15 D14 D1 D0
STATUS
BUSY READY
Max. 500 ns
Max. 10 ms
HIGH-Z
1 2
1 1 0
4 9 10
A5 A4 A1 A0
25 26
D15 D14 D1 D00 D15 D14
CS
SK
DI
DO
The EEPROM operates in the following instruction modes.
Write cycle timing (WRITE)
Read cycle timing (READ)
CPU
EEPRMDT-PIC4
EEPRMCS-P
EEPRMCLK-P
3
39
38
37
2
4
1
DI DO
CS
SK
EEPROM
- 8 -
3.5 Parallel Interface
Parallel data is received from a host system via parallel interface which is compliant to theIEEE1284 specification.
PARALLEL DATA (DATA BITs 1 to 8)
DATA STROBE
BUSY
ACKNOWLEDGE
0.5 µs min.0.5 µs min.
0.5 µs min.
0.5 µs min.
0.5 µs max. 0 min.
0 min.
0 min.0.5 µs to 10 µs
0 min.
Compatible modeThe CPU sets a BUSY-P signal to ON at the same time when it reads the parallel data (PDATA1-P to PDATA 8-P) from the parallel port at the fall of PSTB-N signal. Furthermore, it makes thestore processing of received data into a receive buffer terminate within a certain fixed time andoutputs an ACK-N signal, setting the BUSY-P signal to OFF.
CPU
CN4
65 to 68, 71 to 74
PDATA1-P to PDATA8-P
PSTB-N
BUSY-P
ACK-N
PE-P
FAULT-N
SEL-P
IPRIME-N
SELIN-N
AUTOFD-N
64
78
77
79
80
81
82
83
84
2 to 9
1
11
10
12
13
32
31
36
DATA8-P to
DATA1-P
STB-N
BUSY-P
ACK-N
PE-P
FAULT-N
IPRIME-N
SEL-P
SELIN-N
AUTOFEED-N14
+5V
IC7
+5V18
- 9 -
3.6 LED Lamp Control
There is an LED lamp on the high voltage power supply board which is connected to and controledby the CPU on the main control board.
The light from the LED lamp can be seen on the Lens Cover through the LED Lens.
CPU
main control board high voltage power supply boardCN1
41LED-P
CN1
- 10 -
3.7 LED Head Control
When a paper form is made to arrive at the data write position on print start, the sending of datato the LED head starts as synchronized with the page synchronous signal/line synchronous signal(CPU internal signal).
Bit image data developed on the raster buffer in the CPU are DMA-transferred to the register ofa video interface controller (CPU built-in) and then sent to the shift register of the LED head in aserial transmission synchronized with the VCLK-P signal by the VD0-P signal.
When 1-dot line data (2560 bits) is completely shifted, it is latched by means of the VLD-P signal,causing LEDs to be driven by the VSTB1-N through VSTB4-N signals in different timing for eachsignal.
Some of LED heads have 2496 dots rather than 2560 dots. The controls regarding the numberof dots are adjusted to the LED head installed when the printer is shipped from the factory.
Main control board
LED Head
Chip 40Chip 1
1 to 640 bits
641 to 1280 1281 to 1920 1921 to 2560
Bit 2560
Bit 1
+5V
0V
CPU
VCLK-P
VD0-P
VLD-P
VSTB 1-N VSTB 2-N VSTB 3-N VSTB 4-N
90
89
91
92
9394
95
64 bit shift REG
LATCH
CN6 CN1
- 11 -
VLD-P
VSTB1-N
VSTB2-N
VSTB3-N
VSTB4-N
VDT-P
VDT-P
VCLK-P
VCLK-P
VDT-P
3.33 msec
8 bits
8 bits 2560 bits
0.2 µs
Page synchronous signal*Line synchronous signal*
* CPU internal signal
- 12 -
3.8 Motor and clutch control
The electromagnetic clutch is driven by a control signal from the CPU and the drive circuit shownbelow.The main motor is driven by the control signals from the CPU and the driver IC.
Operation at normal speed: T0 to T3 = 1.515 ms
DMON-P
DMPH1-P
DMPH2-PT0 T1 T2 T3
Rotation Forward rotation Reverse rotationStop
(1) Main motor
MCPU
DMP1
CN7+5V
+5V
+5V
23 22 28 15 10 21 20TAB5
+5V
+5V +24V
ENA ASW1 SW3
SW4SW2
SW1 SW3
SW4SW2
Out1IC10
Out2 Out3
Main Motor
Current Sensor
Current Sensor
ALARMOut4Vmm A Vmm B
ENA B
DECAY
PHASE A PHASE B
0V 0V
0V
0V
0V0VP
Electromagnetic clutch
0V
19
26
25
18
27
969798
99
3 7 1 14 12 24
16
17
8+24V OPEN
DMP2DMP3
RMON
CN8
OSC
GATE
CIR
CUIT
GATE CIRCUIT
BRUNK Q -+
-+
RS
R QS
Vref A Vref BVs A Vs BRs A Rs BLG A PG LG B
To Out3, 4Logic
Signal of DECACY
120140
- 13 -
(2) Motor drive controlTime T0 to T3 determines the motor speed, while the phase different direction betweenphase signals DMPH1-P and DMPH2-P determines the rotation direction. DMON-P signalcontrol a motor coil current. According to the polarity of the phase signal, the coil current flowas follows:
1) +24V → SW1 → motor coil → SW4 → resistor → earth, or,
2) +24V → SW3 → motor coil → SW2 → resistor → earth
The drop voltage across the resistor is input to comparator, where it is compared with areference voltage. If an overcurrent flows, a limiter operates to maintain it within a certainfixed current.
(3) Electromagnetic clutch controlMechanical operation mode is switched by the combination of the clutch status and thedirection of motor rotation.
clutch status
off
off
on
on
rotation direction
Forward
Reverse
Forward
Reverse
operation mode
cleaning
Hopping from manual
feed slot
illegal operation
Hopping from tray
- 14 -
3.9 Fuser Temperature Control
The temperature change in a heat controller is converted into the electric potential TEMPcorresponding to the change in the resistance value of a thermistor, and the resultant potentialis fed back to the control circuit. The CPU performs ON/OFF control of the HEATON-P signal tokeep the heat roller temperature constant in accordance with the state at which the thermistorvoltage (TEMP) is read into directly by the AD converter of the CPU.THCHK-N signal is fixed to “0”.When the paper thickness is set on the menu of the host, the temperature is adjusted to thetargeted thickness accordingly.
Main Control BoardHigh voltage power supply board
+5V
CPU
ACIN
Ther- mistor
Heater
Heat Roller
Thermostat
THCHK-N
HEATON-P
HEATON-N
27
5
7
IC20
+5V +5V
+-6
3
1
IC20+-2
34
85
TEMPAI4
(A/D)
Power supply unit
+5V
- 15 -
Flowchart of Thermistor Circuit Check
HEATER OFF
Short check timer(t16)set
Temperature > Tn
Thermistor error check timer (t2)
within time
Thermistor disconnection check timer
(t35) within time
START
To constant temperature control
End
Heater On
Yes
Yes
Yes
Yes
Yes
NoTime-out
Tn...T0 = T2 = T4 =
No
No
No
No
No
Yes
Fuser error
End
Thermistor disconnection error
Thermistor short error
t2 = t16 = t35 =
90 sec 520 msec
10 sec
Thermistor error check timer (t2) set
Thermistor disconnection check timer (t35) set
Time-out ?
Short error TEMP ?
End
Light Medium Heavy
A/D value changed?
- 16 -
Temperature
ControlledTemperature
T
HEATER ON
OFF
Time
Temperature table
THCHK-N
O
Z
Heater control mode
Normal operation
Not used
T135˚C:140˚C:150˚C:155˚C:155˚C:
Paper Thicknesslightmedium lightmediummedium heavyheavy
- 17 -
3.10 Sensor Control
The CPU supervises the state of each sensor every 40 ms.
OFF
TNRSNS-N
CN1 CN1
PSIN-N
PSOUT-N
WRSNS-N
CPU
+5V
PS1
PS2
PS3
PS4
ON
TransparentShield
Sensor signal
47
44
46
48
+5V
+5V
+5V
+5V
Main Control Board High Voltage Power Supply Board
- 18 -
3.11 Cover Open
When the cover is opened, a cover open microswitch is opened. This makes a CVOPN-N signallow, thereby the CPU detects that cover is open. Furthermore, opening the cover stops applyinga +5V power to the high voltage power supply part, resulting in stopping all high voltage outputs.
CPUCVOPN-N
Cover Open Microswitch
+5V
+5V
0V
Cover close Cover open
High Voltage Power Supply
Part
High voltage output
45
CVOPN-N
Main Control Board
CN1 CN1
High Voltage Power Supply Board
+5V
- 19 -
3.12 Power Supply Part
(1) Power supply unitAn AC power from an inlet is input to Switching Reg. part .AC power is converted to a +24VDC output and +5 VDC output.
F1 F2L
FG
N
Fuse RatingsAC Input
Fuse
F1
F2
230 V
250 V 6.3 A
250 V 2 A
120 V
125 V 10 A
250 V 2 A
ACIN
to AC output
HEATON-N
HEATER CONTROLER
Power supply unit
Switching Reg. Part
Filter Circuit
+24V
+5V
0V
(2) High voltage power supply boardThe +5 VDC power supplied to the high voltage power supply part via the cover openmicroswitch as source voltage. The high voltage power supply part supplies necessaryvoltage for electro-photography print to output terminals CH, DB, SB, TR, and CB accordingto a control signal from the CPU. The table on the next page shows the relationship betweencontrol signals and high voltage outputs.
TR1PWM-P TR2PWM-P CHPWM-P SDB1-P SDB2-PDBPWM-P
CVOPN-N Cover Open Microswitch
CH DB SB TR CB
CN1
+5V
MainControl Board High Voltage Power Supply BoardCN1
CPU
High Voltage Power Supply
Part
55
59
56
53
52
54
45
- 20 -
Control Signals and High Voltage Outputs
Control signal name Level Function
TR1PWM-P
H/L
(PWM)
L
H/L(PWM)
L
H/L(PWM)
L
H
L
H
L
H/L(PWM)
L
Makes the part put out a power to TR.
Makes the part put out a -750V power to TR.
Makes the part put out a -1.35 KV power to CH.
Makes the part put out the following power:
Makes the part put out the following power:
Makes the part put out the power to SB, DB, CB.
+3 to 5 µA +0.5 to 4 KV
+450V or 0V power to SB +300V power to DB
-450V power to SB -300V power to DB +400V power to CB
TR2PWM-P
CHPWM-P
SDB1-P
SDB2-P
DBPWM-P
- 21 -
4. TROUBLESHOOTING
4.1 Troubleshooting Table
(A) High Voltage Power Supply Board
Note: A malfunction of the power supply is not repaired by an agency. The abnormality to betreated here is that of sensors only.
Failure PC Display Message Flowchart No.
A paper input jams occur frequently. P A P E R
I N P U T J A M
A - 1
A paper feed jams occur frequently. A - 2
A paper-exit jams occur frequently. A - 3
A paper size errors occur frequently. A - 4
Paper can not be fed from the manual feed slot . A - 5
The message "COVER OPEN" remains displayed on the PC display.
A - 6
The message "TONERLOW" remains displayed on the PC display.
A - 7
The message "TONERSNS" remains displayed on the PC display.
A - 8
P A P E R
F E E D J A M
P A P E R
E X I T J A M
C O V E R O P E N
T O N E R L O W
T O N E R S E N S O R
P A P E R
S I Z E E R R O R
- 22 -
(B) Main Control Board
Failure PC Display Message Flowchart No.
Initialization error and not restored I N I T I A L I Z A T I O N
E R R O R
B - 1
Program ROM error B - 2
Resident RAM error B - 3
EEPROM error B - 4
Fuser error B - 5
Watchdog timer timeout occurs frequently. B - 6
R O M C H E C K
E R R O R
R A M C H E C K
E R R O R
F U S E R E R R O R
W A T C H D O G
T I M E R E R R O R
E E P R O M C H E C K
E R R O R
Data sent through the Parallel I/F cannot be received.
B - 7
I N I T I A L I Z A T I O N
E R R O R
- 23 -
4.2 Troubleshooting Flowchart
A-1 Paper input jams occur frequently.
• Is PS4 (Write Sensor ) operating normally?
• No Replace PS4.
• Yes Is Pin1 of CN8 in main control board operating normally?
• No Replace Q4 or Q5 in main control board.
• Yes Failure of IC6 (MSM65917) in main control board.
A-2 A paper feed jams occur frequently.
• Is PS4 (Write Sensor ) operating normally?
• No Replace PS4.
• Yes Is PS3 (Outlet Sensor ) operating normally?
• No Replace PS3.
• Yes Failure of IC6 (MSM65917) in main control board.
A-3 A paper exit jams occur frequently.
• Is PS3 (Outlet Sensor) operating normally?
• No Replace PS3.
• Yes Failure of IC6 (MSM65917) in main control board.
A-4 A paper size errors occur frequently.
• Is PS4 (Write Sensor ) operating normally?
• No Replace PS4.
• Yes Failure of IC6 (MSM65917) in main control board.
A-5 Paper can not be fed from manual feed slot.
• Is PS2 (Manual Feed Sensor) operating normally?
• No Replace PS2.
• Yes Failure of IC6 (MSM65917) in main control board.
- 24 -
A-6 The message “COVER OPEN” remains displayed on the PC display.
• Is CVSW (Cover Open Switch) operating normally?
• No Replace CVSW.
• Yes Failure of IC6 (MSM65917) in main control board.
A-7 The message “TONERLOW” remains displayed on the PC display.
• Is PS1 (Toner Sensor) operating normally?
• No Replace PS1.
• Yes Failure of IC6 (MSM65917) in main control board.
A-8 The message “TONERSNS” remains displayed on the PC display.
• Is PS1 (Toner Sensor) operating normally?
• No Replace PS1.
• Yes Failure of IC6 (MSM65917) in main control board.
- 25 -
B-1 Initialization error and not restored
• Replace IC2.
• OK?
• No Is the 10-MHz clock signal being put out to pin 3 of OCS1?
• No Replace OSC1 (CST 10.0MTW).
• Yes Failure of IC6 (MSM65917)
B-2 Program ROM error
• Replace IC2.
B-3 Resident RAM error
• Are negative pulses being put out to Pin 4 , 23 (RAS0-N , CSA-N) of IC11?
• No Failure of IC6 (MSM65917)
• Yes Are the signals at pins, 9 TO 12 , 14 TO 18 , 5(DA00-P to DA09-P) of IC11 being changed?
• No Failure of IC6 (MSM65917)
• Yes Replace IC11.
B-4 EEPROM error
• Replace IC4.
• OK?
• No Failure of IC6 (MSM65917)
B-5 Fuser error
• Is the heater on?
• No Is the voltage at Pin 40 (HEATON-P) of IC6(MSM65917) 5V?
• Yes Replace Q3 or IC20
• No Failure of IC6 (MSM65917)
B-6 Watchdog timer timeout occurs frequently.
• Replace IC2.
• OK?
• No Failure of IC6 (MSM65917)
- 26 -
ON-LINE OFF-LINE
BUSY-P Low High
B-7 Data sent through the Parallel I/F cannot be received.
• Is the signal at Pin 11 (BUSY-P) of CN4 being at low level?
• No Is the signal at Pin 13 (BUSY-P) of IC7 (7407) changed as shownbelow, at data reception?
• No Failure of IC6 (MSM65917)
• Yes Replace IC7 (7407).
• Yes Is the level of the signal at Pin 1 (STB-N) of CN4 changed at data reception?
• No Make sure of the connection of I/F cable or the operation of the h ostcomputer.
• Yes Are the signals at Pin 1 (ACK-N), Pin 9 (FAULT-N) of IC7 (7407) beingrespectively at low level and high level in on-line mode?
• No Replace IC7 (7407).
• OK?
• No
• Yes Failure of IC6 (MSM65917)
- 27 -
5. CIRCUIT DIAGRAM
Figure 5-1 ~ 5-7 Main Control PCB (HBMC-) Circuit Diagram (Rev. 2)
Figure 5-8 ~ 5-14 Main Control PCB (HBMC-) Circuit Diagram (Rev. 3)
Figure 5-15 High voltage Power Supply PCB (OLHV-) Circuit Diagram (Rev.6 ,7 ) (TLHV-) Circuit Diagram (Rev.2 )
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 28 -
Figure 5-1 Main controller PCB(HBMC-1/7) Rev. 2Cicuit Diagram
+5V
+5V
IC5
Not Mounted (HIGH-LEVEL)
MOunted (LOW-LEVEL)
0V
0V
0V
CH1
0V
0V
+5V
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
SIGNAL
OPEN
EAN
Pin-No Short-Wire
MSM65917 Mode change
Tool not connected Tool connected
Internal ROM Enternal ROM Enternal ROM
61 R121
SP1 B Side A Side A Side62
OSC1
R510
R53
1
10
2
2
1 3
2
1
1
1
2
R53
3
C15
0.1µ
50
5.1K
0.1
1
1
2
R52
0 012
R51
3.6K
0.1
12
R50
12
2
C14
0.1µ
50
12
C12
0.1µ
50
12
C13
0.1µ
50
12
C50
9
0.1µ
50
12
C50
3
0.1µ
50
12
C51
1
0.1µ
50
12
C51
0
0.1µ
50
21
C51
4
0.1µ
50
12
C50
4
0.1µ
50
21
C51
3
0.1µ
50
12
R5111 2
3
3
14
1824231720192122
131211
10
15163536
3738394349
344240
8586
41
105
102
9
765
8
871
1 1 1
CH5
CH4CH6CH7
1 1
CH2 CH3
2
4
1
606162
63
45474648
2728293031
26
32
7670585125
7569575033
44106104103
108
107
PST592VCCGND
OUT
CST10.0MTW
CST
0
R5261 2150 0.1
10K 0.1
CH8
SP1 (Short-plug)SP1 SP1 SP1
1 2 3A B
(074G) CVOPN-N
(075F) TNRSNS-N
(075G) WRSNS-N(075G) PSOUT-N
(075F) PSIN-N
(065D) DIPSW2(065D) DIPSW1
(075F) TEMP(016F) THCHK-N
(075E) TR-VSEN(075E) TR-ISEN
GND1GND2GND3GND4GND5 PU00
P40P41P42P43P44P45P46
P20P21P24P25P27
INT0INT1WRNRDNALE
AD0AD1AD2AD3AD4AD5AD6AD7
A8A9
A10A11A12A13A14A15
ROCS
CPCK65917 (1/2)
GND6GND7
VDD1VDD2VDD3VDD4VDD5VDD6VDD7
AGND
AVDD
AI0AI1AI2AI3AI4
P30P31P32
P33P34P35P36P37
RSTN
EANCPENTEST
OSC0
OSC1
IC6
CHPWDBPWT2PWT1PWSDB2SDB1
RMONRMP1RMP2DMONDMP1DMP2
VSB4VSB3VSB2VSB1
VLDPVCLKVD0PVD1P
FLTNSELPPEP
BSYPACKN
DWRNCASNRAS0RAS1RAS2
DA7DA6DA5DA4DA3DA2DA1DA0
DA10DA9DA8
65917 (2/2)
PSBNAFXNSLINIPRN
PDT2PDT1
PDT3PDT4
PDT5PDT6PDT7PDT8
DD0
DD3
DD2DD1
IC6
LED-P (074F)
XCLK-P (065B)
HEATON-P (075D)
FANALM-N (03XG)
EEPRMDT-P (047A)EEPRMCS-P (047B)EEPRMCLK-P (048C)
AD00-P (027B)AD01-P (027B)AD02-P (027B)AD03-P (027B)AD04-P (027B)AD05-P (027B)AD06-P (027B)AD07-P (027B)
A08-P (02XB)A09-P (02XB)A10-P (02XB)A11-P (02XB)A12-P (02XB)A13-P (02XB)A14-P (02XB)A15-P (02XB)
ROMCS-N (02XC)
RD-N (02XC)ALE-P (027C)
FANON-P (037E)
DCLED-P (071F)THCHK-N (013E)
TXD-P (065B)
BANK (02XB)
RXD-P (065B)
535255595456
99100101989697
9293949591908988
8180797877
120125126127128
119118117116115114113112111110109123
124121122
7473727168676665
82838464
(024B) DD01-P(024B) DD00-P(024C) DD03-P(024C) DD02-P
(054B) PDATA8-P(054B) PDATA7-P(054B) PDATA6-P(054C) PDATA5-P(054C) PDATA4-P(054C) PDATA3-P
(054C) PDATA2-P(054C) PDATA1-P
(054E) IPRIME-N(054F) SELIN-N
(054G) AUTOFD-N(054E) PSTB-N
DA10-P (024A)DA09-P (022C)DA08-P (022C)DA07-P (022C)DA06-P (022C)DA05-P (022C)DA04-P (022C)DA03-P (022C)DA02-P (022D)DA01-P (022D)DA00-P (022D)
RAS2-N (025D)RAS1-N (025E)RAS0-N (023E)CAS-N (023E)
DWR-N (022D)
ACK-N (057E)BUSY-P (057D)PE-P (057E)SEL-P (057F)FAULT-N (057F)
VD1-P (041B)VD0-P (041B)VCLK-P (041B)VLD-P (041C)VSTB4-N (041D)VSTB3-N (041D)VSTB2-N (041C)VSTB1-N (041C)
PJON-P (037B)
CHPWM-P (071D)DBPWM-P (072C)TR2PWM-P (071E)TR1PWM-P (071C)SDB2-P (071B)SDB1-P (071A)
DMPH1-P (032C)
DMON-P (031D)DMPH2-P (033C)
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 29 -
+5V
+5V
+5V
0V
0V
0V
0V
CN9
Option-RAM
(01XB) DA10-P
(018B) DD00-P
(01XB) DA09-P(01XC) DA08-P(01XC) DA07-P(01XC) DA06-P(01XC) DA05-P(01XC) DA04-P(01XC) DA03-P(01XC) DA02-P(01XC) DA01-P
(01XC) DA00-P
(01XD) DWR-N
(018B) DD01-P
(018C) DD02-P
(018C) DD03-P
DRAM-A10
DRAM-A09
DRAM-A08
DRAM-A07
DRAM-A06
DRAM-A05
DRAM-A04
DRAM-A03
DRAM-A02
DRAM-A01
DRAM-A00
DRAM-D03
DRAM-D02
DRAM-D01
DRAM-D00
RAS2N
RAS1N
CASN
DRAM-WRN
OE
VCC
VCC
VCC
GND
GND
GND
GND
GND
GND
GND
GND
GND
CN924
CN925
CN926
CN927
CN928
CN929
CN930
CN912
CN911
21
CN910
CN99
CN93
CN92
CN97
CN96
CN98
CN91
CN94
CN95
CN9
19CN9
17CN9
18CN9
13CN9
14CN9
15CN9
16CN9
20CN9
22CN9
23CN9
31CN9
32CN9
R548120
R546120
R549120
R550120
IC11
A9A8A7A6A5A4A3A2A1A0
WEOE
VCCVSS
RAS CAS
I/O4
322
13
4 23
12
2425
26
518171615141211109
I/O3I/O2I/O1
514400J
C52
0
0.1µ
50
12
R54701 2
(01XD) RAS0-N
(01XD)CAS-N
(01XC) RAS2-N
(01XC) RAS1-N
<512>
<256>
DQ1DQ1
DQ2DQ2
WEWE
RASRAS
NCA9
A0A0
A1A1
A2A2
A3A3
Vcc
1
2
3
4
5
9
10
11
12
13
26
25
24
23
22
18
17
16
15
14Vcc
VssVss
DQ4DQ4
DQ3DQ3
CASCAS
OEOE
A8A8
A7A7
A6A6
A5A5
A4A4
IC11
1M Mask
27C1001
27512
IC2
1 2 3 (1) 4 (2) 5 (3) 6 (4) 7 (5) 8 (6) 9 (7) 10 (8) 11 (9) 12 (10) 13 (11) 14 (12) 15 (13) 16 (14)
NC A16 A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 D0 D1 D2 GND
VPP A16 A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 DO D1 D2 GND
- - A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 DO D1 D2 GND
- - VCC A14 A13 A8 A9 A11 OE/VPP A10 CE D7 D6 D5 D4 D3
VCC PGM NC A14 A13 A8 A9 A11 OE A10 CE D7 D6 D5 D4 D3
VCC NC NC A14 A13 A8 A9 A11 OE/OE A10 CE/CE D7 D6 D5 D4 D3
32 31
(28) 30 (27) 29 (26) 28 (25) 27 (24) 26 (23) 25 (22) 24 (21) 23 (20) 22 (19) 21 (18) 20 (17) 19 (16) 18 (15) 17
GND
VCCNCVPPCEOEPGM
A0A1A2A3A4A5A6A7A8A9A10A11A12A13A14A15A16 Q7
21
3124221
303216
23
29284
25232627
56789
101112
20191817151413
Q6Q5Q4Q3Q2Q1Q0
(016E) RD-N
C50
1
0.1µ
50
12 (016C) ROMCS-N
Vcc=+5V, Ground=0V
SOCKETIC2
IC3 27C100174LS373
1D2Q3Q4Q5Q
6Q7Q8Q
1Q2D3D4D5D6D7D8DENOC
2
111181714138743
569
12151619
(016D) AD07-P(016F) BANK(016C) A15-P(016C) A14-P(016C) A13-P(016C) A12-P(016C) A11-P(016C) A10-P(016C) A09-P(016C) A08-P
(016D) AD06-P(016D) AD05-P(016D) AD04-P(016D) AD03-P(016D) AD02-P(016D) AD01-P(016D) AD00-P
(016E) ALE-P
Figure 5-2 Main controller PCB(HBMC-2/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 30 -
NOMOUNTNOMOUNT
CH10CH9
1 1
CN7
4M-DMOTOR
IC10
+5V
(01XF) DMON-P
R54
2
1K0.
11
2R
541
C52
4
22K
5022
00p
0.1
1
12
R54
0
C52
3
MIN
_W:1
.27m
m
C4
4.3K
0.1µ
50
47µ
50
0.1
1 1
21
+
2
2
2
R543 1222K 0.1
B
A C
D
E
0V
0V0V
C5251 2
0.1µ 50
+5V
+24V
ZA21ZA20
11
0Vp
30NC6 13
119642
10
5
24
12
8
7
3
NC5NC4NC3NC2NC1
RSB
RSA
NALM
OUT4
OUT3
OUT2
OUT1
29
141
1528
1918
21
20
22
23
25
16
17
27
26
GND2 GND1
VMM2 VMM1
LGB
LGA
VCC DCAY
VSB
REFB
REFA
CR
NENB
NENA
PHAB
PHAA
VSA
MIN_W:1.27MIN_W:1.27
MTD2005F MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN
_W:0
.635
mm
CN71
CN72
CN73
CN74
IM=0.38A
R1
1 20.
52
R2
1 20.
52
0Vp
DMPH2-N
DMPH2-P
DMPH1-N
DMPH1-P
+5V
R541
1K
10K
0.1
2
R551
0.1
2
(01XF) PJON-P
(01GE) FANON-P
Q5
22K
22K
2
3
1
0V
OVP
+24V
CN8
2M-PJ
Q4
3
3
2SA1338
SS100MA80VACP
2
2
1
1D3
MIN_W:0.635
MIN
_W:0
.635
MIN_W:0.635
CN81
CN82
PJON
OVP
NOMOUNT
CN3
2M-Fan
NOMOUNT
NOMOUNT
NOMOUNT
NO
MO
UN
T
NOMOUNT
2
2
2
22K
22K
1
13
R502Q502 10K 0.1
+24V
Q501
3
3
1
1
22SA1338
0V
D501
SS100MA80VACP
MIN_W:0.635mm
MIN_W:0.635mm
MIN
_W:0
.635
FANPOW
R50
11
10K
0.1
2
0VP
0VP
+5V
FANALM-N FANALM-N (01GF)
CN31
CN32
CN33
(01XF) DMPH1-P
(01XF) DMPH2-P0V
Figure 5-3 Main controller PCB(HBMC-3/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 31 -
+5V
R5201 20
R5191 20
R5131 20
R5121 20
(01XE) VD0-P
(01XE) VD1-P
(01XE) VLD-P
(01XE) VCLK-P
(01XF) VSTB1-N
(01XE) VSTB2-N
(01XE) VSTB3-N
(01XE) VSTB4-N
SS100MA80VACP SS100MA80VACP
NOMOUNT NOMOUNT
NOMOUNTNOMOUNT
SS100MA80VKCP SS100MA80VKCP
D1 D21
3
2 1
3
2
CN6
14F-LED
CN66
CN67
CN68
CN69
CN610
CN611
CN612
CN613
CN63
CN64
CN65
HDDT0-P
HDDT1-P
HDCLK-P
HDLD-P
STB1-N
STB2-N
STB3-N
STB4-N
D41
3
2D5
1
3
2
0V
5V
5V
0V
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
CN61 0VP
MIN_W:1.27mm
CN62 0VP
CN614 FG
MIN_W:1.27mm
+5V
1
1+
2
2
C52
6
C1
0.1µ
3300
µ 50
12
C16
0.01
µ 25
0
12
C8
0.01
µ 25
0
10
0V
0VP
FG1
FG2
FG
1
1
(01GE) EEPRMDT-P
(01GE) EEPRMCS-P
(01GE) EEPRMCLK-P
+5V
R53
7
C52
2
0.1µ
50
5.1K
0.1
1 1
2
R53
8
5.1K
0.1
12
R53
9
10K
0.1
12
2
0V
3
2
61
857
IC4
DI DONC1C8
VCCGND1NC2
4
0V
Figure 5-4 Main controller PCB(HBMC-4/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 32 -
+5V
CN4
36F-Centro
PDATA8-P CN49
PDATA7-P CN48
PDATA6-P CN47
PDATA5-P CN46
PDATA4-P CN45
PDATA3-P CN44
PDATA2-P CN43
PDATA1-P CN42
STB-NCN4
1
IPRIME-NCN4
31
SELIN-NCN4
36
AUTOFEED-PCN4
14
R302 122 0.1
R312 122 0.1
R292 122 0.1
R282 122 0.1
R252 122 0.1
R262 122 0.1
R272 122 0.1
R242 122 0.1
R5281 2100 0.1
R5142 11K 0.1
R5051 23.3K 0.1
R5151 23.3K 0.1
R522110K 0.1
R5211 210K 0.1
R5272 11K 0.1
R50
6
C51
5
560p
50
1
1
2
2
C50
6
1000
p50
12
C50
7
560p
50
12
C50
8
560p
50
12
1K0.
1
R50
41
21K
0.1
R51
6
3.3K
0.1
21
R50
9
3.3K
0.1
21
R50
7
3.3K
0.1
21
R50
8
3.3K
0.1
21
R51
7
3.3K
0.1
21
R51
8
3.3K
0.1
21
R52
4
3.3K
0.1
21
R52
3
3.3K
0.1
21
PDATA8-P(018D)
PDATA7-P (018D)
PDATA6-P(018D)
PDATA5-P (018D)
PDATA4-P(018D)
PDATA3-P (018D)
PDATA2-P(018D)
PDATA1-P (018D)
+5V
0V
0V
0V
0V
+5V
+5V NO
MO
UN
TN
OM
OU
NT
Vcc=+5V , Ground=0V
OC5 6
IC7
07
AUTOFD-N (018E)
SELIN-N (018E)
IPRIME-N (018E)
PSTB-N (018E)
+5V
+5V0V
C50
5
R38
0.1µ
50
1
1
2
2 3.3K
0.1
R37
12 3.3K
0.1
R35
12 3.3K
0.1
R36
12 3.3K
0.1
R43
12 3.3K
0.1
R44
12 3.3K
0.1
(01XE) BUSY-P
(01XE) ACK-N
(01XE) PE-P
(01XE) SEL-P
(01XE) FAULT-N
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
OC13 12
07
IC7
OC1 2
07
IC7
OC3 4
07
IC7
OC11 10
07
IC7
OC9 8
07
IC7
FG
C7
0.01
µ 25
0
12
C17
0.01
µ 25
0
12
0V
+5VR421 2
0
MIN_W:1.27mm
MIN_W:1.27mm
CN438 FG
CN437 FG
CN417 FG
CN418 5V
CN432 FAULT-N
CN413 SEL-P
CN412 PE-P
CN410 ACK-N
CN411 BUSY-P
CN435 HILEVEL
CN434 N/C
CN415 N/C
CN433 SG
CN430 SG
CN429 SG
CN428 SG
CN427 SG
CN426 SG
CN425 SG
CN424 SG
CN423 SG
CN422 SG
CN421 SG
CN420 SG
CN419 SG
CN416 SG
0V
CN4
36F-Centro
Figure 5-5 Main controller PCB(HBMC-5/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 33 -
+5VNOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNTNOMOUNT
NOMOUNT NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NO
MO
UN
T
NO
MO
UN
TN
OM
OU
NT
NO
MO
UN
T
NO
MO
UN
T
NOMOUNT
NO
MO
UN
T
NOMOUNT
IC9
OSCVOUT
LV
CAP+
CAP-
GND
V+C512
211000p 50
8
75
6
2
4
3
C6
10µ
16
21
+ C5
C51
6
10µ
0.1µ
50
16 2
2
1
1 C51
7
0.1µ
502
1
+
0V
0V
0V
SW1
21
34
21 DIPSW2 (014D)
DIPSW1 (014D)
+5V
RXD-P (01GF)
R5251 220 0.1
R5321 220 0.1
R5341 220 0.1
R5301 220 0.1
(01GF) TXD-P
(016F) XCLK-P
(06YE) RXD+(06YF) RXD-
2IC8
34
12
151413
567
11109
1681
7660
DS8925DIN1
DIN2
RIN1-
RIN2+
RIN2-
RIN3+
VCC
GND
VEE
DEN1
DOUT1+
DOUT1-
DOUT2-
ROUT1
ROUT2
ROUT3 0V
0V
0V
0V
C52
1
150p
50
12
C51
8
150p
50
12
C51
9
150p
50
12
CN5
TCS7187-01-201
CN56
TXD+
CN53
TXD-
R5291 220 0.1
R5441 20
R53
61
20.
120
0
200R
535
12
0.1
R5311 220 0.1
CN51
XCLK-N
CN57
+5V
CN54
CN58
SG
+5V
RXD+
CN55
RXD-
CN52
CN5FG
FG
FG
FG
9CN5
10CN5
11
HSK-IN
RXD+ (065B)
RXD- (065B)
Figure 5-6 Main controller PCB(HBMC-6/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 34 -
CN1
High-voltage
(01XG) SDB1-P
(01XG) SDB2-P
(01XG) DBPWM-P
(01XG) TR1PWM-P
(01XF) CHPWM-P
(01XG) TR2PWM-P
(016F) DCLED
R39
R40
C11
1 12 21K 0.1
R5 120
OC
NOMOUNT
LS07
1
1
2
2
3 4
0.11K
R41 12 5 6
9 8
11 10
0.1220
R34 120.1220
R32 210.1300
R33 210.1300
R7 120
R9 120
R13 120
R11 120
R22Q2
Q1
1210K
2SA1338
0.1
0.022µ 50
C1021
0.022µ 50
C1821
0.022µ 50
C1912
2
1
1
2
33
0.022µ 50
R3 120
OC
NOMOUNT
NOMOUNT
LS07
OC
LS07
NOMOUNT
OC
LS07
IC1
IC1
IC1
IC1
NOMOUNT
OC
LS07
IC1
13 12
NOMOUNT
NO
MO
UN
TN
OM
OU
NT
NO
MO
UN
T
NO
MO
UN
T
NO
MO
UN
TN
OM
OU
NT
NOMOUNT NOMOUNT
NOMOUNT
OC
LS07
IC1
Vcc=+5V , Ground=0V
22K
22K
0V
+24V
+5V
C9
0.1µ
50
12
0V
11 0VCN110 0VCN1 9 0VCN1 7 0VCN1 5 0VCN1
17 5VCN115 5VCN1
23CN1 CVOPN-N (014D)
CVOPN-N
1CN1PSOUT-N PSOUT-N (014D)
16CN1WRSNS-N
19CN1PSIN-N
21CN1TNRSNS-N
13CN1
6CN1
22CN1
3CN1
TEMP TEMP (013E)
TNRSNS-N (014D)
PSIN-N (014D)
WRSNS-N (014D)
(016G) LED-P LED-P
DCLED-P
+5V
1 2R19
100K 0.12 1R56
200K 0.1
1 2R545
4.7K 0.1
12
R15
10K
0.1
12
R12
510
0.1
12
R14
510
0.1
12
R10
510
0.1
12
R8
3.3K
0.1
12
R4
3.3K
0.1
12
R6
3.3K
0.1
12
R16
10K
0.1
12
R17
10K
0.1
12
R18
10K
0.1
21
R20
1.2K
0.1
21
R21
1K0.
1
12
R50
3
10K
0.1
1
1
12
+2
2R
23
C50
2
C3
0.1µ
50
47µ
161
2+
C2
47µ
50
1K0.
1
TR-ISEN (014E)TR-ISEN 12
CN14CN1
TR-VSEN (014E) TR-VSEN
TR2PWM-P
2CN1 CHPWM-P
8CN1 TR1PWM-P
DBPWM-P14
CN1
SDB2-P20
CN1
SDB1-P18
CN1
+5V
+5V
0V
0V0V
0V0V
+5V
+5V+5V
+5V
3
24
1
8+
-
5
64
7
8+
-
(016F) HEATON-P
IC20
IC20
393
39322K
22K
Q3
2
1
3
CN28
CN2NC
7
CN20V
4
CN20V
3
CN25V
2
CN25V
1
CN20VP
5
CN224V
+24V
6
HEATON-N
10V
+5V
0VP
CN2
Power
Figure 5-7 Main controller PCB(HBMC-7/7) Rev. 2Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 35 -
+5V
+5V
IC5
0V
0V
0V
CH1
0V
0V
+5V
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
OSC1
R510
R53
1
10
2
2
1 3
2
1
1
1
2
R53
3
C15
0.1µ
50
5.1K
0.1
1
1
2
R52
0 012
R51
3.6K
0.1
12
R50
12
2
C14
0.1µ
50
12
C12
0.1µ
50
12
C13
0.1µ
50
12
C50
9
0.1µ
50
12
C50
3
0.1µ
50
12
C51
1
0.1µ
50
12
C51
0
0.1µ
50
21
C51
4
0.1µ
50
12
C50
4
0.1µ
50
21
C51
3
0.1µ
50
12
R5111 2
3
3
14
1824231720192122
131211
10
15163536
3738394349
344240
8586
41
105
102
9
765
8
871
1 1 1
CH5
CH4CH6CH7
1 1
CH2 CH3
2
4
1
606162
63
45474648
2728293031
26
32
7670585125
7569575033
44106104103
108
107
PST592VCCGND
OUT
CST10.0MTW
CST
0
R5261 2150 0.1
10K 0.1
CH8
SP1 (Short-plug)SP1 SP1 SP1
1 2 3A B
(074G) CVOPN-N
(075F) TNRSNS-N
(075G) WRSNS-N(075G) PSOUT-N
(075F) PSIN-N
(065D) DIPSW2(065D) DIPSW1
(075F) TEMP(016F) THCHK-N
(075E) TR-VSEN(075E) TR-ISEN
GND1GND2GND3GND4GND5 PU00
P40P41P42P43P44P45P46
P20P21P24P25P27
INT0INT1WRNRDNALE
AD0AD1AD2AD3AD4AD5AD6AD7
A8A9
A10A11A12A13A14A15
ROCS
CPCK65917(1/2)
GND6GND7
VDD1VDD2VDD3VDD4VDD5VDD6VDD7
AGND
AVDD
AI0AI1AI2AI3AI4
P30P31P32
P33P34P35P36P37
RSTN
EANCPENTEST
OSC0
OSC1
IC6
CHPWDBPWT2PWT1PWSDB2SDB1
RMONRMP1RMP2DMONDMP1DMP2
VSB4VSB3VSB2VSB1
VLDPVCLKVD0PVD1P
FLTNSELPPEP
BSYPACKN
DWRNCASNRAS0RAS1RAS2
DA7DA6DA5DA4DA3DA2DA1DA0
DA10DA9DA8
65917(2/2)
PSBNAFXNSLINIPRN
PDT2PDT1
PDT3PDT4
PDT5PDT6PDT7PDT8
DD0
DD3
DD2DD1
IC6
LED-P (074F)
XCLK-P (065B)
HEATON-P (075D)
FANALM-N (03XG)
EEPRMDT-P (047A)EEPRMCS-P (047B)EEPRMCLK-P (048C)
AD00-P (027B)AD01-P (027B)AD02-P (027B)AD03-P (027B)AD04-P (027B)AD05-P (027B)AD06-P (027B)AD07-P (027B)
A08-P (02XB)A09-P (02XB)A10-P (02XB)A11-P (02XB)A12-P (02XB)A13-P (02XB)A14-P (02XB)A15-P (02XB)
ROMCS-N (02XC)
RD-N (02XC)ALE-P (027C)
FANON-P (037E)
DCLED-P (071F)THCHK-N (013E)
TXD-P (065B)
BANK (02XB)
RXD-P (065B)
535255595456
99100101989697
9293949591908988
8180797877
120125126127128
119118117116115114113112111110109123
124121122
7473727168676665
82838464
(024B) DD01-P(024B) DD00-P(024C) DD03-P(024C) DD02-P
(054B) PDATA8-P(054B) PDATA7-P(054B) PDATA6-P(054C) PDATA5-P(054C) PDATA4-P(054C) PDATA3-P
(054C) PDATA2-P(054C) PDATA1-P
(054E) IPRIME-N(054F) SELIN-N
(054G) AUTOFD-N(054E) PSTB-N
DA10-P (024A)DA09-P (022C)DA08-P (022C)DA07-P (022C)DA06-P (022C)DA05-P (022C)DA04-P (022C)DA03-P (022C)DA02-P (022D)DA01-P (022D)DA00-P (022D)
RAS2-N (025D)RAS1-N (025E)RAS0-N (023E)CAS-N (023E)
DWR-N (022D)
ACK-N (057E)BUSY-P (057D)PE-P (057E)SEL-P (057F)FAULT-N (057F)
VD1-P (041B)VD0-P (041B)VCLK-P (041B)VLD-P (041C)VSTB4-N (041D)VSTB3-N (041D)VSTB2-N (041C)VSTB1-N (041C)
PJON-P (037B)
CHPWM-P (071D)DBPWM-P (072C)TR2PWM-P (071E)TR1PWM-P (071C)SDB2-P (071B)SDB1-P (071A)
DMPH1-P (032C)
DMON-P (031D)DMPH2-P (033C)
Not Mounted (HIGH-LEVEL)
MOunted (LOW-LEVEL)
SIGNAL
OPEN
EAN
Pin-No Short-Wire
MSM65917 Mode change
Tool not connected Tool connected
Internal ROM Enternal ROM Enternal ROM
61 R53
SP1 B Side A Side A Side62
Figure 5-8 Main controller PCB(HBMC-1/7) Rev. 3Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 36 -
Figure 5-9 Main controller PCB(HBMC-2/7) Rev. 3Cicuit Diagram
+5V
+5V
+5V
0V
0V
0V
0V
CN9
Option-RAM
(01XB) DA10-P
(018B) DD00-P
(01XB) DA09-P(01XC) DA08-P(01XC) DA07-P(01XC) DA06-P(01XC) DA05-P(01XC) DA04-P(01XC) DA03-P(01XC) DA02-P(01XC) DA01-P
(01XC) DA00-P
(01XD) DWR-N
(018B) DD01-P
(018C) DD02-P
(018C) DD03-P
DRAM-A10
DRAM-A09
DRAM-A08
DRAM-A07
DRAM-A06
DRAM-A05
DRAM-A04
DRAM-A03
DRAM-A02
DRAM-A01
DRAM-A00
DRAM-D03
DRAM-D02
DRAM-D01
DRAM-D00
RAS2N
RAS1N
CASN
DRAM-WRN
OE
VCC
VCC
VCC
GND
GND
GND
GND
GND
GND
GND
GND
GND
CN924
CN925
CN926
CN927
CN928
CN929
CN930
CN912
CN911
21
CN910
CN99
CN93
CN92
CN97
CN96
CN98
CN91
CN94
CN95
CN9
19CN9
17CN9
18CN9
13CN9
14CN9
15CN9
16CN9
20CN9
22CN9
23CN9
31CN9
32CN9
R548120
R546120
R549120
R550120
IC11
A9A8A7A6A5A4A3A2A1A0
WEOE
VCCVSS
RAS CAS
I/O4
322
13
4 23
12
2425
26
518171615141211109
I/O3I/O2I/O1
514400J
C52
0
0.1µ
50
12
R54701 2
(01XD) RAS0-N
(01XD)CAS-N
(01XC) RAS2-N
(01XC) RAS1-N
<512>
<256>
DQ1DQ1
DQ2DQ2
WEWE
RASRAS
NCA9
A0A0
A1A1
A2A2
A3A3
Vcc
1
2
3
4
5
9
10
11
12
13
26
25
24
23
22
18
17
16
15
14Vcc
VssVss
DQ4DQ4
DQ3DQ3
CASCAS
OEOE
A8A8
A7A7
A6A6
A5A5
A4A4
IC11
1M Mask
27C1001
27512
IC2
1 2 3 (1) 4 (2) 5 (3) 6 (4) 7 (5) 8 (6) 9 (7) 10 (8) 11 (9) 12 (10) 13 (11) 14 (12) 15 (13) 16 (14)
NC A16 A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 D0 D1 D2 GND
VPP A16 A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 DO D1 D2 GND
- - A15 A12 A7 A6 A5 A4 A3 A2 A1 A0 DO D1 D2 GND
- - VCC A14 A13 A8 A9 A11 OE/VPP A10 CE D7 D6 D5 D4 D3
VCC PGM NC A14 A13 A8 A9 A11 OE A10 CE D7 D6 D5 D4 D3
VCC NC NC A14 A13 A8 A9 A11 OE/OE A10 CE/CE D7 D6 D5 D4 D3
32 31
(28) 30 (27) 29 (26) 28 (25) 27 (24) 26 (23) 25 (22) 24 (21) 23 (20) 22 (19) 21 (18) 20 (17) 19 (16) 18 (15) 17
GND
VCCNCVPPCEOEPGM
A0A1A2A3A4A5A6A7A8A9A10A11A12A13A14A15A16 Q7
21
3124221
303216
23
29284
25232627
56789
101112
20191817151413
Q6Q5Q4Q3Q2Q1Q0
(016E) RD-N
C50
1
0.1µ
50
12 (016C) ROMCS-N
Vcc=+5V, Ground=0V
SOCKETIC2
IC3 27C100174LS373
1D2Q3Q4Q5Q
6Q7Q8Q
1Q2D3D4D5D6D7D8DENOC
2
111181714138743
569
12151619
(016D) AD07-P(016F) BANK(016C) A15-P(016C) A14-P(016C) A13-P(016C) A12-P(016C) A11-P(016C) A10-P(016C) A09-P(016C) A08-P
(016D) AD06-P(016D) AD05-P(016D) AD04-P(016D) AD03-P(016D) AD02-P(016D) AD01-P(016D) AD00-P
(016E) ALE-P
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 37 -
NOMOUNTNOMOUNT
CH10CH9
1 1
CN7
4M-DMOTOR
IC10
+5V
(01XF) DMON-P
R54
2
1K0.
11
2R
541
C52
4
22K
5022
00p
0.1
1
12
R54
0
C52
3
MIN
_W:1
.27m
m
C4
4.3K
0.1µ
50
47µ
50
0.1
1 1
21
+
2
2
2
R543 1222K 0.1
B
A C
D
E
0V
0V0V
C5251 2
0.1µ 50
+5V
+24V
ZA21ZA20
11
0Vp
30NC6 13
119642
10
5
24
12
8
7
3
NC5NC4NC3NC2NC1
RSB
RSA
NALM
OUT4
OUT3
OUT2
OUT1
29
141
1528
1918
21
20
22
23
25
16
17
27
26
GND2 GND1
VMM2 VMM1
LGB
LGA
VCC DCAY
VSB
REFB
REFA
CR
NENB
NENA
PHAB
PHAA
VSA
MIN_W:1.27MIN_W:1.27
MTD2005F MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN_W:0.635mm
MIN
_W:0
.635
mm
CN71
CN72
CN73
CN74
IM=0.38A
R1
1 20.
52
R2
1 20.
52
0Vp
DMPH2-N
DMPH2-P
DMPH1-N
DMPH1-P
+5V
R541
1K
6.2K
0.1
2
R551
0.1
2
(01XF) PJON-P
(01GE) FANON-P
Q5
22K
22K
2
3
1
0V
OVP
+24V
CN8
2M-PJ
Q4
3
3
2SA1338
SS100MA80VACP
2
2
1
1D3
MIN_W:0.635
MIN
_W:0
.635
MIN_W:0.635
CN81
CN82
PJON
OVP
NOMOUNT
CN3
2M-Fan
NOMOUNT
NOMOUNT
NOMOUNT
NO
MO
UN
T
NOMOUNT
2
2
2
22K
22K
1
13
R502Q502 10K 0.1
+24V
Q501
3
3
1
1
22SA1338
0V
D501
SS100MA80VACP
MIN_W:0.635mm
MIN_W:0.635mm
MIN
_W:0
.635
FANPOW
R50
11
10K
0.1
2
0VP
0VP
+5V
FANALM-N FANALM-N (01GF)
CN31
CN32
CN33
(01XF) DMPH1-P
(01XF) DMPH2-P0V
Figure 5-10 Main controller PCB(HBMC-3/7) Rev. 3Cicuit Diagram
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 38 -
Figure 5-11 Main controller PCB(HBMC-4/7) Rev. 3Cicuit Diagram
+5V
R5201 2330
R5191 20
R5131 2330
R5121 20
(01XE) VD0-P
(01XE) VD1-P
(01XE) VLD-P
(01XE) VCLK-P
(01XF) VSTB1-N
(01XE) VSTB2-N
(01XE) VSTB3-N
(01XE) VSTB4-N
SS100MA80VACP SS100MA80VACP
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNTNOMOUNT
SS100MA80VKCP SS100MA80VKCP
D1 D21
3
2 1
3
2
CN6
14F-LED
CN66
CN67
CN68
CN69
CN610
CN611
CN612
CN613
CN63
CN64
CN65
HDDT0-P
HDDT1-P
HDCLK-P
HDLD-P
STB1-N
STB2-N
STB3-N
STB4-N
D41
3
2D5
1
3
2
0V
5V
5V
0V
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
MIN_W:1.27mm
CN61 0VP
MIN_W:1.27mm
CN62 0VP
CN614 FG
MIN_W:1.27mm
+5V
1
1+
2
2
C52
6
C1
0.1µ
3300
µ 50
12
C16
0.01
µ 25
0
12
C8
0.01
µ 25
0
10
0V
0VP
FG1
FG2
FG
1
1
(01GE) EEPRMDT-P
(01GE) EEPRMCS-P
(01GE) EEPRMCLK-P
+5V
R53
7
C52
2
0.1µ
50
5.1K
0.1
1 1
2
R53
8
5.1K
0.1
12
R53
9
10K
0.1
12
2
0V
3
2
61
857
IC4
DI DONC1C8
VCCGND1NC2
4
0V
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 39 -
Figure 5-12 Main controller PCB(HBMC-5/7) Rev. 3Cicuit Diagram
+5V
CN4
36F-Centro
PDATA8-P CN49
PDATA7-P CN48
PDATA6-P CN47
PDATA5-P CN46
PDATA4-P CN45
PDATA3-P CN44
PDATA2-P CN43
PDATA1-P CN42
STB-NCN4
1
IPRIME-NCN4
31
SELIN-NCN4
36
AUTOFEED-PCN4
14
R302 122 0.1
R312 122 0.1
R292 122 0.1
R282 122 0.1
R252 122 0.1
R262 122 0.1
R272 122 0.1
R242 122 0.1
R5281 2100 0.1
R5142 11K 0.1
R5051 23.3K 0.1
R5151 23.3K 0.1
R522110K 0.1
R5211 210K 0.1
R5272 11K 0.1
R50
6
C51
5
560p
50
1
1
2
2
C50
6
1000
p50
12
C50
7
560p
50
12
C50
8
560p
50
12
1K0.
1
R50
41
21K
0.1
R51
6
3.3K
0.1
21
R50
9
3.3K
0.1
21
R50
7
3.3K
0.1
21
R50
8
3.3K
0.1
21
R51
7
3.3K
0.1
21
R51
8
3.3K
0.1
21
R52
4
3.3K
0.1
21
R52
3
3.3K
0.1
21
PDATA8-P(018D)
PDATA7-P (018D)
PDATA6-P(018D)
PDATA5-P (018D)
PDATA4-P(018D)
PDATA3-P (018D)
PDATA2-P(018D)
PDATA1-P (018D)
+5V
0V
0V
0V
0V
+5V
+5V NO
MO
UN
TN
OM
OU
NT
Vcc=+5V , Ground=0V
OC5 6
IC7
07
AUTOFD-N (018E)
SELIN-N (018E)
IPRIME-N (018E)
PSTB-N (018E)
+5V
+5V0V
C50
5
R38
0.1µ
50
1
1
2
2 3.3K
0.1
R37
12 3.3K
0.1
R35
12 3.3K
0.1
R36
12 3.3K
0.1
R43
12 3.3K
0.1
R44
12 3.3K
0.1
(01XE) BUSY-P
(01XE) ACK-N
(01XE) PE-P
(01XE) SEL-P
(01XE) FAULT-N
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
Vcc=+5V , Ground=0V
OC13 12
07
IC7
OC1 2
07
IC7
OC3 4
07
IC7
OC11 10
07
IC7
OC9 8
07
IC7
FG
C7
0.01
µ 25
0
12
C17
0.01
µ 25
0
12
0V
+5VR421 2
0
MIN_W:1.27mm
MIN_W:1.27mm
CN438 FG
CN437 FG
CN417 FG
CN418 5V
CN432 FAULT-N
CN413 SEL-P
CN412 PE-P
CN410 ACK-N
CN411 BUSY-P
CN435 HILEVEL
CN434 N/C
CN415 N/C
CN433 SG
CN430 SG
CN429 SG
CN428 SG
CN427 SG
CN426 SG
CN425 SG
CN424 SG
CN423 SG
CN422 SG
CN421 SG
CN420 SG
CN419 SG
CN416 SG
0V
CN4
36F-Centro
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 40 -
Figure 5-13 Main controller PCB(HBMC-6/7) Rev. 3Cicuit Diagram
+5VNOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNTNOMOUNT
NOMOUNT NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NOMOUNT
NO
MO
UN
T
NO
MO
UN
TN
OM
OU
NT
NO
MO
UN
T
NO
MO
UN
T
NOMOUNT
NO
MO
UN
T
NOMOUNT
IC9
OSCVOUT
LV
CAP+
CAP-
GND
V+C512
211000p 50
8
75
6
2
4
3
C6
10µ
16
21
+ C5
C51
6
10µ
0.1µ
50
16 2
2
1
1 C51
7
0.1µ
502
1
+
0V
0V
0V
SW1
21
34
21 DIPSW2 (014D)
DIPSW1 (014D)
+5V
RXD-P (01GF)
R5251 220 0.1
R5321 220 0.1
R5341 220 0.1
R5301 220 0.1
(01GF) TXD-P
(016F) XCLK-P
(06YE) RXD+(06YF) RXD-
2IC8
34
12
151413
567
11109
1681
7660
DS8925DIN1
DIN2
RIN1-
RIN2+
RIN2-
RIN3+
VCC
GND
VEE
DEN1
DOUT1+
DOUT1-
DOUT2-
ROUT1
ROUT2
ROUT3 0V
0V
0V
0V
C52
1
150p
50
12
C51
8
150p
50
12
C51
9
150p
50
12
CN5
TCS7187-01-201
CN56
TXD+
CN53
TXD-
R5291 220 0.1
R5441 20
R53
61
20.
120
0
200R
535
12
0.1
R5311 220 0.1
CN51
XCLK-N
CN57
+5V
CN54
CN58
SG
+5V
RXD+
CN55
RXD-
CN52
CN5FG
FG
FG
FG
9CN5
10CN5
11
HSK-IN
RXD+ (065B)
RXD- (065B)
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 41 -
Figure 5-14 Main controller PCB(HBMC-7/7) Rev. 3Cicuit Diagram
CN1
High-voltage
(01XG) SDB1-P
(01XG) SDB2-P
(01XG) DBPWM-P
(01XG) TR1PWM-P
(01XF) CHPWM-P
(01XG) TR2PWM-P
(016F) DCLED
R39
R40
C11
1 12 21K 0.1
R5 120
OC
NOMOUNT
LS07
1
1
2
2
3 4
0.11K
R41 12 5 6
9 8
11 10
0.1300
R34 120.1220
R32 210.1300
R33 210.1300
R7 120
R9 120
R13 120
R11 120
R22Q2
Q1
1210K
2SA1338
0.1
0.047µ 50
C1021
0.022µ 50
C1821
0.022µ 50
C1912
2
1
1
2
33
0.022µ 50
R3 120
OC
NOMOUNT
NOMOUNT
LS07
OC
LS07
NOMOUNT
OC
LS07
IC1
IC1
IC1
IC1
NOMOUNT
OC
LS07
IC1
13 12
NOMOUNT
NO
MO
UN
TN
OM
OU
NT
NO
MO
UN
T
NO
MO
UN
T
NO
MO
UN
TN
OM
OU
NT
NOMOUNT NOMOUNT
NOMOUNT
OC
LS07
IC1
Vcc=+5V , Ground=0V
22K
22K
0V
+24V
+5V
C9
0.1µ
50
12
0V
11 0VCN110 0VCN1 9 0VCN1 7 0VCN1 5 0VCN1
17 5VCN115 5VCN1
23CN1 CVOPN-N (014D)
CVOPN-N
1CN1PSOUT-N PSOUT-N (014D)
16CN1WRSNS-N
19CN1PSIN-N
21CN1TNRSNS-N
13CN1
6CN1
22CN1
3CN1
TEMP TEMP (013E)
TNRSNS-N (014D)
PSIN-N (014D)
WRSNS-N (014D)
(016G) LED-P LED-P
DCLED-P
+5V
1 2R19
100K 0.12 1R56
200K 0.1
1 2R545
4.7K 0.1
12
R15
10K
0.1
12
R12
510
0.1
12
R14
510
0.1
12
R10
510
0.1
12
R8
3.3K
0.1
12
R4
3.3K
0.1
12
R6
3.3K
0.1
12
R16
10K
0.1
12
R17
10K
0.1
12
R18
10K
0.1
21
R20
1.2K
0.1
21
R21
1K0.
1
12
R50
3
10K
0.1
1
1
12
+2
2R
23
C50
2
C3
0.1µ
50
47µ
161
2+
C2
47µ
50
1K0.
1
TR-ISEN (014E)TR-ISEN 12
CN14CN1
TR-VSEN (014E) TR-VSEN
TR2PWM-P
2CN1 CHPWM-P
8CN1 TR1PWM-P
DBPWM-P14
CN1
SDB2-P20
CN1
SDB1-P18
CN1
+5V
+5V
0V
0V0V
0V0V
+5V
+5V+5V
+5V
3
24
1
8+
-
5
64
7
8+
-
(016F) HEATON-P
IC20
IC20
393
3932.2K
10K
Q3
2
1
3
CN28
CN2NC
7
CN20V
4
CN20V
3
CN25V
2
CN25V
1
CN20VP
5
CN224V
+24V
6
HEATON-N
10V
+5V
0VP
CN2
Power
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
1 2 3 4 5 6 87 9 X Y
A
B
C
D
E
F
G
H
- 42 -
10DBPWM-P
SDB1-P
CN1
6CN1
SDB2-P 4CN1
TR1PWM-P 16CN1
TR2PWM-P 20CN1
CHPWM-P
(017D) VSEN TR-VSEN
22CN1
12CN1
(01XE) ISEN TR-ISEN21CN1
(015G) TNRSNS TNRSNS-N3CN1
(015G) PSIN PSIN-N5CN1
(015G) WRSNS WRSNS-N8CN1
(015G) PSOUT
(012F) THERM TEMP
PSOUT-N23CN1
11CN1
2CN1
LED
1CN1
7CN1
9CN1
+5V
H5V
H5V
R118CVOPN-N
1 2
G
G
G
G
G
5V
5V
4.7K 0.25
CVSW
13
2N.O
N.C
LED-P
18CN1
DCLED-P
13CN1
0V
14CN1
1CN2
2CN2
0V
15CN1
0V
17CN1
0V
19CN1
0V
LED24V
1 2
SEL3910D-YZ
GND
GND
GGND
CN31
GNDCN32
+5V
+5V
G
TH
5V
THERM (011D)
GND
GND GND
GND
GND
GND
GND
H5V
H5V
GND
GND
H5V
G
R47
1 130
0.252
R48
C31
2
0.1µ
50
12
NO
MO
UN
T
1 130
0.252
1
2
3
4
PS1SG-206 1
2
3
4
PS2SG-206 1
2
3
4
PS3SG-206 1
2
3
4
PS4SG-206
G
TNRSNS (011C)PSIN (011C)
PSOUT (011C)
WRSNS (011C)
G G
6
5
G
GG
G
G
G
G
3
3
2
1
32
1
Q16
22 1
1
Q17
Q15
2SC2235-Y
2SC2235-Y
2SC2235-Y
D82
D62
C25
1
0.1µ
50
470p
3.15
K
D76
RD
27E
-B1
RD
22E
-B
EU
02A
EU
02A
12
12
12
D71
1
1
2
2
1 1
2 2C31
1
C11
7
R11
9
100M
0.50.
1µ50
12
C31
0
C11
4
C11
6
C11
5
D69
D68
D87
RD
200E
-B
R11
5
576K
0.2
5
C11
9
470p
1K
C30
1
C11
1
C30
2
D67
C11
2C30
0
D61
R23
4
330.
25
R10
5
R12
2
C10
3
C10
4
D58
39p
500
470p
1K
C10
8
0.1µ
50
0.1µ
50
0.1µ
50
0.1µ
50
10µ
63
5.1k
0.252
2
1
R12
3
1k0.
2521
R12
4
R12
1
R22
9
D52
D55
D56
D85
D84
D83
D81
470V
Q11
C10
5
C24
1 C10
2
L10
C23
7
C23
6
1
1
12
+2
21000
µC-1
4576
1ZB
300-
Y/Z
5.1K
0.25
1
1
1
1
1
11
1
1
1
1 122
2 2
2 22
2
2
2
32
2
2
R11
2
Q13
C24
0 C10
7
5.1k
BC
R1A
M-1
2
BC
R1A
M-1
2
CR
04A
M-1
2
1ZB
300-
Y/Z
0.25
5.1k
0.25
211
2
2
2
10M
0.252
2
21
12
1
1
1R
111
2
10M
0.25
1
13
24K
4700
p
470p
6K
1ZB
390
D66
D65
1ZB
390
R11
4
470p
0.04
7µ 5
0
0.1µ
50
3.15
K
DH
M3F
J60/
ES
JA58
-06
DHM3FJ60/ESJA58-06
DHM3FJ60/ESJA58-06
DHM3FJ60/ESJA58-06
100
0.25
1
1
11
1
1 1
1
2
122
22
2
22
2
11
1
1 100M
0.52
2
2
2
0.1µ
50
0.1µ
50
0.1µ
50
0.1µ
50
1
1
1
11
1
1
2
2
2
12
22
2
2
C11
8
0.01
µ100
12
4
32
1
1
1
5
5
6
1
12
1 12 2 2
6
23
4
23
4
1
T4
T3
T2
Hi-Voltage_Trans
Hi-Voltage_Trans
Hi-Voltage_Trans
D722
21
R228
1M 0.25
D59
EU02A
R104
R102
0.25 75K1 1
12 2
2
VSEN (011C)
D60
1S953/1S2075K/1S2473
1S95
3/1S
2075
K/1
S24
73
1S95
3/1S
2075
K/1
S24
731S
953/
1S20
75K
/1S
2473
C1100.1µ
50
C113 D63 R113
470p 3.15K
D74
100K 0.25
+5V
ISEN (011C)
J8
J71
1 2
2
J1
J21
1 2
2
J3
J41
1 2
2
J6
J51
1 2
2
J10
J91
1 2
2
J11
J121
1 2
2
G
1 2
R103
1K 0.251 2
R116
330 0.251 2
R100
3M 0.2511 1 22 2
330 0.25
32
1
Q21
32
1
Q22
32
1
11 1
1
2 2
2
2Q10
D51
32
1
Q23
H5V
2SC1815-Y
2SC1815-Y
2SC1815-Y
C106
470p 500
D57
EU02A
EU
02A
G
G
G
2SC2752
EU02A
EU
02A
EU
02A
EU
02A
EU
02A
C101
470p 500
470p
1K
470p
500
39p
500
3
Q12
R233
R231
1M
10M
0.25
0.25
Figure 5-8 High voltage power supply PCB(OLHV-1/1) Rev. 6, 7
or (TLHV-1/1) Rev.3Cicuit Diagram
COMPONENT PARTS LIST
Drawing List
Main Control Board (HBMC PCB, Rev. 2) 4YA4121-2516G002
Main Control Board (HBMC PCB, Rev. 3) 4YA4121-2516G002
High Voltage Power Supply Board (OLHV PCB, Rev.6) 4YA4130-1004G1
High Voltage Power Supply Board (OLHV PCB, Rev.7) 4YA4130-1004G1or(TLHV PCB, Rev.2) 4YA4130-1024G1
- 1 -
IC2
CN
6
R15
R3
R5 R
7R
9
R11
R13C9
R16
R17
R18
R19
R56
R20
R21IC
3
IC4
IC10
1 213 14
IC7
1 19
18 36
CN
4
IC20
OS
C1R33
R23
R24R27R26R25R28R29R31R30R37R38R35R36R43R44R42
C19
C18C10
C11
C15
SP1
A B31
R32
R34
R51
R1
11 2 4
R2
CN7
R50
R52
R54
Q5
Q4 D3CN8
R55
C13
C12C14
R39R40
R41
IC11
12
16
1514302917
CN9
IC5
Q3
C2
IC6
C3
CN2CN1
18C7
C17
C4
C16
C8
C1
60 65
65
63
62
R506R508R507
R509R516
R517R518
R524R523
R504
R505
R515 R512
R503
C503
C509
C620
R510
R537R538
R545
C511
C510
R513
R520R519R522
R521
R514
C505
C526
C50
2
C50
4
C52
2R
546
R54
7R
526
C51
3
C50
1
C51
4
R54
9R
548
R55
0
R52
8
R53
9
R54
0
R54
1
R54
2R
543
C52
3
C52
4
C52
5
R52
7C
515
C506
HBMC Printed Circuit BoardREV.2(4YA4121-2516G2-1/2)
IC2
CN
6
R15
R3
R5 R
7R
9
R11
R13C9
R16
R17
R18
R19
R56
R20
R21IC
3
IC4
IC10
1 213 14
IC7
1 19
18 36
CN
4
IC20
OS
C1R33
R23
R24R27R26R25R28R29R31R30R37R38R35R36R43R44R42
C19
C18C10
C11
C15
SP1
A B31
R32
R34
R51
R1
11 2 4
R2
CN7
R50
R52
R54
Q5
Q4 D3CN8
R55
C13
C12C14
R39R40
R41
IC11
12
16
1514302917
CN9
IC5
Q3
C2
IC6
C3
CN2CN1
18C7
C17
C4
C16
C8
C1
61 66
66
64
63
R506R508R507
R509R516
R517R518
R524R523
R504
R505
R515 R512
R503
C503
C509
C620
R510
R537R538
R545
C511
C510
R513
R520R522R521
R514
C505
C526
C50
2
C50
4
C52
2R
546
R54
7R
526
C51
3
C50
1
C51
4
R54
9R
548
R55
0
R52
8
R53
9
R54
0
R54
1
R54
2R
543
C52
3
C52
4
C52
5
R52
7C
515
C506
- 6 -
HBMC Printed Circuit BoardREV.3(4YA4121-2516G2-1/2)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 2 -
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
D3
R24-R31
R528
R526
R3,R5,R7,R9,R11,R13,R42,R50,R52,R510,R512R513,R519,R520,R546-R550
R34,R41
R32,R33
R21,R23,R39,R40,R54R504,R506,R514,R527
R533,R537,R538
R15-R18,R55,R503R521,R522,R539
R543
R19
R35-R38,R43,R44,R505,R507-R509,R515-R518,R523,R524
R20
R1,R2
SS100MA80VACPSignal Diode
RM73B2A220JRN Resistor
RM73B2A101JRN Resistor
RM73B2A151JRN Resistor
2125JPWChip Jumper
RM73B2A221JRN Resistor
RM73B2A301JRN Resistor
RM73B2A102JRN Resistor
RM73B2A512JRN Resistor
RM73B2A103JRN Resistor
RM73B2A223JRN Resistor
RM73B2A104JRN Resistor
RM73B2A332JRN Resistor
RM73B2A122JRN Resistor
MSF1/2B2 ΩJRS Resistor
611A0000N0001
323A5003J0220
323A5003J0101
323A5003J0151
323A5003P0001
323A5003J0221
323A5003J0301
323A5003J0102
323A5003J0512
323A5003J0103
323A5003J0223
323A5003J0104
323A5003J0332
323A5003J0122
324A1001J0209
1
8
1
1
19
2
2
9
3
9
1
1
16
1
2
HBMC Printed Circuit Board Rev. 2(4YA4121-2516G2-2/2-1/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 3 -
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
R545
R542
R540
R51
R541
R56
C515
C506
C10,C11,C18,C19
C9,C12-C15,C501-C505,C509-C511,C513,C514C520,C522,C523,C525,C526
C524
C7,C8,C16,C17
C1
C2,C4
C3
IC3
RM73B2A472JRN Resistor
RM73B2A102FRN Resistor
RM73B2A432FRN Resistor
RM73B2A362FRN Resistor
RM73B2A223FRN Resistor
RM73B2A204JRN Resistor
CC2012SL1H561J 50VCC Capacitor
CK2012B1H102K 50VCK Capacitor
CK2012B1H223K 50VCK Capacitor
CK2012F1H104Z 50VCK Capacitor
CK2012B1H222K 50VCK Capacitor
TCK45F2E103ZYA 250VCK Capacitor 10000pF
UVS1A332MHA 10VCE Capacitor 3300pF
KME50VB-47 50VCE Capacitor 47UF
SME16VB-47-0A 16VCE Capacitor 47UF
SN74LS373NSBIP Digital IC
323A5003J0472
323A5003F0102
323A5003F0432
323A5003F0362
323A5003F0223
323A5003P0204
303A3007K0561
303A6008K3102
303A6008K3223
303A6008Z3104
303A6008K3222
302A4027Z5103
304A1137A1332
304A1115H1470
304A1123C1470
700A0550N0373
1
1
1
1
1
1
1
1
4
20
1
4
1
2
1
1
HBMC Printed Circuit Board Rev. 2(4YA4121-2516G2-2/2-2/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 4 -
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
IC4
IC11
IC10
IC7
IC5
IC20
IC6
SP1
CN1
CN2
CN6
CN8
CN4
93LC46A-NWMOS-EEPROM
514256JP-70MOS-D-RAM
MTD2005FBIP Linear IC
7407FPBIP Digital IC
PST592D-2BIP Linear IC
UPC393G2BIP Linear IC
MSM65917-012GS-KMOS-CPU(ROM)
IMSA9202B-1-03Z013GFPC Connector
00-5062-301-023-000PC Connector
B8B-XH-APC Connector
ZC-014PC Connector
00-8263-0211-00-000PC Connector
36FAGL-M3Square Type Connector
816A0303M0000
8020003N0601
720A1816N0001
700A0003N0007
720A4037M0015
720A0523N0011
8530193N0012
224A4082P0030
224A5114P0230
224A3530P0080
224A3590P0140
224A3358P0020
220A0122P0360
1
1
1
1
1
1
1
1
1
1
1
1
1
HBMC Printed Circuit Board Rev. 2(4YA4121-2516G2-2/2-3/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 5 -
52
53
54
55
56
57
58
59
60
61
62
63
64
65
CN7
CN9
Q3,Q5
Q4
OSC1
00-8236-0411-00-000PC Connector
TX25-30P-LT-H1PC Connector
DTC124EKNPN-HF-TR
2SA1338PNP-HF-TR
CST10.0MTWOscilator
328-1G7IC Socket
TW-VF-23-210-BFlexible Cable
IMSA-9206H-GFPC Connector
TUBE (black)L=4
224A3358P0040
224A4172P0300
602A1035N0004
600A1032N0010
381A1045B0014
245A1058P0280
238A1123P0002
224A4080P0020
4PP4010-1002P004
1
1
2
1
1
1
1
1
4
HBMC Printed Circuit Board Rev. 2(4YA4121-2516G2-2/2-4/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 6 -
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 7 -
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
D3
R513,R520
R55
R24-R31
R528
R526
R3,R5,R7,R9,R11,R13R42,R50,R52,R510,R512,R546-R550
R34
R32,R33,R41
R21,R23,R39,R40,R54,R504,R506,R514,R527
R533,R537,R538
R15-R18,R503,R521,R522,R539
R543
R19
R35-R38,R43,R44,R505,R507-R509,R515-R518,R523,R524
SS100MA80VACPSignal Diode
RM73B2A331JRN Resistor
RM73B2A622JRN Resistor
RM73B2A220JRN Resistor
RM73B2A101JRN Registor
RM73B2A151JRN Resistor
2125JPWChip Jumper
RM73B2A221JRN Resistor
RM73B2A301JRN Resistor
RM73B2A102JRN Resistor
RM73B2A512JRN Resistor
RM73B2A103JRN Resistor
RM73B2A223JRN Resistor
RM73B2A104JRN Resistor
RM73B2A332JRN Resistor
611A0000N0001
323A5003J0331
323A5003J0622
323A5003J0220
323A5003J0101
323A5003J0151
323A5003P0001
323A5003J0221
323A5003J0301
323A5003J0102
323A5003J0512
323A5003J0103
323A5003J0223
323A5003J0104
323A5003J0332
1
2
1
8
1
1
16
1
3
9
3
8
1
1
16
HBMC Printed Circuit Board Rev. 3(4YA4121-2516G2-2/2-1/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 8 -
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
R20
R1,R2
R545
R542
R540
R51
R541
R56
C515
C506
C10,C18,C19
C9,C12-C15,C501-C505,C509-C511,C513,C514C520,C522,C523,C525,C526
C524
C7,C8,C16,C17
C1
C2,C4
C3
RM73B2A122JRN Resistor
MSF1/2B 2ΩJRS Resistor
RM73B2A472JRN Resistor
RM73B2A102FRN Resistor
RM73B2A432FRN Resistor
RM73B2A362FRN Resistor
RM73B2A223FRN Resistor
RM73B2A204JRN Resistor
CC2012SL1H561J 50VCC Capacitor
CK2012B1H102K 50VCK Capacitor
CK2012R1H223K 50VCK Capacitor
CK2012F1H104Z 50VCK Capacitor
CK2012B1H222K 50VCK Capacitor
TCK45F2E103ZYA 250VCK Capacitor 10000pF
UVS1A332MHA 10VCE Capacitor 3300µF
KME50VB-47 50VCE Capacitor 47UF
SME16VB-47-0A 16VCE Capacitor 47UF
323A5003J0122
323A1001J0209
323A5003J0472
323A5003F0102
323A5003F0432
323A5003F0362
323A5003F0223
323A5003J0204
303A3007K0561
303A6008K3102
303A6008K3223
303A6008Z3104
303A6008K3222
302A4027Z5103
304A1137A1332
304A1115H1470
304A1123C1470
1
2
1
1
1
1
1
1
1
1
3
20
1
1
4
1
2
1
HBMC Printed Circuit Board Rev. 3(4YA4121-2516G2-2/2-2/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 9 -
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
C11
IC3
IC4
IC11
IC10
IC7
IC5
IC20
IC6
SP1
CN1
CN2
CN6
CN8
CK2012F1H473Z 50VCK Capacitor
SN74LS373NSBIP Digital IC
93LC46A-NWMOS-EEPROM
514256JP-70MOS-D-RAM
MTD2005FBIP Linear IC
7407FPBIP Digital IC
PST592D-2BIP Linear IC
UPC393G2BIP Linear IC
MSM65917-014GS-KMOS-CPU(ROM)
IMSA9202B-1-03Z013GFPC Connector
00-5062-301-023-000PC Connector
B8B-XH-APC Connector
ZC-014PC Connector
00-8263-0211-00-000PC Connector
303A6008Z3473
700A0550N0373
816A0303M0000
8020003N0601
720A1816N0001
700A0003N0007
720A4037M0015
720A0523N0011
8530193N0014
224A4082P0030
224A5114P0230
224A3530P0080
224A3590P0140
224A3358P0020
1
1
1
1
1
1
1
1
1
1
1
1
1
1
HBMC Printed Circuit Board Rev. 3(4YA4121-2516G2-2/2-3/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 10 -
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
CN4
CN7
CN9
Q5
Q4
Q3
OSC1
36FAGL-M3Square Type Connector
00-8263-0411-00-000PC Connector
TX25-30P-LT-H1PC Connector
DTC124EKNPN-HF-TR
2SA1338PNP-HF-TR
DTC123YKNPN-HF-TR
CST10.0MTWOscilator
DICF-28CS-EIC Socket
TW-VF-23-210-BFlexible Cable
IMSA-9206H-GFPC Connector
TUBE (black)L=4
220A0122P0360
224A3358P0040
224A4172P0300
602A1035N0004
600A1032N0010
602A1035N0019
381A1045B0014
245A1221P0280
238A1123P0002
224A4080P0020
4PP4010-1002P004
1
1
1
1
1
1
1
1
1
1
4
HBMC Printed Circuit Board Rev. 3(4YA4121-2516G2-2/2-4/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 11 -
OLHV Printed Circuit BoardREV.6(4YA4130-1004G1-1/2)
D57
D55
D58
D61
D60
D52
D67
D69
D68
D71
D76
D59
D56
C105
R122
LED
C237
C110
D84
D63
D62Q
15
D72
D87
R48
D83
D65 D
66
D74
D82
D85
D81
D51
R23
3
R23
1R
47
R10
2
R12
1
R10
0
R11
1
C24
0
C10
8C
104 C
241 C10
6
C10
3
C11
8 C25
1
C31
0C
311
C11
3
C30
0
Q16
C10
1
C10
7
C10
2
J30
J7
J1 J2
J42
J9
J11
J12
J10
J29
J43
J5 J6
J25
J8
J31
R11
6R
103
R12
4R
123
J32
J27
J23
Back side
Back side
J4
J3
J35J33
J34J36
J37
J40
J41
J39
J38
J24
J26
L10
J28C119
C112
CN2
CVSW
C117
C114
J21 J22
R112
R119
R229
R234
R115
R104R105
R113R114
C301
CN3
C302C111
C115
C116
CN1
T4
T3T2
1
2
23
C236
R118
R228
Q13
Q23
Q22
PS2
PS1
PS4
C
C
C
PS3
C
Q21
Q17
Q10
Q11
Q12
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 12 -
OLHV Printed Circuit Board Rev. 6(4YA4130-1004G1-2/2-1/4)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
D60,D61,D68,D69
D63, D67, D72, D74
D51, D55-59, D62,D71, D81,D84
D52,D85
D65,D66
D87
D76
D82
D83
R234
R47,R48
R102,R116
R103,R123
R118
R121,R122,R124,R229
1S953/1S2075K/1S2473Signal Diode
DHM3FJ60/ESJA58-06Rectifier Diode
EU02ARectifier Diode
1ZB300-Y/ZZener Diode
1ZB390Zener Diode
RD200E-BZener Diode
RD22E-B2Zener Diode
RD27E-B1Zener Diode
D05-471Varistor
RD1/4Y33ΩJRD Resistor
RD1/4Y130ΩJRD Resistor
RD1/4Y330ΩJRD Resistor
RD1/4Y1KΩJRD Resistor
RD1/4Y4.7KΩJRD Resistor
RD1/4Y5.1KΩJRD Resistor
611A0003L0001
610A0003M0002
610A0226M0016
613A2003M0001
613A2258M0350
613A1231L0522
613A1231L0262B
613A1231L0282A
632A0200M1470
321A1421J0330
321A1421J0131
321A1421J0331
321A1421J0102
321A1421J0472
321A1421J0512
4
4
10
2
2
1
1
1
1
1
2
2
2
1
4
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 13 -
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
R105
R104
R113
R228,R233
R100
R115
R111,R112,R231
R114,R119
C105,C107,C119
C113,C114,C117
C112
C240,C241
C101,C102,C106
C103,C104,C108,C110,C111,C115,C237,C251,C300,C301,C310,C311
C116
RD1/4Y24KΩJRD Resistor
RD1/4Y75KΩJRD Resistor
RD1/4Y100KΩJRD Resistor
RD1/4Y1MΩJRD Resistor
RD1/4Y3MΩJRD Resistor
RNL1/4C3F576KΩRN Resistor
HMP1/4-106JRN Resistor
HMV1/2C107KRK Resistor
DE0705B471K1K 1KVCK Capacitor 470pF
DE0707B471K3K 3.15KVCK Capacitor 470pF
DE1010B471K6K 6KVCK Capacitor 470pF
DD05-63SL390J500CC Capacitor 39pF
DD05-63B471K500 500VCK Capacitor 470pF
FK16Y5V1H104ZCK Capacitor
FK16Y5V1H473ZCK Capacitor
321A1421J0243
321A1421J0753
321A1421J0104
321A1421J0105
321A1421J0305
323A1222F5763
323A1029J0106
326A3020K0107
302A4028K0471A
302A4028K2471
302A4028K4471
302A1202K0390
302A4003K6471
303A4019Z3104
303A4019Z3473
1
1
1
2
1
1
3
2
3
3
1
2
3
12
1
OLHV Printed Circuit Board Rev. 6(4YA4130-1004G1-2/2-2/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 14 -
OLHV Printed Circuit Board Rev. 6(4YA430-1004G1-2/2-3/4)
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
C118
C302
C236
Q11,Q13
Q12
Q21-Q23
Q15-Q17
Q10
L10
T2,T3,T4
PS1-PS4
CQMF92PP2A103J-F0CQ Capacitor 0.010µF
CQMF92PP2A472J-F0CQ Capacitor 0.0047µF
SME63VB-10-0A 63VCE Capacitor 10µF
BCR1AM-12Gate Thyristor SW
CR04AM-12Gate Thyristor OFF
2SC1815-YNPN-HF-TR
2SC2235-YNPN-HF-TR
2SC2752NPN-HF-TR
C-14576P Coil
High Voltage Transformer
SG-206Photocoupler
306A4103J2103
306A4103J2472
304A1123J1100
622A0022M0014
620A0022M0008
602A1025M0006Y
602A1125M0039Y
602A1223M0039
350A2511P0102
4YB4049-7078P003
652A0114M0003
1
1
1
2
1
3
3
1
1
3
4
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 15 -
54
55
56
57
58
59
60
61
62
63
64
OLHV Printed Circuit Board Rev. 6(4YA4130-1004G1-2/2-4/4)
CVSW
LED
CN1
CN2
CN3
J1,J2
J3-J12
J21-J43
SS-5GL13Microswitch
SEL3910D-YZLED
23FE-BT-VK-NPC Connector
53254-0210PC Connector
00-8263-0212-00-000PC Connector
0.65 Tin-plated Annealed CopperWire
0.65 Tin-plated Annealed CopperWire
0.65 Tin-plated Annealed CopperWire
207A1025P0001
650A0229M0018
224A4134P0230
224A4407P0020
224A3357P0020
TA-0.65
TA-0.65
TA-0.65
1
1
1
1
1
2
10
23
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 16 -
D57
D55
D58
D61
D60
D52
D67
D69
D68
D71
D76
D59
D56
C105
R122
LED
C237
C110
D84
D63
D62
Q15
D72
D87
R48
D83
D65 D
66
D74
D82
D85
D81
D51
R23
3
R23
1R
47
R10
2
R12
1
R10
0
R11
1
C24
0
C10
8C
104 C
241
C10
6
C10
3
C11
8 C25
1
C31
0C
311
C11
3
C30
0
Q16
C10
1
C10
7
C10
2
J30
J7
J1 J2
J42
J9
J11
J12
J10
J29
J43
J5 J6
J25
J8
J31
R11
6R
103
R12
4R
123
J32
J27
J23
J4
J3
J35J33
J34J36
J37
J40
J41
J39
J38
J24
J26
L10
J28C119
C112
CN2
CVSW
C117
C114
J21 J22
R112
R119
R229
R234
R115
R104R105
R113R114
C301
C302C111
C115
C116
CN1
T4
T3T2
1
2
23
C236
R118
R228
Q13
Q23
Q22
PS2
PS1
PS4
C
C
C
PS3
C
Q21
Q17
Q10
Q11
Q12
OLHV Printed Circuit Board orREV.7(4YA4130-1004G1-1/2)
TLHV Printed Circuit BoardREV.3(4YA4130-1024G1-1/2)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 17 -
OLHV Printed Circuit Board Rev. 7(4YA4130-1004G1-2/2-1/4)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
D60,D61,D68,D69
D63, D67, D72, D74
D51, D55-59, D62,D71, D81,D84
D52,D85
D65,D66
D87
D76
D82
D83
R234
R47,R48
R102,R116,R121
R103,R123
R118
R122,R124,R229
1S953/1S2075K/1S2473Signal Diode
DHM3FJ60/ESJA58-06Rectifier Diode
EU02ARectifier Diode
1ZB300-Y/ZZener Diode
1ZB390Zener Diode
RD200E-BZener Diode
RD22E-B2Zener Diode
RD27E-B1Zener Diode
ERZV05D471Varistor-Resistor
RD1/4Y33ΩJRD Resistor
RD1/4Y130ΩJRD Resistor
RD1/4Y330ΩJRD Resistor
RD1/4Y1KΩJRD Resistor
RD1/4Y4.7KΩJRD Resistor
RD1/4Y5.1KΩJRD Resistor
611A0003L0001
610A0003M0002
610A0226M0016
613A2003M0001
613A2258M0350
613A1231L0522
613A1231L0262B
613A1231L0282A
6320229M0001
321A1421J0330
321A1421J0131
321A1421J0331
321A1421J0102
321A1421J0472
321A1421J0512
4
4
10
2
2
1
1
1
1
1
2
3
2
1
3
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 18 -
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
R105
R104
R113
R228,R233
R100
R115
R111,R112,R231
R114,R119
C105,C107,C119
C113,C114,C117
C112
C240,C241
C101,C102,C106
C103,C104,C108,C110,C111,C115,C237,C251,C300,C301,C310,C311
C116
RD1/4Y24KΩJRD Resistor
RD1/4Y75KΩJRD Resistor
RD1/4Y100KΩJRD Resistor
RD1/4Y1MΩJRD Resistor
RD1/4Y3MΩJRD Resistor
RNL1/4C3F576KΩRN Resistor
HMP1/4-106JRN Resistor
HV-38-100MKRK Resistor
DE0705B471K1K 1KVCK Capacitor 470pF
DE0707B471K3K 3.15KVCK Capacitor 470pF
DE1010B471K6K 6KVCK Capacitor 470pF
DD05-63SL390J500CC Capacitor 39pF
DD05-63B471K500 500VCK Capacitor 470pF
FK16Y5V1H104ZCK Capacitor
FK16Y5V1H473ZCK Capacitor
321A1421J0243
321A1421J0753
321A1421J0104
321A1421J0105
321A1421J0305
323A1222F5763
323A1029J0106
326A3021K0107
302A4028K0471A
302A4028K2471
302A4028K4471
302A1202K0390
302A4003K6471
303A4019Z3104
303A4019Z3473
1
1
1
2
1
1
3
2
3
3
1
2
3
12
1
OLHV Printed Circuit Board Rev. 7(4YA4130-1004G1-2/2-2/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 19 -
OLHV Printed Circuit Board Rev. 7(4YA430-1004G1-2/2-3/4)
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
C118
C302
C236
Q11,Q13
Q12
Q21-Q23
Q15-Q17
Q10
L10
T2,T3,T4
PS1-PS4
CQMF92PP2A103J-F0CQ Capacitor 0.010µF
CQMF92PP2A472J-F0CQ Capacitor 0.0047µF
SME63VB-10-0A 63VCE Capacitor 10µF
BCR1AM-12/MAC97-008Gate Thyristor SW
CR04AM-12Gate Thyristor OFF
2SC1815-YNPN-HF-TR
2SC2235-YNPN-HF-TR
2SC2752NPN-HF-TR
C-14576P Coil
High Voltage Transformer
SG-206Photocoupler
306A4103J2103
306A4103J2472
304A1123J1100
622A0003M0001
620A0022M0008
602A1025M0006Y
602A1125M0039Y
602A1223M0039
350A2511P0102
4YB4049-7078P003
652A0114M0003
1
1
1
2
1
3
3
1
1
3
4
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 20 -
54
55
56
57
58
59
60
61
62
63
64
OLHV Printed Circuit Board Rev. 7(4YA4130-1004G1-2/2-4/4)
CVSW
LED
CN1
CN2
J1,J2
J3-J12
J21-J43
SS-5GL13Microswitch
SEL3910D-YZLED
23FE-BT-VK-NPC Connector
53254-0210PC Connector
0.65 Tin-plated Annealed CopperWire
0.65 Tin-plated Annealed CopperWire
0.65 Tin-plated Annealed CopperWire
207A1025P0001
650A0229M0018
224A4134P0230
224A4407P0020
TA-0.65
TA-0.65
TA-0.65
1
1
1
1
2
10
23
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 21 -
TLHV Printed Circuit Board Rev. 3(4YA4130-1024G1-2/2-1/4)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
D60,D61,D68,D69
D63, D67, D72, D74
D51, D55-59, D62,D71, D81,D84
D52,D85
D65,D66
D87
D76
D82
D83
R234
R47,R48
R102,R116,R121
R103,R123
R118
R122,R124,R229
R105
1S953/1S2075K/1S2473Rectifyingl Diode
DHM3FJ60/ESJA58-06Rectifying Diode
EU02ARectifying Diode
1ZB300-Y/ZZener Diode
1ZB390Zener Diode
RD200E-BZener Diode
RD22E-B2Zener Diode
RD27E-B1Zener Diode
ERZV05D471Zener Diode
RD1/4Y33ΩJRD Resistor
RD1/4Y130ΩJRD Resistor
RD1/4Y330ΩJRD Resistor
RD1/4Y1KΩJRD Resistor
RD1/4Y4.7KΩJRD Resistor
RD1/4Y5.1KΩJRD Resistor
RD1/4Y24KΩJRD Resistor
611A0003L0001
610A0003M0002
610A0226M0016
613A2003M0001
613A2258M0350
613A1231L0522
613A1231L0262B
613A1231L0282A
6320229M0001
321A1421J0330
321A1421J0131
321A1421J0331
321A1421J0102
321A1421J0472
321A1421J0512
321A1421J0243
4
4
10
2
2
1
1
1
1
1
2
3
2
1
3
1
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 22 -
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
R104
R113
R228,R233
R100
R115
R111,R112,R231
R114,R119
C105,C107,C119
C113,C114,C117
C112
C240,C241
C101,C102,C106
C103,C104,C108,C110,C111,C115,C237,C251,C300,C301,C310,C311
C116
C118
C302
RD1/4Y75KΩJRD Resistor
RD1/4Y100KΩJRD Resistor
RD1/4Y1MΩJRD Resistor
RD1/4Y3MΩJRD Resistor
RNL1/4C3F576KΩFRN Resistor
HMP1/4-106JRN Resistor
HV-38-100MKRK Resistor
CCHNY5P4B471KTB 1KVCK Capacitor 470pF
DE0707B471K3K 3.15KVCK Capacitor 470pF
DE1010B471K6K 6KVCK Capacitor 470pF
CCTLSL4B390JTB 500VCC Capacitor 39pF
CCHLY5P4B471KTB 500VCK Capacitor 470pF
FK16Y5V1H104ZCK Capacitor
FK16Y5V1H473ZCK Capacitor
MY2A103J-TCQ Capacitor 0.010µF
CQMF92PP2A472J-FOCQ Capacitor 0.0047µF
321A1421J0753
321A1421J0104
321A1421J0105
321A1421J0305
323A1222F5763
323A1029J0106
326A3021K0107
302A4058K7471A
302A4028K2471
302A4028K4471
302A1017K6390
302A4057K6471
303A4019Z3104
303A4019Z3473
3062001J2103
306A4103J2472
1
1
2
1
1
3
2
3
3
1
2
3
12
1
1
1
TLHV Printed Circuit Board Rev. 3(4YA4130-1024G1-2/2-2/4)
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 23 -
TLHV Printed Circuit Board Rev. 3(4YA430-1024G1-2/2-3/4)
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
C236
Q11,Q13
Q12
Q21-Q23
Q15-Q17
Q10
L10
T2,T3,T4
PS1-PS4
CVSW
UVX1J100MTO511(5.0) 63VCE Capacitor 10µF
BCR1AM-12/MAC97-008Bi-Directional Thyristor
CR04AM-12Gate Thyristor
2SC1740STransistor
2SD2451Trsnsistor
2SC2752Transistor
C-14576P Coil
High Voltage Transformer
RPI-574/#9568Photocoupler
SM-05S-04A-9Microswitch
3041001J1100
622A0003M0001
620A0022M0008
602A1035M0002
603A1135M0010
602A1223M0039
350A2511P0102
4YB4049-7078P003
652A0103M0002
207A2020P0001
1
2
1
3
3
1
1
3
4
1
REF. SYMBOL TYPE/NAME PART NO. Q'TY REMARKSNO.
- 24 -
54
55
56
57
58
59
60
61
62
63
64
TLHV Printed Circuit Board Rev. 3(4YA4130-1024G1-2/2-4/4)
LED
CN1
CN2
J1,J2
J3-J12
J21-J43
SEL3910D-YZLED
23FE-BT-VK-NPrinted-Circuit Board Connector
53254-0210Printed-Circuit Board Connector
0.6Short Wire
0.6Short Wire
0.6Short Wire
650A0229M0018
224A4134P0230
224A4407P0020
TA-0.6
TA-0.6
TA-0.6
1
1
1
2
10
23