- (rr

if.* PLANT OPERATIONS MANUAL. .. .

:

i Volume 05 05-1-02-11-1

Section 02 Revision: 11

Date: 6-14-82.

OFF-NORMAL EVENT PROCEDURE,

SHUTDOWN FROM THE REMOTE SHUTDOWN PANEL

SAFETY RELATED

Prepared:_. _.;-- k |-( \d g of . '- --- -- -. t .

' -] - .

Reviewed: /. Nuclear Plant Quality Superinterfdent n'ical ' Review

__ Approved: OhwOpergtons perinten n

Concurrence:,

[[p'p-

As sis' t Plant Man e / /

h/ |ppPSRC: *

,

/4 / /_

~' '

. . . . . . . . . - . . . . . . .

' List of Ef fective Pages:

Page:

1-10.

List of TCN's Incorporated:

! Revision TCN No.

10 None11 None '

I 8206300251 820625*

l PDR ADOCK 05000416| P PDR

"

' GRAND GULF NUCLEAR STATION' '0FF NORMAL EVENT PROCEDURE'

* -. -*

Title: Shutdown From The Remote ;No.: 05-1-02-11-1 : Revision: 11 |Page: 1 |

-

'Shutdown Panel | |

1.0 PURPOSE / DISCUSSION

1.1 The purpose of this procedure is to provide instructions for shuttingdown the plant from outside the control room and bringing the plant to acold shutdown condition from the remote shutdown panel.

1.2 This procedure will interface with the Emergency Plan.

1.3 The following assumptions and initial conditions are considered to beprerequisites for the implementation of this procedure:

' 1.3.1 An unsafe condition exists in the control room. This conditionmay be caused by fire, chlorine or other toxic gas, high airborneactivity, or other emergency. The Shift Supervisor / ShiftSuperintendent will have evaluated the possibility of remaining inthe control room with breathing apparatus and will orderevacuation only if necessary.

'

~s1.3.2 If time permits, the RCIC System will be manually initiated prior

to evacuation.,

..

. _ - -..~ 773t3 The emergency AC buses are energized"from' their normal power- , '-

No loss of off-site power is considered after the start', _ _

sources.

of the emergency that precipitates this procedure.l. -

u .n. ,, . -

~T'.

1.3.4 DC power is supplied from at least one plant DC power source to_. each system or component required for remote shutdown.

. . - . . . . . . . . . ..-, .

1.3.5 All support systems are in normal lineups, operating normally, andcontinue to operate normally throughout this evolution. *

_

1.3.6 Nothing abnormal occurs which would cause reactor plantdeterioration such that immediate operator action would be

,! required upon reaching the remote shutdown panel.i .

Placing the Mode Switch in Shutdown will immediately put the plant., _ _ . ____

in a hot shutdown condition. While the MSIV's are o i' reactor feed pumps (with the aid of the RCIC system) pen, thewill continue| to feed water to the reactor vessel thereby preventing a Low Levelj 2 (-41.6"), containment and auxiliary building isolation, and; subsequent loss of vital plant systems. The main condenser will

remain in service while the main steam bypass valves controlr

reactor pressure and remove sensible and decay heat. In the eventthe MSIV's close and/or the low level trip point is reached, HPCS,RCIC, and the safety-relief valves will all function to

,

I

!

i

i

i

.

___

' GRAND CULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE,

! '

.l ' * Title: Shutdown From Tha Remote No.: 05-1-02-11-1 Ravision: 11 Page: 2

'

; Shutdown PanellI

$i control reactor level and pressure. The operator at the remote

shutdown panel will take control of the RCIC system and, as.

; necessary, the safety-relief valves to control level, pressure,; and.cooldown rate ~until the RHR system can be placed in thej shutdown cooling mode. The operator will also startup the Standby

~Service Water system and the RHR system in the suppression pooli

cooling mode. One control rod drive pump will be used to maintain' rod drive cooling and augment the RCIC system, and will be

available to maintain level after RCIC has been secured.4

. . . . _ -

f'This procedure contains abbreviated portions from the appropriateS0l's and considers the Off-Normal condition of operation with aminimum of controls and instrumentation.

-,

'

2.0 SYMPTOMS

2.1 Any unsafe situation such as fire, toxic gas, high airborne activity or*

_ other condition which, in the opinion of the Shift Supervisor / Shift ?Superintendent, requires. evacuation of the control room. -

,

, , .

3.0 AUTOMATIC ACTIONS7 ____ ,, , ,, . , _ .

.- -

t

t '. .

...-

NOTE'

1. _ These automatic actions will be a result of the-Immediate Operator Actions4T taken in 4.0. -

i. .~. . - ,.

7--- 3.1 With the Mode Switch in SHUTDOWN,.the MSIV's will not close on low mainsteam line pressure. - -~ - - - *

p- , -m

'

3.2 If the MSIV's do not close, the main feed pumps will continue to feed the' vessel, recovering the inventory lost during the shrink following thescram, and will continue to feed the vessel until they and the main

J, turbine trip at +54.9" or until reactor pressure. decreases below that

j required to drive the feed pumps.!

' ' 3.3i ~ ~ ~

Reactor pressure will be controlled by the main steam bypass valves aglong as it remains above the bypass valve setpoint.

| -

3.4 If vessel level reaches -41.6", HPCS and RCIC start and inject water intothe vessel. The HPCS injection valve and RCIC steam supply and injection

| valves will close at 53.5".-

,

n

@

.

.

.

GBAND GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE**

Title: Shutdown From The Remote No.: 05-1-02-11-1 Revision: 11 jPege: 3 |Sh'tdown Panal I |

u

3.5 If the MSIV's close, the safety-relief valves will function as necessaryto maintain reactor pressure, the main steam bypass valve pressurecontrol and reactor feed pump vessel feed functions will be lost, and themain condenser will no longer be available as a consequential heat sink.

4.0 IMMEDIATE OPERATOR ACTIONS

4.1 The Shift Supervisor / Shift Superintendent makes the decision to evacuatethe control room and designates which operators are to man the remoteshutdown panels.

' 4.2 The Control Room Operator will perform the following before leaving the: control room:

4.2.1 Place the Reactor Mode Switch in the SHUTDOWN position.

4.2.2 Verify all control rods are fully inserted./

4.2.3 Manually initiate the RCIC system if time permits.

4.3 If necessary, the plant _may_.le scrammed from ou.tside.the. control. rg e as' Fo'llows: *. . .

. .

. . -- -

NOTE. ' . - . -

-

This will also initiate a Group I Isolation as well as the Scram.-

4.3.1 At panel IC71-P001 open these breakers: ~-

CB-4A Neutron Monitoring *

CB-6A Neutron Monitoring

4.3.2 At panel IC71-P002 open these breakers:

CB-4B Neutron MonitoringCB-6B. Neutron Monitoring . . . - -. . . _ . . _ , _ _ - _ . .

' ~~5.0 SUBSEQUENT ACTIONS

'' ~~

5.1 Proceed to implement the Emergency Plan as directed by the ShiftSupervisor / Shift Superintendent.

NOTE

All controls and indications are located on the remote shutdown panels1H22-P150 and 1H22-P151 unless otherwise indicated.

5.2 The RCIC system may have shutdown on high reactor level. The system will(steam supply and injection valve will open) if level 2 isrestart

reached. However, the system should be manually re-started after thehigh level has cleared by re-opening the RCIC STM SPLY TO RCIC TURBE51-F045 and verifying the RCIC INJ SHUT 0FF VLV E51-F013 re-opens.

.

, - - -, -, m w - - - - -

-m

CftAND GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE

, ' ' '

Title: Shutdown From The Remote No.: 05-1-02-11-1 Revision: 11 Page: 4'

Shutdown Panel

!

5.3 If at any time the RCIC TURBINE trips, reset the trip as follows:4

? 5.3.1 Place the RCIC TURE TRIP /THROT VLV E51-C002 XFER SWITCH in the{ EMER position.',

*' " 5 '. 3 . 2 Close RCIC TURB TRIP /THROT VLV E51-C002

I

5.3.3 _ Place the. RCIC FLO CONT IN MANUAL and run the controller to ~ 'minimum. - -

5.3.4 Reopen RCIC TURB TRIP /THROT VLV E51-C002. Check RCIC Turbinestatus lights on panel 1H22-P150 to see that turbine is reset.

5.4 Control reactor level by controlling RCIC speed with RCIC FLO CONT.Observe reactor level on the shutdown panel while attempting to maintaini

'

vessel level near the normal range of 33" to 40".

5.5 Verify locally that the main turbine / generator has tripped and the tfbypass valves are operating as necessary to control reactor pressure.,

+

5.6 Ensure at least one CRD_ pump _is running to cool, driv.e mechanisms ang.to,-

,

i ~~ ~~ assist in level control. '- ""- - - - - -

5.7 The HPCS pump may be running, recirculating on minimum flow from the CST'

to the suppression pool. The pump will inject water to the vessel if- level falls below -41.6". The.HPCS injection valve will close, returning

the pump to recirculation flow, at +53.5". Observe CST level and'

- suppression pool level. The.HPCS and RCIC suctions will automatically; shift from the CST to the suppression pool at a CST level of l'2" or a

suppression pool level of 18'7". Minimize water transfer from the CST to,

the suppression pool through the RCIC and HPCS minimum flow lines.

5.8 Commence suppression pool cooling as follows:

5.8.1 Select RHR loop A or B for suppression pool cooling mode. (Loop Aj , . ._ , is preferable since Loop A allows for discharge to radwaste). -

i~~

5.8.2 Verify SSW system A(B) in operation, supplying the RHR heat'

~exchangers to be.used for supp. pool cooling. If SSW is notsupplying the RHR heat exchangers, start up SSW as follows:,

|

Open SSW Loop A(B) RTN TO CLC TWR A(B) (P41-F005) A(B)a.|

|

b. Start SSW PMP A(B) P41-C001 A(B)

c. Open SSW PMP A(B) DISCH VLV P41-F001 A(B)

,

I

.

l -

,

L

_ _ _ . _ . .

GjtAND GULF NUCLEAR STATION '0FF-NORMAL EVENT PROCEDURE

'| Title: Shutdown From The Remote, No.: 05-1-02-11-1 Revision: 11 |Page: 5 |

**

| Shutdown Panel | |

t

d. Start (Loop A) SSW CLG TWR FAN A P41-P003A, and SSW CLC TWR.

1 FAN B P41-C003B, or (Loop B) SSW CLC TWR FAN C P41-C.003C, andSSW CLG TWR FAN D P41-C003D.

-

'

,. -.

Observe SSW SYS A(B) FLOW indication Approx. 7900 GPM.e.. __

5.8.3 Place the following RHR transfer switches in the EMER position: -,

. . _ , . . < .. , - t-..

a. .SHUTDN CLG SUCT VLV E12-F006B XFER SWITCH

: b. SUPP POOL SUCT VLV E12-F004B XFER SWITCH!t

c. RHR HX INL VLV E12-F047B XFER SWITCH

d. RHR HX INL VLV E12-F047A XFER SWITCH,

e. SUPP POOL SUCTION VLV E12-F004A XFER SWITCH. ' . /

f. SHUTDN CLG SUCT VLV E12-F006A XFER SWITCH4

5.8.4 '

,_ ,

Open or check open,.thg_following valves , . , ..

,

, , _ RHR PUMP A(B) SUCT FM SUPP POOL 812-F004A(B)*

a. '

'b. RHR HX A(B) INL VLV E12-F047A(B) e. ,._ ,

. .

i . . c. RHR HX A(B)'0UTL VLV E12-F003A(B) -c, . , . _ . . . _ . . - .. .--

, . - - . ,, 1;--

-d. RHR HX A(B) BYP VLV E12-F048A(B)- * ' '"-

9

.5.8.5 - Start RHR PMP A(B) E12-C002A(B). , i

5.8.6 Open RHR A(B) RTN TO SUPP POOL E12-F024A(B). Observe RHR SYS A(B),

_ FLO indication approx. 7450 GPMi

!_ _ _ . ... ..5.8.7 Close RHR HX A(B) BYP VLV E12-F048 A(B) . . _ . .~ -

._-

.

[~ ' '

5. 8. 8 Adjust RHR A(B) TEST RTN TO SUPP POOL E12-F024A(B) to maintain RHR<

SYS A(B)'FLO at about 7450 gpm.

l

.

.

- - - ,. - . - , . -, ,

. _ . - . ._ -~.

_ GRAND GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE-

. ..

Title: Shutdown From The Rtmote No.: 05-1-02-11-1 Rsvision: 11 Page: 6Shutdown Psnal

; 5.8.9 Continue to monitor suppression pool temperature and level, and^

ADJUST RHR flow to maintain temperature less than 120*F.

5.9 Reduce reactor pressure by manually operating the safety / relief valves asfollows:

5.9.1 While observing reactor pressure and level, open a safety / reliefvalve to depressurize slowly while maintaining vessel level above+20".

IClose the safety / relief valve and observe reactor pressure and5.9.2

level. Allow time for level and pressure to stabilize, then opena different safety / relief valve as in Step 5.9.1 above.

,

|5.9.3 Continue to operate safety / relief valves as per the two preceeding

steps. If core decay heat is low enough such that pressure is notrising, allow the reactor to'depressurize without operating reliefvalves. Close safety / relief valves if vessel level drops to f*+20".

5.9.4 Plot vessel cooldown_sn'the time vs temp,erature. graph acqompanying '---- " ~ this procedure. Convert vessel preffure to the corresponding, *

*temperature using the saturated steam data (Table 1). Maintain

'

' the cooldown rate not greater than 100*F/ hour..

--

_--.. 5.9.5 Control vessel level and pressure using a combination ofsafety / relief valve operation ahd m'anual RCIC speed control.

5.9.6 Closely monitor suppression' pool' temperature and level during the~

depressurization operation.

5.10 Depressurize the reactor to 125 psig or less.'

.

5.11 Verify all safety / relief valves are closed.

. . 5.12. Raise vessel level to +45 to +50" and then shutdown the RCIC system and.

place it in standby as follows: (Ref. SOI 04-1-01-E51-1). i

5.12.1 Reduce RCIC Flow to approx. 100 GPM.

5.12.2 close RCIC INJ SHUTOFF VLV E51-F013.

5.12.3 Close RCIC TURB TRIP /THROT VI.V E51-C002.

-

.

.

C,RAi[DCULFNUCLEARSTITION'

'0FFtibRkLEVENTPROCEDUREI*

..*'' Title: Shutdown From The Remote No.: 05-1-02-11-1 Revision: 11 Page: 7 |Shutdown Panel

5.12.4 Verify E51-F019 closed.I |

5.12.5 Stop RCIC GL SEAL COMPR E51-C002-2A.

5.12.6 Close E51-F046.

5.13 Place the RHR loop that is not in suppression pool cooling service in theshutdown cooling mode as follows:

i 5.13.1 Verify the SSW system A(B) in operation supplying RHR heat!

, exchangers to be used for shutdown cooling. If SSW is noti supplying the RHR heat exchangers, start up the SSW system as

per Steps 5.8.2a through 5.8.2.e of this procedure. (Ref. SOI04-01-1-P41-1.

,

5.13.2 Close or check closed the folleving valves to prevent drainingreactor water to the suppresr, ion pool or to the RHR loop in

'

suppression pool cooling mode.'

RHR PMP A(B) SUCT FM SHUTDN CLG E12-F006 A(B) (for the loop ina..

suppression yoo kcooling)... . , . . .

.., ._. c - -- .e t,

... .... . .

b. RHR PUMP A(B) SUCT FM SUPP POOL 112-F004 A(B) (For the loop t'o,_

be placed in shutdown cooling).z- .

_-,,

W 5.13.3 For the RHR loop to be placed in shutdown cooling, open 'tHR PMPi .- A(B) SUCT'FM SHUTDN CLC E12-F006 A(B).

. . . . , . . . .. ... - ,

j CAUTION1 .>

,-- The opening of RHR SHUTDN CLG INBD SUCT VLV E12-F009 and RHR si

." SHUTDN CLG OUTBD SUCT VLV E12-F008 vill allow reactor water to '

'

!.. ,fill the RHR suction piping thereby lowering vessel level.

'"

. 5.13.4 Fill and vent the RHR suction line as follows: ,

-..

,

Check RHR SHUTDN CLG INBD SUCT VLV E12-F009 closed. Ns.I

.|

b. Open RHR SHUTDN CLG OUTBD SdCT VLV E12-F008. .

'~

,

c. Open suction line manual vent valves: E12-F001 and E12-F002|

(between E12-F008 and F009) -

!' ' '

c. Unlock and open fill line isolation valve E12-F020. ' ),

." |

N-

I

, , , , 1

T |( "~~ '

|,s . ~ . .,

''

| % i3

I |\ , , ,

~

i,-

| L T, 1. ,

<;

. - \

|, *4 |

~ ',

e- .>

-n - . - . - - , - .- . -. ,,__ ,

C, RAND GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE*

*, . . 7igle: Shutdown From The Remote No.. 05-1-02-11-1 Revision: 11 Page: 8Shutdown Penal

j

d. When suction line is full and water issues from the vent line,"

close E12-F001, F002 and close and lock E12-F020.

5.13.5 Open the breaker for the minimum flow valve (1E12-F064A or1E12-F064B) for the RHR pump to be placed in shutdown cooling(Breakers 52-153151 for F064A, 52-163114 for F064B). Tocircumvent the potential for draining reactor water to the'

suppression pool at low RRR Flows.

5.13.6 Open or check open.RHR HX A(B) BYPASS VLV E12-F048 A(B).

I' 5.13.7 Close RHR RX A(B) INL VLV E12-F047 A(B) and RHR RX A(B) OUTL VLVE12-F003A(B).

5.13.8 Open RHR SHUTDN CLG INBD SUCT VLV E12-F009.

5.13.9 Start RHR PMP A(B) and immediately throttle open RHR A(B) SHUTDNRTN TO FW E12-F053 A(B) to achieve a stable flow of 2000-4000 gpm

i as read on the RHR SYS A(B) FLO meter.1 . . ..

~

1-

5713r10 When RHR flow is stable place the hfft exchanger 'into service ast *

| follows:' '

a. Open RHR RX A(B) INL VLV E12-F047A(B), , .

b- Open RHR HX'A(B)'0UTL VLV E12-F003A(B).

' Throttle RHR RX A(B) BYP VLV E12-F048A(B) and, asc.

necessary, RHR RX A(B) OUTL VLV E12-F003A(B) to controlreactor cooldown rate. Do not allow RHR flow to drop below1000 GPM.

!'. 5.13.11 Minimize reactor cooldown rate since actual temperature indication

{ is not available at the remote shutdown panel.

2- 5.13.12 Maintain shutdown cooling and suppression pool cooling operation' ~~' until control room accessibility is restored.

..... . . -

| 5.13.13 Once access to the control room is regained, enter the appropriate' EP or S01 as conditions dictate.L

.

a

-

--

.

' ".

L'

GRAND GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE'

'

Title: Shutdown From The RemotejNo.: 05-1-02-11-1 | Revision: 11 [Page: 9 |*

Shutdown Panel | | | |

TABLE I

Saturated Steam Temperature Table

Temp (*F) Press (psig) Temp (*F) Press (psig) Temp (*F) Press (psig),

560 1118 416 281 276 31556 1083 412 268 272 28552 1048 408 256 268 26

'

548 1013 404 244 264 23544 980 400 232 260 20540 948

396 221 256 18536 916 392 211 252 16532 885 388 200 248 14528 855 384 190 244 12*524 826 380 181 240 10520 798

516 ~ 770~-376 172 , .236. .8'' .

372 - 163 232 *7*"

512 743 368 ._ 154 228 5' *

508 71G 364 146 224 3504 691 360 138 - 220 2500 666

'

356 130 216 1

496 642 352 123 212 0492 618 348 116488 595 344 109484 573 340 103480 551

336 97476 530 332 91472 510 328 85468 490 3 24 ... .. 80464 471 320460 452

-75 i

316 70456 434 312 65452 416 308 60448 399 304 56 Note: Pressures are approxi-444 383 300 52 mate values. Accurate440 367 to + 2 psig.

296 48436 351 292 45 Source: 1976 ASME STEAM432 336 288 41 TABLES428 321 284 37424 307 280 34420 294

.. __ _ _ _ - _ _ _ _ _ _ _ _ _ _ - _ .

GRM3D GULF NUCLEAR STATION OFF-NORMAL EVENT PROCEDURE. * . -

.| Title: Shutdown Froa The Remote No.: 05-1-02-11-1 R2 Vision: 11 Pego: 10*

| Shutdown Penal|

Reactor Vessel Temperature (from Table I)

.

*e ,

e

Z- r m en _ wwne (w r-r)e, u

. V- t % a t t t t 7,**

.

I - ,/ 4 .,

n //

//

/r

9

*

// .

/ IJ

em , /

k

/,

/

1

|/ ,e

'1

,' '1

l

/

| *

or =m 1

,

/g ' */ ,

e e

Ie

/ te

h. / |4. /* |/

Ie

/ *

-- / i-

/ ,*/ -

_

1 - I"7 ,

N ,' . / ;s /

- / !'

,' ^$sg

* /,Gn /

as a -a

| /',s ,

//

/'

L/

*

i / eI8 / 1

i - i

. ,.s -

' 's M .k\' *j. /

.; . , ~ 1---

t. s.</ ,

a,

ki N~'e 4 .- .r

.

..

q y n..

->

4.

,- 12 2, e r -

%

'5' N*

' X_ 7

1 .%-.e

- - - ~ . ., ,_

7.,

?_ ) >

]| k h

! s e == J,.....- . -

_ - =. .-

|'

.

|