nine project (8-19-15)
TRANSCRIPT
WIRELINE
OPERATIONS
Mario Castillo
Marshall Baker
August 19, 2015
Job: Powers Device
• Cable connects
device to power
source
• Cable powers at
specified location
LAPTOP CHARGER
COMPARISON
Armored conductive line that lowers/actuates equipment
• Exterior: Multi-strand wire armor cable
• Interior: Insulated electrical conductor wire
WIRELINE (ELECTRIC LINE)
• Slickline
Single strand
• Braided Line
Multi strand
• Specialty Cable
COUNTERS PARTS
WIRELINE TRUCK (PERFORATOR)
EXTERIOR
Drum
Horsehead
Motor
Tool Cavity
Grounding
Cable
INTERIOR
Fire Ups
Shooting Panel
Warrior Interface
Panel
Hoistman’s
Controls
Wellbore – reservoir conduit
Common Methods
1. Wireline Perforating
2. TCP (Tubing Conveyed
Perforating)
COMPLETION PERFORATION
Electrically activated gun string run on wireline
• Alternating polarity sequencing
• Depth control: CCL
• Pump-down required for horizontal section
WIRELINE PERFORATING
Mechanically/pressure activated gun string
• Primarily used in horizontal
• No pump-down needed
• Less accurate than wireline perforating
TUBING CONVEYED PERFORATING (TCP)
APPROACHES
Coil Tubing Unit Workover Rig
Units
Methods
Depth Control
Time Delay Use
Coil Tubing Workover Rig
Time Delays Between Joints
Mechanical
CounterTubing Tally
Necessity Assurance
GUN CARRIER
Shaped ChargesPrimer Cord
Examples
Casing-conveyed perforating
• Eliminates need for wireline
• Primarily used for toe
• Process incorporates balls/seats after toe
FLOWGUNTM
FLOWGUNTM
Completion tool used to isolate zones
TypesBall Drop
Caged Ball
• Allows flow uphole
Casing
4.5” (B10, 3.5)
5.5” (B10, B20, 3.5)
• Millable/Drillable
FRAC PLUGS
Completion tool used to isolate zones
• Incorporates bridging pin
• No communication between zones
Casing4.5” (B10, 3.5)
5.5” (B10, B20, 3.5)
• Millable/Drillable
BRIDGE PLUGS
Retrievable isolation tool
Tasks
Fracturing Squeeze Job
Acidizing Wellhead Servicing
Wireline – Set with B10
Tubing – Set with hydraulic setting tool
RETRIEVABLE BRIDGE PLUG (RBP)
Frac plug replacement
• Largest ID
• Dissolvable ball
• Eliminates intervention
FRACDOCKTM
• Cement Bond Logs
(CBLs)
Inspect cement job
• Caliper Logs
Inspect casing integrity
• Tools run with
centralizers
LOGGING
CBL INSIGHT
Casing Collar Locator
(Depth Control)
Variable Density Log
(Arrival Identifier)
Gamma Ray
(Formation Type)
Amplitude
(Signal Loudness)
Transit Time*
(Quality Control)
* not pictured here
Cement Map*
(Visual Representation)
GOOD CEMENT
LOW Amplitude
NO CEMENT
HIGH Amplitude
PARTIAL CEMENT
MIXED Amplitude
CASED HOLE CALIPER
• Up to 80 fingers
Findings− Wear
− Corrosion
− Deformation
• Produce 3D image
PRESSURE CONTROL
1. Grease Head− Holds pressure
2. Lubricator− Gun string housing
3. Pump in Tee− Equalizes pressure
4. Blowout Preventer (BOP)− Security measure
5. Grease Unit− Supplies honey-oil to grease head
6. Tool trap− Prevents tools from entering the well
7. Line wiper− Cleans wireline
PRESSURE CONTROL 7
5
4
2
1
6
3
US Rig Counts
Currently: 884
Last Year: 1913
All-time High: 2031
WTI Crude Oil: $41.87/bbl
Brent Crude Oil: $49.03/bbl
MARKET
Baker Hughes 8/17/2015
EBITA: ~ 30%
Reasons
− Strong Team
− Innovative
− Add-on Tools
− Close to Perfection
− Far from Ordinary
− Driven to Succeed
NINE SUCCESS
WIRELINE
OPERATIONS
Mario Castillo
Marshall Baker
August 19, 2015