mx120sin - audio-circuit.dk

MX120

SERVICE MANUAL

Performance Specifications ................................... 2 - 3Notes ......................................................................... 3Rear Panel .................................................................. 3Section Location ........................................................ 4Block Diagram ...................................................... 5 - 8Interconnection Diagram .................................... 9 - 10Display Schematic and PCB ............................... 11 - 18Surround Schematic and PCB ............................ 19 - 32Data Schematic and PCB ................................... 33 - 36

S-Video Schematic and PCB .............................. 37 - 40Video Schematic and PCB ................................. 41 - 44Input Schematic and PCB .................................. 45 - 50Component Video Schematic and PCB ............. 51 - 54HDMI Power Supply Schematic and PCB .......... 55 - 56HDMI Module Schematic and PCB ................... 57 - 58Balanced Output Schematic and PCB ............... 59 - 60Parts List ............................................................ 61 - 74Repacking Instruction .............................................. 75

CONTENTS

Serial Number XN1001 And Above

SERIAL NO. XN1001 And Above

MX120A/V CONTROL CENTER

PRELIM

INARY

PERFORMANCE SPECIFICATIONS

2

Audio Specifications

Frequency ResponseLeft, Center, Right,Left Surround,Right Surround,Left Back, Right Back:±0.5dB from 20Hz-20,000Hz

Subwoofer1:±0.5dB from 20Hz-140Hz

Total Harmonic Distortion0.005% maximum from 20Hz to 20,000Hz at rated output

Signal To Noise RatioPhono: 86dB below 10mV input (A Weighted)High Level: 96dB below rated output (A Weighted)

Rated Output Voltage2.5V Unbalanced Outputs (Main)5.0V Balanced Outputs (Main)

Maximum Voltage Output9.5V Unbalanced19V Balanced

Output Impedance100 ohms Unbalanced200 ohms Balanced

Input ImpedancePhono: 47k Ohms, 65pfHigh Level: 22k Ohms Unbalanced

50k Ohms Balanced

Sensitivity for Rated OutputPhono: 5mVHigh Level: 500mV Unbalanced

1V Balanced

Maximum Input SignalPhono: 50mVHigh Level: 5V Unbalanced

10V Balanced

Voltage GainPhono to REC Out: 40dBPhono to Output (Main): 54dBHigh Level to REC Out: 0dBHigh Level to Output (Main): 14dB

Tone ControlsBass Control: ±12dB at 30HzTreble Control: ±12dB at 10,000Hz

General Specifications

Power Requirements100 Volts, 50/60Hz at 65 watts110 Volts, 50/60Hz at 65 watts120 Volts, 50/60Hz at 65 watts220 Volts, 50/60Hz at 65 watts230 Volts, 50/60Hz at 65 watts240 Volts, 50/60Hz at 65 wattsNote: Refer to the rear panel of the MX120 for thecorrect voltage.

Overall DimensionsWidth is 17-1/2 inches (44.45cm)Height is 7-5/8 inches (19.37cm) including feetDepth is 18-3/4 inches (47.63cm) including the FrontPanel and Knobs

Weight27 pounds (12.25Kg) net, 46 pounds (20.87Kg) shipping

Shipping Carton DimensionsWidth is 25 inches (63.5cm)Depth is 27 inches (68.6cm)Height is 12 inches (30.5cm)

1 If any of the Channels have the Loudspeaker Setting ofSmall, the subwoofer has an electronic low pass filter with a24dB per Octave rolloff in all modes except external.

1. Unless otherwise noted, all voltages indicated onthe schematics are measured under the followingconditions:a. AC input at 120 volts, 50/60Hz.b. All voltages are +/-10% with respect to ground.

A high impedance (10 megaohm) voltmeter mustbe used.

NOTES2. On PC board drawings, Square pad indicates:

a. Polarized Capacitors - Positiveb. Diodes - Cathodec. Others - Pin 1

3. WARNINGParts marked with the symbol havecritical characteristics. Use only replacementparts recommended by the manufacturer.

MX120

3

SECTION LOCATION

REAR PANEL

4

NOTES

MX120

5 6

BLOCK DIAGRAM

7 8

BLOCK DIAGRAM con’t

MX120

INTERCONNECT

9 10

1

DISPLAY CONTROL SECTION SCH 7505752A

11 12

MX120

13 14

DISPLAY LED SECTION SCH 7505772B

15 16

DISPLAY KEYBOARD SECTION SCH 7505682C

2A DISPLAY CONTROL SECTION PCB 750575

MX120

DISPLAY KEYBOARD SECTION PCB 7505682C

DISPLAY LED SECTION PCB 7505772B

17 18

19 20

SURROUND 750570 SCH 1 OF 63

MX120

21 22


23 24

3 SURROUND 750570 SCH 3 OF 6

MX120

25 26


27 28


MX120


29 30

SURROUND 750570 PCB3

31 32

MX120

33 34

DATA 750572 SCH 1 OF 24

35 36

DATA 750572 SH 2 OF 2 And PCB4

MX120

37 38

S-VIDEO 750574 SCH 1 OF 25

39 40

5 S-VIDEO 750574 SH 2 OF 2 And PCB

MX120

41 42

VIDEO 750573 SCH6

43 44

VIDEO 750573 PCB6

MX120

45 46

INPUT 750571 SCH 1 OF 27

47 48

INPUT 750571 SCH 2 OF 27

MX120

49 50

INPUT 750571 PCB7

COMPONENT VIDEO 7505768

51 52

MX120

53 54

COMPONENT VIDEO 7505768

55 56

HDMI POWER SUPPLY 7505999

MX120

57 58

HDMI MODULE 75062310

59

BALANCED OUTPUT 75060811

60

MX120

PARTS LISTINTERCONNECTRef. No. Description Part No.F1 FUSE, 800MA SLO-BLO 5 X 20 089141TB1 AC TERMINAL BLOCK 074091T1 TRANSFORMER R-CORE POWER 159340

DISPLAY PCB 750575

1

2A

Ref. No. Description Part No.

61

C1 CAP MONO .01UF 50V 20% X7R 061345C2 CAP ELECT 1UF 50V 066510C14 CAP MONO 33PF 200V 5% NPO T/R 061347C15 CAP MONO 33PF 200V 5% NPO T/R 061347C25 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP MONO .1UF 50V 20% Z5U 061346C27 CAP MONO .1UF 50V 20% Z5U 061346C29 CAP MONO .1UF 50V 20% Z5U 061346C31 CAP MONO .1UF 50V 20% Z5U 061346C32 CAP MONO .1UF 50V 20% Z5U 061346C33 CAP ELECT 10UF 16V 066580C50 CAP ELECT 10UF 16V 066580C51 CAP MONO .1UF 50V 20% Z5U 061346C57 CAP MONO .1UF 50V 20% Z5U 061346C58 CAP MONO .1UF 50V 20% Z5U 061346C100 CAP MONO .1UF 50V 20% Z5U 061346C170 CAP MONO 100PF 100V 10% NPO 061341C200 CAP MONO .01UF 50V 20% X7R 061345C201 CAP MONO .01UF 50V 20% X7R 061345C204 CAP MONO .01UF 50V 20% X7R 061345C205 CAP MONO .01UF 50V 20% X7R 061345C206 CAP MONO .01UF 50V 20% X7R 061345C207 CAP MONO .01UF 50V 20% X7R 061345C210 CAP MONO .01UF 50V 20% X7R 061345C211 CAP MONO .01UF 50V 20% X7R 061345DS5 LED GRN 5MM HI-INTENSITY 058165(DS5) SPACER LED 112108DS6 LED GRN 5MM HI-INTENSITY 058165(DS6) SPACER LED 112108DS7 LED GRN 5MM HI-INTENSITY 058165(DS7) SPACER LED 112108DS8 LED GRN 5MM HI-INTENSITY 058165(DS8) SPACER LED 112108DS9 LED GRN 5MM HI-INTENSITY 058165(DS9) SPACER LED 112108DS10 LED GRN 5MM HI-INTENSITY 058165(DS10) SPACER LED 112108DS11 LED GRN 5MM HI-INTENSITY 058165(DS11) SPACER LED 112108D300 DIODE SILICON 070174D301 DIODE SILICON 070174D302 DIODE SILICON 070174IC4 IC OCTAL D TYPE FLIP FLOP 133603IC5 IC QUAD ANALOG SWITCH HI SPEED 133342IC6 IC OCTAL BUFFER 3-STATE 133349IC7 IC OCTAL BUFFER 3-STATE 133349IC10 IC QUAD ANALOG SWITCH HI SPEED 133342IC11 IC SRAM 133659(IC11) SOCKET IC 28 PIN 178126IC13 IC OCT 3-STT NONINVERTING 133654IC14 IC PROGRAMMED MX120 133665 133664(IC14) SOCKET IC 32 PIN 178165IC15 IC MICRO ROMLESS 133386(IC15) SOCKET IC 40-PIN 178133IC17 IC QUAD ANALOG SWITCH HI SPEED 133342

IC31 IC NAND SCHMIT 2-IN X 4 133595IC32 IC NAND SCHMIT 2-IN X 4 133595IC50 IC 8 BIT A/D SERIAL OUTPUT 133366IC75 IC CPU SUPERVISOR 133639IC20 IC PROG DISPLAY CONTROL 133660 133662(IC20) IC SOCKET 84 PIN PLCC 178185J1 CONN MALE 10 POS 117219J2 SOCKET STRIP 14 PIN .025 SQ 117644J3 CONN MALE 7 PIN 117217J5 CONN 10 PIN BOXED HEADER 117795J7 SOCKET STRIP 14 PIN .025 SQ 117644J8 CONN MALE 10 POS 117219J9 SOCKET STRIP 14 PIN .025 SQ 117644J9_ CONN MALE 5 PIN 0.1 POST ASSY 117216J10 CONN MALE 10 POS 117219J11 CONN 18 PIN FFC 117908J12 SOCKET STRIP 14 PIN .025 SQ 117644J19 CONN MALE 10 POS 117219PCB1 PC BD DISPLAY 129839Q1 TRANSISTOR NPN SILICON 132317Q50 TRANSISTOR NPN SILICON 132317R5 RES NETWORK 8 X 330 ISO 144679R9 RES NETWORK 2 X 22K ISO 144689R18 RES MF 100 OHM 1% 1/4W 144568R19 RES MF 47.5 OHM 1% 1/4W 144642R20 RES MF 100 OHM 1% 1/4W 144568R21 RES MF 182 OHM 1% 1/4W 144579R22 RES MF 182 OHM 1% 1/4W 144579R23 RES MF 47.5 OHM 1% 1/4W 144642R26 RES NETWORK 2 X 22K ISO 144689R27 RES NETWORK 2 X 22K ISO 144689R29 RES NETWORK 2 X 22K ISO 144689R30 RES MF 10 OHM 1% 1/4W 144553R31 RES MF 4.99K 1% 1/4W 144521R32 RES MF 100 OHM 1% 1/4W 144568R45 RES NETWORK 2 X 22K ISO 144689R50 RES NETWORK 9 X 1K ISO 144685R51 RES NETWORK 9 X 1K ISO 144685R52 RES NETWORK 9 X 1K ISO 144685R83 RES FP 10 OHM 5% 1/4W 137105R100 RES MF 10K 1% 1/4W 144504R101 RES MF 10K 1% 1/4W 144504R102 RES NETWORK 4 X 22K BUSSED 144668R105 RES MF 10K 1% 1/4W 144504R131 RES NET 10K X 8 RES BUSSED 144675R150 RES NETWORK 4 X 1K ISOLATED 144500R151 RES NETWORK 4 X 1K ISOLATED 144500R170 RES MF 4.99K 1% 1/4W 144521R171 RES MF 4.99K 1% 1/4W 144521R200 RES NETWORK 2 X 22K ISO 144689R201 RES MF 47.5K 1% 1/4W 144526R203 RES NETWORK 2 X 22K ISO 144689R204 RES NETWORK 2 X 22K ISO 144689R206 RES NETWORK 2 X 22K ISO 144689R300 RES MF 47.5K 1% 1/4W 144526TEST1 CONN 4 PIN 117215U3 IC PROGRAMMED 133336 IR MICRO 133545(U3) SOCKET IC 20 PIN 178181(IC6) SOCKET IC 20 PIN 178181(IC7) SOCKET IC 20 PIN 178181

62

DISPLAY PCB 750575 (Cont’d.)Ref. No. Description Part No.

C4 CAP MONO .1UF 50V 20% Z5U 061346C5 CAP MONO .1UF 50V 20% Z5U 061346C6 CAP MONO .1UF 50V 20% Z5U 061346C10 CAP ELECT 47UF 35V 066446C11 CAP MONO 1000PF 50V 10% NPO 061344C12 CAP MONO .1UF 50V 20% Z5U 061346C16 CAP MONO .1UF 50V 20% Z5U 061346C17 CAP MONO 1000PF 50V 10% NPO 061344C19 CAP ELECT 47UF 35V 066446C20 CAP ELECT 47UF 35V 066446C21 CAP ELECT 10UF 50V 066445DS1 DISPLAY VFD 12 CHARACTER 058182DS2 LED SQUARE RED 058109DS3 LED SQUARE RED 058109DS4 LED SQUARE RED 058109DS5 LED SQUARE RED 058109DS6 LED SQUARE RED 058109DS7 LED SQUARE RED 058109DS8 LED SQUARE RED 058109DS9 LED SQUARE RED 058109DS10 LED SQUARE RED 058109DS11 LED SQUARE RED 058109DS12 LED SQUARE RED 058109DS13 LED SQUARE RED 058109DS14 LED SQUARE RED 058109DS15 LED SQUARE RED 058109DS16 LED SQUARE RED 058109DS17 LED SQUARE RED 058109DS34 LED ARRAY(5) YELLOW RECTANGLE 058127(DS34) CONN SOCKET SIP 10 PIN 117876DS38 LED ARRAY(5) YELLOW RECTANGLE 058127(DS38) CONN SOCKET SIP 10 PIN 117876DS41 LED ARRAY(5) YELLOW RECTANGLE 058127(DS41) CONN SOCKET SIP 10 PIN 117876DS42 LED ARRAY(5) YELLOW RECTANGLE 058127(DS42) CONN SOCKET SIP 10 PIN 117876DS43 LED ARRAY(5) YELLOW RECTANGLE 058127(DS43) CONN SOCKET SIP 10 PIN 117876DS44 LED ARRAY(5) YELLOW RECTANGLE 058127(DS44) CONN SOCKET SIP 10 PIN 117876DS45 LED ARRAY(5) YELLOW RECTANGLE 058127(DS45) CONN SOCKET SIP 10 PIN 117876DS46 LED ARRAY(5) YELLOW RECTANGLE 058127(DS46) CONN SOCKET SIP 10 PIN 117876IC2 IC VFD DISPLAY DRIVER 133549(IC2) SOCKET IC 40-PIN 178133IC3 IC DISPLAY DRIVER 4 DIGIT LED 133663(IC3) SOCKET IC 40-PIN 178133IC12 IC DISPLAY DRIVER 4 DIGIT LED 133663(IC12) SOCKET IC 40-PIN 178133J2 TERMINAL STRIP 14 PIN .025 SQ 117647J7 TERMINAL STRIP 14 PIN .025 SQ 117647J9 TERMINAL STRIP 14 PIN .025 SQ 117647J12 TERMINAL STRIP 14 PIN .025 SQ 117647

LED PCB 7505772B

MOLD1 MOLD FUNCTION LED 017865MOLD3 MOLD LED INDICATOR 017866MOLD4 MOLD FUNCTION LED 017865MOLD5 MOLD FUNCTION LED 017865MOLD6 MOLD FUNCTION LED 017865MOLD7 MOLD FUNCTION LED 017865MOLD8 MOLD FUNCTION LED 017865MOLD9 MOLD FUNCTION LED 017865MOLD10 MOLD FUNCTION LED 017865MOLD11 MOLD LED INDICATOR 017866MOLD12 MOLD LED INDICATOR 017866MOLD13 MOLD LED INDICATOR 017866PCB1 PC BD LED 129786

PC BD SWITCH 129787Q2 TRANSISTOR PNP SILICON 132304R1 RES MF 47.5K 1% 1/4W 144526R6 RES MF 3.32K 1% 1/4W 144518R8 RES MF 10 OHM 1% 1/4W 144553R10 RES NETWORK 5 X 47K BUSSED 144499R12 RES NETWORK 9 X 47K BUSSED 144673R13 RES NETWORK 9 X 47K BUSSED 144673R14 RES NETWORK 9 X 47K BUSSED 144673R15 RES MF 4.99K 1% 1/4W 144521R18 RES MF 4.99K 1% 1/4W 144521R25 RES FP 47 OHM 5% 1/4W 137106S21 SWITCH ROT ENCODER 24 DETENT 146255S22 SWITCH ROT ENCODER 24 DETENT 146255S24 SWITCH ROT ENCODER 24 DETENT 146255S25 SWITCH ROT ENCODER NO DETENT 146256

ASSY INSERTION PCB LED 702421DOUBLE COATED MTG-TAPE 1/16 TK 094409

Ref. No. Description Part No.

KEYBOARD PCB 7505682C

C13 CAP MONO .1UF 50V 20% Z5U 061346C24 CAP ELECT 47UF 35V 066446DS11 LED SQUARE RED 058109(DS11) LED SPACER .220 LENGTH 163001DS12 LED SQUARE RED 058109(DS12) LED SPACER .220 LENGTH 163001DS36 LED SQUARE RED 058109(DS36) LED SPACER .220 LENGTH 163001J2 CONN 18 PIN FFC 117908R16 RES MF 100 OHM 1% 1/4W 144568R17 RES MF 332 OHM 1% 1/4W 144646S1 SWITCH TACT 150059S2 SWITCH TACT 150059S5 SWITCH TACT 150058S7 SWITCH TACT 150058S9 SWITCH TACT 150058S10 SWITCH TACT 150058S11 SWITCH TACT 150058S12 SWITCH TACT 150058S13 SWITCH TACT 150058S14 SWITCH TACT 150058S15 SWITCH TACT 150058S16 SWITCH TACT 150058S17 SWITCH SLIDE DPDT 148076SENSOR SENSOR IR 38KHZ 121046

SHRNK TUBNG 3/8” LONG (077041) 077054PC BD KEYBOARD 129780

PARTS LIST Con’t

Y1 CRYSTAL 11.0592MHZ 180051CUTLIST 184121ASSY INSERTION PCB DISPLAY 702417

MX120

63

SURROUND PCB 750570Ref. No. Description Part No.

3

PARTS LIST Con’tRef. No. Description Part No.

BRKT1 BRACKET PCB CARD MOUNTING 003611C1 CAP ELECT 220UF 50V 20% 066254C2 CAP ELECT 100UF 25V 066573C3 CAP MONO .1UF 50V 20% Z5U 061346C4 CAP MONO .1UF 50V 20% Z5U 061346C5 CAP MONO .1UF 50V 20% Z5U 061346C6 CAP MONO .1UF 50V 20% Z5U 061346C7 CAP MONO .1UF 50V 20% Z5U 061346C8 CAP MONO .1UF 50V 20% Z5U 061346C9 CAP MONO .1UF 50V 20% Z5U 061346C10 CAP MONO .1UF 50V 20% Z5U 061346C11 CAP MONO .1UF 50V 20% Z5U 061346C12 CAP MONO .1UF 50V 20% Z5U 061346C13 CAP MONO .1UF 50V 20% Z5U 061346C14 CAP MONO .1UF 50V 20% Z5U 061346C15 CAP MONO .1UF 50V 20% Z5U 061346C16 CAP MONO 22PF 200V 10% NPO 061339C18 CAP MONO .1UF 50V 20% Z5U 061346C19 CAP MONO .1UF 50V 20% Z5U 061346C20 CAP MONO .1UF 50V 20% Z5U 061346C21 CAP MONO .1UF 50V 20% Z5U 061346C22 CAP MONO .1UF 50V 20% Z5U 061346C23 CAP MONO .1UF 50V 20% Z5U 061346C24 CAP MONO .1UF 50V 20% Z5U 061346C25 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP MONO .1UF 50V 20% Z5U 061346C27 CAP MONO .1UF 50V 20% Z5U 061346C28 CAP MONO .1UF 50V 20% Z5U 061346C29 CAP MONO .1UF 50V 20% Z5U 061346C30 CAP MONO .1UF 50V 20% Z5U 061346C32 CAP MONO .1UF 50V 20% Z5U 061346C36 CAP MONO 22PF 200V 10% NPO 061339C37 CAP MONO 22PF 200V 10% NPO 061339C38 CAP MONO 22PF 200V 10% NPO 061339C39 CAP MONO 22PF 200V 10% NPO 061339C40 CAP MONO 22PF 200V 10% NPO 061339C41 CAP MONO 22PF 200V 10% NPO 061339C42 CAP MONO 22PF 200V 10% NPO 061339C43 CAP MONO 22PF 200V 10% NPO 061339C44 CAP MONO 22PF 200V 10% NPO 061339C45 CAP MONO 22PF 200V 10% NPO 061339C46 CAP MONO 22PF 200V 10% NPO 061339C47 CAP MONO 22PF 200V 10% NPO 061339C48 CAP MONO 22PF 200V 10% NPO 061339C49 CAP MONO 22PF 200V 10% NPO 061339C50 CAP MONO 22PF 200V 10% NPO 061339C53 CAP ELECT 3300UF 35V 066509C55 CAP ELECT 3300UF 35V 066509C56 CAP ELECT 3300UF 35V 066509C58 CAP ELECT 18000UF 16V 066460C59 CAP ELECT 10UF 50V 066445C60 CAP ELECT 10UF 50V 066445C61 CAP ELECT 10UF 16V 066580C62 CAP ELECT 10UF 16V 066580C65 CAP ELECT 10UF 16V 066580C66 CAP ELECT 10UF 16V 066580C67 CAP ELECT 10UF 16V 066580C68 CAP ELECT 10UF 16V 066580C69 CAP ELECT 10UF 16V 066580C70 CAP ELECT 10UF 16V 066580

C71 CAP ELECT 10UF 16V 066580C72 CAP ELECT 10UF 16V 066580C73 CAP ELECT 10UF 16V 066580C77 CAP ELECT 10UF 16V 066580C79 CAP ELECT 10UF 16V 066580C80 CAP ELECT 10UF 16V 066580C81 CAP ELECT 10UF 16V 066580C82 CAP ELECT 10UF 16V 066580C83 CAP ELECT 10UF 16V 066580C84 CAP ELECT 10UF 16V 066580C85 CAP ELECT 10UF 16V 066580C86 CAP ELECT 10UF 16V 066580C87 CAP ELECT 10UF 16V 066580C88 CAP ELECT 10UF 16V 066580C89 CAP ELECT 10UF 16V 066580C94 CAP ELECT 10UF 16V 066580C95 CAP ELECT 10UF 16V 066580C96 CAP ELECT 10UF 16V 066580C97 CAP ELECT 10UF 16V 066580C98 CAP MONO 100PF 100V 10% NPO 061341C99 CAP MONO 100PF 100V 10% NPO 061341C100 CAP ELECT 10UF 16V 066580C101 CAP ELECT 10UF 16V 066580C102 CAP ELECT 10UF 16V 066580C103 CAP ELECT 10UF 16V 066580C104 CAP ELECT 10UF 16V 066580C105 CAP ELECT 10UF 16V 066580C106 CAP ELECT 10UF 16V 066580C107 CAP ELECT 10UF 16V 066580C110 CAP MONO .1UF 50V 20% Z5U 061346C111 CAP MONO .1UF 50V 20% Z5U 061346C113 CAP MONO .1UF 50V 20% Z5U 061346C114 CAP MONO .1UF 50V 20% Z5U 061346C115 CAP MONO .1UF 50V 20% Z5U 061346C116 CAP MONO .1UF 50V 20% Z5U 061346C119 CAP MONO .1UF 50V 20% Z5U 061346C120 CAP MONO .1UF 50V 20% Z5U 061346C121 CAP MPF 0.0022UF 5% 63VDC 064454C128 CAP ELECT 1000UF 25V 066513C129 CAP MONO .1UF 50V 20% Z5U 061346C130 CAP MONO .1UF 50V 20% Z5U 061346C131 CAP MONO .1UF 50V 20% Z5U 061346C132 CAP MPF 0.0022UF 5% 63VDC 064454C133 CAP MONO .1UF 50V 20% Z5U 061346C134 CAP MONO .1UF 50V 20% Z5U 061346C135 CAP MPF 0.0022UF 5% 63VDC 064454C137 CAP MPF 0.1UF 5% 63VDC 064325C138 CAP MPF 0.047UF 5% 63VDC 064320C139 CAP MPF 0.047UF 5% 63VDC 064320C140 CAP MPF 0.1UF 5% 63VDC 064325C141 CAP MPF 0.047UF 5% 63VDC 064320C142 CAP MPF 0.047UF 5% 63VDC 064320C143 CAP MPF 0.047UF 5% 63VDC 064320C144 CAP MPF 0.047UF 5% 63VDC 064320C151 CAP MONO .1UF 50V 20% Z5U 061346C153 CAP MONO 22PF 200V 10% NPO 061339C154 CAP MONO 100PF 100V 10% NPO 061341C155 CAP MONO 22PF 200V 10% NPO 061339C156 CAP MONO 22PF 200V 10% NPO 061339C157 CAP MONO 22PF 200V 10% NPO 061339

64

Ref. No. Description Part No.SURROUND PCB 750570 (Cont’d.)Ref. No. Description Part No.

PARTS LIST Con’t

C158 CAP MONO 22PF 200V 10% NPO 061339C159 CAP MONO 22PF 200V 10% NPO 061339C160 CAP MONO 22PF 200V 10% NPO 061339C161 CAP MONO 22PF 200V 10% NPO 061339C162 CAP MONO 100PF 100V 10% NPO 061341C167 CAP MONO 22PF 200V 10% NPO 061339C168 CAP MONO 100PF 100V 10% NPO 061341C169 CAP MONO 22PF 200V 10% NPO 061339C170 CAP ELECT 100UF 25V 066573C171 CAP ELECT 100UF 25V 066573C172 CAP ELECT 100UF 25V 066573C174 CAP ELECT 100UF 25V 066573C175 CAP ELECT 1000UF 25V 066513C178 CAP MPF 0.1UF 100V 064338C180 CAP MONO 47PF 200V 10% NPO 061340C181 CAP MONO 47PF 200V 10% NPO 061340C182 CAP MONO 47PF 200V 10% NPO 061340C183 CAP MONO 47PF 200V 10% NPO 061340C184 CAP MONO 47PF 200V 10% NPO 061340C185 CAP MONO 47PF 200V 10% NPO 061340C186 CAP MPF 0.1UF 100V 064338C188 CAP MPF 1UF 5% 63VDC 064337C189 CAP MPF 1UF 5% 63VDC 064337C192 CAP MPF 1UF 5% 63VDC 064337C193 CAP MPF 1UF 5% 63VDC 064337C194 CAP ELECT 470UF 50V 066469C195 CAP ELECT 470UF 50V 066469C197 CAP MONO 22PF 200V 10% NPO 061339C198 CAP MONO 22PF 200V 10% NPO 061339C199 CAP MONO 22PF 200V 10% NPO 061339C200 CAP ELECT 10UF 16V 066580C201 CAP MONO 22PF 200V 10% NPO 061339C202 CAP MONO 47PF 200V 10% NPO 061340C203 CAP ELECT 10UF 16V 066580C204 CAP MONO 22PF 200V 10% NPO 061339C205 CAP MONO 22PF 200V 10% NPO 061339C206 CAP MONO 1000PF 50V 10% NPO 061344C215 CAP ELECT 10UF 16V 066580C220 CAP ELECT 10UF 16V 066580C221 CAP ELECT 10UF 16V 066580C236 CAP MONO .1UF 50V 20% Z5U 061346C250 CAP MONO 22PF 200V 10% NPO 061339C251 CAP MONO 47PF 200V 10% NPO 061340C254 CAP MONO .1UF 50V 20% Z5U 061346C255 CAP MONO .1UF 50V 20% Z5U 061346C256 CAP ELECT 10UF 16V 066580C257 CAP ELECT 10UF 16V 066580C258 CAP MONO 22PF 200V 10% NPO 061339C259 CAP MONO 22PF 200V 10% NPO 061339C260 CAP MONO 22PF 200V 10% NPO 061339C261 CAP MONO 22PF 200V 10% NPO 061339C262 CAP ELECT 10UF 16V 066580C263 CAP ELECT 10UF 16V 066580C264 CAP ELECT 10UF 16V 066580C265 CAP ELECT 10UF 16V 066580C280 CAP MONO .1UF 50V 20% Z5U 061346C281 CAP MONO .1UF 50V 20% Z5U 061346C282 CAP MONO .1UF 50V 20% Z5U 061346C284 CAP MONO .1UF 50V 20% Z5U 061346C285 CAP MONO .1UF 50V 20% Z5U 061346

C286 CAP MONO .1UF 50V 20% Z5U 061346C287 CAP MONO .1UF 50V 20% Z5U 061346C288 CAP MONO .1UF 50V 20% Z5U 061346C289 CAP MONO .1UF 50V 20% Z5U 061346C290 CAP MONO .1UF 50V 20% Z5U 061346C291 CAP ELECT 1000UF 25V 066513C300 CAP MONO .1UF 50V 20% Z5U 061346C335 CAP ELECT 10UF 16V 066580C336 CAP ELECT 10UF 16V 066580C337 CAP ELECT 10UF 16V 066580C338 CAP ELECT 10UF 16V 066580C340 CAP ELECT 47UF 50V 066215C341 CAP MONO 1000PF 50V 10% NPO 061344C342 CAP MONO 1000PF 50V 10% NPO 061344C343 CAP MONO 1000PF 50V 10% NPO 061344C344 CAP MONO 1000PF 50V 10% NPO 061344C351 CAP ELECT 47UF 50V 066215C390 CAP ELECT 470UF 50V 066469C393 CAP MONO .1UF 50V 20% Z5U 061346C394 CAP MONO .1UF 50V 20% Z5U 061346C395 CAP MONO 220PF 200V 10% NPO 061342C396 CAP MONO .1UF 50V 20% Z5U 061346C397 CAP MONO 220PF 200V 10% NPO 061342C398 CAP MONO .1UF 50V 20% Z5U 061346C399 CAP MONO .1UF 50V 20% Z5U 061346C350 CAP ELECT 22UF 100V 066574C450 CAP ELECT 10UF 16V 066580D1 DIODE ZENER 33V 5% 1/2W 070182D2 DIODE ZENER 5.1V 070186D3 DIODE ZENER 6.2V 5% 500MW 070184D5 DIODE SILICON 070174D6 DIODE SILICON 070174D7 DIODE SILICON 070174D8 DIODE SILICON 070174D9 DIODE SILICON 070174D10 DIODE SILICON 070174D11 DIODE SILICON 070174D19 DIODE SILICON 070174D27 DIODE RECTIFIER 070175D28 DIODE RECTIFIER 070175D29 DIODE RECT SI 3A 100V 070176D30 DIODE RECT SI 3A 100V 070176D31 DIODE RECT SI 3A 100V 070176D32 DIODE RECT SI 3A 100V 070176D34 DIODE RECTIFIER 070175D35 DIODE RECTIFIER 070175D36 DIODE RECTIFIER 070175D37 DIODE RECTIFIER 070175D40 DIODE RECTIFIER 070175D41 DIODE RECTIFIER 070175D100 DIODE RECTIFIER 070175D101 DIODE RECTIFIER 070175F1 FUSE 3.15A SLO-BLO 5X20 IEC 089130(F1) HOLDER FUSE 5X20MM PCB MOUNT 178159F2 FUSE 3.15A SLO-BLO 5X20 IEC 089130(F2) HOLDER FUSE 5X20MM PCB MOUNT 178159F3 FUSE 0.5A SLO-BLO 5X20 IEC 089126(F3) HOLDER FUSE 5X20MM PCB MOUNT 178159

WASHER SHLDR #10 BLK NYLN INS 104101RIVET 1/8X3/16 STEEL 108011

MX120

65

SURROUND PCB 750570 (Cont’d.)Ref. No. Description Part No.


HS1 HEATSINK TO-220 080023(HS1) INSULATOR ISOSTRATE TO 220 084133IC1 IC VOLUME CONTROL 133583IC3 IC QUAD OPERATIONAL AMPLIFIER 133596IC4 IC REGULATOR 3.3V LOW DROPOUT 133630(IC4) HEATSINK TO-218 080020(IC4) INSULATOR ISOSTRATE TO 220 084133IC5 IC VOLUME CONTROL 133583IC6 IC VOLUME CONTROL 133583IC7 IC VOLUME CONTROL 133583IC8 IC VOLUME CONTROL 133583IC9 IC VOLUME CONTROL 133583IC10 IC VOLUME CONTROL 133583IC11 IC VOLUME CONTROL 133583IC16 IC VOLUME CONTROL 133583IC17 IC VOLUME CONTROL 133583IC18 IC OCTAL D TYPE FLIP FLOP 133603IC19 IC OCTAL D TYPE FLIP FLOP 133603IC20 IC VOLUME CONTROL 133583IC21 IC VOLUME CONTROL 133583IC22 IC VOLUME CONTROL 133583IC23 IC VOLUME CONTROL 133583IC24 IC VOLUME CONTROL 133583IC25 IC QUAD OPERATIONAL AMPLIFIER 133596IC26 IC QUAD OPERATIONAL AMPLIFIER 133596IC27 IC QUAD OPERATIONAL AMPLIFIER 133596IC28 IC QUAD OPERATIONAL AMPLIFIER 133596IC30 IC RS232 DRIVER LINE 133561IC31 IC REGULATOR +12V 133571IC32 IC REGULATOR 24V NEG 133600IC33 IC REGULATOR +15V 133587IC33 HEATSINK TO-218 080020(IC33) INSULATOR ISOSTRATE TO 220 084133IC34 IC VOLTAGE REGULATOR -15V 133566(IC34) HEATSINK TO-218 080020(IC34) INSULATOR ISOSTRATE TO 220 084133IC35 IC MONOSTB MULTIVIB X 2 133593IC36 IC REGULATOR +5V 133569(IC36) HEATSINK TO-218 080020(IC36) INSULATOR ISOSTRATE TO 220 084133IC37 IC 5V 1.5A REGULATOR LOW DROP 133610(IC37) HEATSINK TO-218 080020(IC37) INSULATOR ISOSTRATE TO 220 084133IC38 COUPLER OPTICAL SCHMITT OUTPUT 131030IC40 IC BIFET OP AMP 133560IC41 IC BIFET OP AMP 133560IC42 IC BIFET OP AMP 133560IC44 IC BIFET OP AMP 133560IC45 IC BIFET OP AMP 133560IC46 IC BIFET OP AMP 133560IC48 IC 2 INPUT X 4 133591IC49 IC 2 INPUT X 4 133591IC51 IC 2 INPUT X 4 133591IC52 IC 2 INPUT X 4 133591IC55 IC QUAD OPERATIONAL AMPLIFIER 133596IC56 IC QUAD OPERATIONAL AMPLIFIER 133596IC59 COUPLER OPTICAL SCHMITT OUTPUT 131030IC66 IC SPST QUAD FET SWITCHES N O 133580IC69 IC OPERATIONAL AMPLIFIER 133626IC70 IC OCTAL DAR TRNS ARRY W/DIODE 133624

IC71 IC SPST QUAD FET SWITCHES N O 133580IC73 IC QUAD OPERATIONAL AMPLIFIER 133596IC80 IC 5V 1.5A REGULATOR LOW DROP 133610(IC80) HEATSINK TO-218 080020(IC80) INSULATOR ISOSTRATE TO 220 084133IC91 IC VOLUME CONTROL 133583IC92 IC VOLUME CONTROL 133583IC93 IC BIFET OP AMP 133560IC94 IC BIFET OP AMP 133560IC150 IC HEX INVERTER 133193J1 CONN MALE 10 POS 117219J2 CONN 12 PIN FFC 117907J3 CONN 12 PIN FFC 117907J4 CONN MALE 5 PIN 0.1 POST ASSY 117216J6 CONN MALE 9 POS FRICTION LOCK 117244J7 CONN MALE 5 PIN 0.1 POST ASSY 117216J8 CONN MALE 10 POS 117219J9 CONN SUB D 25 PIN 117959J10 CONN MALE 10 POS 117219J15 CONN MALE 9 POS FRICTION LOCK 117244J16 CONN MALE 10 POS 117219J19 CONN MALE 10 POS 117219J20 CONN 9 PIN SUB D 117902J20_ CONN 4 PIN 117215J21 JACK HEADPHONE DUAL BLACK 1/8” 117549J22 BLADE FASTON W/FEET 117708J23 BLADE FASTON W/FEET 117708J24 BLADE FASTON W/FEET 117708J26 BLADE FASTON W/FEET 117708J27 BLADE FASTON W/FEET 117708J28 BLADE FASTON W/FEET 117708J29 BLADE FASTON W/FEET 117708J30 BLADE FASTON W/FEET 117708J31 CONN 4 PIN 117215J32 CONN 12 PIN FFC 117907J33 JACK HEADPHONE DUAL BLACK 1/8” 117549J34 JACK HEADPHONE DUAL BLACK 1/8” 117549J40 JACK RCA 4X2 WHT/RED 14MM 117791J41 JACK RCA 4X2 WHT/RED 14MM 117791J45 JACK RJ45 117898J46 JACK RJ45 117898

CONN HEADER SOCKET 2X20 117799J93 JACK RCA 1X2 WHT/RED 14MM 117788K4 RELAY REED FORM 1A 5V 500 OHMS 087050K5 RELAY REED FORM 1A 5V 500 OHMS 087050K6 RELAY REED FORM 1A 5V 500 OHMS 087050K7 RELAY REED FORM 1A 5V 500 OHMS 087050K8 RELAY REED FORM 1A 5V 500 OHMS 087050K9 RELAY REED FORM 1A 5V 500 OHMS 087050K10 RELAY REED FORM 1A 5V 500 OHMS 087050K11 RELAY REED FORM 1A 5V 500 OHMS 087050K12 RELAY POWER TV5 24V 087069K13 RELAY 24VDC 5A 277VAC 087057K15 RELAY REED FORM 1A 5V 500 OHMS 087050K20 RELAY REED FORM 1A 5V 500 OHMS 087050K21 RELAY REED FORM 1A 5V 500 OHMS 087050L10 BEADS FERRITE LEADED 076023L11 BEADS FERRITE LEADED 076023L12 BEADS FERRITE LEADED 076023L17 BEADS FERRITE LEADED 076023

66



P1 SOCKET STRIP .025 SQ 20 PIN 117642P3 SOCKET STRIP .025 SQ 20 PIN 117642P6 SOCKET STRIP .025 SQ 20 PIN 117642

DECAL FUSE 3.15A SLO-BLO 126976PCB1 PC BD SURROUND 129782Q4 HEATSINK TO-218 080020(Q4) IC VOLTAGE REGULATOR -5.2V 133567Q10 TRANSISTOR NPN DAR 132303Q3 Q9 Q11 TRANSISTOR NPN SILICON 132317(Q4) INSULATOR ISOSTRATE TO 220 084133R1 RES MF 1.1K 1% 1/4W 144514R2 RES MF 20K 1% 1/4W 144524R3 RES WW 100 OHM 10% 2W BWH 139134R4 RES MF 8.25K 1% 1/4W 144549R5 RES FP 1.1 OHM 5% 1/4W 137002R6 RES MF 20K 1% 1/4W 144524R7 RES MF 10K 1% 1/4W 144504R8 RES NETWORK 2 X 100 OHM ISO 144680R9 RES MF 100 OHM 1% 1/4W 144568R10 RES MF 75 OHM 1% 1/4W 144644R11 RES NETWORK 2 X 100 OHM ISO 144680R12 RES 1.37K 1% 1/4W 144515R14 RES 1.37K 1% 1/4W 144515R15 RES 1.37K 1% 1/4W 144515R16 RES 1.37K 1% 1/4W 144515R17 RES MF 1.65K 1% 1/4W 144516R23 RES NETWORK 4 X 1K ISOLATED 144500R25 RES NETWORK 4 X 1K ISOLATED 144500R27 RES MF 1.1K 1% 1/4W 144514R28 RES POLYSWITCH RXE030 144670R29 RES POLYSWITCH RXE030 144670R30 RES MF 10K 1% 1/4W 144504R31 RES MF 1.21K 1% 1/4W 144566R39 RES MF 100K 1% 1/4W 144528R40 RES MF 8.25K 1% 1/4W 144549R42 RES MF 10K 1% 1/4W 144504R43 RES NETWORK 2 X 22K ISO 144689R44 RES NETWORK 2 X 22K ISO 144689R45 RES MF 20K 1% 1/4W 144524R47 RES MF 20K 1% 1/4W 144524R48 RES MF 3.32K 1% 1/4W 144518R50 RES MF 20K 1% 1/4W 144524R51 RES MF 3.32K 1% 1/4W 144518R54 RES MF 100K 1% 1/4W 144528R55 RES NETWORK 2 X 22K ISO 144689R57 RES MF 10K 1% 1/4W 144504R58 RES MF 1.65K 1% 1/4W 144516R59 RES MF 1.65K 1% 1/4W 144516R60 RES MF 1.65K 1% 1/4W 144516R63 RES NETWORK 2 X 100 OHM ISO 144680R64 RES MF 10K 1% 1/4W 144504R66 RES MF 100K 1% 1/4W 144528R67 RES MF 3.32K 1% 1/4W 144518R68 RES MF 20K 1% 1/4W 144524R69 RES MF 3.32K 1% 1/4W 144518R70 RES MF 20K 1% 1/4W 144524R72 RES NETWORK 2 X 220K ISO 144678R74 RES NETWORK 2 X 22K ISO 144689R78 RES NETWORK 2 X 100 OHM ISO 144680R79 RES NETWORK 2 X 100 OHM ISO 144680

R82 RES MF 1.65K 1% 1/4W 144516R87 RES MF 10K 1% 1/4W 144504R88 RES MF 8.25K 1% 1/4W 144549R89 RES MF 20K 1% 1/4W 144524R90 RES MF 8.25K 1% 1/4W 144549R91 RES MF 20K 1% 1/4W 144524R115 RES MF 100K 1% 1/4W 144528R116 RES MF 3.32K 1% 1/4W 144518R117 RES MF 20K 1% 1/4W 144524R118 RES MF 3.32K 1% 1/4W 144518R119 RES MF 100K 1% 1/4W 144528R120 RES MF 10K 1% 1/4W 144504R121 RES MF 10K 1% 1/4W 144504R122 RES MF 8.25K 1% 1/4W 144549R123 RES MF 20K 1% 1/4W 144524R124 RES MF 8.25K 1% 1/4W 144549R125 RES MF 20K 1% 1/4W 144524R126 RES MF 20K 1% 1/4W 144524R127 RES MF 3.32K 1% 1/4W 144518R128 RES MF 20K 1% 1/4W 144524R129 RES MF 3.32K 1% 1/4W 144518R131 RES MF 10K 1% 1/4W 144504R133 RES NETWORK 2 X 22K ISO 144689R135 RES NETWORK 2 X 22K ISO 144689R137 RES NETWORK 2 X 22K ISO 144689R138 RES NETWORK 2 X 22K ISO 144689R141 RES NETWORK 2 X 22K ISO 144689R146 RES MF 100K 1% 1/4W 144528R152 RES NETWORK 2 X 22K ISO 144689R158 RES MF 30.1K 1% 1/4W 144573R159 RES MF 30.1K 1% 1/4W 144573R161 RES MF 30.1K 1% 1/4W 144573R165 RES MF 61.9K 1% 1/4W 144596R167 RES MF 40.2K 1% 1/4W 144525R168 RES MF 40.2K 1% 1/4W 144525R170 RES MF 61.9K 1% 1/4W 144596R171 RES MF 4.02K 1% 1/4W 144519R172 RES MF 1.65K 1% 1/4W 144516R173 RES MF 2.67K 1% 1/4W 144534R174 RES MF 1.65K 1% 1/4W 144516R175 RES MF 221 OHM 1% 1/4W 144559R176 RES MF 1.1K 1% 1/4W 144514R177 RES MF 27.4K 1% 1/4W 144545R178 RES MF 20K 1% 1/4W 144524R179 RES MF 35.7K 1% 1/4W 144368R183 RES MF 35.7K 1% 1/4W 144368R184 RES MF 20K 1% 1/4W 144524R185 RES MF 27.4K 1% 1/4W 144545R189 RES MF 221 OHM 1% 1/4W 144559R190 RES MF 100K 1% 1/4W 144528R191 RES MF 100K 1% 1/4W 144528R192 RES MF 100K 1% 1/4W 144528R193 RES NETWORK 2 X 22K ISO 144689R196 RES NETWORK 2 X 22K ISO 144689R201 RES MF 10 OHM 1% 1/4W 144553R203 RES MF 100K 1% 1/4W 144528R204 RES MF 100K 1% 1/4W 144528R205 RES MF 100K 1% 1/4W 144528R206 RES MF 100K 1% 1/4W 144528R207 RES MF 100K 1% 1/4W 144528

MX120

67



DATA PCB 7505724

BRKT1 BRACKET PCB CARD MOUNTING 003611BRKT2 BRACKET PCB CARD MOUNTING 003611BRKT3 BRACKET PCB CARD MOUNTING 003611C1 CAP MONO .1UF 50V 20% Z5U 061346C2 CAP MONO .1UF 50V 20% Z5U 061346C3 CAP MONO .1UF 50V 20% Z5U 061346C4 CAP MONO .1UF 50V 20% Z5U 061346C5 CAP MONO .1UF 50V 20% Z5U 061346C6 CAP MONO .1UF 50V 20% Z5U 061346C7 CAP MONO .1UF 50V 20% Z5U 061346C8 CAP MONO .1UF 50V 20% Z5U 061346C10 CAP MPF 0.1UF 5% 63VDC 064325C11 CAP MPF 0.1UF 5% 63VDC 064325C12 CAP MPF 0.1UF 5% 63VDC 064325C13 CAP MPF 0.1UF 5% 63VDC 064325C14 CAP MONO .1UF 50V 20% Z5U 061346C15 CAP ELECT 47UF 35V 066446C16 CAP MONO .1UF 50V 20% Z5U 061346C17 CAP MONO .1UF 50V 20% Z5U 061346C18 CAP MONO .1UF 50V 20% Z5U 061346C19 CAP MONO .1UF 50V 20% Z5U 061346C21 CAP MONO .1UF 50V 20% Z5U 061346C22 CAP ELECT 47UF 35V 066446C23 CAP MONO .1UF 50V 20% Z5U 061346

R208 RES MF 100K 1% 1/4W 144528R209 RES MF 100K 1% 1/4W 144528R210 RES MF 100K 1% 1/4W 144528R211 RES MF 100K 1% 1/4W 144528R212 RES MF 100K 1% 1/4W 144528R213 RES MF 1.65K 1% 1/4W 144516R214 RES MF 5.62K OHM 1% 1/4W 144647R215 RES MF 1.65K 1% 1/4W 144516R216 RES MF 1.65K 1% 1/4W 144516R217 RES MF 1.65K 1% 1/4W 144516R218 RES MF 1.65K 1% 1/4W 144516R219 RES MF 1.65K 1% 1/4W 144516R220 RES MF 1.65K 1% 1/4W 144516R221 RES MF 1.65K 1% 1/4W 144516R222 RES MF 1.65K 1% 1/4W 144516R223 RES MF 5.62K OHM 1% 1/4W 144647R224 RES 1.37K 1% 1/4W 144515R225 RES 1.37K 1% 1/4W 144515R226 RES 1.37K 1% 1/4W 144515R227 RES 1.37K 1% 1/4W 144515R228 RES 1.37K 1% 1/4W 144515R229 RES 1.37K 1% 1/4W 144515R230 RES 1.37K 1% 1/4W 144515R231 RES 1.37K 1% 1/4W 144515R232 RES MF 100K 1% 1/4W 144528R233 RES MF 100K 1% 1/4W 144528R234 RES MF 100K 1% 1/4W 144528R235 RES 1.37K 1% 1/4W 144515R236 RES 1.37K 1% 1/4W 144515R237 RES 1.37K 1% 1/4W 144515R238 RES 1.37K 1% 1/4W 144515R239 RES NETWORK 2 X 100 OHM ISO 144680R240 RES NETWORK 2 X 100 OHM ISO 144680R241 RES NETWORK 2 X 100 OHM ISO 144680R243 RES NETWORK 2 X 100 OHM ISO 144680R244 RES NETWORK 2 X 100 OHM ISO 144680R245 RES NETWORK 2 X 100 OHM ISO 144680R278 RES MF 10 OHM 1% 1/4W 144553R279 RES MF 10 OHM 1% 1/4W 144553R280 RES MF 10 OHM 1% 1/4W 144553R281 RES MF 10 OHM 1% 1/4W 144553R282 RES MF 10 OHM 1% 1/4W 144553R283 RES MF 10 OHM 1% 1/4W 144553R299 RES MF 10K 1% 1/4W 144504R300 RES MF 10K 1% 1/4W 144504R313 RES MF 100K 1% 1/4W 144528R314 RES MF 100K 1% 1/4W 144528R315 RES MF 10 OHM 1% 1/4W 144553R316 RES MF 100K 1% 1/4W 144528R317 RES MF 10 OHM 1% 1/4W 144553R318 RES MF 100K 1% 1/4W 144528R319 RES 1.37K 1% 1/4W 144515R320 RES 1.37K 1% 1/4W 144515R321 RES MF 1.65K 1% 1/4W 144516R322 RES MF 1.65K 1% 1/4W 144516R323 RES 1.37K 1% 1/4W 144515R324 RES 1.37K 1% 1/4W 144515R325 RES MF 1.65K 1% 1/4W 144516R326 RES MF 1.65K 1% 1/4W 144516R327 RES NETWORK 2 X 22K ISO 144689

R329 RES NETWORK 2 X 220K ISO 144678R330 RES NETWORK 2 X 100 OHM ISO 144680R340 RES FP 10 OHM 5% 1/4W 137105R350 RES MF 10 OHM 1% 1/4W 144553R360 RES MF 4.75K 1% 1/4W 144520R361 RES MF 4.75K 1% 1/4W 144520R375 RES MF 3.32K 1% 1/4W 144518R376 RES MF 1.65K 1% 1/4W 144516R380 RES NETWORK 2 X 100 OHM ISO 144680R382 RES NETWORK 2 X 100 OHM ISO 144680R384 RES NETWORK 2 X 100 OHM ISO 144680R386 RES MF 61.9K 1% 1/4W 144596R387 RES MF 61.9K 1% 1/4W 144596R390 RES NETWORK 2 X 220K ISO 144678R391 RES NETWORK 2 X 220K ISO 144678R393 RES MF 1.1K 1% 1/4W 144514R400 RES MF 100K 1% 1/4W 144528R401 RES MF 100K 1% 1/4W 144528R402 RES MF 100K 1% 1/4W 144528R403 RES MF 100K 1% 1/4W 144528R450 RES MF 100K 1% 1/4W 144528R328 RES NETWORK 2 X 22K ISO 144689R22 RES NETWORK 470K X 6 144690S1 SWITCH SLIDE DPDT 148076

SOCKET IC 20 PIN 178181SOCKET IC DIP 16 PIN DUAL 178182CUTLIST MX119 184119SCR MS 4-40 X 1/4 PH PN BLK 400121NUT KEP 4-40 CLR 402001STANDOFF 4-40 X 7/16 M/F 412084ASSY INSERTION PCB SURROUND 702412

68



C24 CAP ELECT 47UF 35V 066446C25 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP ELECT 47UF 35V 066446C30 CAP MONO 220PF 200V 10% NPO 061342C35 CAP MONO .1UF 50V 20% Z5U 061346C40 CAP MONO 220PF 200V 10% NPO 061342C41 CAP MONO 220PF 200V 10% NPO 061342D20 DIODE SILICON 070174D21 DIODE SILICON 070174IC1 IC 2 INPUT X 4 133591IC2 IC 2 INPUT X 4 133591IC3 IC NOR 2 INPUT X 4 133592IC4 IC AND 2 INPUT X 4 133577IC5 IC SHFT REG SER-PAR 133594IC6 IC SHFT REG SER-PAR 133594IC7 IC SHFT REG SER-PAR 133594IC8 IC SHFT REG SER-PAR 133594IC9 IC SHFT REG SER-PAR 133594IC10 IC 8 LN DRIVER ARRAY 133180(IC10) IC SOCKET 18 PIN DIP 178184IC11 IC 8 LN DRIVER ARRAY 133180(IC11) IC SOCKET 18 PIN DIP 178184IC12 IC 8 LN DRIVER ARRAY 133180(IC12) IC SOCKET 18 PIN DIP 178184IC23 IC LINE RECEIVER QUAD 133428IC24 IC 2 INPUT X 4 133591IC25 IC HEX UNBUF INVERTER 133576IC35 IC 8 LN DRIVER ARRAY 133180(IC35) IC SOCKET 18 PIN DIP 178184IC40 IC 8-INPUT SEL/MULTI 133219J5_ CONN MALE 9 POS FRICTION LOCK 117244J8 JACK MINI 117494J9 JACK MINI 117494J14 JACK MINI 117494J15 JACK MINI 117494J16 JACK MINI 117494J17 JACK MINI 117494J18 JACK MINI 117494J19 JACK MINI 117494J20 JACK MINI 117494J21 JACK MINI 117494J22 JACK MINI 117494J36 JACK RCA 4X1 ORANGE 14MM 117778J37 CONN MALE 10 POS RIGHT ANGLE 117260L1 INDUCTOR 3.9UH 5% 122400L2 CHOKE 18UH 5%-10% 122394L3 CHOKE 18UH 5%-10% 122394L4 CHOKE 18UH 5%-10% 122394L5 CHOKE 18UH 5%-10% 122394L6 CHOKE 18UH 5%-10% 122394L7 CHOKE 18UH 5%-10% 122394L8 CHOKE 18UH 5%-10% 122394L9 CHOKE 18UH 5%-10% 122394L10 CHOKE 18UH 5%-10% 122394PCB1 PC BD DATA 129774OPT1 FIBER OPTIC RECEIVER 058179OPT2 FIBER OPTIC RECEIVER 058179OPT3 FIBER OPTIC RECEIVER 058179OPT4 TRANSMITTER FIBER OPTIC 058180R1 RES NETWORK 5 X 100 ISO 144677

R2 RES NETWORK 5 X 100 ISO 144677R3 RES NETWORK 5 X 100 ISO 144677R5 RES MF 100K 1% 1/4W 144528R6 RES MF 100K 1% 1/4W 144528R7 RES MF 100K 1% 1/4W 144528R8 RES MF 100K 1% 1/4W 144528R10 RES MF 100K 1% 1/4W 144528R11 RES MF 100K 1% 1/4W 144528R20 RES MF 1K 1% 1/4W 144513R30 RES MF 75 OHM 1% 1/4W 144644R31 RES MF 75 OHM 1% 1/4W 144644R32 RES MF 75 OHM 1% 1/4W 144644R33 RES MF 365 OHM 1% 1/4W 144505R34 RES MF 95.3 OHM 1% 1/4W 144572R40 RES MF 10K 1% 1/4W 144504R60 RES MF 100K 1% 1/4W 144528R61 RES MF 1K 1% 1/4W 144513R63 RES MF 100K 1% 1/4W 144528T1 TRANSFORMER DIGITAL INTERFACE159351

RIVET 1/8X3/16 STEEL 108011ASSY INSERTION PCB DATA 702414

S-VIDEO PCB 7505744

C3 CAP MONO .1UF 50V 20% Z5U 061346C4 CAP MONO .1UF 50V 20% Z5U 061346C7 CAP MONO .1UF 50V 20% Z5U 061346C8 CAP MONO .1UF 50V 20% Z5U 061346C9 CAP MONO .1UF 50V 20% Z5U 061346C11 CAP MONO .1UF 50V 20% Z5U 061346C13 CAP MONO .1UF 50V 20% Z5U 061346C15 CAP MONO .1UF 50V 20% Z5U 061346C16 CAP ELECT 10UF 50V 066445C17 CAP ELECT 10UF 50V 066445C24 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP MONO .1UF 50V 20% Z5U 061346C30 CAP MONO .1UF 50V 20% Z5U 061346C32 CAP MONO .1UF 50V 20% Z5U 061346C34 CAP MONO .1UF 50V 20% Z5U 061346C36 CAP MONO .1UF 50V 20% Z5U 061346C48 CAP ELECT 10UF 50V 066445C49 CAP ELECT 10UF 50V 066445C51 CAP ELECT 10UF 50V 066445C54 CAP ELECT 10UF 50V 066445C59 CAP MONO .1UF 50V 20% Z5U 061346C60 CAP MONO .1UF 50V 20% Z5U 061346C61 CAP MONO .1UF 50V 20% Z5U 061346C70 CAP MONO .1UF 50V 20% Z5U 061346C71 CAP MONO .1UF 50V 20% Z5U 061346C72 CAP MONO .1UF 50V 20% Z5U 061346C73 CAP MONO .1UF 50V 20% Z5U 061346C74 CAP ELECT 47UF 16V 066380C75 CAP ELECT 47UF 16V 066380C76 CAP ELECT 47UF 16V 066380C77 CAP ELECT 47UF 16V 066380C80 CAP MONO 220PF 200V 10% NPO 061342C81 CAP MONO 220PF 200V 10% NPO 061342C90 CAP ELECT 47UF 16V 066380C91 CAP ELECT 47UF 16V 066380D5 DIODE SIL 400 PIV @ 1.5A 070031

MX120

69

S-VIDEO PCB 750574 (Cont’d.)Ref. No. Description Part No.


5

D6 DIODE SIL 400 PIV @ 1.5A 070031RIVET 1/8X3/16 STEEL 108011

IC1 IC SPST QUAD FET SWITCHES N O 133580IC2 IC SPST QUAD FET SWITCHES N O 133580IC3 IC SPST QUAD FET SWITCHES N O 133580IC4 IC SPST QUAD FET SWITCHES N O 133580IC5 IC SPST QUAD FET SWITCHES N O 133580IC6 IC SPST QUAD FET SWITCHES N O 133580IC9 IC SPST QUAD FET SWITCHES N O 133580IC10 IC SPST QUAD FET SWITCHES N O 133580IC20 IC SHFT REG SER-PAR 133594IC21 IC SHFT REG SER-PAR 133594IC22 IC SHFT REG SER-PAR 133594IC30 IC SHFT REG SER-PAR 133594IC31 IC SHFT REG SER-PAR 133594J1 JACK S-VIDEO 3X1 14MM 117779J2 JACK S-VIDEO 3X1 14MM 117779J5 JACK S-VIDEO 3X1 14MM 117779J20 CONN MALE 10 POS RIGHT ANGLE 117260J23 CONN MALE 6 POS FRICTION LOCK 117218J25_ CONN 4 PIN 117215PCB1 PC BD S-VIDEO 129776Q1 TRANSISTOR NPN SILICON 132317R1 RES MF 75 OHM 1% 1/4W 144644R2 RES MF 75 OHM 1% 1/4W 144644R3 RES MF 75 OHM 1% 1/4W 144644R4 RES MF 75 OHM 1% 1/4W 144644R5 RES MF 75 OHM 1% 1/4W 144644R6 RES MF 806 OHM 1% 1/4W 144512R7 RES MF 75 OHM 1% 1/4W 144644R8 RES MF 75 OHM 1% 1/4W 144644R9 RES MF 75 OHM 1% 1/4W 144644R10 RES MF 75 OHM 1% 1/4W 144644R11 RES MF 806 OHM 1% 1/4W 144512R12 RES MF 75 OHM 1% 1/4W 144644R13 RES MF 75 OHM 1% 1/4W 144644R14 RES MF 75 OHM 1% 1/4W 144644R16 RES MF 75 OHM 1% 1/4W 144644R21 RES MF 10K 1% 1/4W 144504R22 RES MF 806 OHM 1% 1/4W 144512R23 RES MF 806 OHM 1% 1/4W 144512R24 RES MF 10K 1% 1/4W 144504R25 RES MF 75 OHM 1% 1/4W 144644R33 RES MF 75 OHM 1% 1/4W 144644R34 RES MF 10K 1% 1/4W 144504R35 RES MF 75 OHM 1% 1/4W 144644R36 RES MF 806 OHM 1% 1/4W 144512R37 RES MF 806 OHM 1% 1/4W 144512R38 RES MF 806 OHM 1% 1/4W 144512R39 RES MF 10K 1% 1/4W 144504R40 RES MF 806 OHM 1% 1/4W 144512R41 RES MF 47.5K 1% 1/4W 144526R42 RES MF 47.5K 1% 1/4W 144526R43 RES MF 47.5K 1% 1/4W 144526R44 RES MF 47.5K 1% 1/4W 144526R45 RES MF 47.5K 1% 1/4W 144526R46 RES MF 47.5K 1% 1/4W 144526R50 RES FP 10 OHM 5% 1/4W 137105R52 RES FP 10 OHM 5% 1/4W 137105R54 RES FP 10 OHM 5% 1/4W 137105

R56 RES FP 10 OHM 5% 1/4W 137105R58 RES MF 47.5K 1% 1/4W 144526R59 RES MF 47.5K 1% 1/4W 144526R60 RES MF 47.5K 1% 1/4W 144526R61 RES MF 47.5K 1% 1/4W 144526R62 RES MF 47.5K 1% 1/4W 144526R63 RES MF 47.5K 1% 1/4W 144526R67 RES FP 10 OHM 5% 1/4W 137105R76 RES FP 10 OHM 5% 1/4W 137105R77 RES MF 1K 1% 1/4W 144513R80 RES FP 10 OHM 5% 1/4W 137105R81 RES FP 10 OHM 5% 1/4W 137105R83 RES MF 47.5K 1% 1/4W 144526R84 RES MF 47.5K 1% 1/4W 144526R85 RES FP 10 OHM 5% 1/4W 137105R86 RES MF 10K 1% 1/4W 144504R87 RES MF 4.99K 1% 1/4W 144521R88 RES FP 10 OHM 5% 1/4W 137105R89 RES MF 4.99K 1% 1/4W 144521R90 RES MF 75 OHM 1% 1/4W 144644R92 RES MF 806 OHM 1% 1/4W 144512R93 RES MF 806 OHM 1% 1/4W 144512R94 RES MF 10K 1% 1/4W 144504R95 RES MF 806 OHM 1% 1/4W 144512R96 RES MF 10K 1% 1/4W 144504R97 RES MF 806 OHM 1% 1/4W 144512R98 RES MF 47.5K 1% 1/4W 144526R91 RES MF 75 OHM 1% 1/4W 144644R75 RES NETWORK 2 X 22K ISO 144689SP1 BRACKET PCB CARD MOUNTING 003611SP2 BRACKET PCB CARD MOUNTING 003611U14 IC 100MA I FEEDBACK AMP 133579U15 IC 100MA I FEEDBACK AMP 133579U16 IC 100MA I FEEDBACK AMP 133579

ASSY INSERTION PCB S-VIDEO 702416

VIDEO PCB 7505736C5 CAP ELECT 10UF 50V 066445C6 CAP ELECT 10UF 50V 066445C7 CAP ELECT 10UF 50V 066445C8 CAP ELECT 10UF 50V 066445C11 CAP MONO .1UF 50V 20% Z5U 061346C13 CAP MONO .1UF 50V 20% Z5U 061346C14 CAP MONO .1UF 50V 20% Z5U 061346C16 CAP MONO .1UF 50V 20% Z5U 061346C18 CAP MONO .1UF 50V 20% Z5U 061346C19 CAP MONO .1UF 50V 20% Z5U 061346C20 CAP MONO .1UF 50V 20% Z5U 061346C22 CAP MONO .1UF 50V 20% Z5U 061346C23 CAP MONO .1UF 50V 20% Z5U 061346C24 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP MONO .1UF 50V 20% Z5U 061346C30 CAP MONO .1UF 50V 20% Z5U 061346C31 CAP MONO .1UF 50V 20% Z5U 061346C32 CAP MONO .1UF 50V 20% Z5U 061346C33 CAP MONO .1UF 50V 20% Z5U 061346C35 CAP ELECT 47UF 16V 066380C36 CAP ELECT 47UF 16V 066380C37 CAP ELECT 47UF 16V 066380

70

VIDEO PCB 750573 (Cont’d.)Ref. No. Description Part No.


INPUT PCB 7505717

6

C38 CAP ELECT 47UF 16V 066380C39 CAP ELECT 47UF 16V 066380C42 CAP ELECT 47UF 16V 066380C43 CAP ELECT 47UF 16V 066380C44 CAP ELECT 47UF 16V 066380C46 CAP ELECT 47UF 16V 066380C48 CAP MONO .1UF 50V 20% Z5U 061346C50 CAP MONO .1UF 50V 20% Z5U 061346C51 CAP MONO .1UF 50V 20% Z5U 061346C55 CAP MONO .1UF 50V 20% Z5U 061346C83 CAP MONO 220PF 200V 10% NPO 061342D1 DIODE SIL 400 PIV @ 1.5A 070031D2 DIODE SIL 400 PIV @ 1.5A 070031

RIVET 1/8X3/16 STEEL 108011IC2 IC SPST QUAD FET SWITCHES N O 133580IC3 IC SPST QUAD FET SWITCHES N O 133580IC4 IC SPST QUAD FET SWITCHES N O 133580IC7 IC SPST QUAD FET SWITCHES N O 133580IC8 IC SHFT REG SER-PAR 133594IC9 IC 100MA I FEEDBACK AMP 133579IC10 IC 100MA I FEEDBACK AMP 133579IC13 IC SHFT REG SER-PAR 133594IC14 IC SHFT REG SER-PAR 133594IC15 IC SHFT REG SER-PAR 133594IC16 IC SPST QUAD FET SWITCHES N O 133580IC17 IC SHFT REG SER-PAR 133594IC19 IC NAND SCHMIT 2-IN X 4 133595J1 JACK RCA 3X1 YELLOW 14MM 117777J2 JACK RCA 3X1 YELLOW 14MM 117777J5 JACK RCA 3X1 YELLOW 14MM 117777J10 CONN 4 PIN 117215J20 CONN MALE 12 POS ASSY 117220PCB1 PC BD VIDEO 129775R2 RES MF 10K 1% 1/4W 144504R3 RES MF 75 OHM 1% 1/4W 144644R5 RES MF 75 OHM 1% 1/4W 144644R9 RES MF 10K 1% 1/4W 144504R10 RES MF 806 OHM 1% 1/4W 144512R11 RES MF 75 OHM 1% 1/4W 144644R12 RES MF 806 OHM 1% 1/4W 144512R13 RES MF 75 OHM 1% 1/4W 144644R14 RES MF 75 OHM 1% 1/4W 144644R15 RES MF 75 OHM 1% 1/4W 144644R16 RES MF 806 OHM 1% 1/4W 144512R17 RES MF 75 OHM 1% 1/4W 144644R18 RES MF 806 OHM 1% 1/4W 144512R19 RES MF 10K 1% 1/4W 144504R21 RES MF 806 OHM 1% 1/4W 144512R22 RES MF 806 OHM 1% 1/4W 144512R23 RES MF 75 OHM 1% 1/4W 144644R24 RES MF 806 OHM 1% 1/4W 144512R25 RES MF 75 OHM 1% 1/4W 144644R26 RES MF 806 OHM 1% 1/4W 144512R27 RES MF 10K 1% 1/4W 144504R28 RES MF 75 OHM 1% 1/4W 144644R29 RES FP 10 OHM 5% 1/4W 137105R30 RES MF 47.5K 1% 1/4W 144526R32 RES FP 10 OHM 5% 1/4W 137105R33 RES FP 10 OHM 5% 1/4W 137105R34 RES FP 10 OHM 5% 1/4W 137105

R35 RES FP 10 OHM 5% 1/4W 137105R37 RES MF 47.5K 1% 1/4W 144526R38 RES MF 47.5K 1% 1/4W 144526R39 RES MF 47.5K 1% 1/4W 144526R40 RES MF 47.5K 1% 1/4W 144526R41 RES MF 47.5K 1% 1/4W 144526R42 RES MF 47.5K 1% 1/4W 144526R51 RES MF 47.5K 1% 1/4W 144526R52 RES MF 47.5K 1% 1/4W 144526R53 RES MF 47.5K 1% 1/4W 144526R54 RES MF 47.5K 1% 1/4W 144526R55 RES FP 10 OHM 5% 1/4W 137105R56 RES MF 4.99K 1% 1/4W 144521R57 RES FP 10 OHM 5% 1/4W 137105R58 RES MF 4.99K 1% 1/4W 144521R59 RES MF 47.5K 1% 1/4W 144526R91 RES MF 1.1K 1% 1/4W 144514

RES MF 22.1K 1% 1/4W 144564SP1 BRACKET PCB CARD MOUNTING 003611SP2 BRACKET PCB CARD MOUNTING 003611

ASSY INSERTION PCB VIDEO 702415

C1 CAP ELECT 10UF 50V 066445C2 CAP ELECT 10UF 50V 066445C3 CAP ELECT 10UF 50V 066445C4 CAP ELECT 10UF 50V 066445C5 CAP MONO .1UF 50V 20% Z5U 061346C6 CAP MONO .1UF 50V 20% Z5U 061346C7 CAP MONO .1UF 50V 20% Z5U 061346C8 CAP MONO .1UF 50V 20% Z5U 061346C9 CAP ELECT 10UF 16V 066580C12 CAP MONO 100PF 100V 10% NPO 061341C13 CAP MONO 100PF 100V 10% NPO 061341C14 CAP MONO 100PF 100V 10% NPO 061341C15 CAP MONO .1UF 50V 20% Z5U 061346C16 CAP MONO .1UF 50V 20% Z5U 061346C17 CAP MONO .1UF 50V 20% Z5U 061346C18 CAP MONO .1UF 50V 20% Z5U 061346C19 CAP MONO .1UF 50V 20% Z5U 061346C20 CAP MONO .1UF 50V 20% Z5U 061346C21 CAP MONO .1UF 50V 20% Z5U 061346C22 CAP MONO .1UF 50V 20% Z5U 061346C23 CAP MONO .1UF 50V 20% Z5U 061346C24 CAP MONO .1UF 50V 20% Z5U 061346C25 CAP MONO .1UF 50V 20% Z5U 061346C26 CAP MONO .1UF 50V 20% Z5U 061346C29 CAP MONO .1UF 50V 20% Z5U 061346C30 CAP MONO .1UF 50V 20% Z5U 061346C31 CAP MONO .1UF 50V 20% Z5U 061346C34 CAP MONO 100PF 100V 10% NPO 061341C35 CAP ELECT 470UF 16V 066508C36 CAP MONO .1UF 50V 20% Z5U 061346C39 CAP MONO .1UF 50V 20% Z5U 061346C40 CAP MONO 47PF 200V 10% NPO 061340C41 CAP MONO 100PF 100V 10% NPO 061341C43 CAP ELECT 470UF 16V 066508C44 CAP ELECT 10UF 16V 066580C45 CAP MONO 47PF 200V 10% NPO 061340

MX120

71

INPUT PCB 750571 (Cont’d.)Ref. No. Description Part No.


C46 CAP ELECT 10UF 16V 066580C47 CAP MONO 100PF 100V 10% NPO 061341C48 CAP ELECT 10UF 16V 066580C49 CAP MONO .1UF 50V 20% Z5U 061346C50 CAP ELECT 10UF 16V 066580C51 CAP MPF 0.033UF 5% 63VDC 064318C52 CAP MPF 0.033UF 5% 63VDC 064318C53 CAP MONO .1UF 50V 20% Z5U 061346C54 CAP ELECT 10UF 16V 066580C55 CAP MONO .1UF 50V 20% Z5U 061346C56 CAP MONO 100PF 100V 10% NPO 061341C57 CAP MPF 0.01UF 5% 63VDC 064312C58 CAP MPF 0.01UF 5% 63VDC 064312C59 CAP MONO .1UF 50V 20% Z5U 061346C60 CAP MONO .1UF 50V 20% Z5U 061346C61 CAP ELECT 10UF 16V 066580C62 CAP ELECT 10UF 16V 066580C63 CAP MONO 100PF 100V 10% NPO 061341C64 CAP ELECT 10UF 50V 066445C65 CAP ELECT 10UF 16V 066580C66 CAP MONO 100PF 100V 10% NPO 061341C67 CAP MONO 100PF 100V 10% NPO 061341C68 CAP ELECT 10UF 50V 066445C69 CAP MONO 100PF 100V 10% NPO 061341C70 CAP MONO 220PF 200V 10% NPO 061342C71 CAP MONO .1UF 50V 20% Z5U 061346C72 CAP MONO 100PF 100V 10% NPO 061341C98 CAP ELECT 10UF 16V 066580C104 CAP ELECT 10UF 16V 066580C106 CAP ELECT 10UF 16V 066580C112 CAP ELECT 10UF 16V 066580C114 CAP ELECT 10UF 16V 066580C115 CAP ELECT 10UF 16V 066580C116 CAP ELECT 10UF 16V 066580C118 CAP MONO .1UF 50V 20% Z5U 061346C119 CAP MONO .1UF 50V 20% Z5U 061346C130 CAP ELECT 10UF 16V 066580C131 CAP ELECT 10UF 16V 066580C132 CAP ELECT 10UF 16V 066580C134 CAP ELECT 10UF 16V 066580C144 CAP ELECT 10UF 16V 066580C145 CAP ELECT 10UF 16V 066580C151 CAP MONO .1UF 50V 20% Z5U 061346D3 DIODE SILICON 070174D4 DIODE SILICON 070174

RIVET 1/8X3/16 STEEL 108011GP1 BRACKET PCB CARD MOUNTING 003611GP2 BRACKET PCB CARD MOUNTING 003611IC1 IC SPST QUAD FET SWITCHES N O 133580IC2 IC SPST QUAD FET SWITCHES N O 133580IC3 IC SPST QUAD FET SWITCHES N O 133580IC4 IC SPST QUAD FET SWITCHES N O 133580IC5 IC SPST QUAD FET SWITCHES N O 133580IC6 IC SPST QUAD FET SWITCHES N O 133580IC7 IC SPST QUAD FET SWITCHES N O 133580IC8 IC SPST QUAD FET SWITCHES N O 133580IC13 IC SHFT REG SER-PAR 133594IC14 IC SHFT REG SER-PAR 133594IC16 IC SPST QUAD FET SWITCHES N O 133580IC17 IC OPERATIONAL AMPLIFIER 133626

IC18 IC SPST QUAD FET SWITCHES N O 133580IC19 IC OPERATIONAL AMPLIFIER 133626IC20 IC OPERATIONAL AMPLIFIER 133626IC21 IC OPERATIONAL AMPLIFIER 133626IC22 IC OPERATIONAL AMPLIFIER 133626IC23 IC OPERATIONAL AMPLIFIER 133626IC24 IC OPERATIONAL AMPLIFIER 133626IC32 IC OPERATIONAL AMPLIFIER 133626IC33 IC OPERATIONAL AMPLIFIER 133626IC34 IC SHFT REG SER-PAR 133594IC35 IC SHFT REG SER-PAR 133594IC38 IC SPST QUAD FET SWITCHES N O 133580IC39 IC SPST QUAD FET SWITCHES N O 133580J1 JACK RCA 2X2 WHT/RED 14MM 117789J2 JACK RCA 3X2 WHT/RED 14MM 117790J3 JACK RCA 3X2 WHT/RED 14MM 117790J4 JACK RCA 2X2 WHT/RED 14MM 117789J5 CONN XLR FEM HORIZ PCB LATCH 117814J7 CONN XLR FEM HORIZ PCB LATCH 117814J9 CONN MALE 10 POS 117260J20 CONN 4 PIN 117215J21_ CONN 8 POS MALE FRICTION LOCK 117275PCB1 PC BD INPUT 129809Q3 TRANSISTOR NPN SILICON 132317R1 RES MF 100K 1% 1/4W 144528R3 RES MF 10K 1% 1/4W 144504R5 RES MF 47.5K 1% 1/4W 144526R6 RES MF 47.5K 1% 1/4W 144526R7 RES MF 1K 1% 1/4W 144513R8 RES MF 1K 1% 1/4W 144513R9 RES MF 20K 1% 1/4W 144524R10 RES MF 47.5K 1% 1/4W 144526R11 RES MF 47.5K 1% 1/4W 144526R12 RES MF 47.5K 1% 1/4W 144526R13 RES MF 47.5K 1% 1/4W 144526R14 RES MF 95.3 OHM 1% 1/4W 144572R15 RES MF 95.3 OHM 1% 1/4W 144572R16 RES MF 47.5K 1% 1/4W 144526R17 RES MF 7.5K 1% 1/4W 144571R18 RES MF 7.5K 1% 1/4W 144571R19 RES MF 47.5K 1% 1/4W 144526R20 RES FP 10 OHM 5% 1/4W 137105R21 RES MF 95.3K 1% 1/4W 144538R22 RES MF 2.21 OHM 1% 1/4W 144607R23 RES MF 95.3K 1% 1/4W 144538R24 RES MF 2.21 OHM 1% 1/4W 144607R25 RES MF 2.21 OHM 1% 1/4W 144607R26 RES MF 221 OHM 1% 1/4W 144559R27 RES MF 221 OHM 1% 1/4W 144559R28 RES MF 2.21 OHM 1% 1/4W 144607R29 RES MF 47.5K 1% 1/4W 144526R30 RES MF 10K 1% 1/4W 144504R31 RES MF 20K 1% 1/4W 144524R32 RES MF 20K 1% 1/4W 144524R33 RES MF 10K 1% 1/4W 144504R34 RES MF 20K 1% 1/4W 144524R35 RES MF 10K 1% 1/4W 144504R36 RES MF 10K 1% 1/4W 144504R37 RES NETWORK 2 X 220K ISO 144678R38 RES MF 47.5K 1% 1/4W 144526

72

INPUT PCB 750571 (Cont’d.)Ref. No. Description Part No.


COMPONENT VIDEO PCB 7505768

R39 RES NETWORK 2 X 22K ISO 144689R40 RES MF 47.5K 1% 1/4W 144526R41 RES MF 47.5K 1% 1/4W 144526R42 RES MF 47.5K 1% 1/4W 144526R43 RES NETWORK 2 X 22K ISO 144689R44 RES MF 47.5K 1% 1/4W 144526R45 RES NETWORK 2 X 22K ISO 144689R46 RES MF 47.5K 1% 1/4W 144526R47 RES NETWORK 2 X 22K ISO 144689R48 RES MF 47.5K 1% 1/4W 144526R49 RES NETWORK 2 X 22K ISO 144689R50 RES NETWORK 2 X 22K ISO 144689R51 RES NETWORK 2 X 22K ISO 144689R52 RES MF 47.5K 1% 1/4W 144526R53 RES NETWORK 2 X 22K ISO 144689R54 RES MF 47.5K 1% 1/4W 144526R55 RES MF 100 OHM 1% 1/4W 144568R56 RES MF 47.5K 1% 1/4W 144526R57 RES MF 47.5K 1% 1/4W 144526R58 RES MF 47.5K 1% 1/4W 144526R59 RES MF 47.5K 1% 1/4W 144526R60 RES MF 47.5K 1% 1/4W 144526R61 RES MF 47.5K 1% 1/4W 144526R64 RES MF 100 OHM 1% 1/4W 144568R71 RES NETWORK 2 X 22K ISO 144689R78 RES NETWORK 2 X 100 OHM ISO 144680R86 RES NETWORK 2 X 22K ISO 144689R89 RES NETWORK 2 X 100 OHM ISO 144680R110 RES MF 1K 1% 1/4W 144513R111 RES FP 10 OHM 5% 1/4W 137105R112 RES FP 10 OHM 5% 1/4W 137105R113 RES FP 10 OHM 5% 1/4W 137105R114 RES FP 10 OHM 5% 1/4W 137105R116 CAP ELECT 10UF 16V 066580R117 CAP ELECT 10UF 16V 066580U4 IC 3-8 LINE DEC LATCH 133170U1 IC DUAL OPERATIONAL AMPLIFIER 133578U2 IC OPERATIONAL AMP LOW NOISE 133565U3 IC OPERATIONAL AMP LOW NOISE 133565

ASSY INSERTION PCB INPUT 702413

BRKT1 BRACKET PCB CARD MOUNTING 003611C1 CAP MPF 0.047UF 5% 63VDC 064320C2 CAP MPF 0.047UF 5% 63VDC 064320C3 CAP MPF 0.047UF 5% 63VDC 064320C4 CAP ELECT 10UF 50V 066445C5 CAP MONO 220PF 200V 10% NPO 061342C6 CAP MPF 0.047UF 5% 63VDC 064320C7 CAP MPF 0.047UF 5% 63VDC 064320C8 CAP MPF 0.047UF 5% 63VDC 064320C9 CAP MPF 0.047UF 5% 63VDC 064320C10 CAP ELECT 47UF 25V 20% NP 066556C11 CAP ELECT 47UF 25V 20% NP 066556C12 CAP MPF 0.047UF 5% 63VDC 064320C13 CAP MPF 0.047UF 5% 63VDC 064320C14 CAP MPF 0.047UF 5% 63VDC 064320C15 CAP MPF 0.047UF 5% 63VDC 064320C16 CAP MPF 0.068UF 5% 63VDC 064323C17 CAP MPF 0.047UF 5% 63VDC 064320

C19 CAP ELECT 470UF 16V 066508C20 CAP ELECT 470UF 16V 066508C21 CAP MONO 390PF 5% 200V 061352C22 CAP MONO 120P 5% 200V 061351C23 CAP MONO 560PF 200V 5% NPO 061348C24 CAP MONO 390PF 5% 200V 061352C25 CAP MONO 120P 5% 200V 061351C26 CAP MONO 560PF 200V 5% NPO 061348C27 CAP MONO 390PF 5% 200V 061352C28 CAP MONO 120P 5% 200V 061351C29 CAP MONO 560PF 200V 5% NPO 061348C30 CAP ELECT 47UF 25V 20% NP 066556C31 CAP MONO .1UF 50V 20% Z5U 061346C32 CAP MONO .1UF 50V 20% Z5U 061346C33 CAP MONO .1UF 50V 20% Z5U 061346C34 CAP MONO .1UF 50V 20% Z5U 061346C35 CAP ELECT 47UF 25V 20% NP 066556C36 CAP MONO .1UF 50V 20% Z5U 061346C37 CAP MONO .1UF 50V 20% Z5U 061346C40 CAP ELECT 47UF 25V 20% NP 066556C41 CAP ELECT 47UF 25V 20% NP 066556C42 CAP MONO .1UF 50V 20% Z5U 061346C43 CAP ELECT 47UF 25V 20% NP 066556C44 CAP ELECT 10UF 50V 066445C45 CAP MONO .1UF 50V 20% Z5U 061346C46 CAP ELECT 10UF 50V 066445C47 CAP MONO .1UF 50V 20% Z5U 061346C48 CAP MONO .1UF 50V 20% Z5U 061346C49 CAP ELECT 47UF 25V 20% NP 066556C50 CAP MONO 220PF 200V 10% NPO 061342C61 CAP MONO .1UF 50V 20% Z5U 061346C62 CAP ELECT 10UF 50V 066445C63 CAP MONO .1UF 50V 20% Z5U 061346C64 CAP ELECT 10UF 50V 066445C67 CAP MONO 22PF 200V 10% NPO 061339C68 CAP MONO 1000PF 50V 10% NPO 061344C69 CAP MONO 10PF 200V 10% NPO 061338C70 CAP MONO 10PF 200V 10% NPO 061338C71 CAP MONO 22PF 200V 10% NPO 061339C72 CAP MONO 22PF 200V 10% NPO 061339C73 CAP MONO .1UF 50V 20% Z5U 061346C75 CAP MONO .1UF 50V 20% Z5U 061346C76 CAP MONO .1UF 50V 20% Z5U 061346C77 CAP MONO .1UF 50V 20% Z5U 061346C78 CAP MONO .1UF 50V 20% Z5U 061346C79 CAP MONO 33PF 200V 5% NPO T/R 061347C80 CAP MONO 33PF 200V 5% NPO T/R 061347C110 CAP MONO .1UF 50V 20% Z5U 061346C111 CAP MONO .1UF 50V 20% Z5U 061346C112 CAP MONO .1UF 50V 20% Z5U 061346C113 CAP MONO .1UF 50V 20% Z5U 061346C114 CAP MONO .1UF 50V 20% Z5U 061346C115 CAP MONO .1UF 50V 20% Z5U 061346C116 CAP MONO .1UF 50V 20% Z5U 061346C117 CAP MONO .1UF 50V 20% Z5U 061346C118 CAP MONO .1UF 50V 20% Z5U 061346C119 CAP MONO .1UF 50V 20% Z5U 061346C170 CAP ELECT 100UF 25V 066573C174 CAP ELECT 100UF 25V 066573HS1 HEATSINK T0220 080014

MX120

COMPONENT VIDEO PCB 750576 (Cont’d.)Ref. No. Description Part No.


73

HS2 HEATSINK T0220 080014HS3 HEATSINK T0220 080014IC5 IC PROG VIDEO CPLD 133660 133661IC9 IC 100MA I FEEDBACK AMP 133579IC10 IC 100MA I FEEDBACK AMP 133579IC12 IC 100MA I FEEDBACK AMP 133579IC13 IC 100MA I FEEDBACK AMP 133579IC15 IC REGULATOR 3.3V LOW DROPOUT 133630(IC15) IC SOCKET 84 PIN PLCC 178185IC22 IC SHFT REG SER-PAR 133594IC36 IC REGULATOR +5V 133569J1 CONN 2X7 SHROUDER HEADER 117970J2 CONN 2X5 SHROUDER HEADER 117969J3 CONN 4 PIN 117215J4 CONN MALE 7 PIN 117217J5 CONN HEADER 10 POS 117333J6 CONN 2 PIN MALE 117213J7 CONN 4 PIN 117215J8 CONN MALE 6 POS FRICTION LOCK 117218J9 CONN 2 PIN MALE 117213J10 CONN 2X13 SHROUDED HEADER 117971J17 RCA JACK 2 X 3 RBG 117840J19 RCA JACK 2 X 3 RBG 117840J20 CONN MALE 10 POS RIGHT ANGLE 117260J21 CONN MALE 12 POS ASSY 117220L1 BEADS FERRITE LEADED 076023L2 BEADS FERRITE LEADED 076023L3 CHOKE RF 3.3UH 10% 122398L4 CHOKE RF 3.3UH 10% 122398L5 CHOKE RF 3.3UH 10% 122398L6 CHOKE RF 3.3UH 10% 122398L7 CHOKE 8.2UF 5% CC 122399L8 CHOKE RF 3.3UH 10% 122398L9 CHOKE RF 3.3UH 10% 122398L10 BEADS FERRITE LEADED 076023L11 CHOKE RF 3.3UH 10% 122398L12 RES CF 0 OHM 5% 1/4W 141554L13 CHOKE 8.2UF 5% CC 122399L18 INDUCTOR 2.7UH 122395L19 INDUCTOR 2.7UH 122395L20 INDUCTOR 2.7UH 122395L21 INDUCTOR 2.7UH 122395L22 INDUCTOR 2.7UH 122395L23 INDUCTOR 2.7UH 122395Q4 IC VOLTAGE REGULATOR -5.2V 133567R1 RES MF 18.2 OHM 1% 1/4W 144659R2 RES MF 4.75K 1% 1/4W 144520R5 RES NETWORK 8 X 330 ISO 144679R9 RES MF 10K 1% 1/4W 144504R10 RES MF 10K 1% 1/4W 144504R11 RES MF 10K 1% 1/4W 144504R14 RES MF 806 OHM 1% 1/4W 144512R15 RES MF 806 OHM 1% 1/4W 144512R20 RES MF 75 OHM 1% 1/4W 144644R22 RES MF 75 OHM 1% 1/4W 144644R23 RES MF 75 OHM 1% 1/4W 144644R24 RES MF 22.1K 1% 1/4W 144564R25 RES MF 75 OHM 1% 1/4W 144644R26 RES MF 806 OHM 1% 1/4W 144512

R27 RES MF 75 OHM 1% 1/4W 144644R28 RES MF 4.75 OHM 1% 1/4W 144658R29 RES MF 22.1 OHM 1% 1/4W 144554R30 RES MF 10K 1% 1/4W 144504R31 RES MF 10 OHM 1% 1/4W 144553R32 RES MF 10 OHM 1% 1/4W 144553R33 RES MF 22.1 OHM 1% 1/4W 144554R35 RES MF 18.2 OHM 1% 1/4W 144659R36 RES MF 56.2 OHM 1% 1/4W 144660R37 RES MF 18.2 OHM 1% 1/4W 144659R38 RES MF 56.2 OHM 1% 1/4W 144660R39 RES MF 18.2 OHM 1% 1/4W 144659R40 RES MF 56.2 OHM 1% 1/4W 144660R41 RES MF 18.2 OHM 1% 1/4W 144659R42 RES MF 56.2 OHM 1% 1/4W 144660R43 RES MF 18.2 OHM 1% 1/4W 144659R44 RES MF 56.2 OHM 1% 1/4W 144660R45 RES MF 18.2 OHM 1% 1/4W 144659R46 RES MF 56.2 OHM 1% 1/4W 144660R50 RES MF 1.1K 1% 1/4W 144514R53 RES MF 100K 1% 1/4W 144528R54 RES MF 10K 1% 1/4W 144504R55 RES MF 10 OHM 1% 1/4W 144553R60 RES FP 10 OHM 5% 1/4W 137105R61 RES MO 4.7 OHM 5% 1W 144656R62 RES MO 4.7 OHM 5% 1W 144656R63 RES MF 806 OHM 1% 1/4W 144512R65 RES MF 4.75K 1% 1/4W 144520R66 RES MF 4.75K 1% 1/4W 144520R70 RES MF 10K 1% 1/4W 144504R71 RES MF 10K 1% 1/4W 144504R72 RES MF 10K 1% 1/4W 144504R73 RES MF 806 OHM 1% 1/4W 144512R74 RES MF 806 OHM 1% 1/4W 144512R75 RES MF 10K 1% 1/4W 144504R76 RES MF 806 OHM 1% 1/4W 144512R77 RES MF 806 OHM 1% 1/4W 144512R78 RES MF 75 OHM 1% 1/4W 144644R79 RES MF 75 OHM 1% 1/4W 144644R80 RES MF 75 OHM 1% 1/4W 144644R88 RES MF 100K 1% 1/4W 144528R89 RES MF 4.75K 1% 1/4W 144520R90 RES MF 4.75K 1% 1/4W 144520R91 RES MF 10K 1% 1/4W 144504R94 RES CF 0 OHM 5% 1/4W 141554R96 RES CF 0 OHM 5% 1/4W 141554R92 RES MF 10K 1% 1/4W 144504R98 RES MF 56.2 OHM 1% 1/4W 144660R99 RES MF 18.2 OHM 1% 1/4W 144659U2 IC QUAD ANALOG SWITCH HI SPEED 133342Y1 CRYSTAL 17.7344 FUND 180076Y2 CRYSTAL 27MHZ 3RD HARMONIC 180080Y3 CRYSTAL 24.576MHZ 180075Y4 CRYSTAL 14.3181MHZ FUND 180078

SCR MS 6-32X1/4 PH PN CLR 400186NUT KEP 6032 SPECIAL 402045ASSY INSERT PCB COMPONET VIDEO 702410ASSY PCB COMPON VIDEO SM PARTS 750559

HDMI POWER SUPPLY PCB 750599Ref. No. Description Part No.


9

10

74

C1 CAP MPF 0.1UF 100V 064338C2 CAP ELECT 18000UF 16V 066460C3 CAP MONO .1UF 50V 20% Z5U 061346C4 CAP ELECT 100UF 25V 066573C5 CAP MONO .1UF 50V 20% Z5U 061346C6 CAP ELECT 1000UF 25V 066513D1 DIODE RECT SI 3A 100V 070176D2 DIODE RECT SI 3A 100V 070176D3 DIODE RECT SI 3A 100V 070176D4 DIODE RECT SI 3A 100V 070176D5 DIODE SILICON 070174

ISOSTRATE POWER SUPPLY 084208HS1 SUB HEATSINK 018751IC1 IC 5V 1.5A REGULATOR LOW DROP 133610IC2 IC REGULATOR 3.3V LOW DROPOUT 133630J1 CONN 4 PIN 117215J2 CONN MALE 5 PIN 0.1 POST ASSY 117216K1 RELAY POWER TV5 24V 087069

PC BD POWER SUPPLY HDMI 129788SCR MS 6-32X1/4 SEMS PH PN CLR 400250CLIP ANGLE RIGHT 414141

HDMI MODULE PCB 750623

BRACKET PCB CARD MOUNTING 003611HDMI SWITCH MODULE 320276SCR MS 6-32X1/4 SEMS PH PN CLR 400250NUT KEP 6-32 402003

11 BALANCED OUTPUT PCB 750608C37 CAP ELECT 10UF 50V 066445C38 CAP ELECT 10UF 50V 066445C42 CAP MONO .1UF 50V 20% Z5U 061346C73 CAP ELECT 10UF 50V 066445C74 CAP ELECT 10UF 50V 066445C75 CAP ELECT 10UF 50V 066445C76 CAP ELECT 10UF 50V 066445C77 CAP ELECT 10UF 50V 066445C78 CAP ELECT 10UF 50V 066445C79 CAP MONO .1UF 50V 20% Z5U 061346C80 CAP MONO .1UF 50V 20% Z5U 061346

C81 CAP ELECT 10UF 50V 066445C82 CAP ELECT 10UF 50V 066445C83 CAP ELECT 10UF 50V 066445C84 CAP ELECT 10UF 50V 066445C85 CAP MONO .1UF 50V 20% Z5U 061346D5 DIODE SILICON 070174D6 DIODE SILICON 070174D7 DIODE SILICON 070174J1 CONN 4 POS MALE MTS100 NORMAL 117215J6 CONN MALE 9 POS FRICTION LOCK 117244J10 RECEPTACLE XLR MALE 117686J11 RECEPTACLE XLR MALE 117686J12 RECEPTACLE XLR MALE 117686K19 RELAY REED FORM 1A 5V 500 OHMS 087050K20 RELAY REED FORM 1A 5V 500 OHMS 087050K22 RELAY REED FORM 1A 5V 500 OHMS 087050PCB1 PC BD BALANCED OUT 129791R38 RES MF 221K 1% 1/4W 144629R40 RES MF 20K 1% 1/4W 144524R41 RES MF 221K 1% 1/4W 144629R42 RES MF 20K 1% 1/4W 144524R44 RES MF 221K 1% 1/4W 144629R46 RES MF 100 OHM 1% 1/4W 144568R48 RES MF 100 OHM 1% 1/4W 144568R52 RES MF 22.1K 1% 1/4W 144564R54 RES MF 221K 1% 1/4W 144629R56 RES MF 22.1K 1% 1/4W 144564R57 RES MF 20K 1% 1/4W 144524R58 RES MF 20K 1% 1/4W 144524R59 RES MF 100 OHM 1% 1/4W 144568R60 RES MF 100 OHM 1% 1/4W 144568R61 RES MF 20K 1% 1/4W 144524R62 RES MF 100 OHM 1% 1/4W 144568R68 RES MF 221K 1% 1/4W 144629R63 RES MF 20K 1% 1/4W 144524R66 RES MF 22.1K 1% 1/4W 144564R65 RES MF 100 OHM 1% 1/4W 144568R69 RES MF 221K 1% 1/4W 144629U6 IC DUAL OPERATIONAL AMPLIFIER 133578U7 IC DUAL OPERATIONAL AMPLIFIER 133578

ASSY INSERT PCB BALANCED OUT 702422

MX120

75 76

MX120 EXPLODED VIEW

25

27

17

38

65

66

59

56

69

44

5445

46

48

47

49

26

33

32

31

28

24

2828

23

28

23

28

2314

29

28

22

21

30

34

42

38

35

38

37

40

41 43

39

36

20

17

16

15

19 15

4

14

13

12

6

5

11

10

18

9

9

18

87

3

2

1

1

(3X)

(6X)

ASSY REAR PANEL050171

REF

(6X)

(6X)

(46X)

(7X)

(3X)

(3X)

(4X)

(4X)

(9X)

(4X)

(10X)

(4X)

77 78

MX120 EXPLODED VIEW and PARTS LIST Ref No. Description Part No.

MX120

75

MX119

REPACKING INSTRUCTION

The continuous improvement of its products is the policy of McIntosh Laboratory Incorporated, who reserve the right to improve design withoutnotice. Because of the constant upgrading of McIntosh products’ circuitry and components, the Company cannot insure, and does not warrant, theaccuracy of the within schematic material, which is intended for information only.

McINTOSH LABORATORY, INC., 2 CHAMBERS STREET, BINGHAMTON, NEW YORK 13903 Printed in U.S.A. Part Number 041072

SERVICE MANUALSERIAL NO. XN1001 And Above

MX120A/V CONTROL CENTER

mx120sin - audio-circuit.dk

Documents