manual: kv1462ub sm sony en
TRANSCRIPT
UK Model
Chassis No. SCC-B12B-A A
UAT ae ay pee
ta! TRE:
i ¢ i r b
' i
GP-T chassis Note: The service manual for RM-655 has
— SPECIFICATIONS been issued separately.
Television system British TV standards
Coloursystem PAL
Channel coverage UHF channels 21 - 68
< (a total of up to 8 preselected channels) For Service Manuals Contact me Picture tube Trinitrontube . | MAURITRON TECHNICAL SERVICES
Approx. 36.8 cm (14 inches) 8 Cherry Tree Ad, Chinnor
- 90 degree deflection Oxon OX9 40QY | el:- 01844-351694 Fax:- 01814-352584
) (Approx. 33.7 cm picture measured diagonally) Email:- [email protected]
Aerial 75-ohm standard coaxial socket
Loop aerial (supplied)
Speaker _ 7.5 cm dia. Audio output 1.5W
Power requirements
240 V AC, 50 Hz Power consumption
| - 41Wh , Be 40 Wh in standby condition -“ | Dimensions Approx, 366 x 356.5 x 408.5 mm (w/h/d)
(14/2 x 1419 164/s inches)
Weight Approx. 11.0 kg (24 Ib 4 02)
Accessories supplied
Remote Commander RM-655 with 2 batteries
(IEC designation R6, size AA)
Loop aerial (1)
Aerial connector (300 - 75 ohm matching transformer is built-in.) (1)
Design and specifications subject to change without notice.
TRINITRON @ COLOBR TV
SONY. MICROFILM
or
. WAV-1S40ZUD ;___ RM -655 | i : ‘
, TABLE OF CONTENTS | |
| | Section Title | Page —— Section Title | Page
1. GENERAL | 4. CIRCUIT ADJUSTMENT
1-1. Location of Controls.................. 3 4-1. A Board Adjustments ................ 10
1-2, Programming ............ sae deena de 4
23. SODCtAHON 2.5 xc Sse 3. Oe ae oe ee Re , 5 ~ & DIAGRAMS |
| 5-1. Circuit Boards Location............... 13
2. DISASSEMBLY 5-2. Schematic Diagram .................. 14
2-1. Picture Tube Removal ................. 6 5-3. Printed Wiring Boards ................ 17 5-4. Semiconductors lead layout............. 20
3. SET-UP ADJUSTMENTS 6. EXPLODED VIEWS.
3-1]. Beam Landing ...................... 7 wee 6-1. Picture Tube ..................008. 21
3-2, Convergence ..................0000.% 8 en
3-3, Focus(RV707) ....... ccc ccc ee cuce. 9 ReGIe Ure eve SA ETD Senate B CMe Ria -
3-4, White Balance ............. 0000 ees 9 | 7. ELECTRICAL PARTS LIST ............... 23
WARNING !!
AN ISOLATION TRANSFORMER SHOULD BE USED
DURING ANY SERVICE TO AVOID POSSIBLE SHOCK
HAZARD, BECAUSE OF LIVE CHASSIS. ,
THE CHASSIS OF THIS RECEIVER IS DIRECTLY CON. (
NECTED TO THE AC POWER LINE.
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY SHADING AND MARK ON THE SCHEMATIC DIAGRAMS, EXPLODED
VIEWS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ne SE ahs aie oe ek ee en eh Ue a 7
a, 1-1. LOCATION OF CONTROLS
Pull to open the panel.
SECTION 1 GENERAL
Service Manuals Contact
MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor
Oxon OX9 AQY | ss
Tel: 01844-351694 Fax:- ati
Email: [email protected].
@ (power) switch
Remote control detector
PROGR (programme) scan buttons
=< (volume) buttons
Programme number indicator Indicates the programme number being tuned in.
The lower four segments light when the
TV is set in the standby mode.
This lamp blinks when or
MANUALIJFINE on the TVor any button on
the Commander is pressed_
Used for programming
Used for picture adjustments
ee ae ee eee SS SRS ae a ae
os VU s °° T¥womw ow
RM-655
1-2. PROGRAMMING
Automatic and manual programming are available.
Automatic programming presets up to 8 receivable _ channels automatically from the lowest frequency. With
manual programming up to 8 active channels can be preset
in any desired sequence.
Panel opened
Programme number
indicator
CLEAR button MANUAL/JFINE tuning buttons
AUTO PROGRAMME button
PRESET button
AUTOMATIC PROGRAMMING
1 Depress ©.
2 Press PRESET (ON) to set the TV in the programming standby mode. The programme number indicator will
blink.
3 Press AUTO PROGRAMME. Automatic programming will start to tune in 8 receivable channels in sequence. When no more station can be
located, automatic programming will stop. The
programming mode will be released automatically.
MANUAL PROGRAMMING
1 Depress ©.
2 Press PRESET (ON) to set the TV in the programming
standby mode. The programme number indicator will blink.
3 Press PROGR +/— or programme number button on the Commander to select the programme position when a
channel is to be tuned in: + for a higher-numbered position, and — for a lower-numbered position.
4 Press MANUALIFINE + or -. The first channel found will appear. Every time you pess MANUALIFINE +, a higher-numbered channel will be tuned in and every time you press MANUAL/FINE -,a
- lower-numbered channel will be tuned in. Repeat
pressing until the desired channel is found.
Repeat steps 3 and 4 for all desired channels.
5 Press PRESET (OFF).
¢ To reset the TV to the lowest frequency of the band, peess CLEAR when PRESET is set to ON.
Nv IrTveuvL | RM-655
1-3. OPERATION
VIEWING TV PROGRAMME
Usually the Remote Commander is all that is needed to
operate the TV in everyday use.
RM-655 Remote Commander ;
“Point the head towards the
-. femote control detector.
() (standby) switch When the TV is turned on, press this to set it in the standby mode. To turn it on again, press this button again. ->e< (normal) button
st} (muting) button
Programme number buttons
@ (colour buttons —PROGR (programme) scan buttons
<1(volume) buttons QO (picture) buttons
For Service Manuals Contact MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY
Tel:- 01844-351694 Fax:- 01844-352554 Email:- [email protected]
Operation 1 Depress © to turn on the TV.
2 Pointing the head of the Commander towards the remote control detector on the TV, select the TV
programme in either of two ways:
¢ Press the programme number buttons.
¢Press PROGR + or -. |
3 Adjust the volume by pressing = + or —: + for more
volume and — for less volume.
To turn off the TV completely, press © on the TV. To set the TV in the standby mode, press (©) on the
Commander.
To mute the sound immediately, press 45] .
Press it again to restore the sound.
PICTURE ADJUSTMENTS
Press Q: + to increase picture contrast or — to decraase it.
Press @: + for more colour intensity or — for less cohur
intensity.
Turn <2 clockwise for more brightness or counterclec kwise for less brightness. Turn) to stabilize the picture if it rolls vertically. CD (vertical hold) contro!
1 (brightness) control
@ (colour buttons
Q (picture) buttons
To return the picture contrast and colour intensity tot ne
factory setting, press = on the Commander. om:
~>e+ (normal) button
Soar vst veghice Geass Mh es
NV- 1tOUcuD RM-655 |
2-1. PICTURE TUBE REMOVAL
Bezel assy
e Removing Procedures
® Turn up one side of the rubber cap in the direction
indicated by the srrow (@)..
SECTION 2 DISASSEMBLY
Cushion
(7) two screws
picture tube shield
(9) picture tube
AC cord holder
@) Using a thumb, pull up the rubber cap firmly in the |
direction indicated by the arrow ().
Anode button
(©) When one side of the rubber cap is seperated iogm the
anode button, the anode cap can be removed byrgatning up the rubber cap and pulling up it in the directin of the arrow ()
VES as, Lae, .-e tae eee ae Pity aes ws Speers van ve a SOEes aoa ere - ae asoeh i st a ’ ~ a @ ase -2F
vat senr wat. ars . ee as
a ae at - ve a ae gs
| \ |
|
|
MS.
Controls and switch should be set as follows unless
SECTION 3
SET-UP ADJUSTMENTS
The following adjustments should be made
when a complete realignment is required or a
new picture tube is installed.
These adjustments should be performed with
rated power supply voltage unless otherwise.
noted.
otherwise noted:
(p picture control....... maximum
5@s brightness control... .. maximum (fully clockwise)
Perform the adjustments in order as follows:
3-1.
3-2.
3-3.
3-4
Beam Landing
Convergence
Focus (RV707)
White Balance
Note: Test Equipment Required.
1. Colour-bar/Pattern Generator
2. Degausser
ht Bl lt BP Dt De De PAPE PF OMS HOMO OH DPA PP PAOD HD
For r Service “Manuals ; Contact
: MAURITRON TECHNICAL SERVICES
;
3-1. BEAM LANDING 8 Cherry Tree Rd, Chinnor ne ay, sd trol
| - Oxon OX9 4QY
Preparation:
@ Feed in the white pattern.
© Before starting, degauss the entire screen.
l.
10.
Turn on set power supply and receive an all-
white signal.
Evenly degauss the entire screen.
Loosen the deflection yoke mounting screw,
and set the purity control to the centre as
shown in Figure 3-1.
Set BKG VR @ to maximum and set @ and
© to minimum.
Move the deflection yoke back, and adjust the ©
purity control so that @ is in the centre and
© and @ are at the sides, evenly. (Figure
3-2.)
Move the deflection yoke forward so that the
entire screen is red.
* If the deflection yoke is pushed all the way
to the CRT then moved slightly back,
landing adjustment is easier.
Substitute @ , then @ for @ in step 4
and check landing. |
Rotate @ , © and @ once each and check
landing.
When landing is not right, adjust: the purity
control and use magnets as shown in Figure
3-3, then repeat steps 7 and 8 .
When a magnet is used, be sure to perform.
step 2 ,and tighten deflection yoke mounting
screw loosely.
Tel:- 01844-351694 Fax:- 01844-352554
Email:- [email protected]
Fig. 3-2,
Disk magnets or rotatable disk magnets correct these areas (a—d).
corelet on was control corrects corelet on was area.
Dr° ft
Satiecncn ee posi
tioning corrects re.
~ KV-1462UB | _RM-655
3-2, CONVERGENCE
Preparation:
Before starting, perform FOCUS, H.SIZE, V.SIZE
and V.LIN adjustments.
Tum BRIGHTNESS control fully counterclock-
wise and PICTURE control to normal. |
Feed in the dot pattem.
(1) Horizontal and Vertical Static Convergence —
centre dot
centre dot
C board
. Adjust H.STAT VR to coincide red, green and
blue dots on the centre of screen (Horizontal
movement)
. Adjust V.STAT magnet to coincide red, green and
blue dots on the centre of screen (Vertical move-
ment) | |
. If the red, green and blue dots do not coincide on
the centre of screen with H.STAT VR, perform
horizontal convergence adjustment using H.STAT
VR and V.STAT magnet as shown below. (In this
case, H.STAT VR and V.STAT magnet effect.
~ each other.)
Tilt the V.STAT magnet and adjust static con-
vergence to open or close the V.STAT magnet.
4. When the V.STAT magnet is moved in the direc-
tion of arrow (a) and , Red. Green and Blue dots move as shown below.
QQ. ‘. @ (6) -|~- ©) B
If blue dot does not coincide with red and green
dots, perform following steps.
Move BMC magnet (a) to correct insufficient
H. static convergence.
Rotate. BMC magnet (b) to correct insufficient
V. static convergence.
In either case, repeat Beam Landing Adjustment.
a | | KV-14621 Fi | RM-656 ea"
For Service Manuals Contact (2) Dynamic Convergence Adjustment
| | MAURITRON TECHNICAL SERVICES pate ereparahion: 8 Cherry Tree Ra, Chinnor
ne ® Before starting, perform Horizontal and Vertical oer Prcevises O peaaael ie Static Convergence Adjustment. Email:- [email protected]
: ‘ 1. Loosen deflection yoke screw.
2. Remove deflection yoke spacers.
3. Move the deflection yoke for best convergence
as Shown below.
4. Tighten the deflection yoke screw. |
5. Install the deflection yoke spacers.
won,
RV704 B ORIVE RV702 G DRIVE
gig RGB BGR of RV703 G8KG ,
RV701 R &KG
bee RV709 SUB. BRT
a RV706 G2 red RV707 FOCUS tn RV708 H.STAT
cs 3-3. FOCUS (RV707) "3 | Adjust Focus VR(RV707) for a best Picture.
2 3-4, WHITE BALANCE 3, Turn RV704(B.DRIVE) and RV702 (G.DRIVE) fully = clockwise. te SCREEN (G a I (G2)] 4. Set RV701 (R.BKG), RV703 (G.BKG)and RV705 i 1.. Input a dots pattern. = (B.BKG) to minimum : . Set the PICTUR mini turn the | 2. Set the PICTURE control at minimum and turn the Turn RV709 (SUB BRT) slowly to obtiin a faintly
BRIGHT control fully counterclockwise. arent wees | : visible - ; |
3. Confirm that BKG voltage is less than 160V dc when Note the colour that first becomes visible b
turning RV701 (R.BKG). RV703 (G.BKG) and > . RV705 (B.BKG) turning RV/7/09.
4 | Do not turn a BKG control for this olour. Note the colour which becomes visible first when
turning RV706. | . Adjust the other two BKG controls fo best white
balance (neutral gray) of the faint cros— hatch.
7. Set the PICTURE control fully clockwse.
Observe the screen and adjust the DRIV E controls
for best white balance.
8. Repeat steps 1, through 7.
(WHITE BALANCE (Cut off)]
1. Input a all white signal.
2. Set the PICTURE control to minimum and turn the
BRIGHT control mechanical centre.
Spit eth gg. EERE nee a : ase PE UEED: ac Se tog wie a Sa See
er Ef Sh See oi ae we ss - - a = * eo ne PEN TT “a oe os . ! av Sen, Len Ee he - af 2 i ertated Oy
oo x : ee ae : i we me 7 . Se ‘
“0° as “a: Veg. f iene te iene sage oes =
or pie Pao . : ’ a : awe Ww ’ wea: we !
NV: 1 ?UCLUD
RM-655 | a
SECTION 4
CIRCUIT ADJUSTMENT 4-1. A BOARD ADJUSTMENTS
ACC ADJUSTMENT |
1. Input the PAL colour bar signal.
2. Set the PICTURE, COLOUR and BRT control to normal. |
3. Observe 10301 pin (7) waveform and adjust ACC VR (RV304) so that the waveform level is 170+10m Vp-p
{ I
an M i ' :
i va | | ie
ANAT | ee
\ OPM | HW i i th
Vb = 170+10m Vp-p
A:P-C+ ADJUSTMENT For Service Manuals Contact
1. Input the PAL colour bar signal. So 7 | MAURITRON TECHNICAL SERVICES
2. Set the PICTURE, COLOUR and BRT control to 8 mpi aa il
normal, . | Teh- 01844-351694 Fax-- 01844-352554 3. Short circuit between pin (17) and pin (2) of Emait- @[email protected]
1C301 with a jumper.
4. Adjust CV301 for suitable colour intensity.
5. Remove a jumper.
ANTI-PAL, LINE CRAWLING ADJUSTMENT
@ ANTI-PAL ADJUSTMENT e LINE CRAWLING ADJUSTMENT
1. Input the PAL color bar signal. |
2. Set the PICTURE, color and BRT control to 1. Input the PAL colour bar signal. normal. 2. Set the PICTURE, COLOUR and BAT control
3. Observe the A-1 (4) (Blue) output waveform to normal. shown in the oscilloscope. | 3. Observe the A-1 (4) (Blue) output waveform
4. Adjust RV302 (DELAY) and RV303 (PHASE) shown in the oscilloscope. |
to obtain the waveform as show below. ~ 4, Adjust T3017 for minimum line crawling.
oscilloscope
wrong aap right pattern : pattern
TU AGC ADJUSTMENT
Adjust RF AGC (on IF 207) so that snow noie cross
modulation adjust disappear from the picture,
ee LO
or ny <f ».
_ oscilloscope
23h. Bd
Bi). SSS Soa
ABIES
vz
nie ; is si afte
pia
? ao
ae? eae a ae
0 Rt ene renar rites: yn . 4 poe
a ice
sey"
ame ae Rah
STION 4 \DJUSTMENT
oscilloscope
+O
Vb = 170+10m Vp-p
» LINE CRAWLING ADJUSTMENT
1. Input the PAL colour bar signal.
2, Set the PICTURE, COLOUR a to normal.
nd BRT control
Observe the A-! (4) (Blue) output waveform shown in the oscilloscope.
- Adjust T3017 for minimum line crawling.
T3017
oscilloscope
+O
=
° « Lae te -e :
¢ P ‘ 7. os By . ‘ sae Pas . .* .: = od . ‘lee Py am - ; ‘« the os . . won a . . oe :
: . : e ‘ . .
. . . . eee .
oe . . a ‘ an . ory S Bee 5 a - ’ a . .
. aa ‘e . e one ‘ . : 2
. r) 5 . ae , ‘ > 1 .
. : .* . eae ee é :
oo may Pa i: ae ae ois
a te ae Ts ace pats
oes
* «
a .
or ? . . os a8 FOO rT rere Z . noe . a Me oe et oe: . . anes . 3 ys . - 5 s Talore - es . 4 .
os er - 4 . ' ute . . . . < . =
. Sit a oo = “ . . oS tae ‘ . s ” . ’ . mo .. , soe . . o . ‘ vets
KV-1462UB KV-1462UB RM-655 RM-655
ze i¢
tte omens . ae SE een AE RE ae aga ae haatata linha ROD MADAM RE cadet eeeennanadami maha hte od idee ae yoy bs ad
Pal
°
a aque : movas ser AU intestines tran Sie ae . Oe : ai tere .
iaghthow tees FD oe Az 4 ty 4 ome , e . sas
ee be . 2 se . . 3 5 oy on . MS Se Fa : . oo
ony Meer les x
bey * ”
. " - on . ‘s* . a ste
- aoa ‘s # Fd ? oy
7 e ig AT a ¥
s . 7: , oad e 4 i auale SS j F; ster deciee ;
*e . . at . ’ “ i ; é 7 : .
os
eee
nag oo sire 3 ec a te a oe. 2's - o fe ,
: oe ‘ - ‘ ‘ . . oo. . ‘ : « ; ‘ ue .
UB KV-140ZUb | RM-655 For Service Manuals Contact
| MAURITRON TECHNICAL SERVICES - 8 Cherry Tree Rd, Chinnor
Oxon OX9 4QY
- Tel- 01844-351694 Fax:- 04 944-352554
Email:- [email protected]
H-FREQ ADJUSTMENT
1. Input the PAL colour bar signal.
2. Set the PICTURE, COLOUR and BRT control to normal. |
3. Connect a 100u/16V chemical capaciter between
10501 pin(1 Jand ground.
4. Adjust RV501 for the image shown below. §. Disconnect a 100u/16V. 6. Change tuner channel and confirm that picture
does not change.
fo: too low fo: suitable fo: high (fo=15625+50Hz)
| Ns -
Adjust RV502, RV503 and RV55! for a best
vertical sizé picture.
H-CENT ADJUSTMENT
Adjust RV8071 fora centre the picture.
H-SIZE ADJUSTMENT
Adjust RV802 for a best size picture.
~ an —_ age yee bs Pome » vey = Ae we ramen dy “ - . ces on . ae oe. Ww ong (tea ve wae
we Nags s “. racy hee mre im io ‘ F a ee * #4 be eer a ry é aye —_ orn tte ie
ee ie e ad ” a! ow, : E on . . ns ‘ >
= a SOMA cone ‘s eee “3 + “¢ ow. woe oN . a ory
. + Aye i . . ba -
ie ae ~ SR OE AR ET TO RON AOR el See On
_ KV-1462UB KV- | RM-655 | RM-6 5-2. SCHEMATIC DIAGRAM SECTION 5
1 2 DIAGRAMS
5-1. CIRCUIT BOARDS LOCATION A
B
BT-8€
c|
A~9
D a as & oa eas < is << >{_1 <a >} ——}-c =a a K-1
E
Note: | |
@ All capacitors are in uF unless otherwise noted. pF: uuF Pa el ,
SOWV or less are not indicated except for electrolytics. H (PROG. DISP) @ All resistors are in ohms, 1/6W unless otherwise noted.
k: 10002; M: 1000k2 |
e All variable and adjustable resistors have characteristic
curve 8, unless otherwise noted.
: nonflammabie resistor.
fwA7A : fusible resistor. | | G 4 _ : internal component. | |
C__) : panel designation. |
: adjustment for repair.
All voltage are in V.
ame © 8+ bus.
Voltages are dc with respect to ground unless otherwise
noted. . me . | H
Readings are taken with a 10 MQ digital multimeter. | @ Readings are taken with a colour-bar signal input..
e Voltage variations may be noted due to normal produc-
tion tolerances.
@ -: signal path.
The components identified by shading and mark = A\ are critical for safety. Replace only with = part number specified. ss
J
ee ed oe Caer Lt er ele amytht Oe oe,
o6 Pa *: are
KV-14602UB6 RM-655
A (Y/C JUNGLE ,H/V DEF, AFOUT, )
For Service Manuals Contact Q202 IFB-395
MAURITRON TECHNICAL SERVICES a
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY
Tel:- 01844-351694 Fax:- 01 844-352554 ai
Email:- [email protected] [2] Oy
per Te ¥ vo
R206 22k
BT- 662A R202 aw
5.6
He ) 220 0
2 2
0008 — 015 SLH-34VC3F Ost ~ | Q002} 28C2785
; VC AMP! POSITION
(33V_REG)
CZEXZELRIZ> LL
COO! __ M5043!-512SP
7 celia.
2SAUTSF |
0608
8G 680p/ p/30W 3305
0605 RGPIOU
Rig
C60} sTRaat I5A 06 a |
1CQ03 HZT33-02TA
aT | | vee ™ ihe lav RECT
: pPC78LOSJ ~Te02 any | 5V REG ath, ATAW,
z A 4 repre
11SV_DUMPER
“F602: T630mA
C252 = Cas 0.00! i it 50y
° a Q TPI2
C28! in
%
Q201 saute LOET OUT
R047 2
" C615 33
i 160V Of
7 8 9 10 414 42 13 14 15
ee] wo nn
¥CM 30!
() AFT uP (~) AFT ON R206 22k
0301 1SSI9 03 ACC 135) 2
301 st 785 : ween
06 25AlI75 ; (DON KILLER 1] ne T 307 (COON LER
wo ara
c009 00p
Mm
¥,
Gm maermds 2 e 2s IC00}
M50431-Si2SP EN T 0.047 ass (CONTROLLER ] ) wawtitias
gig S$ DONO S
ETS <.
ICSOl pPCI377C JUNGLE
0018 ,0I9 ISSU9_.
(INTIAL SET]
| ven Py “Taso cs0 : peng W | abt [1Se doer
RGPIQ cs0g i | IC004 a 14V_ RECT J soos cs02 503
pPC78LOSJ T 602". ak | 0.001 ,l SV REG st, Aliawr A
— ASAT sovp-p (v) (1/40)
0606 GP08D +} C308 cs09
inde C616
6860p /500V
cé609
snr RGPION Room 0607 W5V_OUMPER
OVP] CSV-CLAMP] F602 a T630ma A\
= ¢603 | | REIG ry 0610 [3] 12k
=e Op i60V Haw) 0607 a= cgie
5, (vewl 3 * yee | A eV 1 Ivvvw) re
eed, “tw ML 115A 06 PO8D R60S RGIS
115V_ REG POMPUP 39 (IW) OTA):
~ 15-
ape Ter aces ce se pee oar i FDP ince dagen “ye Te Saat met, ; meee ge ete -
ffi MR es Oe STN «a Naa SAD RT SS, Se CO ot a Se Te re Om ? ia ahs a I A es Be en gt Migky 24 At W ee
KV-1462Z2UB KV-1462UB RM-655 RM-655
13 14 15 16 17 18 19 20
R325 6.8h
i" R513 4 Zp R326 33k = Sov 930 ‘lea i ue . =e a D301 ISSII9 03 59] 19 ae (PROTECTION) ACC AOS Le ome
_ 2sC
SALI (5 ee ng se Gna KILLER |
C322 a 0.001
CV301 309 © R350 22k
is ote 307
iV. 4OLD! . . BRT
Q302 25C2/85
{A8\) R373
ns29 R524 1C85| aw 190k
(1/4 W) 21%)
0803 2sc27esr pf )ox (H. PULSE C329
+ 0.0! caga 50V EN
aa
ICB0l_wPC4558C ooze Sgt PIN AMP
WV tH) [LI5V sue p-P
aTk== SS Q802 2S01649-CA
L82t |
2.74 R506 CsI
ae felt, ey GPO
“1 I Rae GPO8)
.
baw [ — 1488 RV8O0l
R829 A822 150k 120%
yas 2s0T6I Pac OGD
or <7 ote Ua = . se .. . es : ae _ Anes . Ma dat 38 : : Pe -- . ” ery 2 ‘ aenartura re ,
A : . : \ 7
A ut
KV-1462UB RM-655
19 20 21 22, 23 24 25
eae, For Service Manuals Contact
rf] MAURITRON TECHNICAL SERVICES 7 ra 8 Cherry Tree Rd, Chinnor | | 3
as Oxon OX9 4QY
Ov c306| 50V Tel:- 01844-351694 Fax:- 01844-352554
SOV Email:- [email protected]
2 , | ,
se Son : as
| oe C (R'G*B OUT)
R318 100k
22Vp-p (H)
TH, STAT]
Focus MIN—-MAX OV — 38IV
a
SCREEN MIN — MAX 322V— 876V
(ORT)
Q302 85Vp-p (H)
2502785 3.3K aw)
PcTeMI2H f2vj ane REG]
|
6) 803 a)
pg 2sC2785-F C268 >
a + , Q702 th | Te 25C2688 2 s0v nyse (our)
Aw foes
2SC2688.
Boze = Sao 808
ny oe (4
DBO] ERCOG- 15S OH
ooo soov oy
0802 085 =
0802 ss 0863 acpng SO! oi “RGRIOG. 149V RECT G dy 3 ' can 860 \ (V4aw)
“7 a 00h eov, id ve 150k oS :
aves RGPIOG 2 bP IS ¥ [sie] ---— |, ae.
28 > SSN RON mlaLeee [soy J :
t] ES = the S|,
sores we "eee = 0852 ESIF . opt WILY Cal4 — st
(PINOUT) Stsv | (62 RECT] : aa iC
: |
: A-§
@are a,
Vy "i . das
vase. aer.r ary ° ts
ora
KV-1462UB RM-655
Y/C JUNGLE ©
LH/V DEF. AF OUT
6 7
5-3. PRINTED WIRING BOARDS Oo
1 2
A Board
NV-140ZUB5 KV-1462UB RM-655 RM-655
Y/C JUNGLE | | [A||C] H/V DEF. AF OUT |
“it heb skin ie *) PRET RE fer Tee ERE é 5 ati
. 2000) UTED ammnmmmmemepmemnenih a0 9 m8 em 7:4 witretacemiv wel ~~
11 12. 43 14 4
502 00!
001,013 012
019, 018
, . ry ’ * . re . oo ., oes ers . ase .
. < . . .
22 :
|
boars . ‘ te: 1 : ae va oa
. ome, ae i, a ee nae oe 8 . . a « ee ee :
. . ‘ ? . . a : w 3 a. oe
. -t ° . wos . * ee ry < . wide i ae
ee Le ae eu is Pre
ae :
-
. has se « -
| :
at er et . ae . ‘ ey ery ed ay . :
| | :
ae
- « os . ¥ f
: : .
ee 2 :
. a > <3 :
es .
KV-1462UB RM-655
C [R.G.B OUT} [PROG DISP]
16 17 18 | 19 20 21 22 23
| | | H Board ‘d | 3 : | | 3 A
|B
1C
D ;
For Service Manuals Contact E MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY
Tel:- 01844-351604 Fax:- 01844-352554 Email:- [email protected]
F
IG
H
J 2
cee eee
| KV-1462UB op Ss§
5-4. Semiconductors Lead Layout
BX-1398 —yPC1241H 2SD1761
4 we if . af ae oot
.
A - ge NN
a. tae et a lvinep. af? aes e ds.
: re 7 ny eee ag eee ‘as re . een ae) iro Med re : Aiba]
ee oe ae y ts e ey
* end
ws .
ines a . .
ears a ‘ emryy, . oe oe eed
Pile ane ees a! :«
: Bs oy Sa et
eo aa ORE * eat’ ie an iT) agar a. : f
woe, oa Semel Si) eg ar rr es
Pe Tete peylt etree
re i er ee
‘ ;
j
s@ eaates CXA1 001 Al 1 1 1
M50431-611SP yPC1488H = U05G
Sasnsthoashannans HZS4.3NB1T2 o— HZS5.6NB3T2
ie ae ei RD4.3ESB1 afhens TUTTI RDS.6ESB3
(Top view) cathode
CXK1004L 2SA933
2SD1 387
a E ce 12345678910 ERCO6-15S oe | ERC24-06S
HA17558 For Service Manuals Contact
orgie are conove MAURITRON TECHNICAL SERVICES ae 2SA1115 : - &Cherry Tree Ra, Chinnor
Oxon OX9 4QY 8765 SC40
73c1740 Tel:- 01844-351694 Fax:- 01844-352554
rae | 2SC2458 poet Email;- [email protected]
| 1234, 2SC2603
os dca DTC124XS
Sa L-9P03D ee HZT33-02TA -
“ch a | (Bottom View)
iB sia 2SA1175 eee 2SC2185 GPO8SDPKG23
ate | RGP10GPKG23
ee RGP105 oe ote pPC1377C
ec: —e Hts ocd 22 $2
% ee (Top view)
a R2M
STR50115A
node
- -
-
od pe-
*
t
20
5 vere ae tm ga Vs. ~~
: feat ee meee = Soa.
ee anget Siena ’ ee
ac > wana “
- se ee ae era, oe
ae ts =
oan . ce age w
ae | Kv.1462UB
ig SECTION 6 A EXPLODED VIEWS
3 ee Ha Items with no part number and no des- : * Items marked " * " are not stocked since oo peas SE
= cription are not stocked because they they are seldom required for routine mz The components identified 2 a are seldom required for routine service. service. Some delay should be anticipated ~ = by shading and mark A are %
: - The construction parts of an assembled when ordering these items. | s critical for safety. i om part are indicated with a collation | ¢ Replace only with part ; ° number in the remark column. — : = i number acini ee e : : BORO NNR ON ERRNO
20> 64, PICTURE TUBE
7-685-663-79 TA,BV4x16
tgee
No. Part No. Description Remark | No. Part _No. Description | Remark
1 4-374-921-61 HANDLE (LEFT) . | 9 4-365-808-00 SCREW (5), TAPPING
és 2. 4-374-920-31 HANOLE (RIGHT) | | 10 *4-346-339-00 HOLDER, HV CABLE
is 3 A.8-735-553-05.:: PICTURE: TUBE(A34JBUIOX) i est 11 4-376-557-01 COVER, BACK
= 4 3-703-961-01 SPACER, OY . | 12 4-308-870-00 CLIP, LEAD WIRE
5 1-452-277-00 MAGNET, BMC . 1-452-032-00 MAGNET,DISK; 10MM ¢ 6. WK 1-451-249- 313, OFLECTION YOKE” ‘(S¥=1258). 1-452-094-00 MAGNET, ROTATABLE DISK; 1M™ 4
7. *A-1330-628-A C BOARD, ee nore tae X-4309-608-0 PERMALLOY ASSY, CONVERGENCE
8 .)-426-145-13> COIL; DEGAUSSING © a ope as
bd - is ’,
V ’
io aie as owe
‘he °
“4 woe. ou 3S we $ eis -.
. 7 Po
a , ww tet = —_ .
. . ve a pie
5 ones - . .. e a s : “ vt, a ee ‘ ot 2:
eg = ie = Ts ; ae ne
NvVv- §402UD RM-655
6-2. BEZEL ASSY
@: 7-685-648-79 TA,BV3x12
No. Part No.
51 X-4376-553-1 52 X-4376-552-1 53 4-385-036-01 §4 = *4-374-962-01 55 4-374-926-11 56 4-376-516-21 57 4-376-518-01 58 1-503-344-21 59 4-376-531-11
60. A.1-554-967-12" .
Description Remark
BEZEL ASSY §2,53,54,55,56,57 DOOR ASSY, CONTROL
WINDOW (E), TUNING NET, SPEAKER PUSH BUTTON BUTTON, CONTROL
BUTTON, MULTI SPEAKER
BUTTON (8), POWER oe SWITCH, PUSH (AC POWER)(1 KEY) oc.
No. Part No.
“61. &.4-368-619-03 . - 62: : A. 1- 534- 7 77-3 1
63 = *1-623-023-11 > 64. A.1-463-593-11 65 «= -#1-555-111-71 66° A1-536-683-21 67 A.1-439-311-32
68 *A-1296-341-A 69 = *4-374-987-01 70 = *4-381-686-01
For Service Manuals Contact MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY :
Tel:- 01844-351694 Fax:- 01814-352554 Email:- [email protected]
Description Remark HOLDER, €ORD, AC ee CORD; POWER, SUPPLY ie H BOARD
TUNER, EF. (BT-882A) | CABLE, PIN CONNECTOR,. COAXIAL “ANTENNA |
_ TRANSFORMER. ASSY,: FLYBACK - A BOARD, COMPLETE | GIDE, LIGHT — BRACKET (8), BAR, OPTICAL
« 2.01 «eam MaMetate terete tetete! wotatet
PSNR ISR No The components id entified
re ta“a evo "ete%
oeoaieonteonaeets Os
RO) een e
ow)
critical for Sve ty. st m Replace only vi th part s5 se number specifid, soe8 o. Be
‘oo?
avers ote, asereveserdtacaralesereZeTicese"e°6) siento ae sarere: CONN soreter
Son Ry EONS eS x
sang
by shading andra rk Aare 35 f
4. yQeveees ear seaewrs ¢ a Ir Yo) er 2 Saer ore wes - Ay Mew Pena, _- ad inst coir ed “ 2 se! : G . . nr a eran
ale ie mc et . 1 ool, tp-- = Pee
wed. oa « soar ojt- te ew .
vas ‘ see Py ae = : .
2 | Kv-1462UB | RM-655
: SECTION 7
ELECTRICAL PARTS LIST
NOTE: Pking oo = the picioales aan a. % Be Po by shading and mark A are ie
eeseseveseecesenens "ena
RESISTORS - All resistors are in ohms
are not stocked
required for - Items marked "*"
since they are seldom : critical for safety. | & routine service. Some delay should be ° F : nonflammable
t Replace only with part = anticipated when ordering these items. COILS. ber Bluse me ; ; . a hum venaueenete. ° All variable and adjustable resistors * MMH: mH, UH > pH
aes RNR RK RAN RRRK NU REAA EE EKA REAR BERK have characteristic curve B, unless otherwise noted.
When indicating parts by refer-
mt 23 a
CAPACITORS ence number, please include
* MF: PF, PF : pyF the board name.
Ref .No. Part No. Description Remark [Ret No. Part No. Description Remark
*A-1296-341-A A BOARD, COMPLETE 1 C316 1-106-184-00 MYLAR 0.0033MF 10% 50V_ FOIA I Sete | C318 1-124-791-11 ELECT IMF 20% 50V
| C319 1-108-841-91 MYLAR 0.022MF 10% 50V CONNECTOR | C320 1-124-464-11 ELECT 0.22MF =. 20% 50V
1 C321 . 1-108-841-91 MYLAR 0.022MF 10% 50V Al *1-560-126-00 PLUG, CONNECTOR (2.5MM) 6P | A2 *1-560-290-00 PLUG, CONNECTOR (2.5MM PITCH) }:C322 1-102-074-00 CERAMIC 0.001MF 10% 50V A3 *1-508-786-00 2P PLUG (M) | C323. 1-124-477-11° ELECT _ 47ME 20% 25V A4 *1-508-765-00 3P PLUG (M) | C325 1-101-004-00 CERAMIC 0.01MF 50V AS *1-564-038-00 CONNECTOR PLUG, DY (MINI) 6P | C326 1-101-004-00 CERAMIC 0.O01MF 50V
| C327. 1-124-791-11 ELECT IMF 20% 50V A6 *1-508-786-00 2P PLUG (M) | A7 *1-506-348-XX 3P PLUG (L) | C328 1-124-791-11 ELECT IMF 20% 50V A9 *1-560-129-00 PLUG, CONNECTOR (2.5MM) 9P { C329 =1-101-004-00 CERAMIC 0.O1MF 50V
} C330 1-124-791-11 ELECT IMF 20% 50V CAPACITOR | C331 1-124-477-11 ELECT 47MF 20% 25V
| , | C336 1-102-074-00 CERAMIC 0.001MF 10% 50V cool = 1- 124- 478-11 ELECT 100MF 20% ~~ 25V | , 5 C002. =: 1-101-004-00 CERAMIC 0.01MF 50V { C501 1-136-161-00 FILM 0.047MF 5% 50V C003 1-101-004-00 CERAMIC - 0.O1MF 50V | C502 1-102-074-00 CERAMIC 0.001MF 10% 50V C004 =: 1-124-791-11 ELECT IMFO 20% 50V } C503 1-124-791-11 ELECT IMF 20%. ss 50V C005 =1-101-004-00 CERAMIC 0.01MF | SOV | C504 1-106-347-00 MYLAR 0.0015MF 10% 50V
: | C506 1-108-837-00 MYLAR 0.01MF 10% 50V C006 3=«-:«1-124-477-11 ELECT 47MF 20% 25V | : C007. =:1-102-112-00 CERAMIC 330PF 10% 50V | C507 =1-108-841-91 MYLAR 0.022MF 1Oox 50V C008 =: 1-123-875-91 ELECT 10MF 20% 50V | C508 1-124-791-11 ELECT IMF 10% 50V C009 =: 1-102-973-00 CERAMIC 100PF 5% 50V.. | C509 1-124-791-11 ELECT IMF 10% 50V C010 =: 11-136 -165-00 FILM . O.1MF 5% 50V | C510 1-108-841-91 MYLAR 0.022MF 1Ox 50V
! C511 1-106-351-00 MYLAR 0,0022MF \Ox 50V C015: 1-124-927-11 ELECT 4. 7MF (20% 50V | C016 =6: 1-124-927-11 ELECT 4. 7MF 20% 50V | C512 =1-129-794-00 FILM 0,0033MF 1% 100V C017. =: 1-124-927-11 ELECT 4.7MF 20% 50V |} C513 1-124-791-11 ELECT 1MF 10% 50V C018 1-123-875-91 ELECT 1OMF 20% 50V 1 C514 1-124-477-11 ELECT 47MF 10% = 25V (154 1-123-875-91 ELECT 1OMF 20% 50v. | C515 1-136-161-00 FILM 0.047MF i” 50V
{ C518 .1-131-365-00 TANTALUM 1OMF lox 16V C155 1-123-875-91 ELECT 1OMF 20% 50V | C156 1-123-875-91 ELECT 10MF 20% 50V | C519 1-136-173-00 FILM 0.47MF i% 50V C157. —- 1-136-163-00 FILM 0.068MF 5% 50V | C521 1-124-791-11 ELECT 1MF 10x 50V C158 1-136-163-00 FILM 0.068MF 5% 50V | C522 1-108-837-00 MYLAR 0.01MF lox 50V C201 1-124-477-11 ELECT 47MF 20% 25V | C523. 1-124-791-11 ELECT IMF 10% 50V
| C524 =1-136-160-00 FILM 0.039MF i 4 50V C202 1-124-464-11 ELECT 0.22MF 20% 50V | C203. 1-124-477-11 ELECT 47MF 20% 25V | C525 1-124-475-11 ELECT 470MF 10% 16V C207. _-1-124-791-11 ELECT IMF 20% 50v. = |: C551.~=—s-: 1-101-880-00 CERAMIC 47PF iy 50V C208 1-124-655-11 ELECT 0.47MF 20% 50V | C552 1-102-112-00 CERAMIC 330PF lox 50V C251 1-124-479-11 ELECT 330MF 20% 25V | C553: 1-124-122-11 ELECT 100MF 10% 50V
{ C555 1-124-557-11 ELECT 1000MF Hop 4 25V (252 = 1-102-074-00 CERAMIC 0.001MF 10% 50V | | C253. 1-124-791-11 ELECT IMF 7 20% 50V | C556 1-101-004-00 CERAMIC 0.01MF SOV C254 =1-124-477-11 ELECT 47MF 20% 25V | C557 1-124-900-11 ELECT 470MF 0% 35V C255 1-124-475-11 ELECT 470MF 20% 16V | C601 A.1-130-680-61 FILM | O.1MF 0% j300V. C256 1-136-165-00 FILM O.1MF 5% —50V | C602 A&.1-161-830-51 CERAMIC . 0.0047MF. S00v
-{ C603 =1-102-114-00 CERAMIC 470PF 0% 50V C305 1-124-791-11 ELECT IMF 20% Sov | on a a (306 «=1-124-791-11 ELECT IMF 20% 50V | C604 A.1-161-830-5I CERAMIC | 0,0047MF — 500V C307. -:1-124-927-11 ELECT 4.7MF 20% 50V -| C605 4&.1-161-830-51 CERAMIC. 0.0047MF — §00V. C308 1-102-959-00 CERAMIC 22PF 5% 50V | C606 1-125-318-00 ELECT( BLOCK) 220MF om 400V C309 1-102-111-00 CERAMIC -270PF 10% 50V | C607 1-106-226-00 MYLAR 0.18MF By 4 100¥
| C609 1-162-116-00 CERAMIC 680PF Ny -4 2KV C310 1-102-111-00 CERAMIC 270PF 10% 50V C311 =: 1-124-791-11 ELECT IMF 20% 50v { C610 1-102-112-00 CERAMIC 330PF px 50V C314 =: 1-124-927-11 ELECT 4. 7MF 20% 50V | C612 = 1-124-479-11 ELECT = = 330MF om ov (315 1-123-875-91 ELECT _10MF 20% 50V [; C6E3: A,1-161-830-51. CERAMIC . 0.0047MF. = S00
| KV-140Z2U6 _RM-655
Remark |Ref.No. Part No. Ref .No, Part No. Description Description Remark
f C614 1-123-930-00 ELECT 2.2MF 20% 160V | D606 8-719-911-55 DIODE U05G ; C615 1-123-024-00 ELECT 33MF 16G6V | 0607 8-719-911-55 DIODE U056
C616 1-102-002-00 CERAMIC 680 PF — 10% 500V | 0608 8-719-924-06 DIODE ERC24-06S C802 = 1-123-932-00 ELECT 4.7MF 20% 160V | 0610 8-719-303-49 DIODE R2M C803 1-108-692-81 MYLAR 0.01MF 10% 200V ] 0801 8-719-945-80 DIODE ERCO6-155 ,
C804 1-102-038-00 CERAMIC 0.001MF 500V | D802 8-719-924-06 DIODE ERC24-06S C805 1-102-244-00 CERAMIC 220PF 10% 500V } D851 8-719-924-06 DIODE ERC24-06S C807 1-136-173-00 FILM 0.47MF 5% 50V } 0852 8-719-300-65 DIODE ESIF C808 1-129-765-00 FILM 0.047MF 10% 200V | 0853 8-719-924-06 DIODE ERC24-06S C809 A, 1-161-754-11. CERAMIC 0.001MF 10% 3KV | 0855 8-719-924-06 DIODE ERC24-06S
C810 1-108-630-91 MYLAR 0.022MF 10% 100V |} 0857 8-719-911-55 DIODE U05G C811 1-123-875-91 ELECT 1OMF 20% 50V | 0858 8-719-911-55 DIODE U05G C812 A,1-136-092-11 FILM 0.0072MF 3% 2KV | |
~ (813 1-102-074-00 CERAMIC 0,.001MF 10% 50V | | DELAY LINE C814 =—s- 1-124-477-11 ELECT 47MF 20% 25V {
{| DL301 1-415-122-31 DELAY LINE, 1H (PAL) C815 1-129-898-00 FILM 0.0022MF 10% 630V | C817 = 1-136-171-00 FILM 0.33MF 5% 50V | FUSE C818 1-124-477-11 ELECT 47MF 20% 25V | | C821 1-106-397-00 MYLAR 0.18MF 10% 200V } F601 AMS 532-237-11 FUSE, TIME-LAG 3.15A/250V C822 =1-136-513-11 FILM 0.82MF 5% 200V | *1-533-189-11 HOLDER, FUSE; F601
. . | F602 A.1-532-284-11 FUSE,. TIME- LAG 0.63A/250V_ C825 1-108-692-81 MYLAR O.O1MF | 10% 200V { *1-533-189-11 HOLDER, FUSE; F602 C827 =1-123-943-00 ELECT 1MF 20% 250V | C851 1-123-948-00 ELECT 22MF 20% 250V | Ic C852 = 1-162-114-00 CERAMIC 0.004 7MF 2KV | . C853 1-102-038-00 CERAMIC 0.001MF 500V |} 10001 8-759-605-24 IC M50431-512SP
F | I1c002 8-759-803-24 [IC CXK1004L C854 =: 1-123-875-91 ELECT ~ 1OMF 20% 50V | 1C003 8-759-157-40 IC UuPC574J C856 =1-162-318-11 CERAMIC 0.001MF 10% 500V | 1¢004 8-759-105-33 IC UPC78L05J C857 =1-108-425-00 MYLAR 0.022MF 10% 200V } 1¢005 8-741-139-80 IC BxX1398 C858 = 1-123-875-91 ELECT LOMF 20% 50V | —_ | C859 1-124-478-11 ELECT 100MF 20% 25V | 10251 8-759-101-77 IC UPC1241H
{ IC301 8-752-030-86 [IC CXA1LOO1AP C860 ~ =1-102-228-00 CERAMIC 470PF 10% 500V | 1€501 8-759-100-60 IC UPC1377C C861 =1-123-875-91 ELECT 10MF 20% 50V { 1€551 8-759-113-05 IC UPC1488H —T C888 =: 11-102-228-00 CERAMIC 470PF 10% 500¥ 1C6014,8-749-900-83 IC STR50115A -
TRIMMER | 4-385-008-01 SPACER, MICA; IC601 {| 1¢801 8-759-145-58 IC UPC4558C
CV3O1 1-141-181-11 CAP, TRIMMER | 1C851 8-759-170-12 IC UPC78M12H
OIODE | IF BLOCK
DOO1 = 8-719-120-14 DIODE RD3.9ES-L1 | IF201 1-464-583-11 IF BLOCK (IFB-395) D011 8-719-911-19 DIODE 188119 { 0012 =8-719-911-19 OIODE 1$88119 | COIL 0013. 8-719-911-19 DIODE 158119 { 0018 8-719-911-19 DIODE 1588119 {| LOOL 1-410-470-11 MICRO INDUCTOR IOUH
{ L151 1-410-470-11 MICRO INDUCTOR 10UH 0019 8-719-911-19 DIODE 1$S8119 {| L302 1-410-090-41 MICRO INDUCTOR 18MMH D151 = 8- 719-120-53 DIODE RDS.1ES-L2 } L303 = 1-410-476-11 MICRO INDUCTOR 33UH D201 8-719-121-40 DIODE RDIOES-L3 | £304 1-410-469-21 MICRO INDUCTOR 8.2UH 0301 8-719-911-19 DIODE 188119 { D306 = 8-719-911-19 DIODE 1585119 { (305 1-410-470-11 MICRO INDUCTOR 10UH
{ 1604 1-407-365-00 COIL, CHOKE 0501 8-719-911-19 DIODE 1$5119 | L803 1-407-365-00 COIL, CHOKE : 0502 8-719-911-19 DIODE 158119 |} (804 1-407-497-00 MICRO INDUCTOR 2.7MMH 0551 8-719-911-55 DIODE U05G [| L805 A.1-459-496-11 COIL,..FERRITE (HLC) 0601 A. 8-719-503-06 DIODE S3WB60Z | a D605 8-719-961-04 DIODE RGP10J {| L806 1-408-230-00 MICRO INDUCTOR 820UH
For Service Manuals Contact
MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY
Tel:- 01844-351694 Fax:- 01644-352554
Email:- [email protected]. UK
Ross aes Beste net 8 Sy Bs seceeceeiese estes sitet Se
= The en iden fied | = by shading and mark~®& are ; : critical for safety,
: Replace only with pert 3 BH i number steele Sees es a ieet Sees Rees seats Retina aeeinnceces tt
ey peta these me
tk en
mY Ce ee
Ve ze me Sth
oS ee Srey! Wg, BFS
ESE
ene Ca ere ety
vere 14e aye
Ref .No.
L807 L808 L821
Qool Qo02 Q004 Q008 Q151
Q201 Q202 Q301 Q302 Q306
Q307 Q801 Q802 Q803 Q821
ROO1 ROO2 ROO3 ROOS ROO7
ROO8 ROOS RO10 RO11 RO12
RO13 R014 RO17 RO20 RO22
R023 RO24 RO25 RO26 R027
RO28 RO29 R030 R031 RO32
RO33 R034 RO35 RO36 RO38
R039 1-249-436-11
Part No. Description
1-408-230-00 MICRO INDUCTOR 820UH 1-408-239-00 MICRO INDUCTOR 4,7MMH | 1-408-236-00 MICRO INDUCTOR 2.7MMH
TRANSISTOR |
8-729-117-54 TRANSISTOR 2SA1175 8-729-178-54 TRANSISTOR 2SC2785 8-729-900-83 TRANSISTOR DTC124XxS. 8-729-900-63 TRANSISPOR DTAL24ES 8-729-178-54 TRANSISTOR 2SC2785
8-729-117-54 TRANSISTOR 2SA1175 8-729-801-93 TRANSISTOR 2501387 8-729-178-54 TRANSISTOR 2SC2785 8-729-178-54 TRANSISTOR 2SC2785 8-729-117-54 TRANSISTOR 2SA1175
8-729-900-83 TRANSISTOR DTC124XxS 8-729-168-82 TRANSISTOR 2SC2688 8-729-802-50 TRANSISTOR 2501649-CA 8-729-178-54 TRANSISTOR 2SC2785. 8-729-904-27 TRANSISTOR 2S501761-E
RESISTOR
1-249-417-11 CARBON 1K 5% 1-249-433-11 CARBON 22K oS 1-249-425-11 CARBON 4.7K 5% 1-249-440-11 CARBON 82K 5% 1-249-433-11 CARBON 22K «55%
1-249-433-11 CARBON 22K 5% 1-249-433-11 CARBON 22K oS 1-249-433-11 CARBON 22k = «45% 1-216-440-00 METAL OXIDE 18K 5% 1-249-433-11 CARBON 22k «= «5%
1-249-433-11 CARBON 22K = 5% 1-247-708-11 CARBON 470 5% 1-249-462-11 CARBON 22K «5% 1-249-433-11 CARBON 22k = «45% 1-249-413-11 CARBON 470 5%
1-249-413-11 CARBON 470 5% 1-249-413-11 CARBON 470 5% 1-249-413-11 CARBON 470 5% 1-249-413-11 CARBON 470 5% 1-249-413-11 CARBON 470 5%
1-249-413-11 CARBON 470 5% 1-249-413-11 CARBON 470 5% 1-247-713-11 CARBON 1K 5% 1-247-713-11 CARBON 1K oS 1-247-713-11 CARBON 1K oS
1-247-713-11 CARBON 1K oS 1-247-713-11 CARBON K = 5% 1-247-713-11 CARBON . IK 5% 1-249-429-11 CARBON 10K 5% 1-247-849-00 CARBON 5.6K 5%
CARBON 39K 5%
1/6W 1/6W 1/6W 1/6W 1/6W
1/6W 1/6W
—1/6W
1/6W
1/6W 1/4W 1/4W 1/6W 1/6W
1/6W 1/6W 1/6W 1/6W 1/6W
1/6W 1/6W 1/4W 1/4W 1/4W
1/4W 1/4W 1/4W 1/6W 1/6W
1/6W
Remark |Ref.No. Part No.
ee OE eet = ew cee eae SE cee eee one —_— —
eee eel OE SEN SAAS REM amieeNtc OO LS LL LS A A cs ee SS es OY RENTS wees Sot tee Ne SE ce een mene women ee UD cen eee See cemeeye come SU eee PR es eee eemues SSE
R041 R042 R043 RO44 RO45
R046 RO47 RO48 R151 R152
R153 R154 R201 R202 R203
R205 R206 R207 R210 R211
R253 R254 R301 R306 R307
R310 © R311 R312 R313 R314
R315 R316 R317 R318 R319
R320 R321 R322 R325 R326
R328 - R329 R332 R333 R334
R339 R343 R344 R345 R346
R347 - R350 R359
1-249-411-11 1-247-713-11 1-249-423-11 1-249-429-11
— 1-247-849-00
1-249-433-11 1-249-433-11 1-249-425-11 1-249-462-11 1-247-891-00
-1-249-429-11 1-249-413-11. 1-249-405-11 1-247-711-11 1-247-708-11
1-249-435-11 1-249-433-11 1-249-433-11 1-249-435-11 1-249-433-11
1-249-421-11 1-249-447-11 1-215-483-00 1-249-420-11 1-247-724-11
1-215-479-00 1-215-493-00 1-249-437-11 1-249-433-11 1-246-539-00
1-246-527-00 1-249-441-11 1-249-441-11 1-249-441-11 1-247-704-11
1-247-704-11 1-247-704-11 1-249-420-11 1-249-427-11 1-247-849-00
1-246-511-00 1-247-883-00 1-247-849-00 1-249-412-11 1-249-417-11
1-249-413-11 1-247-885-00 1-247-895-00 1-247-895-00 1-249-433-11 |
1-249-421-11 1-249-433-11 1-247-718-11
Description
CARBON CARBON CARBON CARBON | CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON
330
3.3K 10K 5.6K
22K 22K 4.7K 22K 330K
10K 470 100 680 470
33K 22K 22K 33K 22K
2.2K t 390K 1.8K 8.2K
270K
47K 22K 560K
180K 100K 100K 100K 220
220 220 1.8K 6.8K 5.6K
39K 150K 5.6K 390 1K
470 180K 470K 470K 22K
2.2K 22K 2.7K
eye
KV-1462UB RM-655
1/6W 1/4W 1/6W ‘1/6W —1/6W
1/6W 1/6W 1/6W (1/4W 1/6W
1/6W 1/6W 1/6W 1/4W 1/4W
1/6W 1/6W 1/6W 1/6W 1/6W
1/6W 1/4W 1/6W 1/6W 1/4W
1/6W 1/6W 1/6W 1/6W 1/4W
1/4W 1/6W 1/6W 1/6W 1/4W
1/4W 1/4W 1 /6W 1/6W 1 /6W
“1/4 1 /6W 1 /6W 1 /6W L /6W
L /6W L /6W. L /6W*.
1 /6W 1 /6W
| /6W L /6W L J 4w
Remark
KV-1462U65 | RM-655
A Ref .No. Part No.
R366 =: 1-249- 435-11 R367 = 1-249-423-11 R368 1-249-423-11 R369 =: 1-249-423-11 R370 | 1-249-427-11
R371 1-246-533-00 R373: 1-247-719-11 R501 = 1-249-411-11 R502 =: 1-247-705-11 R503 =1-249-425-11
R504 1-249-440-11 R505 1-249-423-11 R506 ~=1-215-458-00 R507 =: 1-249-459-11 R509 =—s-: 1-249-429-11
R512 1-216-440-00 R513 1-249-423-11 R514 = 1-215-460-00 R515 =: 1-249-425-11 R517 =: 1-249-431-11
R519 = 1-249-425-11 R522 = 1-249-438-11 R524 = 1-214-783-00 R525 = 1-215-455-00 R526 = 1-249-438-11
R527 = 1-249-422-11 R528 = 1-249-424-1)} R529 =1-215-461-00 R530 =: 1-249-393-11 R532 =: 1-247-706-11
R542 1-247-711-11 R551 1-249-440-11 R552 = 1-247-744-11
» R553 =: 1-216-353-00 R554 1-215-867-00
R601 A,1-205-909-11 R602 1-244-923-00 R603 =: 1-247-739-11 R607 AV 1-212-849-51 R609 =: 11-216 -424-11
R615 A, 1-212-849-51 R616 1-216-487-11 R802 1-215-922-11
— R803 1-215-922-11 R804 1-247-721-11
R805 1-249-433-1] R822 1-247-881-00 R823 1-247-717-11 R824 1-249-436-11 R825 1-247-725-11
R826 1-247-719-11 R827 1-249-417-11 R828 1-249-438-11
Description
‘CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON CARBON © CARBON
CARBON CARBON CARBON CARBON CARBON
METAL OXIDE CARBON METAL CARBON CARBON
CARBON CARBON METAL METAL CARBON
CARBON CARBON METAL CARBON CARBON
CARBON CARBON CARBON METAL OXIDE METAL OXIDE
CEMENTED: CARBON CARBON
~ FUS IBLE METAL OXi0€
FUSIBLE.~ METAL OXIDE” METAL OXIDE METAL OXIDE CARBON
CARBON CARBON CARBON CARBON CARBON
CARBON CARBON CARBON
33K 3.3K 3.3K 3.3K 6.8K
330K 3.3K 330 270 4.7K
82K 3.3K 36K 12K 10K
18K 3.3K 43K 4.7K 15K
4.7K 56K 180K 27K 56K
2.7K 3.9K 47K 10 330
680 82K 270 2.2 470
343 120K 100
ad bye 39
~- 4,7 satel :
6.8K 6.8K 4.7K
22K 120K 2.2K 39K 10K
3.3K 1K 56K
1/6W
Remark |Ref.No. Part No.
maT
TAA MTN
R829 R830 R831 R832
R833: A.
* R834 A. R837 A. R851 R852 R853
R854 R855 _— R856 R857 R860
R888 R889 R891 R892
RV302 RV303
— RV304 RV 305 RV501
| | | | | | | | | | | | | | | | | | | | | | | | | | | |
| | {| RVv502 | RV503 1 RVv505 | RV551 | rv801 | | [ | | | | | | | | | | | | | | | | | | | | | | | |
RV802
$001 $002 $003 $004 $005
$006 $007
| S008 $009
SG801
T301 T601 A. ‘T602 A. 7801 T851 A,
1-247-883-00 1-249-424-11 1-247-849-00 1-249-410-11 1-212-857-51
1-212-865-51 1-212-877-51.
- 1-249-382-11 1-215-869-11 1-249-377-11
1-249-381-11 1-202-830-00 1-247-723-11 1-246-527-00 1-247-883-00
1-202-814-11 1-249-429-11 1-249-429-11 1-249-425-11
Description
CARBON CARBON CARBON CARBON
FUSIBLE
FUSIBLE ~ FUSIBLE CARBON METAL OXIDE 1K 5% lW CARBON
CARBON SOLID CARBON CARBON CARBON
SOL ID CARBON CARBON CARBON
Remark
150K 5% 3.9K 5% 5.6K 5%
| 270 5% ;
a
1.2 5
1/6W 1/6W 1/6W 1/6W 1/4W
1/4W 1/4 1/6W
0.47 5% = -1/6W
1/6W 1/2W 1/4W 1/4W 1/6W
7n 7AM OT 10K 6.8K 5% 180K 5% 150K 5%
33K 10K 5% 10K 5% 4.7K 5%
«1/2 1/6W 1/6W 1/6W
VARIABLE RESISTOR
1-228-989-00 1-230-630-11 1-228-995-00 © 1-230-916-11 1-230-522-11
1-228-989-00 1-228-989-00 1-230-915-11 1-224-250-XX 1-223-102-00
1-228-995-00
RES,
RES, RES,
RES, RES,
RES, RES, RES, RES, RES,
RES,
SWITCH
1-554-804-11 1-554-804-11 1-554-804-11 1-554-804-11 1-554-804-11
1-554-804-11 1-554-804-11 1-554-804-11 1-554-804-11
SWITCH, SWITCH, SWITCH, SWITCH, SWITCH,
SWITCH, SWITCH, SWITCH, SWITCH,
SPARK GAP
1-519-063-XX DISCHARGING GAP
TRANSFORMER
1-404-524-11 1-421-862-11 1-448-912-11 1-437-078-00 1-439=311-32
For Service Manuals Contact MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor Oxon OX9 4QY
Tel:- 01844-351694 Fax:- 01844-352554
~ 26
Email:- [email protected]
DAT | CFT:
CARBON 470 CARBON 10K CARBON 22K CARBON 10K METAL GLAZE 4.7K
CARBON 470 CARBON 470 CARBON 10K METAL GLAZE 2.2K WIREWOUND 120
CARBON 22K
1 KEY) 1 KEY)
PUSH (1 KEY) 1 KEY) 1 KEY)
1 KEY) PUSH (1 KEY)
1 KEY) 1 KEY)
SRT (SCT) TRANSFORMER, SOR TTGNTAL eRe oo TRANSFORMER ASSY, FLYBACK =
easetoteeete RS ee ees eee Se
The ay identified & Be
S by shading and mark 4, are;
Soe Ro eoete lace ceancatelece ease
Be *s
“3 critical for safety, =
: Replace only with part a
eA pepe specified. eee RRO :
ee De Oe ee ee eT ee ee ee
23°H, 3 yy ih int ec} pn
48 it,
35 *
ad
NV- | 402UD | RM-655
Ref .No. Part No. Description Remark |Ref.No. Part No. Description Remark ee |
THERMISTOR | R711 1-202-824-00 SOLID 3.3K 1/2W eee | R712 1-216-463-00 METAL OXIDE 12K 5% 2W F
THP6014,1-806-165-11 THERMISTOR (POSITIVE) © } R713 1-249-422-11 CARBON 2.7K 5% 1/6W | | R714 1-249-414-11 CARBON 560 5% 1/6W
TUNER | R715 1-249-414-11 CARBON 560 5% 1/6W
_ TU1514, 1-463-593-11 TUNER, ET (BT-882A) | R716 =1-249-423-11 CARBON. 3.3K 5% 1/6W
: { R717 = 1-202-824-00 SOLID 3.3K 1/2W CRYSTAL | R718 1-216-463-00 METAL OXIDE 12K 5% QW fi
{| R719 1-202-842-11 SOLID 220K 1/2W X001 1-567-686-11 OSCILLATOR, CERAMIC |} R720 ~— 1-202-719-00 SOLID 1M 10% 1/2Ww
X301 1-567-504-11 OSCILLATOR, CRYSTAL | | R721 1-216-341-11 METAL OXIDE 0.22 5% 1W F
YC MODULE | R722 1-202-848-00 SOLID 680K 1/2W ica | R723 1-202-838-00 SOLID 100K 10% 1/2W
YCM301 1-235-753-11 YC MODULE | R724 1-247-849-00 CARBON 5.6K 5% 1/6W 7 { R731 1-249-405-11 CARBON 100 5% 1/6W
Pete eee cee reece ce eee eee ce eee eececreCerTCerTecoSeOCoCCoLCesCoCLCeeorcoo gr. cr 2 |
| R732 1-249-405-11 CARBON 100 5% 1/6W *A-1330-628-A C BOARD, COMPLETE | R733 1-249-405-11 CARBON 100 5% 1/6W
kkk KKK KKK KK KKK |
| VARIABLE RESISTOR 1-526-819-11 SOCKET, CRT |
*4~374-912-01 COVER (MAIN), CV VOL | RV701 1-228-723-00 RES, ADJ, CERAMIC CARBON 4.7K *4~374-913-01 COVER (REAR LID), CV VOL { RV702 1-228-722-00 RES, ADJ, CERAMIC CARBON 3.3K
| | RV703 1-228-723-00 RES, ADJ, CERAMIC CARBON 4.7K CONNECTOR | RV704 1-228-722-00 RES, ADJ, CERAMIC CARBON 3.3K
{| RV705 1-228-723-00 RES, ADJ, CERAMIC CARBON 4.7K Cl *1-506-371-00 2P PLUG (L) | C2 *1-508-786-00 2P PLUG (M) - | RV706 1-230-641-11 RES, ADJ, METAL GLAZE 2.2M C3 *1-560-126-00 PLUG, CONNECTOR (2.5MM) 6P | RV707 1-230-641-11 RES, ADJ, METAL GLAZE 2.2M C4 *1-508-765-00 3P PLUG (M) | RV7084\. 1-230-798-11 RES, ADJ, METAL GLAZE 90M
| RV709 1-228-725-00 RES, ADJ, CERAMIC CARBON 22K CAPACITOR |
{ kkkkhkkkkkkkkkkkk kk kkk kkk hk kh hh thre
C702 = 1-102-112-00 CERAMIC 330PF . 10% 50V | C703 1-102-109-00 CERAMIC 180PF 10% 50V { *1-623-023-11 H BOARD C704 1-102-110-00 CERAMIC 220PF 10% 50V | WERKE C705 1-162-116-00 CERAMIC 680PF 10% 2KV { C706 1-129-714-00 FILM 0.01MF 10% 630V | OIODE
. COIL {| 0901 8-719-919-03 DIODE GL-9P03D
704 1-410-485-21 MICRO INDUCTOR 180UH . aati aeer ere tears nee | |
TRANSISTOR | MISCELLANEOUS | KRKKKKKKKKKKKK
Q701 8-729-168-82 TRANSISTOR 2SC2688 | A te ak Q702 8-729-168-82 TRANSISTOR 2SC2688 | Ay 1-451-249-31 DEFLECTION YOKE (SY-1258) Q703 8-729-168-82 TRANSISTOR 2SC2688 | 1-452-032-00 MAGNET, DISK; 10MM ¢
| 1-452-094-00 MAGNET, ROTATABLE DISK; 15MM 9 RESISTOR | 1-452-277-00 MAGNET, BMC
| SP9O1 1-503-344-21 SPEAKER R701 = 1-249-425-11 CARBON 4.7K 5% 1/6W | R703 1-249-411-11 . CARBON 330 5% 1/6W { Ah. 1-534-777-31 CORD, POWER SUPPLY R704 1-249-423-11 CARBON 3.3K 5% 1/6W [ A. 1-536-683-21. CONNECTOR, COAXIAL ANTENN R705 1-202-824-00 SOLID 3.3K 1/2w | *1-555-111-71 CABLE, PIN R706 1-216-463-00 METAL OXIDE 12K 5% eW F |
| L901 &.1-426-145-13 COIL, DEGAUSSING R707 = 1-249-422-11 CARBON 2.7K 5% 1/6W { $901 A.1-554-967-12 SWITCH, PUSH (AC POWER) (1K EY) R708 1-249-414-11 CARBON 560 5% 1/6W | v901 A. 8-735-553-05 PICTURE TUBE (A34JBU10X) R709 =: 1-249-414-11 CARBON 560. . 5% 1/6W |
R710 =: 1-249-423-11 CARBON 3.3K 5% 1/6W |
augnnupnaenuanes tance coca htasenaetes = The Ore cents Be
: by shading andmark Aare : Be : critical for sifety. = ! Replace only with part 3
ae eet specifid - se ee
ee Ses DS eS eeieeieesnens
ae
a
i ety
‘ ma) Aaa
cc WV-140ZUb i RM-655 |
ACCESSORIES AND PACKING MATERIALS khikkkkkkkkkkkkkhkkkhhhhhkhkh hha
come eebb gt Eh
Part No. =~ Description Remark
A-1470-794-A COMMANDER ASSY (RM-655) 1-501-385-11 ANTENNA, ROOP 1-513-382-00 ANTENNA MUTCHING
*4~374-990-01 CUSHION (UPPER) (ASSY) *4-374-991-01 CUSHION (LOWER) (ASSY)
*4~378-262-01 BAG, PROTECTION *4-385-039-01 INDIVIDUAL CARTON 4-482-396-41 MANUAL, INSTRUCTION
goop the preseettts ig pn
For Service Manuals Contact MAURITRON TECHNICAL SERVICES
8 Cherry Tree Rd, Chinnor ( Oxon OX9 4QY- T . |
Tel:- 01844-351694 Fax:- 01844-352554 Email:- [email protected]
Sony Corporation Ereglish TV Group | S00y069 04.2
9-963-832-01 — 28 - | | Printedin Japan © 1987.5