improved silk reeling
DESCRIPTION
sericultureTRANSCRIPT
Silk Reeling - Improved
It's been over a year since I posted the original set of reeling pictures, and I've learned alot. This is how I reel silk these days. It's based on information I've gotten from a variety ofsources, mostly old books. There is virtually no good modern literature explaining how to
process silk by hand - a condition I'm trying to remedy.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
1 of 19 8/3/2013 6:15 PM
I start out by soaking the cocoons for a few minutes. This helps make it easier to grope theends, by slightly softening the gum on the cocoons. I start by filling the jar with the
cocoons, then with very hot tap water. After five or so minutes, I pour out the water andreplace it with very cold tap water. If you try this at home, make very sure to use a
tempered Mason jar; thinner jars can't handle the temperature shock. I use a narrow-mouthjar because it helps keep the cocoons down.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
2 of 19 8/3/2013 6:15 PM
After the cocoons are soaked, I pour them into a kettle of water just removed from theboil. You can't see it in the pictures, but there's a little single burner under the kettle. I
have put a sieve on top of the cocoons to keep them under the hot water; it's helpful butnot necessary. The cocoons will fizz and sizzle vigorously; the air inside is being expelled
as they heat up, and the gum is softening.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
3 of 19 8/3/2013 6:15 PM
After the cocoons have stopped sizzling, it's time to start groping them for ends. I do thiswith a dish brush. The traditional version looks like a tiny whisk broom, or a wok broom;they are usually made of rice stems or twigs. You can see that the cocoons are floating lowin the water now - they've drawn in some water, so that they're about a third full. It makesthem much easier to reel. I poke at the cocoons with the end of the brush, and also make astirring motion around the surface of the water with it, which picks up the filaments from
the cocoons.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
4 of 19 8/3/2013 6:15 PM
This is what you catch with the brush. You get several cocoons with each swipe, and startpulling the ends from them. As you pull off all the ends together, you will find that they
start separating out - some cocoons will drop off, others are clearly connected to thestrands in your hand. The strands pulled off during the process will wrap around your
hands, cling to your clothes, and get on your nerves. Snap the bundle of strands often, andwipe it off your hands and brush. The silk waste produced by this process is called
"knupps", and is used for making silk to spin.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
5 of 19 8/3/2013 6:15 PM
Here, you can see the threads attached to the cocoons. You can find which ones areattached, by dragging them from one side of the kettle to the other, and by watching to seewhich ones bob around. If you want to see the threads, look in the dark areas right above
the bunch of cocoons, against the side of the kettle. Each cocoon's filament is about 2 to 3denier; a denier is one gram per nine kilometers, or about four and a half million yards per
pound. Needless to say, they're very thin.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
6 of 19 8/3/2013 6:15 PM
I use a slotted spoon to raise the connected cocoons and transfer them to another bowl,with the ends draped over one side so you can find them. Repeat this step until all the
cocoons are in the second bowl. I drape a piece of damp paper towel over the side of thebowl, so that I can stick the filaments to it. They're very fine, and easy to lose track of. Fillthe bowl from the front to the back, so that when you pick up a cocoon from the back, its
filament won't be under the ones in front of it.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
7 of 19 8/3/2013 6:15 PM
Now, it's time to set up for the reeling. I arrange about fifteen cocoons together to make thereeling strand. Here, I'm showing the method for picking up the cocoons. This assumes thatyou're winding the reel right-handed; if you're using the opposite side, then reverse these.
Traditional Japanese reels use the left hand to crank the reel and the right hand to feed thecocoons; I like to crank with my right hand because that arm gets fatigued less easily.
There's a certain amount of "Emperor's New Clothes" involved in this - you honestly can'tsee the filament a lot of the time. I'll hold up my hands like I've got thread in them, andyou pretend you can see it, OK? A lot of this process is done by feel. Seriously, though,
you can barely see the filament coming off the cocoon; it goes diagonally down and to theleft from the middle of my thumbnail.
The following few pictures will show how to drop the cocoon while holding on to thethread. It's something I've worked out based on text and illustrations in a couple of old
books; use whatever works for you.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
8 of 19 8/3/2013 6:15 PM
Here, I've wrapped my fingers around the thread. Yes, I know it's invisible. Trust me, it'sthere. You can see just a little bit, below the pinky finger. The best way I can explain, isthat you just make the motion, knowing where the thread goes - you'll realize when you
drop it, if you've got one that doesn't have the end attached. You can go through themotion with a spool of thread, if it helps you visualize it.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
9 of 19 8/3/2013 6:15 PM
With the cocoon thread captured safely in my last three fingers, and the cocoon heldloosely with forefinger and thumb, I flip the hand over, and drop the cocoon into the
reeling water. When I turn the thumb side upward, the filament is on the tip of my indexfinger.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
10 of 19 8/3/2013 6:15 PM
This is what it looks like when I've dropped the cocoon, and I have the filament on myfinger. Emperor's Clothes, hey?
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
11 of 19 8/3/2013 6:15 PM
This is a close-up of the same view. Notice where you can see the filament crossing in frontof the cocoon at the center bottom, and if your monitor resolution is good you can see the
filament between my fingertip and thumb.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
12 of 19 8/3/2013 6:15 PM
Here, I've got the filament on my finger, and I'm going to attach it to the reeling thread. Ipush the back of my fingertip against the reeling filament, and it just grabs the thread andjoins it on. Don't let go with the thumb and other fingers; this will snap off the end neatly,
leaving no visible mark where the thread is cast on. Once you get used to it, and if youhave a good reel, you can cast on cocoons without ever slowing the reel.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
13 of 19 8/3/2013 6:15 PM
This is what I'm reeling with these days. It's a custom design by Bill Wyatt, based on anantique Japanese silk reel called a Zakuri. The bobbin is accelerated by a series of pulleysand belts, and the arm in front rocks back and forth, so that the wet silk is not piled on topof more wet silk. It makes a HUGE improvement in the process over reeling onto the clockreel, because the rocker arm takes the place of my left hand, so I don't have to stop reeling
to feed cocoons.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
14 of 19 8/3/2013 6:15 PM
This is the antique Japanese version. The uprights are made of a soft wood, similar to pine,and the gears are carved from a hard wood called Zelkova. The bobbin is called an
itomaki, and fits on a removable spindle so that it can be exchanged for a fresh one. Clickhere for a page on the Zakuri, including specific and careful measurements.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
15 of 19 8/3/2013 6:15 PM
This is a major innovation in my silk reeling process, almost as significant as the improvedreel. This is called a Tavalette, or Italian, croissure. Croissure means "crossing" in French -
the filament is passed through a series of guides and pulleys such that it twists togetherwith itself, thus squeezing out much of the water and agglutinating (gluing together) thefilaments with sericin. The reeling pot is just out of the frame at the bottom right. The
filament goes up, through a guide, over the top pulley, around the bottom pulley, throughthe croissure, and then through the upper guide eye to the reel. Croissure makes a much
better quality of silk, because it is less likely to abrade or shred during processing. There isanother type of croissure called Chambon, or French; it requires a double reel and doublecocoon setup, and one thread from each side is taken into the twist and then they separateto wind on to the reels. Note: the pulleys are laundry-line pulleys, they were around $3.50
each at the hardware store. They are mounted on my ever-present chemistry ring stands,but a dowel inserted into a wood block would work just fine.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
16 of 19 8/3/2013 6:15 PM
This shows the actual croissure. The filament at the top right is not any thicker than theothers, the flash is just catching it. I use about thirty twists; I find that if I use too manymore than that, it snaps the filament too easily. Croissure drags on the silk slightly, so if
there is a slub or weak spot, it will break the filament. If the filament breaks, you have topiece up.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
17 of 19 8/3/2013 6:15 PM
This is how you piece up the raw silk filament. It's in the center there - it's an overhandknot with both strands, trimmed close. The ends need to be just a few millimeters long, or
they'll snag later on. In the grading of raw silk, knots over 3mm are considered a minorflaw; over 7mm they are considered a major flaw. With the ends trimmed to 2mm, they are
not considered a flaw unless there are excessive numbers of knots.
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
18 of 19 8/3/2013 6:15 PM
This is a spool of raw silk. With the improved setup, I can make an ounce of raw silk(about 250 cocoons) in an evening's reeling. The bright spot is a dime for scale - the flash
caught it.
Home
Improved Silk Reeling http://www.wormspit.com/newreeling.htm
19 of 19 8/3/2013 6:15 PM