FEATURES

62 SAE net hp (46.2 kW)

Entire loader assembly can be quicklydetached and remounted

Low center of gravity (Turf Loader)

Adjustable front and rear tread

8-speed transmission w/hydraulic directionreverser

Self-adjusting wet-disk brakes

Inboard planetary final drives

Foot-operated differential lock

Power steering

Roll-over protective structure (ROPS)

ADD VERSATILITY WITH:

Mowers

Landscape tools

ENGINE PERFORMANCE

LOADER SPECIFICATIONS

Nominal HeapedBuckets: Capacity

3f4cu. yd. (0.57 m3)

Operating Information:Breakout force 4000 lb. (17.92 kN) (1815 kg)Lifting capacity, full height. . . . . 2500 lb. (1134 kg)Raising time to full height 5.1 sec.Bucket dump time 2.9sec.Lowering time (power) 3.0sec.Rollbacktime 2.6sec.Float-downtime 6.1sec.Minimum recommended rear

ballast 2000Ib.(910kg)

Width

73.8 in. (1.58 m)

I

401 B UTILITY LOADER

/--(,}/ 1

/- ~~:~]~:~,- ,,::.~.-yQ'--<"y'/ ~

/'O-;~:~~~~: :~:' . \1 ' 0'

, ',-I1 ,'I

1 1'11 1'1

c;[)"E'-:0:>.0

':::c<io~L2 ft. 8 in.

I (815 mm)c~

~E'co

0:>",~N

.S"E t--~(\I co~'"':t--~

79.4 in.(2.02 m)

15ft.11 in. (4.85m)11 in.

(280 mm)

43

Nm Ib-ft

160 l I -LI I I!!j217 TORQUE

203 1500t- 190 _140 u:Jtu 176 130 hp kWz

HORSEPOWER -70 5260 45 '::.

50 37 ffi

Ibl .40 30

g/kWh hph 30 22 fu(fJ

-' .274 0.45. cc0

!!j 243 0.40 I

LL 213t-

0.35 FUELCONSUMPTION wz

1100 1500 1900 2300

ENGINE SPEED-RPM

4018 UTILITY LOADER SPECIFICATIONS

(Specifications and design subject to change without notice. Wherever applicable, specifications are In accordance with ICED and SAE Standards. Except where otherwise noted, thesespecifications are based on a unit equipped with 14.9-24, 6-ply-rating rear tires; 7.50/8.00-16, 6-ply-rating front tires; 3/4cu. yd. (0.57 m3) bucket; full fuel tank, 175-lb. (79 kg) operator andstandard equipment)

Power (@ 2500 engine rpm): SAE DINGross..., 66hp(49.2kW)Net 62hp(46.2kW) 65.9hp(48kW)Net engine flywheel power is for an engine equipped with fan, air cleaner, water pump,lubricating oil pump, fuel pump, alternator, and muffler. Gross engine power is without fan.Flywheel power ratings are under SAE standard conditions of 500-ft. (150 m) altitude and85°F (29SC) temperature and DIN 70 020 standard conditions of 760 mm Hg barometer(sea level) and 20°C. temperature.

Engine: John Deere 4-cylinderdiesel, valve-in-head,4-stroke cycleBore and stroke " " ,,4.02x4,33in.(102x110mm)

Piston displacement , , ,.. 219cu.in.(3,589L)Compression ratio ., , , , ,..16.2t01Maximum torque.@ 1300 rpm 160 Ib-ft (217 Nm) (22.1 kg-m)NACC or AMA (U.S. Tax) horsepower. . . . , , . . . . . . . , . . . .. 25,65Mainbearings " ,5Lubrication. . . . . . . . . . . . . . . . , .. Pressure system w/lull-IlowIiIterCooling. . . . . . . . . . . .. Pressurized w/thermostat and Iixed bypassFan " " " , , , SuctionAircleaner ..", , " " " ". DryElectrical system. . .. . .. . . . . . . . . . . . . . . . . ,. 12-volt w/alternatorBattery (12 volt) 72 amps.. , . . . .. Reserve capacity: 110 minutesAlternator " , " " " 35amps

Engine Clutch:Collarshifttransmission.., ,... Foot-operated,

single 11 in. (279 mm) plateHydraulic direction reverser. . . . . . . . . . . . . . . . . . . . . . Foot-operated,

single 10 in. (254 mm) plate

Transmission:Constant mesh, 8 forward speeds, 4-reverse with helical gears andsliding collars; mechanical shuttle. Optional hydraulic direction re-verser provides 8 speeds forward and 8 reverse: hydraulic wetclutches, no clutching required.

FinaIDrives ,.. .Inboard, planetary

Brakes. . . . . . . . . . . Hydraulically actuated, fully enclosed wet-disk.Sell-equalizing. Foot-operated individually or simultaneously

Steering , powerTurning radius (brake applied) . . . . . . . . . . . . . . . . 10 It. 7 in. (3.23 m)Loader clearance circle, dia. (brake applied) ..35 It. 6 in. (10.85 m)Numberolturns,larlefttolarright. , 3.3

Hydraulic System: Closed-centerMax. pressure. . . . .. . . . . . . . 2350 psi (16203 kPa) (165.2 kg/cm2)Loader control 2-leverPump. . . . . . . . . . . . . . . . . . . . . . . Piston, constant pressure, variable-displacement, 13 gpm (0.8 LIs) at 2500 engine rpm

Hydraulic Cylinders: Bore StrokeBoom 2.25in,(57mm) 33,28 in. (845mm)Bucket. . . . . . . . . . . . . .2.25 in. (57 mm) 24.36 in. (624 mm)Cylinder rods. . . . . . Ground, heat-treated, chrome-plated, polishedBoomcylinderrods ,... , 1.5in. (38mm)dia.Bucketcylinderrods .1.25in. (32 mm) dia.

Tires: FrontTurf 27-9.50-15,10-ply-rating,

11Terra-tires

Rear21.5L-16.1, 6 PR, R3

14.9-24, 6-ply-rating, R414.9-24, 6-ply-rating, R116.9-24, 6-ply-rating, R317.5L-24, 8-ply-rating, R4

FrontAxle Swept-back, adjustable

Utility 11L-15, 8-ply-rating, F37.50/8.00-16, 6-ply-rating F3

Wheel Treads (dependent on tires and front axle):Front 49t074in.(1.25t01.88m)Rear 48t076in.(1.22t01.93m)

Dimensions:Height to top 01hood 41t. 7in.(1.40m)Overall height to top 01muffler. . . . . . . . . . . . . . . . . 6 ft. 7 in. (2.01 m)Overall height to top 01canopy. . . . . . . . . . . . . . . . 7 ft. 2 in. (2.18 m)Overall width w/60-in. treadwidth. . . . . . . . . . . . . . 6 ft. 3 in. (1.90m)Overalilength 15ft.11in.(4.85m)Overalilengthw/3-pointhitch 171t.(5.18m)Wheelbase 79.4 in. (2.02m)Ground clearance (under front axle) . . . . . . . . . . . 1 It. 5 in. (430 mm)Ground clearance, min. 11in.(279mm)

Capacities: U.S.Coolingsystem 3gal.Fueltank ...< 19.5gal.EngineAubrication, including Ii Iter 6 qt.Transmission and hydraulic system. . . . . . . . . . . 10 gal.

Additional Standard Equipment:Oil pressure indicator lightAlternator charge indicator lightWater temperature gaugeKey switch safety startCushioned seatVertical muffler w/rain capTransistorized voltage regulatorFendersAntilreezeTwo-position disk rear wheels3f4-yard loader bucketAir-cleaner-restriction indicatorEther starting aidRear PTO (continuous "live" or

independent 540 rpm)Speed-hourmeterHorn

Liters11.473.85.7

37.9

SAEOperatlngWeight 6280 lb. (2850 kg)

Special EquipmentCigaret lighterDeluxe seatDifferential lockFixed front axleFoot throttleFront grille guardFuel gaugeTwo 12-volt batteries, 72 amps each,

reserve capacity: 220 minutes

Hydraulic direction reverserLightsMid PTO (1000 rpm "live," w/rear PTO)Muffler extension (vertical muffler)Parking brakeRear mufflerRemote hydraulic cylinderROPS and seat belt wi or w/o canopy

Single or dual remote-cylinder controlw/quick-connect couplers

Swinging drawbar3-inch seat belt3-point hitch (Category 1 or 2 w/sway

blocks and regular or short links)Toolbox

44

1

Gear: Travel Speedsmph km/h

Fwd. Rev. Fwd. Rev.1 1.3 1.6 2.1 2.62 1.9 2.2 3.1 3.53 2.9 3.3 4.7 5.34 4.0 4.7 6.4 7.65 5.3 6.3 8.5 10.16 7.6 9.0 12.2 14.57 11.2 13.5 18.0 21.78 15.7 18.7 25.3 30.1