hydration unit - dragonproductsltd.com

HYDRATIONUNIT • 4/15 [email protected] • www.dragonproductsltd.com • 866-914-8198 U.S. owned and operated for over 50 years. © Copyright 2014 Modern Group Inc. All rights reserved. Hydration Unit Made in the USA! The Dragon Hydration Unit is capable of transporting and transferring chemicals for oilfield stimulation applications. The unit comes complete with all necessary components and connections. All equipment is positioned and installed for ease of maintenance and repairs. • Maximum working Fluid Rate: 100 BPM TRAILER: • Heavy duty drop tandem axle trailer • Landing legs • ABS Brakes with indicator light • 2” SAE King pin • Front and rear steel fenders with flaps • Steel wheels w/11R22.5 tires • 25,000 lb rated tandem axles ENGINE: • Detroit 60 Series 600BHP • DDEC Engine controls • 24 VDC alternator • Shut down system for low oil pressure, water temperature and engine over speed • 24 Volt electric start • 185 USG fuel • All necessary cooling, battery, air compressor, heavy duty filters

Upload: others

Post on 18-Dec-2021

4 views

Category:

Documents

0 download

Report

Download

Embed Size (px):

TRANSCRIPT

HYDRATIONUNIT • 4/15

Hydration Unit

Made in the USA!

The Dragon Hydration Unit is capable of transporting and transferring chemicals for oilfield stimulation applications. The unit comes complete with all necessary components and connections. All equipment is positioned and installed for ease of maintenance and repairs.

• Maximum working Fluid Rate: 100 BPM

TRAILER:• Heavy duty drop tandem axle trailer• Landing legs• ABS Brakes with indicator light• 2” SAE King pin• Front and rear steel fenders with flaps• Steel wheels w/11R22.5 tires• 25,000 lb rated tandem axles

ENGINE:• Detroit 60 Series 600BHP• DDEC Engine controls• 24 VDC alternator• Shut down system for low oil pressure, water temperature

and engine over speed• 24 Volt electric start• 185 USG fuel• All necessary cooling, battery, air compressor,

heavy duty filters

Hydration Unit

HYDRATION TANK: • Tank, 200 BBL nominal capacity• Open top two compartment • Level markers Walk ways and handrails• Boost Centrifugal Pumps• (2) 12 x 12 Gorman Rupp centrifugal pump hydraulic

driven capable of 100 BBL/min

HYDRAULIC PUMP DRIVES: • Durst Gear pump drive• Sauer Sunstrand Pumps and motors• Sauer Danfoss PVG32 proportional valves• Continental Progressive cavity pumps• Endress=Hauser mass flow measuring system• Brookfield Viscometer• Hydraulic cooling fans

MANIFOLD: • Drivers side manifold (Suction)• (2x) 10 inch Victolic Union, one on opposite ends of the

manifold• (12) 4 inch Fig 206 male unions with manual butterfly

valves• Passenger Side manifold ( Discharge)• (12) 4 inch Fig 206 female unions with manual butterfly

valves• Hydration Tank bypass• Hydration tank recirculation line• Valved external connections• Hydration cut off valve

HYDRATION - ortho.wustl.edu

HYDRATION - sportireland.ie · 2 COACHING IRELAND THE LUCOZADE SPORT EDUCATION PROGRAMME HYDRATION HYDRATION: YOU ARE WHAT YOU DRINK Adequate hydration is essential for good health

10 hydration facts

Cement Hydration

HYDRATION UNIT

320BBL Premix Mud System - dragonproductsltd.com

2 Cement Hydration

HYDRATION AND MICROSTRUCTURE OF BLENDED CEMENT WITH … · HYDRATION AND MICROSTRUCTURE OF BLENDED CEMENT ... the hydration of the blended cements with and ... Hydration and microstructure