home air conditioner yelp furnace air conditioner repair, air ... -...
TRANSCRIPT
Product Data
PG8MAA/PG8JAAMULTIPOISE GAS FURNACE
SERIES E
A10257
The Payne PG8MAA/JAA 80% AFUE Gas Furnaces feature4--way Multipoise design and through--the--furnace downflowventing. The PG8MAA/JAA furnaces are approved for use withnatural or propane gas, and the PG8JAA is approved for use inLow NOx Air Quality Management Districts.
STANDARD FEATURESS Four-position furnace: Upflow, Horizontal Right, Horizontal
Left, Downflow
S Electronic control centerAdjustable heating air temperature rise, LED diagnostics and selftest feature. Stores fault codes during power outages.
S Hot surface ignition (HSI)
S Certified to leak 2 percent or less of its nominal air
conditioning CFM delivered when pressurized to 1--In.
Water Gauge with all present air inlets, air outlets, and
condensate drain port(s) sealed.
DES I GN
C E R T I F I E
D
Always Ask For
Use of the AHRI Certified TM Mark indicates amanufacturer’s participation in the program. Forverification of certification for individual products,go to www.ahridirectory.org.
2
AA
B
[736.9][736.9]2929
Ø7/8Ø7/8[22.2][22.2]
ACCESSORYACCESSORY
5 15/165 15/16[150.7][150.7]
28.3928.39[721.2][721.2]
Ø7/8Ø7/8[22.2][22.2]
ACCESSORYACCESSORY
14 7/814 7/8[337.3][337.3]
(BOTH SIDES)(BOTH SIDES)Ø7/8Ø7/8[22.2][22.2]ACCESSORYACCESSORY
Ø7/8Ø7/8[22.2][22.2]
ACCESSORYACCESSORY
Ø1 3/4Ø1 3/4[44.5][44.5]GAS ENTRYGAS ENTRY
Ø1/2Ø1/2[12.7][12.7]THERMOSTAT WIRE ENTRYTHERMOSTAT WIRE ENTRY
22 1/1622 1/16[560][560]
SIDE INLETSIDE INLET(BOTH SIDES)(BOTH SIDES)
11 7/1611 7/16[290.7][290.7]
9 11/169 11/16[245.4][245.4][197.8][197.8]
7 13/167 13/16
Ø7/8Ø7/8[22.2][22.2]
J.BOX PROVISIONJ.BOX PROVISION
Ø7/8Ø7/8[22.2][22.2]JUNCTION BOXJUNCTION BOXLOCATIONLOCATION
Ø1 3/4Ø1 3/4[44.5][44.5]GAS ENTRYGAS ENTRY
1 15/161 15/16[49.2][49.2]
1[25.4][25.4]
1 1/41 1/4[31.8][31.8]
29 9/1629 9/16[750.7][750.7]
1 15/161 15/16[49.2][49.2]
5 5/85 5/8[143.3][143.3]
5 7/165 7/16[138.5][138.5]
6 13/166 13/16[172.3][172.3]
Ø1/2Ø1/2[12.7][12.7]
THERMOSTAT WIRE ENTRYTHERMOSTAT WIRE ENTRY
1919[481.7][481.7]
OUTLETOUTLET
D21.621.6[549.5][549.5]
BOTTOM INLETBOTTOM INLET
C
33 1/433 1/4[843.9][843.9]
9 9/169 9/16[243.3][243.3]
3/43/4[19.1][19.1]
5 7/85 7/8[148.5][148.5]
3 7/163 7/16[86.8][86.8]
9 7/89 7/8[250.7][250.7]
27 3/427 3/4[704.7][704.7]
2 5/162 5/16[59][59]
FRO
NT
OF
CASI
NG
FRO
NT
OF
CASI
NG
TOP OF CASINGTOP OF CASING4 13/164 13/16[122.2][122.2]
27 3/427 3/4[704.7][704.7]
5 7/85 7/8[148.5][148.5]
8 5/88 5/8[219][219]
5 1/25 1/2[140.3][140.3]
8 7/168 7/16[213.5][213.5]
FRO
NT
OF
CASI
NG
FRO
NT
OF
CASI
NG
TOP OF CASINGTOP OF CASING
6.16.1[155.7][155.7]
2 1/162 1/16[51.6][51.6]
5.15.1[130.5][130.5]
1.71.7[43.5][43.5]
Ø7/8Ø7/8[22.2][22.2]ACCESSORY (2)ACCESSORY (2)
AIR FLOWAIR FLOW
AIR FLOWAIR FLOW
BOTTOM RETURNBOTTOM RETURNWIDTHWIDTH
AIR FLOWAIR FLOW
KNOCK OUTS FORKNOCK OUTS FORVENTING(5 VENTING(5 PLACES)PLACES)
A10290
NOTES:1. Two additional 7/8---in. (22 mm) diameter holes are located in the top plate.2. Minimum return ---air openings at furnace, based on metal duct. If flex duct is used, see flex duct manufacturer’s recommendations for equivalent diameters.
a. For 800 CFM---16---in. (406 mm) round or 14 1/2 x 12---in. (368 x 305 mm) rectangle.b. For 1200 CFM---20---in. (508 mm) round or 14 1/2 x 19 1/2---in. (368 x 495 mm) rectangle.c. For 1600 CFM---22---in. (559 mm) round or 14 1/2 x 22 1/16---in. (368 x 560mm) rectangle.d. For airflow requirements above 1800 CFM, see Air Delivery table in Product Data literature for specific use of single side inlets. The use of both sideinlets, a combination of 1 side and the bottom, or the bottom only will ensure adequate return air openings for airflow requirements above 1800CFM.
FURNACE SIZE
ACABINETWIDTHIN (mm)
BOUTLETWIDTHIN (mm)
CTOP &
BOTTOM FLUECOLLARIN (mm)
DBOTTOM INLET
WIDTHIN (mm)
VENTCONNECTION
SIZEIN (mm)
SHIP WTLB (KG)
024045 14---3/16 (360) 12---9/16 (319) 9---5/16 (237) 12---11/16 (322) 4 (102) 104 (47)036045 14---3/16 (360) 12---9/16 (319) 9---5/16 (237) 12---11/16 (322) 4 (102) 107 (49)024070 14---3/16 (360) 12---9/16 (319) 9---5/16 (237) 12---11/16 (322) 4 (102) 111 (50)036070 14---3/16 (360) 12---9/16 (319) 9---5/16 (237) 12---11/16 (322) 4 (102) 115 (52)048070 17---1/2 (445) 15---7/8 (403) 11---9/16 (294) 16---1/8 (410) 4 (102) 126 (57)042090 17---1/2 (445) 15---7/8 (403) 11---9/16 (294) 16---1/8 (410) 4 (102) 127 (58)048090 21 (533) 19---3/8 (492) 13---5/16 (338) 19---1/2 (495) 4 (102) 140 (64)060090 21 (533) 19---3/8 (492) 13---5/16 (338) 19---1/2 (495) 4 (102) 146 (66)036110 17---1/2 (445) 15---7/8 (403) 11---9/16 (294) 16---1/8 (410) 4 (102) 135 (61)048110 21 (533) 19---3/8 (492) 13---5/16 (338) 19---1/2 (495) 4 (102) 146 (66)066110 21 (533) 19---3/8 (492) 13---5/16 (338) 19---1/2 (495) 4 (102) 152 (69)048135 21 (533) 19---3/8 (492) 13---5/16 (338) 19---1/2 (495) 4 (102)* 149 (68)066135 24---1/2 (622) 22---7/8 (581) 15---1/16 (383) 23 (584) 4 (102)* 163 (74)060155 24---1/2 (622) 22---7/8 (581) 15---1/16 (383) 23 (584) 4 (102)8 170 (77)
*135 and 155 size furnaces require a 5 or 6---in. (127 or 152 mm) vent. Use a vent adapter between furnace and vent stack. See Installation Instructions forcomplete installation requirements.
PG8MAA/JAA
3
A10269
PG8MAA/JAA
4
SPECIFICATIONS
UNIT SIZE 024045 036045 024070 036070 048070 042090 048090
RATINGS AND PERFORMANCE
Input Btuh*Non---weatherized ICS
PG8JAA Upflow; all PG8MAA 44,000 44,000 66,000 66,000 66,000 88,000 88,000
PG8JAA Downflow/Horizontal 42,000 42,000 63,000 63,000 63,000 84,000 84,000
Output Capacity(Btuh)†Non---weatherized ICS
PG8JAA Upflow; all PG8MAA 35,000 36,000 53,000 54,000 53,000 71,000 71,000
PG8JAA Downflow/Horizontal 34,000 34,000 51,000 51,000 51,000 68,000 68,000
AFUE† 80.0 80.0 80.0 80.0 80.0 80.0 80.0
Certified Temperature Rise Range ° F (° C) 30-60(17---33)
20-50(11---28)
40-70(22---39)
30-60(17---33)
25-55(14---30)
40-70(22---39)
30-60(17---33)
Certified External Static Pressure Heat/Cool 0.10/0.50 0.10/0.50 0.12/0.50 0.12/0.50 0.12/0.50 0.15/0.50 0.15/0.50
Airflow CFM‡Heating 920 1250 720 1195 1450 1375 1505
Cooling 845 1160 900 1200 1530 1385 1720
ELECTRICAL
Unit Volts---Hertz---Phase 115-60-1
Operating Voltage Range Min-Max 104-127
Maximum Unit Amps 5.6 7.0 5.0 6.7 9.4 8.1 9.8
Maximum Wire Length (Measure 1 Way in Ft (M)) 47 (14.3) 39 (11.8) 52 (15.8) 40 (12.1) 29 (8.8) 34 (10.3) 28 (8.5)
Minimum Wire Size 14
Maximum Fuse or Ckt Bkr Size (Amps)** 15
Transformer (24v) 40va
External Control Heating 12va
Power Available Cooling 35va
Air Conditioning Blower Relay Standard
CONTROLS
Limit Control SPST
Heating Blower Control Solid-State Time Operation
Burners (Monoport) 2 2 3 3 3 4 4
Gas Connection Size 1/2-in. NPT
GAS CONTROLS
Gas Valve (Redundant) White-Rodgers
Min. inlet pressure (In. W.C.) 4.5 (Natural Gas)
Max. inlet pressure (In. W.C.) 13.6 (Natural Gas)
Ignition Device Hot Surface
BLOWER DATA
Direct-Drive Motor HP (PSC) 1/5 1/3 1/5 1/3 1/2 1/3 1/2
Motor Full Load Amps 2.9 5.2 2.9 5.2 7.9 5.2 7.9
RPM (Nominal)-Speeds 1075-3 1075-3 1075-3 1075-3 1075-3 1075-3 1075-3
Blower Wheel Diameter x Width --- In. (mm) 10 x 6(254 x152)
10 x 6(254 x152)
10 x 6(254 x152)
10 x 6(254 x152)
11 x 8(279 x203)
10 x 8(254 x203)
10 x 10(254 x254)
FILTER ARRANGEMENT External filter rack required
* Gas input ratings are certified for elevations to 2000 ft. (610 M). For elevations above 2000 ft (610 M), reduce ratings 4 percent for each 1000 ft (305 M)above sea level. Refer to National Fuel Gas Code NFPA 54/ANSI Z223.1---2009 Table F.4 or furnace installation instructions.
† Capacity in accordance with U.S. Government DOE test procedures.‡ Airflow shown is for bottom only return-air supply for the as-shipped speed tap. For air delivery above 1800 CFM, see Air Delivery table for other options. A
filter is required for each return-air supply. An airflow reduction of up to 7 percent may occur when using the factory-specified 4-5/16 in. (110 mm) wide, highefficiency media filter.
** Time-delay type is recommended.ICS Isolated Combustion SystemN/A Not applicable
PG8MAA/JAA
5
SPECIFICATIONS continued
UNIT SIZE 060090 036110 048110 066110 048135 066135 060155
RATINGS AND PERFORMANCE
Input Btuh*Non---weatherized ICS
PG8JAA Upflow; all PG8MAA 88,000 110,000 110,000 110,000 132,000 132,000 154,000
PG8JAA Downflow/Horizontal 84,000 105,000 105,000 105,000 126,000 126,000 147,000
Output Capacity(Btuh)†Non---weatherized ICS
PG8JAA Upflow; all PG8MAA 71,000 89,000 89,000 89,000 107,000 107,000 125,000
PG8JAA Downflow/Horizontal 68,000 85,000 85,000 85,000 102,000 102,000 119,000
AFUE† 80.0 80.0 80.0 80.0 80.0 80.0 80.0
Certified Temperature Rise Range ° F (° C) 25-55(14---30)
50-80(28---44)
40-70(22---39)
30-60(17---33)
50-80(28---44)
40-70(22---39)
45-75(25---41)
Certified External Static Pressure Heat/Cool 0.15/0.50 0.20/0.50 0.20/0.50 0.20/0.50 0.20/0.50 0.20/0.50 0.20/0.50
Airflow CFM‡Heating 1990 1335 1515 1900 1525 1850 1790
Cooling 2025 1355 1680 2220 1710 2110 2230
ELECTRICAL
Unit Volts---Hertz---Phase 115-60-1
Operating Voltage Range Min-Max 104-127
Maximum Unit Amps 13.6 8.1 10.0 13.6 10.0 14.4 15.0
Maximum Wire Length (Measure 1 Way in Ft (M)) 32 (9.7) 34 (10.3) 28 (8.5) 32 (9.7) 28 (8.5) 30 (9.1) 29 (8.8)
Minimum Wire Size 12 14 12 14 12
Maximum Fuse or Ckt Bkr Size (Amps)** 20 15 20 15 20
Transformer (24v) 40va
External Control Heating 12va
Power Available Cooling 35va
Air Conditioning Blower Relay Standard
CONTROLS
Limit Control SPST
Heating Blower Control Solid-State Time Operation
Burners (Monoport) 4 5 5 5 6 6 7
Gas Connection Size 1/2-in. NPT
GAS CONTROLS
Gas Valve (Redundant) White-Rodgers
Min. inlet pressure (In. W.C.) 4.5 (Natural Gas)
Max. inlet pressure (In. W.C.) 13.6 (Natural Gas)
Ignition Device Hot Surface
BLOWER DATA
Direct-Drive Motor HP (PSC) 3/4 1/3 1/2 3/4 1/2 3/4 3/4
Motor Full Load Amps 11.1 5.2 7.9 11.1 7.9 11.1 11.1
RPM (Nominal)-Speeds 1075-3 1075-3 1075-3 1075-3 1075-3 1075-3 1075-3
Blower Wheel Diameter x Width --- In. (mm) 11 x 11(279 x279)
10 x 8(254 x203)
10 x 10(254 x254)
11 x 11(279 x279)
10 x 10(254 x254)
11 x 11(279 x279)
11 x 11(279 x279)
FILTER ARRANGEMENT External filter rack required
* Gas input ratings are certified for elevations to 2000 ft. (610 M). For elevations above 2000 ft (610 M), reduce ratings 4 percent for each 1000 ft (305 M)above sea level. Refer to National Fuel Gas Code NFPA 54/ANSI Z223.1---2009 Table F.4 or furnace installation instructions.
† Capacity in accordance with U.S. Government DOE test procedures.‡ Airflow shown is for bottom only return-air supply for the as-shipped speed tap. For air delivery above 1800 CFM, see Air Delivery table for other options. A
filter is required for each return-air supply. An airflow reduction of up to 7 percent may occur when using the factory-specified 4-5/16 in. (110 mm) wide, highefficiency media filter.
** Time-delay type is recommended.ICS Isolated Combustion SystemN/A Not applicable
PG8MAA/JAA
6
A02058
SEE NOTES: 1,2,4,7,8,9UPFLOW
SEE NOTES: 1,2,3,4,7,8,9UPFLOW
SEE NOTES: 1,2,4,5,7,8,9DOWNFLOW
A02059 A02061
SEE NOTES:1,2,3,4,5,7,8,9DOWNFLOW
SEE NOTES: 1,2,3,4,5,7,8,9DOWNFLOW
SEE NOTES: 1,2,4,5,6,7,8,9DOWNFLOW
A02060 A02063 A02062
Venting Notes1. For common vent, vent connector sizing and vent material: United States, latest edition of the National Fuel GasCode (NFGC), ANSI Z223.1/NFPA 54.
2. Immediately increase to 5-in. (127 mm) vent connector outside furnace casing when 5-in. (127 mm) vent connectorrequired, refer to Note 1.
3. Side outlet vent for upflow and downflow installations must use Type B vent immediately after exiting the furnace,except when accessory Downflow Vent Guard is used in downflow position.
4. Type B vent where required, refer to Note 1.5. 4--- in. (102 mm) single wall vent must be used inside furnace casing and the Downflow Vent Guard Kit.6. Accessory Downflow Vent Guard Kit required in downflow installations with bottom vent configuration.7. Chimney Adapter Kit required for exterior masonry chimney applications. Refer to Chimney Adapter Kits for sizingand complete application details.
8. Secure vent connector to furnace elbow with (2) corrosion-resistant sheet metal screws, space approximately 180°apart.
9. Secure all other single wall vent connector joints with (3) corrosion-resistant screws spaced approximately 120°apart. Secure Type B vent connectors per vent connector manufacturer’s recommendations.
PG8MAA/JAA
7
SEE NOTES: 1,2,4,5,7,8,9HORIZONTAL RIGHT
A02068
SEE NOTES: 1,2,4,5,7,8,9HORIZONTAL RIGHT
A02070
SEE NOTES: 1,2,4,7,8,9HORIZONTAL RIGHT
A02069
SEE NOTES: 1,2,4,7,8,9HORIZONTAL LEFT
A02064
SEE NOTES: 1,2,4,5,7,8,9HORIZONTAL LEFT
A02065
SEE NOTES: 1,2,4,5,7,8,9HORIZONTAL LEFT
A02066
SEE NOTES: 1,2,4,5,7,8,9HORIZONTAL LEFT
A02067
PG8MAA/JAA
8
ACCESSORIES
DESCRIPTION PART NO. 024045 036045 024070 036070 048070 042090 048090 060090 036110 048110 066110 048135 066135 060155
External Bottom Return Filter Rack
KGAFR0401B14 X X X X
KGAFR0501B17 X X X
KGAFR0601B21 X X X X X
KGAFR0701B24 X X
External Side Return Filter Rack KGAFR0801SRE X X X X X X X X X X X X X X
Unframed Filter, 3/4-in. (19 mm)
KGAWF1301UFR† X X X X X X X
KGAWF1401UFR X X X X X
KGAWF1501UFR X X
KGAWF1306UFR† X X X X X X X
KGAWF1406UFR X X X X X
KGAWF1506UFR X X
Flue Extension KGAFE0112UPH X X X X X X X X X X X X X X
Twinning Kit KGATW0601HSI X X X X X X X X X X X X X X
Combustible Floor Base KGASB0201ALL X X X X X X X X X X X X X X
Downflow Vent Guard KGBVG0101DFG X X X X X X X X X X X X X X
Vent Extension Kit KGAVE0101DNH X X X X X X X X X X X X X X
Chimney Adapter KitKGACA02014FC X X X X X X X X X X X
KGACA02015FC X X X
Natural-to-Propane Conversion Kit * KGANP4601ALL X X X X X X X X X X X X X X
Propane-to-Natural Conversion Kit KGAPN3901ALL X X X X X X X X X X X X X X
Label Kit KGALB0101KIT X X X X X X X X X X X X X X
Gas Orifice Kit (Qty 50)
KGAHA0150N42
See Installation Instructions for model, altitude, and heat value usages.
KGAHA0250N43(factory supplied)
KGAHA0350N44
KGAHA0450N45
KGAHA0550N46
KGAHA1550N47
KGAHA1650N48
KGAHA0650P54
KGAHA0750P55
KGAHA0850P56
KGAHA5750125
KGAHA5750130
* Factory authorized, field installed. Fuel conversion kits are CSA (formerly AGA/CGA) recognized.† Suitable for Side Return Filter Rack.X AccessoryS Standard
PG8MAA/JAA
9
AIR DELIVERY—CFM (With Filter)*
UNIT SIZE RETURN-AIRSUPPLY SPEED
EXTERNAL STATIC PRESSURE (In. W.C.)
0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 1.0
024045Bottomor
Side(s)
HighMed-HighMed-Low
1085920820
1035875775
975830730
915770680
845710620
770640555
675555470
565440360
390250190
195——
036045Bottomor
Side(s)
HighMed-HighMed-Low
144013601250
137513001210
130512401160
124011751100
116011151040
10701040965
975950885
870850790
730725670
560575520
024070Bottomor
Side(s)
HighMed-HighMed-Low
1030835725
1010815700
980790675
945760645
900720600
845675555
775610475
680490390
490375300
335265—
036070Bottomor
Side(s)
HighMed-HighMed-Low
142513201200
137512801175
132012401145
126512051105
120011401050
11251075990
1035995920
940905840
830790725
655620555
048070Bottomor
Side(s)
HighMed-HighMed-Low
180516301460
174015851420
167015301385
160014701325
153014051280
144513301220
136012551155
128011701080
11801080995
1075990910
042090Bottomor
Side(s)
HighMed-HighMed-Low
165015151385
160014851360
153514401320
146513801260
138513001195
128512201120
117511151025
1055990915
895830710
645600565
048090Bottomor
Side(s)
HighMed-HighMed-Low
206017901505
198517651505
191517151480
182016451440
172015601375
161014701300
149013451190
134011951045
11351010890
925820740
060090
BottomOnly
HighMed-HighMed-Low
240522252020
231021551955
222020801880
213019951805
202518951730
192017851630
179016751535
166015651420
153014201275
135012601135
Both Sidesor 1
Side & Bottom
HighMed-HighMed-Low
253022851995
245022151945
236521501900
227020751840
216519851770
206518901685
194017801600
180516601480
167015251350
150513601180
1 Side OnlyHigh
Med-HighMed-Low
247522601950
239521901910
230021101855
220020351795
209019401730
198518451650
186517351555
173016201445
158514751310
142513251150
036110Bottomor
Side(s)
HighMed-HighMed-Low
162515101360
157514701335
151514151295
144513551250
135512851180
126011851100
11651070985
990890810
785725—
———
048110Bottomor
Side(s)
HighMed-HighMed-Low
203517451530
196517101515
188016501470
179015601400
168014501310
149513401215
136512051095
12151090990
1075955830
875750670
066110
BottomOnly
HighMed-HighMed-Low
253022301920
247022051900
240021651880
232021101845
222020351795
211519501730
200018551650
186517401555
173016151460
159014851340
Both Sidesor 1
Side & Bottom
HighMed-High
—2235
—2200
24152155
23502100
22502040
21451955
20151850
18751740
17151595
15601470
1 Side OnlyHigh
Med-HighMed-Low
254021251790
249521201795
243021051790
235520601765
226520101720
217519401650
206518401585
193517301500
178516151390
165014851280
048135Bottomor
Side(s)
HighMed-HighMed-Low
209017901545
201017551525
193017051500
183516401450
171015501380
159014651315
147013601215
133512101005
1025945855
835785670
066135
BottomOnly
HighMed-HighMed-Low
248521951880
240021501850
231020901820
221520001780
211019201715
200018251635
188017201540
172515651415
153514051290
135512551160
Both Sidesor 1
Side & Bottom
HighMed-HighMed-Low
—21801880
—21451850
238520601820
230520101780
219519451715
208518651635
196017651540
182516601415
167015151290
146513251160
1 Side OnlyHigh
Med-HighMed-Low
—21351880
—20851850
224520351820
215519751780
205518951715
194017951635
182516851540
169515651415
155514451290
138512651160
060155
BottomOnly
HighMed-HighMed-Low
246521151800
243021051790
237520751770
230520301735
223019801695
211019101640
200018301570
186517251465
172515901345
154514251225
Both Sidesor 1
Side & Bottom
HighMed-HighMed-Low
—21551800
—21351790
237520951770
228520401735
220019751695
210518951640
199517901570
187016851465
173015501345
157014001225
1 Side OnlyHigh
Med-HighMed-Low
—21401800
—20951790
226020401770
218019751735
208518901695
197518101640
186517051570
174015951465
160514801345
145513251225
* A filter is required for each return-air supply. Airflow performance includes 3/4-in. (19 mm) washable filter media such as contained in factory-authorizedaccessory filter rack. To determine airflow performance without this filter, assume an additional .1 available external static pressure.
— Indicates unstable operating conditions.
PG8MAA/JAA
10
2010 Payne Heating & Cooling Systems D 7310 W. Morris St. D Indianapolis, IN 46231 Printed in U.S.A. Edition Date: 09/10
Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.
Catalog No: SS-PG8M-04Replaces: SS-PG8M-03
PG8MAA/JAA