![Page 1: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/1.jpg)
Experiment Electronics
Radiation Damages to Electronic Components
Strahlungsschädigungen an elektronischen Bauteilen
Sven LöchnerGSI Darmstadt
SD Gruppenseminar5. Mai 2011
![Page 2: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/2.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 2Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 3: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/3.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 3Experiment Electronics
Categories of Radiation EffectsCategories of Radiation Effects
There are 3 broad classes of effects that may occur on electronic devices after/during exposure to radiation:
1. Total Ionizing Dose (TID) effects2. Displacement Damage (DD) effects3. Single Event Effects (SEE)
![Page 4: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/4.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 4Experiment Electronics
Categories of Radiation EffectsCategories of Radiation Effects
TID and DD• degradation is cumulative• long term effect (maybe only
visible after some time) • uniformly affect all devices
• characterized by the maximum parametric drift (end of lifetime)
SEE• occur stochastically at any time• short time response (<ns)
• tiny part of a device is affected(position of ion strike)
• characterized by the rate of occurrence
TID • operation depends
on surface propertiese.g. MOSFET, BJT
DD• rely on conduction in
bulk semiconductorse.g. BJT, solar cells, optocouplers
SEE• rely on conduction in
bulk semiconductorspossible in MOS
and bipolar world
![Page 5: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/5.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 5Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 6: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/6.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 6Experiment Electronics
Radiation Damages Radiation Damages -- TIDTID
Total Ionising Dose (TID)Gradual effect during complete lifetime of the MOSFET and
BJT devicesReasons:
– Progressive build-up of trapped charge and defects in insulating layers (gate oxide, lateral isolation, passivation, etc.)
– is responsible for parametric degradation and functional failure• MOSFET (interface traps producing inter-bandgap states)
e.g. threshold voltage shift, increase of leakage current• BJT: e.g. current gain decrease
![Page 7: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/7.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 7Experiment Electronics
Radiation Damages Radiation Damages –– TID (MOSFET)TID (MOSFET)Threshold voltage shift
Energy band diagram of a Metal-Oxide-Semiconductor structure with a positive gate
voltage applied
Increase of the sub-threshold current in a NMOS transistor given by a
decrease in the threshold voltage and change of the sub-threshold slope
![Page 8: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/8.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 8Experiment Electronics
Radiation Damages Radiation Damages –– TID (MOSFET)TID (MOSFET)
Leakage current (parasitic channel):path between Source and Drain
prevent e.g. switch-off of the transistorchange of circuit behaviour
(operation point, ...)
![Page 9: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/9.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 9Experiment Electronics
Annealing mechanisms Annealing mechanisms –– TID (MOSFET)TID (MOSFET)
• Annealing of charge in oxide-traps may start immediately(tunneling or thermal process)
• Interface traps do not anneal at room temperature(require higher temperatures to reestablish broken bonds)
![Page 10: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/10.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 10Experiment Electronics
Radiation hardness by technology scalingRadiation hardness by technology scaling
Steps towards a radiation hard layout in CMOS:
• Tox > 10 nm:Delta Vth ~ 1/Tox²
• Tox < 10 nm:Trapped charges in the gateoxide are reduced due to tunneling
Threshold shift after irradiation of 1 Mrad as a function of the gate-oxide thickness
250nm
smaller technology process are more immune against TID
effects (self annealing)
![Page 11: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/11.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 11Experiment Electronics
Radiation hardness by design techniquesRadiation hardness by design techniques
Steps towards a radiation hard layout in CMOS:
• Prevent of nMOS leakage currents due to chip irradiation:
– Using enclosed transistors (right)instead of linear transistors (left)
• Disadvantage:– Complex model of transistor
behavior– Larger area consumption– Bigger parasitic capacitances– Small W/L ratios not possible
![Page 12: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/12.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 12Experiment Electronics
Radiation Damages Radiation Damages –– TID (BJT)TID (BJT)
Bipolar are not immune from TID (bulk semiconductor properties)• Current gain is one of the most radiation-sensitive parameter• Device-to-device / collector-to-emitter leakage can be the
dominant failure mechanism Sensitivity due to dielectric layers (passivation and isolation)• depends strongly on the device structure itself
(position of oxides with respect to the emitter/base/collector)• quality of thick oxides
![Page 13: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/13.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 13Experiment Electronics
Radiation Damages Radiation Damages –– TID (BJT)TID (BJT)
e.g. NPN deviceWith irradiation:• Base current (at a given base-emitter voltage) increases• Collector current remains unchanged
Reducing the device gain
![Page 14: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/14.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 14Experiment Electronics
Most sensitive area
Radiation Damages Radiation Damages –– TID (BJT)TID (BJT)
The base current is the sum of:1. Holes injected from the base into the emitter2. Recombination in the emitter-base depletion region3. Recombination with electrons traversing the neutral
active base
Affected by:non-radiatedionizing dosedisplacement
damage
Schematics of PNP and PNP bipolar transistors
![Page 15: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/15.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 15Experiment Electronics
Radiation Damages Radiation Damages –– TID (BJT)TID (BJT)
Problems with higher and low dose rates for (many) BJTs:• Degradation is higher at low dose
rates than at high dose rates !!!Phenomenon is known as Enhanced Low Dose Rate Sensitifity (ELDRS)
Strongly complicates the extrapolation of test results to operating conditions
In contrast: for MOS devices effects from low/high dose rates are the same
![Page 16: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/16.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 16Experiment Electronics
Radiation Damages Radiation Damages –– ELDRSELDRS
Explanation of ELDRS via space charge modles:
At high dose ratelarge amount of positive charge generatedacts as barrier for holes and hydrogen transport to the interfacereducing the degradation rate
![Page 17: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/17.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 17Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 18: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/18.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 18Experiment Electronics
Displacement DamageDisplacement Damage
Displacement damage (DD) is generated • directly by energetic particles (neutrons, protons, electrons, heavy
ions• indirectly by photons through energetic secondary electrons
DD is related to the displacemnet of atoms in the lattice of the irradiated material
Frenkel pairs
![Page 19: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/19.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 19Experiment Electronics
Displacement Damage ProcessesDisplacement Damage Processes
Low cross section of neutrons and protons with silicon atomsmajority of DD is generated by so-called Primary Knock-on Atom (PKA)
no permanent damageis created
PKA is energetic enoughto displace Secondary Knock-on Atoms (SKA)
![Page 20: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/20.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 20Experiment Electronics
Displacement Damage AnnealingDisplacement Damage Annealing
• Short term annealing processesusually less than an hour
• Long term annealing can go for years
Annealing can be enhanced by:• Temperature• Presence of free carriers•
Time scale of displacement damage formation
after neutron irradiation
![Page 21: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/21.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 21Experiment Electronics
Displacement DamageDisplacement Damage
Effects and related defects generated by displacement damage
![Page 22: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/22.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 22Experiment Electronics
Displacement Damage Displacement Damage -- SummarySummary
Effects on bipolar devices:
• CMOS technologies are largely immune to DDconduction occurs on a tiny region (close to the chip surface)
• BJTs rely on properties of bulk silicondeeply affected
gain decreases (introduction of recombination centers)
![Page 23: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/23.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 23Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 24: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/24.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 24Experiment Electronics
Radiation Damages Radiation Damages -- SEESEE
Single Event Effect (SEE)Generic term for effects that can be triggered in semiconductor
devices by the crossing of ionizing particles.Alpha radiation,Proton / Neutron radiation,Cosmic radiation orHeavy ion radiation
Distinction between two type of effects:Cause of permanent damages (so-called hard errors) Cause temporary malfunctions (so-called soft errors)
![Page 25: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/25.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 25Experiment Electronics
Radiation Damage Radiation Damage -- OverviewOverviewRadiation Damage in Microelectronic
Devices
Cumulative Effectsgradual effect during complete
lifetime of device
Single Event Effects
Ionisingtotal ionising dose
primarily depend on absorbed energy
independent of type of radiation
Non-Ionisingdisplacement
depend on energy and momentum transfer of incident particle to lattice atoms
mainly an issue in bipolar transistors or optoelectronic devices
must specified for a certain radiation type
Destructive Effects
Single Event BurnoutSingle Event Dielectric FailureSingle Event Gate Rupture Single Event Latch-upSingle Event Snapback...
Non-Destructive Effects
Single Event UpsetSingle Event TransientSingle Event Disturb...
![Page 26: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/26.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 26Experiment Electronics
Radiation Damages Radiation Damages –– SEU / SETSEU / SET
Majority of SEE cases are dedicated to soft errors:
Single Event Upset (SEU)Flip of a “bit” (e.g. FlipFlop cell, Memory cell)
Change the state of a digital circuit
Single Event Transient (SET)Short-term change in signal level in an electronic circuit (glitch)
![Page 27: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/27.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 27Experiment Electronics
Charge collectionCharge collection
Cross section of an ASIC Charge collection at the gate
![Page 28: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/28.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 28Experiment Electronics
Linear Energy Transfer (LET)Linear Energy Transfer (LET)
Minimum amount of particle energy induced to a semi-conductor device at which a SEE appears is called LETcrit
The unit of LET is typical MeV·cm²/mg (related to Si for MOS)
deQLET
Si
critcrit ⋅⋅
⋅=
ρeV6.3 d - sensitive depth of penetration
ρ - material density (Si: 2.33g/cm3)
Typical values for 0.18µm process technology:d = 0.5 ... 2µmQcrit = 30 ... 60fC
=> LETcrit between 1.5 and 12 MeV·cm²/mg
![Page 29: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/29.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 29Experiment Electronics
Triple Redundant DTriple Redundant D--FlipFlopFlipFlopDecrease of the possibility for an SEU in a D-FlipFlop cell
Triple Redundant FlipFlop logic3 standard D-FlipFlop cells1 Majority logic(1 Error detection logic)
But: SEU “hardness” depends on refresh timegood for state machine registers
bad for setup/setting registers
Possible Solution for setup registers:automatic reprogramming
self-triggered triple redundant D-FlipFlop
![Page 30: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/30.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 30Experiment Electronics
Dual Interlock Cell (DICE)Dual Interlock Cell (DICE)
DICE (Dual Interlock Cell) memory technologies are (more or less) immune against SEU flips.
Reference: T. Calin, M. Nicolaidis, R. VelazcoUpset Hardened Memory Design for Submicron CMOS TechnologyIEEE Transactions on Nuclear Science, Vol. 43, No. 6, December 1996
![Page 31: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/31.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 31Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 32: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/32.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 32Experiment Electronics
Radiation Effects in Radiation Effects in FPGAsFPGAs
Single Event EffectsSingle Event Transients (SETs)
short glitches (~100...200 ps)Single Event Upsets (SEUs)
flipped SRAM cells
>80% of all Upsets affect routing / PIP / MUX etc.LUT-Upsets <10%
Further:User-Flip-Flop UpsetsIO-Buffer UpsetsConfiguration-Interface-Upsets
![Page 33: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/33.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 33Experiment Electronics
Radiation Effects in Radiation Effects in FPGAsFPGAs
![Page 34: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/34.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 34Experiment Electronics
Radiation Effects in Radiation Effects in FPGAsFPGAs
Mitigating Radiation EffectsSpatial redundancy:
Triple Modular Redundancy (TMR) Double Modular Redundancy (DMR)
Temporal redundancy
Error DetectionParityError Correcting Codes (ECC)
Hamming distance
slides from Heiko Engel
![Page 35: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/35.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 35Experiment Electronics
Mitigating Radiation Effects (FPGA)Mitigating Radiation Effects (FPGA)
Correcting FPGA configurationAny redundancy approach will only be able to mitigate a limited number of
upsetsAim: keeping the number of upsets low
FPGA configuration scrubbingVirtex-4 FPGAs allow reconfiguration during runtime without resetting the device
Current implementation (V4-FX20)”Blind Scrubbing”, no ReadbackInitial Configuration: ~80msSingle Reconfiguration: ~60ms
Scrubbing-Frequency: ~16HzLimited by Flash memory: 8 bit data every 90 ns
Realistic future implementation16 bit every 30 ns (~12ms / ~80Hz)
slides from Heiko Engel
![Page 36: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/36.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 36Experiment Electronics
Radiation Tolerance EstimationsRadiation Tolerance Estimations
Preliminaary test resultsOnly ~1/3 of all SEUs actually affect the running designRedundancy implementation can handle at least 1 functional error per
scrubbing cycle3 SEUs per scrubbing cycle (12ms)max. SEU-Rate: 3/12ms = 250/s
Cross section for proton SEUs <5*10-13 cm²/bitSEU-Rate ~6*106 bit
max. flux ~ O(107) protons/(cm²*s)Total Ionizing Dose estimationsOfficial Xilinx results:
Family: Virtex Virtex-II Virtex-II Pro Virtex-4Structure size: 220nm 150nm 130nm 90nmTID [krad]: 100 200 250 300
slides from Heiko Engel
![Page 37: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/37.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 37Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 38: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/38.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 38Experiment Electronics
Charge Coupled Devices Charge Coupled Devices -- CCDCCD
Charge Coupled Devices (CCDs) are:• A matrix of up to several million photosensitive elements (or pixels)• Operate by converting the photo-generated charge to a voltage• Voltage is multiplexed to a small number of output amplifiers
Present available CCDs• Pixel dark current in the range of pico ampere• Charge transfer efficiencies (CTE) in excess of 0.9999995 per
pixel
![Page 39: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/39.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 39Experiment Electronics
Charge Coupled Devices Charge Coupled Devices -- CCDCCD
Basic structure• Typically an array of Si-MOS capacitors
built on a p-type epitaxial layer• Potential wells are created by applying
a voltage to one of the gate electrodes• The n-type buried channel ensures that
the potential minimum is situated ~1 µm into the silicon so that charge is kept away from the silicon-silicon dioxide interface.
• Charge is moved from one pixel to another by switching the applied voltage from one electrode phase to the next
• A charge sensitive readout amplifier provides a voltage that can be further processed
![Page 40: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/40.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 40Experiment Electronics
Radiation Effects in Radiation Effects in CCDsCCDs
Radiation Effects in CCDs:The performance of CCDs is permanently degraded by • Total ionizing dose (TID) effects
– Threshold voltage shifts on the CCD gatesDegrade output amplifier performance
• Displacement damage effects– Reduces the CTE– Increases the dark current– Produces dark current non-uniformities– Creates random telegraph noise in individual pixels.
Single Event Effects also interfere with the device operation.
![Page 41: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/41.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 41Experiment Electronics
AgendaAgenda
• Categories of Radiation Effects• Total Ionising Dose
– MOSFET– BJTs
• Displacement Damage• Single Event Effects• Radiation Effects in FPGAs• Charge Coupled Devices – CCDs• CMOS Imaging Sensors - CIS
![Page 42: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/42.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 42Experiment Electronics
CMOS Imaging Sensors CMOS Imaging Sensors -- CISCIS
Deep sub-micrometer (DSM, 250nm and beyond) CMOS processes dedicated to imaging (CIS processes) have brought important technological changes:
• Diodes dedicated to photo-detection with optimized doping profiles(enhance photo-collection)
• Introduction of shallow trench isolations (STI)• Optimized dielectric stack (improve light transmission to pixel)• Anti-reflecting coating• Micro-lenses• Color filters • ...
![Page 43: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/43.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 43Experiment Electronics
CIS Pixel Schematic CIS Pixel Schematic –– 3TPD3TPD
Typical three-transistor-active-pixel (3TPD pixel),based on a classical P-N junction
![Page 44: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/44.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 44Experiment Electronics
CIS Pixel Schematic CIS Pixel Schematic –– 4TPPD4TPPD
Four-transistor-active-pixel with in pixel charge transfer (4TPPD pixel), based on a fully depleted pinned photodiode
![Page 45: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/45.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 45Experiment Electronics
Radiation Effects in CISRadiation Effects in CIS
Radiation Effects in CIS:• Cumulative effects are the main contributor for performance
degradation.• The electrical parameters of a typical standard DSM CIS do not
change much with irradiation below ~100 krad (intrinsic radiation hardness of DSM)
• Total ionizing dose (TID) effects– Threshold voltage shifts– Increase of leakage current
more or less uniform over all pixels• Displacement damage effects
– May decrease the sensitivity for the longest wavelengths– Creating of hot pixels with very high dark values
Non-uniform increasing of dark current
![Page 46: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/46.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 46Experiment Electronics
Comparison 3TPD and 4TPPG CISComparison 3TPD and 4TPPG CIS
Comparison 3TPD and 4TPPG CIS:1. Dark current increase distribution following non-ionizing interactions will be
the same in both types of sensors2. Pre-radiation dark current is at least two orders of magnitude lower in
pinned photodiodes (4TPPG) than in 3T pixel photodiodes3. The relative dark current increase due to displacement damage will be 100
times larger in pinned photodiode based sensors (4TPPG)4. High electric field regions are more likely to exist in pinned photodiodes
(4TPPG) than in a well designed 3T pixel photodiode (especially near the transfer gate and the surface). If displacement damages occur in such regions, the resulting dark current can be significantly enhanced.
Displacement damage is expected to be a serious issue for the use of pinned photodiodes in a radiation hard environment.
![Page 47: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/47.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 47Experiment Electronics
Questions ?
![Page 48: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/48.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 48Experiment Electronics
Thank you for your attention
![Page 49: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/49.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 49Experiment Electronics
Additional Additional slidesslides......
![Page 50: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/50.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 50Experiment Electronics
GRISU projectGRISU project
Project objectives:Characterisation of UMC 0.18µm CMOS process concerning the
vulnerability against Single Event Effects (SEE), especially Single Event Upsets (SEU) and Single Event Transients (SET)SEU cross section for different Flip-Flop designs and layoutsCharacterisation of the critical charge Qcrit respectively the
Linear Energy Transfer (LETcrit )SET sensitivity of the UMC 0.18µm process
Single Transistor measurementsComparison of transistor models by simulationTotal Ionising Dose (TID)
Characterisation of the UMC 0.18µm process under irradiation, especially leakage currents, threshold shifts, annealing, ...
![Page 51: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/51.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 51Experiment Electronics
GRISU test ASICGRISU test ASIC
Test structures for TID
measurements
Test structures for SEU measurements
Test structures for SET measurements, Qcrit
Ring oscillator for TID / SEU measurements
GRISU chipUMC 0.18µm process1.5 x 1.5 mm²64 pads
28 core pads36 pads
![Page 52: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/52.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 52Experiment Electronics
SEE Building BlocksSEE Building Blocks
3 different building blocks for SEE characterisation: Test structures for SEU measurements
8 different types of flip-flops implemented, e.g. oversized flip-flops, flop-flops with Dual Interlock Cell (DICE) architecture, ...
Test structures for SET and Qcrit measurementsDifferent inverter chains
=> Qcrit,sim from 20 ... 1000fC2 ring oscillator test structure
![Page 53: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/53.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 53Experiment Electronics
•X6 cave at GSI
Low Energy testing siteLow Energy testing site
Installation of a test facility for ASIC irradiation with heavy ions at X6 cave at GSI (in cooperation with bio physics group)
Beam monitoring via ionisation chamber
Dosimeter setup availableIrradiation of DUT in airEasy access
Disadvantages of setupOnly one ion source
during beam time“Fixed” LET range for ion source
![Page 54: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/54.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 54Experiment Electronics
SEE Tests at GSISEE Tests at GSISEE test with heavy ions at GSI:X6 experimental site11.4 MeV/u7 irradiation tests so far
C-12 (3x)Ar-40Ni-58Ru-96Xe-132
LET in the range of 1...62 MeV·cm²/mg (SiO2)Q = 8..1300 fC
![Page 55: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/55.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 55Experiment Electronics
LET testing rangeLET testing range
Overview of the LET testing range for the applied heavy ions test
![Page 56: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/56.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 56Experiment Electronics
CrossCross--sectionsection ((WeibullWeibull--FitFit))
C-12 Ar-40 Ni-58 Ru-96 Xe-132
LETcrit = 1.93 MeV cm²/mgσsat = 1.48·10-8 cm²/bit
![Page 57: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/57.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 57Experiment Electronics
CrossCross--section (DF)section (DF)
LET = 4 MeVcm²/mg
![Page 58: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/58.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 58Experiment Electronics
TID tests TID tests –– single transistorssingle transistors
Measurements of the transistor characteristics and calculation ofthe threshold voltages for different dose levels (e.g. NMOS 0.24/1.80)
In total 6 chips are irradiatedTotal dose up to 2.5MradDecrease of threshold voltage
~ 20% after 1Mrdno further change
after 1Mrad
![Page 59: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/59.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 59Experiment Electronics
TID tests TID tests –– single transistorssingle transistors
Measurements of the transistor characteristics and extraction ofthe leakage current for different dose levels (e.g. NMOS 0.24/1.80)
In total 6 chips are irradiatedTotal dose up to 2.5MradIncrease of leakage current
no significant increase up to200krad
by 3 orders of magnitude after 2.5Mrad
![Page 60: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/60.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 60Experiment Electronics
TID tests TID tests –– single transistorssingle transistors
Measurements of the annealing and calculation of the thresholdvoltage for different dose levels (e.g. NMOS 0.24/1.80)
Detailed annealing scans only with one 1 chip
2.5Mrad total doseAnnealing at room temp.Increase of threshold voltage
after 6 weeksstill 10% under pre-radiation
valuebut no saturation reached
(maybe further increase possible)
![Page 61: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/61.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 61Experiment Electronics
TID tests TID tests –– single transistorssingle transistors
Measurements of the annealing and extraction of the leakagecurrent for different dose levels (e.g. NMOS 0.24/1.80)
Detailed annealing scans only with one 1 chip
2.5 Mrad total doseAnnealing at room temp. Decrease of leakage current
after 6 weeksalmost back to pre-rad value
![Page 62: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/62.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 62Experiment Electronics
SummarySummary
In all cases, designing with radiation in mind is essential.The semiconductor industry's move to decrease device structure sizes,
reduce power requirements and increase speedless sensitive for TID but lead to increased SEE sensitivityradiation-induced device failure could become a majorproblem
At the board level, however, designers have only the following options: mitigation at chip level by using components, which do meet the radiation
requirementmitigation at board level by using design techniques to achieve a radiation-
tolerant board (or, most likely, a combination of both approaches)Designers can add radiation tolerance to their boards by choosing to
use rad-hard componentsRad-hard component qualification does not guarantee that the device is
insensible to radiation
![Page 63: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/63.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 63Experiment Electronics
Summary (2)Summary (2)
At least for the future experiments (like Panda, CBM, ...) different investigations in all kind of radiation hard techniques are ongoing to keep the specifications for the high radiation levels
Reduce the number of devices in an radiation hard environment to a necessary minimum
Think about redundancy, failures detection, power monitoring of your devices
By using the right technology, qualified parts and proper design, it should be possible to build the right solution for radiation-sensitive applications of your self-developed equipment
Follow the publications of the different conferences / communities that are working in that field (e.g. NSREC, RADECS, ...)
![Page 64: Radiation Damages to Electronic Components … · Dr. Sven Löchner Radiation Damages to Electronic Components Experiment Electronics 3 Categories of Radiation Effects There are 3](https://reader036.vdocuments.site/reader036/viewer/2022071104/5fddf3613e99f754e501cec0/html5/thumbnails/64.jpg)
Dr. Sven Löchner Radiation Damages to Electronic Components 64Experiment Electronics
Total Dose ResultsTotal Dose Results
Beetle showed full functionality beyond 130 Mrad
• full trigger and readout functionality
• full slow control functionality
• performance degradations are small at 10 Mrad:
• peaktime: ≤ 1 nsgain: ≤ 4%
more significant at 130 Mrad:• peaktime: ~ 7 ns
~ 4 ns after annealinggain: ~ 10%
higher after annealing
no tuning of bias settings