CONSUMER TESTING SERVICES (CTS) 16 – 31 OCTOBER 2010
PRODUCT RECALLS
CONTENTS AUTOMOTIVE Pages 1 to 24
THE SGS PUBLICATION GATHERING CONSUMER PRODUCT RECALLS IN THE EU, IN THE USA AND IN AUSTRALIA
Motor Vehicle (43)
Child Safety Seat (1)
Motor Vehicle Equipment (12)
Page 2 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
AUSTRALIA Peugeot—307, 308 and Expert—Exterior Lighting Malfunction
PRODUCT DESCRIPTION
307, 308 and Expert vehicles manufactured between December 2006 till February 2008.
IDENTIFYING FEATURES
Campaign: YWB Target Number: 307
SUPPLIER
Sime Darby Automobiles Pty Ltd t/as Peugeot Automobiles Australia
No picture available.
HAZARDS
The lighting switch position may be incorrectly detected by the lighting management system. In rare cases, this may cause the exterior lights to inadvertenly cut out with no action taken by the driver.
DEFECTS
These vehicles had a previous safety recall campaign to download new lighting control software to the management system. There is a possibility that this software upgrade did not complete satisfactorily and therefore, the vehicle requires the latest software upgrade to be performed.
CONSUMERS ACTION
A registered letter is being sent to all owners contactable by Peugeot Automobiles Australia within the affected VIN range.
AUSTRALIA Volvo—S60, S80, V70, XC60 and XC70
PRODUCT DESCRIPTION
S60, S80, V70, XC60 and XC70 vehicles MY 2010 to 2011.
IDENTIFYING FEATURES
VIn Range: S60 - 000194 to 000701 S80 - 123254 to 136536 V70 - 142445 to 172769 XC60 - 087281 to 141518 XC70 - 082543 to 096858 Campaign Number: R89140 Target Number: 1308
SUPPLIER
Volvo Car Australia Pty Ltd
No picture available.
HAZARDS
If the short circuit occurs during driving and the driver ignores the warning, in the event of an accident where the deployment of the driver's airbag is required, the airbag may not deploy as intended or not deploy at all.
DEFECTS
There may be an electrical short circuit in the driver's airbag clockspring wiring connector. If the deviation occurs the supplemental restraint system lamp (SRS) will be permanently lit and the message "AIRBAG SYSTEM SERVICE REQUIRED" will be displayed in the Driver Information Module (DIM).
CONSUMERS ACTION
Contact your authorised Volvo dealer to have the driver's airbag clockspring wiring connector upgraded.
Page 3 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
AUSTRALIA Kawasaki Motors Pty Ltd—Kawasaki Jet Skis JT1500A9F and JT1500D9F
PRODUCT DESCRIPTION
A total of 32 units imported between December 2009 and April 2010 are affected.
IDENTIFYING FEATURES
JT1500A9F and JT1500D9F
SUPPLIER
Kawasaki Motors Pty. Ltd.
SUPPLIER'S WEB SITE
http://www.kawasaki.com.au/index.php
No picture available.
HAZARDS
If the clamp is installed incorrectly, fuel may leak into the engine compartment, creating the potential for an explosion and/or fire resulting in injury or death.
DEFECTS
On some units, the lower fuel pump clamp may have been installed incorrectly at the factory.
CONSUMERS ACTION
Customers will be contacted by their Kawasaki dealer and referred to an authorised repairer for correct installation of the clamp if necessary.
AUSTRALIA
Toyota—Hiace Commuter Bus KDH222, KDH223 & TRH223—Rear Propeller Shaft Guide
PRODUCT DESCRIPTION
Hiace Commuter Bus KDH222, KDH223 & TRH223 vehicles
IDENTIFYING FEATURES
Campaign Number: 0518J# Target Number: 13, 256
SUPPLIER
Toyota Motor Corporation Australia Limited
No picture available.
DEFECTS
The rear propeller shaft guard fitted does no meed the Australian Design Rule (ADR: 58.21*) due to a lack of propeller shaft guard rigidity.
CONSUMERS ACTION
All owners of affected vehicles will be notified by Recall Notification Letter. Owners are advised to contact their authorised Toyota Dealership for inspection and replacement of the rear propeller shaft guard.
AUSTRALIA Honda—2007 Legend Sedan
PRODUCT DESCRIPTION
2007 Legend Sedan vehicles
IDENTIFYING FEATURES
Identification Plate Number: 35889 VIN Range: JHMKB16507C200040 - JHMKB16507C204774 Campaign Number: 5LB Target Number: 482
SUPPLIER
Honda Australia Pty Ltd
HAZARDS
In the worst case scenaro, the defect may cause brake force reduction.
DEFECTS
It is possible that the rubber seal portion at the rear end of the brake master cylinder may turn and brake fluid may leak from the seal portion, causing the warning light to be illuminated.
CONSUMERS ACTION
Owners of affected vehicles will be contacted by mail.
Owners are advised to contact their authorised Honda Dealership for replacement of the brake master cylinder.
Page 4 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
AUSTRALIA Nissan—C11 Tiida, D40 Navara & R51 Pathfinder
PRODUCT DESCRIPTION
C11 Tiida vehicles produced in Japan. D40 Navara and R51 Pathfinder produced in Europe.
IDENTIFYING FEATURES
VIN Ranges: C11 Tiida JN1BBAC11A0100013 - JN1BBAC11A0103267 JN1FBAC11A0000010 - JN1FBAC11A0003883 D40 Navara VSKCLAD40A0063242 - VSKCLAD40A0119258 VSKCLND40A0062675 - VSKCLND40A0118785 R51 Pathfinder VSKJLWR51A0066034 - VSKJLWR51A0119527 Note: Not all vehicles in the above ranges are included. Campaign Numbers: C11 Tiida -1033 D40 Navara - PS0BF R51 Pathfinder - PS0BF Target Numbers: C11 Tiida -6,539 D40 Navara - 526 R51 Pathfinder - 79
TRADERS WHO SOLD THIS PRODUCT
All authorised Nissan Australian dealers
SUPPLIER
Nissan Motor Co (Australia) Pty Ltd
No picture available.
HAZARDS
In the extreme case, the resulting poor contact can potentially result in the engine stalling and failure to restart the vehicle.
DEFECTS
A concern affecting the intelligent power distribution module (IPDM) relay has been identified. There is a possibility that the ignition relay contacts in the IPDM may become contaminated with a build up of silicon oxide due to silicon evaporating from the relay diode. This can lead to poor conduction at the relay contacts.
CONSUMERS ACTION
Nissan will shortly mail directly to the owners of affected vehicles advising them to return the vehicle to a Nissan dealer to have the relay replaced free of charge with a counter-measure part. In the meantime, should any consumers experience difficulties, they can contact a Nissan dealer or our Customer Assistance Centre on 1800 035 035.
AUSTRALIA Nissan—T31 X-Trail—Overstated GVM Specification on Compliance Label
PRODUCT DESCRIPTION
T31 X-Trail vehicles
IDENTIFYING FEATURES
Campaign Number: S1010 Target Number: 68 VIN Range: JN1TANT31A0100176 - JN1TANT31A0100402 JN1TCNT31A0100122 - JN1TCNT31A0100170 NB. Not all vehicles in the above range are included
SUPPLIER
Nissan Motor Co. (Australia)
No picture available.
HAZARDS
Potential to overload the vehicle.
DEFECTS
A concern has been detected relating to the Gross Vehicle Mass (GVM) specification on the locally printed compliance label. This print error occurred during 16 and 18 August 2010.
CONSUMERS ACTION
Owners will receive a phone call or letter from Nissan. Owners are advised to contact their nearest Nissan Dealer to arrange rectification of their vehicle.
Page 5 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
AUSTRALIA Toyota—Lexus G300, IS250, RX330 and Toyota Kluger—Brake Master Cylinder
PRODUCT DESCRIPTION
Lexus G300, IS250, RX330 and Toyota Kluger MCU28
IDENTIFYING FEATURES
See attached VIN list. Campaign Number: 0516K Target Numebr: 25, 783
SUPPLIER
Toyota Motor Corporation Australia Ltd
No picture available.
HAZARDS
If the defect occurs, a small amount of brake fluid could leak from the rear of the brake master cylinder resulting in a low brake fluid level and illumination of the brake warning light. If the vehicle is operated in this condition, the brake pedal feel could change, and eventually braking performance could begin to gradually degrade.
DEFECTS
During vehicle assembly, Toyota brake fluid contains polymers that act as a lubricant for certain brake system components. If the replacement brake fluid used has insufficient polymers, the brake master cylinder rear rubber seal may become dry and curl during brake application.
CONSUMERS ACTION
All owners of affected vehicles will receive a Recall Notification Letter.
Owners are advised to contact their authorised Toyota Dealership for inspection and replacement of the rear rubber cup of the brake master cylinder.
AUSTRALIA Toyota—Lexus GS300 GRS190—Fuel Suction Tube Connector Replacement
PRODUCT DESCRIPTION
Certain Lexus GS300 vehicels produced from 28 September 2004 to 28 February 2006.
IDENTIFYING FEATURES
See attached VIN range. Target Number: 674 Campaign Number: 0515K
SUPPLIER
Toyota Motor Corporation Australia Limited
No picture available.
HAZARDS
The engine may not start or may stall while driving due to a loss of fuel pressure.
DEFECTS
The fuel suction tube assembly is located in the fuel tank and incorporates the fuel pump and wiring power supply.
The fuel pump wire harness insulation has insufficient flexibility and over time the internal connector may move resulting in wear and poor electrical contact.
CONSUMERS ACTION
All owners of affected vehicles will receive a Recall Notification Letter.
Owners are advised to contact their authorised Toyota Dealership for inspection and replacement of the fuel pump wire harness.
Page 6 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
AUSTRALIA Mercedes-Benz—Vito & Viano Vans (Type 639)
PRODUCT DESCRIPTION
Vito & Viano Vans (Type 639)
Identifying features
Chassis Range: 378470 to 562988 Campaign Number: RC843
SUPPLIER
Mercedes-Benz Australia/Pacific Pty Ltd
No picture available.
HAZARDS
In unfavourable circumstances localised overheating of the relay may occur.
DEFECTS
It is possible that during extreme weather conditions the air-conditioning fan relay may fail.
CONSUMERS ACTION
Contact your authorised Mecedes-Benz dealership to have the additional fan relay replaced with a modified version free of charge.
A full list of authorised dealerships can be found at http://www.mercedes-benz.com.au
EU/PORTUGAL CATEGORY: Motor vehicles
PRODUCT: Passenger car - S80, V70, XC70 and S60
BRAND: Volvo
TYPE/NUMBER OF MODEL: S80, V70, XC70 and S60. Model year 2010 and 2011.
DESCRIPTION: Passenger car.
COUNTRY OF ORIGIN: Sweden
No picture available
INJURIES
The product poses a risk of injuries because there may be an electrical problem with the driver's airbag. The problem will cause the message "Airbag system service required" to be displayed. If the driver ignores the warning however, the driver's airbag may not deploy as intended, or not deploy at all, in the event of a road accident.
Voluntary corrective actions taken by the manufacturer.
EU/GREECE CATEGORY: Motor vehicles
PRODUCT: Passenger car - Astra J and Meriva B
BRAND: Opel
TYPE/NUMBER OF MODEL: The recall concerns 2011 model year vehicles:
- Astra J vehicles, with VIN numbers from B 8 012507 to B 8 016159 and from B G 013718 to B G 028039; - Meriva B vehicles, with VIN numbers from B 4 023636 to B 4 061403. Only vehicles with a passenger seat without seat height adjustment are affected.
DESCRIPTION: Passenger car
COUNTRY OF ORIGIN: United Kingdom, Poland, Spain
No picture available
INJURIES
The product poses a risk of injuries because the bolts connecting the passenger seat rails to the seat frame could break in the event of an accident.
Voluntary corrective actions taken by the manufacturer.
Page 7 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
EU/IRELAND CATEGORY: Motor vehicles
PRODUCT: Passenger car - C2, C3, C3 Pluriel, C8 and Dispatch III
BRAND: Citroen
TYPE/NUMBER OF MODEL:
e2*98/14*0254*20, e2*98/14*0254*17, e2*2001/116*0317*02, e2*98/14*0256*06, e2*2001/116*0289*06, e2*98/14*0257*09, e2*98/14*0258*09, e2*98/14*0258*08, e2*2001/116*0266*08.
VIN/Chassis Nos: VF7 ****** 13374222 to VF7 ****** 97534321.
The recall concerns model year 2008 vehicles.
DESCRIPTION: Passenger car
COUNTRY OF ORIGIN: France
No picture available
INJURIES
The product poses a risk of injuries because a software problem could cause vehicle lights to randomly go out when not required, which could lead to a road accident.
Voluntary corrective actions taken by the manufacturer.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
BMW / X5 2008
MANUFACTURER: BMW OF NORTH AMERICA, LLC
COMPONENT: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
POTENTIAL NUMBER OF UNITS AFFECTED: 20800
SUMMARY: BMW is recalling certain model year 2008 x5 savs vehicles with 6-cylinder engines manufactured from November 1, 2007 through august 31, 2008. Due to a manufacturing process fault, the fuel pump was not produced to specifications. Under specific vehicle operating conditions, the fuel pump¿s commutator could experience an increase in wear.
No picture available.
CONSEQUENCE
This wear could lead to fuel pump malfunction and engine stalling. Engine stalling could create a potential for a crash resulting in injury or death.
REMEDY
The manufacturer has not yet provided a remedy or an owner notification schedule for this campaign. Owners may contact bmw at 1-800-525-7417.
EU/IRELAND CATEGORY: Motor vehicles
PRODUCT: Passenger car - V60, V70, XC70, S80, XC90
BRAND: Volvo
TYPE/NUMBER OF MODEL:
V60 - e9*2007/46*0023*02 V70 - e9*2001/116*0065*10 XC70 - e9*2001/116*0065*10 S80 - e4*2001/116*0057*14 XC90 - e9*2001/116*0046*22
DESCRIPTION: Passenger car
COUNTRY OF ORIGIN: Sweden
No picture available.
INJURIES
The product poses a risk of injuries because the standard wheel bolts (the locking wheel bolts are not affected) may corrode leading to noise and/or vibration, and, if left, to a wheel becoming loose.
Voluntary corrective actions taken by the manufacturer.
Page 8 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
BMW / F 650 GS 2007-2010
MANUFACTURER: BMW OF NORTH AMERICA, LLC
COMPONENT: SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS:DISC
POTENTIAL NUMBER OF UNITS AFFECTED: 1835
SUMMARY: BMW is recalling certain 2007 through 2010 f 650 gs motorcycles manufactured from November 2006 through January 2010. a washer may interfere with the front disc brake fasteners' torque. As a result, over time, a fastener or mutiple fasteners could become loose, allowing the brake disc to become loose.
No picture available.
CONSEQUENCE
A loose brake disc may interfere with proper braking performance and may increase the risk of a crash.
REMEDY
The manufacturer has not yet provided a remedy or a notification schedule. Owners may contact bmw at 1-800-525-7417.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
ALTEC / ALTEC 2008-2009
MANUFACTURER: ALTEC INDUSTRIES INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 578
SUMMARY: Altec is recalling certain model year 2008-2009 digger derricks utility vehicles built from September 2008 through May 2009. The digger bail pins installed on these vehicles were not properly heat treated and can develop cracks during auger use. The digger could become separated from the digger bail allowing the auger/digger assembly to swing freely from the digger hoses.
No picture available.
CONSEQUENCE
A swinging auger/digger could strike a bystander causing serious injury or death.
REMEDY
Dealers will replace the pins free of charge. The safety recall is expected to begin during October 2010. Owners may contact altec at 1-877-462-5832.
EU/GREECE CATEGORY: Motor vehicles
PRODUCT: Passenger car - Giulietta
BRAND: Alfa Romeo
TYPE/NUMBER OF MODEL: The recall concerns vehicles with chassis numbers between 7015114 and 7029602.
DESCRIPTION: Passenger car
COUNTRY OF ORIGIN: Italy
No picture available
INJURIES
The product poses a risk of injuries because the bushing of the rear wishbone may not be correctly fitted in the seat on the same wishbone which could lead to a road accident.
Voluntary corrective actions taken by the manufacturer.
Page 9 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
VOLVO / S80 2010-2011 VOLVO / V70 2010 VOLVO / XC60 2011 VOLVO / XC70 2010-2011
MANUFACTURER: VOLVO CARS OF N.A. LLC.
COMPONENT: AIR BAGS:FRONTAL
POTENTIAL NUMBER OF UNITS AFFECTED: 9746
SUMMARY: Volvo is recalling certain model year 2010-2011 s80, xc70, model year 2011 xc60 and model year 2010 v70 vehicles. There may be an intermittent fault in the driver's airbag clockspring wiring connector for the supplemental restraint system.
No picture available.
CONSEQUENCE
In the event of a crash, the driver's frontal airbag may not deploy as intended or at all and therefore will not be able to properly protect the driver, increasing the risk of injuries.
REMEDY
Dealers will install a metal shim in the driver's air bag clockspring wiring connector. This service will be performed free of charge. The recall is expected to begin on or before October 29, 2010. Owners may contact Volvo at 1-800-458-1552.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
CHRYSLER / 300 2010 CHRYSLER / SEBRING 2010 DODGE / AVENGER 2010 DODGE / CHALLENGER 2010 DODGE / JOURNEY 2010 DODGE / RAM 2011
MANUFACTURER: CHRYSLER GROUP LLC
COMPONENT: STEERING:ELECTRIC POWER ASSIST SYSTEM
POTENTIAL NUMBER OF UNITS AFFECTED: 26397
SUMMARY: Chrysler is recalling certain model year 2010 chrysler sebring, 300, charger (lx) and dodge challenger (lc), avenger (js), and journey (jc), as well as model year 2011 dodge ram light duty pickup (ds) vehicles. Some of these vehicles may experience a separation at the crimped end of the power steering pressure hose assembly.
No picture available.
CONSEQUENCE
Leaked power steering fluid onto hot engine components could cause a fire.
REMEDY: Dealers will inspect and replace as necessary the power steering pressure hoses free of charge. The safety recall is expected to begin during October 2010. Owners may contact chrysler at 1-800-853-1403.
Page 10 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
BMW / K1200 GT 2004-2010 BMW / K1200 R 2004-2010 BMW / K1200 S 2004-2010 BMW / K1300 GT 2004-2010 BMW / K1300 R 2004-2010 BMW / K1300 S 2004-2010
MANUFACTURER: BMW OF NORTH AMERICA, LLC
COMPONENT: SUSPENSION:FRONT:WHEEL BEARING
SUMMARY: BMW is recalling certain model year 2004-2010 motorcycles. The bearings could be subject to corrosion. This could lead to reduced movement of the link lever.
No picture available.
CONSEQUENCE
This could affect the handling of the motorcycle increasing the risk a driver may lose control of the vehicle resulting in a crash.
REMEDY
The manufacturer has not yet provided a remedy or an owner notification schedule for this campaign. Owners may contact bmw at 1-800-525-7417.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
CARRIAGE / CAMEO 2002-2010 CARRIAGE / CARRI-LITE 2002-2008 CARRIAGE / CARRIAGE 2004 CARRIAGE / COMPASS 2005-2006 CARRIAGE / ROYALS 2004
MANUFACTURER: CARRIAGE, INC
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 394
SUMMARY: Carriage is recalling certain recreational vehicles equipped with dimplex electraflame, symphony, or optiflame branded electric fireplaces, stoves, and fireplace inserts. The plug in remote control receiver for the fireplace can overheat.
No picture available.
CONSEQUENCE
An overheated receiver could cause a fire.
REMEDY
Carriage is working with dimplex and dimplex will provide owners a free replacement plug-in remote control kit. The manufacturer has not yet provided an owner notification schedule. Owners may contact dimplex North America customer service at 1-888-346-7539.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
GREAT DANE / MPA 2009
MANUFACTURER: GREAT DANE LIMITED PARTNERSHIP
COMPONENT: SUSPENSION
POTENTIAL NUMBER OF UNITS AFFECTED: 292
SUMMARY: Great Dane is recalling certain mpa20, mpa38, and mpa40 trailers equipped with arvin meritor suspension systems. The suspect systems may have missing welds at the interface of the lower seat bracket and axle beam.
No picture available.
CONSEQUENCE
Missing welds could allow the axle to roll out of position and potentially impact the handling of the trailer such that a driver may lose control of the vehicle, increasing the risk of a crash.
REMEDY
Great Dane is working with arvin meritor to identify owners with the affect suspension systems. The affected vehicles will be repaired free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Great Dane at 1-912-644-2100 or arvin meritor at 1-248-435-0896.
Page 11 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
CROSSROADS / ALL AMERICAN 2002-2003 CROSSROADS / HAMPTON 2008-2011 CROSSROADS / KINGSTON 2008-2010 CROSSROADS / PARADISE POINTE 2002-2008 CROSSROADS / SEVILLE 2008-2011 CROSSROADS / SILVERADO 2003-2006 CROSSROADS / TRANQUILITY 2009-2011
CROSSROADS / ZINGER 2010-2011
MANUFACTURER: CROSSROADS RV
SUMMARY: Crossroads is recalling certain recreational vehicles equipped with dimplex electraflame, symphony, or optiflame branded electric fireplaces, stoves, and fireplace inserts. The plug in remote control receiver for the fireplace can overheat.
No picture availale.
CONSEQUENCE
An overheated receiver could cause a fire.
REMEDY
Crossroads is working with dimplex and dimplex will provide owners a free replacement plug-in remote control kit. The manufacturer has not yet provided an owner notification schedule. Owners may contact dimplex North America customer service at 1-888-346-7539 or crossroads at 888-226-7496.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
HYUNDAI TRANSLEAD / COMPOSITIVE 2010
MANUFACTURER: HYUNDAI TRANSLEAD
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 203
SUMMARY: Hyundai translead is recalling certain model year 2003 53 foot composite dry van trailers, equipped with arvin meritor suspension systems. The suspect systems may have missing welds at the interface of the lower seat bracket and axle beam.
No picture available.
CONSEQUENCE
Missing welds could allow the axle to roll out of position and potentially impact the handling of the trailer such that a driver may lose control of the vehicle, increasing the risk of a crash.
REMEDY
Hyundai translead is working with arvin meritor to identify owners with the affect suspension systems. The affected vehicles will be repaired free of charge. The safety recall is expected to begin during October 2010. Owners may contact hyundai translead at 619-680-3144 or arvin meritor at 1-248-435-0896.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
OPEN RANGE / FIFTH WHEEL 2011 OPEN RANGE / TOY HAULER 2011
MANUFACTURER: OPEN RANGE R.V. COMPANY
COMPONENT: POWER TRAIN:AXLE ASSEMBLY
POTENTIAL NUMBER OF UNITS AFFECTED: 56
SUMMARY: Open range is recalling certain model year 2011 fifth wheel travel trailers and toy haulers manufactured from august 17, 2010, and September 9, 2010, equipped with dexter axles. On some axles, cracks could appear in the spindle weld.
No picture available.
CONSEQUENCE
These cracks can propagate and cause the spindle to detach from the axle tube, resulting in the separation of the wheel end from the vehicle, creating a road hazard that increases the risk of a crash to other vehicles, and compromises the driver's control of the vehicle increasing the risk of a vehicle crash.
REMEDY
Open range is working with dexter axle and will inspect the axle serial number and replace it if it falls within the serial number range. Replacement of the axle will be performed free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact open range at 1-260-768-7771 and dexter axle at 1-800-400-2164.
Page 12 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
JAYCO / EAGLE 2011 JAYCO / EAGLE SUPER LITE 2011 JAYCO / GREYHAWK CLASS C 2011 JAYCO / JAY FEATHER 2011 JAYCO / JAY FEATHER SELECT 2011 JAYCO / JAY FEATHER SPORT 2011 JAYCO / JAY FLIGHT 2011 JAYCO / JAY FLIGHT G2 2011 JAYCO / PINNACLE 2011 JAYCO / RECON ZX 2011
MANUFACTURER: JAYCO, INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 836
SUMMARY: Jayco is recalling certain model year 2011 travel trailers and fifth wheels manufactured from august 16, 2010, through October 1, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Jayco is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or jayco at 1-574-825-0608.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
ACURA / RL 2005-2007 HONDA / ODYSSEY 2005-2007
MANUFACTURER: HONDA (AMERICAN HONDA MOTOR CO.)
COMPONENT: SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS:MASTER CYLINDER
POTENTIAL NUMBER OF UNITS AFFECTED: 471820
SUMMARY: Honda is recalling certain model year 2005-2007 odyssey and acura rl vehicles. Brake fluid containing polymers is used that acts as a lubricant for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.
No picture available.
CONSEQUENCE
A leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.
REMEDY
Dealers will replace the brake master cylinder seal free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Honda at 1-800-999-1009.
Page 13 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
STARCRAFT / AUTUMN RIDGE 2011 STARCRAFT / LEXION S-LITE 2011 STARCRAFT / TRAVEL STAR 2011 STARCRAFT / TRAVEL STAR EXP 2011 STARCRAFT / TRAVEL STAR EXP SPORT 2011
MANUFACTURER: STARCRAFT RV, INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 98
SUMMARY: Starcraft is recalling certain model year 2011 travel trailers and fifth wheel trailers manufactured from august 16, 2010, through October 1, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Starcraft is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or starcraft at 1-800-945-4787.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
OPEN RANGE / JOURNEYER 2011 OPEN RANGE / OPEN RANGE 2011 OPEN RANGE / ROAMER 2011
MANUFACTURER: OPEN RANGE R.V. COMPANY
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 404
SUMMARY: Open range is recalling certain model year 2011 journeyer, open range, and roamer recreational vehicles manufactured from July 1, 2010, through September 20, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Open range is working with atwood and will replace or repair the stoves free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact atwood at 1-574-266-4749.
Page 14 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
LEXUS / GS 2006 LEXUS / IS 2006 LEXUS / RX 2004-2006 TOYOTA / AVALON 2005-2006 TOYOTA / HIGHLANDER 2004-2006
MANUFACTURER: TOYOTA MOTOR CORPORATION
COMPONENT: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
POTENTIAL NUMBER OF UNITS AFFECTED: 728544
SUMMARY: Toyota is recalling certain model year 2005-2006 Avalon, model year 2004-2006 highlander, model year 2004-2006 lexus rx, and model year 2006 lexus gs and is vehicles. Brake fluid containing polymers is used that acts as lubricants for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.
No picture available.
CONSEQUENCE
A leak of brake fluid could lead to a change in brake pedal feel and overtime a degradation in braking performance increasing the risk of a crash.
REMEDY
Dealers will replace the seal with a newly designed one. This service will be performed free of charge. The safety recall is expected to begin during November 2010. Owners may contact Toyota at 1-800-331-4331 and lexus at 1-800-255-3987.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
DUTCHMEN / VOLTAGE 2011
MANUFACTURER: DUTCHMEN MANUFACTURING, INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 26
SUMMARY: Dutchmen is recalling certain model year 2011 voltage fifth wheel travel trailers manufactured from august 13, 2010, through september 29, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
Page 15 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
CROSSROADS / SUNSET TRAIL 2011 CROSSROADS / ZINGER 2011
MANUFACTURER: CROSSROADS RV
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 6
SUMMARY: Crossroads is recalling certain model year 2011 zinger and sunset trail trailers manufactured from august 15, 2010, through september 29, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Crossroads is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October 2010. Owners may contact atwood at 1-574-266-4749 or crossroads at 1-888-226-7496.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
HEARTLAND / NORTH COUNTRY 2011
MANUFACTURER: HEARTLAND RECREATIONAL VEHICLES, LLC
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 198
SUMMARY: Heartland is recalling certain model year 2011 North Country travel trailers, manufactured from July 14, 2010, through September 14, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Heartland is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October 2010. Owners may contact atwood at 1-574-266-4749 or heartland at 1-877-262-8032.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
NEWMAR / BAY STAR 2011
MANUFACTURER: NEWMAR CORPORATION
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 16
SUMMARY: Newmar is recalling certain model year 2011 bay star ca recreational vehicles manufactured from august 6, 2010, through October 5, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Newmar is working with atwood and will replace or repair the stoves free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact atwood at 1-574-266-4749 or newmar at 574-773-7791.
Page 16 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
VOLVO / VHD 2008-2011 VOLVO / VNL 2008-2011 VOLVO / VNM 2008-2011 VOLVO / VT 2008-2010
MANUFACTURER: VOLVO TRUCKS NORTH AMERICA
COMPONENT: EQUIPMENT:OTHER:LABELS
POTENTIAL NUMBER OF UNITS AFFECTED: 1926
SUMMARY: Volvo is recalling certain model year 2008-2011 vhd, vnl, vnm, as well as 2008-2010 vt vehicles for failing to comply with the requirements of part 567, "certification." the tire description may be incorrect on the vehicle¿s certification label.
No picture available.
CONSEQUENCE
The misinformation on these labels could lead to a vehicle overloading that can increase risk of a crash.
REMEDY
Dealers will inspect and replace the labels free of charge. The safety recall is expected to begin on or before December 1, 2010. Owners may contact Volvo at 1-800-458-1552.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
KAWASAKI / VULCAN 2009-2010
MANUFACTURER: KAWASAKI MOTORS CORP., U.S.A.
COMPONENT: ENGINE AND ENGINE COOLING
SUMMARY: Kawasaki is recalling certain model year 2009-2010 Vulcan motorcycles. The engine may stall if the rider is coasting with the clutch pulled in due to an improper setting of the engine control unit (ecu).
No picture available.
CONSEQUENCE
Engine stalling could create a potential for a crash resulting in injury or death.
REMEDY
Dealers will replace the ecu with one containing revised settings to address the engine stalling. The safety recall is expected to begin on or before October 22, 2010. Owners may contact Kawasaki consumer services department at 866-802-9381.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
KEYSTONE / EVEREST 2003-2004 KEYSTONE / MONTANA 2001-2005 KEYSTONE / MONTANA-BIG SKY 2001-2005
MANUFACTURER: KEYSTONE RV COMPANY
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 5633
SUMMARY: Keystone is recalling certain recreational vehicles equipped with dimplex electraflame, symphony, or optiflame branded electric fireplaces, stoves, and fireplace inserts. The plug in remote control receiver for the fireplace can overheat.
No picture available.
CONSEQUENCE
An overheated receiver could cause a fire.
REMEDY
Keystone is working with dimplex and dimplex will provide owners a free replacement plug-in remote control kit. The recall is expected to begin during November 2010. Owners may contact dimplex North America customer service at 1-888-346-7539
Page 17 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
EVER-LITE / 25RB 2011 EVER-LITE / 27RB 2011 EVER-LITE / 29FK 2011 EVER-LITE / 29RK 2011 EVER-LITE / 30RLS-5 2011 EVER-LITE / 31BHS 2011 EVER-LITE / 31DS 2011 EVER-LITE / 31RB 2011 EVER-LITE / 31RKS 2011 EVER-LITE / 31RLS 2011 EVER-LITE / 32MKS 2011 EVER-LITE / 33QB 2011 EVER-LITE / 34BH-DS 2011 EVER-LITE / 34BHK 2011 EVER-LITE / 35RL-DS 2011 EVER-LITE / 35RLS 2011
MANUFACTURER: EVERGREEN RECREATIONAL VEHICLES, LLC
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 67
SUMMARY: Evergreen is recalling certain model year 2011 rvs equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Evergreen is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or evergreen at 1-574-825-4298.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
COACHMEN / BROOKSTONE 2011 COACHMEN / CHAPARRAL 2011 COACHMEN / NORTHRIDGE 2011
MANUFACTURER: COACHMEN RV COMPANY, LLC
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 124
SUMMARY: Coachmen is recalling certain model year 2011 chaparral, brookstone, and northridge fifth wheel travel trailers manufactured from july 1, 2010, through september 20, 2010, equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Coachmen is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or coachmen at 1-574-825-8360.
Page 18 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
TIFFIN / ALLEGRO 2011 TIFFIN / ALLEGRO BUS 2011 TIFFIN / PHAETON 2011
MANUFACTURER: TIFFIN MOTORHOMES, INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 62
SUMMARY: Tiffin motorhomes is recalling certain model year 2011 allegro, allegro bus, and phaeton rvs equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Tiffin is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or tiffin 1-256-356-8661.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
MEDTEC / TYPE II (VAN) 2007-2010
MANUFACTURER: MEDTEC AMBULANCE CORPORATION
COMPONENT: SEAT BELTS
POTENTIAL NUMBER OF UNITS AFFECTED: 198
SUMMARY: Medtec is recalling certain model year 2007 through 2010 ambulances manufactured from September 14, 2007, through April 15, 2010. The rear facing ambulance attendant seat was not equipped with a type 2 seat belt assembly, and so the vehicles fail to comform to the requirements of federal motor vehicle safety standard no. 208, "occupant crash protection."
No picture available.
CONSEQUENCE
Use of an improper seat belt assembly may increase the risk of injury to the seat occupant in the event of a crash.
REMEDY
Medtec will notify owners and dealers will install a type 2 seat belt assembly free of charge. The safety recall is expected to begin during November 2010. Owners may contact medtec toll-free at 1-866-263-3832.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
TIMPTE / TDH 2009-2011
MANUFACTURER: TIMPTE, INC.
COMPONENT: EQUIPMENT:MECHANICAL
POTENTIAL NUMBER OF UNITS AFFECTED: 279
SUMMARY: Timpte is recalling certain model year 2009-2011 tdh trailers equipped with aluminum upper couplers. These trailers have the potential to fracture some of the structural components of the upper coupler.
No picture available.
CONSEQUENCE
This could cause premature failure of the upper coupler increasing the risk of personal injury to the driver.
REMEDY
Dealers will install updated reinforcement brackets to the main beam and front support channels to prevent possible failures. This service will be performed free of charge. The safety recall is expected to begin during November 2010. Owners may contact timpte at 1-402-367-3056.
Page 19 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
ECLIPSE / ATTITUDE 2011 ECLIPSE / MILAN 2011 ECLIPSE / STELLAR 2011
MANUFACTURER: ECLIPSE RECREATIONAL VEHICLES, INC.
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 152
SUMMARY: Eclipse recreational vehicles, inc. Is recalling certain model year 2011 attitude, Milan, stellar rvs equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
Eclipse is working with atwood and will replace or repair the stoves free of charge. The safety recall is expected to begin during October or early November 2010. Owners may contact atwood at 1-574-266-4749 or eclipse at 1-951-684-6868.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
MITSUBISHI / ENDEAVOR 2006-2008
MANUFACTURER: MITSUBISHI MOTORS NORTH AMERICA, INC.
COMPONENT: ELECTRICAL SYSTEM: SOFTWARE
POTENTIAL NUMBER OF UNITS AFFECTED: 19410
SUMMARY: Mitsubishi is recalling certain model year 2006-2008 endeavor with manual air conditioning. Due to an incorrect heater (hvac) controller signal, the air flow from the air vents may randomly change direction and/or the temperature may briefly cycle between hot and cold.
No picture available.
CONSEQUENCE
This condition could affect defroster performance, resulting in poor windshield visibility and potentially cause a crash.
REMEDY
Dealers will inspect for damage and if necessary repair the mode door shaft free of charge. The safety recall is expected to begin during December 2010. Owners may contact mitsubishi at 1-800-222-0037.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
SUZUKI / SX4 2007-2010
MANUFACTURER: AMERICAN SUZUKI MOTOR CORP.
COMPONENT: VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
POTENTIAL NUMBER OF UNITS AFFECTED: 69587
SUMMARY: Suzuki is recalling certain model year 2007 sx4 hatchback and model year 2008-2010 sx4 hatchback and sedan passenger vehicles. The three screws that secure each of the outside rear view mirrors to the mirror base can come loose due to vibration.
No picture available.
CONSEQUENCE
If a rear view mirror falls off the vehicle the driver will have reduced visibility increasing the risk of a crash.
REMEDY
Dealers will replace the base screws on both outer rear view mirrors free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Suzuki at 1-887-697-8985 or visit Suzuki’s website at http://www.suzukiauto.com.
Page 20 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
FORD / EDGE 2011 LINCOLN / MKX 2011
MANUFACTURER: FORD MOTOR COMPANY
COMPONENT: LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
POTENTIAL NUMBER OF UNITS AFFECTED: 71
SUMMARY: Ford is recalling certain model year 2011 edge and Lincoln mkx vehicles manufactured from July 1, 2010, through October 8, 2010. These vehicles were shipped with incorrectly configured electronic module settings that disable the locking function of the liftgate. Accordingly, the vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 206, "door locks and door retention components."
No picture available.
CONSEQUENCE
The liftgate lock may be disabled and the driver may not be able to lock the liftgate using interior lock switches or remote key fob buttons.
REMEDY
Ford will notify owners and dealers will have the affected control modules updated free of charge. The safety recall is expected to begin on or before November 1, 2010. Owners may contact ford at 1-866-436-7332.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
INFINITI / QX56 2004-2006 NISSAN / ARMADA 2004-2006 NISSAN / FRONTIER 2005-2006 NISSAN / PATHFINDER 2005-2006 NISSAN / TITAN 2004-2006 NISSAN / XTERRA 2005-2006
MANUFACTURER: NISSAN NORTH AMERICA, INC.
COMPONENT: ENGINE AND ENGINE COOLING
POTENTIAL NUMBER OF UNITS AFFECTED: 747480
SUMMARY: Nissan is recalling certain model year 2004-2006 armada, titan, and infiniti qx56 and model year 2005-2006 frontier, pathfinder and xterra vehicles. The intelligent power distribution module (ipdm) assembly contains an engine control module (ECM) relay that has a diode for electrical current noise reduction. The ECM relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ECM relay contact due to arcing.
No picture available.
CONSEQUENCE
This could cause engine stalling increasing the risk of a crash.
REMEDY
Dealers will replace the ecm relay inside the ipdm assembly. This service will be performed free of charge. The safety recall is expected to begin during December 2010. Owners may contact nissan at 1-800-647-7261.
Page 21 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
DAMON / DAYBREAK 2011 FOUR WINDS INTERNATIONAL / FREEDOM ELITE 2011 FOUR WINDS INTERNATIONAL / HURRICANE 2011
MANUFACTURER: THOR INDUSTRIES
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 213
SUMMARY: TMC is recalling certain model year 2011 Damon daybreak, four winds freedom elite, and hurricane recreational vehicles equipped with atwood 35 series range ovens. A potential exists for a small fracture within the line delivering gas to the oven cavity burner. Such a fracture may cause propane gas to leak from the line.
No picture available.
CONSEQUENCE
A propane leak in the presence of an ignition source could result in a fire and/or explosion causing property damage and/or personal injury.
REMEDY
TMC is working with atwood and will replace or repair the stoves free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact atwood at 1-574-266-4749 or tmc warranty/service department at 877-855-2867.
USA VEHICLE MAKE / MODEL MODEL YEAR(S)
OPEN RANGE / OPEN RANGE 2011 OPEN RANGE / RESIDENTIAL 2011 OPEN RANGE / ROLLING THUNDER 2011
MANUFACTURER: OPEN RANGE R.V. COMPANY
COMPONENT: EQUIPMENT: RECREATIONAL VEHICLE
POTENTIAL NUMBER OF UNITS AFFECTED: 264
SUMMARY: Open range is recalling certain model year 2009-2011 open range, residential and rolling thunder recreational vehicles equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
No picture available.
CONSEQUENCE
An insufficient response time can result in power not being shut-off in sufficient time to prevent a fire, which has the potential to ignite resulting in personal injury and/or vehicle and property damage.
REMEDY
Open range is working with norcold to get the units repaired free of charge. Please see norcold¿s defect report 10e-049. The recall began on October 30, 2010. Owners may contact norcold at 1-800-767-9101.
Page 22 < BACK TO CONTENTS
AUTO: CHILD SAFETY SEAT
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA CHILD RESTRAINT BRAND NAME / MODEL OR MODEL NO.:
CHAPERONE / E9L69N9 (MOONSTONE)
CHAPERONE / E9L69P2 (RED MILL)
CHAPERONE / E9L69P3 (SAVANNAH)
CHAPERONE / E9L69P5 (COWMOOFLAGE)
MANUFACTURER: BRITAX CHILD SAFETY, INC.
COMPONENT: CHILD SEAT
POTENTIAL NUMBER OF UNITS AFFECTED: 17251
SUMMARY: Britax is recalling certain britax chaperon infant car seats model e9l69n9 moonstone, e9l69p2 red mill, e9l69p3 savannah, and e9l69p5 cowmooflage, manufactured from April 2009 through may 2010. The chest clip was incorrectly produced which could result in a more brittle chest clip than was intended. As a result, the chest clip which positions the harness straps across the infant's shoulders may break when the chest clip is engaged as the infant is secured into the infant car seat.
No picture available.
CONSEQUENCE
The sharp edges of the broken chest clip could create a risk of a skin laceration and the fractured components of the chest clip may present a small parts/choking hazard.
REMEDY
Britax will mail to consumers notice and remedy kits that contain a replacement chest clip and instruction sheet. The safety campaign is expected to begin on or about November 11, 2010. Owners may contact britax customer service department at 1-888-427-4829.
Page 23 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE EQUIPMENT
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA EQUIPMENT BRAND NAME / PART NO. OR MODEL NO.:
WEBASTO / HOLLANDIA 600
WEBASTO / HOLLANDIA 700
WEBASTO / HOLLANDIA TVS 900
MANUFACTURER: BLUE SKY CUSTOM AUTOMOTIVE RESTYLERS
COMPONENT: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 158
SUMMARY: Webasto product North America, inc. (webasto) is recalling certain hollandia 700 and 600 series and hollandia TVs 900 series sunroofs installed as original equipment by blue sky on various passenger vehicles. The adhesive bond between the glass and the metal frame can debond increasing the risk that the sunroof glass would separate from the vehicle. Complete glass-to-frame debonding can develop gradually and may be evidenced by metal corrosion around the sunroof frame, wind noise, vibration, visual bond separation and/or water leakage.
No picture available.
CONSEQUENCE
In the event of a separation, the falling glass could create a road hazard or strike a trailing vehicle, and cause a crash.
REMEDY
Webasto, the manufacturer of the sunroofs, will be performing the safety recall campaign. Owners who have been identified as having an affected sunroof installed in their vehicle will receive a safety recall notice from webasto. The safety recall is expected to begin during October 2010. In order to determine if your vehicle is affected, please review the list of vehicles provided to us by blue sky by clicking on the hyperlink affected vehicle list or you may visit webasto's website at www.sunroofcheck.com. You can also call webasto toll-free at 1-888-749-8632.
USA EQUIPMENT BRAND NAME / PART NO. OR MODEL NO.:
WEBASTO / HOLLANDIA 600
WEBASTO / HOLLANDIA 700
WEBASTO / HOLLANDIA TVS 900
MANUFACTURER: SOUTHSIDE TRIM Component: EQUIPMENT
POTENTIAL NUMBER OF UNITS AFFECTED: 781
SUMMARY: Webasto product North America, inc. (webasto) is recalling certain hollandia 700 and 600 series and hollandia TVs 900 series sunroofs installed as original equipment by southside trim on various passenger vehicles. The adhesive bond between the glass and the metal frame can debond increasing the risk that the sunroof glass would separate from the vehicle. Complete glass-to-frame debonding can develop gradually and may be evidenced by metal corrosion around the sunroof frame, wind noise, vibration, visual bond separation and/or water leakage.
No picture available.
CONSEQUENCE
In the event of a separation, the falling glass could create a road hazard or strike a trailing vehicle, and cause a crash.
REMEDY
Webasto, the manufacturer of the sunroofs, will be performing the safety recall campaign. Owners who have been identified as having an affected sunroof installed in their vehicle will receive a safety recall notice from webasto. The safety recall is expected to begin during October 2010. In order to determine if your vehicle is affected, please review the list of vehicles provided to us by southside trim by clicking on the hyperlink affected vehicle list or you may visit webasto's website at www.sunroofcheck.com. You can also call webasto toll-free at 1-888-749-8632.
Page 24 < BACK TO CONTENTS
AUTO: MOTOR VEHICLE EQUIPMENT
NOTIFYING COUNTRY
PRODUCT DANGER MEASURES ADOPTED
USA EQUIPMENT BRAND NAME / PART NO. OR MODEL NO.:
ADVICS / BRAKE MASTER CYLINDER
MANUFACTURER: ADVICS NORTH AMERICA, INC.
COMPONENT: SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS:MASTER CYLINDER
POTENTIAL NUMBER OF UNITS AFFECTED: 1200364
SUMMARY: Advics is recalling certain brake master cylinders installed as original equipment in certain Toyota and Honda passenger vehicles. Brake fluid containing polymers is used that acts as a lubricant for certain brake system components. If replacement brake fluid is used that does not contain such polymers, or that contains only small amounts, a part of the rubber seal located at the rear of the brake master cylinder may become dry, and the seal may curl during movement of the piston. If this occurs, a small amount of brake fluid could slowly leak from the seal into the brake booster.
No picture available.
CONSEQUENCE
A leak of brake fluid could lead to a change in brake pedal feel and, over time, a degradation in braking performance increasing the risk of a crash.
REMEDY
Owners of the defective brake master cylinders will be notified by their vehicle manufacturer. The safety recall is expected to begin during November 2010. Owners may contact Toyota at 1-800-331-4331 and lexus at 1-800-255-3987 and Honda owners may contact Honda at 1-800-999-1009. See Toyota recall campaign no. 10v-499 and Honda recall campaign no. 10v-504.
SOFTLINES SGS STANDARDS & REGULATIONS SERVICES
FOR ENQUIRIES
www.sgs.com/regulatorycompliance
GCSC has compiled the below sources:
PRODUCT RECALLS IN EUROPE
The Rapid Alert System for Non-Food Products (RAPEX) - Weekly overview reports of RAPEX notifications.
http://ec.europa.eu/consumers/dyna/rapex/rapex_archives_en.cfm
The official contact points of the Member and EFTA-EEA States provide the information published in these weekly overviews. Under the terms of Annex II.10 to the General Product Safety Directive (2001/95/EC) responsibility for the information provided lies with the notifying party. The Commission does not take any responsibility for the accuracy of the information provided.
PRODUCT RECALLS IN THE USA
National Highway Traffic Safety Administration (NHTSA)
www-odi.nhtsa.dot.gov/cars/problems/recalls/recallsearch.cfm (US Automotive recalls)
PRODUCT RECALLS IN AUSTRALIA
http://www.recalls.gov.au/
© 2010 SGS SA. All rights reserved. SGS’s services including compilation(s) of data into this Factsheet are based on publicly available sources as of the date stated herein for which SGS bears no responsibility. Although every effort has been made to ensure accuracy, SGS makes no warranty as to error, omissions and does not accept any liability, without limitation, for indirect or consequential loss or damage, or any loss or damages arising from any use in connection with this document.