Download - ppt on spv module and emt
![Page 1: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/1.jpg)
APresentation
On Solar Photo Voltaic Modules
&Electronic Milk Tester
AtRajasthan Electronics & Instruments Limited
(Kanakpura , Jaipur)
Submitted byPradeep Kumar kumawat
31-8-2015 1
![Page 2: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/2.jpg)
Contents
Introduction about REIL Solar Photo Voltaic Module (i) Working Principle (ii) Block Diagram (iii) Manufacturing Process of SPV Module (iv) Advantages & Disadvantages Electronics Milk Tester (i) Working Principle (ii) Features of EMT Conclusion
31-8-2015 2
![Page 3: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/3.jpg)
Introduction About REIL
REIL was established in 1981. It has an important place among the Electronic Industry Of
Rajasthan. It is a Public Sector Unit. It is a joint venture between Gov. of India And Gov. of
Rajasthan. Shareholding Pattern 1) Gov. of India 51% Holding 2) Gov. of Rajasthan 49% Holding
31-8-2015 3
![Page 4: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/4.jpg)
Solar Photo Voltaic Module
SPV module is used to convert sun light into electrical energy. It has connected assembly of solar cells. Cells are made up of silicon. Output Of each cell is approximately 0.5 volt dc.
SPV Module
31-8-2015 4
![Page 5: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/5.jpg)
Working Principle
It is based on the principle of Photoelectric Effect.
31-8-2015 5
![Page 6: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/6.jpg)
Block Diagram
31-8-2015 6
![Page 7: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/7.jpg)
Manufacturing Process Of SPV Module
Tabbing Of Cells Row Making Stringing Lay- Up Lamination Curing Trimming Channeling
31-8-2015 7
![Page 8: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/8.jpg)
1. Tabbing of cells
Process of making terminals of a Bare cell by soldering copper strips to the Bus bar.
31-8-2015 8
![Page 9: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/9.jpg)
2. Row making
A row of cells is made by connecting positive surfaces of one cell to the negative surface of another cell.
31-8-2015 9
![Page 10: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/10.jpg)
3. Stringing
The rows of SPV cells are connected in series to get desired power rating.
31-8-2015 10
![Page 11: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/11.jpg)
4. Lay-Up
It is a process of placing laminating material to the either side of the string. The laminating materials are-
(i) Top Glass (Toughened Glass) (ii) Ethylene Vinyl Acetate sheet (iii) Polyester Taddler
5. Lamination
The SPV module after lay-up process is placed in the laminator for 11 minutes.
31-8-2015 11
![Page 12: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/12.jpg)
6.Curing
In this process the laminating material attain full strength by placing the module into 1200c temperature for 20 minutes.
7.Trimming
The final module is obtained by cutting the extra laminating material.
31-8-2015 12
![Page 13: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/13.jpg)
8.Channeling
Modules are channelled from all the four sides. Anodized aluminium frames are used for channelling. Channels prevent any damage to the module.
31-8-2015 13
![Page 14: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/14.jpg)
Advantages
It have no moving parts. No noise pollution or any othe type of pollution. Requires minimum maintenance. Have long service lifetimes (upto 20 years).
31-8-2015 14
![Page 15: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/15.jpg)
Disadvantages
High cost. Doesn’t work at night. Efficiency levels are low.
31-8-2015 15
![Page 16: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/16.jpg)
Electronic Milk Tester
It is an instrument which is used for the measurement of fat percentage in milk.
31-8-2015 16
![Page 17: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/17.jpg)
Working Principle
It works on the photometric measurement of light scattered by the fat globules present in the milk sample.
31-8-2015 17
![Page 18: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/18.jpg)
Features of EMT
Operate on AC mains as well as battery. Performs 110-130 samples per hour. Instant measurement and display of milk fat. Instant calculation of amount payable. Printing facility.
31-8-2015 18
![Page 19: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/19.jpg)
Conclusion
This training made me learn the practical aspects of engineering.It gave me experience of working in a professional environment with professional people at a professional place. I have learnt adjusting myself to the busy schedule and workload which I will have to face in the future.
31-8-2015 19
![Page 20: ppt on spv module and emt](https://reader034.vdocuments.site/reader034/viewer/2022051404/58edb49a1a28aba76b8b466b/html5/thumbnails/20.jpg)
Thank You
31-8-2015 20