Download - Flammable Atmospheres
-
8/14/2019 Flammable Atmospheres
1/38
PREVENTION
Understanding
ItsCauses
-
8/14/2019 Flammable Atmospheres
2/38
THE FIRE TRIANGLEFor a fire to start three conditions mustbe met at the same time:
FUEL
OXIDIZER IGNITION
-
8/14/2019 Flammable Atmospheres
3/38
THE FIRE TRIANGLEFuels are materials that burnThe higher the temperature, the easier andquicker they burnCommon fuels include:-- Solvents such as acetone, alcohols, and
toluene-- Gases such as acetylene and propane-- Solids such as wood and paper
-
8/14/2019 Flammable Atmospheres
4/38
THE FIRE TRIANGLEOxidizers: Oxygen or other substancescapable of releasing oxygen to a fireCommon oxidizers include:
acids, especially nitric and perchloric acidschlorine dioxideOthers such as potassium permanganateand potassium chlorate
-
8/14/2019 Flammable Atmospheres
5/38
-
8/14/2019 Flammable Atmospheres
6/38
THE FIRE TRIANGLEFire prevention consists of making surethat the three legs of the fire triangle
never meet FUEL
OXIDIZER IGNITION
-
8/14/2019 Flammable Atmospheres
7/38
FIRE PROPAGATIONRecent studies indicate that the spreador propagation of a fire is alsodependent on a fourth factor - thechemical chain reactions that can occuras a result of heat produced by the fire.
-
8/14/2019 Flammable Atmospheres
8/38
FLAMABLE CONDITIONS A fire will not always start when thelegs of the fire triangle meet, unless allthree elements are present in therequired amountsFor example, vapors from a flammableliquid must be mixed with a certainamount of air in order to ignite andpropagate a flame
-
8/14/2019 Flammable Atmospheres
9/38
FLAMMABLE RANGELower Flammable Limit: The lowestconcentration at which a fuel/air mixturewill burn. Below this there is too little fuel(the mixture is too lean)Upper Flammable Limit: The highest
concentration at which a fuel/air mixturewill burn. Above this there is not enoughoxygen (the mixture is too rich)
-
8/14/2019 Flammable Atmospheres
10/38
FLASH POINTThe lowest temperature at whichsufficient vapors form above the liquidto produce an ignitable mixture with air
-
8/14/2019 Flammable Atmospheres
11/38
FLAMMABILITY RANGEThe Department of Transportationclassifies liquids for transportationregulation purposes
Flammables: All liquids with a flash pointbelow 100 degrees Fahrenheit
Combustibles: All liquids with a flashpoint above 100 degrees Fahrenheit
-
8/14/2019 Flammable Atmospheres
12/38
Flammable AtmospheresCritical Factors:
Oxygen content in the air.
Flammable gases or vaporsFlammable dust (visibility of 5 or less) Proper air/gas mixture can lead toexplosion
Typical Ignition Sources:Sparking or electric tool.Welding / cutting operations.Smoking
-
8/14/2019 Flammable Atmospheres
13/38
Lower Explosive Limit vs. Upper
Explosive LimitAIR
COMBUSTIBLE
LEL UEL
TOO LEAN TO BURN TOO RICH TO BURNEXPLOSIVE RANGE
Gasoline
100% LEL0%
100%1.4% Flammable range 7.6% by volume0%
-
8/14/2019 Flammable Atmospheres
14/38
Lower Explosive Limit vs. Upper
Explosive LimitAIR
COMBUSTIBLE
LEL UEL
TOO LEAN TO BURN TOO RICH TO BURNEXPLOSIVE RANGE
Gasoline
100% LEL0%
100%1.4% Flammable range 7.6% by volume0%
-
8/14/2019 Flammable Atmospheres
15/38
Lower Explosive Limit vs. Upper
Explosive LimitAIR
COMBUSTIBLE
LEL UEL
TOO LEAN TO BURN TOO RICH TO BURNEXPLOSIVE RANGE
Gasoline
100% LEL0%
100%1.4% Flammable range 7.6% by volume0%
-
8/14/2019 Flammable Atmospheres
16/38
Lower Explosive Limit vs. Upper
Explosive LimitAIR
COMBUSTIBLE
LEL UEL
TOO LEAN TO BURN TOO RICH TO BURNEXPLOSIVE RANGE
Gasoline
100% LEL0%
100%1.4% Flammable range 7.6% by volume0%
-
8/14/2019 Flammable Atmospheres
17/38
Lower Explosive Limit vs. Upper
Explosive LimitAIR
COMBUSTIBLE
LEL UEL
TOO LEAN TO BURN TOO RICH TO BURNEXPLOSIVE RANGE
Gasoline
100% LEL0%
100%1.4% Flammable range 7.6% by volume0%
-
8/14/2019 Flammable Atmospheres
18/38
FLAMMABLE GASES & SOLIDSGas cylinders such as acetylene weldinggas need to be properly stored and used
Solids such as paper, wood, and clothneed to be treated as potential fuelsRags or paper soaked with flammableliquids need to properly handled anddisposedMetals that burn (pyrophorics) areespecially dangerous
-
8/14/2019 Flammable Atmospheres
19/38
STORAGE & HANDLINGSince it is impossible to eliminateoxygen from the fire triangle, fire
prevention depends on trying to:Eliminate sources of ignitionRestrict the amount of flammable and
combustible liquids
-
8/14/2019 Flammable Atmospheres
20/38
Eliminate sources of ignitionChoose the least hazardous materialspossibleReduce the amounts stored to aminimum
Use safe storage procedures andcontainersEnsure containers are properly labeled
STORAGE & HANDLING
-
8/14/2019 Flammable Atmospheres
21/38
CONTAINER LABELINGFlammable liquids should have a labelsuch as this:
DANGER FLAMMABLE
KEEP AWAY FROM HEAT, SPARKS &OPEN FLAMES
KEEP CLOSED WHEN NOT IN USE
-
8/14/2019 Flammable Atmospheres
22/38
NFPA LABELING SYSTEM
-
8/14/2019 Flammable Atmospheres
23/38
MATERIAL SAFETY DATA
SHEETS (MSDS)Information regarding fire preventionand fire extinguishing
Safe storage and handling proceduresSpill clean-up proceduresProper labeling
Use to compare products for hazardssuch as flash point and flammabilityrange
-
8/14/2019 Flammable Atmospheres
24/38
STORAGE AMOUNTSLocal and state fire codes limit theamounts of flammable and combustibleliquids that can be stored in variouslocations
CHECK WITH YOUR LOCAL FIREDEPARTMENT
-
8/14/2019 Flammable Atmospheres
25/38
STORAGE AREASBest location to store large amounts offlammable and combustible liquids is aseparate outside buildingIf this is not possible, then a suitableflammable storage cabinet or inside
storage room should be built
-
8/14/2019 Flammable Atmospheres
26/38
FLAMMABLE STOREAGE
CABINETSBuilt to meet OSHA and NFPA standardsLabeled in large letters:
FLAMMABLE-- KEEP FIRE AWAYMaximum of 120 gallons of Class I, II,and III A liquids (60 gallons of Classes I
and II)Maximum of three cabinets may belocated in a given fire area
-
8/14/2019 Flammable Atmospheres
27/38
STORAGE CONTAINERSQuantities of flammable liquidsexceeding one pint should be stored inapproved portable safety cansIn instructional laboratories the largestcontainer size for flammable liquids is
one gallon (or a two gallon safety can)
-
8/14/2019 Flammable Atmospheres
28/38
STORAGE DRUMS55 gallon drums should only be storedin a separate storage area away fromheat and sunlight.The maximum size of drum that shouldbe stored indoors is 5 gallons
-
8/14/2019 Flammable Atmospheres
29/38
INSIDE STORAGE ROOMSRequirements found in NFPA 30(Flammable & Combustible Liquids Code)
Fire resistance rating of 2 hours for walls,floor, and ceilingClass B fire doors
Automatic fire protection systemsMechanical ventilation depending on theamount storedClass I-Division 2 electrical wiring andfixtures
-
8/14/2019 Flammable Atmospheres
30/38
DISPENSINGWhen dispensing from drums, useapproved transfer pumps or drumfaucetsWhen pouring flammable liquids from adrum to a metal container, ground the
drum and bond the metal container tothe drum to prevent the build-up of anystatic charge
-
8/14/2019 Flammable Atmospheres
31/38
SPILLS AND LEAKSSpills must be quickly and safely cleaned upto prevent flammable vapors from igniting
A sufficient quantity of absorbent material shouldbe kept on handTreat spill clean-up materials as flammable anddispose of separately from the regular trash
Large spills of flammable liquids (more than onequart) need special cleanup procedures
-
8/14/2019 Flammable Atmospheres
32/38
FIRE FIGHTINGFour Basic Types of Fires
Class A -- Common SolidsClass B -- Flammable LiquidsClass C -- Electrical Equipment
Class D -- Burning Metals
-
8/14/2019 Flammable Atmospheres
33/38
FIRE EXTINGUISHERSClass A Types -- Water based for areascontaining ordinary combustibles
Class ABC Multipurpose Dry Chemical --Displaces oxygen and smothers the flame Class ABC Halon 1211 -- Inhibits chain
reactions of a fireClass BC -- Carbon Dioxide displaces airand cuts off the oxygen supply
-
8/14/2019 Flammable Atmospheres
34/38
Automatic Sprinkler SystemsWater -- Sprays a mist when activatedby the heat of a fireHalon -- Sprays a halogenated chemicalonto the fire. Halons decompose totoxic gases when heated. Use must be
carefully planned.
-
8/14/2019 Flammable Atmospheres
35/38
OSHA REQUIRED PROCEDURES
FOR FIGHTING FIRESOSHA regulations allow for threesituations:
Total evacuation in case of fire alarm
Partial evacuation with some employeesallowed to use fire extinguishers All employees allowed to use fireextinguishers
OSHA specifies training requirements ifany employees are allowed to use fireextinguishers
-
8/14/2019 Flammable Atmospheres
36/38
USING FIRE EXTINGUISHERSIf you think you can handle the fire, soundthe fire alarm to set the emergency plan inoperationGrab the closet fire extinguisher thatconforms to the type of fire
Activate the fire extinguisher and follow thedirections for use
If at any time you feel overwhelmed, or theextinguisher charge runs out, leave the areaand wait for the professional fire fighters
-
8/14/2019 Flammable Atmospheres
37/38
INTEGRITY OF EQUIPMENTFire fighting equipment must be wellmaintained and checked periodically for
pressure and integrityFire extinguishers must be placed prominentlyaccording to OSHA regulationsFire suppression equipment, such as sprinklersystems, must also meet the appropriateOSHA and NFPA standards
-
8/14/2019 Flammable Atmospheres
38/38
REMEMBER !Fire Prevention Is
Everyones Responsibility