Download - Electrodeposition of Sn
-
8/18/2019 Electrodeposition of Sn
1/23
Electrodeposition of Sn-Zn-Cu alloys fromcitrate solutions
Abstract
The frst stage o this study involves the development o stable baths or
electrodepositing Sn-Zn-Cu alloys; these developments are based on thermodynamic
models o citrate baths and experiments exploring the stability o the baths. The eects
o the sodium citrate !complexation agent" concentration and the p# o the solution on
the stability o the baths $ere examined experimentally. The stability o the baths $as
determined through spectrophotometric analysis. Stable baths designed or the
electrodeposition o Sn-Zn-Cu alloys $ere produced in the range o dominant citrate
complexes $ith highly negative charge !the reduction process is strongly inhibited by
high activation energy". %oltammetric studies and potentiostatic deposition $ere
conducted to analyse the co-deposition o tin& 'inc& and copper& and the co-evolution o hydrogen. The eect o the solution p#& the concentration o sodium citrate and the
hydrodynamic conditions on the electrodeposition process and the composition o the
deposits $ere examined. The deposits $ere analysed using chemical !()*+" as also
grain si'e and phase analysis !)-ray diraction". The possibility o electrodepositing Sn-
Zn-Cu alloys rom citrate solutions $as confrmed. The tin content o these coatings
varied rom , to , $t./& the copper content varied rom 0.1 to 2.1 $t./& and the
'inc content reached up to approximately 03.1 $t./.
4ey$ords
• electrodeposition;• Sn-Zn-Cu alloys;
• lead-ree solders
5. 6ntroduction
Sn-Zn-Cu alloys are o great interest because they may be used industrially as lead-ree
solders& in 7esterite-based solar cells& because Cu2ZnSn!S&Se"8 is an intermediate
product during the synthesis o 7esterites& as negative electrodes in lithium-ionbatteries& and as corrosion resistant layers !combining the properties o brass and
bron'e". The composition o the alloys varies bet$een applications. SAC !tin-silver-
copper alloys" and eutectic Sn-Ag alloys have been used to replace solders containing
lead or many years. These materials have good physicochemical properties& but they
are di9cult to obtain through electrodeposition or electroless deposition methods;
thereore& tin is currently the primary material used or the electrodeposition o solder
layers :5. Sn-Zn eutectic alloys are among the most attractive lead-ree solder
http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0005http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0005http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0005
-
8/18/2019 Electrodeposition of Sn
2/23
-
8/18/2019 Electrodeposition of Sn
3/23
stable Sn!66"-Zn!66"-Cu!66"-citrate baths to confrm that the desired Sn-Zn-Cu deposits
could be obtained.
2. ?xperimental
The chemical compositions o the solutions used $hile studying the stability o thebaths and ta7ing electrochemical measurements are given in Table 5. The optimal
ranges or the p# and concentration o the complexation agent $ere chosen based on
the analysis presented in sub-Section 0.5. All chemicals used in this $or7 $ere
analytical grade. Beionised $ater !ultrapure& resistivity 5
-
8/18/2019 Electrodeposition of Sn
4/23
-
8/18/2019 Electrodeposition of Sn
5/23
euilibrium lines in +ig. 8 or the reduction processes $ith metals!66" !Cu!66"QCu&
Sn!66"QSn& Zn!66"QZn" are calculated under the assumption that the species are reduced
to orm pure metallic phases !Cu& Sn and Zn". This assumption is accurate or the Zn-Sn
system& but the Cu-Sn-Zn system also contains intermetallic phases and solid solutions&
slightly altering its euilibrium lines.
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020
-
8/18/2019 Electrodeposition of Sn
6/23
-
8/18/2019 Electrodeposition of Sn
7/23
-
8/18/2019 Electrodeposition of Sn
8/23
The compositions o the solutions given in Table 5 $ere assigned based on an analysiso the thermodynamic models. The baths $ere clear and blue ater preparation; nodeposits $ere observed in the solution. The stability o the baths $as examinedspectrophotometrically at specifc intervals. The absorbance o the baths $asmeasured rom 2 to 55 nm. The most interesting results are sho$n in+ig. 1. Theintense pea7 bet$een 5 and 11 nm is attributed to copper !66" species !blue colouro solutions". +ig. 1 a& b and c sho$ the relationship bet$een the concentration o thecomplexation agent and the stability o the bath in solutions
-
8/18/2019 Electrodeposition of Sn
9/23
deposits. Joth o these relationships are attributed to an Sn!66"-mediated Cu!66"reduction to metallic copper. 6ncreasing the p# beyond 1.31 destabilises the solutionsthrough a slo$& systematic precipitation o a $hite deposit over several $ee7s. The )-ray diraction analysis reveals that the ma@or component o this deposit is tin!66" oxy-hydroxide !Sn,U8!U#"8" !GCIBS 8,-58
-
8/18/2019 Electrodeposition of Sn
10/23
o copper!66" is strongly inhibited due to the high overpotential o the reduction rom
complexes $ith such high negative charges. Similarly& $hen the copper citrate
complexes are reduced by the tin!66" complex& the charge transer process reuires
complexes $ith negative charges to approach one another. Thereore& the activation
energy or the charge transer process is greater $hen complexes $ith a high negative
charge are present& inhibiting the reduction o Cu!66" species. Signifcant amounts o Cu!66" species occur as sulphate complexes !:Cu!SU8"n2V2n" in solutions $ith lo$
complexation agent concentrations and p# values. The reduction o these complexes
proceeds easily& particularly or neutral :CuSU8!a" species. Consuming these complexes
via reduction causes their regeneration rom the citrate complexes $ith high negative
charges. The Cu!66" reduction is slo$& but not inhibited. Yhen the sulphate complex
concentration decreases due to increases in the concentration o the complexation
agent and p# o a solution& the highly charged citrate complexes are only present in
solution& inhibiting the reduction o copper !66" and stabilising the baths over long
periods.
0.2. %oltammetric studies
+ig. , sho$s the cyclic voltammograms in citrate solution !.,1 " or 'inc!66"& tin!66" and
copper!66" separately. Curve !5" depicts the voltammograms received rom a solution
containing only sodium citrate. The sharp increase in the cathodic current density or
potentials belo$ -5 % vs SC? is attributed to hydrogen!6" reduction o a dominate
protonated citrate ion& according to reaction *5 $hen the current is belo$ -5.1 % vs
SC?L
+urther& a very sharp increase o cathodic current density !belo$ -5.31 % vs SC?" occursdue to the evolution o hydrogen and is related to the decomposition o $aterL
2 # 2 U X 2 e V # 2 X 2 U # V ! * 2 "
Turn athGax on
The reduction o 'inc!66" begins at approximately -5.8 % vs SC? !+ig. ,& curve 2". Iea7
!a" indicates that the oxidation o 'inc begins at approximately -5.5 % vs SC?. The
beginning o the tin !66" reduction occurs at approximately -.< % vs SC? ! +ig. ,& curve
0"& $hile oxidation o tin starts at a potential o about -.3 % vs SC? !pea7 b". The
reduction o copper!66" starts at a potential o about -.8 % vs SC? !+ig. ,& curve 8".Uxidation o copper is invisible in the voltammogram because this process begins at
high potentials& $hich may oxidise the copper electrode !substrate in the voltammetric
study". All o the reduction processes or the metal!66" species are shited to$ard lo$er
potentials relative to the euilibrium potentials !+ig. 8"& $hich enables the reduction o
complex ions $ith high cathodic overpotentials !.0 to .1 %".
%oltammetric studies sho$ electrochemical instability or the cathodic pea7s in
negative potentials& $hich is connected $ith hydrogen evolution. The hydrogen !6"
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0030http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020
-
8/18/2019 Electrodeposition of Sn
11/23
reduction o protonated citrate ions is inhibited by a tin layer& and by an
underpotential-deposited 'inc monolayer on the copper electrode& agreeing $ith the
higher cathodic overpotential observed or the hydrogen evolution on the tin and 'inc
suraces than on the copper surace !Tael \a] parameter is eual -5.28 % vs W#? or tin
and 'inc and -.33 to -.
-
8/18/2019 Electrodeposition of Sn
12/23
The voltammetric studies reveal that the electrodeposition o an Sn-Zn-Cu alloy is
possible $hen using citrate baths. The deposition processes or tin& 'inc and copperbegin in accordance $ith the order o their euilibrium reduction potentials !Cu!66"QCu&
Sn!66"QSn& Zn!66"QZn& +ig. 8"; thereore& this type o co-deposition is normal& according to
the Jrenner classifcations :02.
0.0. 6n>uence o the hydrodynamic conditions on electrodeposition
The eect o the *B? speed on the electrodeposition o tin rom stable citrate solutions
containing Cu!66"& Sn!66"& Zn!66" species is sho$n in +ig. a. These investigations utilised
rotation rates o 51 and ,< radQs or the cathode $hile using a number electrolyte.
The partial current density or Sn electrodeposition remains independent o the rotationrate at potentials rom -5. to approximately -5.0 % vs SC?. The limiting current density
can be observed in this range o the potential. The electrodeposition process $as also
carried out at a constant -5.0 vs SC?& $hen the rotation rate o the cathode ranged
rom 5 to ,< radQs and electrolyte number $as used to determine the limiting
current !+ig. 5a". The partial current densities obtained at -5.0 % vs SC? are
independent o the rotation rate o the cathode. Thereore& the rate o the tin!66"
reduction in this potential range is limited by the dissociation o the dominant tin!66"
citrate complex !SnCit2V" according to *0 and *8L
S n C i t 2 V X #X
_ S n # C i tV
! * 0 "
S n # C i t V X 2 e V X # X S n X # 2 ! * 8 " C i t 2 V
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0160http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0160http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0045http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0020http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0160http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0045http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050
-
8/18/2019 Electrodeposition of Sn
13/23
-
8/18/2019 Electrodeposition of Sn
14/23
The next limiting current density can be observed belo$ -5.8 % vs SC?.
?lectrodeposition $as also carried out at a constant -5. % vs SC? $hen the rotation
rate o the cathode ranged rom 5 to ,< radQs at p# O 1.1 !number " to determine
the limiting partial current density o tin !+ig. 5a". The tin partial current densities are
linearly related to the suare root o the rotation rate at -5. % vs SC?& confrming that
the limiting current has a diusional nature and is connected to the direct reduction o
the dominant tin !66" citrate complex !SnCit2V
" according to reaction *1LS n C i t 2 V X 2 e V X 2 # X S n X # 2 ! * 1 " C i t 2 V
Turn athGaxon
The diusion coe9cient o the Sn!66" species $as calculated based on ^evichKs
euation& generating a value o ,.0 5V3 cm2 sV5. This value is about one order o
magnitude lo$er than or stannous ions !,.1`5V3 cm2 sV5:08"& but this diusion
coe9cient is determined mainly through the dominant citrate complex !monomeric
SnCitV2 complex". The value determined or the diusion coe9cient is closer to values
or dimeric citrate complexes !point ?N on the +ig. 55" than or monomeric citrate
complexes !point ? on the +ig. 55"; thereore& the ormula o this complex should beSn2Cit28V. This conclusion reuires additional investigation. The Sn content in the
deposits increased slightly $hen the speed o the *B? $as increased !+ig. 52".
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0170http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0055http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0055http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050http://www.sciencedirect.com/science/article/pii/S001346861401425X#bib0170http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0055http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0055http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060
-
8/18/2019 Electrodeposition of Sn
15/23
The relationship bet$een the partial current density and the *B? rate or 'inc
deposition is presented in+ig. b. The partial current densities are independent o the
rotation rate o the cathode& even at -5. % vs SC? !+ig. 5b". Throughout the
investigated range o potentials and disc rotation rates& the 'inc electrodeposition
process is controlled by the activation o the 'inc!66" reduction rom the dominate
citrate complex !Zn#CitV"& according to reaction *,L
Z n # C i t V X 2 e V X # X Z n X # 2 ! * , " C i t 2 V
Turn athGaxon
The amount o Zn in the deposits decreases or electrodeposition at higher rotation
rates and at more strongly negative potentials !+ig. 52" $hen the electrodeposition o
Sn and Cu is under diusion or mixed control.
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0045http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0045http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0050http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060
-
8/18/2019 Electrodeposition of Sn
16/23
+ig. c demonstrates the relationship bet$een the partial current density and the rate
o the *B? during copper electrodeposition. T$o limiting current densities can be
observed& similar to the reduction o tin!66". The frst occurs at potentials rom -5 to
-5.0 % vs SC?. To determine the nature o the process& the electrodeposition $as carried
out at a constant 5.0 % vs SC?& $hen the rotation rate o the cathode ranged rom 5 to
,< radQs and a p# O 1.1 electrolyte !number " $as used. The partial current densitiesare independent o the rotation rate o the cathode. The rate o copper reduction is
limited by the dissociation o the dominate copper!66" citrate complex !Cu2Cit28V"&
according to *3 and *
-
8/18/2019 Electrodeposition of Sn
17/23
-
8/18/2019 Electrodeposition of Sn
18/23
The electrodeposition potential strongly in>uences the partial current density o tin !+ig.
50a" or all investigated concentrations o sodium citrate. The limiting current densities
are slightly visible on the polarisation curves at lo$ citrate concentrations !.8 "; theyare more visible $hen the solution has a high sodium citrate concentration !.,1 and
.< ". The signifcant in>uence exerted by the complexation agent is apparent
bet$een .8 and .,1 . The partial current densities o tin increase $hen increasing
the sodium citrate concentration at potentials belo$ -5.8 % vs SC?; ho$ever& urther
increases in the concentration !.,1 to .< " do not aect the electrodeposition o
tin. The Sn content decreases $hen decreasing the potential !rom 2 to ,2 $t./". The
highest tin content in the deposit is reached at higher potentials !rom -5 to -5.8 % vs
SC?". The lo$est tin content is achieved at lo$ concentrations o sodium citrate& at
lo$er potentials !belo$ -5.3 % vs SC?".
The partial current densities during the electrodeposition o copper are lo$ relative to
the current densities or tin and 'inc !+ig. 50c". Changes in the sodium citrate
concentration do not aect the curves signifcantly. This eect is most apparent
bet$een -5.0 and -5. % vs SC? !bet$een .8 and .,1 Wa 0#Cit". The current
density increases $hen increasing the Wa0#Cit concentration. Similar to tin& the
dependence or copper bet$een .,1 and .< nearly disappears. The copper
content in the received deposit is sho$n in +ig. 52. At lo$ potentials& the Cu content
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0065http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060
-
8/18/2019 Electrodeposition of Sn
19/23
remains independent o the sodium citrate concentration. The relationship bet$een the
concentrations o the complexation agent and the Cu is apparent at higher potentials
!rom -5 to -5., % vs SC?". The Cu content increases $hen the concentration o the
complexation agent is increased. The Cu content is also related to the increasing
current density in this range. The maximum Cu content is
-
8/18/2019 Electrodeposition of Sn
20/23
+ig. 58a presents the steady-state partial polarisation curves or tin. The frst limiting
current density observed or the higher potential decreases $hen increasing the p#. This limiting current is connected to reduction o the Sn#CitV citrate complex described
in reaction *8; thereore& $hen the concentration o this complex decreases $ith
increases in the p#& the limiting current is decreased. The second limiting current
density is observed at more negative potentials& but is not ully attained; thereore&
there is a minor relationship bet$een the p# o solution and the frst $ave o reduction
!presence o a reduced Sn#CitVcitrate complex". The Sn content in the deposits& $hich
is related to the p# and deposition potential& remains independent o the solution p#
!+ig. 52a and +ig. 52b" and only changes $hen decreasing the potential. The maximum
Sn content at lo$ p# values is observed rom -5 % to -5.8 % vs SC? !8-, $t./".
The steady-state partial polarisation curves or Zn !66" are sho$n in +ig. 58b. The curves
remain independent o the solution p#. The Zn reduction begins belo$ -5.2 %. Jet$een
-5.2 % and -2 % vs SC?& the Zn content remains independent o the solution p# and
increases $hen increasing the solution p# over a narro$ range at potentials belo$ -2 %
vs SC?.
http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0070http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0070http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0070http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0060http://www.sciencedirect.com/science/article/pii/S001346861401425X#fig0070
-
8/18/2019 Electrodeposition of Sn
21/23
The steady-state partial polarisation curves or copper are similar to those o tin !+ig.
58c". The solution p# is $ea7ly related to the limiting current density. Yhen increasing
the solution p#& the current density decreases. This result is related to the
decreased concentration at increased p#; thereore& the limiting current
related to *< decreases. The Cu content in the deposit remains independent o the
solution p# !+ig. 52" and decreases $hen the electrodeposition potential decreases. The Cu content pea7s at the highest potentials !< $t./".
+ig. 58d presents the steady-state partial polarisation curves or hydrogen& $hich agree
$ith the results obtained previously. Jelo$ -5., % vs SC?& the reduction o hydrogen
increases signifcantly& according to reactions *5 and *2. The solution p# appears
independent o the current density. The current e9ciency decreases $hen decreasing
the electrodeposition potential. This process is the most e9cient at high potentials&
$hile remaining independent o the solution p#.
0.,. Ihase structure and grain si'e
The initial investigations $ere perormed or phase structure and grain si'e
determination by )-ray diraction ! Table 2". The -tin phase !tetragonal& space group
685Qamd !585"& IB+ 8-,30" is the main phase in all deposits. The second phase
Cu,Sn1 !hexagonal& space group I,0Qmmc !58"& IB+ 83-5131" is present in deposits
$ith lo$ 'inc content. The Cu1Zn
-
8/18/2019 Electrodeposition of Sn
22/23
Thermodynamic analysis o the model o citrate baths reveals that the optimal
conditions or the electrodeposition o Sn-Zn-Cu alloys rom citrate solutions reuire a
p# bet$een 8 and ,& but the citrate baths generated under these conditions may be
unstable due to the reduction o Cu!66" by Sn!66" species.
E
The development o a stable electrolyte citrate bath or the electrodeposition o
SnZnCu alloys is possible at p# 1 to 1.31 $hen the citrate ion concentration
exceeds .8 . The reduction o copper !66" species by negatively charged tin!66"
complexes is inhibited because the activation energy o the charge transer
process is high. #igh overpotentials are also observed or the reduction o
citrate copper!66" complexes during voltammetric investigations.
E
The voltammetric studies reveal the possibility o electrodepositing Sn-Zn-Cu
alloys rom citrate baths. The deposition processes or tin!66"& 'inc!66" and
copper!66" agree $ith their standard potentials& $hich is normal co-depositionaccording to the Jrenner classifcation. The 'inc!66" reduction $as strongly
inhibited during its co-reduction $ith tin!66".
E
A mechanism or the co-reduction o the tin!66"& 'inc!66" and copper!66" citrate
complexes& as $ell as the protonated citrate species& $as proposed to explain
the in>uence o the potential& hydrodynamic conditions& p# and concentration o
the complexation agent on the composition o the Sn-Zn-Cu deposit and current
e9ciency.
E
Hnli7e the electrodeposition o tin and copper& the electrodeposition o 'inc is
under activation control due to the reduction o an electroactive citrate 'inc!66"
complex !Zn#CitV" $ith the investigated range o electrode potentials; thereore&
changes in the hydrodynamic conditions !increase o *B? rate" decrease the
'inc content.
E
6ncreasing the citrate concentration in the bath induces the release o citrate
ions during the co-reduction o tin!66" citrate complex conduct to !i" decrease the
concentration o the electroactive 'inc!66" citrate complex !Zn#Cit V" near the
electrode surace and to !ii" increase the concentration o the non-electroactive
'inc!66" citrate complexes $ith high negative charges !Zn2Cit28V and Zn#2Cit28V&
$hich have a high overpotential or Zn!66" reduction".
E
The changes in p# bet$een 1. and 1.31 have little in>uence on the
concentration o the electroactive 'inc!66" citrate complex. #o$ever& these
changes in p# decrease the concentration o complexes $ith lo$er
overpotentials. Conseuently& the frst plateau in the limiting current or Cu!66"
-
8/18/2019 Electrodeposition of Sn
23/23
and Sn!66" decreases& and the 'inc content increases slightly $hen the p# is
increased.
E
The possibility o electrodepositing Sn-Zn-Cu alloys rom citrate solutions $as
confrmed via potentiostatic deposition. The tin content o the coatings varied
rom , to , $t./& the copper content varied rom 0.1 to 2.1 $t./& and the
'inc content approached 03.1 $t./.