document no issue index tad1372ve 22323790 04 - mono marine

Important

General

litersin3

mmin

mmin

kglbkglb

rpm 1200 1500 1800 1900kW 273 315 315 315hp 372 428 428 428

with fan kW 265 303 295 291890 mm hp 361 412 401 396

Nm 2175 2005 1671 1583lbf ft 1604 1479 1232 1168Nmlbf ft%

m/s 6,3 7,9 9,5 10,0ft/sec 20,7 25,9 31,1 32,8MPa 2,14 1,97 1,64 1,56psi 310 286 238 226

MPa 15,4 15,6 14,6 14,3psi 2233 2262 2117 2074

kgm²(not including flywheel) lbft²

kW 21 31 45 51hp 29 42 61 69

Document No Issue IndexTAD1372VE 22323790 04

Bore 1315,16

Stroke 1586,22

This Technical Data Sheet and the corresponding Installation Instructions provide important information to ensure the installed engine will operate according to the design specification in the Volvo Penta application for certification.

Requirements marked with are considered as critical for exhaust emissions compliance according to the design specification in the Volvo Penta application for certification.

Failing to follow and meet these instructions and requirements when installing a certified engine in a piece of nonroad equipment for use in the United States violates U.S. federal law (40 CFR 1068.105(b)), subject to fines or other penalities as described in the Clean Air Act.

In-line four stroke diesel engine with direct injection. Rotation direction, counterclockwise viewed towards flywheel

Number of cylinders 6Displacement, total 12,78

Compression ratio 17,8:1Wet weight Engine only (Estimated)

(excl after treatment comp.)13252921

Power pac 1790

780Firing order 1-5-3-6-2-4

3946

PerformanceIFN Power 315 kW without fan

21751604

Torque at: IFN Power

Max torque at engine speed

rpm 1200 rpm

Max combustion pressure at: IFN Power

Total mass moment of inertia, J (mR2) 1,14327,1

Power tolerance ±2Mean piston speed

Effective mean pressure at: IFN Power

Friction Power

Derating see Technical Diagrams

1/19


rpm 1200 1500 1900 2200kW 70 128 240 283hp 95 174 326 385Nm 557 815 1206 1228lbf ft 411 601 890 906rpmrpm°C

°C°F°C°F°C°F

Vol%

literUS gal

Max literUS gal

Min literUS gal

hh°°°

kPapsi

max °C°F

99% µ50% µ

Engine speed range for VCB activation: 1000-2200Min engine speed with VCB still active: 900Min oil temperature for VCB activation: 55

Engine brake performance (only engines with VCB)Brake power: without fan

Brake torque: without fan

-13with manifold heater 3 kW and block heater

-30-22

*Specify oil and fuel quality T>-15°C Oil VDS3 or VDS4 15W/40 T<-15°C Oil VDS3 or VDS4 5W/40

Cold start performance*Cold start limit temperature without starting aid -15

5with manifold heater 3 kW -25

Heater type Make Power kW Engaged hours(-30°C)

Cooling water temp engine block

Self circulating Volvo 21578298 2 12 -1°C30°F

* See also general section in the sales guide

Lubrication system0,02Lubricating oil consumption (average)

Oil change intervals/specifications VDS3 1000VDS4 1000

Oil system capacity including filters 369,51

Oil pan capacity:(both variants)

307,9319

5,02

Oil pressure at rated speed 300 - 65044 - 94

Engine angularity limits: front up 11front down 11side tilt 11

Lubrication systemLubrication oil temperature in sump: 130

266Oil filter filtration efficiency(in accordance with ISO 4548-12)

3814

2/19


liter/hUS gal/h

kPapsikPa

(meassured at fuel inlet connection) psikPa

(meassured at fuel inlet connection) psiliter/h

US gal/hkPapsi°C°Fµ

96% µ75% µ

Vol%

rpm 1200 1500 1800 1900m³/min 19,0 25,0 26 27

cfm 671 883 918 954

kPapsikW 187 233 252 253

BTU/min 10635 13250 14331 14388°C 438 418 439 444°F 820 784 822 831

kPa 12 16 18 18125 mm psi 1,7 2,3 2,6 2,6

Δ°C 10 10 10 10Δ°F 18 18 18 18kPa 8 9 10 10

(at exhaust gas flow and exhaust temp given) psi 1,2 1,3 1,5 1,5

m³/min 44,0 54,0 57 58cfm 1554 1907 2013 2048

System supply flow at max. Speed 13034,3

Fuel supply line max. restriction (measured at fuel inlet connection)

304,4

Specific UREA consumption in Nonroad Transient Cycle (NRTC) 4,7

Fuel system

Fuel supply line max. pressure, during engine stand still 16523,9

System return flow at max. Speed 30,07,9

Fuel supply line min. pressure, during engine stand still -125-18,1

Fuel filter filtration efficiency

Charge air consumption at:(+25°C and 100kPa)

IFN Power

Fuel return line max. restriction(measured at fuel return connection)

202,9

Max. allowable inlet fuel temp(Measured at fuel inlet connection)

60140

Fuel to conform to Fuel equal to or better than EN590:2009 or ASTM D975-09 and Max sulphur 15ppm

Intake and exhaust system

64

Governor type/make, standard Volvo/EMS2.3

Prefilter / Water separator micron size 10

Exhaust gas temperature after turbine at: IFN Power

See front page for important information

Max allowable back pressure in exhaust line (after turbine)

60,9

Heat rejection to exhaust at: IFN Power


Max allowable air intake restriction including piping

Pipe dimension Ø:


Max allowable temperature drop between turbine and SCR muffler inlet.SCR muffler pressure drop

Exhaust gas flow at:(temp and pressure after turbine at the corresponding power setting) IFN Power

3/19


rpm 1200 1500 1800 1900kW 7,1 7,2 7,4 7,4

BTU/min 404 409 421 421kW 113 135 144 153

BTU/min 6426 7677 8189 8701

m²foot²mmin

kW 4,0 6,0 10,0 12,0hp 5 8 14 16

literUS gal

literUS gal

Coolant pump drive/ratiol/s 3,7 4,7 5,7 6

US gal/s 1,0 1,2 1,5 1,6l/s 3,2 4,2 5,5 5,5

US gal/s 0,8 1,1 1,5 1,5kPapsi°C°F°C°F

kPapsikPapsikPapsi°C°F

literUS gal

Coolant Yellow Volvo Coolant Solution (VCS)Radiator cooling system type Closed circuit

Cooling systemHeat rejection radiation from engine at: IFN Power

Heat rejection to coolant at: IFN Power

Fan diameter 890 mm 89035,04

Standard radiator core area 0,88,61

Fan drive ratio fan Ø890 0,84:1 ccw

Fan power consumption 890 mm

6,3belt/1,41:1 cw

Coolant flow with standard system

Coolant capacity: engine 205,3

std. 0,8m² radiator with hoses 24

180fully open 92

198Maximum static pressure head(expansion tank height + pressure cap setting)

10014,5

Minimum coolant flow

Maximum outer circuit restriction incl. piping 65,09,4

Thermostat: start to open 82

Maximum top tank temperature 107225

Recommended Draw down capacity. The difference between min coolant level in the expansion tank and the lowest level where the engine's coolant system still are functioning

20,5

Minimum static pressure head(expansion tank height + pressure cap setting)

7010,2

Standard pressure cap setting 7510,9

4/19


rpm 1200 1500 1800 1900kW 47 63 62 60

BTU/min 2673 3583 3526 3412kg/s 0,38 0,5 0,52 0,52°C 163 175 170 164°F 325 347 338 327

°C 42 50 50 50°F 108 122 122 122

kPapsikPa 191 205 175 163psi 27,70 29,73 25,38 23,64m²

foot²

0,8 Pull 890 fan

rpmkWhp °C °F m3/s ft3/s Pa psi

1900 315 62 144 6,2 219,0 310 0,0450,84 428 64 147 6,7 236,6 175 0,025

66 151 7,3 257,8 0

0,8 Push 890 fan

rpmkWhp °C °F m3/s ft3/s Pa psi

1900 315 63 145 6,3 222,5 270 0,0390,84 428 64 147 6,6 233,1 185 0,027

66 151 7,2 254,3 0

Charge air mass flow IFN PowerCharge air inlet temp.(Charge air temp after turbo compressor)

IFN Power

Charge air cooler systemHeat rejection to charge air cooler IFN Power

See front page for important informationMaximum pressure drop over charge air cooler incl. piping 12

1,74Charge air pressure(After charge air cooler)

See front page for important informationMax allowable Charge air outlet temp.(Charge air temp after charge air cooler)

Engine speed Engine power Air on temp Air flow External restriction

Standard charge air cooler core area 0,88,61

Cooling performance: m² radiator andCooling air flow and maximum additional external restriction at different radiator air temperatures based on 107°C TTT and 40% coolant. Valid at 1 atm.

Cooling performance: m² radiator andCooling air flow and maximum additional external restriction at different radiator air temperatures based on 107°C TTT and 40% coolant. Valid at 1 atm.

Engine speed Engine power Air on temp Air flow External restriction

5/19


Isochronous

0Adjustable PI-constants

600-900Energized to run/Stop

On/OffOn/Off

°C 125Oil pressure kPa 25,0

kPa 275

°C 105On

kPa5

°C 120

kPa

Warning map value

+20kPa

* Off means no shut down, alarm only

Warning Alarm

Derated 0% to engine protection map

Derated 100% to engine protection map

105°C 107°C 107°C 108°C125°C 127°C 127°C 130°C

Warning map value

Alarm map value

N/A N/A

120°C 125°C 125°C 126°CWarning

map value

Alarm map value

Alarm map value

Alarm map value

Governor droopGovernor response 1Idle speed 700

Engine management systemFunctionality Alternatives Default settingGovernor mode

Engine sensors and switch settings Alarm level Engine protection

Stop functionPreheating functionLamp test

Rated speed 300 Shut down, ON/OFF*Oil level

Oil temp Setting +5 Shut down, ON/OFF*Low idle 50 Shut down, ON/OFF*

Parameter Unit Setting range Default setting Level Action.

Default/Alternative

Coolant temp 107 Shut down, ON/OFF*Coolant level See cooling system

Piston cooling pressure>1000 rpm

kPa

Water in fuel Alarm When ClosedCrank case pressure Rapid Pres inc Shut down,

Fuel feed pressure

1200rpm kPa 100

Shut down, ON/OFF*

Air filter pressure dropAltitude, above sea m Automatic derating,

see section derating

Coolant temp N/A N/AOil temp

Engine speed rpm x % of rated speed 125% of rated speed

Alarm level Shut down, ON/OFF*

Parameter Forced idle after sec

Forced shut down after 2 sec

Charge air temp 125 Shut down, ON/OFF*

Charge air pressureAlarm map value

+30kPa

High charge air temp N/A N/AHigh charge air pressure N/A N/A

N/A N/ALow oil pressure N/A Alarm map value

6/19


AHz/alternator rev.

typekWhp

flywheelstarter motor

kWA

Temperature °C 25 0 -15Battery Ah / CCA 235 / 1300 145 / 1050 145 / 1050

rpm 171 118 98A 290 400 480

kW 6,2 7,5 7,7kW 6,5 8,1 8,5

Ah / CCA

rpm 1200 1500 1800 1900Nm 2210 2030 1680 1580

(with a total added mass moment of inertia, J (mR2)≤0,05 kgm²) lbf ft 1630 1497 1239 1165max left kW 42 53 62 68

hp 57 72 84 92max down kW 36 44 52 60

hp 49 60 71 82max right kW 42 53 62 68

hp 57 72 84 92Nmlbf ft

Nmlbf ft

Nmlbf ft

Nmlbf ft

Nlbf

Starter input power during crankBattery power during crank

Power take offFront end in line with crank shaft max:*

Conditions:(4 mΩ main circuit resistance@

Min battery @ 0°C 140/800

1

Max. rear main bearing load 4000899,2

443Speed ratio direction of rotation viewed from flywheel side 1,31:1/ccwMax allowed bending moment in flywheel housing 15000

11063

Maximum torque on timing gear at rear PTO : * 1000738

Speed ratio direction of rotation viewed from flywheel side 1,31:1/ccwTiming gear at compressor PTO max:* 600

Front end belt pulley load. Direction of load viewed from flywheel side:

Timing gear at servo pump PTO max:* 10074

Speed ratio direction of rotation viewed from flywheel side 1,58:1/ccw

* Maximum allowed torque at individual PTO´s.If more then one PTO output is used simultaniusly, calculations needs to be performed to determine available maximum. Available torque depends on application inertia.

tacho output 6drive ratio 5,25

105P70 / (105P70 ISS för start/stop)

Electrical systemVoltage and type 24VAlternator: output

Starter motor:

110/150

output

Number of teeth on:

Crank speedCrank current

79,515312

Inlet manifold heater (at 20 V) 3Power relay for the manifold heater

7/19

Performance Power (kW) RpmIFN Power 315 1900

Signal Range Derating level

0,5-4,5 V 50 - 400 kPa map50-0 kΩ -40° - 130 °C 125°CDigital50-0 kΩ -40° - 140 °C 107°C0,5-4,5 V 0 -15 kPa Rapid pres

incFrequencyFrequency

575N/A

50-0 kW -40° - 140 °C 127°C

Signal Range0,5-4,5 V 50 - 400 kPa 600 1000 1200 1500 1900

363 363 363 335 290373 373 373 345 300

0,5-4,5 V 0-700 kPa 0 500 1000 1500 19001 50 200 300 3001 25 175 275 275

0,5-4,5 V 0-700 kPa 600 1000 1200 1800 1900100 100 100 300 300N/A N/A N/A N/A N/A

22323790 04

Derating

Boost pressure N/A map value+30 kPa

Sensors Alarm Alarm switch Alarm Level Condition/Delay

Soft derate VE/ Coolant level switch Alarm when closed Low

Soft derate VE/Crankcase pressure N/A Rapid pres inc ShutdownCoolant temperature

Document No Issue Index

Boost temperaure N/A 120°CSoft derate VE/

N/A 105°C

N/AEngine Speed Crank N/A Lost sign N/AEngine Speed Cam N/A Lost sign

Soft derate VE/ Oil level sensor Alarm when low level N/A N/A

Exhaust gas temp N/A 550

Soft derate VE/Oil temperature N/A 125°C

Charge Air pressureSensors Alarm rpm Map Condition Derating

Alarm Level Soft derate VE/

Shut downFuel pressure

Oil pressureWarning Level

TAD1372VE

Warning Level

Alarm Level

Alarm Level

Warning Level

8/19

22323790 04Document No Issue Index

TAD1372VE

1) Soft derate Coolant temp Speed / °C 105°C 107C 108°C Derate map R2

Remaining torque in % 600 100% 100% 85% °C 105 107 1081200 100% 100% 40% % 0 0 1001500 100% 100% 0%

2) Soft derate Oil temp Speed / °C 125°C 127°C 130°C Derate map R2


3)Soft derate Boost Temp Speed / °C 120°C 125°C 126°C Derate map R2


4)Soft derate Exhaust temp Speed / °C 550°C 560°C 575°C 580°C Derate map R2

Remaining torque in % 600 100% 100% 100% 85% °C 550 560 575 5801200 100% 100% 100% 40% % 0 0 0 1001500 100% 100% 100% 0%

Max Torque High Map R2 400 600 700 800 900 1000 1050 1100 1200 1250 13001200 1050 1225 1400 1650 2130 2130 2130 2175 2153 21301400 1450 1500 1600 1700 1800 1900 1910 20052130 2075 2005 1879 1769 1670 1583 1550 500

400 600 700 900 1050 1200 1300 1400 1450 1500 1800900 900 900 900 900 900 900 500 250 0 0

Max Torque Engine Protection Map R2

9/19

Issue Index

04Document No

TAD1372VE 22323790

0

50

100

150

200

250

300

350

0 500 1000 1500 2000 2500

kW

rpm

Power

IFN Power 315 kW

0

500

1000

1500

2000

2500

0 500 1000 1500 2000 2500

Nm

rpm

Torque

IFN Power 315 kW

10/19

Issue Index

04Document No

TAD1372VE 22323790

0

500

1000

1500

2000

2500

0 500 1000 1500 2000 2500

Nm

rpm

0m 1000m 1700m 2500m 3500m

Altitude derated Torque IFN Power 315

11/19

Issue Index

04Document No

TAD1372VE 22323790

0

100

200

300

400

500

600

700

800

900

1000

0 200 400 600 800 1000 1200 1400 1600 1800 2000

Nm

rpm

Max Torque Engine Protection Map R2

Engine protection map

12/19

Issue IndexDocument No

22323790 04TAD1372VE

190

195

200

205

210

215

600 800 1000 1200 1400 1600 1800 2000 2200

g/kWh

rpm

Fuel Consumption

IFN Power 315 kW

0

0,05

0,1

0,15

0,2

0,25

0,3

0,35

0,4

0,45

0,5

600 800 1000 1200 1400 1600 1800 2000 2200

g/kWh

rpm

Smoke emission

IFN Power 315 kW

13/19


22323790 04TAD1372VE

75

125

175

225

275

325

500 700 900 1100 1300 1500 1700 1900 2100

Fuel P (kPa)

rpm

Fuel Pressure Limits

Warning Level

250

270

290

310

330

350

370

390

500 700 900 1100 1300 1500 1700 1900 2100

CAC P abs (kPa)

rpm

Charge Air Pressure Limits

Warning Level Alarm Level

14/19


22323790 04TAD1372VE

0

50

100

150

200

250

300

350

0 200 400 600 800 1000 1200 1400 1600 1800 2000

Oil P abs (kPa)

rpm

Oil Pressure Limits

Warning Level Alarm Level

15/19


22323790 04TAD1372VE

40

50

60

70

80

90

100

110

120

20 31,5 50 80 125 200 315 500 800 1,25 2k 3,15 5k 8 12,5 20k

dB (A)

Frequency Hz

Sound power level engine body 1/3 octave band analysis

IFN Power 315 kW

9698

100102104106108110112114116118120

0 500 1000 1500 2000 2500

dB(A)

rpm

Sound power level Total sound level at full load

IFN Power 315 kW

16/19


22323790 04TAD1372VE

020406080

100120140160180200

0 1 2 3 4 5 6 7 8 9 10

Outer circuit restriction kPa

Outer circuit flow liter/s

Outer circuit restriction versus coolant flow

Max outer circuit restriction Std. Cooling system restriction

1200 rpm Eng. speed 1500 rpm Eng. speed



10,0

15,0

20,0

25,0

30,0

35,0

40,0

45,0

50,0

31,5 63 125 250 500 1000

dB (A)

Frequency Hz

SCR Muffler transmission loss

17/19


TAD1372VE 22323790 04

0

2

4

6

8

10

12

14

16

18

20

0 2 4 6 8 10 12

kW

m³/s

Standard fan Ø

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

0,2

0,4

0,6

0,8

1

1,2

1,4

1,6

1,8

0 2 4 6 8 10 12

Static pressure kPa

m³/s

Standard fan Ø

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

2

4

6

8

10

12

14

16

18

20

0 2 4 6 8 10 12

kW

m³/s

Standard fan Ø 890mm Pull 0,84:1

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

0,2

0,4

0,6

0,8

1

1,2

1,4

1,6

1,8

0 2 4 6 8 10 12

Static pressure kPa

m³/s

Standard fan Ø 890mm Pull 0,84:1

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

2

4

6

8

10

12

14

16

18

20

0 2 4 6 8 10 12

kW

m³/s

Standard fan Ø

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

0,2

0,4

0,6

0,8

1

1,2

1,4

1,6

1,8

0 2 4 6 8 10 12

Static pressure kPa

m³/s

Standard fan Ø

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

2

4

6

8

10

12

14

16

18

20

0 2 4 6 8 10 12

kW

m³/s

Standard fan Ø 890mm Pull/Push 0,84:1

1008 rpm 1260 rpm 1512 rpm 1596 rpm

0

0,2

0,4

0,6

0,8

1

1,2

1,4

1,6

1,8

0 2 4 6 8 10 12

Static pressure kPa

m³/s

Standard fan Ø 890mm Pull/Push 0,84:1

1008 rpm 1260 rpm 1512 rpm 1596 rpm

18/19

Issue Index

BSFC [g/kWh]

Fuel consumption [l/h]

04Document No

TAD1372VE 22323790

19/19

document no issue index tad1372ve 22323790 04 - mono marine

Documents