developed and circulated may 2007 driver induction blue circle southern cement berrima works

Developed and circulated May 2007

DRIVER INDUCTION

BLUE CIRCLE SOUTHERN CEMENT

BERRIMA WORKS


DRIVER CODE OF CONDUCT

• Applies to anyone driving a vehicle on Site• Requires drivers to hold current valid licenses• Provides for penalties &/or disciplinary action

to be taken for non compliance eg warning notice, suspension or cancellation of service contract or business arrangements

• Covers: times of operation, preferred routes, parking restrictions, location of school bus routes


TRUCK ENTRY/EXIT

ALL TRUCKS MUST ENTER & EXIT THE BERRIMA SITE Via GATE 2 (Security Gate) ie THE WEIGHBRIDGE ENTRY OFF TAYLOR AVE (see Green Arrow next slide)


Site Speed Limits as Signposted

50


Seat Belts Must Be Worn At All Times

When In A Vehicle


Mandatory Personal Protective Equipment (when NOT inside truck)

1. Safety Glasses2. Safety Boots3. Safety Helmet4. High Visibility (HiViz) clothing (HiViz Vest as a

minimum)5. Other designated Australian Standards approved

personal protective equipment where signposted


• Drivers are responsible for the security of their own equipment.

Plant Security

• BCSC reserves the right to search vehicles leaving the site.

• Signed authority is required to remove BCSC equipment from the site.


The following points apply to ALL employees & contractors on site:

• NO alcohol or drugs allowed on site • R.B.T & Drug Tests apply• R.B.T will apply to work groups• Drug Tests done as a blanket test• People over the limit will be asked to leave the site

Alcohol And Other Drugs Policy


The following alcohol limits apply:

Provisional license drivers <0.00% BAC

Operators of heavy vehicles <0.02% BAC

Alcohol And Other Drugs Policy cont’d


Smoking Policy

All enclosed areas within the plant and any other areas where a non-smoker may be at risk of inhaling tobacco smoke are declared

NO SMOKING AREAS


Parking RestrictionsParking is NOT permitted

Between No Parking signs or in designated No Parking Areas

On roadway between Machine Shop & No. 5 Kiln


TIPPERS!

• AFTER tipping a load, Tippers are NOT permitted to drive forward from the tipping point until the tip trailer is fully lowered.

• Non compliance may result in disciplinary action being taken, eg a request to immediately leave the site.


During Plant Emergencies

• No vehicular access permitted to site ie gates will be closed during an emergency

• Emergency Hooter will sound

• Drivers are to stop what they are doing; return to their vehicles; turn off engine; remain in cabin & contact CCR (if in possession of mobile phone)

• Await further instructions from an Emergency Warden


Environmental Requirements

• Report, contain or control all spillages. • Fuel and oil MUST NOT be allowed to enter

ducts or drains. • To report spillages contact Shift Process

Controller Ext 262 or outside/mobile 48602262


First Aid Facilities & Requirements

First Aid Room8 hours per day

Mon – Thurs 7.00am – 3.30pm

Friday 6.00am – 2.30pm

During kiln overhauls 24 hours


First Aid Facilities & Requirements

• Report all injuries to Berrima Plant First Aid Officer Ext 333 or outside/mobile calls 48602333

• Report injury to your own supervisor

• Out of normal business hours Ext 262 or outside/mobile call 48602262

developed and circulated may 2007 driver induction blue circle southern cement berrima works

Documents

berrima site

site r

site speed limits

alcohol limits

parking restrictionsparking

parking signs

bcsc equipment

security gate