arrow & osram lighting guide 2011
DESCRIPTION
Arrow & OSRAM Lighting Guide 2011 features top lighting products from OSRAM and other suppliersTRANSCRIPT
Making Bright Ideas BrilliantSM
lighting.arrowasia.com
LIGHTINGArrow Asia
Solution Guide
June 2010
艾睿照明方案手册
Arrow Asia Lighting Group
Table of Content 目录
Solid State Lighting | LED Selection Guide By Application固态照明 | LED 应用方案选择指南
Solid State Lighting | Product Highlights固态照明 | 产品亮点
OSLON SSL
OSRAM OSTAR Lighting Plus
Golden DRAGON Plus
Golden DRAGON Oval Plus
Golden DRAGON Without Lens
Advanced Power TOPLED Plus
Advanced Power TOPLED
DC/DC LED Driver | DC/DC 输入 LED 驱动器
AC Input, Low Power LED Driver | AC 高压低功率的 LED 驱动器
AC Input High Power LED Driver | AC 大功率的 LED 驱动器 (25W以上)
LENS / OPTICS for OSRAM OSLON SSL High Power LEDOSRAM OSLON SSL 系列 LED 的光学元件
PCB / MCPCB | 線路板 / 铝基板
AC/DC LED Driver Street Lamp ApplicationAC/DC LED 路灯驱动器方案
AC/DC Indoor Lighting Application | AC/DC 室內照明方案
p 1.
p 2.
p 3.
p 4.
p 5.
p 6.
p 7.
p 9.
p 8.
p10.
p11.
p12.
p13.
p14.
p15.
p16.
照明方案手册LIGHTING GUIDE 2011 照明方案手册
1
OSLON SSLGolden
DRAGON
Advanced Power
TOPLED Plus
Advanced Power
TOPLED
Power TOPLED
RGB CERAMOS MULTILEDApplications
应用
Golden DRAGON
Plus
OSRAMOSTAR Lighting
Plus
Legend:图例:
Primary Selection主要选择
Secondary Selection次要选择
Alternate Selection替代选择
Solid State Lighting | LED Selection Guide By Application固态照明 | LED 应用方案选择指南
Accent Lighting 重点照明
Bicycle Lights 自行车灯
Bulb Retrofits LED灯泡/灯泡
Can Lights (Recessed)嵌入式灯具
Channel Letters 槽型字
Colored Mood Lighting彩色情调照明
Contour (Strip) Lighting条形轮廓照明
Cove Lighting 凹槽口照明
Emergency Lighting 应急照明
Exit Signs 出口标示灯
Flashlights 闪光信号灯
Flood Lights 泛光灯
Headlights (Wearable)头灯 (可配戴式)
High Bay Lighting (Factory)高隔间照明 (工厂)
In Ground Lighting 地面照明
Landscape Lighting 景观照明
Low Bay Lighting (Parking Garage)低隔间照明 (停车库)
MR-16 ReplacementMR-16 替代品
Outdoor - Street, Tunnel, Parking and Highway Lighting 室外 – 街道、隧道、停车场和公路照明
Path Lights 路灯
Pendants 吊灯
Refrigerated Display Case Lighting冷冻展示箱照明
Shelf Lighting 玻璃层板照明
Spot Lights 射灯
Strip Lights 条灯
Theatrical Stage Lighting (Colored Light)剧场舞台照明 (彩色灯光)
Theatrical Stage Lighting (White Light)剧场舞台照明 (白光)
Under Cabinet Lighting橱柜照明
Underwater Lighting水下照明
Wall Washers (Interior and Exterior)洗墙灯 (室内及室外)
LED
LIGHTING GUIDE 2010 照明方案手册LIGHTING GUIDE 2011 照明方案手册
2
Overview of Fine Binning Scheme 精细分选方案概述
Warm White 暖白光LCW xxxx–xx–4J9X
White 白光LW xxxx–xx–1W8J
Ultra White 超白光LUW xxxx–xx–2W8G
Solid State Lighting | Product Highlights固态照明 | 产品亮点
0.44
0.39
0.34
0.29
0.24
0.25 0.30 0.35 0.40 0.45 0.50
Different White Types 不同白光类型
1
1
1
2
3
4
5
6
7
8
8
8 9
4
5
6
7
8
9
AB
CD
EF
GH
IJ
KL
MN
OP
QR S T U V W X
YZ
WX
2700K3000K
3500K
4000K
4500K
5000K
5700K
6500K
3
FEATURES(特点)• New Power Champ (typ. CRI:70), Eco Champ (typ. CRI:82), Color Champ (typ. CRI:95) for warm white• Footprint of just 3 x 3 mm• Viewing angle = 80° & 150°• Thermal resistance of RthJS (typ.) 7 K/W
APPLICATIONS(应用)• Solid state lighting, e.g. indoor/outdoor lighting, retail/shop lighting, retrofit, etc.
TA = 25°C
TA = 25°C
°C
°C
mA
Unit单位
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
°CJunction Temperature Tj结点温度 Tj
-40 ~ +110
-40 ~ +110
800
125
95
-40 ~ +110
-40 ~ +110
800
125
82
-40 ~ +110
-40 ~ +110
800
125
70
-40 ~ +110
-40 ~ +110
1000
125
70
-40 ~ +110
-40 ~ +110
1000
125
N/A
N/A
N/ATypical CRI典型 CRI
Forward Current IF正向电流 IF
K2700 - 4000 2700 - 5000 4000 - 5000 6000 - 6500CCT Range相对色温
OSLON SSL
Part型号
ForwardVoltage
正向电压VF (V)
LuminousIntensity发光强度
IV (cd)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
LA CP7P/CPDP–JXKX–24
LD CP7P/CPDP–IT2U–35
LT CP7P/CPDP–JYKZ–26
Amber琥珀
45 ~ 82lm@400mA
45 ~ 112lm@350mA
280 ~ 560mW@350mA
2.2 400
350
36
––
44
Blue蓝
Green绿
617
453
5283.2
3503.2
4002.2
LY CP7P/CPDP–HZJZ 39 ~ 71lm@400mA 31Yellow黄
590
LR CP7P/CPDP–HZKX 39 ~ 82lm@400mA 34Red红
625
LUW CP7P/CPDP–KTLP–5C8E
LCW CP7P/CPDP–KQKS–5R8T
LCW CP7P/CPDP–KQKS–5L8N
97 ~ 130lm@350mA
71 ~ 97lm@350mA
––
––
Ultra White超白
6500K
3000K
4000K
Warm White暖白
80 & 150
LCW CP7P/CPDP/CQ7P/CQDP.CC(Color Champ)
LCW CP7P/CPDP/CQ7P/CQDP.EC(Eco Champ)
LCW CP7P/CPDP/CQ7P/CQDP.PC(Power Champ)
LUW CP7P/CPDP/CQ7P/CQDPUltra White
LA/LD/LH/LT/LR/LYCP7P/CPDPColor
Parameter项目
Unit单位
Part型号
Color of Emission颜色
Wave Length 波长λD (nm) / Color
Temperature 色温
ForwardVoltage
正向电压VF (V)
LuminousIntensity发光强度
IV (cd)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
Luminous Flux光束 ΦV
• 暖白的 Power Champ (典型 CRI:70), Eco Champ (典型 CRI:82),Color Champ (典型 CRI:95)• 封装尺寸仅为 3 x 3 mm• 具有 80° 及 150° 的辐射角• 热阻 RthJS 典型值是 7 K/W
• 固态照明 例如:室内/室外照明, 零售/商铺照明,LED 灯泡等
照明方案手册LIGHTING GUIDE 2011 照明方案手册
4
FEATURES(特点)• Low thermal resistance of 3.5 K/W• 140° viewing angle ideal for secondary reflector optics• Stable brightness over lifetime• Lens design optimized for maximum package efficiency
APPLICATIONS(应用)• Shop: downlights, spots, floodlights• Home: spotlights, retrofits, task lights• Office: spotlights, downlights, task lights, indirect lighting
TA = 25°C
TA = 25°C
Parameter项目
Unit单位
Ultra White超白
White / Warm White白/暖白
-40 ~ +110
-40 ~ +110
110
100 - 700
-40 ~ +110
-40 ~ +110
110
100 - 700
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
°C
°C
°C
6000 - 6500 2700 - 4000CCT Range相对色温
K
mA
OSRAM OSTAR Lighting Plus
Part型号
Color of Emission颜色
ColorTemperature
色温
LE UW S2LN–NYPX–5C8E
LE UW S2LN–NYPX–5E8G
LE CW S2LN–NXNZ–5U8X
LE CW S2LN–NXNZ–5R8T
LE CW S2LN–NXNZ–5L7N
6500K
6000K
100 - 700
80
70 425lm@350mA
355lm@350mA
365lm@350mA
375lm@350mA
2700K
4000K
3000K
3.2
Warm White暖白
Ultra White超白
White白
140
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
Luminous Flux光束 ΦV
(Grouping Current)
ColorRendering
Index显色性 (Ra)
• 低热阻:3.5 K/W• 辐射角度 140°,易於配合光学元件• 稳定亮度• 镜片设计配合高效率封装
• 室内照明,商业及住宅用途 如聚光灯,射灯,泛光灯,传统灯泡替换,工作灯
5
FEATURES(特点)• Complete color spectrum: ultra white, white, warm white, red, green, blue and others• Junction temperature (max.): 125°C• Thermal resistance of RthJS (typ.) 7 K/W• Viewing angle: 170°• New Power Champ (typ. CRI:70) for warm white with higher brightness output
APPLICATIONS(应用)• Solid state lighting, e.g. indoor/outdoor commercial and residential architectural lighting, street lights, substitution of micro incandescent lamps, etc.
Part型号
Color of Emission颜色
ColorTemperature
色温
ColorRendering
Index显色性 (Ra)
LUW W5AM–KYLY–4C8E
LUW W5AM–KZLY–6P7R
LUW W5AM–KZLY–5F8G
LW W5AM–KYLX–5K8L
LCW W5AM–KXKZ–4J8K
LCW W5AM–KXKZ–4L8N
LCW W5AM–JZKZ–4O9Q
LCW W5AM–JZKZ–4R9T
LCW W5AM–JZKY–4U9X
6500K 82 ~ 150lm@350mA
97 ~ 150lm@350mA
82 ~ 130lm@350mA
71 ~ 112lm@350mA
71 ~ 112lm@350mA
61 ~ 112lm@350mA
61 ~ 112lm@350mA
61 ~ 97lm@350mA
97 ~ 150lm@350mA
350
6000K 70
80
80
70
5700K
5600K
4500K
4000K
3500K
3000K
LCW W5AM PC–KYLX–4H8I
LCW W5AM PC–KYLX–4J8K
LCW W5AM PC–KYLX–4L8N
82 ~ 130lm@350mA
82 ~ 130lm@350mA
82 ~ 130lm@350mA
5000K
4500K
4000K
2700K
3.2
Warm White暖白
Ultra White超白
White白
170
TA = 25°C
TA = 25°C
Parameter项目
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
Power Dissipation Ptot容许损耗 Ptot
LUW W5AM Ultra White超白
-40 ~ +110
-40 ~ +110
125
1000
3.8
Typ. CRICRI 典型值
CCT Range相对色温
70
6000 - 6500
LCW W5AM. EC(Eco-Champ)White / Warm White
白 / 暖白
-40 ~ +110
-40 ~ +110
125
4.0
1000
2700 - 5000
82
LCW W5AM. PC(Power-Champ)White / Warm White
白 / 暖白
-40 ~ +110
-40 ~ +110
125
4.0
1000
4000 - 5000
70
Unit单位
°C
°C
°C
mA
W
N/A
K
Golden DRAGON Plus
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
Luminous Flux光束 ΦV
• 完整光谱:超白、白、暖白、红、绿、蓝及 其它颜色• 最大结温 125°C• 热阻 RthJS 典型值是 7 K/W• 辐射角度∶170°• 新的 Power Champ (典型 CRI:70) 令暖白灯配有 较高亮度输出
• 固态照明 例如:室内/室外商业及住宅 建筑照明,街道照明,取代白炽灯照明等
照明方案手册
6
LIGHTING GUIDE 2011 照明方案手册
FEATURES(特点)• Viewing angle: horizontal 120°, vertical 70°• Reflow soldering• Thermal resistance of RthJS (typ.) 6.5 K/W
APPLICATIONS(应用)• Outdoor lighting, e.g. street lamp, tunnel lamp, parking lot lamp, etc.• Linear indoor applications, e.g. fluorescent replacement, floor lighting, etc.
TA = 25°C
TA = 25°C
Parameter项目
Unit单位
Ultra White超白
White / Warm White白/暖白
-40 ~ +110
-40 ~ +110
125
1000
3.8
-40 ~ +110
-40 ~ +110
125
4.0
1000
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
Power Dissipation Ptot容许损耗 Ptot
°C
°C
°C
mA
W
Golden DRAGON Oval Plus
Part型号
Color of Emission颜色
ColorTemperature
色温
LUW W5PM–KYLX–6P7R
LUW W5PM–KZLX–6P7R
LW W5PM–KXKY–7K8L
LW W5PM–KYKZ–7K8L
LCW W5PM–JYKX–5U8X
LCW W5PM–JYKY–5O8Q
LCW W5PM–JYKY–5R8T
LCW W5PM–KXKY–4L8N
LCW W5PM–KYKZ–4L8N
6500K82 ~ 130lm@350mA
71 ~ 97lm@350mA
82 ~ 112lm@350mA
52 ~ 82lm@350mA
52 ~ 97lm@350mA
52 ~ 97lm@350mA
71 ~ 97lm@350mA
82 ~ 112lm@350mA
97 ~ 130lm@350mA
350
70
80
5600K
3500K
3000K
4000K
2700K3.2
Warm White暖白
Ultra White超白
White白
70/120
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
Luminous Flux光束 ΦV
ColorRendering
Index显色性 (Ra)
• 椭圆型辐射角,水平角度 120°,垂直角度 70°• 可采用回流焊接• 热阻 RthJS 典型值是 6.5 K/W
• 室外照明,如路灯,隧道灯,停车场照明等• 线性照明,如替代荧光灯,地灯照明等
7
FEATURES(特点)• Small footprint of 1.8 mm height only• Thermal resistance of RthJS (typ.) 6.5 K/W• Full color spectrum: red, amber, yellow, true green, blue, dark blue, ultra white, white and warm white
APPLICATIONS(应用)• Lighting and signage, e.g. architectural lighting, room lighting, etc.• Automotive interior and exterior lighting• Communication, e.g. flash light for mobile phone, digital camera, etc.
TA = 25°C
TA = 25°C
Unit单位
Parameter项目
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
Red / Amber红/琥珀
-40 ~ +110
-40 ~ +110
125
1000
White / Warm White白 / 暖白
-40 ~ +110
-40 ~ +110
125
1000
Blue / Green蓝/绿
-40 ~ +110
-40 ~ +110
125
500
°C
°C
°C
mA
Part型号
Color of Emission颜色
LA W5SM–HZJZ–24
LR W5SM–HYJY–1
LY W5SM–GZJX–46
LY W5SM–GYHZ–35
LB W5SM–FYGY–35
LB W5SM–EYGX–35
LB W5SM–EYGX–24
LT W5SM–HYJZ–36
LT W5SM–JXJZ–25
LUW W5SM–JZKY–5P7R
LUW W5SM–JZKX–6P7Q
LUW W5SM–KXKY–6P7Q
LW W5SM–JYKY–JKQL
LCW W5SM–JXKX–4J8K
LCW W5SM–JXJZ–4L8N
LCW W5SM–JYJZ–4L8N
LCW W5SM–HZJZ–4O9Q
LCW W5SM–HYJX–4R9T
LCW W5SM–HZJX–4R9T
LCW W5SM–JXJY–4R9T
LCW W5SM–HYJY–4U9X
617 39 ~ 71lm@400mA
24 ~ 52lm@400mA
21 ~ 45lm@400mA
13 ~ 24lm@350mA
8.2 ~ 21lm@350mA
33 ~ 71lm@350mA
45 ~ 71lm@350mA
61 ~ 97lm@350mA
61 ~ 82lm@350mA
71 ~ 97lm@350mA
52 ~ 97lm@350mA
45 ~ 82lm@350mA
45 ~ 71lm@350mA
52 ~ 71lm@350mA
39 ~ 71lm@350mA
33 ~ 52lm@350mA
39 ~ 52lm@350mA
45 ~ 61lm@350mA
33 ~ 61lm@350mA
33 ~ 61lm@400mA400
625
590
470
528
6500K
5600K
4500K
3500K
4000K
3000K
2700K
18.3
15.6
12.6
11.0
6.2
4.9
17.5
19.1
23.7
20.7
24.3
25.0
14.0
17.6
15.2
15.0
17.0
20.5
17.8
18.5
2.2
3503.2White白
120
Red红
Yellow黄
Blue蓝
Green绿
Warm White暖白
Golden DRAGON Without Lens
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
Luminous Flux光束 ΦV
Wave Length 波长λD (nm) / Color
Temperature 色温
LuminousIntensity发光强度
IV (cd)
• 尺寸小,高度仅 1.8 mm• 热阻 RthJS 典型值是 6.5 K/W• 完整的颜色组合:红、琥珀、黄、纯绿、蓝、 深蓝、超白、白和暖白光
• 照明及标志,例如建筑物照明、房间照明• 汽车,包括外部和内部• 通讯,例如移动电话和数码相机的闪光灯等
LIGHTING GUIDE 2010 照明方案手册LIGHTING GUIDE 2011 照明方案手册
8
FEATURES(特点)• Slim package of 2.25mm height only, suitable for thin applications that need bright, homogenous lighting• Special over-casting lens• More than 125% of NTSC color gamut for RGB backlighting • Wide and stable radiation pattern
APPLICATIONS(应用)• Industry, e.g. large pixel video wall• Solid state lighting, e.g. architectural lighting• LCD backlighting – direct view and lightguide
TA = 25°C
TA = 25°C
Parameter项目
Red / Green / Dark Blue / Ultra White / Warm White红/绿/深蓝/超白/暖白
Unit单位
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
°C
°C
-40 ~ +85
-40 ~ +85
125
200
°C
mA
Advanced Power TOPLED Plus
Part型号
Color of Emission颜色
LR G5AP–BZCZ–1–1
LT G5AP–CZEX–36–1
LD G5AP–2M2N–35–1
LUW G5GP–GXHY–5C8E
LUW G5GP–GXHY–5E8G
LCW G5GP–FZHX–5J8K
LCW G5GP–FZHX–5L8N
LCW G5GP–FYHZ–5O8Q
LCW G5GP–FYGY–5R8T
LCW G5GP–FYGY–5U8X
13.8lm@100mA
24.2lm@100mA
18 ~ 39lm@100mA
15 ~ 33lm@100mA
13 ~ 33lm@100mA
13 ~ 24lm@100mA
100
2.4 ~ 4.5
3.9 ~ 8.2
7.6
7.6
6.4
6.4
6.1
5.0
5.0
20.1 ~ 35.5*
623
527
457
5700K
4500K
4000K
3500K
3000K
2700K
3.2
3.3––
2.3
Warm White暖白
Ultra White超白
145
135
Red红
Dark Blue深蓝
Green绿
6500K
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
LuminousIntensity发光强度
IV (cd)
Luminous Flux光束 ΦV
Wave Length 波长λD (nm) / Color
Temperature 色温
* Unit: mW/sr @100mA 单位 : mW/sr @100mA
• 设计纤薄,高仅为 2.25mm,适用于纤薄 且需要明亮、光线一致的应用• 采用特制透镜• RGB 背光源超过 125% 的 NTSC 色域• 出光角度宽广而均匀
• 工业,例如:大型视频墙• 固态照明,例如:建筑照明• LCD 背光照明 – 直视型
9
FEATURES(特点)• Available in red, amber, yellow, true green, blue, white and warm white• Meeting the high quality requirements of the automotive industry
APPLICATIONS(应用)• Solid state lighting, e.g. indoor and outdoor lighting, architectural lighting, decorative & entertainment light, illuminated lighting and market signs• Automotive interior and exterior lighting• Consumer, e.g. portable lighting, backlight for display
TA = 25°C
TA = 25°C
Parameter项目
Red / Yellow红/黄
Blue / Green / White / Warm White蓝/绿/白/暖白
Unit单位
Operating Temperature Range Top工作温度范围 Top
Storage Temperature Range Tstg存储温度范围 Tstg
Junction Temperature Tj结点温度 Tj
Forward Current IF正向电流 IF
Power Dissipation Ptot容许损耗 Ptot
°C
°C
-40 ~ +110
-40 ~ +110
125
200
560
-40 ~ +110
-40 ~ +110
125
1075
250
°C
mA
W
Part型号
Color of Emission颜色
LA G6SP–CBEA–24–1
LR G6SP–CADB–1–1
LY G6SP–BBDB–36–1
LB G6SP–V2BB–35–1
LT G6SP–CBEB–25–1
LW G6SP–EAFA–JKQL–1
LCW G6SP–CBEB–4J8K
LCW G6SP–CBEB–4L8N
LCW G6SP–CBEB–4O9Q
LCW G6SP–CBEA–4R9T
LCW G6SP–CAEA–4U9X
617 16.8lm@140mA
12.6lm@140mA
4.95lm@140mA
18.7lm@140mA
31.6lm@140mA
13.4lm@140mA
22lm@140mA
20lm@140mA
18.6lm@140mA
17lm@140mA
22.6lm@140mA
625
590
528
5600K
4500K
4000K
3500K
3000K
2700K
470
3.55 ~ 9
2.8 ~ 7.1
2.24 ~ 7.1
0.9 ~ 2.8
3.55 ~ 11.2
7.1 ~ 14
3.55 ~ 11.2
3.55 ~ 11.2
3.55 ~ 11.2
2.8 ~ 9
2.8 ~ 9
2.1
2.2
140
3.6
White白
120
Red红
Yellow黄
Blue蓝
Green绿
Warm White暖白
Advanced Power TOPLED
ForwardVoltage
正向电压VF (V)
ViewingAngle
光束角( °)
ForwardCurrent
正向电流IF (mA)
LuminousIntensity发光强度
IV (cd)
Luminous Flux光束 ΦV
Wave Length 波长λD (nm) / Color
Temperature 色温
• 颜色包括:红、琥珀、黄、纯绿、蓝、白和 暖白光• 符合汽车工业的严格要求
• 固态照明,例如:室内及室外照明、建筑物照 明、装饰及娱乐照明、房间照明和广告照明等• 汽车,包括外部和内部• 消费类,例如:可携式照明、显示器背光照明
照明方案手册LIGHTING GUIDE 2011 照明方案手册
10
DC/DC LED drivers include buck, boost and middle voltage input application. DC/DC LED drivers are widely used in portable lighting application as well as certain general lighting application such as solar energy powered LED lighting application, torch, projector and MR16. Arrow Lighting introduces DC/DC lighting solution with high efficiency, PWM dimming as well as high input voltage range.
DC/DC 的 LED 驱动包括降压、升压以及一些低压输入的应用。他们
如同通用照明一样,被广泛的用于各种便携式应用,如太阳能供电
的 LED 照明、手电筒、投影仪和 MR16。在 DC/DC LED 驱动方案中,
艾睿提供各种高效率、PWM 调光的方案。
* Pink highlight means best in class. 标示粉红色的表示在系列中是最好的。
** 1K pcs order price is for reference only. Please consult Arrow sales representative for quotation. 1K 报价只作参考,如阁下对产品有兴趣,请与客户代表联络再作详细报价。
TISupplier 供应商
Min. Input Voltage最少输入电压
Component Count零件总数
Topology线路结构
Number of LEDLED 数量
1K pcs ReferencePrice (USD)**参考价格
Built-in MOSFET内置 MOSFET
Package封装
NS
Remark附录
Max. Input Voltage最大输入电压
1A
35KHz -500KHz
15
SOIC8
12 - 15
700mV
No
0.75
TPS40200
4.5V
Buck
Wide inputrange, ext.MOSFET
allow highcurrent
52V
Adjustable
up to 94%
No, requireexternalcircuit
LM3404HV(LM3414HV)
Adjustable
Base onselected o/p
voltage
7
MSOP8
9
200mV
Yes(0.75 Ohm)
1.50
6V
Buck
1A
Very wideinput rangeLM3414HV
65V
75V
up to 96%
Yes
LM3409HV
6V
Adjustable
Base onRoff / Coff
15
eMPOP10
10
Nil
No
1.50
Buck
4A
up to 95%
eMPOP10improvethermal
performance
75V
Yes
TPS40211
1A
Set by ext.resistor
16
10 pin SON
10
270mV
No
0.99
4.5V
Wide inputrange, ext.MOSFET
allow highcurrent
52V
Adjustable
up to 94%
Boost,Flyback,SEPIC
No, requireexternalcircuit
LT3756
100V
100V
100KHz to 1MHz
19
QFN16,MSOP16
25
0 - 100mV
No
2.90
Depend on the external
components
94%
6V
100VIN, 100VOUT LED
Controller
Buck, Boost, Buck-Boost
Mode
PWM +Analog
ON SemiRichtek
RT8453
40V
Depend on the number of
LEDs
500KHz
5
SOP8
3 to 6
190mV
Yes BJT
0.50
Buck
90%
4.5V
1000mA
OTPthermal SD
PWM +Analog
Infineon
ILD4120
40V
Depend on the number of
LEDs
500KHz
5
DSO8
3 to 6
N/A
Yes BJT
0.65
Buck
90%
4.5V
1000mA
OVPOCP
PWM +Analog
NCL30100
18V
up to 700KHz
12
TSOP-6
5
38mV
No
0.50
Buck
up to 95%
6.35V
2A or above
Adjustable
External MOSFET
allow high current
Yes
NCP5030(buck-boost)
5.5V
700KHz
8
WDFN12
1
200mV
Yes
0.80
Buck / Boost
up to 87%
2.7V
up to 0.9A
3V to 5.5V
Buck / Boost topology
No
L6920
ST
5.5V
up to 220KHz
3
TSSOP8
1
Nil
Yes
1.20
Boost
up to 1A
Adjustable
0.6V
up to 92%
Little external component
No
LTC
LT3596
60V
16+
52-LEAD QFN
3*10
Single external resistors set
for each channel
Yes
3.65
60V Step-Down LED Driver
Buck
100mA
Depend on the number of LEDs per channel
6V
up to 90%
200KHz to 1MHz
10000:1True color
PWM + Analog
NXP
UBA3070
12V
90%
Adjustable
30KHz -125KHz
26
SO8
up to 20
0.52V
No
0.45
Buck / Boost
350mA orabove
2nd currentcontrol
Yes
190V
LM3424
4.5V
Automotive grade LED
driver AEC-Q100 Grade 1
20+
TSSOP20
10 or above
2.35V
No
1.75
Buck / Boost / SEPIC
up to 1A
up to 95%
Automotive grade LED driver AEC-
Q100 Grade 1
75V
Yes
up to 2MHz
Part No. 产品编号
Output Voltage输出电压
Max. Output Current最大输出电流
Est. Efficiency效能
Switching Frequency开关频率
Feedback Voltage反馈电压
Built-in DimmingControl调光控制
DC/DC LED Driver | DC/DC 输入 LED 驱动器
SUPPLIERS (供应商)
11
* Pink highlight means best in class. 标示粉红色的表示在系列中是最好的。
** 1K pcs order price is for reference only. Please consult Arrow sales representative for quotation. 1K 报价只作参考,如阁下对产品有兴趣,请与客户代表联络再作详细报价。
NS
LM3445 LM3450
90Vac
132V /270V
15 to 100V
8W to15W
DIP8
Userdefined
1.27V
1.55
AC/DC
Yes, Triacdimming
compatible
Yes, Triacdimming
compatible
Non-isolated
Buck
85% orabove
up to 15
No
PPFC byvalley fill,front enddimming
85V
265Vac
DC50V
100W
TSSOP-16
Freerunning
1.5V
1.85
AC/DC
Flyback
Typical80% to
85%
10 to 100
No
70:1 PWMdecoded
from phase dimmer
CY8CLED02AC
Cypress
90Vac
264Vac
DC50V
30W
85%
SO8
Max 200KHz
1.538V
Available by
request
AC/DC
up to 15
Yes, Triacdimming
compatible
Flyback
No
Resonantcontrolachieve
highefficiency /
Also available in
non-dimming
No
AC/DC
SO8
Flyback
Isense1.03V
ICL8001G
Infineon
207Vac
250Vac
DC29V
9W to12W
Freq.modulation
0.65
8
Yes, Triacdimming
compatible
up to 88%
QR flybackPF, Triacdimming
SSL2101
NXP
80Vac
132V /270V
DC50V
10W to15W
80% orabove
DIP16
Userdefined
Isense0.25V
1.80
AC/DC
10 to 15
Yes, Triacdimming
compatible
Flyback /Buck
Yes(6.5 Ohm)
Triac Dim,very goodlinearity,built-in
MOSFETand avoid
E cap
SN0901026(TPS92210)
TI
90Vac
270Vac
DC50Vmax
120W
90%
DIP8
Freq.modulation
0.7V
0.75
AC/DC
60+
Yes, Triacdimming
compatible
PFC + Flyback
No
High efficiencyand PFC,
compatiblewith Triacdimming
FairchildON Semi
Yes(10 Ohm)
DIP8
8
Flyback
85Vac
265Vac
DC50V
10W
80% to85%
100KHz
2.5V
0.36
AC/DC
No, requireexternalcircuit
FSEZ1016
Optocouplerfree design,Jitter mode
Yes(9.3 Ohm)
DIP8
Flyback
Isense1.3V
FSEZ1216
85Vac
265Vac
DC50V
10W
42KHz
0.35
AC/DC
6
No, requireexternalcircuit
70%
Fixed freq.to reduce
EMI
Yes(4.5 Ohm)
DIP8
FSQ0365
85Vac
265Vac
DC50V
25W
75%
0.7V
0.41
AC/DC
20
No, requireexternalcircuit
Flyback
Freq.modulation
Minimumfreq.
switchingincreaseefficiency
SO8
up to 15
Flyback
No
85Vac
265Vac
DC50V
80% orabove
Userdefined
Isense0.5V
0.65
AC/DC
Yes, Triacdimming
compatible
NCL30000
ON Semi
High efficiencyand PFC,
compatiblewith Triacdimming
25W
NXP
Flyback
SSL152x
80Vac
265Vac
DC50V
12W
80% to85%
DIP8 /SO14
Userdefined
2.5V
0.25 to0.44
AC/DC
10
No, requireexternalcircuit
Yes(6.5 to 48
Ohm)
Valleyswitchingincreaseefficiency
Flyback
SSL162x
70Vac
265Vac
DC50V
80% to85%
SO8
1V
0.33 to0.55
AC/DC
20
No, requireexternalcircuit
Userdefined
Valleyswitchingincreaseefficiency
25W
Yes(6.5 Ohm)
ST
No
L6562A
85Vac
DC50V
15 / 90WPFC
82% to85%
DIP8
2.5V
0.21
AC/DC
10
No, requireexternalcircuit
Boost /Flyback
Userdefined
Very highPF, Triacdimmingavailable
132V /270V
Flyback
Freq.modulation
Viper15/25
85Vac
265Vac
DC50V
6W to10W
0.5V
0.26
AC/DC
No, requireexternalcircuit
85%
10 to 12
DIP7 / SO16
QR for Valley
switching
Yes(7 Ohm)
DIP8
Flyback
2.5V
ICE3B0565J
Infineon
85Vac
265Vac
DC50Vmax
12W
67KHz
0.25
AC/DC
10
No, requireexternalcircuit
Lowest Rdsand freq.
Jitter
82% to86%
Yes(4.7 Ohm)
Yes(11 Ohm)
65KHz /100KHz /130KHz
Freq. Jitterfor EMI,creepage
for HV
DIP8
Flyback
265Vac
2.5V
NCP101X
85Vac
DC50V
7W
0.26
AC/DC
6
No, requireexternalcircuit
80% to85%
65KHz /100KHz
DIP8
Freq. Jitterfor EMI,creepage
for HV
10
Flyback
85Vac
265Vac
DC50V
15W
82% to86%
2.5V
0.50
AC/DC
No, requireexternalcircuit
NCP1027
Yes(5.8 Ohm)
Triac Dimming (可配调光器) Non-Triac Dimming (非调光)
Supplier 供应商
Min. Input Voltage最少输入电压
ACDC / DCDC
Max. Input Voltage最大输入电压
Output Voltage输出电压
Max. Output Power最大输出功率
Switching Frequency开关频率
Feedback Voltage反馈电压
Topology线路结构
Built-in DimmingControl调光控制
Number of LEDLED 数量
1K pcs ReferencePrice (USD)**参考价格
Built-in MOSFET内置 MOSFET
Est. Efficiency效能
Package封装
Remark附录
Part No. 产品编号
SUPPLIERS (供应商)
AC input low power LED driver are widely used in indoor lighting application such as LED light bulb retrofit, LED fluorescent tube replacement as well as LED ballast. Arrow lighting solution introduces various controllers and solutions which accept universal input voltage, precious current regulation and high reliability. Most of the LED driver for AC input is able to design for isolated topology which enhance design flexibility and address safety concern in LED lighting.
AC 输入的低功率驱动被广泛的应用于室内照明,如球泡灯的升级改
造,荧光灯的替换。艾睿可提供各种控制器和方案,可应用于全电
压输入、精确电流控制且具有高可靠性的特点。大多数 AC 输入的驱
动方案,可设计成隔离的路线结构,这有利于提高设计的灵活性以
及满足安规方面的考虑。
AC Input, Low Power LED Driver | AC 高压低功率的 LED 驱动器
12
LIGHTING GUIDE 2011 照明方案手册
AC Input, high power LED Driver can connect to Universal Off-Line input ( 85V to 265V AC input) directly and able to achieve high power factor correction to compile IEC power quality standard. High power LED driver can put to use in application such as outdoor lighting, architectural lighting and etc.
AC 输入的大功率 LED 驱动可直接连接到电网(85V 至 265V),除此之外,可获得高功率因素,易于满足 IEC 的标准,并且这些 LED 驱动可用于室外照明、建筑照明等。
AC Input High Power LED Driver | AC 大功率的 LED 驱动器 (25W以上)
SUPPLIERS (供应商)
* Pink highlight means best in class. 标示粉红色的表示在系列中是最好的。** 1K pcs order price is for reference only. Please consult Arrow sales representative for quotation. 1K 报价只作参考,如阁下对产品有兴趣,请与客户代表联络再作详细报价。
Supplier 供应商
Topology线路结构
Number of LEDLED 数量
1K pcs ReferencePrice (USD)**参考价格**
Built-in DimmingControl
调光控制
Package封装
Remark附录
Min. Input Voltage最少输入电压
Output Voltage输出电压
Max. Output Power最大输出功率
Switching Frequency开关频率
Feedback Voltage反馈电压
Est. Efficiency效能
Max. Input Voltage最大输入电压
ACDC / DCDC
PFC outputvoltage variesdepends on
loading
Boost / Buck
SO8
30
Self oscillating
2.5V
0.32
UCC28810
AC/DC
Transitionmode PFC
85Vac
276Vac
up to 200W
No, requireexternalcircuit
90% orabove
up to 150V
Boost / Buck
SO8
30
Self oscillating
2.5V
0.32
UCC28811
TI
AC/DC
Non-isolatedBuck
––
––
up to 200W
No, requireexternalcircuit
90% orabove
DC50V Max.
DIP8
60+
Freq.modulation
0.7V
0.8
SN0901026(TPS92210)
AC/DC
90Vac
270Vac
120W
90%
DC80V / Lowvoltage
constantvoltage source
SO16
125KHz
0.5V
0.78
SSL1750 /SSL1751
NXP
AC/DC
PFC flybackcombo chip/ Syn RectcontrollerSSL1761
70Vac
276Vac
No, requireexternalcircuit
88% to92%
DC80V / Lowvoltage
constantvoltage source
Flyback
SO8
25
63KHz
1V
0.25
SSL1530
AC/DC
Fixed freq.flyback
70Vac
265Vac
60W
No, requireexternalcircuit
86% to88%
DC80V / Lowvoltage
constantvoltage source
Flyback
DIP8
20
Free running
2.5V
0.26
NCP1207
ON Semi
AC/DC
Free runningquasi
resonantflyback
85Vac
265Vac
60W
No, requireexternalcircuit
86% to88%
DC80V / Lowvoltage
constantvoltage source
Flyback
SOIC8
20
User definedset by Ct
2.5V
0.20
NCP1351
AC/DC
Variable freq.offtimeflyback
85Vac
265Vac
No, requireexternalcircuit
84% to88%
DC80V / Lowvoltage
constantvoltage source
SOIC16
User definedset by Ct(100KHz)
0.6V
1.00
NCP1652
AC/DC
Single stageflyback PFC
85Vac
276Vac
No, requireexternalcircuit
85% orabove
DC80V / Lowvoltage
constantvoltage source
Flyback
DIP8
30
65KHz
2.5V
0.20
FAN7602
Fairchild
AC/DC
Flyback withfreq.
modulation
85Vac
265Vac
60W
No, requireexternalcircuit
84% to88%
LLC
User defined
DC80V / Lowvoltage
constantvoltage source
SO20
50 or above
N/A
0.65
ICE2HS01G
Infineon
AC/DC
LLC +Syn Rect
85Vac
265Vac
Up to 250W
No, requireexternalcircuit
95% orabove
250W 60W
PFC + FlybackPFC + Flyback(combo chip)
Flyback (PFCsingle stage)
20 to 100100 to 150
Yes, Triacdimming
compatible
High efficiencyand PFC,
compatible with Triac dimming
250W
10% to 90%input voltage
Buck
DIP8 / SOIC8
500KHz
500mV
0.60
IRS2540
AC/DC, DC/DC
AC/DC, DC/DC
Non-isolatedbuck
9V
200VDC
Yes Yes
84% to88%
10% to 90%input voltage
Buck
DIP8 / SOIC8
500KHz
500mV
0.66
IRS2541
IR
Non-isolatedbuck
9V
600VDC
84% to88%
250W >500W
50 to 100 50 to 100
Part No. 产品编号
13
For certain applications such as spotlight and torch, the viewing angle needs to be focus into a narrower angle. Thus, an optical lens or reflector cup is needed to focus the LED beams into a narrower angle. The normal single optics or lens have the viewing angles as 8, 12, 16, 20, 25, 30, 34, 36, 40, 45, Oval 8x50, 6x50, 60x120 and 50x135 degree. 3-in-1 lens and multi-in-1 lens also available currently for various application. In this page, optic products for OSRAM OSLON SSL/Golden Dragon Plus LEDs will be introduced.
对于某些应用,宽视角需要转换成较窄的光束角以达到客户所需要的要
求,使用光学透镜或者反光杯恰好可以使光束角变窄。通常单个 LED 透镜的光学角度有 8度、12度、16度、20度、25度、30度、34度、36度、40度、45度,以及椭圆的 8*50度、6*50度、60*120度、50*135度。同样
还有多合一的透镜也在很多产品中广泛使用。在这一页主要介绍可适用
于 OSRAM OSLON SSL/Golden Dragon Plus 系列的光学元件。
LENS / OPTICS for OSRAM OSLON SSL High Power LEDOSRAM OSLON SSL 系列 LED 的光学元件
FEATURES(特点)• Available in single, multi-in-1, lens with many viewing angles 可以提供各种角度和各种规格的透镜, 包括单个以及多合一
APPLICATIONS(应用)• General lighting (indoor or outdoor) 通用照明(室内和室外)• Architectural lighting 建筑照明• Industrial lighting 工业照明• Portable lighting (includes camping, bike lighting, torch light, etc) 便携式照明
Single Lens Product Offering Table(单个 LED 光学元件概要)
BENEFITS(优点)• Customer can choose the right viewing angle single lens for many of their applications from one supplier, Arrow Asia 针对客户的多种应用,艾睿都可以提供 配套产光学方案给客户
Strada-T-DW-OSL LENS SERIES (LEDIL)Dimensions = (19.6 x 15.5 x 10.7)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Screws or tapeC11425_Strada-T-DW-OSL/CA11426_Strada-T-DW-OSL-tape
Iris-OSL LENS SERIES (LEDIL)Dimensions = (D=38.0 x H=27.1)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Holder (PC), Screw mounting & Glue or Adhesive tapeCA11362_Iris-OSL-tape / CA11358_Iris-OSL-screw
Emily-OSL LENS SERIES (LEDIL) Dimensions = (D=26.00 x H=14.7)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Adhesive tape, Position pinsEmily-OSL Ordering Codes: CA1138x/CA1139x_Emily-XX-OSL
HEIDI-OSL LENS SERIES (LEDIL) Dimensions = (D=21.60 x H=11.7)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Adhesive tape & Position pinsHEIDI-OSL Ordering Codes: CA1126x_Heidi-XX-OSL
Regina-OSL REFLECTOR SERIES (LEDIL)Dimensions = (D=19.00 x H=15.30)mmMaterial = PCLight Sources = Osram Oslon SSL LEDsFastening = Position pins,(glue needed)C11347_Regina-OSL
Lisa2-Clip16-OSL LENS SERIES (LEDIL)Dimensions = (D=9.9 x H=6.6)mmMaterial = PCLight Sources = Osram Oslon SSL LEDsFastening = Snap pinsLisa2-Clip16-OSL Ordering Codes: FA1108x_Lisa2-XX-clip16-OSL
GT3-OSL LENS SERIES (LEDIL) Dimensions = (D=35.00 x H=8.9)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Position pins, (glue needed)GT3-OSL Ordering Codes: C1089x_GT3-OSL-XX
Tuija-3 LENS SERIES (LEDIL) Dimensions = (D=50.00 x H=14.5)mmMaterial = PMMALight Sources = Osram-os Oslon SSL LEDsFastening = Position pins, (glue needed)Tuija-3 Ordering Codes: C1119x_Tuija-3-XX-OSL
Cute-3-OSL LENS SERIES (LEDIL)Dimensions = (D=35.00 x H=15)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Position pins, (glue needed)Cute-3-OSL Ordering Codes: C1075x_Cute-3-XX-OSL
GT4-OSL LENS SERIES (LEDIL)Dimensions = (D=35.00 x H=8.9)mmMaterial = PMMALight Sources = Osram Oslon SSL LEDsFastening = Position pins, (glue needed)GT4-OSL Ordering Codes: C1092x_GT4-OSL-XX
Strada-C-GD LENS SERIES (LEDIL)Dimensions = (D=19.6 x 15.55 x H=6.8)mmMaterial = PMMALight Sources = Osram Golden Dragon+ LEDsFastening = Screw mounting or Adhesive tapeStrada-C-GD Ordering Codes: C1091x_Strada-C-GD
LO2-TAPE LENS SERIES (LEDIL)Dimensions = (D=21.56 x H=14.6)mmMaterial = PMMALight Sources = Osram-os Platinum/ Dragon+ LEDsFastening = Holder (PC), Adhesive tapeLO2-TAPE Ordering Codes: FA1075x_LO2-XX
LL01CR-BRxxL (LedLink) Dimensions = 19.6 x 12.5mmBeam Angle = 40OSLON
LL01CR-DGxxL (LedLink) Dimension = 28.8 x 16.5mmBeam Angle = 30, 40OSLON
LL01ED-AJxxL (LedLink)Dimension = 28.8 x 19.8mmBeam Angle = 40, 60OSLON
LL01ED-CTxxL (LedLink)Dimension = 31 x 11.2mmBeam Angle = 38OSLON
LL01OS-CBxxL (LedLink)Dimension = 25.6 x 10mmBeam Angle = 15OSLON
LL03LU-DMxxL (LedLink) Dimension = 23.1 x 10.9mmBeam Angle = 15, 253-in-1 (OSLON)
LL03LU-DOxxL (LedLink) Dimension = 35 x 10.5mmBeam Angle = 15, 25, 403-in-1 (OSLON)
LL04LU-DNxxL (LedLink)Dimension = 25.4 x 10.4mmBeam Angle = 15, 254-in-1 (OSLON)
LL06ED-ADxxL (LedLink)Dimension = 73.3 x 13.9mmBeam Angle = 25, 40, 606-in-1 (OSLON)
LL09ED-GKxxL (LedLink)Dimension = 67 x 9.8mmBeam Angle = 409-in-1 (OSLON)
LL36ED-AAxxL (LedLink)Dimension = 140 x 12.7mmBeam Angle = 4536-in-1 (OSLON)
LL03CR-EKxxL (LedLink)Dimension = 35 x 9.0mmBeam Angle = 40, 603-in-1 (Golden Dragon+)
LL06ED-ADxxL (LedLink)Dimension = 73.3 x 13.9mmBeam Angle = 25, 40, 606-in-1 (Golden Dragon+)
LL12ED-BGxxL (LedLink)Dimension = 95 x 11.2mmBeam Angle = 4012-in-1 (Golden Dragon+)
FD4-M1-D01-0 (FRAEN)Material = PMMADimension = D41.5 x 9.9mmBeam Angle = 224-in-1 (Golden Dragon)
LL01OS-HGxxL (LedLink)Dimension = 9.7 x 6mmBeam Angle = 30OSLON
LL01OS-BWxxL (LedLink)Dimension = 37.2 x 15.4mmBeam Angle = 10, 30, 56, 76Golden Dragon+
LL01ZZ-FLxxL (LedLink)Dimension = 22 x 10.6mmBeam Angle = 40, 60Golden Dragon+
LL01OS-DCxxL (LedLink) Dimension = 37.2 x 10mmBeam Angle = 56Golden Dragon+
FDG Series (FDG-x1-D01-yy)(FRAEN)Material = PMMADimension = 25 x 25 x 27mmBeam Angle = 6 - 35Golden Dragon
FDP Series (FDP-N1-D01-xx / FDP-M1-D01-xx) (FRAEN)Material = PMMADimension = 20 x 20 x 13.8mmBeam Angle = 9 - 18Golden Dragon
** Please consult Arrow sales representative for more product details. 如阁下对产品有兴趣,请与客户代表联络再作详细报价。
Multi-in-1 Lens Product List(多合一光学元件概要)
SUPPLIERS (供应商)
LIGHTING GUIDE 2011 照明方案手册
14
Due to the high current needed to drive the high-brightness LEDs, thermal management becomes increasingly important especially when the number of LED count becomes increasing. Arrow Lighting source and provide differentiated PCBs so that our customers have the world best commercially available fast heat-drain PCBs. Arrow will also provide custom IRC Anotherm board, single LED per MCPCB as well as 3 in 1 MCPCB for special customers' needs.
由于驱动高亮度 LED 需要电流高,所以散热变的越来越重要,特别是
当 LED 数量增加的时候。为了使我们的客户拥有全世界最好最快的商
用散热 PCB,艾睿照明小组开发并且提供多样化的 PCB,艾睿也会提
供给特殊客户 IRC Anotherm 散热板,单颗 LED 的铝基板和三合一的铝
基板。
PCB / MCPCB | 線路板 / 铝基板
SUPPLIER (供应商)
TYPES(种类)
FEATURES(特点)• Available in FR4 with metal base at 0.8w/m-‘K 金属衬底的 FR4,导热系数 0.8w/m-‘K• Available in MCPCB, at about 1 to 4w/m-‘K 铝基板,导热系数在 1-4w/m-‘K• Available in IRC Anotherm at 27w/m-‘K IRC Anotherm 导热系数在 27w/m-‘K
APPLICATIONS(应用)• Torch light or any single to 3 LED source of lighting 手电筒,任何带 1 到 3 颗 LED 光源
• Street lighting, park lighting 路灯、庭院灯
• General lighting 通用照明
BENEFITS(优点)• Cheap and must be used with Vias,for 1 to 2 LEDs @350mA 便宜,使用时需要 Vias,在 350mA 焊 1 到 2 颗 LED• Industrial standard, affordable price 符合工业标准,价格合理
• Better thermal MCPCB 散热比铝基板好
• Best available thermal MCPCB 最有效的散热铝基板
A) Standard Star-board, MCPCB
Star Alu PCB for OSRAM Golden Dragon Plus
B) 6 pcs OSRAM OSLON for LED Light Bulb
5cm DIA x 2mm
C) Alu PCB - 20 pcs OSRAM OSLON for Panel Light / Street Lamp
7.5cm x 7.5cm x 2mm
D) Cu PCB - OSRAM OSTAR LE UW S2W
2.5cm x 1.5cm x 2mm copper
15
LED driver is one of the key part in street lamp lighting design. It performs constant current control, protection and power conversion for the LED. As in order to design a reliable and long life LED driver. Some of the design criteria needs to be considered and are shown as follow:
LED 驱动器是路灯照明设计的关键部分之一,LED 驱动實施 LED 的恒流控制,保护功能和 AC/DC 转换。为了设计一个可靠的,寿命长的 LED 驱动器,必须考虑一些设计标准,下面将介绍这些标准:
AC/DC LED Driver Street Lamp ApplicationAC/DC LED 路灯驱动器方案
AC/DC Street Lighting Application Description - LED DriverAC/DC 路灯照明应用描述 - LED 驱动器
Outdoor Product Qualification 室外照明防水防尘等級:
EMI 电磁干扰:
Power Factor and Harmonics 功率因数和谐波:
Protection of Lighting Strokes 雷击保护:
Operating Temperature 操作温度:
Energy Star Life Time (outdoor) 能源之星寿命要求 (戶外):
Lighting Fixture Safety 照明设备安全等級:
Solution A: NXP Street Lamp LED Driver Solution 恩智浦 LED 路灯驱动方案
NXP SSL1750 AC/DC NXP UBA3070 DC/DC
90W (can redesign for 150W-200W 可重新设计为150W-200W) 15W per string 每串 15W (瓦)
PFC + Flyback 功率因数 + 反激 350mA Step Down 350mA 降压
75 - 270 Vac (伏) 90% or above 90%以上
** Overall system efficiency 84% or above 整体效能 84% 以上
Isolated flyback (3750V hipot) 反激隔离 (3750V 高压) 45V (伏)
90% or above 90%以上
EN55015 by 2 stages EMI filter 2 段 EMI 滤波
IEC1000-3-2
Peak Power 最大功率
Topology 线路结构
I/P Voltage 电压范围
Isolation 隔离
Est. Efficiency 最高效率
EMI 电磁干扰
Harmonic 谐波
Peak Power 最大功率
Topology 线路结构
Efficiency 效率
Output Voltage 输出电压
EMI FilterAC Input DCM PFC Flyback SW Flyback Tx
Opto-Isolation
2nd Rectifier
SSL1761SSL1750
Low Voltage DC
LED at350mA – 1000mA
滤波 不连续功率因素 反激开关 反激变压器 次级整流
光藕
CC Controller
UBA3070恒流控制
CC Controller
UBA3070恒流控制
CC Controller
UBA3070恒流控制
CC Controller
UBA3070恒流控制
Solution B - TI LED Driver Solution (AC/DC modular basis LED driver) 德州仪器 LED 驱动方案 (AC/DC 模塊)
120W (瓦)
Isolated flyback 反激隔离
185V - 260V
88% or above 88% 以上
EN55015 class B
IEC1000-3-2 (PF>0.9)
TI SN0901026 AC/DC Modular LED Driver
Peak Power 最大功率
Isolation 隔离
Input Voltage 电压范围
Est. Efficiency 效率
EMI 电磁干扰
PFC 功率因数
EMI FilterAC Input Flyback Tx
Flyback Tx
Flyback Tx
2nd Rectifier
2nd Rectifier
2nd Rectifier
Rectifier Flyback SW
Flyback SW
Flyback SW
Optocoupler
Optocoupler
Optocoupler
SN0901026
SN0901026
SN0901026
LED at 350mAto 700mA
LED at 350mAto 700mA
LED at 350mAto 700mA
滤波 反激开关
反激开关
反激开关
整流 反激变压器
反激变压器
反激变压器
光藕
光藕
光藕
次级整流
次级整流
次级整流
IP65 or above 或以上
EN55015 class B
IEC1000-3-2 class C
IEC1000-4-5
-20°C to 50°C
35000 hrs
IEC60598
D 1D 2D 3
D 1D 2D 3
D 1D 2D 3
D 1D 2D 3
16
LIGHTING GUIDE 2011 照明方案手册
This application note introduce the design criteria indoor lighting application and design idea of LED driver, which this includes dimming and non dimming light bulb, PAR lamp and MR16.
Arrow lighting offers various LED driver solutions for dimming application, they offer good linearity as well as electrical performance.
本应用手冊介紹了室內照明的基本概念和 LED 驱动要求,包括调光及非调光灯泡的应用。
艾睿照明提供多种可配调光器的 LED 驱动方案,它们提供良好的调光光线性及电器性能参数。
AC/DC Indoor Lighting Application | AC/DC 室內照明方案
General Requirement of Triac Dimming Solution for Indoor Lighting Application (Triac 调光室内照明方案的基本要求)
Triac Dimming LED Driver Solution (Triac 调光 LED 驱动方案)
EMI and Rectifier Flyback SW Flyback Tx 2nd Rectifier
SN0901025PrimarySensing
EMI 及整流 反激开关 反激变压器 次级整流
初级取样
EMI and Rectifier
PPFC Buck Switch
LM3445
FilterEMI 及整流
被动功率因素校正 降压开关 滤波
National Semiconductor LED driver by LM3445
EMI and Rectifier
PPFC Flyback Tx /SW
2nd Rectifier
SSL2101Optocoupler /
TL431
EMI 及整流 被动功率因素校正 反激变压器 次级整流
光藕 / TL431
EMI and Rectifier Flyback SW
反激开关2nd Rectifier
EMI 及整流 次级整流
Flyback Tx反激变压器
SecondarySensing
次级取样
Optocoupler光藕
New solution of Viper15/25 can fit PAR30 bulb
ST Viper15/25
ST LED driver by Viper15/25
Peak Power 最大功率
Topology 线路结构
I/P Voltage 电压范围
Est. Efficiency 最高效率
EMI 电磁干扰
PFC 功率因数
7W, 10W and 25W(瓦)
Isolated Flyback 反激隔離
90V - 264V (伏)
80% or above 80%以上
EN55015 class B
PF>0.9
Peak Power 最大功率
Topology 线路结构
I/P Voltage 电压范围
Est. Efficiency 最高效率
EMI 电磁干扰
PFC 功率因数
12W - 15W(瓦)
Buck (降压)
90V - 264V (伏)
80% or above 80%以上
EN55015 class B
PF>0.9
Peak Power 最大功率
Topology 线路结构
I/P Voltage 电压范围
Est. Efficiency 最高效率
EMI 电磁干扰
PFC 功率因数
10W, 15W, and (25W(瓦) SSL2102)
Isolated Flyback 反激隔離
90V - 264V (伏)
80% or above 80%以上
EN55015 class B
PF>0.9
Peak Power 最大功率
Topology 线路结构
I/P Voltage 电压范围
Est. Efficiency 最高效率
EMI 电磁干扰
PFC 功率因数
10W (瓦)
Isolated Flyback 反激隔離
90V - 264V (伏)
82% or above 82%以上
EN55015 class B
PF>0.9
TI SN0901026
NXP SSL2101
ST Viper15/25
Dimming Linearity调光线性
Dimmer Compatible List调光器的兼容性
Parallel Operation并行控制
Flickering闪烁
This is to define the linearity of light output from LED lamp as the firing angle change in Triac dimmer.通过可控硅调光器触发相位变化使 LED 的光输出达到线性的变化。The LED lamp should be able to perform the same when it is dimmed by various types of dimmer, no matter by leading and trailing edge dimmer.不论是用于前缘或后缘的相位调光,以及使用多种不同的调光器都不会影响 LED 的调光线性。For multiple lamp operation, one should expect to have the same linearity of various LED lamps when control by single dimmer.当多个 LED 灯由单一调光器驱动时,调光线性需保持一致。No flickering is expected when the LED lamp is dimmed.当 LED 灯具进行调光时,不会出现闪烁。
NS LM3445
Dim
min
g (
调光
)No
n-Di
mm
ing
(非
调光
)
R = 21mm
About Arrow AsiaA business unit of Arrow Electronics., Inc. (NYSE: ARW), Arrow Asia Pac is one of Asia Pacific’s leading electronic
component distributors. In addition to its regional headquarters in Hong Kong, Arrow Asia Pac operates 54 sales
offices, four primary distribution centers and 14 local warehousing facilities in 13 countries/territories across Asia.
Providing a full range of semiconductors, passive, electromechanical and connector products from over 200
leading international and local suppliers, Arrow Asia Pac serves more than 10,000 original equipment and contract
manufacturers and commercial customers in Asia-Pacific. Visit us at www.arrowasia.com.
About OSRAM Opto SemiconductorsOSRAM is part of the Industry sector of Siemens and one of the two leading lighting manufacturers in the world.
Its subsidiary, OSRAM Opto Semiconductors GmbH in Regensburg (Germany), offers its customers solutions
based on semiconductor technology for lighting, sensor and visualization applications. OSRAM Opto
Semiconductors has production sites in Regensburg (Germany) and Penang (Malaysia). Its headquarters for
North America is in Sunnyvale (USA), and for Asia in Hong Kong. OSRAM Opto Semiconductors also has sales
offices throughout the world. For more information, go to www.osram-os.com. OSRAM, the parent company, offers
its customers a complete supply chain in the LED sector including components, modules and solutions.
Asia Pacific
Hong [email protected]: (852) 2484 2484fax: (852) 2484 2122
[email protected] Office - Melbournetel: (61) 3 9737 4900fax: (61) 3 9737 4999
Adelaidetel: (61 08) 8333 2122fax: (61 08) 8333 2322
Brisbanetel: (61) 7 5575 7088fax: (61) 7 3216 5750
Sydneytel: (61) 2 9868 9900fax: (61) 2 9868 9901
[email protected] Office - Shanghaitel: (86) 21 2215 2000fax: (86) 21 2215 2333
Beijingtel: (86) 10 8528 2030fax: (86) 10 8528 2698
Chengdutel: (86) 28 8620 3226fax: (86) 28 8620 3223
Chongqingtel: (86) 23 6877 0466fax: (86) 23 6877 0465
Fuzhoutel: (86) 591 8784 8456 (86) 591 8784 5282fax: (86) 591 8784 5280
Guangzhoutel: (86) 20 3887 1735 (86) 20 3887 1736 (86) 20 3887 1737fax: (86) 20 3887 1739
Hangzhoutel: (86) 571 8763 1324 (86) 571 8763 4569fax: (86) 571 8763 2452
Nanjingtel: (86) 25 8470 2617fax: (86) 25 8470 2665
Ningbotel: (86) 574 8764 1932fax: (86) 574 8764 1933
Qingdaotel: (86) 532 5566 2799fax: (86) 532 5566 2611
Shenyangtel: (86) 24 2334 1176fax: (86) 24 2334 1073
Shenzhentel: (86) 755 8836 7918fax: (86) 755 8250 5200
Suzhoutel: (86) 512 6761 1929fax: (86) 512 6761 7651
Tianjintel: (86) 22 2320 1626fax: (86) 22 2320 1625
Wuhantel: (86) 27 5980 5281fax: (86) 27 5980 5283
Xiamentel: (86) 592 239 4567 (86) 592 239 4234fax: (86) 592 239 4000
Xiantel: (86) 29 8834 4048 (86) 29 8765 1125 (86) 29 8765 1126fax: (86) 29 8834 4148
Zhengzhoutel: (86) 371 6566 5757fax: (86) 371 6566 5756
Zhuhaitel: (86) 756 337 3352fax: (86) 756 337 3351
[email protected] Office - Bangaloretel: (91) 80 4135 3800fax: (91) 80 4112 7784
Chennaitel: (91) 44 4235 9002fax: (91) 44 2811 0358
Cochintel: (91) 95 6741 9262fax: (91) 44 2811 0358
Hyderabadtel: (91) 40 6677 4146fax: (91) 40 6677 4138
Kolkatatel: (91) 33 4003 4585 (91) 33 4003 4664 (91) 33 4006 8556fax: (91) 33 2283 2402
Mumbaitel: (91) 22 4091 2400fax: (91) 22 6692 1415
New Delhitel: (91) 12 0453 5500fax: (91) 12 0453 5505
Punetel: (91) 20 4015 9006fax: (91) 20 4015 9010
[email protected] Office - Tokyotel: (81) 3 3547 1861fax: (81) 3 3547 1871
[email protected] Office - Seoultel: (82) 2 2650 9700fax: (82) 2 2653 2700
Gurotel: (82) 2 2611 8400fax: (82) 2 2611 8155
SeoulExcel Tech, Inc.tel: (82) 2335 7823fax: (82) 2335 7825
[email protected] Office - Penangtel: (60) 4 229 6613fax: (60) 4 229 6623
Kuala Lumpurtel: (60) 3 7804 6313fax: (60) 3 7804 6213
New [email protected] Office - Christchurchtel: (64) 3 366 2000fax: (64) 3 366 2111
Aucklandtel: (64) 9 622 0101fax: (64) 9 272 2310
[email protected]: (632) 772 3053fax: (632) 772 3054
[email protected]: (65) 6559 8388fax: (65) 6559 8288
[email protected] Office - Taipeitel: (886) 2 7722 5168fax: (886) 2 7723 8168
Hsinchutel: (886) 3 620 1968fax: (886) 3 620 2188
Kao Hsiungtel: (886) 7 553 0868fax: (886) 7 552 9238
[email protected]: (662) 694 2332fax: (662) 694 2331
Chiang Maitel: (662) 02 694 2332
[email protected]: (84 8) 823 7850fax: (84 8) 823 7840
Arrow [email protected]
Making Bright Ideas BrilliantSM
lighting.arrowasia.com