mcil/bh (wb) impulse micro mini wet pluggable · pdf filemcil- -fs mcil- -mp mcbh- -mp mcbh-...
Post on 27-Mar-2018
256 Views
Preview:
TRANSCRIPT
1-800-327-0971Technical Bulletin 66 01 rev 0105 © 2009 Teledyne Impulse
MCIL/BH (WB)MICRO MINI WET PLUGGABLE (WATERBLOCKED)
IMPULSETELEDYNE
in event of damage to neoprene face of bulkhead.
DESCRIPTION ANDMATERIAL
CABLE
USES
GUIDELINES
Molded neoprene.Two to eight contacts.Up to 600 VDC.Up to 10,000 PSI, mated.
Inline connectors in this series are molded on a standard 24"length of cable, #20 AWG, unless otherwise specified.
Light to medium duty applications.Hazardous environments.
Lubricate mating surface with 3M Silicone Spray or equivalent,DO NOT grease! Connectors must be lubricated on a regular basis.
Avoid nicks and cuts around contacts as these are the sealingsurfaces.Elastomers can be seriously degraded if exposed to direct sunlightor high ozone levels for extended periods of time.Do not over tighten bulkhead nuts.Do not pull on cable to disconnect.Avoid sharp bends at cable entry to connector.
ORDERINGINFORMATION
Bulkhead connectors do not come with nuts and washers. Nutsand washers should be ordered separately.
Bulkhead connectors have 12" teflon leads, Type E per MIL
equivalent.Lubricate o-ring with Dow Corning #111 Valve Lubricant or
16878/4, two to four contact - #20 AWG, five to eight
All mounting surfaces require a 32 finish.
Replace o-rings when re-using connectors.
Bulkhead connector design open face pressure rated to 5000 PSI.Contacts gold plated per MIL-G-45204.
Glass reinforced epoxy puck with o-ring seal provides waterblock
contact - #22 AWG.
PLUGGABLE (WATERBLOCKED)
Technical Bulletin 66 05 1-800-327-0971 © 2009 Teledyne Impulse rev 0109
MICRO MINI WETMCIL/BH (WB)-2/3/4IMPULSETELEDYNE
**
* *
MCIL- -MPMCIL- -FS
MCBH- -MP MCBH- -FS
.37
NEOPRENE
NEOPRENE
7/16-20 UNF-2A
12" TEFLONLEADS
.50
LENGTHMATED2.9
.99
1.10
.62 DIA.
STAINLESS STEEL/ALUMINUM/TITANIUM
BRASS/
2-014O-RING
.81 HEX.31 .37
.15
LEADS12" TEFLON
.50
.31
BRASS/
ALUMINUM/TITANIUMSTAINLESS STEEL/
.81 HEX
O-RING 2-014
7/16-20 UNF-2A
2-016.41
LENGTHMATED2.9
.75
1.10
.25
.25
GLASS REINFORCEDEPOXY INSERT
O-RING
13
2
4 1
2
GUIDE PIN
2
GUIDE PIN
1
1.62
MCBH- -MP R/A MCBH- -FS R/A
* Specify number of contacts.
SLEEVES
10,000
MCDC- -MP
MCDC- -FS
not to exceed100 in/lbs
*
*
3
GUIDE PIN
.50
.87
DELRIN LOCKING
GLASS REINFORCED EPOXY INSERT
4 #12
W/ GUIDE PIN
3 #12W/ GUIDE PIN W/ GUIDE PIN
2 #12
DIA.62
.88
.75
.15
1.12 .37
O-RING
FEMALE
.41
*
.37
MCDLS-F
(MP FACE VIEW)
12" TEFLON LEADS
* Dummy plugs found on page 65 125
MATED PRESSURE RATING (psi)
DUMMY PLUG FORMCIL/BH (WB)-FS
DUMMY PLUG FOR
CONFIGURATION
MCDLS-M
CONTACT
MCIL/BH (WB)-MP
FOR MCIL/BH (WB)-FS/MPMOUNTING TORQUE
.94DIA .88*
2-014
MALE
7/16-20 UNEF-2A
.62
1.12
Technical Bulletin 66 06 1-800-327-0971
PLUGGABLE (WATERBLOCKED)
rev 0109 © 2009 Teledyne Impulse
MICRO MINI WETMCIL/BH (WB)-2/3/4-R/AIMPULSETELEDYNE
GLASS REINFORCED
.20
.99
NEOPRENE
.62 DIA.
12" TEFLONLEADS
.50
LENGTHMATED2.9
.37
1.10
NEOPRENE
STAINLESS STEEL/
EPOXY INSERT
BRASS/
7/16-20 UNF-2A
2-014O-RING
.81 HEX
2-016
.15
LEADS12" TEFLON
ALUMINUM/TITANIUM
.50
BRASS/
ALUMINUM/TITANIUMSTAINLESS STEEL/
.81 HEX
O-RING 2-014
7/16-20 UNF-2A
.37
.41
LENGTHMATED2.9
.75
1.10
.37
O-RING
MCIL- -FS
MCBH- -MP
MCIL- -MP
MCBH- -FS
*
*
*
*
.31.31
Technical Bulletin 66 11 1-800-327-0971
PLUGGABLE (WATERBLOCKED)
© 2009 Teledyne Impulse rev 0109
MICRO MINI WETMCIL/BH (WB)-5/6/8 IMPULSETELEDYNE
PLUGGABLE (WATERBLOCKED)
Technical Bulletin 66 12 1-800-327-0971 © 2009 Teledyne Impulse rev 0109
MICRO MINI WETMCIL/BH (WB)-5/6/8-R/AIMPULSETELEDYNE
MCBH- -FS R/AMCBH- -MP R/A
GLASS REINFORCED EPOXY INSERT
.37
*
2-014
7/16-20 UNEF-2A
12" TEFLON LEADS
*
O-RING
DIA .88 .94.62
DIA
.75
.15
1.12 .37 .88
.41
.62
1.12
MCDC- -MP
100 in lbsnot to exceed
MCDC- -FS
10,000
6 #155 #15 8 #15
8
* Specify number of contacts.
*
*
.87
.50 1.62
23
1 4 56
75
4 6 15
2
3
3
4
12
DELRIN LOCKINGSLEEVES
* Dummy plugs found on page 65 125
MOUNTING TORQUE
DUMMY PLUG FOR
FOR MCIL/BH (WB)-FS/MP
DUMMY PLUG FOR
MCIL/BH (WB)-FS
MCDLS-F
MATED PRESSURE RATING (psi)
MCDLS-M
CONFIGURATION(MP FACE VIEW)
FEMALEMALE
CONTACT
MCIL/BH (WB)-MP
top related