laboratory safety lisa bognar phillips bognar.6@nd.edu risk management & safety 631-5037 riskman...
Post on 25-Dec-2015
238 Views
Preview:
TRANSCRIPT
LABORATORY LABORATORY SAFETYSAFETY
Lisa Bognar Phillips
Bognar.6@nd.edu
Risk Management & Safety
631-5037
http://www.nd.edu/~riskman
Including Blood Borne Pathogens, Emergency Response, Personal Protective Equipment and Hazardous Waste Management Training
Chemical Hazards
Physical Hazards Health Hazards
There are two general hazard classes that must be evaluated when assessing the safety of a chemical:
Chemical Hazards: Physical Hazards
Compressed Gas - cylinders of compressed gas are under intense pressure.
Corrosivity – strong acids and bases can cause visible destruction of metals at the site of contact.
Flammability - both solid and liquid chemicals can serve as fuel sources to support a fire.
Reactivity - many substances will react violently if allowed contact with air, water or other chemicals. Friction, shock, light or heat can be enough to trigger some reactions.
Oxidizability – compounds that release oxygen as they decompose. React with flammables
Chemical Hazards: Health Hazards
Irritants - cause reversible inflammation of skin, eyes or nasal passages.
Sensitizers - cause allergic reaction after repeated exposures. Individual sensitivities vary.
Carcinogens - alter DNA or cause cells with altered DNA to multiply.
Systemic Toxins - typically target a specific organ or system (liver, kidney, blood, nervous system, reproductive system, etc.).
Toxins – based on dose. Anything can be poisonous.
Corrosives – cause burns to the skin, eyes, mucous membranes and respiratory tract. HF is not like typical mineral acids. It is extremely toxic and penetrates to the bone. Calcium gluconate is the only antidote that should be used on an HF burn.
Routes of EntryRoutes of Entry
Inhalation:Inhalation: The major route of entry when working with solvents. Great rapidity of absorption
Routes of EntryRoutes of Entry
Absorption:Absorption: May produce systemic poisoning. Condition of skin determines rate of entry. Examples: organic lead, solvents, (xylene, methylene chloride) organo phosphate pesticides, cyanides
Routes of EntryRoutes of Entry
Ingestion:Ingestion: Usually accidental or due to poor hygiene practices
)
Chemical Right to KnowChemical Right to Know
.MSDS Includes the following:
Product InformationFire and ExplosionToxicologyHealth EffectsPPEStorageLeaks and SpillsWaste DisposalFirst Aid
Product InformationProduct Information
Finding an MSDS
Chemical manufacturers and distributors CANNOT refuse a request for an MSDS.
There are excellent on-line MSDS databases:
http://www.hazard.com/msds/index.php
http://www.nd.edu/~riskman
University of Notre Dame Chemical Hygiene Plan (CHP) Contains information and procedures that
laboratory personnel can use to protect themselves from the chemicals they work with
First place to look for answers to questions you might have regarding chemical or laboratory issues
Located on Risk Management and Safety website http://www.nd.edu/~riskman
Topics include:- Emergency Response - Personal Protective
Eq.- Chemical compatibility -Waste Management- Standard Operating Procedures (SOPs)
Personal Protective Equipment
Gloves are required anytime you are handling chemicals, biologicals and radioactive materials
Eye protection is required anytime you are handling
chemicals, biologicals and radioactive materials
Open toed shoes do not protect your feet and ARE NOT allowed in the
laboratory. (NO FLIP FLOPS, SANDALS, etc)
Wear Eye Protection When Using:Wear Eye Protection When Using:
Glassware under reduced pressure Cryogenic materials Glassware under elevated pressure Explosives Caustics, Irritants or Corrosives Biohazards Radioactive Materials UV Light Toxic Chemicals Carcinogens Flammable Materials Lasers
Be sure you know which type of glove is appropriate for the chemical you are using
GlovesGloves
Example of wrong glove having been used
GlovesGloves
Remove soiled gloves. If gloves become soiled or contaminatedduring experiment, stop, and remove carefully.
Wash your hands and put on new pair of gloves. If you double-glove, remove soiled glove, replace with new one, and continue your work.
Safety Equipment:Chemical Fume Hood
Airflow into the hood prevents chemicals inside from migrating out into your breathing zone.
If air velocity into the hood is impeded or slowed, the hoods ability to capture chemicals is compromised.
Factors that affect airflow:
•Bulky objects inside
•Drafts
•Sash Height
Gas Cylinder Safety Storage and Handling
Gas cylinders should not be stored in exits or egress routes or blocking any safety equipment
Gas cylinders (excluding lecture bottles) should be stored in an upright position and with safety caps in place unless in use.
Use only the appropriate regulator for the gas Gas cylinders must be secured with a chain or
appropriate belt above the midpoint but below the shoulder of the cylinder
Cylinder SafetyCylinder Safety
Cylinder must be secured by chain or other steadying device
What’s Wrong in this Picture?
Electrical SafetyElectrical Safety
Eliminate frayed or worn wiring
Never stretch wires across floor or other equipment.
Staff should know location of circuit breakers
Electrical SafetyElectrical Safety
Match size of extension cord to appliance power cord to prevent cord overheating.
Extension cords are not intended for "permanent" installations -- appliances shall be connected to permanently wired receptacles.
)
Examples of Poor StorageExamples of Poor Storage
•Never store a chemical with a missing or obscured
label
Container LabelsContainer Labels
All chemicals (including solutions and chemicals transferred from their original containers) should be labeled with their common names, concentrations and hazards. Additional information such as: date received, date opened, date of expiration should also be recorded.
Label may also include: Proper handling, Storage, Emergency response
Refrigerators and FreezersRefrigerators and Freezers
Ordinary household refrigerators and freezers constitute a hazard when used for storage of flammable or unstable chemicals. These units produce conditions that can lead to explosions.
Domestic refrigerators should not be used for flammable chemical storage.
"Lab-safe" refrigerators and freezers (designed for storage of flammable liquids) must be used for flammable chemicals.
Definition
BiosafetyThe application of combinations of laboratory practice and procedure, laboratory facilities, and safety equipment when working with potentially infectious microorganisms.
We use these practices to protect the workers and those around, the product and the environment.
Laboratory Requirements
Knowledgeable supervisor Knowledgeable personnel
Aware of potential hazards Proficient in lab practices &
techniques Availability of a lab specific
biosafety manual Contact information Copies of IBC,IRB,RCC, and/or IACUC
protocols Standard Operating Procedures
For unique procedures Laboratory inspection checklist Emergency response plan
Special procedures where needed Relevant reference materials
Classification of Infectious Agents
Found in the NIH Guidelines. Classified into risk groups on
the basis of risk to the individual and to the community.
Currently, 4 risk group levels have been designated. the least risk (RG-1) to the most
risk (RG-4).
RG-1 Agents RG-2 Agents
Not associated with disease in healthy adult humans.
Generally only require a laboratory with minimal containment Biosafety Level 1
laboratory “Declaration of
Dangerous Goods” is not required for shipment.
Bacillus subtilis, Saccharomyces cerevisiae, Staphylococcus epidermidis, Escherichia coli K-12
Associated with human diseases which are rarely serious.
Preventative and therapeutic interventions are available.
Generally require a laboratory with moderate containment. Biosafety Level 2
laboratory “Declaration of Dangerous
Goods” required for shipment.
Measles virus, Salmonella spp., Toxoplasma spp., Hepatitis B virus, leshmainia, plasmodium falciparum
Biohazardous Waste Containers
Biohazardous waste containers shall be clearly marked with the universal biohazard symbol.
•Puncture-proof, leak-proof, sealable receptacles•avoid over-filling
Orange Biohazard Bags
Orange Biohazard Bags contain previously contaminated waste that has been decontaminated (autoclaved) by lab personnel. May be taken to the dumpster if brown bagged. Housekeepers WILL NOT handle these bags.
Emergency Response
Fires/accidents 911 (From a cell phone 574-631-5555)
Spills 1-5037(Risk Management and Safety)
After Hours Spills 911State the type of emergency and the exact location
of emergency.
If a chemical is involved spell the chemical name to the dispatcher.
Fire SafetyFire Safety
•Alert persons in area of fire
•Close doors to confine fire
•Activate fire alarm
•Evacuate through nearest exit
•Do not use elevators
•Move away from the building.
How to Use a Fire How to Use a Fire ExtinguisherExtinguisher
pull pinpull pin
aim at the base of the aim at the base of the firefire
squeeze handlesqueeze handle
sweep from side to sidesweep from side to side
US&A (v 2/07)
Fire Extinguisher TrainingFire Extinguisher Training
Learn how to operate a portable fire extinguisher by participating in fire extinguisher training program sponsored by Notre Dame Fire Department. Contact them at 1-6200 if you would like to take the class
Biological/Chemical Exposures
Needle Sticks:Needle Sticks:
•Wash thoroughly with soap and water
•Identify source (consent?)
Ocular Exposures:Ocular Exposures: Dermal Exposures:Dermal Exposures:
•Rinse at eyewash at least 15 minutes
•Hold eye open to ensure effective wash
•Rinse under drench shower at least 15 minutes•Remove all contaminated clothing
•Seek Medical Treatment•Your supervisor must fill out an accident/exposure form
First Aid - Chemical Burns (Eyes)First Aid - Chemical Burns (Eyes)
Forcibly open eyelids to ensure effective washing behind eyelid
Wash from nose out to ear to avoid washing chemicals back into eye or into an unaffected eye
Flood eyes and eyelids Flood eyes and eyelids with water/eye solution with water/eye solution for minimum of 15 for minimum of 15 minutes minutes
First Aid - Chemical Burns (Eyes)First Aid - Chemical Burns (Eyes)
Make sure you know the location of the nearest eyewash station.
Eye Wash MaintenanceEye Wash Maintenance
Eyewashes are periodically checked by Maintenance but are not flushed. Lab personnel must test eyewashes monthly.
Designate someone to test eye washes monthly. Let run for 1 minute
Spill ResponseSpill Response
Be prepared for emergencies
Biological Spills/Decontamination
• Cover spill with paper towels• Soak towels with disinfectant (10% Bleach is effective)
• Wait 10 minutes
• While wearing PPE, clean up the spill using paper towels
• Wipe spill area with disinfectant
• Dispose of all clean-up materials as biological waste (red bag)
Notify Risk ManagementNotify Risk Management1-5037 if you need assistance1-5037 if you need assistance
Chemical SpillsIdentify the chemical
Assess your ability to safely contain and clean up the spill:
I CANCAN safely clean it up
I CANNOTCANNOT safely clean it up
(spill size, chemical identification, PPE)
Notify coworkers and vacate/secure the area
Call 911On cell call
574-631-5555
Use spill kit to contain and clean up the spill (MSDS helps)
Notify coworkers and secure the area
Call Risk Management to confirm clean up
Chemical Waste DisposalSatellite Accumulation
Label (3 things):
•Must be labeled as soon as first drop of waste is put into the container.
•Words “waste or “hazardous waste”•Description or Name of chemical(s)
Container•Compatible and in good condition•Has “tight-fitting” closure and container is closed unless adding waste.
Secondary Containment•Must segregate incompatibles•One container per waste stream
US&A (v 2/07)
Hazardous Waste Disposal RulesHazardous Waste Disposal Rules
Do not use chemical symbols or abbreviations when labeling your containers
Generator Signs
Faculty name printed
4 Liters
Chemistry 341
Acetone 20
Methanol 40
Abbreviations and formulas NOT acceptable
Person who generates waste signs form
RM&S use ONLY
All other waste…
Gloves, paper, etc:disposed of in regular (clear) trash bags and bags are to be removed by custodians daily.
Broken Glass: if clean, should be disposed of in a puncture proof box marked “Broken Glass”.
Laboratory Security
There are extremists who vandalize workplaces where they suspect animal research is being conducted and others who identify sources for chemicals/ biologicals to be used in terrorism or illegal drug production
Protect your lab and your research:
• NEVER prop open any card or key access corridor doors.•Don’t let people ‘piggy-back’ to gain access to restricted areas.• Keep your lab doors closed and locked when unattended.•Question strangers, and report suspicious activity to campus security.
Emergency Phone Numbers
• Security 911 or 631- 5555 from cell• Risk Management & Safety 1-5037• ND Fire 1-6200
top related