compare these features 98 cast iron series “flow-mate”

COMPARE THESE FEATURES • Non-cloggingengineeredplasticvortex

impellerdesign• Corrosionresistantpowdercoatedepoxy finish• Durablecastconstruction.Castswitch

case,motor,pumphousingandbase.Nosheetmetalpartstorustorcorrode.

• Castings-Allcastironclass25-3025000#tensilestrength

• Stainlesssteelscrews,guard,handle,armandsealassembly

• Floatoperated2-polemechanicalswitch• Motor-Permanentsplitcapacitor,60Hz,

1725RPM,oil-filled,hermeticallysealed,automaticresetthermaloverloadprotection

• Bearings-Upper&loweroilfedcastiron• Carbonandceramicshaftseal• Entireunitpressuretestedafterassembly.• Watertightneoprene“”ringbetween motorandpumphousing• Maximumtemperatureforeffluentor dewatering130°F-54°C• Passes½inchsphericalsolids• Noscreenstoclog• Standardcordlength15ft.(ULListed)• 1½"NPTDischarge(1½"X2"PVCAdapter

includedwithBN&BEModels)• Onpoint-9½"• Offpoint-3"• Majorwidth-101/8"• Height-12"SIMPLEX AND DUPLEXSYSTEMS AVAILABLE

PACKAGED SYSTEMSAVAILABLE

Note: The sizing of effluent systems normally requires variable level float(s) controls and properly sized basins to achieve required pumping cycles or dosing timers with nonautomatic pumps.

SECTION: 2.20.035FM0973

0114Supersedes

0312

98 Cast Iron Series

“FLOW-MATE”(FOR PUMP PREFIX IDENTIFICATION SEE NEWS & VIEWS 0052)

MODEL BN98

MODELS AVAILABLE• Automatic or Nonautomatic• ½ HP, 1 Ph., 115V or 230V• Available with Piggyback Variable Level Float Switch.

MODEL 98

FORSEPTICTANKLOWPRESSUREPIPE(LPP)

ANDENHANCEDFLOWSTEPSYSTEMS

EFFLUENTOR DEWATERING PUMP

SUBMERSIBLE1½" NPT DISCHARGE

©Copyright2014ZoellerCo.Allrightsreserved.

R LU R

TestedtoULStandardUL778andCertifiedtoCSA

StandardC22.2No.108

Product information presented here reflects conditions at time of publication. Consult factory regarding discrepancies or inconsistencies.

MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961

(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624

visit our web site:www.zoeller.com

®

Your Peace of Mind is Our Top Priority ®

12 1/16"

4 21/32" [11.8cm]

3 7/8" 6 1/4"

3 7/8" [9.8cm]

4" [10.2cm]

4 5/8"

1-1/2" NPT

[30.6cm]

[15.9cm][9.8cm]

[11.7cm]

RESERVE POWERED DESIGNForunusualconditionsareservesafetyfactorisengineeredintothedesignofeveryZoellerpump.

SK1102

©Copyright2014ZoellerCo.Allrightsreserved.

10 20 30 40 50 60 70 80

5

10

15

20

25

0

0

80 160 240

2

4

6

GALLONS

LITERS

FLOW PER MINUTE

MET

ERS

FEET

TOTA

L DY

NAM

IC H

EAD

PUMP PERFORMANCE CURVEMODEL 98

98

TOTAL DYNAMIC HEAD/FLOWPER MINUTE

EFFLUENT AND DEWATERING

95170231273

Liters

23 ft.(7.0m)Shut-off Head:20 7.1 25

Meters

1510

Feet5

4.63.01.5

MODEL

6172Gal.

45

009971

CAUTIONAll installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).

For information on additional Zoeller products refer to catalog on Piggyback Variable Level Switches, FM0477; Electrical Alternator, FM0486; Mechanical Alternator, FM0495; Sump/Sewage Basins, FM0487; Single Phase Simplex Pump Control, FM1596; Alarm Systems, FM0732.

SELECTION GUIDE

1.Integralfloatoperatedmechanicalswitch,noexternalcontrolrequired.2.Forautomaticusesinglepiggybackvariablelevelfloatswitchordoublepiggybackvariablelevelfloatswitch.RefertoFM0477.

3.SeeFM1228forcorrectmodelofsimplexcontrolpanel.4.SeeFM0712forcorrectmodelofduplexcontrolpanelorFM1663foraresidentialalternatorsystem.

98 Series Control Selection Model Volts-Ph Mode Amps Simplex Duplex M98 115 1 Auto 9.4 1 4 N98 115 1 Non 9.4 2or3 4 D98 230 1 Auto 4.7 1 4 E98 230 1 Non 4.7 2or3 4

CONSULT FACTORY FOR SPECIAL APPLICATIONS

• Electricalalternators,forduplexsystems,areavailableandsuppliedwithanalarm

• Mechanicalalternators,forduplexsystems,areavailablewithorwithoutalarmswitches

• Variablelevelfloatswitchesareavailableforcontrollingsingleandthreephasesystems

• Doublepiggybackvariablelevelfloatswitchesareavailableforvariablelevellongcyclecontrols

• RefertoFM1922andFM0806fortemperaturesabove130°F

OPTIONAL PUMP STAND P/N 10-2421• Reduces potential clogging by debris.• Replaces rocks or bricks under the pump.• Made of durable, noncorrosive ABS.• Raises pump 2" off bottom of basin.• Provides the ability to raise intake by adding sections of 1½"

or 2" PVC piping.• Attaches securely to pump.• Accommodates sump, dewatering and effluent applications.NOTE: Make sure float is free from obstruction.

"Easy assembly" (pump & discharge pipe not included.)

MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961

(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624

Your Peace of Mind is Our Top Priority ®

® visit our web site:www.zoeller.com