air quality permitting issues with portable\temporary internal
TRANSCRIPT
Air Quality Permitting Issues with Portable\Temporary Internal
Combustion Engines
September 1, 2011
Robert Hammer Air Quality Program Manager ALTUS Environmental, LLC
1
Examination
Stationary Source Air Permitting Programs
Is a Portable\Temporary Internal Combustion Engine (ICE) a “Stationary Source”?
(Stationary vs. Mobile\Nonroad)
Is a Permit Required?
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
2
I texted my wife the other day: “We should open a business of our own. I’d like to open a stationary store.”
She texted me back: “Bad idea! That business would go nowhere. Oh…did you mean stationery? ” 1
1Be aware that this slide, portraying a fictitious event, was reviewed by my wife and received her approval with the understanding that I, Robert Hammer, will be the butt of the joke. I take no responsibility should this humor be shared in any other form.
It’s possible that any of you could be contacted as a witness in my defense, should information to the contrary reach my wife.
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
3
A Key Question:
What Does Stationary Mean?
Well…………how’s it being applied?
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
4
Presentation Focus is on ICE 1. Air Permitting Overview
2. Stationary ICE
3. Permitting Requirements for Portable\Temporary
ICE
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
5
Presentation Focus is on ICE
Size Matters
This Presentation Assumes the ICE are Large Enough to Require Permitting
See the Applicable Regulations
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
6
1. Air Permitting Overview
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
7
Key Factors in Air Permitting
Type of Source
Source Size
Type of Emission
Hours of Operation
Emission Level
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
State\Local Regulations
Federal Regulations
Air Quality Attainment Status
8
Source Categories
Portable
Temporary
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Point
Fugitive
Stationary
Mobile
Nonroad
9
Air Permitting Regulations State\Local Specific At least Meet Federal Requirements
Typically Focus on “Stationary” Sources State Regulations Might Not Specify “Stationary
Source” Everywhere May Only Specify “Source”
May Have Unique Requirements for Portable and\or Temporary Sources
Exempts “Mobile” Sources Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
10
2. Stationary Source
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
11
Does “Stationary” Mean Stationary
Stationary
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Mobile
Portable\Temporary
12
According to www.dictionary.com Stationary Standing Still; not Moving.
Having a Fixed Position; not Movable.
Established in One Place; not Itinerant or Migratory.
Remaining in the Same Condition or State; not Changing
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
13
“Stationary”: 1990 Clean Air Act Amendments (CAAA)
(z) Stationary Source.— The term “stationary source” means generally any source of an air pollutant except those emissions resulting directly from an internal combustion engine for transportation purposes or from a nonroad engine or nonroad vehicle as defined in section 7550 of this title. (Title III, General Provisions, Section 302, Definitions, paragraph (z) (CAA 302(z)))
Ties Back to: New Source Performance Standards (NSPS) for ICE
National Emission Standards for Hazardous Air Pollutants (NESHAP) for ICE
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
14
ICE Federal NSPS and NESHAP
NSPS IIII - Standards of Performance for Stationary Compression ICE
NSPS JJJJ - Standards of Performance for Stationary Spark Ignition ICE
NESHAP ZZZZ – NESHAP for Stationary Reciprocating ICE
Each Applies to “Stationary” not “Mobile”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
15
Connections in ICE NSPS and NESHAP
Stationary
Mobile
Nonroad (40 CFR 1068.30)
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
16
“Stationary ICE”: ICE NSPS and NESHAP
Definition in NSPS IIII, NSPS JJJJ, and NESHAP ZZZZ Nearly Identical
40 CFR 60.4219 (NSPS IIII): “Stationary internal combustion engine means any internal combustion engine, except combustion turbines, that converts heat energy into mechanical work and is not mobile. …..”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
17
“Stationary ICE”: ICE NSPS and NESHAP
“Stationary” ICE “Is Not Mobile”
Makes Sense!
So……….
What does “Mobile” Mean?
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
18
What Does “Mobile” Mean? According to EPA Website: Mobile Source
Emissions - Past, Present, and Future, Glossary http:www.epa.gov/oms/invntory/overview/definitions.htm
“Mobile Sources: Motor vehicles, engines, and equipment that move, or can be moved, from place to place. Mobile sources include vehicles that operate on roads and highways ("on-road" or "highway" vehicles), as well as nonroad vehicles, engines, and equipment. Examples of Mobile Sources are cars, trucks, buses, earth-moving equipment, lawn and garden power tools, ships, railroad locomotives, and airplanes.”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
19
What Does “Mobile” Mean?
Mobile = Onroad + Nonroad
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
20
What Does “Mobile” Mean?
ICE NSPS and NESHAP Don’t Directly Define “Mobile”, but Say that
“Stationary” is Not “Nonroad”
40 CFR 60.4219 (NSPS IIII): “….Stationary ICE differ from mobile ICE in that a stationary internal combustion engine is not a nonroad engine as defined at 40 CFR 1068.30 (excluding paragraph (2)(ii) of that definition), and is not used to propel a motor vehicle or a vehicle used solely for competition. Stationary ICE include reciprocating ICE, rotary ICE, and other ICE, except combustion turbines.”
Similar to CAA Definition of “Stationary”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
21
What Does “Nonroad Engine” Mean? NSPS IIII Reference: 40 CFR 1068.30 says
“Nonroad Engine” Means:
“…portable or transportable, meaning designed to be and capable of being carried or moved from one location to another…”
Unless “…remains or will remain at a location for more than 12 consecutive months or a shorter period of time for an engine located at a seasonal source. …” “…replaces an engine at a location and that is intended to perform the same or similar function as the engine replaced will be included in calculating the consecutive time period….”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
22
ICE NSPS and NESHAP Stationary vs. Mobile vs. Nonroad
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Mobile
Nonroad
Stationary YES
NO
NO
Implied
Stipulated
23
“Stationary”: State\Local
Depends on Their Regulations
But, May Only Reference “Source” not “Stationary Source” in Some Places
References to New Source Review (NSR) will specify “Stationary Source” Major Source
Major Modification
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
24
If an ICE Can Be Moved is it “Stationary”?
It’s Possible To Move a “Stationary Source”
Depending on the Circumstances, the Same ICE Could Be Either: Stationary, or
Mobile (Nonroad), or
Change from one to the other
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
25
Portable\Temporary ICE Stationary
or Nonroad (reporting\permitting required)
or Mobile\Nonroad (exempt)
Are there State\Local Regulatory Definitions of a “Portable” Source?
Does State\Local Regulatory Definition of “Source” Still Exclude “Nonroad” ICE?
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
26
3. Permitting Requirements for Portable\Temporary ICE
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
27
Portable\Temporary ICE Permitting Check State\Local Regulations (see examples)
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Type Mobile\Nonroad
Why? Replacement?
How Temporary? Length of Time
Seasonal?
Emission Level?
Established Policies for Federal Minor NSR Program? (Other than Nonroad Stationary)
28
Do Portable\Temporary ICE Need Permits Depending on Factors Such as: State\Local and Federal Jurisdiction
Stationary or Nonroad Designation
Size (hp)
Operating Hours
Emissions Level
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
29
Do Portable\Temporary ICE Need Permits
State\Local Permitting Is it Stationary or Nonroad?
Specific to Their Regulations Is your Source a “Stationary Source” According to the
Agency’s Regulations?
Do the Agency’s Regulations Only Require “Stationary Sources” to Obtain Permits?
• Do they exempt Nonroad sources?
Look at Other Exemptions in the Agency’s Regulations?
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
30
Do Portable\Temporary ICE Need Permits Federal Major and Minor New Source Review (NSR)
and Title V Permitting Stationary – Possibly (Size, Emission Levels?)
Mobile\Nonroad - No
“Nonroad engines are a category of units/equipment that, under the Clean Air Act Section 302(z), are excluded from the definition of “stationary source,” and, hence, are exempt from stationary source permitting requirements, i.e., Title V (e.g., garden tractors, off-highway mobile cranes and bulldozers).” (U.S. EPA Region IX Letter to the Law Office of Marc Chytilo, December 14, 2001) http://epa.gov/airquality/permits/response/ca-chytilo.pdf
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
31
Examples
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
32
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ
Colorado (Page 1 of 6)
“Stationary Source” (Reg. 3 Part A I.B.43)
“….Those emissions resulting directly from an internal combustion engine for transportation purposes or from a non-road engine as defined in Section I.B.29. of this Part shall not be considered a stationary source. …”
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
33
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ
Colorado (Page 2 of 6)
Air Pollution Emission Notice Regulations Stipulate “Stationary Source” (Reg. 3 Part A I.B.43)
Construction Permit Regulations Stipulate “Stationary Source” (Reg. 3 Part B II.A.1)
Nonroad Engines are not subject to Construction Permit Program under Reg. 3 part B
But……….
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
34
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ
Colorado (Page 3 of 6)
“While agreeing that non-road engines should not be treated as stationary sources, the Division expressed a concern that a large aggregation of these engines might result in a violation of ambient air quality standards. To reconcile these conflicting concerns the regulatory revisions create a new state-only non-road engine program for certain non-road engines.”
(Regulation 3, PART G STATEMENTS OF BASIS, SPECIFIC STATUTORY AUTHORITY AND PURPOSE I.DD., Adopted July 18, 2002, Revisions to Regulation Number 3)
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
35
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ
Colorado (Page 4 of 6) Nonroad Engine Definition Parallels NSPS IIII and
JJJJ and NESHAP ZZZZ (Reg. 3 Part A I.B.31.a and I.B.31.b)
Nonroad Engine Definition also Stipulates a Permitting Program
(Reg. 3 Part A I.B.31.c and I.B.31.d)
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
36
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ Colorado (Page 5 of 6) Nonroad Permitting
Nonroad Engines not Co-located at an Existing Major Source (Reg. 3 Part A I.B.31.c):
• That Have ≥ 1,200 hp and Operate > 4,380 hours per year at the Same Location must then Submit an Air Pollution Emission Notice (APEN) and Pay a Fee
• If NOX ≥ 100 tpy, CO ≥ 100 tpy or SO2 ≥ 40 tpy then Obtain Site-specific Temporary State Only Nonroad Engine Permit
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
37
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ Colorado (Page 6 of 6) Nonroad Permitting
Nonroad Engines which are Co-located at an Existing Major Source of NOX and SO2 (Reg. 3 Part A I.B.31.d):
• That Have ≥ 1,200 hp must then Submit an APEN and Pay a Fee
• If NOX ≥ 40 tpy, CO ≥ 100 tpy or SO2 ≥ 40 tpy then Obtain Site-specific Temporary State Only Nonroad Engine Permit
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
38
Texas, Arizona, and Washington
No Permit Required for Nonroad ICE
Be Sure to Document that the Source is and REMAINS a “Nonroad” ICE
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Is a Permit Required for ICE if Not a “Stationary Source” Defined in IIII/JJJJ/ZZZZ
39
Arizona Nonroad Engine Checklist Slide 1 of 4
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
40
http://www.azdeq.gov/environ/air/permits/download/nonroad.pdf
Arizona Nonroad Engine Checklist Slide 2 of 4
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
41
Arizona Nonroad Engine Checklist Slide 3 of 4
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
42
Arizona Nonroad Engine Checklist Slide 4 of 4
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
43
Example Portable ICE Permitting Programs
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
44
SUMMARY Portable\Temporary ICE Could be Either:
Stationary
Nonroad (requiring a permit)
Mobile\Nonroad (No permitting)
Stationary can become Mobile\Nonroad
Mobile\Nonroad can become Stationary
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
45
SUMMARY Permitting Programs Vary Mobile\Nonroad could be exempt
Look at State\Local and Federal Regulations
May Depend on:
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
Size (hp) Operating Hours Emissions
Level
Why? • Replacement?
How Temporary? • Length of Time
Seasonal?
46
??????????
Robert Hammer (720) 215-4730
[email protected] www.altusenviro.com
Robert Hammer, Rocky Mountain AWMA Meeting, September 1, 2011
47