9-877-534-04+hcd-gx450
TRANSCRIPT
SERVICE MANUAL
Sony CorporationHome Audio Division
Published by Sony Techno Create Corporation
HCD-GX450US Model
Canadian Model
MINI HI-FI COMPONENT SYSTEM9-877-534-042006J16-1
© 2006.10
• HCD-GX450 is the tuner, deck, CD andamplifier section in MHC-GX450.
SPECIFICATIONS
Ver. 1.3 2006.10
Amplifier section
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION:
With 6 ohm loads, both channels driven, from 120 – 10,000 Hz: rated 125 watts per channel minimum RMS power, with no more than 10% total harmonic distortion from 250 milliwatts to rated output.Front speakerContinuous RMS power output (reference):
125 + 125 watts (6 ohms at 1 kHz, 10% THD)
Total harmonic distortion less than 0.07% (6 ohms at 1 kHz, 60 W)
Sub wooferContinuous RMS power output (reference):
150 watts (6 ohms at 50 Hz, 10% THD)
Total harmonic distortion less than 0.07% (6 ohms at 50 Hz, 75 W)
CD player sectionSystem Compact disc and digital
audio system
Laser Semiconductor laser (λ=780 nm)
Emission duration: continuous
Frequency response 2 Hz – 20 kHz (±0.5 dB)Wavelength 780 – 790 nmSignal-to-noise ratio More than 90 dBDynamic range More than 90 dB
Tape deck sectionRecording system 4-track 2-channel, stereoFrequency response 50 – 13,000 Hz (±3 dB),
using Sony TYPE I cassettes
Tuner sectionFM stereo, FM/AM superheterodyne tuner
FM tuner sectionTuning range 87.5 – 108.0 MHz
(100-kHz step)Antenna FM lead antennaAntenna terminals 75 ohms unbalancedIntermediate frequency 10.7 MHz
AM tuner sectionTuning range 530 – 1,710 kHz
(with the tuning interval set at 10 kHz)531 – 1,710 kHz (with the tuning interval set at 9 kHz)
Antenna AM loop antennaAntenna terminals External antenna terminalIntermediate frequency 450 kHz
GeneralPower requirements 120 V AC, 60 HzPower consumptionUSA models: 265 watts
Canadian models: 330 VADimensions (w/h/d) incl. projecting parts and controls Amplifier/Tuner/Tape/CD section:
Approx. 280 × 327 × 425 mm
Mass Approx. 10.0 kg
Design and specifications are subject to change without notice.
Former Type Models New Type Models
Model Name Using Similar Mechanism New NewCD
CD Mechanism Type CDM74-F1BD81 CDM74KF-K6BD81CSection
Optical Pick-up Name KSM-215DCP/C2NP KSM-213DCP/C2NP
Tape deck Model Name Using Similar Mechanism New New
Section Tape Transport Mechanism Type CWM43FF-05 CWM43FF-05
2
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITHMARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTSLIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESECOMPONENTS WITH SONY PARTS WHOSE PART NUMBERSAPPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTSPUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORTÀ LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LESDIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONTCRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NEREMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONYDONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OUDANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
After correcting the original service problem, perform thefollowing safety checks before releasing the set to the customer:Check the antenna terminals, metal trim, “metallized” knobs, screws,and all other exposed metal parts for AC leakage. Check leakage asdescribed below.
LEAKAGE
The AC leakage from any exposed metal part to earth groundand from all exposed metal parts to any exposed metal part havinga return to chassis, must not exceed 0.5 mA (500 microamperes).Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCAWT-540A. Follow the manufacturers’ instructions to use theseinstruments.
2. A battery-operated AC milliammeter. The Data Precision 245digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of aVOM or battery-operated AC voltmeter. The “limit” indicationis 0.75 V, so analog meters must have an accurate low-voltagescale. The Simpson 250 and Sanwa SH-63Trd are examples ofa passive VOM that is suitable. Nearly all battery operateddigital multimeters that have a 2V AC range are suitable. (SeeFig. A)
SAFETY CHECK-OUT
HCD-GX450
The release method of a CD disc tray LOCK function
There is a disc lock function for the disc theft prevention for ademonstration at a shop front in this machine.Procedue:1. Press the ?/1 button to turn the set on.2. Press two buttons of x and Z (EJECT) simultaneously for
five seconds.3. The message “LOCKED” is displayed and the tray is locked.
(Even if exiting from this mode, the tray is still locked.)4. Press two buttons of x and Z (EJECT) simultaneously for
five seconds again.5. The message “UNLOCKED” is displayed and the tray is
unlocked.6. To exit from this mode, press the ?/1 button to turn the set
off.
To Exposed Metal Parts on Set
0.15 µF 1.5 kΩACVoltmeter(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
Unleaded solderBoards requiring use of unleaded solder are printed with the lead-free mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size.)
: LEAD FREE MARKUnleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350°C.Caution: The printed pattern (copper foil) may peel away if theheated tip is applied for too long, so be careful!
• Strong viscosityUnleaded solder is more viscous (sticky, less prone to flow) thanordinary solder so use caution not to let solder bridges occur suchas on IC pins, etc.
• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.
3
HCD-GX450
This appliance is classified as a CLASS 1 LASER product. TheCLASS 1 LASER PRODUCT MARKING is located on the rearexterior.
Laser component in this product is capableof emitting radiation exceeding the limit forClass 1.
CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous radiationexposure.
Notes on chip component replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing• Keep the temperature of soldering iron around 270˚C
during repairing.• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).• Be careful not to apply force on the conductor when soldering
or unsoldering.
NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostaticbreak-down because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic break-down and alsouse the procedure in the printed matter which is included in therepair parts.The flexible board is easily damaged and should be handled withcare.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission,observe from more than 30 cm away from the objective lens.
TABLE OF CONTENTS
1. SERVICING NOTE ·························································· 4
2. GENERAL ·········································································· 6
3. DISASSEMBLY3-1. Cover (Top) ····································································· 93-2. CD Door ·········································································· 93-3. Front Panel Section ······················································· 103-4. CD Mechanism Deck (CDM74-F1BD81) ···················· 103-5. Tape Mechanism Deck, Game Jack Board ··················· 113-6. PANEL Board ······························································· 113-7. Back Panel Section, SUB-TRANS Board ···················· 123-8. Power Transformer ······················································· 123-9. MAIN Board ································································· 133-10. SUB-WOOFER Board ················································ 133-11. AMP Board ································································· 143-12. BD81A Board ····························································· 143-13. CONNECT Board ······················································· 153-14. DRIVER Board, SW Board ········································ 153-15. Optical Pick-up (KSM-215DCP/C2NP) ····················· 163-16. SENSOR Board ·························································· 163-17. MOTOR (TB) Board ··················································· 173-18. MOTOR (LD) Board ·················································· 17
4. TEST MODE ···································································· 18
5. DIAGRAMS5-1. Block Diagrams – PANEL Section – ···························· 22
– MAIN Section – ······················································· 23– BD/DRIVER Section – ············································ 24– SUB-WOOFER Section – ········································ 25
5-2. Printed Wiring Board – BD81A Section – ··················· 265-3. Schematic Diagram – BD81A Section – ····················· 275-4. Printed Wiring Board
– CD MECHANISM Section – ··································· 285-5. Schematic Diagram – CD MECHANISM Section – ··· 295-6. Printed Wiring Board – MAIN Section – ···················· 305-7. Schematic Diagram – MAIN Section (1/2) – ·············· 315-8. Schematic Diagram – MAIN Section (2/2) – ·············· 325-9. Printed Wiring Board – PANEL COMB Section – ······ 335-10. Schematic Diagram – PANEL COMB Section – ······ 345-11. Printed Wiring Board – SUB-WOOFER Section – ··· 355-12. Schematic Diagram
– SUB-WOOFER Section – ········································ 365-13. Printed Wiring Board – PANEL Section – ················· 375-14. Schematic Diagram – PANEL Section (1/2) – ·········· 385-15. Schematic Diagram – PANEL Section (2/2) – ·········· 395-16. Printed Wiring Board – TRANS Section – ················ 405-17. Printed Wiring Board – AMP Section – ····················· 415-18. Schematic Diagram – AMP POWER Section – ········ 425-19. IC Pin Function Description ······································· 46
6. EXPLODED VIEWS6-1. MAIN Section ······························································· 516-2. Front Panel Section ······················································· 526-3. MAIN Board Section ···················································· 536-4. CD Mechanism Deck Section -1 (CDM74-F1BD81) ··· 546-5. CD Mechanism Deck Section -2 (CDM74-F1BD81) ··· 55
7. ELECTRICAL PARTS LIST ······································· 56
4
HCD-GX450SECTION 1
SERVICING NOTE
• SERVICE POSITION -1 (AMP BOARD)
front panel
CD mechanism deck
AMP board
To inspect the AMP board, turn both of the front panel and the CD mechanism deck so that the left side of the product faces down.
5
HCD-GX450
• SERVICE POSITION -2 (BD81A BOARD)
BD81A board
CD mechanism deck
Remove the CD mechanism deck and place it on top of the pedestal as shown.Inspect the BD81A bard in this set up.
6
HCD-GX450SECTION 2GENERAL
Main unit
ALBUM + ALBUM –
qh (12, 14, 19)wg (12, 14, 19)
CD eg (9, 11, 14, 19, 20)CD SYNC wj (19)Deck A wk (18)Deck B qj (18, 19, 20, 24)DISC 1 – 3 q; (12, 14, 35)DISC SKIP/EX-CHANGE qs
(11, 12, 14, 19)Disc tray 9 (11)DISPLAY 2 (17, 27, 28)Display window 5 EFFECT ON/OFF 8 (22)ENTER qa (14, 15, 22)EQ BAND 7 (22)GAME es (20, 23, 30)GAME INPUT AUDIO L/R jacks wd (20, 29)
GAME INPUT VIDEO jack wf (29)
GAME MIXING wh (23)GROOVE 8 (21)ILLUMINATION 3 (28)Operation Dial
(– EQ +/l L) 6 (12, 14, 19, 22)
P FILE qd (22)PHONES jack ql PLAY MODE wl (12, 14, 18, 19,
20, 35)Power illuminator qk (28)PRESET EQ qd (22)REC PAUSE/START wj (19, 20,
23, 24)Remote sensor 4SURROUND 8 (23)TAPE A/B ed (18, 19, 20, 24)TUNER/BAND ef (15, 16, 20)TUNING MODE wl (15, 16, 35)TUNING + qh (15, 16)TUNING – wg (15, 16)VOLUME control w; (21)
?/1 (power) 1 (8, 16, 27, 30, 33, 35)
X (pause) wg (12, 19)Z (eject) qf (11)PUSH Z (deck B) (eject) qg (18)x (stop) wg (12, 19, 24, 35)M (fast forward) qh (12, 19)H (play) qh (12, 18, 19) m (rewind) wg (12, 19)Z PUSH (deck A) (eject) e; (18)
List of button locations and reference pages
How to use this pageUse this page to find the location of buttons and other parts of the system that are mentioned in the text.
Illustration numberr
TAPE A/B ed (18, 19, 20, 24)R R
Name of button/part Reference page
ALPHABETICAL ORDER
A – O P – Z
BUTTON DESCRIPTIONS
ALBUMALBUM
TUNING TUNING
J
Hh
S
j
s
wd
123456 78 9
q;
qf
qa
qsqd
w;
ql
qgqh
qk
wfwgwh
wkwj
wl
es
efed
eg
e;
qj
7
HCD-GX450
Use buttons on the remote for the operation.
1 Press ?/1 to turn on the system.
2 Press CLOCK/TIMER SET.
3 Press . or > repeatedly to set the hour.
4 Press ENTER.
5 Press . or > repeatedly to set the minute.
6 Press ENTER.
The clock starts working.
To adjust the clock
1 Press CLOCK/TIMER SET.
2 Press . or > repeatedly to select “CLOCK SET”, then press ENTER.
3 Do the same procedures as step 3 to 6 above.
Notes The clock settings are canceled when you disconnect
the power cord or if a power failure occurs.
Setting the clockRemote control
ALBUM – qd (12, 14)ALBUM + qa (12, 14)CD qk (11, 14)CLEAR qg (14)CLOCK/TIMER SELECT 2
(26, 27)CLOCK/TIMER SET 3 (10, 25,
26)DISC SKIP q; (12, 14)DISPLAY wa (17, 27, 28)ENTER 9 (10, 14, 15, 25, 26)EQ qf (22)
?/1 (power) 1 (8, 26)m/M (rewind/fast forward) 7 (12, 19)
–/+ (tuning) qh (15)./> (go back/go forward) qh (10, 12, 19)
N (play) 8 (12, 18)X (pause) 8 (12, 19)x (stop) 8 (12, 19)
ALPHABETICAL ORDER
A – E
FM MODE 4 (17)FUNCTION 6 (11, 14, 15, 16)PLAY MODE w; (12, 14, 18)REPEAT 4 (13)SLEEP ws (25)TAPE qj TUNER BAND 5 (15, 16)TUNER MEMORY ql (15)TUNING MODE w; (15, 16)VOLUME +/– qs (21, 25)
F – Z
BUTTON DESCRIPTIONS
456
7
8
9
q;
ws 1
qd
qg
qf
waw;qlqkqj
qh
qa
qs
32
8
HCD-GX450SECTION 3
DISASSEMBLY
Note: Disassemble the unit in the order as shown below.
3-1.COVER (TOP)(Page 9)
3-2.CD DOOR(Page 9)
3-3.FRONT PANEL SECTION(Page 10)
3-8.POWER TRANSFORMER(Page 12)
3-7.BACK PANEL SECTION,SUB-TRANS BOARD
(Page 12)
3-4.CD MECHANISM DECK(CDM74-F1BD81)
(Page 10)
3-15.OPTICAL PICK-UP(KSM-215DCP/C2NP)
(Page 16)
3-5.TAPE MECHANISM DECK,GAME JACK BOARD
(Page 11)
3-14.DRIVER BOARD,SW BOARD(Page 15)
3-17.MOTOR (TB) BOARD(Page 17)
3-18.MOTOR (LD) BOARD(Page 17)
3-16.SENSOR BOARD(Page 16)
3-12.BD81A BOARD(Page 14)
3-6.PANEL BOARD(Page 11)
3-9.MAIN BOARD(Page 13)
3-10.SUB-WOOFER BOARD(Page 13)
3-11.AMP BOARD(Page 14)
3-13.CONNECT BOARD(Page 15)
SET
9
HCD-GX450
Note: Follow the disassembly procedure in the numerical order given.
3-1. COVER (TOP)
3-2. CD DOOR
cover (Side-R)
cover (Side-L)
5
qd
qs
qs
q;
qf cover (top)
6 two screws (Case 3 TP2)
8 screw (+BVTP 3 × 10)
3 screw (+BVTP 3 × 10)
9 screw (+BVTP 3 × 10)
4 screw (+BVTP 3 × 10)
1 two screws (case 3 TP2)
qa two screws (+BVTP 3 × 10)
7 screw (case 3 TP2)
2 screw (Case 3 TP2)
2 Pull-out the disc tray.
1 Turn the pulley to the direction of arrow.
3 two claws
4 CD door
pulley
Front panel side
CD mechanism deck (CDM74)
10
HCD-GX450
3-4. CD MECHANISM DECK (CDM74-F1BD81)
3-3. FRONT PANEL SECTION
1 three screws (+BVTP 3 × 8)
qd front panel section
7 wire (flat type) 29 core (CN302)
8 wire (flat type) 17 core (CN253)
9 connector 5p (CN309)
qs connector 8p (CN103)
3 screw (+BVTP 3 × 10)
2 screw (+BVTP 3 × 10)
4 screw (+BVTP 3 × 8)
5 screw (+BVTP 3 × 8)
0 connector 3p (CN304C)
qa connector 3p (CN102B)
6 connector 2p (CN805)
2 connector 12p (CN701)3 connector 9p (CN254)
4 CD mechanism deck (CDM74-F1BD81)
1 three screws (+BVTP 3 × 10)
11
HCD-GX450
3-5. TAPE MECHANISM DECK, GAME JACK BOARD
3-6. PANEL BOARD
2 six screws (+BVTP 2.6 × 8)
5 GAME JACK board 4 two screws (+BVTP 2.6 × 8)
3 tape mechanism deck
1 wire (flat type) 13 core (CN602)
1 ten screws (+BVTP 2.6 × 8)
5 PANEL board
4 connector 5p (CN605)
3 connector 6p (CN604)
2 seven claws
12
HCD-GX450
3-7. BACK PANEL SECTION, SUB-TRANS BOARD
3-8. POWER TRANSFORMER
3 connector 3p (CN308)
1 connector 2p (CN904)
7 connector 2p (CN901)
8 SUB-TRANS board
4 two screws (+BVTP 3 × 10)
5 three screws (+BVTT 3 × 10)
6 two screws (+BVTT 3 × 10)
9 back panel section
2 wire (flat type) 11 core (CN101)
1 connector 3p (CN905)
2 connector 10p (CN907)
4 earth wire
5 four screws (+ITC 4 × 8)
3 screw (+BVIT 3 × 8R)
6 power transformer
13
HCD-GX450
3-9. MAIN BOARD
3-10. SUB-WOOFER BOARD
1 connector 7p (CN502)
4 SUB-WOOFER board
2 two screws (transistor)
3 two screws (+BVTP 3 × 8)
5 MAIN board
3 two screws (+BVTP 3 × 8)
1 connector 10p (CN907)
4 connector 13p (CN441)
2 connector 4p (CN501)
Main board
14
HCD-GX450
3-11. AMP BOARD
3-12. BD81A BOARD
6 AMP board
1 two screws (+BVTP 3 × 8)
5 heat sink
2 screw (+BVTP 3 × 14)
4 two screws (transistor)
3 two screws (+BVIT 3 × 8R)
5 BD81A board
3 screw (+BVTP 2.6 × 8)
1 wire (flat type) 27 core (CN202)
4 Remove soldering from the four points.2 wire (flat type) 16 core (CN101)
15
HCD-GX450
3-13. CONNECT BOARD
3-14. DRIVER BOARD, SW BOARD
3 CONNECT board
1 wire (flat type) 27 core (CN251)2 two screws (+BVTP 2.6 × 8)
3 connector 4p (CN703)
4 DRIVER board
6 SW board
2 wire (flat type) 5p (CN702)
1 two screws (+BTTP (M2.6))
5 screw (+BTTP (M2.6))
16
HCD-GX450
3-15. OPTICAL PICK-UP (KSM-215DCP/C2NP)
3-16. SENSOR BOARD
5 two coil springs (insulator)
9 two coil springs (insulator)
6 two insulators
0 two insulators
qs screw (+BVTP 2.6x 8)
7 two screws (BVTT M2.6)
3 screw (BVTT M2.6)
2 holder (213) ASSY
8 two stoppers (BU)
qd Remove the four solderings of motor.
qf CN101 (flat type)
qg BD81A board
qh optical pick-up (KSM-215DCP/C2NP)
1 floating screw (+PTPWH M2.6)
4 floating screw (+PTPWH M2.6)
qa
2 tray
3 belt (table)
5 pulley (table)
8 screw (+BTTP (M2.6))
0 SENSOR board
7 gear (geneva)
9 connector (CN731)
1 floating screw (+PTPWH M2.6)
6 floating screw (+PTPWH M2.6)
4 floating screw (+PTPWH M2.6)
17
HCD-GX450
3-17. MOTOR (TB) BOARD
3-18. MOTOR (LD) BOARD
6 Remove the two solderings of motor.
7 MOTOR (TB) board
5 table motor assy (M741)
5 two screws (+BTTP (M2.6))
4
3 wire (flat type) 5 core (CN742)
1 stopper
2 stopper
4 Remove the two solderings of motor.
3 MOTOR (LD) board
1 belt (loading)
5 loading motor assy (M751)
2 two screws (+BTTP (M2.6))
18
HCD-GX450SECTION 4TEST MODE
[Change-over of AM Tuner Step between 9 kHz and10 kHz]• A step of AM channels can be changed over between 9 kHz and
10 kHz.
Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “TUNER”, and press TUNER/BAND
button to select the BAND “AM”.3. Press ?/1 button to turn the set OFF.4. Press PLAY MODE/TUNING MODE and ?/1 buttons si-
multaneously, and the display of fluorescent indicator tubechanges to “AM 9 k STEP” or “AM 10 k STEP”, and thus thechannel step is changed over.
[Cold Reset]• The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returningthe set to the customer.
Procedure:1. Press three buttons x , PLAY MODE/TUNING MODE ,
and DISC 1 simultaneously.2. The fluorescent indicator tube displays “COLD RESET” and
the set is reset.
[Aging Mode]This mode can be used for operation check of CD section and tapedeck section.• If an error occurred:
The aging operation stops and is displayed status.• If no error occurs:
The aging operation continues repeatedly.
1. Operating method of Aging ModePress ?/1 button to turn the set ON and select “CD” of the function.1) Set three discs in tray. Press the PLAY MODE/TUNING MODE
button to set the “ALL DISCS” mode, and the PRESET EQbutton to “REPEAT” off.
2) Load the tapes recording use into both decks.3) Press three buttons x , PLAY MODE/TUNING MODE ,
and EX-CHANGE simultaneously.4) Aging operations of CD and tape are started at the same time.5) To exit the aging mode, perform [Cold Reset].
2. Aging mode in CD section1) Operation during aging mode• In the agining mode ,the program is excuted in the following
sequence.(1) The disc tray opens and closes.(2) The disc tray turns to select a disc 3.(3) The pick-up accesses to the first track, and plays 3 seconds.(4) The pick-up accesses to the last track, and plays 3 seconds.(5) The disc tray opens and closes.(6) The disc tray turns to select a disc 1.(7) The same operation starts like step (3).(8) After a disc 1 aging operation, a disc 2 is selected.(9) When an aging operation of a disc 3 is completed, the display
“AGING ∗∗∗∗ ” value increases.(10) If no error occurs, the aging operation continues repeatedly.
2) Error display
Step
1
2
3
4
5
6
7
8
9
10
11
12
Operation
Rewind the TAPE A
Rewind the TAPE B
Play the TAPE A (1 minute)
Stop the TAPE A (1 second)
Play the TAPE A (3 minutes)
Rewind(AMS) the TAPE A
F.F.(AMS) the TAPE A
Play the TAPE B (1 minute)
Stop the TAPE B (1 second)
Record the TAPE B (3 minutes)
Rewind(AMS) the TAPE B
F.F.(AMS) the TAPE B
Display
TAPE AAG-1
TAPE BAG-2
TAPE AAG-2
TAPE AAG-3
TAPE AAG-4
TAPE AAG-5
TAPE AAG-6
TAPE BAG-2
TAPE BAG-3
TAPE BAG-4
TAPE BAG-5
TAPE BAG-6
Disc error
Display Error
E00D01022 Focus error (No disc)
E00D02022 Sub Q error (Focus is good)
E00D02023 TOC reading error
E00D02014 Access error (Unable within regular time)
Mechanism error
Display Error
E00M__E_0 Error during opening tray
E00M__C_2 EX-CHANGE disc error
E00M__D_0 Error during closing tray
E00M__F_3 EX-OPEN error
E00M__D_5 EX-CLOSE error
E00M__C_2 Chuck-up error
E00M__C_3 Unchucking error
3. Aging mode in Tape Deck section1) Operation during aging mode• In the agining mode, the program is excuted in the following
sequence.
2) Error display• If error occurred, the display remains like “TAPE BAG-2”.
4. Exiting from the aging mode• Be sure to perform Cold Reset to exit from the aging mode.
19
HCD-GX450
[MC Test Mode]• This mode is used to test the function of the equalizer.
Procedure:1. Press ?/1 button to turn the set ON.2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and DISC 3 simultaneously.3. Press the EQ + button.
The function of the equalizer is set to “MAX”.4. Press the EQ - button.
The function of the equalizer is set to “MIN”.5. Press the PRESET EQ button.
The function of the equalizer is set to “EQ FLAT”.6. MASTER VOLUME up and down.
“VOLUME MIN” “VOLUME 16” “VOLUME MAX” isdisplayed.
7. Press the GROOVE button.The message “VACS OFF” or “VACS ON” is displayed.
8. To exit from this mode, press ?/1 button to turn the set OFF.
[CD Ship Mode (LOCK) ]• This mode moves the pick-up to the position durable to vibra-
tion. Use this mode when returning the set to the customer afterrepair.
Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “CD”.3. Press ?/1 button to turn the set OFF.4. Press CD button and ?/1 button simultaneously.5. The “STANDBY” display blinks instantaneously, the message
“LOCK” is displayed and the CD ship mode is set.
[CD Ship (LOCK) & COLD RESET MODE]Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “CD”.3. Press ?/1 button to turn the set OFF.4. Press three buttons x , CD and DISPLAY simultaneously.5. The “STANDBY” display blinks instantaneously and CD ship
mode is set.6. To fluorescent indicator tube displays “COLD RESET” and
the set is reset.
[Disc Tray Lock]Procedure:1. Press the ?/1 button to turn the set ON.2. Select the function “CD”.3. Press two buttons of x and Z simultaneously for five seconds.4. The message “LOCKED” is displayed and the tray is locked.
(Even if exiting from this mode, the tray is still locked.)5. Press two buttons of x and Z simultaneously for five seconds
again.6. The message “UNLOCKED” is displayed and the tray is
unlocked.7. To exit from this mode, press the ?/1 button to turn the set
OFF.
[PANEL Test Mode]• All fluorecent segments and LEDs are tested.• Keyboard check.
Procedure:1. Press ?/1 button to turn the set ON.2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and ENTER simultaneously.3. All segments and LEDs (without STANDBY LED) are turned
on.4. Press X and ENTER buttons simultaneously, and the key
check mode is activated.5. The message “KEY 0 0 0 ” is displayed.
Each time a button is pressed, the key code number is displayed.6. Press X and ENTER buttons simultaneously, and the key
count mode is activated.7. The message “KEYCNT 0” is displayed.
Each time a button is pressed, “KEYCNT 0” value increased.However, once a button is pressed, it is no longer taken intoaccount.
8. Press X and ENTER buttons simultaneously, and the headphone detect mode is activated.
9. The message “H_P OFF” is displayed when a headphone jackis not inserted.“H_P ON ” is displayed when a headphone jack is inserted.
10. Press X and ENTER buttons simultaneously, and the volumecontrol detect mode is activated.
11. The message “VOLUME FLAT” is displayed.“VOLUME UP” is displayed if rotating MASTER VOLUMEknob clockwise, or “VOLUME DOWN” is displayed if rotatingcounterclockwise.
12. To exit from the GC test mode after the head phone detect mode,press X and ENTER buttons simultaneously.
[Version and Destination Display Mode]• The version or destination is displayed.
Procedure:1. Press ?/1 button to turn the set ON.2. To enter the test mode, press the three buttons x , PLAY
MODE/TUNING MODE and DISC 2 simultaneously.3. The destination is displayed.4. Press DISPLAY buttons simultaneously.5. The version is displayed.6. To exit from this mode, press the three buttons x , PLAY
MODE/TUNING MODE and DISC 2 simultaneously andpress ?/1 button to turn the set OFF.
[CD Service Mode]• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pick-up.
Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “CD”.3. To enter the test mode, press three buttons x , PLAY MODE/
TUNING MODE , and Z simultaneously.4. The CD service mode is selected.5. With the CD in stop status, press M button to move the
pick-up to outside track, or press m button to inside track.6. To exit from this mode, perform as follows:
1) Move the pick-up to the most inside track.2) Press ?/1 button to turn the set OFF.
Note: • Always move the pick-up to most inside track when exiting fromthis mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can bechipped.
20
HCD-GX450
[CD Repeat 5 Times Limit Release Mode]Procedure:1. Press ?/1 button to turn the set ON.2. Select the function “CD”.3. Press three buttons x , CD and ENTER simultaneously.4. The message “LIMIT OFF” is displayed.5. Press ?/1 button the set OFF.
[AMP TEST MODE]Procedure:1. Press ?/1 button to turn the set ON.2. To enter the test mode, press three buttons x , PLAY
MODE/TUNING MODE and ENTER simultaneously.3. Press the DISPLAY button.
The message “V0 0 0” “ 000” is displayed.4. Press the GROOVE button.
The message “DBFB ON” “DBFB OFF” is displayed.5. Press the SURROUND button.
The message “SURROUND ON” “SURROUND OFF” isdisplayed.
6. Press the EQ BAND button.The message “LOW” “MID” “HIGH” is displayed.
7. Press ?/1 button to turn the set OFF.
2121
HCD-GX450SECTION 5DIAGRAMS
Note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolyticsand tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwisespecified.
• f : internal component.• C : panel designation.
Note on Printed Wiring Boards:• X : parts extracted from the component side.• b : Pattern from the side which enables seeing.
• Indication of transistor.
• AbbreviationCND : Canadian model
Note:The components identi-fied by mark 0 or dottedline with mark 0 are criti-cal for safety.Replace only with partnumber specified.
Note:Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepiéce portant le numérospécifié.
• A : B+ Line.• B : B– Line.• H : adjustment for repair.• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal produc-tion tolerances.no mark : FM( ) : CD STOP
• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.
• Circled numbers refer to waveforms.• Signal path.
F : TUNERE : PB (DECK A)d : PB (DECK B)G : REC (DECK B)J : CDf : AUDIO
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note is printed in each block.)
C
B
These are omitted.
E
Q
B
These are omitted.
C E
Q
Circuit Boards Location
• Waveforms
Caution:Pattern face side: Parts on the pattern face side seen from(SIDE A) the pattern face are indicated.Parts face side: Parts on the parts face side seen from(SIDE B) the parts face are indicated.
– PANEL BOARD –
1 IC601 qd (I-XT2)
2 V/DIV, 10 s/DIV
2 IC601 qh (CF2)
2 V/DIV, 40 ns/DIV
5.2 Vp-p30.5 s
4.9 Vp-p100 ns
MOTOR (LD) board
SW board
SENSOR board BD81A board
MOTOR (TB) board
DRIVER board
CONNECT board
SUB-TRANS board
SUB-WOOFER board
AMP board
VIDEO OUT board
GAME JACK board
PANEL board
6 STREAM LED board
H/P JACK board
MAIN board
TRANS board
REM board
2222
HCD-GX450
5-1. BLOCK DIAGRAMS – PANEL SECTION –
IC601(1/2)SYSTEM CONTROLLER
CN603
D401
+B
-B
F904
12 I-XT1X601
32.768kHz 13 I-XT2
MP3-TTB80
IC610
15 CF1X602
10MHz 16 CF2
283 SIRDS-INREMOTE
CONTROLRECIEVER
82STREM-LED1
74
4230
POWER RELAY
11RESET
29ACCUT
MASTER VOLUME
ABD/DRIVER
SECTION
25 KEY3
MP3-RESET6MP3--REQ4MP3-ACK3MP3-CS2MP3-CS'1MP3-CLK100MP3-DI99MP3-DO98CD-CLK97SENS96CD-DATA95XLT94XRES93XTCN92SCOR5
FUNCTIONKEY
S641-S650
27 KEY1FUNCTIONKEY
S601-S612
26 KEY2FUNCTIONKEY
S621-S630
9 VOLUME-IN110 VOLUME-IN2ENCODER
S851
LEDDRIVER
Q610
LED610
80STREM-LED3 LEDDRIVER
Q612
LED612
81STREM-LED2 LEDDRIVER
Q611
LED611
77STREM-LED6 LEDDRIVER
Q614
LED615
78STREM-LED5 LEDDRIVER
Q615
LED614
79STREM-LED6 LEDDRIVER
Q613
LED613
76POWER LED
G01-G13
S1-S21
LED601
F905
AC3
D301-D304
D902Q902
IC301
REG
-VFL
F906
AC4
VF
D305-D308
D902-905
F907
REG
+3.5V 13
IC303
REG
SWITCH
Q361,Q362,Q314,Q315
RELAYDRIVE
+9V 13
D309-D312IC304
REG+9VVF
-VFL13
IC302
REG+3.5V 124
+3.3V
PT902SUB TRANSFORMER
RY901
PT901POWER TRANSFORMER
IC603
REG 15
IC604
RESET 13
Q605RESET
SWITCH
FL601
FLUORESCENTINDICATOR
TUBEACIN
SCORXTCNXRST
XL-T-CDCD-DATA
SENSCD-CLK
MP3-DOMP3-DI
MP3-CLKMP3-CSMP3-CP
MP3-ACKMP3-REQ
MP3-RESETMP3-STB
C18C15C14C13C12C11C10C9C8C7C6C5C4C3C2C1
C1C2C3C4C5C6C7C8C9
C10C11C12C13C14C15C18
Q301,Q302
434547505265
2323
HCD-GX450
– MAIN SECTION –
CN201
CD NO SENS
CD OPEN/CLOSE
CD ENCORDER
LM-R
LM-F
TM-R
TM-F
D BD/DRIVERSECTION
CN306Q371
INVERTER
SW ON/OFFSW OUTSW LIMITER
GND
OVERLOAD/DC
RELAY+
RELAY-
C SUB-WOOFERSECTION
E SUB-WOOFERSECTION
TUNER
IC101SOUND PROCESSOR IC102
BUFFER
61 TUNER_L
19 SI
18 SO
59 GAME-L
9 TAPEA1
11 TAPEB1
15 REC-OUT1
DATA
RCLK
1 CDL
24 I-STREEMA/VACS75 SYSTEM-MUTE69 ASM
19WFR/HP/MIC18PROTECT
73SENSOR
21CD-OPEN/CLOSE20CD ENCORDERCLK
DATA9188
32VOUT233VOUT1
25 5 1SW OUT
35
34
BBIN1
BBNF1
31BBNF2
40ASMOUT
11 Q5
12 Q6
7 Q1
6 Q0
CD-RR-CH
R-CH
CD-L
R-CH
FAN
IC371SP DRIVER
IC104BUFFER
94
IC201SELECTOR
IC601(2/2)SYSTEM CONTORLLER
IC441POWER AMP
513
411
RELAYDRIVE
Q485-Q488
OVERLOAD DET
Q441,Q442
OVERLOAD DET
Q481,Q482
R-CHR-CH
RY441
CN443
3 DATADO
5 LCKLCH4 CLK
18 SOCLK
7
8
SOL-BSOL-B
SOL-A
MOTOR
6 SOL-A
MOTOR
IC602VIDEO BUFFER
L
R
GAME INPUT
VIDEO OUT
JK441
Q106BUFFER
Q107BUFFER
Q327BUFFER
MUTE
SWITCH
MUTESTK
-VFL
Q108
SWITCH
AC4
+B
+10V
Q308,Q309,Q313
Q105
+Vcc
Q303
Q489
FANDRIVE
Q310-Q312
OVERHEATDET
Q483,Q484
TH441
Q101-Q104
SWITCH
CD-MUTE
Q304-Q307
TUNER-L
TUNER-R
DODI
CLKCE
TUNEDSTEREO
TU-MUTE
DODI
CLKCE
TUNEDSTEREO
Q351,Q352
J804
J803
VIDEO
VIDEO
R-CH
L
R
BIASOSC
Q321
Q324
+9V
STK
CD-MUTE
R-CH
REC SWCONT
7 P/B SW
R-CH
L
R
HP2
HP1
L
R
HRP2
HRP1
HE1
DECK-B
SWITCH
Q322,Q323
L101
SWITCH
Q308,Q309Q313
10 Q4FAN 17 Q11
LM-R 13 Q7LM-F 14 Q8TM-R 15 Q9TM-F 16
345Q10
DATACLOCK
LCH
BBD/DRIVERSECTION
J801PHONES
FAN
DECK-A
TAPEMECHANISM DECK
Q603
I-REEL-A
232270
4
TAPE B START+TAPE A START+
SOLASOLA
A-PHOTO
PWDEWC BMODE BMODE AB HALF
A HALF
I-REEL-B71
CLK
848586
CEDI
DO
LCH87
B-PHOTO
A TRIGDRIVE
3 SOLBSOLB
Q601
2 MOTOR
SOLA
CLK
CE
68 STEREO67 TUNED
STEREOTUNED
DATARCLK
DO
83DI
LCH
SOLB
MOTORCOMP
CAP MDRIVE
Q602B TRIGDRIVE
56
55
SAOUT1
SAOUT2
30BBNF2
SWITCH
SWITCH
DEF
SPEAKER
• Signal Path• R-CH is omitted due to same as L-CH
: TUNER
: CD
: PB(DECK A)
: PB(DECK B)
: AUDIO
: REC(DECK B)
2424
HCD-GX450
– BD/DRIVER SECTION –
CN201
MP3STB
MP3REQMIACKMICKMIDIO
MILP
MICS
MP3RST
SRMSTB
SCOR
SENSCLOCK
XLT
DATA
XRST
XTACN
SCOR
SENSCLOCK
XLT
DATA
XRST
XTACN
LOUT
ROUT
DOUT
A PANELSECTION
B MAINSECTION
IC731(TABLE SENSOR)
CN701
IC701(LD)MOTOR DRIVER
42
911
RINFIN
OUT1OUT2
IC712TBL MOTOR DRIVER
42
97
RINFIN
OUT1OUT2
DMAIN
SECTION
LMRLMF
TM-RTM-F
TBL ADDRESS SWE-1E-2E-3
OPEN SW
Q731
M751(LOADING)
M741(TBL)
RE701
S751(LEVER SW)
ROTARYENCODER
E-3E-2E-1
SWITCH
M
M
+3V
: CD
• Signal Path
• R-CH is omitted due to same as L-CH
OPTICAL PICK-UPBLOCK
(KSM-215DCP/C2NP)
LDDRIVER
Q10
+1.7V+3.3V
LD
GND
FOCUSCOIL
F+
F
T+
TTRACKING
COIL
IC251
SW101
X17116.9MHz
+3.3V
SL/SP MOTORDRIVER
IC101RF AMP
16
7
15
17
18
VR
PD
19
20
21
22
5
9
3
24MUTE
CH2OUT-F
CH1FIN
CH1RIN
CH2FIN
SFDR
OPIN+
CH2OUT-R
CH1OUT-R
CH1OUT-F
CH4OUT-F
CH4OUT-R
CH3OUT-R
CH3OUT-F
M
M
M101(SPINDLE)
M102(SLED)
VCC
VC
A
B
C
D
E
F
DETECTOR
A
B
E19
F20
LD36
PD37
TFDR11
SSTP7
FFDR13
CH3FIN30
MPD6
95XTACN
100XRST
102DATA
104XLAT
105CLOCK
86AOUT2
81AOUT1
71DOUT
61PCMD1
62LRCK1
63LRCK
65PCMD
DIGITAL SIGNALIC301
PROCESSOR
21
40
SDO011
LRCKIA16
SFSY/LRCK1B19
SDIO14
77 XTAO
78 XTAI
55VDD
VDD
VDDM
26
27
C28
D29
107SENS
XTACN
XRST
DATA
XLAT
CLOCK
SENS
113GFS
114C2PO
2
3
1
FOK
TRDR12
10SRDR CH3RIN29
CH2RIN FRDR14
XRST100
66BCK
60BCK1
BCKIA15
SBSY/BCK1B18
6
3.3V
IC303
8
5 1
3STANBY
36PO11/BUCK/AD1
8MIACK7MICK
6MIDIO
4MICS
5MILP
2RESET
41SRMSTB
115SCOR SCOR
REG
2525
HCD-GX450
– SUB-WOOFER SECTION –
DETECT
SWITCH
OVERCOARDETECT
CN501
IC501AMP
RY501
JK501
SUB WOOFER OUT
Q501
Q502
Q507
Q503
SW-SIG-IN
GND
SW-LIMIT
SW-SENCE
CMAINSECTION
CN502
GND
OVERLOAD/DC
RELAY+ +B
+B
RELAY-
EMAINSECTION
CN5032PT-2
3SW IN
8 12-RE
13+RE
DETECT
Q506,Q505
DETECT
CONTROL
2626
HCD-GX450
5-2. PRINTED WIRING BOARD – BD81A SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
Ref. No. Location
IC101 D-7IC251 C-6IC301 C-7IC303 B-7
Q10 E-4
• SemiconductorLocation
IC251
IC101
IC301
IC303
OPTICALPICK-UPBLOCK
(KSM–215DCP)
CONNECTBOARDCN251
(Page 33)
SPINDLEMOTOR
SLEDMOTOR
(LIMIT)
4 5
13
1 2
A
B
C
D
E
3 4 5 6 7 8 9
E
C 3 0 3C 3 0 5
C 3 1 5C 3 1 6
C 3 1 4
C 3 1 2
R 3 0 2R 3 5 3
R 3 5 2
C 3 0 8C 3 1 8
C 1 8 4
C 2 1 0R 1 6 2R 1 9 1
C 1 7 2
R 1 7 2
C 3 0 1
C 1 8 3
R 2 0 5
R 2 0 1C 2 0 1
C 2 0 3
C 1 5 1
R 1 2 1
C 1 2 3
C 1 9 5
C 1 6Q 1 0
C 1 7
C 1 1 6
C 2 5 9C 2 5 8
C 2 5 7C 2 6 0
M 1 0 1
C 3 2 0
R 2 5 2
C 3 0 6
R 4 1 9
C 3 1 3R 4 0 3
R 3 0 1
M 1 0 2
R 3 0 3
R 4 0 7
C 1 6 3 R 1 6 3
C 1 1 5
C 1 1 2C 1 1 1
R 1 1 1
C N 1 0 1
C 1 2 2 C1
43
R 2 0 3R 1 4 2C 1 4 1
C 1 4 2R 1 3 3
C 1 6 1
C 3 1 0R 4 0 9
C 2 1 1
S 1 0 1
FB3
01
R1
65
C1
82
C2
09
X1
71
X1
72
R1
71
C1
71
C1
74
R1
73
C1
96
C1
34 C
12
5
C1
5
C1
1C
10
C1
8R
11
R1
2R
13
R1
0
C1
4
R 3 1 3
C3
02
R4
05
R3
51
C2
55
C2
52
R2
51
C2
51
C1
14
C1
13
R1
13
R1
14
R1
12
C1
24
C1
94
R4
12
R4
06
C1
81
C1
62
R1
61
R2
04
R1
81
R1
82
C1
86
C1
85
CN
20
2C
N2
01
R4
10
R 4 0 1
R 4 0 2
R 3 0 5
C 3 1 7
R1
51
C1
52
C1
33
C1
32
R1
32 R1
41
R1
31
C1
31
R1
43
C3
07
R3
07
C3
09
R4
11
R4
04
C3
04
C3
11
R 3 0 6
R3
04
C2
12
R4
08
C2
13
R2
53
R3
54
2727
HCD-GX450
5-3. SCHEMATIC DIAGRAM – BD81A SECTION – • See page 46 for IC PIN FUNCTION DESCRIPTION.
TP165
TP166
TP178
TP14
4
TP14
7
TP15
3
TP186
TP187
TP167
TP16
0
TP16
2
TP177
TP14
5
TP14
8
TP12
1
TP12
2
TP12
3
C305
JPO004
JPO10
TP25
0
TP301
TP302
TP303
TP304
TP103
TP104
TP105
TP14
6
R161
R16
3
R351
R352
R353
R354R401
R402
R403
R404
R405
R406
R407
R408
R409
R411
R412
R419
R11
R19
1
R13
2
R251
R253
R12
R14
2
R14
3
R10
JPO102
JPO103
M101
S101
C15
C17
C115
C116
C12
2
C125
C132
C13
3
C134
C141
C142
C143
C151
C161
C181
C194
C201
C203
C252
C255
C25
7
C303
C306
C308
C309
C310
C311
C312
CN101
R12
1
R171C171C313
C314
C183
C184
TP420
TP421
TP422
TP423
TP424
R252
TP42
5
TP42
6
C259
TP427
TP428
TP429
TP430
TP431
TP432
R13
Q10
C16
C12
3
C260
R172
C124
R13
3
R313
TP433
TP436
C316
C10C11
C162
C317
C315
C307
TP401
TP407
TP406
TP405
TP404
TP403
TP402
TP408
TP410TP434
TP417
TP416
TP415
TP414
TP413
TP412
TP419
TP411
TP435
TP409
TP19
TP18
TP17
TP16
TP15
TP102
TP14
TP13
TP12
TP11
TP10
C195
C182
C174
R13
1
C13
1 C18
R301
FB301
R303
R182
R181
X171C172
R173
R203
IC303
R302
R162
R16
5
C211
C210
C212
R15
1
R205
R410
C320
C213
C13
CN201
C185
C186
C163
C19
6
C15
2
C318
R30
6
IC251
C258
C251
C302
M102
TP25
3
TP25
2
TP25
1
C111
R112
R114
R111
R113
C112
C113
C114
R193
C209
R305
IC301
R14
1
IC101
R307
TP12
5
TP12
4
TP14
2
TP14
9
R204
R20
1
MIRR
DFCT
FOK
XU
GF
XP
CK
GFS
MVDD
MGND
LOCK
WD
CK
CO
UT
VC
WFC
K
SB
SO
RFD
CO
2204V
MDP
APC
SP-
LRCK
PCMD
BCK
C2P
O
100
100
100
100
100
100100
100
100
100
100
100
100
100
100
100
100
100
0
0
10k
10k
10k
100k
1k
3.3k
3.3
FEI
TEI
SW
0.1F
2204V
0.1 F10010V
0.1 B
0.1 F
0.47
B
0.01
B
0.1 F
0.1
B
0.00
15B
0.1 F
10010V
0.1 F
0.1 F
0.1F
10010V
10010V
0.1 F
0.1 F
0.1
F
0.1F
0.1 F
474V
0.1 F
0.1 F
0.1 F
0.1 F
16P
15k
0.1 F
47 4V
22 6.3V
22 6.3V
AGND
DGND
MP3GND
IOP1
IOP2
22k
SW+
SW-
PCMDI
FRDR
FFDR
TRDR
TFDR
MDP
1
2SB1690K
1F
0.1
B
220 10V
330p
CH
180k
220
MP3VDD
AVDD
0.0022 B
106.3
B
106.3
B
0.1 F
0.01 B
0.1 B
0.1 F
MP3STB
MICS
MILP
MIDIO
MICK
MIACK
MP3REQ
MP3RST
ROUTAVDD
SCOR
SENS
CLK
XLT
DATA
XRST
XTCN
LOUT
DVDD
DOUT
F-
T-
F-
F+
PD
F
C
B
A
D
E
0.1 F
0.1 F
0.1 F
1M100p
CH
0.001 B
100k
BLM21B272S
100k
100
100
0
0
BH15FB1W
10k
47k
220p CH
0.1 B
22p CH
0
0
100
0
22p CH
NM
2200p CH
2200p CH
0.1 0.1
1
0.01B
0
0.0068B
0.1F
SL-
SL+
SP+
0.0033 B
15k
15k
1k
1k
470p
0.0033
470p B
NM
0.01
B
100k
TC94A34FG-002
4.7k
CXD3059AR
10k
RFA
CI
RFA
CO
EXC
K
0
0
47022p CH
0.1F
1M16.9MHz27p CH
0
27P
BA5947FM(HSOP28)
0.1
2828
HCD-GX450
5-4. PRINTED WIRING BOARD – CD MECHANISM SECTION – • See page 21 for Circuit Boards Location.
1
A
B
C
D
E
F
G
H
2 3 4 5 6 7 8 9 10 11 12 13 14
(LEVER SW)CN751S751
IC731
CN731
CN741
CN74
2
C715
C731
C735
C736
R70
1
R711
R731
R721
R722
R723
R73
5
R73
2
R733
R73
4
D70
1
D71
1
Q731
C751
IC71
2
IC70
1
CN704
C737
R71
3
R712
C741
R70
2
JW702
JW703
JW704
JW705
JW706
JW707
JW70
8
JW711
CN70
3
CN702CN705
R751
C752
CN70
1
JW712
JW701
JW70
9
JW710
JW713
JW714
CN72
1
MAINBOARDCN301
(Page 30)
Ref. No. Location
D701 D-6D711 D-7
IC701 F-6IC712 F-7IC731 E-11
Q731 C-9
• SemiconductorLocation
2929
HCD-GX450
5-5. SCHEMATIC DIAGRAM – CD MECHANISM SECTION –
CN30132
no mark : FM
R701
D701
R712R711
R721
C735 C736
R722
C737
R723
R733
R734R735
C741
CN731 CN741
CN742
CN702
CN703 CN751
CN704CN721C751
R751
C752
CN705 CN751
R732R731
M741
CN701
IC731
E-1E-2E-3
Q731
D711
R713
C731
C715
S751
R702
470
MTZJ-T-77-5.1A
4.7k 1k
4.7k
0.1 0.1
4.7k
0.1
4.7k
1k
12k100
0.01
3P 3P
5P
5P
4P 4P
2P2P0.01
4.7k
0.1
2P 2P
10k100
(TBL)
12P
RPI-576TABLE
SENSORDTC114ESA
TBL ADDRESSENS SWITCH
MTZJ-T-77-3.6B
22k
1050V
10016V
(LEVER SW)
100
VREF
OUT2
RNF
OUT1
VM VCC
FIN
GND
RIN
IC701BA6956AN
LD MOTORDRIVER
VREF
OUT2
RNF
OUT1
VM VCC
FIN
GND
RIN
BA6956AN
DRIVER
IC712
TBL MOTOR
RE701ROTARY
ENCODER
M751(LOADING)
3030
HCD-GX450
5-6. PRINTED WIRING BOARD – MAIN SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
IC371
IC201
IC304
IC30
2
IC303 IC301
IC102
IC104
IC101
CONNECTBOARDCN254
(Page 33)
PANELBOARDCN601
(Page 37)
H/P JACKBOARDCN804
(Page 33)
TRANSBOARDCN907
(Page 40)
AMPBOARDCN441
(Page 41)
SUB-WOOFERBOARDCN501
(Page 35)
DRIVERBOARDCN701
(Page 28)
GAMEJACKBOARDCN801
(Page 33)
2928
3
1
R CHPB
HEAD
HP1
HP2
L CH
1
2
3
ERASEHEAD
DECK-B(REC/PLAY)
REC/PBHEAD HE1
HRP2
L CH
HRP1
R CH
1
2
3
4
3
4
(CHASSIS)
(CHASSIS)
12
FAN
TUNER
10
EE
E
E
E
E
E
E
E
E
E
E
E
E
E
E
EE
E
E
E
9 1
1
19
336
8
1
5
11 1
1 3 1 3 1
1
3
3
E
E
E
E
E
13 1
E
E
E
E
E
121
3 1
31
1 4
1 2
A
B
C
D
E
F
G
H
I
J
K
3 4 5 6 7 8 9 10 11 12 13
DECK-A(PLAY)
JW146
R310
R308JW108
Q313
R311
C376R312 JW122
JW151
Q309
JW125
JW121
JW126
JW127
JW123
JW124
C354
C374
C373
C372
R374
R375
R376
R377
R378
R139
R138
C371
R371
R372
C375
R373
JW150
JW129
JW128
R272
JW130
JW131
JW132
JW133
JW134
CN30
2
FB20
3FB
204
FB202
FB201
C217
C222
C216
JW136
JW135
JW137
JW140
JW139
C214
R203
JW138D324
D325
D326 R249
C250
JW98
JW97
JW96
JW95
R358
JW94
C353
Q352
LP30
3
CN30
9
R216
R217
JW20
1
JW93
JW92
JW91
JW90
JW89
JW87
JW81
JW85
JW84
JW15
7
JW83
JW82
JW86
JW88
R219
R218
LP30
4
JW20
2R3
97
C235
EP10
1
R396Q371
LP30
2 JW15
8
R395
R390
R389
R387
R386
R385
R391
D321
R388
R394
R392
R393
D322 R313
R363
R325
R322
C321
R354
R351
D215
C259
R266
D214
D213
D212
R265
C258
R357Q351
R352R356
R353
C351
R264
C352
R214R213
R252
Q324R250
R251
D211
R246
R247
Q323 Q322
R248
JW100
JW99
JW101
CN11
2
C264
C265
C112
C111
Q305
R205
R207
R202
C107
R210
R204
Q304
R201
R282
C113
JW10
6
R281
C211
R206
JW141
Q307R209
Q306
Q102
R105
C106
C102
R211
R208
R212
R103
C105
C206 C1
10C104
R101
C101
R104
C193
C213
R108C1
59
C109
C108
C103
R198 R1
97R1
07
R106
R283
C114
C247
R244
C245
R243
R284R109
C115
JW159
R111C191
R113
C120JW155
C121C119 R1
16
R117
R114 C1
22
R115
JW10
4
C248
R242
C242
C318
C315
Q321
C311
C116
C192 C2
41C2
44
JW10
3
C118
C117
R110
R195
L101 C243JW102R245
C249
C267 C266
CN103 C246
JW79
C251
Q327
R263
R262R253
C252
C253 R364
Q362
C270
JW78
R321
JW156
Q315
Q314
Q361
R362
R361
R323
R324
JW80
D316R274
R275
C316
Q308
R306
R307
R384
R383
R382
R381
R379
R380
JW14
5
JW10
9
JW110
JW112
JW113
JW114
R280
JW115
JW12
0
JW11
9
JW11
6
JW11
7
JW11
8
C212
JW142 C160
C157
C153
C152
C164
C162
C154
R142 R141
JW311
R137
C151
R136
C150
C149
C146
R135
JW10
7
C144
C148
R133
C145
C142
C141
C275
R132
R134
C140
C139
C274
C136
C135
C147
R131
R176
C143
JW33
JW34
JW35
Q106
R129
R169
R128
R177
R127
Q107
C137
C133R126
R125C127
R121
C134R124
C128
JW38
C126
JW37
C129
C131
R172
R182
C181
R123
C130
R120 R119
C132 C186
C187
R196C125JW39
C124R112
R194
R241
JW43
JW42
C123JW41
JW40
JW44
JW45
R118
C184
R171C183
R170
C138
JW36
R168 R167 R166
C177C179
C180 C178
R161
R165
C185
R160
R164
C176
C312
JW32
C308
D313
C309
JW50
JW77
JW76
JW65
JW64
JW75
JW74
JW73 JW
72
JW71
JW70
JW49
R151
R152 Q1
01
Q103
Q104
R154
R159
R163
R223
R222 R2
21
D201
Q312R2
32
R155
JW48
JW47
JW46
C313 C310
JW66
JW67
D312
D310
D311
D309 D3
05
D307
D306
D308 D3
01
D303
D302
D304
JW63
JW62
JW61
C306 C305 C303 C304C301 C302
CN303
JW69R273
JW30
5
JW58
JW59
CN307
JW55
JW52
JW51
JW53
JW54
JW56
JW57
JW148JW149
R156
C175
D315
R153
Q102
R158
R157
JW30
JW31
R231
R220 R229
JW302
R230 D207
D206
D205
D204
D203
D202
C230 Q311
R227
R228C229
R226 R225Q310
R147
JW29
D314
JW301
JW10
5
CN306
R271 C231
CN314
R270
R269R268
C194
R173
C203R192R199
C196R181
R182
R187
C190
C189
R175
R174
C188
Q108 R1
93Q3
03
R178
Q105
JW26
C198
R184
C202
JW27
R189
R186
C199
JW20
JW19
JW24
JW23
JW21
JW22
JW17
C342
R342
R341
R343
R344
R345
R347
R346
JW16
JW15
JW14
JW13
JW12
JW11
JW10
JW9 JW
144
JW14
3
LP30
1
JW1
C166
C228
JW8
C165
CN308
JW7
JW6JW5
JW4
JW3
JW2
CN101
R348
JW18
CN301
JW30
3
EP30
1
JW68
Ref. No. Location
• Semiconductor LocationRef. No. Location
D201 I-10D202 H-10D203 H-11D204 H-11D205 I-11D206 I-10D207 I-10D211 F-4D212 G-5D213 G-5D214 G-5D215 G-4D301 I-8D302 I-8D303 I-8D304 I-8D305 I-7D306 I-7D307 I-7D308 I-7D309 I-7D310 I-6D311 I-6D312 I-6D313 F-8D314 F-9D315 H-8D316 G-6D321 H-5D322 H-5D324 E-4D325 E-4D326 F-4
IC101 D-6IC102 D-8IC104 D-11IC201 E-5
IC301 G-8IC302 E-9IC303 G-7IC304 G-7IC371 B-4
Q101 H-9Q102 H-9Q103 H-9Q104 H-10Q105 E-10Q106 D-7Q107 D-7Q108 F-11Q303 E-11Q304 E-4Q305 E-4Q306 B-4Q307 B-4Q308 B-4Q309 B-3Q310 H-10Q311 H-11Q312 H-10Q313 B-3Q314 G-6Q315 G-6Q321 F-7Q322 F-4Q323 F-4Q324 F-4Q327 G-5Q351 G-4Q352 G-4Q361 G-6Q362 G-6Q371 I-5
3131
HCD-GX450
5-7. SCHEMATIC DIAGRAM – MAIN SECTION (1/2) –
EP101
C177
C180 C182
C187
C141
C145
C176
D201
D206
D20
7
R176
R177
R159R163
R166
R153R154
R136
R125
R227 R228
R202
R203R204
R217
R138
R151
R221
R222
R225
R229
R23
0
R231
R232
R109
R110
R11
2
R394 R393
R392
R391
Q106
Q304
D324
D325
Q310
R170
R172
R201
R207R206
R113
R162
R158R157Q311
C124
Q101
C229
Q312C228
C235
R226
IC101C193
C206
R115 R129
R155
R272
C188
C203
R118
R173R174
R175
Q105
Q108
Q303
IC104
R271
R270
R181
C190
R184
R186R187
R189
Q371
R385
R390
R386
R396
R397
R101
R199
Q102
Q305
D202
C179
C181
C274
C275
R282
R283
R284
R168
R135
R111 R114
C231
R178
R12
6
R132
R131
R128
Q103
Q104
Q306Q307
R182
R192
D326
C185
IC102
C186
C184
R269
R268
R169
C175
R165 R161
C178
C183
C165
C164
C16
0
C152
C15
3
C162R141
R133
C143C142
C138
C137
C123
C12
7
C102
C125
R196
R117
C132
R120
C12
8
C129 C1
30
R123C134R124
R121
R127
C13
1
C13
3
C147
C144
C149
C151
C150
C148
R134
C146
C101
R198
C118
R195
C115
C192 C191
R194
C122
C11
9
C114
C113
C112
C111 R281
R208
R209
R205
R210
R211R212
R193
C196
C198
C199
C194
C211
C213
C212
C216 C222
C214
FB201
FB203
FB204
C217
FB202
R387
R388R395
R220
R219
C103
R104
R103
C105
C106
C104
C110 R107
C109 C108
R197
R108
R106
CN308
C230
R152
C189
Q107
CN307
CN314
JW311
R389
JW202JW201
D205
D204
D203
R223R167
R164
R171
R160
R142
C154
R137
C157C159R
139
R105
C107R102
C117 C12
1
C140
C139
C13
5
C136
R116
R156
R216
R218
C11
6
C120
R11
9
CN309
C202CN306
C166
22p
220p 220p
0.01
10 50V
10 50V
10 50V
1SS355
1SS355
1SS
355
220k
220k
10k10k
10k
10k10k
4.7k
10k
1k 1k
10k
10k10k
56
1k
4.7k
22k
5.6k
4.7k
4.7k
4.7k
10k
10k
470k
330k
470k
1k 10k
1k
10k
2SC3052
2SC3052
10EDB40
10EDB40
2SC2001
10k
100
4.7k
2.2k47k
330k
2.2k
2.2k47k2SC2001
100p
2SC3052
4.750V
2SA9530.1
0.1
47k
BD3401KS22200p
2200p
1M 47k
4.7k
470k
2250V
10 50V
10k
10k10k
10k
2SC3052
2SC3052
2SC3052
NJM4565M
10k
1k
47k
0.01
4.7k
33k47k
100
2SC3052
4.7k
22k
22k
4.7k
10k
10k
220k
2SA1235
2SA1235
MTZJ-13B
47p
47p
47p
47p
2.2k
2.2k
2.2k
100k
4.7k
0.1
10k
10k
2SC3661
2SC3661
2SC36612SC3661
33k
22k
1050V
NJM4565M
4716V
4716V
2.2k
10k
100k
2.2 50V
10k 10k
4716V
22p
1 50V
150
V
0.0022
0.00
22
4.7k
150V
1050V
1050V
1050V
2250
V
100
10V
1 50V
100p
C126
1000
p
0
100
4716V
1M
100
10V
4716
V
4716
V
10k0.1 M10k47k
0.04
7
0.04
7
10 50V
0.1
0.01
0.01
0.01
0.01
4.7k
0.1
1 50V
2.2k
1050V
0.01
2.250V
2.250V
1050V
0.01
1 50V
1 50V
1 50V
1 50V 2.2k
1k
10k
4.7k
2.2k
1k10k
1k
4716V
0.22
0.33
1050V
2.2 50V
10 50V
10 50V
0.1 0.1
100010V
0
0
0
0.1
0
4.7k
22k22k
22k
0.1 50V
15k330k
220p
0.01
0.150V
1050V 15k
0.01 220p
2.2k
330k
3P
4716V
10k
2250V
2SC3052
13P
4.7k
JWJW
JW
JW
JW
100k10k
10k
10k
10k
0.00
474.7k
150V
150V
1050V10k
330p 33
0p
100
470k
56
47k
5P
100 16V4P
1 50V
150k150k
10EDB40
0.06
8M
4.7k
15k
15k
1 50V
1 50V1k
0.06
8M
4.7k
0.068M
0.068M
6.8k
220p
CH
6.8k
220p
CH
PH-S(3P)
6802W
390
1k
0
390
680 2W
3232
HCD-GX450
5-8. SCHEMATIC DIAGRAM – MAIN SECTION (2/2) –
IC30
2
C310
C311
D301
D304D303
C309
C312
C313
C318
D305D306
D307
Q322
R263
R264
R265
C258
R266
R262C253
R253
C315
R243
R244
R247
Q324
R250R251
R249
EP301
D30
9
D310D312
D311
R384
R379
R374
R375
R376
R377
R378
C375
C372
C373
Q361
R361R362
R364
R363
Q351
C351
Q352
R344
R245
C266
HE1
C265
C308
D315
D314
R307
R306
R308
R31
1
R310
R313
R274
Q313
Q309
Q314
C321R322
R324
D321
R325
D316
R323
IC30
1
IC30
4
Q323
C250
Q321Q327
D214
D213
D212
L101
IC30
3
C241
D211
C316
Q362C270
R356
R353 R352R351
R357R354
R358
R34
8
IC201
C249
HRP1
HRP2
HP1
HP2
D313
C251
R21
3
R21
4
C376
D322
Q315
R321
D215
C354
C342
CN301
R346 R345
R342 R341
R343
R347
R248
C352
C267
CN103
C246C248
C244C242
R241
R246
R252
R373
R372
R371
C374
D302C303
C304
C302
C301
R273
R275
C252
C259
R242
R383
R382
R380
R312
Q308
JW301
CN112
C264
C353
CN303
C306
JW303
JW302 JW305
C371
IC371
C247
C245
D30
8
C305
R381
C243
CN302
330025V
1050V
10EDB40
10EDB4010EDB40
2250V
1050V
220025V
100 16V
10EDB4010EDB40
10EDB40
2SA1235
1M
1k
10k
0.4750V
100k
3.3k0.1 50V
100
10016V
10k
2SB1116
10k10k
47k
10ED
B40
10EDB4010EDB40
10EDB40
10k
10k
10k
10k
10k
10k
10k
0.1
100p
100p
2SA1235
10k2.2k
4.7k
4.7k
2SC3052
1000p
2SC3052
22k
4.7k
1000p
1000p
2250V
10k
10k
2.2k
4.7k
10k
4.7k
0
2SC3052
2SC3052
2SA1235
2.250V
22k
10k
1SS355
4.7k
1SS355
4.7k
TA78
033L
S
TA78
09S
2SC3052
4716V
2SC20012SC3052
1SS355
1SS355
1SS355
TA78
09S
1000p
1SS355
220025V
2SC305210 50V
470
47k 100k15k
2.2k4.7k
100
22k
BA3126N
1050V
11EQS04
47 16V
1k1k
2.250V
1SS355
2SC3052
4.7k
1SS355
0.1
0.1
12P
1k 10k
1k 10k
22k
22k
10k
22 50V
1000p
8P
1000p
0.0150.0047
10
100
100
100
100
4716V
10EDB400.1
0.1
0.1
0.1
0
0
10016V
0.22 50V
10k
10k
10k
22k
2SA1235
JW
3P
1000p
2.250V
11P
0.1
JW
JW JW
100p
BU2099FV
0.01
1000
p
10ED
B40
0.1
10k
29P
TA78
033L
S
8.2k
8.2k
10EDB40
10EDB40
0.015M
0.015M
0
27k
3333
HCD-GX450
5-9. PRINTED WIRING BOARD – PANEL COMB SECTION – • : Uses unleaded solder.• See page 21 for Circuit Boards Location.
Ref. No. Location
LED610 B-7LED611 B-6LED612 B-6LED613 C-6LED614 C-6LED615 C-7
• SemiconductorLocation
(CHASSIS)
(CHASSIS)
VIDEO
AUDIO
L R
GAME INPUT
MAINBOARDCN314
(Page 30)
E
PANELBOARDCN604
(Page 37)
JPANELBOARDCN605
(Page 37)
M
VIDEOOUT
6
5
5
1
1
1
2
MAINBOARDCN309
(Page 30)
PHONES
MASTER VOLUME3 1
(AMS- HML-)
(AMS+ HML+)
(ILLUMINATIONLIGHT)
MAINBOARDCN305
(Page 30)
BD81ABOARDCN201
(Page 26)
PANELBOARDCN603
(Page 37)
1 2
A
B
C
D
E
F
3 4 5 6 7 8 9 10 11
2 1
1
3
LED610-LED615
FB251FB252
JW261CN253
JW252 JW253
JW254
JW255 JW257
JW256
JR252 JW258
JW259
CN251
JW251C
257
CN
254
C25
6C
255
C25
4
C25
2C
251
JR25
1
C25
3
R80
1
R80
2
CN
801
CN802
WIRE804
R803
C801
JR801
R804
C802
C803
WIRE801
C804
J804
LED
612
CN
607
LED
613
R70
5
R70
7
R70
9 LED
615
CN
606LE
D61
0
R69
9
R70
1
R70
3
LED611
R673
LED614
SW601S660 J801
JW83
1
CN
804
C83
1
C830 C832
W803
CN
805
LP802
J803
3434
HCD-GX450
5-10. SCHEMATIC DIAGRAM – PANEL COMB SECTION –
R801
R802
R803
R804
LED
611
LED
612
LED
613
LED
614
LED
615
R673
R699
R7
01
R7
03
R7
05
R7
07
R7
09
S660SW601
LED
610
W803
FB251
FB252
CN254
JW252
JW253
JW255
JW257
JW258
JW259
C257
C251
C25
2
C25
3
C254 C25
5
C25
6
CN253
JW254
JW251
CN251
CN607CN606
CN804
C830 C831
C832
J801
C801
C802 C804 C803
CN801
CN802
J804
JR801
CN805J803
WIRE801
JW256
JW261
WIRE
5P
1000p 1000p
0.1
2P
10k
10k
22k
22k
ENCORDERVR
SW ESE24SV
22k
22
01/8
W
220
1/8
W
220
1/8
W
220
1/8
W
220
1/8
W
220
1/8
W
SEL
U52
23C
-STP
15
SEL
U52
23C
-STP
15
SEL
U52
23C
-STP
15
SEL
U52
23C
-STP
15
SEL
U52
23C
-STP
15
SEL
U52
23C
-STP
15
EMI
EMI
9P
JW
JW
JW
JW
JW
JW
0.1
100p
0.01
100p
470p 0.1
0.1
17P
JW
JW
27P
5P6P
470p
470p 0.22 0.22
3P
2P
0
JW
JW
3535
HCD-GX450
5-11. PRINTED WIRING BOARD – SUB-WOOFER SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
Ref. No. Location
D501 C-3D502 C-5D503 C-5D504 B-6D505 C-8D506 C-7D507 C-2
IC501 D-3
Q501 D-5Q502 C-8Q503 C-6Q505 C-7Q506 C-7Q507 D-1
• SemiconductorLocation
IC501
MAINBOARDCN306
(Page 30)
AMPBOARDCN443
(Page 41)
1
17
4
SUB WOOFER OUT
CONTROL
(IMPEDANCE USE 6–16 )
E
E
E
E
EE
1 2
A
B
C
D
3 4 5 6 7 8
R516
R532
RY501
JW514
JK501
CN503
JW519
D504
LP501CN502
R506
R50
9
R50
5
D50
1
D50
7
C506R
503
R50
2
R50
1
R53
1
R53
0
Q50
7
R52
9
C504
C50
2
C50
3C
518
C50
5
R50
4
R50
7
C50
8
R50
8
C507
C511 R51
0
R51
1 D50
2
D50
3R
515
R51
4
R51
3Q
501
CN501
C509
C516
C510
JW513
JW504
JW506
JW520JW
501
JW503
JW50
5
JW50
7
JW51
5
JW51
6
JW50
9
JW51
7
JW51
0
JW51
1 JW51
2
JW50
8
R52
0
Q50
3
R53
3
C51
7Q
506
Q50
5R
524
C51
4
C515
R51
7
Q50
2D
505
R52
6
R52
7
D50
6
R52
8
JW51
8
C51
3C
512
R51
2
R51
8
R51
9
R52
5
3636
HCD-GX450
5-12. SCHEMATIC DIAGRAM – SUB-WOOFER SECTION –
Q501
Q503
Q505
Q506
R506
R507
R508
R509
R510 R511
JW501
C502
C505
R50
2
R50
3
R504
R514R515
R517
R525
R526R527
RY501R505
C504
R518
R519
JW520
R524 R520
C517 R533
R532
C514
CN502
C515
C506 C509 C510
C511
C513
C512
R512
R513
JK501
CN503
Q502
R516
R501C503R529
C507
R528
IC501
Q507
R530
R531
C516
D506
D505
D507
D50
1 D50
3
D50
2
D50
4
C508
CN501
2SC1841
2SC2785
2SC2785
2SC2785
1 1/4W FR
4.7k1/2W
4.7k1/2W
100 1/4W FR
0.225W
0.225W
JW
220p50V
10p50V
47k
1/4W
1k1/
4W
47k1/4W
22k1/4W 47k
1/4W
10k1/4W
22k1/4W
8.2k1/4W1M
1/4W
SP RELAY12V
4.7k 1/2W
2225V
2.2k1/4W
2.2k1/4W
JW
47k1/4W
100k1/4W
1050V
22k1/4W
22k1/4W
10035V
7P
4.750V
10025V
100100V
10100V
10100V
0.1
0.1
101/2W
1k1/4W
2P
2SA1175
1001/2W
47k1/4W
4700p16V
2.2k1/4W
4750V
10k1/4W
STK404-130S
2SC2785
22k1/4W
4.7k1/4W
1050V
MTZJ-T-77-6.8B
1SS133T-77
1SS133T-77
MTZ
J-T7
7-12
B
1SS1
33T-
77
1SS1
33T-
77
1SS1
33T-
77
220p 50V
4P
3737
HCD-GX450
5-13. PRINTED WIRING BOARD – PANEL SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
IC610
IC602
IC60
4
IC603
IC601
CONNECTBOARDCN253
(Page 33)
MAINBOARDCN302
(Page 30)
6 STREAMLED BOARD
CN607(Page 33)
6 STREAMLED BOARD
CN606(Page 33)
TAPEMECHNISM
DECK
GAME MIXING
GAME
TUNING-
TUNER/BAND
DISPLAY
ILLUMINATION
TAPE A/B
CD
x
X
MALBUM–
CD SYNC
RECPAUSE/START
PLAY MODE/TUNING MODE
DISC 1
DISC 2
DISC 3
GROOVE
SURROUND
EQ BQND
RESET EQ
P FILE
EFFECTON/OFF
DISC SKIPEX-CHANGE
ENTER
M
ALBUM+
h
TUNING+
(CHASSIS)
1 5 10 15 20 25 30 35 41 45
51 50
31
30
11
1 3
45
3
1
3
100
81
80
11
65
E EE
E E E
20 11
101
E
E
E
E
E
3
15
13
4
1 2
A
B
C
D
E
F
G
3 4 5 6 7 8 9 10 11 12 13
(FLUORESCENT INDICATOR TUBE)
*1
*1
LC87
6996
A ty
peus
ed fo
r IC6
01
R 6 2 9
JW6
01
JW6
02
JW8
09
JW8
08
JR6
17
R7
85
R7
83
R7
82
R7
81
R7
78
R7
77
R7
76
R7
75
R7
74
R7
71
JR6
10
D6
26
D6
23
D6
21
R7
70
R7
17
R7
18
R7
16
R7
69
R7
68
R7
67
R7
66
R7
65
R7
64
R7
63
R7
62
R7
61
R7
60
R7
59
R7
58
R7
57
R7
56
R7
55
R7
54
R7
53
R7
52
R7
51
R7
50
R7
49
C6
40
R7
48
C6
39
R7
47
C6
38
R7
46
C6
37
R7
45
C6
36
R7
44
C6
35
R7
43
C6
34
R7
42
C6
33
R7
41
C6
32
R7
40
C6
31
R7
39
C6
30
R7
38
C6
29
R7
37
C6
28
Q6
16
R6
84
R7
72
R6
44
R6
43
D6
05
R6
41
R7
36
R6
42
R6
54
R6
53
R7
35
R6
75
R6
72
R7
31
R6
59
R6
38
R6
60
R6
40
D6
03
R6
39
D6
04
R6
74
CN
61
0
R7
89
C6
20
C6
47
C6
22
C 6 2 1
C6
41
R7
19
R6
46
R6
45
R6
47
JW7
86
R 7 8 0
R 7 7 9
J W 7 9 1
C N 6 0 3
S 6 0 4
R 6 2 8
R 6 2 7
S 6 0 5
S 6 0 6
S 6 4 3
R 6 6 5
S 6 4 2
R 6 9 0
R 6 9 3
R 6 9 1 R 6 9 2
R 6 9 4
R 6 9 5
R 6 9 7
R 6 3 5R 6 7 6
R 6 6 4
S 6 1 1
S 6 1 2
R 6 5 2R 6 7 8 R 6 6 3 R 6 7 7
D 6 3 0
J R 6 2 2
J R 6 2 3
S 6 0 7
S 6 0 8
S 6 1 0
C6
48
R6
20
R6
14
R6
12 R
79
7R
61
1R
60
2R
61
3 R6
03
R6
06 R6
19
R6
01
R6
18
R7
99
R7
98
R6
15
R6
17
R6
16
R6
08
R6
07
R6
10
R6
70
C 6 1 2
S 6 0 3
C 6 5 4
R 7 7 3
R 7 8 4
R 7 9 5
R 7 9 4R 7 9 3
R 7 9 2R 7 9 6
S 6 4 6
R6
69
R7
90
R6
09
R6
04
R6
05R
66
8
S 6 4 5
S 6 4 4
C 6 5 5
C N 6 0 2
R6
48
R6
49
R6
50
R6
51
R7
34
CN
60
1
R 6 9 6
R6
67
R6
66
S 6 4 1J W 7 9 0
J W 7 8 9
J W 7 8 8
J W 7 8 7
J W 7 8 0J W 7 9 4J W 7 9 3
J W 7 9 2
JW7
85
JW7
79
JW7
78
JW7
66
JW7
68
JW7
61
JW7
62
JW7
58
JW7
56
JW8
12
JW7
54
JW7
52
JW7
38
JW7
44
JW7
43
J W 8 1 0
J W 7 5 0J W 7 4 5
J W 7 4 6
JW7
64
JW7
65
JW7
67
JW7
49
J W 7 6 0
J W 7 4 7
J W 7 4 8
JW7
63
JW7
59
JW7
57
JW7
55
JW7
53
JW7
51
JW7
35
JW7
34
JW7
33
JW7
32
JW7
31
JW7
30
JW7
29
JW7
28
JW7
22
JW7
23
JW7
24
JW7
21
JW7
17JW
70
9
JW7
10
JW7
11
JW7
08
JW8
04 JW
80
3
JW8
02
JW8
07
JW8
06
JW8
05
JW7
00
JW8
00
JW8
01
JW7
07
JW7
06
JW7
05
JW7
04
J W 6 9 9 J W 6 9 8 J W 6 9 7 J W 6 9 6
F L 6 0 1
J W 6 9 5 J W 6 8 9
J W 6 9 4
C 6 4 2
C 6 4 9
R 7 8 8
JW6
92
JW7
14
JW7
13
JW8
13
JW6
83
JW6
75
JW7
36
JW7
37 JW
67
4 JW6
73
JW6
72
JW6
71
JW6
69
JW6
70
JW6
68
JW6
67
JW6
66
JW7
39
JW6
60
J W 6 6 2
J W 6 6 1
J W 7 4 0
JW6
59
JW7
41
JW6
58
JW6
57
JW6
56
JW6
55
JW6
54
JW6
53
JW6
52
JW6
51
JW6
48
JW6
45
JW6
76
JW8
15
J W 6 7 9
J W 6 7 8
J W 6 7 7
J W 6 3 9
J W 6 3 5
J W 6 2 7
J W 6 3 3
J W 6 2 6
J W 6 2 5
J W 6 1 9
J W 6 1 8
J W 6 1 7
J W 6 1 6
J W 6 1 5
J W 6 1 0
J W 6 1 4
JW6
44
JW6
43
JW6
08
JW6
07
JW6
28
JW6
29
JW6
30
JW6
32
JW6
86
JW6
24
JW6
23
JW6
22
JW6
21
JW6
13
JW6
12
JW6
11
JW6
47
J W 6 6 4
J W 8 1 1
J W 6 6 3
JW6
82
JW6
81
JW6
80
J W 7 1 9
J W 7 2 0
JW6
93
JW6
91
JW6
90
R8
54
R6
36
R6
37
R7
87
R7
25 JR
61
1
C6
13
D6
11
Q6
10
Q 6 1 1
D 6 1 6
R 6 2 4
Q 6 1 3 Q 6 1 5
C N 6 0 5C N 6 0 4
Q 6 1 4R 7 0 6
R6
21
R6
15
Q6
01
JR6
21
Q6
03
R6
25 R6
22
R6
26
Q6
02
R6
23
R7
04
R7
00
R7
02
R7
08
R6
98
R7
11
R7
10
R7
13
R7
12
C6
18 C
61
7R
72
2
R6
61
C6
04
JR6
14
C6
01
R6
32
C6
02
R6
33
C6
03
R6
34
JR6
03
JR6
09
JR6
07
R6
55
R6
56
R6
58
R6
57
R6
62
R7
24
S 6 4 8R 7 2 0
J W 6 6 5
S 6 4 7
J W 6 4 6
J W 6 0 6J W 6 4 1
J W 6 3 7
J R 6 0 8
S 6 2 7
S 6 2 3
J W 6 3 4
S 6 2 7
C 6 1 5
C 6 0 8
R 6 8 5
R 6 7 1
S 6 2 4
S 6 2 8
S 6 2 9
R 7 2 1
S 6 5 0
S 6 3 0
S 6 4 9Q 6 1 2
D6
09
C6
09
C6
06
C6
46
R6
86
R7
28
C 6 4 3R 7 3 3
X 6 0 2
Q 6 0 5
R 7 2 3
R7
27
R7
32
X6
01
C6
25 C
62
4
C6
26 C
60
7
R6
81 R6
80
C6
53
R7
14
JR6
12
R7
29
R7
30
R6
79
R8
63
C6
10
D 6 1 4
D 6 3 1
C 6 1 4S 6 2 6
S 6 2 1
J R 6 2 4
S 6 2 2
C 6 1 1R 6 8 2
R 6 8 9R 6 8 7
C 6 1 9
C 6 2 3
Q 6 0 4
R 6 8 3
R 7 8 6
S 6 0 2 L E D 6 0 1 S 6 0 1R 7 9 1
R6
88
D6
08
D6
32
C6
44
C6
05
D6
07
R7
15
D6
10
D6
13
CN
60
8
JW6
88
JW6
87
W I R E 8 0 6
JW8
14
JW7
03 JW
70
2
JW7
01
JW7
16
JW7
15
JW7
18
JW7
25
JW7
26JW
72
7
JW7
69
JW7
70
JW7
77
JW7
76
JW7
75
JW7
74
JW7
73
JW7
72
JW7
71
J W 7 9 9
J W 7 9 8
J W 7 9 7
J W 7 9 6
J W 7 9 5
Ver. 1.1
*1 IC601, R789When IC601 is exchanged for LC876A type,remove R789. (R789 : Location C-4)
Ref. No. Location
• Semiconductor LocationRef. No. Location
D603 C-11D604 C-11D605 C-10D607 C-10D608 D-8D609 D-8D610 D-8D611 D-8D613 D-9D614 C-9D615 F-6D616 F-6D621 B-6D623 B-6D626 B-5D630 E-4D631 C-8D632 C-9
IC601 C-7
IC602 D-11IC603 D-9IC604 C-8IC610 C-12
LED601 B-11
Q601 F-6Q602 F-7Q603 F-6Q604 B-9Q605 C-8Q610 E-8Q611 E-7Q612 E-7Q613 F-7Q614 F-8Q615 F-8Q616 A-9
Original Part Repair Part
6-804-130-01 LC876996A-52S4-E 6-804-130-01 LC876996A-52S4-E
1 This IC is not compatible with 2
and 3.
6-804-440-01 LC876996A-53H2-E 6-804-440-01 LC876996A-53H2-E
or
2 6-805-469-01 LC876A96A-55D8-E
When the above IC is exchanged,
remove R789.
3 6-805-469-01 LC876A96A-55D8-E 6-805-469-01 LC876A96A-55D8-E
Attention when exchanging IC601
3838
HCD-GX450
5-14. SCHEMATIC DIAGRAM – PANEL SECTION (1/2) –
R635
R691
R692
R693
R694
R695
R696
R697
R731
R63
4
R63
2
R63
3
JW811
JW65
5
JW65
6
JW65
8
JW67
4JW
705
JW71
8
JW63
5JW
701
JW71
4
JW659
R672
JW601
JW602
R629
JW660
Q610
Q612 Q611 Q614Q615 Q613
R698
CN604
CN605
R854R628
R627
R690
C65
5
JW641
R720 R671R721R722
R659R660R661R662 R658 R657 R656 R655 R654 R653
R675
R676R664R665R666R667R668R669R670
R663 R652 R651 R650 R649 R648 R647 R646 R645 R644 R643 R642
R674
S601S602S603S604S605S606S607
S608S610S611S612
S630S629
S628 S627S624 S623 S622 S621
S641S642S643S644S645
S646S647S649 S648S650
IC602
R704
R706
R708
R700
R702
C601 C602 C603
C644 C604
JR60
8
JR60
7 JR609
JW62
6
JW62
5
JW71
6
JW70
3
S626
CN601
D604
D603
R641 C605R640
R639
R638
D605
100
100
100
100
100
100
100
100
10
DTC143EKA-T146
220
6P
22010k
10k
100
0.1
6.8k 4.7k10k15k
3.3k4.7k6.8k10k 2.2k 1.5k 1.5k 1k 680 470
15k
15k4706801k1.5k1.5k2.2k3.3k
22k 15k 10k 6.8k 4.7k 3.3k 2.2k 1.5k 1.5k 1k 680 470
15k
29P
1SS355TE-17
1SS355TE-17
220k 4.750V12k
4.7k
1SS355TE-17
100
100
100
100
JW
JW JW JW
JWJW
JW
JWJW
JW
JW
10k
JW
DTC143EKA-T146
DTC143EKA-T146
DTC143EKA-T146 DTC143EKA-
T146DTC143EKA-
T146
5P
JW
BU2099FV
220
220
220
220
220
22p 22p22p
1016V 0.1
25V
00
0
JW
JW
JW
JW100
3939
HCD-GX450
5-15. SCHEMATIC DIAGRAM – PANEL SECTION (2/2) – • See page 49 for IC PIN FUNCTION DESCRIPTION.
R732
R717
R73
3
R73
4
R73
5
R60
5
R60
3
R60
1
R60
2
R60
4
R73
6
R771
R784
R787
R72
3
R72
5
R773
R75
0
R75
1
R75
2
R75
3
R75
4
R75
5
R75
6
R75
7
R75
8
R75
9
R76
0
R76
1
R76
2
R76
3
R76
4
R76
5
R76
6
R76
7
R76
8
R76
9
R77
0
R78
8
R79
1
R79
2
R79
3
R79
4
R79
5
R79
6
C654
R738
R739
R740
R741
R742
R743
R744
R745
R746
R747
R748
R621
R623
R625
R681
R680
R72
9
R73
0
R712
R713
R710
R711
R749
R777
R778
R775
JR617
R63
7
R63
6
R737
R789
JW812
JW707
JW706
R608
R622
JW607 Q602
JW608
D616
R626
R798
R616
R799
R618
R620
Q603
R615
R617
R619
D615
R624
JW606
R613
R797
R612
R614
R611
R609R790
R610
CN602
R60
7
R60
6
C648
C641
C618C617
IC601
C649C653
C607
D609D611
R72
7
R72
8X
601
C62
5
C624
C610 C611
X602
C647
D630 R678
D607
R679
R863
C646 C606C608
C609
Q604
R684R683R786
Q616
D610
D631
R688
D613R689
C615
IC604
D632
R687
C614R685
R686
Q605
C613
C612
D608
IC603
IC610
CN610
CN608
C623
C628
C629
C630
C631
C632
C633
C63
4
C63
5
C636
C637
C638
C639
C640
C622
R716
R718R719 LED601C621
C620
R772
JW673 JW721
JW670 JW724
JW723
JW728
JW729
JW722
JW70
8
JW70
9
C642
R714
R715C619
R785
R782
R781
R779
R776
R783
R780
R774
R682
D614
JR61
1
JR61
2
CN603
JR621
Q601
R677
D621
D62
3D626
FL601
C643
C626
JR624
WIRE806
470k
3.3k
100
1k 1k
4.7k
4.7k
4.7k
4.7k
47k
1k
47k
100
100
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100
100
100
100
100
100
100
0.1
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
100k
10k
10k
10k
220k
22k
100
100
10
10
10k
10k
100k
100
100
100
100k
*1
*1 R78947K: LC876996A type used for IC601no mount: LC876A96A type used for IC601
4.7k
1k
2SB1116-TP-LK
1SS355TE-17
1k
1k
10k
1k
10k
22k
2SB1116-TP-LK
22k
22k
22k
1SS355TE-17
1k
22k
1k
10k
22k
22k
22k1k
10k
13P
47k
4.7k
2216V
0.125V
1000p1000p
0.1330p
1000p
1SS355TE-171SS355TE-17
4.7M
4.7M
32.7
68K
Hz
22p
18p
10006.3V
0.1
10MHz
4710V
1SS355TE-17 100k
1SS355TE-17
100
100
2216V 1
0.011
2SA1175TP-HFE
1k220k10k
DTC143EKA-T146
UDZSTE-174.3B
UDZSTE-176.8B
470
1SS355TE-174.7k
2.250V
M62703ML
UDZSTE-173.6B
10k
0.147k
47k
2SC3052F
0.1
1016V
1SS355TE-17
MM1574A
RPM7240-H4
3P
3P
4.750V
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
4.750V
22k
22k3.3k SELU5223C -STP150.022
4735V
1k
0.1
100
4747
10V
100
10k
1SS355TE-17
0
2SB1068TP-K
0
0.1
0.1
0
WIRE(CHASSIS)
100
100
100
JR
10k
10k
JW
JW
JW
JW
JW
JW
LC876996A-52S4-ELC876996A-53H2-ELC876A96A-55D8-E
JW JW
JW JW
JW
JW
JW
JW
JW JW
100
100
100
100
100
470
100
0 0
17P
1SS355TE-17
1SS3
55TE
-17
1SS355TE-17
FL
*1
*1 IC601, R789When IC601 is exchanged for LC876A type,remove R789.Refer to Attention when exchanging IC601 (Page 37).
Ver. 1.1
4040
HCD-GX450
5-16. PRINTED WIRING BOARD – TRANS SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
Ref. No. Location
D901 B-3D902 B-2D903 B-2D904 B-2D905 B-2D906 C-10D908 C-8
Q902 C-9
• SemiconductorLocation
*
* Not replaceablebuilt in transformer
POWER TRANSFORMER(MAIN)POWER TRANSFORMER
(SUB)
1
1
1
3
3
2
E
1
10
MAINBOARDCN303
(Page 30)
F
AMPBOARDCN442
(Page 41)
N
1 2
13
AC
IN
1
2
1 2
A
B
C
D
E
F
3 4 5 6 7 8 9 10 11 12
D904 D905
D902 D903 JW918
JW92
3
JW90
6
JW92
2JW
921
JW92
0JW
902
JW924
JW91
0
JW903
CN90
1
CN904R902
LP903CN906
C906
C908
Q902 JW900
C909
FH907 F904 FH908
FH909 F905 FH910
FH911
FH913
F906
F907
FH912
FH914
JW926JW917
CN90
5C9
20
C921
C922
C924
C923LP902
C926
CN90
7
C925
JW93
0JW
929
JW909
R90
3
R90
4
D90
6
C910
PT901
C911
D90
8
R90
8
CN903
RY901CN902
PT902
D90
1
LP90
1
4141
HCD-GX450
5-17. PRINTED WIRING BOARD – AMP SECTION – • See page 21 for Circuit Boards Location. • : Uses unleaded solder.
Ref. No. Location
D401 F-3D441 D-6D442 D-6D443 D-2D481 D-6D482 D-4D483 C-9
IC441 B-7
Q441 D-6Q442 D-6Q481 D-9Q482 D-8Q483 D-8Q484 D-8Q485 C-4Q486 C-4Q487 C-4Q488 C-5Q489 C-9
• SemiconductorLocation
IC441
SPEAKER
(IMPEDANCE USE 6–16 )
+ - + -
LR
(CHASSIS)
(CHASSIS)
(CHASSIS)
MAINBOARDCN307
(Page 30)
TRANSBOARDCN905
(Page 40)
SUB-WOOFERBOARDCN502
(Page 35)
E
E
E
E
E
EE
E
E
E
1 7
13
13
1
1 2
A
B
C
D
E
F
G
3 4 5 6 7 8 9 10
R462
JW400
JW472
L442
R461
RY441
L441
D443
JW408
R407
JW409
JW416
JW418
JW419
JW41
5
CN44
1
JW41
0
JW43
3
C406
JW40
7
JW411
JW412JW417
R402
D401
C404 C403
JW44
5
R401
JW44
4JW
443
JW40
2
C405
JW43
4
JW40
1
R489
JW43
5
JW43
6
JW446
JW447
JW454
JW453JW452
CN443
JW455
JW456
JW457
JW458
JW459
JW460
JW461
JW462
JW43
7
JW43
8
JW43
9JW
440
D481
D482
R490
JW422
JW433 JW424JW425
JW473
JW474
Q488
JW426
JW427
JW420
JW421
JW414 C402
Q487
C408
EP40
1
JW413
C407
C486
R482
R488
R487 C4
87
Q485
R481
R448
R446
R442
Q486
C411
C442
C448
C444
R444
R414
R412
R413
R441 R4
47
JW45
1JW
442
C446
JW45
0C4
47
R445
C445
JW449
C443
R443
C441
R411
JW44
1
C489
JW428
JW429
R460
R458
D442
D441
R457
R459
R456
Q442
Q441
R455
JW430
JW431
R495
JW46
3
JW432
R496
R452
JW40
4
JW40
3
R451
JW46
6
JW46
7
TH441
C452
C454
Q483
Q484
EP49
1
R454 JW
464
R453JW
465
JW46
9
JW47
0
JW47
1
C492
Q489
C453
C451
R485
R484 R483
R486
C481
Q481
Q482
R466
R465
R492
R494R493
D483
C488
R491
R467
JW468
JK441
CN442
EP402LP401
4242
HCD-GX450
5-18. SCHEMATIC DIAGRAM – AMP POWER SECTION –
C403
C404
C441
C442
C908
EP401
EP402
Q441
Q442
Q481
Q482
Q483Q484
Q485
Q486
Q487
R441
R442
R446 R458
R459
R460
R495
RY901
D908
R902
C407
C408
D90
6
R492
R494
JW917
JW401
JW40
2
JW403
JW404
RY441
R481
R487
R488
R490
C911
C447
C448
L441
L442
R461
R462
D401
IC441(1/2)
IC441(2/2)
TH441
JW909
C405
C406
Q488
R451
R452
R411
R412
C446
JW441
JW442
FH908 FH907
FH910
FH912
FH909
FH911
F904
F905
F906
FH913FH914 F907
C906
R908
C910
C909
R903
R904
Q902
C924
C925
C92
6
CN906 CN902
D905
D903 D902
D904
D90
1
JW903
JW906
JW910
JW902
W001CN901
PT901
CN905
CN907
C402
R45
6D
442
D44
1
C489
R402
EP491
Q489
R467R491
C445R413
R493
C488
R447
C451
C453
D48
1
R453 C481
R485
R483
R484
R486
C444 R444R414
C487
R489
D48
2
C411
R401
D443
R407
R455
R466 R465
JW407
R496
R457
C486R482
C454
C452
R454
R448
R445
R443C443
C492D483
CN442
CN443
JK441
CN441
PT902
CN904
C92
0
C92
1
C92
2
C923
CN903
0.1100V
0.1100V
1050V
1050V
22063V
TERMINAL, EARTH
TERMINAL, EARTH
2SC1841
2SC1841
2SC2785
2SC2785
2SC27852SC2785
2SA1175
2SC2785
2SC2785
1k
1k
1k 22k
47k
47k
11/4W
FR
RELAY U
10EDB40-TB3
0.01
16V
0.01
16V
MTZ
J-T7
2-27
D
1k1/4W
2.2k1/4W
JW
JW
JW
JW
JW
SP RELAY12V
4.7k1/4W
33k1/4W
22k1/4W
4.7k1/4W
100025V
2235V
2235V
10 1/2W
10 1/2W
0.1
1 1/4W
10050V
1050V
12k
1k
2SA1932
0.1
0.1
0.1
3P 3P
10EDB40-TB3
10EDB40-TB3 10EDB40-TB3
10EDB40-TB3
1SS1
33T-
77
2P
3P
10P
0.0116V
1k1S
S13
3T-7
71S
S13
3T-7
7
100100V
100k
TERMINAL,EARTH
2SC1841
33k1/4W
22k1/4W
33k1/4W
2235V
0.1
0.1
1SS
133T
-77
101/2W
10010V
100k1/4W
100k1/4W
1000p
4.750V
4.7k1/4W
1SS1
33T-
77
0.0116V
100k
1SS133T-77
1001/2W
1k
56k1/4W
47k1/4W
JW
100 1/4W FR
22k
2.250V
10k1/4W
0.1
0.1
101/2W
1k
1000p
0.011SS133T-77
3P
13P
2P
0.01
0.01
0.01
0.01
2P
3.3M1/2W
JW
330063V
330063V
0.225W
0.225W
STK403-130
STK403-130
TH-10K
D10XB20
2SC2001LK
2.2k1/4W
2.2k1/4W
100p50V
JW
JW
T8.0AL/125V
T8.0AL/125V
T3.15AL/125V
T3.15AL/125V
JW
JW
JW
JW
AC CORD U
100p50V4.7k
1/4W
47k1/4W
221/4W
56k1/4W
47k1/4W
4.7k1/4W
47k1/4W
47k1/4W
7P
43
HCD-GX450
• IC BLOCK DIAGRAMS
IC251 BA5947FM (BD81A BOARD)
IC701, 712 BA6956AN (DRIVER BOARD)
1 2 3 4 5 6 7 8 9
CONTROL LOGIC
TSD
VREF
OUT2
OUT1
RNF
VM VCC
FIN
GND
RIN
15
16
17
1819
20
21
22
23
24
25
26
27
36
28
29
30
31
32
33
34
35
1
2
3
4
5
6
7
8
9
10
11
12
13
14
LEVELSHIFT
FR
R
F
RF
F
19k
6.5k
50k 50k
100k
50k
PIN310k
Vref
50k 50k
PIN26
(ch1, 2)
POWVCC
(ch3, 4)
SW
PreVcc
INTERFACE
INTERFACE
INTERFACE
R
F
50k 50k
POWVCC
MUT
E
Vref
POWVCC
RF
10k
CH1PUTF
CH1OUTR
CH2OUTF
CH2OUTR
POWVCC
CNF4
GND
C-M
C-P
VG
CH2RIN
CH2FIN
CH1RIN
CH1FIN
SW
OPIN+
OPIN-
NC
CH4OUTR
CH4OUTF
CH3OUTF
CH3OUTR
POWVCC
MUTE
GND
GND
PREGND
CT
CH3RIN
CH3FIN
CH4IN
CH4CAPA
OUTVREF
DPOUT
TREVCC
NC
D
D
D
D
D
D
D
D
44
HCD-GX450
IC301 TC94A34FG-002 (BD81A BOARD)
33
34
35
36
37
38
39
40
41
42
1
8
43
61 62 63 646059565250
47
46
45
44
48
49
2526272829303132 1718192021222324
9
10
11
2
3
4
5
6
7
5857555351
12
13
14
15
16
54
RAS
CAS
OE
WE
PIO
7
PIO
6
PIO
5
PIO
4
BusSwitch
BUCK
CCE
AD12
AD11
Gen
eral
In/O
utpu
t Por
t
Add
ress
Cal
c.2s
ets
Y-P
oint
erre
gist
erC
-Poi
nter
regi
ster
X-P
oint
erre
gist
er
VDDM
SRMSTB
VDDT
AD10
AD9
ER
AM
2k w
ord
CR
AM
4k w
ord
CR
OM
4k w
ord
YR
AM
4k w
ord
XR
AM
4k w
ord
SR
AM
/D
RA
M I/
F
SR
AM
I/F
1Mbi
tS
RA
MX
-Bus
Y-B
us
AD7
AD6
AD5
AD8
VC0Timing
Generator
PR
AM
Inst
ruct
ion
Dec
oder
Pro
gram
Con
trol
MC
U. I
/F
regi
ster
XO
• X
1 •
X2
Y0
• Y1
• Y2
MX
MY
MZ
MA
C
A0
A1
AX
AY
ALU
A2
A3
DIT
roun
d &
lim
itro
und
& li
mit
Aud
io I/
F
LRCKIA
BCKIA
SDI0
LRCKO
BCKO
SDO0
VSS
VDDT
MIACK
MICK
MIDIO
MILP
MICS
STANBY
RESET
VDDP
AD
4
AD
3
AD
2
AD
1
AD
0
VS
S
VD
D
CK
O
VD
DX
XO
TE
ST
VC
OI
VS
SXXI
MIM
D
VS
SP
PIO
3
PIO
2
PIO
1
PIO
0
VS
S
CK
I
VD
D
TX
O
SF
SY
SB
SY
DAT
A
PO
M
Sub
cod
eI/F
CD
P C
ont
I/F
45
HCD-GX450
IC101 BD3401KS2 (MAIN BOARD)
IC201 BA3126N (MAIN BOARD)IC371 BU2099FV (MAIN BOARD)IC602 BU2099FV (PANEL BOARD)
1
REC
SW1
2 3
PB S
W1
GND
4
CONT
5
GND
6
VCC
7
PB S
W2
8
GND
9
REC
SW2
VSS N.C.
DATA
CLOC
K
LCK
OUTPUT BUFFER (Open Drain)
12BIT SHIFT REGESTER
Q0 Q1 Q2 Q3 Q4
12BIT STORAGE RAGESTER
CONT
OROL
CIRC
UIT
L. P
. F
VDD
OE SO Q11
Q10
Q9 Q8 Q7 Q6 Q5
1 2 3 5 6 7 84 10
16 15 14 13 12 11
9
17181920
0
+
TNF2
TNF1
SUR1
SUR2
LINEOUT2
LINEOUT1
SAOUT2
SAOUT1
CAP
MIC
GAME L
GAME R
TUNER L
TUNER R
MD L
MD R
VOLO
UT1
TONE
OUT
1
TONE
OUT
2
AMS
OUT
BNF2
BNF1
MNF
1
MNF
2
MOU
T1
MOU
T2
BOUT
2
BOUT
1
BBNF
1
BBIN
1
VIN1
VIN2
VOLOUT2
BBNF2
BBIN2
LF1
LF2
LF3
LF4
SWOUT
FILTER
1/2 Vcc
Vcc
GND
VDD
SI
SC
ALC
CD L
CD R
TAPE
L
TAPE
R
PBNF
2
PBNF
1
PBOU
T2
PBOU
T1
TAPE
A1
TAPE
A2
TAPE
B1
TAPE
B2
RECN
F2
RECN
F1DI
GITA
LCO
NTRO
L
Di-L
IMIT
ER
RECO
UT2
RECO
UT1
46 45 44 43 42 41 40 39 38 37 36 35 34 3348 47
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
SURROUND
ATT ATT
BUFFERMIX
MIC MIXVOCAL FADER
+-
+-
BASS MIDDLE TREBLE
BASS MIDDLE TREBLE
G fc=100HZ
f
ALC ALC
INPUTSELECTOR
+
+-
+-
+-
+ -
+ -+ -+-
+-
+- + -
+ -
+-
+-
+-
+-
+-49
SOFT
SWIT
CH ++-
+ -
+
46
HCD-GX450
5-19. IC PIN FUNCTION DESCRIPTION• IC101 CXD3059AR (RF AMP) (BD81A BOARD)
Pin No
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
I/O
I/O
I/O
I/O
—
I/O
O
I
—
O
O
O
O
O
O
—
—
—
—
I
I
I
O
I
O
I/O
I
I
I
I
—
—
O
I
O
I
O
I
—
I
—
O
I
—
I
I
O
O
I
—
Pin Name
MIRR
DFCT
FOK
VSS
LOCK
MDP
SSTP
IOVSS1
SFDR
SRDR
TFDR
TRDR
FFDR
FRDR
IOVDD1
AVDD0
AVSS0
NC
E
F
TEI
TEO
FEI
FEO
VC
A
B
C
D
NC
AVDD4
RFDCO
PDSENS
AC_SUM
EQ_IN
LD
PD
NC
RFC
AVSS4
RFACO
RFACI
AVDD3
BIAS
ASYI
ASYO
VPCO
VCTL
AVSS3
Description
Mirror signal input/output (Not used)
Defect signal input/output (Not used)
Focus OK signal input/output (Not used)
Internal digital ground
GFS is sampled at 460Hz; when GFS is high , this pin outputs a high signal
If GFS is low eight consecutive
Spindle motor servo control output
Disk innermost detection signal input
I/O digital ground
Sled drive output
Sled drive output
Tracking drive output
Tracking drive output
Focus drive output
Focus drive output
I/O digital power supply
Analog power supply
Analog ground
Not used
E signal input
F signal input
Tracking error signal input to DSSP block
Tracking error signal output from RF amplifier block
Focus error signal input to DSSP block
Focus error signal output from RF amplifier block
Center voltage output from RF amplifier block
A signal input
B signal input
C signal input
D signal input
Not used
Analog power supply
RFDC signal output (Not used)
Reference voltage pin for PD
RFAC summing amplifier output
Equalizer circuit input
APC amplifier output
APC amplifier input
Not used
Equalizer cut-off frequency adjustment pin
Analog ground
RFAC signal output
RFAC signal input or EFM signal input
Analog power supply
Asymmetry circuit constant current input
Asymmetry comparator voltage input
EFM full-swing output (Low = VSS, High = VDD)
Wide-band EFM PLL charge pump output
Wide-band EFM PLL VCO2 control voltage input
Analog ground
47
HCD-GX450
Pin No.
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
I/O
I
O
I
O
—
O
I
—
I
—
I
I
I
O
—
O
O
—
O
I
—
O
I
I
—
—
—
O
I
—
—
O
O
—
—
O
O
—
—
—
O
O
—
I
—
I
O
I
Pin Name
CLTV
FILO
FILI
PCO
AVDD5
DDVROUT
DDVRSEN
AVSS5
DDCR
NC
BCKI
PCMDI
LRCKl
LRCK
VSS
PCMD
BCK
VDD
EMPH
EMPHI
IOVDD2
DOUT
TEST
TES1
IOVss2
NC
XVSS
XTAO
XTAI
XVDD
AVDD1
AOUT1
VREFL
AVSS1
AVSS2
VREFR
AOUT2
AVDD2
NC
IOVDD0
RMUT
LMUT
NC
XTSL
IOVSS0
XTACN
SQSO
SQCK
Description
Multiplier VCO1 control voltage input
Master PLL (slave = digital PLL) filter output
Master PLL filter input
Master PLL charge pump output
Analog power supply
DC/DC converter output
DC/DC converter output voltage monitor pin
Analog ground
DC/DC converter reset pin
Not used
D/A interface bit clock input
D/A interface serial data input (2’s COMP, MSB first)
D/A interface LR clock input
D/A interface LR clock output f = Fs
Internal digital ground
D/A interface serial data output (2’s COMP, MSB first)
D/A interface bit clock output
Internal digital power supply
High when the playback disc has emphasis, low it has not
High when de-emphasis is ON, low when input OFF
I/O digital power supply
Digital Out output
Test pin Normally ground
Test pin Normally ground
I/O digital ground
Not used
Master clock ground
Crystal oscillation circuit output
Crystal oscillation circuit input
Master clock power supply
Analog power supply
Lch analog output
Lch reference voltage
Analog ground
Analog ground
Rch reference voltage
Rch analog output
Analog power supply
Not used
I/O digital power supply
Rch “0” detection flag (Not used)
Lch “0” detection flag (Not used)
Not used
Crystal selection input (Not used)
I/O digital ground
Oscillation circuit control
Self-oscillation when high, oscillation stop when low
Subcode Q 80-bit and PCM peak and level data output
CD TEXT data output
SQSO readout clock input
48
HCD-GX450
Pin No.
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
Pin Name
SBSO
EXCK
XRST
SYSM
D ATA
VSS
XLAT
CLOCK
VDD
SENS
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2PO
SCOR
VDD
C4M
WDCK
COUT
NC
I/O
O
I
I
I
I
—
I
I
—
O
I
I/O
O
O
O
O
O
O
—
O
O
I/O
—
Description
Subcode P to W serial output
SBSO readout clock input
System reset Reset when low
Mute input Muted when high
Serial data input from CPU
Internal digital ground
Latch input from CPU The serial data is latched at the falling edge
Serial data transfer clock input from CPU
Internal digital power supply
SENS output to CPU
SENS serial data readout clock input
Anti-shock input/output
WFCK output (Not used)
XUGF output (Not used)
XPCK output (Not used)
GFS output (Not used)
C2PO output (Not used)
High output when the subcode sync, S0 or S1, is detected
Internal digital power supply
4 2336MHz output (Not used)
Word clock output f = 2Fs (Not used)
Track number count signal input/output (Not used)
Not used
49
HCD-GX450
• IC601 LC876996A-52S4-E (SYSTEM CONTROLLER) (PANEL BOARD)
Pin No
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
I/O
O
O
I
O
I
O
I
I
I
I
I
I
O
—
I
O
—
I
I
I
I
I
I
I
I
I
I
I
I
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
O
—
O
O
O
O
Pin Name
O-MP3 CS
O-MP3 LP MOTER
I-MP3 ACK SOL-B
O-MP3 REQ SOL-A
I-SCOR
O-MP3 RESET
I-BU1924 DATA
I-BU1924 CLK
I-VOLUME-IN1
I-VOLUME-IN2
RESET
I-XT1
I-XT2
VSS1
CF1
CF2
VDD1
I-PROTECT
WFR/HP/MIC-IN
I-CD ENCODER
I-CD OPEN/CLOSE
I-TAPE A START
I-TAPE B START
I-STREAM/VACS
I-KEY 3
I-KEY 2
I-KEY 1
I-SIRDS-IN
I-AC CUT
G13
G12
G11
G10
G9
G8
G7
G6
G5
G4
G3
G2
G1
S1
S2
S3
VDD3
S4
S5
S6
S7/METER-SW1
Description
CS output to CD Digital Processor
LP output to CD Digital Processor and Motor signal output
ACK input from CD Digital Processor and Motor signal input
REQ output to CD Digital Processor and Motor signal output
CD Scor input
RESET output to CD Digital Processor
Data input(Not used)
Clock input(Not used)
Volume signal input from the encoder
Volume signal input from the encoder
Reset input
Connection for input a crystal resonator
Connection for input a crystal resonator
Ground
Connection for input a ceramic resonator
Connection for input a ceramic resonator
Power supply
Power amplifier circuit protection signal input
SubWoofer or Headphone detection signal input
Signal input from the CD encoder
CD tray open switch signal input
TAPE A switches signal input
TAPE B switches signal input
Stream/Vacs signal input
Function key input
Function key input
Function key input
Data input from the remote contorol receiver
Power down signal input
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube grid signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
Power supply
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
50
HCD-GX450
Pin No
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
I/O
—
O
O
O
O
O
O
O
O
O
O
O
O
O
O
I
I
I
I
I
I
—
O
O
O
O
O
O
O
O
O
O
I
O
O
O
O
O
—
—
O
O
O
O
O
I
O
O
I
O
Pin Name
-VPP
S8/METER-SW2
S9/METER-SW3
S10/SW1
S11/SW2
S12/SW3
S13/SW4
S14/SW5
S15/SW6
S16/SW7
S17/SW8
S18/SW9
S19/SW10
S20
S21
I-SPEC/MODE/METER
I-TUNED-IN
I-STEREO-IN
I-ASM-IN
I-REEL-A-IN
I-REEL-B-IN
VDD4
I-CD Num Senser
O-POWER-RELAY
O-SYSTEM-MUTE
O-POWER-LED
STREAM-LED6 SOLB
STREAM-LED5 SOLA
STREAM-LED4 MOTOR
STREAM-LED3 MP3-STB
STREAM-LED2
STREAM-LED1
I-LC72121 DI
O-LC72121 CE
O-LC72121/BU2099FV DO
O-LC72121/BU2099FV CLK
O-BU2099FV LCH
O-BD3401 CLK
VSS2
VDD2
O-BD3401 DATA
O-XTCN
O-XRES(RESET)
O-XLT(CD-LAT)
O-CD-DATA
I-SENS
O-CD-CLK
O-MP3-DO
I-MP3-DI
O-MP3-CLK
Description
Power supply (-)
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
FL tube segment signal output
METER swich input
Tuning a frequency signal input
Stereo tuning signal input
ASM signal input
A deck photo sensor signal input
B deck photo sensor signal input
Power supply
Table address sensor swich signal input
POWER RELAY control output
System muting signal output
POWER LED control signal output
Illumination LED control signal output
Illumination LED control signal output
Illumination LED control signal output
Illumination LED control signal output
Illumination LED control signal output
Illumination LED control signal output
Data input from Tuner
Chip select output to Tuner
Data input from Tuner and SP Driver
Clock output to Tuner and SP Driver
LCH output to SP Driver
Clock output to Sound Processor
Ground
Power supply
Data output toSound Processor
CD xtcn signal output
CD reset signal output
CD xlt signal output
CD data output
CD sens input
CD clk output
Clock output to CD Digital Processor
Data input from CD Digital Processor
Clock output to CD Digital Processor
SECTION 6EXPLODED VIEWS
51
HCD-GX450
NOTE:• -XX, -X mean standardized parts, so they may
have some differences from the original one.• Items marked “*” are not stocked since they
are seldom required for routine service. Somedelay should be anticipated when ordering theseitems.
The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.
Les composants identifiés par une marque0 sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.
• The mechanical parts with no reference numberin the exploded views are not supplied.
• AbbreviationCND : Canadian model
6-1. MAIN SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
CD mechanism deck section-1
#1
#1
#2
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
#1
a
a
#2
3
2
121
1
1
1
5
front panelsection
Main board section
4
notsupplied
7 8
9
10
notsupplied
notsupplied
notsupplied
notsupplied
#2
notsupplied
notsupplied
bb
PT902
1 3-363-099-31 SCREW (CASE 3 TP2)2 4-245-183-61 COVER (SIDE-L) (US)2 4-245-183-71 COVER (SIDE-L) (CND)3 4-252-196-21 DOOR, CD4 3-038-018-01 EMBLEM, SONY
5 4-244-849-61 COVER (TOP) (US)5 4-244-849-71 COVER (TOP) (CND)7 1-763-117-13 FAN, DC
8 1-769-940-11 WIRE (FLAT TYPE) (11 CORE)9 1-693-631-12 TUNER (FM/AM)10 1-400-285-11 F-BEAD, E2515 MRT12 4-245-184-61 COVER (SIDE-R) (US)12 4-245-184-71 COVER (SIDE-R) (CND)
0PT902 1-443-614-11 TRANS ASSY, SUB#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3#2 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
52
HCD-GX450
6-2. FRONT PANEL SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
not supplied
not supplied
not supplied
not supplied
not supplied
not supplied
not supplied
69
68
a
53
51
53
a
52
77
78
59
61
63
62
54
54
54
54
64
6667
65
76
59
74 75
74 73
not supplied
not supplied
not supplied
not supplied
54
57
58
56
72
55
71
70
60
51 4-252-202-01 DOOR (B), CASS52 4-252-201-01 DOOR (A), CASS53 4-238-631-01 TAPE SPRING54 4-951-620-01 SCREW (2.6X8), +BVTP55 4-252-207-11 BUTTON, FF/ALBUM+
56 4-252-208-11 BUTTON, FR/ALBUM-57 4-252-214-01 KNOB, VOLUME58 X-4956-295-1 RING ASSY, KNOB59 4-224-104-41 DAMPER60 4-252-198-01 WINDOW, DISPLAY
61 4-231-824-01 CAM (A), HEART62 4-231-836-01 SPRING (HEART CAM-A)63 4-252-195-21 PANEL, FRONT (US)63 4-252-195-31 PANEL, FRONT (CND)64 1-769-975-11 WIRE (FLAT TYPE) (13 CORE)
65 1-773-048-11 WIRE (FLAT TYPE) (17 CORE)66 4-231-841-01 SPRING (HEART CAM-B)67 4-231-825-01 CAM (B), HEART68 4-225-252-01 CUSHION (FOOT)69 1-796-485-51 DECK, MECHANICAL (CWM43FF-05)
70 4-252-200-01 BUTTON COVER71 4-252-206-01 BUTTON, STOP72 4-252-205-01 BUTTON, PLAY73 2-657-155-01 BELT (BR)74 4-235-777-01 BELT (FR)
75 4-243-609-01 BELT (AF)76 1-773-282-11 WIRE (FLAT TYPE)(29 CORE)77 4-252-221-01 SPRING (A), CASS DOOR78 4-252-222-01 SPRING (B), CASS DOOR
Ver. 1.3
53
HCD-GX450
6-3. MAIN BOARD SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
not supplied
not supplied
not supplied
not supplied
104
105
101
101
102
103
#2
F904F905
F906
F907
PT901
#2
#4
106
#3
108
108
107
107
101 4-242-527-01 S-SCREW, ITC+4-8 R102 A-4750-756-A AMP BOARD, COMPLETE
0103 1-783-531-11 CORD, POWER* 104 3-703-244-00 BUSHING (2104), CORD
105 4-988-533-01 HOLDER, PWB
106 A-4750-741-A MAIN BOARD, COMPLETE107 4-242-539-01 BVIT 3B +3-8R W/O SLOT108 3-905-609-41 SCREW (TRANSISTOR)
0F904 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (T8.0AL/125V)0F905 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (T8.0AL/125V)0F906 1-533-451-11 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/125V)0F907 1-533-451-11 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/125V)0PT901 1-443-254-11 TRANSFORMER, POWER
#2 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3#3 7-685-881-09 SCREW +BVTT 4X8 (S)#4 7-685-649-79 SCREW +BVTP 3X14 TYPE2 IT-3
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.
54
HCD-GX450
6-4. CD MECHANISM DECK SECTION -1 (CDM74-F1BD81)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
152
154
155155
156
156157
157
158
158159
151
156
162
163
164165160
161164
CD mechanism deck section-2151
153
166
M741
151 4-218-253-21 SCREW (M2.6), +BTTP152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)153 1-687-134-12 MOTOR (TB) BOARD154 4-243-815-01 TABLE (LOADING)155 4-245-571-02 GEAR (STOPPER)
156 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING157 4-245-570-01 GEAR (JOINT)158 4-245-572-01 BUSHING (GEAR)159 1-687-132-12 SENSOR BOARD
160 4-243-820-01 GEAR (TABLE)161 4-243-819-01 GEAR (GENEVA)162 4-243-816-01 TRAY163 4-243-823-01 BELT (TABLE)164 4-985-672-01 SCREW (+PTPWH M2.6), FLOATING
165 4-243-821-01 PULLEY (TABLE)166 3-231-598-01 SHEET (BA)M741 A-4723-963-A MOTOR ASSY, TABLE
55
HCD-GX450
6-5. CD MECHANISM DECK SECTION -2 (CDM74-F1BD81)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
201
202
232
202
202
203
204
205
206
207
208
210
211
212 213
214
215
216217
219231220
205
205
222
223
223
224
224
225
225
226
232
230
218223
223
222229
222
222
205
205205
205
M751
RE701
227228
not supplied
not supplied
233
201 1-687-135-12 DRIVER BOARD202 4-218-253-31 SCREW (M2.6), +BTTP203 1-687-669-12 SW BOARD204 4-244-034-01 BELT (LOADING)205 4-218-252-61 SCREW (+PTPWH M2.6), FLOATING
206 4-225-844-01 GEAR (LOADING A)207 4-224-613-01 GEAR (SHAFT)208 1-687-133-12 MOTOR (LD) BOARD210 4-244-108-01 GEAR, SWING211 4-224-609-01 GEAR (LOADING C)
212 4-224-608-01 COLLAR, SWING213 3-016-533-11 WASHER (FR), STOPPER214 4-224-611-01 GEAR (LOADING B)215 4-224-606-01 GEAR (RV)216 4-243-818-01 GEAR (U/D)
217 4-243-822-02 LEVER (LIFTER)218 X-4955-707-2 PULLEY (A5) ASSY, CHUCKING
219 4-231-189-01 PULLEY (B), CHUCKING220 X-4955-536-1 HOLDER (213) ASSY222 4-227-549-11 INSULATOR223 4-227-045-31 SPRING (INSULATOR), COIL224 4-231-151-01 STOPPER (BU)
225 4-218-253-31 SCREW (M2.6), +BTTP226 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)227 1-775-251-11 WIRE (FLAT TYPE) (27 CORE)228 A-4751-431-A BD81A BOARD, COMPLETE
0229 8-820-244-01 OPTICAL PICK-UP KSM-215DCP/C2NP
230 1-471-035-11 MAGNET ASSY231 4-243-817-11 CHASSIS232 4-951-620-01 SCREW (2.6X8), +BVTP233 1-469-854-11 CORE, FERRITEM751 A-4736-655-A MOTOR ASSY, LOADING
RE701 1-477-680-12 ENCODER, ROTARY
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.
56
HCD-GX450
NOTE:• Due to standardization, replacements in the
parts list may be different from the partsspecified in the diagrams or the componentsused on the set.
• -XX, -X mean standardized parts, so theymay have some difference from the originalone.
• Items marked “*” are not stocked since theyare seldom required for routine service.Some delay should be anticipated whenordering these items.
• CAPACITORS:uF: µF
• COILSuH: µH
• RESISTORSAll resistors are in ohms.METAL: metal-film resistorMETAL OXIDE: Metal Oxide-film resistorF: nonflammable
• SEMICONDUCTORSIn each case, u: µ, for example:uA...: µA... , uPA... , µPA... ,uPB... , µPB... , uPC... , µPC... ,uPD..., µPD...
When indicating parts by reference number,please include the board name.
The components identified by mark 0 ordotted line with mark 0 are critical for safety.Replace only with part number specified.
Les composants identifiés par une marque0 sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
SECTION 7ELECTRICAL PARTS LIST
6 STREAM LED BOARD*******************
< DIODE >
LED610 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
LED611 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
LED612 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
LED613 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
LED614 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
LED615 6-500-809-01 DIODE SELU5223C-STP15(ILLUMINATION LIGHT)
< RESISTOR >
R673 1-216-837-11 METAL CHIP 22K 5% 1/10WR699 1-216-182-00 RES-CHIP 220 5% 1/8WR701 1-216-182-00 RES-CHIP 220 5% 1/8WR703 1-216-182-00 RES-CHIP 220 5% 1/8WR705 1-216-182-00 RES-CHIP 220 5% 1/8W
R707 1-216-182-00 RES-CHIP 220 5% 1/8WR709 1-216-182-00 RES-CHIP 220 5% 1/8W
< SWITCH >
S660 1-418-632-11 ENCODER, ROTARY (MASTER VOLUME)SW601 1-786-289-11 SWITCH, DETECTION
************************************************************
A-4750-756-A AMP BOARD, COMPLETE********************
7-685-871-01 SCREW +BVTT 3X6 (S)
< CAPACITOR >
C402 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC403 1-137-749-11 MYLAR 0.1uF 100VC404 1-137-749-11 MYLAR 0.1uF 100VC405 1-135-516-11 ELECT 3300uF 20% 63VC406 1-135-516-11 ELECT 3300uF 20% 63V
C407 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC408 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC411 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC441 1-126-964-11 ELECT 10uF 20.00% 50VC442 1-126-964-11 ELECT 10uF 20.00% 50V
C443 1-162-294-31 CERAMIC 0.001uF 10% 50VC444 1-162-294-31 CERAMIC 0.001uF 10% 50VC445 1-162-282-31 CERAMIC 100pF 10.00% 50VC446 1-162-282-31 CERAMIC 100pF 10.00% 50VC447 1-126-965-11 ELECT 22uF 20.00% 35V
C448 1-126-965-11 ELECT 22uF 20.00% 35VC451 1-136-497-81 FILM 0.1uF 5.00% 50VC452 1-136-497-81 FILM 0.1uF 5.00% 50VC453 1-136-497-81 FILM 0.1uF 5.00% 50VC454 1-136-497-81 FILM 0.1uF 5.00% 50V
C481 1-104-658-91 ELECT 100uF 20.00% 10VC486 1-126-961-11 ELECT 2.2uF 20.00% 50VC487 1-126-963-11 ELECT 4.7uF 20.00% 50VC488 1-126-965-11 ELECT 22uF 20.00% 35VC489 1-128-563-11 ELECT 100uF 20.00% 100V
C492 1-162-306-11 CERAMIC 0.01uF 30.00% 16V
< CONNECTOR >
CN441 1-778-981-21 CONNECTOR, BOARD TO BOARD 13P
< DIODE >
D401 6-500-360-01 DIODE D10XB20D441 8-719-991-33 DIODE 1SS133T-77D442 8-719-991-33 DIODE 1SS133T-77D443 8-719-991-33 DIODE 1SS133T-77D481 8-719-991-33 DIODE 1SS133T-77
D482 8-719-991-33 DIODE 1SS133T-77D483 8-719-991-33 DIODE 1SS133T-77
< TERMINAL >
* EP401 1-537-738-21 TERMINAL, EARTH* EP402 1-537-738-21 TERMINAL, EARTH* EP491 1-537-738-21 TERMINAL, EARTH
< IC >
0 IC441 6-600-221-01 IC STK403-130
< TERMINAL BOARD >
JK441 1-694-884-11 TERMINAL BOARD (4P) (SPEAKER)
< COIL >
L441 1-422-009-13 COIL, AIR-COREL442 1-422-009-13 COIL, AIR-CORE
6 STREAM LED AMP
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
57
HCD-GX450
< TRANSISTOR >
Q441 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ442 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ481 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ482 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ483 8-729-119-79 TRANSISTOR 2SC2785TP-FEK
Q484 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ485 8-729-119-76 TRANSISTOR 2SA1175TP-EQ486 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ487 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ488 8-729-142-46 TRANSISTOR 2SC2001TP-LK
Q489 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEA
< RESISTOR >
R401 1-249-441-11 CARBON 100K 5% 1/4WR402 1-249-441-11 CARBON 100K 5% 1/4WR407 1-260-087-11 CARBON 100 5% 1/2WR411 1-249-421-11 CARBON 2.2K 5% 1/4W FR412 1-249-421-11 CARBON 2.2K 5% 1/4W F
R413 1-249-425-11 CARBON 4.7K 5% 1/4WR414 1-249-425-11 CARBON 4.7K 5% 1/4WR441 1-249-417-11 CARBON 1K 5% 1/4W FR442 1-249-417-11 CARBON 1K 5% 1/4W FR443 1-249-437-11 CARBON 47K 5% 1/4W
R444 1-249-437-11 CARBON 47K 5% 1/4WR445 1-249-417-11 CARBON 1K 5% 1/4W FR446 1-249-417-11 CARBON 1K 5% 1/4W FR447 1-249-437-11 CARBON 47K 5% 1/4WR448 1-249-437-11 CARBON 47K 5% 1/4W
0R451 1-217-156-00 METAL 0.22 10% 5W0R452 1-217-156-00 METAL 0.22 10% 5W
R453 1-260-076-11 CARBON 10 5% 1/2WR454 1-260-076-11 CARBON 10 5% 1/2WR455 1-249-417-11 CARBON 1K 5% 1/4W F
R456 1-249-417-11 CARBON 1K 5% 1/4W FR457 1-249-433-11 CARBON 22K 5% 1/4WR458 1-249-433-11 CARBON 22K 5% 1/4WR459 1-249-437-11 CARBON 47K 5% 1/4WR460 1-249-437-11 CARBON 47K 5% 1/4W
R461 1-260-076-11 CARBON 10 5% 1/2WR462 1-260-076-11 CARBON 10 5% 1/2WR465 1-249-437-11 CARBON 47K 5% 1/4WR466 1-249-438-11 CARBON 56K 5% 1/4WR467 1-249-435-11 CARBON 33K 5% 1/4W
R481 1-249-425-11 CARBON 4.7K 5% 1/4W FR482 1-249-429-11 CARBON 10K 5% 1/4WR483 1-247-791-91 CARBON 22 5% 1/4WR484 1-249-438-11 CARBON 56K 5% 1/4WR485 1-249-441-11 CARBON 100K 5% 1/4W
R486 1-249-441-11 CARBON 100K 5% 1/4WR487 1-249-435-11 CARBON 33K 5% 1/4WR488 1-249-433-11 CARBON 22K 5% 1/4WR489 1-249-425-11 CARBON 4.7K 5% 1/4W FR490 1-249-425-11 CARBON 4.7K 5% 1/4W F
R491 1-249-433-11 CARBON 22K 5% 1/4WR492 1-249-417-11 CARBON 1K 5% 1/4W FR493 1-249-435-11 CARBON 33K 5% 1/4W
R494 1-249-421-11 CARBON 2.2K 5% 1/4W F0R495 1-217-831-11 FUSIBLE 1 5% 1/4W
0R496 1-212-881-11 FUSIBLE 100 5% 1/4W
< RELAY >
RY441 1-755-373-11 RELAY
< THERMISTOR >
TH441 1-807-796-11 THERMISTOR************************************************************
A-4751-431-A BD81A BOARD, COMPLETE**********************
< CAPACITOR >
C10 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3VC11 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3VC14 1-164-360-11 CERAMIC CHIP 0.1uF 16VC15 1-164-360-11 CERAMIC CHIP 0.1uF 16VC16 1-115-156-11 CERAMIC CHIP 1uF 10V
C17 1-126-246-11 ELECT CHIP 220uF 20% 4VC18 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC111 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50VC112 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC113 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V
C114 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC115 1-164-360-11 CERAMIC CHIP 0.1uF 16VC116 1-128-995-21 ELECT CHIP 100uF 20% 10VC122 1-107-826-11 CERAMIC CHIP 0.1uF 10.00% 16VC123 1-107-826-11 CERAMIC CHIP 0.1uF 10.00% 16V
C124 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC125 1-164-360-11 CERAMIC CHIP 0.1uF 16VC131 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC132 1-117-863-11 CERAMIC CHIP 0.47uF 10.00% 6.3VC133 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C134 1-164-360-11 CERAMIC CHIP 0.1uF 16VC141 1-107-826-11 CERAMIC CHIP 0.1uF 10.00% 16VC142 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC143 1-164-360-11 CERAMIC CHIP 0.1uF 16VC151 1-128-995-21 ELECT CHIP 100uF 20% 10V
C152 1-115-156-11 CERAMIC CHIP 1uF 10VC161 1-164-360-11 CERAMIC CHIP 0.1uF 16VC162 1-164-360-11 CERAMIC CHIP 0.1uF 16VC163 1-164-360-11 CERAMIC CHIP 0.1uF 16VC164 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C171 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC172 1-162-920-11 CERAMIC CHIP 27PF 5% 50VC174 1-164-360-11 CERAMIC CHIP 0.1uF 16VC181 1-164-360-11 CERAMIC CHIP 0.1uF 16VC182 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C183 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC184 1-124-778-00 ELECT CHIP 22uF 20% 6.3VC185 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC186 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC194 1-164-360-11 CERAMIC CHIP 0.1uF 16V
AMP BD81A
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
58
HCD-GX450
C195 1-164-360-11 CERAMIC CHIP 0.1uF 16VC196 1-164-360-11 CERAMIC CHIP 0.1uF 16VC201 1-128-995-21 ELECT CHIP 100uF 20% 10VC203 1-128-995-21 ELECT CHIP 100uF 20% 10VC209 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C210 1-107-826-11 CERAMIC CHIP 0.1uF 10.00% 16VC211 1-164-230-11 CERAMIC CHIP 220PF 5% 50VC212 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC213 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC251 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
C252 1-164-360-11 CERAMIC CHIP 0.1uF 16VC255 1-164-360-11 CERAMIC CHIP 0.1uF 16VC257 1-164-360-11 CERAMIC CHIP 0.1uF 16VC258 1-164-360-11 CERAMIC CHIP 0.1uF 16VC259 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C260 1-128-394-11 ELECT CHIP 220uF 20% 10VC302 1-164-360-11 CERAMIC CHIP 0.1uF 16VC303 1-164-360-11 CERAMIC CHIP 0.1uF 16VC304 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC305 1-126-246-11 ELECT CHIP 220uF 20% 4V
C306 1-164-360-11 CERAMIC CHIP 0.1uF 16VC307 1-164-360-11 CERAMIC CHIP 0.1uF 16VC308 1-126-208-21 ELECT CHIP 47uF 20.00% 4VC309 1-164-360-11 CERAMIC CHIP 0.1uF 16VC310 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C311 1-164-360-11 CERAMIC CHIP 0.1uF 16VC312 1-164-360-11 CERAMIC CHIP 0.1uF 16VC313 1-164-360-11 CERAMIC CHIP 0.1uF 16VC314 1-126-208-21 ELECT CHIP 47uF 20.00% 4VC315 1-107-826-11 CERAMIC CHIP 0.1uF 10.00% 16V
C316 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC317 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC318 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC320 1-216-864-11 METAL CHIP 0 5% 1/10W
< CONNECTOR >
CN101 1-770-425-11 CONNECTOR, FFC/FPC 16PCN201 1-818-350-11 CONNECTOR (FFC) 27P
< FERRITE BEAD >
FB301 1-216-864-11 METAL CHIP 0 5% 1/10W
< IC >
IC101 8-752-425-12 IC CXD3059ARIC251 6-705-808-01 IC BA5947FMIC301 6-705-365-01 IC TC94A34FG-002IC303 6-705-807-01 IC BH15FB1WG
< TRANSISTOR >
Q10 6-550-363-01 TRANSISTOR 2SB1690KT146
< RESISTOR >
R10 1-216-791-11 METAL CHIP 3.3 5% 1/10WR11 1-216-864-11 METAL CHIP 0 5% 1/10WR12 1-216-845-11 METAL CHIP 100K 5% 1/10WR13 1-218-446-11 METAL CHIP 1 5% 1/10WR111 1-216-821-11 METAL CHIP 1K 5% 1/10W
R112 1-216-835-11 METAL CHIP 15K 5% 1/10WR113 1-216-821-11 METAL CHIP 1K 5% 1/10WR114 1-216-835-11 METAL CHIP 15K 5% 1/10WR121 1-216-835-11 METAL CHIP 15K 5% 1/10WR131 1-216-857-11 METAL CHIP 1M 5% 1/10W
R132 1-216-833-11 METAL CHIP 10K 5% 1/10WR133 1-216-848-11 METAL CHIP 180K 5% 1/10WR141 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR142 1-216-821-11 METAL CHIP 1K 5% 1/10WR143 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R151 1-216-864-11 METAL CHIP 0 5% 1/10WR161 1-216-809-11 METAL CHIP 100 5% 1/10WR162 1-216-841-11 METAL CHIP 47K 5% 1/10WR163 1-216-809-11 METAL CHIP 100 5% 1/10WR165 1-216-864-11 METAL CHIP 0 5% 1/10W
R171 1-216-817-11 METAL CHIP 470 5% 1/10WR172 1-216-857-11 METAL CHIP 1M 5% 1/10WR173 1-216-864-11 METAL CHIP 0 5% 1/10WR181 1-216-809-11 METAL CHIP 100 5% 1/10WR182 1-216-809-11 METAL CHIP 100 5% 1/10W
R191 1-216-864-11 METAL CHIP 0 5% 1/10WR201 1-500-445-21 INDUCTOR 0uHR203 1-216-864-11 METAL CHIP 0 5% 1/10WR204 1-500-445-21 INDUCTOR 0uHR205 1-216-864-11 METAL CHIP 0 5% 1/10W
R251 1-216-833-11 METAL CHIP 10K 5% 1/10WR252 1-216-837-11 METAL CHIP 22K 5% 1/10WR253 1-216-833-11 METAL CHIP 10K 5% 1/10WR301 1-216-845-11 METAL CHIP 100K 5% 1/10WR302 1-216-833-11 METAL CHIP 10K 5% 1/10W
R303 1-216-845-11 METAL CHIP 100K 5% 1/10WR305 1-216-845-11 METAL CHIP 100K 5% 1/10WR306 1-216-864-11 METAL CHIP 0 5% 1/10WR307 1-216-833-11 METAL CHIP 10K 5% 1/10WR313 1-216-813-11 METAL CHIP 220 5% 1/10W
R351 1-216-809-11 METAL CHIP 100 5% 1/10WR352 1-216-809-11 METAL CHIP 100 5% 1/10WR353 1-216-809-11 METAL CHIP 100 5% 1/10WR354 1-216-809-11 METAL CHIP 100 5% 1/10WR401 1-216-809-11 METAL CHIP 100 5% 1/10W
R402 1-216-809-11 METAL CHIP 100 5% 1/10WR403 1-216-809-11 METAL CHIP 100 5% 1/10WR404 1-216-809-11 METAL CHIP 100 5% 1/10WR405 1-216-809-11 METAL CHIP 100 5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10W
R407 1-216-809-11 METAL CHIP 100 5% 1/10WR408 1-216-809-11 METAL CHIP 100 5% 1/10WR409 1-216-809-11 METAL CHIP 100 5% 1/10WR410 1-216-833-11 METAL CHIP 10K 5% 1/10WR411 1-216-809-11 METAL CHIP 100 5% 1/10W
R412 1-216-809-11 METAL CHIP 100 5% 1/10WR419 1-216-809-11 METAL CHIP 100 5% 1/10W
< SWITCH >
S101 1-771-853-11 SWITCH, DETECTION (LIMIT)
BD81A
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
59
HCD-GX450
< VIBRATOR >
X171 1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz)************************************************************
CONNECT BOARD**************
< CAPACITOR >
C251 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC252 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC253 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC254 1-164-315-11 CERAMIC CHIP 470PF 5.00% 50VC255 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C256 1-164-156-11 CERAMIC CHIP 0.1uF 25VC257 1-164-156-11 CERAMIC CHIP 0.1uF 25V
< CONNECTOR >
CN251 1-779-295-11 CONNECTOR,FFC(LIF(NON-ZIF))27PCN253 1-784-778-11 CONNECTOR, FFC 17P
* CN254 1-564-725-11 PIN, CONNECTOR (SMALL TYPE) 9P
< FERRITE BEAD >
FB251 1-469-116-21 FERRITE 0uHFB252 1-469-116-21 FERRITE 0uH
************************************************************
1-687-135-12 DRIVER BOARD************
< CAPACITOR >
C715 1-126-933-11 ELECT 100uF 20.00% 16VC731 1-126-964-11 ELECT 10uF 20.00% 50VC735 1-164-159-21 CERAMIC 0.1uF 50VC736 1-164-159-21 CERAMIC 0.1uF 50VC737 1-164-159-21 CERAMIC 0.1uF 50V
C741 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC751 1-162-306-11 CERAMIC 0.01uF 30.00% 16VC752 1-164-159-21 CERAMIC 0.1uF 50V
< CONNECTOR >
CN701 1-785-338-11 PIN, CONNECTOR(LIGHT ANGLE)12PCN702 1-784-766-11 CONNECTOR, FFC 5P
* CN703 1-564-720-11 PIN, CONNECTOR (SMALL TYPE) 4PCN704 1-785-328-11 PIN, CONNECTOR (LIGHT ANGRE)2P
< DIODE >
D701 8-719-921-42 DIODE MTZJ-T-77-5.1AD711 8-719-109-69 DIODE MTZJ-T-77-3.6B
< IC >
IC701 8-759-598-69 IC BA6956ANIC712 8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q731 8-729-029-66 TRANSISTOR DTC114ESA-TP
< RESISTOR >
R701 1-249-413-11 CARBON 470 5% 1/4W F
R702 1-247-807-31 CARBON 100 5% 1/4WR711 1-249-417-11 CARBON 1K 5% 1/4W FR712 1-249-425-11 CARBON 4.7K 5% 1/4W FR713 1-249-433-11 CARBON 22K 5% 1/4W
R721 1-249-425-11 CARBON 4.7K 5% 1/4W FR722 1-249-425-11 CARBON 4.7K 5% 1/4W FR723 1-249-425-11 CARBON 4.7K 5% 1/4W FR731 1-247-807-31 CARBON 100 5% 1/4WR732 1-249-429-11 CARBON 10K 5% 1/4W
R733 1-249-417-11 CARBON 1K 5% 1/4W FR734 1-249-430-11 CARBON 12K 5% 1/4WR735 1-247-807-31 CARBON 100 5% 1/4WR751 1-249-425-11 CARBON 4.7K 5% 1/4W F
************************************************************
GAME JACK BOARD****************
< CAPACITOR >
C801 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC802 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC803 1-165-128-11 CERAMIC CHIP 0.22uF 16VC804 1-165-128-11 CERAMIC CHIP 0.22uF 16V
< JACK >
J804 1-815-684-11 JACK, PIN 3P (GAME INPUT)
< JUMPER RESISTOR >
JR801 1-216-864-11 METAL CHIP 0 5% 1/10W
< RESISTOR >
R801 1-216-833-11 METAL CHIP 10K 5% 1/10WR802 1-216-833-11 METAL CHIP 10K 5% 1/10WR803 1-216-837-11 METAL CHIP 22K 5% 1/10WR804 1-216-837-11 METAL CHIP 22K 5% 1/10W
************************************************************
H/P JACK BOARD**************
< CAPACITOR >
C830 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC831 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC832 1-164-156-11 CERAMIC CHIP 0.1uF 25V
< JACK >
J801 1-793-829-11 JACK, HEADPHONE (PHONES)************************************************************
A-4750-741-A MAIN BOARD, COMPLETE*********************
7-685-871-01 SCREW +BVTT 3X6 (S)
< CAPACITOR >
C101 1-126-960-11 ELECT 1uF 20.00% 50VC102 1-126-960-11 ELECT 1uF 20.00% 50VC103 1-126-956-91 ELECT 0.1uF 20.00% 50VC104 1-126-956-91 ELECT 0.1uF 20.00% 50VC105 1-164-816-11 CERAMIC CHIP 220PF 2.00% 50V
MAINBD81A CONNECT DRIVER GAME JACK H/P JACK
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
60
HCD-GX450
MAIN
C106 1-130-483-00 MYLAR 0.01uF 5% 50VC107 1-126-964-11 ELECT 10uF 20.00% 50VC108 1-164-816-11 CERAMIC CHIP 220PF 2.00% 50VC109 1-130-483-00 MYLAR 0.01uF 5% 50VC110 1-126-964-11 ELECT 10uF 20.00% 50V
C111 1-126-960-11 ELECT 1uF 20.00% 50VC112 1-126-960-11 ELECT 1uF 20.00% 50VC113 1-126-960-11 ELECT 1uF 20.00% 50VC114 1-126-960-11 ELECT 1uF 20.00% 50VC115 1-130-483-00 MYLAR 0.01uF 5% 50V
C116 1-164-816-11 CERAMIC CHIP 220PF 2.00% 50VC117 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC118 1-126-964-11 ELECT 10uF 20.00% 50VC119 1-130-483-00 MYLAR 0.01uF 5% 50VC120 1-164-816-11 CERAMIC CHIP 220PF 2.00% 50V
C121 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC122 1-126-964-11 ELECT 10uF 20.00% 50VC123 1-126-965-91 ELECT 22uF 20.00% 50VC124 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC125 1-162-953-11 CERAMIC CHIP 100PF 5% 50V
C126 1-162-971-91 CERAMIC CHIP 1000PF 10% 50VC127 1-104-658-91 ELECT 100uF 20.00% 10VC128 1-104-658-91 ELECT 100uF 20.00% 10VC129 1-126-947-11 ELECT 47uF 20.00% 16VC130 1-126-947-11 ELECT 47uF 20.00% 16V
C131 1-131-688-31 MYLAR 0.047uF 5.00% 50VC132 1-126-947-11 ELECT 47uF 20.00% 16VC133 1-131-688-31 MYLAR 0.047uF 5.00% 50VC134 1-130-495-00 MYLAR 0.1uF 5% 50VC135 1-131-693-31 MYLAR 0.12uF 5.00% 50V
C136 1-131-693-31 MYLAR 0.12uF 5.00% 50VC137 1-126-964-11 ELECT 10uF 20.00% 50VC138 1-126-964-11 ELECT 10uF 20.00% 50VC139 1-131-693-31 MYLAR 0.12uF 5.00% 50VC140 1-131-693-31 MYLAR 0.12uF 5.00% 50V
C141 1-126-964-11 ELECT 10uF 20.00% 50VC142 1-126-964-11 ELECT 10uF 20.00% 50VC143 1-126-960-11 ELECT 1uF 20.00% 50VC144 1-130-495-00 MYLAR 0.1uF 5% 50VC145 1-126-964-11 ELECT 10uF 20.00% 50V
C146 1-130-495-00 MYLAR 0.1uF 5% 50VC147 1-126-964-11 ELECT 10uF 20.00% 50VC148 1-130-483-00 MYLAR 0.01uF 5% 50VC149 1-130-483-00 MYLAR 0.01uF 5% 50VC150 1-130-483-00 MYLAR 0.01uF 5% 50V
C151 1-130-483-00 MYLAR 0.01uF 5% 50VC152 1-130-475-00 MYLAR 0.0022uF 5% 50VC153 1-130-475-00 MYLAR 0.0022uF 5% 50VC154 1-130-479-00 MYLAR 0.0047uF 5% 50VC157 1-126-960-11 ELECT 1uF 20.00% 50V
C159 1-126-960-11 ELECT 1uF 20.00% 50VC160 1-126-960-11 ELECT 1uF 20.00% 50VC162 1-126-960-11 ELECT 1uF 20.00% 50VC164 1-126-960-11 ELECT 1uF 20.00% 50VC165 1-126-960-11 ELECT 1uF 20.00% 50V
C166 1-126-960-11 ELECT 1uF 20.00% 50VC175 1-109-953-11 ELECT 2.2uF 20.00% 50VC176 1-126-964-11 ELECT 10uF 20.00% 50V
C177 1-162-945-11 CERAMIC CHIP 22PF 5% 50VC178 1-126-947-11 ELECT 47uF 20.00% 16V
C179 1-162-949-11 CERAMIC CHIP 47uF 5.00% 50VC180 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC181 1-162-949-11 CERAMIC CHIP 47uF 5.00% 50VC182 1-162-957-11 CERAMIC CHIP 220PF 5% 50VC183 1-162-945-11 CERAMIC CHIP 22PF 5% 50V
C184 1-126-947-11 ELECT 47uF 20.00% 16VC185 1-126-964-11 ELECT 10uF 20.00% 50VC186 1-126-947-11 ELECT 47uF 20.00% 16VC187 1-162-974-11 CERAMIC CHIP 0.01uF 50VC188 1-126-965-91 ELECT 22uF 20.00% 50V
C189 1-126-965-91 ELECT 22uF 20.00% 50VC190 1-162-974-11 CERAMIC CHIP 0.01uF 50VC191 1-126-961-11 ELECT 2.2uF 20.00% 50VC192 1-126-961-11 ELECT 2.2uF 20.00% 50VC193 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C194 1-126-964-11 ELECT 10uF 20.00% 50VC196 1-126-947-11 ELECT 47uF 20.00% 16VC198 1-137-190-91 FILM 0.22uF 5.00% 50VC199 1-136-171-00 FILM 0.33uF 5.00% 50VC202 1-126-933-11 ELECT 100uF 20.00% 16V
C203 1-126-964-11 ELECT 10uF 20.00% 50VC206 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC211 1-109-953-11 ELECT 2.2uF 20.00% 50VC212 1-126-964-11 ELECT 10uF 20.00% 50VC213 1-126-964-11 ELECT 10uF 20.00% 50V
C214 1-126-926-11 ELECT 1000uF 20.00% 10VC216 1-164-156-11 CERAMIC CHIP 0.1uF 25VC217 1-164-156-11 CERAMIC CHIP 0.1uF 25VC222 1-164-156-11 CERAMIC CHIP 0.1uF 25VC228 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C229 1-126-963-11 ELECT 4.7uF 20.00% 50VC230 1-126-947-11 ELECT 47uF 20.00% 16VC231 1-164-156-11 CERAMIC CHIP 0.1uF 25VC235 1-164-156-11 CERAMIC CHIP 0.1uF 25VC241 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C242 1-130-479-00 MYLAR 0.0047uF 5% 50VC243 1-130-485-00 MYLAR 0.015uF 5% 50VC244 1-130-473-00 MYLAR 0.0015uF 5% 50VC245 1-164-357-11 CERAMIC CHIP 0.001uF 5.00% 50VC246 1-130-485-00 MYLAR 0.015uF 5% 50V
C247 1-164-357-11 CERAMIC CHIP 0.001uF 5.00% 50VC248 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC249 1-126-964-11 ELECT 10uF 20.00% 50VC250 1-126-947-11 ELECT 47uF 20.00% 16VC251 1-126-947-11 ELECT 47uF 20.00% 16V
C252 1-126-933-11 ELECT 100uF 20.00% 16VC253 1-126-956-91 ELECT 0.1uF 20.00% 50VC258 1-126-959-11 ELECT 0.47uF 20.00% 50VC259 1-126-957-11 ELECT 0.22uF 20.00% 50VC264 1-162-971-11 CERAMIC CHIP 0.001uF 10.00% 50V
C265 1-162-971-11 CERAMIC CHIP 0.001uF 10.00% 50VC266 1-162-971-11 CERAMIC CHIP 0.001uF 10.00% 50VC267 1-162-971-11 CERAMIC CHIP 0.001uF 10.00% 50VC270 1-126-964-11 ELECT 10uF 20.00% 50VC274 1-162-949-11 CERAMIC CHIP 47uF 5.00% 50V
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
61
HCD-GX450
MAIN
C275 1-162-949-11 CERAMIC CHIP 47uF 5.00% 50VC301 1-130-495-00 MYLAR 0.1uF 5% 50VC302 1-130-495-00 MYLAR 0.1uF 5% 50VC303 1-130-495-00 MYLAR 0.1uF 5% 50VC304 1-130-495-00 MYLAR 0.1uF 5% 50V
C305 1-130-495-00 MYLAR 0.1uF 5% 50VC306 1-130-495-00 MYLAR 0.1uF 5% 50VC308 1-126-965-91 ELECT 22uF 20.00% 50VC309 1-126-965-91 ELECT 22uF 20.00% 50VC310 1-126-944-11 ELECT 3300uF 20.00% 25V
C311 1-126-964-11 ELECT 10uF 20.00% 50VC312 1-126-964-11 ELECT 10uF 20.00% 50VC313 1-126-943-11 ELECT 2200uF 20.00% 25VC315 1-126-933-11 ELECT 100uF 20.00% 16VC316 1-126-943-11 ELECT 2200uF 20.00% 25V
C318 1-126-947-11 ELECT 47uF 20.00% 16VC321 1-126-961-11 ELECT 2.2uF 20.00% 50VC342 1-164-156-11 CERAMIC CHIP 0.1uF 25VC351 1-164-357-11 CERAMIC CHIP 0.001uF 5.00% 50VC352 1-126-965-91 ELECT 22uF 20.00% 50V
C353 1-126-961-11 ELECT 2.2uF 20.00% 50VC354 1-164-156-11 CERAMIC CHIP 0.1uF 25VC371 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC372 1-162-953-11 CERAMIC CHIP 100PF 5% 50VC373 1-162-953-11 CERAMIC CHIP 100PF 5% 50V
C374 1-126-947-11 ELECT 47uF 20.00% 16VC375 1-164-156-11 CERAMIC CHIP 0.1uF 25VC376 1-126-961-11 ELECT 2.2uF 20.00% 50V
< CONNECTOR >
CN101 1-568-830-11 CONNECTOR, FFC 11P* CN103 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P* CN112 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P* CN301 1-568-950-11 PIN, CONNECTOR 12P
CN302 1-568-844-11 CONNECTOR, FFC 29P
CN305 1-568-937-11 PIN, CONNECTOR (STRAIGHT) 10PCN307 1-778-982-21 CONNECTOR, BOARD TO BOARD 13PCN308 1-564-506-11 PLUG, CONNECTOR 3PCN309 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
* CN314 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
< DIODE >
D201 8-719-988-61 DIODE 1SS355TE-17D202 8-719-921-88 DIODE MTZJ-13BD206 8-719-988-61 DIODE 1SS355TE-17D207 8-719-988-61 DIODE 1SS355TE-17D211 8-719-988-61 DIODE 1SS355TE-17
D212 8-719-988-61 DIODE 1SS355TE-17D213 8-719-988-61 DIODE 1SS355TE-17D214 8-719-988-61 DIODE 1SS355TE-17D215 8-719-988-61 DIODE 1SS355TE-17D301 6-500-522-21 DIODE 10EDB40-TB3
D302 6-500-522-21 DIODE 10EDB40-TB3D303 6-500-522-21 DIODE 10EDB40-TB3D304 6-500-522-21 DIODE 10EDB40-TB3D305 6-500-522-21 DIODE 10EDB40-TB3D306 6-500-522-21 DIODE 10EDB40-TB3
D307 6-500-522-21 DIODE 10EDB40-TB3
D308 6-500-522-21 DIODE 10EDB40-TB3D309 6-500-522-21 DIODE 10EDB40-TB3D310 6-500-522-21 DIODE 10EDB40-TB3D311 6-500-522-21 DIODE 10EDB40-TB3
D312 6-500-522-21 DIODE 10EDB40-TB3D313 8-719-210-21 DIODE 11EQS04-TA1BD314 6-500-522-21 DIODE 10EDB40-TB3D315 6-500-522-21 DIODE 10EDB40-TB3D316 8-719-988-61 DIODE 1SS355TE-17
D321 8-719-988-61 DIODE 1SS355TE-17D322 8-719-988-61 DIODE 1SS355TE-17D324 6-500-522-21 DIODE 10EDB40-TB3D325 6-500-522-21 DIODE 10EDB40-TB3D326 6-500-522-21 DIODE 10EDB40-TB3
< TERMINAL BOARD >
EP101 1-537-770-21 TERMINAL BOARD, GROUNDEP301 1-537-770-21 TERMINAL BOARD, GROUND
< RESISTOR >
FB201 1-216-864-11 METAL CHIP 0 5% 1/10WFB202 1-216-864-11 METAL CHIP 0 5% 1/10WFB203 1-216-864-11 METAL CHIP 0 5% 1/10WFB204 1-216-864-11 METAL CHIP 0 5% 1/10W
< IC >
IC101 6-705-852-01 IC BD3401KS2IC102 8-759-710-28 IC NJM4565M-A(TE2)IC104 8-759-710-28 IC NJM4565M-A(TE2)IC201 8-759-508-69 IC BA3126NIC301 6-702-771-01 IC TA78033LS
IC302 6-702-771-01 IC TA78033LSIC303 8-759-701-59 IC TA7809SIC304 8-759-701-59 IC TA7809SIC371 6-704-046-01 IC BU2099FV
< COIL >
L101 1-424-849-11 COIL, OSCILLATION (BIAS)
< TRANSISTOR >
Q101 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ102 6-550-289-01 TRANSISTOR 2SA1235FQ103 8-729-802-80 TRANSISTOR 2SC3661-TAQ104 8-729-802-80 TRANSISTOR 2SC3661-TAQ105 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
Q106 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ107 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ108 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ303 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ304 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
Q305 6-550-289-01 TRANSISTOR 2SA1235FQ306 8-729-802-80 TRANSISTOR 2SC3661-TAQ307 8-729-802-80 TRANSISTOR 2SC3661-TAQ308 6-550-289-01 TRANSISTOR 2SA1235FQ309 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
Q310 8-729-142-46 TRANSISTOR 2SC2001TP-LKQ311 8-729-142-46 TRANSISTOR 2SC2001TP-LKQ312 8-729-041-19 TRANSISTOR 2SA953-T-K
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
62
HCD-GX450
MAIN
Q313 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ314 6-550-289-01 TRANSISTOR 2SA1235F
Q315 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ321 8-729-142-46 TRANSISTOR 2SC2001TP-LKQ322 6-550-289-01 TRANSISTOR 2SA1235FQ323 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ324 8-729-140-04 TRANSISTOR 2SB1116-TP-LK
Q327 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ351 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ352 8-729-120-28 TRANSISTOR 2SC3052F-T1-LFQ361 6-550-289-01 TRANSISTOR 2SA1235FQ362 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
Q371 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
< RESISTOR >
R101 1-216-833-11 METAL CHIP 10K 5% 1/10WR102 1-216-833-11 METAL CHIP 10K 5% 1/10WR103 1-216-851-11 METAL CHIP 330K 5% 1/10WR104 1-216-835-11 METAL CHIP 15K 5% 1/10WR105 1-216-816-11 METAL CHIP 390 5% 1/10W
R106 1-216-851-11 METAL CHIP 330K 5% 1/10WR107 1-216-835-11 METAL CHIP 15K 5% 1/10WR108 1-216-816-11 METAL CHIP 390 5% 1/10WR109 1-216-853-11 METAL CHIP 470K 5% 1/10WR110 1-216-851-11 METAL CHIP 330K 5% 1/10W
R111 1-216-847-11 METAL CHIP 150K 5% 1/10WR112 1-216-853-11 METAL CHIP 470K 5% 1/10WR113 1-216-851-11 METAL CHIP 330K 5% 1/10WR114 1-216-847-11 METAL CHIP 150K 5% 1/10WR115 1-216-857-11 METAL CHIP 1M 5% 1/10W
R116 1-216-809-11 METAL CHIP 100 5% 1/10WR117 1-216-809-11 METAL CHIP 100 5% 1/10WR118 1-216-833-11 METAL CHIP 10K 5% 1/10WR119 1-216-841-11 METAL CHIP 47K 5% 1/10WR120 1-216-857-11 METAL CHIP 1M 5% 1/10W
R121 1-216-841-11 METAL CHIP 47K 5% 1/10WR123 1-216-833-11 METAL CHIP 10K 5% 1/10WR124 1-216-833-11 METAL CHIP 10K 5% 1/10WR125 1-216-833-11 METAL CHIP 10K 5% 1/10WR126 1-216-833-11 METAL CHIP 10K 5% 1/10W
R127 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR128 1-216-833-11 METAL CHIP 10K 5% 1/10WR129 1-216-841-11 METAL CHIP 47K 5% 1/10WR131 1-216-833-11 METAL CHIP 10K 5% 1/10WR132 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R133 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR134 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR135 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR136 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR137 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R138 1-216-821-11 METAL CHIP 1K 5% 1/10WR139 1-216-864-11 METAL CHIP 0 5% 1/10WR141 1-216-821-11 METAL CHIP 1K 5% 1/10WR142 1-216-821-11 METAL CHIP 1K 5% 1/10WR151 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R152 1-216-833-11 METAL CHIP 10K 5% 1/10WR153 1-216-833-11 METAL CHIP 10K 5% 1/10W
R154 1-216-833-11 METAL CHIP 10K 5% 1/10WR155 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR156 1-216-853-11 METAL CHIP 470K 5% 1/10W
R157 1-216-841-11 METAL CHIP 47K 5% 1/10WR158 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR159 1-216-833-11 METAL CHIP 10K 5% 1/10WR160 1-216-833-11 METAL CHIP 10K 5% 1/10WR161 1-216-833-11 METAL CHIP 10K 5% 1/10W
R162 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR163 1-216-833-11 METAL CHIP 10K 5% 1/10WR164 1-216-833-11 METAL CHIP 10K 5% 1/10WR165 1-216-833-11 METAL CHIP 10K 5% 1/10WR166 1-216-833-11 METAL CHIP 10K 5% 1/10W
R167 1-216-833-11 METAL CHIP 10K 5% 1/10WR168 1-216-845-11 METAL CHIP 100K 5% 1/10WR169 1-216-845-11 METAL CHIP 100K 5% 1/10WR170 1-216-833-11 METAL CHIP 10K 5% 1/10WR171 1-216-833-11 METAL CHIP 10K 5% 1/10W
R172 1-216-809-11 METAL CHIP 100 5% 1/10WR173 1-216-833-11 METAL CHIP 10K 5% 1/10WR174 1-216-833-11 METAL CHIP 10K 5% 1/10WR175 1-216-833-11 METAL CHIP 10K 5% 1/10WR176 1-216-849-11 METAL CHIP 220K 5% 1/10W
R177 1-216-849-11 METAL CHIP 220K 5% 1/10WR178 1-216-833-11 METAL CHIP 10K 5% 1/10WR181 1-216-837-11 METAL CHIP 22K 5% 1/10WR182 1-216-841-11 METAL CHIP 47K 5% 1/10WR184 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R186 1-216-839-11 METAL CHIP 33K 5% 1/10WR187 1-216-841-11 METAL CHIP 47K 5% 1/10WR189 1-216-809-11 METAL CHIP 100 5% 1/10WR192 1-216-837-11 METAL CHIP 22K 5% 1/10WR193 1-216-821-11 METAL CHIP 1K 5% 1/10W
R194 1-216-831-11 METAL CHIP 6.8K 5% 1/10WR195 1-216-831-11 METAL CHIP 6.8K 5% 1/10WR196 1-216-864-11 METAL CHIP 0 5% 1/10WR197 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR198 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R199 1-216-849-11 METAL CHIP 220K 5% 1/10WR201 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR202 1-216-833-11 METAL CHIP 10K 5% 1/10WR203 1-216-833-11 METAL CHIP 10K 5% 1/10WR204 1-216-833-11 METAL CHIP 10K 5% 1/10W
R205 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR206 1-216-841-11 METAL CHIP 47K 5% 1/10WR207 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR208 1-216-821-11 METAL CHIP 1K 5% 1/10WR209 1-216-833-11 METAL CHIP 10K 5% 1/10W
R210 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR211 1-216-821-11 METAL CHIP 1K 5% 1/10WR212 1-216-833-11 METAL CHIP 10K 5% 1/10WR213 1-216-821-11 METAL CHIP 1K 5% 1/10WR214 1-216-821-11 METAL CHIP 1K 5% 1/10W
R216 1-216-806-11 METAL CHIP 56 5% 1/10WR217 1-216-806-11 METAL CHIP 56 5% 1/10WR218 1-215-891-11 METAL OXIDE 680 5% 2WR219 1-215-891-11 METAL OXIDE 680 5% 2WR220 1-216-837-11 METAL CHIP 22K 5% 1/10W
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
63
HCD-GX450
R221 1-216-837-11 METAL CHIP 22K 5% 1/10WR222 1-216-830-11 METAL CHIP 5.6K 5% 1/10WR223 1-216-845-11 METAL CHIP 100K 5% 1/10WR225 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR226 1-216-841-11 METAL CHIP 47K 5% 1/10W
R227 1-216-821-11 METAL CHIP 1K 5% 1/10WR228 1-216-821-11 METAL CHIP 1K 5% 1/10WR229 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR230 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR231 1-216-833-11 METAL CHIP 10K 5% 1/10W
R232 1-216-833-11 METAL CHIP 10K 5% 1/10WR241 1-216-797-11 METAL CHIP 10 5% 1/10WR242 1-216-838-11 METAL CHIP 27K 5% 1/10WR243 1-216-832-11 METAL CHIP 8.2K 5% 1/10WR244 1-216-832-11 METAL CHIP 8.2K 5% 1/10W
R245 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR246 1-216-809-11 METAL CHIP 100 5% 1/10WR247 1-216-833-11 METAL CHIP 10K 5% 1/10WR248 1-216-833-11 METAL CHIP 10K 5% 1/10WR249 1-216-841-11 METAL CHIP 47K 5% 1/10W
R250 1-216-833-11 METAL CHIP 10K 5% 1/10WR251 1-216-833-11 METAL CHIP 10K 5% 1/10WR252 1-216-864-11 METAL CHIP 0 5% 1/10WR253 1-216-809-11 METAL CHIP 100 5% 1/10WR262 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R263 1-216-857-11 METAL CHIP 1M 5% 1/10WR264 1-216-821-11 METAL CHIP 1K 5% 1/10WR265 1-216-833-11 METAL CHIP 10K 5% 1/10WR266 1-216-845-11 METAL CHIP 100K 5% 1/10WR268 1-216-833-11 METAL CHIP 10K 5% 1/10W
R269 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR270 1-216-821-11 METAL CHIP 1K 5% 1/10WR271 1-216-833-11 METAL CHIP 10K 5% 1/10WR272 1-216-853-11 METAL CHIP 470K 5% 1/10WR273 1-216-864-11 METAL CHIP 0 5% 1/10W
R274 1-216-864-11 METAL CHIP 0 5% 1/10WR275 1-216-864-11 METAL CHIP 0 5% 1/10WR281 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR282 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR283 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R284 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR306 1-216-833-11 METAL CHIP 10K 5% 1/10WR307 1-216-833-11 METAL CHIP 10K 5% 1/10WR308 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR310 1-216-833-11 METAL CHIP 10K 5% 1/10W
R311 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR312 1-216-837-11 METAL CHIP 22K 5% 1/10WR313 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR321 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR322 1-216-837-11 METAL CHIP 22K 5% 1/10W
R323 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR324 1-216-833-11 METAL CHIP 10K 5% 1/10WR325 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR341 1-216-833-11 METAL CHIP 10K 5% 1/10WR342 1-216-821-11 METAL CHIP 1K 5% 1/10W
R343 1-216-837-11 METAL CHIP 22K 5% 1/10W
R344 1-216-837-11 METAL CHIP 22K 5% 1/10WR345 1-216-833-11 METAL CHIP 10K 5% 1/10WR346 1-216-821-11 METAL CHIP 1K 5% 1/10WR347 1-216-837-11 METAL CHIP 22K 5% 1/10W
R348 1-216-837-11 METAL CHIP 22K 5% 1/10WR351 1-216-835-11 METAL CHIP 15K 5% 1/10WR352 1-216-845-11 METAL CHIP 100K 5% 1/10WR353 1-216-841-11 METAL CHIP 47K 5% 1/10WR354 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R356 1-216-817-11 METAL CHIP 470 5% 1/10WR357 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR358 1-216-809-11 METAL CHIP 100 5% 1/10WR361 1-216-833-11 METAL CHIP 10K 5% 1/10WR362 1-216-821-11 METAL CHIP 1K 5% 1/10W
R363 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR364 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR371 1-216-809-11 METAL CHIP 100 5% 1/10WR372 1-216-809-11 METAL CHIP 100 5% 1/10WR373 1-216-809-11 METAL CHIP 100 5% 1/10W
R374 1-216-833-11 METAL CHIP 10K 5% 1/10WR375 1-216-833-11 METAL CHIP 10K 5% 1/10WR376 1-216-833-11 METAL CHIP 10K 5% 1/10WR377 1-216-833-11 METAL CHIP 10K 5% 1/10WR378 1-216-833-11 METAL CHIP 10K 5% 1/10W
R379 1-216-833-11 METAL CHIP 10K 5% 1/10WR380 1-216-833-11 METAL CHIP 10K 5% 1/10WR381 1-216-833-11 METAL CHIP 10K 5% 1/10WR382 1-216-833-11 METAL CHIP 10K 5% 1/10WR383 1-216-833-11 METAL CHIP 10K 5% 1/10W
R384 1-216-833-11 METAL CHIP 10K 5% 1/10WR385 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR386 1-216-837-11 METAL CHIP 22K 5% 1/10WR387 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR388 1-216-837-11 METAL CHIP 22K 5% 1/10W
R389 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR390 1-216-837-11 METAL CHIP 22K 5% 1/10WR391 1-216-833-11 METAL CHIP 10K 5% 1/10WR392 1-216-821-11 METAL CHIP 1K 5% 1/10WR393 1-216-833-11 METAL CHIP 10K 5% 1/10W
R394 1-216-821-11 METAL CHIP 1K 5% 1/10WR395 1-216-837-11 METAL CHIP 22K 5% 1/10WR396 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR397 1-216-833-11 METAL CHIP 10K 5% 1/10W
************************************************************
1-687-133-12 MOTOR (LD) BOARD****************
************************************************************
1-687-134-12 MOTOR (TB) BOARD****************
< CONNECTOR >
CN742 1-784-727-11 CONNECTOR, FFC 5P************************************************************
MAIN MOTOR (TB)MOTOR (LD)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
64
HCD-GX450
PANEL BOARD***********
< CAPACITOR >
C601 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC602 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC603 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC604 1-164-156-11 CERAMIC CHIP 0.1uF 25VC605 1-126-163-11 ELECT 4.7uF 20% 50V
C606 1-115-156-11 CERAMIC CHIP 1uF 10VC607 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC608 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC609 1-115-156-11 CERAMIC CHIP 1uF 10VC610 1-126-916-11 ELECT 1000uF 20.00% 6.3V
C611 1-164-156-11 CERAMIC CHIP 0.1uF 25VC612 1-126-157-11 ELECT 10uF 20% 16VC613 1-164-156-11 CERAMIC CHIP 0.1uF 25VC614 1-164-156-11 CERAMIC CHIP 0.1uF 25VC615 1-124-257-00 ELECT 2.2uF 20% 50V
C617 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC618 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC619 1-124-589-11 ELECT 47uF 20% 16VC620 1-119-772-91 ELECT 47uF 20.00% 35VC621 1-162-995-11 CERAMIC CHIP 0.022uF 50V
C622 1-126-163-11 ELECT 4.7uF 20% 50VC623 1-126-163-11 ELECT 4.7uF 20% 50VC624 1-162-918-11 CERAMIC CHIP 18PF 5.00% 50VC625 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC626 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C628 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC629 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC630 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC631 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC632 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C633 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC634 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC635 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC636 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC637 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C638 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC639 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC640 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC641 1-164-156-11 CERAMIC CHIP 0.1uF 25VC642 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C643 1-164-156-11 CERAMIC CHIP 0.1uF 25VC644 1-126-157-11 ELECT 10uF 20% 16VC646 1-124-234-00 ELECT 22uF 20% 16VC647 1-124-589-11 ELECT 47uF 20% 16VC648 1-124-234-00 ELECT 22uF 20% 16V
C649 1-164-156-11 CERAMIC CHIP 0.1uF 25VC653 1-162-959-11 CERAMIC CHIP 330PF 5% 50VC654 1-164-156-11 CERAMIC CHIP 0.1uF 25VC655 1-164-156-11 CERAMIC CHIP 0.1uF 25VC656 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
< CONNECTOR >
CN601 1-784-751-11 CONNECTOR, FFC 29PCN602 1-784-774-11 CONNECTOR, FFC 13P
CN603 1-784-778-11 CONNECTOR, FFC 17P* CN604 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P
CN605 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
CN608 1-818-282-11 PIN, CONNECTOR 3P
< DIODE >
D603 8-719-988-61 DIODE 1SS355TE-17D604 8-719-988-61 DIODE 1SS355TE-17D605 8-719-988-61 DIODE 1SS355TE-17D607 8-719-988-61 DIODE 1SS355TE-17D608 8-719-988-61 DIODE 1SS355TE-17
D609 8-719-988-61 DIODE 1SS355TE-17D610 8-719-083-59 DIODE UDZSTE-174.3BD611 8-719-988-61 DIODE 1SS355TE-17D613 8-719-988-61 DIODE 1SS355TE-17D614 8-719-988-61 DIODE 1SS355TE-17
D615 8-719-988-61 DIODE 1SS355TE-17D616 8-719-988-61 DIODE 1SS355TE-17D621 8-719-988-61 DIODE 1SS355TE-17D623 8-719-988-61 DIODE 1SS355TE-17D626 8-719-988-61 DIODE 1SS355TE-17
D630 8-719-988-61 DIODE 1SS355TE-17D631 8-719-978-33 DIODE UDZSTE-176.8BD632 8-719-083-57 DIODE UDZSTE-173.6BD633 8-719-988-61 DIODE 1SS355TE-17
< INDICATOR TUBE >
FL601 1-518-976-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC601 6-804-130-01 IC LC876996A-52S4-E IC601 6-804-440-01 IC LC876996A-53H2-E IC601 6-805-469-01 IC LC876A96A-55D8-E
IC602 6-704-046-01 IC BU2099FVIC603 6-704-045-01 IC MM1574ANLE
IC604 8-759-533-04 IC M62703ML-E1
< JUMPER RESISTOR >
JR607 1-216-864-11 METAL CHIP 0 5% 1/10WJR608 1-216-864-11 METAL CHIP 0 5% 1/10WJR609 1-216-864-11 METAL CHIP 0 5% 1/10WJR611 1-216-864-11 METAL CHIP 0 5% 1/10WJR612 1-216-864-11 METAL CHIP 0 5% 1/10W
JR614 1-216-296-11 SHORT CHIP 0JR617 1-216-864-11 METAL CHIP 0 5% 1/10WJR621 1-216-864-11 METAL CHIP 0 5% 1/10WJR622 1-216-864-11 METAL CHIP 0 5% 1/10WJR623 1-216-864-11 METAL CHIP 0 5% 1/10W
< DIODE >
LED601 6-500-809-01 DIODE SELU5223C-STP15 (?/1)
< TRANSISTOR >
Q601 8-729-116-57 TRANSISTOR 2SB1068TP-KQ602 8-729-140-04 TRANSISTOR 2SB1116A-TP-LKQ603 8-729-140-04 TRANSISTOR 2SB1116A-TP-LKQ604 8-729-119-76 TRANSISTOR 2SA1175TP-HFE
PANELVer. 1.1
When IC601 is exchanged for LC876A type, remove R789.Refer to Attention when exchanging IC601 (Page 37).
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
65
HCD-GX450
Q605 8-729-120-28 TRANSISTOR 2SC3052F-T1-LF
Q610 8-729-027-55 TRANSISTOR DTC143EKA-T146Q611 8-729-027-55 TRANSISTOR DTC143EKA-T146Q612 8-729-027-55 TRANSISTOR DTC143EKA-T146Q613 8-729-027-55 TRANSISTOR DTC143EKA-T146Q614 8-729-027-55 TRANSISTOR DTC143EKA-T146
Q615 8-729-027-55 TRANSISTOR DTC143EKA-T146Q616 8-729-027-55 TRANSISTOR DTC143EKA-T146
< RESISTOR >
R601 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR602 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR603 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR604 1-216-841-11 METAL CHIP 47K 5% 1/10WR605 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R606 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR607 1-216-841-11 METAL CHIP 47K 5% 1/10WR608 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR609 1-216-837-11 METAL CHIP 22K 5% 1/10WR610 1-216-833-11 METAL CHIP 10K 5% 1/10W
R611 1-216-837-11 METAL CHIP 22K 5% 1/10WR612 1-216-833-11 METAL CHIP 10K 5% 1/10WR613 1-216-837-11 METAL CHIP 22K 5% 1/10WR614 1-216-837-11 METAL CHIP 22K 5% 1/10WR615 1-216-837-11 METAL CHIP 22K 5% 1/10W
R616 1-216-833-11 METAL CHIP 10K 5% 1/10WR617 1-216-837-11 METAL CHIP 22K 5% 1/10WR618 1-216-833-11 METAL CHIP 10K 5% 1/10WR619 1-216-837-11 METAL CHIP 22K 5% 1/10WR620 1-216-837-11 METAL CHIP 22K 5% 1/10W
R621 1-216-833-11 METAL CHIP 10K 5% 1/10WR622 1-216-049-11 RES-CHIP 1K 5% 1/10WR623 1-216-833-11 METAL CHIP 10K 5% 1/10WR624 1-216-049-11 RES-CHIP 1K 5% 1/10WR625 1-216-833-11 METAL CHIP 10K 5% 1/10W
R626 1-216-049-11 RES-CHIP 1K 5% 1/10WR627 1-216-833-11 METAL CHIP 10K 5% 1/10WR628 1-216-833-11 METAL CHIP 10K 5% 1/10WR629 1-216-150-91 RES-CHIP 10 5% 1/8WR632 1-216-809-11 METAL CHIP 100 5% 1/10W
R633 1-216-809-11 METAL CHIP 100 5% 1/10WR634 1-216-809-11 METAL CHIP 100 5% 1/10WR635 1-216-809-11 METAL CHIP 100 5% 1/10WR636 1-216-833-11 METAL CHIP 10K 5% 1/10WR637 1-216-833-11 METAL CHIP 10K 5% 1/10W
R638 1-216-809-11 METAL CHIP 100 5% 1/10WR639 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR640 1-216-834-11 METAL CHIP 12K 5% 1/10WR641 1-216-849-11 METAL CHIP 220K 5% 1/10WR642 1-216-817-11 METAL CHIP 470 5% 1/10W
R643 1-216-819-11 METAL CHIP 680 5% 1/10WR644 1-216-821-11 METAL CHIP 1K 5% 1/10WR645 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR646 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR647 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R648 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR649 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R650 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR651 1-216-833-11 METAL CHIP 10K 5% 1/10WR652 1-216-835-11 METAL CHIP 15K 5% 1/10W
R653 1-216-817-11 METAL CHIP 470 5% 1/10WR654 1-216-819-11 METAL CHIP 680 5% 1/10WR655 1-216-821-11 METAL CHIP 1K 5% 1/10WR656 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR657 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
R658 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR659 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR660 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR661 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR662 1-216-833-11 METAL CHIP 10K 5% 1/10W
R663 1-216-837-11 METAL CHIP 22K 5% 1/10WR664 1-216-817-11 METAL CHIP 470 5% 1/10WR665 1-216-819-11 METAL CHIP 680 5% 1/10WR666 1-216-821-11 METAL CHIP 1K 5% 1/10WR667 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
R668 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR669 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR670 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR671 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR672 1-216-833-11 METAL CHIP 10K 5% 1/10W
R674 1-216-835-11 METAL CHIP 15K 5% 1/10WR675 1-216-835-11 METAL CHIP 15K 5% 1/10WR676 1-216-835-11 METAL CHIP 15K 5% 1/10WR677 1-216-864-11 METAL CHIP 0 5% 1/10WR678 1-216-845-11 METAL CHIP 100K 5% 1/10W
R679 1-216-174-00 RES-CHIP 100 5% 1/8WR680 1-216-837-11 METAL CHIP 22K 5% 1/10WR681 1-216-849-11 METAL CHIP 220K 5% 1/10WR682 1-216-833-11 METAL CHIP 10K 5% 1/10WR683 1-216-849-11 METAL CHIP 220K 5% 1/10W
R684 1-216-821-11 METAL CHIP 1K 5% 1/10WR685 1-216-841-11 METAL CHIP 47K 5% 1/10WR686 1-216-841-11 METAL CHIP 47K 5% 1/10WR687 1-216-833-11 METAL CHIP 10K 5% 1/10WR688 1-216-817-11 METAL CHIP 470 5% 1/10W
R689 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR690 1-216-809-11 METAL CHIP 100 5% 1/10WR691 1-216-809-11 METAL CHIP 100 5% 1/10WR692 1-216-809-11 METAL CHIP 100 5% 1/10WR693 1-216-809-11 METAL CHIP 100 5% 1/10W
R694 1-216-809-11 METAL CHIP 100 5% 1/10WR695 1-216-809-11 METAL CHIP 100 5% 1/10WR696 1-216-809-11 METAL CHIP 100 5% 1/10WR697 1-216-809-11 METAL CHIP 100 5% 1/10WR698 1-216-182-00 RES-CHIP 220 5% 1/8W
R700 1-216-182-00 RES-CHIP 220 5% 1/8WR702 1-216-182-00 RES-CHIP 220 5% 1/8WR704 1-216-182-00 RES-CHIP 220 5% 1/8WR706 1-216-182-00 RES-CHIP 220 5% 1/8WR708 1-216-182-00 RES-CHIP 220 5% 1/8W
R710 1-216-833-11 METAL CHIP 10K 5% 1/10WR711 1-216-833-11 METAL CHIP 10K 5% 1/10WR712 1-216-797-11 METAL CHIP 10 5% 1/10WR713 1-216-797-11 METAL CHIP 10 5% 1/10WR714 1-216-809-11 METAL CHIP 100 5% 1/10W
PANEL
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
66
HCD-GX450
R715 1-216-805-11 METAL CHIP 47 5% 1/10WR716 1-216-837-11 METAL CHIP 22K 5% 1/10WR717 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR718 1-216-837-11 METAL CHIP 22K 5% 1/10WR719 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R720 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR721 1-216-833-11 METAL CHIP 10K 5% 1/10WR722 1-216-835-11 METAL CHIP 15K 5% 1/10WR723 1-216-809-11 METAL CHIP 100 5% 1/10WR725 1-216-809-11 METAL CHIP 100 5% 1/10W
R727 1-220-397-11 METAL CHIP 4.7M 5% 1/10WR728 1-220-397-11 METAL CHIP 4.7M 5% 1/10WR729 1-216-809-11 METAL CHIP 100 5% 1/10WR730 1-216-809-11 METAL CHIP 100 5% 1/10WR731 1-216-809-11 METAL CHIP 100 5% 1/10W
R732 1-216-853-11 METAL CHIP 470K 5% 1/10WR733 1-216-809-11 METAL CHIP 100 5% 1/10WR734 1-216-821-11 METAL CHIP 1K 5% 1/10WR735 1-216-821-11 METAL CHIP 1K 5% 1/10WR736 1-216-821-11 METAL CHIP 1K 5% 1/10W
R737 1-216-845-11 METAL CHIP 100K 5% 1/10WR738 1-216-845-11 METAL CHIP 100K 5% 1/10WR739 1-216-845-11 METAL CHIP 100K 5% 1/10WR740 1-216-845-11 METAL CHIP 100K 5% 1/10WR741 1-216-845-11 METAL CHIP 100K 5% 1/10W
R742 1-216-845-11 METAL CHIP 100K 5% 1/10WR743 1-216-845-11 METAL CHIP 100K 5% 1/10WR744 1-216-845-11 METAL CHIP 100K 5% 1/10WR745 1-216-845-11 METAL CHIP 100K 5% 1/10WR746 1-216-845-11 METAL CHIP 100K 5% 1/10W
R747 1-216-845-11 METAL CHIP 100K 5% 1/10WR748 1-216-845-11 METAL CHIP 100K 5% 1/10WR749 1-216-845-11 METAL CHIP 100K 5% 1/10WR750 1-216-845-11 METAL CHIP 100K 5% 1/10WR751 1-216-845-11 METAL CHIP 100K 5% 1/10W
R752 1-216-845-11 METAL CHIP 100K 5% 1/10WR753 1-216-845-11 METAL CHIP 100K 5% 1/10WR754 1-216-845-11 METAL CHIP 100K 5% 1/10WR755 1-216-845-11 METAL CHIP 100K 5% 1/10WR756 1-216-845-11 METAL CHIP 100K 5% 1/10W
R757 1-216-845-11 METAL CHIP 100K 5% 1/10WR758 1-216-845-11 METAL CHIP 100K 5% 1/10WR759 1-216-845-11 METAL CHIP 100K 5% 1/10WR760 1-216-845-11 METAL CHIP 100K 5% 1/10WR761 1-216-845-11 METAL CHIP 100K 5% 1/10W
R762 1-216-845-11 METAL CHIP 100K 5% 1/10WR763 1-216-845-11 METAL CHIP 100K 5% 1/10WR764 1-216-845-11 METAL CHIP 100K 5% 1/10WR765 1-216-845-11 METAL CHIP 100K 5% 1/10WR766 1-216-845-11 METAL CHIP 100K 5% 1/10W
R767 1-216-845-11 METAL CHIP 100K 5% 1/10WR768 1-216-845-11 METAL CHIP 100K 5% 1/10WR769 1-216-845-11 METAL CHIP 100K 5% 1/10WR770 1-216-845-11 METAL CHIP 100K 5% 1/10WR771 1-216-841-11 METAL CHIP 47K 5% 1/10W
R772 1-216-821-11 METAL CHIP 1K 5% 1/10WR773 1-216-809-11 METAL CHIP 100 5% 1/10WR774 1-216-809-11 METAL CHIP 100 5% 1/10W
R775 1-216-809-11 METAL CHIP 100 5% 1/10WR776 1-216-809-11 METAL CHIP 100 5% 1/10W
R777 1-216-809-11 METAL CHIP 100 5% 1/10WR778 1-216-809-11 METAL CHIP 100 5% 1/10WR779 1-216-809-11 METAL CHIP 100 5% 1/10WR780 1-216-817-11 METAL CHIP 470 5% 1/10WR781 1-216-809-11 METAL CHIP 100 5% 1/10W
R782 1-216-809-11 METAL CHIP 100 5% 1/10WR783 1-216-809-11 METAL CHIP 100 5% 1/10WR784 1-216-809-11 METAL CHIP 100 5% 1/10WR785 1-216-809-11 METAL CHIP 100 5% 1/10WR786 1-216-833-11 METAL CHIP 10K 5% 1/10W
R787 1-216-809-11 METAL CHIP 100 5% 1/10WR788 1-216-809-11 METAL CHIP 100 5% 1/10W
R789 1-216-841-11 METAL CHIP 47K 5% 1/10W(IC601 LC876996A TYPE)
R790 1-216-821-11 METAL CHIP 1K 5% 1/10WR791 1-216-809-11 METAL CHIP 100 5% 1/10W
R792 1-216-809-11 METAL CHIP 100 5% 1/10WR793 1-216-809-11 METAL CHIP 100 5% 1/10WR794 1-216-809-11 METAL CHIP 100 5% 1/10WR795 1-216-809-11 METAL CHIP 100 5% 1/10WR796 1-216-809-11 METAL CHIP 100 5% 1/10W
R797 1-216-821-11 METAL CHIP 1K 5% 1/10WR798 1-216-821-11 METAL CHIP 1K 5% 1/10WR799 1-216-821-11 METAL CHIP 1K 5% 1/10WR854 1-216-813-11 METAL CHIP 220 5% 1/10WR863 1-216-174-00 RES-CHIP 100 5% 1/8W
< SWITCH >
S601 1-762-875-21 SWITCH, KEYBOARD (?/1)S602 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)S603 1-762-875-21 SWITCH, KEYBOARD (EQ BAND)S604 1-762-875-21 SWITCH, KEYBOARD (DISC 1)S605 1-762-875-21 SWITCH, KEYBOARD (DISC 2)
S606 1-762-875-21 SWITCH, KEYBOARD (DISC 3)S607 1-762-875-21 SWITCH, KEYBOARD (DISC SKIP/EX-CHANGE)S608 1-762-875-21 SWITCH, KEYBOARD (Z)S610 1-762-875-21 SWITCH, KEYBOARD (P FILE)S611 1-762-875-21 SWITCH, KEYBOARD (PRESET EQ)
S612 1-762-875-21 SWITCH, KEYBOARD (ENTER)S621 1-762-875-21 SWITCH, KEYBOARD (CD)S622 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)S623 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)S624 1-762-875-21 SWITCH, KEYBOARD (GAME)
S626 1-762-875-21 SWITCH, KEYBOARD (ILLUMINATION)S627 1-762-875-21 SWITCH, KEYBOARD
(PLAY MODE/TUNING MODE)S628 1-762-875-21 SWITCH, KEYBOARD (GAME MIXING)S629 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)S630 1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)
S641 1-762-875-21 SWITCH, KEYBOARD (GROOVE)S642 1-762-875-21 SWITCH, KEYBOARD (SURROUND)S643 1-762-875-21 SWITCH, KEYBOARD (EFFECT ON/OFF)S644 1-762-875-21 SWITCH, KEYBOARD (TUNING +)S645 1-762-875-21 SWITCH, KEYBOARD (H)
S646 1-762-875-21 SWITCH, KEYBOARD (M ALBUM +)S647 1-762-875-21 SWITCH, KEYBOARD (m ALBUM -)
PANELVer. 1.1
When IC601 is exchanged for LC876A type, remove R789.Refer to Attention when exchanging IC601 (Page 37).
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
67
HCD-GX450
S648 1-762-875-21 SWITCH, KEYBOARD (X)S649 1-762-875-21 SWITCH, KEYBOARD (x)S650 1-762-875-21 SWITCH, KEYBOARD (TUNING -)
< VIBRATOR >
X601 1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)X602 1-795-004-21 VIBRATOR, CERAMIC (10MHz)
************************************************************
REM BOARD**********
< CONNECTOR >
CN610 1-816-423-11 SOCKET, CONNECTOR 3P
< IC >
IC610 6-600-174-01 IC RPM7240-H4 ( )
< JUMPER RESISTOR >
JR624 1-216-296-11 SHORT CHIP 0************************************************************
1-687-132-12 SENSOR BOARD*************
< CONNECTOR >
CN731 1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE)3P
< IC >
IC731 6-600-022-01 IC RPI-576************************************************************
SUB-TRANS BOARD****************
< CONNECTOR >
CN901 1-564-321-00 PIN, CONNECTOR(3.96mm PITCH)2P
< DIODE >
D901 8-719-991-33 DIODE 1SS133T-77D902 6-500-522-21 DIODE 10EDB40-TB3D903 6-500-522-21 DIODE 10EDB40-TB3D904 6-500-522-21 DIODE 10EDB40-TB3D905 6-500-522-21 DIODE 10EDB40-TB3
< RELAY >
0RY901 1-755-276-11 RELAY, POWER************************************************************
SUB-WOOFER BOARD******************
< CAPACITOR >
C502 1-162-286-21 CERAMIC 220PF 10.00% 50VC503 1-162-600-11 CERAMIC 0.0047uF 10.00% 16VC504 1-104-662-91 ELECT 22uF 20.00% 25VC505 1-162-199-31 CERAMIC 10PF 5% 50VC506 1-104-665-11 ELECT 100uF 20.00% 25V
C507 1-126-967-11 ELECT 47uF 20.00% 50VC508 1-162-286-21 CERAMIC 220PF 10.00% 50VC509 1-128-563-11 ELECT 100uF 20.00% 100VC510 1-128-582-11 ELECT 10uF 20.00% 100VC511 1-128-582-11 ELECT 10uF 20.00% 100V
C512 1-136-497-81 FILM 0.1uF 5.00% 50VC513 1-136-497-81 FILM 0.1uF 5.00% 50VC514 1-126-948-11 ELECT 100uF 20.00% 35VC515 1-126-963-11 ELECT 4.7uF 20.00% 50VC516 1-126-964-11 ELECT 10uF 20.00% 50V
C517 1-126-964-11 ELECT 10uF 20.00% 50V
< CONNECTOR >
* CN501 1-564-706-11 PIN, CONNECTOR (SMALL TYPE) 4P* CN502 1-564-510-11 PLUG, CONNECTOR 7P* CN503 1-564-517-11 PLUG, CONNECTOR 2P (CONTROL)
< DIODE >
D501 8-719-110-31 DIODE MTZJ-T-77-12BD502 8-719-991-33 DIODE 1SS133T-77D503 8-719-991-33 DIODE 1SS133T-77D504 8-719-991-33 DIODE 1SS133T-77D505 8-719-991-33 DIODE 1SS133T-77
D506 8-719-109-97 DIODE MTZJ-T-77-6.8BD507 8-719-991-33 DIODE 1SS133T-77
< IC >
IC501 6-600-091-01 IC STK404-130S
< JACK >
JK501 1-774-785-11 JACK, PIN 1P (SUB WOOFER OUT)
< TRANSISTOR >
Q501 8-729-140-84 TRANSISTOR 2SC1841TP-PAFAEAQ502 8-729-119-76 TRANSISTOR 2SA1175TP-EQ503 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ505 8-729-119-79 TRANSISTOR 2SC2785TP-FEKQ506 8-729-119-79 TRANSISTOR 2SC2785TP-FEK
Q507 8-729-119-79 TRANSISTOR 2SC2785TP-FEK
< RESISTOR >
R501 1-249-437-11 CARBON 47K 5% 1/4WR502 1-249-437-11 CARBON 47K 5% 1/4WR503 1-249-417-11 CARBON 1K 5% 1/4W FR504 1-249-437-11 CARBON 47K 5% 1/4WR505 1-260-107-11 CARBON 4.7K 5% 1/2W
0R506 1-217-831-11 FUSIBLE 1 5% 1/4WR507 1-260-107-11 CARBON 4.7K 5% 1/2WR508 1-260-107-11 CARBON 4.7K 5% 1/2W
0R509 1-212-881-11 FUSIBLE 100 5% 1/4W0R510 1-245-233-11 METAL 0.22 10% 5W
0R511 1-245-233-11 METAL 0.22 10% 5WR512 1-260-076-11 CARBON 10 5% 1/2WR513 1-249-417-11 CARBON 1K 5% 1/4W F
SUB-WOOFERREM SENSOR SUB-TRANS
The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.
PANEL
HCD-GX450
68
Ref. No. Part No. Description Remarks
68
R514 1-249-433-11 CARBON 22K 5% 1/4WR515 1-249-437-11 CARBON 47K 5% 1/4W
R516 1-260-087-11 CARBON 100 5% 1/2WR517 1-249-429-11 CARBON 10K 5% 1/4WR518 1-249-421-11 CARBON 2.2K 5% 1/4W FR519 1-249-421-11 CARBON 2.2K 5% 1/4W FR520 1-249-441-11 CARBON 100K 5% 1/4W
R524 1-249-437-11 CARBON 47K 5% 1/4WR525 1-249-433-11 CARBON 22K 5% 1/4WR526 1-249-428-11 CARBON 8.2K 5% 1/4W FR527 1-247-903-00 CARBON 1M 5% 1/4WR528 1-249-429-11 CARBON 10K 5% 1/4W
R529 1-249-421-11 CARBON 2.2K 5% 1/4W FR530 1-249-433-11 CARBON 22K 5% 1/4WR531 1-249-425-11 CARBON 4.7K 5% 1/4W FR532 1-249-433-11 CARBON 22K 5% 1/4WR533 1-249-433-11 CARBON 22K 5% 1/4W
< RELAY >
RY501 1-755-373-11 RELAY************************************************************
1-687-669-12 SW BOARD*********
< SWITCH >
S751 1-786-514-11 SWITCH, LEVER (SLIDE) (LEVER)************************************************************
TRANS BOARD************
< CAPACITOR >
C906 1-164-159-11 CERAMIC 0.1uF 50VC908 1-128-553-11 ELECT 220uF 20.00% 63VC909 1-126-964-11 ELECT 10uF 20.00% 50VC910 1-126-968-11 ELECT 100uF 20.00% 50VC911 1-126-942-61 ELECT 1000uF 20.00% 25V
C920 1-131-679-31 CAP, METALIZED FILM 0.01uF 5% 50VC921 1-131-679-31 CAP, METALIZED FILM 0.01uF 5% 50VC922 1-131-679-31 CAP, METALIZED FILM 0.01uF 5% 50VC923 1-131-679-31 CAP, METALIZED FILM 0.01uF 5% 50VC924 1-131-692-11 CAP, METALIZED FILM 0.1uF 5% 50V
C925 1-131-692-11 CAP, METALIZED FILM 0.1uF 5% 50VC926 1-164-159-21 CERAMIC 0.1uF 50V
< CONNECTOR >
CN904 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2PCN905 1-564-506-11 PLUG, CONNECTOR 3P
* CN906 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P* CN907 1-764-333-11 PLUG, CONNECTOR 10P
< DIODE >
D906 8-719-110-69 DIODE MTZJ-T-77-27DD908 6-500-522-21 DIODE 10EDB40-TB3
< TRANSISTOR >
Q902 8-729-048-52 TRANSISTOR 2SA1932(TP)The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.
Les composants identifiés parune marque 0 sont critiquespour la sécurité.Ne les remplacer que par unepièce portant le numéro spécifié.
SUB-WOOFER SW VIDEO OUTTRANS
Ref. No. Part No. Description Remarks
< RESISTOR >
0R902 1-219-237-11 SOLID 3.3M 20% 1/2WR903 1-249-430-11 CARBON 12K 5% 1/4WR904 1-249-417-11 CARBON 1K 5% 1/4W F
0R908 1-217-831-11 FUSIBLE 1 5% 1/4W************************************************************
VIDEO OUT BOARD***************
< CONNECTOR >
* CN805 1-564-704-11 PIN, CONNECTOR (SMALL TYPE) 2P
< JACK >
J803 1-774-227-11 JACK, PIN 1P (VIDEO OUT)************************************************************
MISCELLANEOUS**************
7 1-763-117-13 FAN, DC8 1-769-940-11 WIRE (FLAT TYPE) (11 CORE)9 1-693-631-12 TUNER (FM/AM)10 1-400-285-11 F-BEAD, E2515 MRT64 1-769-975-11 WIRE (FLAT TYPE) (13 CORE)
65 1-773-048-11 WIRE (FLAT TYPE) (17 CORE)69 1-796-485-51 DECK, MECHANICAL (CWM43FF-05)76 1-773-282-11 WIRE (FLAT TYPE)(29 CORE)
0103 1-783-531-11 CORD, POWER152 1-776-182-11 WIRE (FLAT TYPE) (5 CORE)
226 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)227 1-775-251-11 WIRE (FLAT TYPE) (27 CORE)
0229 8-820-244-01 OPTICAL PICK-UP KSM-215DCP/C2NP230 1-471-035-11 MAGNET ASSY233 1-469-854-11 CORE, FERRITE
0F904 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (T8.0AL/125V)0F905 1-576-537-11 FUSE, GLASS TUBE (DIA.5) (T8.0AL/125V)0F906 1-533-451-11 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/125V)0F907 1-533-451-11 FUSE, GLASS TUBE (DIA. 5) (T3.15AL/125V)
M741 A-4723-963-A MOTOR ASSY, TABLE
M751 A-4736-655-A MOTOR ASSY, LOADING0PT901 1-443-254-11 TRANSFORMER, POWER0PT902 X-4956-292-1 TRANS ASSY, SUB
RE701 1-477-680-12 ENCODER, ROTARY