38

Family and LifeStyle

1

Food Hygiene

8 Food Hygiene8.1 Food Hygiene

8.2 Personal Hygiene

8.2.1 Personal Hygiene Practices

8.2.2 Hygiene Practices for Food Preparation and Serving

8.3 Environmental Hygiene

8.4 Storage of Food

8.4.1 Dry food stores

8.4.2 Refrigerators

8.4.3 Deep-freeze storage

8.5 Safe Practices in Defrosting (thawing)

8.5.1 Defrosting by refrigerator

8.5.2 Defrosting under running water

8.5.3 Defrosting by microwave oven

Contents Page

2

4

4

7

11

11

11

12

12

13

13

13

14

DRAFT July 2009

2

Food Hygiene

8 Food Hygiene The hot and humid climate of summer in Hong Kong provides a perfect environment for bacteria to multiply. Consumption of contaminated food or water can result in food poisoning or other food borne-disease such as cholera or Hepatitis A. It’s therefore important to pay attention to personal, food and environmental hygiene.

8.1 Food hygiene

Purchase of food

❖ Purchase food from a hygienic, reliable and reputable source to ensure quality. Never patronize unlicensed hawkers.

❖ Choose fresh meat and vegetables. Meat should have a fresh red colour and luster and should have an elastic feel. Vegetables should have a fresh green colour with no rotting leaves. Shellfish should have intact shells. The water and containers rearing shellfish should be clean.

❖ Avoid stocking up large amounts of food.

❖ Check expiry dates of pre-packaged foods, e.g. “use by” date and “best before” date. Do not buy expired food or those with damaged package.

❖ Do not purchase food with abnormal appearance such as rusty canned foods, any change of colour or foul smell.

❖ Do not buy any food that is not covered properly e.g. barbecued meat hanging outside the shops. Avoid buying non-prepacked drinks and fruits that have already been cut or peeled.

Handling of food

❖ Food that spoils easily or will not be cooked immediately should be stored in the refrigerator.

❖ Raw and cooked foods should be stored separately. Raw food should be stored on the lower shelf of the refrigerator, and cooked food on the upper shelf.

DRAFT July 2009

3

Food Hygiene

❖ Keep your refrigerator’s temperature below 4℃. Do not store excessive amount of food in the refrigerator, as this will affect the circulation of cold air.

❖ Keep your refrigerator clean.

❖ Always wash your hands with soap and water before preparing food and after handling raw meat.

❖ Do not handle food when suffering from diarrhoea or some other gastro-intestinal illness.

Cooking of food❖ All meat, seafood and vegetables must be washed thoroughly. Remove all internal

organs from fish. Scrub the shells of shellfish, and then soak them in clean water for a period of time. Remove the outer leaves of vegetables, and soak the vegetables in clean water for a period of time.

❖ To avoid cross-contamination, use different sets of knives and chopping boards for raw and cooked foods. If only one set of knife and chopping board is available, use it for cooked food first. Brush and wash the used utensils with detergent immediately after use.

❖ Cook food thoroughly. Frozen food should be completely defrosted before cooking, and preferably should be cut into thin slices to facilitate thorough cooking.

❖ Eat your cooked food as soon as possible after cooking. In the case of cold dishes such as salads and jellyfish, keep them in the refrigerator right until they are ready to be served.

❖ Cook only as much food as you can eat to avoid leftovers. If there is leftover, wrap it well before storing in the refrigerator. Reheat food thoroughly before serving.

Storage of food❖ Store raw and cooked foods separately in the refrigerator (cooked food in the upper

shelf and raw food in the lower shelf) to avoid cross-contamination.

❖ Frozen food must be completely defrosted before cooking and should be cooked thoroughly. Defrost the frozen food either by placing it in the lower shelf of refrigerator or thawing it under running water. Do not leave frozen food in room temperature to avoid rapid growth of bacteria.

DRAFT July 2009

4

Food Hygiene

❖ Never leave food, raw or cooked, at room temperature for more than 2 hours. Serve cooked food as soon as possible after cooking. Leftovers should be kept in the refrigerator at 4°C or below.

❖ Do not store excessive amount of food in the refrigerator, as this will affect the circulation of cold air.

❖ All foods as well as condiments should be covered and stored properly.

8.2 Personal hygienePersonal hygiene is aimed at preventing the spread of bacteria from the body or clothing to avoid food poisoning. It is the responsibility of the individual and all food handlers to understand the principles of food hygiene and its importance.

❖ to prevent food becoming contaminated with food poisoning bacteria;

❖ to prevent the multiplication of any food poisoning bacteria which get into food;

❖ to destroy any food poisoning bacteria which may be present by thorough cooking.

8.2.1 Personal Hygiene Practices

(A) Clothing and Personal Effects

(i) Only clean and protective clothing should be worn and they should be fit to wear. If they become soiled during food preparation, they should be changed or cleaned as necessary. These clothing should be washed after use.

(ii) Wear disposable gloves when handling ready-to-eat food. They should be discarded if damaged or soiled.

(iii) Wear face masks when handling food. They should be discarded when damaged, soiled, or after prolonged use.

(iv) Shoes should be worn when handling food.

(v) Personal belonging, such as handbags, footwear, umbrellas and dirty clothing, should not be stored or left in any food preparation area. They should be put away from food preparation areas.

DRAFT July 2009

5

Food Hygiene

(B) Hair

(i) During the handling food, hair should be covered with a clean hat or hair net. Long hair should be tied back as well.

(ii) Combing of hair should not be conducted in food handling areas.

(C) Nails and Jewelry

(i) Long and dirty nails harbour dirt and bacteria, therefore, nails should be kept short and unpolished.

(ii) Food handlers should have their watches, rings and jewelry removed before they work with food. Jewelry which may easily become detached should not be worn while handling food to avoid them from falling on the food and cause contamination.

(D) Hands

Hands of food handlers should be kept clean at all times.

(i) Cuts or wounds on hands of food handlers should be completely covered by suitable waterproof dressings or gloves.

(ii) Food handlers should wash their hands:

❖ before commencing work;❖ before handling food;❖ after visiting the toilet;❖ after handling raw food;❖ after handling soiled equipment or utensils;❖ after coughing, sneezing, smoking, eating, drinking or blowing nose;❖ after handling animals or waste;❖ after touching their ears, noses, hair, mouths or other parts of their bodies; or❖ after engaging in any activities that may contaminate hands. (e.g. handling

money, carrying out cleaning duties, etc.)

(iii) Staff engaged in food handling should not be allowed to handle cash simultaneously.

(iv) Handwashing should be frequent, thorough and performed in basins. The following proper procedures should be adopted for washing hands:

DRAFT July 2009

6

Food Hygiene

❖ wet the hands with running water, preferably with warm water;❖ apply liquid soap;❖ rub hands for 20 seconds (wash all surfaces thoroughly, including forearms,

wrists, palms, back of hands, fingers and under fingernails);❖ if necessary, use a clean and sanitary nail brush to clean nails;❖ rinse hands thoroughly;❖ dry hands with a clean paper towel, continuous cloth towel in dispenser or air

dryer.

(E) Health

(i) Any person engaged in handling food who suffers from diarrhoea, vomiting, septic cuts, boils or discharges from the ear, eye or nose should not come into contact with food, food utensils and equipment.

(ii) When sneezing or coughing inside food preparation area is unavoidable, food handlers should turn away from food and cover their noses and mouths with tissue paper or handkerchieves. Disposable paper tissues are preferable as they can be discarded. Hands should then be thoroughly cleaned at once.

(iii) Food handlers with open cuts or wounds on the exposed parts of their bodies should not be allowed to handle food or to come into contact with food utensils, equipment, unless such cuts / wounds are completely protected by impermeable or waterproof gloves or dressings. Bandages or dressings should be brightly coloured so that, if they are inadvertently removed, they will be readily visible if it falls into food. Bandages and dressings should be changed regularly. A well-equipped first-aid box containing bandages or dressings and antiseptic, should be kept on the premises.

(F) Personal behaviour

Inside food preparation areas, food handlers should refrain from performing the following behaviours which may result in contamination of food:

(i) smoking or using tobacco;(ii) spitting;(iii) chewing, eating, sneezing or coughing over unprotected food;(iv) touching ready-to-eat food with bare hands;(v) sitting, lying or standing on any surface liable to come into contact with food;(vi) tasting food with fingers; and(vii) touching hair or other parts of bodies such as noses, eyes or ears.

DRAFT July 2009

7

Food Hygiene

8.2.2 Hygiene Practices for Food Preparation and Serving

(A) It is essential to prevent the contamination of food by bacteria carried by food handlers or by bacteria from raw foods. The direct handling of food should be avoided where possible. Food should be handled with utensils, such as tongs. Food handlers should wear disposable plastic gloves when handling high risk foods, such as cooked meats.

(B) In the kitchen it is essential to keep raw and cooked foods separated in order to prevent cross-contamination from raw to cooked foods. This means having separate preparation areas for the these types of food. Raw food has more bacteria than cooked food, and are very likely to contain food poisoning bacteria. Separate equipment should be used for the preparation of raw and cooked foods. Items such as knives and chopping boards can be colour-coded for different uses, e.g. for raw meat, raw vegetables, cooked foods. Equipment such as meats slicers and mincers, which cannot be duplicated, should be thoroughly cleaned after being used for raw meat.

(C) It is essential to control the temperature of food during preparation, processing, cooking and storage in order to prevent the multiplication of pathogenic bacteria. Appropriate temperature control is probably the single most important factor in the prevention of food poisoning. A breakdown in temperature control is a major factor in at least 75% of food poisoning outbreaks.

DRAFT July 2009

8

Food Hygiene

Figure 8.1 Shows the exponential growth curve of a bacteria. The life cycle of a typical bacterial cell is 20 minutes. Therefore, the number of bacteria will be doubled in 20 minutes.

Figure 8.2 A typical growth curve of bacteria.

DRAFT July 2009

9

Food Hygiene

(D) Food handlers must avoid keeping high risk foods, such as meats and poultry, egg and milk dishes, cream cakes and desserts, in the danger zone (5-63℃) for longer than necessary. Consideration should be given to the following processes:

(i) Preparation: Food should be kept in preparation areas within the shortest period of time. Preparation areas should be well ventilated and not too hot. When preparation is finished, food should be cooked, refrigerated or frozen.

(ii) Defrosting: Frozen foods, must be defrosted before cooking. This should be carried out at a low temperature, i.e. in a refrigerator, or quickly, e.g. in microwave oven. Care is needed to ensure that food is completely defrosted before cooking. Otherwise, at the end of the cooking time, the centre of the food may not be hot enough to kill bacteria.

(iii) Cooking: Foods, particularly meat and poultry, should be cooked thoroughly, so that the centre temperature is 70℃, i.e. high enough to kill most bacteria. This is particularly important for products such as burgers and sausages. Stews and gravies should be heated to the boiling point (100℃). Centre temperatures can be checked using a temperature probe. This must be cleaned between use for different products. After cooking, food must be served immediately, kept hot or cooled quickly.

(iv) Warm-holding: Food should be kept hot at 70℃ or above in hot cabinets or bain-maries.

(v) Chilling: Cooked foods should be cooled quickly within 1.5 hours. They are best chilled at temperature of 10℃ or below.

(vi) Reheating: Food should be heated up quickly and heated thoroughly. Small portions may be heated in a microwave oven, though care is needed to ensure even cooking and the absence of ‘cold spot’.

DRAFT July 2009

10

Food Hygiene

Additional Information

Temperature control during preparation and serving of foodBacterial growth is the division of one bacterium into two identical daughter cells during a process called binary fission. Hence, local doubling of the bacterial population occurs. Both daughter cells from the division do not necessarily survive. However, if the number surviving exceeds unity on average, the bacterial population undergoes exponential growth.

Bacterial growth in batch culture can be modeled with four different phases: lag phase (A), exponential or log phase (B), stationary phase (C), and death phase (D).

1. During the lag phase, bacteria adapt themselves to growth conditions. It is the period where the individual bacteria is maturing and not yet able to divide. During the lag phase of the bacterial growth cycle, synthesis of Ribonucleis acid (RNA), enzymes and other molecules occur.

2. Exponential phase (sometimes called the log phase) is a period characterised by cell doubling. The number of new bacteria appearing per unit time is proportional to the present population. If growth is not limited, doubling will continue at a constant rate so both the number of cells and the rate of population increase doubles with each consecutive time period. For this type of exponential growth, plotting the natural logarithm of cell number against time producing a straight line. The slope of this line is the specific growth rate of the organism, which is a measure of the number of divisions per cell per unit time. The actual rate of this growth (i.e. the slope of the line in the figure) depends upon the growth conditions, which affect the frequency of cell division events and the probability of both daughter cells surviving. Exponential growth cannot continue indefinitely, because the medium is soon depleted of nutrients and accumulated with wastes.

3. During the stationary phase, the growth rate slows down as a result of nutrient depletion and accumulation of toxic products. This phase is reached as the bacteria begin to exhaust the resources that are available to them.

4. At the death phase, bacteria run out of nutrients and die.

DRAFT July 2009

11

Food Hygiene

8.3 Environmental hygiene❖ Maintain good lighting and ventilation in the kitchen. Keep the floor, ceiling and

walls clean and dry.

❖ Ensure good maintenance of refrigerator, cooker hood, exhaust fans and cooking utensils. The inside of refrigerators including their rims should be cleaned regularly. Over-frosted refrigerators should be defrosted promptly.

❖ Linens should be used for one single purpose only. For example, towels used for cleaning up food spills on table surfaces should not be used for any other purpose such as for polishing dried utensils. Soiled linens should be kept in suitable receptacles or laundry bags away from food preparation areas to prevent contamination of food, food equipment and utensils.

❖ Ensure drains are not blocked.

❖ Maintain pest control to eliminate mice, houseflies and cockroaches. Do not keep pets in the kitchen.

❖ Dispose refuse and food waste into garbage bin with lid on at all times and empty the contents at least once a day.

❖ Clean food containers immediately after use and store them in a dust and pest-free cupboard after drying.

8.4 Storage of foodTo prevent contamination, food should be stored in suitable containers and kept in clean conditions.

8.4.1 Dry food stores

(A) Dried foods should be stored in air-tight containers in a cool storage area.

(B) Containers should be stored on racks at least 45cm from the floor to allow circulation of air.

DRAFT July 2009

12

Food Hygiene

8.4.2 Refrigerators

(A) Refrigerators can be used for the short-term storage of a wide variety of foods.

(B) Since most pathogenic bacteria are unable to multiply at 1-4℃, food storage in a refrigerator is reasonably safe. However, the refrigerated temperature should not exceed 4℃ as some bacteria (e.g. Listeria monocytogenes) can grow and multiply at temperature just above this. Many microorganisms can grow fairly well at low temperatures and spoilage will eventually occur, even within a refrigerator.

(C) For a refrigerator to function efficiently, air must be able to circulate freely around the food. Therefore, refrigerators should not be overloaded.

(D) Raw foods should be well separated from cooked foods to prevent cross-contamination by food poisoning bacteria. If they are stored in the refrigerator, cooked foods should be above raw foods.

(E) Strong smelling foods should be stored in air-tight containers.

(F) Refrigerators with automatic defrosting are recommended, as they keep the ice layer inside the refrigerator to a minimum. For other refrigerators, defrosting must be carried out at regular intervals.

8.4.3 Deep-freeze storage

(A) Freezing is a way to extend the shelf-life of food products using low temperature. Under freezing temperature, some germs may be killed but some can survive. However, no germ can grow at such low temperature.

(B) Deep-freeze cabinets used for long-term food storage should be maintained at a temperature of -18℃ or below.

(C) Frozen meat and fish may be stored for up to six months and frozen fruits and vegetables for up to one year.

(D) When frozen food is thawed, the bacteria which have survived start to grow and multiply again. Food, therefore, should not be thawed and refrozen. However, if foods are partially thawed, for example, while shopping or as a result of power cut, it may be safe to refreeze the food if the food is still frozen and the food is cold. Once food is completely thawed, it should be used straight away. It is normally safe to cook, thawed food and refreeze it as a cooked dish.

DRAFT July 2009

13

Food Hygiene

8.5 Safe practices in defrosting (thawing)Freezing prevents bacteria from growing, but does not kill them. Before cooking or eating frozen foods, defrosting is required. Defrosting is a way to soften frozen food into its original form. Improper defrosting (e.g. defrosting at room temperature) provides an opportunity for food poisoning bacteria to grow and / or produce toxins. Therefore, during defrosting, a good practice needs to be applied. Otherwise, the bacteria in food may grow rapidly.

Four commonly used defrosting methods are:

❖ defrosting in refrigerator❖ defrosting under running water❖ defrosting by microwave oven

8.5.1 Defrosting in refrigerator

(A) A long defrosting time, usually overnight.

(B) Food should be wrapped to prevent contamination.

(C) We should place ready-to-eat (RTE) food and non-ready-to-eat food at upper and lower shelf of refrigerator respectively.

(D) The defrosted food should be placed in refrigerator at all time until it is used or consumed.

(E) Food should be used or consumed within 2 days.

8.5.2 Defrosting under running water

(A) RTE food should be wrapped before putting in water to prevent contamination.

(B) Non-RTE food could be defrosted without wrapping. (C) Water should be kept running to facilitate faster defrosting.

(D) If the defrosted food is not used immediately, they should be wrapped and put in refrigerator.

DRAFT July 2009

14

Food Hygiene

8.5.3 Defrosting by microwave oven

(A) Food should be wrapped before putting in microwave oven.

(B) The defrosting should be divided into two phases. Food should be taken out for stirring or turning over to facilitate adequate and even defrosting.

(C) Turn off the machine and wait for a few seconds before taking food out.

DRAFT July 2009

15

Food Hygiene

Not for SaleThe copyright of the materials in this booklet belongs to the Education Bureau. The materials can be used by schools only for educational purpose. Written prior permission of the Education Bureau must be sought for other commercial uses.

DRAFT July 2009

16

Food Hygiene

DRAFT July 2009

38

Family and LifeStyle