600 mw coal based thermal power plant environmental at … · 2018. 12. 24. · 76.4 74.3 75.61...
TRANSCRIPT
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
1
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
2
POWER PLANT
ENVIRONMENTAL STATEMENT
OF
JHABUA POWER LTD.
UNIT – BARELA & GORAKHPUR
TEHSIL: GHANSORE
DISTRICT – SEONI (M.P.)
CAPACITY: 1 X 600 MW
FINANCIAL YEAR ENDING THE 31ST MARCH, 2018
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
3
ENVIRONMENTAL STATEMENT FORM-V
(See rule 14)
Environmental Statement for the financial year ending with 31st March,
2018 as per condition stipulated under clause no. xxxiv of Specific
Conditions in Environmental Clearance granted by Ministry of Environment
& Forest vide letter no. F.No J - 13012/105/2008 - IA.II (T) dated 17th
February, 2010 and under the clause no 23 of Consent to Establishment
from MP Pollution control Board vide letter no 11425/TS/MPPCB/2010,
dated 15th December 2010.
PART- A
Environmental Statement Report for the Financial Year ending the 31st
March, 2018.
i. Name and address of the
owner/occupier of the industry
Operation or process.
Mr. Janmejaya Mahapatra
Chief Operating Officer
Jhabua Power Ltd
(Avantha Power & Infrastructure
Limited),
Vill. Barela-Gorakhpur, Near Overhead
Tank, Tehsil-Ghansore, Dist. Seoni,
Madhya Pradesh ,480997
ii. Industry category Primary-
(STC Code) Secondary – (STC
Code)
Red Category
iii. Production Capacity 1 X 600 MW
iv. Year of establishment COD: 3rd May, 2016
v. Date of the last environmental
statement submitted.
August 21th , 2017
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
4
PART - B
(I) Water and raw Material Consumption:-
Water consumption by Consumption M3/day
1 Process Average 418 M3/Day
2 Cooling Average 10648 M3/Day
3 Domestic Average 279 M3/Day
S.
No.
Name of the
Products
Process water consumption per unit of
products
During the previous
financial year 2016-17
During the current
financial year 2017-18
1. Process Water 0.179 M3 0.045 M3
(II) Raw material consumption
Name of the
Raw materials*
Name of the
Products
Raw Material consumption
per unit of products
During the
previous financial
year 2016-17
During the
current financial
year 2017-18
Coal Electricity 0.86 MT/MW 0.708 MT/MW
*Industry may use codes if disclosing details of raw material would violate
contractual obligations, otherwise all industries have to name the raw
materials used.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
5
PART - C
Pollution discharged to environment/unit of output
(Parameter as specified in the consent issued)
The plant is commissioned on 3rd May 2016 and under operation.
Observation in and around the plant site:
Pollutants Quantity of
Pollutants
discharged
(mass/day)
Concentration of
Pollutants discharged
(mass/volume)
Percentage
of variation
from
prescribed
standards
with
reasons.
(a) Air As per air
consent
Enclosed as Annexure-1 NA
(b) Water Zero Discharge Enclosed as Annexure-
2a & 2b
NA
PART – D
HAZARDOUS WASTES
As specified under Hazardous Wastes (Management & Handling Rules, 1989)
S.
No.
Hazardous
Wastes
Total Quantity (Kg)
During the previous
financial year 2016-17
During the current financial
year 2017-18
a. From Process Used Oil-7140 Liter 1. Used Oil-8560 Liter
2. Waste residue containing Oil: 100 Liter
b. From Pollution
Control Facilities
NIL
NIL
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
6
PART - E
SOLID WASTES
S.
No.
Solid Wastes Total Quantity (Kg)
During the previous
financial year 2016-17
During the current
financial year 2017-18
a. From Process 21372 MT Bottom ash from
boiler
95652 MT Bottom ash from
boiler
b. From Pollution
Control Facility
86825 MT-Fly ash from
ESP
376758 MT-Fly ash from
ESP
c. Quantity recycled or
reutilized within the
unit.
62.28% fly ash is
utilized by cement
industries, bricks
manufacturer, Highway
construction and roof
sheet manufacturers.
Total ash utilization is
67%, utilized by cement
industries, bricks
manufacturer, Highway
construction and roof
sheet manufacturers.
PART – F
Please specify the characteristics (in terms of concentration and
quantum) of hazardous as well as solid wastes and indicate
disposal practice adopted for both these categories of wastes.
SOLID WASTE:
Ash is the main solid waste generated in the coal based thermal
power plant. The quantity of fly ash and bottom ash generated
will be 3414 TPD and 853 TPD respectively on full capacity of 600
MW.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
7
Fly ash is utilized as per notification for fly ash by Ministry of
Environment & Forest, New Delhi. 62.28% fly ash is utilized in 1st
year of plant operation while 67% (including bottom ash) in 2nd year
by cement industries, bricks manufacturer, Highway construction and
roof sheet manufacturers.
Intermediate & main Silo is constructed for the storage & disposal of
dry fly ash. Unutilized fly ash is disposed to ash pond through high
concentration slurry disposal system for which pipe line is laid down
with ash water recovery system. Ash pond is constructed in 100
acres with 250µ liner.
HAZARDOUS WASTE:
Authorization no 642, dated 17.04.2013 for generation, collection,
storage and disposal of below H.W. has already been granted by
MPPCB, Bhopal for five years from the date of commissioning.
Generated hazardous waste is being disposed off in environmental
friendly manner as below;
Sl.No Hazardous wastes Mode of Disposal
1 Used/Spent Oil
Authorized Hazardous waste Recycler
registered with MPPCB.
2 Oil & grease skimming
residues
Authorized Hazardous waste Recycler
registered with MPPCB.
3 Waste cotton Residual
Containing Oil
Common Treatment, Storage & Disposal
Facility (CTSDF) at Dist- Dhar, M.P.
4 Waste filter & filter
material.
Common Treatment, Storage & Disposal
Facility (CTSDF) at Dist- Dhar, M.P.
5 Used Ion Exchange
Residue
Authorized Hazardous waste Recycler
registered with MPPCB.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
8
6 Used batteries with Acid
from Batteries
Authorized Hazardous waste Recycler
registered with MPPCB.
PART – G
Impact of the pollution control measures taken on
conservation of natural resources and consequently on the
cost production.
The ambient air quality monitoring with respect to the 10 km radius
study area around the project site is being carried out by M/s Vardan
Envirolab, Gurgaon on monthly, quarterly and six monthly basis to
access existing ambient air quality of the area. The various sources of
air pollution in the region are dust rising from unpaved roads,
domestic fuel burning, vehicular traffic, agricultural activities, other
industries like stone crusher, etc.
The surface and ground water quality of the study area is also being
done on six monthly basis by M/s Vardan Envirolab, Gurgaon.
In order to know the baseline of noise levels in and around the project
site, noise levels were measured in the core zone and within the plant
premises. Regular monitoring of ambient air quality, Noise Level,
ground & surface water quality have been carried out to evaluate the
quality of environment.
Result for the same has been attached as below;
1. Ambient air quality monitoring report enclosed as Annexure 1.
2. Ground water quality report enclosed as annexure 2a.
3. Surface water quality report enclosed as annexure 2b.
4. Noise level monitoring report enclosed as annexure 3.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
9
Sampling, monitoring & analysis of above report is carried out by our
environmental consultant M/s Vardan Envirolab, Gurgaon.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
10
PART – H
Additional measures/investment proposal for environmental
protection including abatement of pollution.
Green belt development.
Online Permanent continuous AAQM System.
Online Permanent continuous Effluent quality monitoring
(EQMS) System.
Monitoring Van for ambient air quality Monitoring.
Opacity meter and gaseous monitoring system for continuous
online monitoring of PM, SOx, NOx and CO in 275 meter stack.
Installation of Ash water recovery system.
World Environment day celebration on 5th June 2017.
PART - I
MISCELLANEOUS:
Any other particulars in respect of environmental protection
and abatement of pollution.
A system followed by training is being implemented for the
effective compliance of Environmental clearance and consent
to operate.
Water sprinkling being used in the kuchha roads of site and
other dust vulnerable areas of the plant.
Greenery is being developed in and around the plant and till
March 2017 approximately 1,67,604 plantation has been
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
11
completed @ 2500 plants per ha in and around the plant
premises. Photographs of Green belt is enclosed as annexure
-4.
Native species is being preferred for the plantation having
following characteristics:
Fast growing with thick canopy cover.
Adequate height with longer duration of foliage.
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
12
Annexure - 1
Ambient Air Quality Monitoring Results
DECEMBER -2017
S. No.
Parameters Project Site
Village
Barela
Village
Binaki
Village
Dola
Village
Durjanpur
Village
Panarjhir
Village
Gorakhpur
Village
Gunehri
1. Particulate Matter (PM2.5),
g/m3
46.2 33.05 30.2 31.2 34.57 36.1 32.59 34.2
2. Particulate Matter (PM10),
g/m3
81.4 68.2 64.4 62.14 63.19 70.2 66.2 67.2
3. Nitrogen Dioxide
(NO2), g/m3
28.6 20.1 15.6 16.2 18.1 19.8 17.8 19.2
4. Sulphur Dioxide
(SO2), g/m3
10.4 7.8 5.2 7.1 7.8 8.1 8.9 8.4
5. Mercury ( mg/m3)
BDL BDL BDL BDL BDL BDL BDL BDL
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
13
Annexure – 2A
Ground Water Monitoring Results
DECEMBER -2017
S. No.
Parameter Project Site
Village- Barela
Vilage-Panarjhir
Village-Durjanpur
Village-Gunehri
Village- Dola
Village- Binaiki
Village- Gorakhpu
r
Desirable limit (Max.)
Permissible limit in the Absence of Alternate
Source (Max.)
1 Colour (Hazen Unit)
BDL BDL BDL BDL BDL BDL BDL BDL 5 15
2 Odour Agreeable
Agreeable
Agreeable
Agreeable Agreeable
Agreeable
Agreeable
Agreeable
Agreeable
Agreeable
3 Turbidity (NTU) BDL BDL BDL BDL BDL BDL BDL BDL 1 5
4 pH (at 25 0C) 7.51 7.35 7.51 7.61 7.48 7.53 7.48 7.43 6.5-8.5 No relaxation
5 Total Dissolved Solids (mg/l)
353 331 324 344 337 342 337 359 500 2000
6 Total Hardness as CaCO3 (mg/l)
152.3 144.1 140.2 153.2 148.5 153.4 146.3 149.6 200 600
7 Alkalinity as CaCO3, (mg/l)
132.2 127.4 118.7 124.1 120.6 123.5 124.5 136.3 200 600
8 Sulphate as SO4
(mg/l)
60.1 58.2 60.4 61.4 56.2 64.2 56.1 54.2 200 400
9 Chloride as Cl (mg/l)
76.4 74.3 75.61 78.3 77.43 78.51 76.3 75.8 250 1000
10 Nitrate as NO3 mg/l
4.98 5.78 5.97 6.02 5.74 5.53 6.1 5.12 45 No relaxation
11 Calcium as Ca mg/l
50.2 47.52 48.63 50.37 49.82 50.22 50.02 48.3 75 200
12 Magnesium as Mg (mg/l)
6.57 6.2 4.58 6.68 5.88 6.82 5.22 7.06 30 100
13 Iron as Fe (mg/l) 0.24 0.23 0.34 0.35 0.34 0.28 0.28 0.22 1.0 No relaxation
14 Fluoride as F (mg/l)
0.62 0.6 0.63 0.7 0.72 0.73 0.67 0.58 1.0 1.5
15 Aluminum (as Al) BDL BDL BDL BDL BDL BDL BDL BDL 0.03 0.2
16 Boron (as B) ( mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.5 0.1
17 Cadmium as Cd BDL BDL BDL BDL BDL BDL BDL BDL 0.003 No
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
14
(mg/l) relaxation
18 Chromium as Cr (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.05 No relaxation
19 Copper as Cu (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.05 1.5
20 Lead as Pb (mg/l) BDL BDL BDL BDL BDL BDL BDL BDL 0.01 No relaxation
21 Manganese as Mn (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.1 0.3
22 Selenium as Se ( mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.01 No relaxation
23 Arsenic as As (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.01 No relaxation
24 Zinc as Zn (mg/l BDL BDL BDL BDL BDL BDL BDL BDL 5 15
25 Mercury as Hg (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.001
No relaxation
26 Residual free Chlorine (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.2 1.0
27 Phenolic Compound (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.001 0.002
28 Anionic Detergent (mg/l)
BDL BDL BDL BDL BDL BDL BDL BDL 0.2 1.0
29 Cyanides (mg/l) BDL BDL BDL BDL BDL BDL BDL BDL 0.05 No relaxation
30 E. Coli Absent Absent Absent Absent Absent Absent Absent Absent Not detectable
31 T. Coliform per/100 ml
<2 <2 <2 <2 <2 <2 <2 <2 Not detectable
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
15
Annexure – 2B
Surface Water Sampling Results
DECEMBER -2017
Sr. No Parameters Pariyat River near Biuai
Village
Temor River near Pati
village
Nala near Binaiki
Surface Water Quality Standards (as per IS 10500:2012 and amendment 1).
Desirable Permissible
1 Colour (Hazen Unit) BDL BDL 5 5 15
2 Odour Agreeable Agreeable Agreeable Agreeable Agreeable
3 Turbidity (NTU) 2 2 12 1 5
4 pH (at 25 0C) 7.46 7.62 7.59 6.5-8.5 No relaxation
5 Total Dissolved Solids (mg/l)
148 156 115 500 2000
6 TSS mg/l 5.02 4.92 22.4 - -
7 Total Hardness as CaCO3 (mg/l)
122.84 125.4 148.2 200 600
8 Alkalinity as CaCO3, (mg/l)
67.8 72.1 91.8 200 600
9 Sulphate as SO4
(mg/l) 5.12 6.32 16.2 200 400
10 Chloride as Cl (mg/l) 5.82 6.32 21.4 250 1000
11 Nitrate as NO3 mg/l 4.92 5.1 4.02 45 No relaxation
12 Calcium as Ca mg/l 28.1 25.4 28.4 75 200
13 BOD mg/l 4.51 3.59 11.4 - -
14 Magnesium as Mg (mg/l)
12.81 15.07 18.79 30 100
15 Iron as Fe (mg/l) 0.08 0.06 0.07 1.0 No relaxation
16 Fluoride as F (mg/l) 0.45 0.44 0.49 1.0 1.5
17 COD mg/l 12.3 11.28 36.8 - -
18 Aluminum (as Al) BDL BDL BDL 0.03 0.2
19 Boron (as B) ( mg/l) BDL BDL 0.06 0.5 0.1
20 Cadmium as Cd (mg/l)
BDL BDL BDL 0.003 No relaxation
21 Chromium as Cr (mg/l)
BDL BDL BDL 0.05 No relaxation
22 Copper as Cu (mg/l) BDL BDL BDL 0.05 1.5
23 Lead as Pb (mg/l) BDL BDL BDL 0.01 No relaxation
24 Manganese as Mn (mg/l)
BDL BDL 0.11 0.1 0.3
25 Selenium as Se ( mg/l)
BDL BDL BDL 0.01 No relaxation
26 Arsenic as As (mg/l)
BDL BDL BDL 0.01 No relaxation
27 Zinc as Zn (mg/l BDL BDL 0.23 5 15
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
16
28 Mercury as Hg (mg/l)
BDL BDL BDL 0.001
No relaxation
29 Residual free Chlorine (mg/l)
BDL BDL BDL 0.2 1.0
30 Phenolic Compound (mg/l)
BDL BDL BDL - -
31 Anionic Detergent (mg/l)
BDL BDL BDL
32 Cyanides (mg/l) BDL BDL BDL
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
17
Annexure – 3
Ambient Noise Level Results
DECEMBER -2017
S. No.
Name Of Sampling / Monitoring Location
Noise level Monitoring Unit - dB (A)
CPCB Limits in dB(A)
Day Time
Leq
Night Time
Leq
Day Time
(6:00 a.m. to 10:00 p.m.)
Night Time
(10:00 p.m. to 6:00 a.m.)
1 Project area 67.84 56.07 75 70
2 Village -Barela 53.94 44.21 55 45
3 Village - Gorakhpur
52.63 43.22 55 45
4 Village -Durjanpur 50.21 40.82 55 45
5 Village - Guneri 51.33 41.3 55 45
6 Village - Dola 52.10 41.11 55 45
7 Village – Binaiki 51.74 41.66 55 45
8 Village - Panarjhir 52.1 42.13 55 45
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
18
Annexure 4
Plantation on 33% land of 406 acres
134 acres
Density of plantation 2500 plants/Hectare
Area required per plant 4.0 SQM
Total plantation required on 134 acres (542164 SQM) of land
135541 Nos
No of plantation completed 167604 Nos
Survival rate maintained >70%
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
19
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
20
600 MW Coal Based Thermal Power Plant
At Villages Barela and Gorakhpur, Tehsil Ghansore, District Seoni (Madhya Pradesh)
Environmental Statement Report,
2017-2018
21