08lpbypass _std
TRANSCRIPT
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 1/40
May 24, 2012 PMI Revision 00 1
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 2/40
May 24, 2012 PMI Revision 00 2
• Introduction of LP Bypass system
• Overview of LP Bypass
• System details and lay out
• Control scheme of LP bypass system•
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 3/40
May 24, 2012 PMI Revision 00 3
• LP bypass bypasses steam to IPT & LPT & maintain flow
through RH.
Function of LP bypass:-1. To monitor the pressure in reheat system and to control it
under certain operating condition.
2. The volume of steam not utilized by the IPT & LPT during
start up & shut down must pass through condenser.
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 4/40
May 24, 2012 PMI Revision 00 4
LP Bypass system provide a very effective means of controlling reheat –steam flow during
LP BYPASS SYSTEM
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 5/40
May 24, 2012 PMI Revision 00 5
It enhances fast starting capability of turbines from allinitial conditions e.g.
Cold condition
Warm condition
Hot Condition
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 6/40
May 24, 2012 6
LP steam-bypass system operates in parallel with theturbine
Protects Condenser from excessive temperature andpressure that could result from sudden injection of
superheated steam
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 7/40
May 24, 2012 PMI Revision 00 7
•
•
LP BYPASS SYSTEM
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 8/40
May 24, 2012 PMI Revision 00 8
Upon receiving load rejection signal from electricalsystem:
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 9/40
May 24, 2012 PMI Revision 00 9
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 10/40
May 24, 2012 PMI Revision 00 10
• If LP steam- bypass system fails or the
condenser cannot accept LP bypass
steam , Safety Valves open and dump
steam to atmosphere
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 11/40
May 24, 2012 PMI Revision 00 11
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 12/40
May 24, 2012 PMI Revision 00 12
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 13/40
May 24, 2012 PMI Revision 00 13
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 14/40
May 24, 2012 PMI Revision 00 14
•
•
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 15/40
May 24, 2012 PMI Revision 00 15
• Set point formation
• Pressure control for LP bypass system
• LP bypass HYDRAULIC System• Protection system
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 16/40
May 24, 2012 PMI Revision 00 16
•
•
•
Control scheme
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 17/40
May 24, 2012 PMI Revision 00 17
Set Value formation
The Two set values – fixed and variable are formed for theLPBypass control system
set value to be used is determined by a maximum valueselector
For the formation of variable set point, a pressuretransducer is used to measure the steam pressure in HPturbine
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 18/40
May 24, 2012 PMI Revision 00 18
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 19/40
May 24, 2012 PMI Revision 00 19
LP Bypass System
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 20/40
May 24, 2012 PMI Revision 00 20
Features of LPBP Controller
• LPBP controller maintains pressure after reheater
by controlling LP bypass valves
• It acts on the coil of the LPBP E-H converter to
position the control valves.
• Two setpoints, fixed and variable are used in
maximum selection circuit
• Variable setpoint is derived from HP first stage
pressure
• Water spray is in two stages depending on steam
flow through LPBP stations.
• LPBP valves cannot open until adequate spray
water pressure and required vacuum is there and
condenser wall temp is not high.
• Valves can also be operated manually
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 21/40
May 24, 2012 PMI Revision 00 21
LP BYPASS SETPOINTS
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 22/40
May 24, 2012 PMI Revision 00 22
Hydraulic Mode of Operation
•
•
•
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 23/40
May 24, 2012 PMI Revision 00 23
Hydraulic Mode of Operation
•
•
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 24/40
May 24, 2012 PMI Revision 00 24
Design of LPBypass Valves for 210 MW
Steam Turbine
• Controlled by 8bar mineral oil
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 25/40
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 26/40
May 24, 2012 PMI Revision 00 26
Protection Devices
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 27/40
May 24, 2012 PMI Revision 00 27
Protection Devices cause closure of
bypass station in case of following
eventualities
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 28/40
May 24, 2012 PMI Revision 00 28
•
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 29/40
May 24, 2012 PMI Revision 00 29
CURVE FOR LPBYPASS
CONTROLLER
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 30/40
May 24, 2012 PMI Revision 00 30
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 31/40
May 24, 2012 PMI Revision 00 31
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 32/40
May 24, 2012 PMI Revision 00 32
Actuator Bypass
Stop Valve
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 33/40
May 24, 2012 PMI Revision 00 33
ActuatorLPBPCV
500 MW
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 34/40
May 24, 2012 PMI Revision 00 34
Pilot valve
for Water
Injection Valve
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 35/40
May 24, 2012 PMI Revision 00 35
Water
InjectionValve
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 36/40
May 24, 2012 PMI Revision 00 36
Combined Bypass
Stop & Control
Valve 210 MW
Feedback for Pilot valve of
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 37/40
May 24, 2012 PMI Revision 00 37
Feedback for Pilot valve of Bypass Control Valve 210 MW
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 38/40
May 24, 2012 PMI Revision 00 38
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 39/40
7/31/2019 08LPbypass _Std
http://slidepdf.com/reader/full/08lpbypass-std 40/40
M 24 2012 PMI R i i 00 40