05- gas meter calibration-individual meter
TRANSCRIPT
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
1/14
Faculty of Chemical & Natural Resources Engineering
BKG3721
Fuel & Combustion Lab
Experiment 05
GAS E!E" CAL#B"A!#$% #%'#(#')AL
E!E"
%ameatri* %o+Group,ro-ramSe*tion'ate
Sem+ 11 Session 2012.2013
1+0 $b/e*ti e
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
2/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
To provide hands on experience and enhance the understanding onthe principles of gas meter calibration using the reference meterconcept. The system used in this experiment is theSOLTEQ/CL /!"!#/$$ Calibration Station.
2+0 #ntro u*tion
The calibration process as conducted in this experiment follo%s theinternational standards as practiced by the industry. The experienceand exposure gained from doing this experiment %ill enhance theunderstanding of gas meter design and operation.
&n this particular experiment' system stabili(ation is closely lin)ed%ith the time period and steady state process. &n order to reachstabili(ed supply of the compressed air medium' buffering is re*uiredto ensure consistent supply by maintaining constant do%nstreamdemand. &f large fluctuation occurs in the do%nstream demand'stability might not be reached. y ensuring sufficient gas supply andappropriate flo% control' operation accuracy and verification of gasmeter should be achieved.
&t is important to remember that since the supply pressure by theportable gas cylinder is relatively high' pressure regulator must beemployed and appropriate safety precaution exercised. The controlof opening and closing of the isolation valve should be madecarefully.
The second stage regulator is employed to ensure gas supply doesnot exceed the maximum operating pressure of %et type gas meterto about "# + %.c.. Touch,screen -C installed should be operated onlyafter basic operation of the system is thoroughly understood.
lo% control is by means of using the appropriate hand valves. Eachpressure sensing line should be made up to al%ays in the openingposition. The closing and opening of isolation hand valves shouldfollo% the instruction belo%.
2
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
3/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
Note: Air Compressor will immediately stop, once the Air ReceivingUnit reaches its setpoint. The compressor will be automaticallytriggered if this pressure is reduced .0
3+0 Experimental ,ro*e ures
3+2 #n i i ual (eri i*ation o 'iap4ra-m Gas eter
3+2+1 'iap4ra-m eter %o+1 an "e eren*e eter
a. $ecord the initial reading of reference %et typemeter and meter no.". $ecord also the reading ofthe pressure and temperature of the relatedposition using online touch,screen system.
b. Open isolation valves nos 1 2,S3T' 2,$E ' 2,"' 2,4'2,5' 2,6' 2,"4 and ,"7.
c. Open the gas supply system from cylinders.d. Ensure isolation valves 2,8' 2,#' 2,7' 2,9' 2,:' 2,
"!' 2,""' 2,"8' 2,"# and 2,LO3; is fully closed.e.
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
4/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
a. $ecord the initial reading of reference %et typemeter and meter no.4. $ecord also the reading ofthe pressure and temperature of the relatedposition using online touch,screen system.
b. Open isolation valves nos1 2,S3T' 2,$E ' 2,8' 2,#'2,7' 2,6' 2,"4 and 2,"7.
c. Open the gas supply system from cylinders.d. Ensure isolation valves 2,"' 2,4' 2,5' 2,9' 2,:' 2,
"!' 2,""' 2,"8' 2,"# and 2,LO3; is fully closed.e.
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
5/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
g. 3t the end of 4 minutes record the pressure'temperature and meter reading at reference meterand meter no.8.
h. 3t the end of # minutes repeat the aboveinstruction g0.
i. Close isolation valve 2,LO3; at this particularmoment.
=. Stop the stop %atch.). Stop the gas supply from the cylinders by closing
the valve 2,S3T.l. Tabulate results.
3+2+ 'iap4ra-m eter %o+ an "e eren*e eter
a. $ecord the initial reading of reference %et typemeter and meter no.#. $ecord also the reading ofthe pressure and temperature of the relatedposition using online touch,screen system.
b. Open isolation valves nos 1 2,S3T' 2,$E ' 2,8' 2,5'2,6' 2,"!' 2,"" and 2,"7.
c. Open the gas supply system from cylinders.d. Ensure isolation valves 2,"' 2,4' 2,#' 2,7' 2,9' 2,
:' 2,"4' 2,"8' 2,"# and 2,LO3; is fully closed.e.
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
6/14
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
7/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
+1 #n i i ual (eri i*ation o 'iap4ra-m Gas eter
!able +1+1 'iap4ra-m eter %o+1 an "e eren*e eter
Temperatur e
(oC)
Pressure(bar)
Initial Volume, V 1(L)
Final Volume,Vo(L)
Vo-V 1(L)
First Two Minutes
Meter No1
Ref Meter
Four Minutes
Meter No1
Ref Meter
!able +1+2 'iap4ra-m eter %o+2 an "e eren*e eter
Temperatur e
(o
C)
Pressure(bar)
Initial Volume, V 1(L)
Final Volume,Vo
(L)
Vo-V 1(L)
First Two Minutes
Meter No!
Ref Meter
Four Minutes
Meter No!
Ref Meter
7
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
8/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
!able +1+3 'iap4ra-m eter %o+3 an "e eren*e eter
Temperatur e
(oC)
Pressure(bar)
Initial Volume, V 1(L)
Final Volume,Vo(L)
Vo-V 1(L)
First Two Minutes
Meter No"
Ref Meter
Four Minutes
Meter No"
Ref Meter
!able +1+ 'iap4ra-m eter %o an "e eren*e eter
Temperatur e
(oC)
Pressure(bar)
Initial Volume, V 1(L)
Final Volume,Vo(L)
Vo-V 1(L)
First Two Minutes
Meter No#
Ref Meter Four Minutes
Meter No#
Ref Meter
!able +1+5 'iap4ra-m eter %o5 an "e eren*e eter
Temperatur e
(oC)
Pressure(bar)
Initial Volume, V 1(L)
Final Volume,Vo(L)
Vo-V 1(L)
First Two Minutes
Meter No$
Ref Meter
Four Minutes
Meter No$
8
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
9/14
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
10/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
5+0 A%AL S#S
-lot the percent error and percent correction against the meter y forthe simultaneous case on the graph paper provided. $epeat the plotfor the individual case on the same graph paper.
a0
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
11/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
11
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
12/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
Fi-ure 18 S*4emati* 'ia-ram o Flo9 Control S:stem
12
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
13/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013
13
-
8/12/2019 05- Gas Meter Calibration-Individual Meter
14/14
BKG3751 Fuel an Combustion Lab Sem ## 2012.2013