+ = great peoplegreat brands smiles springfield. kraft foods group, inc. energy savings heat...
TRANSCRIPT
+ =
great people great brands smiles
Springfield
Kraft Foods Group, Inc.
ENERGY SAVINGS Heat Recovery
Boiler Stacks and Ammonia Compressor Green Ideas to Reduce Water Usage Water Audit - EcoLab LED Lighting
Kraft Foods Group, Inc.3
Heat Recovery
Boiler Stacks – 115-120 degrees recovery temperature used to heat water• Process loop works as a scrubber to reduce
emissionsAmmonia Compressor – High Heat Source• Heats Water - 75 GPM @ 140 degrees• Natural Gas, Electric, and Condenser Water
Chemical Savings.Annual Savings in Natural Gas• ~7,600,000,000 BTU • $27,394
Boiler Stacks & Ammonia Compressor – Add Heat Exchangers
2012
2008
Kraft Foods Group, Inc.4
Green Ideas to Reduce Water Usage
• June – Dec 2012• 32 Ideas & Suggestions• 14 Implemented by Jan 1, 2013 • 5 Top Ideas
– Reduce Sprinkler -1 X a week– Turn Off Sprinkler
• 11,760 gallons– Cleaning Frequency - Wet Cleaning vs.
Dry Cleaning in 3 areas• 38,280 gallons
– Spray Balls with Selsor Jet Hose in 5 Blenders vs. Hand held Power Hose
• 131,250 gallons – High Pressure Hose Reduced to ½
Pressure after First 3 hours• 1,303,000 gallons
• 1,612,948 Gallons Saved Annually – Savings in Energy & Chemicals
Water Conservation Contest
179,090
1,303,000
13,740117,118
Gallons of Water Saved An-nually
CHEESENCDNHR
TOTAL Gallons
1,612,948
Kraft Foods Group, Inc.5
WATER AUDIT - 2013Ecolab – Four Consultants Performed Audit – February
• Cream Silos – CIP Clean– 3 Silos– Reduce CIP Acid Wash Time– Reduce Acid Wash Temperature– Reduce 7 minutes off Each Silo
• Water Loss – 155 GPM• Minutes Per Day - 10 • Days Per Week - 1
– Total Savings of Water• 179,400 Gallons Annually
– Savings of Energy to Heat Water• ~134,729,400 BTU
Kraft Foods Group, Inc.6
LED LIGHTING
Main Lobby – ATG-LED– 2’ X 2” iBright LED Flat Panel Troffers
replaced old 2’ X 2’ fluorescent fixtures – 20 lights
• Reduction in Labor & Disposal Cost• $467 Annually Savings
Replace Fluorescent Lighting Across the Facility
Environmental Facts• Last 15 – 30 years• 130,000 hours Will Start to Dim• No Mercury or Harmful Gases
– No Special Disposal • Solid State – No Glass• Glare Free Illumination• 15% Less Heat than Fluorescent –
Saves on AC
iBright™ 2X2Flat LED Panel
40 mm
Kraft Foods Group, Inc.7
LED LIGHTING
• Front Parking Lot - HoloPhane– 4,368 Annual Operating Hours – 20 Fixtures– Total kwh
• 22.26 (old) vs. 6 (new)– Rated Lamp Life Hours
• 12,000 (old) vs. 70,000 (new)– 10 year Warranty– 1.5 years payback – $4,823 Annual Savings
• Reduction in Labor & Disposal Cost
Replacing Fluorescent Lighting Across the Facility
• Cafeteria & Conf Rooms – ATG-LED– Currently 2’ X 4” Fluorescent Fixtures
• 81 Fixtures• 3 Tubes @ 32 Watts each• Totals 96 Watts• Each Fixture has Ballast – 3-6 Watts• ~100 Watts Total
– Retro Fit with iBright 2’ X 2’ Flat LED• 81 fixtures• 40 Watts Total = 60% Reduction
– 41,749 kwh Reduction Annually– $4,341 Annual Savings
• Reduction in Labor & Disposal Cost
Kraft Foods Group, Inc.
ENERGY SAVINGS
QUESTIONS?