2000 ds golf car - club car 0899b000… · use gasoline containing up to 15% mtbe by volume....

Owner’s Manual

2000DS Golf Car

Gasoline

2000 DS Golf Car Gasoline Vehicle Owner’s Manual i

FUEL AND OIL RECOMMENDATIONS

FuelUse only clean, fresh, unleaded regular grade

gasoline.Octane Rating

The octane rating of a gasoline is a measureof its resistance to “knocking”. Use of a mini-mum of 87 octane of the anti-knock index isrecommended.The anti-knock index is posted onservice station pumps in the U.S.A.

Oxygenated FuelIf you use oxygenated fuel (either ethanol orMTBE added to gasoline), be sure it is unleadedand meets the minimum octane rating require-ment.

The following are the EPA approved percent-ages of fuel oxygenates.

ETHANOL: (Ethyl or Grain Alcohol) You mayuse gasoline containing up to 10% ethanol byvolume.

MTBE: (Methyl Tertiary Butyl Ether) You mayuse gasoline containing up to 15% MTBE byvolume.METHANOL: (Methanol or Wood Alcohol) 5% byvolume.

You may use gasoline containing up to 5%methanol by volume, as long as it also containscosolvents and corrosion inhibitors to protectthe fuel system. Gasoline containing more than5% methanol by volume may cause startingand/or performance problems. It may also dam-age metal, rubber, and plastic parts of your fuelsystem.

Engine OilThe following engine oils are recommended.

API Service Classification: SC, SD, SE, SF,SG, or SH.

Oil ViscosityChoose the viscosity according to the tem-

perature as follows:

Fuel InformationTHIS VEHICLE IS CERTIFIED TO OPER-

ATE ON UNLEADED REGULAR GRADEGASOLINE ONLY. A minimum of 87 octane ofthe anti-knock index is recommended.The anti-knock index is posted on service station pumpsin the U.S.A.Emission Control Information

To protect the environment in which we alllive, Club Car has incorporated crankcase emis-sion (1) and exhaust emission (2) control sys-tems (EM) in compliance with applicable regu-lations of the U.S. Environmental ProtectionAgency and California Air Resources Board.1. Crankcase Emission Control System

A sealed-type crankcase emission controlsystem is used to eliminate blow-by gases.Theblow-by gases are led to the breather chamberthrough the crankcase. Then, it is led to the aircleaner.

Oil is separated from the gases while passingthrough the inside of the breather chamberfrom the crankcase, and then returned back tothe bottom of the crankcase.

2. Exhaust Emission Control SystemThe exhaust emission control system applied

to this engine consists of a carburetor and anignition system having optimum ignition timingcharacteristics.

The carburetors have been calibrated toprovide lean air/fuel mixture characteristicsand optimum fuel economy with a suitable aircleaner and exhaust system.Maintenance and Warranty

Proper maintenance is necessary to ensurethat your engine will continue to have low emis-sion levels.Those items identified by the PeriodicMaintenance Chart are necessary to ensurecompliance with the applicable standards.

The Club Car Limited Emission ControlSystem Warranty requires that you return yourengine to an authorized Club Car Dealer forremedy under warranty. Please read the warrantycarefully, and keep it valid by complying withthe owner’s obligations it contains.Tampering with Emission ControlSystem Prohibited

California State law prohibits the following

acts or the causing thereof: (1) the removal orrendering inoperative by any person other thanfor purposes of maintenance, repair, or replace-ment, of any device or element of design incor-porated into any new engine for the purposes ofemission control prior to its sale or delivery to theultimate purchaser or while it is in use, or (2) theuse of the engine after such device or element ofdesign has been removed or rendered inopera-tive by any person.

Among those acts presumed to constitutetampering are the acts listed below:

Do not tamper with the original emission relat-ed parts:• Carburetor and internal parts• Spark plugs• Magneto or electronic ignition system• Fuel filter element• Air cleaner element• Crankcase• Cylinder head• Breather chamber and internal parts• Intake pipe and tube

EMISSION CONTROL INFORMATION

-20°C -10°C 0°C 10°C 20°C 30°C 40°C

-4°F 14°F 32°F 50°F 68°F 86°F 104°F

SAE 5W-20

SAE 10W-30/SAE 10W-40

SAE 30

SAE 40

NOTE

• If “knocking or pinging” occurs, use adifferent brand of gasoline or higheroctane rating.

• Do not mix oil with gasoline.

• Gasoline is extremely flammable andcan be explosive under certain con-ditions. Turn the engine switch OFF.Do not smoke. Make sure the area iswell ventilated and free from anysource of f lame or sparks; thisincludes any appliance with a pilotlight. Never fill the tank so the fuellevel rises into the filler neck. If thetank is overfilled, heat may causethe fuel to expand and overflowthrough the vents in the tank cap.

• After refueling, make sure the tankcap is closed securely.

• If gasoline is spilled on the fuel tankwipe it off immediately.

WARNING

CAUTION

WARNING

WARNING

• THE ENGINE EXHAUST FROM THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATEOF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS, OR OTHER REPRODUCTIVE HARM.

NOTE

• Using multi-grade oils (5W-20, 10W-30, and 10W-40) will increase oilconsumption. Check oil level morefrequently when using them.

ii 2000 DS Golf Car Gasoline Vehicle Owner’s Manual

NOTICE

The Club Car Limited Warranty for owners of single golf cars appears on the pages following this notice, andthe Limited Lifetime Fleet Warranty appears on the last pages of this manual. No other warranties, express orimplied, are contained herein. Your authorized representative checked this vehicle before it was delivered toyou and will provide a completed warranty registration card to you.

Club Car is not liable for errors in this manual or for incidental or consequential damages that result from theuse of the material in this manual.

This vehicle conforms to the current American National Standards Institute’s Z130 Safety and PerformanceRequirements for Golf Cars. This standard, which promotes safety in the design, application, and operationof golf cars, defines a golf car as “a vehicle used to convey a person or persons and equipment to play thegame of golf in an area designated as a golf course.” Throughout this manual, the words “golf car” and “vehi-cle” are used interchangeably.

This manual contains proprietary information that is protected by copyright. All rights are reserved. No part ofthis manual may be photocopied, reproduced, or translated to another language without the written consentof Club Car, Inc.

The information contained in this document is subject to change without notice.

Club Car reserves the right to make design changes to vehicles without obligation to make these changes onunits previously sold.

These vehicles do not conform to Federal Motor Vehicle Safety Standards for automobiles or to FMVSS 500for low-speed vehicles, and are not equipped for operation on public streets, roads, or highways.

P.O. Box 204658Augusta, Georgia 30917-4658 USA

Telephone: 1-800-ClubCar (258-2227)www.clubcar.com

©1999 Club Car, Inc.

Club Car, Armorflex,

and

Tranquility

areregistered trademarks of Club Car, Inc.

This manual effective July 26, 1999

2000 DS Golf Car Gasoline Vehicle Owner’s Manual iii

CLUB CAR LIMITED THREE YEAR WARRANTY FOR 2000 SINGLE

GOLF CARS

1. WARRANTY:

CLUB CAR, INC., (“CLUB CAR”) hereby warrants to the original retail purchaser that its new 2000 Model DSgolf car purchased from CLUB CAR or an authorized distributor or dealer for use in the United States orCanada shall be free from defects in materials and workmanship under normal use and service as a golf car forthe periods stated below, subject to the provisions, limitations, and exclusions contained in this limited warranty.

LIMITED THREE YEAR WARRANTY:

The golf car frame (excluding the front and rear bumper mounts), rack and pinion steering gearbox unit,suspension system (defined as the shock absorbers, shock mounts, A-plate, leaf springs, shackles, andassociated hardware), gasoline engine, unitized transaxle, torque converters (drive and driven), startergenerator, transaxle (electric vehicle), and electric motor are warranted with respect to parts and labor againstdefects in materials and workmanship for a period of three years from the date of purchase.

LIMITED TWO YEAR WARRANTY:

All remaining components of the golf car not specified otherwise, except options and accessories, arewarranted with respect to parts and labor against defects in materials and workmanship for a period of twoyears from the date of purchase.

LIMITED ONE YEAR WARRANTY:

All original equipment options and accessories supplied by Club Car are warranted with respect to parts andlabor against defects in material and workmanship for a period of one year from the date of purchase.

This limited warranty covers materials, workmanship, and repair labor cost as to those items specifically listedabove for the periods specified. Such repair labor shall be performed only by CLUB CAR, its authorizeddistributors or dealers, or a service agency approved by CLUB CAR.

IF THE WARRANTY REGISTRATION FORM IS NOT COMPLETED AND RETURNED TO CLUB CAR AT THETIME OF THE ORIGINAL RETAIL SALE, PURCHASER MUST PROVIDE PROOF OF DATE OF PURCHASEWITH ANY WARRANTY CLAIM.

2. EXCLUSIONS:

Excluded from any CLUB CAR warranty are all fuses, filters, decals (except safety decals), spark plugs, lubricants,trim pieces, seats, routine wear items such as the charger plug and receptacle, brake shoes, belts, brushes,bushings, engine mounts, mats and pads, maintenance adjustments, cosmetic deterioration, and items whichdeteriorate or fail due to exposure or ordinary wear and tear. Batteries, battery charger, onboard computer, andsolid state controller are covered by separate CLUB CAR warranties. Tires are warranted by their manufacturer.Also excluded from any CLUB CAR warranty is damage to a golf car or component resulting from a cause otherthan a defect including unreasonable or unintended strain or use, improper installation of accessories, installationof parts or accessories that are not original equipment, overloading, accident, alteration, abuse, or neglect.

Transportation expenses for warranty service are also excluded from this warranty.

3. VOIDING OF WARRANTY:

THIS AND ANY OTHER WARRANTY SHALL BE VOID IF THE GOLF CAR IS ABUSED OR USED IN ANUNINTENDED MANNER OR SHOWS INDICATIONS THAT IT HAS BEEN ALTERED IN ANY WAY,INCLUDING, BUT NOT LIMITED TO, MODIFICATION OF THE SPEED GOVERNOR, BRAKING SYSTEM,STEERING, TRANSAXLE, OR OTHER OPERATING SYSTEMS OF THE CAR TO CAUSE IT TO PERFORMOUTSIDE CLUB CAR SPECIFICATIONS. THE WARRANTY IS LIKEWISE VOID IF THE CAR SHOWSINDICATIONS THAT REASONABLE OR NECESSARY MAINTENANCE AS OUTLINED IN THE OWNER’SMANUAL AND MAINTENANCE AND SERVICE MANUAL WAS NOT PERFORMED AT THE TIME AND INTHE MANNER SPECIFIED IN SUCH MANUALS.

iv 2000 DS Golf Car Gasoline Vehicle Owner’s Manual

4. SOLE REMEDY:

CLUB CAR’s only liability under this limited warranty, or in any action, whether based upon warranty, contract,negligence, strict product liability, or otherwise, is limited to the repair or replacement, at CLUB CAR’s option, ofa golf car or component thereof that CLUB CAR deems to be defective. Replacement shall mean furnishing,during the applicable limited warranty period, a new golf car or factory reconditioned vehicle or componentthereof which is identical or reasonably equivalent to the warranted product or component at no cost to thepurchaser. Repair shall mean remedying a defect in the golf car or component thereof at no cost to thepurchaser during the applicable limited warranty period. If CLUB CAR elects to repair the golf car, it mayprovide factory reconditioned parts or components. All parts and components replaced under warranty shallbecome the property of CLUB CAR.

5. HOW TO MAKE A WARRANTY CLAIM:

To make a warranty claim under this limited warranty, you must present the golf car or defectivecomponent to an authorized CLUB CAR distributor or dealer or send the defective component, freightprepaid, to WARRANTY ADMINISTRATION, CLUB CAR, INC., 4125 Washington Road, Augusta,Georgia 30809.

6. DISCLAIMER:

THIS LIMITED WARRANTY IS EXCLUSIVE. CLUB CAR MAKES NO OTHER WARRANTY OF ANY KIND,EXPRESS OR IMPLIED. ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR APARTICULAR PURPOSE WHICH EXCEED THE OBLIGATIONS OR TIME LIMITS STATED IN THISWARRANTY ARE HEREBY DISCLAIMED BY CLUB CAR AND EXCLUDED FROM THIS WARRANTY.THE PURCHASER AND CLUB CAR EXPRESSLY AGREE THAT THE REMEDY OF REPLACEMENT ORREPAIR OF THE DEFECTIVE GOLF CAR OR COMPONENT THEREOF IS THE EXCLUSIVE AND SOLEREMEDY OF THE PURCHASER. CLUB CAR MAKES NO OTHER REPRESENTATION OR WARRANTYOF ANY KIND, AND NO REPRESENTATIVE, EMPLOYEE, DISTRIBUTOR OR DEALER OF CLUB CARHAS THE AUTHORITY TO MAKE OR IMPLY ANY REPRESENTATION, PROMISE OR AGREEMENTWHICH IN ANY WAY VARIES THE TERMS OF THIS WARRANTY.

7. NO CONSEQUENTIAL DAMAGES:

IN NO EVENT SHALL CLUB CAR BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIALDAMAGES INCLUDING, BUT NOT LIMITED TO, LOSS RELATED TO PROPERTY OTHER THAN THEGOLF CAR, LOSS OF USE, LOSS OF TIME, INCONVENIENCE, OR ANY OTHER ECONOMIC LOSS.

Some states allow neither limitation on the duration of an implied warranty nor exclusions or limitation ofincidental or consequential damages. Therefore, the above limitations or exclusions may not apply to you.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.

8. INFORMATION:

For further information contact WARRANTY ADMINISTRATION, CLUB CAR, INC., P.O. Box 204658,Augusta, Georgia 30917-4658, U.S.A., 706-863-3000.

9. WARNING:

Any modification or alteration of any golf car beyond factory specifications, including those that affect the weightdistribution, stability, or speed of the golf car, can cause serious personal injury or death.

2000 DS Golf Car Gasoline Vehicle Owner’s Manual v

FOREWORD

Thank you for choosing Club Car, the golf car most widely recognized as the industry leader in vehicleefficiency and long-lasting value. You have chosen the finest golf car on the market. Please protect yourinvestment and ensure that your Club Car provides years of reliable, superior performance by returning yourWarranty Registration (provided by your distributor/dealer), and by reading and following the maintenanceinstructions in this manual.

Your comfort and safety are important to us as well, so we urge you to read and follow the step-by-step oper-ating instructions and safety procedures in this manual. These instructions must be followed in order to avoidthe risk of severe personal injury. If you rent or loan your vehicle to others, we recommend that you ask themto read this manual before they operate the vehicle.

Club Car products are backed by a customer support system designed to offer you fast, courteous service. Inthe event that your golf car needs repairs or service, we recommend that your local authorized Club Carrepresentative perform them. For the name and address of the Club Car representative nearest you, logon toour web site at www.clubcar.com or call 1-800-ClubCar (258-2227). If you would prefer to write to us, directyour letter to: Club Car, Attention: Marketing Services, P.O. Box 204658, Augusta, Ga. 30917-4658 USA.Your local authorized Club Car representative can also provide technical advice, parts, and service manuals.

We hope you will consider this owner’s manual a permanent part of your golf car. If you sell the vehicle,please include the manual so that the next owner will have the important operating, safety, and maintenanceinformation it contains.

vi 2000 DS Golf Car Gasoline Vehicle Owner’s Manual

TABLE OF CONTENTS

Safety Details . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Vehicle Feature Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Model Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Safety Committee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Pre-Operation Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Driving Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Transporting on a Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Daily Pre-Operation Safety Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Periodic Service Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Periodic Lubrication Schedule . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Vehicle Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Fueling Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Cleaning the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Subsequent Owner Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Fairway Villager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

DS Gasoline Vehicle Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Safety signs like you see above may at first seem shocking, but their impact is mildcompared with the reality of severe personal injury.

Your safety and satisfaction are of the utmost importance to Club Car. That is whybefore operating the vehicle, we urge you to review the information in this manual.Understand and become familiar with the DANGER, WARNING and CAUTION state-ments and procedures it contains, along with the safety decals that are affixed toyour vehicle.

Take time to understand the language of safety. It is a language that can save your life.

! WARNING

Moving Parts

Practice Safety

2000 DS Golf Car Gasoline Vehicle Owner’s Manual 1

Safety Details

SAFETY DETAILS

It is important to note that some vital statements throughout this manual and on the decals affixed to thevehicle are preceded by the words DANGER, WARNING, CAUTION, or NOTE. For your protection, we rec-ommend that you take special notice of these safety procedures. Safety procedures are essential and mustbe followed.

Throughout this manual and on the operation and warning decals affixed to the vehicle, the words “golf car”and “vehicle” are used interchangeably. “Golf car” is defined in the Notice of this manual and no other repre-sentation is stated or implied.

If any of the operation or warning decals on the vehicle become damaged, have been removed or cannot beeasily read, they should be replaced immediately to avoid possible personal injury, property damage, ordeath. Contact your Club Car distributor/dealer.

• THIS OWNER’S MANUAL SHOULD BE READ COMPLETELY BEFORE ATTEMPTING TO DRIVEOR SERVICE THE VEHICLE. FAILURE TO FOLLOW THE INSTRUCTIONS IN THIS MANUALCOULD RESULT IN PROPERTY DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.

• A DANGER INDICATES AN IMMEDIATE HAZARD WHICH WILL RESULT IN SEVEREPERSONAL INJURY OR DEATH.

• A WARNING INDICATES AN IMMEDIATE HAZARD WHICH COULD RESULT IN SEVEREPERSONAL INJURY OR DEATH.

• A CAUTION INDICATES HAZARDS OR UNSAFE PRACTICES WHICH COULD RESULT IN MINORPERSONAL INJURY OR PRODUCT OR PROPERTY DAMAGE.

• A NOTE PROVIDES KEY INFORMATION TO MAKE PROCEDURES MORE EASILY UNDERSTOOD.

Figure 1 Battery Cable Removal

WARNING

DANGER

WARNING

CAUTION

NOTE

FRONTOF VEHICLE

AS SEEN FROMPASSENGER SIDE

OF VEHICLE

REMOVE NEGATIVECABLE FIRSTDISCONNECT BATTERY CABLES

BEFORE WORKING ON VEHICLE

2 2000 DS Golf Car Gasoline Vehicle Owner’s Manual

General Warnings

GENERAL WARNINGS

The safety statements listed must be followed whenever the vehicle is being operated, repaired, or serviced.Vehicle feature identification information is also included on page 4. Other specific WARNING statementsappear throughout this manual and on the vehicle.

• BATTERY VAPORS - FLAMMABLE! EXPLOSIVE! DO NOT SMOKE. KEEP SPARKS AND FLAMESAWAY FROM THE AREA OF THE VEHICLE. SERVICE ONLY IN WELL-VENTILATED AREAS.

• GASOLINE VAPORS - FLAMMABLE! EXPLOSIVE! DO NOT SMOKE. KEEP SPARKS AND FLAMESAWAY FROM THE AREA OF THE VEHICLE. SERVICE ONLY IN WELL-VENTILATED AREAS.

• DO NOT OPERATE GASOLINE VEHICLE IN ENCLOSED AREA WITHOUT PROPER VENTILATION.ENGINE PRODUCES CARBON MONOXIDE WHICH IS AN ODORLESS, DEADLY POISON.

• A GOLF CAR WILL NOT PROVIDE PROTECTION FROM LIGHTNING, FLYING OBJECTS, OROTHER STORM RELATED HAZARDS. IF CAUGHT IN A STORM WHILE DRIVING A GOLF CAR,EXIT THE VEHICLE AND SEEK SHELTER IN ACCORDANCE WITH APPLICABLE SAFETYGUIDELINES FOR YOUR LOCATION.

• NEVER LEAVE CHILDREN UNATTENDED IN THE VEHICLE.

• WHEN STOPPING AND LEAVING THE VEHICLE, ALWAYS:

- TURN THE KEY SWITCH TO OFF AND REMOVE THE KEY.

- PLACE THE FORWARD/REVERSE HANDLE IN NEUTRAL.

- ENGAGE THE PARK BRAKE.

• THE ENGINE EXHAUST FROM THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATEOF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.

• ONLY TRAINED TECHNICIANS SHOULD REPAIR OR SERVICE THE VEHICLE. ANYONE DOINGEVEN SIMPLE REPAIRS OR SERVICE SHOULD FOLLOW THE PROCEDURES EXACTLY ASSTATED IN THIS MANUAL, AND FOLLOW ALL DANGER, WARNING, AND CAUTIONPROCEDURES LISTED IN THIS MANUAL AS WELL AS THOSE AFFIXED TO THE VEHICLE.

• WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION WHEN SERVICING THEVEHICLE. WEAR A FULL FACE SHIELD WHEN WORKING WITH BATTERIES.

• USE INSULATED TOOLS WHEN WORKING AROUND BATTERIES OR ELECTRICAL CONNECTIONS.

• IMPROPER USE OF THE VEHICLE OR FAILURE TO PROPERLY MAINTAIN IT COULD RESULTIN DECREASED VEHICLE PERFORMANCE OR SEVERE PERSONAL INJURY.

• ANY MODIFICATION OR CHANGE TO THE VEHICLE WHICH AFFECTS THE STABILITY ORHANDLING OF THE VEHICLE, OR INCREASES MAXIMUM VEHICLE SPEED BEYOND FACTORYSPECIFICATIONS, COULD RESULT IN SEVERE PERSONAL INJURY OR DEATH.

• FRAME GROUND - DO NOT ALLOW TOOLS OR OTHER METAL OBJECTS TO CONTACT FRAMEWHEN DISCONNECTING BATTERY OR OTHER ELECTRICAL WIRING. NEVER ALLOW APOSITIVE WIRE TO TOUCH THE VEHICLE FRAME, ENGINE OR OTHER METAL COMPONENT.

• PRIOR TO SERVICING THE VEHICLE:

- TURN THE KEY SWITCH TO OFF AND REMOVE THE KEY.

- PLACE THE FORWARD/REVERSE HANDLE IN NEUTRAL AND CHOCK THE WHEELS.

- DISCONNECT BATTERY, NEGATIVE CABLE FIRST, (FIGURE 1, PAGE 2).

- DISCONNECT THE SPARK PLUG WIRE FROM THE SPARK PLUG.

DANGER

WARNING


Vehicle Feature Identification

DS GASOLINE VEHICLE

FNR

DRIVER/PASSENGERWARNING DECAL

GASOLINE WARNING DECAL(ON VEHICLE FRAME NEAR FUEL TANK)

FRAME GROUND ANDGOVERNOR WARNING DECAL

(ON VEHICLE FRAME NEAR BATTERY)

OILWARNING

LIGHT

SERIAL NUMBER

BRAKE PEDAL

PARK BRAKE PEDAL

OPERATING INSTRUCTIONSDECAL

CHOKE

FORWARD/REVERSEHANDLE

OIL FILL

NEUTRALLOCK-OUT

CAM

FUEL SHUT-OFFVALVE

ACCELERATOR PEDAL

OFF ON

KEY SWITCH

• GASOLINE EXPLOSION / FIRE.• CAN CAUSE SEVERE INJURY OR DEATH.• NO SMOKING, SPARKS, OR OPEN FLAME.• STOP ENGINE, ALLOW TO COOL BEFORE REFUELING.• TURN FUEL VALVE ( ) ON DURING OPERATION.

( ) OFF DURING STORAGE OR TRANSPORT. CCI 1015476-01

WARNING

ROTATING PARTS ANDHOT MANIFOLD DECAL

(ON STARTER/GENERATOR AND ENGINE)


General Information

GENERAL INFORMATION

We urge the owner/operator to read and understand this manual, and to pay special attention to the featuresspecific to his/her vehicle(s).

MODEL IDENTIFICATION

The serial number of your Club Car is printed on a bar code decal mounted on the frame directly above theaccelerator pedal (Example: AG0001-123456) (Figure 2, Page 5) . There is also a second serial numberdecal mounted on the front body frame behind the center dash panel. The center dash panel must beremoved to access it. See following NOTE.

SAFETY COMMITTEE

If the golf car is to be rented or is part of a fleet, we strongly recommend that a safety committee beappointed. One of the main concerns of this committee should be the safe operation of the golf cars.

This should include at a minimum:

• Where golf cars should be driven.

• Ensuring that proper warnings of driving hazards are displayed and visible.

• Who should and who should not drive golf cars.

• Instructing first time drivers.

• Maintaining golf cars in a safe driving condition.

• How various rules are to be enforced.

The safety committee should include all these items and such others as the committee feels necessary orappropriate.

• ALWAYS HAVE THE VEHICLE SERIAL NUMBER AT HAND WHEN ORDERING PARTS ORMAKING INQUIRIES. IF THE VEHICLE IS EQUIPPED AS A FAIRWAY VILLAGER FOURPASSENGER VEHICLE, READ THE SPECIAL INSTRUCTIONS BEGINNING ON PAGE 22.

Figure 2 Serial Number Location

NOTE

This vehicle is covered by one or more of thefollowing U.S. Patents as applicable: D271008D292899, 4343503, 4539162, 4637270, 48218274826467, 5042519, 5083736 and otherpatents pendings.

ClubGOGO

SERIAL NUMBER

AG0001-123456P O BOX 204658AUGUSTA GA 30917

Club CarR

SERIAL NUMBERDECAL


Pre-Operation Checklist

PRE-OPERATION CHECKLIST

Your Club Car has been thoroughly inspected and adjusted at the factory, and also by your Club Car distribu-tor/dealer. However, upon arrival of your new Club Car(s), you should become familiar with its controls andoperation, and carefully inspect each vehicle to be satisfied that it is in proper working condition beforeaccepting delivery.

Use the following checklist as a guide to inspect your new vehicle. This checklist may also be used in con-junction with the Periodic Service Schedule on page 16. Any problems should be corrected only by your ClubCar distributor/dealer or a trained technician.

• General: All the parts should be in place and properly installed. Be sure that all nuts, bolts, and screwsare tight. Check all hose clamps for tight fit as well as the starter belt for tightness.

• Warning Decals: Check to ensure that all warning and operation decals are in place. See Page 4.

• Tires: Check for proper tire pressure. See Vehicle Capacities, Page 18 .

• Engine: Check for proper engine oil level. See Engine Oil, Page 18 .

• Fuel: Check fuel level. See Fueling Instructions, Page 19 .

PERFORMANCE INSPECTIONAfter you have familiarized yourself with the vehicle’s controls and have read and understood the drivinginstructions, take the vehicle for a test drive. Use the following checklist as a guide to inspect your new vehi-cle. Any problems should be corrected only by your Club Car distributor/dealer or a trained technician.

All vehicles• Brakes: Be sure the brakes function properly. When brake pedal is fully depressed under moderate

pressure, it should not go more than halfway to the floor, and vehicle should come to a smooth, straightstop within 14 feet. If the pedal goes more than halfway to the floor, or if the vehicle swerves or fails tostop within 14 feet, have the brake system checked and adjusted as required. Brake adjustment mustbe maintained so that the brake pedal cannot be depressed to the floor under any circumstance.

• Park Brake: When latched, the park brake should lock the wheels and hold the vehicle stationary (onincline of 20% or less). It should release when either the accelerator or brake pedal is depressed.

• Reverse Buzzer: The reverse buzzer should sound as a warning when the vehicle is in reverse.

• Steering: The vehicle should be easy to steer and should not have any play in the steering wheel.

• Accelerator: With the key switch ON and the forward/reverse handle in the FORWARD position; as theaccelerator pedal is depressed, the engine should start and the vehicle should come up smoothly to fullspeed. When the pedal is released it should return to the original position and the engine should stop.All DS vehicles operate at reduced speed in reverse.

• Governor: Check maximum speed of the vehicle. The vehicle should operate at 12-15 MPH (19-24KPH) on a level surface.

• General: Listen for any unusual noises such as squeaks or rattles. Check the vehicle’s ride and perfor-mance. Have a Club Car distributor/dealer or a trained technician investigate anything unusual.

• BE SURE THE PLASTIC HAS BEEN REMOVED FROM THE SEAT BOTTOM BEFOREOPERATING THE VEHICLE. FAILURE TO DO SO MAY RESULT IN A FIRE, PROPERTYDAMAGE, PERSONAL INJURY, OR DEATH.

WARNING


Controls

CONTROLS

Read DANGER and WARNING on page 3.

KEY SWITCH The key switch is mounted on the dash to the right of the steering column (Figure 3, Page 7) . It has two posi-tions, OFF and ON, which are clearly labeled. See following NOTE.

FORWARD/REVERSE CONTROLThe Forward/Reverse handle is located on the seat support panel, below and to the right of the driver’s rightknee (Figure 4, Page 7) . The handle has three distinct positions: F (FORWARD), N (NEUTRAL), and R(REVERSE). Rotate the handle towards the driver, F (FORWARD), to operate the vehicle in the forwarddirection, or towards the passenger, R (REVERSE), to operate the vehicle in reverse. When the handle is inthe straight up, or N (NEUTRAL) position, the vehicle will not operate. The engine will stop if it is shifted tothis position during operation. DS vehicles operate at reduced speed in reverse. When the vehicle is inreverse, the reverse warning buzzer will sound.

• IF RENTING OR LOANING THE VEHICLE, MAKE SURE THE DRIVER IS FAMILIAR WITH ALLCONTROLS AND OPERATING PROCEDURES BEFORE ALLOWING THE VEHICLE TO BE DRIVEN.

• DO NOT TAMPER WITH THE GOVERNOR. DOING SO WILL VOID THE WARRANTY, AS WELLAS DAMAGE THE ENGINE AND OTHER COMPONENTS, AND COULD RESULT IN PROPERTYDAMAGE, PERSONAL INJURY, OR DEATH DUE TO ACCIDENT AT UNSAFE SPEED.

• DO NOT SHIFT THE FORWARD/REVERSE HANDLE WHILE THE VEHICLE IS MOVING. TOAVOID INJURY TO AN UNSUSPECTING PASSENGER OR DAMAGE TO THE VEHICLE, ALWAYSBRING THE VEHICLE TO A FULL STOP BEFORE SHIFTING THE F&R HANDLE.

• RELEASE THE ACCELERATOR PEDAL AND THEN DEPRESS THE BRAKE PEDAL FIRMLYUNTIL THE VEHICLE STOPS. TO AVOID UNINTENTIONALLY STARTING OR ROLLING THEVEHICLE, SET THE PARK BRAKE, TURN THE KEY SWITCH TO OFF, AND REMOVE THE KEYWHEN LEAVING THE VEHICLE.

• THE KEY CAN BE REMOVED WHEN THE KEY SWITCH IS IN THE OFF POSITION ONLY.

Figure 3 Key Switch Figure 4 Forward/Reverse Handle

WARNING

NOTE

OFF ON


Controls

ACCELERATOR PEDALThe accelerator pedal is the pedal on the right, with the word GO molded into it (Figure 5, Page 8) . The oper-ation of the accelerator pedal differs from that of an automobile. When the key switch is ON, and the Forward/Reverse handle is in either FORWARD or REVERSE, depressing the accelerator pedal will automaticallyrelease the park brake and start the vehicle moving in the direction selected (FORWARD or REVERSE). Asthe accelerator pedal is depressed, speed will increase until full speed is reached. When the accelerator isreleased, power will be cut off and the engine will stop running.

BRAKE PEDALThe brake pedal is the large pedal on the left with the word STOP molded into it (Figure 5, Page 8) . To slowor stop the vehicle, depress the brake pedal with your foot (Figure 6, Page 8) .

PARK BRAKE PEDALThe park brake pedal is the small raised portion in the upper left corner of the brake pedal. It has the wordPARK molded into it and the words PARK BRAKE marked on top of it (Figure 7, Page 8) . To set the parkbrake, depress the brake pedal firmly and tilt the park brake portion of the pedal forward with your foot(Figure 7, Page 8) . See following WARNING.

Figure 5 Accelerator and Brake Pedal Figure 6 Brake Pedal

Figure 7 Park Brake Pedal

• THE PARK BRAKE WILL RELEASE AUTOMATICALLY WHEN EITHER THE ACCELERATOR ORBRAKE PEDAL IS DEPRESSED. THE PARK BRAKE HAS MULTIPLE LOCKING POSITIONS ANDSHOULD BE FIRMLY PRESSED AND LOCKED TO PREVENT THE VEHICLE FROM ROLLING.

WARNING


Controls

NEUTRAL LOCK-OUTFor the convenience of the trained technician, there is a neutral lock-out cam located on the back of the For-ward/Reverse handle. If the neutral lock-out cam is pulled out approximately 3/8 inch (10 mm) and thenrotated one-half turn until it snaps into place, the cam will be in the SERVICE position (Figure 8, Page 9) .This will allow the technician to operate the engine in NEUTRAL for certain maintenance procedures. Withthe cam in this position, the vehicle will not operate if the Forward/Reverse handle is placed in either theFORWARD or REVERSE position.

To put the cam back into the OPERATE position, pull the cam out approximately 3/8 inch (10 mm) and rotateit one-half turn until it snaps into place (Figure 9, Page 9). See following WARNING and NOTE.

CHOKEThe choke is located on the seat support panel below and to the left of the driver’s left knee (Figure 10, Page 10) .If the vehicle is hard to start in cool or cold temperatures, simply push in the choke cover with your left hand to acti-vate it. Hold it during start up and release the choke cover after the engine starts and operates smoothly.

OIL LIGHTThe DS Gasoline golf car is equipped with a low oil warning light, located on the dash panel just above thesteering column (Figure 11, Page 10) . If the oil warning light comes on, oil should be checked and added tothe engine as necessary before continuing to use the vehicle. The vehicle should never be driven with the oilwarning light remaining on. If the oil warning light goes on and off, you may proceed, but oil should be addedat the first opportunity. If the oil level is correct and the light stays on, have a trained technician check thevehicle. See following CAUTION.

• WITH THE CAM IN THE SERVICE POSITION AND THE ENGINE RUNNING, THE VEHICLE MAYMOVE SUDDENLY IF THE FORWARD/REVERSE HANDLE IS SHIFTED OR ACCIDENTALLYBUMPED. TO PREVENT THIS, CHOCK THE FRONT AND REAR WHEELS AND ALWAYS FIRMLYSET THE PARK BRAKE BEFORE SERVICING OR LEAVING THE VEHICLE.

• BE SURE TO RETURN THE CAM TO THE OPERATE POSITION AFTER SERVICING THEVEHICLE, OR IT WILL NOT OPERATE WITH THE FORWARD/REVERSE HANDLE IN EITHERTHE FORWARD OR REVERSE POSITION.

Figure 8 Neutral Lock-out – Service Figure 9 Neutral Lock-out – Operate

WARNING

NOTE

NEUTRAL FORWARD

SERVICE POSITION

NEUTRAL FORWARD

OPERATE POSITION


Driving Instructions

DRIVING INSTRUCTIONS

• FAILURE TO ADD OIL IMMEDIATELY WHEN THE OIL WARNING LIGHT STAYS ON MAYRESULT IN PERMANENT ENGINE DAMAGE.

Figure 10 Choke Figure 11 Oil Light

• ONLY LICENSED DRIVERS SHOULD BE ALLOWED TO DRIVE THIS VEHICLE.• IF RENTING OR LOANING THE VEHICLE, MAKE SURE THE DRIVER IS FAMILIAR WITH ALL

CONTROLS AND OPERATING PROCEDURES BEFORE ALLOWING THE VEHICLE TO BE DRIVEN.• NO MORE THAN TWO PEOPLE SHOULD BE ON THE VEHICLE AT ONE TIME.• THE VEHICLE IS NOT SPECIALLY EQUIPPED FOR HANDICAPPED PERSONS:

- BE SURE ALL PERSONS CAN PROPERLY OPERATE THE VEHICLE PRIOR TO ALLOWINGTHEM TO DRIVE THE VEHICLE.

- BE SURE ALL PASSENGERS ARE CAPABLE OF SECURING THEMSELVES IN A MOVINGVEHICLE BEFORE ALLOWING THEM TO RIDE IN ONE.

• FOR NIGHT USE, THE VEHICLE MUST BE EQUIPPED WITH HEADLIGHTS, TAILLIGHTS, AND REFLECTORS.• STOP THE VEHICLE BEFORE SHIFTING THE FORWARD/REVERSE HANDLE. FAILURE TO DO SO

MAY RESULT IN INJURY TO AN UNSUSPECTING PASSENGER AND (OR) DAMAGE TO THE VEHICLE. • DO NOT LEAVE CHILDREN UNATTENDED IN THE VEHICLE.

• TO AVOID BEING STRUCK, DO NOT STAND IN FRONT OF OR BEHIND THE VEHICLE.

WHEN DRIVING THE VEHICLE:• OPERATE THE VEHICLE FROM THE DRIVER SEAT ONLY.• TO PREVENT FALLS FROM THE VEHICLE, REMAIN SEATED IN A MOVING VEHICLE AND HOLD

ON TO SEAT HANDLES OR HANDRAILS AT ALL TIMES. DRIVER SHOULD KEEP BOTH HANDSON THE STEERING WHEEL WHEN THE VEHICLE IS IN MOTION.

• TO PREVENT THE POSSIBILITY OF SERIOUS INJURY, KEEP YOUR ENTIRE BODY INSIDE THE VEHICLE.• TO PREVENT OVERTURNING THE VEHICLE, DRIVE SLOWLY IN TURNS.• TO PREVENT OVERTURNING THE VEHICLE, DRIVE SLOWLY STRAIGHT UP AND DOWN

SLOPES. DO NOT DRIVE THE VEHICLE ON SLOPES EXCEEDING 20% INCLINE.

• TO AVOID POSSIBLE INJURY TO AN INATTENTIVE PASSENGER AND (OR) DAMAGE TO THEVEHICLE, AVOID SUDDEN STARTS, SUDDEN STOPS, AND ABRUPT TURNS.

• TO AVOID THE POSSIBILITY OF LOSING CONTROL OF OR OVERTURNING THE VEHICLE, REDUCESPEED FOR ADVERSE DRIVING CONDITIONS SUCH AS WET GRASS OR ROUGH TERRAIN.

WARNINGS CONTINUED ON FOLLOWING PAGE...

CAUTION

CHOKEPRACTICE GOLF ETIQUE

Club C

OIL LIGHT

WARNING


Driving Instructions

No one should drive the vehicle without first being instructed in the proper operation and use of the vehicle’scontrols. An experienced operator should accompany each first-time driver on a test drive before allowinghim/her to operate the vehicle alone. Only licensed drivers should be allowed to drive this vehicle.

To ensure safe operation of the vehicle, follow exactly and in order, all of the following procedures. Read andunderstand all instructions prior to driving the vehicle.

STARTING THE VEHICLE

1. Study and understand controls.2. Make sure everyone is seated and holding onto seat handles or handrails.3. Read safety warnings located on dash and (or) above pedals.4. Make sure wheels are turned in desired direction.5. Turn key to the ON position and make sure nothing is in your path.6. Select direction by placing Forward/Reverse handle in desired position (F = forward or R = reverse). A

buzzer will sound as a warning when the vehicle is in REVERSE.7. Slowly depress accelerator pedal. The park brake will release automatically and the vehicle will start to

move. As the accelerator pedal is depressed, speed will increase until full speed is reached. See fol-lowing WARNING.

STOPPING THE VEHICLE

To stop the vehicle, release the accelerator pedal and depress the brake pedal with your right foot until thevehicle comes to a complete stop.

• DO NOT USE THE VEHICLE ON PUBLIC ROADS. IT IS NOT DESIGNED OR INTENDED FOR STREETUSE AND SHOULD NOT BE LICENSED FOR USE ON PUBLIC ROADS.

• OBEY ALL LOCAL RULES CONCERNING GOLF CARS.

• THE VEHICLE SHOULD BE DRIVEN IN ONLY SPECIFIED AREAS BY TRAINED DRIVERS.

• DO NOT DRIVE WHILE UNDER THE INFLUENCE OF ALCOHOL, DRUGS, OR MEDICATIONS.

• IF THE FORWARD/REVERSE HANDLE IS SHIFTED INTO NEUTRAL , POWER WILL BE CUT OFFAND THE ENGINE WILL STOP RUNNING.

• VEHICLE OPERATOR MUST CONTROL SPEED WHEN GOING DOWNHILL.• NEVER SHIFT THE VEHICLE OUT OF FORWARD WHILE GOING DOWNHILL. IF YOU DO, YOU

WILL NOT BE ABLE TO SHIFT INTO REVERSE OR BACK INTO FORWARD UNTIL STOPPED.• DEPRESS THE BRAKE PEDAL AS NECESSARY AND PARTIALLY DEPRESS THE

ACCELERATOR WHEN DESCENDING A HILL. WITH THE ACCELERATOR PEDAL PARTIALLYDEPRESSED, THE GOVERNOR WILL CAUSE THE ENGINE TO ASSIST THE BRAKES INCONTROLLING DOWNHILL SPEED.

• DRIVING THROUGH WATER MAY AFFECT THE BRAKES. AFTER DRIVING THROUGH WATER,CHECK EFFECTIVENESS OF THE BRAKES BY GENTLY DEPRESSING THE BRAKE PEDAL. IFTHE VEHICLE DOES NOT SLOW DOWN AT THE NORMAL RATE, CONTINUE TO DEPRESS THEBRAKE PEDAL UNTIL THE BRAKES DRY OUT AND NORMAL PERFORMANCE RETURNS.

WARNING

NOTE

WARNING

WARNING


Towing

PARKING AND LEAVING THE VEHICLE1. After stopping the vehicle, firmly depress the park brake pedal until it locks. This will prevent the vehicle

from rolling.

2. Turn key switch to OFF and place the Forward/Reverse handle in the NEUTRAL position. Remove the keyand turn fuel shut-off valve to closed (OFF) position when the vehicle is not in use (Figure 12, Page 12) .

TOWING

All vehicles are equipped with both front and rear tow bar attaching points. A light duty tow bar is available forbreak-down towing and single vehicle towing. A heavy duty tow bar and an on-board tow bar are available formulti-vehicle towing. See following WARNING.

• WHEN STOPPED ON A HILL, USE THE BRAKE PEDAL TO HOLD YOUR POSITION. DO NOTUSE THE ACCELERATOR PEDAL.

• NEVER TOW THE VEHICLE ON PUBLIC STREETS OR HIGHWAYS.

• USE ONLY APPROVED CLUB CAR TOW BARS.

• TURN THE KEY SWITCH TO OFF AND PLACE THE FORWARD/REVERSE HANDLE IN NEUTRALBEFORE TOWING THE VEHICLE.

• EXTREME CAUTION SHOULD BE USED WHEN TOWING ANY VEHICLE.

• DO NOT TOW MORE THAN ONE CLUB CAR VEHICLE WITH ANOTHER CLUB CAR VEHICLE. IFMORE THAN ONE VEHICLE MUST BE TOWED, AN ADEQUATELY POWERED VEHICLE(TRACTOR OR FULL SIZED TRUCK) PROPERLY FITTED, WITH A TOW HITCH HEIGHT OF 11INCHES SHOULD BE USED. ONLY HEAVY-DUTY TOW BARS SHOULD BE USED FOR MULTI-VEHICLE TOWING. NEVER TOW MORE THAN FIVE VEHICLES AT ONE TIME.

• TURN FUEL SHUT-OFF VALVE TO CLOSED (OFF) POSITION (FIGURE 12, PAGE 12).

• DO NOT EXCEED 5 MPH (8 KPH) TOWING SPEED.

• DO NOT ALLOW PEOPLE IN THE VEHICLES BEING TOWED.

• AVOID SUDDEN STARTS, SUDDEN STOPS, AND TIGHT TURNS WHEN TOWING.

Figure 12 Closed Fuel Shut-off Valve Figure 13 Open Fuel Shut-off Valve

CAUTION

WARNING

CLOSED (OFF) POSITION(SELECTOR IS ALIGNED

WITH OFF MARKINGS ON THE SIDES OF VALVE)

OFFOFF

VIEWED FROM SELECTOR SIDE OF VALVE


FULL OPEN (ON)POSITION


Transporting on a Trailer

TRANSPORTING ON A TRAILER

If your vehicle must be transported over long distance or on public highways, it should be done on an approvedtrailer, and the following WARNING statement should be heeded:

STORAGE


Figure 14 Partially Closed Fuel Shut-off Valve

• FOR USE ON PUBLIC ROADS, THE TRAILER MUST MEET ALL FEDERAL, STATE, AND LOCALREQUIREMENTS SUCH AS TAILLIGHTS, BRAKE LIGHTS, ETC.

• NEVER TOW A CLUB CAR VEHICLE BEHIND A PASSENGER VEHICLE OR TRUCK ON APUBLIC ROAD UNLESS IT IS ON AN APPROVED TRAILER

• ALWAYS USE AN APPROVED TRAILER THAT HAS A LOAD RATING OF 1200 LB (544 KG) PERVEHICLE TO BE TOWED (EXAMPLE: A TWO-CAR TRAILER SHOULD BE RATED AT 2 X 1200 =2400 LBS (2 X 544 = 1088 KG)).

• THE VEHICLE TO BE TOWED SHOULD BE TIED SECURELY TO THE TRAILER, WITH THEFORWARD/REVERSE HANDLE IN NEUTRAL , THE KEY SWITCH OFF, AND THE PARK BRAKEFIRMLY DEPRESSED AND LOCKED.

• WHEN TOWING ON A TRAILER, NORMAL ROAD SPEED OF THE TOW VEHICLE MUST BE REDUCED.• BECAUSE OF THE ADDED LENGTH OF THE TRAILER, CAUTION SHOULD BE USED WHEN

TURNING A CORNER.• REMOVE THE VEHICLE WINDSHIELD BEFORE TRANSPORTING ON A TRAILER.• TURN FUEL SHUT-OFF VALVE TO CLOSED (OFF) POSITION (FIGURE 12, PAGE 12).

• NEVER ATTEMPT TO DRAIN GASOLINE WHEN THE ENGINE IS HOT OR WHILE IT IS RUNNING.BE SURE TO CLEAN UP ANY SPILLED GASOLINE BEFORE OPERATING THE VEHICLE.

• STORE GASOLINE IN AN APPROVED GASOLINE CONTAINER ONLY. STORE IN A WELL-VENTILATED AREA AWAY FROM SPARKS, OPEN FLAMES, HEATERS, OR HEAT SOURCES.

• KEEP GASOLINE OUT OF THE REACH OF CHILDREN.• DO NOT SIPHON GASOLINE FROM THE VEHICLE.


PARTIALLY CLOSEDPOSITION

WARNING

DANGER


Storage

To prepare your vehicle for extended off season storage:

1. Store vehicle in a cool place. This will help prevent battery self-discharge. If the battery appears to beweak, have it charged using an automotive-type 12-volt battery charger rated 10 amps or less.

2. Drain carburetor.

2.1. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lock-out cam in theSERVICE position. Turn the fuel shut-off valve to the OFF position and operate the engine untilfuel remaining in the carburetor and fuel lines is used up and the engine stalls. Return the neutrallock-out cam to OPERATE position.

2.2. Loosen (do not remove) the carburetor drain screw and drain fuel remaining in bowl into a small con-tainer, then pour the fuel from the container into vehicle fuel tank. Tighten the carburetor drain screw.

2.3. Disconnect fuel vent line from fuel tank vent nipple.

2.4. Plug the fuel tank vent nipple so that it is air tight. We recommend using a slip-on vinyl cap.

3. To protect the engine, remove the spark plug and pour 1/2 ounce of SAE 10 weight oil into engine through thespark plug hole. Rotate engine crankshaft several times and then re-install spark plug. See following WARNING.

4. Increase tire pressure to 20 psi (138 kPa).

5. Grease front suspension and do all other semi-annual periodic lubrication. See Periodic LubricationSchedule, Page 17.

6. Thoroughly clean front body, rear body, seats, engine compartment, and underside of vehicle.

7. Do not latch the park brake. Chock wheels to prevent the vehicle from rolling.

TO RETURN THE STORED VEHICLE TO SERVICE1. Restore fuel system to operation.

1.1. Remove plug from the fuel tank vent nipple and connect the vent line to the nipple. Open fuel shut-off valve.Make sure the valve is fully open (Figure 13, Page 12) . A partially closed fuel valve (Figure 14,Page 13) combined with the use of the choke, can result in a fouled spark plug and engine failure.

1.2. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lock-out cam in theSERVICE position. Crank the engine until fuel is pumped into the carburetor and fuel lines andthe engine starts. Turn engine off and return neutral lock-out cam to the OPERATE position.

2. Readjust tire pressure to 12-14 psi (83/97 kPa).

3. Perform the Pre-Operation Checklist. See page 6 .

• DO NOT ATTEMPT TO CHARGE A BATTERY IF IT IS FROZEN OR IF THE CASE IS BULGED.DISCARD THE BATTERY. FROZEN BATTERIES CAN EXPLODE.

• BATTERIES IN A LOW STATE OF CHARGE WILL FREEZE AT LOW TEMPERATURES.

• TURN THE KEY SWITCH OFF, REMOVE THE KEY, AND LEAVE THE FORWARD/REVERSEHANDLE IN THE NEUTRAL POSITION DURING STORAGE. THIS IS TO PREVENTUNINTENTIONALLY STARTING THE VEHICLE OR FIRE HAZARD.

• DUE TO THE OIL ADDED TO THE ENGINE IN PREPARATION FOR STORAGE, THE ENGINE MAY SMOKEEXCESSIVELY FOR A SHORT WHILE WHEN RUNNING IT FOR THE FIRST TIME AFTER STORAGE.

WARNING

CAUTION

WARNING

NOTE


Maintenance

MAINTENANCE


GENERAL INFORMATIONTo ensure trouble-free vehicle performance, it is very important to follow an established preventive mainte-nance program (regularly scheduled service, even though the vehicle is functional). Regular and consistentvehicle maintenance can prevent vehicle down-time and expensive repairs that result from neglect. Any vehi-cle not functioning correctly should be removed from use until it is properly repaired. This will prevent furtherdamage to the vehicle and avoid the possibility of injury due to unsafe conditions.Contact your local Club Car distributor/dealer to perform all repairs and semi-annual and annual periodic service.See following WARNING.

DAILY PRE-OPERATION SAFETY CHECKLIST

Inspect and drive the vehicle, using the Pre-operation Checklist (page 6) and Performance Inspection (page 6)

as guides to check the following items.

• Vehicle warning decals

• Brake system

• Park brake

• Reverse warning buzzer

• Steering and linkages

• Proper acceleration and maximum speed

In addition, check the items listed below:

• Tires: Visually inspect for wear, damage and proper inflation.

• Exhaust system: Check for leaks.

• Forward/Reverse shifter: Check for proper operation. See Controls, Page 7 .

• Fuel system: Check fuel tank, lines, cap, pump, fuel filters and carburetor for fuel leakage.

• IF PROBLEMS ARE FOUND DURING SCHEDULED INSPECTION OR SERVICE, DO NOTOPERATE THE VEHICLE UNTIL REPAIRS ARE MADE. FAILURE TO MAKE NECESSARYREPAIRS COULD RESULT IN FIRE, PROPERTY DAMAGE, SEVERE PERSONAL INJURY, ORDEATH.

• MOVING PARTS - DO NOT ATTEMPT TO SERVICE GASOLINE VEHICLE WHILE THE ENGINE IS RUNNING.

• HOT! DO NOT ATTEMPT TO SERVICE HOT ENGINE, MOTOR, RESISTORS, OR EXHAUSTSYSTEM. ATTEMPTING TO DO SO COULD CAUSE SEVERE BURNS.

• TURN FUEL SHUT-OFF VALVE TO CLOSED (OFF) POSITION (FIGURE 12, PAGE 12).• TO AVOID UNINTENTIONALLY STARTING THE VEHICLE, BEFORE SERVICING ALWAYS

DISCONNECT THE BATTERY, NEGATIVE LEAD FIRST (FIGURE 1, PAGE 2) AND DISCONNECTTHE SPARK PLUG WIRE FROM THE SPARK PLUG.

• FRAME GROUND - DO NOT ALLOW TOOLS OR OTHER METAL OBJECTS TO CONTACT FRAMEWHEN DISCONNECTING BATTERIES OR OTHER ELECTRICAL WIRING. NEVER ALLOW APOSITIVE WIRE TO TOUCH THE VEHICLE FRAME, ENGINE, OR OTHER METAL COMPONENT.

WARNING


Periodic Service Schedule

PERIODIC SERVICE SCHEDULE


• SERVICE, REPAIRS, AND ADJUSTMENTS MUST BE MADE PER INSTRUCTIONS IN THE 2000DS GOLF CAR MAINTENANCE & SERVICE MANUAL.

• IF THE VEHICLE IS CONSTANTLY SUBJECTED TO HEAVY USE OR SEVERE OPERATINGCONDITIONS, THE PREVENTIVE MAINTENANCE PROCEDURES SHOULD BE PERFORMEDMORE OFTEN THAN RECOMMENDED IN THE SERVICE AND LUBRICATION SCHEDULES.

• BOTH THE PERIODIC SERVICE SCHEDULE AND PERIODIC LUBRICATION SCHEDULE MUSTBE FOLLOWED TO KEEP VEHICLE IN OPTIMUM OPERATING CONDITION.

PERIODIC SERVICE SCHEDULE

Monthly Service by Owneror Trained technician

Engine

Check engine oil level; change as required. See lubrication schedule, page 17. Dispose of used oil properly.Check engine cooling air intake; clean as necessary. Visually inspect the unshrouded area around engine exhaust for grass and debris and clean as necessary.

Tires Check air pressure and adjust as necessary. See Capacities Chart on page 18.

General VehicleWash engine compartment and underside of vehicle. Do not wash engine when hot. Dispose of waste water properly.

Semi-annual Service by Trained technician Only(Every 50 hours of operation or every 100 rounds for golf cars)

BatteryClean terminals and wash dirt from casing; Check electrolyte level. See page 19.

Front Wheel Alignment and CamberCheck and adjust as required. See Maintenance & Service Manual, Section 7.

Electrical wiring and connections Check for tightness and damage.

Brake System

Check brake shoes; replace if necessary.

Lubricate brake slides per Lubrication Schedule.

Check brake cables for damage; replace as required.

Annual Service byTrained technician Only(Every 100 hours of operation or every 200 rounds for golf cars)

Engine

Check for leaks around gaskets, fill plugs, etc.

Inspect, clean and regap spark plug; replace if necessary.

Engine Air Intake System

Check air filter element; clean or replace if necessary.Dispose of used filter element properly.

Check clamps for tightness; check hose for cracks.

General Vehicle Check for loose hardware and tighten as required.

Two year Service by Trained technician Only(Every 200 hours of operation or every 400 rounds for golf cars)

Fuel Filters Replace. Dispose of used filters properly.

WARNING

NOTE


Periodic Lubrication Schedule

PERIODIC LUBRICATION SCHEDULE

*See (Figure 15, Page 17).

• IF PROBLEMS ARE FOUND DURING SCHEDULED INSPECTION OR SERVICE, DO NOT OPERATETHE VEHICLE UNTIL REPAIRS ARE MADE. FAILURE TO MAKE NECESSARY REPAIRS COULDRESULT IN FIRE, PROPERTY DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.

PERIODIC LUBRICATION SCHEDULE

REGULAR INTERVAL SERVICE PLACE* RECOMMENDED LUBRICANT

Semi-annually by Owneror Trained Technician (Every 50 hours of operation or every 100 rounds for golf cars)

Brake Pedal shaft bearings 1. Dry Moly Lube - Club Car Part No. 1012151

Brake Linkage and Pivots 2. Dry Moly Lube - Club Car Part No. 1012151

Accelerator push rod pivots, mounts, and shifter cable pivots

3. Dry Moly Lube - Club Car Part No. 1012151

Front Suspension (5 fittings) 4. Chassis Lube - EP NLGI Grade 2

Brake slides 5. Dry Moly Lube - Club Car Part No. 1012151

Annually by TrainedTechnician Only (Every 100 hours of operation or every 200 rounds for golf cars)

Check/fill unitized transaxle to plug level 6.27 oz. (.8 liter) 80-90 WT. API Class GL-3 or 80-90 WT. AGMA Class EP Gear Lube

Inspect front wheel bearings(Repack as necessary)

7. Chassis Lube - EP NLGI Grade 2

First Change 100 Hours -Additional Change Every 200 Hours of Operation(or every 400 rounds forgolf cars), or Annually -Whichever Comes First

Change engine oil and oil filter 8.32 oz. (.97 liter) without filter; 38 oz. (1.16 liters) with filter. See Oil Viscosity on page 18 .

Figure 15 Vehicle Lubrication Points

WARNING

8

33

43 4

2

2

1

1

7

7

4

44

3

6

3

5

5


Vehicle Capacities

VEHICLE CAPACITIES

ENGINE OIL

Even though the oil warning light on the dash should warn you if your oil is getting low, engine oil level shouldbe checked monthly. Vehicle should be on a level surface when checking oil (Figure 16, Page 18). Do notoverfill with oil.

OIL VISCOSITYChoose the viscosity according to the temperature as shown (Figure 18, Page 18) . See following NOTE.

CAPACITIES

Engine Crankcase without filter 32 oz. (.98 liters)

Engine Crankcase with filter 38 oz. (1.16 liters)

Unitized Transaxle (gas vehicle) 27 oz. (.8 liters)

Gasoline Tank 7 gallons (26.5 liters)

Tire Pressure 12-14 psi (83-96 kPa)

Figure 16 Engine Oil Level Figure 17 Gasoline Tank

• PROPERLY RECYCLE OR DISPOSE OF USED OIL IN ACCORDANCE WITH LOCAL, STATE,AND FEDERAL REGULATIONS.

Figure 18 Oil Viscosity

LowLevel

SafeLevel

FullLevel

2

1

3

Remove dipstickand clean.

Reinsert dipstickuntil fully seated.

Oil must be inthe safe level.

TO CARBURETOR

VENT TUBES

SHUT-OFF VALVE

VENT

NOTE

-20°C -10°C 0°C 10°C 20°C 30°C 40°C

-4°F 14°F 32°F 50°F 68°F 86°F 104°F

SAE 5W-20

SAE 10W-30/SAE 10W-40

SAE 30

SAE 40


Fueling Instructions

FUELING INSTRUCTIONS


1. Turn the key switch to the OFF position.

2. Lift and remove seat bottom.

3. The fuel tank is located on passenger side of vehicle. Remove fuel cap and fill the fuel tank with fresh

unleaded gasoline only. See preceeding CAUTION.

4. Replace fuel cap on tank. Make sure cap is tightened securely.

5. Replace seat bottom.

BATTERY

Read DANGER and WARNING on page 3.The battery in the DS Gasoline vehicle is a 12-volt, low maintenance battery that requires infrequent water-ing (Figure 19, Page 20) . See following DANGER and WARNING.

• USING MULTI-GRADE OILS (5W-20, 10W-30, AND 10W-40) WILL INCREASE OILCONSUMPTION. CHECK OIL LEVEL MORE FREQUENTLY WHEN USING THEM.

• TURN KEY SWITCH TO THE OFF POSITION BEFORE FUELING.

• NEVER POUR GASOLINE INTO THE FUEL TANK WHEN THE ENGINE IS HOT OR WHILE IT ISRUNNING.

• TO AVOID ELECTRIC ARC CAUSED BY STATIC ELECTRICITY, THE FUEL STORAGE/PUMPING DEVICE MUST BE GROUNDED. IF THE PUMP IS NOT GROUNDED, THE VEHICLEMUST BE GROUNDED TO THE PUMP BEFORE AND DURING THE FUELING OPERATION.

• IF THE VEHICLE HAS AN ALL-WEATHER ENCLOSURE INSTALLED, THE GAS TANK MUST BEPROPERLY VENTED AS SHOWN (SEE FIGURE 17, PAGE 18).

• TO AVOID THE POSSIBILITY OF FIRE, BE SURE TO CLEAN UP ANY SPILLED GASOLINEBEFORE OPERATING THE VEHICLE.

• TO ALLOW FOR EXPANSION, DO NOT FILL HIGHER THAN ONE INCH FROM THE TOP OF THEFUEL TANK. AVOID FUEL SPILLAGE.

• WHENEVER POSSIBLE, AVOID USING OXYGENATED FUELS AND FUELS THAT AREBLENDED WITH ALCOHOL. VEHICLES TO BE STORED FOR EXTENDED PERIODS SHOULD BEPREPARED FOR STORAGE AS INSTRUCTED ON PAGE 13 OF THIS MANUAL.

NOTE

DANGER

CAUTION

NOTE


Battery

Any corrosion around the positive (+) or negative (-) terminals should be washed off with a solution of baking sodaand water (1 cup per gallon of water). Rinse solution off the battery. Be sure terminals are tight. Let the terminals dryand then spray them with Club Car battery terminal spray (Club Car Part No.1014305). See following CAUTION.

Be sure battery clamp is properly tightened. Tighten to 12 ft.Ib (16.3 N-m). A loose battery clamp may allowthe battery to become damaged from vibration or jarring.If battery appears weak, have it charged by a trained technician. The battery should never be left dischargedany longer than absolutely necessary (do not leave discharged overnight).

• BATTERY - EXPLOSIVE GASES! DO NOT SMOKE! KEEP SPARKS AND FLAMES AWAY FROMTHE AREA OF THE VEHICLE.

• TOOLS, WIRES, AND METAL OBJECTS CAN CAUSE SPARKS WHEN SHORTED ACROSS ABATTERY.

• FOLLOW ALL INSTRUCTIONS CAREFULLY WHEN WORKING WITH BATTERIES.

• CHARGE BATTERY IN A WELL-VENTILATED AREA ONLY.

• POISON! CONTAINS ACID! CAUSES SEVERE BURNS - AVOID CONTACT WITH SKIN, EYES,OR CLOTHING. ANTIDOTES:

- EXTERNAL: FLUSH WITH WATER FOR 15 MINUTES. CALL A PHYSICIAN IMMEDIATELY .

- INTERNAL: DRINK LARGE QUANTITIES OF MILK OR WATER FOLLOWED WITH MILK OFMAGNESIA OR VEGETABLE OIL. CALL A PHYSICIAN IMMEDIATELY .

- EYES: FLUSH WITH WATER FOR 15 MINUTES. CALL A PHYSICIAN IMMEDIATELY .

• DO NOT JUMP START THE VEHICLE. TO CHARGE THE BATTERY, USE AN AUTOMOTIVETYPE 12-VOLT CHARGER RATED AT 10 AMPS OR LESS.

• IF BATTERY WIRE TERMINALS ARE DAMAGED OR CORRODED, THEY SHOULD BEREPLACED OR CLEANED AS NECESSARY. FAILURE TO DO SO MAY CAUSE THEM TOOVERHEAT DURING OPERATION.

Figure 19 Battery Figure 20 Electrolyte Level for Battery

DANGER

WARNING

CAUTION

12V BATTERY

ELECTROLYTE LEVEL AT LEAST

1/2 IN. ABOVE PLATES OR TO LEVEL

INDICATOR

PLATESLEVEL

INDICATOR

BATTERYCAP


Cleaning the Vehicle

CLEANING THE VEHICLE

Club Car vehicles are equipped with an Armorflex® front body and rear body. Use only commercially avail-able automotive cleaners with a sponge or soft cloth for normal cleaning. A garden hose at normal operatingresidential water pressure is adequate.

Club Car does not recommend any type of pressure washing or steam cleaning. Such a process (especiallyif the vehicle has a soft rear body that is removed) will expose electrical components to moisture. Moistureentering electrical components can result in water damage and subsequent component failure.

Use non-abrasive wax products. Battery acid, fertilizers, tars, asphalt, creosote, paint or chewing gum shouldbe removed immediately to prevent possible stains.

The seats of the vehicle will last longer with proper cleaning. Use a solution of 10% liquid dish soap and warmwater applied with a soft cloth. For imbedded dirt, a soft bristle brush may be used. For heavy soiling, difficultstains or scratches, blemishes, or other body damage, see Section 4 of the DS Maintenance and Service Manual.

ACCESSORIES

There is a complete line of accessory equipment available from Club Car and our dealers/distributors. Careshould be taken that these accessories are properly installed by trained technicians, and that they are usedin the manner for which they were designed. See following WARNING.

• DISPOSE OF WASTE WATER PROPERLY.

• TINTED WINDSHIELDS AND WEATHER-PROOF ENCLOSURES WILL NOT PROTECT OCCUPANTS

FROM FLYING OBJECTS (GOLF BALLS, ETC.).

ACCESSORY EQUIPMENT:

• Accent Striping • Rear View Mirror • Differential Guard

• Custom Club Decals • Glove Box • Hour Meter

• Number Decals • Performance Grade Tires • Information Holder

• Canopy Top • Standard Tread Tires • Beverage Cooler

• Rear Rain Curtain • Extra Traction Tires • Extra Two-bag Attach-ment

• Weather-proof Enclosure • Ashtray • Sand Bunker Rake Kit

• Tinted Split Windshield • Chrome Hub Wheel Covers • Golf Club and BallCleaner

• Tinted Snap-on Windshield • Chrome Sport Wheel Covers • Fuel Gauge

• Club Protector • Uncommon Key Switch • Spark Arrestor Kit

NOTE

WARNING


Subsequent Owner Registration

SUBSEQUENT OWNER REGISTRATION

In the event a vehicle is bought as a used vehicle from another individual or from a distributor/dealer, we

strongly urge the new owner to register the vehicle with Club Car. This will enable us to contact you if the

need arises. Please send your name, address, and serial number(s) of the vehicle(s) to Club Car, Inc., P.O.

Box 204658, Augusta. GA 30917-4658, ATTN: Vehicle Registration.

FAIRWAY VILLAGER

The Fairway Villager is designed to provide a smooth and comfortable ride for four passengers. An optionalrack for two golf bags is also available. Contact your nearest Club Car distributor/dealer. This Owner’s Man-ual should be read thoroughly prior to operating the vehicle.

• Adjustable Seat Back • Trailer Hitch • Onboard Tow Bar

• Sand Bottle DivotRepair Kit

• Sand Basket and DivotBucket Repair Kit

• Box Bed Kit

• Lighting Package (headlights,taillights, brake lights, and horn)

• Temporary Tow Bar for Sin-gle Vehicle Towing

• Heavy Duty Front Bumper

• Turn Signals (for vehicles withlights)

• Permanent Tow Bar for Multi-ple Vehicle Towing (factoryinstalled)

Figure 21 Fairway Villager

SEAT HANDLE

HAND RAIL

FOOT REST

PASSENGER WARNINGDECAL

(ON HAND RAIL)


DS Gasoline Vehicle Specifications

The Fairway Villager should be driven and maintained as stated in this Owner’s Manual with the following additions:

MAINTENANCERefer to pages 16 through 17 for periodic service schedule and periodic lubrication schedule. See following NOTE .

DS GASOLINE VEHICLE SPECIFICATIONS

• VEHICLE SHOULD BE DRIVEN AT SLOWER SPEEDS WHEN FOUR PERSONS ARE IN THE VEHICLE.

• PASSENGERS SHOULD HOLD ON TO SEAT HANDLES OR HAND RAILS AT ALL TIMES (SEEFIGURE 21, PAGE 22). DRIVER SHOULD KEEP BOTH HANDS ON THE STEERING WHEELWHILE VEHICLE IS MOVING.

• DO NOT LEAVE CHILDREN UNATTENDED ON THE REAR SEAT WHILE VEHICLE IS MOVING.

• NO MORE THAN FOUR PERSONS SHOULD BE ON THE VEHICLE AT ONE TIME.

• IF THE VEHICLE IS CONSTANTLY HAULING HEAVY LOADS, THE PREVENTIVE MAINTENANCEPROCEDURES SHOULD BE PERFORMED MORE OFTEN THAN RECOMMENDED IN THESERVICE AND LUBRICATION SCHEDULES.

SPECIFICATIONS DS

POWER SOURCE

Engine: 4 cycle, OHV, 286 cc, 9.0 hp rated., single cylinder, air cooled, with pressure lubrication system. •

Fuel System: Side draft carburetor with float bowl, fixed jets, fuel filter, and impulse fuel pump. •

Governor: Automatic ground speed sensing, internally geared in unitized transaxle. •

Ignition: Transistor electronic ignition with electronic RPM limiter. •

Unitized Transaxle: Fully synchronized forward and reverse with neutral and reduced speed reverse (11.8:1 forward, 17.1:1 reverse). •

Torque Converter: Automatic, variable speed, dry type. •

Electrical System: 12 volt, 500 cca at 0°, 650 at 32°, 105 minute reserve capacity and 35 amp charging capacity. •

STEERING/SUSPENSION/BRAKES

Steering: Self-adjusting rack and pinion. •

Suspension: Front and rear tapered mono-leaf springs with dual hydraulic shocks. •

Brakes: Dual rear wheel self-adjusting brakes with cast iron drums and single brake pedal with automatic-release park brake. •

BODY/CHASSIS

Frame/Chassis: Twin I-Beam welded aluminum. •

Front and Rear Body: Armorflex® •

Body Finish: Matched paint finish over molded-in color. •

Tires: 18.00 x 8.50 - 8.00 tubeless, 4 ply rated. •

SEATING CAPACITY/FUEL CAPACITY

Standard Seating Capacity: 2 persons •

Fairway Villager Seating Capacity: 4 persons •

Fuel Tank: 7 gallons (26.5 liters), unleaded gasoline only. •

WARNING

NOTE


DS Gasoline Vehicle Specifications

DIMENSIONS/WEIGHT

Overall Length 91.5 in. (232 cm)

Overall Width 47.25 in. (120 cm)

Overall Height: At Steering Wheel. 48 in. (122 cm)

Wheelbase 65.5 in. (166 cm)

Ground Clearance 4.5 in. (11 cm)

Front Wheel Tread 34.5 in. (88 cm)

Rear Wheel Tread 38.5 in. (98 cm)

Weight: Standard gasoline powered vehicle (dry, without battery) 598 lb. (271 kg.)

Weight: Fairway Villager gasoline powered vehicle (dry) 638 lb. (289 kg.)

Forward Speed: At 2700 rpm 12-15 mph (19-24 kph)

Curb Clearance Circle (diameter) 17 ft. 6 in. (533 cm)

Braking Distance: At 12 mph (19 kph) 14 ft. (427 cm)

SPECIFICATIONS DS


CLUB CAR LIMITED LIFETIME WARRANTY FOR 2000 FLEET GOLF CARS

1. WARRANTY:

CLUB CAR, INC., (“CLUB CAR”) hereby warrants to the Original Retail Fleet Purchaser or Original RetailFleet Lessee, as those terms are defined herein, and subject to the provisions, limitations and exclusionscontained in this limited warranty, that its new 2000 Model DS golf car purchased from CLUB CAR or anauthorized distributor or dealer for use in the United States or Canada shall be free from defects in materialsand workmanship under normal use and service as a golf car for the periods stated below.

LIMITED LIFETIME WARRANTY:

The golf car frame (excluding the front and rear bumper mounts), the rack and pinion steering gearbox unit,and the suspension system (defined as the shock absorbers, shock mounts, A-plates, leaf springs, shacklesand associated hardware) are warranted with respect to parts and labor against defects in materials andworkmanship for the lifetime of the vehicle while owned by the Original Retail Fleet Purchaser or in thepossession of the Original Retail Fleet Lessee.

LIMITED THREE YEAR WARRANTY:

The gasoline engine, transmission, torque converter (drive and driven), unitized transaxle, starter generator,transaxle (electric vehicle), and electric motor are warranted with respect to parts and labor against defectsin materials and workmanship for a period of three years from the date of purchase while owned by theOriginal Retail Fleet Purchaser or in the possession of the Original Retail Fleet Lessee.

LIMITED TWO YEAR WARRANTY:

All remaining components of the golf car not specified otherwise, except options and accessories, arewarranted with respect to parts and labor against defects in materials and workmanship for a period of twoyears from the date of purchase while owned by the Original Retail Fleet Purchaser or in the possession ofthe Original Retail Fleet Lessee.

LIMITED ONE YEAR WARRANTY:

All original equipment options and accessories supplied by Club Car are warranted with respect to parts andlabor against defects in material and workmanship for a period of one year from the date of purchase.

This limited warranty covers materials, workmanship and repair labor cost as to those items specifically listedabove for the periods specified. Such repair labor shall be performed only by CLUB CAR, its authorizeddistributors or dealers, or a service agency approved by CLUB CAR.

IF THE WARRANTY REGISTRATION FORM IS NOT COMPLETED AND RETURNED TO CLUB CAR ATTHE TIME OF THE ORIGINAL RETAIL SALE, PURCHASER MUST PROVIDE PROOF OF DATE OFPURCHASE WITH ANY WARRANTY CLAIM.

2. EXCLUSIONS:

Excluded from any CLUB CAR warranty are all fuses, filters, decals (except safety decals), spark plugs,lubricants, and trim pieces, seats, routine wear items such as the charger plug and receptacle, brake shoes,belts, brushes, bushings, engine mounts, mats and pads, maintenance adjustments, cosmetic deterioration,and items which deteriorate or fail due to exposure or ordinary wear and tear. Batteries, the battery charger,onboard computer, and solid-state speed controller are covered under separate CLUB CAR warranties. Tiresare warranted by their manufacturer. Also excluded from any CLUB CAR warranty is damage to a golf car orcomponent resulting from a cause other than a defect including unreasonable or unintended strain or use,improper installation of accessories, installation of parts or accessories that are not original equipment,overloading, accident, alteration, abuse or neglect.

Transportation expenses for warranty service are also excluded from this warranty.


3. VOIDING OF WARRANTY:

THIS AND ANY OTHER WARRANTY SHALL BE VOID IF THE GOLF CAR IS ABUSED OR USED IN ANUNINTENDED MANNER OR SHOWS INDICATIONS THAT IT HAS BEEN ALTERED IN ANY WAY,INCLUDING, BUT NOT LIMITED TO, MODIFICATION OF THE SPEED GOVERNOR, BRAKING SYSTEM,STEERING, TRANSAXLE, OR OTHER OPERATING SYSTEMS OF THE CAR TO CAUSE IT TO PERFORMOUTSIDE CLUB CAR SPECIFICATIONS. THE WARRANTY IS LIKEWISE VOID IF THE CAR SHOWSINDICATIONS THAT REASONABLE OR NECESSARY MAINTENANCE AS OUTLINED IN THE OWNER’SMANUAL AND MAINTENANCE AND SERVICE MANUAL WAS NOT PERFORMED AT THE TIME AND INTHE MANNER SPECIFIED IN SUCH MANUALS.

4. SOLE REMEDY:

CLUB CAR’s only liability under this limited warranty, or in any action whether based upon warranty, contract,negligence, strict product liability or otherwise, is limited to the repair or replacement, at CLUB CAR’s option,of a golf car or component thereof that CLUB CAR deems to be defective. Replacement shall meanfurnishing, during the applicable limited warranty period, a new golf car or factory reconditioned vehicle orcomponent thereof which is identical or reasonably equivalent to the warranted product or component at nocost to the purchaser. Repair shall mean remedying a defect in the golf car or component thereof at no costto the purchaser during the applicable limited warranty period. If CLUB CAR elects to repair the golf car, itmay provide factory reconditioned parts or components. All parts and components replaced under warrantyshall become the property of CLUB CAR.

5. HOW TO MAKE A WARRANTY CLAIM:

To make a warranty claim under this limited warranty, you must present the golf car or defectivecomponent to an authorized CLUB CAR distributor or dealer or send the defective component, freightprepaid, to WARRANTY ADMINISTRATION, CLUB CAR, INC., 4125 Washington Road, Augusta,Georgia 30809.

6. DEFINITIONS:

For the purpose of this warranty, an Original Retail Fleet Purchaser is the original purchaser of the golf carwho is in the business of owning or operating golf courses and who purchases such golf car for the purposeof renting it to golf players for use on such courses. An Original Retail Fleet Lessee is the first end-user of thegolf car who is in the business of owning and operating golf courses and who leases such golf car for thepurpose of renting it to golf players for use on such golf courses. In the event the golf car is purchased orleased by any entity for the purpose of leasing it to an Original Retail Fleet Lessee, then this limited warrantyshall extend only to the first Original Retail Fleet Lessee, and not to such entity or to any subsequent lesseeof the golf car.

7. DISCLAIMER:

THIS LIMITED WARRANTY IS EXCLUSIVE. CLUB CAR MAKES NO OTHER WARRANTY OF ANY KIND,EXPRESS OR IMPLIED. ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR APARTICULAR PURPOSE WHICH EXCEED THE OBLIGATIONS OR TIME LIMITS STATED IN THISWARRANTY ARE HEREBY DISCLAIMED BY CLUB CAR AND EXCLUDED FROM THIS WARRANTY.THE PURCHASER AND CLUB CAR EXPRESSLY AGREE THAT THE REMEDY OF REPAIR ORREPLACEMENT OF THE DEFECTIVE GOLF CAR OR COMPONENT THEREOF IS THE EXCLUSIVEAND SOLE REMEDY OF THE PURCHASER. CLUB CAR MAKES NO OTHER REPRESENTATION ORWARRANTY OF ANY KIND, AND NO REPRESENTATIVE, EMPLOYEE, DISTRIBUTOR, OR DEALER OFCLUB CAR HAS THE AUTHORITY TO MAKE OR IMPLY ANY REPRESENTATION, PROMISE, ORAGREEMENT WHICH IN ANY WAY VARIES THE TERMS OF THIS WARRANTY.


8. NO CONSEQUENTIAL DAMAGES:

IN NO EVENT SHALL CLUB CAR BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIALDAMAGES INCLUDING, BUT NOT LIMITED TO, LOSS RELATED TO PROPERTY OTHER THAN THEGOLF CAR, LOSS OF USE, LOSS OF TIME, INCONVENIENCE, OR ANY OTHER ECONOMIC LOSS.

Some states allow neither limitation on the duration of an implied warranty nor exclusions or limitation ofincidental or consequential damages. Therefore, the above limitations or exclusions may not apply to you.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.

9. INFORMATION:

For further information, contact WARRANTY ADMINISTRATION, CLUB CAR, INC., 4125 Washington Road,Augusta, Georgia 30809, U.S.A., 706-863-3000.

10. WARNING:

Any modification or alteration of any golf car beyond factory specifications, including those that affect theweight distribution, stability, or speed of the golf car, can cause serious personal injury or death.


Club Car, Inc.

P.O. Box 204658

Augusta, GA 30917-4658

USA

Web www.clubcar.com

Phone 1.706.863.3000

1.800.ClubCar

Intl’l +1 706.863.3000

Fax 1.706.863-5808

Publication Part Number 102067301

Edition Code 0899B00000

2000 ds golf car - club car 0899b000… · use gasoline containing up to 15% mtbe by volume....

Documents